WHEEL-HORSE PRODUCTS, INC.

OWNERS MANUAL

CHARGER 9

MODEL

1·7931

SOUTH BEND, IND.

A. The tractor is wheel and tire

separate carton.

B.

ASSEMBLY

BATTERY

one carton with the Part No. in a

the ten

caps. Remove or any seal-

NOTE: time of

been used to close or re-

to level

of and at be above 60°F. Never fill bat-

3. BOOST CHARGE: 15 amps. for 10 minutes or 7 amps. for 30 minutes. if necessary, after

4. Install rear of tractor.

service, add

DO NOT ADD ACID.

TIRES

front 16 x and

has been

f1ated to air pressure. The rear tires are 8.50 x 12 and should have 6 to 8 pg'Lnl~UIi

BEFORE YOU

the Tnt:tnrv

Manual.

2

Wheel-a-Matic Transmission: The transmission been filled with Automatic Transmission fluid at the

is "A" automatic which is used in automobiles and at any service

A. Remove cated under and insert

I). Now check level make sure transmission is filled

,hr,ft',..;;", all grease lubricant every to ten hours of nn,,,.,.,,,,tin

Refer to IV for the location

should be used where

OPERATING INSTRUCTIONS

direction and are controlled control handle located on the

To go Forward the control handle Forward.

• To go Backward the control handle Back.

To control handle in Neutral

• You may also the tractor at the foot on the left side.

The tractor is affected ment of the control handle. For safest control handle should not be moved too

on

TOWING INSTRUCTIONS

This tractor should never be towed or DUlsne,a with-out first the valve.

A. The face of the

is located on the sur-or tow directions

B. CAUTION: Do not tow for distance or over a of seven miles per hour.

STARTING ENGINE

the a

valve on gas tank.

2. The tractor has a all way to

Pull throttle lever ~ way out and to the to lock it in Note: The throttle control

device. Turn the throttle control to the to the desired and turn

4. Pull choke lever the out to choke en· If is warm been

be

5. choke in to off to the

or out to desired

6. When in cold weather the

• Use

the and the not have to turn the transmission.

PARKING BRAKE

creep. released. Caution: Do

to the transmission. left before

TRANSMISSION CARE

oil filter after first ten hours. every year or 100 hours of

as

JtAJt outomatic transmission oil.

• Check oil and maintain at proper level as indicated on

1 fer to Check

CARE OF TRACTOR

air cleaner This will add to

3. structions.

tires

4. tractor covered and nof in use.

5. these

a

6. grass and dirt off transmission transmission

7. level

NOTE: If tractor has been in necessary

8. Control Handle Friction

when

may be

The control lever is friction loaded so The tension been

should

force at control lever. Be sure to

tension has and

nof lubricotion.

9. Neutral

A. If tion this

should creep while neutral corrected. To check for creep

not

surface and de· and can·

B. To make neutral

Block

2. Remove of the which hold it.

3. loosen set screw in arm with allen

4.

5.

on

and

front

ng1ogled, insert screwdriver cam and rotate

until rear wheels set screw in arm and re-

6. NOTE: The on the proper

must be

7.

8. Your tractor is as as the you it. See your Wheel Horse for a after each season of use.

AnACHING TOOLS

All drawn ........ I .. 'n"'nt'" attach seconds .

3-

SAFETY SUGGESTIONS Recommended by Power Eq'lip,nellt

Know controls and how to read the owners manual.

2. not allow children to nor adults it without proper instruction.

3. Clear work of which be up and thrown.

4. all clutches and shift into neutral before away from power driven

5. Do not carry passengers. a safe distance away.

and

children and

6. Never direct of any material toward allow anyone near machine

in or area to another.

10. alert and other hidden Know what is behind you, before

11. Beware of reduce and to

control. 12. Don't or start ""nn,,,n

or downhill. 13. Use care when loads or

and

un­away,

14. Watch out for traffic when near rOI~d'wrlv;;:

4

1 flammable.

a.

with care it is

container.

b. motor -up

c. cap

d. garage gases

machine in devices in

in owner's manual.

p CI,FICATIONS

Overall Wheelbase """"'" ....• " .. , ...•.•........ Width Overall ... ........ . ...................... 36

inches inches

. , , ., ... ,' . .,.33 inches

Ibs. Crop Clearance .... ,

........... 13

H.P.

