Model Name - Acson International TM2012...Model Name Models : Indoor Outdoor Heatpump A5WMY10LR...
28
TECHNICAL SPECIFICATION TS-A5WMY-L_(i) Model Name Models : Indoor Outdoor Heatpump A5WMY10LR A5LCY10FR A5WMY15LR A5LCY15FR A5WMY20LR A5LCY20CR A5WMY25LR A5LCY25CR
Transcript of Model Name - Acson International TM2012...Model Name Models : Indoor Outdoor Heatpump A5WMY10LR...
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
Model Name Models : Indoor Outdoor
Heatpump
A5WMY10LR A5LCY10FR
A5WMY15LR A5LCY15FR
A5WMY20LR A5LCY20CR
A5WMY25LR A5LCY25CR
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
Content Page Nomenclature ---------------------------------------- 1
- Product Line-up
Application Information ---------------------------------------- 3 - Operating Range - Refrigeration Circuit
- Installation Guideline
Sound Data ---------------------------------------- 8
- Sound Pressure Level
Engineering and Physical Data ---------------------------------------- 9
Performance Data ---------------------------------------- 10
Outline & Dimension ---------------------------------------- 14
Wiring Diagram ---------------------------------------- 16
Troubleshooting ---------------------------------------- 16
Note: Installation and maintenance are to be performed only by qualified personnel who are familiar with local codes and regulation, and experienced with this type of equipment
Caution : Sharp edges and coil surfaces are a potential injury hazard. Avoid contact with them
Warning : Moving machinery and electrical power hazard may cause severe personnel injury or death. Disconnect and lock off power before servicing equipment
“Acson” is a registered trademark of Acson International. All rights reserved. © 2012 Acson International. All rights reserved throughout the world.
Bulletin illustrations cover the general appearance of Acson International products at the time of publication. We reserve the right to change design and construction specification at any time without notice
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
1
Nomenclature Indoor
A 5 WM Y 10 L R – A C B D D
Outdoor A 5 LC Y 10 F R – A C D O A
Brand A : Acson
Product Specification Variation D: Forth Issue
Refrigerant 5: R410A
Model R: Heatpump
Product Type WM: Wall Mounted Filtration
B: Bio Filter
Size 10 : 8700 - 9700 Btu/h 15 : 11,000 - 11,900 Btu/h 20: 18,600 - 19,176 Btu/h 25: 21,200 – 21,837 Btu/h
Product series L : L Series
Brand A: Acson
Refrigerant 5: R410A
Compressor BrandD: Daikin
Product Type LC: Single Split Condensing Unit
Product series C: C Series F: F Series
Electrical CharacteristicsA : 50Hz / 1Ph / 220-240V
Grille D: Grille D
Market RegionC: Export with CE mark
System Y: DC Inverter with Daikin Protocol
Size 10 : 8700 - 9700 Btu/h 15 : 11,000 - 11,900 Btu/h 20: 18,600 - 19,176 Btu/h 25: 21,200 – 21,837 Btu/h
System Y: DC Inverter with Daikin Protocol
Product Specification Variation A: First Issue
Specification O: Standard Unit
Market RegionC: Export with CE mark
Electrical CharacteristicsA : 50Hz / 1Ph / 220-240V
Model R: Heatpump
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
2
Product Line-Up Indoor Unit A5WMY
Outdoor Unit A5LCY
Model
Nom
encl
atur
e
Classification
PC
B
Han
dset
Air
Pur
ifica
tion
Mar
king
Others
W_2
_03C
W_2
_04A
GS
02
Bio
Filt
er
CE
Aut
o R
esta
rt
HE
ATP
UM
P 10LR ACBDD X X X X X
15LR ACBDD X X X X X
20LR ACBDD X X X X X
25LR ACBDD X X X X X
Model
Nom
encl
atur
e
Classification
PC
B
Fin
Ref
riger
ant C
ontro
l
Com
pres
sor
Mar
king
Oth
ers
2P25
7375
-1
S_2
_04A
Blu
e C
oate
d
Cap
. Tub
e
EXV
Swin
g
CE
HE
ATP
UM
P 10FR ACDOA X X X X X
15FR ACDOA X X X X X
20CR ACDOA X X X X X
25CR ACDOA X X X X X
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
3
Application Information Operating Range Ensure the operating temperature is in allowance range. Cooling
A5WMY 10/15LR – A5LCY 10/15FR A5WMY 20/25LR – A5LCY 20/25CR
Heating
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
4
Refrigerant Circuit Model: A5WMY 10/15LR – A5LCY 10/15FR
Part Number: 70014113878
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
5
Model: A5WMY 20/25LR – A5LCY 20/25CR
Part Number: 70034106462
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
6
Installation Guideline
Installation Diagram
Outdoor Clearance
Sharp edges and coil surfaces are potential injury hazard. Avoid from contact with them. Caution
If the condensing unit is operated in an atmosphere containing oils (including machine oils), salt (coastal area), sulphide gas (near hot spring, oil refinery plant), such as substances may lead to failure of the unit.
