Sony Ta-kmsw500 Ver1.3 Sm

7/24/2019 Sony Ta-kmsw500 Ver1.3 Sm

1/24

SERVICE MANUAL

Sony CorporationAudio & Video Business Group

Published by Sony EMCS (Malaysia) PG Tec

SPECIFICATIONS

POWER AMPLIFIER

9-890-522-04

2009K80-1

2009.11

E Model

Australian Model

Canadian Model

TA-KMSW500

Ver. 1.3 2009.11

TA-KMSW500 is the amplifier section in HT-DDW5500/DDW7500/DDW8500.

Design and specifications are subject to change

without notice.

Power amplifier (TA-KMSW500)

RMS output (6 ohms, 80 Hz, THD 10%)

200 W per channel 1)

2)185 W per channel

Input LINE IN (input pin jacks)

1)Measured under the following conditions:

2)Measured under the following conditions:

Area code Power requirements

E51, SP, SAF, MY 240 V AC, 50 Hz

EA 127 V AC, 60 Hz

CND 120 V AC, 60 Hz

AR, AUS, TH 230 V AC, 50 Hz

Area code Power requirements

AR, TH 220 V AC, 50 Hz

Abbreviation

AR : Argentina model

AUS : Australian model

EA : Saudi Arabia model

E51 : Chilean and Peruvian models

MY : Malaysia model

SAF : South African model

SP : Singapore model CND : Canadian model

TH : Thai model


2/24

TA-KMSW500

2

UNLEADED SOLDER

Boards requiring use of unleaded solder are printed with the lead-

free mark (LF) indicating the solder contains no lead.

(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARK

Unleaded solder has the following characteristics.

Unleaded solder melts at a temperature about 40 C higher

than ordinary solder.

Ordinary soldering irons can be used but the iron tip has to be

applied to the solder joint for a slightly longer time.

Soldering irons using a temperature regulator should be set to

about 350 C.

Caution: The printed pattern (copper foil) may peel away if the

heated tip is applied for too long, so be careful!

Strong viscosity

Unleaded solder is more viscous (sticky, less prone to flow)

than ordinary solder so use caution not to let solder bridges

occur such as on IC pins, etc.

Usable with ordinary solder

It is best to use only unleaded solder but unleaded solder may

also be added to ordinary solder.

Notes on chip component replacement

Never reuse a disconnected chip component.

Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

SAFETY-RELATED COMPONENT WARNING!

COMPONENTS IDENTIFIED BY MARK 0OR DOTTED LINEWITH MARK 0ON THE SCHEMATIC DIAGRAMS AND IN

THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.

REPLACE THESE COMPONENTS WITH SONY PARTS

WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS

MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

TABLE OF CONTENTS

1. GENERAL............................................................................ 3

2. DISASSEMBLY2-1. Case ..................................................................................... 4

2-2. Back Panel Section ............................................................. 5

2-3. Front Panel Section ............................................................. 5

2-4. Main Board Section ............................................................ 6

3. DIAGRAMS3-1. Block Diagram ................................................................... 7

3-2. Printed Wiring Boards MAIN Section ......................... 9

3-3. Schematic Diagram MAIN Section ............................ 10

3-4. Printed Wiring Boards LED RIGHT,

LED LEFT, VOLUME CONTROL Section ............ .......11

3-5. Schematic Diagram LED RIGHT,

LED LEFT, VOLUME CONTROL Section .................. 12

4. EXPLODED VIEWS

4-1. Case ................................................................................... 144-2. Front Panel Section ........................................................... 15

4-3. Back Panel Section ........................................................... 16

4-4. Chassis Section ................................................................. 17

5. ELECTRICAL PARTS LIST......................................... 18


3/24

TA-KMSW500

3

SECTION 1

GENERAL

This section is extracted

from instruction manual.

LOCATION OF CONTROLS

Front Panel

ILLUMINATION

VOLUME

O N O F F

MIN

ILLUMINATION

The illumination is on(initial setting).

The illumination is off.

Illuminationindicator

Lights up to indicate thesubwoofer output level.

ON

OFF

SUBWOOFERVOLUME

Turn to adjust the volumelevel of the subwoofers.

Rear Panel

AUDIO

IN

SUBWOOFERONLY FORSS-WP7500

SUBWOOFER

IN

SYSTEMCONTROL

SUBWOOFER SPEAKERS

ONLYFOR

STR-KM5500/7500/8500

SYSTEMCONTROLINPUT/OUTPUTsection

SYSTEMCONTROLOUT jack

Connects to thepower amplifier(page 18).

SYSTEMCONTROL IN

jack

Connects to thereceiver (page 18).

OUT

DC5V

50mA MAX

SYSTEM CONTROL

IN

SYSTEMCONTROL

SPEAKERS section

Connects to thesupplied speakers(page 16).

AUDIO INPUT/OUTPUT section

AUDIO INjack

Connects to the

receiver.Black


4/24

TA-KMSW500

4

SECTION 2

DISASSEMBLY

Note: This set can be disassemble according to the following sequence.

2-1. CASE (Page 4)

2-2. BACK PANEL SECTION

(Page 5)

2-3. FRONT PANEL SECTION

(Page 5)

2-4. CHASSIS SECTION

(Page 6)

SET

Note: Follow the disassembly procedure in the numerical order given.

2-1. CASE

two screws (+BVST 4 8) (black)

two screws (+BVST 4 8) (black)

three screws (+BVTP 3 8)

case


5/24

TA-KMSW500

5



five screws

(+BVTP 3 x 8)

CNP651 (7P)

front panel section

CNP901 (2P)

CNP650 (3P)

five screws (+BVTP 3 8)

two screws (+BVTP 3 8)

one screw (+BVTP 3 8)

back panel section


6/24

TA-KMSW500

6

2-4. MAIN BOARD SECTION

CNP801 (7P) CNP902 (2P)

MAIN board section

two screws (+BVTP 3 x 8)

two screws

(+BVTP 3 x 8)

one screw (+BVTP 3 x 8)


7/24

TA-KMSW500

TA-KMSW500

77

3-1. BLOCK DIAGRAM

SECTION 3

DIAGRAMS

SUBWOOFERAUDIO IN

VOLUMECONTROL

POWER AMPQ701 - Q703,

Q705

POWER AMPQ751 - Q753,

Q755

POWERTRANSFORMER

S901VOLTAGE SELECTOR

E51 ONLY

T901

J201IC202AMP

3 7

IC203AMP

5 7

3 1

IC400PRE DRIVER

8 3

6 IN1

IN2

+VOUT1

-VOUT1

+VOUT2

-VOUT2

2

12

11

Signal path

: AUDIO (ANALOG)

R-ch is omitted due tosame as L-ch.

