Caterpillar CB 534D Serie FGH Sist. Electrico

8/19/2019 Caterpillar CB 534D Serie FGH Sist. Electrico

http://slidepdf.com/reader/full/caterpillar-cb-534d-serie-fgh-sist-electrico 1/6

KENR3619-05 April2012

Volume 1 of 3: Standard Machine

Printed in U.S.A.

CB-534D Asphalt Compactor

Electrical System

© 2012 Caterpillar, All Rights Reserved

EAA1-UPFEA1-UPGCA1-UPC2B1-UPC4B1-UPFGH1-UPB5M1-UP

C8M1-UP

PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit Breaker Symbol

Harness and Wire Symbols

Symbols

Symbols and Definitions

Harness And Wire Electrical Schematic Symbols

Fuse: Acomponent in an electrical circuit that will open the circuit if too much current flowsthrough it.

Switch (NormallyOpen): Aswitch that will close at a specified point (temp, press, etc.). Thecircle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (NormallyClosed): Aswitch that will open at a specified point (temp, press, etc.).No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. Thegrounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground.It is grounded by being fastened to the machine.

Reed Switch: Aswitch whose contacts are controlled by a magnet. A magnet closes thecontacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sendermeasures the temperature or pressure. Its resistance changes to give an indication tothe gauge of the temperature or pressure.T

Relay(MagneticSwitch): Arelay is an electrical component that is activated by electricity.It has a coil that makes an electromagnet when current flows through it. Theelectromagnet can open or close the switch part of the relay.

Magnetic Latch Solenoid: Amagnetic latch solenoid is an electrical component that isactivated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)that make electromagnet when current flows through them. It also has an internal switch that placesthe latch coil circuit open at the time the coil latches.

Solenoid: Asolenoid is an electrical component that is activated by electricity. It has acoil that makes an electromagnet when current flows through it. The electromagnetcan open or close a valve or move a piece of metal that can do work.

1

2

AG-C4111-7898

L-C123E-5179

9X-1123Component

Part Number

Pin orSocket Number

Part Number: for Connector ReceptaclePart Number: for Connector Plug

Harness Identification Letter(s):

(A, B, C, ..., AA, AB, AC, ...)

Plug

325-AG135 PK-14

Wire Color

Wire Gauge

Receptacle

1

1

2

2

Sure-Seal connector: Typicalrepresentationof a Sure-Sealconnector. The plug and receptaclecontain both pins and sockets.

Deutsch connector: Typicalrepresentationof a Deutsch connector. The plug contains allsockets and the receptacle contains allpins.

Fuse (5 Amps)

5A

Harness identification code:

This example indicates wire group 325,

wire 135 in harness "AG".

L-C123E-5179

Wire , Ca ble , or Ha rne ss

Assembly Identification: Includes

Harness Identification Letters and

Harness Connector Serialization

Codes (see sample).

Harness ConnectorSerialization Code:

The "C" stands for "Connector" and the

number indicates which connector in the

harness (C1, C2, C3, ...).

K E N R 3

6 1 9 - 0 5 V O L 1 o f 3

3 6 P a g

e , ( D i m e n s i o n s : 4 8 i n c h e s x 3 5 i n c h e s )

A

3

4

5

6

8

9

10

11

1214

15

13

16

B1

2

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

37

35

33

34

3638

7

39

40

41

42

43

44

45

Machine Harness Connector And Component Locations

A

3

4

5

6

8

9

10

11

1214

15

13

16

B

1

2

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

37

35

33

34

3638

7

39

40

41

42

43

44

45

71

70

47

47

70

71

WireDescription

Wire

Number W ir e Co lo r D es cr ip ti on

Wire


Po we r Ci rc uit s Lig ht ing Cir cuit s- Co nt inu ed

1 01 RD Un -swi tch ed Ba tte ry (+) 65 3 GN Fl oo dLa mp - Lef tF ron t

103 YL Vibe Fuse 680 GN High Int Relay Coil (IRH Only)

1 05 B R K ey Swi tc h/ Ign it io nF us e 69 0 GN Hi gh In tRe lay Ou tpu t

108 BU Radio Fuse A631 BU SprayLamp

1 09 R D A lt er na to r Ou tp ut ( +) ControlCircuits

110 GN Water SprayFuse 710 GN Propel Handle Speed PWM

1 12 P U M ai nP ow er Re la yO ut pu t( Sw it ch ed ) 7 51 G N P WM Ou t2 Sp ee dS ol en oi d

114 GN Light Breaker (30A) 777 PU Brake Release Motor

115 PK Light Breaker (15A) C729 BU Cutter Door Raise Solenoid

1 17 R D M ai nB re ak er (U n- Sw it ch ed ) C 73 0 B R C ut te rD oo rL ow er So le no id

118 GY Right Washer /Wiper Fuse F711 GN Can 1(+)

119 PK Front Washer / Wiper Fuse F712 GY Can 1(-)

121 YL Backup Alarm Fuse H750 BR Drum Offset Right

122 BU Hitch Offset Fuse H751 OR Drum Offset Left

123 WH Gage Fuse J704 BU Right Front Solenoid Valve

124 GN HVAC Fuse J705 WH Right Front Solenoid Valve

1 25 OR P ro du ct Li nk o rF ro nt Fa n J 70 6 OR L ef tRe ar So le noi dV al ve

134 YL Power Port Fuse J707 PU Left Rear Solenoid Valve

135 BU Propel Control Fuse J708 GN Right Rear Solenoid Valve

14 4 GN Ro ta ti ng Be aco nFu se J 70 9 YL Ri gh tR ea rS ol eno id Va lve

155 PK Brake Fuse J710 BR Differential Lock Indicator Lamp (+)

160 PU GlowPlugs J711 PK Right Rear Speed Sensor Signal

175 PK Joint Cutter Fuse J712 BR Right Rear Speed Sensor (-)

176 YL Recorder Fuse J713 BR Left Front Speed Sensor (-)

1 81 R D T hr ot tl eB re ak er / St ar tR el ay J 71 4 G Y L ef tF ro nt So le no id Va lv e

GroundCircuits J 71 5 G N L ef t Fr on t So le no id V al ve

200 BK Main Chassis J717 BU Left Front Speed Sensor Signal

206 BK Not Used J718 OR Right Front Speed Sensor Signal

2 86 BK A tt ch Re co rd ing Mod ul e J 71 9 P U Ri gh tF ro nt Sp ee dS en so r( -)

A249 BK Can1Shield J720 YL LeftRearSpeedSensorSignal

BasicMachineCircuits J 72 1 Y L S pe ed S en so rs 1 2V S up pl y

304 Starter Relay Output J722 BR Left Rear Speed Sensor (-)

3 06 G N N eu tr al S ta rt Re la yT oS ta rt er Re la y J 72 3 G Y M od eS wi tc h

3 07 O R K ey Sw it ch To Ne ut ra l S ta rt Re la y K 70 8 B U P ro pe l S pe ed - Mo de 1

308 YL Main Power Relay Coil K709 GY Propel Speed -Mode 2

3 20 OR Ho rn Swi tc hTo Ho rn Re la y K7 25 GN P rop el Fo rwa rd Pum p

3 21 B R B ac ku pA la rm La mp / Tr av el Al ar m K 72 6 B U P ro pe l R ev er se Pu mp

32 2 G Y Fo rwa rd Wa rn ing Hor n U 73 4 GN P ar ki ng Br ake Swi tch (NO )

33 0 Y L Ne utr al Sta rt Re lay Co il U 73 5 GY P ar ki ng Br ake Swi tch (NC)

37 6 GN G low Pl ug Rel ay Co il C 85 0 G N A mp Si gn al T oRe co rdi ng Mo dul e

384 Glow Plugs F877 WH Neutral Switch

A305 YL RelayToWarningHorn) T825 YL VibrationSolenoid

MonitoringCircuits 9 96 R D J oi nt C ut te r Re la y 2C oi l

4 03 G N A lt er na to r 'R ' Te rm in al 9 97 P U J oi nt C ut te r Re la y 2

4 05 G Y E ng in e Oi l Pr es su re S wi tc h (L ow ) 9 98 G N J oi nt C ut te r Sw it ch ( Wa te r Sp ra y)

406 PU Coolant Temperature A914 OR Speed Dial Pot

419 YL Parking Brake Sensor A915 OR Sensor Power Ground

42 8 OR H ydr au li cT em pe ra tu re Sen de r A 91 6 G N 5 V DC Su pp ly

447 PK Fuel Level Gage A919 BU Throttle Solenoid

449 BU Speedometer Signal A925 YL Sensor Power Ground

4 65 OR L ow Ch ar ge Pr ess ur eW arn in g A9 26 Y L 5 V DC Su pp ly

480 GN Glow Plug Relay Coil A982 BR Engine Throttle Control

A429 YL Drum CenterSwitch A983 BU EngineThrottleControl -Signal

C444 YL Indicator -Alternator A990 BU Cnfg Pin Analog

E455 BR Hydraulic Oil Filter C903 BU Water Pump 1Switch

F 42 0 G N I nd ic at or - R ec or di ng M od ul e C 90 4 G N W tr S pr ay N eu tr al S to p Rl y To W tr S pr ay R ly

AccessoryCircuits C 90 5 O R W at er Pu mp 2 Sw it ch

500 BR Wiper -Front (Park) C906 PU Vibe Hi/Low Amp Switch

501 GN Wiper -Front (Low) C922 BR Front Drum Water Pump

503 BR Wiper -Rear (Park) C923 OR Rear Drum Water Pump

504 YL Wiper -Rear (Low) C924 YL Forward Vibratory Valve

505 BU Wiper -Rear (High) C925 GN Reverse Vibratory Valve

506 PU Washer -Front C926 BU Front Drum Select Solenoid

507 WH Washer -Rear C927 PU Rear Drum Select Solenoid

5 13 O R A /C R ef ri ge ra nt Pr es su re Sw it ch C 92 8 G Y D ru m O ff se tR T

5 21 Y L F an S pe ed S wi tc h To A /C P re ss ur e Sw it ch C 92 9 W H D ru m O ff se t LT

5 36 W H H az ar dS wi tc hT oT ur nS ig na l S wi tc h C 93 2 Y L L ig ht Vi be On

5 37 G N T ur nS ig na l S wi tc hT oF la sh er C 93 3 G N A ut o/ Ma nu al S wi tc hV ib e

A503 PK DefrosterFan-Front(Low) C935 PU DoutWaterPump2

A504 YL DefrosterFan-Rear(Low) C936 GY DoutBackupAlarm

A506 OR DefrosterFan-Front(High) C937 WH DoutWaterPump1

LightingCircuits K 91 8 G N P WM Ou tV ib eP Fw d

603 PK Rotary Beacon Lamp K919 YL PWM Out Vibe P Rev

604 OR Stop Lamps M904 OR Auxiliary Circuit 1(Digital Input)

6 05 Y L Tu rn La mp s- Le ft M9 05 WH A ux il ia ry Cir cui t 2 (Di gi ta l In pu t)

