v50-manual · Title: v50-manual.tif Created Date: 12/13/2002 18:48:27
TP3999202 2007 S40 V50 C70 Wiring Diagram
324
2007 VOLVO WIRING DIAGRAM S40 (04-)/V50/C70 (06-) TP 3999202
-
Upload
anonymous-ziv78l1ui -
Category
Documents
-
view
111 -
download
28
description
Volvo S40 V50 and C70 eletrical wiring diagram
Transcript of TP3999202 2007 S40 V50 C70 Wiring Diagram
-
2007
VOLVO
WIRING DIAGRAM S40 (04-)/V50/C70 (06-)TP 3999202
-
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)
Warning!Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:1. Personal injuries when performing repair work.2. Damage or malfunction of the SRS/SIPS bag/IC system.Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop.In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations Be especially careful when working on or around SRS, SIPS, and IC components. Make sure that no wires are pinched, frayed, or pierced. Never install accessories by the sensors. Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA. Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA. Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminalData link connector in the passenger compartment.
Changes introduced up to April 2006Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands.This manual may therefore include illustrations and text that do not apply to the vehicles in your country.
Order number TP 3999202Replaces previous publication 3999201 at Electronic Wiring Diagram (EWD) Volvo Car Corporation
TP 39101001Also available at Electronic Wiring Diagram (EWD) TP 39102001
We retain the right to make modifications.
-
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)..................................................... 2Abbreviations................................................................. 7How to use the wiring diagrams 1:2............................... 8Electrical distribution 1:2.............................................. 10
FusesEngine compartment distribution box F1-F10............... 12Engine compartment distribution box F11-F18............. 13Engine compartment distribution box F20-F31............. 14Engine compartment distribution box F32-F34............. 15Engine compartment distribution box F35-FH1 ............ 16Central Electronic Module (CEM) F43-F49................... 17Central Electronic Module (CEM) F51-F63................... 18Central Electronic Module (CEM) F64-F74................... 19Central Electronic Module (CEM) F77-F86................... 20Battery PF1-PF2........................................................... 21
RelaysIgnition switch and relays............................................. 22Distribution box in engine compartment R2-R14......... 23Central Electronic Module (CEM) R15-R18................. 24Central Electronic Module (CEM) R1-R11B ................ 25Other relays ................................................................. 26
Ground connectionsOverview...................................................................... 2731/3 - 31/10 ................................................................. 2831/11 - 31/52 ............................................................... 2931/66 - 31/67 ............................................................... 3031/80 - 31/107 ............................................................. 3131/110 - 31/116 ........................................................... 3231/117 - Ground connections in chassis...................... 33
Control modulesOverview of locations................................................... 34Overview of designations............................................. 35Central Electronic Module (CEM) 1:2 ........................ 36Data communication, Low speed CAN 1:2 ................ 38Data communication, High speed CAN ..................... 40Data communication, MOST S40/V50 ...................... 41Data communication, MOST C70................................ 42Data communication, LIN 1:2 .................................... 43Start Control Module (SCU) ....................................... 45Accessory Electronic Module (AEM) ......................... 46
Group 23 Fuel systemEngine management system Diesel, 5-cyl. 2.4l 1:3..... 47Engine management system, 4-cyl. 1.6l 1:2................ 50Engine management system, 4-cyl. 1.8l & 2.0l 1:2...... 52
Engine management system, 5-cyl. 1:2....................... 54Engine management system, 5-cyl. Turbo 1:2 ............ 56Engine management system Diesel, 4-cyl. 1.6l 1:2 ..... 58Engine management system Diesel, 4-cyl. 2.0l 1:2 ..... 60Emission control, 4-cyl. 1.6l ......................................... 62Emission control, 4-cyl. 1.8l & 2.0l ............................... 63Emission control, 5-cyl. ................................................ 64Emission control, 5-cyl. Turbo...................................... 65
Group 26 Cooling systemCooling fan................................................................... 66Cooling fan Diesel........................................................ 67
Group 27 Engine controlCruise control, 4-cyl. .....................................................68Cruise control, 5-cyl. .....................................................69
Group 32 Alternator and voltage regulatorPower supply, 4-cyl...................................................... 70Power supply, 5-cyl...................................................... 71
Group 33 Starting systemStarting system, 4-cyl................................................... 72Starting system, 5-cyl................................................... 73Starting system, 5-cyl. Diesel....................................... 74
Group 35 LightingFollow-me-home lighting.............................................. 75High and low beam ...................................................... 76High and low beam (Bi-Xenon) .................................... 77Manual beam length adjustment.................................. 78Automatic beam length adjustment (Bi-Xenon) ........... 79Position/Parking lights, Tail lights S40/V50 ................. 80Position/Parking lights, Tail lights (Bi-Xenon) S40/V50 ...................................................................... 81Position/Parking lights, Tail lights C70......................... 82Position/Parking lights, Tail lights (Bi-Xenon) C70....... 83Fog lights S40/V50 ...................................................... 84Fog lights C70.............................................................. 85Fog lights LHD, Japan S40/V50................................... 86Fog lights LHD, Japan C70.......................................... 87Brake lights S40/V50 ................................................... 88Brake lights C70 .......................................................... 89Reversing lights S40/V50............................................. 90Reversing lights C70.................................................... 91Interior lighting S40/V50 1:2 ........................................ 92Interior lighting C70 1:2................................................ 94Instrument and control illumination .............................. 96Auxiliary lights .............................................................. 97
Table of Contents 1:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 3
-
Group 36 Additional electrical equipmentDirection indicators and hazard warning flashers S40/V50 ...................................................................... 98Direction indicators and hazard warning flashers (Bi-Xenon) S40/V50 .................................................... 99Direction indicators and hazard warning flashers C70 ...................................................................... 100Direction indicators and hazard warning flashers (Bi-Xenon) C70 ......................................................... 101Windshield wiper/washer ........................................... 102Headlight washer ....................................................... 103Rear window wiper/washer V50 ................................ 104Rain sensor................................................................ 105Horn ...................................................................... 106Immobilizer/Steering column lock module (SCL) ...... 107Keyless vehicle S40/V50 1:2 ..................................... 108Keyless vehicle C70 1:2 ............................................ 110Rear parking assistance ............................................ 112Front parking assistance............................................ 113Anti-theft alarm S40/V50............................................ 114Anti-theft alarm C70................................................... 115Accessory Electronic Module (AEM) ......................... 116