Caution
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
7
Cable Size
Model Unit A5WMY 10/15LR A5WMY 20/25LR Power supply cable size Number of wire
mm2 1.5 3
Interconnection cable size Number of wire
mm2 1.5 4
Recommended fuse A 15 20 Refrigerant Piping
When the piping length becomes too long, both the capacity and reliability drop. As the number of bend increases, system piping resistance to the refrigerant flow increases, thus lowering the cooling capacity, and as the result the compressor may become defective. Always choose the shortest path and follow the recommendation as tabulated below:
Additional Charge The refrigerant gas is charged in the outdoor unit and if the piping length is 7.5m, additional charge of the refrigerant after vacuuming is not necessary. When the piping length is more than 7.5m, additional charge (g) per additional 1m length as tabulated. R410A – Heatpump
Indoor A5WMY 10/15LR A5WMY 20LR Outdoor A5LCY 10/15FR A5LCY 20CR
Add. Charge, g/m 20
Model Indoor A5WMY 10/15LR A5WMY 20LR A5WMY 25LR Outdoor A5LCY 10/15FR A5LCY 20CR A5LCY 25CR
Min. Length, m 3 Max. Length, m 20 30
Max. Elevation, m 10 Liquid pipe, mm 6.4
Gas pipe,mm 9.5 12.7 15.88
Note: Installation and maintenance are to be performed only by qualified personnel who are familiar with local codes and regulations, and experienced with this type of equipment.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
8
Sound Data Sound Pressure Level
Model Speed 1/1 Octave Sound Pressure Level (dB) ref 20μPa Overall (dBA)
Noise Criteria125Hz 250Hz 500Hz 1kHz 2kHz 4kHz 8kHz
A5WMY 10LR
Turbo 43 39 37 37 33 26 13 41 36 High 42 38 37 36 32 24 12 40 35 Med 37 33 32 30 25 17 13 34 29 Low 32 29 28 24 19 14 13 29 22 Quiet 21 22 20 15 10 7 8 21 -
A5WMY 15LR
Turbo 41 39 38 38 36 29 15 42 37 High 40 38 38 37 34 27 14 41 36 Med 36 32 32 30 26 18 11 34 29 Low 33 29 29 25 21 15 11 30 23 Quiet 24 22 21 17 11 7 7 22 -
A5WMY 20LR
Turbo 39 41 40 40 37 29 16 44 39 High 35 37 37 36 32 25 12 40 35 Med 34 36 36 34 29 22 11 38 33 Low 30 34 33 31 26 18 10 35 30 Quiet 28 32 30 28 22 14 10 32 26
A5WMY 25LR