60 6 G Y Tu rn La mp s- Ri ght N 92 8 O R Wa ter Sp ra yO ff Ti me Se le ct Si gn al

607 PK Not Used N929 YL Water SprayOn Tim Select Power

60 8 GN Re ar Wor k L amp s N 93 0 B R Wa ter Sp ra yO nTi me Se le ct Si gn al

610 OR Headlamps - Basic N957 PK TXD - Comm 1

614 PU Tail / Position /Dash Lamps N960 OR RXD -Comm 1

619 GN Headlamps -LowBeam N970 YL DTR - Comm 1

631 GY Flood Lamp -Rear Left hand N973 BR DCD -Comm 1

63 2 WH Fl oo dL am p- Re ar Ri gh tH an d N 97 9 GN S ign al G rou nd -C om m 1

645 OR Headlamps Relay P978 GN Vibe On/Off Switch

6 46 O R S wi tc hT oF ro nt Fl oo dL am ps Re la y P 97 9 Y L W at er On /O ff Sw it ch

6 47 G N S wi tc hT oR ea rF lo od La mp sR el ay T 96 9 Y L O ff se tC on fi g

651 PK Not Used T970 GY Test Mode

65 2 Y L Fl oo dL am p- Ri gh tF ron t X9 82 P U V ibe Hi /L ow Amp Swi tc h

Component Location - Volume1

ComponentSchematic

Location

Machine

LocationComponent

Schematic

Location

Machine

Location

Alarm -Backup D-14 33 Potintiometer-WaterSprayOnTime F-3 A

Alternator G-12 23 ProductLink I-14 10

Battery B-14 8 Relay - Back Up Alarm F-6 1

Beacon - Rotating C-11 16 Relay - Brake Release F-6 1

Breaker -Alternator G-12 20 Relay -Brake Release Latch G-6 1

Breaker -Glow Plug G-12 20 Relay -Drum Spray Lights E-6 1

Breaker -Light 15A D-4 B Relay - Front Work Light G-6 3

Breaker - Light 20A D-8 B Relay - Glow Plug F-14 B

Breaker - Main G-12 20 Relay - High Intensity H-4 B

Breaker - Throttle G-13 25 Relay - Horn E-6 1

Bus - Glow Plugs F-14 39 Relay - Main E-8 B

Control -Propel (Handle) B-6 B Relay -Neutral Start 1 F-6 1

Diode - A/C (Attch) E-13 35 Relay - Neutral Start 2 F-6 1

Display - Brake Light G-3 A Relay - Rear Work L ight G-6 1

Display - Function Lamps F-3 A Relay - Starter G-14 25

Flasher C-6 B Relay - Water Spray F-6 1

Fuse - Back Up Alarm G-6 1 Relay - Water Spray 3 F-6 1

Fuse - Brake H-6 1 Relay - Water Spray Neutral S top E-6 1

Fuse - Front High Int L H-6 1 Sender - Fuel Level C-13 24

Fuse -Front High Int R G-6 1 Sender -Hydraulic Temperature D-13 36

Fuse - Gage H-6 1 Sender - Water Level C-9 19

Fuse - Hitch Offset H-6 1 Sensor - Propel Speed C-13 38

Fuse - Ignition G-6 1 Sensor - Vibratory Speed E-11 37

Fuse - Joint Cutter H-6 1 Solenoid - 2 Speed Valve E-13 26

Fuse -Power Port G-6 1 Solenoid -A/C Compressor E-14 23

Fuse -Propel C ontrol H-6 1 Solenoid -Brake Release E-13 24

Fuse -Rear High Int L H-6 1 Solenoid -Cold Start Advance E-13 34

Fuse -Rear High Int R H-6 1 Solenoid -Drum Offset Left D-11 22

Fuse -Recorder H-6 1 Solenoid -Drum Offset Right F-11 22

Fuse -Rotating Beacon H-6 1 Solenoid -Dump Valve B-13 15

Fuse - Vibratory H-6 1 Solenoid - Fuel Shutoff F-12 26

Fuse -Water Spray H-6 1 Solenoid -Joint Cutter Down E-11 21

Gage -Fuel Level G-2 A Solenoid -Joint Cutter Wat er Spray C-11 45

Gage - Water Level F-2 A Solenoid - Propel Pump F-12 24

Ground - Console D-6 2 Solenoid - Throttle G-14 25

Ground -Frame Disconnect H-14 7 Solenoid -Vib Control E-12 24

Gr ou nd -F ra me En gi ne A -1 3 23 S ol en oi d- Vi bS el ec tV al ve Fro nt E- 12 2 4

G ro un d- Fr am eR ea rM ac hi ne C -1 3 2 3 S ol en oi d- Vi bS el ec t Va lv eR ea r E -1 2 2 4

Ground - Front Frame D-9 20 Speedometer G-2 A

Ground - Platform Stud D-8 2 Stud - Jump Start B-13 9

Horn B-9 3 Suppresor - ARC #1 E-12 40

Hourmeter I-2 A Suppresor - ARC #2 F-14 31

Indicator -Dif fLock C-6 B Suppresor -ARC (Dump Valve) B-13 15

Lamp - Backlight LH G-2 A Switch - A/C Pressure F-14 26

Lamp - Backlight RH F-2 A Switch - Beacon E-3 A

Lamp - HID FLH B-8 11 Switch - Brake A-7 B

Lamp - HID FRH B-8 12 Switch - Cold Start Temperature E-13 34Lamp - HID RLH A-9 13 Switch - Coolant Temperature E-12 30

Lamp - HID RRH A-9 14 Switch - Diff Lock E-4 5

Lamp - Rear Spray 1 D-14 41 Switch - Disconnect B-15 32

Lamp - Rear Spray 2 D-14 42 Switch - Drum Center F-11 22

Lamp -Rear Spray 3 D-14 43 Swit ch -Engine Oil Pressure D-13 31

Lamp - Signal Front LH F-9 4 Switch - Hazard E-2 A

Lamp - Signal Front RH E-9 3 Switch - HID E-2 A

La mp -S ign al R ear LH C -14 27 S wit ch -H yd ra ul ic C har ge Pre ss ur e F -11 1 7

Lamp -Signal Rear RH C-14 29 Swit ch -Hydraulic Indicator E-11 7

Lamp - Spray 1 C-9 3 Switch - Key Start A-8 B

Lamp - Spray 2 C-9 44 Switch - Light Master E-1 A

Lamp - Spray 3 E-9 4 Switch - Lights Select E-2 A

Lamp - Work L amp Rear LH C-14 27 Switch - Propel 2 Speed H-2 B

Lamp -Work Lamp Rear RH C-14 29 Swit ch -Thrott le Speed 2 A-6 B

Light -License Plate B-14 27 Switch - Turn Signal D-3 A

Light -Spray Vibratory F-3 A Switch - Vib Drum Select H-1 A

Motor -Fuel Lift Pump E-14 28 Swit ch -Vibrat ory Auto /Manual H-1 A

Motor - Starter H-2 6 Switch - Vibratory High /Low Amp H-2 A

Motor - Water Pump 1 D-9 18 Switch - Water Pump Select H-2 A

Motor - Water Pump 2 D-9 18 Tachometer - Vibratory F-2 A

Port - Auxiliary D-4 1 Timer - Spray A-5 B

Potentiometer -Aut oSpeed Control C-6 B Timer -Thrott le G-14 25

P ot en ti om et er - W at er S pr ay O nT im e F -3 A

Machinelocationsarerepeatedforcomponentslocatedclosetogether.

Off MachineSwitch Specification- Volume 1Part No. Function Actuate Deactuate Contact Position

107-0614 EngineOil Pressure93± 21kPa

(13.48± 3psi)

70± 21kPa

(10± 3ps i)NormallyClosed

134-0404 Hydraul ic I ndicat orPressure275.8± 27.5kPa

(40± 4ps i)

206.8MIN

(30psi MIN)NormallyOpen

165-2521 Hydraul icChargePressure14000KpaMAX(203psiMAX)

1100± 75kPa(159.5±10.8 psi)

AtoC: NormallyOpen A toB:NormallyClosed

203-3219 Coolant Temperat ure107± 3°C

(224.6± 5.4°F)90°C MIN

(194°FMIN)NormallyOpen

235-1790 ColdSt art Temperat ure40± 3°C

(104± 5.4°F)

30± 3°C

(86± 5.4°F)NormallyOpen

Resistor,Senderand Solenoid Specifications- Volume1Part No. Component Description Resistance (Ohms)¹

3E-1908 Solenoid: A/C Compressor 3.5 ± 0.15

199-6852 Sender: Fuel Level Empty = 240 to 250 /Full = 28 to 33

202-8716 Sender: Water Level Empty = 240 / Full = 30

270-8384 Potentiometer: Auto Speed Control 1.0K ± 200

276-1827 Potentiometer: Water SprayOn Time 100K ± 2 0K

279-6525 Solenoid: Dump Valve 7.5 ± 0.5

¹A troom temperatureunlessotherwisenoted.

A = LocatedontheInstrumentPanel.

B= Locatedinsidethe RightHandConsole.

ConnectorLocation - Volume1

ConnectorNumber Schematic

Location

Machine

Location

CONN 1 H-12 10

CONN 2 I-12 10

CONN 3 B-12 70

CONN 4 C-12 7

CONN 5 D-11 47

CONN 6 F-12 20

CONN 7 H-12 10

CONN 8 I-12 10

CONN 9 B-9 71

CONN 10 C-8 B

CONN 11 D-8 A

CONN 12 E-8 ACONN 13 F-8 1

CONN 14 G-8 1

CONN 15 H-8 B

CONN 16 H-8 B

CONN 17 C-7 B

CONN 18 C-7 B

CONN 19 E-4 B

CONN 20 E-4 B

CONN 21 F-4 A

CONN 22 G-4 A

Theconnectorsshownin thischartare forharnesstoharness connectors.

Connectorsthatjoina harnesstoa componentaregenerallylocated atornear

thecomponent. SeetheComponent LocationChart.

BU

WH



K E

N R 3 6 1 9 - 0 5 V O L 2 o f 3

3 0 P a g e , ( D i m e n s i o n s : 3 9 i n c h e s x 2 8 i n c h e s )

PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol



Symbols



Fuse: A component in an electricalcircuit that willopen the c ircuit if too much current flows

through it.

Switch (Normally Open): Aswitch that willclose at a s pecified point (temp, press, etc.). The

circle indicatesthat the component hasscrew terminalsand a wire can be disconnected from it.

Switch (Normally Closed): Aswitch that willopen at a specified point (temp, press, etc.).

No circle indicatesthat the wire cannot be disconnected from the component.

Ground (Wired): Thisindicates that the component is connected to a grounded wire. The

grounded wire isfastened to the machine.

Ground (Case): Thisindicates that the component doesnot have a wire connected to ground.

It isgrounded bybeing fastened to the machine.

Reed Switch: Aswitch whose contactsare controlled bya magnet. Amagnet closes the

contactsof a normallyopen reed switch; it opensthe contacts of a normallyclosed reed switch.

