TEST REPORT - WordPress.com · 6/17/2019 · TEST REPORT SOP and results with (*) are not included...
Transcript of TEST REPORT - WordPress.com · 6/17/2019 · TEST REPORT SOP and results with (*) are not included...
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
Serie :Receiving Date: 06/07/2017Test Start Date: 08/07/2017
19/07/2017Test End Date:
Batch No.:RAW MATERIALSample description:
17-010613Reference No.: VERDE FLAME
Job no Report No.:
Composition indicated: UNKNOWN
The following sample was (were) submitted and identified by the client as:
SOP description Conclusions*SOP 25 - Colour fastness to artificial light for fabrics - Xenom lamp* See Results
SOP 52-Determination of arylamines for natural samples* See Results
SOP 58-Determination of formaldehyde by photometric in textile samples (DC) See Results
SOP 70-Determination of allergenous dyes* See Results
SOP 55-Determination of cadmium and lead in textile samples by ICP-MS See Results
SOP 20-Determination of the content of phenols* See Results
SOP 60-Colour Fastness to Rubbing (Direct Contact) See Results
SOP 62-Colour Fastness to Acid perspiration (Direct contact) See Results
SOP 62-Colour Fastness to Alkaline perspiration (Direct contact) See Results
SOP 13 - Colour fastness to domestic washing C06 See Results
Sample Tested
SUMMARY OF TEST CONCLUSIONS*
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 1 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
250 SOP 25 - Colour fastness to artificial light for fabrics - Xenom lamp
5ID
S-170708-00148ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
*
CAS S-170708-00148
Colour change Blue Scale 7/8Hours test process 30
Notes:General Notes:- Applied standard based in UNE-EN ISO 105-B02:2001 (Equivalent to ISO 105-B02:1994)- NA = not applicable
Specific Notes:Note 1: Used Blue scale from 1 to 8.
520 SOP 52-Determination of arylamines for natural samples
S-170711-00743Composite SampleID ID AMSLab Description Conclusion*
S-170711-00681 FABRIC GREEN See Results6
(N°= 6)
*
CAS S-170711-00743
0-dianisidine (3,3-dimethoxybenzidine) 119-90-4 n.d.
2,4,5-trimethylaniline 137-17-7 n.d.
2,4-Diaminotoluene 95-80-7 n.d.
2,4-dimethylaniline 95-68-1 n.d.
2,6-dimethylaniline 87-62-7 n.d.
2-Nafthylamine 91-59-8 n.d.
3,3-dichlorobenzidine 91-94-1 n.d.
3,3-dimethylbenzidine 119-93-7 n.d.
4,4-Diaminediphenyl sulfide 139-65-1 n.d.
4,4-Oxydianiline 101-80-4 n.d.
4,4-diaminophenylmethane 101-77-9 n.d.
4,4-methylen-bis-(2-Chloroaniline) 101-14-4 n.d.
4,4-methylendi-o-toluidine 838-88-0 n.d.
4-Aminoazobenzene 60-09-3 n.d.
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 2 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
CAS S-170711-00743
4-Aminobiphenyl 92-67-1 n.d.
4-Chloro-o-toluidine 95-69-2 n.d.
4-Chloroaniline 106-47-8 n.d.
4-Methoxy-m-phenilenediamine 615-05-4 n.d.
5-Nitro-o-toluidine 99-55-8 n.d.
6-methoxy-m-toluidine 120-71-8 n.d.
Benzidine 92-87-5 n.d.
o-Aminoazotoluene 97-56-3 n.d.
o-Anisidine 90-04-0 n.d.
o-toluidine 95-53-4 n.d.
Notes:General Notes:- Applied standard UNE-EN 14362-1:2012- Requirement by the client=20 mg•Kg-1 for textile30 mg•Kg-1 for leather goods- Lack of sample * = Component Weight < 1% Total- (Nº=..) = number of subsamples included. If N>number of subsamples visible, in this composite sample it mixed different references bycustomer indications.
Test Notes:Report Unit: mg•Kg-1n.d.= not detected (<MDL)MDL (Method Detection Limit )= 1,0 mg•Kg-1
Specific Notes:(**) The result is out of specifications
582 SOP 58-Determination of formaldehyde by photometric in textilesamples (DC)
S-170711-00745Composite SampleID ID AMSLab Description Conclusion*
S-170711-00682 FABRIC GREEN See Results7
(N°= 6)
CAS S-170711-00745
Formaldehyde 50-00-00 13.0
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 3 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
Notes:General Notes:- Applied standard ITX-GB/T 2912.1/2012- Requirement by the client, products for over 3 years=75 mg•Kg-1 for items of direct contact300 mg•Kg-1 garment with indirect contact- Lack of sample * = Component Weight < 1% Total- (Nº=..) = number of subsamples included. If N>number of subsamples visible, in this composite sample it mixed different references bycustomer indications.