Turbo 42 44 43 42 40 35 20 46 41 High 39 41 40 38 36 31 16 43 37 Med 37 39 38 37 33 28 13 41 36 Low 33 36 35 33 28 22 11 37 32 Quiet 28 33 32 28 23 17 9 33 26
Model Measuring Location
A5WMY 10LR
A5WMY 15LR
A5WMY 20LR
A5WMY 25LR
Standard: JIS C 9612
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
9
Engineering & Physical Data
Engineering Data – R410A
A5WMY 10LR A5WMY 15LR A5WMY 20LR A5WMY 25LRA5LCY 10FR A5LCY 15FR A5LCY 20CR A5LCY 25CR
Btu/h 8700 11000 18600 21200W 2550 3230 5450 6210
Btu/h 9700 11900 19176 21837W 2840 3500 5620 6400W 730 970 1460 1880W 700 930 1500 1710A 4.06 4.68 6.53 8.45A 3.86 5.12 6.72 7.63
W/W 3.49 3.33 3.73 3.30W/W 4.06 3.76 3.75 3.74
kg 0.74 1.00 1.45 1.50V/Ph/Hz
l/s / CFM 178 / 378 185 / 392 273 / 578 322 / 703l/s / CFM 163 / 345 169 / 358 250 / 529 309 / 654l/s / CFM 128 / 272 133 / 282 222 / 471 276 / 585l/s / CFM 101 / 215 109 / 232 197 / 418 239 / 507l/s / CFM 86 / 182 86 /182 177 / 374 206 / 437
EXTERNAL STATIC PRESSURE (SH/H/M/L) Pa (in.wg.)dBA 41 / 40 / 34 / 29 / 21 42 / 41 / 34 / 30 / 22 44 / 40 / 38 / 35 / 32 46 / 43 / 41 / 37 / 33mmmmkg
mm
W 37 63A 39 65
0.320.33
W 18 18
mm
m2
pcCOLOURl/s / CFM 444 / 940 382 / 810
dBA 46 48mmmmkg 28 30
mmmm 12.70 15.87
W 32 35A 0.26 0.28W
cm3
W 661 893 1303 1697W 631 853 1341 1525A 3.61 4.19 5.68 7.36A 3.41 4.6 5.86 6.54A
mm
m2 0.33 0.321 2
COLOUR000452103F1010 000452103F1515 000452103CW2020 000452103CW2525
ALL UNITS ARE BEING TESTED AND COMPLY TO ISO 5151 (NON-DUCTED UNIT) OR ISO 13253 (DUCTED UNIT).
ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOTICE.
2
NA
0.62
23
INNER GROOVE COPPER
ALUMINIUM
550 x 658 x 289580 x 775 x 355
PROPELLERDIRECT
9.52
310 x 1065 x 224366 x 1136 x 285
1419
2WASHABLE SARANET FILTER
SEAMLESS INNER GROOVE COPPER7
ALUMINIUM
20E
0.29
220 - 240 / 1 / 50
0.19 0.21
40
0.56
CROSS FLOWDIRECT
BRUSHLESS
NOMINAL RUNNING CURRENT (HEATING)
MODEL INDOOR UNITOUTDOOR UNIT
0.18
RATED RUNNING CURRENT (COOLING) RATED RUNNING CURRENT (HEATING)
37 42
R410A
EERCOPREFRIGERANT CONTROL (EXPANSION DEVICE)REFRIGERANT CHARGEPOWER SOURCE
NOMINAL COOLING CAPACITY
NOMINAL HEATING CAPACITY