Sender: A component that isused with a temperature or pressure gauge. The sender

measuresthe temperature or pressure. Its resistance changesto give an indication to

the gauge of the temperature or pressure.T

Relay (Magnetic Switch): Arelayis an electricalcomponent that isactivated byelectricity.

It hasa coilthat makes an electromagnet when current flowsthrough it. The

electromagnet can open or close the switch part of the relay.

Magnetic Latch Solenoid: Amagnetic latch solenoid isan electricalcomponent that is

activated byelectricityand held latched by a permanent magnet. It hastwo coils (latch and unlatch)

that make electromagnet when current flowsthrough them. It also hasan internal switch that places

the latch coilcircuit open at the time the coil latches.

Solenoid: Asolenoid isan electrical component that isactivated byelectricity. It hasa

coilthat makesan electromagnet when current flowsthrough it. The electromagnet

can open or close a valve or move a piece of metal that can do work.

1

2

AG-C4111-7898

L-C123E-5179

9X-1123Component

Part Number

Pin orSocket Number



(A, B, C, ..., AA, AB, AC, ...)

Plug

325-AG135 PK-14

Wire Color

Wire Gauge

Receptacle

1

1

2

2

Sure-Seal connector: Typicalrepresentationof a Sure-Sealconnect or. The plug and receptacle

contain both pins and sockets.

Deutsch connector: Typicalrepresentationof a Deutsch connector. The plug contains all

sockets and the receptacle contains allpins.

Fuse (5 Amps)

5A


Thisexample indicates wire group 325,wire 135 in harness "AG".

L-C123E-5179

Wire, Cable, o r Harness

Assembly Identification:Includes

HarnessIdentification Letters andHarness Connector Serialization

Codes (see sample).

Harness ConnectorSerialization Code:The "C" stands for "Connector" and the

number indicates which connector in theharness(C1, C2, C3, ...).

Volume 2 of 3: Cab Option / Split Drum Option


CB-534D Asphalt Compactor Electrical System

©2012 Caterpillar, AllRightsReserved Printed in U.S.A.

EAA1-UPFEA1-UPGCA1-UPC2B1-UPC4B1-UPFGH1-UPB5M1-UPC8M1-UP



Location

Machine

Location

CONN 5 B-4 47

CONN 10 E-3 B

CONN 11 F-7 A

CONN 12 F-7 A

CONN 15 F-8 A

CONN 16 E-1 , F-2 , F-3 B

CONN 23 C-7 B

CONN 24 A-4 , F-1 B

CONN 25 B-3 53

CONN 26 C-3 52

CONN 27 C-3 49

CONN 28 E-3 B

CONN 29 C-2 50

CONN 30 C-2 51

Theconnectorsshowninthischartarefor harnesstoharnessconnectors.

Connectorsthatjoinaharnesstoacomponentaregenerallylocatedatornear

thecomponent.SeetheComponentLocationChart.

ComponentSchematic

Location

Machine

Location

AmplifierAssembly-RecordingModule A-7 B

Beacon - Cab E-8 66

Control - Direction & Speed F-4 46

Control - Traction D-4 47

D io de - A rc S up pr es so r (A dp t Ha rn es s) D -2 B

D iod e- D1 (J oi nt Cut te rC on tro l) A -4 B

Fuse - F Washer Wiper D-6 54

Fuse - Front Fan D-6 54

Fuse - Heater D-5 54

Fuse - R Washer Wiper D-6 54

Fuse - Radio D-6 54

Fuse - Recording Module D-6 54

Heater - A/C F-8 55

I nd ic at or - Li gh t( Re co rd in gM od ul e) A -6 B

Lamp - HID Cab FL E-5 59

Lamp - HID Cab FR E-5 58

Lamp - HID Cab RL E-8 61

Lamp - HID Cab RR E-8 60

Light - Dome E-8 64

M od ul e - Fr eq ue nc y (R ec or di ng M od ul e) B -6 B

M od ul e - Th re sh ol d (R ec or di ng M od ul e) B -6 B

Motor - Blower D-8 65

Motor - Front Washer F-8 62

Motor - Rear Washer F-8 62

Motor - Wiper Front D-8 56

Motor - Wiper Rear D-8 63

R ec ep ta cl eA ss em bl y- Ad pt H ar ne ss D -2 B

Relay -1 (Joint Cutter Control) A-3 B

Relay -2 (Joint Cutter Control) B-3 B

Relay -3 (R ecording Module) A-6 B

Sensor -Left Front Speed C-2 52

Sensor -Left Rear Speed C-1 50

Sensor -Right Front Speed B-2 53

Sensor -Right Rear Speed D-1 51

Solenoid -Front Flow Divider D-3 49

Switch - Front Fan E-5 57

Switch - Front Wiper F-5 57

Switch -Joint Cutter Up /Down B-2 B

Switch - Rear Wiper F-5 57

Tachometer - 12 Volt A-7 B



B= LocatedinsidetheRightHandConsole.


Resistor,Senderand Solenoid Specifications- Volume 2Part No. Component Description Resistance (Ohms)¹

240-5204 Resistor: Assembly 130 ± 6.5¹ Atroom temperatureunlessotherwisenoted.

Component

1 2 3 4

OF F OF F OF F OF F No Di ag no sti c

ON OFF OFF OFF

Rear Right

Wheel Speed

Sensor

OFF ON O FF O FFRear Left Wheel

Speed Sensor

OF F OF F ON OFFFront Right

Wheel Speed

Sensor

OFF OFF OFF ONFront Left WheelSpeed Sensor

OFF ON ON ONRear Right

Solenoid Valve

ON OFF ON ONRear Left

Solenoid Valve

ON ON OFF ONFront Right

Solenoid Valve

ON ON ON OFFFront Right

Solenoid Valve

ON OFF ON OFF 5 VDC Supply

OFF ON ON OFF 12 VDC Supply

ON OFF OFF ONLow Battery

Power

ON OFF ON OFFBattery

Overcharge

ON ON ON ON Warning Lamp

LED Indicator State

Traction Control

ECM LED Diagnostics

A

52

B

49

5346


AB

1

46

50

51

48

49

47

47

49

52 53

48

49

50 51

58

57

59

62

55

54

66

60

65

63

6164

56

Cab Component Locations



K E

N R 3 6 1 9 - 0 5 V O L 3 o f 3


PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol



Symbols



Fuse: A component in an electricalcircuit that willopen the c ircuit if too much current flows

through it.

Switch (Normally Open): Aswitch that willclose at a s pecified point (temp, press, etc.). The

circle indicatesthat the component hasscrew terminalsand a wire can be disconnected from it.

Switch (Normally Closed): Aswitch that willopen at a specified point (temp, press, etc.).

No circle indicatesthat the wire cannot be disconnected from the component.

Ground (Wired): Thisindicates that the component is connected to a grounded wire. The

grounded wire isfastened to the machine.

Ground (Case): Thisindicates that the component doesnot have a wire connected to ground.

It isgrounded bybeing fastened to the machine.

Reed Switch: Aswitch whose contactsare controlled bya magnet. Amagnet closes the

contactsof a normallyopen reed switch; it opensthe contacts of a normallyclosed reed switch.

Sender: A component that isused with a temperature or pressure gauge. The sender

measuresthe temperature or pressure. Its resistance changesto give an indication to

the gauge of the temperature or pressure.T

Relay (Magnetic Switch): Arelayis an electricalcomponent that isactivated byelectricity.

It hasa coilthat makes an electromagnet when current flowsthrough it. The

electromagnet can open or close the switch part of the relay.

Magnetic Latch Solenoid: Amagnetic latch solenoid isan electricalcomponent that is

activated byelectricityand held latched by a permanent magnet. It hastwo coils (latch and unlatch)

that make electromagnet when current flowsthrough them. It also hasan internal switch that places

the latch coilcircuit open at the time the coil latches.

Solenoid: Asolenoid isan electrical component that isactivated byelectricity. It hasa

coilthat makesan electromagnet when current flowsthrough it. The electromagnet

can open or close a valve or move a piece of metal that can do work.

1

2

AG-C4111-7898

L-C123E-5179

9X-1123Component

Part Number

Pin orSocket Number



(A, B, C, ..., AA, AB, AC, ...)

Plug

325-AG135 PK-14

Wire Color

Wire Gauge

Receptacle

1

1

2

2

Sure-Seal connector: Typicalrepresentationof a Sure-Sealconnect or. The plug and receptacle

contain both pins and sockets.

Deutsch connector: Typicalrepresentationof a Deutsch connector. The plug contains all

sockets and the receptacle contains allpins.

Fuse (5 Amps)

5A


Thisexample indicates wire group 325,wire 135 in harness "AG".

L-C123E-5179

Wire, Cable, o r Harness

Assembly Identification:Includes

HarnessIdentification Letters andHarness Connector Serialization

Codes (see sample).

Harness ConnectorSerialization Code:The "C" stands for "Connector" and the

number indicates which connector in theharness(C1, C2, C3, ...).

Volume 3 of 3: IRH Version


CB-534D Asphalt Compactor Electrical System

©2012 Caterpillar, AllRightsReserved Printed in U.S.A.

EAA1-UP

FEA1-UPGCA1-UPC2B1-UPC4B1-UPFGH1-UPB5M1-UPC8M1-UP

ComponentSchematic

Location

Machine

Location

B re ak er - L ig ht 1 5A C -3 B

B re ak er - L ig ht 2 0A C -3 B

Control - Direction &Speed C-7 46

Control - Propel B-5 B

D io de - Ar c Su pp re ss or (H ou rM et er ) F -3 A

Diode - Pack B-6 B

Display - Function Lamps E-2 A

Flasher B-5 B

Fuse - Back Up Alarm E-5 1

Fuse - Brake F-5 1

Fuse -Front High Into Left F-5 1

Fuse -Front High Into Right E-5 1

Fuse - Gage F-5 1

Fuse - Hitch Offset F-5 1

Fuse - Ignition E-5 1

Fuse - Joint Cutter F-5 1

Fuse - Power Port Fuse E-5 1

Fuse - Propel Control F-5 1

Fuse -Rear High Into Left F-5 1

Fuse -Rear High Into Right F-5 1

Fuse - Recorder Fuse F-5 1

Fuse - Rotating Beacon F-5 1

Fuse - Vibratory F-5 1

Fuse - Water Spray F-5 1

Gage - Fuel Level D-2 A

Gage - Water Level D-2 A

Ground - Console C-5 2

Hourmeter F-2 A

Indicator -Differential Lock C-5 B

Jumper -1 & 2(Vibe Control) E-5 1

Jumper -3 & 4(Vibe Control) E-5 1

Lamp - Backlight LH E-2 A

Lamp - Backlight RH C-2 A

Light - Brake 2 C-2 A

Light - Spray Vibratory C-2 A

Port - Auxiliary D-3 1

P ot en ti om et er - Au to Sp ee dC on tr ol D -3 B

P ot en ti om et er - Wa te rS pr ay Ti me r E -2 A

Relay - Back Up Alarm D-5 1

Relay - Front Light D-5 1

Relay - High Intermittent D-3 B

Relay - Horn D-5 1

Relay - Main B-5 B

Relay - Rear Light D-5 1

Relay - Water Spray 1 D-5 1

Relay - Water Spray 2 D-5 1

Resistor - Assembly C-7 B

Resistor - Datalink E-5 1

Sensor -Neutral Position B-6 B

Speedometer D-2 A

Switch - Beacon C-2 A

Switch - Brake A-5 B

Switch -Differential Lock C-3 5

Switch - Hazard C-2 A

Switch - HID C-2 A

Switch - Key Start B-7 B

Switch - Light Master C-1 A

Switch - Light Select C-2 A

Switch - Propel 2Speed A-5 B

Switch - Throttle Speed A-4 B

Switch - Turn Signal B-2 A

Switch -Vibe Auto \Manual F-1 A

Switch -Vibe High \Low Amp F-2 A

Switch -Vibrat ory Drum Select E-2 A

Switch -Water Pump Select E-2 A

Tachometer - Vibe D-2 A



B= LocatedinsidetheRightHandConsole.


