ZZK/CLAB-KSPCB/04/ 5491 Environmental Officer, · PDF fileEnvironmental Officer, Regional...

ZZK/CLAB-KSPCB/04/ 549109-10-2017

Environmental Officer,Regional Office, Speed Post with A D Karnataka State Pollution Control Board“ Parisara Bhavan” , LIG – II, B –B-1, Main Road, A-16th CrossNear Hari Om Trust, HabbuwadaKARWAR – 581 303

Dear Sir:

Sub: Water pollution Control Report

We are sending herewith the following for the month of Sept

1. The weekly analysis report of treated mill effluent (including sewage).2. Daily readings of on-line meter of D.O, Temperature & flow at single point discharge, with Energy

consumption. 3. Upstream & Downstream water quality monitoring report of Ka

We hope you will find this in order.

Thanking You,

Very truly yours,THE WEST COAST PAPER MILLS LTD

B H RathiPresident (Technical)

Encl: As above

Regional Office, Speed Post with A D State Pollution Control Board

217

Near Hari Om Trust, Habbuwada

Sub: Water pollution Control Report

We are sending herewith the following for the month of September 2017.

The weekly analysis report of treated mill effluent (including sewage).line meter of D.O, Temperature & flow at single point discharge, with Energy

Upstream & Downstream water quality monitoring report of Kali River.


THE WEST COAST PAPER MILLS LTD

Regional Office, Speed Post with A D

line meter of D.O, Temperature & flow at single point discharge, with Energy

I Week

II Week

III Week

IV Week

There was breakdown or failure

of the plant

Under Performance was noticed

A Industrail effluent

2 Suspended solids mg/I 50.0 [ max ] 31 37 31 30 32

3 Particle size of suspended solids mg/I <850 <850 <850 <850

4 Dissolved solids [inorganics] mg/I 2100 [ max ] 480 526 444 584 509

5 Temperature o C 36 37 32 36 Continuous 35

6 pH value 7.0 - 8.5 7.4 7.4 7.2 7.4 7.4

7 Oil & Greese mg/I 10.0 [ max ] Nil Nil Nil Nil Nil

8 Total residual chlorine mg/I 1.0 [ max ] Nil Nil Nil Nil Nil

9 Ammonical Nitrogen [as N] mg/I 50.0 [ max ] Nil Nil Nil Nil Nil

10 Total Kjeldhal Nitrogen [as N] mg/I 100.0 [ max ] 1.2 1.0 1.0 1.1 1.1

11 Free Ammonia [ as NH3 ] mg/I 5.0 [ max ] Nil Nil Nil Nil Nil

12 Bio Chemical Oxygen Demand mg/I 17

[3 days at 27 o C ] Nil

13 Chemical Oxygen Demand mg/I 250.0 [ max ] 126 137 125 131 130

14 Chloride [ as CI ] mg/I 350.0 [ max ] 152 158 148 144 150.5

15 Dissolved Phosphate [ as P ] mg/I 5.0 [ max ] Nil Nil Nil Nil Nil

16 Sulphate [ as SO4] mg/I 1000.0 [ max ] 50 46 62 50 52

17 Sulphide [ as S ] mg/I 2.0 [ max ] Nil Nil Nil Nil Nil

18 Phenolic compound [ as C6H5OH ] mg/I 1.0 [ max ] Nil Nil Nil Nil Nil

19 Bio assay

Date : 09 -10 -2017

Signature :

Name : B H RathiPresident Technical

Address : West Coast Paper Mills Ltd.,

Bangur Nagar DANDELI . ( U.K.) 581-325

WEST COAST PAPER MILLS LIMITED, DANDELICentral Laboratory ( IPC )

Report of analysis of treated effluent along with treated sewage showing performance of the treatment plant for the month of

Sep-2017

sample collected & tested by CENTRAL LABORATORY (IPC)

SL.No. Pollution parameters as mentioned in the condition imposed under consent granted under section 25/26 of the water (prevention & control of pollution ) Act 1974.

Maximum permissible limits or ranges allowed as per consent conditions.

concentration or range of parameters as per report.