RY401

CURRENTDETECT

Q704

SYSTEMCONTROL

IN

RELAYDRIVER

Q902

J901

CURRENTDETECT

Q754

PROTECTORSWITCH

Q501

IC501PROTECTOR

TB401

SPEAKERSSUBWOOFER

LED DRIVERRIGHT

Q102 - Q107

LED DRIVERLEFT

Q152 - Q157

PROTECTORQ601 - Q602D600 - D601

LEDD105, D109, D113,D117, D121, D122

LEDD155, D159, D163,D167, D171, D172

DCFAN

9V

RF801RECT

D801 - D804

RECTD821

F901

RF802

+9V +9V

REG

IC650 F902

F903

RY901

AC IN ~


8/24

TA-KMSW500

TA-KMSW500

88

For Schematic Diagrams.Note:

All capacitors are inF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics

and tantalums.

All resistors are in and 1/4W or less unless otherwisespecified.

f : internal component.

2: nonflammable resistor. 5: fusible resistor. C: panel designation.

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.

(In addition to this, the necessary note is printed in each block.)

A: B+ Line. B: B Line. Voltages and waveforms are dc with respect to ground

under no-signal (detuned) conditions. no mark: FM

Voltages are taken with VOM (Input impedance 10 M).

Voltage variations may be noted due to normal productiontolerances.

Waveforms are taken with an oscilloscope.

Voltage variations may be noted due to normal productiontolerances.

Circled numbers refer to waveforms.

Signal path. F : TUNER (FM/AM) L : VIDEO (AUDIO) I : VIDEO J : DVD (DIGITAL) c : CD (ANALOG) Abbreviation E51 : Chilean and Peruvian models


For Printed Wiring Boards.Note:

X: Parts extracted from the component side. f : internal component.

: Pattern from the side which enables seeing.

Caution:

Parts face side:

(SIDE A)Pattern face side:

(SIDE B)

Parts on the parts face side seen from

the parts face are indicated.Parts on the pattern face side seen from

the pattern face are indicated.

Note:

The components identi-fied by mark 0or dottedline with mark0are criti-cal for safety.Replace only with part

number specified.

Note:

Les composants identifispar une marque 0 sontcritiques pour la scurit.

Ne les remplacer que parune pice portant le nu-

mro spcifi.

Abbreviation E51 : Chilean and Peruvian models


Circuit Boards Location

MAIN board

VOLUME CONTROL board

VOL CONTROL SUPPORT board

LEFT LED board

RIGHT LED board


9/24

TA-KMSW500

TA-KMSW500

99

1

A

B

C

D

E

F

G

H

I

J

K

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

EB EB

R401

JS703

C200

C201

C205

C206

C212

C213

C600

C601

C604C606

C751

C804

C821

C822

RY401

E

B Q602

Q702

L701 D

821

1

7

CNP801

Q752

L751

R320

R709

HS650

R902

R710

R711

R713

R717

1

7

CNP651

C501

C503

C507

R350

C703

C705

C707

C320

C708

C709

FH901

FH902

FH903

C701

FH904

FH905

FH906

C706

C715

R759

R760

R761

R763

R767

S901

C350

C753

C755

C757

C758 C759

E B

Q601

C756

C765

HS120

1

3

CNP901

1 7

CNP903

JS903

JS901

1

4

CNP902

C502

C803

C650

C829

LP200

JW823

JW826

JW828

JW838

JW845

JW846

JW847

JW848

JW804

JW814

JW815

JW816

JW820

JW832

JW835

JW840

JW841

JW849

JW856

JW857

JW801

JW808

JW850

JW854

JW802

JW812

JW813

JW839

JW842

JW851

JW852

JW853

JW855

JW803JW809

JW825

JW824

JW827

JW829

JW830

JW831

JW833

JW836

JW837

JW858 JW806

JW807

JW810

JW811

JW821

JW822

JW834

JW843

JW844

JW800

RY901

C505

1 3CNP650

RF801

RF802

JW805

JW819

JW817

JW860

F903

F902

F901

1 2 3 1 2 3 1 2 3 1 2 3

Q703 Q705 Q755Q753

C823

C824

BE

B

E

BE

B

E

B E

B EB E

B E

B

E

Q501

Q701 Q704

Q810

Q901

Q751

Q754

Q811

R812

Q902

D801

D803

R210

R211 R

212

R213

R600R601

C202

C204

C210

C211

C603

R640

C605

R641

CL901

CL902

CL903

CL904

CL907

R680

R681

C651

D401

D600

D601

R300

R301R302

R304

R501

R502

R503

R504R

505

R506

R507

R508

R701

R702

R703

R704

R706

R707

R708

R518

R901

R714 R715

R810

R528

C300

C504

C506

R351

C702

C704

C714

R751

R752

R753

R754

R756

R757

R758

CL801

CL802

CL803

CL804

CL805

CL806

R764

R813R765

D301

D302

C752

C754

D501

D502

D503

C764

CL650

CL652

CL653

CL654

CL655CL656

CL657

D901

D351 D352

D740

D811

D810

R200

D741 R811

R201

R202

R203

R204

R205R206

R207R208

CL906

CL905

C801

C802

R905

R903

R906

R907R904

CL651

CL201

D802

D804

CL403

CL909

CL402 CL404

CL908

CL401CL202 CL911

CL910

CL912

CL649

IO

IC650

1 15

IC400

IC501

IC203

IC202

J201

TB401

SPEAKERS SUBWOOFER

RL

++

J901

SYSTEMCONTROLIN

VOLTAGESELECTOR

T901MAIN POWER

TRANSFORMER

MAIN BOARD

1-879-009-

12

(12)

(AC IN)

LED RIGHT

BOARDCN101

(Page 11)

DC FAN

1

7

CNP651

EXCEPTE51, EA

E51, EA

CND, SAF, AUS

E51, EA

SUBWOOFERAUDIOIN

3-2. PRINTED WIRING BOARDS MAIN Section : Uses unleaded solder. See page 14 for Circuit Boards Location.