Resistor, Senderand Solenoid Specifications- Volume3Part No. Component Description Resistance (Ohms)¹

134-2540 Resistor: CAN Data Link 120 ± 12240-5204 Resistor: Assembly 130 ± 6.5

270-8384 Potentiometer: Auto Speed Control 1.0K ± 200

¹ Atroom temperatureunlessotherwisenoted.



Location

Machine

Location

CONN 11 F-7 A

CONN 12 D-7 A

CONN 13 D-8 1

CONN 14 E-8 1

CONN 15 F-7 B

CONN 31 D-7 B

CONN 32 F-8 67

CONN 33 E-3 A

CONN 34 F-3 A

Theconnectorsshowninthischartareforharnessto harnessconnectors.

Connectorsthatjoinaharnesstoacomponentaregenerallylocatedatornear

thecomponent.SeetheComponentLocationChart.

WireDescriptionWire


Wire


Power Circuits Lighting Circuits -Continued

101 RD Un-switched Battery (+) 653 GN Flood Lamp -Left Front

103 YL Vibe Fuse 680 GN High Int Relay Coil (IRH Only)

105 BR Key Switch /Ignition Fuse 690 GN High Int Relay Output

108 BU Radio Fuse A631 BU Spray Lamp

1 09 R D A lt er na to r Ou tp ut ( +) Control Circuits

110 GN Water Spray Fuse 710 GN Propel Handle Speed PWM

1 12 P U Ma in Pow er Re la yO ut pu t( Swi tc he d) 7 51 G N P WM Ou t2 Spe ed So le no id

114 GN Light Breaker (30A) 777 PU Brake Release Motor

115 PK Light Breaker (15A) C729 BU Cutter Door Raise Solenoid

1 17 RD Ma in Br ea ke r( Un- Sw it ch ed ) C 730 B R Cu tt er Do or Lo we rS ol eno id

118 GY Right Washer /Wiper Fuse F711 GN CAN 1Data Link (+)

119 PK Front Washer /Wiper Fuse F712 GY CAN 1Data Link (-)

121 YL Backup Alarm Fuse H750 BR Drum Offset Right

122 BU Hitch Offset Fuse H751 OR Drum Offset Left

123 WH Gage Fuse J704 BU Right Front Solenoid Valve

124 GN HVAC Fuse J705 WH Right Front Solenoid Valve

125 O R Product Link or Front Fan J 706 OR Left Rear Solenoid Valv e

134 YL Power Port Fuse J707 PU Left Rear Solenoid Valve

135 BU Propel Control Fuse J708 GN Right Rear Solenoid Valve

144 GN Rotating Beacon Fuse J709 YL Right Rear Solenoid Valve

155 PK Brake Fuse J710 BR Differential Lock Indicator Lamp (+)

160 PU Glow Plugs J711 PK Right Rear Speed Sensor Signal

175 PK Joint Cutter Fuse J712 BR Right Rear Speed Sensor (-)

176 YL Recorder Fuse J713 BR Left Front Speed Sensor (-)

1 81 RD Th ro ttl eB re ak er / Sta rt Re lay J 71 4 G Y Le ft Fr on tS ol en oi dV al ve

GroundCircuits J 71 5 G N L ef t Fr on tS ol en oi d Va lv e

200 BK Main Chassis J717 BU Left Front Speed Sensor Signal

206 BK Not Used J718 OR Right Front Speed Sensor Signal

286 BK Attch Rec ording Module J719 PU Ri ght Front Speed Sensor (-)

A249 BK CAN1Data LinkShield J720 YL LeftRearSpeed SensorSignal

BasicMachineCircuits J 72 1 Y L S pe ed S en so rs 1 2V S up pl y

304 Starter Relay Output J722 BR Left Rear Speed Sensor (-)

3 06 G N Ne ut ral S ta rt Re la yTo St art er Re la y J 72 3 G Y Mo de Swi tc h

3 07 O R K ey Swi tc hTo Neu tr al S ta rt Re la y K 70 8 B U P ro pe l S pe ed - Mo de 1

308 YL Main Power Relay Coil K709 GY Propel Speed - Mode 2

320 OR Horn Switch To Horn Relay K725 GN Propel Forward Pump

3 21 B R B ac kup Al arm L am p/ Tra ve l A la rm K 72 6 B U P ro pe l R ev ers eP um p

322 GY Forward Warning Horn U734 GN Parking Brake Switch (NO)

330 YL Neutral Start Relay Coil U735 G Y Park ing Brake Switch (NC)

376 GN Glow Plug Relay Coil C850 GN Amp Signal To Recording Module

384 Glow Plugs F877 WH Neutral Switch

A305 YL RelayToWarning Horn) T825 YL VibrationSolenoid

MonitoringCircuits 9 96 R D J oi nt C ut te r Re la y 2C oi l

4 03 G N A lt er na to r 'R 'T er mi na l 9 97 P U J oi nt C ut te rR el ay 2

4 05 G Y E ng in eO il Pre ss ure Swi tc h(L ow) 9 98 G N J oi nt Cut te rS wi tc h(W at er Sp ra y)

406 PU Coolant Temperature A914 OR Speed Dial Pot

419 YL Parking Brake Sensor A915 OR Sensor Power Ground

428 OR Hydraul ic Temperature Sender A916 GN 5V DC Suppl y

447 PK Fuel Level Gage A919 BU Throttle Solenoid

449 BU Speedometer Signal A925 YL Sensor Power Ground

465 OR Low Charge Pressure Warning A926 YL 5V DC Supply

480 GN Glow Plug Relay Coil A982 BR Engine Throttle Control

A429 YL Drum CenterSwitch A983 BU EngineThrottleControl - Signal

C444 YL Indicator - Alternator A990 BU Cnfg Pin Analog

E455 BR Hydraulic Oil Filter C903 BU Water Pump 1Switch

F 42 0 G N I nd ic at or - Re co rd in gM od ul e C 90 4 G N W tr S pr ay Ne ut ra l S to pR ly T oW tr S pr ay Rl y

AccessoryCircuits C 905 O R W at er Pu mp 2 Swi tc h

500 BR Wiper -Front (Park) C906 PU Vibe Hi/Low Amp Switch

501 GN Wiper - Front (Low) C922 BR Front Drum Water Pump

503 BR Wiper - Rear (Park) C923 OR Rear Drum Water Pump

504 YL Wiper - Rear (Low) C924 YL Forward Vibratory Valve

505 BU Wiper -Rear (High) C925 GN Reverse Vibratory Valve

506 PU Washer -Front C926 BU Front Drum Select Solenoid

507 WH Washer - Rear C927 PU Rear Drum Select Solenoid

513 OR A/C Refri gerant Press ure Swi tch C928 G Y Drum O ffset RT

5 21 Y L F an S pe ed Sw it ch T o A /C P re ss ur eS wi tc h C 92 9 W H D ru m O ff se t LT

5 36 W H H az ar dS wi tc hTo Tur nS ig na l S wi tc h C 93 2 Y L L ig ht Vi be On

5 37 G N Tu rn Si gn al S wi tc hT oF la sh er C 93 3 G N A ut o/ Ma nua l S wi tc hV ib e

A503 PK DefrosterFan- Front(Low) C935 PU DoutWaterPump 2

A504 YL DefrosterFan- Rear(Low) C936 GY DoutBackupAl arm

A506 OR DefrosterFan-Front (High) C937 WH DoutWaterPump 1

LightingCircuits K 91 8 G N P WM Ou tV ib eP Fw d

603 PK Rotary Beacon Lamp K919 YL PWM Out Vibe P Rev

604 OR Stop Lamps M904 OR Auxiliary Circuit 1(Digital Input)

605 YL Turn Lamps -Left M905 WH Auxiliary Circuit 2(Digital Input)

606 GY Turn Lamps -Right N928 OR Water Spray Off Time Select Signal

607 PK Not Used N929 YL Water Spray On Tim Select Power

608 GN Rear Work Lamps N930 BR Water Spray On Time Select Signal

610 OR Headlamps - Basic N957 PK TXD - Comm 1

614 PU Tail /Position /Dash Lamps N960 OR RXD - Comm 1

619 GN Headlamps - Low Beam N970 YL DTR - Comm 1

631 GY Flood Lamp -Rear Left hand N973 BR DCD - Comm 1

632 W H Fl ood Lamp -Rear Ri ght Hand N979 GN Signal Ground -Comm 1

645 OR Headlamps Relay P978 GN Vibe On/Off Switch

6 46 O R S wi tc hTo Fro nt Fl oo dL am ps Re lay P 97 9 Y L W at er On/ Off Sw it ch

647 GN Swi tch To Rear Fl ood Lamps Rel ay T969 YL Offset Config

651 PK Not Used T970 GY Test Mode

652 YL Flood Lamp -Right Front X982 PU Vibe Hi/Low Amp Switch

WH

BU

A

5

B1

2

46


A

5

B

1

246

67

67



K E

N R 3 6 1 9 - 0 5 V O L 3 o f 3


Components are shown installed on a fully operable machine with the key and engine off, transmission shifter in neutraland with parking brake set.

Refer to the appropriate Service Manualfor Troubleshooting, Specif ications and Systems Operations.

