SPRITE MK III AND IV MIDGET MK II AND III SPRITE MK 3 ...SPRITE MK III AND IV MIDGET MK II AND III...

SPRITE MK III AND IV MIDGET MK II AND III

III. No. I Part No. IIIIIISPRITE MK 3 ANDMK 4,MIDGETMK 2 ANDMK 3

DESCRIPTION I Qty . I Change Point REMARKS

n~~!O20 2S 21 15 19

~

9-110-8..II~121 Q-1413~

If- 25i

~ I~- - -

2

I16

8G 26688G 2668 20

8G 2432 38G 2432 23

2 8G 24332 8G 2433 203 AEG 189

AJJ 3377 3AJJ 3377 23AJJ 3377 43

4 88G 2294 AEA 7314 AEA 6485 2A 299

6 AEG 5676 AEG 5426 AEG 5297 12G 7298 AEG 578

AHT 4013AEG 417

AHT 141

12A 18612G 296AEA 400AEA 311AEA 401AEA 402AEA 4032A 8792A 11AHT 288AHT 326

8G 26688G 2668 20

8G 2432 38G 2432 23

2 8G 24332 8G 2433 203 AEG 189

SPECIAL TUNING-ENGINE UNIT

PISTON ASSEMBLY-ENGINE SETGRADE 3-9.75: 1 COMPRESSIONRATIO

Standard 1SET.020"(.508mm)O/S 1SET

PISTON ASSEMBLY-ENGINE SET-GRADE 3-12 : 1 COMPRESSIONRATIO


RING-PISTON-ENGINE SETStandard 1SET.020"(.508mm)O/ S 1SET

Pin-gudgeon .4PISTON ASSEMBLY-ENGINE SET-GRADE 3-9.75: 1 COMPRESSIONRATIO-LIGHTWEIGHT FORGED

Standard 1SET.020"(.508mrn)O/S 1SET.040"(1.016mm)O/S 1SET

CAMSHAFTTuning 1Competition 1Racing 1

Pin-driving-oil pump 1CAMSHAFT

Road use 1Rally 1Racing 1

Flange-driving-oil pump 1Gear-camshaft-lightened 1MAIN BEARING SET 1

Main bearing nuts NLA

HEAD ASSEMBLY-POLISHED-COMPLETE t .Guides 8Valve-inlet 4Valve-exhaust .4Spr ings-outer 8Springs-inner 8Cap-top 8Washer-bottom 8Seals 8Cotters 8PRSWasher -spring(Disc) 1SETCrankshaft-Nitrided 1

PISTON ASSEMBLY-ENGINE SETGRADE 3-9.75: 1 COMPRESSIONRATIO


PISTON ASSEMBLY-ENGINE SET-GRADE 3-12: 1 COMPRESSIONRATIO


RING-PISTON-ENGINE SETStandard 1SET.020"(.508mm)O/ S 1SET

Pin-gudgeon .4PISTON ASSEMBLY-ENGINE SET-GRADE 3-9 .75 : 1 COMPRESSION

]C-MG

] C-MG,1098cc

1098CC

] C-MG,1275cc

1275CCC-MG,1275ccC-MGUse with studsAEG 323 2 offand 12G 479-4 off .

C-MG

1098CC ONLY.

] C-MG

1

NOTE:_AIIPllrf§ listed with the Remark C-MG are Competition parts and must be orderedInner-150Ib 8 C-MG ,max.load

170 with camAEA 648.~~ ~~ C'-'~-·;·

17r 9 AEA 494

,~~ ... ~L.-- o © !

~

10 AEA 767

fXJ " 9 AEA 49420 25 21 IS 19

27 10 AEA 524~ 11 AEA 653

9 AEA 652

9-1

28 ----.., 10 AEA 52424 12 AEA 654

~13 AEG 54413 AEG 569,oJ

~15 AEA 69214 AEA 399

II17 RI< R7R

SPRING-VALVE9 AEA 494 Inner-150Ib .....................................8

10 AEA 767 Outer-140Ib ...........'.........................89 AEA 494 Inner-165Ib .....................................8

10 AEA 524 Outer-180lb ....................................811 AEA 653 Cup-bottom.............................................89 AEA 652 Spr ing-valve-inner-180Ib .......................8

10 AEA 524 Spring-valve-outer .................................812 AEA 654 Collar-locating ........................................8 ...13 AEG 544 Valve-inlet 1.401"(35.5mm dia) .............4 I13 AEG 569 Valve-inlet-competition .........................415 AEA 692 Screw -tappet adjusting .........................814 AEA 399 SHAFT-VALVE ROCKER-

STRENGTHENED ................................... 117 6K 878 Plug-plain .............................................. 118 2K 4608 Plug -screwed ........................................1

BRACKET-ROCKER SHAFT19 12G 1926 Plain ................................................22 12G 1926 With oil hole ..................................1

20 12G 1927 Tapped ........................................... 121 12G 1221 ROCKER-VALVE(FORGED) ...................822 2A 21 Bush .......................................................823 5C 2436 Rivet .......................................................824 12H 2178 Washer-cylinder head nut .....................525 AJJ 3325 KIT-CHAIN TIMING-DUPLEX .................1

AEG 578 Sprocket-camshaft ............................... 1AEA 695 Sprocket-camshaft ............................... 12H 4905 Chain -timing ......................................... 1AEA 687 Screw-countersunk ..............................2AEG 392 Spacer-valve rocker ...............................3

26 AEA 539 Belt-fan-short .........................................2PLUG-SPARKING

27 37H 4208 N64Y rally and road use ...............427 27H5982 N57R rac ing ...................................427 37H 2149 N62R racing ...................................427 37H 2148 N60Y racing ...................................428 88G 219 Gasket -p lug ...........................................4

REMARKS

C-MG

C-MGC-MG,not 1275cc

C-MG

C-MG ,10CC

]C-MG

C-MG ,1275cc

C-MG ,max.load170 with camAEA 648.

