Frameless Quadrant Enclosureresources.kohler.com/plumbing/mira/pdf/1317134-w2... · Installation...

Post on 12-Mar-2020

1 views 0 download

Transcript of Frameless Quadrant Enclosureresources.kohler.com/plumbing/mira/pdf/1317134-w2... · Installation...

1 1317134-W2-B

These instructions must be left with the user

Installation Guide

Frameless Quadrant Enclosure

21317134-W2-B

Safety Information1. Careshouldbetakenwhendrillingintowallsandfloorstoavoidanyhidden

pipes or wires.2. Westronglyrecommendthatallglasspanelsaremovedbyaminimumoftwo

peopleandthatanyprotectivepackagingalongtheglassedgesiskeptinplaceforaslongaspossibletopreventdamagebeforeinstallation.

3. Wearprotectivefootwearwhenliftingpanels.4. Wearsafetyglasseswhendrilling.

General1. Read all of these instructions and retain this guide for later use.2. Passonthisguideintheeventofchangeofownershipoftheinstallationsite.3. Follow all warnings, cautions and instructions contained in this guide.4. Removeallprotectivetapefromtheenclosurebeforeinstallation.5. Excessiveflowratesmayleadtooverflowingandleaking.6. WaterSpraymayextendbeyondtheentranceofwalk-inenclosuresandwe

recommend tiling of the adjacent area.7. We recommend a drainage test is carried out to ensure the waste is adequate

fortheflowdelivered.8. Doorsthatopenoutwardsmaydripwaterontofloor,ensurethefloorcovering

willnotbeaffectedbywater.9. Walkinsanddividerpanelsaredesignedtominimisewaterescapingoutside

theenclosurebutbytheirverynaturearenotfullywatertight.

Introduction

General Information

ThankyouforpurchasingaqualityMiraproduct.Toenjoythefullpotentialofyournewproduct,pleasetaketimetoreadthisguidethoroughly,havingdoneso,keepithandyforfuturereference.The followingpagesaim toprovidecomprehensive installation instructions,plusadviceonhowtocareandmaintainyourproduct.Werecommendthattheunitisinstalledbyaqualifiedplumberorengineer.

3 1317134-W2-B

Before Fitting the Enclosure1. Ensurethetrayislevelandwallsareverticalandsquare.2. Shower fittings shouldbepositioned such thatwater dischargesdown the

centre line of a bath or across the opening of a shower cubicle door.3. Ensure water is not directed at the shower door or side panels. This could result

inwatersprayingoutsideoftheenclosure.4. Ensurethedooropeningispositionedcorrectlyandisadequateforallusers.5. Ensurethereisacompletesiliconesealbetweenthetrayandfinishedwall.6. Ensure the door is undamaged and no parts are missing.7. Ensurethesizeofdoor/panelissuitablefortheinstallation.Temperedsafety

glass cannot be cut.8. Ensure nothing can impact the door or glass panels during operation.

When Fitting the Enclosure1. Thewallchannelsmustbeinstalledontoatiledorwaterprooffinishedflatand

evenwallsurface.Failuretodosowillresultinanunsatisfactoryseal,whichmaycausepropertydamage.

2. Werecommendourenclosuresarefittedontoshowertrays. Warning!Theuseofgrout/tilecleaners,scaleremovers,abrasivescourers,

drainunblockersandotherpowerfuldetergentsmayleadtodamageofmetallic,platedandplasticsurfaces,includingthetrayandshowerwaste.

Use of the Enclosure1. Highwaterpressureandflowmayleadtoexcessivesplashingcausingwater

to escape outside of the enclosure.2. Incertaincircumstancessuchascleaning,watersprayeddirectlyattheseals

mayescapeoutsideoftheenclosure.3. Withanywalk in or openendedenclosure, splashingmay causewater to

escape outside of the enclosure.

Yourenclosurehasthebenefitofourguaranteewhichstartsfromdateofpurchase.For terms and conditions refer to the guarantee booklet packed with the product.