Engine Oil Capacity . """" .. 2.5 Fuel Capacity .. ., . , . , ,. " . .,', ... .6 quarts

5.50-8 Pneumatic wheel (rear) Terra-Type 8.50 x 12" Pneumatic: (23" wheel dia.)

forward 0 to 7 Reverse 0 to M.P,H.

Turning Radius outside of outside wheel) .....••. ,.... ..6'

FIG. I

FIG. II FIG. III

-5 -

HOOD RELEASE

Fig. IV

-6-

7

8

&

9

pages 12 and 13 for Transmission break down Parts

When ordering olways list Part name

Item Port Item No. No. No. No. Req'd.

7627 59 7665 60 6825 61

12 62 932120·4 5 14 3926 6 3988 1

7 6 936125 2 8 9

10 8

4 4

6 6465 937022 2

2 920081·4 2 7432 1 6129 2 3 920009·4 6

82 83 84

5631 85 3 86

30 31 3 6 32 33 2 34 2

1

6472 x X 5628 5629 915002.6 4

Neutral

44 2 1230 45 Rod Neutral 5450 46 Hairpin 5458 47 Hairpin 7 4 48 933188 Roll 106 49 5448 Ass'y. 107

Plunger 108 109 110 4

10.16 4

1

2 5186

57 Pin

58

o

154 7229 155 156 7185 157 3023 158 7618 159 160 161 162 163 164 165 166 167 168

175

pages 12 and 13 for Transmission break down and Parts

Screw Self Tap

Clip Connector Three

ordering parts always list Pari No.

No. Req'd.

1 2 I

4

2 2

4

5

1 1 2

2 1

2 2

176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199

204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220

222 223 224 225 226 227 228

11-

Description

7464 latch fender

5977 7617 7616

7559

7417

7018 7019

7027 7230 5455

5467

933182

5438 5437 5432 5433 5434 5435 1004 Whe,,1 K6-2O

5637 Ass'y. Wheel, &

5635 Wheel

4999 Beoring Boll

5636 Tire 16 5.50-8 5512 Tube

2844 Washer

2816 7420 Wheel

7469 933215 937014 7468 7561 7568

7477 5604 7421 7634 7633

No. Req'd.

2

2 2 1

2

ARTS LIS

(Order No. 5054 for Cemple,,, TI'Q1'I6mi$sion)

p<> rts P'Clrt No. Nome of

No, I'"m Req'd. No,

1.0.

Ball 2

2

LD. 2

I.D.

3915

6455

5960

2822 R.H.

2821

2819 2

2827

I.D,

2828 Thru.! ::1

645.0 Reelr

6451 Rear LH,

2920 Axl"

933217 Roll Pin >< 2

Block 64 971113

Gear 7267

5963 Gear -22

.'!964 Geor 33 Teeth

Shaft Die. 971015

1" Shaft 7054

971018

5999 71

72

73 7051

74 7050 CO"" 2

33 9151 7049 2

34 3

35 7152

36 7753 2

37 7754 2

5990

Pipe

Support &Iotk 7977

48" ROTARY MOWER

42" ROTARY MOWER

36" MOWER

37" THROWER 211)

50" SICKLE BAR MOWER 31

111 )

32" DISC 151

TILLER 2

2" PLOW 411

TRAILING CULTIVATOR 711

TWO SECTION CULTIVATOR 72

BLADE 1 1

TOOTH HARROW 161

4-WHEEl UTILITY WAGON

2-WHEEl TRAILER

SPIKED DISC AERATOR

LAWN ROLLER 1)

FRONT AND REAR WHEEL DISCS 1)

FRONT

ATTACHMENT CLUTCH

TIRE CHAINS

HYDRAULIC POWER LIFT 11

WHEelS 1

· .

..

15

Printed in U.S.A. 8-14-67 FORM NO. 396