C-MG ,10CC

]C-MG

C-MG ,1275cc

C-MG

Outer-140Ib 8Inner-165Ib 8Outer-180Ib 8

Cup-bottom 8Spr ing-valve-inner-180Ib 8Spring-valve-outer 8Collar-locating 8Valve-inlet 1.401"(35.5mm dia) .4Valve-inlet-competition : 4Screw-tappet adjusting 8SHAFT-VALVE ROCKER-STRENGTHENED 1Pl lln-nl~ in 1

SPRITE MK 3 AND MK 4,MIDGET MK 2 AND MK 3

Part No. IIIIII DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-ENGINE UNIT-continued

III. No. ISPRITE MK III AND IV MIDGET MK II AND III

(Q~~~20 25 21 IS 19

~

9-1

10--8I I~12--6 fl

1U I..

13

\ --.

II

,, 1~.Qlf.; , ~lR.l!!"I ~ !!~,~~ .w.i.t.f:1..H1~ .R~m~r.~..~:-MG are Competit ion parts and must be orderedSump 1 J C-MGPipe-oil suction 1 C-MG,1275cc onlyBolt-bracket to strainer 2Piece-d istance 2Spring 1Gasket 1Seal-oil-main bearing cap-front 1Seal-oil-main bearing cap-rear 1

Manifold-exhaust large bore 1 ]Gasket-cyl inder head 1 C-MGGasket-manifold 1Gasket-rocker cover 1KIT-OIL COOLER 1 C-MG,1275cc

1

SPRIT E MK III AND IV MIDGET MK II AND III- - - - - - - -------- - - - --------- ------ _ . -- - - - _..

@T-----......u , ') 10

\. u

III. No. I Part No.

1 AJJ 33242 AHT 123 AHT 144 HBZ 4146 AHH 61627 6K 8718 GEG 501

12G 3016

12G 1009

11 AHT 1113 AEA 64714 AEA 41115 AEA 51116 AJJ 332317 ARH 186

AHA 839619 PMZ 41020 HZS 40421 LWZ 20422 NH 604041

AHA 8778AHA 8777

AHA 8779HZS 407

27 LWZ 20428 FNZ 10429 . AHH 6865

AHH 686619 PMZ 408

NH 60404130 AHA 3390

PMZ 314LWZ 203

33 AHA 642434 AHA 642335 12A 176837 AHA 840138 ARO 9809

39 AHT 181

I

2 AHT 123 AHT 144 HBZ4146 AHH 61627 6K 8718 GEG 501

12G 3016

12G 1009

11 AHT 1113 AEA 64714 AEA41115 AEA 51116 AJJ 3323


II II I1 DESCRIPTION I Qty· .1 Change Point

SPECIAL TUNING-~NGINE UNIT-continued

KIT-SUMP(DEEP) 1Sump 1Pipe-oil suction 1Bolt-bracket to straine r 2Piece-d istance 2Spring 1Gasket 1Seal-oil-ma in bear ing cap-front 1Seal-o il-main bearing cap-rear 1

Manifold-exhaust large bore 1Gasket-cyl inder head 1Gasket-man ifold 1Gasket -rocker cover 1KIT-OIL COOLER. 1Cooler-oil 1Bracket-support. 1Screw-bracket to coole r .4Screw-bracket to chassis .4Washer-sp ring 8Nut 8Hose-flexible-block to cooler 1Hose-flexible-filter tocooler 1Bracket -p ipe clip 1Screw 2Washer-spri ng 2Nut : ; 2Strap NLAPlate-clamp , 2Screw 2Nut 2Plate-clamp 1Screw NLAWasher-spr ing 2Adaptor-crankcase 1Adaptor-filter 1Washer-adaptor 1Grommet .4

Cooler-o il 1

Cover-oil cooler : 1

REMARKS

] C-MGC-MG ,1275cc only

] C-MG

C-MG ,1275cc

Alternative toARH 186 forracing.C-MG

~"'HII ~ MK III ANU IV MIUli~ I MK II ANU III

III. No. ISPRITE MK 3 AND MK 4,MIDGET MK 2 AND MK 3

Part No. IIIIII DESCRIPTION I Qty. I Change Point REMARKS

SPECIAL TUNING-DISTRIBUTOR-IGNITION AND ENGINE ANCILLARIES.

C-MG .

C-MG.

C-MG .

C-MG use withcompetioncamshafts.

