theft prevention

For more information, call 1-800-888-4784 (4STI) or visit www.sti-usa.com

FeaTureS · User can select whether to use as an

alarm or annunciator.

· May be mounted on top, right, left or next to almost any door.

· 105 or 95 dB warning horn.

· In exit alarm mode, alarm can be set to sound for 30 seconds, 3 minutes or indefinitely (unless disarmed with key supplied or until battery is drained).

· In annunciator mode, it announces door entry with a set of 10 beeps.

· May be programmed for 15 second entry delay or immediate alarm.

· Detects both unauthorized exits and entries.

· Recommended operational temperature range is 32° to 113°F.

· Unit is completely self-contained.

· STI-6400WIR supervised wireless 433 mhz (with 4 or 8-channel receiver). Up to 1000 foot (line of sight) range.

· STI-6402 provides protection for double door applications with two sets of reed contacts.

· STI-6403 allows for remote horn to be located 300 feet from the door it is protecting - 18 gauge wire not included or electrically supervised.

· STI-6404 provides protection for double doors and has remote horn capabilities (18 guage wire not included).

· STI-6405 allows keyholder to reset the alarm, unit cannot be turned off.

· STI-6406 can be operated from both sides of the exit/entry door.

· Highly visible “stop sign” design acts as a deterrent.

· Arming delay allows unit to arm following authorized exits.

· Available in red or green.

· Easy to install...much less expensive than heavy horizontal bar type units... and practical for all emergency doors.

· Three year guarantee against breakage of polycarbonate in normal use (one year on electro mechanical and electronic components).

ProducT overvIew The highly effective Exit Stopper can serve as an inexpensive security device and help stop theft by alerting you to any unauthorized exits or entries through emergency exit doors.

how IT workS If the protected door is opened, the electronic Exit Stopper emits an ear piercing alarm for 30 seconds, 3 minutes or continuously (as preset by the user). A key operated override will silence the alarm and allow authorized exits. The unit can be set for a 15 second delay before arming or tripping. Exit Stopper “Always Active” allows the key holder to reset the alarm, but does not allow the alarm to be turned off. Exit Stopper is fitted with a 9 VDC alkaline battery. It is available in red or green for almost any type of door, mounting or installation, including remote placement of the alarm (not for outdoor use).

STI exit Stopper®

STI-6406

STI-6400

STI-6405

Wireless Now Available

Printed in U.S.A., © 1987 - 2009 Safety Technology International, Inc.

2306 Airport Road Waterford, Michigan 48327, USA

Tel: 248-673-9898 Fax: 248-673-1246 Toll-free: 800-888-4784 info@sti-usa.com www.sti-usa.com

Unit 49G Pipers Road Park Farm Industrial Estate Redditch, Worcestershire B98 OHU England

Tel: 44 (0) 1527 520 999 Fax: 44 (0) 1527 501 999 Free: 0800 085 1678 (UK) www.sti-europe.com

06/11Subject to change without notice.

STI exit Stopper® Dimensions and Technical Information

modelS avaIlable STI-6400 Exit Stopper multifunction door alarm STI-6400WIR Wireless Exit Stopper multifunction door alarm STI-6400WIR4 Wireless Exit Stopper multifunction door alarm with

4-Channel Receiver STI-6402 Exit Stopper multifunction door alarm for double door

installation STI-6402WIR Wireless Exit Stopper multifunction door alarm for

double door installation STI-6403 Exit Stopper multifunction door alarm with remote horn STI-6404 Exit Stopper for double door with remote horn STI-6405 Exit Stopper multifunction door alarm with “always

active” feature STI-6406 Exit Stopper with dual access control STI-6453AED Replacement siren alarm STI-34104 4-Channel receiver STI-34108 8-Channel receiver STI-30104 Lamp controller SUB-6403 Remote horn to use in conjunction with all above exit

alarm models or to replace remote horn in STI-6403 06402 Magnet and reed switch with spacers 16200 Warning “Door Alarmed” label

SPecIFIcaTIonS Housing 1/8 in. Polycarbonate Power Source 9 VDC Alkaline or 12-24 VDC Wired Warning Horn 95 dB - Low at 1 foot 105 dB - High Relay Contacts Form C Dry 0-30 Volts AC/DC, 1 Amp Dimensions 5.375 in. x 5.375 in. x 2 in. 137mm x 137mm x 51mm Standby Current 10 uA Alarm Current 200 mA Recommended 32°F to 113°F Operating (0°C to 45°C) Temperature

FeaTure JP2 JP3 JP4 JP5 JP7 Volume- (105 dB) at 1 foot ON*

Volume- (95 dB) at 1 foot OFF

Duration- 30 Second Alarm OFF* OFF*

Duration- 180 Second Alarm OFF ON

Duration- Continuous Alarm ON OFF

Duration- Annunciator Mode ON ON

Trip- Immediate OFF*

Trip- 15 Second Delay ON

Arming- Immediate ON*

Arming- 15 Second Delay OFF

*Factory Settings

STI-30104 LAMP CONTROLLER (OPTIONAL)

AC ADAPTER

GREEN LED

TRANSISTOR OUTPUT JACK

RECEIVER ANTENNA

SPEAKER

STI-34104 INDOOR RECEIVER

BUTTON

RED LED

SENSOR TRANSMITTER CAP

SENSOR TRANSMITTER BASE

MOUNTING TUBE CAP

WALL MOUNT (INCLUDED) NOT NEEDED FOR POLE MOUNT INSTALLATION

2 “C” BATTERIES (NOT INCLUDED)

SENSOR TRANSMITTER

12”MOUNTING TUBE

MOUNTING STAKE

SENSOR TRANSMITTER BOTTOM

SENSOR TRANSMITTER

MOUNTING TUBE CAP

MOUNTING STAKE

SENSOR TRANSMITTER BOTTOM SCREWS

RECHARGEABLE NiMH BATTERIES

H L

SENSITIVITY JUMPERS (SOLAR TYPE)

SENSITIVITY JUMPERS (BATTERY TYPE)

HL

FINGER NOTCHES

REMOVE PLASTIC TAB FROM BATTERIES

DRIVEWAY

3’OR LESS

25' OR MORE

PLACE SENSOR TRANSMITTER 3' OR LESS FROM EDGE OF DRIVEWAY AND 25' OR MORE FROM STREET.

