Post on 01-Dec-2021
HEAT TRANSFER IN A PACKED BED REACTOR)
AT LOW REYNOLDS NUMBERS: THE
HYDROGENATION OF ETHYLENE TO
ETHANE ON NICKEL CYLINDERS
By
JOHN EARLY KLOPP ,1
Bachelor of Science
Oklahoma State University
Stillwater, Oklahoma
1963
Submitted to the faculty of the Graduate School of the Oklahoma State University
in partial fulfillment of the requirements £or the degree of MASTER OF SCIENCE
May, 1965
HEAT TRANSFER IN A PACKED BED REACTOR
AT LOW REYNOLDS NUMBERS: THE
HYDROGENATION OF ETHYLENE TO
ETHANE ON NICKEL CYLINDERS
Thesis Approved:
581457 ii
~u~~ JSJAtELUN£~
LILmR/mY
PREFACE
The heat transfer in a packed, catalytic bed was studied
with the hydrogenation of ethylene to ethane acting as the heat
source. The flow rate of the gases in the reaction tube was con
fined to the laminar regime based upon the boundary layer film
Reynolds number. The calculated results for this system agree
with previous investigations for non-reacting systems.
I am indebted especially to Dr. James w. Fulton 9 my Thesis
Adviser, for his guidance and advice. I also am indebted to
Doctors John H. Erbar and Kenneth J, Bell for their serving on
my Thesis Review Committee and their offering of many helpful
suggestions. The aid of my research associate 9 Berry Crain, Jr.,
has been of great value to me and to this thesis.
I would like to thank the Office of Education, Department
of Health 1 Education 9 and Welfare 9 for the financial support of
an N.D.E.A, Fellowship for the 1963-64 school year and the School
of Chemical Engineering and the Oklahoma State University Research
Foundation for financial support for Summer, 1964. The Phillips
Petroleum Company supplied the ethylene and ethane used in this
study, and Girdler Catalysts 1 Inc. 9 supplied the nickel-on-alumina
catalyst. Both of these companies supplied their products free
of charge.
I would also like to thank Doctors Robert N, Maddox and
John B, West for the suggestions and guidance that they have
given me in both my graduate and undergraduate studies.
iii
TABLE OF CONTENTS
Chapter
I. INTRODUCTION
II. REVI.EW OF .THE LITERATURE •
Reaction Kinetics . Heat Transfer ..... Mass Transfer.
III. APPARATUS
Feed System . . Reactor .• Temperature Measuring System Gas Analysis System.
0 .
IV. MATERIALS •o•ci•••eo
Catalyst Dispersing Agent Reactant Gases
V, EXPERIMENTAL PROCEDURE.
Temperature Sensing Packing the Reactor
System ' 0 '
Calibration of Flowmeters Catalyst Reduction Reaction Run 0 0 0 . . . Product Stream Analysis 0
VI. EXPERIMENTAL RESULTS . . Experimental Data Calculations
VII. DISCUSSION OF RESULTS
.
. .
. . .
Interpretation of Data ••• Correlation of Data •.
. .
.
0 . . . . . . 0
• .• 0 0
.
.
.
Comparison to Previous Investigations .
VIII. CONCLUSIONS
iv
. 0
0 0 .
0 . 0 .
. . . .
. . .
.
.
.
.
Page
1
3
3 4 6
8
8 10 10 12
13
13 13 13
15
15 16 16 17 18 19
20
20 23
24
24 24 26
27
Chapter
NOMENCLATURE
A SELECTED BIBLIOGRAPHY
APPENDICES
A. B. c. D. E. F.
Sample Calculations •.•••• Computer Calculation Program Computer Curve Fit Program Experimental Data •••••. Conductive and Radiant Heat Transfer Influence of Particle Orientation Upon
Surface Temperature ....•...•
v
Page
28
29
35
36 40 49 55 99
102
LIST OF ILLUSTRATIONS
Figure Page
1. Schematic Diagram of Apparatus o 9
2o Detailed Diagram of the Reactor 11
3. Dependence of Conversion upon Reynolds Number 21
4o Dependence of Surface Temperature upon Reynolds Number o 22
5. Presentation of Calculated j-Factors and Reynolds Numbers o QI o o o o o o ~ o o o o o o o o o 25
vi
CHAPTER I
INTRODUCTION
"No branch of chemical engineering is more central to the
purposes of the craft than the study of the chemical reactor ••• (3) 11
One of the major aspects of reactor design is heat transfer.
Heat transfer characteristics influence the size, shape, and oper-
ating conditions of a chemical reactor.
A packed bed reactor operating in laminar flow was chosen
for this study. The heat source was the hydrogenation of ethylene
to ethane on nickel catalyst cylinders. There were several rea-
sons for this selection. First, the literature contains very
little information on generalized heat transfer correlations for
packed, catalytic beds which are operated in the laminar flow
regime.
Second, the hydrogenation of ethylene to ethane has several
characteristics which make it a well-suited reaction for this
study:
1. the reaction is highly i~reversible;
2. the system has no side reactions;
3. the reaction is completely heterogeneous (i.e.,
the reaction does not proceed to a measurable extent
in the absence of a catalyst);
4. the reaction is relatively simple in chemical reaction
mechanism;
5. the reaction is highly exothermic; and,
1
6. the reaction occurs readily at atmospheric pressure and
normal temperatures.
In the laminar flow regime, heat transfer in a catalytic,
packed bed is a function of the reaction rate, bulk fluid tem
perature and pressure, fluid flow rate, physical properties of
the fluid and catalyst, and shape and size of both the catalyst
particle and the reactor. The method used currently to describe
heat transfer in flow reactors is to correlate a dimensionless
quantity, the heat transfer j-factor, with the ~eynolds number.
The purpose of this study has been to obtain this heat
transfer correlation for a heterogeneous catalytic reaction
occurring in a packed bed reactor operated in laminar flow.
2
CHAPTER II
- --.REVIEW OF THE LITERATURE
Reaction Kinetics
Articles on heterogeneous catalysis and the hydrogenation of
ethylene to ethane are readily available in the literature (7,12,
13,21,30,42,44,47,51,57,59,60,62,65,66)0 Rideal (51) used a
relatively inert nickel catalyst on a strip of nickel foil to
study the rate of reaction of the hydrogenation of ethylene. He
made the important observation that oxygen inhibited the reaction;
the hydrogenation of ethylene was negligible until all of the
oxygen had been converted to watero
Sussman and Potter (55) studied the hydrogenation of ethylene
in a flow reactor. They observed that the controlling step was
the surface reaction between the adsorbed olefin and hydrogen
which was adsorbed with disassociation. It was noted that hydro
gen was only weakly adsorbed in comparison to the ethylene.
Bond (7) summarized the experimental data and results of
previous investigators who had studied the hydrogenation of
ethylene on nickel and other catalysts. Pauls, Comings, and
Smith (44) obtained reaction rate and kinetics data for the hydro
g.enation of ethylene on a catalyst similar to the nickel-on
alumina catalyst used in this study.
The catalytic effectiveness factor and reaction rate have
been investigated by Carberry (12), Prater (47), and Weisz (66).
3
Chu and Hougen (15)' and! vak Kreve'len ilrid. Hoftijzer (62\ have
reported the dependency of the effectiveness factor upon adsdrp-
tion in a heterogeneous chemical reaction. Thiele (59) reported
that b~low a cert•in grairi ~ize, the activity of the catalyst was
proportional to the weight of catalyst present. Fulton (21)
studie'd the influence o'f catalyst particle size upon the reaction
kinetics of the .hydrogenation of ethylerie to ethane.
Heat Transfer
The heat tr~nsfer coefficient, h, is defined by:
d = hA6T
Q = heat transferred per unit time, Btu/hr.
A = cross-sectional area perpendicular to flow of heat, sq. ft.
T = temper~tur~, °F.
(II-1)
4
h = propo~tionality c~nstant, determined experimentally, Btu/(hr.-sq. ft.-°F),
Origifi~iiy the heat transfer coefficient in a packed bJd was
tbrrei~ted ~~ ~ fu~ction ot th~ characteristic di~ehsions oi the
bed, av~rage fluid temperature, and mass velocity (l,,14,18,22f32,
36,37,38,39). Kern (32) summarized some of these correlations.
thilton and Colburn (14) defined th~ heat tran~fer j-iactor,
(II-2)
where,
N = Prandtl number= C µ/k, dimensionless Pr p
µ = vi~cosity, lb./(ft.-hr.)
5
k = thermal cpnductivity, Btu/(hr.-sq. ~ft •. ::°F.) ~
f = refers to physical properties evaluated at ari thm.etic average of surface and bulk temperatures.
Data have been repo~ted for the heat transfer j-factor as a
function of Reynolds p.umber in packed be~s, but most of the studies
were lfor non-reacting ~yst~~s (5,1'9,24). Eichhorn (19) developed
a j-factor correlation for dielectrically-heated plastic particles . . - -
in. a packed bed. His correlation was: , I !1.
jh = o.~35 (NRe)-0.35
for, 1 < NRe < 18
Baumeister and Bennett (5) electrically heated metal spheres ·,.. . .
in a packed bed. Tpeir correlation was: . l ) J ;} :. ! :Y> ., • . ~- ~.
j = o.91~(N )-o.~p . h , · Re
f~r, 200 <~Re< 10,400
µlaser and Thodos (24) also electrically heated metal spheres
fn a p~c~ed bed; the correlatiqn that they obtained wa~:
0.535 · · · 0 3 (N ) • , -.~e
= 1.6
for, 100 < NRe < 10,000
where, (jh/jh) = 1.0 + 10.73 0
(a )0.5
for, 5 >> 0.0 t
N = (DPG)/(~-E)¢µ ' ~e
(a )0.5 p
E = bed void fra~tion, dimensionless
(N )-.384 Re
a~ = p~rticle surf~ce ar~a, s q. ft./particle
¢ = shape factor, described by Aris (~} ' ... ; . . .
Dt = diameter of reactor tube, f .t.
6
The use of the jh/jh0 correlation was intended for cases in which
the particles were large enough, with respect to the tube diameter,
to create wall and packing effects.
The only heat transfer j-factor correlation for a chemically
reacting system was obtained by Satterfield and Resnick (50).
They studied the decomposition of hydrogen peroxide on catalytic
spheres. They developed:
j = h ( )-0.34
0.992 NRe
for 1 15 < NRe < 161
Although Satterfield and Resnick correlated the j-factor to the
Reynolds number in a catalytic, facked bed, they also showed that
their flow stayed .entirely in the turbulent flow regime.
Mass Transfer
It is necessary to enter the area of mass transfer studies
to obtain j-factors in fully developed laminar flow in a packed
bed. Chilton and Colburn (14) defined the mass transfer j-factor,
jd, as
=
where, kG
M
p
( N ) 2/3 Sc
lb-moles = mass transfer coefficient,
hr.-sq-ft.-atm.
= molecular weight, lb/lb-mole
= mean partial pressure of inerts, atm.
= µ/PD., dimensionless. l
density, lb/cu. ft.
Several authors have proposed values of the ratio, jh/jd, ranging
from 0.8 to 1.5 (14,23,49,50). In any case the following values
of the jd versus Reynolds number correlation are given to illus
trate the spread of reported data.
jd = 16.8/NRe NRe < 40 (23)
jd = 0.18(NRe)-.376 l< NRe < 400 (40)
jd = 0.66(NRe)-.46 0.17 < NRe < 250 ( 4)
Most, if not all, of the variation in the data may be attributed
to the range of Reynolds numbers included. The transition region
from laminar to turbulent flow in a packed bed may occur for a
Reynolds number range:
10 < N < 1000 Re
(50)
In addition it has been shown that, in the laminar regime,
the slope of the j-factor versus Reynolds number plot (on log-
log coordinates) may change from a positive value at low Reynolds
number to a negative value at a higher Reynolds number (4,48).
Bar-Ilan and Resnick (4) reported that, for the sublimation of
naphthalene spheres in an air steam, the maximum j-factor occurred
at a Reynolds number of approximately 1.5. Later, Resnick and
White (48) reported that the maximum occurred at Reynolds numbers
of 2, 20, and 100. They observed that this variation was created
by different sized particles.
From the state of confusion of the reported data it would
seem •quite beneficial to obtain a good heat transfer j-factor
correlation for the laminar flow regime. That is the purpose
of this study.
7
CHAPTER III
APPARATUS
The apparatus may be divided into four units: feed system,
reactor, temperature measuring system, and the ~as analysis system.
A schematic diagram of the apparatus appears in Figure 1 on
page 9.
Feed System
Hydrogen and ethylene gases were fed from commercial cylin
ders with constant pressure regulators and pressure reducing
needle valves. Each gas passed separately through a purifier,
another needle valve for fine flow control, a drying bottle, a
capillary flowmeter, and the gas-mixing flask.
A Deoxo catalytic purifier for electrolytic hydrogen was
used in the hydrogen line to reduce any oxygen present to water.
A heated purifier containing Deoxo Model C catalyst was used for
the removal of oxygen and sulfur in the ehtylene feed.
Both gas streams passed from their purifiers through drying
bottles containing Drierite which removed the water vapor.
Triethylene glycol was used in both capillary flowmeters
because of its low vapor pressure at room temperature (the
operating temperature for the flowmeters). The gas mixing
chamber was a 50-ml. Erlenmeyer flask.
8
HYDROGEN PURIFIER -HYDROGE~ 1
CYLINDER r ~ L--'
ETHYLEN CY LINDE~
RISING SOAP Fl LM FLOWMETE
SOAP RESERVOIR GAS
DRYER ...-----. ,;-NEEDLE VALVE
HYDROGEN FLOW METER /f
BED PRESSURE DROP MANOMETER
.~NEEDLE VALVE BOILING LIQUID
JACKET
LIQUID CONDENSER
-cw
GAS SAMPLE SEPTUM
VENT
MERCURY MANOMETER
t---M-AIR LEAK
l.-,w_AIR L EAK
VACUUM PUMP
ETHYLENE :-l.l I >~ © - TH ERMOCOUPLE PROBE FLOWMETER
Figure 1. Schematic Diagram of Apparatus.
CD
Reactor
A detailed diagram of the reactor is shown in Figure 2,
page 11. The entering gases passed through the preheater helix
of 7-mm. glass tubing which was wrapped around the reaction tube
and were fed into the bottom of the reaction tube. The gases
passed from the bottom of the reaction tube upwards through the
dispersed catalyst bed and out the side gas tube.
The preheater helix and reaction tube were surrounded by a
boiling liquid which served the dual purpose of preheating the
gases to reaction temperature and providing a nearly constant
bulk gas temperature in the reaction tube.
The boiling liquid was contained by a glass jacket which
was heated by an insulated electrical resistance wire helix.
10
The temperature of the liquid was controlled by regulation of the
vacuum above it.
Both the top and the bottom of the reaction tube were plugged
with ground glass plugs. These plugs aided in the loading and un
loading of the reaction tube. In addition, the top plug contained
a 14-mm. glass tube which served as an exit tube for the thermo
couple wires which were attached to particles in the bed.
Temperature Measuring System
All temperatures, except room temperature, were sensed by
iron-constantan thermocouples.
The entering and exit bulk gas temperatures were sensed by
thermocouples inserted into 3-mm. glass balls which were placed
GAS FEED
' 7 MM
i
PREHEATER COIL - ---N----1~
PRODUCT OUTLET - --+1-------i----i--l-'
REACTION TUBE ~--- ----
BOILING LIQUID ___ ...,___.. ... JACKET
ASBESTOS WRAPPED ELECTRIC HEATER--~
CONDENSE.R. INLET
4"
2" t
Figure 2. Detailed Diagram of the Reactor .
2s.l.." 4
11
at the bottom and top of the packed bed. Catalyst temperatures
were sensed by thermocouples inserted in them.
The voltage potential of each thermocouple was measured
by a Leeds and Northrup Potentiometer~ Model No. 8686.
Gas Analysis System
12
The reactant and product streams were analyzed by a vapor
phase chromatograph. A quarter-inch copper tube, four feet in
length, packed with finely divided silica gel was used as the
separation column. A helium flow of 100 cc. per minute was used
for the column and the thermal conductivity cell. Both the column
and the cell were kept at a constant temperature of 165°F. with
boiling acetone.
The analysis was determined by the area-weight fraction
method (40,45).
CHAPTER IV
MATERIALS
The materials used in this study were the catalyst, the bed
dispersing agent, and the reactant gases, hydrogen and ethylene.
Catalyst
The catalysts used for this study were nickel on alumina
cylinders. The catalyst, supplied free of charge by Girdler
Catalysts, was Gir~ler ~atalyst No. T-310, sample ~o. 10-152.
The catalyst contained 10-12% by weight nickel and the particles
averaged 3.08-mm. in diameter and 3.55-mm. in length.
The catalyst was obtained in its unreduced form (NiO), and
it was re~vced after it was packed in the bed. Reduction was
accomplished by passing hydrogen over the catalyst while main
taining a packed bed temperature of 700°F. with Hitec molten
salt. The reduction period was ten hours and only hydrogen and
ethylene ·were exposed to the catalyst after reduction in order
to prevent deactivation.
Dispersing Agent
The dispersing agent chosen was a bed of 3-mm glass spheres.
These spheres were nearly the same size as the catalyst cylinders.
Reactant Gases
The hydrogen was taken from commercial gas cylinders. The
13
14
hydrogen, manufactured by the electrolytic process, was about 99%
pure.
Pure grade ethylene was supplied free of charge by the
Phillips Petroleum Company. The mole percent purity was 99.3%
with traces of acetylene, carbon monoxide, carbon dioxide, sulfur,
oxygen, and water.
CHAPTER V
EXPERIMENTAL PROCEDURE
The description of the experimental procedure for this study
is divided into six sections: preparation of the temperature
sensing system; method of packing the reactor; calibration of the
flowmeters; reduction of the catalyst; procedure during a reaction
run; and the method of. analyzing the product streams.
Temperature Sensing System
Several methods were attempted for the insertion of the
thermocouples in the glass spheres and catalyst cylinders. The
method finally adopted consisted of: abrading a hole in the
cylinder or sphere; cementing the thermocouple bead in the hok;
coating the thermocouple wires; and connecting the thermocouple
wires to the potentiometer.
Holes were drilled into the catalyst cylinders and glass
spheres with an air and fine sand abrasive unit. This operation
produced a uniform, conical hole in both the catalyst cylinders
and the glass spheres.
The cement used was Sauereisen ceramic cement. This material
was received in a dry, powdered form; and it was mixed with a
small amount of water to form a very thick slurry. A thermocouple
bead was dipped into the slurry and inserted into the conical
hole in the particle. The cement was allowed to dry overnight.
15
16
A thinner solution of Sauereisen cement was used to coat the
thermocouple wire. The wires were first thoroughly cleaned with
vinegar, rinsed with distilled water, and dried. The Sauereisen
was coated onto the wires with a small, oil-paint ~rush; and each
coat was allowed to dry in air for six hours. Three coats were
applied to each thermocouple wire.
After the bed was packed, the thermocouple wires were threaded
out through the top ground glass plug in the reaction tube and
soldered to a multi-point radio switch. Lead wires were soldered
from the common poles on the radio switch to the poles on the
potentiometer.
Packing the Reactor
After the bottom plug was inserted into the reactor, two
inches of glass wool were placed at the bottom of the reaction
tube. A glass sphere with a thermocouple in it was placed on top
of the glass wool. Three inches of 3-mm. glass spheres were
poured on top of that glass sphere. Then a catalyst particle
with a thermocouple in it was placed on top of the glass spheres,
and more glass spheres were placed on the catalyst particle. More
catalyst particles and glass spheres were added until the desired
number of particles were in the bed.
The beds for different runs contained from three to nine
catalyst particles.
Calibration of Flowmeters
The flowmeters were calibrated before and after each reaction
17
run. Tygon tubing was used to connect the outlet of the capillary
flowmeters with a rising soap-film flowmeter. The volumetric flow
was obtained by measuring the time required for the soap film,
stretched across the rising film flowmeter, to rise the length
of the flowmeter. The volumetric flow rate was obtained by divid
ing the volume of the flowmeter (100 cc.) by the time required for
the soap film to displace this volume,
In addition to the capillary flowmeters used to measure the
flow of the reactant gases, a manometer was installed to measure
the pressure drop across the bed.
catalyst Reduction
With the boiling liquid jacket empty, hydrogen was fed to
the reactor at the rate of one gram-mole per hour; and it was
allowed to purge the reactor for one hour. Finely-ground Hitec
was added to the jacket, and the heaters were turned on. The
reactor and salt were heated to 300°F., the melt ing point of
Hitec, As the Hitec melted, more was added to keep the level of
the Hitec above that of the packed bed. This process took about
four hours.
After all the Hitec had melt e d, the current to the heaters
was increased; and the reaction tube and molten salt were heated
to 700°F, The reactor was allowed to remain at 700°F, for ten
hours, and the hydrogen rate was continued at 1.0 gm-mole/hr.
to prevent deactivation of the catalyst. After the catalyst
particles were reduced, the molten salt was drained from the
reactor, the h eaters turned off, and the reactor allowed to cool.
18
Reaction Run
After reduction, the reactor jacket was rinsed with water
three times and filled with two liters of distilled water. The
heaters were turned on again, and the reactor was brought to the
desired temperature for the reaction run.
When the reactor reached the desired temperature, the hydro
gen flow rate was adjusted to 2.00 cc./sec.; and the ethylene flow
was begun and adjusted to 0.50 cc./sec. The hydrogen-to-ethylene
molar ratio of four-to-one was held constant throughout the reac
tion run; a greater concentration of ethylene has been shown to
coke the catalyst surface (7).
After the reactor reached steady state, which took approxi
mately twenty minutes, one reactant gas sample, four product gas
samples, and three thermocouple readings were recorded. The pro
duct gas samples were taken every eight minutes, and the thermo
couple readings were recorded while the gas samples were being
eluted from the chromatograph column.
The flow rates were increased to 4.00 cc./sec. for the hydro
gen and 1.00 cc./sec. for the ethylene after the last gas sample
had been taken for the first set of flow rates. The reaction run
was continued in this manner until all the desired readings had
been taken; then the flow rates were reduced to their original
values (2.00/0.50) and the readings were repeated to detect any
change in catalyst activity. After all readings were taken, the
ethylene flow was stopped, the heaters turned off, and the bed
allowed to cool with hydrogen flowing through it.
19
Product Stre~ Analysis
Five cc. gas samples were taken from the product stream every
eight minutes and injected into the chromatograph injection port.
The inlet gas stream, product gas stream, and the injection port
were equipped with rubber setpums through which the gas sample
could be withdrawn or injected with a gas syringe and needle,
As stated in the previous chapter 1 the chromatograph curves
were analyzed by the curve area-weight fraction method applicable
to short-chained alkanes and alkenes (40,45)0 In this method the
ratio of the areas under the elution curves for short-chained
alkanes and alkenes is equal to the ratio of the weight fractions
of the two components.
CHAPTER VI
EXPERIMENTAL RESULTS
Experimental Data
Several runs were made with different bed packings. The
flow rate through the reactor was always in the laminar flow
regime (i.e., the Reynolds numbers were equal to or less than 3.0).
The number of catalyst particles in the packed bed was varied
from nine for the first run to three for the last run. The flow
rate for each run was varied from a Reynolds number of 0.2 to a
Reynolds number of 3.0. The bulk gas temperature was varied from
83°F. to 207°F. The packing and bulk temperature were constant
for any one run.
As the flow rate was increased, the percent conversion of
ethylene in the product stream decreased;and the surface tempera
ture of the catalyst particles increased. The dependence of the
conversion upon Reynolds number is shown in Figure 3 on page 21.
The dependence of the catalyst surface temperature upon the
Reynolds number and the bulk gas temperature is shown in Figure 4
on page 22.
The maximum bed pressure drop was 0.8 in. triethylene glycol;
therefore, this pressure drop was negligible in the flowmeter
calibrations.
20
z 0
90
80
70
en so 0:: w > z 50 0 0
..,_ 40 z w 0 o:: 30 w a.
20
10
00
LEGEND o - RUN NO. I 3 I , 202°F c - RUN NO. 195, 147°F ~ - RUN NO. 185, 201°F
~
·~ ~ ~
-~- ._..,.___ -- ,.. -
~~ A
,
l . . .
0.5 1.0 1.5 2.0 2.5 REYNOLDS NUMBER
Figure 3. Dependence of Conversion upon Reynolds Number.
--
. -
3.0
[\J f--'
u. 0
400
350
aJ 300 a:: ::> ~ 250 a:: UJ ~
.~ 200 UJ ._ w 150 0
~ a:: ::> U)
100
50
00
~ -
~
-... ..
0.5 1.0
-- ---~ .J
--
...
1.5 REYNOLDS NUMBER
--\,I
~ --
-
LEGEND SYMBOL BULK TEMP.
0 201°F .
a 147°F A 85°F -
I
2.0 2.5
Figure 4o Dependence of Surface Temperature upon Reynolds Number.
-
-
-3.0
tv tv
Calculations
The heat of reaction was calculated a:t the surface teinpera-
ture of the catalyst particles by the following equation (55): T
6HT = 6H: + f CpdT (V-1)
298
The heat transfer coefficient was calculated from:
h =
where,
Q
a (T-Tb) p s (V-2)
23
Q = heat generated.by reaction on one particle, Btu/hr.
a p
=external.surface area of the particle, sq.ft. per particle
Ts= surface temperature of the particle, °F.
Tb= average bulk gas temperature, °F.
The heat transfer j-factor was calculated from Equation (II-2):
(h/C G)(Np ) 2 / 3 p . r (II-2)
A detailed explanation of the calculations appears in Appendix
A, and necessary assumptions appear in Appendices E and F. The
·computer prograpi which was.· used to calculate the j-factors and
Reynolds numbers is described in Appendix B, and the computer
program used to curve fit the data is described in Appendix c.
The experimental data·and the calculated j-factors and Reynolds
numbers are in Appendix D.
CHAPTER VII
DISCUSSION OF RESULTS
Interpretation of Data
From Figure 3 it is apparent that the percent conversion of
ethylene to ethane was ~irectly proportional to the amount of
catalyst present and inversely proportional to the flow rate
through the packed bed. For example, Run No. 131 had nine
catalyst particles in the bed,and Run No. 195 had three catalyst
particles in the bed. The percent conversion for Run No. 131 was
approximately three times that of Run No. 195 at any one flow
rate. Figure 3 also shows that the percent conversion was rela
tively independent of the bulk gas temperature. Runs No. 195
and No. 185 both had three catalyst particles in the.bed, but
Run No. 195 was at a bulk gas temperature ,of 147°F. and Run No.
185 was at 201°F.
Figure 4 shows that the catalyst surface temperature increased
with increased flow rate 1 but the temperature drop between the
bulk gas and the catalyst surface was almost constant.
Correlation of Data
The calculations from the experimental data show the effect
of the Reynolds number upon the heat transfer j-factor for this
reacting system. Figure 5 on page 25 shows this relationship for
all the calculated experimental points (2051 points). A least
24
0::
80.0 70.0
60.0
!50.0
40.0
30.0
20.0
~ o 1!5.0
~ I ·- 10.0
9.0 8.0
1.0
6.0
~.o
4.0
3.0 0 .2
25
" ' " -·
" " ' ~ "' ~ •o ~
' 0
~ '
- ' -A jh= 13.8 ( NR,fl.O./'l./ '~
or\..
~· . "' "
0 . 3 0.4 0.!5 0.6 0.8 1.0 2.0 3.0 4.0
REYNOLDS NUMBER
Figure 5. Presentation of Calculated j-Factors and Reynolds Numbers.
squares curve-fit for these points gave: jh = 13.B(N )-1.005• Re
26
The standard deviation was 7.35 and the percent average deviation
was 12.4%.
All points which were more than three standard deviations
from the calculated line were rejected and the points were curve-
fitted again. The remaining points (2024 points) formed the linei
jh = 13.6(NRe)-0" 969 .- The standard deviation of this line was
2, 589 and the percent avera.ge deviation was lL Oo/o.
Comparison to Previous Investigations
The correlation obtained agrees with the one proposed by
Gamson, Thodos, and Hougen (23)i but it does not agree with the
correlations obtained by Bar-Ilan and Resnick (4) and by Satter-
field and Resnick (49). There is a simple explanation for this
disagreement. Bar-Ilan and Resnick reported that the Reynolds
numbers for their system varied from 0.2 to 250i and Satterfield
and Resnick reported that the Reynolds numbers for their system
varied from 1.0 to 400. Therefore, the upper range of Reynolds
numbers for both of these pairs of investigators indicates that
the flow was not laminari but that it was in the turbulent regime.
CHAPTER VIII
CONCLUSIONS
The heat transfer j-factor may be correlated with the
Reynolds number for the flow of fluids through packed beds. This
correlation has been extended to the laminar regime for a gas mix-
ture reacting heterogeneously on a catalyst surface in a packed
bed. This study indicated that the relationship is:
= 13.8(NRe)-l.O
where the heat transfer factor, jh 1 is defined as:
jh = (h/CPG)(NPr)!/3
27
NOMENCLATURE
a = Particle external surface area, sq. ft./particle. p
A = Cross-sectional area for heat flow, sq. ft.
C = Heat capacity, Btu/(hr.-sqo ft.-°F). p
D = Diameter, ft.