C-MG .

l~MG

Plate-clamping 1COVER ASSEMBLy 1Brush and spring 1SET

Arm-rotor 1Contacts 1SETCondenser 1Terminal-bush and lead 1Spring-automatic advance 1SETVacuum unit 1Sundry parts 1SET

KIT-HIGH TENSION-PLUG-WATER PROOFING 1Plug-cover-Iodge 1Lead H.T. length 6 feet 1

Plate-clamping 1COVER ASSEMBLy 1

Brush and spring 1SETArm-rotor 1Contacts 1SETCondenser 1Terminal-bush and lead 1Spring-automatic advance 1SETVacuum unit 1Sundry parts 1SET

KIT-HIGH TENSION-PLUG-WATER PROOFING 1Plug-cover-lodge 1Lead H.T. length 6 feet 1Coil . 1Cover-coil 1

SWITCH-IGNITION CUT-OUT 1Pulley-dynamo for reducedspeed 1Bracket-alternator mounting 1KIT-BLANKING SLEEVE-THERMOSTAT BY-PASS 1Blanking sleeve 1Joint-thermostat 1

NOTE.AII parts listed with the remark C-MG are competition parts and must be ordered...,.__.4.__ 0.'.:_" 1_..•__ ..1 <"--_:-. T . ,_:__ ""-_. competion

camshafts.

DISTRIBUTOR. 1

2 3H 21384 GDC 1025 17H 50656 GRA 1017 GCS 1018 GSC 101

10 37H 298113 27H 802216 47H 555520 17H 5106

AJJ 4010

AHT 265AHT 266

27H 7766

2 3H 21384 GDC 1025 17H 50656 GRA 1017 GCS 1018 GSC 101

10 37H 298113 27H 802216 47H 555520 17H 5106

AJJ 4010

AHT 265AHT 266AHT 2698G 727AHT 332AEA 535

AHT 32AJJ 4012

11G 176GTG 101

EI818

2~. . .

~

~3

II

12

L__



Part No. IIIII1 DESCRIPTION I Qty. I Change Point REMARKS

SPECIAL TUNING-FLYWHEEL,CLUTCH,GEARBOX,FINAL DRIVE AND AXLESHAFT.

NOTE (1).Gear set AJJ 3319 can also be used on gearboxes fitted to 1098cc engines prior tochange po int(Le.10CC prefix) provided 1st speed wheel and synchronizer 22G 326and reverse wheel 22G 240 are fitted.NOTE (2).

FIy;Nhee-I-lfghtened::1275cc .:': ..~..~.~~1 - - - ~ :.L: _ _ --~- -_ ..... _ • • - .... - _ ..... _ .. - .... ...a: ..__•

Cover-assembly-1098cc 1Plate-driven-clutch 1Cover-assembly-1275cc 1Plate -driven 1Plate-driven-6.5" 1Plate-driven-race only 1 C-MG .KIT-GEAR SET-CLOSE RATIO-STRAIGHT CUT 1Shaft-1st Motion 1Gear-2nd speed 1Gear-3rd speed 1Laygear 1Gasket-front cover 1Gasket-cover-change speed

lever 1 ·

C-MG .

Flywheel-lightened-1275cc 1Cover-assembly-1 098cc 1Plate-driven-clutch 1Cover-assembly-1275cc 1Plate -driven 1Plate-driven-6.5" 1Plate-driven-race only 1KIT-GEAR SET-CLOSE RATIO-STRAIGHT CUT 1Shaft-1st Motion 1Gear-2nd speed 1Gear-3rd speed 1Laygear 1Gasket-front cover 1Gasket-cover-change speed

lever 1Gasket-side cover 1Gasket-extension to gearbox 1Gasket-casing to extension-front 1Gasket-casing to extension-rear 1Washer-lock-shaft 2

1 AHT 702 BHA 44483 BHA 45192 AEG 5463 AEG 5473 AHT 383

AHT 4094 AJJ 3319

5 AEG 31386 AEG 31397 AEG 31408 22G 3069 22G 165

10 2A 3341

11 2A 328612 22A 48113 2A 3344

14 2A 3345

15 2A 3035

1 AHT 702 BHA 44483 BHA 45192 AEG 5463 AEG 5473 AHT 383

AHT 4094 AJJ 3319

5 AEG 31386 AEG 31397 AEG 31408 22G 3069 22G 165

10 2A 3341

I~fA,110 ~

19

...-16CO"" 17

1- 18

~(J

J-18

~(J

SPECIAL TUNING-FLYWHEEL,CLUTCH,GEARBOX,FINAL DRIVE AND AXLESHAFT-continued.

NOTE.~!! pQ..r:tli.li~e.Q .'«iLh....tQ~.lPma[IL~-MG are comoetitinn narts ~nrl must hA nrrlArAri r1irA~t

SYNCHRONIZER ASSEMBLy 1Ball 3Spring 3

WHEEL ASSEMBLY-REVERSE 1Bush 1

Layshaft 1 Use with closerat io gear setAJJ 3319Standard for(E)12CC Da/H101 .

Part No. IIIII1 DESCRIPTION I Q1Y· I Change Point REMARKS

C-MG.

C-MG.

C-MG.

Use with closeratio gear setAJJ 3319Standard for(E)12CC Da/H101 .