NOMINAL TOTAL INPUT POWER (COOLING)NOMINAL TOTAL INPUT POWER (HEATING)NOMINAL RUNNING CURRENT (COOLING)
HEIGHT X WIDTH X DEPTH
REFRIGERANT TYPE
IND
OO
R U
NIT
CONTROL AIR DISCHARGEOPERATION
HIGH MEDIUM
QUIET
UNIT WEIGHTCONDENSATE DRAIN SIZE
FAN TYPEDRIVE
FAN MOTOR
TYPEINDEX OF PROTECTION (IP)INSULATION GRADERATED INPUT POWER (COOLING)RATED INPUT POWER (HEATING)
MOTOR OUTPUTPOLES
COIL
TUBE MATERIALDIAMETER
FIN MATERIALFACE AREAROW
AIR QUALITY FILTER TYPEQUANTITY
CASING
OU
TDO
OR
UN
IT
AIR FLOWSOUND PRESSURE LEVELUNIT DIMENSION HEIGHT X WIDTH X DEPTHPACKING DIMENSION HEIGHT X WIDTH X DEPTHUNIT WEIGHT
PIPE CONNECTION
TYPE FLARE
SIZE LIQUIDGAS
793 x 990 x 415
FAN TYPEDRIVE
FAN MOTOR
TYPEINDEX OF PROTECTION (IP)INSULATION GRADERATED INPUT POWERRATED RUNNING CURRENTMOTOR OUTPUTPOLES
COMPRESSOR
TYPEOIL TYPEOIL AMOUNTRATED INPUT POWER (COOLING)RATED INPUT POWER (HEATING)RATED RUNNING CURRENT (COOLING) RATED RUNNING CURRENT (HEATING) LOCKED ROTOR AMP.
TUBE MATERIALDIAMETER
FIN MATERIALFACE AREAROW
6.35
OUTDOOR: 35°C DB / 24°C WB OUTDOOR: 8°C DB / 6°C WB
CASINGDRAWING NUMBER
COOLING HEATINGINDOOR: 27°C DB / 19°C WB INDOOR: 20°C DB
COIL
EXV
753 x 855 x 328
0
44 1 PHASE SCR
4 8
2
WIRELESS HANDSETNON DUCTED
TURBO
LOWAIR FLOW
288 x 800 x 206350 x 894 x 280
9
SOUND PRESSURE LEVEL (H/M/L)UNIT DIMENSION HEIGHT X WIDTH X DEPTHPACKING DIMENSION
238
375
DC BRUSHLESS
1200.53666
450
WHITE
7
LIGHT GREY
869 / 184251
49
DAPHNE FVC50KHERMETIC SWING
FE
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
10
Performance Data Model: A5WMY10LR – A5LCY10FR Cooling Mode
TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI21°C 2.40 1.99 0.55 2.32 1.94 0.60 2.23 1.89 0.65 2.14 1.84 0.70 1.97 1.71 0.76 1.82 1.61 0.8424°C 2.41 2.39 0.55 2.32 2.32 0.60 2.24 2.24 0.65 2.15 2.15 0.70 1.97 1.97 0.76 1.82 1.82 0.8427°C 2.43 2.43 0.56 2.34 2.34 0.60 2.26 2.26 0.65 2.18 2.18 0.71 2.01 2.01 0.77 1.87 1.87 0.8530°C 2.50 2.50 0.56 2.43 2.43 0.60 2.35 2.35 0.66 2.28 2.28 0.71 2.11 2.11 0.77 1.98 1.98 0.8524°C 2.65 1.86 0.56 2.56 1.81 0.61 2.46 1.77 0.66 2.37 1.72 0.72 2.17 1.60 0.78 2.01 1.51 0.8627°C 2.65 2.13 0.56 2.56 2.08 0.61 2.47 2.03 0.66 2.37 1.99 0.72 2.18 