Group 37 Wiring and fuses12V outlet S40/V50.................................................... 11712V outlet C70........................................................... 118Diagnostics system.................................................... 119Tow hitch cable harness, 4-pin .................................. 120Tow hitch cable harness, 7-pin .................................. 121Tow hitch cable harness, 13-pin ............................... 122
Group 38 InstrumentsDriver information module.......................................... 123Seat belt reminder S40/V50....................................... 124Seat belt reminder C70.............................................. 125
Group 39 OtherAudio S40/V50 1:2..................................................... 126Audio C70 1:2............................................................ 128Audio High Performance/Premium Sound S40/V50 1:2 ............................................................... 130Audio High Performance/Premium Sound C70 1:2 ... 132Cellular phone 1:2...................................................... 134Satellite radio ............................................................. 136
Multimedia & Traffic information .............................. 137Turn by Turn navigation, Audio.................................. 138Turn by Turn navigation, Audio High Performance/Premium Sound ......................................................... 139Handsfree Universal, Audio ....................................... 140Handsfree Universal, Audio High Performance/Premium Sound ......................................................... 141Handsfree Max with Adapter...................................... 142Handsfree Max .......................................................... 143Subwoofer.................................................................. 144
Group 43 TransmissionAutomatic transmission AW55-51.............................. 145Transmission M66...................................................... 146Differential Electronic Module (DEM)......................... 147
Group 59 Brake systemBrake control system & STC...................................... 148Brake control system & DSTC ................................... 149
Group 64 SteeringElectronic power steering........................................... 150
Group 83 Doors and openingsCentral locking, front doors S40/V50 ......................... 151Central locking, rear doors S40/V50.......................... 152Central locking system C70 ....................................... 153Central locking, tailgate S40/V50............................... 154Central locking, tailgate C70...................................... 155Central locking, storage compartment C70................ 156Child safety lock S40/V50.......................................... 157Central locking, fuel filler flap ..................................... 158Signal receiver, remote-control, central locking......... 159Power windows, front doors S40/V50........................ 160Power windows, front doors C70 ............................... 161Power windows, rear doors S40/V50......................... 162Power sunroof S40/V50............................................. 163Power roof C70.......................................................... 164
Group 84 Exterior decorative elements, etc.Power door mirrors S40/V50...................................... 165Power door mirrors C70............................................. 166Heated door mirrors ................................................... 167Heated rear window................................................... 168Blind Spot Information System................................... 169
Table of Contents 2:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 4
-
Group 85 Interior equipmentPower drivers seat with memory function LHD S40/V50 .................................................................... 170Power drivers seat with memory function RHD S40/V50 ................................................................... 171Power drivers seat with memory function LHD C70 ...................................................................... 172Power drivers seat with memory function RHD C70 ...................................................................... 173Power passenger seat with memory function LHD C70 ...................................................................... 174Power passenger seat with memory function RHD C70 ...................................................................... 175Power drivers seat LHD............................................ 176Power drivers seat RHD ........................................... 177Power passenger seat LHD....................................... 178Power passenger seat RHD ...................................... 179Heated seats.............................................................. 180
Group 87 Climate control systemClimate control system PTC element ...................... 181Climate control system, 4-cyl. Gasoline 1:2............... 182Climate control system, 5-cyl. 1:2.............................. 184Climate control system, Diesel 1.6l & 2.0l 1:2 ........... 186Parking heater, auxiliary heater ................................. 188Relay, electric engine heater ..................................... 189Electric engine heater Flexifuel.................................. 190
Group 88 Internal equipmentAuto-dimming rearview mirror.................................... 191Supplemental Restraint System Module (SRS) S40/V50 1:2 ............................................................... 192Supplemental Restraint System Module (SRS) C70 1:2 ...................................................................... 193
Connectors .............................................. 195
Branching points .....................................229
Cable harness routing in vehicleEngine harness Gasoline, 4-cyl. 1.6l ........................240Engine harness Gasoline, 4-cyl. 1.8l ........................240Engine harness Gasoline, 5-cyl. .................................241Engine harness Gasoline, 5-cyl., Turbo......................241Engine harness Diesel 1.6l .........................................242Engine harness Diesel 2.0l .........................................242Engine harness Diesel 2.4l .........................................243Engine compartment harness, 4-cyl. ..........................244Engine compartment harness, 5-cyl. .........................244Dashboard harness LHD ............................................245Dashboard harness RHD............................................245Floor harness S40 LHD ..............................................246Floor harness S40 RHD..............................................247Floor harness V50 LHD ..............................................248Floor harness V50 RHD..............................................249Floor harness C70 LHD ..............................................250Floor harness C70 RHD..............................................251Roof harness S40 .......................................................252Roof harness V50 .......................................................252Tunnel harness S40/V50 ............................................253Tunnel harness C70 ...................................................253Drivers door harness S40/V50...................................254Passenger door harness S40/V50..............................254Drivers door harness C70 ..........................................255Drivers door harness supplement C70.......................255Passenger door harness C70 .....................................256Passenger door harness supplement C70..................256Rear right door harness S40/V50 ...............................257Rear left door harness S40/V50..................................257Harness, rear side panel, left C70 ..............................258Harness, rear side panel, right C70 ............................258Tailgate harness C70..................................................260Tailgate harness S40..................................................259Tailgate harness V50..................................................259