D. :;: Diffusion coefficient, sq. ft./hr. l.
f = Fanning friction factor, dimensionless.
G = Superficial mass velocity, lb./(hr.-sq. f_t.).
h = Heat transfer coefficient, Btu./(hr.-sqo ft.-°F.
k = Thermal conductivity, Btu./(hr.-sq. ft.-(°F/ft.)).
k = Mass transfer coefficient, lb-mole/(hr.-sq. ft.-atm.). g
M = Molecular weight, lb./lb-mole~
NPr =
NRe =
Nsc =
Prandtl number, (C µ/k), dimensionless. . p !
Reynolds number,. (DG/µ) (unless otherwise defined), dimensionless.
Schmidt number, (µ/PD. ) , dimensio:qless. . l.
T = Temperature., °F.
E = Bed void fracti~n, dimensionless.
µ = Viscosity, lb./(ft.-hr.).
P = Density, lb./cu. ft.
¢ = Shape factor,·dimensionless.
Subscripts.
b = Bulk gas phase.
BM = Bulk mean.
f = film.
28
P,p = Constant pressure.
s = Catalyst surface.
t = Reaction tube.
29
A SELECTED BIBLIOGRAPHY
1. Argo, w. B., and J.M. Smith. "Heat Transfer in Packed Beds," Chem, .Eng. Prog., 49 (1953), 443. --,- -- --
2. Aris, R. "On Shape Factors for Irregular Particles," Chem. Eng. Science,~ (1957), 262.
3. Aris, R. "Chemical Reactor Analysis," Ind. Eng. Chem., 56 (1964), (23.
4. Bar-Ilan, M,, and W. Resnick. "Gas Phase Mass Transfer in Fixed Beds at Low Reynolds Numbers," Ind. Eng. Chem., 49 (1957), 313.
5. Baumeister, E. B., and c. o. Bennett. "Fluid Particle Heat Transfer in Packed Beds,":!.:.....!...:_ Ch.~{.:_,± (1958), 69.
6. Bird, R. B., w. c. Stewart, and E. N. Lightfoot. Transport Phenomena, New York: John Wiley and Sons, 1963.
7. Bond, G. c. Catalysis by Metals. New York: Academic Press, 1962.
8. Bradshaw, R, D,, and c. 0, Bennett. "Fluid particle Mass Transfer in a Packed Bed,"~.!.:.. Ch.~::!...:.., 2_ (1961), 48.
9. Brinn, M, S,, et al. "Heat Transfer to Granual Materials Moving Downward Through Vertical Tubes,'' Ind. Eng. Chem., 40, (1958), 1050. -
10, Brownell, L· E,, H, s. Dombrowski, and C, A. Dickey. "Pressure Drop in a Packed Bed," Chem. Eng., 48 (1950), 415.
11. Callaghan, M, J., and D. M, Mason. "Momentum and Heat Transfer Correlations for a Reacting Gas in Turbulent Pipe Flow," ~ .!...:_ Ch. ~ ::!...:._, 10 (1964), 52.
12. Carberry, J. J. 11 The Catalytic Effectiveness Factor Under Nonisothermal Conditions,"A. I. Ch. E, J., 7 (1961), 350. - - - - -
13. Chen, J. c., and S. W. Churchill. "Radiant Heat Transfer in Packed Beds,":!.:....!.:.. Ch.~::!...:..,~ (1963), 35.
14. Chilton, T. H,, and A. P. Colburn. "Mass Transfer Coefficients Prediction from Data on Heat Transfer and Fluid Friction," Ind. and Eng. Chem., 26 (1934), 1183.
30
31
15. Chu, c., and o. A, Hougen. "The Effect of Adsorption on the Effectiveness Factor of Catalyst Particles," Chem. Eng. Science, 17 (1962), 167. ~~
16. Coberly, c. A., and w. R. Marshall, Jr. "Temperature Gradients in Gas Streams Flowing Through Fixed Granular Beds, 11
Chem. Eng. Prog., 47 (1951), 141.
17. Douglas, W. J.M. "Heat and Mass Transfer in a Turbulent Bed Contactor, 11 Chem. Eng. Pro.g., 60 (1964) 1 66.
18. Eckert, E. R. G. Introduction to the Transfer of Heat and Ma.ss. New York: McGraw-,Hill Book Company-,-1950.
19. Eichhorn, J. and R.R. White. "Particle to Fluid Heat Transfer in Fixed and Fluidized Beds 1 11 Chem. En!i:,_ Prog. Symposium Series,± (1951) 1 11.
20. Foust, A, S, et al. Principles of Unit Operations. New York: John Wiley and Sons,19~
21. Fulton, J. W. "Influence of Catalyst Particle Size on Reaction Kinetics: Hydrogenation of Ethylene on Nickel," Ph, D. Thesis, University of Oklahoma, Norman, 1964.
22. Gamson, B. w. "Heat and Mass Transfer in Fluid-Solid Systems," Chem. Eng. Prog., 47 (1951), 19.
23. Gamson, B, w., G, Thodos, and o. A. Hougen. "Heat, Mass, and Momentum Transfer in the flow of Gases.Through Granular Solids," Trans.!..:_.!..:. Ch.~' 39 (1943), 1.
24. Glaser, M, B,, and G. Thodos. ''Heat and Momentum Transfer in the Flow of Gases Through Packed Beds,"!..:_.!..:. Ch.~ .'.!..:_, ± (1958), 63.
25. Hanrattry, T, J. "The Nature of Wall Heat Transfer Coefficients in Packed Beds," Chem. Eng. Science, 3 (1954), 209.
26, Hobson, M. and G, Thodos. "Mass Transfer in the Flow of Liquids Through Granular Solids," Chem. Eng. Prog., 45 (1949), 517.
27. Hobson, M., and G, Thodos. Flow of Gases Through 47 (1951), 370.
"Mass Transfer in the Laminar Granular Beds," Che~ Eng. Prog.,
28. Hoelscher, H, E. "Reactor Design Based on Proposed Distributed Boundary Layer Thickness,"!.:_!.:_ Ch.~!!..:_, ±, (1958), 300.
29. Hougen, J. o., and E. L. Piret. "Effective Thermal Conductivity of Granular Solids Through Which Gases are Flowing, 11 Chem •. Eng. Pro.g., 47 (1951), 295.
30. Hougen, Q. A. "Engineering Aspects of Solid Catalysts," Ind. Eng. Chem., 53 (1961), 509.
32
31. Hurt, D. M. "Principles of Reactor Design," Ind. Eng. Chem., 35 (1943), 522.
32. Kern, D. Q. Process Heat Transfer. New York: McGraw-Hill Book Company, 1950.
33. Kusick, c. L., and J. HappeL "Boundary Layer Mass Transport with Heterog.eneous Catalysts," Ind. and Eng. Fundo, .! (1962), 163.
34. Kwong, s. s., and J.M. Smith. "Radial Heat Transfer in Packed Beds," Ind. Eng. Chem., 49, (1957), 894.
35. Leinroth, J. p., Jr., and T. K. Sherwood. "Semi-Batch Operations of a Recirculation Reactor for the Hydrogenation of Ethylene,"!:.._!..:_ Ch.~!!..:._, 10 (1964), 524.
36. Leva, M. "Heat Transfer to Gases Through Packed Tubes," Ind. Eng. Chem., 39 (1947), 857.
37. Leva, M., and M. Grummer. "Heat Transfer to Gases Through Packed Tubes," Ind. Eng. Chem., 40 (1948), 415.
38. Leva, M., M. Weintraub, and M. Grummer. "Heat Transmission Through Fluidized Beds of Small Particles," Chem. Eng. Prog., ~ (1949-), 563.
39. Leva, M. et al. "Cooling of Gases Through Packed Tubes, 11
Ind. Eng. Chem., !Q (1948), 747.
40. Littlewood, A. B. Gas Chromatography. London: Academic Press, 1962.
41. Masamune, s., and J.M. Smith. "Thermal Conductivity of Beds of Spherical Particles," Ind.~ Eng. Chem. Fund., ~ (1963) , 136.
42. Mingle, J. o., and, J.M. Smith. "Effectiveness Factors for Porous Catalysts,".:!!..!..:_ Ch.~!!.:._, Z, (1961), 243.
43. McCune, L. K., and R.H. Wilhelm. "Mass and Momentum Transfer in Solid-Liquid Systems," Ind. and Eng. Chem., 41 (1949), 1124.
44. Pauls, A· c., E, w. Comings, and J.M. Smith. "Kinetics of the Hydrogenation of Ethylene," A.!..:_ Ch • .!:_!!.:._, 5 (1959), 453.
45. pecsok, R. L., ed. Principles and Practice of Gas Chromatography. 2nd ed. New York: John Wiley and Sons, 1961.
46 •. Pe.rry, J. H., ed. Chemical.Engine.ers' Handbook. 3rd.ed. New York: McGraw-Hill Book Company, 1950.
33
47. Prater, c. D. "The. Temperature Produced by Heat of Reaction in .the Interior of Porous Pellets, 11 Chem •. Eng. Science, ~ (1958), 284.
48. Resnick, W., and R.R. White. "Mass Transfer in Systems of Gases ~nd Fluidized Solids," Chem. Eng. Prog., 45 (1949), 377.
49. Satterfield, c. N,, H. Resnick, and R. L. Wentworth. "Simultaneous Heat and Mass Transfer in a DiffusionControlled Chemical Reaction, 11 Chem •. Eng. Prog., 50 (1954), 460.
50. Satterfield, c. N., and H. Resnick. "Simultaneous Heat and Mass Transfer in a Diffusion-Controlled Chemical Reaction," Chem. Eng. Prog., 50 (1954), 504.
51. Rideal, E. K., and H. S. Taylor. catalysis in Theory and Practice. London: McMillan and Company;- 1926.
52. Schilson, R. E., and N. R. Amundson. "Intraparticle Diffusion and Conduction in Porous Catalysts," Chem. Eng. Science, 13 (1961), 226.
53. Sen Gupta, A., and G. Thodos. "Direct Analogy Between Heat and Mass Transfer in Beds of Spheres, 11 A. I. Ch.
54.
55.
~ !!...=_, ~ (1963), 751. - -
Sen Gupta, A.' and G. Thodos. "Transitional Behavior for the Simultaneous Mass and Heat Transfer of Gases Flow-ing Through packed and Distended Beds, " Ind. and Eng. Chem. Fund., 3 (1964), 218. --- --
-Smith, J.M., and H. c. Van Ness. Introduction to Chemical
New York: McGraw-Hill Engineering Thermodynamics. Book Company, 1959.
56. Stiel, L. I., and G. Thodos. "Viscosity of Hydrogen," Ind. and Eng. Chem. Fund., ~ (1963), 233 .•
57. Sussman, L. O., and M. Potter. "Reaction Kinetics for the Hydrogenation of Ethylene," Ind, and Eng. Chem., 46 (1954), 457.
58. Taecker, R. G., and O. A. Hougen. "Heat and Mass Transfer of Gas Film in the Flow of Gases Through Commercial Tower Packings," Chem. Eng. Prog., 45 (1949), 188.
34
59, Thiele, E. w. "Relation Between Catalytic Activity and Size of Particle,11 Ind. and Eng. Chem., 31 (1939), 916.
60. . Tinkler, . J .. I)., and. A. B. Metzner. "React ion Rates in Nonisotherma1.Catalysts, 11 Tnd. Eng.:. Chem., 53 (1961), 663.
61. Touloukia:i;i,A., ed. Thermophysical Properties Data Book. Lafayette, Indiana: Purdue University, 1964.
62. van Krevelen, D. W., and P. T. Hoftijzer. "Kinetics of Simultaneous Adsorption and Chemical Reaction," Chem. ,'Eng. Prog. , ~ ( 1948) , 7.
63. Volk, w. Applied Statistics for Engineers. New York: McGraw-Hill Book Company-;-I"958o
64. von.Rosenberg, D. U., p. L, Durrill, and E. Ho Spencer. "Numerical Solution of Partial Differential Equations Representing Fixed Bed Reactions," Brit. Chem. Eng., March (1962), 186.
65. Walas, S .. M. Reaction Kinetics for Chemical Engineers. New York: McGraw-Hill Book Company, 1959.
66. Weisz, p. B., and J. S. Hicks, "The Behavior of Porous Catalyst Particles in View of Internal Mass and Heat Diffusion Effects," Chem. Eng. Science, 17 (1962), 265.
67. Wilkie, c. P., and o. A. Hougen. "Mass Transfer in the Flow of Gases Through Granular Solids Extended to Low Modified Reynolds Number," Trans. A. I, Ch, E., 41 (1945), 445. - - - -
68. Yagi, s., and N. Wakao. "Heat and Mass Transfer from Wall to Fluid in Packed Beds,"!:_..!.:_ Ch.~{!_,~ (1959), 79.
APPENDIX A
SAMPLE CALCULATIONS
35
APPENDIX A
SAMPLE CALCULATIONS '
The j-factor and ~eynolds number are calculated for a hydro-
gen flow of 22.0 cc./sec. and an ethylene flow of 5.5 cc./sec.
The catalyst surface temperature was 357°F. and the average bulk
gas temperature was 208°F. An analysis of the chromatograph
curves showed that the weight percent conversion of ethylene to
ethane was 31. 7% ..
1. Molar flow rates:
Hydrogen rate= (22.0 cc./sec.)(3600 sec./hr.)(l gm-mole/
22,400 cc.)(742 mm Hg/760 mm. Hg.)
= 3.08 gm-mole/hr.
Ethylene rate= 0.77 gm-mole/hr.
2. Molar conversion: Basis= 100 pounds.
Ethane~ 31.7 pounds.
Ethylene= 68,2 pounds.
Ethane= (31.7 lb.)(lb-mole/30.1 lb.)= 1.053 lb-mole.
Ethylene= (68.2 lb.)(lb-mole/28.1 lb.)= 2.425 lb-mole.
Total= 3.478 lb-mole.
Mole percent conversion~ (1.053/3.478)(100) = 30.35%.
3. · Heat of. Reaction at 357°F, (55)
@298°F., 6Hr = t.Hf(Products) - 6Hf(Reactants)
6Hr = (-20,236) - Ci,;12,496-0)
6H = - 32,732 cal./gm-mole. r
36
t:.C = C (Products) - C (Reactants) p p p
C (Hydrogen)= 6.947 - 0.200 x 10-3T + 0.481 x l0-6T2 p
C (Ethylene)= 2.830 + 28.601 x l0-3T - 8.72 x l0-6T2 p
C (Ethane)= 3.019 + 28.120 x l0-3T - 8.537 x l0-6T2 p
(C in Btu/(lb-mole-°F.) and Tin °R.) p
t:.C = - 6,758 - 0.281 x l0-3T - 0.292 x l0-6T2 p
! 357
t:.H357 = t:.H298 + t:.CpdT
298
- 0.0973
6.758(T2-T1 ) - 0.1405 x l0-3 (T: - T~)
x l0-6 (T3 - T3 ) 2 1
t:.H357 = - 33,811 cal./gm-mole.
4. Heat Generated and Transferred.
Heat jenerated = (0.77 gm-mole/hr.)(0.3035 conversion)
(33,811 cal./gm-mole) ;I ,1
Heat l?;enerated = 8,250 cal./hr. = 32.7 Btu/hr.
Heat transferred by each particle= (32.7 Btu/hr.)/9
= 3.63 Btu/hr.
5. Pran4tl Number: (6) !
' The Prandtl number for gases is relatively constant for
small changes in temperature.
NPr(Hydrogen) = 0.73
NPr(Ethylene) = 6.80
Np (Ethane) = 0.77 ;r .
NPr(Mixture) = 0.8(0.73) + 0.2(0.80) = 0.744
6. Heat Capacity (55):
37
Hydrogen= 6.9 Btu/(lb-mole-°F.)
Ethylene= 11.5 Btu/(lb-mole-°F.)
C (Mixture)= 0.8(6.9) + 0.2(11.5) = 7.81 Btu/(lb-mole-°F.) p
7. Mass Velocity:
Hydrogen= 3.08 gm-mole/hr. = 0.01358 lb./hr.
Ethylene= 0.77 gm-mole/hr. = 0.0475 lb./hr.
Cross-sectional area of reaction tube =~D2/4
A =7T(O.lll4 ft.) 2/4 = 0.00974 ft 2 .
G = (0.01358+0.0475)/0.00974 = 6.28 lb./(hr.-sq. ft.)
8. Heat Transfer Coefficient:
h = Q/(a AT) p
-4 2 a = 5.10 x 10 ft .
p
AT= 357 - 208 = 149°F.
h = 3.63/((0.000510)(149)) = 43.0 Btu/(hr.-sq. ft.-°F.)
9. j-Factor:
. = (h/C G)(N ) 2/ 3 Jh p Pr
l lb.-mole = 7.23 lb.
jh = (43.0/((7.8)(6.28))(7.23)(0.744) 2/ 3 = 5.28
10. Viscosity (56,61):
The viscosity for the Reynolds number is evaluated at the
arithmetic average film temperature, that is, the average of
the catalyst surface temperature and the average bulk gas
temperature.
Tf = 0.5(357 + 208) = 282.5°F.
µ(Hydrogen)= 0.00208(T/33.3)0. 65
T = °K.
µ (Hydrogen) 0.01165 cp.
(56)
38
39
µ(Ethylene)= 0.001(2.468 + 0.00975T + 0.00007859T2
- 0.00000008462T3 ) (1)
T = °F.
µ(Ethylene)= 0.0134 cp.
µ(Mixture)= 0.8(0.01165) + 0.2(0.0134)
= 0.0120 cp. = 0.0290 lb./(ft.-hr.)
11. Reynolds number:
NRe = DG/µftJ
NRe = (0.0101)(6.98)/(0.0290)(0.91) = 2.67
APPENDIX B
COMPUTER CALCULATION PROGRAM
40
APPENDIX B
COMPUTER CALCULATION PROGRAM
Because of the large amount of time involved in the calcula-
tion of the j-factors and Reynolds numbers 1 a Fortran program was
developed for the IBM 1620 Digital Computer. The block diagram
appears on pages 4.3 and 44 followed by a description of the terms
used and a listing of the program.
The format given below must be used for input data for the
program:
Number of Cards cc Format Data Units
1 1-4 I4 Run number
5-8 I4 Number of Catalyst par-ticles ,'.,
9-12 I4 Number of thermocouples
13-26 El4.8 Average particle area sq. ft.
27-40 El4.8 Average particle ft. diameter
N 1-14 El4.8 Particle surface area sq. ft.
15-28 El4.8 Particle diameter ft.
1 1-14 El4-8 Ethylene flow rate cc/sec.
15-28 El4.8 Hydrogen flow rate cc/sec.
29-42 El4.8 Weight percent conver-sion
1 1-14 El4·.8 Input gas thermocouple mv. potential
41
Number of Cards cc
15-28
N 1-14
Format
El4.8
El4.8
Data Units
output gas thermocou- mv. ple potential
Catalyst particle mv. thermocouple potential
The only abnormal processing instruction was a sense switch
42
setting, If more than one set of flow rates and conversions were
taken, sense switch 1 was turned on. This permitted leading more
of the last (N+2) cards without reloading the first (N+l) cards.
43
Block .Diagram
Read run number, number of catalyst particles, number of
thermocouples, average particle area, average particle
diameter.
• Do I = 1, number of thermocouples. I
! y Read particle area and diameter. I
' Read ethylene flow rate, hydrogen flow rate, and weight
' ~ ·~l' ,, -· ~
percent conversion
• Calculate molar and mass flow rates. 1·
~ Read input and output thermocouple potentials. I
i Calculate input, output, and average gas temperatures. I
i Do I = 1, number of thermocouples· I
~ Read thermocouple potential.
i ~ Calculate surface temperature and temperature drop. I
t Calculate average surface temperature and average tempera-
ture drop.
l Calculate heat of reaction and heat transferred by aver-
age particle.
I °1 Do I = 1, number of thermocouples + i. I
~ . -j Calculate heat transfer coefficient. I
44
Calculate bulk gas heat capacity and mass velocity.j
Do I= 1, number of thermocouples+ 1. I
Calculate film viscosity and heat capacity. I
calculate j-factor and Reynolds number. 1.
Punch run number, number of catalyst particles, ethylene
flow rate, hydrogen flow rate, molar pe~cent con-
- version, number of thermocouples, surface tempera-
ture, average bulk temperature, Reynolds number and
j-factor.
onl~If sense switch 1 I
Off
45
The following list describes the terms used in this program.
The list is arranged as the terms first appear in the program
listing.
Term Description
NRUN Run number
M Number od catalyst particles in bed
N Number of thermocouples in bed
AREAP Average particle external surface area
DPART Average particle diameter
AREA Particle external surface area
D Particle diameter
CCSCE Ethylene flow rate
CCSCH Hydrogen flow rate
CONV Weight percent conversion
CONEE Term used to calculate molar conversion
CONEA Term used to calculate molar conversion
FLHRE Ethylene molar flow'rate
PDHRE Ethylene mass flow rate
FLHRH Hydrogen molar flow rate
PDHRH Hydrogen mass flow rate
VBLKI Input gas thermocouple potential
VBLKO Output gas thermocouple potential
TBLKI Input gas temperature
TBLKO Output gas temperature
BLKAV Average bulk temperature
SMDEL Sum of temperature drops
VTC Catalyst particle thermocouple potential
Term Description
TEMTC catalyst particle surface temperature
DELT Temperature drop from surface to bulk gas
DELAV Average temperature drop
TREAC Reaction temperature in absolute units
A,B,C Constants used in the calculation of the heat of reaction
HREAC Heat of reaction
PHEAT Average heat transferred by a catalyst particle
H Heat transfer coefficient
CONEA Average surface temperature
HAV Heat transfer coefficient
GM Superficial mass velocity
T Average bulk gas temperature
CPH Hydrogen bulk gas heat capacity
CPE Ethylene bulk gas heat capacity
CPB Bulk gas heat capacity
T Average film temperature
CPH Hydrogen film heat capacity
CPE Ethylene film heat capacity
CPFLM Film heat capacity
UH Film hydrogen viscosity
UE Film ethylene viscosity
UFILM Film viscosity
FACTJ j-factor
RE Reynolds number
46
47
DIMENSION AREA(lO),TEMTC(lO),VTC(lO) ,DELT(lOl,DClO),H(lO) 2 READ 100,NRUN,M,N,AREAP,DPART
J=N+l AREA(Jl=AREAP DCJl=DPART DO 200 l=l,N
200 READ 101,AREACI),D(ll 1 READ 102,CCSCE,CCSCH,CONV
CONEA=CONV/30.068 CONEE=(lOO.O-CONVl/28.052 CONEE=CONEE+CONEA CONV=CONEA*lOO.O/CONEE FLHRE=0.1394*CCSCE PDHRE=28.052*FLHRE/453.5924 FLHRH=0.1394*CCSCH PDHRH=2.0l6*FLHRH/453.5924 READ 104,VBLKI,VBLKO TBLKI=39.24818+32.651772*VBLKI TBLK0=39.24818+32.651772*VBLKO BLKAV=0.5*(TBLKI+TBLKOl SMDEL=O·O DO 201 · 1=1,N READ 101,VTC(l) TEMTC(Il=39.24818+32.651772*VTC(I) DELT(I)=TEMTC(l)-SLKAV
201 SMDEL=SMDEL+DELT(Il Z=N DELAV=SMDEL/Z DELT(Jl=DELAV TEMTC(Jl=BLKAV+DELT(Jl TREAC=CDELAV+BLKAV+460.2lll.8 Tl=298.0 A=6.758*(TREAC-Tll B=0.0001405*((TREAC*TREACl-(Tl*Tlll C=0.0000000973*((TREAC*TREAC*TREAC)-(Tl*Tl*Tl)l HREAC=-32732.0-A-B-C HEAT=-CONV*FLHRE*HREAC/25200.0 X=M PHEAT=HEAT/X DO 202 1=1,J PHEAT=PHEAT*(DELT(Jl/DELAVl
202 H(Il=PHEAT/(DELT(ll*AREA(ll l CONEA=BLKAV+DELAV HAV=PHEAT/(DELAV*AREAPl GM=(PDHRE+PDHRHl/(0.00972) T=(BLKAV+460e2)/l.8 CPH=C6.947-0.000200*T+0.00000048l*T**2.0l/2e016 CPE=(2.830+0.02860l*T-0·000008762*T**2•0l/28.052 CPB=(PDHRH*CPH+PDHRE*CPEl/(PDHRH+PDHREl DO 203 I=l,J T=(BLKAV+0.5*DELT(l)+460.2l/l.8 CPH=(6.947-0.000200*T+0.00000048l*T**2•0l/2eOl6 CPE=(2.a30+0.02a601*r-o.oooooa162*T**2.0>12a.os2
48
CPFLM=0.2235*CPH+0.7765*CPE UH=0.00208*(T/33.3l**0•65 . . . UE=0.001*<2,468+0.00975*T+0.00007&59*T*T-0~00000008462*T*T*T> UFILM=2.419l*(O.B*UH+0.2*UEl . . FACTJ=O·B33*(H(I)/CCPB*GM)) RE=D<Il*GM/(UFILM*0•9l)
203 PUNCH 121,NRUN,M,CCSCE,CCSCH,CONV~N,TEMTC<I),BLKAV,RE,FACTJ IF(SENSE SWITCH lll,2 - .
100 FORMAT(I4,14,I4,El4.B,~14.8l 101 FORMAT(E14.8,E14.8) 102 FORMAT(El4.B,E14.8,E14.8) 104 FORMAT(El4.8,El4e8) 121 FORMAT(14,13,F6.l,F6el,F7.2,I4,F9.l,F6.l,F8.3,F8.2)
END . . '
APPENDIX C
CURVE FIT PROGRAM
49
APPENDIX C
CURVE FIT .PROQ.RAM.
A Fortran program was developed for the IBM 1620 Digital
Computer to curve fit the experimental data. This program calcu
lated the constants in the equation, jh ~ aN b The program used Re
the least squares technique explained by Volk (63). It also cal-
culated the percent average deviation of all points as well as the
standard deviation.
The input data for this program was the output data of the
calculation program explained in Appendix B. Below is the defin-
ition of terms. The block diagram is on pages 52 and 53, and the
program listing is on page 54.
Term Description
SUMX Sum of the logarithms of the Reynolds numbers
N Number of data points
SUMY Sum of the Logarithms of the j-factors
SUMXY Sum of the cross products of the logarithms of the Reynolds numbers and the logarithms of the j-factors
SUMXS Sum of squares of the logarithms of the Reynolds numbers
SXYB Corrected cross product sum of squares
CCSCE Ethylene flow rate
CCSCH Hydrogen flow rate
NRUN Run number
M Number of catalyst pellets
N Number of thermocouples
50
51
Term Description
TEMTC Catalyst surface temperature
BLKAV Average bulk gas temperature
RE Reynolds number
FAGTJ j-factor
SUMXS Corrected sum of squares for the logarithms. of the Reynolds numbers
B bin jh
A a in above equation
YCALC j-factor calculated from above equation
SUMSQ Sum of squares for deviation
PCDEV Percent deviation of a data point from calculate equation
SEE Standard deviation
It is necessary to have sense switch 1 in the On position
until the last card is to be read. At that time the sense switch
must be moved to the Off position, and all input cards reloaded
into the read hopper.
52
Block. Diagram
Set all sums equal to zero. I
.... Read run number, number of catalyst particles, ethylene
flow rate, hydrogen flow rate, mole percent conver-
sion, number of thermocouples, catalyst surface tern-·
perature, average bulk gas temperature, Reynolds
number, j-factor.
Calculate logarithm of Reynolds number and j-factor. Set
these equal to x and Yi respectively.
Calculate sum of: x•s, y•s, xy•s, xx• s. I -
On ~ If sense switch 11
Off
Calculate corrected sum of cross products, a, and b. I 1..jDo I ::; 1, number of cards read in first read statement.I
Read all data as on first read statement.I
Calculate j-factor from curve-fitted correlation. I
Calculate sum of squares for deviation. I
Calculate percent deviation. I
Punch Reynolds number, j-factor, calculated j-factor, and ......
percent deviation.
'
53
Calculate standard deviation.
Punch a, b, standard deviation, number of points.
