Product Selector Guide High-Power AC-DC Products · 2016. 3. 10. · 2 About Power Integrations...

Product Selector GuideHigh-Power AC-DC Products

March 2016

2

About Power Integrations

AC-DC Product Overview

Power Integrations is the leading supplier of high-voltage analog integrated circuits used in energy-efficient power supplies. The company’s innovative technology enables compact, energy-efficient power converters for a wide range of electronic products, AC-DC, DC-DC and LED lighting applications. With industry-leading product quality and delivery, the company has shipped billions of devices to customers around the world.

Since its introduction in 1998, EcoSmart energy-efficiency technology has saved an estimated $4.5 billion of standby energy waste. These savings equate to approximately 31 billion kilowatt-hours of electricity – an amount which, if produced by coal-burning power plants, would have resulted in approximately 20 million tons of carbon emissions, roughly equal to the annual emissions of 3 million automobiles.

For more information, please visit www.power.com.

50 W3 W2.5 W0 W 10 W 25 W 30 W 35 W 250 W150 W 350 W 450 W 550 W 3000 W20 W 90 W

Isolated FlybackMain, Bias, or

Standby Supply

High Power,Isolated Flyback and

Main, PFC Boost,Boost-Follower,

PFC + LLCHalf Bridge

High-PerformanceHigh-Voltage Diodes

PI-6

361x

-012

216

Power Productsto Support

Low Standby and No-Load Operation

HiperTFS-2(Two-Switch Forward)

HiperTFS-2(Standby)

HiperPFS-2(PFC)

TinySwitch-III

™

LinkSwitch-HP™

TinySwitch-4™

Qspeed

™

™

™

™

™

™

™

CAPZero / SENZero

HiperLCS(LLC)

HiperPFS-3

TOPSwitch-JX

http://www.power.com

3

Enabling Predictable SuccessPower Integrations’ highly integrated ICs enable the design and production of switch-mode power supplies that use up to 70% fewer components compared to discrete solutions. Switchers that incorporate our ICs are smaller, lighter, and more portable than comparablepower supplies built with linear transformers.

We combine a high-voltage MOSFET switch with a controller on a single chip to provide key power supply functions, such as:

• High-voltage start-up• Short-circuit and open-loop protection• Programmable current limit• Line undervoltage and overvoltage protection• Output overvoltage protection• Accurate over-temperature and over-power protection• Soft-start• Feedback compensation• Remote ON/OFF

Reducing Component Count

High-VoltageMOSFET

Full-FeaturedPSU Controller

Design Simplification

PI-5136a-062409

D

S

FB

BP

LinkSwitch-II

85 - 265VAC

5 V, 1 A

RTN

PI-5135a-062309

D

S

EN/UV

BP/M

TinySwitch-III

85 - 265VAC

5 V, 1 A

RTN

LinkSwitch-II dramatically simplifies low-power CV/CC charger designs by eliminating an optocoupler and secondary control circuitry. The device introduces a revolutionary control technique to provide very tight output voltage and current regulation, compensating for transformer and internal parameter tolerances along with input voltage variations.

4

EcoSmart – Enabling Energy-Efficient Power Supply Design

Power Integrations’ EcoSmart technology dramatically reduces standby and no-load energy waste (by up to 95% in some applications) by intelligently managing the flow of power into a device’s power supply. Using innovative IC products from Power Integrations, manufacturers can offer energy-efficient products that meet all current and proposed standby energy consumption standards around the world.

The Green Room

Power Integrations’ Green Room web site (www.power.com/greenroom) offers the latest information in energy-efficient design, including:

• Energy-efficiency regulations: Search by application, regulatory agency or geographic location• Mr. Green’s blog: An informative blog about energy-efficiency standards and other green matters• Energy FAQs: Answers to frequently asked questions about energy efficiency• Energy-efficiency resources: Links to other helpful web sites addressing energy issues• Introduction to green power: Tips for minimizing standby waste

Reference Designs

Reference Design Kits (RDKs) provide all of the essential materials needed to demonstrate the advanced features of Power Integrations’ ICs. Kits include a fully assembled and tested reference design power supply board, product samples and unpopulated PCB.

For more information, go to www.power.com/dak.htm

PI Expert Design Software

This powerful, interactive software takes a designer’s power supply specifications and automatically determines the critical components (including transformer specifications) needed to generate a working switch-mode power supply. Designs can be optimized for efficiency or cost using auto-design or manual control options. PI Expert simplifies the design of LED drivers, offline power supplies, and DC-DC converters, reducing design time from days to minutes.

To download PI Expert or request a CD, go to www.power.com/designsoftware.htm

PI Forums

Power Integrations provides several forums where designers can discuss technical questions with PI engineers and the extensive Power Integrations’ design community:

• Power Supply Design Forum: For general technical questions • PI Expert Support Forum: For discussing PI Expert Design Software• Green Energy Forum: For discussing energy efficiency regulations, EcoSmart technology and improving the

energy efficiency of electronic products

To participate in PI Forums, go to www.power.com/forum

Total Product Support

• Application notes• Data sheets• Design example reports• Design ideas• Engineering prototype reports• PI Expert design software• Reference design kits

Design Tools

5

PI-

4290

-020

306

0% 50% 100% 150% 200% 250%

Variation in Flyback Converter Output Power Capability Over Device Tolerance Range (Normalized to Rated Output Power)

Requires over-ratedpower componentsfor reliable design

ILIMIT: ±20%, fOSC: ±10%




System with Competitor Device C

System with PI Device (no I2f parameter)

I2f: ±11%System with PI Device (with I2f parameter)

System with Competitor Device B

System with Competitor Device A

Comprehensive Fault Protection – Simplifies Design and Improves Reliability• On-chip hysteretic thermal shutdown with auto-recovery • Control loop fault protection is independent of bias voltage • Protects entire system: device, PC board, magnetics and output rectifiers

PI-

3225

-062

209

Hysteretic Thermal Shutdown

tFault Applied– open-loop– short-circuit– overload

Average OutputPower

100%

3%

Directly detectsloss of feedbacksignal – independentof bias voltage

PI-3946-013009

Output Power During Loss of Feedback

Conducted EMI without Jitter Conducted EMI with Jitter

Tight Device Tolerances – Reduce System Cost• Power Integrations’ ICs have tight tolerances for current limit and switching frequency. This reduces the output overload power and

therefore the power rating, size and cost for the output rectifiers, transformer and clamp components.

Frequency Jittering – Reduces EMI and EMI Filtering Costs• Enables smaller, lower cost filter components

Product Features and Benefits

6

EMIComparison

Package Design/Pin Layout – Improves Reliability• Wide package DRAIN – SOURCE creepage reduces probability of arcing• Important for high pollution degree environments and forced air cooling• Optimal pin arrangement allows compliance with safety agency adjacent pin short-circuit test• Packages below are RoHS compliant

Source Heat Sinking – For Low Radiated EMI • Heat sink connected to SOURCE for low

radiated EMI

Typical Power Device

Power IntegrationsDevice

Product Features and Benefits

H PackageeSIP-16F

L PackageeSIP-16KeSIP-16G

H PackageeSIP-16CeSIP-16JeSIP-16D

PI-7198-111113

PI-6016-061410

P PackagePDIP-8C

D PackageSO-8

G PackageSMD-8C

PI-4891-072406

E PackageeSIP-7C

PI-5029-032108

PI-5258-101608

L PackageeSIP-7F

V PackageeDIP-12B

PI-5845-082511

K PackageeSOP-12B

PI-6357-082511

PI-6708-022712

1

3

4

5

6

7

8

9

10

11

13

14

16

PI-6541-091411

PI-3149-072406

7

High-Power, Resonant Converter Power MOSFET LLC Solution

HiperLCSThe HiperLCS is an integrated LLC power stage incorporating a multi-function controller, high-side and low-side gate drivers, plus two power MOSFETs in a half-bridge configuration. Figure 1 shows a simplified schematic of a HiperLCS based power stage where the LLC resonant inductor is integrated into the transformer.

The variable frequency controller provides high efficiency by switching the power MOSFETs at zero voltage (ZVS), eliminating switch-ing losses.

Key Benefits• LLC half-bridge power stage incorporating controller, high and low-side gate drives, and high-voltage power MOSFETs

• Eliminates up to 30 external components• High maximum operating frequency of 1 MHz

• Nominal steady-state operation up to 500 kHz • Dramatically reduces magnetics size and allows use of SMD ceramic output capacitors

• Precise duty symmetry balances output rectifier current, improving efficiency• 50% ±0.3% typical at 300 kHz

• Comprehensive fault handling and current limiting• Programmable brown-in/out thresholds and hysteresis• Undervoltage (UV) and overvoltage (OV) protection • Programmable over-current protection (OCP)• Short-circuit protection (SCP)• Over-temperature protection (OTP)

• Programmable dead-time for optimized design• Programmable burst mode maintains regulation at no-load and improves light load efficiency• Programmable soft-start time and delay before soft-start• Accurate programmable minimum and maximum frequency limits• Single package designed for high-power and high-frequency

• Reduces assembly cost and reduces PCB layout loop areas• Simple single clip attachment to heat sink• Exposed thermal pad connected to ground potential – no insulators required between package and heat sink• Staggered pin arrangement for simple PC board routing and high-voltage creepage requirements

• Paired with HiperPFS PFC product gives complete, high efficiency, low part count PSU solutions

Applications• High-efficiency power supplies (80 PLUS Silver, Gold and Platinum)• LCD TV power supplies• LED street and area lighting• Printer power supplies • Audio amplifier

LLC Feedback Circuit

HiperLCS

HB

VREF

DT/BF

RFMAX

RBURST

IS

FB

VCC

VCCH

High-VoltageDC Input OV/UV

G S1/S2

D

PI-6159-010813

StandbySupply

CONTROL

B+

V+

RTN

B-

8

High-Power, Two-Switch Forward and Flyback Solution

HiperTFS-2The HiperTFS-2 device family members incorporate both a high-power two-switch-forward converter and a mid-power flyback (stand-by) converter into a single, low-profile eSIP power package. The single chip solution provides the controllers for the two-switch-forward and flyback converters, high- and low-side drivers, all three of the high-voltage power MOSFETs, and eliminates the converter’s need for costly external pulse transformers. The device is ideal for high power applications that require both a main power converter (two-switch forward) up to 586 W peak, and standby converter (flyback) up to 20 W. HiperTFS-2 includes Power Integrations’ standard set of comprehensive protection features, such as integrated soft-start, fault and overload protection, and hysteretic thermal shutdown. HiperTFS-2 utilizes advanced power packaging technology that simplifies the complexity of two-switch forward layout, mounting and thermal management, while providing very high power capabilities in a single compact package. The devices operate over a wide input voltage range, and can be used following a power-factor correction stage such as HiperPFS.