Q753 J-5 Q754 I-6 Q755 J-6 Q810 I-3

Q704 I-3 Q705 J-2 Q751 J-6 Q752 J-6

D301 F-4 D302 F-4 D351 F-4 D352 F-4

D401 C-6 D501 G-8 D502 I-7 D503 I-7

D600 E-5 D601 E-6 D740 I-6 D741 I-3

D801 H-9 D802 G-10 D803 G-10 D804 H-9

D810 H-5 D811 H-5 D821 I-10 D901 D-7

IC202 C-3 IC203 E-3 IC400 G-1 IC501 H-6

IC650 F-5

Q501 I-7 Q601 E-6

Q602 D-5 Q701 J-2 Q702 J-2 Q703 J-1

Ref. No. Location

Semiconductor Location

Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location

Ver. 1.2

Q811 I-6 Q901 D-7 Q902 B-6

Ref. No. Location


10/24


11/24

TA-KMSW500

TA-KMSW500

1111

1

A

B

C

D

E

F

G

H

I

J

K

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

S101

C101

C102

18 3CN101

D105

D109 D113 D117 D121 D122

17 3CN102

JW100

JW101

JW102

C151 C152

13

CNP103

CNP104

1

4

D159D163

D167

D171D172

RV001

B

E

B

E B

E

B

E

B

E

B

E

B

E

B

E

B

E

B

E

B

EB

E

B

E

B

E

5.LED-L

Q101

Q102

Q103

Q

104

Q

105

Q

106

Q107

D114

R122R107

CL102

CL105

CL101

R112

CL106

R118

R101

R113

CL103

R115

R121R106

D118

R109

R104D

110

CL107

R119

R102

R110

D111

D101

CL104

R116

D108

D1112

R108

D107

R103

R105

R114 R117 R120R111

D106

D104

D119

D115

D116

R123

R124

R125

Q151

Q152

Q153

Q154

Q155

Q156

Q157

D168

R164R171 R155

R158

R169

R153

R168

D151

R159

R170

R154R165 R156

D164

R163

R166

D156

R161

R160

R151

D160

R162 R157

R152

D169

R172

D158

D157

D154

D161

D166

D165

D162

R173

R174

R175

CL173

CL172

CL171

R131

CL001

CL002

CL003

R167

LED RIGHT BOARD

LED LEFT BOARD

VOLUMECONTROLBOARD

1-879-010-

12

(12)

1-879-420-

12

(12)

1-879-938-

12

(12)

MAIN

BOARD

CNP651

(Page 9)

ILLUMINATIONON/OFF

SUBWOOFERVOLUME

3-4. PRINTED WIRING BOARD LED RIGHT, LED LEFT, VOLUME CONTROL Section See page 14 for Circuit Boards Location. : Uses unleaded solder.

D101 B-9 D104 C-3 D105 C-2 D106 C-4

D107 C-4 D108 C-4 D109 C-3 D110 C-5 D111 C-5 D113 C-4 D114 C-6 D115 C-6 D116 C-6 D117 C-5 D118 C-7 D119 C-7 D121 C-6 D122 C-7 D151 F-3 D154 F-7 D156 F-6 D157 F-6 D158 F-6 D159 F-7 D160 F-5 D161 F-5

Ref. No. Location

D162 F-5 D163 F-6 D164 F-4 D165 F-4

D166 F-4 D167 F-5 D168 F-3 D169 F-3 D171 F-4 D172 F-3 D1112 C-5

Q101 B-9 Q102 C-2 Q103 C-3 Q104 C-4 Q105 C-5 Q106 C-6 Q107 C-7 Q151 F-3 Q152 G-8 Q153 G-7 Q154 G-6 Q155 G-5 Q156 G-4 Q157 G-3

Ref. No. Location

Semiconductor Location

Ver. 1.2


12/24

TA-KMSW500

TA-KMSW500

1212

. SCHEMATIC DIAGRAM LED RIGHT, LED LEFT, VOLUME CONTROL Section

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

LED RIGHT BOARD

LED LEFT BOARD

VOLUME CONTROL BOARD

MAIN

BOARD

CNP651

(Page 10)

07.5

-0.2

07.5

-0.2

06.6

0

06.6

0

06.6

0.2

06.6

0

09

9

0

0

9

0

6.6

0

0

6.6

0

0

6.6

0

0

6.6

0

0

7.5

0

0

7.5

0

2SA1163-GQ101

PROTECTOR SWITCH

2SC3052EF-T1-LEFQ105


2SC3052EF-T1-LEFLED DRIVER

Q102

2SC3052EF-T1-LEFLED DRIVER

LED DRIVER

LED DRIVER

LED DRIVER

LED DRIVER

Q107



MA2J1110GLS0D101

CL101

CL102

CL103

CL104

CL105

CL106

CL107

330R119

330R122

S101ILLUMINATION

ON/OFF

1 23

4 56

10kR102

10kR104

10kR101

35V

47C101

33kR103

680R105

10kR108

22kR111

33kR114

68kR117

33kR120

MA2J1110GLS0D1112

MA2J1110GLS0D106

MA2J1110GLS0D119

MA2J1110GLS0D114

MA2J1110GLS0D116

MA2J1110GLS0D118

MA2J1110GLS0D110

MA2J1110GLS0D107

MA2J1110GLS0D108

MA2J1110GLS0D104

MA2J1110GLS0D115

MA2J1110GLS0D111

16080

R123

16080

R124

16080

R125

16V100

C102

SELT5E20C-S TP15D109




SELU5920A-S TP15D121

SELU5920A-S TP15D122

100R118

100R121

470R107

470R112

470R116

470R109

470R110

470R106

470R115

470R113

1

3

4

5

6

7

CN1027P

IN

GND

OUT

LED-L

GND

+9V

1

8

3

4

5

6

7

CN1018P

IN

GND (LED)