I G) tol
I END I
3 SUMX=O.O N=O SUMY=O.O SUMXY=O•O SUMXS=o.o SXYB=O.O SUMSQ=O.O SMPCT=O.O
1 READ 121, CCSCE,CCSCH,FACTJ,REN,BLKAV,TEMTC,DELT,J,NRUN N=N+l SUMX=SUMX+LOGF(RENl SUMY=SUMY+LOGF(FACTJl SUMXY=SUMXY+(LOGF(FACTJ)*LOGF(RENl l SUMXS=SUMXS+(LOGF(RENl*LOGF(RENll IF(SENSE SWITCH 1>1,2
2 Z=N SXYB=SUMXY-<SUMX*SUMY)/Z SUMXS=SUMXS-(SUMX*SUMXl/Z B=SXYB/SUMXS A=SUMY/Z-B*(SUMX/Zl A=EXPF(Al DO 200 K=l,N READ 121, CCSCE,CCSCH,FACTJ,REN,BLKAV,TEMTC,DELT,I,NRUN YCALC=A*(REN**B) SUMSQ=(YCALC-FACTJl**2+SUMSQ PCDEV=lOO.O*((YCALC-FACTJl/YCALC) SMPCT=SMPCT+ABSF(PCDEV)
200 CONTINUE SEE=CSUMSQ/CZ-2.0))**0•5 PUNCH 103 PUNCH 105,A,B PUNCH 102, SEE,N PCTAV=SMPCT/Z PUNCH 106, PCTAV GO TO 3
102 FORMA1t4HSEE=,f8.3,10X,10HNO OF PTS=,15) 103 FORMAT Cl I) 105 FORMAT(2HA=,FB.4,6X,2HB=,F8.4//) 106 FORMATC/17HPER CENT AVE DEV=,F8.3////) 121 FORMAT<I4,I3,F6.l,F6•1,F7.2,I4,F9.1,F6.l,F8•3,F8•21
END
54
APPENDIX D
EXPERIMENTAL DATA
55
APPENDIX D
EXPERIMENTAL DATA
The output from the program explained in Appendix A appears
on pages 57 through 98~
56
57
RUN NO ETHYL HYDRO CON THERM SURFACE BULi<. REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION · PLE F F
131 9 .s 2.0 78.24 4 256.0 201.0 ·242 42.20 131 9 .s 2.0 78.24 4 24s.o 201.0 ·263 54.03 131 9 .s 2.0 78.24 4 248.4 201.0 ·244 53.14 131 9 .s 2.0 78.24 4 221.0 201.0 ·264 105.00 131 9 .5 2.0 78.24 4 244.3 207 • 0 . .254 55.16 131 9 .5 2.0 78.24 4 254.8 205.6 ·243 42.05 131 9 .5 2.0 78.24 4 243e7 205.6 e264 53.88 131 9 .5 2.0 78.24 4 246.7 205.6 .245 53.56 131 9 .5 2.0 78.24 4 226.8 205.6 .265 102.69 131 9 .5 2.0 78.24 4 243.o 205.6 ·254 55.0l 131 9 .5 2.0 78.24 4 254.9 205.5 .243 41.89 131 9 .5 2.0 78.24 4 243.6 205.5 e264 53.84 131 9 .5 2.0 78.24 4 247.1 205.5 .244 52.89
·131 9 .5 2.0 78.24 4 226.5 205.5 e265 103.97 131 9 .5 2.0 78.24 4 243.0 205.5 .254 54.83 131 9 1.0 4.0 59.13 4 279.1 205.3 e480 21.26 131 9 1.0 4.0 59.13 4 262.2 205.3 ·523 27.39 131 9 1.0 4.0 59.13 4 274.9 205.3 ·482 23.97 131 9 i.o 4.0 59.13 4 249.1 205.3 .524 37.74 131 9 1.0 4e0 59.13 4 266.3 205.3 .502 25.57 131 9 1.0 4.0 59.13 4 278.9 204.5 e480 21.11 13'1 9 1.0 4.0 59.13 4 262.o 204.5 ·523 21.01 131 9 1.0 4.0 59.13 4 274.6 204.5 ·483 23.79 131 9 1.0 4.0 59.13 4 248.4 204.5 e524 37.66 131 9 1.0 4.0 59.13 4 266.o 204.5 e503 25.38 131 9 1.s 6·0 50.46 4 294.7 204.3 ·715 14.85 131 9 1.5 6e0 50.46 4 274.4 204.3 ·180 19.0l 131 9 1.5 6e0 50.46 4 294.o 204.3 ·717 15.89 131 9 1.5 6e0 50.46 4 265.1 204.3 ·180 23.28 131 9 1.5 6e0 50.46 4 202.0 204.3 e748 17.17 131 9 1.5 6e0 50.46 4 294.3 203.8 .715 14.82 131 9 1.5 6.0 50.46 4 273.8 203.8 e781 19.01 131 9 1.5 6.0 50.46 4 293.3 203.8 .11a 15.92 131 9 1.5 6.0 50.46 4 265.o 2·03~5 ·180 2i.00 131 9 1.5 6e0 50.46 4 281.6 203.8 ·748 17.13 131 9 2.0 a.o 44.28 4 309.3 206.6 .945 11.48 131 9 2.0 a.a 44.28 4 286e8 206.6 1.033 14.58 131 9 2.0 a.o 44.28 4 310.6 206.6 .947 12.04 131 9 2.0 a.a 44.28 4 201.1 206.6 le030 16.67 131 9· 2.0 a.o 44.28 4 296.9 206.6 ·989 12.97 131 9 2.0 a.a 44.28 4 309.1 206.3 .945 11.46 131 9 2.0 a.o 44.28 4 286.6 206.3 le033 14.55 131 9 2.0 a.a 44.28 4 311.0 206.3 .947 11.95 131 9 2.0 a.o 44.28 4 280.4 206.3 le031 · 16e 76 131 9 2.0 0.0 44e28 4 296.8 206.3 e989 12.95 131 9 2.5 10.0 40.81 . 4 318.9 206.1 lel76 9.64 131 9 2.5 10.0 40.81 4 295e4 206.1 le286 12.09 131 9 2.5 10.0 40.81 4 324.7 206.l lel76 9.74 131 9 2.5 10.0 40.81 4 291.1 206.l 1.2a2 13.48
58
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
131 9 2.5 10.0 40.81 4 307.5 206.1 1.230 10.66 131 9 2.5 10.0 40.81 4 318.9 206.3 1.176 9.66 131 9 2 ., 5 10.0 40.81 4 295.2 206.3 1.286 12.15 131 9 2.5 10.0 40.81 4 324.3 206.3· 1.176 9.79 131 9 2.5 10.0 40.81 4 291.1 206.3 1.2a1 13. 51 131 9 2.s 10.0 40.81 4 307.4 206.3 1.230 10.10 131 9 3.0 12.0 36.87 4 325.o 206.7 1·407 8.30 131 9 3.0 12.0 36.87 4 300.4 206.7 1.539 10.40 131 9 3.0 12.0 36.87 4 333.7 206.7 le405 8.21 131 9 3.0 12.0 36.87 4 298.o 206.7 le532 11.34 131 9 3.0 12.0 36.87 4 314.3 206.7 le470 9.08 131 9 3.0 12.0 36.87 4 325.6 206.6 le406 8 .. 26 131 9 3.0 12.0 36.87 4 301.0 206.6 le538 10.33 131 9 3.0 12.0 36.87 4 333.9 206.6 le405 0.20 131 9 3.0 12.0 36.87 4 298.6 206.6 1.532 11.25 131 9 3.0 12.0 36.87 4 314.8 206.6 1.470 9.03 131 9 3.5 14.0 35.20 4 336.4 201.0 le632 7.26 131 9 3.5 14.0 35.20 4 310.7 201.0 1.786 8.99 131 9 3.5 14.0 35.20 4 349.9 201.0 le626 6e98 131 9 3.5 14.0 35.20 4 310.4 201.0 le776 9.58 131 9 3.5 l4e0 35.20 4 326.8 201.0 1·705 7.79 131 9 3.5 14.0 35.20 4 336.4 206.7 1·632 7.24 131 9 3.5 14·0 35.20 4 310.4 206.7 le786 8.99 131 9 3.5 14.0 35.20 4 348.3 206.7 le627 1.05 131 9 3.5 l4e0 35.20 4 309.2 206.7 1.777 9.66 131 9 3.5 14.0 35.20 4 326.l 206.7 le706 1.02 131 9 4.0 16.0 32.85 4 345.8 206.9 le857 6e32 131 9 4.0 16.0 32.85 4 319.o 206.9 2.032 1.11 131 9 4.0 16·0 32.85 4 360.4 206.9 le849 6.oe 131 9 4.0 16.o 32.85 4 318.7 206.9 2.022 8.27 131 9 4.0 16.0 32.85 4 336.o 206.9 1.940 6.76 131 9 4.o 16·0 32.85 4 346.1 201.0 le856 6e31 131 9 4.0 16.0 32.85 4 319.3 201.0 2.032 7.75 131 9 4.0 l6e0 32.85 4 360.7 201.0 le849 6.06 131 9 4.0 l6e0 32.85 4 319.2 201.0 2.021 0.24 131 9 4.0 16·0 32.85 4 336.3 201.0 1.939 6.75 131 9 4.5 18.0 32.85 4 352.9 201.0 2.091 6.02 131 9 4.5 1a.o 32.85 4 324.6 201.0 2.200 7.41 131 9 4.5 18.0 32.85 4 367.6 201.0 2.073 5.81 131 9 4.5 1a.o 32.85 4 325.3 201.0 2e267 7.82 131 9 4.5 10.0 32.85 4 342.6 201.0 2.175 6.44 131 9 4.5 10.0 32.85 4 353.6 201.0 2.oa1 5.99 131 9 4.5 1a.o 32.85 4 325.9 201.0 2.279 7.33 131 9 4.5 18.0 32.85 4 369.6 207.0 2.011 5.,74 131 9 4.5 19.0 32.85 4 326.6 201.0 2·265 7.74 131 9 4.5 1a.o 32.85 4 343.9 201.0 2.173 6.38 131 9 5.0 20.0 30.50 4 359.4 207.5 2e305 5.37 131 9 5.0 20.0 30.50 4 331.6 207.5 2.524 6.52 131 9 5.o 20.0 30.50 4 377.9 207.5 2.291 5.08
59
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
131 9 5.0 20.0 30.50 4 331.3 207.5 2.511 6.95 131 9 5.0 20.0 30.50 4 350.0 207.5 2.407 5.69 131 9 5.0 20.0 30.50 4 360.3 208.0 2·303 5.36 131 . 9 s.o 20.0 30.50 4 331.8 208.0 2.523 6e54 131 9 5.0 20.0 30.50 4 378.9 208.0 2.290 5.07 131 9 5.0 20.0 30.50 4 332.1 2oa.o 2.509 6.93 131 9 5.0 20.0 30.50 4 350.8 20'8. o 2e406 5.68 131 9 5.5 22.0 28.85 4 367.5 208.5 2.524 4.86 131 9 5.5 22.0 28.85 4 338.6 208.5 2·766 5.89 131 9 5.5 22.0 28.85 4 385.6 208.5 2.510 4e63 131 9 5.5 22.0 28.85 4 337.3 208.5 2.752 6.32 131 9 5.5 22.0 28.85 4 357.3 208.5 2e637 5.16 131 9 5.5 22.0 28.85 4 367.4 208.8 2.524 4.87 131 9 5.5 22.0 28.85 4 339.1 208.8 2.765 5.00 131 9 5.5 22.0 28.85 4 385.6 208.8 2.510 4.64 131 9 5.5 22.0 28.85 4 338.2 208.8 2.751 6.28 131 9 5.5 22.0 28.85 4 357.6 208.8 2e637 5.16 132 9 .5 2.0 78.03 4 256.0 201.0 .242 42.08 132 9 .5 2.0 78.03 4 245.0 201.0 .263 53.88 132 9 .5 2.0 78.03 4 248.4 201.0 .244 53.00 132 9 .5 2.0 78.03 4 221.0 201.0 .264 104.72 132 9 .5 2.0 78.03 4 244.3 201.0 .254 55.02 132 9 .5 2.0 78.03 4 254.8 205.6 .243 41.94 132 9 .5 2.0 78.03 4 243.7 205.6 .264 53.74 132 9 .5 2.0 78.03 4 246.7 205.6 .245 53.42 132 9 .5 2.0 78.03 4 226.8 205.6 ·265 102.42 132 9 .5 2.0 78.03 4 243.o 205.6 .254 54.86 132 9 .5 2.0 78.03 4 254.9 205.5 ·243 41.78 132 9 .5 2.0 78.03 4 243.6 205.5 ·264 53.69 132 9 .5 2.0 78.03 4 247.l 205.5 .244 52.75 132 9 .5 2.0 78.03 4 226.5 205.5 ·265 103.70 132 9 .5 2.0 78.03 4 243.0 205.5 .254 54.69 132 9 1.0 4.0 59.53 4 279.l 205.3 e480 21.41 132 9 1.0 4.0 59.53 4 262.2 205.3 .523 27.58 132 9 1.0 4.0 59.53 4 274.9 205.3 ·482 24.13 132 9 1.0 4.0 59.53 4 249.l 205.3 .524 37.99 132 9 1.0 4.0 59.53 4 266.3 205.3 e502 25.75 132 9 1.0 4.0 59.53 4 278.9 204.5 ·480 21.25 132 9 1.0 4.0 59.53 4 262.o 204.5 .523 27.25 132 9 1.0 4.0 59.53 4 274.6 204.5 ·483 23.96 132 9 1.0 4.0 59.53 4 248.4 204.5 .524 37.92 132 9 1.0 4.0 59.53 4 266.0 204.5 .503 25.56 132 9 1.5 6e0 52.37 4 294.7 204.3 .715 15.41 132 9 l.5 6.0 52.37 4 274.4 204.3 e780 19.73 132 9 1.5 6e0 52.37 4 294.0 204.3 .111 16.49 132 9 1.5 6e0 52.37 4 265.l 204.3 .160 24.16 132 9 1.5 6·0 52.37 4 202.0 204.3 .748 17.82 132 9 1.5 6·0 52.37 4 294 .3 203.8 ·715 15.38 132 9 1.5 6.0 · 52.37 4 273.8 203.8 .181 19.73
60
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
132 9 1.5 6·0 52.37 4 293.3 203.8 .718 16.52 l .'.\2 9 1.5 6e0 52.37 4 265.o 203.8 .1ao 23.95 132 9 1.5 6a0 52.37 4 281.6 203.8 e748 17.78 132 9 2.0 a.o 44.77 4 309.3 206.6 .945 11.61 132 9 2.0 a.o 44.77 4 286.8 206.6 le033 14.74 132 9 2.0 a.o 44.77 4 310.6 206.6 .947 12.18 132 9 2.0 8.o 44.77 4 281.l 206.6 1.030 16.85 132 9 2.0 8·0 44.77 4 296.9 206.6 a989 13.12 132 9 2.0 8.o 44.77 4 309.l 206.3 .945 11.59 132 9 2.0 a.o 44.77 4 286.6 206.3 la033 14.72 132 9 2.0 a.o ...,.'+~77 4 311.0 206.3 .947 12.09 132 9 2.0 8.o 44.77 4 280.4 206.3 1.031 16.95 132 9 2.0 8.o 44.77 4 296.8 206.3 a989 13.09 132 9 2.5 10.0 40.12 4 318.9 206.l lal76 9.48 132 9 2.5 10.0 40.12 4 295.4 206.l 1.286 111.80 132 9 2.5 10.0 40.12 4 324 .7 206.l 1.176 9.57 132 9 2.5 10.0 40.12 4 291.1 206.1 1.202 13 .2 5 132 9 2.5 10.0 40.12 4 307.5 206.l 1.230 10.48 132 9 2.5 10.0 40.12 4 318.9 206.3 lel 76 9.49 132 9 2.5 10.0 40.12 4 295.2 206.3 le286 11.94 132 9 2.5 10.0 40.12 4 324.3 206.3 1.176 9.63 132 9 2.5 10.0 40.12 4 291.1 206.3 1.251 13.28 132 9 2.5 10.0 40.12 4 307.4 206.3 1.230 10.52 132 9 3.0 12.0 36.96 4 325.0 206.7 le407 a.32 132 9 3.0 12.0 36.96 4 300.4 206.7 1.539 10.43 132 9 3.0 12.0 36.96 4 333.7 206.7 le405 a.24 132 9 3.0 12.0 36.96 4 290.0 206.7 1.532 11.37 132 9 3.0 12.0 36.96 4 314.3 206.7 1.470 9.10 132 9 3.0 12.0 36.96 4 325.6 206.6 le406 8.2a 132 9 3.0 12.0 36.96 4 301.0 206.6 1.538 10.35 132 9 3.0 12.0 36.96 4 333.9 206.6 le405 8.22 132 9 3.0 12.0 36.96 4 298.6 206.6 1.532 11.28 132 9 3.0 12.0 36.96 4 314.8 206.6 le470 9.06 132 9 3.5 14·0 34.51 4 336.4 201.0 1.632 1.12 132 9 3.5 14.0 34.51 4 310.7 207.0 1.786 0.82 132 9 3.5 14.0 34.51 4 349.9 201.0 1.626 6.85 132 9 3.5 14.0 34.51 4 310.4 201.0 1.776 9e39 132 9 3.5 14·0 34.51 4 326.8 201.0 1.105 7. 64 132 9 3.5 14.0 34.51 4 336.4 206.7 1.632 1.10 132 9 3.5 14.0 34.51 4 310.4 206.7 1·786 8.82 132 9 3.5 14.0 34.51 4 348.3 206.7 le627 6.91 132 9 3.5 14.0 34.51 4 309.2 206.7 1.111 9.47 132 9 3.5 14.0 34.51 4 326.l 206.7 le706 7.67 132 9 4.0 16·0 33.24 4 345.8 206.9 le857 6e39 132 9 4.0 16.0 33.24 4 319.0 206.9 2.032 7.86 132 9 4.0 16.0 33.24 4 360.4 206.9 le849 6.15 132 9 4.0 16.0 33.24 4 318.7 206.9 2.022 8e37 132 9 4.0 16.0 33.24 4 336.0 206.9 1.-940 6.84 132 9 4.0 16·0 33.24 4 346.l 201.0 le856 6a38
61
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL- CC/SC CC/SC SION PLE F F
132 9 4.0 16.0 33.24 4 319.3 201.0 2.032 7.85 132 9 4.0 16.0 33.24 4 360.7 201.0 le849 6.14 132 9 4.0 16.0 33.24 4 319.2 201.0 2.021 8.34 132 9 4.0 16.0 33.24 4 336.3 201.0 1.939 6.83 132 9 4.5 18.o 31.67 4 352.9 201.0 2.081 5.8o 132 9 4.5 18.0 31.67 4 324.6 201.0 2.280 7.14 132 9 4e5 1a.o 31.67 4 367.6 201.0 2.073 5.60 132 9 4.5 18.o 31.67 4 325.3 201.0 2.267 7.54 132 9 4.5 18.o 31.67 4 342.6 201.0 2.175 6.21 132 9 4.5 1a.o 31.67 4 353.6 201.0 2.081 5.78 132 9 4.5 18.o 31.67 4 325.9 201.0 2.279 1.01 132 9 4.5 10.0 31.67 4 369.6 201.0 2.011 5.53 132 9 4.5 18.o 31.67 4 326.6 201.0 2.265 7.46 132 9 4.5 18.0 31.67 4 343.9 201.0 2.173 6.15 132 9 5.0 20.0 30.31 4 359.4 207.5 2.305 5.34 132 9 5.0 20.0 30.31 4 331.6 207.5 2.524 6.48 132 9 5.0 20.0 30.31 4 377.9 207.5 2.291 5.05 132 9 5.0 20.0 30.31 4 331.3 207.5 2.511 6.90 132 9 5.0 20.0 30.31 4 350.0 207.5 2e407 5.65 132 9 5.0 20.0 30.31 4 360.3 208.0 2·303 5.33 132 9 s.o 20.0 30.31 4 331.8 208.o 2.523 6.50 132 9 5.0 20.0 30.31 4 378.9 208.0 2.290 5e04 132 9 5.0 20.0 30.31 4 332.1 208.0 2.509 6.88 132 9 5.0 20.0 30.31 4 350.0 200.0 2·406 5.65 132 9 5.5 22.0 29.14 4 367.5 208.5 2.524 4e90 132 9 5.5 22.0 29.14 4 338.6 208~5 2e766 5.95 132 9 5.5 22.0 29.14 4 385.6 208.5 2.510 4.68 132 9 5.5 22.0 29.14 4 337.3 208.5 2.752 6.38 132 9 5.5 22.0 29.14 4 357.3 208.5 2e637 5.21 132 9 5.5 22.0 29.14 4 367.4 208.8 2.524 4.92 132 9 5.5 22.0 29.14 4 339.l 208.8 2·765 5.94 132 9 5.5 22.0 29.14 4 385.6 208.8 2.510 4.68 132 9 5.5 22.0 29.14 4 338.2 208.8 2.151 6.35 132 9 5.5 22.0 29.14 4 357.6 208.8 2.637 5.21 133 9 .5 2.0 78.13 4 256.o 201.0 .242 42.14 133 9 .5 2.0 78.13 4 245.o 201.0 .263 53.95 133 9 .5 2.0 78.13 4 248.4 201.0 .244 53.07 133 9 .5 2.0 78.13 4 221.8 201.0 .264 104.86 133 ·9 .5 2.0 78.13 4 244.3 201.0 .254 55.09 133 9 .5 2.0 78.13 4 254.8 205.6 .243 42.00 133 9 .5 2.0 78.13 4 243.7 205.6 .264 53.81 133 9 .5 2.0 78.13 4 246.7 205.6 .245 53.49 133 9 .5 2.0 78.13 4 226.8 205.6 .265 102.55 133 9 .5 2.0 78.13 4 243.o 205.6 .254 54.94 133 9 .5 2.0 78.13 4 254.9 205.5 .243 41.83 133 9 .5 2.0 78.13 4 243.6 205.5 e264 53.76 133 9 .5 2.0 78.13 4 247.1 205.5 .244 52.82 133 9 .5 2.0 78.13 4 226.5 205.5 ·265 103.83 133 9 .5 2.0 78.13 4 243.o 205.5 .254 54.76
62
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
133 9 1.0 4.0 59.84 4 279.1 205.3 e480 21.52 133 9 1.0 4.0 59.84 4 262.2 205.3 e523 21.12 133 9 1.0 4.0 5.9. 84 4 274.9 205.3 e482 24.26 133 9 1.0 4·0 59.84 4 249.1 205.3 .524 38.19 133 9 1.0 4.0 59.84 4 266, 3 205.3 ·502 25.88 133 9 1.0 4.0 59.84 4 278.9 204.5 ·480 21,36 133 9 1.0 4e0 59.84 4 262.0 204.5 e523 27.39 133 9 1.0 4.0 59.84 4 274.6 204.5 e483 24.08 133 9 1.0 4.0 59.84 4 248.4 204.5 .524 38.11 133 9 1.0 4.0 59.84 4 266.0 204.5 e503 25.69 133 9 1.5 6e0 50.26 4 294.7 204.3 .715 14.79 133 9 1.5 6·0 50.26 4 274.4 204.3 ·180 18.93 133 9 1.5 6e0 50.26 4 294.0 204.3 .111 15.83 133 9 1.5 6.0 50.26 4 265.1 204.3 .1ao 23.19 133 9 1.5 6e0 50.26 4 202.0 204.3 .748 11.10 133 9 1.5 6·0 50.26 4 273.8 203.8 e781 18.93 133 9 1.5 6e0 50.26 4 294.3 203.8 .715 14.76 133 9 1.5 6e0 50.26 4 293.3 203.8 .118 15.86 133 9 1.5 6.0 50.26 4 265.o 203.8 .100 22.99 133 9 1.5 6·0 50.26 4 281.6 203.8 ·748 11.01 133 9 2.0 0.0 44.28 4 309.3 206.6 • 945 11.48 133 9 2.0 a.o 44.28 4 286.8 206.6 1.033 14.58 133 9 2.0 a.a 44.28 4 310.6 206.6 .947 12.04 133 9 2.0 0.0 44.28 4 281.1 206.6 1.030 16.67 133 9 2.0 a.a 44.28 4 296.9 206.6 ·989 12.97 133 9 2.0 a.o 44.28 4 309.1 206.3 .945 11.46 133 9 2.0 a.o 44.28 4 286.6 206.3 1.033 14.55 133 9 2.0 a.a 44.28 4 311.0 206.3 .947 11.95 133 9 2.0 a.o 44.28 4 280.4 206.3 1.031 16.76 133 9 2.0 0.0 44.28 4 296.8 206.3 ·989 12.95 133 9 2.5 10.0 40.41 4 318.9 206.l lel76 9.55 133 9 2.5 10.0 40.41 4 295.4 206.l le286 11.97 133 9 2.5 10.0 40.41 4 324.7 206.1 1.176 9.64 133 9 2.5 10.0 40.41 4 291.l 206.1 1.202 13.35 133 9 2.5 10.0 40.41 4 307.5 206.l 1.230 10.55 133 9 2.5 10.0 40.41 4 318.9 206.3 1.176 9.57 133 9 2.5 10.0 40.41 4 295.2 206.3 1.286 12.03 133 9 2.5 10.0 40.41 4 324.3 206.3 1.176 9.70 133 9 2.5 10.0 40.41 4 291.1 206.3 1.201 13.38 133 9 2.5 10.0 40.41 4 307.4 206.3 1.230 10.59 133 9 3.0 12.0 36.57 4 325.o 206.7 le407 0.24 133 9 3.0 12.0 36.57 4 300.4 206.7 1.539 10.32 133 9 3.0 12.0 36.57 4 333.7 206.7 le405 8.15 133 9 3.0 12.0 36.57 4 298.0 206.7 1.532 11.25 133 9 3.0 12.0 36.57 4 314.3 206.7 1.470 9.00 133 9 3.0 12.0 36.57 4 325.6 206.6 le406 0.19 133 9 3.0 12.0 36.57 4 301.0 206.6 le538 10.24 133 9 3.0 12.0 36.57 4 333.9 206.6 le405 0.14 133 9 3.0 12.0 36.57 4 298.6 206.6 1.532 11.16
63
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
133 9 3.0 12.0 36.57 4 314.8 206.6 le470 8.96 133 9 3.5 14.0 34.51 4 336.4 201.0 1.632 7.12 133 9 3.5 14.0 34.51 4 310.7 201.0 1.786 8.82 133 9 3.5 14.0 34.51 4 349.9 201.0 le626 6.85 133 9 3.5 14.0 34.51 4 310.4 201.0 le776 9.39 133 9 3.5 14.0 34.51 4 326.8 201.0 le705 7.64 133 9 3.5 14.0 34.51 4 336.4 206.7 1.632 7.10 133 9 3.5 14·0 34.51 4 310.4 206.7 le786 8.02 133 9 3.5 14.0 34.51 4 348.3 206.7 1.627 6.91 133 9 3.5 14.0 34.51 4 309.2 206.7 1.777 9.47 133 9 3.5 14.0 34.51 4 326.1 206.7 1.106 7.67 133 9 4.0 16·0 32.85 4 345.8 206.9 1.857 6.32 133 9 4.0 16.0 32.85 4 319.0 206.9 2.032 7.77 133 9 4.0 16.0 32.85 4 360.4 206.9 le849 6.08 133 9 4.0 16.0 32.85 4 318.7 206.9 2.022 8.21 133 9 4.0 16.0 32.85 4 336.0 206.9 le940 6.76 133 9 4.0 16.0 32.85 4 346.1 201.0 le856 6.31 133 9 4.0 16.0 32.85 4 319.3 201.0 2.032 7.75 133 9 4.0 16.0 32.85 4 360.7 201.0 1.849 6.06 133 9 4.0 16.0 32.85 4 319.2 201.0 2.021 8.24 133 9 4.0 16.0 32.85 4 336.3 201.0 1.939 6.75 133 9 4.5 18.0 31.58 4 352.9 201.0 2.081 5.78 133 9 4.5 10.0 31.58 4 324.6 201.0 2.200 1.12 133 9 4.5 10.0 31.58 4 367.6 201.0 2.073 5.58 133 9 4.5 1a.o 31.58 4 325.3 201.0 2e267 7.52 133 9 4.5 10.0 31.58 4 342.6 201.0 2.175 6.19 133 9 4.5 18.0 31.58 4 353.6 201.0 2.oa1 5.76 133 9 4.5 1a.o 31.58 4 325.9 201.0 2.279 7.05 133 9 4.5 1a.o 31.58 4 369.6 201.0 2.011 5.52 133 9 4.5 18.0 31.58 4 326.6 201.0 2.265 7.44 133 9 4.5 1a.o 31.58 4 343.9 201.0 2.173 6.13 133 9 5.0 20.0 29.92 4 359.4 207.5 2.305 5.27 133 9 5.0 20.0 29.92 4 331.6 207.5 2.524 6.40 133 9 5.0 20.0 29.92 4 377.9 207.5 2.291 4.99 133 9 5.0 20.0 29.92 4 331.3 207.5 2.511 6.81 133 9 5.0 20.0 29.92 4 350.0 207.5 2.407 5.58 133 9 5.0 20.0 29.92 4 360.3 208.0 2.303 5.26 133 9 5.0 20.0 29.92 4 331.8 200.0 2.523 6.42 133 9 5.0 20.0 29.92 4 378.9 200.0 2.290 4.97 133 9 5.0 20.0 29.92 4 332.1 208.0 2.509 6.80 133 9 5.0 20.0 29.92 4 350.8 208.0 2.406 5.57 133 9 5.5 22.0 28.46 4 367.5 208.5 2.524 4.79 133 9 5.5 22.0 28.46 4 338.6 208.5 2.766 5.01 133 9 5.5 22.0 28.46 4 385.6 208.5 2.510 4.57 133 9 5.5 22.0 28.46 4 337.3 208.5 2.752 6.23 133 9 5.5 22.0 28.46 4 357.3 208.5 2.637 5.09 133 9 5.5 22.0 28.46 4 367.4 208.8 2.524 4.80 133 9 5.5 22.0 28.46 4 339.1 208.8 2.765 5.8o 133 9 5.5 22.0 28.46 4 385.6 208.8 2.510 4.58