12’ MAX

DRIVEWAY

PLACE SENSOR TRANSMITTER 3' OR LESS FROM EDGE OF DRIVEWAY AND 25+ FEET OR MORE FROM STREET.

25' OR MORE

3' OR LESS

12' MAX

+

+

-

B

DETAIL B SCALE 2:1

B

C

H L

-

+

+

-

B

-

FINGER NOTCHES

DO NOT PULL ANTENNA!

WALL MOUNT (INCLUDED) NOT NEEDED FOR POLE MOUNT INSTALLATION

SENSITIVITY ADJUSTMENT

SENSITIVITY ADJUSTMENT

POWER CONNECTOR ANTENNA CONNECTOR

12”MOUNTING TUBE

GREEN LED

TRANSISTOR OUTPUT JACK

RECEIVER ANTENNA

SPEAKER

BUTTON

RED LED

POWER CONNECTOR ANTENNA CONNECTOR

STI-34104 STI-34108

POLYCARBONATE COVER

POLYCARBONATE BASE

120 dB HORN

ALARM DURATION

ALARM TRIP DELAY

EXIT DELAY VOLUME

VIEW OF THE CIRCUIT BOARD

EMERGENCY EXIT ONLY STOPSTOP

ALARM SOUNDS WHEN DOOR IS OPENED

ON OFF

EMERGENCY EXIT ONLY STOPSTOP

ALARM SOUNDS WHEN DOOR IS OPENED

ON OFF

FLANGES SLOTS

TERMINAL STRIP

9 VOLT BATTERY

19011 TAMPERPROOF SCREW (1) PROVIDED

19016 TAMPER WRENCH (1) PROVIDED

BASE

COVER

19014 MOUNTING SCREW (4) PROVIDED

EMERGENCY EXIT ONLY STOPSTOP

ALARM SOUNDS WHEN DOOR IS OPENED

ON OFF

19039 SCREW 6 x 1 1/4 in.

(2) PROVIDED

19018 ANCHOR (2) PROVIDED

BOTTOM SURFACE AS SHOWN WIRES THROUGH NOTCH ON AND ROUTE REED SWITCH REMOVE FRONT COVER

VIEW SHOWING MAGNET INSTALLATION

MAGNET

DOOR

DOOR STOP

JAM

MAGNET

6400 UNIT

MAGNET MUST BE INSTALLED OPPOSITE RAISED RIB ON OUTER COVER.

SPACERS - USE AS NECESSARY

19018 ANCHOR (2) PROVIDED

TYPICAL FLUSH MOUNT DOOR JAM INSTALLATION

DOOR SWING

NOTE: 2 SPACERS MUST BE USED ON STEEL DOORS

19039 SCREW 6 x 1 1/4 in. (2) PROVIDED

MAGNET

6400 UNIT

DOOR STOP

SWING DOOR

TYPICAL RECESSED MOUNT DOOR JAM INSTALLATION

3/4 in. [19 mm] MAXIMUM GAP 3/8 in. [9.5mm] ON METAL DOOR AND FRAME

NC COM NO GD V+ RS1 RS2 KEYSW

TERMINAL BLOCK WIRING CONNECTIONS

FO RM

C D

RY CO

N TA

CT S

RE M

O TE

PO

W ER

IN PU

T 9-

24 V

D C

RE ED

SW IT

CH TE

RM IN

A LS

KE Y

SW IT

CH TE

RM IN

A LS

INTERNAL REED SWITCH (RS1)

06402 REED SWITCH (RS2)

OPTIONAL: TO REMOTE

HORN STI-6403

VIEW SHOWING INSTALLATION OF ADDITIONAL REED SWITCH 06402

TO KEY SWITCH

TERMINAL BLOCK

ALARM DURATION

ALARM TRIP DELAY

EXIT DELAYVOLUME

VIEW OF THE CIRCUIT BOARD

19016 TAMPER WRENCH (1) PROVIDED

19011 TAMPERPROOF SCREW (1) PROVIDED

9 VOLT BATTERY

TERMINAL STRIP

SLOTSFLANGES

COVER 19014 MOUNTING SCREWS (4) PROVIDED

BASE

MAXIMUM GAP 3/4 in. (19mm) 3/8 in. (9.5mm) ON METAL DOOR AND FRAME

SPACERS (USE AS NECESSARY) NOTE: 2 SPACERS UNDER BOTH MAGNET AND REED SWITCH MUST BE USED ON STEEL DOORS

MAGNET ASSEMBLY (SEE ABOVE FOR INSTALLATION)

aPProvalS & warranTy

POLYCARBONATE COVER

POLYCARBONATE BASE

120 dB HORN

ALARM DURATION

ALARM TRIP DELAY

EXIT DELAY VOLUME

VIEW OF