TABLE OF CONTENTS...3 ENSURE THAT ALL CABLE SHEAVES, BEAR INGS, AND SHAFTS ARE SUFFICIENTLY LUBR...

21
2 TABLE OF CONTENTS ............................................................................................................................................................................................ 2 ................................................................................................................................................................. 2 ....................................................................................................................................................................................................... 3 ................................................................................................................................................................................ 5 ..................................................................................................................................................... 6 ....................................................................................................................................................... 7 ........................................................................................................................................................................................... 7 .................................................................................................................................................................................................. 15 ............................................................................................................................................................................................................... 16 ..................................................................................................................................................................................................... 17 .................................................................................................................................................................. 17 ........................................................................................................................................................................................................ 19 ........................................................................................................................................................................... 20 ........................................................................................................................................................................................................................ 21 IMPORTANT INFORMATION Two Post Lifts 1. 2. - There can be no cracks in the slab within 36 in. of the base plate location, and no seams in the foundation within 6 in. of its location! Remember: any structure is only as strong as the foundation on which it is located! IMPORTANT! Make sure you have extra help or heavy duty lifting equipment when unloading and assembling the lift. 3. 5. 6. 7. This is a vehicle lift installation/operation manual and no attempt is made or implied herein to instruct the user in lifting methods particular to an individual application. Rather, the contents of this manual are intended as a basis for operation and maintenance of the unit as it stands alone or as it is intended and anticipated to be used in conjunction with other equipment. Proper application of the equipment described herein is limited to the parameters detailed in the specifications and the uses set forth in the descriptive passages. Any other proposed application of this equipment should be documented and submitted in writing to the factory for examination. The user assumes full responsibility for any equipment damage, personal injury, or alteration of the equipment described in this manual or any subsequent damages.

Transcript of TABLE OF CONTENTS...3 ENSURE THAT ALL CABLE SHEAVES, BEAR INGS, AND SHAFTS ARE SUFFICIENTLY LUBR...

  • 2

    TABLE OF CONTENTS ������������������ ............................................................................................................................................................................................ 2 ������������������������������ ................................................................................................................................................................. 2 ������������������ ....................................................................................................................................................................................................... 3 ����������������������� ................................................................................................................................................................................ 5 ���������������������������������� ..................................................................................................................................................... 6 �������������������������������������� ....................................................................................................................................................... 7 �������������������� ........................................................................................................................................................................................... 7 �������������

    �� .................................................................................................................................................................................................. 15 ������������� ............................................................................................................................................................................................................... 16 ����������������� ..................................................................................................................................................................................................... 17 ����������������������������� .................................................................................................................................................................. 17 �����!�������� ........................................................................................................................................................................................................ 19 ���������������!�����"� ........................................................................................................................................................................... 20 ��������� ........................................................................................................................................................................................................................ 21

    IMPORTANT INFORMATION Two Post Lifts 1. �#���$%&'(���)�&$�)*+(�,$���($�����('$���$%&'(�,%--�,$���$�+%&�%�&������$/��($��(��('$���$%&'(�4���%$� 8%('�����$%&'(�4-�%)�

    $+(�,-%+'$�:���$�(%�#�('$�4�)/��$�(+�����4'$4;�����+'��(�&$+:����+'��(�&$+���$ �%+4�+�/-��+�8'$���//-%4�,-$�(��$+(�,-%+'�('$�,$+(�-%�(�-�4�(%��:�'$ -%�(�+'�*-��,$�-�4�($��������$-�(%

  • 3

    ENSURE THAT ALL CABLE SHEAVES, BEARINGS, AND SHAFTS ARE SUFFICIENTLY LUBRICATED. ALSO, THE CORNERS OF EACH COLUMN SHOULD BE LIGHTLY GREASED WITH QUALITY TYPE LITHIUM GREASE PRIOR TO OPERATING THE LIFT. LUBRICATE ALL ON AN ANNUAL BASIS. Motors and all electrical components are not sealed against the weather and moisture. Install this lift in a protected indoor location. Failure by the owner to provide the recommended shelter could result in unsatisfactory lift performance, property damage, or personal injury. '%+�-%�(�%+����F=AAA�-,:�4�/�4%(#=�2-��+(��%�(+:�'$�-�4;%�&�-�(4'�+#+($)�%+�

  • ?

  • 5

    LIFT AREA LAYOUT INFORMATION OVERHEAD MODEL (Asymmetrical Arm configuration) NOTE: Lift can be installed so power unit can column can be located on either side. However to save operation steps it is recommended that it is placed on passenger side of lift.

  • 6

    FOUNDATION and ANCHORING REQUIREMENTS 1. ���4�$($�+'�--�'�

  • 7

    TOOLS REQUIRED FOR INSTALL The installation of this lift is relatively simple and can be accomplished by two men in a few hours. The following tools and equipment are needed:

    � ��%+(�������;-%�(�D�/(%���-E � �$(�%4���4;$(+������/$��"�$�4'�+$( � 8��IA>�(��IL>�+($/�-���$�+ � �%+$�&�%/+ � ����@L��%&'(��#���*-%4��%-�D�//��G:�IL�C*��(+E � N))���4;$(��$���"�$�4' � �/$��$�+*�$ � ��C*$�8�$�4'�8%('�I-I�NK�+�4;$(�������4'��+ � ?>��$

  • N

    Anchors must be at least 6” from the edge of the slab or any seam. 1. �+$���4��4�$($�'�))$����%--�8%('���4��,%�$�(%/=�+�-%����%--�,%(�('$�+�)$��%�)$($���+�('$���4'��=�@�?H:�D:MMP�(��:MNM�%�4'$+��%�)$($�E.