Key Benefits• Single IC solution for two-switch forward main (66 kHz/132 kHz) and flyback (132 kHz) standby• High integration allows smaller form factor and higher power density designs, with reduced component count• Incorporates control, gate drivers, and three power MOSFETs• Level shift technology eliminates need for pulse transformer• Protection features include: UV, OV, OTP, OVP, standby OPC, SCP, and ILIMIT• Transformer reset control, prevents saturation under all conditions• Main duty cycle operation above 50% for reduced rms currents and lower output diode voltage rating• Less than 10% variation in standby overload power over input voltage range• Up to 586 W peak output power in a highly compact package• >90% efficiency at full load• Simple clip mounting to heat sink without need for insulation pad• Halogen free and RoHS compliant

Applications• PC• Printer • LCD TV • Video game consoles • High-power adapters• Industrial and appliance

HD

DC Input(VDC)

MainOutput

StandbyOutput

RTN

G S

HiperTFS-2 VDDH

L

FB

FB

EN

EN

BP

DSB

EN FB

Co

ntro

l, G

ate

Dri

vers

, Lev

el S

hift

R

D

HS

PI-7078-082213

Two-SwitchForward

Transformer

Standby FlybackTransformer

*Simplied feedback circuit

* *

* *

+

9

High-Power, PFC with Power MOSFET Solution

HiperPFS-2 The HiperPFS-2 device family members reach a very high level of integration including a continuous conduction mode (CCM) boost PFC controller, gate driver, ultra-low reverse recovery (Qspeed) diode (eeSIP™ package options) and high-voltage power MOSFET in a single, low-profile CoolPAD (GROUND pin connected) power package that is able to provide near unity input power factor. The HiperPFS-2 devices eliminate the PFC converter’s need for external current sense resistors, the power loss associated with those components, and leverages an innovative control technique that adjusts the switching frequency over output load, input line voltage, and even input line cycle. This control technique is designed to maximize efficiency over the entire load range of the converter, particu-larly at light loads. Additionally, this control technique significantly minimizes the EMI filtering requirements due to its wide bandwidth spread spectrum effect. The HiperPFS-2 also features an integrated non-linear amplifier for enhanced load transient response, a user programmable power good (PG) signal as well as user selectable power limit functionality. HiperPFS-2 includes Power Integrations’ standard set of comprehensive protection features, such as integrated soft-start, UV, OV, brown-in/out, and hysteretic thermal shut-down. HiperPFS-2 also provides cycle-by-cycle current limit for the power MOSFET, power limiting of the output for overload protection, and pin-to-pin short-circuit protection.

Key Benefits• Highly integrated for smallest boost PFC form factor

• Integrated controller and MOSFET in all package options• Ultra-low reverse recovery loss diode (Qspeed) included in extended eSIP package option• Lossless internal current sense reduces component count and system losses• EN61000-3-2 Class C and D compliant

• Packaging optimized for high volume production• Exposed pad connected to GROUND pin (CoolPAD)• Eliminates insulating pad/heat-spreader

• Enhanced features • Programmable power good (PG) signal• User selectable power limit: Enables device swapping in a given design to optimize efficiency/cost• Integrated non-linear amplifier for fast output OV and UV protection

• High efficiency and power factor across load range • >95% efficiency from 10% load to full load• <200 mW no-load consumption at 230 VAC in remote off-state• Light load PF >0.9 at 20% load on optimized designs >200 W• PF >0.95 at 50% load• Enables 80+ Platinum designs

• Frequency adjusted over line voltage and each line cycle• Spread-spectrum across >60 kHz window simplifies EMI filtering requirements• Lower boost inductance

• Provides up to 425 W peak output power• >425 W peak power in power limit voltage regulation mode

• Protection features include: UV, OV, OTP, brown-in/out, cycle-by-cycle current limit and power limiting for overload protection• Halogen free and RoHS compliant

Key Benefits• PC• Printer• LCD TV • Video game consoles • High-power adaptors • High-power LED lighting • Industrial and appliance• Generic PFC converters

PI-6691-050313

ACIN

DCOUT

+

S

C

PGT

FB

VCC

PG

KD

RGV

CONTROL

HiperPFS-2

VCC

10

High-Efficiency, Flyback Controller and MOSFET Solution

HiperPFS-3 The HiperPFS-3 devices incorporate a continuous conduction mode (CCM) boost PFC controller, gate driver, ultra-low reverse recovery (Qspeed) diode and high-voltage power MOSFET in a single, low-profile (GROUND pin connected) power package. HiperPFS-3 devices eliminate the PFC converter’s need for external current sense resistors and the associated power loss, and use an innovative control technique that adjusts the switching frequency over output load, input line voltage, and even input line cycle. This control technique maximizes efficiency over the entire load range of the converter, particularly at light loads. Additionally, it significantlyminimizes the EMI filtering requirements due to its wide bandwidth spread spectrum effect. The HiperPFS-3 uses advanced digitaltechniques for line monitoring functions, line feed-forward scaling, and power factor enhancement, while using analog techniques for the core controller in order to maintain extremely low no-load power consumption. The HiperPFS-3 also features an integrated non-linear error amplifier for enhanced load transient response, a user programmable Power Good (PG) signal as well as user selectable power limit functionality. HiperPFS-3 includes Power Integrations’ standard set of comprehensive protection features, such as integrated UV, OV, brown-in/out, and hysteretic thermal shutdown. HiperPFS-3 also provides cycle-by-cycle current limit and Safe Operating Area (SOA) protection of the power MOSFET, power limiting of the output for overload protection, and pin-to-pin short-circuit protection.

Key Benefits• High efficiency and power factor across load range

• >95% efficiency from 10% load to full load• <60 mW no-load consumption at 230 VAC• PF >0.92 easily achievable at 20% load• EN61000-3-2 Class C and D compliant

• Highly integrated for smallest boost PFC form factor• Integrated controller, MOSFET and ultra-low reverse recovery loss diode (Qspeed)• Packaging optimized for high volume production

• Eliminates insulating pad/heat-spreader• Enhanced features

• Programmable Power Good (PG) signal• User selectable power limit: Enables different HiperPFS-3 family members to be tested in the same design for optimum device

selection• Integrated non-linear amplifier for fast output OV and UV protection and transient response• Digital line peak detection that provides robust performance even with distorted input voltage from UPS or generators• Digital power factor enhancer compensates for EMI filter and bridge distortion, providing high-line PF >0.92 @ 20% load

• Frequency adjusted over line voltage and each line cycle• Spread-spectrum across >60 kHz window simplifies EMI filtering requirements• Lower boost inductance

• Provides up to 450 W peak output power for universal applications, 1 kW for high-line only applications• Protection features include: UVLO, UV, OV, OTP, brown-in/out, cycle-by-cycle current limit and power limiting for overload protection• Halogen free and RoHS compliant

Key Benefits• PC• Printer• LCD TV • Video game consoles• 80 Plus™ Platinum designs • High-power adaptors • High-power LED lighting • Industrial and appliance• Generic PFC converters

PI-7224-061615

ACIN

DCOUT

+

S

C

PGT

FB

VCC

PG

KD

REFGV

CONTROL

HiperPFS-3

VCC

11


TOPSwitch-JXThe TOPSwitch-JX is a highly integrated monolithic off-line switcher IC designed for off-line flyback power supplies. TOPSwitch-JX integrated circuits enable design of power supplies up to 177 W universal input and 244 W high-line input, while providing high efficiency under all load conditions. TOPSwitch-JX also provides very good performance at low load and during standby (no-load) operation. The TOPSwitch-JX family allows the designer to easily meet efficiency requirements for the latest energy-efficiency standards. Innovative and proprietary features enable design of compact and cost effective switching power supplies while reducing overall design cycle time and system cost. The TOPSwitch-JX family also enables the design of power supplies with robust functionality and provides enhanced safety features such as output overvoltage protection, overload power limiting and hysteretic thermal protec-tion. TOPSwitch-JX family of solutions easily meets energy efficiency standards such as European Code of Conduct, EC EuP and ENERGY STAR.

High Efficiency Flyback Controller and MOSFET• Flyback controller with 725 V power MOSFET and programmable current limit• Designed for <100 mW 230 VAC no-load specifications

• <90 mW at 230 VAC in 65 W adaptor• <70 mW at 264 VAC in monitor supply• 95 mW consumption at 20 mW load and 264 VAC input

• Multi-mode PWM control technique maximizes efficiency over load• 89% average efficiency in notebook adaptor• High efficiency across load allows use in high-power standby supplies

• Selectable switching frequency (66 kHz or 132 kHz)• Frequency jitter to reduce EMI filtering requirements

Extensive Protection Features• Auto-restart limits power delivery to <3% during overload faults

• Output short-circuit protection (SCP)• Output over-current protection (OCP)• Output overload protection (OPP)

• Output overvoltage protection (OVP)• User programmable for hysteretic/latching shutdown• Simple fast AC reset• Primary or secondary sensed

• Line undervoltage (UV) detection prevents turn-off glitches• Line overvoltage (OV) shutdown extends line surge withstand• Accurate thermal shutdown with large hysteresis (OTP)

Advanced Package for High-Power Applications• Up to 177 W output power capability in a highly compact package

• Up to 43 W power without external heat sink in low profile eDIP option• Simple clip mounting to heat sink

• Can be directly connected to heat sink without insulation pad• Provides thermal impedance equivalent to a TO-220• Heat slug connected to ground potential for low EMI

• Staggered pin arrangement for simple routing of board traces and high-voltage creepage requirements

Applications• Notebook or laptop adapter• Generic adapter• Printer• LCD monitor• Set-top box• PC or LCD TV standby• LCD-TV and monitor display power

supplies• LED streetlights

PI-5578-090309

ACIN

DCOUT

D

S

CTOPSwitch-JXCONTROL

V

+

-

FX

12


LinkSwitch-HPThe LinkSwitch-HP family of flyback power supply ICs incorporate a primary-side regulated (PSR) controller and high-voltage power MOSFET in a single package. The IC family includes devices optimized for constant voltage (CV) operation at power ranges from 9 W to 90 W. LinkSwitch-HP IC controller features ±5% CV accuracy, selectable current limit, programmable latching or hysteretic OVP, UVP and OTP, improved overload power compensation over line, fast AC reset, and programmable shutdown delay time.

High Design Flexibility for Low System Cost• Dramatically simplifies power supply designs

• Eliminates optocoupler and all secondary control circuitry• ±5% or better output voltage tolerance

• 132 kHz operation reduces transformer and power supply size• Accurate programmable current limit

• Compensation over line limits overload power• Frequency jittering reduces EMI filter cost• Fully integrated soft-start for minimum start-up stress• 725 V MOSFET simplifies meeting derating requirements (LNK677x)• 650 V MOSFET for lowest system cost (LNK676x/LNK666x)• Fast transient response family option (LNK666x)

Extensive Protection Features• Auto-restart limits power delivery to 3% during overload faults

• Output short-circuit protection (SCP)• Output overload/over-current protection (OPP, OCP)• Optional extended shutdown delay time

• Output overvoltage protection (OVP), hysteretic or latching• Line brown-in/out protection (line UV)• Line overvoltage (OV) shutdown extends line surge withstand• Accurate thermal shutdown (OTP), hysteretic or latching

Advanced Green Package Options• eSIP™-7C package:

• Vertical orientation for minimum PCB footprint• Simple heat sink mounting using clip or adhesive pad

• eSOP™-12B package:• Low profile surface mounted for ultra-slim designs• Heat transfer to PCB via exposed pad and SOURCE pins• Supports either wave or IR reflow soldering

• eDIP™-12B package:• Low profile through-hole mounted for ultra-slim designs• Heat transfer to PCB via exposed pad or optional metal heat sink

• Extended creepage to DRAIN pin• Heat sink is connected to SOURCE for low EMI• Halogen free and RoHS compliant

Typical Applications• LCD Monitor and TV• Adapter• Appliances• Embedded power supplies (DVD, set-top box)• Industrial

LinkSwitch-HP

DCOUT

ACIN

PI-6530-101711

D

S

FB

BP

CPPD

CONTROL

13

High-Efficiency Flyback for Standby/Auxiliary

TinySwitch-4With line-compensated overload power protection, TinySwitch-4 devices dramatically reduce the maximum overload variation over the universal input voltage range. It is particularly helpful in applications such as PC standby and CV adapters to limit the maximum output power during the overload fault condition. TinySwitch-4 also incorporates a 725 V MOSFET that easily allows 80% de-rating for high reflected voltage and high bus voltage designs. The BP/M pin permits the MOSFET current limit to be adjusted up or down, allowing designers to optimize power delivery and efficiency in a variety of physical implementations. An on-time extension function extends the low-line regulation range, enabling hold-up time to be met with lower values of input capacitance.