GND

OUT

+9V

LED-R

LED-L

2SA1163-GQ151

PROTECTORSWITCH

2SC3052EF-T1-LEFLEDDRIVER

Q1522SC3052EF-T1-LEF





Q156

LED DRIVERLED DRIVER LED DRIVER LED DRIVER LED DRIVER

MA2J1110GLS0D151

330R168

330R171

10k

R152

10kR153

33kR172

25V47

C151

680R154

10kR157

22kR160

33kR163

68kR166

33kR169

10kR151

D161 D168D 16 2 D 16 4 D 16 5D160D154

D154,D156 - DD158,D160- D162,D164- D166,

D168- D169

D166D157 D169

MA2J1110GLS0

D156 D158

0R175

16080

R1740

R173

16V100

C152

470R162

470R159

470R158

470R161

470R155

470R165

470R156

470R164

100R167

100R170

1

3

4

CNP1033P

LED L

GND (LED)

+9V

CL171

CL172

CL173

100kR131

1

3

4

4PCNP104

IN

GND

OUT

CL001

CL002

CL003

SELU5920A-S TP15

D172

SELU5920A-S TP15

D171

SELT5E20C-S TP15

D155

SELT5E20C-S TP15

D167

SELT5E20C-S TP15

D159

SELT5E20C-S TP15

D163

RV00113

2SUBWOOFER

VOLUME


13/24

TA-KMSW500

13

IC Block Diagrams

IC202, IC203 NJM4565M-D (MAIN BOARD)

A OUTPUT

V+

B OUTPUT

B -INPUT

B +INPUT

A -INPUT

A +INPUT

V-

8

7

6

5

4

3

2

1

A B

IC501 uPC1237C-A (MAIN BOARD)

SWITCH FOR

LATCH/AUTOMATIC

RESET

OUTPUT

OFFSET

DETECTOR

OVERLOAD

DETECTOR

AC-OFF

DETECTOR

FLIP-FLOP

OUTPUT

OFFSET

DETECTOR

OUTPUT

OFFSET

DETECTOR

1

LOADOVER

2

DETECTDC

3

RESET

4

OFFAC

6

DRIVER

RELAY

5

GND

7

OFFAC

8

VCC


14/2414

TA-KMSW500

SECTION 4

EXPLODED VIEWS

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

Note:

-XX and -X mean standardized parts, so they may

have some difference from the original one.

Color Indication of Appearance Parts Example:

KNOB, BALANCE (WHITE) . . . (RED)

R RParts Color Cabinets Color

Abbreviation

AR : Argentina model MY : Malaysia model

AUS : Australian model SAF : South African


model SP : Singapore model

E51 : Chilean and

Peruvian models

Items marked * are not stocked since

they are seldom required for routine ser-

vice. Some delay should be anticipated

when ordering these items.

The mechanical parts with no reference

number in the exploded views are not sup-

plied. Accessories are given in the last of the

electrical parts list.

4-1. CASE

The components identified by

mark 0 or dotted line with mark

0are critical for safety.

Replace only with part number

specified.

#1

#1

#1

#1

#1

#1

1

2

2

back panel section

chassis section

front panel section

1 3-285-693-51 CASE

2 2-580-630-01 SCREW, +BVST 4X8

#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3


15/2415

TA-KMSW500


52

51

not supplied

53

supplied with

RV001

54

54

54

not supplied

(VOLUME CONTROL board)

not supplied

(LEFT LED board)

not supplied

(RIGHT LED board)

not supplied

(VOL CONTROL

SUPPORT board)


51 X-2342-687-1 FRONT PANEL ASSY

52 4-977-358-01 CUSHION

53 4-127-221-01 KNOB, VOLUME

54 3-087-053-01 +BVTP2.6 (3CR)


16/2416

TA-KMSW500



101 1-763-738-11 DC FAN

102 3-703-244-00 CORD BUSH (2104) (EXCEPT TH)

102 4-996-267-12 BUSHING (FBS 001), CORD (TH)

0103 1-777-071-83 CORD, POWER (EXCEPT AR, TH)0103 1-829-387-11 CORD, POWER (AR)

0103 1-833-566-21 POWER SUPPLY CORD (AUS)

0103 1-834-270-11 CORD, POWER (CND)

0103 1-834-288-21 CORD, POWER (TH)

0104 1-569-008-33 ADAPTOR, CONVERSION 2P (E51)0105 1-770-019-71 ADAPTOR, CONVERSION PLUG 3P (EA)


#1

#1

102

103105

104

101

not supplied

The components identified by mark 0or dotted

line with mark0 are critical for safety.

Replace only with part number specified.

Ver. 1.2


17/2417

TA-KMSW500

4-4. CHASSIS SECTION


151 A-1653-231-A MAIN BOARD, COMPLETE (EXCEPT E51, EA)

151 A-1660-457-A MAIN BOARD, COMPLETE (E51)

151 A-1660-457-A MAIN BOARD, COMPLETE (EA)

152 3-905-609-01 SCREW (TRANSISTOR)

153 4-977-358-01 CUSHION

154 4-249-675-01 +BV SUMITITE S 4X6 ROUND

0F901 1-532-464-33 FUSE (T2.5AL/250V) (EXCEPT CND)

0F901 1-533-452-12 FUSE, GLASS TUBE (DIA. 5) (CND)

0F902 1-532-464-33 FUSE (T2.5AL/250V) (E51, EA)

0F903 1-532-504-33 FUSE (T4AL/250V) (E51, EA)

0Q703 6-702-390-01 TRANSISTOR MN2488-OPY-MK

0Q705 6-702-391-01 TRANSISTOR MP1620-OPY-MK

0Q753 6-702-390-01 TRANSISTOR MN2488-OPY-MK

0Q755 6-702-391-01 TRANSISTOR MP1620-OPY-MK

0T901 1-445-698-12 POWER TRANSFORMER (SAF, AUS)

0T901 1-445-713-12 TRANSFORMER, POWER (E51)

0T901 1-445-731-11 POWER TRANSFORMER (CND)

0T901 1-445-751-11 TRANSFORMER, POWER (EA)


F903F902

F901

T901

154154

153not supplied

not supplied

151

Q703Q705

Q753

Q755

#1

#1

#1

#1

152

The components identified by mark 0or dotted

line with mark0 are critical for safety.