Component illustrations ..........................261
Index 1:2 ....................................................316
List of components 1:6 ............................318
Table of Contents 3:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 5
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 6
-
GroupsGroup 23 = Fuel systemGroup 26 = Cooling systemGroup 27 = Engine controlsGroup 32 = Alternator and voltage regulatorGroup 33 = Starting systemGroup 35 = LightingGroup 36 = Additional electrical equipmentGroup 37 = Wiring and fusesGroup 38 = InstrumentsGroup 39 = OtherGroup 43 = TransmissionGroup 59 = Brake systemGroup 64 = SteeringGroup 83 = Doors and openingsGroup 84 = Exterior decorative elements, etc.Group 85 = Interior equipmentGroup 87 = Climate control systemGroup 88 = Internal equipment
Ignition switch symbolsX = Accessories (audio position)S = Powered upon insertion of key15 = Contact remains connected during
start15l = Contact is broken while starting30 = Constant power from the battery50 = Start
Countries/MarketsA = AustriaAUS = AustraliaB = BelgiumCDN = CanadaCH = SwitzerlandD = GermanyDK = DenmarkE = SpainEU/OS = Markets outside USA and CanadaFIN = FinlandGB = Great BritainISR = IsraelJ = JapanKOR = KoreaN = NorwayNL = NetherlandsS = SwedenUSA = United States of AmericaWEU = Western Europe
OtherAUTO = Automatic transmissionAWD = All wheel driveCAN = CAN communicationD = DieselDPY = DisplayECC = Electronic climate control systemETA = Engine throttle bodyEXT. X = Extended X-feedGDL = Gas discharge lampHISPEED = High speed data busIR = Infrared sensorLIN = LIN communicationLHD = Left-hand driveLOSPEED = Low speed data busMAN = Manual transmissionMEMORY = Memory drivers seatMMS = Mass Movement SensorGASOLINE = GasolineRHD = Right-hand driveSCR = ScreenedSRS = AirbagT = Turbocharged engineW/O = Without2WD = Two-wheel drive4CYL, I4 = 4-cylinder engine5CYL, I5 = 5-cylinder engine
ColorsBK, SB = BlackBN = BrownBU, BL = BlueGN = GreenGY, GR = GrayLGN = Light GreenOG, OR = OrangePK, P = PinkRD, R = RedVT, VO = VioletWH, W = WhiteYE, Y = Yellow
ExplanationsAbbreviationsTP 3999202 S40 (04-)/V50/C70 (06-) 2007 7
-
The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily con-tained in this manual.
How to use the wiring diagrams 1:2
A. Component designationEvery component has a component designation that consists of two parts.
The first part is a type number that describes the type of component in question, for example 3/xx.
The second part of the designation is a serial num-ber, e.g. x/2.
Together, this constitutes a component designation, e.g. 3/2.
At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.
List of type numbersThe list shows which type of component that respec-tive type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.
1 Battery2 Relay3 Switch4 Control module5 Driver information module6 Electric motor7 Sensor8 Actuator9 Heating element10 Light11 Fuse15 Electrical distribution rail/box16 Audio17 Service/diagnostics18 Contact reel19 Meter20 Ignition component/shunt27 Optics31 Ground connection63 Branching point64 Connector
B. Branching pointsThe wiring diagrams contain numbered junction points, e.g. 63/352.
This manual contains a section with a list of branch-ing points. This list shows all the components that are connected to each branching point.
The location of the branching points is shown in the "Cable harness routing in vehicle" section.
C. ConnectorsConnectors provide a bridge between two cable har-nesses and are described in the "Connectors" sec-tion.
D. Electrical distributionOperation of the fuses and relays is shown in the "Electrical distribution" section.
E. Data communicationTodays cars contain CAN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wir-ing diagram. Complete information on CAN and MOST communication is found in the section "Con-trol modules".
F. AbbreviationsA number of different abbreviations are used in the manual. These are explained in the section "Abbre-viations".
G. Component locationThere is a section at the end of the manual in which the appearance and location of components is described in numerical order.TP 3999202 S40 (04-)/V50/C70 (06-) 2007 8
-
How to use the wiring diagrams 2:2
Explanation of symbols= System voltage
= Ground connection via wiring
= Ground connection in component/chassis= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box= Further connection to...
= Connector between cable harnesses= Connector connected in component
LIN
CAN
1
1
G
EA C F B D
10/17-18
BK
GN-BK
CAN
CAN
63/211
31/11 31/12
F:14
F:16
D:14
D:15
A:6
A:8
TCM
4/28 30+
F18
2
11
2
F4
MAN
63/53
MAN
GN-YEGN-YE
64/90
10
31/52
E:14
4/56
CEM
3/10 1
2
GN-BKGN-BK
BK
V50
10/55
10/48
BK
V50
BK
F79
2
1
LIN
15/31
C:45
E:21
E:22
GN-BK
S40 S40
BK
BK
2/80
R2
TAIL
FOG
BACK
10/18
10/18
A:4
C:4
C:2
A:2
TAIL
FOG BACK
GND GND2
TURNSTOP
10/55
10/17
A:2
A:4
TAIL
FOGBACK
GNDGND2
TURNSTOP
10/48
TURN
STOP
A:2A:3 C:3 C:1
A:4
TAIL
FOG
BACK
10/17
C:2
C:4
TURN
STOP
A:2 A:3C:1C:3
A:4
C:4 C:2
A:1 C:1C:3C:4C:2C:1A:3C:3
V50V50
S40S40
LIN
3/156
64/90A:7 WH-RD RD
33
64/111
2A:2
LIN
3/155GSMWH-RD
AUTO
RD-YE
RD-BU
GN-BK
UP
UP
UP UPTP 3999202 S40 (04-)/V50/C70 (06-) 2007 9
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 10
FECA
14
39
GN-BU
GN-YE
B DElectrical distribution 1:2Overview
1
F36
F34
F35
F33
F32
3
2
5
5
3
1 2
35
1 2
F10
F17
F14
BK-WH
GN-BU
2/32
R14
R13
2/35
R10
2/82
F12
F13
F9
RD-OG
RD-OG
RD-GN
RD-OG
RD-OG
15/31
6/2550
31
M
ACM
30
B:16/26
B+
31
G
B:1
A:1
RD
RD
12V BK
31/3
1/1
BK
31/4
PF2 PF1
RD
RD-OG
40
64/90=15/31A
8/84:1
7/51:6
64/90=15/31A
11
4BK-RD
GY
64/90=15/31A
41
12
21BK-BU
GN-BU
GN-BU
GN-YE GN-YE
I4
I5
Diesel
Diesel
BK-RD
GN-BU
2
11
2
35
63/13
GN-YE
GN-YE
GN-YE
5cyl
I4 Diesel
64/90=
15/31A
31
64/90
9GN-BU
GN-BU
GN-BU
GN-BU
GN-BU
64/113
6GN-BU
6
B:11 B:29
B:17
B:33
ECM
4/46.1-3
CAN
LIN
5 CYL
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 11Electrical distribution 2:2Overview
RD-WH
RD-BK
RD-GN
RD-OG
RD-BU
RD-OG
RD-BU
21
3
5
3
1
5
2
3
1
5
2
2
5
3
1
CAN
CEM
4/56
LIN
BK-YE
G:11
C
G:18
E:29
E:9
E:30
3/1
30
15X
5
50 S
B:7
A:42
A:15
A:30
A:17
B:5
B:2 B:1
B:3
GY-BK
RD-GN
YE
GN-WH
64/111
5
G:9
E:22
E:23
E:20
E:21RD-YE
RD-BU
RD-WH
RD-OG
RD
RD
BK-BU
2/182R9
2/34R4
2/22R11
R2
2/17
F20
F26
F3
F30
F31
F2
F16
F6
F23
F4
F18
F27
F29
F11
F8
F7
F1
F5
F21
F28
F22
A
RD-OG
E
BK-WH
F
GN-BU
15/31
WH-BK
R5
F24
BK-RD
13
64/90=15/31A
RD
WH-BK
BK BK BK
GN-WH
OG-BU
23
64/90=15/31A
64/90=15/31A
RD
RD-WH
RD-WH
S40/V50
C70
RD13
17
64/90=15/31A
BK-YE
18GN-YE
BK-RD
B
64/861
1RD
D
GN-BU
16/10
63/121
63/231
63/120
16/11
GN-WH10/5:1
10/6:1
GN-YE6/104:1
35
1 2
2/142
64/113
7
31/114
I4 I5
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 12F30
F11
F8
F17
F15
F7
F13
F16
F9
F18
F14 F12 F10
F6
F5
F4
F3
F2
F1
F24 F21 F20 F22
F31
F25
F32
F33
F34
F35
F36
F29
F19
F28 F27 F26 F23
FusesEngine compartment distribution box F1-F10
15/31 Engine compartment distribution boxNo. Fuse function via AF1 4/71 Cooling fan control module - 50F2 6/71 Electrical Power Steering Module (EPS) - 80F3 2/193 Relay, comfort functions
F45 Fuse in the Central Electronic Module (CEM)F48-F49 Fuses in the Central Electronic Module (CEM)F60-F61 Fuses in the Central Electronic Module (CEM)F62-F63 Fuses in the Central Electronic Module (CEM)F68-F69 Fuses in the Central Electronic Module (CEM)F84-F85 Fuses in the Central Electronic Module (CEM)