Guarantee

41317134-W2-B

Domestic ü

Light Commercial ü

HeavyCommercial û

Healthcare û

Recommended Usage

Tools Required

6.0 mm

5 1317134-W2-B

Pack Contents

X 8 q X 8 q

X 1 q X 1 qX 1 q(4.0 mm)(3.0 mm)

X 2 q

X 8 q

Top Carriers Bottom Carriers

Glass lintel brackets andcovers

X 2 q

X 2 q

X 2 q

X 2 q

X 4 q X 8 q

X 4 q

X 2 q

X 2 q

X 2 q

X 4 q

61317134-W2-B

X 2 q

X 2 q

X 2 q X 1 q

X 1 q

X 1 q

X 1 q

A

7 1317134-W2-B

X 1 q X 1 q

B

81317134-W2-B

Installation

Note!Coverthetraywastetopreventthelossofsmallparts.Note!Protectthetraysurfaceduringenclosureinstallation.

Note! Makesurethatthewallshavebeentileddowntothetray. MakesuretheTrayisleveled.Makesurethewallsareflatandsquare.

(a) Installtheshowertrayinaccordancewiththemanufacturer’sinstructions. Caution!Makesurethattheshowertrayislevelinalldirectionsandthatthe

wallsareverticalandsquare.

a

b

± 0 mm

1

9 1317134-W2-B

Adjustment Dimensions

Note! All dimensions shown are in mm.

Min/MaxFrameAdjustment Enclosure Size MinimumX(mm) MaximumX(mm)

20 900 x 900870870

890890

20 1000 x 800970770

990790

20 1000 x 1000970970

990990

20 1200 x 9001170870

1190890

Door Configuration Table (ALWAYS AS BELOW)

900 X 900 Openstowardscurved(larger)panel

1000 X 1000 Openstowardscurved(larger)panel

1000 X 800 Openstowardscurved(larger)panel

1200 X 900 Openstowardscurved(shorter)panel

X (From Tiled Wall)

X(From Tiled

Wall)

101317134-W2-B

b

c

a

d

x4

x4

6 mm

± 0 mm

x4

x4

2

6.0 mm

(a) Positionthewallchannelonthewallusingthedimensionssuppliedintheabovetableonpage10forcorrectenclosuresize.Usingaspiritlevelmakesurethatit is upright.

(b) Markthepositionofthefixingholes,thenremovethewallchannel.(c) Drillwitha6mmmasonrybit (notsupplied)andplugusing thewallplugs

(supplied).(d) Position thewall channelon thewallandpartially install thefixingscrews.

Ensurethatthescrewheadspacersarefittedtothescrews.(e) Applysiliconesealantaccordingtothemanufacturersinstructionsalongthe

length of the wall and at the bottom of the wall channel.(f) Ensurespacersareonthescrews.Fullytightenthefixingscrews,makingsure

that the wall channel is upright.

Screw Head Spacer

Note! Ensure longer face of wall channel is on the outside of the enclosure.

Note! Trimwallplugstofinishedwallsurface, as wall channel will not sit flatiftheyareproud.

Note!Usehandscrewdriveronlytoavoiddamagetoplasticspacers.

11 1317134-W2-B

6.0 mm

3

b

c

a

d

x4

x4

6 mm

x4

x4

(a) Position the second wall channel on the wall using the dimensions supplied intheabovetableonpage10forcorrectenclosuresize.Usingaspiritlevelmake sure that it is upright.

(b) Markthepositionofthefixingholes,thenremovethewallchannel.(c) Drillwitha6mmmasonrybit (notsupplied)andplugusing thewallplugs

(supplied).(d) Positionthewallchannelonthewallandpartiallyinstallthefixingscrews.(e) Applysiliconesealantaccordingtothemanufacturersinstructionsalongthe

length of the wall and at the bottom of the wall channel.(f) Ensurespacersareonthescrews.Fullytightenthefixingscrews,makingsure

that the wall channel is upright.

± 0 mm

Screw Head Spacer

Note! Trim wall plugstofinishedwall surface, as wall channel will not sit flatiftheyareproud.

Note! Ensure longer face of the wall channel is on outside of the enclosure.

Note! Use hand screwdriveronlytoavoiddamagetotheplastic spacers.

121317134-W2-B

4

(a) DecideonwhetheryourdoorwillbeLHorRHopening.(b) Install the top and bottom carriers as shown in the above diagram.(pre

assembled in parts pack)(c) Installthebottomcarrierslooselyondoor.(d) Installthecoversontoallthecarriers.(e) Toaidassemblylater,placetheassembleddoorinsidetheenclosure/tray

area(leancarefullyagainstwall).

x2

Note! The door on the enclosure is reversible and can be altered to suit your configuration. See the door opening table on page 9 for your door opening options

Note! Ensure carriers are mounted levelandstraightontheglass.