Test Notes:Report Unit: mg•Kg-1n.d.= not detected = <LOQLOQ (Limit of quantification )= 2,0 mg•Kg-1
Specific Notes:(**) The result is out of specifications
700 SOP 70-Determination of allergenous dyes
8ID
S-170711-00683ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
*
CAS S-170711-00683
Disperse Blue 1 2475-45-8 n.d.
Disperse Blue 102 12222-97-8 n.d.
Disperse Blue 106 12223-01-7 n.d.
Disperse Blue 124 61951-51-7 n.d.
Disperse Blue 26 3860-63-7 n.d.
Disperse Blue 3 2475-46-9 n.d.
Disperse Blue 35 56524-77-7 n.d.
Disperse Blue 7 3179-90-6 n.d.
Disperse Brown 1 23355-64-8 n.d.
Disperse Orange 1 2581-69-3 n.d.
Disperse Orange 3 730-40-5 n.d.
Disperse Orange 37 13301-61-6 n.d.
Disperse Red 1 2872-52-8 n.d.
Disperse Red 11 2872-48-2 n.d.
Disperse Red 17 3179-89-3 n.d.
Disperse Yellow 1 119-15-3 n.d.
Disperse Yellow 3 2832-40-8 n.d.
Disperse Yellow 39 12236-29-2 n.d.
Disperse Yellow 49 54824-37-2 n.d.
Disperse Yellow 9 6373-73-5 n.d.
Notes:General Notes:- Applied standard DIN 54231- Requirement by the client= 50,0 mg•Kg-1- Lack of sample * = Component Weight < 1% Total
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 4 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
Test Notes:Report Unit: mg•Kg-1n.d.= not detected (<MDL)MDL (Method Detection Limit )= 1,0 mg•Kg-1
Specific Notes:(**) The result is out of specifications
550 SOP 55-Determination of cadmium and lead in textile samples by ICP-MS
S-170711-00751Composite SampleID ID AMSLab Description Conclusion*
S-170711-00685 FABRIC GREEN See Results10
(N°= 4)
CAS S-170711-00751
Cadmium 7440-43-9 n.d.
Lead 7439-92-1 n.d.
Notes:
General Notes:- Applied standard CPSC-CH-E1002-08.3 (2012)- Requirement by the client, products for over 3 years=75,0 mg•Kg-1 for cadmium100,0 mg•Kg-1 for lead- Lack of sample * = Component Weight < 1% Total
Test Notes:Report Unit: mg•Kg-1n.d.= not detected = <LOQLOQ (Limit of quantification )= 50,0 mg•Kg-1
Specific Notes:(**) The result is out of specifications
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 5 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
200 SOP 20-Determination of the content of phenols
9ID
S-170711-00684ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
*
CAS S-170711-00684
PCP 87-86-5 n.d.
TeCP 25167-83-3 n.d.
Notes:General Notes:- Requirement by the client= 0,05 mg•Kg-1 .- Lack of sample * = Component Weight < 1% Total
Test Notes:Report Unit mg•Kg-1n.d= not detected (<MDL)MDL (Method Detection Limit )= 0,05 mg•Kg-1
Specific Notes:(**) The result is out of specifications
600 SOP 60-Colour Fastness to Rubbing (Direct Contact)
1ID
S-170708-00144ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
CAS S-170708-00144
Cross Staining n.a.
Length direction Dry Colour Change 5
Length direction Dry Staining 4/5
Length direction Wet Colour Change 5
Length direction Wet Staining 3/4
Width direction Dry Colour Change 5
Width direction Dry Staining 4/5
Width direction Wet Colour Change 5
Width direction Wet Staining 3/4
Notes:General Notes:- Applied standard UNE-EN ISO 105-X12:2016 (Equivalent to ISO 105-X12:2016)- Requirement by the client, products for over 3 years= 3 in Grey Scale ISO 105-A02 for Colour Change 3 in Grey Scale ISO 105-A03 for Colour Staining.
- Requirement by the client, products intended for children under 3 years= 4 in Grey Scale ISO 105-A02 for Colour Change 4 in Grey Scale ISO 105-A03 for Colour Staining.
- n.a. = not applicable
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 6 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
- Lack of sample * = Component Weight < 1% Total
Test Notes:Note 1: Rubbing plug with a cylinder of (16 ± 0.1) mm, which apply a downward force of (9 ± 0.2) NNote 2: Only for Hair fabrics: Rubbing plug with a rectangular area of 19 mm x 25.4 mm, which apply a downward force of (9 ± 0.2) NNote 3: Adjacent Fabric Monofibre used: CottonNote 4: Impregnation/absorption percentage for wet rubbing: 95-100 %Note 5: Conditioning time for analyzed fabrics and adjacent fabrics: 4 hoursNote 6: Environmental conditions: (20±2) ºC and (65±2) % of RH
Specific Notes:(**) The result is out of specifications
621 SOP 62-Colour Fastness to Acid perspiration (Direct contact)
2ID
S-170708-00145ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
CAS S-170708-00145
Colour Change 5
Cross Staining n.a.
Staining Acetate 5
Staining Acrylic 5
Staining Cotton 5
Staining Linen n.a.