Carrier 1CROWN WHEEL AND PINION

3.727:1 ratio 14.555:1 ratio 13.9:1 ratio-standard 1.Il ?? ·1 .",tin 1

Carrier : 1CROWN WHEEL AND PINION

3.727:1 ratio 14.555:1 ratio 13.9:1 ratio-standard 14.22:1 ratio 1

Differential-limited slip 1Shaft-axle-heavy duty(discwheels) 2Shaft-axle-heavy duty(wirewheels) 2

1ST SPEED WHEEL-2ND SPEEDSYNCHRONIZER ASSEMBLy 1Ball 3Spring 3

WHEEL ASSEMBLY-REVERSE 1Bush 1

Layshaft 1

22G 1118

BLS 10722G 31722G 11142A 328222G 673

23 BTA 549

24 BTA 53524 BTA 81624 BTA 1223?<1 RTA "~Q

17 BLS 10718 22G 31719 22G 111420 2A 328221 22G 673

23 BTA 549

24 BTA 53524 BTA 81624 BTA 122324 BTA 53925 BTA 122626 BTA 940

BTA 939

16

1718192021

III. No. I

12

I19

I ~b>,,120 p19


SPRITE MK. 3 AND MK. 4,MIDGET MK. 2 AND MK. 3

1 AJJ 40152 AUF 4003 21A 7504 ACB 92525 21A 6326 AUC 18337 AUC 26988 AHB 67159 AHH 6707

10 AUC 2141

REMARKS

C-MG .KIT-DUAL FUEL PUMP 1Pump-petrol-dual 1Bracket 2Rubber 2Clips 2Banjo 2Bolts 2Hose-flexible 1Hose-flexible 1Washer-fibre 4

Part No. 11.1111 DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-FUEL SYSTEM.

III. No. I;)""11 ~ IVI" III AI"U IV IVIIUU~ I IVI" II AI"U III

9

I PI.J,) qUI::>

2 AUF 4003 21A 7504 ACB 92525 21A 6326 AUC 18337 AUC 26988 AHB 67159 AHH 6707

10 AUC 2141

NOTE.~I wAt.!i'f-tm:!~jtbMl9..~~~~~~..~.-:~0.. "lro Mrnnotitinn Mrtc! <linn rn"C!t ~fiJI'i3~:..on niro"tPump-petrol-dual 1Bracket 2Rubber 2Clips 2Banjo 2Bolts 2Hose-flexible ' 1Hose-flexible 1Washer-fibre 4

SPR IT E MK III ANU IV MIUlil: I IVIK II A I\JU III SPRITE-MK 3 AND MK 4,MIDGET MK 2 AND MK 3

III. No. I Part No. 111111 - DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-CARBURETTER.

REMARKS

C-MG.

C-MG.

C-MG .

C-MG...,

CARBURETTER INSTALLATION 1PRCoupling-rod 2Bolt-coupling 4Washer-plain : 4Nut-bolt 4Lever-throttle 1Bolt-lever 1Washer-spring 1Nut-bolt 1Screw-pin 2

KIT-INSTALLATION-CARBURETTER. 1Gasket. 4Nut-lock 1Pipe-petrol-connecting 1Pipe-petrol-feed 1Trunnion 1Bolt 2Trunnion 2Screw 2Stirrup 1Stud 4

Pipe-flare for carburetter 2

NOTE.All parts listed with the remark C-MG are competition parts and must be ordered directfrom British Leyland Special Tuning Dept.,ta;upYiWg-loa:~~:~.~.~.~ ~~~.~.~ .~.i.~~ zBolt-coupling 4Washer-plain : 4Nut-bolt 4Lever-throttle 1Bolt-lever 1Washer-spring 1Nut-bolt 1Screw-pin 2

KIT-INSTALLATION-CARBURETTER 1Gasket. 4Nut -lock 1Pipe-petrol -connecting 1Pipe-petrol-feed 1Trunnion 1Bo lt 2~ -

1 AUD 1943 AUC 43344 AUC 26695 AUC 46126 AJD 8014 Z7 AUC 44548 AJD 10429 LWZ 303

10 AJD 8012 Z13 AUC 504714 AJJ 333415 AEH 55119 53K 139220 ACH 897721 AHB 905922 1B 269723 53K 102324 AUC 505825 AUC 504726 AUC 102527 CHS 2614

AHT 247

3 AUG 43344 AUC 26695 AUC 46126 AJD 8014 Z7 AUC 44548 AJD 10429 LWZ 303

10 AJD 8012 Z13 AUC 504714 AJJ 333415 AEH 55119 53K 139220 ACH 897721 AHB 905922 1B 269723 53K 1023

E2 7 0 2

30

28

~.reo~~




SPECIAL TUNING-CARBURETTER-WEBER TYPE.

REMARKS

NOTE.

~W~~~~:[~i?~~~~fgE!6'i~i:::::T- u_u~,~'u --~- u ~ u - ~ ]~_~~.~Manifold 1Bracket-throttle 1Bolt 2Washer 2Bracket-abutment 1Washer 2Cable-thrott le 1 C-MG .Trunnion 1Nut 1Lever 1Bol t 3Washer 4Nut 6Washer 6

30

28

rj{;l)....-.1',1\'

0 " " ....

~.

-«.