-2/1932/1932/193
-2/193
-
60
F4 2/63 Relay, high beam4/56 Central Electronic Module (CEM)F55 Fuses in the Central Electronic Module (CEM)F58-F59 Fuses in the Central Electronic Module (CEM)F74 Fuses in the Central Electronic Module (CEM)F77 Fuses in the Central Electronic Module (CEM)
---
2/63--
60
F5 9/41 PTC-element - 80F6 4/109 Glow plug control module, 4-cyl. Diesel
4/109 Glow plug control module, 5-cyl. Diesel--
6070
F7 4/16 Brake Control Module (BCM), pump - 30F8 4/16 Brake Control Module (BCM), valves - 20F9 2/32 Main relay, engine management system
F32-F36 Fuses in the engine compartment distribution box-
2/3230
F10 4/31 Fan control module - 40continues
-
F79 Fuse in the Central Electronic Module (CEM)F81-F83 Fuses in the Central Electronic Module (CEM)F86 Fuse in the Central Electronic Module (CEM)
2/80-
2/89continuesTP 3999202 S40 (04-)/V50/C70 (06-) 2007 13F30
F11
F8
F17
F15
F7
F13
F16
F9
F18
F14 F12 F10
F6
F5
F4
F3
F2
F1
F24 F21 F20 F22
F31
F25
F32
F33
F34
F35
F36
F29
F19
F28 F27 F26 F23
FusesEngine compartment distribution box F11-F18
15/31 Engine compartment distribution boxNo. Fuse function via AF11 2/182 Relay, headlight washer motor
6/104 Pump, high pressure headlight washer-
2/18220
F12 2/82 Relay, heated rear window9/2 Heated rear window
-2/82, 16/141
30
F13 6/25 Starter motor 2/35 30F14 4/110 Trailer Module (TRM) - 40F15 4/59 Convertible Roof Module (CRM) 30F16 2/159 Infotainment relay, S40/V50
16/105 Audio module (AUD), S40/V50F22 Engine compartment distribution box, S40/V50F43 Fuse in the Central Electronic Module (CEM), S40/V50F64 Fuse in the Central Electronic Module (CEM), S40/V50F65-F67 Fuses in the Central Electronic Module (CEM), S40/V50
-----
2/159
30
F16 2/159 Infotainment relay, C7016/105 Audio module (AUD), C70F22 Engine compartment distribution box, C70F43 Fuse in the Central Electronic Module (CEM), C70F64 Fuse in the Central Electronic Module (CEM), C70F65-F67 Fuses in the Central Electronic Module (CEM), C70
-----
2/159
40
F17 6/1 Wiper Motor Module (WMM) - 30F18 2/80 Relay, reversing light
2/89 Relay, interior lighting4/56 Central Electronic Module (CEM)F46-F47 Fuses in the Central Electronic Module (CEM)F56-F57 Fuses in the Central Electronic Module (CEM)
---
2/89-
40
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 14F30
F11
F8
F17
F15
F7
F13
F16
F9
F18
F14 F12 F10
F6
F5
F4
F3
F2
F1
F24 F21 F20 F22
F31
F25
F32
F33
F34
F35
F36
F29
F19
F28 F27 F26 F23
FusesEngine compartment distribution box F20-F31
15/31 Engine compartment distribution boxNo. Fuse function via AF20 2/17 Relay, horn
16/10 Horn 116/11 Horn 2
-2/172/17
15
F21 4/7 Combustion Preheater Module (CPM) - 20F22 16/79 Subwoofer Module (SUB) - 25F23 4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM), 5-cyl.--
10
F24 9/32 PTC resistor, crankcase ventilation9/38 Electrically heated fuel filter
2/1422/142
20
F26 3/1 Start Control Module (SCU)4/56 Central Electronic Module (CEM)F44 Fuse in the Central Electronic Module (CEM)F51-F54 Fuses in the Central Electronic Module (CEM)F73 Fuse in the Central Electronic Module (CEM)
-3/13/13/13/1
15
F27 8/3 Electromagnetic clutch, climate control system 2/22 10F29 2/34 Relay, front fog lights
10/5 Fog light, front left10/6 Fog light, front right
-2/342/34
15
F30 4/46 Engine control module (ECM), 4-cyl. 2.0l/1.6l Diesel - 3F31 6/26 Alternator, 4-cyl. - 10
continues
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 15F30
F11
F8
F17
F15
F7
F13
F16
F9
F18
F14 F12 F10
F6
F5
F4
F3
F2
F1
F24 F21 F20 F22
F31
F25
F32
F33
F34
F35
F36
F29
F19
F28 F27 F26 F23
FusesEngine compartment distribution box F32-F34
15/31 Engine compartment distribution boxNo. Fuse function via AF32 6/143 Regulator motor, Turbo
7/15 Front heated oxygen sensor, 4-cyl.7/17 Mass airflow sensor (MAF)7/82 Rear heated oxygen sensor, 4-cyl.8/6-8/10 Injection valves, 5-cyl.8/121 Coolant valve, 4-cyl. 2.0l Diesel8/122 Rear heated oxygen sensor, 4-cyl. 1.6l Diesel
-------
10
F33 4/46 Engine control module (ECM), 5-cyl. Diesel6/114 Vacuum pump, 5-cyl.7/15 Front heated oxygen sensor, 5-cyl.7/82 Rear heated oxygen sensor, 5-cyl. T7/186 Rear heated oxygen sensor, not 5-cyl.7/187 Center heated oxygen sensor, not 5-cyl.8/84 Switch, vacuum pump9/32 PTC resistor, crankcase ventilation9/38 Heated fuel filter, Diesel
-8/84
-------
20
F34 8/6-8/9 Injection valves, 1.6l.8/77 Fuel volume control valve, 4-cyl. 2.0l Diesel8/111 High-pressure solenoid valve, 4-cyl. 1.6l Diesel8/113 Fuel pressure bypass valve, Man8/119 Pressure monitor, climate control system, 5-cyl.8/120 EGR valve8/133 Control valve fuel pressure20/3 -20/7 Spark plug and ignition coil20/17 Transformer, ignition coils, 1.6l
---------
10
continues
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 16F30
F11
F8
F17
F15
F7
F13
F16
F9
F18
F14 F12 F10
F6
F5
F4
F3
F2
F1
F24 F21 F20 F22
F31
F25
F32
F33
F34
F35
F36
F29
F19
F28 F27 F26 F23
FusesEngine compartment distribution box F35-FH1
15/31 Engine compartment distribution boxNo. Fuse function via AF35 2/22 Relay, climate control system
4/46 Engine control module (ECM), 5-cyl. Diesel6/67 Pump, fuel leakage control6/99 Engine EGR7/17 Mass airflow sensor (MAF)7/192 Water detection sensor8/6-8/9 Injection valves8/18 EVAP valve8/19 Solenoid, variable valve timing, intake8/28 Turbocharger control valve8/45 Solenoid, variable valve timing, intake8/65 Power steering pressure monitor8/81 Solenoid, variable valve timing outlet8/82 Solenoid, variable turbo geometry, 4-cyl. Diesel8/114 Valve mixing air/fuel8/132 Control valve inlet9/32 PTC-resistor air preheating
--
2/22--------------
15
F36 4/46 Engine Control Module (ECM)7/15 Heated oxygen sensor, front7/51 Accelerator pedal sensor
---
10
FH1 10/65 Auxiliary light, front right10/69 Auxiliary light, front left
2/642/64
20
-
continuesTP 3999202 S40 (04-)/V50/C70 (06-) 2007 17FusesCentral Electronic Module (CEM) F43-F49
F37 F42
F86
F64
F65
F43
4/56 Central Electronic Module (CEM) No. Fuse function via AF43 16/1 Integrated Audio Module (IAM)
16/46 RTI Display16/60 Phone Module (PHM)16/108 Multimedia Module (MMM)
----
15
F44 4/9 Supplemental Restraint System Module (SRS) - 10F45 9/1 Front 12V outlet
9/25 Rear 12V outlet--
15
F46 3/111 Light Switch Module (LSM)5/1 Driver Information Module (DIM)10/1 Lamp housing, front left10/2 Lamp housing, front right10/29 Glove compartment lighting10/97 Courtesy lighting, left10/102 Courtesy lighting, right
-------
5
F47 10/22 Ceiling light10/150 Rear reading light10/114 Vanity mirror lighting, left10/115 Vanity mirror lighting, right
----
5
F48 2/16 Relay, rear window wiper2/92 Relay, windshield washer motor2/93 Relay, rear window washer motor6/2 Washer pump6/2 Washer pump6/32 Rear window wiper motor
---
2/922/932/16
15
F49 4/9 Supplemental Restraint System Module (SRS)7/93 Occupant Weight Sensor (OWS), USA/CDN
--
10
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 18F37 F42
F86
F64
F65
F43
FusesCentral Electronic Module (CEM) F51-F63
4/56 Central Electronic Module (CEM) No. Fuse function via AF51 2/142 Fuel filter preheater relay
4/82 Differential Electronic Module (DEM)4/86 Parking Assistance Module (PAM)4/112 Gas Discharge Lamp Module (GDL), master, left4/113 Gas Discharge Lamp Module (GDL), slave, right10/1 Front left lamp housing, beam length adjustment10/2 Front right lamp housing, beam length adjustment
-----
4/1124/113
10
F52 4/16 Brake Control Module (BCM)4/28 Transmission Control Module (TCM)
--
5
F53 6/71 Electrical Power Steering Module (EPS) - 10F54 4/46 Engine Control Module (ECM), 5-cyl. T - 10F55 4/93 Keyless Vehicle Module (KVM) - 20F56 16/35 Siren Control Module (SCM) - 10F57 3/9 Contact brake light
17/13 Data link connector--
15
F58 4/113 Gas Discharge Lamp Module (GDL), slave, right10/2 Lamp housing, front right
--
7.5
F59 4/112 Gas Discharge Lamp Module (GDL), master, left10/1 Lamp housing, front left
--
7.5
F60 9/12 Seat Heating Module (SHM), drivers side - 15F61 9/13 Seat Heating Module (SHM), passenger side - 15F62 4/33 Sunroof control module - 20F63 3/129 Rear Right Door Module (RDM) - 20