VOLUME3 of 3: IRHVERSION

SCHEMATICPART NUMBER: 189-5902, CHANGE: 05, VERSION: -

THISSCHEMATIC ISFOR THECB-534D ASPHALT COMPACTORELECTRICAL SYSTEM

MEDIANUMBER: KENR3619-05

A

B

C

D

E

F

8 7 6 5 4 3 2 1

1234

F

E

D

C

B

A

5678

A BB RE V C OL OR

RD RED

WH WHITE

OR ORANGE

YL YELLOW

PK PINK

BK BLACK

GY GRAY

PU PURPLE

BR BROWN

GN GREEN

BU BLUE

COLORABBREVIATIONS S YM BO L D ES CR IP TI ON

BLADE, SPADE, RING OR SCREW

TERMINAL

CIRCUITCONNECTED

CIRCUITNOTCONNECTED

ELECTRICALCONNECTIONTO

MACHINESTRUCTURE

INTERNALELECTRICALCONNECTION

TOSURFACEOFCOMPONENT

CONNECTOR

ATCH WIRE, CABLE, COMPONENT

CIRCUITCONNECTED

SPLICE

CIRCUIT GROUPING DESIGNATIONH#

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON

STARTING CIRCUIT

GROUND CIRCUIT

STARTING AID CIRCUIT

FUNCTION LAMPS / GAGES / MONITOR CIRCUIT

ENGINE CONTROL CIRCUIT

DIRECTION AND SPEED CONTROL CIRCUIT

TRACTION CONTROL CIRCUIT

VIBRATORY CONTROL CIRCUIT

WATER SPRAY PUMP CONTROL CIRCUIT

HEATER AND AIR CONDITIONER CIRCUIT

TURN SIGNAL/WIPER/WASHER CIRCUIT

WIRE GROUP COLOR DESCRIPT IONS

OTHER COLOR DESCRIPTIONS

HIGHWAYS

CAN DATA LINK

FUSE BLOCK1249636 BASE

103-J1 YL-18-GXL

117-J52 RD-16

117-J13 RD-6

112-J10 PU-12

112-J66 PU-14

112-J175 PU-12

112-J15 PU-12

114-J24 GN-14-GXL

121-J18 YL-18-GXL

121-J19 YL-18-GXL

121-J20 YL-16

123-J22 WH-18-GXL

134-J160 YL-16

135-J26 BU-18-GXL

135-J85 BU-18-GXL

135-J159 BU-18-GXL

135-J31 BU-18-GXL

135-J32 BU-18-GXL

144-J36 GN-18-GXL

200-J178 BK-18-GXL

200-J44 BK-18-GXL

200-J45 BK-16

200-J46 BK-14-GXL

200-J47 BK-18-GXL

200-J54 BK-16 200-J62 BK-16

200-J63 BK-6

200-J64 BK-18-GXL

306-J67 GN-16

308-J69 YL-16

321-J72 BR-18-GXL

322-J186 GY-18-GXL

376-J79 GN-18-GXL

403-J80 GN-18-GXL

405-J81 GY-18-GXL

406-J82 PU-18-GXL

419-J84 YL-18-GXL

403-J80 GN-18-GXL

405-J81 GY-18-GXL

406-J82 PU-18-GXL

428-J88 OR-18-GXL

428-J88 OR-18-GXL

465-J96 OR-18-GXL

465-J96 OR-18-GXL

605-J98 YL-18-GXL

605-J98 YL-18-GXL

606-J99 GY-18-GXL

606-J99 GY-18-GXL

614-J102 PU-18-GXL

614-J104 PU-16

614-J107 PU-18-GXL

680-J111 GN-18-GXL

112-J15 PU-12

112-J175 PU-12

117-J157 RD-16

135-J28 BU-16

105-J4 BR-16

155-J39 PK-18-GXL

112-J10 PU-12

117-J52 RD-16

134-J160 YL-16

123-J22 WH-18-GXL

690-J182 GN-14-GXL

690-J182 GN-14-GXL

690-J189 GN-14-GXL

690-J189 GN-14-GXL

690-J163 GN-14-GXL

690-J163 GN-14-GXL

690-J173 GN-14-GXL

751-J128 GN-18-GXL

K708-J110BU-18-GXL

777-J131 PU-18-GXL

A914-J149OR-18-GXL

A914-J149OR-18-GXL

A915-J94 OR-18-GXL

A915-J94 OR-18-GXL

A916-J139GN-18-GXL

B439-J91 RD-18-GXL

B439-J91 RD-18-GXL

C444-J93 YL-18-GXL

C444-J93 YL-18-GXL

U734-J180GN-18-GXL

C926-J155BU-18-GXL

C926-J155BU-18-GXL

H751-J130OR-18-GXL

C932-J161YL-18-GXL

C933-J162GN-18-GXL

C927-J156PU-18-GXL

C927-J156PU-18-GXL

K725-J124GN-16-GXL

K725-J124GN-16-GXL

K726-J125BU-16-GXL

K726-J125BU-16-GXL

C936-J164GY-18-GXL

C936-J152GY-18-GXL

C937-J151WH-18-GXL

A990-J172BU-16-GXL

T825-J123YL-16-GXL

K918-J150GN-18-GXL

K919-J148YL-18-GXL

123-J177 WH-18-GXL

105-J2 BR-16

105-J5 BR-18-GXL

308-J70 YL-16

135-J29 BU-18-GXL

C933-J162GN-18-GXL

680-J111 GN-18-GXL

H750-J127BR-18-GXL

C932-J161YL-18-GXL

710-J165 GN-18-GXL

P979-J170YL-18-GXL

376-J79 GN-18-GXL

322-J186 GY-18-GXL

117-J13 RD-6

P978-J169GN-18-GXL

H751-J130OR-18-GXL

320-J65 OR-18-GXL

A 9 8 2 - J 1 7 1 B R - 1 8 - G X L

200-J42 BK-14-GXL

200-J45 BK-16

200-J62 BK-16

200-J178 BK-18-GXL

112-J12 PU-10

105-J5 BR-18-GXL

P979-J170YL-18-GXL

H751-J130OR-18-GXL

200-J57 BK-18-GXL

614-J107 PU-18-GXL

306-J67 GN-16

K919-J148YL-18-GXL

K918-J150GN-18-GXL

C926-J155BU-18-GXL

C927-J156PU-18-GXL

403-J80 GN-18-GXL

C444-J93 YL-18-GXL

321-J72 BR-18-GXL

B439-J91 RD-18-GXL

A982-J171BR-18-GXL

428-J88 OR-18-GXL

406-J82 PU-18-GXL

308-J68 YL-18-GXL

376-J79 GN-18-GXL

605-J98 YL-18-GXL

606-J99 GY-18-GXL

751-J128 GN-18-GXL

K726-J125BU-16-GXL

200-J64 BK-18-GXL

135-J29 BU-18-GXL

C933-J162GN-18-GXL

A916-J139GN-18-GXL

A915-J94 OR-18-GXL

A914-J149OR-18-GXL

135-J85 BU-18-GXL

135-J31 BU-18-GXL

135-J32 BU-18-GXL

H750-J127BR-18-GXL

710-J165 GN-18-GXL

K708-J110BU-18-GXL

144-J36 GN-18-GXL

123-J22 WH-18-GXL

103-J1 YL-18-GXL

200-J46 BK-14-GXL

C932-J161YL-18-GXL

C933-J162GN-18-GXL

419-J84 YL-18-GXL

E455-J213BR-18-GXL

B422-J215BU-18-GXL

175-J158 PK-18-GXL

105-J7BR-18-GXL

631-J134 GY-14-GXL

631-J135 GY-14

631-J133 GY-14-GXL

632-J137 WH-14-GXL632-J138 WH-14

632-J136 WH-14-GXL

646-J140 OR-16

647-J141 GN-16-GXL

652-J191 YL-14

652-J143 YL-14

652-J142 YL-14-GXL

653-J146 GN-14-GXL

653-J147 GN-14

653-J145 GN-14-GXL

C905-J167OR-18-GXL

C922-J179BR-18-GXL

105-J6 BR-18-GXL

B440-J93 WH-18-GXL

449-J181 WH-18-GXL

B440-J110WH-18-GXL

521-J101 YL-18-GXL

115-J176 PK-16

123-J34 WH-18-GXL

112-J17 PU-16

537-J120 GN-18-GXL

C928-J192GY-18-GXL

C929-J193WH-18-GXL

C936-J207GY-18-GXL

A631-J184BU-18-GXL

112-J109 PU-10

603-J121 PK-18-GXL

105-J7 BR-18-GXL

110-J14 GN-18-GXL

112-J16 PU-12

112-J16 PU-12

115-J176 PK-16

115-J23 PK-16

115-J23 PK-16

122-J30 BU-18-GXL

123-J33 WH-18-GXL

123-J33 WH-18-GXL

123-J34 WH-18-GXL

135-J43 BU-18-GXL

135-J43 BU-18-GXL

521-J101 YL-18-GXL

449-J181 WH-18-GXL

176-J144 OR-18-GXL

B440-J94 WH-18-GXL

603-J122 PK-18-GXL

200-J50 BK-18-GXL

200-J71 BK-16

200-J71 BK-16

B440-J110WH-18-GXL

449-J115 WH-18-GXL

449-J115 WH-18-GXL

521-J101 YL-18-GXL

X982-J174PU-18-GXL

537-J120 GN-18-GXL

603-J105 PK-18-GXL

603-J105 PK-18-GXL

B440-J93 WH-18-GXL

614-J168 PU-18-GXL

614-J168 PU-18-GXL

122-J30 BU-18-GXL

652-J142 YL-14-GXL

653-J145 GN-14-GXL

632-J136 WH-14-GXL

C729-J153BU-18-GXL

C730-J154BR-18-GXL

C905-J167OR-18-GXL

C903-J166BU-18-GXL

C922-J179BR-18-GXL

C923-J183OR-18-GXL

C928-J192GY-18-GXL

C928-J192GY-18-GXL

C929-J193WH-18-GXL

A916-J197GN-18-GXL

C935-J202PU-18-GXL

A915-J194OR-18-GXL

N929-J195YL-18-GXL

614-J129 PU-18-GXL

998-J212 BR-18-GXL

E455-J213BR-18-GXL

E455-J213BR-18-GXL

A429-J214YL-18-GXL

A429-J214YL-18-GXL

A429-J214YL-18-GXL

B422-J215BU-18-GXL

B422-J215BU-18-GXL

X982-J174PU-18-GXL

A631-J184BU-18-GXL

447-J114 PK-18-GXL

447-J114 PK-18-GXL

447-J114 PK-18-GXL

155-J38 PK-18-GXL

135-J3 BU-18-GXL

J723-J11 GY-18-GXL

J723-J11 GY-18-GXL

200-J55 BK-18-GXL