29 AHT 14330 AJJ 336031 AHT 11332 AHT 19933 SH 50506134 LWZ 30535 ACA 528937 PWZ 20339 AHT 8540 ACC 506242 FNZ 20444 AUC 150145 53K 12846 LWZ 20347 FNZ 10348 PWZ 10549 AUC 445450 ACB 531151 AHB 611452 AHT 15653 PCR 80954 AEH 78655 12A 556 AEC 207557 AEH 77659 LNZ 20560 AHT 15561 AHT 15762 AEA 605

7H 25663H 2287

29 AHT 14330 AJJ 336031 AHT 11332 AHT 19933 SH 50506134 LWZ 30535 ACA 528937 PWZ 20339 AHT 8540 ACC 506242 FNZ 20444 AUC 150145 53K 12846 LWZ 20347 FNZ 10348 PWZ 105

Carburetter-Weber(45 DCOE) 1KIT-INSTALLATION-WEBER-CARB 1Manifold 1Bracket-throttle 1Bolt 2Washer 2Bracket-abutment. 1Washer 2Cable-throttle 1Trunnion 1Nut 1Lever 1Bolt 3Washer 4Nut 6Washer 6Lever 2Ball -jo int 2Rod 1Petrolflex 26" 1Clip 1Adaptor-union 1Bracket for spring 1Spr ing 1Stud 4Nut 4Spindle 1

~8,~F~g~~.~.~.~~:::.':::::::::::::::::::::::::::::::::::~Plug-servo 1Washer. 1

C-MG .

C-MG .

C-MG .

C-MG.

]C-MG.

SPRITE MK III AND IV MIDGET MK II AND IIISPRITE MK 3 ANDMK 4,MIDGETMK 2 ANDMK 3

REMARKS

] C-MG.

IIIIII DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-TWIN CARBURETTER ASSEMBLY.

CARBURETTER ASSEMBLY-FRONT 1CARBURETTER ASSEMBLY-REAR 1

BODY ASSEMBLY-FRONT 1BODY ASSEMBLY-REAR 1Pin-piston lifting 2Spring-pin 2Circlip-pin 2

CHAMBER AND PISTON ASSEMBLY 2Screw-needle locking 2

Washer(fibre) 2Spring-piston-blue 2Screw-chamber to body 6Jet 2Nut-adjusting 2Spring-adjusting nut 2Nut-gland sealing 2Ring-seal ing(aluminium) 2Ring-sealing(cork) 2Washer-bottom bearing NLABearing-bottom 2Washer-gland(cork) .4Washer-gland(brass) .4Spring-gland 2Bearing-top 2Washer-top bearing NLANeedle-jet standard(No.6) 2Lever-jet : NLASpring-jet-lever -return 2Link-jet lever 2Pin-link to body 2Pin-link to lever 2Pin-lever to jet 2Pin-split NLAWasher-starlock 2Spindle-throttle(front) NLASpindle-throttle(rear) 1Lever-throttle stop NLAScrew-adjusting 2Pin-taper NLALever-return spring 2Bolt-lever 2Washer-plain 2Nut-bolt 2Disc-throttle 2Screw-disc 4Chamber -f1oat(front) 2

NOTE.All parts listed with the remark C-MG are competition parts and must be ordered directJrrqm.'2.~i~Ls,h,l.:.~yl.~OQ,§.~~~'-:r.Ilr;ti(l.9..P.~P.t·. JBODY ASSEMBLY-FRONT.. 1 C-MG.BODY ASSEMBLY-REAR 1Pin-piston lifting 2Spring-pin 2Circlip-pin 2

CHAMBER AND PISTON ASSEMBLY 2Screw-needle locking 2

Washer(fibre) 2Spring-piston-blue 2Screw-chamber to body 6Jet 2Nut-adjusting 2Spring-adjusting nut 2Nut-gland sealing 2Ring-sea ling(aluminium) 2Di ... " ro.ooli ..." ..1,.._......\ t)

III. No. I Part No.

AUC 9353AUC 9354

2 AUD 7047AUD 9024

3 AUC 12494 AUC 11515 AUC 12507 AUD 25008 AUC 2057

10 AUC 490011 AUC 458712 AUC 217513 AUC 818214 AUC 212115 AUC 211416 AUC 323217 AUC211718 AUC 211819 AUC 323320 AUC 323121 AUC 212022 AUC 211923 AUC 115824 AUC 323025 AUC 212226 AUD 100527 AUC 404528 AUC 466729 AUC 471930 AUC 238131 AUC 500932 AUC 238133 CPS 20434 AUC 500435 AUC 3212

AUC 351336 AUC 219937 AUC 2521

AUC 210640 AUC 820941 AJD 104242 AUC 839643 AJD 8012 Z44 AUC 311645 AUC 135846 AUC 3496

+t ~37

-4S0 \--38

~ " • 39~~36

~_-43

./~ .. 3S ~ -42

o ~-40

1--41

\)

.. .. ':. .c.l.·"\ '. \\

.: \Il~

II

9

~IO~

E2419

2 AUD 7047AUD 9024

3 AUC 1249

\)4 AUC 11515 AUC 12507 AUD 25008 AUC 2057

Il~ \ , '. \~ 10 AUC 4900.:" 11 AUC 4587

12 AUC 2175

. ~. ~13 AUC 818214 AUC 2121

9 ~3715 AUC 2114

~'O+t 16 AUC 3232

I e, \--38 17 AUC 2117-4S ill 11.11('')1111


REMARKS

Washer-plain-pillar 2Washer-inner(steel) 2Washer-outer(steel) 2Grommet(rubber) 4Locknut-pillar 2Float 2Lid-float chamber(front) 1Lid-float chamber(rear) 1Gasket-lid 2Needle and seat 2Lever-hinged 2Pin-hinge 2Nut-cap 2Washer(aluminium) 2Pipe-air vent and overflow 2Washer(fibre) 2Bolt-banjo 2Washer(fibre) ~ 4Filter 2


Part No. III1II DESCRIPTION I Qty . I Change Point

SPECIAL TUNING-TWIN CARBURETTER ASSEMBLY-continued

48 AUC 138449 AUC 138950 AUC 138851 AUC 153452 AJD 8206 Z53 AUC 112354 AUO 2283

AUD 228455 AUC 114756 AUO 909657 AUO 228558 AUC 115259 AUC 186760 AUC 155761 AUC 320062 AUC 192863 AUC 269864 AUC 214166 AUC 2139

III. No. I

48~47~

<49-~

51~

~~50 ft

- 51

+4 ~37

<45J \---38iU 39 ~@-36

~ . >~;;k :~,-35~<40

J1- 41

[- , - - -

1\

9

~\O~/

11-'

15 &?

