Xiaomi Redmi Note Headphone Jack Replacement ... Step 1 ¢â‚¬â€‌...

Click here to load reader

download Xiaomi Redmi Note Headphone Jack Replacement ... Step 1 ¢â‚¬â€‌ Battery Make sure the Xiaomi Redmi Note

of 11

  • date post

    03-Apr-2020
  • Category

    Documents

  • view

    2
  • download

    0

Embed Size (px)

Transcript of Xiaomi Redmi Note Headphone Jack Replacement ... Step 1 ¢â‚¬â€‌...

  • Xiaomi Redmi Note Headphone Jack Replacement

    This guide will show how to replace the headphone jack on the Xiaomi Redmi Note.

    Written By: Zongyi Li

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 1 of 11

  • INTRODUCTION

    This guide will show how to replace the headphone jack. This guide requires soldering and desoldering the part.

    TOOLS: iFixit Opening Tools (1) Phillips #00 Screwdriver (1) Tweezers (1) Soldering Workstation (1)

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 2 of 11

    file:///Store/Tools/iFixit-Opening-Tool/IF145-335?o=2 file:///Store/Tools/Phillips-00-Screwdriver/IF145-006?o=4 file:///Store/Tools/Tweezers/IF145-020?o=5 file:///Store/Tools/Soldering-Workstation/IF145-238?o=2

  • Step 1 — Battery

    Make sure the Xiaomi Redmi Note is powered off before removing the battery.

    Insert the plastic opening tool between the charging port and the rear case.

    Pry the end of the rear case up from the charging port.

    Step 2

    Run the plastic opening tool along the seam on the side of the phone to remove the rear casing.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 3 of 11

  • Step 3

    Locate the indentation at the bottom of the battery.

    Place a finger in the indentation and lift up to remove the battery.

    Step 4 — Midframe

    Remove twelve 3.5mm Phillips #00 screws from the midframe.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 4 of 11

  • Step 5

    Insert a plastic opening into the seam between the midframe and the bottom frame of the phone.

    Run the plastic opening tool along the seam.

    Pry up the midframe with the plastic opening tool.

    Once the midframe has been sufficiently lifted with the tool, place a hand underneath the edge to lift the entire component out of the frame.

    There will be snapping sounds as the clips on the midframe disconnect from the phone.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 5 of 11

  • Step 6 — Front-Facing Camera

    Use tweezers to lift the retaining flap of the zero insertion force (ZIF) connector to the upright position.

    Use tweezers to pull the ribbon cable out of the ZIF connector.

    Remove the front-facing camera from the motherboard.

    Step 7 — Rear Camera

    Disconnect the rear-facing camera from the motherboard by pulling out the press-fit connector to its left.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 6 of 11

  • Step 8 — Motherboard

    Locate the three ZIF connectors on the motherboard.

    Step 9

    Use tweezers to lift the retaining flap on the ZIF connector to the upright position.

    Pull the ribbon cable out of the connector by pulling to the left.

    Repeat these steps for the other two ZIF connectors.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 7 of 11

  • Step 10

    Locate the antenna cable on the bottom right of the motherboard and use tweezers to lift the cable off of the motherboard.

    Step 11

    Remove the two 2.9mm Philips #00 screws.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 8 of 11

  • Step 12

    Flip over the motherboard to reveal the back.

    Use a plastic opening tool to pry off the snap fit connector, located on the bottom right off of the motherboard.

    Step 13

    Lift up the motherboard and turn it over to place it by the side of the phone.

    Do not attempt to remove the motherboard at this stage. Pulling on the board can damage its connection to the vibrating motor.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 9 of 11

  • Step 14

    Use tweezers to peel the vibrating motor off the frame of the phone.

    The vibrating motor is glued to the frame, so do not be afraid to use force to dislodge it.

    Step 15 — Headphone Jack

    Flip over the motherboard and locate the headphone jack at the top left corner.

    Desolder the 6 soldered connections on the sides of the headphone jack from the motherboard.

    Learn how to solder and desolder here.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 10 of 11

    https://www.ifixit.com/Guide/How+To+Solder+and+Desolder+Connections/750

  • To reassemble your device, follow these instructions in reverse order.

    Step 16

    Use tweezers to pull off the headphone jack from the motherboard.

    Xiaomi Redmi Note Headphone Jack Replacement Draft: 2018-07-25Guide ID: 89006 -

    This document was generated on 2019-09-28 11:24:08 PM (MST).

    © iFixit — CC BY-NC-SA www.iFixit.com Page 11 of 11

    Xiaomi Redmi Note Headphone Jack Replacement Written By: Zongyi Li INTRODUCTION

    TOOLS: Step 1 — Battery Step 2 Step 3 Step 4 — Midframe Step 5 Step 6 — Front-Facing Camera Step 7 — Rear Camera Step 8 — Motherboard Step 9 Step 10 Step 11 Step 12 Step 13 Step 14 Step 15 — Headphone Jack Step 16