J710-J56 BR-18-GXL

J710-J56 BR-18-GXL

200-J187 BK-18-GXL

C937-J151WH-18-GXL

306-J67 GN-16

419-J188 YL-18-GXL

C923-J183OR-18-GXL

U735-J185GY-18-GXL

N929-J195YL-18-GXL

C937-J151WH-18-GXL

C929-J193WH-18-GXL

200-J59 BK-18-GXL

200-J59 BK-18-GXL

K709-J108GY-18-GXL

K919-J148YL-18-GXL

K918-J150GN-18-GXL

419-J217 YL-18-GXL

K709-J108GY-18-GXL

A631-J201BU-18-GXL

751-J128 GN-18-GXL

C903-J166BU-18-GXL

C905-J167OR-18-GXL

U734-J180GN-18-GXL

405-J86 GY-18-GXL

405-J86 GY-18-GXL

465-J89 OR-18-GXL

405-J83 GY-18-GXL

405-J83 GY-18-GXL

H750-J127BR-18-GXL

710-J165 GN-18-GXL

419-J217 YL-18-GXL

P978-J169GN-18-GXL

P979-J170YL-18-GXL

135-J60 BU-16

A990-J172BU-16-GXL

T825-J123YL-16-GXL

200-J92 BK-18-GXL

200-J91 BK-18-GXL

200-J91 BK-18-GXL

200-J92 BK-18-GXL

135-J61 BU-18-GXL

135-J74 BU-18-GXL

A916-J97 GN-18-GXL

X982-J174PU-18-GXL

U735-J185GY-18-GXL

A631-J95 BU-18-GXL

777-J131 PU-18-GXL

777-J131 PU-18-GXL

465-J89 OR-18-GXL

C903-J166BU-18-GXL

C905-J167OR-18-GXL

537-J120 GN-18-GXL

A925-J112YL-18-GXL

A925-J112YL-18-GXL

A926-J113YL-18-GXL

A926-J113YL-18-GXL

A982-J171BR-18-GXL

A249-J77 BK-18-GXL

F712-J76 GY-18-GXL

200-J53 BK-18-GXL

614-J106 PU-18-GXL

K709-J40 GY-18-GXL

K708-J51 BU-18-GXL

135-J8 BU-18-GXL

135-J9 BU-18-GXL

135-J21 BU-18-GXL

F711-J75 GN-18-GXL

F711-J218GN-18-GXL

F 7 1 1 - J 1 1 7 G N - 1 8 - G X L

F712-J220GY-18-GXL

A249-J190BK-18-GXL

F 7 1 2 - J 1 1 9 G Y - 1 8 - G X L

A 2 4 9 - J 2 2 1 B K - 1 8 - G X L

200-J58 BK-18-GXL

135-J21 BU-18-GXL

K708-J110BU-18-GXL

135-J35 BU-18-GXL

449-J116 WH-18-GXL

449-J116 WH-18-GXL

110-J222 GN-18-GXL

114-J25 GN-14-GXL

608-J126 GN-14-GXL

608-J126 GN-14-GXL

619-J132 GN-18-GXL

619-J132 GN-18-GXL

619-J132 GN-18-GXL

998-J212 BR-18-GXL

614-J129 PU-18-GXL

200-J73 BK-18-GXL

C730-J154BR-18-GXL

175-J158 PK-18-GXL

C729-J153BU-18-GXL

175-J334 PK-18

200-J332 BK-18

C729-J337 BU-18

U734-J335 GN-18

F877-J333 WH-18

F877-J333 WH-18

330-J336 YL-18

330-J78 YL-18-GXL

330-J78 YL-18-GXL

330-J79 YL-18-GXL

604-J37 YL-18-GXL

604-J37 YL-18-GXL

200-J332 BK-18

175-J334 PK-18

C729-J337BU-18

B422-J215BU-18-GXL

449-J116 WH-18-GXL

447-J114 PK-18-GXL

406-J82 PU-18-GXL

428-J88 OR-18-GXL

E455-J213BR-18-GXL

C444-J93 YL-18-GXL

405-J81 GY-18-GXL

605-J98 YL-18-GXL

606-J99 GY-18-GXL

647-J141 GN-16-GXL

646-J140 OR-16

603-J121 PK-18-GXL

135-J90 BU-18-GXL

465-J96 OR-18-GXL

C926-J155BU-18-GXL

C927-J156PU-18-GXL

B439-J91 RD-18-GXL

B440-J93 WH-18-GXL

403-J80 GN-18-GXL

603-J122 PK-18-GXL

B440-J94 WH-18-GXL

176-J144 OR-18-GXL

117-J13 RD-6

112-J109 PU-10

200-J63 BK-6

F711-J75 GN-18-GXL

F712-J76 GY-18-GXL

A249-J77 BK-18-GXL

N929-J195YL-18-GXL

P978-J169GN-18-GXL

330-J79 YL-18-GXL

465-J87 OR-18-GXL

308-J69 YL-16

105-J2 BR-16

653-J147 GN-14

652-J191 YL-14

631-J135 GY-14

632-J138 WH-14

614-J102 PU-18-GXL

135-J28 BU-16

135-J26 BU-18-GXL

135-J159 BU-18-GXL

A916-J197GN-18-GXL

N929-J195YL-18-GXL

A915-J194OR-18-GXL

105-J7 BR-18-GXL

105-J100 BR-18-GXL

135-J26 BU-18-GXL

652-J143 YL-14

176-J144 OR-18-GXL

122-J30 BU-18-GXL

632-J137 WH-14-GXL

653-J146 GN-14-GXL

110-J14 GN-18-GXL

135-J28 BU-16

175-J158 PK-18-GXL

112-J10 PU-12

631-J134 GY-14-GXL

123-J177 WH-18-GXL

112-J16 PU-12

105-J4 BR-16

121-J20 YL-16

117-J52 RD-16

144-J36 GN-18-GXL

103-J1 YL-18-GXL

603-J121 PK-18-GXL

680-J111 GN-18-GXL

200-J41 BK-16

C932-J161YL-18-GXL

C922-J179BR-18-GXL

135-J90 BU-18-GXL

A631-J95 BU-18-GXL

614-J104 PU-16

614-J104 PU-16

A916-J97 GN-18-GXL

A915-J103OR-18-GXL

A914-J149OR-18-GXL

A916-J197GN-18-GXL

A916-J97 GN-18-GXL

690-J189 GN-14-GXL

690-J182 GN-14-GXL

647-J141 GN-16-GXL

690-J163 GN-14-GXL

200-J42 BK-14-GXL

646-J140 OR-16

105-J5 BR-18-GXL330-J78 YL-18-GXL

134-J160 YL-16

112-J12 PU-10

200-J41 BK-16

114-J24 GN-14-GXL

112-J17 PU-16

112-J66 PU-14

419-J84 YL-18-GXL

114-J25 GN-14-GXL

114-J24 GN-14-GXL

J723-J11 GY-18-GXL

200-J55 BK-18-GXL

J723-J11 GY-18-GXL

200-J46 BK-14-GXL

200-J42 BK-14-GXL

200-J41 BK-16

200-J55 BK-18-GXL

200-J62 BK-16

200-J71 BK-16

200-J54 BK-16

614-J129 PU-18-GXL

C936-J207GY-18-GXL

200-J73 BK-18-GXL

C936-J207GY-18-GXL

C730-J154BR-18-GXL

998-J212 BR-18-GXL

200-J73 BK-18-GXL

C729-J153BU-18-GXL

T825-J123YL-16-GXL

135-J61 BU-18-GXL

200-J92 BK-18-GXL

A990-J172BU-16-GXL

135-J74 BU-18-GXL

110-J14 GN-18-GXL

C936-J164GY-18-GXL

C935-J202PU-18-GXL

C935-J202PU-18-GXL

C923-J183OR-18-GXL

608-J126 GN-14-GXL

121-J20 YL-16

322-J186 GY-18-GXL

320-J65 OR-18-GXL

320-J65 OR-18-GXL

619-J132 GN-18-GXL

200-J50 BK-18-GXL

200-J48 BK-18-GXL

200-J49 BK-18-GXL

121-J18 YL-18-GXL

121-J19 YL-18-GXL

115-J23 PK-16

200-J59 BK-18-GXL

200-J47 BK-18-GXL

200-J48 BK-18-GXL

200-J64 BK-18-GXL

200-J49 BK-18-GXL

200-J73 BK-18-GXL

200-J178 BK-18-GXL

200-J63 BK-6

X982-J174PU-18-GXL

112-J12 PU-10

112-J17 PU-16

112-J66 PU-14

308-J70 YL-16

J710-J56 BR-18-GXL

112-J175 PU-12

112-J15 PU-12

117-J157 RD-16

112-J109 PU-10

200-J45 BK-16

537-J120 GN-18-GXL

200-J44 BK-18-GXL

115-J23 PK-16

419-J188 YL-18-GXL

U734-J335 GN-18

U734-J180GN-18-GXL

135-J27 BU-18-GXL

135-J27 BU-18-GXL

155-J39 PK-18-GXL

U735-J185GY-18-GXL

K709-J108GY-18-GXL

200-J187 BK-18-GXL

200-J187 BK-18-GXL

690-J173 GN-14-GXL

135-J3 BU-18-GXL

135-J60 BU-16

308-J68 YL-18-GXL

105-J4 BR-16

105-J100 BR-18-GXL

465-J87 OR-18-GXL

135-J74 BU-18-GXL

135-J61 BU-18-GXL

135-J90 BU-18-GXL

A631-J95 BU-18-GXL

A631-J201BU-18-GXL

A915-J103OR-18-GXL

117-J157 RD-16

103-A1 YL-18

103-A2 YL-18

144-A13 GN-18

200-A14 BK-18

200-A15 BK-18

200-A16 BK-18

115-A5 PK-14-GXL

200-A29 BK-18

200-A33 BK-18

428-A41 OR-18

536-A45 WH-18

536-A46 WH-18

537-A109 GN-18

603-A51 PK-18

614-A100 PU-18

614-A62 PU-18

614-A68 PU-18

614-A69 PU-18

614-A72 PU-18

C924-A93 YL-18

C925-A94 GN-18

C927-A96 PU-18

C933-A98 GN-18

E455-A99 BR-18

123-A8 WH-18

123-A6 WH-18

123-A11 WH-18

123-A7 WH-18

123-A9 WH-18

200-A22 BK-18

200-A104 BK-14

200-A20 BK-18

200-A21 BK-18

200-A36 BK-18

200-A26 BK-18

200-A31 BK-18

403-A37 GN-18

447-A42 PK-18

449-A43 WH-18

200-A17 BK-18

200-A35 BK-18

200-A18 BK-18

200-A102 BK-14

605-A52 YL-18

B440-A91 WH-16

614-A66 PU-16

614-A74 PU-16

614-A65 PU-18

614-A63 PU-18

614-A78 PU-18