continues
-
8/48 Auto-dimming rearview mirror10/22 Ceiling light
--
F74 4/83 Fuel pump control module, Gasoline6/33 Fuel pump
2/232/23, 26/5
15
continuesTP 3999202 S40 (04-)/V50/C70 (06-) 2007 19F37 F42
F86
F64
F65
F43
FusesCentral Electronic Module (CEM) F64-F74
4/56 Central Electronic Module (CEM) No. Fuse function via AF64 10/245 Lock indicator, left door, C70
10/246 Lock indicator, right door, C7016/49 Traffic Message Channel Module (TMC)16/139 Global Positioning System Module (GPS)16/145 Remote Digital Audio Receiver (RDAR)
-----
5
F65 2/157 Relay, subwoofer control module7/182 Remote control IR sensor, RTI16/46 RTI Display16/105 Audio Module (AUD)16/150 AM/FM antenna and amplifier, rear right fender
-----
5
F66 3/112 Climate Control Module (CCM)16/1 Integrated Audio Module (IAM)16/1.2 Infotainment Control Module (ICM)
---
10
F68 3/254 Steering Wheel Module (SWM) - 5F69 6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), left-hand side6/96 Damper Motor Module (DMM), right-hand side6/102 Damper Motor Module (DMM), defroster6/103 Damper Motor Module (DMM), floor/ventilation7/149 Rain Sensor Module (RSM)7/159 Air quality sensor
-------
5
F73 3/117 Switch unit, ceiling light3/217 Belt buckle contact, rear left3/218 Belt buckle contact, center rear3/219 Belt buckle contact, rear right4/33 Sunroof control module
-----
5
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 20F37 F42
F86
F64
F65
F43
FusesCentral Electronic Module (CEM) F77-F86
4/56 Central Electronic Module (CEM) No. Fuse function via AF77 4/78 Accessory Electronic Module (AEM)
17/19 12V outlet, cargo compartment17/39 13-pin outlet, tow hitch cable harness
---
15
F79 8/48 Auto-dimming rearview mirror10/48 Reversing light, right10/55 Reversing light, left
2/80--
5
F81 3/128 Rear Left Door Module (LDM) - 20F82 3/127 Passenger Door Module (PDM) - 25F83 3/126 Driver Door Module (DDM) - 25F84 3/27 Switch unit, power passenger seat
4/54 Power Seat Module (PSM)--
25
F85 3/26 Switch unit, power drivers seat4/52 Power Seat Module (PSM)
- 25
F86 3/26 Switch unit, power drivers seat3/27 Switch unit, power passenger seat3/268 Load assistance switch4/52 Power Seat Module (PSM)4/54 Power Seat Module (PSM)10/24 Cargo compartment lighting 10/25 Ceiling light, cargo compartment 10/26 Reading light, rear left10/27 Reading light, rear right10/114 Vanity mirror lighting, left26/5 DC/AC converter, fuel tank
----------
2/23
5
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 21PF1
PF2
FusesBattery PF1-PF2
1/1 Battery No. Fuse function via APF1 6/25 Starter motor
6/26 Alternator--
150
PF2 F1-F14 Fuses in the engine compartment distribution boxF16-F18 Fuses in the engine compartment distribution boxF20-F21 Fuses in the engine compartment distribution boxF23-F24 Fuses in the engine compartment distribution boxF26-F27 Fuses in the engine compartment distribution boxF29-F31 Fuses in the engine compartment distribution box
------
150
-
RelaysIgnition switch and relays
B
A
Position
Key Out
0
II
I
III
X
Terminal
30
S X 15
X
X X
X
X X
X X
X
X X
X
50
X
4
8
1
3
Relays, general
The diagram indicates two or three different designations for the relays position. This is described below.
A = Corresponds to the position on the back of the relay box (wiring side)
B = Corresponds to the position on the relay.C = An old designation that may be found on
the relay
A B C
4
2(85)
3
5(87)
2
1(86)
4(87a)5
3(30)
1
A B C
4
2(85)
3
5(87)
2
1(86)
4(87a)5
3(30)
1TP 3999202 S40 (04-)/V50/C70 (06-) 2007 22
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 23R6R9
R10 R7
R3 R1
R2R4R5R8R11
R13
R12
R14
RelaysDistribution box in engine compartment R2-R14
15/31 Engine compartment distribution boxPos Relay functionR2 2/17 Relay, hornR4 2/34 Relay, front fog lightsR5 2/142 Fuel filter preheater relayR9 2/182 Relay, headlight washer motorR10 2/82 Relay, heated rear windowR11 2/22 Relay, climate control systemR13 2/35 Relay, starter motorR14 2/32 Main relay, engine management system
-
R18 R15
RelaysCentral Electronic Module (CEM) R15-R18
4/56 Central Electronic Module (CEM)Pos Relay functionR15 2/23 Fuel pump relay, GasolineR18 2/193 Relay, comfort functionsTP 3999202 S40 (04-)/V50/C70 (06-) 2007 24
-
Relays - solderedCentral Electronic Module (CEM) R1-R11B
4/56 Central Electronic Module (CEM)Pos Relay functionR1 2/89 Relay, interior lightingR2 2/80 Relay, reversing lightR7A 2/92 Relay, windshield washer motorR7B 2/93 Relay, rear window washer motorR8 2/63 Relay, high beamR11A 2/16 Relay, rear window wiperR11B 2/159 Relay, infotainmentTP 3999202 S40 (04-)/V50/C70 (06-) 2007 25
-
RelaysOther relays
Relays accessoriesPos Relay functionDashboard 2/64 Relay auxiliary lightsCargo compart-ment
2/157 Relay, subwoofer control module
Front member
2/192 Relay, electric engine heater
Beneath glove com-partment
2/238 Relay, audio disconnectionTP 3999202 S40 (04-)/V50/C70 (06-) 2007 26
-
19
31/11 31/12
31/66
31/83
31/6
31/115
31/52
31/114
31/3
31/1
31/80
31/4
31/84
31/10
31/116
31/110
31/67
31/89
31/107
31/112
31/102
31/88
31/117
Ground connectionsOverviewTP 3999202 S40 (04-)/V50/C70 (06-) 2007 27
-
31/3 Left MacPherson strut tower1/1 Battery
31/4 Engine1/1 Battery
31/6 A-post, drivers side3/111 Switch unit, lights4/102 Steering Column Lock Module (SCL)10/1 Lamp housing, front left10/2 Lamp housing, front right17/13 Data link connector
31/10 A-post, passenger side2/16 Relay, rear window wiper2/23 Relay, fuel pump2/63 Relay, high beam2/89 Relay, interior lighting2/92 Relay, windshield washer motor2/93 Relay, rear window washer motor2/159 Relay, infotainment2/193 Relay, comfort functions3/25 Switch, power roof/sunroof3/112 Climate Control Module (CCM)3/117 Switch unit, ceiling light3/156 Gear Selector Module (GSM)3/173 Switch, trunk lid/tailgate private lock3/286 BLIS switch4/33 Sunroof control module4/56 Central Electronic Module (CEM)6/2 Washer pump6/48 Damper motor, recirculation6/95 Damper Motor Module (DMM), left-hand side6/96 Damper Motor Module (DMM), right-hand side6/102 Damper Motor Module (DMM), defroster6/103 Damper Motor Module (DMM), floor/ventilation6/117 Interior temperature sensor7/122 Mass Movement Sensor Module (MMS), front7/149 Rain Sensor Module (RSM)7/159 Air quality sensor8/48 Auto-dimming rearview mirror8/134 Solenoid, reverse interlock, manual9/1 Front 12V outlet9/25 Rear 12V outlet10/22 Ceiling light10/29 Glove compartment lighting10/114 Vanity mirror lighting, left, S40/V5010/115 Vanity mirror lighting, right10/150 Rear reading light16/1 Integrated Audio Module (IAM)16/93 Control module, cellular phone handsfree
Ground connections31/3 - 31/10TP 3999202 S40 (04-)/V50/C70 (06-) 2007 28
-
31/11 Rear left side3/78 Lock unit, trunk lid/tailgate4/78 Accessory Electronic Module (AEM)10/18 Lamp housing, rear left16/79 Subwoofer Module (SUB)16/105 Audio Module (AUD)16/145 Remote Digital Audio Receiver (RDAR)17/19 12V outlet, cargo compartment, C70
31/12 Rear right side4/59 Convertible Roof Module (CRM)4/78 Accessory Electronic Module (AEM)4/86 Parking Assistance Module (PAM)4/110 Trailer Module (TRM)6/37 Lock motor, fuel filler flap10/17 Lamp housing, rear right16/139 Global Positioning System Module (GPS)16/145 Remote Digital Audio Receiver (RDAR)17/19 12V outlet, cargo compartment, S40/V5017/37 4-pin outlet, tow hitch cable harness17/38 7-pin outlet, tow hitch cable harness17/39 13-pin outlet, tow hitch cable harness
31/52 Left MacPherson strut tower3/10 Reversing light contact4/28 Transmission Control Module (TCM)4/46 Engine Control Module (ECM)7/24 Front knock sensor, Gasoline7/192 Water detection sensor, Diesel8/3 Electromagnetic clutch, climate control system, Diesel9/32 PTC resistor, crankcase ventilation9/38 Heated fuel filter, Diesel10/65 Auxiliary light, front right10/69 Auxiliary light, front left
Ground connections31/11 - 31/52TP 3999202 S40 (04-)/V50/C70 (06-) 2007 29
-