1<4 {)ll A~3 --\

21 _.e!)

11 ~10 - -~ 1918 --~

'7 -- -~16 .----t:-::!

~1;<4\l.-' 58------./

:\

/ 33 57

13 \~ ~~ ~19 30 ~

~ 1811 ~ • c:(}31 53 -

~34 <46

17 ~

~ 3331

i-------- ------n

-

9

~,o.--------.

E2419

48 AUC 138449 AUC 138950 AUC 138851 AUC 153452 AJD 8206 Z53 AUC 112354 AUO 2283

AUD 228455 AUC 114756 AUO 909657 AUO 2285

. 58 AUC 115259 AUC 186760 AUC 155761 AUC 3200~., Allr. 1Q?A

NOTE.Washer-plain-pillar 2Washer-inner(steel) 2Washer-outer(steel) 2Grommet(rubber) 4Locknut-pillar 2Float 2Lid-float chamber(front) 1Lid-float chamber(rear) 1Gasket-lid 2Needle and seat 2Lever-hinged 2Pin-hinge 2Nut-cap 2Washer(aluminium) 2Pipe-air vent and overflow 2WJ'l~hpr{fihrp\ _ n _ _ n __ nn 2



Part No. IIII11 DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-INSTALLATION KIT FOR HS6 CARBURETTERS

REMARKS

NOTE.A!I parts listed. ~ith the remark ~-MG are competition parts and must be ordereddirect from British Leyland Special Tuning Dept.~ ~~ _ . -. ·_ .~ l.-.. r":\. • • _ I . __'- ! ._ .

AUD 416 SU HS6carburetters

ILLUSTRATION NOT USED

AJJ 4001

12G 297PWZ 105LNZ 20512G 2463ADP 21037H 4760

AHT 8512H 889ACH 585412H 100127H 307351K3811AHH 5791HZS 510AHT 239

AEC 2075CHS 2513ACC 5062FNZ 204AHA 636753K 3503AEG 349AAA 649ZCS 405LWZ 304PWZ 105ADP 210AHH 7209AHT 392

12G 297PWZ 105LNZ 20512G 2463ADP 21037H 4760

AHT 8512H 889ACH 585412H 100127H 307351K 381141-l1-l1;.701

KIT-INSTALLATION FOR HS6CARBURETTER 1

Ferrule 2Washer-plain 8Nut 12Manifold-inlet. 1Plug-screwed 1Pipe-petrol(flexible) AIR

Cable-accelerator 1Piece- 'T ' 1Clip 6Clip 2Adaptor 1Washer-copper 2Joint 2Screw 4Bracket-throttle returnspring 1Spring 4Stud 8Trunn ion 1Nut 1irunnion 1Screw 1Bracket-abutment... 1Washer-tab 1Screw 1Washer-spring 1Washer-plain 4Plug 1Pipe-flare 2Pipe-flare-1.75" alloy 1

Ferrule 2Washer-plain 8Nut 12Manifold-inlet.. 1Plug-screwed 1Pipe-petrol(flexible) AIR

Cable-accelerator 1Piece-'T' 1Clip 6Clip 2Adaptor 1Washer-copper 2. In i n t ?

'1

C-MG.Use withAUD 416 SU HS6carburetters

Supplied in 10'(3.048m)lengthsC-MG

C-MG

C.MG

]Alternat ivesC-MG

Supplied in 10'(3.048m)lengthsC-MG

C-MG



SPECIAL TUNING-TWIN HS6 CARBURETTERS

III. No. I REMARKS

C-MG

C-MG


CARBURETIER INSTALLATION(HS6) 1CARBURETIER ASSEMBLY-FRONT. 1CARBURETIER ASSEMBLY-REAR. 1

BODY ASSEMBLY-FRONT 1BODY ASSEMBLy-REAR 1Pin-lift piston 2Spring-piston lift pin 2Washer-tab 1

Circlip-piston lift pin 2SUCTION CHAMBER ASSEMBLy 2Screw-needle locking 2

Cap and damper 2Washe r(fibre) 2Spring-piston-Red 2Screw-securing 6JET-ASSEMBLY-FRONT 1JET-ASSEMBLY-REAR 1Nut : 2Washer 2Gland 2Ferrule 2

Bearing-jet 2Washer-jet bearing 2Screw-jet locking 2Spring 2Screw-jet adjusting 2Chamber-float 2Washer-support 2Grommet(rubber)-front 1Grommet(rubber)-rear 1Bolt-mounting 2Bolt-float chamber fixing 2Float 2Needle and seat assembly 2Lid-float chamber-front 1Lid-float chamber-rear 1Gasket-lid 2Screw-lid 6Washer-spring 6Throttle-spindle 2Throttle-disc 2Screw-disc , 4Lever-throttle-front 1Lever-throttle-rear 1Lever-lost motion 2