    �����(�*+$�$G4$++%

  • 9

    STEP 13. ��+(�--�('$��

  • 10

    '%+�%+�('$����-��8$�$��+%�$�4���%�&$:�'$�����8�%+�8'$�$�('$�4�,-$����)�('$���8$��+%�$�4�)$+���8�:������('$��%&'$+(�+$((%�&=�*+$�('$�$#$-$(��(�('$�(�/=�-$�(�'����4���$�:������('$�-�8�+$((%�&=��%�$4(-#�,$-�8�('$�(�/�$#$-$(=�('$�$�%+���+$4����$#$-$(�%�+%�$�('$�4���%�&$:����++�('$�4�,-$�('��*&'�('$�(�/�$#$-$(�����,�-(�%�(��('$�%��$�=�'%��$��$#$-$(:��W*+(�,$�+*�$�4�,-$+������(�4��++����������(�(%&'($��('$�4�,-$��*(+���8��*�(%-�('$#���$��*�����*���('$�/*--$#+:

    STEP 18. �T*+(�('$�4���%�&$�4�,-$�($�+%��:�'%+�%+��44�)/-%+'$��,#�(%&'($�%�&�('$�4���%�&$���T*+()$�(��*(����('$�(�/����$�4'�

    4���%�&$:�'$��$���4���%�&$���T*+()$�(��*(���T*+(+�('$��//�+%($�/�+(�4���%�&$�'$%&'(:�'$�-$�(�/�+(�4���%�&$��*(���T*+(+�('$��%&'(�4�-*)��4���%�&$=�����('$��%&'(�4�-*)��4���%�&$��*(���T*+(+�('$�-$�(�4�-*)��4���%�&$:��T*+(�$�4'�4�,-$�(���//��G%)�($-#�SH�+%�$-(�-+%�$�/-�#:

    STEP 19. �#-%��$��4$�($�%�&�����4'�%��%�+(�--�(%��Q���;$�+*�$�('$�X%/H����('$�,�((�)����('$ 4#-%��$��%+�/��/$�-#�-�4�($��%�(��('$�4$�($��'�-$����(�/����('$�4#-%��$��)�*�(�%��,�+$:��*--�('$ /�$-�((�4'$��-$���4'�%��%��,�('�+%�$+�*/������

  • 11

    STEP 23. �T*+(�('$�4���%�&$�4�,-$+�($�+%��:��T*+(�$�4'�4�,-$�(���//��G%)�($-#�I�LK�+%�$-(�/+%�$ /-�#: �'$4;�('$�-�(4'��$-$�+$+�(��%�+*�$�('$�4���%�&$�%+�+(%--�+%((%�&����('$��//��/�%�($�-�(4':

    STEP 24. �$)�

  • 12

    STEP 2. Disconnect Electrical Power Before Installation

    Over Head Shut Off Wires

    Connect Ground Wire

    Over Head Shut-Off Wire Bundle

  • 13

    ��8�#�*���$��$��#�(��4���$4(�('$��*+'�!*((���X��H�8%�$�(����$����('$�L�8%�$+��$)�%�%�&�%��('$��

  • I?

    STEP 4. ��8�4���$4(�('$��$)�%�%�&�8%�$�(��($�)%��-�3L2. Disconnect Electrical Power Before Installation

    Remaining wire to terminal 3L2

  • 15

    LIFT LOCKOUT/TAGOUT PROCEDURE Purpose '%+�/��4$�*�$�$+(�,-%+'$+�('$�)%�%)*)��$C*%�$)$�(+�����('$�-�4;�*(����$�$��('�(�4�*-��4�*+$ %�T*�#�(��/$�+���$- ,#�('$��/$��(%������-%�(+�%���$$������$/�%�����,$%�&�+$�

  • 16

    SAFETY AND OPERATING INSTRUCTIONS Only authorized personnel are to operate lift Read operating and safety procedures manual completely before operating lift.