1.86 0.78 2.01 1.76 0.8630°C 2.66 2.63 0.56 2.57 2.57 0.61 2.47 2.47 0.66 2.38 2.38 0.72 2.19 2.19 0.78 2.03 2.03 0.8633°C 2.69 2.69 0.56 2.60 2.60 0.61 2.52 2.52 0.66 2.43 2.43 0.72 2.25 2.25 0.78 2.10 2.10 0.8627°C 2.92 1.82 0.57 2.82 1.78 0.62 2.71 1.73 0.67 2.61 1.69 0.73 2.40 1.57 0.79 2.22 1.48 0.8730°C 2.92 2.22 0.57 2.82 2.17 0.62 2.71 2.12 0.67 2.61 2.07 0.73 2.40 1.94 0.79 2.22 1.84 0.8733°C 2.92 2.59 0.57 2.82 2.54 0.62 2.72 2.49 0.67 2.61 2.44 0.73 2.40 2.29 0.79 2.23 2.18 0.8736°C 2.93 2.93 0.57 2.83 2.83 0.62 2.73 2.73 0.67 2.63 2.63 0.73 2.43 2.43 0.79 2.26 2.26 0.8821°C 2.50 2.08 0.56 2.41 2.03 0.61 2.32 1.97 0.66 2.22 1.92 0.71 2.04 1.79 0.77 1.88 1.68 0.8524°C 2.51 2.51 0.56 2.42 2.42 0.61 2.33 2.33 0.66 2.23 2.23 0.71 2.05 2.05 0.77 1.90 1.90 0.8527°C 2.54 2.54 0.56 2.45 2.45 0.61 2.37 2.37 0.66 2.28 2.28 0.71 2.11 2.11 0.78 1.96 1.96 0.8630°C 2.64 2.64 0.57 2.57 2.57 0.61 2.49 2.49 0.66 2.41 2.41 0.72 2.23 2.23 0.78 2.09 2.09 0.8624°C 2.76 1.97 0.57 2.66 1.92 0.62 2.56 1.87 0.67 2.45 1.82 0.72 2.25 1.69 0.78 2.08 1.60 0.8627°C 2.76 2.27 0.57 2.66 2.22 0.62 2.56 2.17 0.67 2.46 2.12 0.72 2.26 1.98 0.78 2.09 1.87 0.8630°C 2.77 2.77 0.57 2.68 2.68 0.62 2.58 2.58 0.67 2.48 2.48 0.72 2.29 2.29 0.79 2.12 2.12 0.8733°C 2.82 2.82 0.57 2.73 2.73 0.62 2.65 2.65 0.67 2.56 2.56 0.73 2.37 2.37 0.79 2.22 2.22 0.8727°C 3.03 1.93 0.58 2.92 1.88 0.63 2.81 1.83 0.68 2.70 1.79 0.74 2.48 1.67 0.80 2.30 1.57 0.8830°C 3.03 2.37 0.58 2.92 2.32 0.63 2.82 2.26 0.68 2.70 2.21 0.74 2.49 2.07 0.80 2.30 1.97 0.8833°C 3.04 2.77 0.58 2.93 2.72 0.63 2.82 2.66 0.68 2.71 2.61 0.74 2.50 2.45 0.80 2.31 2.31 0.8836°C 3.06 3.06 0.58 2.96 2.96 0.63 2.85 2.85 0.68 2.75 2.75 0.74 2.54 2.54 0.80 2.37 2.37 0.8921°C 2.59 2.17 0.56 2.50 2.12 0.61 2.40 2.06 0.66 2.30 2.00 0.72 2.11 1.87 0.78 1.95 1.76 0.8624°C 2.61 2.61 0.56 2.51 2.51 0.61 2.42 2.42 0.66 2.32 2.32 0.72 2.13 2.13 0.78 1.97 1.97 0.8627°C 2.65 2.65 0.57 2.56 2.56 0.61 2.48 2.48 0.66 2.39 2.39 0.72 2.21 2.21 0.78 2.06 2.06 0.8630°C 2.78 2.78 0.57 2.70 2.70 0.62 2.62 2.62 0.67 2.53 2.53 0.73 2.34 2.34 0.79 2.19 2.19 0.8724°C 2.86 2.08 0.57 2.75 2.03 