Lowest System Cost with Enhanced Flexibility • 725 V rated MOSFET

• Increases BV de-rating margin• Line compensated overload power – no additional components

• Dramatically reduces max overload variation over universal input voltage range • ±5% turn on UV threshold: line voltage sense with single external resistor • Simple ON/OFF control, no loop compensation needed• Selectable current limit through BP/M capacitor value

• Higher current limit extends peak power or, in open frame applications, maximum continuous power • Lower current limit improves efficiency in enclosed adapters/chargers• Allows optimum TinySwitch-4 choice by swapping devices with no other circuit redesign

• Tight I2f parameter tolerance reduces system cost• Maximizes MOSFET and magnetics utilization

• ON-time extension – extends low-line regulation range/hold-up time to reduce input bulk capacitance• Self-biased: no bias winding or bias components• Frequency jittering reduces EMI filter costs• Pin-out simplifies heat sinking to the PCB • SOURCE pins are electrically quiet for low EMI

Enhanced Safety and Reliability Features• Accurate hysteretic thermal shutdown protection with automatic recovery eliminates need for manual reset • Auto-restart delivers <3% of maximum power in short-circuit and open loop fault conditions• Output overvoltage shutdown with optional Zener

• Fast AC reset with optional UV external resistor • Very low component count enhances reliability and enables single-sided printed circuit board layout• High bandwidth provides fast turn-on with no overshoot and excellent transient load response• Extended creepage between DRAIN and all other pins improves field reliability

Applications• PC Standby and other auxiliary supplies• DVD/PVR and other low power set top decoders• Supplies for appliances, industrial systems, metering, etc• Chargers/adapters for cell/cordless phones, PDAs, digital cameras, MP3/portable audio, shavers, etc.

+ +

PI-6578-020915

Wide-RangeHigh-Voltage

DC InputD

S

EN/UV

BP/M

DCOutput

TinySwitch-4

14

High-Efficiency Flyback for Standby/Auxiliary

TinySwitch-IIITinySwitch-III incorporates a 700 V MOSFET, oscillator, high-voltage switched current source, current limit (user selectable) and thermal shutdown circuitry. The IC family uses an ON/OFF control scheme and offers a design flexible solution with a low system cost and extended power capability. Unlike conventional PWM (pulse width modulator) controllers, it uses a simple ON/OFF control to regulate the output voltage. The controller consists of an oscillator, enable circuit (sense and logic), current limit state machine, 5.85 V regulator, BYPASS/MULTI-FUNCTION pin undervoltage, overvoltage circuit, and current limit selection circuitry, over-temperature protection, current limit circuit, leading edge blanking, and a 700 V power MOSFET. TinySwitch-III incorporates additional circuitry for line undervoltage sense, auto-restart, adaptive switching cycle on-time extension, and frequency jitter. Figure below shows the functional block diagram with the most important features.

Product Highlights (Lowest System Cost with Enhanced Flexibility)• Simple ON/OFF control, no loop compensation needed• Selectable current limit through BP/M capacitor value

• Higher current limit extends peak power or, in open frame applications, maximum continuous power• Lower current limit improves efficiency in enclosed adapters/chargers• Allows optimum TinySwitch-III choice by swapping devices with no other circuit redesign

• Tight I2f parameter tolerance reduces system cost• Maximizes MOSFET and magnetics power delivery• Minimizes max overload power, reducing cost of transformer, primary clamp & secondary components

• ON-time extension – extends low line regulation range/hold-up time to reduce input bulk capacitance• Self-biased: no bias winding or bias components• Frequency jittering reduces EMI filter costs• Pin-out simplifies heat sinking to the PCB• SOURCE pins are electrically quiet for low EMI

Enhanced Safety and Reliability Features• Accurate hysteretic thermal shutdown protection with automatic recovery eliminates need for manual reset• Improved auto-restart delivers <3% of maximum power in short-circuit and open loop fault conditions• Output overvoltage shutdown with optional Zener• Line undervoltage detect threshold set using a single optional resistor• Very low component count enhances reliability and enables single-sided printed circuit board layout• High bandwidth provides fast turn on with no overshoot and excellent transient load response• Extended creepage between DRAIN and all other pins improves field reliability

EcoSmart• Easily meets all global energy efficiency regulations• No-load <150 mW at 265 VAC without bias winding, <50 mW with bias winding• ON/OFF control provides constant efficiency down to very light loads – ideal for mandatory CEC regulations and 1 W PC standby

requirements

Applications• PC Standby and other auxiliary supplies• Chargers/adapters for cell/cordless phones, PDAs, digital cameras, MP3/portable audio, shavers, etc.• DVD/PVR and other low power set top decoders• Appliances, industrial systems, metering, etc.

PI-4095-082205

Wide-RangeHigh-Voltage

DC InputD

S

EN/UV

BP/M

DCOutput

TinySwitch-III

++

15

CAPZero-2When AC voltage is applied, CAPZero-2 blocks current flow in the X capacitor safety discharge resistors, reducing the power loss to less than 5 mW, or essentially zero at 230 VAC. When AC voltage is disconnected, CAPZero-2 automatically discharges the X capacitor by connecting the series discharge resistors. This operation allows total flexibility in the choice of the X capacitor to optimize differen-tial mode EMI filtering and reduce inductor costs, with no change in power consumption.

Designing with CAPZero-2 is simply a matter of selecting the appropriate CAPZero-2 device and external resistor values in Table 1 for the X capacitor value being used. This design choice will provide a worst-case RC time constant, when the AC supply is disconnected, of less than 1 second as required by international safety standards.

The simplicity and ruggedness of the two terminal CAPZero-2 IC makes it an ideal choice in systems designed to meet EuP Lot 6 requirements.

The CAPZero family has two voltage grades: 825 V and 1000 V. The voltage rating required depends on surge requirement and circuit configuration of the application. See Key Applications Considerations section for details.

Product Highlights• One part to cover X capacitor values from 100 nF to 6 mF• Blocks current through X capacitor discharge resistors when AC voltage is connected• Automatically discharges X capacitors through discharge resistors when AC is disconnected• Simplifies EMI filter design – larger X capacitor allows smaller inductive components with no change in consumption• Only two terminals – meets safety standards for use before or after system input fuse• >4 mm creepage on package and PCB• Self supplied – no external bias required• High common mode surge immunity – no external ground connection• High differential surge withstand – 1000 V internal MOSFETs• NEMKO and CB certification

EcoSmart• <5 mW consumption at 230 VAC for all X capacitor values

Applications• All AC-DC converters with X capacitors of 100 nF up to 6 mF• Appliances requiring EuP Lot 6 compliance• Adapters requiring ultra low no-load consumption• All converters requiring very low standby power• Lossless generation of zero crossing signal

Automatic X Capacitor Discharge IC

PI-7508-012015

X Capacitor1

CEXTAC

X Capacitor2

MOVPOS1 MOVPOS2

Other EMI Filter

Components

D1

R1

R2

CAP200DG D2

16

SENZeroSENZero is a compact low cost solution to eliminate losses in resistive signal paths connected between high-voltage rails and switching power supply controller(s). Examples include feed-forward or feedback signal paths connected to boost controllers in power factor corrected systems and feed-forward signal paths in two switch forward / LLC / half and full bridge converters.

The device is available in 2 (SEN012) and 3 (SEN013) channel versions according to the application’s requirements. The internal gate drive and protection circuitry provides gate drive signals to the internal 650 V MOSFETs in response to the voltage applied to the VCC pin. This simple configuration provides easy integration into existing systems by using the system VCC rail as an input to the SENZero.

The SENZero family uses a low cost compact SO-8 package to reduce PCB area while the pin configuration is designed to meet pin-pin fault conditions.

Product Highlights• Eliminates significant standby losses• Disconnects unnecessary circuit blocks during standby, remote-off, or light-load conditions• Ultra low leakage (maximum 1 mA) 650 V MOSFETs

• <0.5 mW per channel during standby• Single component provides remote disconnect functionality

• No external components or additional bias supply needed for remote-off• Integrates multiple disconnect MOSFETs, gate drive, and protection• Minimal component count provides higher reliability

• Protection features to help production/manufacturing yields• Pin-to-pin fault and ESD protection

• Triggerable via remote-off signal or load conditions• Integrated gate pull down circuit protects against loss of trigger signal fault

• Green package technology• RoHS compliant and halogen free

• Withstands high differential surge conditions• S1, S2 and S3 interface with controller pins up to 6.5 V above system ground

EcoSmart• <3 mW loss at 230 VAC in Off/standby mode

Applications• AC-DC converters with high-voltage resistive signal paths• Ideal for all very low standby systems such as those meeting EuP Lot 6 and similar energy efficiency standards

High-Voltage Sense Signal Disconnect IC

PI-6136-032315

+

ACInput

High-VoltageDC

SENZero

D2 VCCD1 D3

S1 GS2 S3

Control&

Drive

SystemVCC

SystemStandbySignal

PFCIC

17

Qspeed DiodesQspeed diodes combine an extremely low reverse recovery charge (QRR) with very soft recovery. Together, these features help designers improve the performance of their power conversion circuits.

Product Highlights• Ideal for continuous conduction mode (CCM) PFC circuits

• Very low reverse recovery (QRR) greatly reduces power loss in PFC diode and switching MOSFET• Flat QRR temperature characteristic reduces overdesign compared to ultrafast diodes• Ultra-soft recovery characteristic reduces EMI • Reduced switching losses and EMI allows higher switching frequency for smaller PFC inductors• Common cathode TO-220 package option is ideal for interleaved designs

• Reduced peak inverse voltage and soft recovery characteristic eliminate snubber circuits • Ideal for output rectifier diodes for electric vehicle chargers

• Product families optimized for different performance characteristics – lowest EMI and highest efficiency against different operating frequencies

High-Performance Diodes

Qspeed diodes significantly reduce reverse recovery loss that improves efficiency.