6 1 4 - A 7 6 P U - 1 8

614-A75 PU-18

537-A49 GN-18

200-A47 BK-18c0

6 1 4 - A 6 6

P U - 1 6

105-A12 BR-16

606-A91 GY-18

680-A80 GN-18

C927-A96 PU-18

144-A13 GN-18

330-A83 YL-18

465-A44 OR-18

200-A34 BK-14-GXL

603-A51 PK-18

646-A79 OR-18

C926-A95 BU-18

449-A43 WH-18

447-A42 PK-18

614-A71 PU-18

C906-A82 PU-18

614-A74 PU-16

646-A79 OR-18

C925-A94 GN-18

200-A34 BK-14-GXL

C924-A93 YL-18

A631-A81 BU-18

C932-A56 YL-18

C933-A98 GN-18

103-A1 YL-18

680-A80 GN-18

105-A12 BR-16

406-A39 PU-18

428-A41 OR-18

B440-A89 WH-18

B439-A86 RD-18

647-A58 GN-18

605-A54 YL-18

405-A38 GY-18

C444-A92 YL-18

B439-A86 RD-18

C926-A95 BU-18

B440-A89 WH-18

403-A37 GN-18

200-A50 BK-18

614-A97 PU-18

C903-A84 BU-18C905-A145 OR-18

X982-A53 PU-18

A915-A167 OR-18

N929-A168 YL-18

A916-A170 GN-18

103-A3 YL-18

123-A106 WH-18

B422-A81 BU-18

200-A57 BK-18

B422-A81 BU-18

C903-A84 BU-18

X982-A53 PU-18

135-A4 BU-18

135-A4 BU-18

C905-A145 OR-18

135-A10 BU-18

135-A107 BU-18

135-A73 BU-18

614-A77 PU-18

200-A25 BK-18

115-A59 PK-14

200-A28 BK-18

614-A85 PU-18

200-A301 BR-18

105-A300 BR-18

614-A302 PU-18

135-A73 BU-18

E455-A99 BR-18

465-A44 OR-18

405-A38 GY-18

406-A39 PU-18

614-A64 PU-18

647-A58 GN-18

115-A5 PK-14-GXL

537-A48 GN-18

C932-A56 YL-18

614-A97 PU-18

606-A91 GY-18

605-A54 YL-18

536-A46 WH-18

537-A49 GN-18

123-A101 WH-18

A631-A81 BU-18

200-A18 BK-18

A916-A170 GN-18

N929-A168 YL-18

A915-A167 OR-18

200-A17 BK-18

419-A40 YL-18

406-A39 PU-18

428-A41 OR-18

E455-A99 BR-18

465-A44 OR-18

C444-A92 YL-18

C444-A92 YL-18

405-A38 GY-18

200-A14 BK-18

123-A8 WH-18

200-A36 BK-18

606-A55 GY-18

449-A43 WH-18

B422-A81 BU-18

200-A30 BK-18 447-A42 PK-18

123-A6 WH-18

123-A6 WH-18

200-A102 BK-14

200-A102 BK-14

200-A32 BK-18

200-A26 BK-18

200-A57 BK-18

614-A97 PU-18

B440-A91 WH-16

200-A32 BK-18

200-A32 BK-18

200-A27 BK-18

200-A26 BK-18

C906-A82 PU-18

200-A24 BK-18

200-A23 BK-18

200-A105 BK-18

200-A50 BK-18

200-A15 BK-18

B440-A91 WH-16

614-A100 PU-18

103-A3 YL-18

200-A36 BK-18

614-A71 PU-18

614-A71 PU-18

200-A14 BK-18

123-A8 WH-18

200-A57 BK-18

135-A10 BU-18

C933-A98 GN-18

200-A25 BK-18

200-A27 BK-18

123-A106 WH-18

123-A9 WH-18

123-A7 WH-18

200-A19 BK-16

200-A21 BK-18

200-A19 BK-16

200-A20 BK-18

123-A101 WH-18

200-A103 BK-18

614-A77 PU-18

614-A65 PU-18

200-A24 BK-18

614-A68 PU-18

614-A69 PU-18

115-A59 PK-14

115-A303 PK-18

115-A303 PK-18

200-A33 BK-18

614-A72 PU-18

614-A302 PU-18

200-A35 BK-18

605-A52 YL-18

606-A55 GY-18

200-A27 BK-18

614-A75 PU-18

614-A64 PU-18

419-A40 YL-18

330-A83 YL-18

537-A109 GN-18

200-A35 BK-18

200-A57 BK-18

200-A26 BK-18

200-A27 BK-18

200-A104 BK-14

200-A104 BK-14

200-A32 BK-18

123-A106 WH-18

123-A9 WH-18

123-A101 WH-18

123-A7 WH-18

200-A20 BK-18

200-A19 BK-16

200-A36 BK-18

200-A21 BK-18

614-A71 PU-18

123-A11 WH-18

123-A11 WH-18

200-A30 BK-18

200-A22 BK-18

200-A34 BK-14-GXL

200-A22 BK-18

200-A103 BK-18

200-A103 BK-18

200-A105 BK-18

200-A31 BK-18

200-A23 BK-18

200-A50 BK-18

200-A105 BK-18

200-A24 BK-18

200-A23 BK-18

200-A31 BK-18

614-A74 PU-16

614-A78 PU-18

614-A65 PU-18

614-A77 PU-18

614-A78 PU-18

614-A64 PU-18

614-A64 PU-18

614-A302 PU-18

115-A303 PK-18

115-A59 PK-14

614-A69 PU-18

614-A68 PU-18

536-A46 WH-18

537-A49 GN-18

200-A33 BK-18

614-A72 PU-18

614-A100 PU-18

200-A15 BK-18

103-A3 YL-18

1 0 3 - A 2

Y L - 1 8

614-A66 PU-16

B440-A91 WH-16

614-A97 PU-18

605-A52 YL-18

605-A52 YL-18

606-A55 GY-18

606-A55 GY-18

200-A14 BK-18

105-J6 BR-18-GXL

105-J6 BR-18-GXL

C729-J337 BU-18

A925-J112YL-18-GXL

A926-J113YL-18-GXL

123-J22 WH-18-GXL

123-J22 WH-18-GXL

123-J34 WH-18-GXL

105-J4 BR-16

112-J10 PU-12

112-J16 PU-12

105-J5 BR-18-GXL

105-J5 BR-18-GXL

112-J175 PU-12

112-J175 PU-12

200-J58 BK-18-GXL

200-J58 BK-18-GXL

117-J157 RD-16

135-J27 BU-18-GXL

135-J27 BU-18-GXL

155-J39 PK-18-GXL

155-J39 PK-18-GXL

134-J160 YL-16

134-J160 YL-16

117-J52 RD-16

121-J20 YL-16

110-J14 GN-18-GXL

110-J14 GN-18-GXL

112-J15 PU-12

U734-J335 GN-18

U734-J335 GN-18

603-J121 PK-18-GXL

603-J121 PK-18-GXL

C936-J164GY-18-GXL

C936-J164GY-18-GXL

A631-J95 BU-18-GXL

A631-J95 BU-18-GXL

419-J188 YL-18-GXL

419-J84 YL-18-GXL

419-J84 YL-18-GXL

449-J116 WH-18-GXL

121-J20 YL-16

A249-J77 BK-18-GXL

F712-J76 GY-18-GXL

F711-J75 GN-18-GXL

135-J90 BU-18-GXL

K725-J124GN-16-GXL

465-J96 OR-18-GXL

465-J96 OR-18-GXL

200-J92 BK-18-GXL

200-J92 BK-18-GXL

200-J91 BK-18-GXL

200-J91 BK-18-GXL

200-J91 BK-18-GXL

200-J49 BK-18-GXL

200-J49 BK-18-GXL

200-J49 BK-18-GXL

200-J50 BK-18-GXL

200-J50 BK-18-GXL

200-J50 BK-18-GXL

200-J48 BK-18-GXL

200-J48 BK-18-GXL

200-J48 BK-18-GXL

320-J65 OR-18-GXL

200-J47 BK-18-GXL

200-J47 BK-18-GXL

200-J47 BK-18-GXL

115-J23 PK-16

115-J23 PK-16

537-J120 GN-18-GXL537-J120 GN-18-GXL

330-J78 YL-18-GXL

320-J65 OR-18-GXL

200-J44 BK-18-GXL

200-J44 BK-18-GXL

308-J70 YL-16

308-J70 YL-16

614-J102 PU-18-GXL

200-J71 BK-16

200-J71 BK-16

200-J54 BK-16

200-J54 BK-16

200-J54 BK-16

A915-J94 OR-18-GXL

A915-J94 OR-18-GXL

614-J104 PU-16

200-J44 BK-18-GXL

155-J39 PK-18-GXL

112-J16 PU-12

117-J52 RD-16

112-J10 PU-12

135-J90 BU-18-GXL

419-J188 YL-18-GXL

112-J15 PU-12

134-J160 YL-16

117-J157 RD-16

631-J133 GY-14-GXL

321-J72 BR-18-GXL

200-J58 BK-18-GXL

200-J64 BK-18-GXL

200-J178 BK-18-GXL

200-J50 BK-18-GXL

419-J188 YL-18-GXL

A982-J171BR-18-GXL

114-J25 GN-14-GXL

200-J44 BK-18-GXL

690-J173 GN-14-GXL

C903-J166BU-18-GXL

1 0 5 - A 3 0 0 B R - 1 8

2 0 0 - A 3 0 1 B R - 1 8

123-J34 WH-18-GXL

C936-J152GY-18-GXL

MATINGCONNECTORC-C13E3376LOCATIONVOL2 F-7

MATINGCONNECTORC-C23E5179LOCATIONVOL2 F-8

MATINGCONNECTORG-C11030213LOCATIONVOL1 H-8

MATINGCONNECTORC-C161275485LOCATIONVOL2 F-8

H8

H8

H10

H11

H9

H11

H10

TWISTEDPAIR

6 0 4 - L P 2

O R - 1 8

6 0 4 -L P 1 O R -1 8 6 0 4- E J1 O R -1 8

330-J78 YL-18-GXL

IRH ONLY

MATINGCONNECTORG-C59G4348LOCATIONVOL1 F-8

FORIRHSPLITDRUMONLY

REARHIGHINTR2

20A

1138492

POWERPORTFUSE2

10A

1138490

RECORDERFUSE2

15A

113-8491

JOINTCUTTER2

10A

113-8490

HITCHOFFSET2

10A

1138490

BRAKEFUSE2

15A

1138491

FRONTHIGHINTL2

20A

1138492

GAUGE2

15A

1138491

BREAKERAS.