Dates on which

All efforts to remove colour & odour as far as practicable

74 CPU and odourless

1 Colour & Odour

No Breakdowns or FailureShall not exceed 40 o C in any section of

the stream within 15 mts. Down stream from the effluent outlet

30.0 [ max ] 18 16 15 17

Not Less than 90% of the test animal shall survive in 96 hrs test. The test shall be conducted as per IS 6582

Free from toxic materials as all test fishes survived after 96 hrs

Shall pass through 850 microns

IS sieve

Total

Energy Consumption Kwh

1 1-Sep-17 4.3 36 16220

2 2-Sep-17 4.3 37 16009

3 3-Sep-17 4.4 36 15682

4 4-Sep-17 4.2 36 15239

5 5-Sep-17 4.4 36 15065

6 6-Sep-17 4.2 37 16596

7 7-Sep-17 4.3 36 16125

8 8-Sep-17 4.3 37 16164

9 9-Sep-17 4.2 36 16337

10 10-Sep-17 4.3 37 16681

11 11-Sep-17 4.4 37 16691

12 12-Sep-17 4.2 37 16307

13 13-Sep-17 4.2 37 16774

14 14-Sep-17 4.2 36 19614

15 15-Sep-17 4.3 37 15244

16 16-Sep-17 4.5 36 14248

17 17-Sep-17 4.2 37 16769

18 18-Sep-17 4.3 37 17472

19 19-Sep-17 4.2 37 16707

20 20-Sep-17 4.4 36 17682

21 21-Sep-17 4.3 36 17059

22 22-Sep-17 4.4 37 16795

23 23-Sep-17 4.2 35 16196

24 24-Sep-17 4.2 36 16668

25 25-Sep-17 4.4 36 16727

26 26-Sep-17 4.4 35 16007

27 27-Sep-17 4.1 35 16065

28 28-Sep-17 4.4 36 16452

29 29-Sep-17 4.3 35 16492

30 30-Sep-17 4.3 35 16236

Average Reading 4.3 36 16411

Date : 09 -10 -2017

Signature :


Address : West Coast Paper Mills Ltd.,Bangur Nagar DANDELI . ( U.K.) 581-325

WEST COAST PAPER MILLS LIMITED, DANDELI

Central Laboratory ( IPC )

Report on daily discharge, pH. DO & temperature of combined treated effluent for the month of September– 2017

SL .No Date D.O ppm Temp o C

Kali river upstream & Down stream water samples analysis report. Samples collected jointly by KSPCB officials & Central Laboratory ( IPC) personnel on 14-09-2017

Kariempalli Village

Harnoda Village

1 pH 7.4 7.3 7.1

2 Colour Turbid Turbid Turbid

3 Odour No Odour No Odour No Odour

4 Suspended Solids ppm 12 16 14

5 Dissolved Solids ppm 34 36 32

6 Total Solids ppm 46 52 46

7 Hardness as CaCO3 ppm 24 32 30

8 Alkalinity (M.O)as CaCO3 ppm 32 42 36

9 Chloride as Cl ppm 7.2 6.8 6.6

10 Sulphate as SO4 ppm 14.8 15.6 15.0

11 Turbidity NTU 200 200 200

12 B O D 3 ppm 1.8 1.6 1.4

13 Sp. Conductivity m s 54.8 58.0 51.6

Date : 09 -10 -2017

Signature :



WEST COAST PAPER MILLS LIMITED, DANDELI

Central Laboratory ( IPC )

Date of sample collection: 14-09-2017

SL.No.

Parameter UpstreamDownstream

ZZK/CLAB-KSPCB/04/ 549209-10-2017


Dear Sir:

Sub: Air Pollution Control Report

We are sending herewith the following for the month of Septem

1. Analysis report of stack emission showing the performance of the Air pollution control equipments / Instruments.

2. The Ambient Air Quality Monitoring report and Meteorological report.3. Month wise Fly ash & Bottom ash generation quantity & disposal


Thanking You,



Encl: As above


217


Sub: Air Pollution Control Report

We are sending herewith the following for the month of September 2017

Analysis report of stack emission showing the performance of the Air pollution control equipments /

The Ambient Air Quality Monitoring report and Meteorological report.Month wise Fly ash & Bottom ash generation quantity & disposal quantity to different parties in MT.




Analysis report of stack emission showing the performance of the Air pollution control equipments /

quantity to different parties in MT.

Tolerance Achieved Tolerance Achieved

102,109

Particulates 150 48

H2S 10 0.92

2 152,611 Particulates 150 56

H2S 10 1.06

3 Rotary Lime Kiln-I 20,000 5,848 Particulates 150 11

4 Rotary Lime Kiln -II 39,600 7,775 Particulates 150 12

5 FBC Boiler - I 92,000 59,724 Particulates 150 44

6 FBC Boiler - II 1,23,912 64,457 Particulates 150 46

7 FBC Boiler - III 1,38,480 94,689 Particulates 150 29

8 FBC Boiler - IV 1,44,108 116,804 Particulates 150 54

Note : Flue gases of RLK I & II have been diverted to PCC plant for manufacture of PCC to reduce CO2 emission to Environment.