64
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j OF ENE GEN VER ocou- TEMP TEMP. NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
133 9 5.5 22.0 28.46 4 338.2 208.8 2.751 6e20 133 9 5.5 22.0 28.46 4 357.6 208.8 2.637 5.09 134 9 .5 2.0 78.44 4 256.Q 207.0 .242 42.31 134 9 .5 2.0 78.44 4 245.o 201.0 .263 54.17 134 9 .5 2.0 78.44 4 248.4 201.0 .244 53.28 134 9 .5 2.0 78.44 4 221.a 201.0 .264 105.28 134 9 .5 2.0 78.44 4 244.3 20'7.o .254 55.31 134 9 .5 2.0 78.44 4 254.8 205..6 .243 42.17 134 9 .5 2.0 78.44 4 243.7 205.6 ·264 54.02 134 9 .5 2.0 78.44 4 246.7 205.6 .245 53.70 134 9 .5 2.0 78.44 4 226.8 205.6 .265 102.96 134 9 .5 2.0 78.44 4 243.0 205.6 .254 55.16 134 9 .5 2.0 78.44 4 254.9 205.5 .243 42.00 134 9 .5 2.0 78.44 4 243.6 205.5 .264 53.98 134 9 .5 2.0 78.44 4 247.1 205.5 ·244 53.03 134 9 .5 2.0 78.44 4 226.5 205.5 .265 104.25 134 9 .5 2.0 78.44 4 243.0 205.5 .254 54.98 134 9 1.5 6.0 49.66 4 294.7 204.3 .715 14.61 134 9 1.5 6.0 49.66 4 274.4 204.3 .1ao 18.71 134 9 1.5 6·0 49.66 4 294.o 204.3 .111 15.64 134 9 1.5 6·0 49.66 4 265.l 204.3 ·180 22.91 134 9 1.5 6e0 49.66 4 282.0 204.3 .748 16.89 134 9 1.5 6·0 49.66 4 294.3 203.8 .715 14.58 134 9 1.5 6·0 49.66 4 273.8 203.8 e781 18.71 134 9 1.5 6·0 49.66 4 293.3 203.8 .118 15.67' 134 9 1.5 6e0 49.66 4 265.0 203.8 .1ao 22.71 134 9 1.5 6.0 49.66 4 281.6 203.8 .748 16.86 134 9 2.0 0.0 44.77 4 309.3 206.6 .945 11.61 134 9 2.0 8.o 44.77 4 286.8 206.6 1.033 14.74 134 9 2.0 8.o 44.77 4 310.6 206.6 .947 12.18 134 9 2.0 a.o 44.77 4 281.l 206.6 1.030 16.85 134 9 2.0 a.o 44.77 4 296.9 206). 6 ·989 13 .12 134 9 2.0 a.a 44.77 4 309.1 206.3 .945 11. 59 134 9 2.0 0.0 44.77 4 286.6 206.3 1.033 14.72 134 9 2.0 a.o . 44. 77 4 311.0 206.3 .947 12.09 134 9 2.0 a.o 44.77 4 280.4 206.3 1.031 16.95
• 134 9 2.0 0.0 44.77 4 296.8 206.3 .989 13.09 134 9 2.5 10.0 37.75 4 318.9 206.1 1.116 8.92 134 9 2.5 10.0 37.75 4 295.4 206.1 le286 11.10 134 9 2.5 10.0 37.75 4 324.7 206.l 1.176 9.01 134 9 2.5 10.0 37.75 4 291.l 206.l 1.282 12.47 134 9 2.5 10.0 37.75 4 307.5 206.1 1.230 9.86 134 9 2.5 10.0 37.75 4 318.9 206.3 1.116 8.93 134 9 2.5 10.0 37.75 4 295.2 206.3 1.286 11.24 134 9 2.5 10.0 37.75 4 324.3 206.3 lel76 9.06 134 9 2.5 10.0 37.75 4 291.l 206.3 1.201 12.50 134 9 2.5 10.0 37.75 4 307.4 206.3 1.230 9.90 134 9 3.0 12.0 36.77 4 325.0 206.7 1.407 B.28 134 9 3.0 12.0 36.77 4 300.4 206.7 1.539 10.37
65
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
1"34 9 3.0 12.0 36.77 4 333.7 206.7 le405 8.19 1~4 9 3.0 12.0 36.77 4 298.0 206.7 le532 11.31 134 9 3.0 12.0 36.77 4 314.3 206.7 le470 9.05 134 9 3.0 12.0 36.77 4 325.6 206.6 le406 e.24 134 9 3.0 12.0 36.77 4 301.0 206.6 le538 10.30 134 9 3.0 12.0 36.77 4 333.9 206.6 le405 e.1a 134 9 3.0 12.0 36.77 4 298.6 206.6 1.532 11.22 134 9 3.0 12.0 36.77 4 314.8 206.6 1.470 9.01 134 9 3.5 14.0 34.90 4 336.4 201.0 1.632 1.20 134 9 3.5 14.0 34.90 4 310.7 201.0 1.786 8.92 134 9 3.5 l4e0 34.90 4 349.9 201.0 le626 6.92 134 9 3.5 14.0 34.90 4 310.4 201.0 le776 9.50 134 9 3.5 14.0 34.90 4 326.8 201.0 le705 7.73 134 9 3.5 14.0 34.90 4 336.4 206.7 le632 7.18 134 9 3.5 14.0 34.90 4 310.4 206.7 le786 8.92 134 9 3.5 14·0 34 .• 90 4 348.3 206.7 le627 6.99 134 9 3.5 14·0 34.90 4 309.2 206.7 1.777 9.58 134 9 3.5 14.0 34.90 4 326.1 206.7 le706 7.76 134 9 4.5 18.0 31.48 4 352 .9 201.0 2.oa1 5.77 134 9 4.5 18.0 31.48 4 324.6 201.0 2.2ao 1.10 134 9 4.5 1a.o 31.48 4 367.6 201.0 2.073 5.56 134 9 4.5 18.0 31.48 4 325.3 201.0 2.267 7.50 134 9 4.5 18.0 31.48 4 342.6 201.0 2.175 6.17 134 9 4.5 18.0 31.48 4 353.6 207.0 2.oa1 5.74 134 9 4.5 18.0 31.48 4 325.9 201.0 2.279 7.03 134 9 4.5 10.0 31.48 4 369.6 201.0 2.011 5.50 134 9 4.5 1a.o 31.48 4 326.6 201.0 2.265 7.42 134 9 4.5 1a.o 31.48 4 343.9 201.0 2.173 6.11 134 9 5.0 20.0 30.02 4 359.4 207.5 2.305 5.29 134 9 5.0 20.0 30.02 4 331.6 207.5 2.524 6.42 134 9 5.0 20.0 30.02 4 377.9 207.5 2.291 5.oo 134 9 5.0 20.0 30.02 4 331.3 207.5 2.511 6.83 134 9 5.0 20.0 30.02 4 350.0 207.5 2.407 5.60 134 9 5.0 20.0 30.02 4 360.3 208.0 2.303 5.27 134 9 5.0 20.0 30.02 4 331.8 208.0 2.523 6.44 134 9 5.0 20.0 30.02 4 378.9 208.0 2.290 4.99 134 9 5.0 20.0 30.02 4 332.1 208.0 2.509 6.82 134 9 5.0 20.0 30.02 4 350.8 208.0 2e406 5.59 135 9 .5 2.0 78.21 4 256.0 201.0 .242 42.18 135 9 .5 2.0 78.21 4 245.o 201.0 .263 54.0l 135 9 .5 2.0 78.21 4 248 .4 201.0 .244 53.13 135 9 .5 2.0 78.21 4 221.a 201.0 ·264 104.96 135 9 .5 2.0 78.21 4 244.3 201.0 .254 55.14 135 9 .5 2.0 78.21 4 254.8 205.6 .243 42.04 135 9 .5 2.0 78.21 4 243.7 205.6 ·264 53.86 135 9 .5 2.0 78.21 4 246.7 205.6 .245 53.54 135 9 .5 2.0 78.21 4 226.8 205.6 .265 102.66 135 9 .5 2.0 78.21 4 243.0 205 .6 .254 54.99 135 9 .5 2.0 78.21 4 254.9 205.5 .243 41.87
66
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
135 9 .5 2.0 78.21 4 243.6 205.5 .264 53.82 135 9 .5 2.0 78.21 4 247.1 205.5 .244 52.87 135 9 .5 2.0 78.21 4 226.5 205.5 e265 103.94 135 9 .5 2.0 78.21 4 243.0 205.5 .254 54.81 135 9 1.0 4.0 59.50 4 279.l 205.3 e480 21.40 135 9 1.0 4.0 59.50 4 262.2 205.3 .523 27.56 135 9 1.0 4.0 59.50 4 274.9 205.3 ·482 24.12 135 9 1.0 4.0 59.50 4 249.l 205.3 .524 37.97 135 9 1.0 4.0 59.50 4 266.3 205.3 e502 25.73 135 9 1.0 4.0 59.50 4 278.9 204.5. .480 21.24 135 9 1.0 4.0 59.50 4 262.0 204.5 .523 27.24 135 9 1.0 4.0 59.50 4 274.6 204.5 e483 23.94 135 9 1.0 4.0 59.50 4 248.4 204.5 .524 37.90 135 9 1.0 4.0 59.50 4 266.o 204.5 e503 25.54 135 9 1.5 6.0 50.69 4 294.7 204.3 .715 14.92 135 9 1.5 6.0 50.69 4 274.4 204.3 .780 19.09 135 9 1.5 6.0 50.69 4 294.0 204.3 .111 15.96 135 9 1.5 6.0 50.69 4 265.l 204.3 .180 23.38 135 9 1.5 6.0 50.69 4 202.0 204.3 .748 17.24 135 9 1.5 6.0 50.69 4 294.3 203.8 .715 14.88 135 9 1.5 6e0 50.69 4 273.8 203.8 .781 19.09 135 9 1.5 6.0 50.69 4 293.3 203.8 .718 15.99 135 9 1.5 6.0 50.69 4 265.0 20-3.8 .780 23.18 135 9 1.5 6·0 50.69 4 281.6 203.8 ·748 17.21 135 9 2.0 a.o 44.55 4 309.3 206.6 .945 11. 55 135 9 2.0 a.o 44.55 4 286 .8 206.6 le033 14 .67 135 9 2.0 8.0 44.55 4 310.6 206.6 .947 12.12 135 9 2.0 a.a 44.55 4 281.1 206.6 1.030 16.77 135 9 2.0 0.0 44.55 4 296.9 206.6 .989 13.05 135 9 2.0 8.0 44.55 4 309 .1 206.3 .945 11. 53 135 9 2.0 8.o 44.55 4 286.6 206.3 1.033 14.64 135 9 2.0 0.0 44.55 4 311.0 206.3 .947 12.03 135 9 2.0 8.o 44.55 4 280.4 206.3 1.031 16.86 135 9 2.0 0.0 44.55 4 296.8 206.3 .989 13 .0 3 135 9 2.5 10.0 40.02 4 318.9 206.l 1.116 9.45 135 9 2.5 10.0 40. 02 4 295.4 206.1 le286 11.85 135 9 2.5 10.0 40.02 4 324.7 206.l 1.176 9.55 135 9 2.5 10.0 40.02 4 291.1 206.l 1.282 13.22 135 ·9 2.5 10.0 40.02 4 307 .5 206.1 1.230 10 .45 135 9 2.5 10.0 40.02 4 318.9 206.3 lel76 9 . 47 135 9 2 .5 10.0 40.02 4 295.2 206.3 le286 11. 91 135 9 2.5 10.0 40.02 4 324.3 206.3 lel76 9.60 135 9 2.5 10.0 40.02 4 291.1 206.3 1.281 13.·25 135 9 2.5 10.0 40.02 4 307.4 206.3 1.230 10.49 135 9 3.0 12.0 36.79 4 325.0 206.7 1.407 8.29 135 9 3.0 12.0 36.79 4 300 .4 206.7 1 .539 10.38 135 9 3.0 12.0 36.79 4 333.7 206 .7 le405 0 . 20 135 9 3.0 . 12.0 36 . 79 4 290.0 206.7 1.532 11 . 32 135 9 3.0 12.0 36.79 4 314 . 3 206 .7 1 .470 9.06
67
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
135 9 3.0 12.0 36.79 4 325.6 206.6 le406 a.24 135 9 3.0 12.0 36.79 4 301.0 206.6 1.538 10.31 135 9 3.0 12.0 36.79 4 333.9 206.6 le405 a.19 135 9 3.0 12.0 36.79 4 298.6 206.6 1.532 11.23 135 9 3.0 12.0 36.79 4 314.8 206.6 le470 9.01 135 9 3.5 14.0 34.78 4 336.4 201.0 le632 1.11 135 9 3.5 14.0 34.78 4 31 0.7 201.0 l e786 8.89 135 9 3.5 14e0 34.78 4 349.9 201.0 le626 6e90 135 9 3.5 14.0 34.78 4 310.4 201.0 1.776 9.46 135 9 3.5 14.0 34.78 4 326.8 201.0 1.105 1.10 135 9 3.5 14.0 34.78 4 336.4 206.7 1·632 7.16 135 9 3.5 14.0 34.78 4 310.4 206.7 le786 a.ea 135 9 3.5 14·0 34.78 4 348.3 206.7 1.627 6.96 135 9 3.5 14.0 34.78 4 309.2 206.7 1.111 9.54 135 9 3.5 14.0 34.78 4 326.l 206.7 1.706 7.73 135 9 4.0 16.0 32.98 4 345.8 206.9 le857 6.34 135 9 4.0 16.0 32.98 4 319.o 206.9 2.032 1.80 135 9 4.0 16.0 32.98 4 360.4 206.9 le849 6.10 135 9 4.0 16·0 32.98 4 318.7 206.9 2.022 0.31 135 9 4.0 16·0 32.98 4 336.o 206.9 le940 6.79 135 9 4.0 16·0 32.98 4 346.l 201.0 le856 6.33 135 9 4.0 16.0 32.98 4 319.3 201.0 2.032 7.78 135 9 4.0 16.0 32.98 4 360.7 201.0 le849 6e09 135 9 4.0 l6e0 32.98 4 319.2 201.0 2.021 0.21 135 9 4.0 16.0 32.98 4 336.3 201.0 1.939 6.77 135 9 4.5 10.0 32.87 4 352.9 201.0 2.001 6.02 135 9 4.5 10.0 32.87 4 324.6 201.0 2.200 7.41 135 9 4.5 18.0 32.87 4 367.6 201.0 2.073 5.81 135 9 4.5 18.0 32.87 4 325.3 201.0 2e267 7.83 135 9 4.5 10.0 32.87 4 342.6 201.0 2.175 6.44 135 9 4.5 18.0 32.87 4 353.6 201.0 2.001 6.oo 135 9 4.5 18.0 32.87 4 325.9 201.0 2.279 7.34 135 9 4.5 10.0 32.87 4 369.6 201.0 2.011 5.74 135 9 4.5 10.0 32.87 4 326.6 201.0 2.265 7.75 135 9 4.5 10.0 32.87 4 343.9 201.0 2.173 6.38 135 9 5.0 20.0 30.19 4 359.4 207.5 2e305 5.32 135 9 5.0 20.0 30.19 4 331.6 207.5 2.524 6.46 135 9 5.0 20.0 30.19 4 377.9 207.5 2.291 5.03 135 9 5.0 20.0 30.19 4 331.3 207.5 2.511 6.87 135 9 5.0 20.0 30.19 4 350.0 207.5 2.407 5.63 135 9 5.0 20.0 30.19 4 360.3 208.0 2.303 5.30 135 9 5.0 20.0 30.19 4 331.8 208.0 2.523 6.47 135 9 5.0 20.0 30.19 4 378.9 208.0 2.290 5.02 135 9 5.0 20.0 30.19 4 332.1 200.0 2e509 6.86 135 9 s.o 20.0 30.19 4 350.8 208.0 2e406 5.62 135 9 5.5 22.0 28.82 4 367.5 208.5 2.524 4.85 135 9 5.5 22.0 28.82 4 338.6 208.5 2.766 5.89 135 9 5.5 22.0 28.82 4 385.6 208.5 2.510 4.63 135 9 5.5 22.0 28.82 4 337.3 208.5 2.752 6.31
68
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
135 9 5.5 22.0 28.82 4 357.3 208.5 2.637 5.16 135 9 5.5 22.0 28.82 4 367.4 208.8 · 2 • 524 4.86 135 9 5.5 22.0 28.82 4 339.l 208.8 2.765 5.87 135 9 5.5 22.0 28.82 4 385.6 208.8 2. 5 10 4.63 135 9 5.5 22.0 28.82 4 338.2 208.8 2.751 6.28 135 9 5.5 22.0 28.82 4 357.6 208.8 2e637 5.15 141 9 .5 2.0 72.33 4 200.6 154.l .257 41.59 141 9 .5 2.0 72.33 4 190.6 154.l .2ao 52.47 141 9 .5 2.0 72.33 4 195.l 154.l .259 50.09 141 9 .5 2.0 72.33 4 171.1 154.-1 .201 119.54 141 9 .s 2.0 72.33 4 189.3 154.l .269 54.49 141 9 .5 2.0 72.33 4 199.8 152.9 .258 41.24 141 9 .5 2.0 72.33 4 189.8 152.9 .200 52.04 141 9 .5 2.0 72.33 4 194.1 152.9 .259 49.85 141 9 .5 2.0 72.33 4 170.6 152.9 .282 115.06 141 9 .5 2.0 72.33 4 188.6 152.9 .210 53.89 141 9 1.5 6·0 44.38 4 242.0 154.2 .755 13.57 141 9 1.5 6·0 44.38 4 221.2 154.2 .825 17.65 141 9 1.5 6e0 44.38 4 240.6 154.2 .758 14.65 141 9 1.5 6·0 44.38 4 203.2 154.2 e829 25.62 141 9 1.5 6·0 44.38 4 226.8 154.2 .792 16.33 141 9 1.5 6e0 44.38 4 241.9 154.5 .755 13.62 141 9 1.5 6e0 44.38 4 221.4 154.5 .825 17.67 141 9 1.5 6e0 44.38 4 241.2 154.5 .757 14.59 141 9 1.5 6.0 44.38 4 203.9 154.5 .829 25.37 141 9 1.5 6.0 44.38 4 221.1 154.5 .791 16.30 141 9 2.5 10.0 37.85 4 266.3 154.0 1.242 9.07 141 9 2.5 10.0 37.85 4 241.6 154.o 1.360 11.55 141 9 2.5 10.0 37.85 4 212.1 154.0 le241 9.13 141 9 2.5 10.0 37.85 4 230.4 154.0 le361 14.06 141 9 2.5 10.0 37.85 4 252.7 154.0 le30l 10.26 141 9 2.s 10.0 37.85 4 266.2 154.l 1.242 9.09 141 9 2.5 10.0 37.85 4 241.3 154.1 le360 11.59 141 9 2.5 10.0 37.85 4 272.5 154.l 1.242 9.14 141 9 2.5 10.0 37.85 4 230.7 154.l 1.361 14.01 141 9 2.s 10.0 37.85 4 252.7 154.1 1.301 10.27 141 9 3.5 14.0 36.18 4 285.7 154.3 1.121 7.43 141 9 3.5 14.0 36.18 4 258.5 154.3 1.887 9.30 141 9 3.5 14.0 36.18 4 299.5 154.3 1.713 1.14 141 9 3.5 14·0 36.18 4 251.5 154.3 le883 10.58 141 9 3.5 14.0 36.18 4 273.8 154.3 1.ao1 a.12 141 9 3.5 14.0 36.18 4 285.6 154.3 1.121 7.44 141 9 3.5 14e0 36.18 4 258.l 154.3 le887 9.33 141 9 3.5 14.0 36.18 4 298.3 154.3 1.714 1.20 141 9 3.5 14.0 36.18 4 250.9 154.3 1·884 10.65 141 9 3.5 14.0 36.18 4 273.2 154.3 1.001 B.16 141 9 4.5 18.0 30.80 4 301.8 154.2 2.194 5.64 141 9 4.5 10.0 30.80 4 272.5 154.2 2e408 6.99 141 9 4.5 1a.o 30.80 4 319.6 154.2 2.100 5.35
69
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/~C CC/SC SION PLE F F
141 9 4.5 1a.o 30.80 4 265.9 154.2 2e403 7.86 141 9 4.5 1a.o 30.80 4 290.0 154.2 2.295 6.10 141 9 4.5 18.0 30.80 4 301.9 154.2 2.194 5.64 141 9 4.5 1a.o 30.80 4 272.9 154.2 2·407 6.96 141 9 4.5 18.0 30.80 4 319.5 154.2 2.1ao 5.35 141 9 4.5 18.0 30.80 4 266.6 154.2 2.402 7.81 141 9 4.5 18.0 30.80 4 290.2 154.2 2.295 6e09 141 9 5.5 22.0 29.24 4 313.9 154.l 2·665 4.95 141 9 5.5 22.0 29.24 4 283.7 154.l 2.925 6.06 141 9 5.5 22.0 29.24 4 333.4 154.l 2·646 4.69 141 9 5.5 22.0 29.24 4 276.3 154.1 2.921 6.83 141 9 5.5 22.0 29.24 4 301.8 154.l 2·788 5.33 141 9 5.5 22.0 29.24 4 312.3 154.0 2.667 5.oo 141 9 5.5 22.0 29.24 4 281.8 154.o 2·928 6.14 141 9 5.5 22.0 29.24 4 332.2 154.0 2·647 4.72 141 9 5.5 22.0 29.24 4 275.6 154.0 2.922 6.86 141 9 5.5 22.0 29.24 4 300.5 154.0 2.790 5.37 142 9 .5 2.0 72.64 4 200.6 154.l .257 41.77 142 9 .5 2.0 72.64 4 190.6 154.1 .200 52.69 142 9 .5 2.0 72.64 4 195.1 154.1 .259 50.31 142 9 .5 2.0 72.64 4 171.1 154.l .201 120.05 142 9 .5 2.0 72.64 4 189.3 154.1 .269 54.72 142 9 .5 2.0 72.64 4 199.8 152.9 .258 41.41 142 9 .5 2.0 72.64 4 189.8 152.9 .200 52.26 142 9 .5 2.0 72.64 4 194.1 152.9 .259 50.06 142 9 .5 2.0 72.64 4 170.6 152.9 .202 115.55 142 9 .5 2.0 72.64 4 188.6 152.9 .210 54.13 142 9 1.5 6e0 47.46 4 242.0 154.2 .755 14.52 142 9 1.5 6e0 47.46 4 221.2 154.2 ·825 18.88 142 9 1.5 6e0 47.46 4 240.6 154.2 ·758 15.67 142 9 1.5 6.0 47.46 4 203.2 154.2 .829 27.40 142 9 1.5 6·0 47.46 4 226.8 154.2 .792 17.47 142 9 1.5 6.0 47.46 4 241.9 154.5 .755 14.57 142 9 1.5 6.0 47.46 4 221.4 154.5 .825 18.90 142 9 1.5 6·0 47.46 4 241.2 154.5 .757 15.61 142 9 1.5 6·0 47.46 4 203.9 154.5 .829 27.14 142 9 1.5 6•0 47.46 4 221.1 154.5 e791 17.44 142 9 2.5 10.0 38.74 4 266.3 154.0 1.242 9.29 142 9 2.5 10.0 38.74 4 241.6 154.0 1.360 11.82 142 9 2.5 10.0 38.74 4 212.1 154.Q 1.241 9.34 142 9 2.5 10.0 38.74 4 230.4 154.0 1.361 14.39 142 9 2.5 10.0 38.74 4 252.7 154.0 1.301 10.50 142 9 2.5 10.0 38.74 4 266.2 154.1 1.242 9.30 142 9 2.5 10.0 38.74 4 241.3 154.1 1.360 11.86 142 9 2.5 10.0 38.74 4 272.5 154.l 1.242 9.35 142 9 2.5 10.0 38.74 4 230.7 154.l 1.361 14.34 142 9 2.5 10.0 38.74 4 252.7 154.1 l e.301 10.51 142 9 3.5 14.0 33.63 4 285.7 154.3 1.121 6.91 142 9 3.5 14.0 33.63 4 258.5 154.3 le887 8.64
70
RUN NO ETHYL HYDRO CON THERM SURFACE ~ULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
.1 ·42 9 3.5 14e0 33.63 4 299.5 154.3 1.113 6e64 l '1·2 9 3.5 14.0 33.63 4 251.5 154.3 1.883 9.84 142 9 3.5 14.0 33.63 4 273.8 154.3 1.801 7.55 142 9 3.5 14.0 33.63 4 285.6 154.3 1.121 6e91 142 9 3.5 14.0 33.63 4 258.l 154.3 le887 8.67 142 9 3.5 · 14.0 33.63 4 298.3 154.3 1.114 6.70 142 9 3.5 14.0 33.63 4 250.9 154.3 le884 9.·90 142 9 3.5 14.0 33.63 4 273.2 154.3 1.8oi 7.59 142 9 4.5 1a.o 30.70 4 301.8 154.2 2.194 5.62 142 9 4.5 18.0 30.70 .4 272.5 154.2 2e408 6.96 142 9 4.5 19.0 30.70 4 319.6 154.2 2.180 5.33 142 9 4.5 18.0 30.70 4 265.9 154.2 2e403 7.83 142 9 4.5 18.0 30.70 4 290.0 154.2 2.295 6e08 142 9 4.5 18.0 30.70 4 301.9 154.2 2.194 5e62 142 9 4.5 18.o 30.70 4 272.9 154.2 2e407 6.94 142 9 4.5 1a.o 30.70 4 319.5 154.2 2.1eo 5.33 142 9 4.5 18.0 30.70 4 266.6 154.2 2e402 1.18 142 9 4.5 18.0 30.70 4 290.2 154.2 2.295 6.07 142 9 5.5 22.0 28.95 4 313.9 154.1 2e66'5 4.90 142 9 5.5 22.0 28.95 4 283.7 154.l 2e925 6.oo 142 9 5.5 22.0 28.95 4 333.4 154.1 2e646 4.64 142 9 5.5 22.0 28.95 4 276.3 154.1 2e92l 6e76 142 9 5.5 22.0 28.95 4 301. 8 154.1 2e788 5.27 142 9 5.5 22.0 28.95 4 312.3 154.0 2e667 4e95 142 9 5.5 22.0 28.95 4 281.8 154.0 2e928 6e08 142 9 5.5 22.0 28.95 4 332.2 154.0 2e647 4.67 142 9 5.5 22.0 28.95 4 275.6 154.0 2.922 6.79 142 9 5 . 5 22.0 28 . 95 4 300.5 154.0 2.190 5.32 143 9 .5 2.0 72.33 4 200.6 154.l .257 41.59 143 9 .5 2.0 72.33 4 190.6 154.1 .280 52.47 143 9 .5 2.0 72.33 4 195.l 154.1 .259 50.09 143 9 .s 2.0 72.33 4 111.1 154.l .2a1 119.54 143 9 .5 2.0 72.33 4 189.3 154.l .269 54.49 143 9 .5 2.0 72.33 4 199.8 152.9 .258 41.24 143 9 .5 2.0 72.33 4 189.8 152.9 .280 52.04 143 9 .5 2.0 72.33 4 194.1 152.9 .259 49.85 143 9 .5 2.0 72.33 4 170.6 152.9 .292 115.06 143 9 .5 2.0 72.33 4 188.6 152.9 .210 53.89 143 9 1.5 6e0 47.06 4 242.0 154.2 .755 14.40 143 9 1.5 6·0 47.06 4 221.2 154.2 ·825 18.72 143 9 1.5 6e0 47.06 4 240.6 154.2 .758 15.54 143 9 1.5 6·0 47.06 4 203.2 154.2 .829 27.17 143 9 1.5 6e0 47.06 4 226.8 154.2 .192 17.32 143 9 1.5 6·0 47.06 4 241.9 154.5 .755 14.45 143 9 1.5 6e0 47.06 4 221.4 154.5 ·825 18.74 143 9 1.5 6·0 47.06 4 241.2 154.5 .757 15.48 143 9 1.5 6·0 47.06 4 203.9 154.5 .829 26.91 143 9 1.5 6·0 47.06 4 227.1 154.5 .791 17.29 143 9 2.5 10.0 37.95 4 266.3 154.0 1.242 9.10
71
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