0.62 2.65 1.98 0.67 2.54 1.93 0.73 2.33 1.80 0.79 2.15 1.69 0.8727°C 2.86 2.41 0.57 2.76 2.36 0.62 2.66 2.30 0.67 2.55 2.24 0.73 2.34 2.10 0.79 2.16 1.99 0.8730°C 2.89 2.89 0.58 2.79 2.79 0.62 2.69 2.69 0.67 2.58 2.58 0.73 2.38 2.38 0.79 2.21 2.21 0.8833°C 2.95 2.95 0.58 2.86 2.86 0.63 2.78 2.78 0.68 2.68 2.68 0.74 2.49 2.49 0.80 2.33 2.33 0.8827°C 3.13 2.04 0.58 3.02 1.99 0.63 2.91 1.94 0.69 2.79 1.89 0.74 2.56 1.77 0.81 2.37 1.67 0.8930°C 3.14 2.51 0.58 3.03 2.47 0.63 2.91 2.41 0.69 2.80 2.36 0.74 2.57 2.21 0.81 2.38 2.09 0.8933°C 3.15 2.94 0.59 3.04 2.89 0.63 2.93 2.83 0.69 2.81 2.77 0.75 2.59 2.59 0.81 2.40 2.40 0.8936°C 3.18 3.18 0.59 3.08 3.08 0.64 2.97 2.97 0.69 2.87 2.87 0.75 2.65 2.65 0.81 2.47 2.47 0.90
345
16°C
19°C
22°C
215
16°C
19°C
22°C
272
16°C
19°C
22°C
AFR (CFM) EWB EDB
Outdoor temperature19°C 25°C 30°C 35°C 40°C 46°C
Remark: Notes:AFR: Air flow rate (CFM) 1. Ratings shown are gross capacities which do not include a deduction for indoor fan motor heat.EWB: Entering Wet Bulb Temp. (⁰C) 2 shows nominal capacities.EDB: Entering Dry Bulb Temp. (⁰C) 3. Direct interpolation is permissible. Do not extrapolate.TC: Total Cooling Capacity (kW) 4. Unit is able to operate at ambient from 10 ⁰C to 46⁰C without pressure trip.SC: Sensible Cooling Capacity (kW)PI: Power Input
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
11
Model: A5WMY15LR – A5LCY15FR Cooling Mode
TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI21°C 3.04 2.21 0.74 2.94 2.15 0.80 2.83 2.10 0.86 2.71 2.04 0.94 2.49 1.89 1.02 2.30 1.78 1.1224°C 3.05 2.65 0.74 2.94 2.59 0.80 2.83 2.53 0.86 2.72 2.46 0.94 2.50 2.30 1.02 2.31 2.17 1.1227°C 3.07 3.00 0.74 2.97 2.93 0.80 2.87 2.86 0.87 2.76 2.76 0.94 2.54 2.54 1.02 2.37 2.37 1.1230°C 3.17 3.17 0.74 3.08 3.08 0.80 2.98 2.98 0.87 2.89 2.89 0.95 2.68 2.68 1.03 2.50 2.50 1.1324°C 3.36 2.06 0.75 3.24 2.01 0.81 3.12 1.96 0.88 3.00 1.90 0.95 2.76 1.77 1.03 2.55 1.67 1.1427°C 3.36 2.36 0.75 3.24 2.31 0.81 3.12 2.26 0.88 3.00 2.20 0.95 2.76 2.06 1.03 2.55 1.95 1.1430°C 3.37 2.91 0.75 3.25 2.85 0.81 3.13 2.79 0.88 3.02 2.72 0.95 2.78 2.55 1.03 2.58 2.41 1.1433°C 3.41 