    � ���/$�-#�)�%�(�%������%�+/$4(�-%�(�%���44�����4$�(���8�$�>+�)��*�-: � �����(��/$��($���-%�(�('�(�%+���)�&$�����%���$$������$/�%�: � --�8���-#��*('��%O$��/$�+���$-�%��('$�-%�(�,�#: � �(�#�4-$�������%�(�8'$����%+%�&����-�8$�%�&�D���������E � �$$/�'���+������$$(��8�#����)�/%�4'�/�%�(+��(��--�(%)$+: � �$

  • 17

    SAFETY PROCEDURES � �$

  • IN

    Weekly Maintenance (every 40-Hours) 1. �'$4;���4'���,�-(+�(��C*$�(��PA��(--,+�����('$�\�%�:���4'���,�-(+:������(�*+$����%)/�4( 1. 8�$�4'�(��(%&'($����4'���,�-(+: 2. �'$4;��-��������+(�$++�4��4;+��$�����4'���,�-(+: 3. �'$4;�'#���*-%4��%-�-$

  • 19

    TROUBLESHOOTING '$�4�))���/��,-$)+�('�(�)�#�,$�$�4�*�($�$������('$%��/��,�,-$�4�*+$+���$ 4�

  • 20

    ILLUSTRATED PARTS BREAKDOWN

  • 21

    PARTS LIST OF OH LIFT ITEM DRAWING DESCRIPTION QTY PRICE 1 ��?"-L�I-00 �����������"���������� 1 2 ��?"-L�I-00 �����������"���������� 1 3 ��?"-100-00 ��������������� 1 ? !PMNL-NJ ��]

    ��������!�� �IL]?A L? 5 !F@-NM �����"�����IL L? 6 !FM:I-NP ���"�����IL @? 7 !JIMA-NJ ��]

    ��������IL 29 N ��?�-?AA-A? ����������� ? 9 ��?A-700-02 ������!���"�����!������ ? 10 ��?�-?AA-02 ?K�������!���"���� ? 11 !NF?:I-NJ ]��������������LP 10 12 ��?�-?AA-01 ���������� 2 13 ��?�-?AA-03 ����!������ 2 I? ��?�-?�A-00 ����!���"���������� 1 15 !PMNL-NJ ��]

    ��������!����IL]LP 5 16 ��?�-?�A-00 ����!���"���������� 1 17 !FI-NJ ����������L]LA N IN ��?A-000-12 �������� ? 19 ��?"-000-03 �"������!������� 10 20 ��?�-600-00 "������������ 2 21 ��?A-200-03 �!���"����� 2 22 ��?A-200-A? �!���"�����"���� 2 23 ��?A-200-05 �������!������ 2 L? ��?A-000-09 �����������]���������������� 2 25 ��?A-000-!IA ��-����!������������� 2 26 ��?A-100-00 ������������ 2 27 ��?"-000-02 ���������DW���-��E 1 LN ��?A-200-01 "����"������ 2 29 !NIN-NP ��������������������������"��J]N 20 30 ��?A-000-AN ���������D����-��E 1 31 ��?�-000-IN ���� 2 32 ��?A-000-A? �����W����� ? 33 ��?A-000-05 ����W���� ? @? ��?�-000-21 �����������"������� 1 35 ��?"-000-01 ����������� 1 36 !PMNL-NJ ��]

    ��������!����N]LP ? 37 !FM:I-NP ���"�����N N @N !F@-NM �����"�����N ? 39 !JIMA-NJ ��]

    ��������N ? ?A !FM:I-NP ���"�����LA ?I !JIMA-NJ ��]

    ��������LA N ?L ��?"-500-�A ����!����������"���������� 1 ?@ ��?A-500-02 �]������������ 2 ?? ��?A-521-00 ���������!�����"���������� 2

  • 22

    ?P !PMN@-NJ ��]

    ��������!����LA]PA 2 ?J ��?A-500-03 �������!������ 2 ?M !F@-NM �����"�����LA 2 ?N !JIMA-NJ ��]

    ��������LA 2 ?F !NIN-NP ��������������������������"��J]@P 2 50 !FM:I-NP ���"�����J 2 51 ��?A-520-01 ������������������ 2 52 ��?"-?AA-00 �����������"���������� 2 53 !NMF-NJ �������������������� ? P? ��?A-530-02 ������������������ ? 55 ��?"-500-�A ����!����������"���������� 1 56 ��?A-NAA-00 !���"���������� ? 57 ��?"-310-00 ����"��"���������� 2 PN ��?A-000-15 ���������!����IA ? 59 ��?A-530-01 ����!� ? 60 !JIMA-NJ ��]

    ��������IA ? 61 !F@-NM �����"�����IA ? 62 !FM:I-NP ���"�����IA N 63 ��?A-530-A? ��� ? J? ��?A-530-03 ������� ? 65 ��?A-200-02 �������� 2 66 ��?A-500-01 ������!���� 16 67 ��?A-100-03 �������]�� 2 JN ��?A-100-02 ����������� 2 69 ��?A-100-A? !�������! 2 70 ��?A-500-A? "������� 2 71 !MA-NP ��]��!�������������������������"���J]LA ? 72 ��?A-000-03 ������� ? 73 ��?A-000-02 ����� ? M? �-��� 1 75 !NIF-NP ����������������������������������"��J]IL ? 76 !FM:I-NP ���"�����J ? 77 ��?�-]LA-01 !������� 2 MN ��?�-]LI-00 !�����"���������� ? 79 ��?"-000-A? ����������� 2 NA !NIN-NP ����������������������������������"��J]LA ? NA ��?�-000-05 �����!��� 6 101 ��?�-320-00 ����- ������������� ? 102 ��?A-520-00 ����������������!����� 2 103 ��?�-]LA-00 !��������� 2