PI-6452-051011

f < 80 kHz X-Series Lowest VF

f > 80 kHzQ-Series Lowest EMI

H-Series Highest Efficiency

Application Guide

0 20 40 60 80 120100 180 200140 160

Time (ns)

Dio

de

Cur

rent

(A)

8

6

4

2

0

-2

-4

-6

-8

PI-

6645

-121

511

Qspeed H-Series DiodeUltrafast Diode

0

10

20

30

40

50

60

70

80

PI-

6644

-120

211

150 1 10 30

Frequency (MHz)

Leve

l (d

BµV

)

Qspeed Q-Series DiodeUltrafast Diode

0 20 40 60 80 120100 180 200140 160

Time (ns)

Dio

de

Cur

rent

(A)

9

678

543210

-1-2-3-4-5-6

PI-

6643

-120

211

Qspeed Q-Series DiodeUltrafast Diode

1918

Power 85-265 VAC

(rated)(W)

Peak Power 85-265 VAC /

230 VAC(W)

Device Package PSR/Opto

CV Accuracy

(best)(%)

Cable-Drop Compensation (1 mF, 10 mF)

CC Accuracy

(best) (%)

Typical No-Load Power at

230 VAC (with bias winding)

(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device

Output Short-Circuit

Protection

Programmable Current

LimitLine UV Line OV

Line Ripple

Rejection

Soft Start(ms)

I2f Trimming

Nominal Switching Frequency

(kHz)

On-Time Extension

Peak Power Delivered During

Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

110 110 LCS700 H, L Opto ± 5 N/A N/A < 1 W 5.2 PWM Y Auto-Restart LCS700 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N170 170 LCS701 H, L Opto ± 5 N/A N/A < 1 W 7.7 PWM Y Auto-Restart LCS701 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N220 220 LCS702 H, L Opto ± 5 N/A N/A < 1 W 10.3 PWM Y Auto-Restart LCS702 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N275 275 LCS703 H, L Opto ± 5 N/A N/A < 1 W 12.9 PWM Y Auto-Restart LCS703 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N350 350 LCS705 H Opto ± 5 N/A N/A < 1 W 19.3 PWM Y Auto-Restart LCS705 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N440 440 LCS708 H Opto ± 5 N/A N/A < 1 W 30.9 PWM Y Auto-Restart LCS708 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N

110 120 PFS7323 L Non-Isolated ± 5 N/A N/A < 130 4.1 PWM Y Auto-Restart PFS7323 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A130 150 PFS7324 L Non-Isolated ± 5 N/A N/A < 130 4.8 PWM Y Auto-Restart PFS7324 N/A Fixed Y V N/A 18 N/A Variable N/A N/A N/A N/A185 205 PFS7325 H, L Non-Isolated ± 5 N/A N/A < 130 5.9 PWM Y Auto-Restart PFS7325 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A230 260 PFS7326 H Non-Isolated ± 5 N/A N/A < 130 7.2 PWM Y Auto-Restart PFS7326 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A290 320 PFS7327 H Non-Isolated ± 5 N/A N/A < 130 8.4 PWM Y Auto-Restart PFS7327 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A350 385 PFS7328 H Non-Isolated ± 5 N/A N/A < 130 9.5 PWM Y Auto-Restart PFS7328 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A380 425 PFS7329 H Non-Isolated ± 5 N/A N/A < 130 10.5 PWM Y Auto-Restart PFS7329 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A110 120 PFS7523 H, L Non-Isolated ± 5 N/A N/A < 60 7.5 PWM Y Auto-Restart PFS7523 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A130 150 PFS7524 H, L Non-Isolated ± 5 N/A N/A < 60 9.0 PWM Y Auto-Restart PFS7524 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A185 205 PFS7525 H, L Non-Isolated ± 5 N/A N/A < 60 11.3 PWM Y Auto-Restart PFS7525 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A230 260 PFS7526 H Non-Isolated ± 5 N/A N/A < 60 13.5 PWM Y Auto-Restart PFS7526 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A290 320 PFS7527 H Non-Isolated ± 5 N/A N/A < 60 15.8 PWM Y Auto-Restart PFS7527 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A350 385 PFS7528 H Non-Isolated ± 5 N/A N/A < 60 18.0 PWM Y Auto-Restart PFS7528 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A405 450 PFS7529 H Non-Isolated ± 5 N/A N/A < 60 21.0 PWM Y Auto-Restart PFS7529 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 280 PFS7533 H Non-Isolated ± 5 N/A N/A < 60 7.5 PWM Y Auto-Restart PFS7533 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 350 PFS7534 H Non-Isolated ± 5 N/A N/A < 60 9.0 PWM Y Auto-Restart PFS7534 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 480 PFS7535 H Non-Isolated ± 5 N/A N/A < 60 11.3 PWM Y Auto-Restart PFS7535 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 610 PFS7536 H Non-Isolated ± 5 N/A N/A < 60 13.5 PWM Y Auto-Restart PFS7536 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 750 PFS7537 H Non-Isolated ± 5 N/A N/A < 60 15.8 PWM Y Auto-Restart PFS7537 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 900 PFS7538 H Non-Isolated ± 5 N/A N/A < 60 18.0 PWM Y Auto-Restart PFS7538 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 1000 PFS7539 H Non-Isolated ± 5 N/A N/A < 60 21.0 PWM Y Auto-Restart PFS7539 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A

148 187 TFS7701 H Opto External N/A N/A < 50 1.70 PWM &ON/OFF Y Latch / Non-Latch /

Auto-Restart TFS7701 Auto-Restart Selectable Y Y N/A 12 Y 66 & 132 N 2 Y Y















IC Product Tables – Enclosed IC Product Tables – Enclosed

2120

Power 85-265 VAC

(rated)(W)


230 VAC(W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2f Trimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

12 20 TOP264 V Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y15 26 TOP265 V Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y16 16 TOP264 K Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y17 40 TOP266 V Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP266 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y19 55 TOP267 V Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y20 20 TOP264 E Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y20 20 TOP265 K Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y

21.5 70 TOP268 V Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y22.5 80 TOP269 V Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y23 23 TOP266 K Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y

24.5 93 TOP270 V Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y26 26 TOP265 E Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y26 26 TOP267 K Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y26 118 TOP271 V Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y30 30 TOP268 K Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y33 33 TOP269 K Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y36 36 TOP270 K Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y40 40 TOP266 E Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP266 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y40 40 TOP271 K Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y55 55 TOP267 E Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y70 70 TOP268 E Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y80 80 TOP269 V Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y93 93 TOP270 E Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y118 118 TOP271 E Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y


2322

Power 85-265 VAC

(rated)(W)


230 VAC(W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2f Trimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

9 15 LNK6663 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable9 15 LNK6763 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable9 15 LNK6773 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable11 16 LNK6664 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable11 16 LNK6764 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable11 16 LNK6774 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable12 21 LNK6663 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable12 21 LNK6763 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable12 21 LNK6773 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 19 LNK6665 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 19 LNK6765 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 19 LNK6775 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 21 LNK6663 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 21 LNK6763 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable13 21 LNK6773 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 21 LNK6666 V PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 21 LNK6766 V PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 21 LNK6776 V PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 22 LNK6664 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 22 LNK6764 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 22 LNK6774 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable18 26 LNK6665 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable18 26 LNK6765 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable18 26 LNK6775 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable19 25 LNK6667 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable19 25 LNK6767 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable19 25 LNK6777 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 30 LNK6664 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 30 LNK6764 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 30 LNK6774 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 29 LNK6668 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 29 LNK6768 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 29 LNK6778 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6666 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6766 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6776 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable25 33 LNK6669 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable25 33 LNK6769 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable25 33 LNK6779 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 40 LNK6665 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 40 LNK6765 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 40 LNK6775 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 36 LNK6667 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 36 LNK6767 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 36 LNK6777 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6668 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6768 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6778 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6669 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6769 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6779 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable40 60 LNK6666 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable40 60 LNK6766 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable40 60 LNK6776 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable55 85 LNK6667 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable55 85 LNK6767 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable55 85 LNK6777 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable63 98 LNK6668 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable63 98 LNK6768 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable63 98 LNK6778 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable72 111 LNK6669 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable72 111 LNK6769 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable72 111 LNK6779 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable


2524

Power 85-265 VAC

(rated)(W)


230 VAC(W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2f Trimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

5 8.5 TNY284 P, D, K Opto External Remote Sense External < 30 0.25 ON/OFF Y Latch TNY284 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y5 8.5 TNY274 P, G Opto External Remote Sense External < 50 0.25 ON/OFF Y Latch TNY274 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y6 11.5 TNY285 P, D Opto External Remote Sense External < 30 0.275 ON/OFF Y Latch TNY285 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y6 11.5 TNY275 P, G Opto External Remote Sense External < 50 0.275 ON/OFF Y Latch TNY275 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 15 TNY286 P, D Opto External Remote Sense External < 30 0.35 ON/OFF Y Latch TNY286 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 15 TNY276 P, G Opto External Remote Sense External < 50 0.35 ON/OFF Y Latch TNY276 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 18 TNY287 D Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

7.5 11.5 TNY285 K Opto External Remote Sense External < 30 0.275 ON/OFF Y Latch TNY285 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y8 18 TNY287 P Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y8 18 TNY277 P, G Opto External Remote Sense External < 50 0.45 ON/OFF Y Latch TNY277 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y9 19 TNY288 D Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

9.5 15 TNY286 K Opto External Remote Sense External < 30 0.35 ON/OFF Y Latch TNY286 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y10 21.5 TNY288 P Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y10 21.5 TNY278 P, G Opto External Remote Sense External < 50 0.55 ON/OFF Y Latch TNY278 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y11 18 TNY287 K Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y12 25 TNY289 P Opto External Remote Sense External < 30 0.65 ON/OFF Y Latch TNY289 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y12 25 TNY279 P, G Opto External Remote Sense External < 50 0.65 ON/OFF Y Latch TNY279 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y14 28.5 TNY290 P Opto External Remote Sense External < 30 0.75 ON/OFF Y Latch TNY290 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y14 28.5 TNY280 P, G Opto External Remote Sense External < 50 0.75 ON/OFF Y Latch TNY280 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

14.5 21.5 TNY288 K Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y17 25 TNY289 K Opto External Remote Sense External < 30 0.65 ON/OFF Y Latch TNY289 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y20 28.5 TNY290 K Opto External Remote Sense External < 30 0.75 ON/OFF Y Latch TNY290 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y


2726

IC Product Tables – Open Frame

Open Frame Power

85-265 VAC (rated) (W)

Open Frame Peak Power

85-265 VAC / 230 VAC (W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit(A)

ON/OFF, PWM, Multi-mode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2fTrimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

110 110 LCS700 H, L Opto ± 5 N/A N/A < 1 W 5.2 PWM Y External LCS700 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N170 170 LCS701 H, L Opto ± 5 N/A N/A < 1 W 7.7 PWM Y External LCS701 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N220 220 LCS702 H, L Opto ± 5 N/A N/A < 1 W 10.3 PWM Y External LCS702 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N275 275 LCS703 H, L Opto ± 5 N/A N/A < 1 W 12.9 PWM Y External LCS703 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N350 350 LCS705 H Opto ± 5 N/A N/A < 1 W 19.3 PWM Y External LCS705 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2 N/A N440 440 LCS708 H Opto ± 5 N/A N/A < 1 W 30.9 PWM Y External LCS708 Auto-Restart Y Y Y N/A Programmable N/A Variable N/A 0.2- N/A N