Ver. 1.2


18/2418

TA-KMSW500

SECTION 5

ELECTRICAL PARTS LIST

LEFT LED BOARD

**************

< CAPACITOR >

C151 1-119-772-11 ELECT 47uF 20% 35V

C152 1-119-774-11 ELECT 100uF 20% 16V

< CONNECTOR >

* CNP103 1-564-518-11 PLUG, CONNECTOR 3P

< DIODE >

D151 6-501-817-01 DIODE MA2J1110GLS0

D154 6-501-817-01 DIODE MA2J1110GLS0

D155 6-502-781-01 DI SELT5E20C-S TP15

D156 6-501-817-01 DIODE MA2J1110GLS0

D157 6-501-817-01 DIODE MA2J1110GLS0

D158 6-501-817-01 DIODE MA2J1110GLS0

D159 6-502-781-01 DI SELT5E20C-S TP15

D160 6-501-817-01 DIODE MA2J1110GLS0

D161 6-501-817-01 DIODE MA2J1110GLS0

D162 6-501-817-01 DIODE MA2J1110GLS0

D163 6-502-781-01 DI SELT5E20C-S TP15

D164 6-501-817-01 DIODE MA2J1110GLS0

D165 6-501-817-01 DIODE MA2J1110GLS0

D166 6-501-817-01 DIODE MA2J1110GLS0

D167 6-502-781-01 DI SELT5E20C-S TP15

D168 6-501-817-01 DIODE MA2J1110GLS0

D169 6-501-817-01 DIODE MA2J1110GLS0

D171 6-502-782-01 DI SELU5920A-S TP15

D172 6-502-782-01 DI SELU5920A-S TP15

< TRANSISTOR >

Q151 8-729-216-31 TRANSISTOR 2SA1163-G

Q152 8-729-620-07 TRANSISTOR 2SC3052EF-T1-LEF






< RESISTOR >

R151 1-216-833-11 METAL CHIP 10K 5% 1/10W R152 1-216-833-11 METAL CHIP 10K 5% 1/10W

R153 1-216-833-11 METAL CHIP 10K 5% 1/10W

R154 1-216-819-11 METAL CHIP 680 5% 1/10W

R155 1-216-817-11 METAL CHIP 470 5% 1/10W

R156 1-216-817-11 METAL CHIP 470 5% 1/10W

R157 1-216-833-11 METAL CHIP 10K 5% 1/10W

R158 1-216-817-11 METAL CHIP 470 5% 1/10W

R159 1-216-817-11 METAL CHIP 470 5% 1/10W

R160 1-216-837-11 METAL CHIP 22K 5% 1/10W

R161 1-216-817-11 METAL CHIP 470 5% 1/10W

R162 1-216-817-11 METAL CHIP 470 5% 1/10W

R163 1-216-839-11 METAL CHIP 33K 5% 1/10W

R164 1-216-817-11 METAL CHIP 470 5% 1/10W

R165 1-216-817-11 METAL CHIP 470 5% 1/10W

R166 1-216-843-11 METAL CHIP 68K 5% 1/10W

R167 1-216-809-11 METAL CHIP 100 5% 1/10W

R168 1-216-815-11 METAL CHIP 330 5% 1/10W

R169 1-216-839-11 METAL CHIP 33K 5% 1/10W

R170 1-216-809-11 METAL CHIP 100 5% 1/10W

R171 1-216-815-11 METAL CHIP 330 5% 1/10W

R172 1-216-839-11 METAL CHIP 33K 5% 1/10W

R173 1-216-864-11 SHORT CHIP 0

R174 1-216-864-11 SHORT CHIP 0

R175 1-216-864-11 SHORT CHIP 0

*************************************************************

A-1653-231-A MAIN BOARD, COMPLETE (EXCEPT E51, EA)

A-1660-457-A MAIN BOARD, COMPLETE (E51, EA)

A-1735-189-A MAIN BOARD, COMPLETE (CND, AUS, AR, TH)

*********************

7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

< CAPACITOR >

C200 1-126-964-11 ELECT 10uF 20% 50V

C201 1-126-964-11 ELECT 10uF 20% 50V

C202 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C204 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C205 1-137-190-91 FILM 0.22uF 5% 50V

C206 1-137-190-91 FILM 0.22uF 5% 50V



C212 1-136-157-00 FILM 0.022uF 5% 50V

C213 1-136-175-00 FILM 0.68uF 5% 50V


C320 1-128-582-11 ELECT 10uF 20% 100V

C350 1-128-582-11 ELECT 10uF 20% 100V C501 1-128-579-11 ELECT 2.2uF 20% 100V

C502 1-126-968-11 ELECT 100uF 20% 50V


When indicating parts by reference num-

ber, please include the board name.

Note:

Due to standardization, replacements in

the parts list may be different from the

parts specified in the diagrams or the com-

ponents used on the set.

-XX and -X mean standardized parts, so

they may have some difference from the

original one.

Items marked * are not stocked since

they are seldom required for routine ser-

vice.

Some delay should be anticipated when

ordering these items.

CAPACITORS

uF: F

COILS

uH: H

RESISTORS

All resistors are in ohms.

METAL: Metal-film resistor.

METAL OXIDE: Metal oxide-film resistor.

F: nonflammable

SEMICONDUCTORS

In each case, u: , for example:

uA. . : A. . , uPA. . , PA. . ,

uPB. . : PB. . , uPC. . , PC. . ,

uPD. . : PD. .