Staining Polyamide 5
Staining Polyester 5
Staining Silk n.a.
Staining Viscose n.a.
Staining Wool 5
Notes:General Notes:- Applied standard UNE-EN ISO 105-E04:2013 (Equivalent to ISO 105-E04:2013)- Requirement by the client, products for over 3 years= 3 in Grey Scale ISO 105-A02 for Colour Change 3 in Grey Scale ISO 105-A03 for Colour Staining.
- Requirement by the client, products intended for children under 3 years= 3-4 in Grey Scale ISO 105-A02 for Colour Change 3-4 in Grey Scale ISO 105-A03 for Colour Staining.
- n.a. = not applicable- Lack of sample * = Component Weight < 1% Total
Test Notes:Note 1: Acid solution used with pH 5.5 (± 0.2)Note 2: Adjacent Fabric Monofibre used: See Results if only appear two results in stainingNote 3: Adjacent Fabric Multifibre type used: DW, see results if appear more than two results in staining.Note 4: Perspirometer position for test: Vertical
Specific Notes:(**) The result is out of specifications
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 7 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
622 SOP 62-Colour Fastness to Alkaline perspiration (Direct contact)
3ID
S-170708-00146ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
CAS S-170708-00146
Colour Change 5
Cross Staining n.a.
Staining Acetate 5
Staining Acrylic 5
Staining Cotton 5
Staining Linen n.a.
Staining Polyamide 5
Staining Polyester 5
Staining Silk n.a.
Staining Viscose n.a.
Staining Wool 5
Notes:General Notes:- Applied standard UNE-EN ISO 105-E04:2013 (Equivalent to ISO 105-E04:2013)- Requirement by the client, products for over 3 years= 3 in Grey Scale ISO 105-A02 for Colour Change 3 in Grey Scale ISO 105-A03 for Colour Staining.
- Requirement by the client, products intended for children under 3 years= 3-4 in Grey Scale ISO 105-A02 for Colour Change 3-4 in Grey Scale ISO 105-A03 for Colour Staining.
- n.a. = not applicable- Lack of sample * = Component Weight < 1% Total
Test Notes:Note 1: Alkaline solution used with pH 8 (± 0.2)Note 2: Adjacent Fabric Monofibre used: See Results if only appear two results in stainingNote 3: Adjacent Fabric Multifibre type used: DW, see results if appear more than two results in staining.Note 4: Perspirometer position for test: Vertical
Specific Notes:(**) The result is out of specifications
130 SOP 13 - Colour fastness to domestic washing C06
4ID
S-170708-00147ID AMSLab
FABRIC GREENDescription
See ResultsConclusion*
CAS S-170708-00147
Colour Change 5
Cross Staining n.a.
Staining Acetate 5
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 8 of
19/07/2017Job No./Report No: 17-010613Date:
TEST REPORT
SOP and results with (*) are not included in the ENAC acreditation scope
CAS S-170708-00147
Staining Acrylic 5
Staining Cotton 5
Staining Linen n.a.
Staining Polyamide 5
Staining Polyester 5
Staining Silk n.a.
Staining Viscose n.a.
Staining Wool 5
Washing Temperature 30ºC
General Notes:- Applied standard UNE-EN ISO 105-C06:2010 (Equivalent to ISO 105-C06:2010)- n.a. = not applicable- Lack of sample * = Component Weight < 1% Total
- Requirement recommended= 3 in Grey Scale ISO 105-A02 for Colour Change 3 in Grey Scale ISO 105-A03 for Colour Staining.
Test Notes:Note 1: Test Temperature: Indicated in results tableNote 2: Test number according with Tª: A1S (40ºC - 30 min) / A1M (40ºC - 45 min) / B1S (50ºC - 30 min) / B1M (50ºC - 45 min) / C1S (60 ºC -30 min) / C1M (60 ºC - 40 min)Note 3: Steel balls used: YesNote 4: Treatment with acetic acid: NoNote 5: Detergent used: ECE phosphate reference detergent (B)Note 6: Adjacent Fabric Monofibre used: See Results if only appear two results in stainingNote 7: Adjacent Fabric Multifibre type used: DW, see results if appear more than two results in staining.
Specific Notes:(**) The result is out of specifications
19/07/2017Issue Date:
Signed: Manuel Lolo Signed: Pablo Perez Signed: Esteban Ramirez
General Manager Physical Lab ManagerChemical Lab Manager
-Reported results do not include uncertainties (but are available for the customer).-Opinions and interpretations expressed herein are outside the scope of accreditation.-Unless otherwise stated the result shown in this test report refer only the sample/s tested and such sample/s are retained for 30 days only.-Test reports without AMSLab seal and authorized signatures are invalid.-This document can’t be reproduced or modified except in full, without prior given approval of the company.-Any printed copy of this document is copy from the original digital document.Applied Mass Spectrometry Laboratory, S.L.U.Avda. Benigno Rivera, n°56 27003 Lugo (Spain)Tel.: +34 982808074 - Fax.: +34 982803180 [email protected] / www.ams-lab.com 9Pag. 9 of