110 120 PFS7323 L Non-Isolated ± 5 N/A N/A < 130 4.1 PWM Y Auto-Restart PFS7323 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A130 150 PFS7324 L Non-Isolated ± 5 N/A N/A < 130 4.8 PWM Y Auto-Restart PFS7324 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A185 205 PFS7325 H, L Non-Isolated ± 5 N/A N/A < 130 5.9 PWM Y Auto-Restart PFS7325 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A230 260 PFS7326 H Non-Isolated ± 5 N/A N/A < 130 7.2 PWM Y Auto-Restart PFS7326 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A290 320 PFS7327 H Non-Isolated ± 5 N/A N/A < 130 8.4 PWM Y Auto-Restart PFS7327 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A350 385 PFS7328 H Non-Isolated ± 5 N/A N/A < 130 9.5 PWM Y Auto-Restart PFS7328 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A380 425 PFS7329 H Non-Isolated ± 5 N/A N/A < 130 10.5 PWM Y Auto-Restart PFS7329 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A110 120 PFS7523 H, L Non-Isolated ± 5 N/A N/A < 60 7.5 PWM Y Auto-Restart PFS7523 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A130 150 PFS7424 H, L Non-Isolated ± 5 N/A N/A < 60 9.0 PWM Y Auto-Restart PFS7424 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A185 205 PFS7525 H, L Non-Isolated ± 5 N/A N/A < 60 11.3 PWM Y Auto-Restart PFS7525 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A230 260 PFS7526 H Non-Isolated ± 5 N/A N/A < 60 13.5 PWM Y Auto-Restart PFS7526 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A290 320 PFS7527 H Non-Isolated ± 5 N/A N/A < 60 15.8 PWM Y Auto-Restart PFS7527 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A350 385 PFS7528 H Non-Isolated ± 5 N/A N/A < 60 18.0 PWM Y Auto-Restart PFS7528 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A405 450 PFS7529 H Non-Isolated ± 5 N/A N/A < 60 21.0 PWM Y Auto-Restart PFS7529 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 280 PFS7533 H Non-Isolated ± 5 N/A N/A < 60 7.5 PWM Y Auto-Restart PFS7533 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 350 PFS7534 H Non-Isolated ± 5 N/A N/A < 60 9.0 PWM Y Auto-Restart PFS7534 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 480 PFS7535 H Non-Isolated ± 5 N/A N/A < 60 11.3 PWM Y Auto-Restart PFS7535 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 610 PFS7536 H Non-Isolated ± 5 N/A N/A < 60 13.5 PWM Y Auto-Restart PFS7536 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 750 PFS7537 H Non-Isolated ± 5 N/A N/A < 60 15.8 PWM Y Auto-Restart PFS7537 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 900 PFS7538 H Non-Isolated ± 5 N/A N/A < 60 18.0 PWM Y Auto-Restart PFS7538 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/AN/A 1000 PFS7539 H Non-Isolated ± 5 N/A N/A < 60 21.0 PWM Y Auto-Restart PFS7539 N/A Fixed Y Y N/A 18 N/A Variable N/A N/A N/A N/A


















2928


Open Frame Power


Open Frame Peak Power

85-265 VAC / 230 VAC (W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit(A)

ON/OFF, PWM, Multi-mode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2fTrimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

22.5 43 TOP264 V Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y25 57 TOP265 V Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y V Y Dual Slope 17 Y 66/132 Y 2 Y Y

28.5 86 TOP266 V Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP266 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y30 30 TOP264 K Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y32 103 TOP267 V Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y34 34 TOP265 K Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y36 112 TOP268 V Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y

37.5 120 TOP269 V Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y39 39 TOP266 K Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP266 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y41 140 TOP270 V Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y43 43 TOP264 E Opto External Remote Sense External < 75 1.3 Multimode Y Latch / Auto-Restart TOP264 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y43 177 TOP271 V Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y45 45 TOP267 K Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y50 50 TOP268 K Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y55 55 TOP269 K Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y57 57 TOP265 E Opto External Remote Sense External < 75 1.7 Multimode Y Latch / Auto-Restart TOP265 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y60 60 TOP270 K Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y66 66 TOP271 K Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y86 86 TOP266 E Opto External Remote Sense External < 75 2.55 Multimode Y Latch / Auto-Restart TOP266 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y103 103 TOP267 E Opto External Remote Sense External < 75 3 Multimode Y Latch / Auto-Restart TOP267 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y112 112 TOP268 E Opto External Remote Sense External < 75 3.25 Multimode Y Latch / Auto-Restart TOP268 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y120 120 TOP269 E Opto External Remote Sense External < 75 3.48 Multimode Y Latch / Auto-Restart TOP269 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y140 140 TOP270 E Opto External Remote Sense External < 75 4.2 Multimode Y Latch / Auto-Restart TOP270 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y177 177 TOP271 E Opto External Remote Sense External < 75 5.17 Multimode Y Latch / Auto-Restart TOP271 Auto-Restart Y Y Y Dual Slope 17 Y 66/132 Y 2 Y Y


3130


Open FramePower


Open FramePeak Power

85-265 VAC / 230 VAC (W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2f Trimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

15 25 LNK6663 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 25 LNK6763 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable15 25 LNK6773 V PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 28 LNK6664 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 28 LNK6764 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable20 28 LNK6774 V PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 35 LNK6663 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 35 LNK6763 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable21 35 LNK6773 K PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6665 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6765 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable22 30 LNK6775 V PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 34 LNK6666 V PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 34 LNK6766 V PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable26 34 LNK6776 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 35 LNK6663 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6663 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 35 LNK6763 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6763 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable27 35 LNK6773 E PSR ± 5 N/A N/A < 30 0.77 Multimode Y Latch / Auto-Restart LNK6773 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable28 39 LNK6664 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable28 39 LNK6764 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable28 39 LNK6774 K PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6667 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6767 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable30 41 LNK6777 V PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable31 42 LNK6665 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable31 42 LNK6765 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable31 42 LNK6775 K PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable34 47 LNK6668 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable34 47 LNK6768 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable34 47 LNK6778 V PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6664 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6664 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6764 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6764 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable36 47 LNK6774 E PSR ± 5 N/A N/A < 30 1.04 Multimode Y Latch / Auto-Restart LNK6774 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable37 48 LNK6666 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable37 48 LNK6766 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable37 48 LNK6776 K PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable39 54 LNK6669 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable39 54 LNK6769 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable39 54 LNK6779 V PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable43 59 LNK6667 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable43 59 LNK6767 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable43 59 LNK6777 K PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable45 59 LNK6665 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6665 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable45 59 LNK6765 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6765 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable45 59 LNK6775 E PSR ± 5 N/A N/A < 30 1.30 Multimode Y Latch / Auto-Restart LNK6775 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable48 68 LNK6668 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable48 68 LNK6768 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable48 68 LNK6778 K PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable56 77 LNK6669 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable56 77 LNK6769 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable56 77 LNK6779 K PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable68 88 LNK6666 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6666 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable68 88 LNK6766 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6766 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable68 88 LNK6776 E PSR ± 5 N/A N/A < 30 1.95 Multimode Y Latch / Auto-Restart LNK6776 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable90 117 LNK6667 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6667 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable90 117 LNK6767 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6767 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable90 117 LNK6777 E PSR ± 5 N/A N/A < 30 2.60 Multimode Y Latch / Auto-Restart LNK6777 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable104 135 LNK6668 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6668 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable104 135 LNK6768 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6768 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable104 135 LNK6778 E PSR ± 5 N/A N/A < 30 3.00 Multimode Y Latch / Auto-Restart LNK6778 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable118 153 LNK6669 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6669 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable118 153 LNK6769 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6769 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable118 153 LNK6779 E PSR ± 5 N/A N/A < 30 3.40 Multimode Y Latch / Auto-Restart LNK6779 Latch / Auto-Restart Y Y Y N 15 N 132 N N/A Y Programmable


3332


Open FramePower


Open FramePeak Power

85-265 VAC / 230 VAC (W)


CV Accuracy

(best)(%)


CC Accuracy

(best) (%)



(mW)

Typical Current

Limit (A)

ON/OFF, PWM,

Multimode

Output Power

Limiting

Output OVP Device


Protection



Line Ripple

Rejection

Soft Start(ms)

I2f Trimming


(kHz)

On-Time Extension


Short-Circuit(%)

Fast AC Reset

Integrated Latching

Shutdown

5 8.5 TNY284 P, D, K Opto External Remote Sense External < 30 0.25 ON/OFF Y Latch TNY284 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y5 8.5 TNY274 P, G Opto External Remote Sense External < 50 0.25 ON/OFF Y Latch TNY274 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y6 11.5 TNY285 P, D Opto External Remote Sense External < 30 0.275 ON/OFF Y Latch TNY285 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y6 11.5 TNY275 P, G Opto External Remote Sense External < 50 0.275 ON/OFF Y Latch TNY275 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 15 TNY286 P, D Opto External Remote Sense External < 30 0.35 ON/OFF Y Latch TNY286 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 15 TNY276 P, G Opto External Remote Sense External < 50 0.35 ON/OFF Y Latch TNY276 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y7 18 TNY287 D Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

7.5 11.5 TNY285 K Opto External Remote Sense External < 30 0.275 ON/OFF Y Latch TNY285 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y8 18 TNY287 P Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y8 18 TNY277 P, G Opto External Remote Sense External < 50 0.45 ON/OFF Y Latch TNY277 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y9 19 TNY288 D Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

9.5 15 TNY286 K Opto External Remote Sense External < 30 0.35 ON/OFF Y Latch TNY286 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y10 21.5 TNY288 P Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y10 21.5 TNY278 P, G Opto External Remote Sense External < 50 0.55 ON/OFF Y Latch TNY278 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y11 18 TNY287 K Opto External Remote Sense External < 30 0.45 ON/OFF Y Latch TNY287 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y12 25 TNY289 P Opto External Remote Sense External < 30 0.65 ON/OFF Y Latch TNY289 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y12 25 TNY279 P, G Opto External Remote Sense External < 50 0.65 ON/OFF Y Latch TNY279 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y14 28.5 TNY290 P Opto External Remote Sense External < 30 0.75 ON/OFF Y Latch TNY290 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y14 28.5 TNY280 P, G Opto External Remote Sense External < 50 0.75 ON/OFF Y Latch TNY280 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y

14.5 21.5 TNY288 K Opto External Remote Sense External < 30 0.55 ON/OFF Y Latch TNY288 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y17 25 TNY289 K Opto External Remote Sense External < 30 0.65 ON/OFF Y Latch TNY289 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y20 28.5 TNY290 K Opto External Remote Sense External < 30 0.75 ON/OFF Y Latch TNY290 Auto-Restart Y Y N Inherent N/A Y 132 Y 3 N Y


34

Design Examples

HiperLCS – LLC High-Voltage DC-DC Resonant Converter (DER-270)125 W, 24 V, 4 A, and 12 V, 2.4 A, 380 VDC INPUT POWER SUPPLY

Hip

erLC

SU

1LC

S701

HG

HB

VR

EF

DT/

BF

IS

FB

VC

C

VC

CH

OV

/UV

G

R62.

2 Ω

D1

UF4

005

R14

3.3

kΩ

R13

442

kΩ1%

C17

2.2

nF

R11

27 Ω

R12

220 Ω

U2A

LTV8

17A

D2-

D3

SL44

D4

STPS

30L6

0CT

U2B

LTV8

17A

12

V

24

V

RTN

R10

6.81

kΩ

1%

R54.

7 Ω

R18

10 kΩ

1%

R17

22 kΩ

C23

330 µF

16 V

C16

680 µF

16 V

C14

10 µ

F35

V

C922

nF

630

V

C15

10 µ

F35

V

L115

0 nH

L215

0 nH

C833

0 nF

50 V

C44.

7 nF

200

V

C25

33 n

F20

0 V

R21

1.2

kΩ

R24

1.5

kΩ

R23

4.7

kΩ

R22

130

kΩ1%

R851

.1 kΩ

1%

R95.

76 kΩ

1%

1 6

7

T1EF

D35

/35 12 9,10 11 8

C24.

7 nF

200

V

C1 1 µF

25 V

C6 1 µF

25 V

C54.

7 nF

200

V

C24

47 µ

F35

VC3

220

nF50

V

D5

BAV1

9WS

C7 1 nF

200

V

C12

47 p

F1

kV

C11

6.2

nF1.