NOTE.CARBURETIER INSTALLATION(HS6) 1CARBURETIER ASSEMBLY-FRONT . 1CARBURETIER ASSEMBLY-REAR. 1

BODY ASSEMBLY-FRONT 1BODY ASSEMBLy-REAR 1Pin-lift piston 2Spring-piston lift pin 2Washer-tab 1

Circl ip-piston lift pin 2SUCTION CHAMBER ASSEMBLy 2Screw-needle locking 2

Cap and damper 2Washer(fibre) 2Spring-piston-Red 2~('r.. w_ll:: ..('I ..inn n

AUD 416

CUD 9093CUD 9094AUD 9544AUD 9550AUC 1249AUC 1151AUC 1206AUC 1250AUD 9187AUC 2057AUC 8114AUC 4900AUC 4387.11.11(' ?17l:;

AUD 416

CUD 9093CUD 9094AUD 9544

2 AUD 95503 AUC 12494 AUC 1151

AUC 12065 AUC 12506 AUD 91877 AUC 20578 AUC 81149 AUC 4900

10 AUC 438711 AUC 217512 AUD 914812 AUD 914913 AUD 212914 AUD 219315 AUD 219416 AUD 219517 AUC 846018 AUC 847819 AUC 200220 AUC 211421 AUC 846123 AUC 131026 AUC 1329

AUD 267733 AUD 267625 AUC 131824 AUD 301727 AUD 990429 AUD 9585

AUD 925830 AUD 920331 AUC 845932 AUC 2175

LWZ 30334 AUC 849435 AUC 328036 AUC 1358

AUD 278837 AUD 278738 AUC 1400

234

56789

1011

"'4 --"~" ,- --- - .. (r-

30 - -:::: ------

29

27~28_~. )31 ....------:

23 . ~o~1.

~".'~

9


SPECIAL TUNING-TWIN HS6 CARBURETTERS-contlnued


III. No. I

AUD 216339 AUD 216440 AUC 142441 AUC 262543 AUC 848353 AUC 2451

AUD 949244 AUD 9493

PTZ 60545 AUC 142646 AUC 847350 AUD 207649 AUC 5032

AUC 846251 AUC 1375

AUD 205052 AUD 204955 AUC 2439

AUE 58656 AUE 58757 AJD 104258 AUC 839658 AJD 8012 Z54 AUE 18057 AJD 1042

LWZ 30359 AJD 8012 Z

MO 0022A

JO~L~,,__ &..IVV

39 AUD 216440 AUC 1424

9 41 AUC 262543 AUC 8483

29~53 AUC 2451

AUD 9492

28 44 AUD 9493PTZ 605

27~45 AUC 142646 AUC 8473

31 ....---.-: 50 AUD 2076b

49 AUC 5032

23~ ~-~AUC 8462

51 AUC 1375AUD 2050

kl) Alln I)nAO


REMARKS .

Lever-earn-front 1Lever-earn-rear 1Bearing-nut 2Washer-spacing 1Screw-stop 4Spring-screw locking 4Lever-pick-up-front 1Lever-pick-up-rear 1Screw-self-tapping 2Bolt-pivot-earn lever 2Tube-pivot bolt 2Washer-spring 2Washer-distance 4Spring-pick-up lever-front... 1Spr ing-pick-up lever-rear 1Spring-earn lever-front 1

, Spring-earn lever-rear 1Rod-connecting 1

LEVER ASSEMBLY-FRONT 2LEVER-ASSEMBLY-REAR 2Bolt-lever 4Washer -plain 4Nut-bolt 4

Lever-throttle 1Bolt-lever 1Washer-spring 1Nut-bolt 1

NOTE.1!~AAr:te.J,il!ltfl<t,'«!~~J~.~ .~~.'!1.~.~~.~:~0:~rA r.nmnAtitinn n",rt~ ",nn mild ho Imiororl

Lever-earn-rear 1 -Bear ing-nut 2Washer-spacing 1Screw-stop 4Spring-screw locking 4Lever-pick-up-front 1Lever-pick-up-rear 1Screw -self-tapping 2Bolt-pivot-earn lever 2Tube-pivot bolt 2Washer-spring 2Washer-distance 4Spring-pick-up lever-front... 1Spr ing-pick-up lever-rear 1Spring-earn lever-front 1C_ri 1.-• •_ ... ..

Part No. IIII11 DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-SHOCK ABSORBER AND ANTI-ROLL BAR


III. No. I

1 AHA 64512 AHA 64525 AHA 79066 AHA 79077 AHA 8272

8 AJJ 3322

9 AHA 827710 AHA 827811 CMZ 21012 LWZ 20314 53K 136915 LWZ 40516 LNZ 20518 AJJ 3314

19 AHA 701320 AHA 701121 AHA 701222 AHA 702823 HZS 50624 WL 60005125 NH 60504126 AHH 654127 1B 735628 HZS 50529 WL 60005130 AHH 654631 PMZ 30732 LWZ 20333 FNZ 10334 AHT 5634 AHT 57