31/66 Left B-post3/26 Switch unit, power drivers seat, LHD3/27 Switch unit, power passenger seat, RHD3/35 Switch, handle, trunk lid/tailgate3/76 Lock unit, rear left door3/78 Lock unit, trunk lid/tailgate3/85 Power window switch, rear left door3/128 Rear Left Door Module (LDM)3/260 Contact, locking, rear left3/264 Contact, unlocking, rear left3/287 Rear seat entry switch, left4/52 Power Seat Module (PSM), LHD4/54 Power Seat Module (PSM)4/93 Keyless Vehicle Module (KVM), RHD6/32 Rear window wiper motor, V506/35 Fuel pump, auxiliary heater8/51 Igniter, side airbag, drivers side, LHD8/52 Igniter, side airbag, front right, RHD8/92 Lap belt tensioner, driver, LHD9/2 Heated rear window9/12 Seat Heating Module (SHM), drivers side, LHD9/13 Seat Heating Module (SHM), passenger side, RHD10/3 License plate lighting, S4010/19 Auxiliary brake light, V5010/26 Reading light, rear left10/114 Vanity mirror lighting, left, C70, LHD
31/67 Right B-post3/26 Switch unit, power drivers seat, RHD3/27 Switch unit, power passenger seat, LHD3/77 Lock unit, rear right door3/86 Power window switch, rear right door3/129 Rear Right Door Module (RDM)3/261 Locking switch, rear right3/265 Unlocking switch, rear right3/288 Rear seat entry switch, right4/52 Power Seat Module (PSM), RHD4/54 Power Seat Module (PSM)4/82 Differential Electronic Module (DEM)4/93 Keyless Vehicle Module (KVM), LHD7/93 Occupant Weight Sensor (OWS), USA/CDN7/158 Mass movement sensor rear8/51 Igniter, side airbag, drivers side, RHD8/52 Igniter, side airbag, passenger side, LHD8/92 Drivers lap belt tensioner, RHD9/12 Seat Heating Module (SHM), drivers side, RHD9/13 Seat Heating Module (SHM), passenger side, LHD10/27 Reading light, rear right10/114 Vanity mirror lighting, left, C70, RHD
Ground connections31/66 - 31/67TP 3999202 S40 (04-)/V50/C70 (06-) 2007 30
-
31/80 Left MacPherson strut tower4/16 Brake Control Module (BCM), valves
31/83 A-post, drivers side3/1 Ignition switch3/6 Switch, hazard warning flashers3/254 Steering Wheel Module (SWM)4/103 Remote Receiver Module (RRX)5/1 Driver Information Module (DIM)17/13 Data link connector
31/84 A-post, passenger side4/56 Central Electronic Module (CEM)7/51 Accelerator pedal sensor7/149 Rain Sensor Module (RSM)8/31 Airbag igniter, passenger side8/32 Igniter, airbag stage 2, passenger side16/1 Integrated Audio Module (IAM)16/1.2 Infotainment Control Module (ICM)16/46 RTI Display16/60 Phone Module (PHM)16/108 Multimedia Module (MMM)
31/88 Engine9/32 PTC resistor, crankcase ventilation20/3 Spark plug and ignition coil20/4 Spark plug and ignition coil
31/89 Engine20/5 Spark plug and ignition coil20/6 Spark plug and ignition coil20/7 Spark plug and ignition coil
31/102 Front member2/192 Relay, electric engine heater
31/107 Tailgate (V50)16/16 Window antenna amplifier31/117 Ground connection, roof, V50
Ground connections31/80 - 31/107TP 3999202 S40 (04-)/V50/C70 (06-) 2007 31
-
31/110 Right MacPherson strut tower3/271 Contact, immobilizer, clutch pedal4/7 Combustion Preheater Module (CPM)4/113 Control module, gas discharge lamp slave, right6/1 Wiper Motor Module (WMM)6/28 Motor, passenger compartment fan6/104 Pump, high pressure headlight washer7/4 Brake fluid level sensor7/5 Washer fluid level sensor8/119 Pressure monitor, climate control system8/127 Pressure switch, climate control system, Diesel10/2 Lamp housing, front right10/6 Fog light, front right
31/112 Right MacPherson strut tower9/41 PTC element, Diesel
31/114 Left MacPherson strut tower3/62 Hood alarm contact4/71 Cooling fan control module4/109 Glow plug control module, Diesel4/112 Gas Discharge Lamp Module (GDL), master 6/71 Electrical Power Steering Module (EPS)6/114 Vacuum pump, Gasoline10/1 Lamp housing, front left10/5 Fog light, front left16/10 Horn 116/11 Horn 216/35 Siren Control Module (SCM)
31/115 Left A-post3/126 Driver Door Module (DDM), LHD4/83 Fuel pump control module, RHD4/111 Additive Dosing Module (ADM), RHD6/33 Fuel pump, RHD
31/116 Right A-post3/127 Passenger Door Module (PDM), LHD4/83 Fuel pump control module, LHD, Gasoline4/111 Additive Dosing Module (ADM), LHD6/33 Fuel pump
Ground connections31/110 - 31/116TP 3999202 S40 (04-)/V50/C70 (06-) 2007 32
-
31/117 Roof31/107 Ground connection, tailgate (V50)
31/119 Left MacPherson strut tower4/16 Brake Control Module (BCM)
Grounded directly to chassis3/4 Switch unit, cruise control (SWS)3/37 Contact horn3/47 Parking brake contact4/9 Supplemental Restraint System Module (SRS)4/56 Central Electronic Module (CEM)6/25 Starter motor7/6 Sensor, coolant temperature8/3 Electromagnetic clutch, climate control system, Gasoline8/33 Igniter, belt tensioner, drivers side8/34 Igniter, belt tensioner, passenger side8/55 Igniter, rear left belt tensioner8/56 Igniter, rear right belt tensioner8/66 Igniter, left inflatable curtain8/67 Igniter, right inflatable curtain8/128 Drivers belt force limiter8/129 Passenger belt force limiter16/16 Window antenna amplifier16/49 Traffic Message Channel Module (TMC)16/141 Interference filter, rear window, left16/142 Interference filter, rear window, right16/150 AM/FM antenna and amplifier, rear right fender18/4 Contact reel20/22-25 Glow plug
Ground connections31/117 - Ground connections in chassisTP 3999202 S40 (04-)/V50/C70 (06-) 2007 33
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 34
AQSLCM
DDM
KVM
PSM
RSM
SCL
AUD
ICM
GPS
SUB
TMC
TRM
SCU
LDM
CCM
EPS
SCM
ACM
CEM
PDM
GDL
AEM
DMM
RRX
ECM
IAM
CPM
SHM
BCM
SWM
DIM
GDL
TCM
WMM
MMM
RCM
GSMBSC
SHMOWS
SRS
PHM
RDM
ADM
DEMPAM
CRM
Control moduleserview of locationsOv
-
Unit DesignationACM 6/26 Alternator Control Module (ACM)ADM 4/111 Additive Dosing Module (ADM)AEM 4/78 Accessory Electronic Module (AEM)AQS 7/159 Air Quality Sensor (AQS)AUD 16/105 Audio Module (AUD)BCM 4/16 Brake Control Module (BCM)BSC 7/164 Body Sensor Cluster Stability Sensor (BSC)CCM 3/112 Climate Control Module (CCM)CEM 4/56 Central Electronic Module (CEM)CPM 4/7 Combustion Preheater Module (CPM)DDM 3/126 Driver Door Module (DDM)DEM 4/82 Differential Electronic Module (DEM)DIM 5/1 Driver Information Module (DIM)
DMM Damper Motor Module (DMM)-6/48 Damper Motor Module (DMM), recirculation-6/95 Damper Motor Module (DMM), left-hand side-6/96 Damper Motor Module (DMM), right-hand side-6/102 Damper Motor Module (DMM), defroster-6/103 Damper Motor Module (DMM), floor/ventilation
ECM 4/46 Engine Control Module (ECM)EPS 6/71 Electrical Power Steering Module (EPS)GDL Gas Discharge Lamp Module (GDL)
-4/112 Gas Discharge Lamp Module (GDL), master, left-4/113 Gas Discharge Lamp Module (GDL), slave, right
GPS 16/139 Global Positioning System Module (GPS)GSM 3/156 Gear Selector Module (GSM)IAM 16/1 Integrated Audio Module (IAM)ICM 16/1.2 Infotainment Control Module (ICM)KVM 4/93 Keyless Vehicle Module (KVM)LCM 4/126 Left Camera Module (LCM)LDM 3/128 Rear Left Door Module (LDM)MMM 16/108 Multimedia Module (MMM)OWS 7/93 Occupant Weight Sensor (OWS)PAM 4/86 Parking Assistance Module (PAM)PDM 3/127 Passenger Door Module (PDM)PHM 16/60 Phone Module (PHM)PSM 4/52 Power Seat Module (PSM)
4/54 Power Seat Module (PSM)RCM 4/127 Right Camera Module (RCM)RDM 3/129 Rear Right Door Module (RDM)RRX 4/103 Remote Receiver Module (RRX)RSM 7/149 Rain Sensor Module (RSM)SCL 4/102 Steering Column Lock Module (SCL)SCM 16/35 Siren Control Module (SCM)SCU 3/1 Start Control Module (SCU)SHM Seat Heating Module (SHM)
-9/12 Seat Heating Module (SHM), drivers side-9/13 Seat Heating Module (SHM), passenger side
SRS 4/9 Supplemental Restraint System Module (SRS)SUB 16/79 Subwoofer Module (SUB)SWM 3/254 Steering Wheel Module (SWM)TCM 4/28 Transmission Control Module (TCM)TMC 16/49 Traffic Message Channel Module (TMC)
Control modulesOverview of designationsTP 3999202 S40 (04-)/V50/C70 (06-) 2007 35
TRM 4/110 Trailer Module (TRM)WMM 6/1 Wiper Motor Module (WMM)
-
B:12
B:11
A:32
G:18
G:9
H:22
H:1
D:3
C:4
C:3
A:25
G:2
C:14
B:6
C:6
B:3
H:6
A:41
E:37
E:25
C:2
H:21
E:10
C:12
C:13
B:5
C:7
D:5
B:14
A:1
B:10
E:13
E:39
E:38
D:4
C:9
H:23
B:17
G:26
G:3
C:10
A:40
H:2
B:1
G:1
A:35
A:33
E:9
E:40
C:26
G:11
C:8
C:45
H:5
C:20
A:7
A:38
C:11
D:7
D:9
D:12
C:38
E:29
C:39
A:3
E:1
E:2
E:3
A:10
F:12
B:26
A:34
B:27
F:20
F:21
F:18
F:19
G:21
G:12
G:23
A:15
F:28
F:31
B:21
B:22
B:23
G:27
B:19
B:2
B:4
F:7
F:5