6 kV

C13

2.2

nF25

0 VA

C

U3

LM43

1AI

M3D

R2%

VR1

ZMM

5243

B-7

13 V

C10

1 µF

50 V

R15

1 kΩ

R20

47.5

kΩ

1%

R420

kΩ

1%

R1

976

kΩ1% R2

976

kΩ1% R3

976

kΩ1%

S1/S

2

D

38

0 V

PI-6

542a

-012

716

VC

C

+1

2 V

CO

NTR

OL

B+ B-

Inpu

t lin

e se

nsin

gU

VLO

pro

tect

ion

Hig

hly

inte

grat

ed L

LC r

eson

ant

conv

erte

r an

d po

wer

MO

SFET

sH

igh

switc

hing

fre

quen

cy r

educ

esm

agne

tics

size

and

cos

t

Ou

tpu

t R

ecti

fier

Very

tig

ht s

ymm

etry

and

du

ty c

ycle

ena

blin

g 60

VSc

hott

ky a

t 24

V o

utpu

tPo

st f

ilter

and

dam

ping

net

wor

k

TL43

1 re

fere

nce

circ

uit

Soft

fin

ish

capa

cito

rEM

I fil

ter

Smal

ler

valu

ere

sona

nt c

apac

itor

Cu

rren

t Se

nse

Cir

cuit

Sim

ple,

fast

(1-

cycl

e) n

o pe

akde

tect

or o

r re

ctifi

er n

eede

d

Feed

back

Cir

cuit

Prog

ram

mab

le F

MAX

, FM

IN, F

STAR

T,

F BU

RST

and

dea

d-tim

e

V CC

inpu

tne

twor

k

Mai

n ou

tput

cera

mic

cap

acito

rs

Activ

e lo

adZe

ner

Boot

str

ap

Hig

h-vo

ltage

by

pass

cap

acito

r

35

Design Examples

HiperLCS – LLC DC-DC Resonant Converter with PFC Front End (RDK-382)150 W, 43 V, 3.5 A, 90 – 265 VAC INPUT LED STREET LIGHT POWER SUPPLY

B+

B-

S

CPG

T

FB VC

C

PG

KD

RG

V CO

NT

RO

L

Hip

erPFS

-2U

1P

FS7326H

PI-7115-082113

N E 90 - 265V

AC

LR

T12.5 Ω

D7

BA

V19W

S

C17

2.2 µF25 V

C16

47 µF50 V

C9

470 nF450 V

C10

22 nF50 V

R13

49.9 kΩ1%

R14

100 kΩ1%

R21

6.2 kΩ1%

C11

1 nF200 V

D6

BA

V19W

S

VR2ZMM5242B-7

12 VQ

2M

MB

T4401LT1GQ

1IR

FRC

20TRP

BF

R20

39 kΩ

R22

487 kΩ1%

R1

4.7 Ω2 W

BR

1G

BU

8J600 V

L19 m

HC

2220 nF275 V

21

43

C1

470 nF275 VA

C

F15 A

RV

1320 VA

C

tO

L4

15

0 µH

C19

2.2 µF25 V

C15

47 nF200 V

R24

3 kΩ1%

R17

1.5 MΩ

1%

R10

1.5 MΩ

1%

R11

1.5 MΩ

1%

R12

1 MΩ

1%

R18

787 kΩ1%

R4

680 kΩ1% R

3680 kΩ

1% R2

680 kΩ1%

R19

1.6 MΩ

1%

D1

BA

V19W

S

D3

BA

V19W

S

D4

BA

V19W

SD

5B

AV

19WS

R5

1.3 MΩ

R6

1.3 MΩ

R7

1.3 MΩ

R8

7.5 kΩ1 WR

97.5 kΩ

1 W

C18

22 nF50 V

D8BAS16HT1G

D2

1N5408-T

VR

3Z

MM

5248B-7

18 V

1121187

3

C5

1 µF100 V

R23

60.4 kΩ1%

C20

47 nF50 V

R15

4.7 kΩR

164.7 kΩ

C12

3.3 µF25 V

C8

1 µF100 V

VC

CP

VC

CP

VC

CS

VC

CP

R

SR

ET

C4

100 nF50 V

C6

100 nF50 V

C3

100 nF50 V

C7

100 nF50 V

C13

22 nF630 V

C14

120 µF630 V

B-

HiperLC

SU

3LCS702H

G

HB

VR

EF

DT/B

F

IS

FB

VC

C

VC

CH

OV

/UV

G

R352.2 Ω

D9

UF4005

R4036 Ω

R39220 Ω

D11

DSSK20-015A

U4B

PC357A

43

V, 3

.5 A

J2-1

,2

RTN

J2-3

,4

DIM

R33

6.81 kΩ

R34

4.7 Ω

C36120 µF

C2947 nF

C354.7 µF

C39100 nF

U2LM431AIM3

Q4MMBT440LT1G

Q3MMBT440LT1G

C37100 nF

C414.7 nF

C40100 nF

C344.7 µF

L3300 nH

C28330 nF

C264.7 nF

C2233 nF

R321 kΩ

R36

4.7 kΩ

R371 kΩ

R38

127 kΩ

R3046.4 kΩ

R454.7 kΩ

R251 kΩ

D12BAV19WS

R4610 kΩ

R4310 kΩ VR11N

5259B-T

R47121 kΩ

R5524.9 kΩ

R5010 kΩ

R444.7 kΩ

R5424.9 kΩ

R530.1 Ω R51

20 kΩ

D13

DL4002 R52

0.1 Ω

R49100 Ω

U5

LM321

13

54

2

R48100 Ω

U4A

PC357A

R315.76 kΩ

R411 Ω

R421 Ω

35

T1170 W

6,7

81

C251 µF

C3222 nF

C234.7 nF

C241 µF

C21330 nF

D10

BAV19WS

C271 nF

C3147 pF

C308.2 nF

C332.2 nF

R29

19.6 kΩ

R26

976 kΩ

R27

976 kΩ

R28

976 kΩ

S1/S2

D

VC

CP

R

PI-7114a-071515

B+

CO

NTR

OL

+

VC

CS

SR

ET

C3810 nF200 V

36

Design Examples

HiperLCS – LLC High-Voltage DC-DC Resonant Converter (RDR-239)150 W, 24 V, 6.25 A, 380 VDC INPUT POWER SUPPLY

Hip

erLC

SU

1LC

S702

HG

HB

VREF

DT/

BF

IS

FB

VCC

VCC

H

OV/

UV

G

R6

2.2 Ω

D1

UF4

005

R14

7.5

kΩ

R13

86.6

kΩ

1%

C19

3.3

nF20

0 V

C17

2.2

nF20

0 V

R11

24 Ω

R12

220 Ω

U2A

LTV8

17A

D2

STPS

30L6

0CT

U2B

LTV8

17A

24 V

RTN

R10

7.68

kΩ

1%

R5

4.7 Ω

R18

10 kΩ

1%

R23

47 Ω

R17

22 kΩC16

470 μ

F35

V

C15

10 μ

F35

V

C9

22 n

F63

0 V

C14

10 μ

F35

V

L115

0 nH

C8

330

nF50

V

C4

4.7

nF20

0 V

R20

1.2

kΩ

R21

4.7

kΩ

R19

143

kΩ1%

R8

36.5

kΩ

1%

R9

7.68

kΩ

1%

1FL

1

T1EE

L25.

4 FL2,

3

FL4

5

C2

4.7

nF20

0 V

C1

1 μ

F25

VC

54.

7 nF

200

V

C6

1 μ

F25

V

C20

47 μ

F35

V

C3

220

nF50

V

D3

1N41

48

C7

1 nF

200

V

C12

47 p

F1

kV

C11

6.2

nF1.

6 kV

C13

2.2

nF25

0 VA

C

U3

LM43

1AIM

3DR

2%

C10

330

nF50

V

R15

1 kΩR

161.

5 kΩ

R4

20 kΩ

1%

R1

976

kΩ1% R

297

6 kΩ

1% R3

976

kΩ1%

S1/S

2

D

380

V

PI-6

160-

0620

11

V CC

+12

V

CO

NTR

OL

B+ B-

37

Design Examples

HiperLCS – LLC High-Voltage DC-DC Resonant (DER-282)100 W, 24 V, 3 A, and 12 V, 2.32 A, 380 VDC INPUT POWER SUPPLY

Hip

erLC

SU

1LC

S700

HG

HB

VREF

DT/

BF

IS

FB

VCC

VCC

H

OV/

UV

G

R6

2.2 Ω

D1

UF4

005

R14

9.1

kΩ

R13

887

kΩ1%

C19

2.2

nF20

0 V C

1722

nF

R11

20 Ω

R12

220 Ω

U2A

LTV8

17A

D3

STPS

15L4

5CB-

TR

D2

STPS

15L6

0CB-

TR

U2B

LTV8

17A

12 V

RTN

R10

7.32

kΩ

1%

R5

4.7 Ω

R18

10 kΩ

1%

R21

10 kΩ

R17

470

kΩ

C23

220 μ

F16

V

C16

220 μ

F35

V

C15

10 μ

F35

V

C9

22 n

F63

0 V

C14

10 μ

F35

V

L253

6 nH

L153

6 nH

C8

330

nF50

V

C4

15 n

F50

V

R23

3.6

kΩ

R22

4.7

kΩ1/

8 W

R24

66.5

kΩ

1%

R8

31.6

kΩ

1%

R9

7.32

kΩ

1%

3 2

10

T2EF

D30

8 9 6 7 5C

24.

7 nF

200

V

C1

1 μ

F25

VC

61 μ

F25

V

C5

4.7

nF50

V

C25

220 μ

F16

V

C3

470

nF10

0 V

D4

1N41

48

C7

1 nF

50 V

C12

47 p

F1

kV

C26

3.3

nF1.

6 kV

C13

2.2

nF25

0 VA

C

U3

LM43

1AI

M3D

R2%

C24

10 μ

F50

V

D5

1N41

48

R15

1 kΩ

R20

42.2

kΩ

1%

R16

1 kΩ

R4

20 kΩ

1%

R1

976

kΩ1% R

297

6 kΩ

1% R3

976

kΩ1%

S1/S

2

D

385

V

PI-6

504-

0824

11

V CC

+12

V

24 V

CO

NTR

OL

B+ B-

C18

2.2

nF

38

HD

14 -

25

V

VR4MMSZ5243BT1G

13 V

D7

STP

S30

L60C

T

D6STPS30L60CT

D9

UF4

005

L141

µH

C4

47 n

F50

V

C5

47 n

F50

V

C10

1500

µF

16 V

C24

1500

µF

16 V

R21

3.3

kΩ

R28

100 Ω

R30

1 kΩ

R34

19.1

kΩ

1% R31

4.99

kΩ

1%

U7

LM43

1U5

LM43

1

R33

1 kΩ

R32

10 kΩS

W1

Rem

ote

ON

/OFF

U3A

PC

357A

R24

3.92

kΩ

1%

R15

1 kΩ

R38

1 kΩ

U1A

PC

357A

R9

15 kΩ

1%

R10

220 Ω

C9

1 nF

100

V

D8

UF4

005

C19

1 nF

200

V

C20

330 µF

35 V

C1

120 µF

450

V

R26

200 Ω C

1710

00 µ

F16

V

C21

2.2

nF25

0 VA

C

U2A

PC

357A

C16

330

nF50

V

C15

330 µF

25 V

C13

470

pF

100

V

U2B

PC

357A

U1B

PC

357A

R25

232

kΩ1%

R27

232

kΩ1% R

394.