143 9 2.s 10.0 37.95 4 241.6 154.0 1.360 11.5a 143 9 2.5 10.0 37.95 4 212.1 154.0 1.241 9.15 143 9 2.s 10.0 37.95 4 230.4 154.0 le361 14.10 141 9 2.s 10.0 37.95 4 252.7 154.0 le30l 10.29 143 9 2.5 10.0 37.95 4 266.2 154.1 le242 9.11 143 9 2.5 10.0 37.95 4 241.3 154.1 le360 11.62 143 9 2.5 10.0 37.95 4 272.5 154.l 1.242 9 .16.. 143 9 2.5 10.0 37.95 4 230.7 154.l 1.361 14.05 143 9 2.5 10.0 37.95 4 252.7 154. l le301 10.30 143 9 3.5 14.0 34.41 4 285.7 154.3 1.121 1.01 143 9 3.5 14.0 34.41 4 258.5 154.3 1.887 8.84 143 9 3.5 14·0 34.41 4 299.5 154.3 1.113 6.79 143 9 3.5 14.0 34.41 4 251.5 154.3 1.883 10.07 143 9 3.5 14.0 34.41 4 273.8 154.3 1.001 7.73 143 9 3.5 14.0 34.41 4 285.6 154.3 1.121 1.01 143 9 3.5 14·0 34.41 4 258.l 154.3 le887 a.ea 143 9 3.5 14.0 34.41 4 298.3 154.3 1.114 6.85 143 9 3.5 14·0 34.41 4 250.9 154.3 le884 10.13 143 9 3.5 14.0 34.41 4 273.2 154.3 1.801 7.76 143 9 4.5 10.0 30.31 4 301.8 154.2 2.194 5.55 143 9 4.5 18.0 30.31 4 272.5 154.2 2.408 6e87 143 9 4.5 18.o 30.31 4 319.6 154.2 2.100 5.26 143 9 4.5 18.0 30.31 4 265.9 154.2 2 .. 403 7.73 143 9 4.5 18.o 30.31 4 290.0 154.2 2.295 6.oo 143 9 4.5 18.0 30.31 4 301.9 154.2 2.194 5.55 143 9 4.5 10.0 30.31 4 272.9 154.2 2e407 6.85 143 9 4.5 10.0 30.31 4 319.5 154.2 2.180 5.27 143 9 4.5 18·0 30.31 4 266.6 154.2 2e402 7.68 143 9 4.5 1a.o 30.31 4 290.2 154.2 2.295 5.99 143 9 5.5 22.0 31.67 4 313.9 154.1 2e665 5.37 143 9 5.5 22.0 31.67 4 283.7 154.l 2.925 6.56 143 9 5.5 22.0 31.67 4 333.4 154.l 2e646 5e08 143 9 5.5 22.0 31.67 4 276. 3 154.1 2.921 7.40 143 9 5.5 22.0 31.67 4 301.8 154.l 2.788 5.77 143 9 5.5 22.0 31.67 4 312.3 154.0 2.667 5.41 143 9 5.5 22.0 31.67 4 281.8 154.0 2.928 6.66 143 9 5.5 22.0 31.67 4 332.2 154.0 2e647 5.11 143 9 5.5 22.0 31.67 4 275.6 154.0 2.922 7.43 143 ·9 5.5 22.0 31.67 4 300.5 154.0 2.190 5.82 144 9 .5 2.0 72.43 4 200.6 154.l .257 41.65 144 9 .s 2.0 72.43 4 190.6 154.1 .200 52.54 144 9 .5 2.0 72.43 4 195.1 154.l .259 50.16 144 9 .5 2.0 72.43 4 171.1 154.1 .251 119.71 144 9 .5 2.0 72.43 4 189.3 154.1 ·269 54.57 144 9 .s 2.0 72.43 4 199.8 152.9 .258 41.30 144 9 .s 2.0 72.43 4 189.8 152.9 .2ao 52.11 144 9 .5 2.0 72.43 4 194.l 152.9 .259 49.92 144 9 .5 2.0 72.43 4 170.6 152.9 .202 115.22 144 9 .5 2.0 72.43 4 18'8. 6 152.9 .210 53.97
72
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
144 9 1.5 6e0 47.36 4 242.0 154.2 .755 14.49 144 9 1.5 6e0 47.36 4 221.2 154.2 ·825 18.84 144 9 1.5 6e0 47.36 4 240.6 154.2 e758 15.64 144 9 1.5 6·0 47.36 4 203.2 154.2 e829 27.34 144 9 1.5 6·0 47.36 4 226.8 154.2 .192 17.43 144 . 9 1.5 6e0 47.36 4 241.9 154.5 .755 14.54 144 9 1.5 6e0 47.36 4 221.4 154.5 .825 18.86 144 9 1.5 6e0 47.36 4 241.2 154.5 .757 15.57 144 9 1.5 6e0 47.36 4 203.9 154.5 .829 21.oa 144 9 1.5 6.0 47.36 4 227.l 154.5 .791 17.40 144 9 2.s 10.0 38.14 4 266.3 154.0 1.242 9.14 144 9 2.5 10.0 38.14 4 241.6 154.0 1.360 11.64 144 9 2.5 10.0 38.14 4 212.1 154.o 1.241 9.20 144 9 2.5 10.0 38.14 4 230.4 154.0 le361 14.17 144 9 2.5 10.0 38.14 4 252.7 154.0 le30l 10.34 144 9 2.s 10.0 38.14 4 266.2 154.1 1.242 9.16 144 9 2.5 10.0 38.14 4 241.3 154.1 le360 11.68 144 9 2.5 10.0 38.14 4 272.5 154.1 1.242 9.21 144 9 2.s 10.0 38.14 4 230.7 154.1 le361 14.12 144 9 2.5 10.0 38.14 4 252.7 154.l 1.301 10.35 144 9 3.5 14.0 34.02 4 285.7 154.3 1.121 6.99 144 9 3.5 14.0 34.02 4 258.5 154.3 le887 8.74 144 9 3.5 14.0 34.02 4 299.5 154.3 1.713 6.72 144 9 3.5 14.0 34.02 4 251.5 154.3 le883 9.95 144 9 3.5 l4e0 34.02 4 273.8 154.3 1.001 7.64 144 9 3.5 14.0 34.02 4 285.6 154.3 1.121 6.99 144 9 3.5 14.0 34.02 4 258.l 154.3 le887 8.78 144 9 3.5 14.0 34.02 4 298.3 154.3 1.714 6.77 144 9 3.5 14.0 34.02 4 250.9 154.3 1.884 10.02 144 9 3.5 14.0 34.02 4 273.2 154.3 1.001 7.68 144 9 4.5 10.0 30.50 4 301.8 154.2 2.194 5.59 144 9 4.5 18.0 30.50 4 272.5 154.2 2-.408 6.92 144 9 4.5 10.0 30.50 4 319.6 154.2 2.150 5.30 144 9 4.5 18.0 30.50 4 265.9 154.2 2.403 7.78 144 9 4.5 10.0 30.50 4 290.0 154.2 2.295 6.04 144 9 4.5 18.0 30.50 4 301.9 154.2 2.194 5.58 144 9 4.5 10.0 30.50 4 272.9 154.2 2.407 6.90 144 9 4.5 10.0 30.50 4 319.5 154.2 2.100 5.30 144 9 4.5 18.0 30.50 4 266.6 154.2 2.402 7.73 144 9 4.5 1a.o 30.50 4 290 .2 154.2 2.295 6.03 145 9 .5 2.0 73.15 4 200 .6 154.l .257 42.06 145 9 .5 2.0 73.15 4 190.6 154.l .280 53.07 145 9 .5 2.0 73.15 4 195.1 154.l .259 50.66 145 9 .5 2.0 73.15 4 171.l 154.1 .281 120.91 145 9 .5 2.0 73.15 4 189.3 154.l .269 55.11 145 9 .5 2.0 73.15 4 199.8 152.9 .258 41.71 145 9 .5 2.0 73.15 4 189.8 152.9 .2ao 52.63 145 9 .5 2.0 73.15 4 194.1 152.9 .259 50.42 145 9 .5 2.0 73.15 4 170.6 152.9 .282 116.37
73
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
145 9 .s 2.0 73.15 4 188.6 152.9 .210 54.51 146 9 .5 2.0 72.58 4 200.6 154.l .257 41.73 146 9 .5 2.0 72.58 4 190.6 154.l .290 52.65 146 9 .s 2.0 72.58 4 195.1 154.1 .259 50.26 146 9 .5 2.0 72.58 4 111.1 154.l .2e1 119.95 146 9 .5 2.0 72.58 4 189.3 154.l .269 54.68 146 9 .5 2.0 72.58 4 199.8 152.9 .258 41.38 146 9 .5 2.0 72.58 4 189.8 152.9 .200 52.22 146 9 .5 2.0 72.58 4 194.l 152.9 .259 50.02 146 9 .5 2.0 72.58 4 170.6 152.9 .202 115.45 146 9 .5 2.0 72.58 4 188.6 152.9 .210 54.08 146 9 1.5 6·0 46.56 4 242.0 154.2 .755 14.24 146 9 1.5 6.0 46.56 4 221.2 154.2 .825 18.53 146 9 1.5 6e0 46.56 4 240.6 154.2 .758 15.37 146 9 1.5 6·0 46.56 4 203.2 154.2 .829 26.88 146 9 1.5 6·0 46.56 4 226.8 154.2 .792 17.14 146 9 1.5 6e0 46.56 4 241.9 154.5 .755 14.29 146 9 1.5 6e0 46.56 4 221.4 154.5 .025 18.54 146 9 1.5 6e0 46.56 4 241.2 154.5 .757 15.31 146 9 1.5 6·0 46.56 4 203.9 154.5 .829 26.63 146 9 1.5 6·0 46.56 4 227.l 154.5 .791 17.11 146 9 2.5 10.0 38.17 4 266.3 154.0 le242 9.15 146 9 2.5 10.0 38.17 4 241.6 154.o le360 11.64 146 9 2.5 10.0 38.17 4 212.1 154.0 1.241 9.20 146 9 2.5 10.0 38.17 4 230.4 154.0 1.361 14.18 146 9 2.5 10.0 38.17 4 252.7 154.0 1.301 10.35 146 9 2.5 10.0 38.17 4 266.2 154.l 1.242 9.17 146 9 2.5 10.0 38.17 4 241.3 154.l 1.360 11.69 146 9 2.5 10.0 38.17 4 272.5 154.l 1.242 9.22 146 9 2.5 10.0 38.17 4 230.7 154.l le361 14.13 146 9 2.5 10.0 38.17 4 252.7 154.l le301 10.36 146 9 3.5 14·0 34.56 4 285.7 154.3 1.121 1.10 146 9 3.5 14·0 34.56 4 258.5 154.3 le887 0.00 146 9 3.5 14·0 34.56 4 299.5 154.3 1.113 6.82 146 9 3.5 14.0 34.56 4 251.5 154.3 1.883 10.11 146 9 3.5 l4e0 34.56 4 273.8 154.3 1.001 7.76 146 9 3.5 14.0 34.56 4 285.6 154.3 1.121 1.10 146 9 3.5 14.0 34.56 4 258.l 154.3 1.887 8.91 146 9 3.5 14.0 34.56 4 298.3 154.3 1.114 6.88 146 9 3.5 14.0 34.56 4 250.9 154.3 le884 10.11 146 9 3.5 14.0 34.56 4 273.2 154.3 1.801 1.00 146 9 4.5 18.0 30.58 4 301.8 154.2 2.194 5e60 146 9 4.5 10.0 30.58 4 272.5 154.2 2e408 6e94 146 9 4.5 18.0 30.58 4 319.6 154.2 2.1ao 5.31 146 9 4.5 18.o 30.58 4 265.9 154.2 2e403 1.ao 146 9 4.5 18.o 30.58 4 290.0 154.2 2.295 6e05 146 9 4.5 18.0 30.58 4 301.9 154.2 2.194 5.60 146 9 4.5 18·0 30.58 4 272.9 154.2 2·407 6.91 146 9 4.5 18.0 30.58 4 319.5 154.2 2.190 5.31
74
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
146 9 4.5 1e.o 30.58 4 266.6 154.2 2e402 1.15 146 9 4.5 1a.o 30.58 4 290.2 154.2 2.295 6.04 146 9 5.5 22.0 29.95 4 313.9 154.1 2.665 5.07 146 9 5.5 22.0 29.95 4 283.7 154.l 2.925 6.21 146 9 5.5 22.0 29.95 4 333.4 154.l 2·646 4e80 146 9 5.5 22.0 29.95 4 276.3 154.1 2.921 6.99 146 9 5.5 22.0 29.95 4 301.8 15'4.1 2.10a 5.46 146 9 5.5 22.0 29.95 4 312.~ 154.0 2e667 5.12 146 9 5.5 22.0 29.95 4 281.8 154.0 2.928 6.29 146 9 5.5 22.0 29.95 4 332.2 154.0 2e647 4.83 146 9 5.5 22.0 29.95 4 275.6 154.0 2.922 7.03 146 9 5.5 22.0 29.95 4 300.5 154.0 2.790 5.50 151 9 1.0 4.0 59.43 4 279.0 205.0 .480 2i.33 151 9 1.0 4.0 59.43 4 261.7 205.0 .523 27.60 151 9 1.0 4.0 59.43 4 274.6 205.0 ·483 24.09 151 9 1.0 4.0 59.43 4 249.0 205.o e524 37.83 151 9 1.0 4e0 59.43 4 266.l 205.o .502 25.69 151 9 1.0 4.0 59.43 4 279.0 205.1 e480 21.33 151 9 1.0 4.0 59.43 4 261.8 205.1 .523 27.59 151 9 1.0 4.0 59.43 4 274.7 205.l e483 24.08 151 9 1.0 4.0 59.43 4 249.0 205.l .524 37.80 151 9 1.0 4.0 59.43 4 266.1 205.1 .502 25.68 151 9 2.0 0.0 44.57 4 309.2 206.4 .945 11. 53 151 9 2.0 0.0 44.57 4 286.5 206.4 le033 14.69 151 9 2.0 0.0 44.57 4 310.5 206.4 .947 12.10 151 9 2.0 0.0 44.57 4 280.8 206.4 1.030 16.80 151 9 2.0 0.0 44.57 4 296.7 206.4 • 989 13.05 151 9 2.0 0.0 44.57 4 309.4 206.5 .945 11.53 151 9 2.0 0.0 44.57 4 286.6 206.5 le033 14.69 151 9 2.0 0.0 44.57 4 310.6 206.5 .947 12.10 151 9 2.0 0.0 44.57 4 280.8 206.5 le030 16.83 151 9 2.0 0.0 44.57 4 296.9 206.5 e989 13.05 151 9 5.0 20.0 30.21 4 359.7 207.6 2e304 5.31 151 9 5.0 20.0 30.21 4 331.7 207.6 2.524 6.47 151 9 5.o 20.0 30.21 4 377.9 207.6 2.291 5.04 151 9 5.0 20.0 30.21 4 331.3 207.6 2.511 6.89 151 9 5.0 20.0 30.21 4 350.1 207.6 2.407 5.64 151 9 5.0 20.0 30.21 4 359.8 208.0 2.304 5.32 151 9 5.0 20.0 30.21 4 331.9 208.0 2.523 6.47 151 9 5.0 20.0 30.21 4 378.2 208.0 2.291 5.04 151 9 5.0 20.0 30.21 4 331.6 208.0 2.510 6e89 151 9 5.0 20.0 30.21 4 350.4 208.0 2e406 5.64 152 9 1.0 4.0 59.23 4 279.0 205.o .480 21.26 152 9 1.0 4.0 59.23 4 261.7 205.o .523 27.51 152 9 1.0 4.0 59.23 4 274.6 205.0 .483 24.00 152 9 1.0 4.0 59.23 4 249.0 205.0 .524 37.70 152 9 1.0 4.0 59.23 4 266.1 205.o ·502 25.60 152 9 1.0 · 4.0 59.23 4 279.0 205.1 e480 21.26 152 9 1.0 4.0 59.23 4 261.8 205.1 .523 27.49
75
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j
OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
E,2 9 1.0 4.0 59.23 4 274.7 205.l e483 23.99 152 9 1.0 4.0 59.23 4 249.0 205.1 .524 37.68 15~ 9 1.0 4.0 59.23 4 266.l 205.1 e502 25.59 152 9 2.0 a.o 44.28 4 309.2 206.4 .945 11.45 152 9 2.0 a.o 44e28 4 286.5 206.4 le033 14.60 152 9 2.0 8.o 44.28 4 310.5 206.4 • 947 12.02 152 9 2.0 a.o 44.28 4 280.8 206.4 le030 16.69 152 9 2.0 a.o 44.28 4 296.7 206.4 .989 12.96 152 9 2.0 a.o 44.28 4 309.4 206.5 .945 11.45 152 9 2.0 a.o 44.28 4 286.6 206.5 1.033 14.60 152 9 2.0 a.o 44.28 4 310.6 206.5 .947 12.02 152 9 2.0 a.o 44.28 4 280.8 206.5 1.030 16.72 152 9 2.0 a.a 44.28 4 296.9 206.5 .989 12.97 152 9 5.o 20.0 29.92 4 359.7 207.6 2·304 5.26 152 9 5.0 20.0 29.92 4 331.7 207.6 2.524 6.40 152 9 5.0 20.0 29.92 4 377.9 207.6 2.291 4.99 152 9 5.0 20.0 29.92 4 331.3 207.6 2.511 6.82 152 9 5 . 0 20.0 29 . 92 4 350.l 207.6 2.407 5.58 152 9 5.0 20.0 29.92 4 359.8 208.0 2.3Q4 5.27 152 9 5.0 20.0 29.92 4 331.9 208.0 2.523 6.41 152 9 5.0 20.0 29.92 4 378.2 208.0 2.291 4.99 152 9 5.0 20.0 29.92 4 331.6 208.0 2.510 6.82 152 9 5.0 20.0 29.92 4 350.4 208.0 2e406 5.59 153 9 1.0 4.0 59.64 4 279.0 205.0 ·480 21.40 153 9 1.0 4.0 59.64 4 261.7 205.o .523 21.10 153 9 1.0 4.0 59.64 4 274.6 205.0 .493 24.17 153 9 1.0 4.0 59.64 4 249.0 205.0 .524 37.96 153 9 1.0 4.0 59.64 4 266.l 205.0 .502 25.78 153 9 1.0 4.0 59.64 4 279.0 205.1 e480 21.40 153 9 1.0 4.0 59.64 4 261.8 205.1 .523 27.68 153 9 1.0 4.0 59.64 4 274.7 205.1 e483 24.16 153 9 1.0 4.0 59.64 4 249.o 205.1 .524 37.93 153 9 1.0 4.0 59.64 4 266.1 205.1 .502 25.77 153 9 2.0 a.o 44.48 4 309.2 206.4 .945 11. 51 153 9 2.0 e.o 44.48 4 286.5 206.4 le033 14.66 153 9 2.0 a.o 44.48 4 310.5 206.4 .947 12.08 153 9 2.0 a.o 44.48 4 280.8 206.4 1.030 16.77 153 9 2.0 a.a 44.48 4 296.7 206.4 e989 13.02 153 9 2.0 0.0 44.48 4 309.4 206.5 .945 11. 51 153 9 2.0 a.o 44.48 4 286.6 206.5 1.033 14.66 153 9 2.0 0.0 44.48 4 310 .6 206.5 .947 12.oe 153 9 2.0 a.a 44.48 4 280.8 206.5 1.030 16.79 153 9 2.0 0.0 44.48 4 296.9 206.5 e989 13.03 153 9 5.0 20.0 30.11 4 359.7 207.6 2e304 5.30 153 9 5.0 20.0 30.11 4 331 .7 207.6 2.524 6.44 153 9 5.0 20.0 30.11 4 377.9 207.6 2.291 5.03 153 9 5.0 20.0 30.11 4 331 .3 207 .6 2 .511 6.87 153 9 5.0 20.0 30 .11 4 350 .l 207 .6 2 e407 5.62 153 9 5.0 20.0 30.11 4 359 .8 200.0 2e304 5.3Q
76
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
153 9 5.0 20.0 30.11 4 331.9 208.0 2.523 6.45 153 9 5.0 20.0 30.11 4 378.2 208.0 2.291 5.03 153 9 5.0 20.0 30.11 4 331.6 208.0 2.510 6.87 15:) 9 5.0 20.0 30.11 4 350.4 208.0 2e406 5.62 154 9 1.0 4.0 59.53 4 279.0 205.0 e480 21.37 154 9 1.0 4.0 59.53 4 261.7 205.0 ·523 27.65 154 9 1.0 4.0 59.53 4 274.6 205.0 ·483 24.13 154 9 1.0 4.0 59.53 4 249.o 205.0 .524 37.90 154 9 1.0 4.0 59.53 4 266.1 205.0 e502 25.74 154 9 1.0 4.0 59.53 4 279.0 205.1 e480 21.37 154 9 1.0 4.0 59.53 4 261.8 205.1 e523 27.63 154 9 1.0 4.0 59.53 4 274.7 205.1 ·483 24.12 154 9 1.0 4.0 59.53 4 249.o 205.l .524 37.87 154 9 1.0 4.0 59.53 4 266.1 205.l .502 25.73 154 9 2.0 8.o 44.67 4 309.2 206.4 .945 11. 56 154 9 2.0 s.o 44.67 L• 286.5 206.4 1 .033 14.73 154 9 2.0 s.o 44.67 4 310.5 206.4 .947 12.13 154 9 2.0 8.o 44.67 4 280.8 206.4 1.030 16.84 154 9 2.0 8.o 44.67 4 296.7 206.4 ·989 13.08 154 9 2.0 s.o 44.67 4 309.4 206.5 .945 11. 56 154 9 2.0 s.o 44.67 4 286.6 206.5 1.033 14.73 154 9 2.0 9.0 44.67 4 310.6 206.5 .947 12 .13 154 9 2.0 8.o 44.67 4 280 .8 206.5 1.030 16.87 154 9 2.0 0.0 44.67 4 296.9 206.5 .989 13.08 154 9 5.0 20.0 30.02 4 359.7 207.6 2.304 5.28 154 9 5.0 20.0 30.02 4 331.7 l07_6 2.524 6.42 154 9 5.0 20.0 30.02 4 377.9 207.6 2.291 5.01 154 9 5.0 20.0 30.02 4 331.3 207.6 2.511 6.84 154 9 5.0 20.0 30.02 4 350.1 207.6 2.407 5.60 154 9 5.0 20.0 30.02 4 359.8 208.0 2e304 5.29 154 9 5.0 20.0 30.02 4 331.9 200.0 2.523 6.43 154 9 5.0 20.0 30.02 4 378.2 200.0 2.291 5.01 154 9 5.0 20.0 30.02 4 331 .6 208.0 2.510 6e84 154 9 5.0 20.0 30.02 4 350.4 208.0 2e406 5.61 155 9 1.0 4.0 59.46 4 219.o 205.o e480 21.34 155 9 1.0 4.0 59.46 4 261.7 205.o .523 27.61 155 9 1.0 4.0 59.46 4 274.6 205.0 e483 24.10 155 9 1.0 4.0 59.46 4 249.0 205.0 .524 37.85 155 ·9 1.0 4.0 59.46 4 266 .1 205.0 .502 25.70 155 9 1.0 4.0 59.46 4 279.0 205.1 ·480 21.34 155 9 1.0 4.0 59.46 4 261.8 205.1 .523 27.60 155 9 1.0 4.0 59.46 4 274.7 205.1 ·483 24.09 155 9 1.0 4.0 59.46 4 249.0 205.1 e524 37.82 155 9 1.0 4.0 59.46 4 266.l 205.l e502 25.69 155 9 2.0 a.o 44.50 4 309.2 206.4 .945 11. 51 155 9 2.0 a.o 44.50 4 286.5 206.4 l e033 14.67 155 9 2.0 a.a 44.50 4 310.5 206.4 .947 12.oa 155 9 2 .0 a.o 44.50 4 280.8 206.4 1.030 16.77 155 9 2.0 0.0 44.50 4 296.7 206.4 .989 13.03
77
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
155 9 2.0 0.0 44.50 4 309.4 206.5 .945 11. 51 155 9 2.0 0.0 44.50 4 286.6 206.5 le033 14.67 155 9 2.0 0.0 44.50 4 310.6 206.5 .947 12.00 155 9 2.0 0.0 44.50 4 200.0 206.5 le030 16.60 155 9 2.0 0.0 44. 50 4 296.9 206.5 e989 13.03 155 9 5.0 20.0 30.07 4 359.7 207.6 2e304 5.29 155 9 5.0 20.0 30.07 4 331.7 207.6 2.524 6e43 155 9 5.0 20.0 30.07 4 377.9 207.6 2.291 5.02 155 9 5,0 20.0 30.07 4 331.3 207.6 2.511 6.85 155 9 5.0 20.0 30.07 4 350.1 207.6 2.407 5e6l 155 9 5.0 20.0 30.07 4 359.8 208.0 2e304 5.29 155 9 5.0 20.0 30.07 4 331.9 208.0 2.523 6.44 155 9 5.0 20.0 30.07 4 378.2 200.0 2.291 5.02 155 9 5.0 20.0 30.07 4 331.6 200.0 2.510 6.85 155 9 5.0 20.0 30.07 4 350.4 208.0 2e406 5.61 181 3 1.0 4.0 18.87 2 255.2 199.9 • 490 26.98 181 3 1.0 4.0 18.87 2 248.o 199.9 e480 30.65 181 3 1.0 4.0 18.87 2 251.6 199.9 e496 28.56 181 3 1.0 4.0 18.87 2 256.l 199.5 .490 26.35 181 3 1.0 4.0 18.87 2 248.o 199.5 ·480 30.43 181 3 1.0 4.0 18.87 2 252.l 199.5 e496 28.11 181 3 1.0 4.0 18.87 2 256.9 199.5 e489 26.01 181 3 1.0 4.0 18.87 2 248.0 199.5 • 480 30.37 181 ' 3 1.0 4.0 18.87 2 252.4 199.5 .495 27.88 181 3 1.5 6e0 13.53 2 273.0 201.1 .120 14.91 181 3 1.5 6e0 13.53 2 263.3 201.1 ·714 17.03 181 3 1.5 6e0 13.53 2 268 .2 201.1 .737 15.82 181 3 1.5 6·0 13.53 2 273.5 201.1 .121 14.80 181 3 1.5 6·0 13.53 2 263.7 201.l .714 16.90 181 3 1.5 6e0 13.53 2 268 .6 201.1 .737 15.70 181 3 1.5 6·0 13.53 2 211.0 200.4 .129 15.17 181 3 1.5 6·0 13.53 2 260.7 200.4 ·715 17.57 181 3 1.5 6·0 13.53 2 265.9 200.4 .739 16.20 181 3 2.0 a.o 13.54 2 283 .6 201.4 .965 13.05 181 3 2.0 a.o 13.54 2 273.3 201.4 .947 14.75 181 3 2.0 0.0 13.54 2 278.5 201.4 .977 13.78 181 3 2.0 0.0 13.54 2 283.9 201.2 • 965 12.98 181 3 2.0 8.0 13.54 2 273.6 201.2 .947 14.65 181 3 2.0 0.0 13.54 2 2 78. 8 201.2 .977 13.70 181 3 2 .0 0.0 13.54 2 284.l 201 .6 .965 13 .01 181 3 2.0 0.0 13.54 2 2 73.6 201.6 .947 14.74 181 3 2.0 0.0 13.54 2 2 78 • 8 201.6 .977 13.76 181 3 2.5 10.0 11.97 2 292.4 202.l i .200 10.51 181 3 2.5 10.0 11.97 2 201 .1 202.1 1.179 11.87 181 3 2.5 10.0 11.97 2 286.8 202.1 1.216 11.09 181 3 2.5 10.0 11.97 2 293.1 202.6 1.200 10.49 181 3 2.5 10.0 11.97 2 281.8 202.6 1.110 11.05 181 3 2 .5 10.0 11.97 2 287.4 20 2 .6 1.215 11.01 181 3 2.5 10.0 11.97 2 293.7 202.5 lel99 10.41
78
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
181 3 2.5 10.0 11. 97 2 282.3 202.5 1.118 11.11 181 3 2.5 10.0 11.97 2 288.0 202.5 1.215 11.00 181 3 3.5 14·0 10.74 2 310.3 203.1 le665 7.96 181 3 3.5 14.0 10.74 2 296.4 203.l le637 9e04 181 3 3.5 14.0 10.74 2 303.4 203.1 le687 8.43 181 3 3.5 14.0 10.74 2 310.7 203.4 le664 7.95 181 3 3.5 14.0 10.74 2 296.7 203.4 le636 9.04 181 3 3.5 14.0 10.74 2 303.7 203.4 1.686 8.42 181 3 3.5 14.0 10.74 2 317.8 203.8 le658 7.49 181 3 3.5 14.0 10.74 2 297.5 203.8 1.635 9.01 181 3 3.5 14.0 10.74 2 307.7 203.8 le683 8.14 181 3 4.5 1a.o 9.13 2 323.7 202.9 2.126 6.01 181 3 4.5 18.0 9.13 2 306.3 202.9 2.094 6.94 181 3 4.5 10.0 9.13 2 315.0 202.9 2.157 6.41 181 3 4.5 1a.o 9.13 2 323.8 202.e 2.126 6.oo 181 3 4.5 1a.o 9.13 2 307.5 202.0 2.093 6.85 181 3 4.5 10.0 9.13 2 315.6 202.e 2.156 6.37 181 3 4.5 10.0 9.13 2 323.9 202.5 2.126 5.98 181 3 4.5 10.0 9.13 2 306.4 202.5 2.094 6.91 181 3 4.5 10.0 9.13 2 315.2 202.5 2;.157 6.38 181 3 5.5 22.0 8.16 2 339.l 202.4 2.500 4.76 181 3 5.5 22.0 8.16 2 319.0 202.4 2.544 5.52 181 3 5.5 22.0 8.16 2 329.o 202.4 2.618 5.00 181 3 5.5 22.0 8.16 2 338.5 202.4 2.581 4.78 181 3 5.5 22.0 8.16 2 318.5 202.4 2.545 5.53 181 3 5.5 22.0 8.16 2 328.5 202.4 2e619 5.10 181 3 5.5 22.0 0.16 2 339.1 202.1 2.579 4e77 181 3 5.5 22.0 0.16 2 319.2 202.1 2.543 5e52 181 3 5.5 22.0 e.16 2 329.2 202.1 2·618 5e09 182 3 1.0 4.0 18.86 2 255.2 199.9 e490 26.97 182 3 1.0 4.0 18.86 2 248.0 199.9 e480 30.64 182 3 1.0 4.0 18.86 2 251.6 199.9 e496 28.55 182 3 1.0 4.0 18.86 2 256.l 199.5 e490 26.34 182 3 1.0 4.0 18.86 2 248.0 199.5 .480 30.43 182 3 1.0 4.0 18.86 2 252.1 199.5 e496 28.10 182 3 1.0 4.0 18.86 2 256.9 199.5 ·489 26.00 182 3 1.0 4.0 18.86 2 248.0 199.5 e480 30.37 182 3 1.0 4.0 18.86 2 252.4 199.5 .495 21.aa 182 3 1.5 6.0 15.09 2 273.0 201.1 .120 16.63 182 3 1.5 6.0 15.09 2 263.3 201.1 .714 18.99 182 3 1.5 6e0 15.09 2 268.2 201.1 .737 17.65 182 3 1.5 6.0 15.09 2 273.5 201.1 .121 16.51 182 , 3 1.5 6.0 15.09 2 263.7 201.1 .714 18.85 182 3 1.5 6·0 15.09 2 268.6 201.1 .737 17.51 182 3 1.5 6.0 15.09 2 271.0 200.4 .729 16.92 182 3 1.5 6.0 15.09 2 260 .7 200.4 .715 19.59 182 3 1.5 6·0 15.09 2 265 .9 200 .4 e738 18.07 182 3 2.0 a.a 13.22 2 283 .6 201.4 .965 12.74 182 3 2.0 a.a 13.22 2 273.3 201.4 .947 14.40