Date : 09 -10 -2017

Signature :



WEST COAST PAPER MILLS LIMITEDCENTRAL LABORATORY ( IPC )

Report analysis of stack emission showing performance of air pollution control for the month of

Sep-2017Tested by Central Laboratory ( IPC )

Stack No.

Stack attached to.

Rate of Emission Nm3/ hr Constituents to be controlled in

emission.

Tolerance Limit mg/Nm3

1Chemical Recovery Boiler-I

1,25,000

Chemical Recovery Boiler -II

2,25,720

I Ambient Air Quality

i] Suspended Particulate Matter PM 2.5 60 µg/m3 30.0 34.0 23.0 24.0

ii] Suspended Particulate Matter PM 10 100 µg/m3 68.0 73.0 51.0 53.0

iv] Sulphur Dioxide [ SO2 ] 80 µg/m312.0 11.0 9.0 8.0

v] Oxidies of Nitrogen[NOx] 80 µg/m3 17.3 22.0 19.0 18.0

vi] Hydrogen Sulphide [H2S] - µg/m3Negl Negl Negl Negl

1 st Week 2nd Week 3rd Week 4th Week

II Meteorological Data

i] Wind Velocity - KM/hr 2.24 2.22 4.60 2.05

ii] Wind Direction - SEE SW NWW S

iii] TemperatureMaximum - o C 32.0 32.0 29.0 31.0

Minimum -o C 20.0 20.0 19.0 19.0

iv] Relative Humidity,

Maximum

Morning - % 97 98 94 97

Evening - % 79 78 88 89

Minimum

Morning - % 91 83 94 92

Evening - % 69 70 65 76

Total Rainfall - mm 0.000 27.250 74.000 111.100 212.350

Date :

Signature :

Name : B H Rathi

President Technical


Fire station

P.M/c Old

Clarifier

P.MIll Old Clarifier

Kerwad Village

Meteorological Data For month of September 2017

09 -10 -2017


Analysis Report of Ambient Air Quality monitoring for the month of September 2017

SL.No.

CharacteristicNAAQ STD

Unit

For the Month

For the Year For the Month

For the Year

1.0 2,302 14,503 4,810 28,205

2.0

2.1.0

2.1.1 Nil Nil Nil 655

2.1.2 Nil Nil Nil Nil

2.1.2 Nil Nil Nil 655

2.2.0

2.2.1 104 2,736 732 5,176

2.2.2 2,198 10,253 4,078 20,309

2.2.3 Nil 1,514 Nil 2,064

2.2.4 2,302 14,503 4,810 28,205

2.3.0 2,302 14,503 4,810 28,205

Date :

Signature :



West Coast Paper Mills Ltd DandeliCentral laboratory ( IPC )

Details of Fly ash & Bottom ash generation & Disposal practice for the month of September 2017 and for the year 2017-2018.

S.No Particulars

2017 – 2018

Quantity of Bottom ash (Eco ash),

MT

Quantity of Fly ash,

MT

Total Quantity of Fly ash & Eco Ash Generated

Disposal Details

Cement Industries

JK cement

Kanori Cement , Bagalkot

Sub Total Sl.No 2.1.0 ( SI. No 2.1.1 )

Brick / Block manufacturing Industries

Hubli

Grand Total Of Disposed quantity SI.No ( SI. No 2.1.0+ 2.2.0 )

09 -10 -2017

Kali Nirmiti Kendra , Dandeli / Nearby area

Others

Sub Total

ZZK/CLAB-KSPCB/04/ 549309-10-2017


Dear Sir:

Sub: Analysis report of treated trade effluent collected jointly by K.S.P.C.B. official & mills.

We are enclosing herewith our analysis report of above mentioned sample collected jointly by K.S.P.C.B. Official & mills on 14th of September 2017.


Thanking You,



Encl: As above


217



We are enclosing herewith our analysis report of above mentioned sample collected jointly by K.S.P.C.B. Official & mills on 14th of September 2017.





We are enclosing herewith our analysis report of above mentioned sample collected jointly by K.S.P.C.B.