7 kΩ

D10

BA

V19

WS

+38

0 V

DC

J3-1

12 V

Bia

s

J4-1 B-

J3-3

B-

J4-2

R14

1 kΩ

C3

100

nF50

V

D3

1N40

07

R5

4.7 Ω

1/2

W

R1

2.2 Ω

1 W

F13.

5 A

D13

1N40

05

R20

4.7

kΩ

R16

7.5

kΩ

R35

1.33

MΩ

1%R13

1.33

MΩ

1%R12

1.33

MΩ

1%

R23

619 Ω

1%

R22

4.7

kΩ

U3B

PC

357A

R6

100 Ω

1/2

W

VR3P6KE150A

R18

1.33

MΩ

1% R19

1.33

M1%

R36

1.33

MΩ

1%

Hip

erT

FS-2

U6

TFS

7703

HD

41N

4007

D12

UF4

003

D16

SB

3100

2 1

34 6

9,10

7,8,

9

10,1

1,12

5

HS

+38

0 V

DC

RT

N

J5-3

,4

RT

N

J2-2

FB

EN

T1 EF2

5

T2E

E16

D

GS

56

VD

DH

13

R L

FB BP

EN7 9 10 11 8

DS

B

16 14 1 3

PI-

6999

-110

513

C12

10 µ

F16

V

6,7

CO

NT

RO

L

+12

V

Mai

nJ5

-1,2

+12

V

Sta

ndb

yJ2

-1

R37

2.2 Ω

1 WC22

3.3

nF10

0 V

L22.

2 µH

R7

2.2 Ω

1/2

W

C18

1 nF

200

V

C2

2.2

nF1

kV

C8

47 n

F50

V

R11

39 kΩ

Q1

MM

BT4

401

C6

100

nF50

V

Design Examples

HiperTFS-2 – Two-Switch Forward and Flyback Standby Power Supply (DER-368)190 W CONTINUOUS, 280 W PEAK, 12 V, 15 A AND 12 V, 0.83 A, 300 – 420 VAC INPUT POWER SUPPLY

39

HiperPFS-2 – Boost PFC Front End Power Supply (DER-294)350 W, 385 V, 0.91 A, 90 – 264 VAC INPUT PFC POWER SUPPLY

Design Examples

L536

0 µH

VO

DC

OU

T+ VO

S

C PG

T

FBVC

C

PGK

D

RG

VCO

NTR

OL

Hip

erP

FS-2

U1

PFS7

328H

PI-6

971-

0309

16

N Rem

ote

ON

EL

R122

0 kΩ

RT1

2.5 Ω

R10

1 Ω

1%

R516

kΩ

R6 3 kΩ D2

D1

S1AB

R410

kΩ

D4

BAV1

6

C647

µF

50 V

C5 1 µF

450

V

C7 22 n

F50

V

R14

24.9

kΩ

1%

R15

100

kΩ1%

R16

7.5

kΩ1%

R17

487

kΩ

C847

0 pF

50 V

D5

S1AB

VR1

1N47

43A

13 V

Q1

MM

BT44

03

3 4

21

U3

LTV81

7A

Q2

MM

BT44

01LT

1G

R11

1 Ω

1%

R12

2.2

kΩ1%

R222

0 kΩ

R3 10 Ω

2 W

1%

L1Fe

rrite

Bea

d

BR1

GBU

8K-B

P80

0 V

L29

mH

C222

0 nF

275

V

C468

0 pF

250

VAC

C368

0 pF

250

VAC

C168

0 nF

275

VAC

F1 6.3

A

RV1

320

VAC

Aux

iliar

yP

ower

Supp

ly

tO

D1

CA

PZ

ero

U2

CAP0

05D

G

D2

L322

0 µH

+

+C1

22.

2 µF

25 V

C13

270 µF

450

V

C14

47 n

F20

0 V

R21

60.4

kΩ

1%R18

1.5

MΩ

1%R7

1.5

MΩ

1% R81.

5 MΩ

1% R9 1 MΩ

1%

R19

787

kΩ

R20

1.6

MΩ

1%

C10

10 n

F1

kV

C11

22 n

F25

VD6

BAV1

16

D3

1N54

08-T

C93.

3 µF

25 V

R22

3 kΩ C1

547

nF

25 V

Ultr

a-lo

w r

ever

sere

cove

ry Q

spee

d D

iode

Inpu

t lin

e se

nse

(bro

wn-

in a

nd

brow

n-ou

t pr

otec

tion)

Spre

ad s

pect

rum

var

iabl

e sw

itchi

ngfr

eque

ncy

over

line

cyc

le r

educ

es E

MI

Driv

e fr

om e

xter

nal

bias

sup

ply

CAPZ

ero

elim

inat

es

pow

er lo

st f

rom

X c

apac

itor

disc

harg

e re

sist

ors

Hip

erPF

S-2

inte

grat

ed P

FC c

ontr

olle

r pl

usM

OSF

ET a

nd lo

ssle

ss c

urre

nt s

ensi

ng

DC

volta

ge s

ense

,lo

op c

ompe

nsat

ion

and

OV/

UV

prot

ectio

n

POW

ER G

OO

D p

inge

nera

tes

a co

ntro

lsy

nchr

oniz

atio

n si

gnal

whe

n ou

tput

vol

tage

isw

ithin

reg

ulat

ion

40

HiperPFS-3 – Boost PFC Front End Power Supply (DER-394)275 W, 385 V, 0.71 A, 90 – 264 VAC INPUT PFC POWER SUPPLY

Design Examples

L140

0 µH

VO

J3-1

J2-2

J4-1

J4-2

RL1

J2-1

DC

OU

T+ VO

J3-3

S

C PG

T

FBVC

C

PG

KD

REF

GVC

ON

TRO

L

Hip

erP

FS-3

U1

PFS7

527H

PI-725

7a-061

915

N

Po

wer

Go

od

90

- 2

64

VA

C

EL

R1

510

kΩ

R6

1 Ω

1%

R3

10 kΩ

1%

R4

16.2

kΩ

1%

R5

3.01

kΩ

1% D1

S1AB

-13-

F

C847

µF

50 V

C768

0 nF

450

V

C9 1 µF

35 V

C10

1 µF

50 V

R14

30.1

kΩ

1% 1/8

W

R15

332

kΩ1% 1/8

W

C11

470

pF50

VH

S1

D3S1AB-13-F

VR1BZX384-B13,115

13 V

Q1

MM

BT44

03

3 4

21

U3

LTV81

7A

Q2

MM

BT44

01LT

1G

R7

1 Ω

1%

R8

2.21

kΩ

1% 1/8

W

R2

510

kΩ

C268

0 pF

250

VAC

BR1

GBU

8K-B

P80

0 V

L29

mH

C433

0 nF

275

V

C668

0 pF

250

VAC

C568

0 pF

250

VAC

C168

0 pF

250

VAC

F1 5 A

RV1

320

VAC

VC

CSu

pply

C333

0 nF

275

VAC

RT1

2.5 Ω

D1

CA

PZ

ero

U2

CAP0

03D

G

D2

L333

0 µH

+

+C1

41

nF50

V

C17

180 µF

450

V

R19

162

kΩ1% 1/8

W

R16

3.74

MΩ

1%R10

6.2

MΩ

1% R11

6.2

MΩ

1% R12

3.74

MΩ

1% R13

162

kΩ1% 1/8

W

R17

6.2

MΩ

1% R18

6.2

MΩ

1%

C15

10 n

F1

kV

C13

1 µF

50 V

D2

1N54

08-T

C12

100

nF25

V

C16

470

pF50

V

tO

41

TOPSwitch-JX – LCD Monitor (DER-187)35 W, 13 V, 2.69 A, 90 – 264 VAC INPUT FLYBACK POWER SUPPLY

D

S X F

C

V

CONTROL

PI-6233-030916

R1033 Ω

R433 Ω1/8 WR3

3.9 MΩ1/2 W

R9100 Ω

R1210 kΩ

R1410 kΩ1%

R1342.2 kΩ

1%

R111.2 kΩ

U3TL4312%

VR21N5255B

28 V

D5FR106

R520 Ω

R810 Ω1/8 W

R715.4 kΩ

1%

R2100 kΩ1/2 W

R133 Ω

U2BLTV817A

U2ALTV817A

L19 mH

L33.3 µH

L2(3.5 × 7.6 mm)

U1TOP267EG

C947 µF16 V

C1, C2220 pF

250 VAC

C1647 nF50 V

C1022 µF50 V

C51 nF100 V

D6BAV20

D7, D8SB580

C8100 nF50 V

D11N4937

D21N4007

D31N4937

D41N4007

C13680 µF25 V

C14680 µF25 V

C15330 µF25 V

C12470 pF100 V

1

3

2

NC

T1EF25

9,10

7,8

5

4C4100 µF400 V

C62.2 nF1 kV

C72.2 nF

250 VAC

C3100 nF

275 VAC

RT110 Ω

F13.15 A

TOPSwitch-JX

L

E

N

13 V, 2.69 A

RTN

tO

90 - 264VAC

R64.7 Ω

C1122 pF1 kV

725 V MOSFET technology allowshigher transformer turns ratio enablinglower diode voltage rating; reduces circuit cost, improves efficiency

Output overvoltage protection (OVP).Resistor (R5) sets latching or hysteretic shutdown

– Internal high-voltage current source eliminates start-up circuitry– Internal current sense circuit eliminates sense resistor

– Tight I2f tolerance minimizes the size of the transformer and output diodes and reduces overload to rated power ratio

132 kHz switching frequency forgreatly reduced transformer costFrequency jittering simplifies

EMI filter design, reducingdevelopment time andcomponent cost

Line undervoltage/overvoltage(UV/OV) detection, dual-slope line feed-forward for output ripplereduction

TOPSwitch-JX– Accurate thermal shutdown with large hyteresis provides complete system-level protection

– DIP-8 package with 2 Ω MOSFET and optimized pinout eliminates heat sink– Auto-restart limits available power to <3% of maximum power in short-circuit and open-loop fault conditions

Design Examples

42

TOPSwitch-JX – Low Profile DC-DC Flyback Converter (DER-299)100 W, 24 V, 3 A and 12 V, 2.34 A, 380 VDC INPUT POWER SUPPLY