79
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLD.S J OF . ENE GEN VER ·ocou""". TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
182 · 3 2.0 a.o .13.22 2 278.5 201~4 .977 .13.45 182 3 2.0 a.o 13.22· 2 283.9 201.2 e965 12.67 182 3 2.0 8.o 13.22 2 273 .• 6. 201 ..• 2 .947 · 14. 30 182 3 2.0 8.o 13.22 2 278.8 201.2 .977 13.37 182 3 2.0 a.o 13.22 2 284.1 201.6 .965 12.11 182 3 2.0 a.o 13.22 2 273.6 201.6 .947 1'•· 39 182 3 2.0 0.0 13.22 2 278.8 201'.6 .977 13.43 182 3 2e5 10.0 12.90 2 292.4 202.1 1.200 11.33 182 3 2.5 10.0 12.90 2 281.1 202.1 1.179 12.00 182 3 2.5 10.0 12.90 2 286.8 202.1 1.216 11.96 182 3 2.5 10.0 12.90 2 293.1 202.6 1.200 11.31 182 3 2.5 10.0 12.90 2 281.8 202.6 1.11a 12.11 182 3 2.5 10.0 12.90 2 287.4 202 •. 6 1.215 11.94 182 3 2.5 10~0 12.90 2 293.7 202.5 lel99 11.23 182 3 2.5 10.0 12.90 2 282.3 202.5 1.110 12.69 182 3 2.5 10.0 12.90 2 288.0 202.5 1.215 11.86 182 3 3.5 14.0 10.53 2 310.3 2p3.l 1.665 1.ao 182 ·3 3.5 14.0 10.53 2 296.4 203.1 1.637 8.86
. 182 3 3.5 14.0 10.53 2 303.4 203.1 le687 8.26 182 3 3.5 14.0 10.53 2 310.7 203.4 le664 7.79 182 3 3.5 14.0 10.53 2 296 •. 7 203.4 le636 8.86 182 3 3.5 14.0 10.53 2 303.7 203.4 le686 8.25 182 3 3.5 14.0 10.53 2 317.8 203.8 le658 7.34 182 3 3.5 14.0 10.53 2 297.5 203.8 le635 8.83 182 3 3.5 14·0 10.53 2 307.7 203.8 le683 7.97 182 3 4.5 10.0 0 .67 2 323.7 202.9 2.126 5.11 182 3 4.5. 18.0 8.67 2 306.3 202.9 2.094 6e59 182 3 4.5 1a.o 8.67 2 315.o 202.9 2.157 6.09 182 3 4.5 19.0 8.67 2 323.8 202.0 2.126 5.70 182 3 4.5 10.0 8.67 2 307.5 202.0 2.093 6.51 182 3 4.5 10.0 8.67 2 315.6 202.0 2el56 6.05 182 3 4.5 10.0 8e67 2 323.9 202.5 2.126 5.68 182 3 4.5 18.o 8.67 2 ·306.4 202.5 2.094 6.56 182 3 4.5 1a.o 8.67 2 315.2 202.5 2.157 6.06 182 3 5.5 22.0 7.65 2 339.1 202.4 2.590 4.46 182 3 5.5 22.0 7.65 2 319.o 202.4 2.544 5.17 182 3 5.5 22.0 7.65 2 329.0 202.4 2e618 4.77 182 3 5.5 22.0 7.65 2 338.5 202.4 2.581 4.48 182 3 5.5 22.0 7.65 2 318.5 202.4 2.545 5.19 182 3 5.5 22.0 7.65 2 328.5 202.4 2.619 4.79 182 3 5.5 22.0 7.65 2 339 .• 1 202.1 2.579 4.47 182 3 5.5 22.0 7e65 2 319.2 202.1 2.543 5.17 182 3 5 •. 5 22.0 7.65 2 329.2 202.7 2·618 4.77 183 3 1.0 4.0 19.23 2 255.2 199.9 ·490 27.49 183 3 1.0 4.0 19.23 2 240.0 199.9 .480 31.24 183 3 1 .• 0 4·0 19.23 2 251,;6 199.9 ·496 29.11 183 3 1.0 4.0 19.23 2 256.1 199.5 .490 26.86 183 3 1.0 4.0 19.23 2 248.0 199.5 e480 31.02 183 3 1.0 4.0 19.23 2 252.l 199.5 e496 28.65
80
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
183 3 1.0 4e0 19.23 2 256.9 199.5 e489 26.51 1R3 3 1.0 4.0 19.23 2 248.0 199.5 e480 30.96 183 3 1.0 4.0 19.23 2 252.4 199.5 .495 28.42 183 3 1.5 6·0 15.29 2 213.0 201.1 .128 16.85 183 3 1.5 6·0 15.29 2 263.3 201.1 .714 19.24 183 3 1.5 6·0 15.29 2 268.2 201.1 .737 17.88 . 183 3 1.5 6e0 15.29 2 273.5 201.1 .121 16.72 18 3 3 1.5 6·0 15.29 2 263.7 201.1 .714 19.10 183 3 1.5 6e0 15.29 2 268.6 201.1 .737 17.75 183 3 1.5 6e0 15.29 2 211.0 200.4 .129 17.14 183 3 1.5 6.0 15.29 2 260.7 200.4 .115 19.85 183 3 1.5 6.0 15.29 2 265.9 200.4 .738 18.31 183 3 2.0 8.o 13.39 2 283.6 201.4 ·965 12.91 183 3 2.0 0.0 13.39 2 273.3 201.4 .947 14.59 183 3 2.0 8.o 13.39 2 278.5 201.4 .977 13.63 183 3 2.0 0.0 13.39 2 283.9 201.2 • 965 12.84 183 3 2.0 8.o 13.39 2 273.6 201.2 .947 14.49 183 3 2.0 8.o 13.39 2 278.8 201.2 .977 13.55 183 3 2.0 8.o 13.39 2 284.l 201.6 .965 12.88 183 3 2.0 8.o 13.39 2 273.6 201.6 .947 14.58 183 3 2.0 8.o 13.39 2 278.8 201.6 .977 13.61 183 3 2.5 10.0 12.25 2 292.4 202.1 1.200 10.75 183 3 2.5 10.0 12.25 2 281.1 202.1 1.179 12.15 183 3 2.5 10.0 12.25 2 286.8 202.1 1. 216 11.35 183 3 2.5 10.0 12.25 2 293.l 202.6 1.200 10.74 183 3 2.5 10.0 12.25 2 281.8 202.6 1.118 12.12 183 3 2.5 10.0 12.25 2 287.4 202.6 1.215 11. 33 183 3 2.5 10.0 12.25 2 293.7 202.5 1.199 10.66 183 3 2.5 10.0 12.25 2 282.3 202.5 1.178 12.04 183 3 2.5 10.0 12.25 2 288.o 202.5 1.215 11.25 183 3 3.5 14.0 9.48 2 310.3 203.l le665 1.02 183 3 3.5 14.0 9.48 2 296.4 203.l le637 7.97 183 3 3.5 14.0 9.48 2 303.4 203.l le687 7.43 183 3 3.5 14.0 9.48 2 310.7 203.4 1.664 1.01 183 3 3.5 14.0 9.48 2 296.7 203.4 1.636 7.97 183 3 3.5 14.0 9.48 2 303.7 203.4 le686 7.42 183 3 3.5 14.0 9.48 2 317. 8 203.8 1.658 6.60 183 3 3.5 14.0 9.48 2 297.5 203.8 1.635 7.95 183 3 3.5 14.0 9.48 2 307.7 203.8 le683 1.11 183 3 4.5 18.o 8.92 2 323.7 202.9 2.126 5.87 183 3 4.5 18·0 8.92 2 306.3 202.9 2·094 6.78 183 3 4.5 10.0 8.92 2 315.0 202.9 2.157 6.27 183 3 4.5 18.0 8.92 2 323.8 202.a 2.126 5.87 183 3 4.5 18.0 8.92 2 307.5 202.0 2.093 6e70 183 3 4.5 18.o 8.92 2 315.6 202.8 2.156 6.22 183 3 4.5 10.0 8.92 2 323.9 202.5 2.126 5.85 183 3 4.5 18.0 8.92 2 306.4 202.5 2.094 6.75 183 3 4.5 10.0 8.92 2 315.2 202.5 2.157 6.24 183 3 5.5 22.0 7.68 2 339.l 202.4 2e580 4e47
81
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
183 3 5.5 22.0 7.68 2 319.0 202.4 2.544 5el9 183 3 5.5 22.0 7.68 2 329.o 202.4 2e618 4e78 183 3 5.5 22.0 7.68 2 338.5 202.4 2.5a1 4.49 18J 3 5.5 22.0 7.68 2 318.5 202.4 2.545 5.20 183 3 5.5 22.0 7.68 2 328.5 202.4 2.619 4.80 183 3 5.5 22.0 7.68 2 339.l 202.1 2.579 4.48 183 3 5.5 22.0 7.68 2 319.2 202.1 2.543 5.19 183 3 5.5 22.0 7.68 2 329.2 202.1 2·618 4.79 184 3 1.0 4.0 19.24 2 255.2 199.9 .490 27.51 184 3 1.0 4.0 19.24 2 248.o 199.9 e480 31.26 184 3 1.0 4.0 19.24 2 251.6 199.9 e496 29.13 184 3 1.0 4.0 19.24 2 256.l 199.5 e490 26.88 184 3 1.0 4.0 19.24 2 248.o 199.5 ·480 31.04 184 3 1.0 4.0 19.24 2 252.l 199.5 ·496 28.67 184 3 1.0 4.0 19.24 2 256.9 199.5 .489 26.53 184 3 1.0 4.0 19.24 2 240.0 199.5 ·480 30.98 184 3 1.0 4.0 19.24 2 252.4 199.5 .495 28.44 184 3 1.5 6.0 15.55 2 273.0 201.1 .728 17.13 184 3 1 .5 6·0 15.55 2 263.3 201.1 .714 19.57 184 3 1.5 6·0 15.55 2 268.2 201.1 .737 18.18 184 3 1.5 6e0 15.55 2 273.5 201.1 .121 17.00 184 3 1.5 6e0 15.55 2 263.7 201.1 .714 19.42 184 3 1.5 6·0 15.55 2 268.6 201.1 .737 18.04 184 3 1.5 6·0 15.55 2 211.0 200.4 .729 17.43 184 3 1.5 6·0 15.55 2 260,7 200.4 .715 20.18 184 3 1.5 6·0 15.55 2 265.9 200. 1+ .738 18.61 184 3 2.0 0.0 13.39 2 283.6 201 .4 e965 12.90 184 3 2.0 0.0 13.39 2 273.3 201.4 .947 14.58 184 3 2.0 0.0 13.39 2 278.5 201 .4 .977 13.62 184 3 2.0 0.0 13.39 2 283.9 201.2 ·965 12.83 184 3 2.0 a.o 13.39 2 273.6 201.2 .947 14.48 184 3 2 .0 a.o 13.39 2 278.8 201.2 .977 13.54 184 3 2.0 0.0 13.39 2 284 .1 201.6 .965 12.87 184 3 2 .0 0.0 13.39 2 273.6 201.6 .947 14.57 184 3 2.0 0.0 13.39 2 278 .8 201.6 .977 13.60 184 3 2.5 10.0 12.34 2 292 .4 202 .1 1 .200 10.83 184 . 3 2.5 10.0 12.34 2 281.l 202.1 1.179 12.24 184 3 2.5 10.0 12.34 2 286.8 202.1 1.216 11.44 184 3 2.5 10.0 12.34 2 293 .1 202 .6 1.200 10.01 184 3 2.5 10.0 12.34 2 281.8 202 .6 1 .178 12.21 184 3 2 .5 10.0 12.34 2 287 .4 202 .6 1.215 11 .42 184 3 2.5 10.0 12.34 2 293.7 202.5 1.199 10.74 184 3 2.5 10.0 12.34 2 282.3 202 .5 1.110 12.13 184 3 2.5 10 .0 12.34 2 288.0 202.5 1.215 11.34 184 3 4.5 18.0 8.84 2 323.7 202.9 2 .126 5.82 184 3 4.5 18.0 8.84 2 306 . 3 202.9 2 .094 6.72 184 3 4.5 18.0 8.84 2 315 . o 202 .9 2.157 6.21 184 3 4.5 1a.o 8.84 2 323 .8 202.0 2 .126 5 .81 184 3 4.5 1a.o 8.84 2 307.5 202.a 2.093 6.63
82
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j
OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
184 3 4.5 18.0 8.84 2 315.6 202.8 2el56 6el6 184 3 4.5 10.0 8e84 2 323.9 202.5 2el26 5.79 184 3 4.5 10.0 8.84 2 306.4 202.5 2e094 6e69 18+ 3 4.5 10.0 0.04 2 315.2 202.5 2.157 6.18 184 3 5.5 22.0 7.98 2 339.1 202.4 2.580 4.65 184 3 5.5 22.0 7.98 2 319.0 202.4 2 • 544 . 5.40 184 3 5.5 22.0 7.98 2 329.0 202.4 2e618 4.97 184 3 5.5 22.0 7.98 2 338.5 202.4 2·581 4.67 184 3 5.5 22.0 7e98 2 318.5 202.4 2.545 5.41 184 3 5.5 22.0 7.98 2 328.5 202.4 2.619 4.99 184 3 5.5 22.0 7.98 2 339.1 202.1 2.579 4.66 184 3 5.5 22.0 7e98 2 319·. 2 202.1 2.543 5e40 184 3 5.5 22.0 7.98 2 329.2 202.1
. 2.618 4.98
185 3 1.0 4.0 19.06 2 255.2 199.9 e490 27.25 185 3 1.0 4.0 19.06 2 248.0 199.9 ·480 . 30.96 185 3 1.0 4.0 19.06 2 251.6 199.9 .496 28.85 185 3 1.0 4.0 19.06 2 256.1 199.5 .490 26.62 185 3 1.0 4e0 19.06 2 248.0 199.5 ·480 30.75 185 3 1.0 4.0 19.06 2 252.1 199.~ e496 28.40 185 3 1.0 4.0 19.06 2 256.9 199.5 ·489 26.28 185 3 1.0 4.0 19.06 2 248.0 199.5 ·480 30.69 185 3 1.0 4.0 19.06 2 252.4 199.5 .495 28.17 185 3 1.5 6·0 14.86 2 213.0 201.1 .128 16.38 185 3 1.5 6·0 14.86 2 263.3 201.1 ·714 18.71 185 3 1.5 6·0 14.86 2 268.2 201.1 .737 17.38 185 3 1.5 6·0 14.86 2 273.5 201.l .121 16.26 185 3 1.5 6.0 14.86 2 263.7 201.1 .714 18.57 185 3 1.5 6e0 14.86 2 268.6 201.1 .737 17.25 185 3 1.5 6.0 14.86 2 271.0 200.4 .729 16.66 185 3 1.5 6e0 1°4. 86 2 260.7 200.4 .715 19.30 185 3 1.5 6.0 14.86 2 265.9 200.4 .738 17.80 185 3 2.0 0.0 13.38 2 283.6 201.4 .965 12.90 185 3 2.0 0.0 13.38 2 273.3 201.4 .947 14.58 185 3 2.0 0.0 13.38 2 278. 5 201.4 .977 13.62 185 3 2.0 0.0 13.38 2 283.9 201.2 .965 12.83 185 3 2.0 0.0 13.38 2 273.6 201.2 .947 14.48 185 3 2.0 0.0 13.38 2 278.8 201.2 .977 13.54 185 3 2.0 0.0 13.38 2 284.1 201.6 ·965 12.87 185 ·3 2.0 0.0 13.38 2 273.6 201.6 .947 14.57 185 3 2.0 0.0 13.38 2 278.8 201.6 .977 13 •. 60 185 3 2.5 10.0 12.34 2 292.4 202.1 ·l • 200 10.83 185 3 2.5 10.0 12.34 2 281.l 202.1 1.179 12.24 185 3 2.5 10.0 12.34 2 286.8 202.1 1.216 11.44 185 3 2.5 10.0 12.34 2 293.1 202.6 1.200 10.81 185 3 2.5 10.0 12.34 2 281.8 202.6 lel78 12.21 185 3 2.5 10.0 12.34 2 287.4 202.6 1.215 11.42 185 3 2.5 10.0 12.34 2 293.7 202.5 1.199 10.74 185 3 2.5 10.0 12.34 2 282.3 202.5 1·178 12.13 185 3 2 .• 5 10.0 12.34 2 288.o 202.5 1.215 11.34
83
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
185 3 3.5 14.0 10.29 2 310.3 203.l le665 7.62 185 3 3.5 14.0 10.29 2 296.4 203.1 le637 8e66 185 3 3.5 14.0 10.29 2 303.4 203.l le687 8.01 185 3 3.5 14.0 10.29 2 310.7 203.4 le664 7.61 185 3 3.5 14·0 10.29 2 296.7 203.4 1.636 8.66 185 3 3.5 l4e0 10.29 2 303.7 203.4 le686 8.06 185 3 3.5 14·0 10.29 2 317.8 203.8 le658 1.11 185 3 3.5 14·0 10.29 2 297.5 203.8 le635 8.63 185 3 3.5 14.0 10.29 2 307.7 203.8 le683 7.79 185 3 4.5 18.0 8.89 2 323.7 202.9 2.126 5.85 185 3 4.5 10.0 a.09 2 306.3 202.9 2.094 6.76 185 3 4.5 1a.o 8.89 2 315.o 202.9 2.157 6.24 185 3 4.5 10.0 . 8 .89 2 323.8 202.0 2.126 5.84 185 3 4.5 10.0 8.89 2 307.5 202.0 2.093 6.67 185 3 4.5 10.0 8.89 2 315.6 202 • 8 . 2el56 6e20 185 3 4.5 1a.o a.89 2 323.9 202.5 2.126 5.82 185 3 4.5 10.0 8.89 2 306.4 202.5 2.094 6.73 185 3 4.5 1a.o 8.89 2 315.2 202.5 2.157 6.21 185 3 5.5 22.0 7.87 2 339.1 202.4 2.500 4.59 185 3 5.5 22.0 7.87 2 319.0 202.4 2.544 5.32 185 3 5.5 22.0 7.87 2 329.o 202.4 2e618 4.90 185 3 5.5 22.0 1.a1 2 338.5 202.4 2.501 4.61 185 3 5.5 22.0 1.a1 2 318.5 202.4 2.545 5.33 185 3 5.5 22.0 7.87 2 328.5 202.4 2.619 4.92 185 3 5.5 22.0 7.87 2 339.1 202.1 2.579 4.60 185 3 5.5 22.0 7.87 2 319.2 202.1 2.543 5.32 185 3 5.5 22.0 1.81 2 329.2 202.1 2.618 4.91 191 3 1.0 4e0 17.28 2 204.9 147.3 ·518 23.97 191 3 1.0 4.0 17.28 2 195.4 147.3 ·509 28.35 191 3 1.0 4.0 17.28 2 200.2 147.3 .525 25.85 191 3 1.0 4.0 17.26 2 203.6 147.2 .519 24.47 191 3 1.0 4.0 17.26 2 194.3 147.2 e509 28.95 191 3 1.0 4e0 17.26 2 199.o 147.2 .525 26.39 191 3 1.0 4.0 17.26 2 203.8 147.5 .519 24.50 191 3 1.0 4.0 17.26 2 194.5 147.5 ·509 29.05 191 3 1.0 4.0 17.26 2 199.1 147.5 .525 26.45 191 3 1.0 4.0 17.26 2 204.4 147.8 .518 24.40 191 3 1.0 4.0 17.26 2 195.2 147.8 e509 28.81 191 3 1.0 4.0 17.26 2 199.8 147.8 .525 26.29 191 3 1.5 6e0 13.87 2 217.3 147.3 .112 15.87 191 3 1.5 6·0 13.87 2 207.6 147.3 .759 18.23 191 3 1.5 6·0 13.87 2 212.4 147.3 .182 16.88 191 3 1.5 6e0 13.87 2 217.3 147.4 .112 15.87 191 3 1.5 6·0 13.87 2 207.6 147.4 e758 18.24 191 3 1.5 6.0 13.87 2 212.4 147.4 .192 16.89 191 3 1.5 6e0 13.87 2 217.5 147.6 .112 15.88 191 3 1.5 6e0 13.87 2 201.1 147.6 .758 18.26 191 3 1.5 6e0 13.87 2 212.6 147.6 .182 16.90 191 3 1.5 6e0 13.87 2 217.7 147.7 .112 15.85
84
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
191 3 1.5 6·0 13.87 2 208.0 147.7 .758 18.19 191 3 1.5 6·0 13.87 2 212.9 147.7 .1a2 16.86 191 3 2.0 8.o 12.20 2 227.4 146.9 1.024 12.15 191 3 2.0 a.o 12.20 2 217.3 146.9 1.006 13.74 191 3 2.0 a.o 12.20 2 222.4 146.9 1.037 12.84 191 3 2.0 8.o 12.20 2 226.8 146.2 1.025 12.14 191 3 2.0 a.o 12.20 2 216.3 146.2 1.007 13.80 191 3 2.0 8.o 12.20 2 221.6 146.2 1.038 12.85 191 3 2.0 a.o 12.20 2 226.3 145.5 1.026 12.11 191 3 2.0 a.o 12.20 2 215.7 145.5 1.001 13. 78 191 3 2.0 a.o 12.20 2 221.0 145.5 1.039 12.83 191 3 2.0 a.o 12.20 2 225.7 145.4 1.026 12.19 191 3 2.0 8.0 12.20 2 215.1 145.4 1.008 13.88 191 3 2.0 8.o 12.20 2 220.4 145.4 1.039 12.92 191 3 2.5 10.0 11.17 2 236.3 146.2 1.275 9.96 191 3 2.5 10.0 11.17 2 224.6 146.2 1.253 11.30 191 3 2.5 10.0 11.17 2 230.4 146.2 1.291 10.54 191 3 2.5 10.0 N . • 17 2 236.4 146.1 1.275 9.93 191 3 2.5 10.0 11.11 2 224.6 146.l 1.253 11.30 191 3 2.5 10.0 11.17 2 230.5 146.l 1.291 10.52 191 3 2.5 10.0 11.11 2 236.4 146.2 1.275 9.94 191 3 2.5 10.0 11.11 2 224.5 146.2 1.253 11. 31 191 3 2.5 10.0 11.11 2 230.5 146.2 1.291 10.53 191 3 2.5 10.0 11.17 2 236.3 146.0 1.275 9.93 191 3 2.5 10.0 11.11 2 224.6 146.0 1.253 11.21 191 3 2.5 10.0 11.17 2 230.4 146.0 1.292 10.51 191 3 3.5 14.0 9.50 2 254.0 146.5 1.767 1.10 191 3 3.5 14.0 9.50 2 239.l 146.5 1.739 8.15 191 3 3.5 14.0 9.50 2 246.6 146.5 1.792 7.55 191 3 3.5 14.0 9.50 2 254.9 146.5 1.766 1.05 191 3 3.5 14.0 9.50 2 239.7 146.5 1.739 8.10 191 3 3.5 14.0 9.50 2 247.3 146.5 1.791 7.50 191 3 3.5 14·0 9.50 2 254.5 146.4 1.766 7.06 191 3 3.5 14.0 9.50 2 239.4 146.4 1.739 8.12 191 3 3.5 14.0 9.50 2 246.9 146.4 1.191 7.52 191 3 3.5 14.0 9.50 2 253.5 146.2 1.768 1.12 191 3 3.5 14.0 9.50 2 238.5 146.2 1.740 a.1a 191 3 3.5 14.0 9.50 2 246.0 146.2 1.792 7.57 191 3 4.5 18.o 8.64 2 268.l 146,7 2.254 5.73 191 3 4.5 18.0 8.64 2 250.6 146.7 2.222 6.61 191 3 4.5 1a.o 8.64 2 259.4 146.7 2.2a1 6.11 191 3 4.5 1a.o 8.64 2 267.7 146.6 2.255 5.74 191 3 4.5 1a.o a.64 2 250.2 146.6 2.222 6.64 191 3 4.5 18.o 8.64 2 258.9 146.6 2.2aa 6.13 191 3 4.5 1a.o 8.64 2 267.9 146.4 2.255 5.12 191 3 4.5 1a.o 8.64 2 250.4 146.4 2.222 6.61 191 3 4.5 18.0 8.64 2 259.2 146.4 2.2a8 6.11 191 3 4.5 18 .o a.64 2 267.9 146.3 2.255 5.72 191 3 4.5 1a.o a.64 2 250.6 146.3 2.222 6.59
8 5
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CCI.SC CC/SC SION PLE F F
191 3 4.5 1e.o 8.64 2 259.3 146.3 2.2ee 6.09 191 3 5.5 22.0 7.79 2 282.8 146.6 2.733 4.61 191 3 5.5 22.0 7.79 2 262.e9 146.6 2.698 5.33 191 3 5.5 22.0 7.79 2 212.a 146.6 2.775 4.92 191 3 5.5 22.0 1.19 2 283.0 146.5 2.733 4.60 191 3 5.5 22.0 7.79 2 262.7 146.5 2e698 5.34 191 3 5.5 22.0 7e79 2 212.9 14t5'.5 2.775 4.92 191 3 5.5 22.0 7.79 2 283.7 146.6 2.732 4e58 191 3 5.5 22.0 1.19 2 263.3 146.6 2e697 5.32 191 3 5.5 22.0 7.79 2 273~5 146.6 2.774 4e90 191 3 5.5 22.0 1.19 2 282.9 146.6 2.733 4e61 191 3 5.5 22.0 7.79 2 263.1 146.6 2e697 5.33 191 3 5.5 22.0 1.19 2 213.0 146.6 2.775 4e92 192 3 1.0 4.0 17.20 2 204.9 147.3 .518 23.85 192 3 1.0 4.0 11.20 2 195.4 147.3 e509 20.22 192 3 1.0 4.0 11.20 2 200.2 147.3 .525 25.72 192 3 1.0 4.0 11.20 2 203.6 147.2 .519 24.38 192 3 1.0 4.0 17.20 2 194.3 147.2 .509 28.84 192 3 1.0 4.0 11.20 2 199.o 147.2 .525 26.29 192 3 1.0 4.0 11.20 2 203.8 147.5 e519 24.41 192 3 1.0 4.0 11.20 2 194.5 147.5 ·509 28.95 192 3 1.0 4.0 11.20 2 199.l 147.5 .525 26.35 192 3 1.0 4.0 17.20 2 204.4 147.8 .518 24.31 192 3 1.0 4.0 11.20 2 195.2 147.8 ·509 28.71 192 3 1.0 4.0 17.20· 2 199.8 147.8 .525 26.20 192 3 1.5 6·0 14.30 2 217.3 147.3 .112 16. 3 7 192 3 1.5 6e0 14.30 2 207.6 147.3 e758 18.80 192 3 1.5 6e0 14.30 2 212.4 147.3 .782 17.41 192 3 1.5 6.0 14.30 2 217.3 147.4 .112 16.37 192 3 1.5 6e0 14.30 2 207.6 147.4 .758 18.81 192 3 1.5 6·0 14.30 2 212.4 147.4 .782 17.42 192 3 1.5 6e0 14.30 2 217.5 147.6 .112 16.38 192 3 1.5 6.0 14.30 2 201.1 147.6 e758 18.84 192 3 1.5 6·0 14.30 2 212.6 147.6 .1a2 17.43 192 3 1.5 6.0 14.30 2 211.1 147.7 • 772 16.35 192 3 1.5 6.0 14.30 2 2oa .• o 147.7 .758 18.76 192 3 1.5 6.0 14.30 2 212.9 147.7 e782 17.39 192 3 2.0 a.o 12.25 2 227.4 146.9 1.024 12.20 192 3 2.0 0.0 12.25 2 217.3 146.9 1.006 13.80 192 3 2.0 a.o 12.25 2 222.4 146.9 le037 12.89 192 3 2.0 a.o 12.25 2 226.8 146.2 1.025 12.19 192 3 2.0 8.0 12.25 2 216.3 146.2 1.001 13.86 192 3 2.0 8.o 12.25 2 221.6 146.2 le038 12.91 192 3 2.0 a.o i2.2s 2 226.3 145.5 1.026 12.16 192 3 2.0 0.0 12.25 2 215.7 145.5 1.001 13.84 192 3 2.0 0.0 12.25 2 221.0 145.5 le039 12.88 192 3 2.0 8.0 12.25 2 225.7 145.4 1.026 12.24 192 3 2.0 a.a 12.25 2 215.l 145.4 1.ooe 13.94 192 3 2.0 8.0 12.25 2 220.4 145.4 le039 12.97