A Industrail effluent

2 Suspended solids mg/I 50.0 [ max ] 18

3 Particle size of suspended solids mg/I

4 Dissolved solids [inorganics] mg/I 2100 [ max ] 466

5 Temperature o C 33

6 pH value 7.0 - 8.5 7.3

7 Oil & Greese mg/I 10.0 [ max ] Nil

8 Total residual chlorine mg/I 1.0 [ max ] Nil

9 Ammonical Nitrogen [as N] mg/I 50.0 [ max ] Nil

10 Total Kjeldhal Nitrogen [as N] mg/I 100.0 [ max ] 1.0

11 Free Ammonia [ as NH3 ] mg/I 5.0 [ max ] Nil

12 Bio Chemical Oxygen Demand

[ 3 days at 27 o C ] mg/I

13 Chemical Oxygen Demand mg/I 250.0 [ max ] 100

14 Chloride [ as CI ] mg/I 350.0 [ max ] 138

15 Dissolved Phosphate [ as P ] mg/I 5.0 [ max ] 0.001

16 Sulphate [ as SO4] mg/I 1000.0 [ max ] 54

17 Sulphide [ as S ] mg/I 2.0 [ max ] Nil

18 Phenolic compound [ as C6H5OH ] mg/I 1.0 [ max ] Nil19 Bio assay Free from toxic materials as all test

fishes survived after 96 hrs

Date : 09 -10 -2017

Signature :




Analysis report of treated trade effluent along with treated colony sewage (samples collected jointly by K.S.P.C.B. officials KARWAR and Central Laboratory-IPC)

personnel on 14-09-2017

SL.NoPollutants as specified in consent

conditionTolerance Limits Pollutants Concentration

All efforts to remove colour & odour as far as practicable1 Colour & Odour

70 CPU & odourless

Not Less than 90% of the test animal shall survive in 96 hrs test. The test shall be conducted as per IS 6582

Shall pass through 850 micronsLess than 850 m

IS sieve

Shall not exceed 40 o C in any section of the stream within 15 mts. Down stream from the effluent outlet

30.0 [ max ] 13

ZZK/CLAB-KSPCB/04/ 549409-10-2017

Senior Environmental Officer, Hazardous waste cell, Karnataka State Pollution Control Board49, Parisara Bhavan,4th & 5th Floor,Church Street,Bangalore - 560 001.

Dear Sir:

Sub: Details of Waste Oil & Waste Oil sHandling & Trans boundary Movement) Rule

We are sending herewith the following for the month of September 20171. Quantity of storage & transportation details of Waste Oil.2. Quantity of Waste oil sludge reprocessed on our RLK.3. E – Waste generation and Disposal details.

4. Detail Disposal of Non Ferrous Scrap. 5. Detail disposal of used Batteries.


Thanking You,



Encl: As above

Cc: Environmental Officer, Speed Post Regional Office, Karnataka State Pollution Control Board

“ Parisara Bhavan” , LIG B-1, Main Road, A-16th CrossNear Hari Om Trust, HabbuwadaKARWAR – 581 303

Speed post with A.DHazardous waste cell, Karnataka State Pollution Control Board,

Sub: Details of Waste Oil & Waste Oil sludge under the provisions of Hazardous waste (Management, Handling & Trans boundary Movement) Rule- 2008 amended 2010

We are sending herewith the following for the month of September 2017Quantity of storage & transportation details of Waste Oil.

y of Waste oil sludge reprocessed on our RLK.Waste generation and Disposal details.

4. Detail Disposal of Non Ferrous Scrap.5. Detail disposal of used Batteries.



Environmental Officer, Speed Post

Karnataka State Pollution Control Board“ Parisara Bhavan” , LIG – II, B – 217

16th CrossNear Hari Om Trust, Habbuwada

Speed post with A.D

ludge under the provisions of Hazardous waste (Management,

Environmental Officer, Speed Post with A D

September-2017

For the Month

I

1.0 Nil

2.0 Nil

2.3 Balance in storage yard Nil

II

1.0 Nil

2.0 Nil

2.1 Nil

2.2 Nil

III

2.0 Nil

IV

1.0 Nil

V 1.0 Nil

Date :

Signature :



West Coast Paper Mills Ltd DandeliCentral Laboratory ( IPC )

Details of Lubricating waste oil And Furnance oil sludge

S.No ParticularsQuantity ( KL ) Category (5.1)

For the Year from April 2017 to March 2018

LUBRICATING WASTE OIL

Total generation 2.000

Total Quantity Disposed 2.000

Nil

FURNANCE OIL SLUDGE Quantity (KL) Category (3.3)

Total generation Nil

Total Quantity Disposed Nil

Recycled in RLK Nil

Closing Balance Nil

E – Waste Quantity in ( Kgs )

For the Year from April 2017 to March 2018

Total Quantity Disposed Nil

09 -10 -2017

Non Ferrous scrap Quantity in ( Kgs )

Scrap copper rewinding wire and copper cable 1560

Scrap used Batteries 2240

ZZK/CLAB-KSPCB/04/ 5491 Environmental Officer, · PDF fileEnvironmental Officer, Regional...

Documents

Transcript of ZZK/CLAB-KSPCB/04/ 5491 Environmental Officer, · PDF fileEnvironmental Officer, Regional...