Design Examples

D

S

C

V

FX

CONTROL

PI-6676-080315

R811.3 kΩ

1%

R51 kΩ

R7510 Ω

R61 kΩ1%

D4BAV21

U1ALTV817A

U1BLTV817A

R92.2 Ω

VR1P6KE200A

D3FR106

D51N4148

VR21N5255B-T

28 V

R156.8 Ω

R164.7 Ω

C1547 µF16 V

C31000 µF

35 V

C6220 µF35 V

C4820 µF25 V

C5220 µF35 V

C7330 nF50 V

C982 µF450 V

L11 µH

L21 µH

C1322 µF50 V

C142.2 nF

250 VAC

R1030 Ω1 W

R141.80 MΩ

1%

R134.7 MΩ

R124.70 MΩ

1%

R1112.7 kΩ

1%

C12100 nF50 V

D1DSSK20-015A

R4215 kΩ

1%

R378.7 kΩ

1%

T1PQ38

FL1

2

C8100 nF50 V

U2LM431AIM3/NOPB

2%

C112.2 nF1 kV

24 V, 3 A

J1-5

300 - 420VDC

12 V, 2.34 A

J1-1

RTN

J1-4

1 6

3 5

4

TP1

TP2

U3TOP270VG

TOPSwitch-JX

FL2

R1730 Ω2 W

R130 Ω2 W

C21 nF200 V

D2STPS30100ST

R230 Ω

R1830 Ω

C1470 pF100 V

43

PI-6844-120312

C182.2 nF

250 VAC

VR1BZG03C130

130 V

L410 mH

BR2DF206ST-G

600 V

C268 µF400 V

D2BAV21WS-

7-F

T1RM8D1

DL4937

C622 µF16 V

C8100 pF50 V

C2310 pF50 VC20

4.7 nF50 V

C310 nF630 V

C121000 µF

16 V

C13680 pF100 V

D8STPS30100ST

C5470 nF50 V

7

FL2

FL19

6 8

C14150 nF

275 VAC

R293.3 MΩ

R303.3 MΩ

F12 A

90 - 265VAC

12 V, 2.5 A

J3

RTN

J4

J1 J2

LinkSwitch-HP

D

S

FB

BP

CPPD

CONTROLU1

LNK6766E

C2210 µF16 V

L5100 µH

R1941.2 kΩ

1%

R823.2 kΩ

1%1/8 W

R7100 kΩ1/8 W

R94.3 kΩ

1%1/8 W

R1320 Ω1/8 W

R2100 Ω1/2 W

R33 kΩ R28

27 kΩ

R2010.2 kΩ

1%

C7100 nF25 V

LinkSwitch-HP – High-Efficiency, Universal Input Power Supply (RDK-313)30 W, 12 V, 2.5 A, 90 – 265 VAC INPUT POWER SUPPLY

Design Examples

44

D

S

EN/UV

BP/M

90 - 295VAC

5 V, 4 A

RTN

PI-6559-021015

R122 MΩ

R132 MΩ

R151.5 MΩ1/8 W

C910 µF16 V

C112.2 µF50 V

R143.3 kΩ1/8 W

R81 kΩ1/8 W

R710 kΩ1%

R28.2 Ω

R34.7 Ω1/2 W

R947 Ω

R430 kΩ1/8 W

R610 kΩ1%

R122 Ω1/2 W

D1UF4006-E3

D31N4937

U2TL431

VR21N5254

27 V

VR1P6KE150A

TinySwitch-4U1

TNY290PG

U3PC817

In a PC standby application input stagewill be part of main power supply input

D4STPS30L60CT

RT16 Ω

F15 A

C32.2 nF1 kVBR1

2KBP10M1000 V

C268 µF450 V

C4100 µF50 V

C81000 µF

10 V

L110 mH

L22.2 µH

C51.5 nF100 V

C6, C71500 µF

10 V

C1047 nF100 V

C132.2 nF

250 VAC

1 9,10

7,8

T1EE22

4

53

C1100 nF

275 VACC16

100 nF100 V

TinySwitch-4 – Low Cost, High-Efficiency, Flyback Power Supply (RDK-295)20 W, 5 V, 4 A, 90 – 295 VAC FLYBACK POWER SUPPLY

Design Examples

45

TinySwitch-III – Constant Voltage Input Adapter (RDK-91)12 W, 12 V, 1 A, 85 – 265 VAC INPUT POWER SUPPLY

Typically 2% to 5%higher efficiencythan RCC

Single resistor UV lockoutprevents output glitchesduring power-up/down

On-time extension maximizeshold-up time

Optional TinySwitch-IIIbias resistor reduces no-load consumption below 50 mW

Tight I2f parametermaximizes power delivery andminimizes overload power

132 kHz operation optomizes core size

On-time extensionincreases hold-uptime

Tight parametric tolerances and auto-restart minimize diode size

ON/OFF control eliminates compensation components and allows accurate output with low-cost Zener reference

Self-powered from drain,no bias winding needed

Single capacitor selectscurrent limit, provides designflexibility

Modulated feedback threshold preventsgroup pulsing, reduces output ripple

Simple latching output OV shutdown removes or reduces rated power of secondary components

Built-in frequency jitterallows simple EMI filter

TinySwitch-IIIU1

TNY278PN

PI-4286-030916

85 - 265VAC

*Optional components

T1EE25

+12 V, 1 A

RTN

Design Examples

46

RD

RReference Design Report (RDR)

Reference Design Reports contain a power supply reference design specification, schematic, bill of materials, transformer documentation, and PCB layout. Performance data and typical operating characteristics are included. The design has been put into production for use in our Reference Design Kits (RDKs).

DIDesign Idea (DI) Design Ideas are concise two-page documents describing a design for a specific application. Key design points are highlighted.

DERDesign Example

Report (DER)

Design Example Reports contain a power supply design specification, schematic, bill of materials, transformer documentation, and PCB layout. This design has been built and bench-tested to provide performance data and typical operation characteristics.

Reference Designs

Application Product Family

AC Input Voltage(V)

Output Voltage(V)

Output Power(W) Topology Documents DAK/

RDK

All in One PC HiperPFS-3 + LinkSwitch-HP 90-264 20 150 PFC +

Flyback DER-437

Appliance

TinySwitch-III 165-265 9 9 Flyback DI-177

TinySwitch-III 200-400 12 / 15 20 Flyback DI-176

TinySwitch-III 85-265 -5 / -12 13 (7.2 PK) Flyback DI-122

General Purpose

HiperPFS 180-264 30 900 PFC Boost DER-274

HiperLCS 300-420 (DC) 24 150 LLC

TOPSwitch-JX 85-264 12 30 Flyback RDR-242 RDK-242

TinySwitch-III 85-265 12 15 Flyback DER-228

TinySwitch-III 85-265 12 12 Flyback DI-91, RDR-91

Industrial Controls TinySwitch-III 18-30 5 1.25 Flyback DI-153

LCD Monitor

LinkSwitch-HP 90-265 12 30 Flyback RDR-313 RDK-313

LinkSwitch-HP 90-265 5 / 18 17 Flyback RDR-321 RDK-321

TOPSwitch-JX 90-264 5 / 16 36.3 Flyback DER-259

TOPSwitch-JX 90-265 5 / 14.5 27 Flyback DER-235

LCD TV

HiperPFS 90-264 380 100 PFC Boost DER-272

TOPSwitch-JX 300-420 (DC) 380 100 Flyback DER-299

HiperLCS 300-420 (DC) 12 / 24 125 LLC DER-270

HiperLCS 300-420 (DC) 12 / 24 100 LLC DER-282

HiperPLC / TinySwitch-III 85-265 24, 12, 5, 5 225 (285) PFC + LLC RDR-189

HiperPFS-3 +LinkSwitch-HP 90-264 12 / 24 100 PFC +

Flyback DER-393

47

Reference Designs

Application Product Family

AC Input Voltage(V)

Output Voltage(V)

Output Power(W) Topology Documents DAK/

RDK

LED Driver

HiperLCS 90-265 43 150 LLC RDR-382 RDK-382

HiperLCS 90-265 48 150 PFC + LLC RDR-292

HiperPLC 140-265 48 150 PFC + LLC Half-bridge DER-212

TinySwitch-III 195-265 20 14 Flyback DER-173, DI-173

TinySwitch-III 185-265 10 (1.8 A) 18 Flyback DI-130

Notebook Adapter TOPSwitch-JX 90-265 19 65 Flyback DER-243

PC Main

HiperTFS-2 300-420 12 190Two-Switch Forward +

FlybackDER-368

HiperPFS-2 90-264 385 350 PFC Boost DER-294

HiperPFS-3 90-264 385 275 PFC Boost DER-394

HiperPFS 90-264 380 180 PFC Boost RDR-248

HiperTFS 300-385 5 / 12 300Two-Switch Forward +

FlybackRDR-249

HiperTFS-2 + HiperPFS-3 90-264 5 / 61 300

Two-Switch Forward +

FlybackDER-484

HiperPFS 90-264 380 347 PFC Boost RDR-236

PC Standby

TOPSwitch-JX 110-400 12 30 Flyback DER-275

TinySwitch-4 90-295 5 20 Flyback RDR-295 RDK-295

CAPZero 85-264 N/A N/A N/A RDR-252 RDK-252

TOPSwitch-JX 110-400 5 20 Flyback DER-247

TOPSwtich-JX 110-400 12 30 Flyback DER-246

TinySwitch-III 85-295 / 110-420 (DC)

5 (4 A) / 15 (67 mA) 21 Flyback DER-114

©2016 Power Integrations. Power Integrations and the Power Integrations logo are registered trademarks of Power Integrations. All rights reserved.

World Headquarters5245 Hellyer AvenueSan Jose, CA 95138, USAMain: +1 408-414-9200Customer Service Phone: +1-408-414-9665Fax: +1-408-414-9765Email: [email protected] [email protected]

On the Webwww.power.com

China (Shanghai)Rm 2410, Charity Plaza, No. 88North Caoxi RoadShanghai, PRC 200030Phone: +86-21-6354-6323Fax: +86-21-6354-6325Email: [email protected]

China (Shenzhen)17/F, Hivac Building, No. 2, Keji Nan 8th Road, Nanshan District, Shenzhen, China, 518057Phone: +86-755-8672-8689Fax: +86-755-8672-8690Email: [email protected]

GermanyLindwurmstrasse 11480337 MünchenGermanyPhone: +49-895-527-39110Fax: +49-895-527-39200Email: [email protected]

India (Bangalore)#1, 14th Main RoadVasanthanagarBangalore-560052 India Phone: +91-80-4113-8020Fax: +91-80-4113-8023Email: [email protected]

India (New Delhi)#45, Top FloorOkhla Industrial Area, Phase – IIINew Delhi 110020, India Phone: +91-11-4055-2351/53Fax: +91-80-4113-8023Email: [email protected]

India (Mumbai)Power Integrations India Private LimitedUnit: 106-107, Sagar Tech Plaza-BSakinaka, Andheri Kurla RoadMumbai - 400072, Maharashtra, India Phone: +91-22-4003-3600/3700Fax: +91-80-4113-8023Email: [email protected]

ItalyVia Milanese 20, 3rd. Fl. 20099 Sesto San Giovanni (MI) ItalyPhone: +39-024-550-8701Fax: +39-028-928-6009Email: [email protected]

JapanKosei Dai-3 Building2-12-11, Shin-Yokohama, Kohoku-kuYokohama-shi, Kanagawa 222-0033 JapanPhone: +81-45-471-1021Fax: +81-45-471-3717Email: [email protected]

KoreaRM 602, 6FLKorea City Air Terminal B/D, 159-6Samsung-Dong, Kangnam-GuSeoul, 135-728, KoreaPhone: +82-2-2016-6610Fax: +82-2-2016-6630Email: [email protected] Singapore 51 Newton Road#19-01/05 Goldhill PlazaSingapore, 308900Phone: +65-6358-2160Fax: +65-6358-2015Email: [email protected]

Taiwan5F, No. 318, Nei Hu Road, Sec. 1Taipei 11493, Taiwan R.O.C.Phone: +886-2-2659-4570Fax: +886-2-2659-4550Email: [email protected]

United KingdomCambridge Semiconductor,a Power Integrations companyWestbrook Centre, Building 5, Suite 21Milton RoadCambridge CB4 1YGPhone: +44 (0) 1223-446483Email: [email protected]

Worldwide Sales Support Locations

mailto:[email protected]

Product Selector Guide High-Power AC-DC Products · 2016. 3. 10. · 2 About Power Integrations...

Documents

Transcript of Product Selector Guide High-Power AC-DC Products · 2016. 3. 10. · 2 About Power Integrations...