bo prot
-
Upload
adrian-reyes -
Category
Documents
-
view
212 -
download
0
Transcript of bo prot
7/17/2019 bo prot
http://slidepdf.com/reader/full/bo-prot 1/1
BOILER PROTECTION
1 NO POWER AVAILABLE
Any of the boiler protection panel power supply (! "P# VA$% &' V$% )*
+olt% ,1 +olts- is lost.
I.. /AN# O"0 O/ OPERA0ION
When both I fans are inicate out of ser+ice2 /.. /AN# O"0 O/ OPERA0ION
When both / fans are inicate out of ser+ice
& NO $O3B"#0ION AIR /LOW
Airflow to boiler is less than *4 of a no5inal 5easure +alue of %!!!
6N57% which e8uates to &*!%!!! N579hr.
* NO #0EA3 E:;A"#0
• both ;P #V not open < ;P bypass close
• ;P #V close < ;P =V close
• ;P #V not open < 2 out of & ;P =V close
•
both IP =V close < LP bypass close < R; +ent +al+e close• at start up> furnace probe in ser+ice% furnace ?as te5perature @ **! $%
B$P heaer te5perature 1C! $
C RE=ENERA0IVE AIR ;EA0ER# O"0 O/ OPERA0ION
When both air heaters are reco?niDe as bein? out of ser+ice
R"3 LEVEL LOW LOW
less than )C!! 55 L0:F!*A9B% iscrepancy between the le+el trans5itter
+alues ?reater than 2!4 (harwire to boiler protection panel-
' /"RNA$E PRE##"RE LOW LOW
less than )1.1* 5bar% out of 2 /0OFP#LLF!!1A9B9$
G $ON0ROL AIR PRE##"RE LOW LOW
instru5ent air supply reuces to * bar% out of 2 Press #witches1! /"RNA$E PRE##"RE ;I=; ;I=;
eHcees ,1&.* 5bar% any of /0OFP#;;F!!1A9B9$
11 #$ANNER $OOLIN= AIR PRE##"RE LOW LOW
below *! 5bar( !.!* bar- for 5ore than 5in /ARFP#LLF!!1A9B
1 /LA3E E0E$0ION /AIL"RE
when one or 5ore coal firin? le+els fail to etect two fla5es on any coal firin?
le+el a fireball etection failure will occur
12 R9BA$6 WI0; A0 L#0 1 3ILL IN 3AN9#03 /LW @ C! 4
R9bacJ initiate with 1 out of 2 5ills in 3AN < not #EL to trip% #/@11&! t9hr
1& BOILER #0EA3 PRE##"RE ;I=; ;I=;
eHcees 1G* bar ?a?e for 5ore than * sec% /#RFP0F!*!A9B
1* NO BOILER $IR$"LA0ION P"3P# IN OPERA0ION
No B$P in ser+ice for 5ore than * sec
1C #0EA3 /LOW @*!4% LE## 0;AN $IR$. P"3P# IN OPER.
#/ @ G*! t9hr < only 1 B$P in ser+ice% 0K1! sec
1 $$R E3ER=EN$ #0OP OPERA0ION
Location> operatorMs esJ or bacJ panel
1' R9BA$6 WI0; /"RN PRE##9AIR /LW 3EA# /A"L0
R9bacJ initiate with out of 2 /0OFP0F!*A9B9$ fault or
3ill A9B9$9 /0F!A9B% /$A9BF/0F!*1 airflow 5easure5ent fault