The components identified by mark 0

or dotted line with mark 0are critical for

safety.


MAIN

Abbreviation

AR : Argentina model

AUS : Australian model


E51 : Chilean and Peruvian models

MY : Malaysia model

SAF : South African model

SP : Singapore model

LEFT LED

Ver. 1.2


19/24


TA-KMSW500

1919

C503 1-126-967-11 ELECT 47uF 20% 50V


C505 1-126-934-11 ELECT 220uF 20% 16V


C507 1-126-963-11 ELECT 4.7uF 20% 50V

C600 1-126-933-11 ELECT 100uF 20% 16V C601 1-126-933-11 ELECT 100uF 20% 16V


C604 1-126-947-11 ELECT 47uF 20% 35V


C606 1-126-947-11 ELECT 47uF 20% 35V

C650 1-126-934-11 ELECT 220uF 20% 16V


C701 1-126-964-11 ELECT 10uF 20% 50V


C703 1-107-792-11 CERAMIC 100PF 5% 500V

C704 1-162-927-11 CERAMIC CHIP 100PF 5% 1kV

C705 1-116-177-21 CERAMIC 3PF 0.25PF 1kV

C706 1-126-923-91 ELECT 220uF 20% 10V

C707 1-126-947-11 ELECT 47uF 20% 35V

C708 1-114-989-81 CERAMIC 47PF 5% 1000V

C709 1-114-989-81 CERAMIC 47PF 5% 1000V


C715 1-136-157-00 FILM 0.022uF 5% 50V

C751 1-126-964-11 ELECT 10uF 20% 50V


C753 1-107-792-11 CERAMIC 100PF 5% 1kV


C755 1-116-177-21 CERAMIC 3PF 0.25PF 1kV

C756 1-126-923-91 ELECT 220uF 20% 10V

C757 1-126-947-11 ELECT 47uF 20% 35V

C758 1-114-989-81 CERAMIC 47PF 5% 1000V C759 1-114-989-81 CERAMIC 47PF 5% 1000V


C765 1-136-157-00 FILM 0.022uF 5% 50V



C803 1-126-942-61 ELECT 1000uF 20% 25V

C804 1-104-666-11 ELECT 220uF 20% 25V

C821 1-130-777-00 MYLAR 0.1uF 5% 100V

C822 1-130-777-00 MYLAR 0.1uF 5% 100V

C823 1-116-301-11 ELECT 4700uF 20% 71V

(E51, EA, AR,TH)

C823 1-116-372-11 ELECT 4700uF 20% 80V (SAF)

C824 1-116-301-11 ELECT 4700uF 20% 71V

(E51, EA, AR,TH)

C824 1-116-372-11 ELECT 4700uF 20% 80V (SAF)

C829 1-126-925-91 ELECT 470uF 20% 10V



CNP801 1-785-104-11 PIN, CONNECTOR (3.96mm PITCH) 6P

CNP901 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

* CNP902 1-565-792-11 PIN, CONNECTOR (3.96mm PITCH) 2P

(CND, SAF, AUS)

CNP903 1-568-106-11 PIN, CONNECTOR (3.96mm PITCH) 4P (E51, EA)

< DIODE>

D301 6-501-817-01 DIODE MA2J1110GLS0 D302 6-501-817-01 DIODE MA2J1110GLS0

D351 6-501-817-01 DIODE MA2J1110GLS0

D352 6-501-817-01 DIODE MA2J1110GLS0

D401 6-501-817-01 DIODE MA2J1110GLS0

D501 6-501-817-01 DIODE MA2J1110GLS0

D502 6-501-817-01 DIODE MA2J1110GLS0

D503 6-501-817-01 DIODE MA2J1110GLS0

D600 6-501-752-01 DIODE MAZ8082GMLS0

D601 6-501-752-01 DIODE MAZ8082GMLS0

D740 6-501-817-01 DIODE MA2J1110GLS0

D741 6-501-817-01 DIODE MA2J1110GLS0

D801 8-719-053-18 DIODE 1SR154-400TE-25

D802 8-719-053-18 DIODE 1SR154-400TE-25

D803 8-719-053-18 DIODE 1SR154-400TE-25

D804 8-719-053-18 DIODE 1SR154-400TE-25

D810 6-501-817-01 DIODE MA2J1110GLS0

D811 6-501-817-01 DIODE MA2J1110GLS0

D821 6-500-360-01 DIODE D10XB20

D901 6-501-817-01 DIODE MA2J1110GLS0

< FUSE HOLDER >

FH901 1-533-293-11 FUSE HOLDER 0A 0V

FH902 1-533-293-11 FUSE HOLDER 0A 0V

FH903 1-533-293-11 FUSE HOLDER 0A 0V

(E51, EA)

FH904 1-533-293-11 FUSE HOLDER 0A 0V

(E51, EA)

FH905 1-533-293-11 FUSE HOLDER 0A 0V

(E51, EA)

FH906 1-533-293-11 FUSE HOLDER 0A 0V

(E51, EA)

< IC >

IC202 8-759-710-97 IC NJM4565M-D

IC203 8-759-710-97 IC NJM4565M-D

IC400 6-713-895-01 IC STK350-630-E IC501 6-708-609-01 IC uPC1237C-A

IC650 6-713-032-01 IC KIA7809API-U/PF

< JACK >

J201 1-774-785-11 JACK, PIN 1P (SUBWOOFER AUDIO IN)

J901 1-820-056-21 SMALL TYPE JACK (3.5MM)

(SYSTEM CONTROL IN)