86
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
192 3 2.5 10.0 10.81 2 236.3 146.2 1.275 9.63 192 3 2.5 10.0 10.81 2 224.6 146.2 1.253 10.94 192 3 2.5 10.0 10.81 2 230.4 146.2 1.291 10.19 192 3 2.5 10.0 10.81 2 236.4 146.1 1.275 9e60 192 3 2.5 10.0 10.81 2 224.6 146.l 1.253 10.93 192 3 2.5 10.0 10.81 2 230.5 146.l 1.291 10.11 192 3 2.5 10.0 10.01 2 236.4 146.2 1.275 9.61 192 3 2.5 10.0 10.01 2 224.5 146.2 1.253 10.94 192 3 2.5 10.0 10.81 2 230.5 146.2 1.291 10.18 192 3 2.5 10.0 10.81 2 236.3 146.0 1.275 9e60 192 3 2.5 10.0 10.81 2 224.6 146.0 1.253 10.91 192 3 2.5 10.0 10.81 2 230.4 146.0 1.292 10.16 192 3 3.5 14.0 9.68 2 254.0 146.5 1.767 7.23 192 3 3.5 14.0 9.68 2 239.1 146.5 1.739 8.31 192 3 3.5 14.0 9.68 2 246.6 146.5 1.792 1.10 192 3 3.5 14.0 9.68 2 254.9 146.5 le766 1.18 192 3 3.5 14·0 9.68 2 239.7 146.5 1.739 8.26 192 3 3.5 14.0 9.68 2 247.3 146.5 le79l 7.64 192 3 3.5 14.0 9.68 2 254.5 146.4 le766 1.20 192 3 3.5 14.0 9.68 2 239.4 · 146.4 1.739 a.28 192 3 3.5 14.0 9.68 2 246.9 146.4 1.191 7.66 192 3 3.5 14.0 9.68 2 253.5 146.2 1.768 7.25 192 3 3.5 14.0 9.68 2 238.5 146.2 le740 a.34 192 3 3.5 14.0 9.68 2 246.0 146.2 1.792 1.12 192 3 4.5 1a.o 8.14 2 268.1 146.7 2.254 5.39 192 3 4.5 1a.o 0.14 2 250.6 146.7 2 .222 6.23 192 3 4.5 18.0 0.14 2 259.4 146.7 2e287 5.75 192 3 4.5 1a.o 0.14 2 267.7 146.6 2.255 5.41 192 3 4.5 10.0 8.14 2 250.2 146.6 2.222 6.25 192 3 4.5 18.0 8.14 2 258.9 146.6 2.2aa 5.77 192 3 4.5 1a.o 8 .14 2 267.9 146.4 2.255 5.39 192 3 4.5 1a.o 8.14 2 250.4 146.4 2.222 6.23 192 3 4.5 1a.o a.14 2 259.2 146.4 2.28a 5.75 192 3 4.5 1a.o 0.14 2 267.9 146.3 2.255 5.39 192 3 4.5 18.0 8.14 2 250.6 146.3 2.222 6.21 192 3 4.5 10.0 0.14 2 259.3 146.3 2.2a0 5.74 192 3 5.5 22.0 8.56 2 282.8 146.6 2.733 5.06 192 3 5.5 22.0 a.56 2 262.9 146.6 2e698 5.86 192 3 5.5 22.0 0.56 2 212.0 146.6 2.775 5.41 192 3 5.5 22.0 a.56 2 283.o 146.5 2.733 5.05 192 3 5.5 22.0 8.56 2 262.7 146.5 2.698 5.87 192 3 5.5 22.0 0.56 2 212.9 146.5 2.775 5.40 192 3 5.5 22.0 8.56 2 283.7 146.6 2.732 5.03 192 3 5.5 22.0 0.56 2 263.3 146.6 2.697 5.85 192 3 5.5 22.0 8.56 2 273.5 146.6 2.774 5.38 192 3 5.5 22.0 8.56 2 282.9 146.6 2.733 5.06 192 3 5.5 22.0 8.56 2 263.l 146.6 2e697 5.85 192 3 5.5 22.0 a.56 2 213.0 146.6 2.775 5 .40 193 3 1.0 4.0 17.34 2 204.9 147.3 .518 24.06
87
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
193 3 1.0 4.0 17.34 2 195.4 147.3 .509 28.46 193 3 1.0 4.0 17.34 2 200.2 147.3 .525 25.95 193 3 1.0 4.0 17.34 2 203.6 147.2 .519 24.59 19: 3 1.0 4.0 17.34 2 194.3 147.2 e509 29.09 193 3 1.0 4.0 17.34 2 199.o 147.2 .525 26.52 193 3 1.0 4.0 17.34 2 203.8 147.5 .519 24.62 193 3 1.0 4.0 17.34 2 194.5 147.5 .509 29.20 193 3 1.0 4.0 17.34 2 199.l 147.5 .525 26.58 193 3 1.0 4.0 17.34 2 204.4 147.8 .518 24.52 193 3 1.0 4.0 17.34 2 195.2 147.8 e509 28.95 193 3 1.0 4.0 17.34 2 199.8 147.8 .525 26.42 193 3 1.5 6e0 14.17 2 217.3 147.3 .112 16.21 193 3. 1.5 6e0 14.17 2 207.6 147.3 e758 18.62 193 3 1.5 6.0 14.17 2 212.4 147.3 .782 17.25 193 3 1.5 6e0 14.17 2 217.3 147.4 .112 16.22 193 3 1.5 6e0 14.17 2 207.6 147.4 e758 18.63 193 3 1.5 6.0 14.17 2 212.4 147.4 .782 17.26 193 3 1.5 6·0 14.17 2 217.5 147.6 .112 16.22 193 3 1.5 6e0 14.17 2 201.1 147.6 .758 18.66 193 3 1.5 6·0 14.17 2 212.6 147.6 .782 17.27 193 3 1.5 6e0 14.17 2 217.7 147.7 .112 16.20 193 3 1.5 6e0 14.17 2 208.0 147.7 .758 18.59 193 3 1.5 6e0 14.17 2 212.9 147.7 .782 17.23 193 3 2.0 0.0 12.51 2 227.4 146.9 le024 12.45 193 3 2.0 0.0 12.51 2 217.3 146.9 1.006 14.08 193 3 2.0 0.0 12.51 2 222.4 146.9 1.037 13.15 193 3 2.0 0.0 12.51 2 226.8 146.2 1.025 12.44 193 3 2.0 a.o 12.51 2 216.3 146.2 1.001 14.14 193 3 2.0 0.0 12.51 2 221.6 146.2 le038 13.17 193 3 2.0 0.0 12.51 2 226.3 145.5 1.026 12.41 193 3 2.0 a.o 12.51 2 215.7 145.5 1.001 14.12 193 3 2.0 0.0 12.51 2 221.0 145.5 le039 13.14 193 3 2.0 0.0 12.51 2 225.7 145.4 1.026 12.49 193 3 2.0 0.0 12.51 2 215.1 145.4 1.000 14.23 193 3 2.0 a.o 12.51 2 220.4 145.4 le039 13.24 193 3 2.5 10.0 10.98 2 236.3 146.2 1.275 9.79 193 3 2.5 10.0 10.98 2 224.6 146.2 1.253 11.11 193 3 2.5 10.0 10.98 2 230.4 146.2 1.291 10.35 193 3 2.5 10.0 10.98 2 236.4 146.l 1.275 9.76 193 3 2.5 10.0 10.98 2 224.6 146.l 1.253 11.10 193 3 2.5 10.0 10.98 2 230.5 146.l 1.291 10 .33 193 3 2.5 10.0 10.98 2 236.4 146.2 1.275 9.76 193 3 2.5 10.0 10.98 2 224.5 146.2 1.253 11.11 193 3 2.5 10.0 10.98 2 230.5 146.2 1.291 10.34 193 3 2.5 10.0 10.98 2 236.3 146.0 1.275 9.76 193 3 2.5 10.0 10.98 2 224.6 146.0 1.253 11.00 193 3 2.5 10.0 10.98 2 230.4 146.0 1.292 10. 3 3 193 3 3.5 14.0 9.35 2 254.0 146.5 le767 6.99 193 3 3.5 14.0 9.35 2 239.1 146.5 1.739 8.03
88
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
193 3 3.5 14.0 9.35 2 246.6 146.5 le792 7e44 193 3 3.5 14.0 9.35 2 254.9 146.5 le766 6e94 193 3 3.5 14.0 9.35 2 239.7 146.5 1.739 7.98 193 3 3.5 14.0 9.35 2 247.3 146.5 le791 7.39 193 3 3.5 14.,0 9.35 2 254.5 146.4 1.766 6.96 193 3 3.5 14.0 9.35 2 239.4 146.4 1.739 8.oo 193 3 3.5 14.0 9.35 2 246.9 146.4 le791 7.40 193 3 3.5 14.0 9.35 2 253.5 146.2 le768 1.01 193 3 3.5 l4e0 9.35 2 238.5 146.2 le740 8.05 193 3 3.5 14.0 9.35 2 246.o 146.2 1.792 · 7.46 193 3 4.5 18.0 8.39 2 268.1 146.7 2.254 5.56 193 3 4.5 18.0 8.39 2 250.6 146.7 2 • 2·22 6.42 193 3 4.5 18.o 8.39 2 259.4 146.7 2.281 5.93 193 3 4.5 18.0 8.39 2 267.7 146.6 2.255 5.58 193 3 4.5 18.0 8.39 2 250.2 146. 6. 2.222 6.44 193 3 4.5 18.0 8.39 2 258.9 146.6 2.288 5.95 193 3 4.5 18.0 8e39 2 267.9 146.4 2.255 5.56 193 3 4.5 18.0 8.39 2 250.4 146.4 2.222 6.42 193 3 4.5 1a.o 0.39 2 259.2 146.4 2.288 5.93 193 3 4.5 18.0 8.39 2 267.9 146.3 2.255 5.55 193 3 4.5 10.0 a.39 2 250.6 146.3 2.222 6.40 193 3 4.5 18.o 8.39 2 259.3 146.3 2 .288 5.92 193 3 5.5 22.0 7.73 2 282.8 146.6 2.733 4.58 193 3 5.5 22.0 7.73 2 262.9 146.6 2.698 5.30 193 3 5.5 22.0 7.73 2 272.8 146.6 2.775 4.89 193 3 5.5 22.0 7.73 2 283.o 146.5 2.733 4.57 193 3 5.5 22.0 7.73 2 262.7 146.5 2.698 5.30 193 3 5.5 22.0 7.73 2 272.9 146.5 2.775 4.88 193 3 5.5 22.0 7.73 2 283.7 146.6 2.732 4.55 193 3 5.5 22.0 7.73 2 263.3 146.6 2e697 5.28 193 3 5.5 22.0 1.13 2 273.5 146.6 2.774 4.86 193 3 5.5 22.0 7.73 2 282.9 146.6 2.733 4.58 193 3 5.5 22.0 7.73 2 263.1 146.6 2.697 5.29 193 3 5.5 22.0 7.73 2 273.0 146.6 2.775 4.88 194 3 1.5 6·0 13.78 2 217.3 147.3 .112 15.77 194 3 1.5 6e0 13.78 2 207.6 147.3 .759 18.11 194 3 1.5 6e0 13.78 2 212.4 147.3 .102 16.78 194 3 1.5 6e0 13.78 2 217.3 147.4 .112 15.77 194 3 1.5 6e0 13.78 2 207.6 147.4 .15a 18.12 194 3 1.5 6.0 13.78 2 212.4 147.4 .1a2 16.78 194 3 1.5 6.0 13.78 2 217.5 147.6 .112 15.78 194 3 1.5 6.0 13.78 2 201.1 147.6 .758 18.14 194 3 1.5 6e0 13.78 2 212.6 147.6 ·182 16.80 194 3 1.5 6·0 13.78 2 211.1 147.7 .112 15.75 194 3 1.5 6·0 13.78 2 208.0 147.7 .758 18.08 194 3 1.5 6·0 13.78 2 212.9 147.7 .102 16.75 194 3 2 .0 a.o 10.97 2 227.4 146.9 1.024 10.92 194 3 2 .0 a.a 10.97 2 217.3 146.9 1 ·006 12.35 194 3 2.0 a.o 10.97 2 222.4 146.9 1 .037 11. 54
89
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
194 3 2.0 8.o 10.97 2 226.8 146.2 1.025 10.91 194 3 2.0 8.o 10.97 2 216.3 146.2 1.001 12.40 194 3 2.0 8.o 10.97 2 221.6 146.2 le038 11. 55 194 3 2.0 8.o 10.97 2 226.3 145.5 1.026 10.88 194 3 2.0 8.o 10.97 2 215.7 145.5 1.001 12.39 194 3 2.0 a.o 10.97 2 221.0 145.5 1.039 11.53 194 3 2.0 a.a 10.97 2 225.7 145.4 1.026 10.95 194 3 2.0 8.o 10.97 2 215.1 145.4 1.008 12.48 194 3 2.0 8.o 10.97 2 220.4 145.4 le039 11.61 194 3 2.5 10.0 11.44 2 236.3 146.2 1.275 10.20 194 3 2.5 10.0 11.44 2 224.6 146.2 1.253 11. 58 194 3 2.5 10.0 11.44 2 230 .4 146.2 1.291 10.79 194 3 2.5 10.0 11.44 2 236.4 146.1 1.275 10.17 194 3 2.5 10.0 11.44 2 224.6 146.l 1.253 11. 57 194 3 2.5 10.0 11.44 2 230.5 146.1 1.291 10.11 194 3 2.5 10.0 11.44 2 236.4 146.2 1.275 10.18 194 3 2.5 10.0 11.44 2 224.5 146.2 1.253 11.58 194 3 2.5 10.0 11.44 2 230.5 146.2 1.291 10.78 194 3 2.5 10.0 11.44 2 236.3 146.0 1.275 10.11 194 3 2.5 10.0 11.44 2 224.6 146.0 1.253 11. 55 194 3 2.5 10.0 11.44 2 230.4 146.0 1.292 10.76 194 3 3.5 14.0 9.73 2 254.o 146.5 1.767 1.21 194 3 3.5 l4e0 9.73 2 239.1 146.5 1.739 8.35 194 3 3_. 5 14.0 9.73 2 246.6 146.5 1.792 1.14 194 3 3.5 14.0 9.73 2 254.9 146.5 1.766 1.22 194 3 ~.5 14.0 9.73 2 239.7 146.5 1.739 8.30 194 3 3.5 14.0 9.73 2 247.3 146.5 1.191 7.69 194 3 3.5 14.0 9.73 2 254.5 146.4 le766 1.24 194 3 3.5 14·0 9.73 2 239.4 146.4 1.739 8.32 194 3 3.5 l4e0 9.73 2 246.9 146 • . 4 1.191 1.10 194 3 3.5 14·0 9.73 2 253.5 146.2 le768 1.29 194 3 3.5 14.0 9.73 2 238.5 146.2 1.140 8.38 194 3 3.5 14.0 9.73 2 246.o 146.2 1.792 7.76 194 3 4.5 18.0 8.65 2 268.1 146.7 2.254 5.73 194 3 4.5 18.o 8.65 2 250.6 146.7 2.222 6.62 194 3 4.5 18.0 8.65 2 259.4 146.7 2.287 6.11 194 3 4.5 18.0 8.65 2 267.7 146.6 2.255 5.75 194 3 4.5 18.0 8.65 2 250.2 146.6 2.222 6.64 194 3 4.5 18.0 8.65 2 258.9 146.6 2.288 6.13 194 3 4.5 18.0 8.65 2 267.9 146.4 2 .255 5.73 194 3 4.5 1a.o 8e65 2 250.4 146.4 2.222 6.62 194 3 4.5 18.0 8.65 2 259.2 146.4 2.2aa 6.11 194 3 4.5 18.o 8.65 2 267.9 146.3 2.255 5.72 194 3 4.5 18.o a.65 2 250.6 146.3 2.222 6.60 194 3 4.5 18.o 8.65 2 259.3 146.3 2.2a8 6el0 194 3 5.5 22.0 7.58 2 282.8 146.6 2,.733 4e48 194 3 5.5 22.0 7.58 2 262.9 146.6 2.698 5.19 194 3 5.5 22.0 7.58 2 212 .a 146.6 2.775 4.79 194 3 5.5 22.0 7.58 2 283.0 146.5 2.733 4.47
90
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS j
OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
194 3 5.5 22.0 7.58 2 262.7 146.5 2.698 5.19 194 3 5.5 22.0 7.58 2 272.9 146.5 2.775 4.78 194 3 5.5 22.0 7.58 2 283.7 146.6 2.732 4.45 194 3 5.5 22.0 7.58 2 263.3 146.6 2.697 5.18 194 3 5.5 22.0 7.58 2 273.5 146.6 2.774 4.76 194 3 5.5 22.0 7.58 2 282.9 146.6 2.733 4.48 194 3 5.5 22.0 7.58 2 263.1 14'6. 6 2.697 5.18 194 3 5.5 22.0 7.58 2 273.0 146.6 2.775 4.78 195 3 1.0 4.0 11.20 2 204.9 147.3 .518 23.86 195 3 1.0 4.0 .17.20 2 195.4 147.3 e509 28.23 195 3 1.0 4.0 11.20 2 200.2 147.3 .525 25.73 195 3 1.0 4.0 11.20 2 203.6 147.2 .519 24.39 195 3 1.0 4.0 17.20 2 194.3 147.2 e509 28,85 195 3 1.0 4.0 11.20 2 199.0 147.2 .525 26.30 195 3 1.0 4.0 11.20 2 203.8 147.5 .519 24.42 195 3 1.0 4.0 17.20 2 194.5 147.5 ·509 28.96 195 3 1.0 4.0 11.20 2 199.1 147.5 .525 26.36 195 3 1.0 4.0 17.20 2 204.4 147.8 .518 24.32 195 3 1.0 4.0 11.20 2 195.2 147.8 .509 28.72 195 3 1.0 4.0 17.20 2 199.8 147.8 .525 26.21 195 3 1.5 6·0 14.03 2 217.3 147.3 .112 16.05 195 3 1.5 6e0 14.03 2 207.6 147.3 .758 18.44 195 3 1.5 6.0 14.03 2 212.4 147.3 .782 17.08 195 3 1.5 6·0 14.03 2 217.3 147.4 .112 16.06 195 3 1.5 6·0 14.03 2 207.6 147.4 .758 18.45 195 3 1.5 6·0 14.03 2 212~4 147.4 .782 17.09 195 3 1.5 6·0 14.03 2 217.5 147.6 .112 16.06 195 3 1.5 6·0 14.03 2 201.1 147.6 .758 18.47 195 3 1.5 6e0 14.03 2 212.6 147.6 e782 11.10 195 3 1.5 6e0 14.03 2 211.1 147.7 .112 16.04 195 3 1.5 6·0 14.03 2 208.0 147.7 .758 18.40 195 3 1.5 6·0 14.03 2 212.9 147.7 .182 17.06 195 3 2.0 9.0 12.30 2 227.4 146.9 1.024 12.25 195 3 2.0 a.o 12.30 2 217.3 146.9 1.006 13.85 195 3 2.0 a.a 12.30 2 222.4 146.9 1.037 12.94 195 3 2.0 a.o 12.30 2 226.8 146.2 1.025 12.23 195 3 2.0 a.a 12.30 2 216.3 146.2 1.001 13.91 195 3 2.0 a.o 12.30 2 221.6 146.2 le038 12.95 195 3 2.0 8.0 12.30 2 226.3 145.5 1.026 12.20 195 3 2.0 a.o 12.30 2 215.7 145.5 1.001 13.88 195 3 2.0 a.o 12.30 2 221.0 145.5 le039 12.93 195 3 2.0 a.o 12.30 2 225.7 145.4 1.026 12.28 195 3 2.0 8.o 12.30 2 215.l 145.4 1.008 13.99 195 3 2.0 8e0 12.30 2 220.4 145.4 1.039 13.02 195 3 2.5 10.0 11.10 2 236.3 146.2 1.275 9.89 195 3 2.5 10.0 11.10 2 224.6 146.2 1.253 11. 23 195 3 2.5 10.0 11.10 2 230.4 146.2 1.291 10.47 195 3 2.5 10.0 11.10 2 236.4 146.l 1.275 9.86 195 3 2.5 10.0 11.10 2 224.6 146.l 1.253 11.22
91
~
'
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
1'95 3 2.5 10.0 11.10 2 230.5 146.1 le29l 10.45 195 3 2.5 10.0 11.10 2 236.4 146.2 1.275 9e87 195 3 2.5 10.0 11.10 2 224.5 146.2 1.253 11.24 195 3 2.5 10.0 11.10 2 230.5 146.2 1.291 10.46 195 3 2.5 10.0 11.10 2 236.3 146.0 1.275 9.86 195 3 2.5 10.0 11.10 2 224.6 146.0 1.253 11.20 195 3 2.5 10.0 11.10 2 230.4 146.0 le292 10.44 195 3 3.5 14·0 9.57 2 254.o 146.5 le767 7.15 195 3 3.5 14.0 9.57 2 239.1 146.5 1.739 8.21 195 3 3.5 14.0 9.57 2 246.6 146.5 1. 1 92 7.60 195 3 3.5 14.0 9.57 2 254.9 146.5 le766 1.10 195 3 3.5 14·0 9.57 2 239.7 146.5 1.739 8.16 195 3 3.5 14.0 9.57 2 247.3 146.5 1.791 7.55 195 3 3.5 14.0 9.57 2 254.5 146.4 1.766 7.11 195 3 3.~ 14.0 9.57 2 239.4 146.4 1.739 8.18 195 3 3.5 14.0 9.57 2 246.9 146.4 le791 7.57 195 3 3.5 14.0 9.57 2 253.5 146.2 le768 1.1 1 195 3 3.5 14.0 9.57 2 238.5 146.2 1.140 8.24 195 3 3.5 14.0 9.57 2 246.o 146.2 le792 7.63 195 3 4.5 18.0 8.45 2 268.l "146. 7 2.254 5.60 195 3 4.5 1a.o 8.45 2 250.6 146.7 2.222 6.47 195 3 4.5 18.0 8.45 2 259.4 146.7 2.201 5.98 195 3 4.5 1a.o 8.45 2 267.7 146.6 2.255 5.62 195 3 4.5 10.0 0.45 2 250.2 146.6 2.222 6.49 195 3 4.5 18.0 8.45 2 258.9 146.6 2.2aa 6.oo 195 3 4.5 18.0 8.45 2 267.9 146.4 2.255 5.60 195 3 4.5 10.0 8.45 2 250.4 146.4 2.222 6.47 195 3 4.5 18.0 a.45 2 259.2 146.4 2.2a8 5.97 195 3 4.5 1a.o 8.45 2 267.9 146.3 2.255 5.59 195 3 4.5 18.0 8.45 2 250.6 146.3 2.222 6.45 195 3 4.5 18.0 0.45 2 259.3 146.3 2.288 5.96 195 3 5.5 22.0 1.10 2 282.8 146.6 2.733 4.55 195 3 5.5 22.0 1.10 2 262.9 146.6 2e698 5.27 195 3 5.5 22.0 1.10 2 212.a 146.6 2.775 4.86 195 3 5.5 22.0 1.10 2 283.0 146.5 2.733 4.54 195 3 5.5 22.0 1.10 2 262.7 146.5 2e698 5.28 195 3 5.5 22.0 1.10 2 212.9 146.5 2.775 4.86 195 3 5.5 22.0 1.10 2 283.7 146.6 2.732 4.53 195 3 5.5 22.0 1.10 2 263.3 146.6 2.697 5.26 195 3 5.5 22.0 1.10 2 273.5 146.6 2.774 4.84 195 3 5.5 22.0 1.10 2 282.9 146.6 2.733 4.,55 195 3 5.5 22.0 1.10 2 263.1 146.6 2.697 5.27 195 3 5.5 22.0 1.10 2 273.0 146.6 2.775 4.86 211 3 1.0 4.0 14.16 2 130.0 85.4 .563 25.67 211 3 1.0 4·0 14.16 2 125.9 85.4 .551 27.95 211 3 1.0 4.0 14.16 2 127.9 85.4 .570 26.63 211 3 1.0 4.0 14.16 2 128.7 85.4 .564 26.48 211 3 1.0 4.0 14.16 2 126.1 85.4 .551 27.81 2ll 3 1.0 4.0 14.16 2 127.4 85.4 .570 27.0l
92
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou.:.. TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
211 3 1.0 4.0 14.16 2 129.1 85.2 .564 26.11 211 3 1.0 4.0 14.16 2 126.5 85.2 .551 27.42 211 3 1.0 4.0 14.16 2 127.8 85.2 .570 26,63 211 3 1.5 6·0 16.93 2 146.l 86.2 .836 22.91 211 3 1.5 6e0 16.93 2 138.9 86.2 .820 25.73 211 3 1.5 6e0 16.93 2 142.5 86.2 e846 24.12 211 3 1.5 6e0 16.93 2 146.6 86.2 .836 22.12 211 3 1.5 6.0 16.93 2 139.2 86.2 .820 25.62 211 3 1.5 6e0 16.93 2 142.9 86.2 e846 23.97 211 3 1.5 6e0 16.93 2 147.2 86.4 .836 22.57 211 3 1.5 6e0 16.93 2 139.5 86.4 .020 25.53 211 3 1.5 6e0 16.93 2 143.3 86.4 e846 23.85 211 3 2.0 0.0 10.22 2 156.2 86.2 1.108 11.85 211 3 2.0 0.0 10.22 2 147.4 86.2 1.000 13.39 211 3 2.0 0.0 10.22 2 151.8 86.2 1.122 12.51 211 3 2.0 0.0 10.22 2 156.7 86.5 1.101 11.81 211 3 2.0 8.o 10.22 2 144.5 86.5 le090 14.14 211 3 2.0 0.0 10.22 2 150.6 86.5 1.123 12.80 211 3 2.0 0.0 10.22 2 156.4 86.6 1.108 11.88 211 3 ~2 .o a.a 10.22 2 147.7 86.6 le087 13 .42 211 3 2.0 a.o 10.22 2 152.0 86.6 1.122 12.55 211 3 2.5 10.0 11. 03 2 165.9 84.4 1.378 11.00 211 3 2.5 10.0 11.03 2 155.5 84.4 1.354 12.45 211 3 2.5 10.0 11.03 2 160.7 84.4 1.396 11. 63 211 3 2.5 10.0 11.03 2 166.1 84.5 1.378 10.99 211 3 2.5 10.0 11.03 2 155.6 s~~s 1.354 12.46 211 3 2.5 10.0 11.03 2 160.8 84.5 1.396 11.63 211 3 2.5 10.0 11. 03 2 166.2 84.2 1.378 10.93 211 3 2.5 10.0 11. 03 2 155.9 84.2 1.354 12.36 211 3 2.5 10.0 11.03 2 161.1 84.2 1.396 11 . 55 211 3 3.5 14.0 8.91 2 179.4 83.6 1.915 7.58 211 3 3.5 14·0 8.91 2 166.8 83.6 1.884 8.62 211 3 3 .5 14.0 a.91 2 173.1 83.6 le941 8.03 211 3 3.5 14.0 8.91 2 179.5 83.6 1.914 7.56 211 3 3.5 14.0 8.91 2 166.9 83.6 1.884 8.61 211 3 3.5 14.0 8.91 2 173.2 83.6 1.941 8.01 211 3 3.5 14.0 0.91 2 182.7 83.6 1.911 7.33 211 3 3.5 14.0 0.91 2 169.9 83.6 1.aao 8.31 211 ·3 3.5 14·0 8.91 2 176.3 83.6 1 .937 7.75 211 3 4.5 18.0 1.21 2 196.1 83.3 2.437 5 . 25 211 3 4.5 18.o 1.21 2 180.7 83.3 2.402 6.01 211 3 4.5 18.0 1.21 2 188.4 83.3 2.473 5.58 211 3 4.5 18.0 1.21 2 197.2 83.5 2.435 5.21 211 3 4.5 18.o 1.21 2 181.9 83.5 2.400 5.95 211 3 4.5 18.0 1.21 2 189.6 83.5 2.471 5.53 211 3 4.5 18.0 1.21 2 197.1 61.4 2e469 4e40 211 3 4.5 18.0 1.21 2 182.2 61.4 2.433 4.89 211 3 4.5 18·0 1.21 2 189.6 61.4 2.505 4.61 211 3 5.5 22.0 6.87 2 211.0 81.7 2.955 4.34
93
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