LIGHTBREAKER15A6T3643

ROTATINGBEACON2

10A

1138490

BACKUPALARMFUSE2

15A

1138491

WATERSPRAY FUSE2

10A

1138490

PROPELCONTROLFUSE2

15A

1138491

VIBFUSE2

10A

1138490

REARHIGHINTL2

20A

1138492

1

2

3

4

5

6

7

8

J-C71429117

THRTTLE 2 SPEED

1957637

GN

BR

OR

ST

ON

OFF

B

S

C

R

KEY START SWITCH 21543197

YL

STAID

PROPEL CONTROL 22308771

N/CWATERSPRAY

+SWITCHCOMMON

N/CLEFTDRUMOFFSET

N/OLEFTDRUMOFFSET

N/OVIB

N/CVIB

N/CHORN

N/OHORN

N/OWATERSPRAY

N/ORIGHTDRUMOFFSET

N/CRIGHTDRUMOFFSET

-GROUND

+BATTERY

SIGNAL

CAL

SENSOR2572531

A1 A2 A3 A4 A5 A6 A7 A8 A9

B1B2B3B4B5B6B7B8B9

C1C2C3C4C5C6C7C8C9

D1D2D3D4D5D6D7D8D9

J-C241249636

1

2

3

4

J-C121733047

CONSOLE GROUND 2M12 STUD

IGNITION2

10A

1138490

FRONTHIGHINTR2

20A

1138492

1

2

J-C151552273

3

4

5

6

WH-14

BK-14

OR-14

AUTOSPEED CONTROL12708384J-C13

1552267 A

B

C

WATERSPRAY 11409378

WATERSPRAY 21409378

BACKUPALARM21409378

HORNRELAY21409378

REARLIGHT1409378

FRONTLIGHT1409378

+ -

AUXPORT 11787539

1 2

PROPEL 2 SPEED 22621412

1

2

3

4

5

6

7

8

J-C81429117

BK-18

BK-18

MAIN RELAY 22418367

1

2

J-C163E3364

1

J-C259G4351

BK-18

BK-18

HIGHINTRELAY12418367

1

2

J-C273E3364

PLATFORMSTUD1

M12STUD

4 3

21

BLOCK-LIGHT1166565BLOCK-CONTACT1165277

X1

X2

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

J-C17X6222

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

J-C29X0146

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

J-C92538112

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

1

2

J-C111552252

3

4

5

6

7

8

9

10

11

12

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

J-C179X4391

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

1

2

3

4

J-C311552272

LIGHT BREAKER 20A 26T3644

1

2

3

4

5

6

7

8

9

10

11

12

J-C291552252

DIFF LOCK SWITCH 27T2296

DIFF LOCK INDICATOR 28L9801

J-C41552267

A B C

J-C51552267

A B C

1

2

RESISTOR AS2405204

3

4

5

6

J-C61552273

RESISTOR1342540120

J-C141740502

A B C

J-C181552267

A

B

C

JUMPER2660539

A B C

W H - 1 6

JUMPER 32660541

A B C

W H - 1 6

1

2

3

4

5

6

7

8

J-C101429117

1

J-C301275486

GROUND

POWER

LAMP(OUT)

FLASHER 27T4848

J-C221129609

A1 A2

A3

A4

A5

B 1 B 2

B3

B4

B5

C 1 C 2

C3

C4

C5

D 1 D 2

D3

D4

D5

E 1 E 2

E3

E4

E5

F1 F2

F3

F4

F5

30

86

85

87

87a

J-C261116795

1

2

J-C31552264

3

4

5

6

7

8

J-C213E3388

J-C201552267

AB

C

1

2

J-C191552272

3

4

NUETRAL POS SENSOR AS2838438

BUBR

BK

DIODE PACK1729200

MUR460

MUR460

MUR460

1

2

3

4

5

6

7

8

A-C161429117

VIB HIGH LOW AMP 12216988

1

2

3

4

5

6

7

8

A-C171429117

1

2

3

4

5

6

7

8

A-C31429117

1

2

3

4

5

6

7

8

A-C141429117

1

2

3

4

5

6

7

8

A-C131429117

1

2

3

4

5

6

7

8

A-C21429117

VIB AUTO MAN 22247837

1

2

3

4

5

6

7

8

A-C11429117

54

3

6

2

1

TURN SIGNAL SW 21384894

VIB DRUM SELECT 22247835

LIGHT SELECT2247836

PARKINGBRAKE

GROUND

NEUTRAL

GROUND

BRAKE LIGHT 22236540

BATTERY

LOWCHARGEPRESS

GROUND

HYDRAULICTEMP

HYDRAULICFILTER

POWER

FUNCTION LAMPS 22236539

COOLANTTEMP

OILPRESS

BACKLIGHTLAMP

GROUND

LHTURNLAMP

GROUND

BACKLIGHT LAMP LH 22236540

BACKLIGHTLAMP

GROUND

RHTURNLAMP

GROUND

BACKLIGHT LAMP RH 22236540

1

2

3

4

5

6

A-C151117898

WATERSPRAY

GROUND

VIBRATOR

GROUND

SPRAY VIB LIGHT 22236540

A-C261552267

A

B

C

1

2

A-C61552252

3

4

5

6

7

8

9

10

11

12

1

2

A-C101552272

3

4

1

2

A-C181552272

3

4

1

2

A-C41552272

3

4

1

2

A-C111552272

3

4

A-C251552267

A

B

C

1

2

A-C241552269

A-C211141749

I

S

G

A-C221141749

I

S

G

FUEL LEVEL GAGE 21723570

IGNSEND

GRD

A-C199X0146

A-C207X6222

A-C231141749

I

S

G

WATER PUMP SELECT 2

1957634

A-C271957639

11

13

14

3

12

15

16

6 9

10

WH-14

BK-14

OR-14

WATER SPRAY TIMER2761827

+ -

SIG

HOURMETER 22005717

HAZARD SW 21957632

2

3

5

6

7

A-C121429117

8

1

4

ARC SUP DIODE1893158

MUR4601

2

A-C501552269

LIGHT MASTER 22247834

1

2

LP-C13E3364

EJ-C11552269

PROPEL 3 SPEED2621411

BEACON 21957631

HID SWITCH 22247831

DIRECTION AND SPEED CONTROL3021426

SWVIBEHI/LOAM

PRPLSPDMODE2

CAN1SHIELD

CAN1DATALINKHIGH

CAN1DATALINKLOW

ENGINEOILPRESS

SWWATERON/OFF

SWWTRPUMP2

SWWTRPUMP1

SWVIBEAT/MN

SWNCPRKBRK

DRUMOFFSETRH

VIBESYSCONFIG

POWERGROUND-

POWERSUPPLY+

SWNOPRKBRK

DRUMOFFSETLH

5 V D C S E N S O R +

SENSORPWRGRND

PRPLSPDMODE1

CNFGPINANALOG

NEUTRALSWITCH

PRPLHNDLSPDPWM

HYDCHARGEPRESS

DOUTWATERPMP1

SPEEDDIALPOT

DOUTWATERPMP2

LIGHTPRKBRAKE

SWVIBON/OFF

WTRTIMER POT

LIGHTNTRLSTART

ZERODGROFFSET

LIGHTVIBEON

PWMOUT2SPDSOL

PWMOUTFWDPROPEL

PWMOUTRVRPROPEL

PWMOUTVIBEPFWD

PWMOUTVIBEPRVR

DOUTPARKBRAKE

DRUMOFFSETLEFT

DRUMOFFSETRIGHT

SHUNTVALVE

POWERSUPPLY+

POWERSUPPLY+

POWERSUPPLY+

POWERSUPPLY+

DOUTBACKUPALARM

LIGHTWATERSPRAY

SPEEDOMETER 21974694

WATER LEVEL GAGE 21974692

VIBE TACH 21974695

JUMPER 22660537

A B C

W H - 1 6

JUMPER 42660540

A B C

W H - 1 6

POWER DISTRIBUTION

POWER DISTRIBUTION

VIBCONFIG

MODELCONFIG

5 AMP 2-4 AMP 534D 434D

WIRE AS 271-2760STOP LAMP HARNESS 271-2759

MAIN HARNESS 297-8775 ( IRH ONLY)

MAIN HARNESS 297-8775 ( IRH ONLY)

INSTR HARNESS 265-7413 ( IRH ONLY)

INSTR HARNESS 265-7413 ( IRH ONLY)

WIRES IN THE FOLLOWINGGROUPS SHALL BE TWISTED:ONE TWIST PER 25 MM.

WIRE GROUP WIRE NAME

AH_TW1 A249-AH63

AH_TW1 F711-AH61

AH_TW1 F712-AH62

AH_TW2 A249-AH67

AH_TW2 F711-AH65

AH_TW2 F712-AH66

AH_TW3 A249-AH5

AH_TW3 F711-AH3

AH_TW3 F712-AH4

J _T W1 A 24 9- J7 7

J _T W1 F 71 1- J7 5

J _T W1 F 71 2- J7 6

J _T W2 A 24 9- J2 21

J _T W2 F 71 1- J1 17

J _T W2 F 71 2- J1 19

J _T W3 A 24 9- J1 90

J _T W3 F 71 1- J2 18

J _T W3 F 71 2- J2 20

L_TW1 944-L5

L_TW1 945-L6

HARNESS ASSEMBLY

I DE NT S H /L OC P AR T N O. A TC H G RO UP N A ME

A SH3/H5 300-4138 IRH INSTRUMENT PANEL

AC SH1/G4 251-1616 STD INSTR HARNESS

AH SH2/F3 290-6094 STD ADAPTER HARNESS

C S H2 /F 8 2 53 -1 39 5 S TD C AB H AR NE SS

E S H 1/ G1 2 2 66 -9 4 32 S TD E N GI NE H AR NE S S

EC SH2/F1 284-8474 STD PLATFORM EDGE CUTTER OPTION

EU SH2/D2 284-8475 STD REAR EGDE CUTTER OPTION

E J S H3 /H 11 2 71 -2 76 0 I RH W IR E A S

F SH1/H11 223-9737 STD HID LIGHTING (ROPS)

F SH1/A9 226-2676 STD HID LIGHTING (OPEN PLATFORM)

G S H1 /G 12 2 50 -3 39 9 S TD F RO NT V EH IC LE

H S H1 /C 12 2 37 -0 45 1 S TD R EA R V EH IC LE

J S H 3/ H1 0 2 97 -8 7 75 I RH P LA T FO RM HA RN E SS

J C S H 2/ A5 2 31 -3 3 03 O PT E DG E C UT T ER H A RN ES S

J N S H1 /H 8 2 91 -6 18 0 S TD M AI N H AR NE SS

K S H 1/ H1 3 2 56 -6 8 03 O PT P RO DU C T L I NK H A RN ES S

LT SH2/C3 247-8631 OPT HARNESS AS (SPLIT DRUM REAR)

M SH2/B4 247-8630 OPTHARNESS AS (SPLIT DRUM FRONT)

R SH1/F14 222-2842 OPT AIR CONDITIONER HARNESS

R M S H 2/ C8 2 19 -7 0 14 O PT R EC O RD IN G M OD U LE

L S H1 /H 13 2 57 -9 36 3 O PT H AR NE SS A S

V H S H 1/ B1 2 2 82 -9 0 84 S TD J U MP ER H AR NE S S

L P S H 3/ H1 2 2 71 -2 7 59 I RH S TO P L AM P H AR N ES S

PM S H 2/ D2 2 7 5- 9 33 9 O PT H AR NE S S A S

NOTE A: FOR 2 AMPLITUDE OR VERSA-VIB OPTION CONNECT C20 TO C18 AND CONNECT C21 TO C19. FOR 5 AMPLITUDE OPTION CONNECT C20 TO C19 AND C21 TO C18.

NOTE B: THE COLD START ADVANCE SOLENOID IS PART OF THE FUEL INJECTION PUMP

NOTE C: THE TWO OPTIONAL RADIO WIRES NEEDS TO BE HEATSHRINK OR WRAP WITH ELECTRICAL TAPE

NOTE: SH = SHEET = VOLUME

CONN 34

CONN 33

BRAKE SW

CONN 31

CONN 13

CONN 12

CONN 14

CONN 32

CONN 15

CONN 11

614-J129 PU-18

Caterpillar CB 534D Serie FGH Sist. Electrico

Documents

Transcript of Caterpillar CB 534D Serie FGH Sist. Electrico