G:28
F:24
F:22
B:28
B:30
G:19
A:42
E:14
E:41
H:18
H:20
H:19
B:18
B:32
F:1
F:3
F:2
F:13
F:17
B:31
B:29
A:39
A:17F44
F52
F53
F54
F51
F47
F86
F46
F79
2/89R1
2/80R2
4/56
15+
CEM
CAN
LIN
Control modulesCentral Electronic Module (CEM) 1:2 TP 3999202 S40 (04-)/V50/C70 (06-) 2007 36
BA
-
A:19
C:23
D:14
C:29
C:30
C:44
A:9
A:4
C:24
C:31
C:25
A:18
E:36
A:8
C:16
E:28
C:17
C:40
A:29
A:21
C:27
C:41
G:30
D:8
E:11
E:27
C:21
E:8
A:14
D:10
A:28
E:12
A:45
H:7
63/25
BK
BK
63/12
BK
BK
A:44
C:46
A:43
C:37
C:42
C:43
C:28
A:23
C:22
E:30
C:33
C:34
G:32
G:16
H:24
H:8
H:4
C:18
A:16
B:25
B:24
F:15
F:30
G:14
G:15
B:9
B:8
F:14
F:16
B:15
B:16
F56F83
F82F57F43F64F85F84F62
F66F65
F67
R11B
2/159
R152/23
F81
F63
F74 E:23
E:20
2/93
2/92
2/63
R7B
R7A
R8
2/193R18
E:22
F55
F58
F59
F68
F69
F80
F49
F61
F60
F45
F77
2/16R11A
BA
F48
F73
30+ (4)
30+ (3)
30+ (2)
E:18 30+ (5)
E:21 30+ (1)
A:30 X+
G:29
F:25
F:9
C:1
G:24
G:13
G:6
G:22
G:7
G:31
H:17
B:13
3
1 25
4
4/56
CEM
CAN
LIN
4
512
Control modulesCentral Electronic Module (CEM) 2:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 37
31/10 31/84
H:3 C:32
-
16/60
PHM
7
4
#
1
CAN
0
5
8
6
9
2 3
A:3
A:12
3/127
CAN
PDM
A:4
CAN
A:5
4/7
CPM
CAN
4/52
4/54
PSMCAN
3/126
DDM
CAN
SRS
4/9
10
1
CAN
7/93
OWS
B:16
B:15
4/56
CAN
CEM
B:9
B:8 GY-BK
BU-YE
BU-RD
GY-RD
11
17/13
CAN
3
BU-RD
GY-RDG:16
G:32
A:11
A:12
BU-BK B:25
GY-OG B:24
BU-RD
BU-RD
A:53
A:56 GY-RD
63/221
GY-RD
BU-RD
GY-RDA:3
A:12
64/43
2
1
A:51
A:52
BU-YE
GY
GN
WH
-BK
63/220
1
2
64/41
63/228
63/232
63/233
63/229
BU-RD
GY-RD
F:30 F:15
A
B
4/93
CAN
KVMB:4
B:3
B:3
B:4
LIN
RHD BU-RD
RHD GY-RD
A:14
A:4
A:3
A:7
B:1
B:2
CAN
4/86
PAM
CAN
4/110
TRM
CAN
4/78
AEM
64/322
63/421
63/422
BU-RD
BU-RD
GY-RD
GN GN
WH WH
GY-RD
GY-RDGY-RD
WH
GY-RD
BU-RD
GY-RD
GY-RD
BU-RD
BU-RD
GY-RD
BU-RD
BU-RD
GN
BU-RD
GY-RD
BU-RD
RHD
LHD
LHD
RHD
LHD
LHD
BU-RD
BU-RD
GY-RD
GY-RD
4/59
CAN
CRMF:1
F:9BU-RD
GY-RD
GY-RD
GY-RD
BU-RD
BU-RD
GN
WH
1 2
64/31
64/30
64/245
12
11
11
1
3
10
9
64/31
CAN
PSM
B:3
B:4
GN
WH12
4X/110B1 2
C70
C70
C70
C70
C70
Control modulesData communication, Low speed CAN 1:2 TP 3999202 S40 (04-)/V50/C70 (06-) 2007 38
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 39Control modulesData communication, Low speed CAN 2:2
A
B
9
10
CAN
5/1
DIM
BU-WH
GY-VT
A:9
CAN
A:10ICM
16/1.2
A:8
A:7 GY-RD
BU-WH
C/F
CAN
11
9
8
10
CCM
3/112
GY-BK
BU-YE
-
CAN
B:58
B:45
B:57
B:44
4/46.1
ECM
63/223
11
15
CAN
BCM
4/16
CAN
4/56
CEM
G:14
G:15
63/216
BU-RD
GY-RD
A:2
A:3
CAN
6/71
63/215
63/222GY-RD
BU-RD1
15
64/90
GY-RD
BU-RD
GY-RD
BU-RD
29
25
7/164
CAN
CAN
1
2
17 1864/113
BU
GY
BU
GY
B:11
B:12
14
617/13
GY-RD
BU-RD
GY-RD
GY-RD
BU-RD
BU-RD
BSC
EPS
DSTC
GY-RD
BU-RD
ECM
4/46.6
CAN
A:41
A:30
GY-RD
BU-RD
1
15
64/90
A:8
A:6CAN
4/28
TCM
AW 55-51
CANB:54
B:41
B:57
B:44
4/46.2
ECM
BU-RD
GY-RD
GY-RD
BU-RD1
15
64/90
1
15
64/90
ECM
4/46.5
CAN
A:4A
A:3A
GY-RD
BU-RD
GY-RD
BU-RD
CAN
3/254
SWM
CAN
4/111
ADM
5
4
64/112
7
6
2
6
64/51
5
6
64/50
4
3
64/50
4/82
DEM
GY-RD
A:7
C:9
C:8BU-RD
GY -RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
63/224
63/225
BU-RDBU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD2WD & GDL
W/O AWD
W/O AWD
AWD
GDL/AWD
2WD
ECM
4/46.4
CAN
A:4A
A:3A
GY-RD
BU-RD
ECM
4/46.7
CAN
B:31
B:19
GY-RD
BU-RD
1
15
64/90
GY-RD
BU-RD
1
15
64/90
CAN
B:22
B:23
B:49
B:50
4/46.3
ECMGY-RD
BU-RD
F:16
F:14
5 CYL
2,4 L
5 CYL
2,4 L D
4 CYL
2,0 L D
4 CYL
1,6 L D
4 CYL
1,8 L
5 CYL
2,5 L T
4 CYL
1,6 L
Control modulesData communication, High speed CAN TP 3999202 S40 (04-)/V50/C70 (06-) 2007 40
CAN
A:8GY-RD
-
CAN
16/60
PHM
D:1
D:2#
7
0
8
1
4 5
2
9
6
3
CAN
ICM
16/1.2
2 1 64/97
16/108
MMMC:1
C:2
B:2B:1 B:1 B:2
16/105
AUDD:2
D:1
O O
O
O O
O
O
O
O
O
OO
O
OG
OG
OG
OG
OG
OG
OG
OG
OG
CAN
IAM
16/1
OGO
O
2
1
64/978
OG
OG
OG
O O
16/105
AUD
16/145
RDAR
2
1
O
OO
OG
OG
OG
64/978
D:2
D:1
2
1
1 64/9792
16/105
AUD
16/49
TMC
C:2
C:1
O
OO
OG
D:2
D:1
16/139
GPS
O
O
OG
OG
OG
OG
64/978
C:2
C:1
2
1
16/105
AUD
16/139
GPS
C:1
C:2
O
O
O
OG
OG
OG
64/978
D:1
D:2
1
2
16/105
AUD
16/145
RDAR
2
1
O
O
OG
D:2
D:1
16/139
GPS
O
O
OG
OG
OG
64/978
C:2
C:1
2
1
Control moduleData communication, MOST S40/V50 TP 3999202 S40 (04-)/V50/C70 (06-) 2007 41
-
CAN
16/60
PHM
D:1
D:2#
7
0
8
1
4 5
2
9
6
3
CAN
ICM
16/1.2
16/105
AUD
2 1 64/97
16/108
MMM
2 1 64/972
16/139
TMC
16/49
16/105
C:1
C:2
B:2B:1 B:1 B:2
D:2
D:1
C:2
C:1
C:1
D:1
C:2
D:2
OO
O
O
O O
O
O O
O
O
O
O
O
OO
O
O
O
O
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
CAN
IAM
16/1
OGO
O
O
2 164/979
OG
OG
OG
OG
OG
O O
C:1
C:2
16/105
AUDD:1
D:2
16/79
SUB
16/79
SUB
AUD
C:1
C:2
O
O
O
OG
OG
OG
64/978
1
2
2 1 64/974
16/139
RDAR
16/145
16/105
C:2
C:1
C:1
D:1
C:2
D:2
OO
O
O
O
O
OG
OG
OG
OG
OG
OG
C:1
C:2
16/79
SUB
AUD
16/105
AUD
16/49
TMC
D:2
D:1
O
OO
OG
D:2
C:1
16/139
GPS
GPS
GPS
O
O
OG
OG
OG
OG
OG
64/971
C:2
C:1
2
1
16/79
SUB
D:2
D:1
O
OO
OG
C:2
C:1
16/145
RDAR
16/105
AUD
O
O
OG
OG
OG
OG
OG
64/973
C:2
C:1
2
1
Control moduleData communication, MOST C70TP 3999202 S40 (04-)/V50/C70 (06-) 2007 42
OG
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 43Control modulesData communication, LIN 1:2
3/156
WH-GN3
7/149
LIN
H:23
WH-GN
WH-GN
G:3
WH-RD
1
6/1 LHD
WMM
4
6/1 RHD
WH-BK
LIN
G:26
G:1
CEM
4/56
A:11 A:11
LIN
A:12
ECU SLAVE
4/112
GDLECU MASTER
SCM
16/35
2
64/90A:7 RDRD
33
64/111
2 2
LIN
4/102
LIN
A:2
LIN
3/1
3/155GSM
LIN
RSM
LIN
WMM
LIN
4/113
GDL
4/28
LIN
TCM
I5
AW55-51
WH-RD
WH-GN
WH-GNWH-GN
LIN
4/103
WH
4
5A:35
LIN
BUS
3
LIN
BUS
9
LIN
BUS
2
B:17
RD
SCU
SCL
RRX
63/339
LIN
-
TP 3999202 S40 (04-)/V50/C70 (06-) 2007 44Control modulesData communication, LIN 2:2
5 CYL
2,5 L T
LIN
16/1.2
ICM
3/112
7
12
LIN
C/F
CCM
LIN
3/254
SWM
SHM
LIN
9/12
SHM
9/13
LIN
3
64/545
64/1127
6
6
A:2 A:2
WH
WH-GN
WH WH-GN
WH
WH
WH-GN
WH-GN
C:5A:2 WH-BU
LIN
RDM
3/129
PDM
LIN
3/127
LDM
3/128
3/81
LIN
DDM
3/126
LIN
LIN
WINDOW
CONTROL
SWITCH
64/47
1
4 4
64/4163/26 64/43
1
64/45
BK
BK
BKWH-RD
WH-RD
GN-WH
GN-WH
BK
BK
BK
BK
BK
A:13
A:13
B:4 B:4
4
B:2
66
AQS
6/102
LIN
7/159 LHD
LIN
ECC
DMM
4 4
BU
BU
RHD
WH
WH-GN
RHD
LHDLHD
64/30 64/31LIN
7/159 RHD
LIN
ECCAQS
6/103
DMM
YE
YE
VT
VT
6/95
6/48 RHD
2
2
2
6/96
6/48 LHD
2
ACM
6/26
LIN
ECM
LIN
4/46.1
ECM
LIN
4/46.2
A:88
A:46
WH-RD
WH-RD
WH-RD
LIN
4/126
LCM
S40/V50
C70
S40/V50
S40/V50LIN
4/127
RCM
S40/V50
C70
S40/V50
S40/V50
5 CYL
2,4 L
-
PATS
63/339
MODULE
0
12
3
KEY ININHIBIT
32 1
0
F26
305
IMMOBILIZERSUPPLY
S B1
B2
50
15
XB4
30
POWER
GROUND
BK-YE
WH-GN
RD-BK
RD-GN
RD-GN
RD-GN
A:2A:1
A:3
B:5
B:6
B:8
RD
3/1 B:7
GY-BK
B:2
RD-BK
GN-WH
B:3
YE
B:1
63/88
63/5
CEM
LIN
SCL
LIN
4WH-GN
WH-GN
B:17
BK
A:42
A:17
A:15
B:13
A:30
LIN
4/102
4/56
SCU
1
2
F44
1
2
F52
1
2
F53
1
2
F54
1
2
F51
1
2
F73
A:10 E:3 E:2 E:1 A:3 C:39 E:29 C:38 A:16 C:18 H:4
Control modulesStart Control Module (SCU) TP 3999202 S40 (04-)/V50/C70 (06-) 2007 45
31/83
-
Control modulesAccessory Electronic Module (AEM)
Pos Function TypeA:1 Electrical distribution GroundA:2 Electrical distribution FeedA:3 CAN communication Input/output signalsA:4 CAN communication Input/output signalsB:1 Remote start FeedB:2 Remote start GroundB:3 Remote start Input signalB:4 Electric engine heater GroundB:5 Electric engine heater Steering, alternating
current feedB:11 Handsfree, mute of audio Input signalB:15 Alarm signal Output signalB:16 Alarm signal Output signalB:33 Alarm signal Output signalB:34 Alarm signal Output signal
B:26
B:1
A:1
A:2
A:3
A:4
B:50
B:25TP 3999202 S40 (04-)/V50/C70 (06-) 2007 46
-
BN-RD
YE-RD8/98 1
2
A:23
A:93
CAN
LIN
A:44
A:63
A:41
A:78
A:61
ECM
WH-VT
BN-WH
YE-VT
WH-BU
BN-BU
7/154
7/1743
1
2
P
4/46.3
7/173
A:33
A:7
BN-WH
YE-RD
WH-VT
A:10
QLT2
7/166
3
1
BN A:36
YE A:42
WH A:34
1
2
8/111
M
1
2
1
2
3
6
3
2
4
1ETA
6/120
6/118
GN-RD
BN-BU
BK-OG
A:24
A:72
A:67
A:18WH-BU
YE A:47
BN A:94
A:11YE-BU
5
4
3
2
1 BK
GN-OG
WH-BK
A:4
A:5
A:81
A:40YE-BK
A:52BN-YE
5 CYL
2,4 L D
Group 23 Fuel systemEngine management system Diesel, 5-cyl. 2.4l 1:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 47
-
MAF
2(85) 3(30)
2/32 R14
GN-BU
GN-RD
GN-BU
GN-BK
GN-YE
GN-YE
GN-BU
5(87)1(86)
A:56
A:60
A:53
A:77
A:29
A:59
A:86
A:50
A:1
F9
15/31
2
1
2
1
BK-BUBK-BU
GN-BU
BN-WH
WH-VT
A:48
A:6
A:80
A:57
A:31
BN-BU
WH-RD
BN-RD
7/16
7/25
7/17 4
1
3
2
A
2
1
30+
F35 F34 F36
2
1
F32
2
1
F33
2
1