Note! Slider blocks should be on theouterofthecurve.

x2

3.0 mm

13 1317134-W2-B

b

a

b

12 mm

c

d

(a) Use the glass lintel bracket as a guide, place at the end of the glass panel, as illustrated.

(b) Push gaskets onto the glass and up to glass lintel bracket to get yourmeasurement. (12 mm as shown)

(c) Removeglasslintelbracketforlateruse.

5 Prepare the fixed panels for installation, fitting the panel gaskets.

Note! SmallfinongasketstofaceINSIDE of enclosure.

141317134-W2-B

6

bb

c

1

2

3

4

d

(a) Select the lintels for top and bottom as per yourglassconfiguration.(b) Place the opening and closing glass panels

into the wall channel while positioning on the bottom lintel with cutouts on glass.

(c) Place the back plates on the internal side of glass on both panels and tighten the two screws on each side.

(d) Screw the 2 glass lintel brackets into place onto the bottom lintel.(e) Makesureproperalignmentofthetwoglasspanelsandthebottomrail

alongthetray.(f) MakesurethatglasspanelsaresetinsideLshapebracket.(g) Insert the glass lollipops spacers (1) with serrations facing inside unit.(h) Placeretainingblock(2)overtheglass.(i) Fit the screws (3). (j) Fitthecover(4).

x2 x2x4

Glass lintel bracket

3.0 mm

Note! Be careful not to lose the lollipop down the wall channel.

Note! The lollipop must sit within the thickness of the glass, pushing it too far in will result in the top bracket not being able to locate down.

Note! Push the narrow side of the coversonfirst,tightlyfitting.

± 0 mm

15 1317134-W2-B

± 0 mm

a

b

d

(a) Position the top lintel with the cutouts on the glass.(b) Place the back plates on the internal side of glass on both panels and tighten

the two screws on each side.(c) Usingaspiritlevelmakesurethatbothglasspanelsareuprightandthetop

lintelislevel.(d) Screw the two glass lintel brackets into place onto the top lintel.

x2 x2x4

± 0 mm

7

3.0 mm

Fitting the top lintel

Note! Shouldyourtoplintelnotbelevel,youcan use the packers (supplied). See next page for details.

161317134-W2-B

(a) Loosen the screws and pull up the top lintel.(b) Locate the support packer onto the gasket.(c) Pullbackthetoplintelandmeasurethelevel.

a

b

± 0mm

c

Support packers for top lintel level

Afterpositioningthetoplintelwiththecutoutsontheglass,youneedtoensurethelevelbeforefullytighteningthetwoscrewsoneachside.Thesupportpackersareanoptiontogetthelintelfullylevel.Pleasefollowsteps below to install the support packers.

17 1317134-W2-B

8

H2 O

H 2O

(a) Pushinthebeadingsealsusingtherollerprovidedforbothchannelsontheinside of the enclosure, starting at the bottom and working upwards.

(b) Makesurethatboththeglasspanelsarelevelandequalaboutthetray.

± 0 mm

Important!Wet the beading seal to help with installation.

Note! Prior to beading, ensure thattheglasspanelsarelevelwiththeedgesofthetray.

The ribs on the beading go towards the glass.

Insideview

Insideview

181317134-W2-B

9

(a) Turntheslidingdoor(pre-installedwithcarriers)soitisinthecorrectorientation.As determined in step 4.

(b) Mounttheslidingdoorontothetoplintel.(c) Carefullypushthebottomdoorcarriersintothebottomlintel,pressingdown

on the carriers as required.(d) Adjust thedoor levelby rotating theadjustmentscrewson topof thedoor.

Clockwise=LowerDoor.Anti-clockwise=RaiseDoor.(e) Thebottomcarrierscanbeadjustedindividually.Ifrequiredloosenthebolts

andmovethecarriersupordownontheglass,whenthedesiredpositionisachievedre-tightenthebolts.

(f) Oncealladjustmentshavebeenmade,ensurethedooredgesarevertical.

a

h

c

b

4.0 mm

b

RaiseDoor-AntiClockwiseLowerDoor-Clockwise

Note! Ensure that lintel is free from debris.