< COIL >

L701 1-420-872-52 COIL, AIR-CORE

L751 1-420-872-52 COIL, AIR-CORE

< TRANSISTOR >

Q501 8-729-216-31 TRANSISTOR 2SA1163-G

Q601 8-729-140-93 TRANSISTOR 2SB733-34

Q602 8-729-140-98 TRANSISTOR 2SD773-34

Q701 8-729-216-31 TRANSISTOR 2SA1163-G

Q702 8-729-922-39 TRANSISTOR 2SD2144S-V


Q751 8-729-216-31 TRANSISTOR 2SA1163-G

Q752 8-729-922-39 TRANSISTOR 2SD2144S-V






MAIN

Ver. 1.3


20/24


TA-KMSW500

20

< RESISTOR>

R200 1-216-821-11 METAL CHIP 1K 5% 1/10W

R201 1-216-839-11 METAL CHIP 33K 5% 1/10W

R202 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R203 1-216-841-11 METAL CHIP 47K 5% 1/10W

R204 1-216-821-11 METAL CHIP 1K 5% 1/10W

R205 1-216-832-11 METAL CHIP 8.2K 5% 1/10W

R206 1-216-841-11 METAL CHIP 47K 5% 1/10W

R207 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R208 1-216-833-11 METAL CHIP 10K 5% 1/10W

R210 1-216-845-11 METAL CHIP 100K 5% 1/10W

R211 1-216-845-11 METAL CHIP 100K 5% 1/10W

R212 1-216-832-11 METAL CHIP 8.2K 5% 1/10W

R213 1-216-832-11 METAL CHIP 8.2K 5% 1/10W

R300 1-216-821-11 METAL CHIP 1K 5% 1/10W

R301 1-216-821-11 METAL CHIP 1K 5% 1/10W

R302 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R304 1-216-841-11 METAL CHIP 47K 5% 1/10W

0R320 1-249-381-11 CARBON 1 5% 1/4W

0R350 1-249-381-11 CARBON 1 5% 1/4W

R351 1-216-821-11 METAL CHIP 1K 5% 1/10W

0R401 1-249-381-11 CARBON 1 5% 1/4W

R501 1-216-837-11 METAL CHIP 22K 5% 1/10W

R502 1-216-833-11 METAL CHIP 10K 5% 1/10W

R503 1-216-839-11 METAL CHIP 33K 5% 1/10W

R504 1-216-843-11 METAL CHIP 68K 5% 1/10W

R505 1-216-835-11 METAL CHIP 15K 5% 1/10W

R506 1-216-843-11 METAL CHIP 68K 5% 1/10W

R507 1-216-833-11 METAL CHIP 10K 5% 1/10W

R508 1-216-845-11 METAL CHIP 100K 5% 1/10W

R518 1-216-846-11 METAL CHIP 120K 5% 1/10W

R528 1-216-845-11 METAL CHIP 100K 5% 1/10W

R600 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R601 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R640 1-216-837-11 METAL CHIP 22K 5% 1/10W

R641 1-216-845-11 METAL CHIP 100K 5% 1/10W

R680 1-216-837-11 METAL CHIP 22K 5% 1/10W

R681 1-216-845-11 METAL CHIP 100K 5% 1/10W

R701 1-216-821-11 METAL CHIP 1K 5% 1/10W

R702 1-216-843-11 METAL CHIP 68K 5% 1/10W

R703 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R704 1-216-843-11 METAL CHIP 68K 5% 1/10W

R706 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R707 1-216-844-11 METAL CHIP 82K 5% 1/10W

R708 1-216-818-11 METAL CHIP 560 5% 1/10W

0R709 1-249-405-11 CARBON 100 5% 1/4W

0R710 1-249-405-11 CARBON 100 5% 1/4W

0R711 1-249-393-11 CARBON 10 5% 1/4W

0R713 1-234-182-11 ENCAPSULATED COMPONENT

R714 1-216-830-11 METAL CHIP 5.6K 5% 1/10W

R715 1-218-867-11 METAL CHIP 6.8K 5% 1/10W

0R717 1-249-389-11 CARBON 4.7 5% 1/4W

R751 1-216-821-11 METAL CHIP 1K 5% 1/10W

R752 1-216-843-11 METAL CHIP 68K 5% 1/10W

R753 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R754 1-216-843-11 METAL CHIP 68K 5% 1/10W

R756 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R757 1-216-844-11 METAL CHIP 82K 5% 1/10W

R758 1-216-818-11 METAL CHIP 560 5% 1/10W

0R759 1-249-405-11 CARBON 100 5% 1/4W

0R760 1-249-405-11 CARBON 100 5% 1/4W

0R761 1-249-393-11 CARBON 10 5% 1/4W

0R763 1-234-182-11 ENCAPSULATED COMPONENT

R764 1-216-830-11 METAL CHIP 5.6K 5% 1/10W

R765 1-218-867-11 METAL CHIP 6.8K 5% 1/10W

0R767 1-249-389-11 CARBON 4.7 5% 1/4W

R810 1-216-822-11 METAL CHIP 1.2K 5% 1/10W

R811 1-216-835-11 METAL CHIP 15K 5% 1/10W

R812 1-216-822-11 METAL CHIP 1.2K 5% 1/10W

R813 1-216-835-11 METAL CHIP 15K 5% 1/10W

R901 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

0R902 1-249-381-11 CARBON 1 5% 1/4W

R903 1-216-838-11 METAL CHIP 27K 5% 1/10W

R904 1-216-845-11 METAL CHIP 100K 5% 1/10W

R905 1-216-846-11 METAL CHIP 120K 5% 1/10W

R906 1-216-837-11 METAL CHIP 22K 5% 1/10W

R907 1-216-834-11 METAL CHIP 12K 5% 1/10W

< FUSE >

RF801 1-523-082-11 FUSE 1A 250V

RF802 1-523-082-11 FUSE 1A 250V

< RELAY >

RY401 1-755-170-11 RELAY (12V)

RY901 1-755-541-11 RELAY

S901 1-786-055-31 SELECTOR, VOLTAGE (E51, EA)

< TERMINAL >

TB401 1-694-785-11 TERMINAL BOARD (SPEAKERS SUBWOOFER)