A:25
A:3
A:75
A:26
A:74
A:73
A:2
A:49
8/7
8/8
8/6 1
2
1
2
1
2
8/10
8/9
1
2
1
2
GN-YE
BK-WH
GN-YE
BU
GN-YE
BK-GN
GN-YE
BK-BU
BK
GN-YE
A:90WH-BU
BK-YE A:37
GN-BU
WH-BU
YE-GN A:32
BN-RD
WH-RD
1
1
1
2
2
2
P 27/162
3
1
WH-GN A:65
YE-GN A:19
BN-GN A:64
3
7/165
8/120
6/143
1
2
4
1
2
6
3
1
2
4
A:15BN3
A:82BK-GN
WH-GN
GY A:87
A:85
M
8/113
1
2
BK-GN
GN-BK
GN-OG
BK-GN
YE-GN
WH-GN
63/54 64/90
A:92
A:66
A:71
A:28
BK-RD A:9
YE-BK A:217
6
RD
C
GN-YE
GN-OG
B
GN-RD
D
1
2
A:62
A:847/190
WH-RD
BN-RD
A:8
A:587/191WH-BU
BN-BU
P
GN-YE
GN-BU
GN-BU
GN-BU
BN-GN
BK-YE
WH
WH-BK
BN
GY
7/15
GN-BU AUTO
CAN
LIN
ECM
4/46.3
F6
2
1
14
40
16
2
4
3
6
2
1
5
64/90
64/90
21
64/90
41
64/9039
64/90
35
12
5 CYL
2,4 L D
11 10 9
1345
2
1
64/902738 26 24
2
1
2
1
2
1
GN-YE
GN-RD
GN-BU
GN-OG
WH-RD
WH-RD
WH-RD
WH-RD
WH-RD
20/22 20/23 20/24 20/26
4/109
DRIVER
N
GLOW P5 GLOW P4 GLOW P3 GLOW P1
PUISSANCE
MOS
PUISSANCE
MOS
PUISSANCE
MOS
PUISSANCE
MOS
DRIVER
N
DRIVER
N
DRIVER
N
GLOW PLUG RELAY BOX
2
25
2
1
GN-WH
20/25
GLOW P2
PUISSANCE
MOS
DRIVER
N
Group 23 Fuel systemEngine management system Diesel, 5-cyl. 2.4l 2:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 48
-
30+
1
2
F18
1
2
1
F24
63/33
B:47
B:42
ABK-BU
BK-YE
7/51
GN-BU
GN-BU
GN-BU
GN-OG
GY GY
4
51
2
3
6
B
3/1 30
15X
5
50 S
7
B:2 B:3
15I
C
B:22
B:23
B:4
63/12
63/120
63/121
63/25
63/65
BK
BK-YE
31/52
GN-YE
GN-OG
GN-WH
BN
BK
WH
YE
RD-BK
WH-BK
BK
BK
BK
WH-BK
GN-RD
BK
RHD
LHD
BK
14
7
8
BK
BK-OG
BK
BK-OG
BK-OG
64/51
63/85
63/53
B:38 GN-YE
GN-WH
GN-WH
GN-WH
GN-WH
GN-WH
RD-BU
D
B:5
B:3
B:1
ECM
4/46.3
CAN
LIN
2/142 R5
WH-BK
RD-YE
2
1
2
F26
1
2
1
25
3
F4
64/111
5
64/90B:48 GN-WH
BK-YE
BK-WH
BK-WHBK-YE
BK-YE
GN-BU
8
37
64/1117
64/90
28
6/33
M
5 6
1
64/1137
RD
64/90 13
3/9 2
1
CAN
CEM F74
E:21
LIN
1
2
F57
1
2
R15
2/23
F51
1
2
E:22A:17
RD RD
E:29
C:16
1
2
1
2
A:42
E:40
E:10
G:7
G:31
G:22
A:28
E:28E:41
OG
RD
OG-WH
2 5
1 3
4
9/32
9/32
B:2
B:6
4/56
9/38
15/31
5 CYL
2,4 L D
Group 23 Fuel systemEngine management system Diesel, 5-cyl. 2.4l 3:3TP 3999202 S40 (04-)/V50/C70 (06-) 2007 49
31/84 31/116 31/1031/11431/115
-
65
4
3
2
1
R14
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
18/6
30+
BN
BN
BN
WH
7/161
2
1
2
F35F34
2
11
2
F32
ETA
B:13
6/120
64/60
64/60
63/SH8 63/SH7
63/74
GN-RD
GN-BU
GN-YE
GN-WH
GN-WH
GN-WH
4/46.7
7/24YE
BK
WH-RD
A
A:27
A:13
A:28
A:12
A:31
BK
SCR
A:16
A:32
B:41
B:42
ECM
A:21
YE
A:6BN
CAN
WH-BU
WH-BU
YE-BU
WH-RD
YE
BN
WH-BU
WH-BU
YE-BU
A:22
A:48
1
2
B:36
WH-GN
GN-WH
A:52
B:17
P7/165
3
2
1
4
WH-VT
YE-GN
BN-GN
B:35
7/6
1
P
BK-OG
BK-BU
BK-OG
BK-YE
BK-WH
BK-BU
BK-OG
BK-YE
BK-WH
A:20
B:3
15/31
RD-OG
RD-OG
F9
21
64/90
64/90
63/99
63/52
12 14
BK-BU BK-BU
GN-BU
GN-BU
GN-RD
1
2
F36
41
GN-BU
8
7
2
3
1
4
9
10
16
5
15
14
13
B:29BN-WH
BK-GN
12
8/65
A:3
BK-OG A:1
3
2
1
20/17
20/3
20/6
20/4
20/5
GN-RD
4 CYL
1,6 L
Group 23 Fuel systemEngine management system, 4-cyl. 1.6l 1:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 50
C
GN-OG
BGN-YE
-
M5 6
6/33
I4 PETROL
2 WD
1 4 2
ECM
B:7
B:40
A:42
A:8
4/46.7
ABK-BU
CAN
3/9 2
1
GN-WH
BK-OG
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
1
2
F30
RD-YE
RD-BU
64/90
8
13
37
28GY
GN-BU
GN-WH
64/111
64/51
7
7/5115
2
6
3
4
2
R15
2/23
5
1 3
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
A:47
A:40
B:21
GN-WH
B:9 RD RD
GN-BU
GY
WH
YE
BN
E:28E:41
OGOG-WH
BK-YE
7 8
63/12
BK-YE
BK
GN-YE
B:8
BK-YE
A:5 BK-YE
BK-YE
BK-YE
BK
GN-WH
BK-OG
63/25
BK
BK
BK-OG
LHD
RHD
4
B:19
B:31
4 CYL
1,6 L
Group 23 Fuel systemEngine management system, 4-cyl. 1.6l 2:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 51
B
C 31/1031/84 31/52
GN-OG
31/11531/116
-
65
4
3
2
1
R14
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
18/6
30+
BN
WH
BN
7/161
2
1
2
F33
1
2
F35F34
2
11
2
F32
GN-BU
ETA
B:16
GN-BK
3 1
2
20/6
WH-BU
GN-RD
3 1
2
20/5
20/4
2
13
GN-BU
WH-RD
WH
GN-YE
3 1
2
20/3
GN-BU
6/120
GN-RD
C
GN-OG
63/95
WH-GN
GN-RD
GN-BU
GN-YE
GN-WH
63/54
4/46.6
7/24BK
GN-BK
YE-GN
SCR SCR
WH-GN
WH-VT
YE
GN-RD
BK-OG
A
B:2
B:3
B:13
B:14
B:41
B:36
B:39
B:27
B:29
B:11
B:46
B:23
B:34
B:22
B:10
ECM
B:37WH-BU
B:38BN-BU
CAN
WH-BU
YE-BU
BGN-YE
B:25
B:26
1
2
B:30
1
3
2
4
7/165
63/74
63/67
1
28/45
GN-YE
B:8BK-YE
BK-OG
8/1141
2
GN-OG
B:9BK-RD
BK-BU
BK-YE
BK-WH
15/31
RD-OG
RD-OG
F9
21
64/90
64/90
63/99
12 14
1
2
F36
BK-BU BK-BUGN-BU
GN-BU
GN-BU
41
4 CYL
1,8 L
Group 23 Fuel systemEngine management system, 4-cyl. 1.8l & 2.0l 1:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 52
DBK-BU
-
ECM
A:10
A:11
A:23
A:35
4/46.6
ABK-BU
B
CAN
3/9 2
1
C
GN-WH
RD
BK
BK
RD
BK
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21
LIN
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
RD-YE
RD-BU
64/90
8
37
28
4
34
17
5
GY
GN -BU
GN-WH
64/1117
7/5115
2
6
3
4
2
R15
2/23
3
1 5
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
A:32
A:39
A:46
GN-WH
GN-BU
GY
A:1
A:4
A:12
BK-RD
WH-RD
BK-YE
A:14
A:28
BK-OG
YE-RD
A:13
WH
YE
BN
E:28E:41
OGOG-WH
BK-YE
6/26
7 8
64/54
64/51
3 4
63/12
BK-YE
BK
GN-YE
A:34
BK-YE
BK-YE
BK-YE
GN-OG
GN-YE
BK
GN-OG
BK-OG
BK-OG
GN-WH
63/25
BK
BK
BK-OG
LHD
RHDM
3
26/5
FlexiFuel
6/33
2
1
5
Flexi
fuel
1.8l/
2.0l M
6/33
4
A:30
A:41
29
19
B:20
B:15
A:1
A:2
GY
BU
WH-VT
ACM
DC/AC
4 CYL
1,8 L
Group 23 Fuel systemEngine management system, 4-cyl. 1.8l & 2.0l 2:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 53
D 31/84 31/1031/52BK-BU
31/11531/116
-
65
4
1
2
3
2
1
MAF
R14
2
1
2/32
8/81
2
8/91
22(85)
1(86)
3(30)
5(87)
8/71
2
2
1
8/6
30+
2
18/10
GY
BK
BN
BN-WH
YE-VT
7/81
7/16
3
1
2
2
1
P
1
2
F32
1
2
F35F34
2
11
2
F36
GN-BU
7/17
4
3
2
5
GY
BN-BU
WH-RD
BN-BU
ETA
A:67
BK
BK
BK
BK
BK
31/89
31/88
GN-BU
3 1
2
4
20/7
GN-BU
3 1
2
4
20/6
WH-BK
GN-BU
3 1
2
4
20/5
20/4
4
2
13
GN-BUBK-WH
GN-WH
WH-RD
WH
GN-BU
3 1
2
4
20/3
GN-YE
6/120
GN-BU
C
GN-BU
63/103
WH-GN
WH-BU
GN-YE
GN-YE
GN-YE
GN-YE
GN-YE
63/54
4/46.1
7/24
7/25
WH-BK
BN-YE
WH-RD
BN-RD
GN-RD
BK-OG
A
A:84
A:83
A:82
A:81
A:80
A:93
A:3
A:4
A:46
A:20
A:58
A:59
A:62
A:21
A:60
A:34
A:35
A:75
A:74
ECM
A:24YE
A:72BN-BU
GN-BU
GN-BU
CAN
WH-BU
YE-BU
BGN-YE
A:15
A:96
BK-OG
BK-OG
A:53
A:78
1
2
A:22
A:16
WH-BU
A:71
A:94
P7/156
3
2
1
4
WH-GN
YE-BU
BN-BU
A:91
7/6
1
P
BK-GN
GN-BU
63/97 YE-RD A:12
YE-RD
YE-RD
YE-RD
YE-RD
YE-RD
A:23
A:70
A:69
BK
BK-BU
BK-GN
BU
BK-WH
A:5
A:13
15/31
RD-OG
RD-OG
F9
21
64/90
41 64/90
63/98
12 14 391
2
8/84
1
6/114
P
63/121
BK
GN-RD
BK
63/120
BK
1
2
F33
BK-BU BK-BU
GN-BU
GN-BU
GN-BU
GN-YE
GN-YE
GN-YE
63/13
1
2
1
8/182
1
8/192
1
9/322
5 CYL
2,4 L
Group 23 Fuel systemEngine management system, 5-cyl. 1:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 5431/114
-
4 5
1 4
M
5 66
6/33
I5 PLASTIC
AWD 2WD
I5 PZEV
METAL TANK
6/33 1
BK-RD
M
5
1
GN-OG
GN-OG
BK-RD
ECM
B:3
B:2
B:1
B:16
4/46.1
ABK-BU
B
CAN
3/9 2
1
C
GN-W
H
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21 A:17
LIN
3/1 30
15X
5
50 S
B:7
B:2 B:3
64/1115
RD
RD
GY-BK
GN-WH
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
1
2
F23
RD-YE
RD-BU
RD
64/113
7
64/90
23
8
37
28
13
24
GY
GN-YE
GN-WH
64/1117
7/5115
2
6
3
4
2
R15
2/23
5
1 3
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
B:54
B:26
B:41
B:14
GN-WH
GN-YE
GY
WH
YE
BN
E:28 E:1
F54
1
2
E:41
OG
OG-W
H
BK-YE
B:30 GN-YE
B:20 WH-BK WH-BK WH-BK
63/12
BK-YE
BK
GN-YE
B:6
B:4
63/65
BK-YE
BK-YE
BK-YE
GN-BU
GN-BU
GN-BU
BK
BK-OG
63/25BK
BK
BK-OG
LHD
RHD
4
A:45
A:58
A:44
A:57
63/56 RDRD
RD MAN
4/83
1 2 3
WH-BK
BK-OG
64/5114 7 8
GN-W
H
BK-OG
BK-RD
BK-OG
63/33
GN-YE
5 CYL
2,4 L
Group 23 Fuel systemEngine management system, 5-cyl. 2:2TP 3999202 S40 (04-)/V50/C70 (06-) 2007 55
31/1031/8431/52 31/11531/116
-
65
4
1
2
3
2
1
MAF
R14
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
1
8/6
30+
2
1
8/10
GY
WH-GN
BN
WH-VT
BN-WH7/16
3
1
2
2
1
1
2
F32
1
2
F35F34
2
11
2
F36
GN-BU
7/17
4
3
5
BN-BU
WH-RD
BN-RD
ETA
A:42
BK
BK
BK
BK
BK
31/89
31/88
GN-NU
3 1
2
4
20/7
GN-BU
3 1
2
4
20/6
WH-BK
GN-BU
3 1
2
4
20/5
20/4
4
2
13
GN-BU
WH-RD
WH
GN-BU
3 1
2
4
20/3
GN-YE
6/120
GN-BU
GN-YE
63/103
WH-GN
WH-BU
GN-YE
GN-YE
GN-YE
GN-YE
GN-YE
63/54
4/46.2
7/24
7/25
WH-BK
BN-YE
WH-RD
BN-RD
GN-RD
BK-OG
A
A:1
A:25
A:3
A:2
A:26
A:18
A:63
A:87
A:7
A:55
A:81
A:57
A:77
A:53
A:34
A:82
A:58
A:75
A:14
ECM
A:19WH-BU
A:74BN-BU
CAN
WH-BU
YE-BU
GN-BU
B
A:88
A:65
1
2
A:12
A:43
WH-BU
A:41
A:89
P7/156