211 3 5.5 22.0 6.87 2 194.9 81.7 2.913 4e90 211 3 5.5 22.0 6.87 2 203.o 81.7 2.999 4.58 211 3 5.5 22.0 6.87 2 210.4 81.9 2.956 4.37 211 3 5.5 22.0 6.87 2 194.0 81.9 2.914 4.95 211 3 5.5 22.0 6.87 2 202.2 81.9 3.000 4.62 211 3 5.5 22.0 6.87 2 211.9 81.9 2.953 4.32 211 3 5.5 22.0 6.87 2 195.o 81.9 2.913 4.91 211 3 5.5 22.0 6.87 2 203.5 81.9 2.997 4.57 211 3 5.5 22.0 6.87 2 212.1 81.9 2.953 4.31 211 3 5.5 22.0 6.87 2 195.6 81.9 2.912 4.88 211 3 5.5 22.0 6.87 2 203.8 81.9 2.997 4.56 212 3 1.0 4~0 11. 93 2 130.0 85.4 .563 21.63 212 3 1.0 4.0 11.93 2 125.9 85.4 .551 23.55 212 3 1.0 4.0 11.93 2 127.9 85.4 .570 22.45 212 3 1.0 4.0 11.93 2 128.7 85.4 .564 22.32 212 3 1.0 4.0 11.93 2 126.l 85.4 .551 23.44 212 3 1. 0 4.0 11.93 2 127.4 85.4 .570 . 22.76 212 3 1.0 4.0 11.93 2 129.l 85.2 .564 22.00 212 3 1.0 4.0 11.93 2 126.5 85.2 .551 23.11 212 3 1.0 4.0 11.93 2 121.8 85.2 .570 22.44 212 3 1.5 6·0 12.04 2 146.l 86.2 • 836 16.28 212 3 1.5 6e0 12.04 2 138.9 86.2 .020 18.29 212 3 1.5 6·0 12.04 2 142.5 86.2 • 846 17.14 212 3 1.5 6e0 12.04 2 146.6 86.2 .836 16.15 212 3 1.5 6e0 12.04 2 139.2 86.2 .020 18.21 212 3 1.5 6·0 12.04 2 142.9 86.2 e846 17.04 212 3 1.5 6.0 12.04 2 147.2 86.4 .836 16.04 212 3 1.5 6.0 12.04 2 139.5 86.4 .a20 18.15 212 3 1.5 6e0 12.04 2 143.3 86.4 .846 16.95 212 3 2.0 0.0 9.34 2 156.2 86.2 1.108 10.82 212 3 2.0 8.o 9.34 2 147.4 86.2 1.088 12.23 212 3 2.0 9.0 9.34 2 151.8 86.2 1.122 11.43 212 3 2.0 8.o 9.34 2 156.7 86.5 1.101 10.78 212 3 2.0 9.0 9.34 2 144.5 86.5 le090 12.91 212 3 2.0 0.0 9.34 2 150.6 86.5 1.123 11.69 212 3 2.0 9.0 9.34 2 156.4 86.6 1.108 10.85 212 3 2.0 0.0 9.34 2 147.7 86.6 le087 12.26 212 3 2.0 8.o 9.34 2 152.0 86.6 1.122 11.46 212 3 2.5 10.0 9.54 2 165.9 84.4 1.378 9.51 212 3 2.5 10.0 9.54 2 155.5 84.4 1.354 10.77 212 3 2.5 10.0 9.54 2 160.7 84.4 1.396 10.05 212 3 2.5 10.0 9.54 2 166.l 84.5 1.378 9.50 212 3 2.5 10.0 9.54 2 155.6 84.5 1.354 10.11 212 3 2.5 10.0 9.54 2 160.8 84.5 le396 10.05 212 3 2.5 10.0 9.54 2 166.2 84.2 1.378 9.45 212 3 2 .. 5 10.0 9.54 2 155.9 84.2 1.354 l0.69 212 3 2.5 10.0 9.54 2 161.1 84.2 le396 9.98 212 3 3.5 14.0 9.34 2 179.4 83.6 1.915 7.94 212 3 3.5 14.0 9.34 2 166.8 83·. 6 1·884 9.03
94
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
212 3 3.5 14.0 9.34 2 173.1 83.6 1.941 8.41 212 3 3.5 14.0 9.34 2 179.5 83.6 1.914 7.93 212 3 3.5 14.0 9.34 2 166.9 83.6 le884 9.02 212 3 3.5 14.0 9.34 2 173.2 83.6 1.941 8e40 212 3 3.5 14.0 9.34 2 182.7 83.6 le9ll 7.68 212 3 3.5 14.0 9.34 2 169.9 83.6 1.880 8.71 212 3 3.5 14.0 9.34 2 176.3 83.6 1.937 8.12 212 3 4.5 18.o 7.23 2 196.l 83.3 2.437 5.23
. 212 3 4.5 18.o 1.23 2 180.7 83.3 2e402 5.98 212 3 4.5 18.0 7.23 2 188.4 83.3 2.473 5.55 212 3 4.5 18.0 1.23 2 197.2 83.5 2.435 5.19 212 3 4.5 18.0 7.23 2 181.9 83.5 2.400 5.92 212 3 4.5 1a.o 7.23 2 189.6 83.5 2e471 5.50 212 3 4.5 18.0 7.23 2 197.1 61.4 2.469 4.38 212 3 4.5 1a.o 1.23 2 182.2 61.4 2.433 4e86 212 3 4.5 18.0 7.23 2· 189.6 61.4 2.505 4.59 212 3 5.5 22.0 6.67 2 211.0 81.7 2.955 4.21 212 3 5.5 22.0 6.67 2 194.9 81.7 2.913 4.76 212 3 5.5 22.0 6.67 2 203.0 81.7 2.999 4.45 212 3 5.5 22.0 6.67 2 210.4 81.9 2e956 4.24 212 3 5.5 22.0 6.67 2 194.0 81.9 2.914 4.8o 212 3 5.5 22.0 6.67 2 202.2 81.9 3.000 4.48 212 3 5.5 22.0 6.67 2 211.9 81.9 2.953 4.19 212 3 5.5 22.0 6.67 2 195.0 81.9 2.913 4.76 212 3 5.5 22.0 6.67 2 203.5 81.9 2.997 4e44 212 3 5.5 22.0 6.67 2 212.1 81.9 2.953 4.18 212 3 5.5 22.0 6.67 2 195.6 81.9 2.912 4.74 212 3 5.5 22.0 6.67 2 203.8 81.9 2.997 4.42 213 3 1.0 4.0 12.24 2 130.0 85.4 e563 22.20 213 3 1.0 4.0 12.24 2 125.9 85.4 .551 24.17 213 3 1.0 4.0 12.24 2 127.9 85.4 .570 23.03 213 3 1.0 4.0 12.24 2 128.7 85.4 .564 22.90 213 3 1.0 4.0 12.24 2 126.l 85.4 .551 24.05 213 3 1.0 4.0 12.24 2 127.4 85.4 .570 23.35 213 3 1.0 4.0 12.24 2 129.1 85.2 .564 22.58 213 3 1.0 4.0 12.24 2 126.5 85.2 .551 23.71 213 3 1.0 4.0 12.24 2 121.8 85.2 .570 23.02 213 3 1.5 6.0 11.16 2 146.1 86.2 .836 15.09 213 3 1.5 6e0 11.16 2 138.9 86.2 .020 16.95 213 3 1.5 6·0 11.16 2 142.5 86.2 e846 15.89 213 3 1 •. 5 6e0 11.16 2 146.6 86.2 ·836 14.97 213 3 1.5 6·0 11.16 2 139.2 86.2 .020 16.88 213 3 1.5 6e0 11.16 2 142.9 86.2 .846 15.79 213 3 1.5 6.0 11.16 2 147.2 86.4 .836 14.87 213 3 1.5 6e0 11.16 2 139.5 86.4 .820 16.82 213 3 1.5 6·0 11.16 2 143.3 86.4 .846 15.71 213 3 2.0 8.o 13.30 2 156.2 86.2 1.108 15.41 213 3 2.0 a.o 13.30 2 147.4 86.2 1.00a 17.41 213 3 2.0 0.0 13.30 2 151.8 86.2 1.122 16.27
95
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
213 3 2.0 a.a 13.30 2 156.7 86.5 1.107 15.35 213 3 2.0 a.o 13.30 2 144.5 86.5 1.090 18.38 21~ 3 2.0 8.o 13.30 2 150.6 86.5 1.123 16.65 213 3 2.0 8.o 13.30 2 156.4 86.6 1 .108 15.45 213 3 2.0 a.o 13 .30 2 147.7 86.6 1.087 17.46 213 3 2.0 a.o 13.30 2 1s2.o 86.6 1.122 16.32 213 3 2.5 10.0 9.77 2 165.9 84.4 1.378 9.75 213 3 2.5 10.0 9.77 2 155.5 84.4 1.354 11. 03 213 3 2.5 10.0 9.77 2 160.7 84.4 1.396 10.30 213 3 2.5 10.0 9.77 2 166.l 84.5 1.378 9.74 213 3 2.5 10.0 9.77 2 155.6 84.5 1.354 11.04 213 3 2.5 10.0 9.77 2 160.8 84.5 1.396 10.30 213 3 2.5 10.0 9.77 2 166.2 84.2 1.378 9.68 213 3 2.5 10.0 9.77 2 155.9 84.2 1.354 10.95 213 3 2.5 10.0 9.77 2 161.l 84.2 l.396 10.23 213 3 3.5 14.0 8.16 2 179.4 83.6 l.915 6.93 213 3 3.5 14.0 a.16 2 166.8 83.6 1.884 7.89 213 3 3.5 14.0 8.16 2 173.l 83.6 1.941 7.34 213 3 3.5 14.0 8.16 2 179.5 83.6 1.914 6.92 213 3 3.5 14.0 8.16 2 166.9 83.6 l.884 7.88 213 3 3.5 14.0 8.16 2 173.2 83.6 le941 7.33 213 3 3.5 14.0 8.16 2 182.7 83.6 1.911 6.71 213 3 3.5 14.0 8.16 2 169.9 83.6 1.880 7.61 213 3 3.5 14.0 8.16 2 176.3 83.6 1.937 7.09 213 3 4.5 18·0 7.53 2 196.l 83.3 2.437 5.44 213 3 4.5 18.0 7.53 2 180.7 83.3 2·402 6.23 213 3 4.5 18.0 7.53 ,2 188.4 83.3 2.473 5.78 213 3 4.5 1s.o 7.53 2 197.2 83.5 2.435 5.40 213 3 4.5 18.o 7.53 2 181 .9 83.5 2.400 6.17 213 3 4.-5 18.o 7.53 2 189.6 83.5 2.471 5.73 213 3 4.5 18.0 7 .53 2 197.l 61.4 2.469 4e56 213 3 4.5 18.0 7.53 2 182.2 61.4 2 .433 5.07 213 3 4.5 18.0 7.53 2 189.6 61.4 2 .505 4.78 213 3 5.5 22.0 7.36 2 211.0 81.7 2.955 4.65 213 3 5.5 22.0 7.36 2 194.9 81.7 2.913 5.26 213 3 5.5 22.0 7.36 2 203.0 81.7 2.999 4.91 213 3 5.5 22.0 7.36 2 210.4 81.9 2.956 4.68 213 3 5.5 22.0 7.36 2 194.o 81.9 2 .914 5.30 213 3 5.5 22.0 7.36 2 202 .2 81.9 3 .000 4.95 213 3 5.5 22.0 7.36 2 211.9 81.9 2.953 4.63 213 3 5 .5 22 .0 7.36 2 195.o 81.9 2 .91 3 5.26 213 3 5.5 22.0 7.36 2 203.5 81.9 2.997 4.90 213 3 5.5 22.0 7.36 2 212.1 81.9 2.953 4.62 213 3 5.5 22.0 7.36 2 195.6 81.9 2 .912 5.23 213 3 5.5 22.0 7.36 2 203.8 81.9 2.997 4.89 214 3 1.0 4.0 11.96 2 130.0 85.4 .563 21 .68 214 3 1.0 4.0 11.96 2 125.9 85.4 .551 23.61 214 3 1.0 4.0 11.96 2 127 . 9 85.4 .570 22 . 50 214 3 1. 0 4.0 11.96 2 128.7 85.4 .564 22 . 37
96
RUN NO ETHYL HYDRO CON THE RM SURFACE BULK F:EYNOLDS j
OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
214 3 1 .0 4.0 11.96 2 126 .1 85.4 .551 23.49 2~4 3 1 . 0 4.0 11.96 2 127.4 85.4 .570 22.81 214 3 1.0 4.0 11. 96 2 129.1 85.2 .564 22 .06 214 3 1.0 4 .0 11.96 2 126.5 85.2 .551 23.16 214 3 1.0 4.0 11.96 2 127 . 8 85. 2 .570 22.49 214 3 1.5 6 .0 10.1 1 2 146.1 86.2 .836 14.57 214 3 1.5 6e0 10.77 2 138 . 9 86.2 .820 16.36 214 3 1.5 6·0 10.77 2 142.5 86.2 .846 15.34 214 3 1.5 6·0 10.77 2 146.6 86.2 .836 14 .45 214 3 1.5 6e0 10.77 2 139.2 86.2 .820 16.29 214 3 1.5 6·0 10.77 2 142.9 86.2 .846 15.24 214 3 1.5 6·0 10.77 2 147.2 86.4 .836 14.36 214 3 1.5 6·0 10.77 2 139.5 86.4 e820 16.24 214 3 1.5 6·0 10.77 2 143.3 86.4 .846 15.17 214 3 2.0 8.0 10.29 2 156.2 86.2 1.108 11. 92 214 3 2.0 8.o 10.29 2 147.4 86.2 1.088 13.48 214 3 2.0 8.o 10.29 2 151.8 86.2 1.122 12.59 214 3 2.0 a.a 10.29 2 156.7 86.5 1.101 11.88 214 3 2.0 a.o 10.29 2 144.5 86.5 1.090 14.23 214 3 2.0 8.o 10.29 2 150.6 86.5 1.123 12.89 214 3 2.0 a.a 10.29 2 156.4 86.6 1.108 11.96 214 3 2.0 a.o 10.29 2 147.7 86.6 1.087 13.51 214 3 2.0 8.o 10.29 2 152.0 86.6 1.122 12.63 214 3 2.5 10.0 9.50 2 165.9 84.4 1.378 9.47 214 3 2.5 10.0 9.50 2 155.5 84.4 1.354 10.12 214 3 2.5 10.0 9.50 2 160.7 84.4 le396 10.01 214 3 2.5 10.0 9.50 2 166.l 84.5 1.378 9.46 214 3 2.5 10.0 9.50 2 155.6 84.5 1.354 10.73 214 3 2.5 10.0 9.50 2 160.8 84.5 1.396 10.01 214 3 2.5 10.0 9.50 2 166.2 84.2 1.378 9.41 214 3 2.5 10.0 9.50 2 155.9 84.2 1.354 10.64 214 3 2.5 10.0 9.50 2 161.1 84.2 le396 9.94 214 3 3.5 14.0 8.04 2 179.4 83.6 1.915 6.83 214 3 3.5 14.0 8.04 2 166.8 83.6 le884 1.11 214 3 3.5 14.0 8.04 2 173.l 83.6 1.941 7.24 214 3 3.5 14.0 0.04 2 179.5 83.6 1.914 6.82 214 3 3.5 14.0 8.04 2 166.9 83.6 1.884 7.76 214 3 3.5 14.0 8.04 2 173.2 83.6 le941 7.23 214 3 3.5 14.0 e.04 2 182.7 83.6 1.911 6.61 214 3 3.5 14.0 8.04 2 169.9 83.6 le880 7.50 214 3 3.5 14.0 8e04 2 176.3 83.6 1.937 6.99 214 3 4.5 10.0 7.89 2 196.1 83.3 2.437 5.70 214 3 4.5 18.0 7.89 2 180.7 83.3 2.402 6.53 214 3 4.5 1a.o 7.89 2 188.4 83.3 2.473 6.06 214 3 4.5 18.0 7.89 2 197.2 83.5 2.435 5.66 214 3 4.5 1a.o 7.89 2 181.9 83.5 2e400 6.46 214 3 4.5 18.0 7.89 2 189.6 83.5 2.471 6.oo 214 3 4.5 10.0 7.89 2 197.1 61.4 2.469 4.78 214 3 4.5 18·0 7e89 2 182.2 61.4 2.433 5.31
97
RUN NO ETHYL HYDRO CON THERM SURFACE BULK REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
214 3 4.5 18.0 7.89 2 189.6 61.4 2e505 5.oo 214 3 5.5 22.0 7.62 2 211.0 81.7 2.955 4.82 214 3 5.5 22.0 7.62 2 194.9 81.7 2.913 5.44 211, 3 5.5 22.0 7.62 2 203.0 81.7 2.999 5.08 214 3 5.5 22.0 7.62 2 210.4 81.9 2.956 4e85 214 3 5.5 22.0 7.62 2 194.o 81.9 2e914 5.49 214 3 5.5 22.0 7.62 2 202.2 81.9 3eOOO 5.12 214 3 5.5 22.0 7.62 2 211.9 81.9 2.953 4.79 214 3 5.5 22.0 7.62 2 195.o 81.9 2.913 5e44 214 3 5.5 22.0 7.62 2 203.5 81.9 2.997 5.01 214 3 5.5 22.0 7.62 2 212.1 81.9 2.953 4.78 214 3 5.5 22.0 7.62 2 195.6 81.9 2.912 5.41 214 3. 5.5 22.0 7.62 2 203.8 81.9 2.997 5.06 215 3 5.5 22.0 6.48 2 211.0 8~.7 2.955 4.09 215 3 5.5 22.0 6.48 2 194.9 81.7 2.913 4.62 215 3 5.5 22.0 6.48 2 203.0 81.7 2.999 4.32 215 3 5.5 22.0 6.48 2 210.4 81.9 2.956 4.12 215 3 5.5 22.0 6.48 2 194.0 81.9 2.914 4.66 215 3 5.5 22.0 6.48 2 202.2 81.9 3.ooo 4.35 215 3 5.5 22.0 6.48 2 211.9 81.9 2.953 4.07 215 3 5.5 22.0 6.48 2 195.o 81.9 2.913 4.63 215 3 5.5 22.0 6.48 2 203.5 81.9 2.997 4.31 215 3 5.5 22.0 6.48 2 212.1 81.9 2.953 4e07 215 3 5.5 22.0 6.48 2 195.6 81.9 2.912 4.60 215 3 5.5 22.0 6.48 2 203.8 81.9 2.997 4.30 216 3 1.0 4.0 12.57 2 130.0 8 5 . 4 .563 22.79 216 3 1.0 4.0 12.57 2 125.9 85.4 .551 24.82 216 3 1.0 4.0 12.57 2 127.9 85.4 .570 23.65 216 3 1.0 4.0 12.57 2 128.7 85.4 .564 23.51 216 3 1.0 4e0 12.57 2 126 .1 85.4 .551 24.70 216 3 1.0 4.0 12.57 2 127.4 85.4 .570 23.98 216 3 1.0 4.0 12.57 2 129.l 85.2 .564 23.18 216 3 1.0 4.0 12.57 2 126.5 85.2 .551 24.35 216 3 1.0 4.0 12.57 2 127.8 85.2 .570 23.64 216 3 1.5 6e0 12.12 2 146.1 86.2 .836 17.21 216 3 1.5 6.0 12.12 2 138.9 86.2 .820 19.33 216 3 1.5 6e0 12.72 2 142.5 86.2 .846 18.12 216 3 1.5 6.0 12.72 2 146.6 86.2 .836 17.07 216 3 1.5 6e0 12.72 2 139.2 86.2 • 8·20 19.25 216 3 1.5 6.0 12.72 2 142.9 86.2 .846 18.01 216 3 1.5 6e0 12.72 2 llf7e2 86.4 .836 16.95 216 3 1.5 6·0 12.72 2 139.5 86.4 .820 19.18 216 3 1.5 6e0 12.72 2 11+3. 3 86.4 .846 17.91 216 3 2.0 0.0 10.79 2 156.2 86.2 1.108 12.50 216 3 2.0 0.0 10.79 2 147.4 86.2 1.088 14.12 216 3 2.0 8.o 10.79 2 151.8 86.2 1.122 13.20 216 3 2.0 8.o 10.79 2 156.7 86.5 1.101 12.46 216 3 2.0 8.o 10.79 2 144.5 86.5 1.090 14.91 216 3 2.0 8.o 10.79 2 150.6 86.5 1.123 13. 51
98
)
RUN· NO ETHYL HYDRO CON THERM SURFACE BULK· REYNOLDS J OF ENE GEN VER ocou- TEMP TEMP· NUMBER FACTOR PEL CC/SC CC/SC SION PLE F F
216 3 2.0 .8 .o 10.79 2 156.4 86.6. le 108. 12 • 5,4 216 3 2.0 8.o 10.79 2 147.7 86.6 le087. 14.16 216 3 2.0 a.o 10.79 2 152.0 86.6 1.122 13.24 216 3 2.5 10.0 9.96 2 165.9 84.4 1.378 9.93 216 3 2.5 10.0 9.96 2 155.5 84.4 1.354 11.24 216 3 2.5 10.0 9.96 2 160.7 84.4 le396 10.50 216 3 2.5 10.0 9.96 2 166.1 84.5 1.379 9.92 216 3 2.s 10.0 9.96 2 155.6 84.5 1.354 11.25 216 3 2.5 10.0 9.96 2 160.8 84.5 le396 10.49 216 3 2.5 10.0 9e96 2 166.2 84.2 le378 9.87 216 3 2.5 10.0 9.96 2 155.9 84.2 1.354 11.16 216 3 2.5 10.0 9.96 2 161.1 84.2 le396 10.42 216 3 3.5 14·0 8.61 2 179.4 83.6 1.915 7.32 216 3 3.5 14.0 8.61 2 166.8 83.6 le884 8.33 216 3 3.5 14.0 0.61 2 173.1 83.6 le941 7.75 216 3 3.5 14.0 a.61 2 179.5 83.6 le914 7.31 216 3 3.5 14.0 8.61 2 166.9 83.6 le884 e.32 216 3 3.5 14.0 8.61 2 173.2 83.6 le941 7.74 216 3 3.5 14.0 8.61 2 182.7 83.6 1.911 1.oa 216 3 3.5 14.0 8.61 2 169.9 83.6 1.000 0.03 216 3 3.5 14.0 8.61 2 176.3 83.6 1.937 7.49 216 3 4.5 10.0 7.38 2 196.1 83.3 2.437 5.33 216 3 4.5 18.0 7.38 2 180.7 83.3 2e402 6.10 216 3 4.5 18.0 7.38 2 188.4 83.3 2.473 5.66 216 3 4.5 i0.o 7.38 2 197.2 83.5 2.435 5.29 216 3 4.5 10.0 7.38 2 181.9 83.5 2e400 6.04 216 3 4.5 10.0 7.38 2 189.6 83.5 2e471 5.61 216 3 4.5 10.0 7.38 2 197.1 61.4 2e469 4.47 216 3 4.5 10.0 7.38 2 182.2 61.4 2.433 4.96 216 3 4.5 10.0 7e38 2 189.6 61.4 2e505 4e68 216 3 5.5 22.0 1.00 2 211.0 81.7 2.955 4.42 216 3 5.5 22.0 1.00 2 194.9 81.7 2.913 4.99 216 3 5.5 22.0 1.00 2 203.0 81.7 2.999 4.67 216 3 5.5 22.0 1.00 2 210.4 ·81.9 2.956 4.45 216 3 5.5 22.0 1.00 2 194.o 81.9 2.914 5.04 216 3 5.5 22.0 1.00 2 202.2 81.9 3.000 4.70 216 3 5.5 .22 .o 1.00 2 211.9 81.9 2.953 4.40 216 3 5.5 22.0 1.00 2 195.0 81.9 2.913 s.oo 216 3 5.5 22.0 1.00 2 203.5 81.9 2.997 4.66 216 3 5.5 22.0 1.00 2 212.1 81.9 2.953 4.39 216 3 5.5 22.0 1.00 2 195.6 81.9 2.912 4.97 216 3 5.5 22.0 1.00 2 203.8 81.9 2.997 4e64
APPENDIX E
CONDUCTIVE AND RADIANT HEAT TRANSFER
99
APPENDIX E
CONDUCTIVE AND RADIANT HEAT TRANSFER
The calculations below show that conductive and radiant heat
transfer were negligible in this study. The surface temperature
was 357°F.; the bulk gas temperature was 208°F.; and the heat
transfer rate was 32.7 Btu/hr.
1. Conductive heat transfer (41).
Q = kA(L\T/L\X) .C
k = 0.03 Btu/(hr.-sq. ft.-(°F/ft. ))
A = (7 particles)(0.000510 sq. ft./particle) = 0.00357 sq.ft.
6T = 357°F. - 208°F. = 149°F.
6X = (0.50)(3.4 cm.)(in./2.54 cm.)(ft./12 in.)= 0.0556 ft.
Qc = (0.03)(0.00357)(149)/(0.0556) = 0.287 Btu./hr.
2. Radiant heat transfer (20).
4 4 Qr = 0-AC (Tl - T2 )
E = l/((l/E1 ) + (l/E2 ) - LO)
E = 0.821
Tl - 357°F. = 817°R.
T2 - 208°F. = 668°R.
a- = 1.73 x -9 /( 10 Btu. hr.-sq. ft.- 0 R4 )
Q r = 0.118 Btu./hr.
3. Total heat loss from radiation and conduction.
100
101
Qt= 0.287 + 0.118 = 0.405 Btu./hr.
Percent of total= (0.405/32.7)(100) = 1.24%
APPENDIX F
INFLUENCE OF PARTICLE ORIENTATION UPON SURFACE TEMPERATURE
102
APPENDIX F
IN.FLUEN.C:E, ... OF .. P.A-RT,I CLE .... QRIEN';rA.TJ..Q.N ... tJ.P.ON .. .S lJ.RFACE . ~EMP.ERA.'l'l.JRE
It was noted that there was a dependence of catalyst surface
temperature upon catalyst particle orientation. The particles
which were oriented with the mi:;\jor axis of the cylinder parallel
to the direction of flow consistently had a higher surface tem
perature than those particles which were oriented with their major
axis perpendicular to the flow.
Since these particles would not have generated the same amount
of heat because the surface temperatures were different 1 the fol
lowing procedure was used to calculate the heat evolved by a
particle:
l. The arithmetic average surface temperature was calculated
for all catalyst particles.
2. The heat of reaction was calculated at that temperature.
3. An average amount of heat evolved per particle was calculated
by dividing the heat production rate by the number of cata
lyst particles in the packed bed.
4. The amount of heat evolved by any particle was calculated
as the product of the heat rate calculated in (3) above and
the ratio of the temperature drop of that particle to the
average temperature drop.
Although the above procedure was used to calculate the heat
evolved per particle, the j-factors for the particles with their
major axis parallel to the direction of flow were consistently
103
lower· than those with their major axis perpendicular to the
direction of flow.
b This made the constant, a, in the equation, jh = aNRe'
consistently lower· for those particles with their major axes
parallel than those with their major axes perpendicular to the
direction of flow. These results are shown below:
Orientation of Axis to Flow
parallel
Perpendicular
a ( in j . aN b) h Re
11.2 11.7 11.6 12.0· 11. l 11.5 12.5 12.5 13.5
15.3 19.1 15.9 22.9 15.1 18.2 14.1 14.2 14.8
104
VITA
John Early Klopp
Candidate for the Degree of
Master of Science
Thesis: HEAT TRANSFER IN A PACKED BED REACTOR AT LOW REYNOLDS NUMBER: THE HYDROGENATION OF ETHYLENE TO ETHANE ON NICKEL CYLINDERS
Major Field: Chemical Engineering
Biographical:
Personal Data: Born in San Antonio, Texas, November 10, 1940, the son of G. Kirt and Alberta E, Klopp.
Education: Attended grade school in Erlanger and South Fort Mitchell, Kentucky; graduated from Beechwood High School, South Fort Mitchell, in 1958; attended the University of Kentucky, Lexington, for one year; received the Bachelor of Science degree from the Oklahoma State University in August, 1963; completed the requirements for the Master of Science degree in May, 1965.
Professional Experience: Worked as a Summer Management Trainee for the Procter and Gamble Manufacturing Company, Dallas, Texas, in 1963.
VITA
John Early Klopp
Candidate for the Degree of
Master of Science
Thesis: HEAT TRANSFER IN A PACKED BED REACTOR AT LOW REYNOLDS NUMBER: THE HYDROGENATION OF ETHYLENE TO ETHANE ON NICKEL CYLINDERS
Major Field: Chemical Engineering
Biographical:
Personal Data: Born in San Antonio, Texas, November 10, 1940, the son of G. Kirt and Alberta E, Klopp.
Education: Attended grade school in Erlanger and South Fort Mitchell, Kentucky; graduated from Beechwood High School, South Fort Mitchell, in 1958; attended the University of Kentucky, Lexington, for one year; received the Bachelor of Science degree from the Oklahoma State University in August, 1963; completed the requirements for the Master of Science degree in May, 1965.
Professional Experience: Worked as a Summer Management Trainee for the Procter and Gamble Manufacturing Company, Dallas, Texas, in 1963.