35 AJJ 3356

20 AHA 701121 AHA 701222 AHA 702823 HZS 50624 WL 60005125 NH 60504127 1B 735628 HZS 50629 WL 600051

1 AHA 64512 AHA 64525 AHA 79066 AHA 79077 AHA 8272

8 AJJ 3322

9 AHA 827710 AHA 827811 CMZ 21012 LWZ 20314 53K 136915 LWZ 40516 LNZ 205


ABSORBER-SHOCKFront-RH 1Front-LH 1Rear-RH-adjustable 1Rear-LH-adjustable 1

Spring-rear road-Iowered-semi-elliptic 2KIT-FRONT SUSPENSION- .LOWERING 1Piece-distance 8

~~~t;~~.~.~~. ~~~.~.:::::::.: : ':': :~::::: : : : :: : : : ::: ::: ~Washer-spring 4Bolt 8Washer 8Nut 8

KIT-ANTI-ROLL BAR-.5625"(14.3mm)D1A.BAR 1Bar-anti-roll 1Link-anti-roll bar-RH 1Link-anti-roll bar-LH 1Bracket-link 2Screw-bracket to lower link 6Washer-spring 6

. Nut 6Bearing-anti-roll bar 2Strap-bearing 2Screw-strap to frame 4Washer-spring 4Stop-end 4Screw-clamping-end top 4Washer-spring 4Nut 4

Bar-anti-roll-.625"(15.9mm)dia., 1Bar-anti-roll-.6875"(17.5mm)dia 1KIT-INSTALLATION-ANTI-ROLLBAR..........................•............................... 1Link-anti-roll bar-RH 1Link-anti-roll bar-LH 1Bracket-link 2Screw-bracket to lower link 6Washer-spring 6Nut-screw 6Strap-bearing 2Screw-strap to frame .4Washer-spring 4

NOTE,ABSORS-ER:'SHOd<'L 0. ~ ••~ --- u . , •• u - - ~ - u J _ _

Front-RH 1Front-LH 1Rear-RH-adjustable 1Rear-LH-adjustable 1

Spring-rear road-Iowered-semi-elliptic 2KIT-FRONT SUSPENSION-LOWERING 1Piece-distance 8

~~~t;~~.~.~~.~~~~. :::::::.: : ':' ::~::::: :: : :: : : : :::: :: ~Washer-spring 4Bolt 8Washer 8Nut 8

REMARKS

C-MG

C-MG

C-MG

C-MG

SPRITE MK III AND IV MIDGET I'vlK II AND Iii SPRITE MK 3 AND MK 4,MIDGET MK 2 AND MK 3

III. No. I Part No. IIIII1 DESCRIPTION I Qty. I Change Point

SPECIAL TUNING-BRAKES-ROAD WHEELS-BODYWORK AND LITERATURE

REMARKS

C-MG

C-MG

] C-MG

] C-MG

] C-MG..i

NOTE.All parts listed with the remark C-MG are competition parts and must be orderedbWJf.:p~ts9~..~~~!!~~. ~. ~~I.~.,:,.~..~~~::!~~ .:: ~ ~~~~r npntMaster-cylinder 1Pedal-brake-RHD 1Connector 1Screw-bleed 1Pipe-brake-front-21.25" 1Pipe-brake-rear-17" 1Clips-brake pipes 2

Set-brake pad-DS 11 linings 1Wheel-wire-60 spoke-13 " x 5" 5KIT-BONNET STRAP 1Buckle-half 1Tongue-half 1Retainer 2

KIT-HEADLAMP COWL. 1KIT-RUBBER TOGGLE-RETAINER 1

KIT-DUAL BRAKING SYSTEM 1Box-pedal 1Master-cylinder 1Pedal-brake-RHD 1Connector 1Screw-bleed 1Pipe-brake-front-21 .25" 1Pipe-brake-rear-17" 1Clips-brake pipes 2

Set-brake pad-DS 11 linings 1Wheel-wire-60 spoke-13 " x 5" 5KIT-BONNET STRAP 1Buckle-half 1Tongue-half 1Retainer 2

KIT-HEADLAMP COWL. 1KIT-RUBBER TOGGLE-RETAINER 1Strap-rubber 1Clip-retaining NLAFerrule-rubber strap retainer 1

Special tuning booklet-1098cc 1Special tuning booklet-1275cc 1Special tuning data set... 1Binder for special tuningsheets 1Divider set for binder 1British Leyland special tuningemblem 1PRBritish Leyland special tuning-Iapel badge : 1Workshop manual. 1Badge-woven-special tuning 1JACKET-RALLY-BRITISH LEYLAND

Small 1Medium 1Large 1Extra large 1

on~ '+000

AHH 8421AHH 8522BCA 40023H 242817H 776921A 3621K 8983

36 AHT 1637 AHA 757341 AJJ 338138 AHH 551839 AHH 551940 AHH 5517

AJJ 3385AJJ 4016

AJJ 404BHA 4666AHH 8421AHH 8522BCA 4002 .3H 242817H 776921A 3621K 8983

36 AHT 1637 AHA 757341 AJJ 338138 AHH 551839 AHH 551940 AHH 5517

AJJ 3385AJJ 40164K 77174K 7715AHT 287AKD 5007AKD 5098AJJ 3333AKD 5061

AKD 5093AKD 5125

AHT 2000

AKD 4021 AAHT 333

AHT 352AHT 353AHT 354AHT 355

(19641<

~I

SPRITE MK III AND IV MIDGET MK II AND III SPRITE MK 3 ...SPRITE MK III AND IV MIDGET MK II AND III...

Documents

Transcript of SPRITE MK III AND IV MIDGET MK II AND III SPRITE MK 3 ...SPRITE MK III AND IV MIDGET MK II AND III...