************************************************************

RIGHT LED BOARD

***************

< CAPACITOR >

C101 1-119-772-11 ELECT 47uF 20% 35V

C102 1-119-774-11 ELECT 100uF 20% 16V

< DIODE >

D101 6-501-817-01 DIODE MA2J1110GLS0

D104 6-501-817-01 DIODE MA2J1110GLS0

D105 6-502-781-01 DI SELT5E20C-S TP15

D106 6-501-817-01 DIODE MA2J1110GLS0

D107 6-501-817-01 DIODE MA2J1110GLS0

D108 6-501-817-01 DIODE MA2J1110GLS0

D109 6-502-781-01 DI SELT5E20C-S TP15

D110 6-501-817-01 DIODE MA2J1110GLS0

D111 6-501-817-01 DIODE MA2J1110GLS0

D113 6-502-781-01 DI SELT5E20C-S TP15

D114 6-501-817-01 DIODE MA2J1110GLS0

D115 6-501-817-01 DIODE MA2J1110GLS0

D116 6-501-817-01 DIODE MA2J1110GLS0

D117 6-502-781-01 DI SELT5E20C-S TP15

D118 6-501-817-01 DIODE MA2J1110GLS0

D119 6-501-817-01 DIODE MA2J1110GLS0

D121 6-502-782-01 DI SELU5920A-S TP15

D122 6-502-782-01 DI SELU5920A-S TP15

MAIN RIGHT LED

Ver. 1.2


21/24


TA-KMSW500

2121

D1112 6-501-817-01 DIODE MA2J1110GLS0

< TRANSISTOR >

Q101 8-729-216-31 TRANSISTOR 2SA1163-G


Q103 8-729-620-07 TRANSISTOR 2SC3052EF-T1-LEF Q104 8-729-620-07 TRANSISTOR 2SC3052EF-T1-LEF




< RESISTOR >

R101 1-216-833-11 METAL CHIP 10K 5% 1/10W

R102 1-216-833-11 METAL CHIP 10K 5% 1/10W

R103 1-216-839-11 METAL CHIP 33K 5% 1/10W

R104 1-216-833-11 METAL CHIP 10K 5% 1/10W

R105 1-216-819-11 METAL CHIP 680 5% 1/10W

R106 1-216-817-11 METAL CHIP 470 5% 1/10W

R107 1-216-817-11 METAL CHIP 470 5% 1/10W

R108 1-216-833-11 METAL CHIP 10K 5% 1/10W

R109 1-216-817-11 METAL CHIP 470 5% 1/10W

R110 1-216-817-11 METAL CHIP 470 5% 1/10W

R111 1-216-837-11 METAL CHIP 22K 5% 1/10W

R112 1-216-817-11 METAL CHIP 470 5% 1/10W

R113 1-216-817-11 METAL CHIP 470 5% 1/10W

R114 1-216-839-11 METAL CHIP 33K 5% 1/10W

R115 1-216-817-11 METAL CHIP 470 5% 1/10W

R116 1-216-817-11 METAL CHIP 470 5% 1/10W

R117 1-216-843-11 METAL CHIP 68K 5% 1/10W

R118 1-216-809-11 METAL CHIP 100 5% 1/10W

R119 1-216-815-11 METAL CHIP 330 5% 1/10W

R120 1-216-839-11 METAL CHIP 33K 5% 1/10W

R121 1-216-809-11 METAL CHIP 100 5% 1/10W

R122 1-216-815-11 METAL CHIP 330 5% 1/10W

R123 1-216-864-11 SHORT CHIP 0

R124 1-216-864-11 SHORT CHIP 0

R125 1-216-864-11 SHORT CHIP 0

< SWITCH >

S101 1-554-118-00 SWITCH, PUSH (1 KEY) (ILLUMINATION ON/OFF)

*************************************************************

VOL CONTROL BOARD

******************

< CONNECTOR>

CNP104 1-691-765-11 PLUG (MICRO CONNECTOR) 3P

R131 1-216-845-11 METAL CHIP 100K 5% 1/10W

< ROTARY ENCODER >

RV001 1-227-861-11 POTENTIOMETER (SUBWOOFER VOLUME)

*************************************************************

MISCELLANEOUS

**************

101 1-763-738-11 DC FAN

0103 1-777-071-83 CORD, POWER (EXCEPT AR, TH)

0103 1-829-387-11 CORD, POWER (AR)

0103 1-833-566-21 POWER-SUPPLY CORD (AUS)

0103 1-834-270-11 CORD, POWER (CND)

0103 1-834-288-21 CORD, POWER (TH)

0104 1-569-008-33 ADAPTOR, CONVERSION 2P (E51)

0105 1-770-019-71 ADAPTOR, CONVERSION PLUG 3P (EA)

0F901 1-532-464-33 FUSE (T2.5AL/250V)0F902 1-532-464-33 FUSE (T2.5AL/250V) (E51, EA)

0F903 1-532-504-33 FUSE (T4AL/250V) (E51, EA)

Q703 6-702-390-01 TRANSISTOR MN2488-OPY-MK

Q705 6-702-391-01 TRANSISTOR MP1620-OPY-MK

Q753 6-702-390-01 TRANSISTOR MN2488-OPY-MK

Q755 6-702-391-01 TRANSISTOR MP1620-OPY-MK

0T901 1-445-698-12 POWER TRANSFORMER (SAF, AUS)

0T901 1-445-713-12 TRANSFORMER, POWER (E51)

0T901 1-445-731-11 POWER TRANSFORMER (CND)

0T901 1-445-751-11 TRANSFORMER, POWER (EA)

************************************************************

VOL CONTROLRIGHT LED

Ver. 1.2


22/24

TA-KMSW500

MEMO

22


23/24

MEMO

TA-KMSW500

23


24/24

TA-KMSW500

REVISION HISTORY

Checking the version allows you to jump to the revised page.

Also, clicking the version at the top of the revised page allows you to jump to the next revised page.

Ver. Date Description of Revision

1.0 2009.04 New

1.1 2009.05 Additional of HT-DDW8500 model.

1.2 2009.07 Additional of Canadian, Thai and Saudi Arabia models.

1.3 2009.11 Change P/N and description for C708, C709, C758, C759 in MAIN board.

Sony Ta-kmsw500 Ver1.3 Sm

Documents

Transcript of Sony Ta-kmsw500 Ver1.3 Sm