Note! Avoidoveradjustment of the levelingscrews.This will ensure there is no contact between the lintel and the metal slider carriages. Note! Apply the supplied

lubricant in the three marked locations. This is critical to ensure smooth operation of the door. Move the door left and right to distribute the lubricant over the length of the track.

d

g

19 1317134-W2-B

(g) Fitcarriercovers.(h) Apply thesupplied lubricantwithin the trackwayof the lintelat the3spots

detailedabove.Movethedoorleftandrighttodistributethelubricant.

(a) Fit anti jump strip on the top lintel.

VIEW FROM INSIDE OF ENCLOSURE

Anti Jump Strip10

201317134-W2-B

11 Handle Installation

2.0 mm

a

c

b

Note! Handle installations are the same for all the handle options.

21 1317134-W2-B

12

(a) Fitthe3verticalsealsasshownabove.

Door Closing verticalSeal

Rear door verticalseal

Inline panel verticalseal

221317134-W2-B

13

(a) Applysealantinaccordancewiththesealantmanufacturersinstructionsalongtheoutsidesurfacesofthedoorframeonly.

(b) Allow the silicone sealant to cure for 24 hours before use.

23 1317134-W2-B

MaintenanceGeneral MaintenanceProviding the shower enclosure hasbeen correctly installed and is operated inaccordancewiththeinstructionscontainedinthisguide,difficultiesshouldnotarise.Ifanymaintenanceisrequiredthenitmustbecarriedoutbyacompetenttradespersontowhomthemaintenanceinstructionsareprovided.Beforereplacinganypartsensuretheunderlyingcauseofthemalfunctionhasbeenresolved.Ifthedoorbecomesdifficulttoslide,thenapplymorelubrication.

KOHLER Glass CleanerFor occasional cleaning of glass treated with KOHLER Glass Protector or for more regular maintenance of untreated surfaces, we recommend using KOHLER Glass Cleaner.

The cleaner cleans and polishes without smearing or streakingandrejuvenatestheGlassProtector.

Chrome PartsUseonlycleansersexpresslyspecifiedforchrome!

CareTopreservethebeautyofyourshowerenclosureformanyyears,pleaseobservethe following care instructions:Rinseglassand framewithclearwateraftershowering.Removewaterdropletswith a squeegee. Do not rub dry!Tocleanyourshowerhygienicallyandeasily,werecommend the use of a biodegradable cleanser.Regular cleansingwith a biodegradable cleanser prevents stubborn stains andensuresacleanandhygienicsurfaceformanyyears.Donotusescouringorcausticcleansersunderanycircumstances!Thesecandamagethesurfaceoftheframe,glassanddecorativepartsaswellastheplasticparts.

CleaningWarning!Theuseofgrout/tilecleaners,scaleremovers,abrasivescourers,drainunblockersandotherpowerfuldetergentsmayleadtodamageofmetallic,platedandplasticsurfaces,includingthetrayandshowerwaste.Avoidtheuseof‘sprayandleave’cleaners.AnycleanerusedshouldhaveapHlevelbetween4and8andimmediatelywipeddryusingasoftcloth.

241317134-W2-B

Spare Parts12

33

7

9

64

54

2

5

1

25 1317134-W2-B

Part Numbers1 4.1922.094 SpareQuadLintelPack-Pair2 4.1922.079 Spare Slider Enclosure Parts Pack3 4.1922.057 Spare Glazing Bead Pack4 4.1922.096 Spare Quad Seal Pack5 4.1922.095 Spare Quad Carriers Pack6 4.1922.099 Spare Quad Anti Jump7 4.1922.141 Spare Fixing Pack8 4.1922.108 Spare Lubrication

9 4.1922.144 SpareGlassLintelBrackets,ScrewsandCovers.(x4 of each)

261317134-W2-B

Notes

27 1317134-W2-B

Declaration of Performance

281317134-W2-B KohlerMiraLimited,August2018

18Kohler Mira Ltd, Cromwell Road, Cheltenham,

Gloucestershire GL52 5EP, UK

KOHLERMira Ascend & Composed Shower Enclosures

& Bath ScreensDeclaration of Performance: CE 0120

EN 14428:2015