3.41 0.75 3.29 3.29 0.81 3.19 3.19 0.88 3.08 3.08 0.96 2.85 2.85 1.04 2.66 2.66 1.1527°C 3.69 2.02 0.76 3.57 1.97 0.83 3.44 1.92 0.90 3.30 1.87 0.97 3.04 1.74 1.05 2.81 1.64 1.1630°C 3.70 2.46 0.76 3.57 2.41 0.83 3.44 2.35 0.90 3.30 2.30 0.97 3.04 2.15 1.05 2.81 2.04 1.1633°C 3.70 2.88 0.76 3.57 2.82 0.83 3.44 2.76 0.90 3.31 2.71 0.97 3.04 2.54 1.05 2.82 2.41 1.1636°C 3.71 3.26 0.76 3.59 3.20 0.83 3.46 3.13 0.90 3.34 3.06 0.97 3.08 2.87 1.06 2.86 2.72 1.1621°C 3.17 2.31 0.74 3.05 2.25 0.80 2.94 2.19 0.87 2.82 2.13 0.94 2.59 1.98 1.02 2.39 1.86 1.1324°C 3.18 2.80 0.74 3.06 2.73 0.80 2.95 2.67 0.87 2.83 2.60 0.95 2.60 2.43 1.03 2.40 2.29 1.1327°C 3.22 3.18 0.75 3.11 3.11 0.81 3.00 3.00 0.87 2.89 2.89 0.95 2.67 2.67 1.03 2.49 2.49 1.1430°C 3.35 3.35 0.75 3.25 3.25 0.81 3.15 3.15 0.88 3.05 3.05 0.96 2.83 2.83 1.04 2.64 2.64 1.1524°C 3.49 2.18 0.76 3.37 2.13 0.82 3.24 2.07 0.89 3.11 2.01 0.96 2.86 1.88 1.04 2.64 1.77 1.1527°C 3.50 2.51 0.76 3.37 2.46 0.82 3.25 2.40 0.89 3.12 2.35 0.96 2.86 2.19 1.04 2.65 2.08 1.1530°C 3.51 3.10 0.76 3.39 3.03 0.82 3.27 2.97 0.89 3.14 2.89 0.96 2.90 2.71 1.05 2.69 2.56 1.1533°C 3.57 3.57 0.76 3.46 3.46 0.82 3.35 3.35 0.89 3.24 3.24 0.97 3.00 3.00 1.05 2.81 2.81 1.1627°C 3.84 2.14 0.77 3.70 2.09 0.83 3.56 2.03 0.90 3.42 1.98 0.98 3.14 1.85 1.06 2.91 1.74 1.1730°C 3.84 2.62 0.77 3.70 2.57 0.83 3.57 2.51 0.90 3.42 2.45 0.98 3.15 2.30 1.06 2.91 2.18 1.1733°C 3.85 3.07 0.77 3.71 3.01 0.83 3.58 2.95 0.90 3.44 2.89 0.98 3.16 2.71 1.06 2.93 2.57 1.1736°C 3.87 3.47 0.77 3.75 3.41 0.84 3.61 3.34 0.91 3.48 3.26 0.98 3.21 3.05 1.07 3.00 2.88 1.1821°C 3.29 2.41 0.75 3.17 2.35 0.81 3.04 2.28 0.88 2.92 2.22 0.95 2.68 2.07 1.03 2.47 1.95 1.1424°C 3.30 2.93 0.75 3.18 2.86 0.81 3.06 2.79 0.88 2.94 2.71 0.95 2.70 2.53 1.03 2.49 2.39 1.1427°C 3.36 3.35 0.75 3.25 3.25 0.81 3.14 3.14 0.88 3.02 3.02 0.96 2.79 2.79 1.04 2.60 2.60 1.1530°C 3.52 3.52 0.76 3.42 3.42 0.82 3.32 3.32 0.89 3.21 3.21 0.97 2.97 2.97 1.05 2.77 2.77 1.1624°C 3.62 2.31 0.76 3.49 2.25 0.82 3.35 2.19 0.89 3.22 2.14 0.97 2.95 1.99 1.05 2.73 1.88 1.1627°C 3.63 2.67 0.76 3.50 2.61 0.83 3.37 2.55 0.89 3.23 2.49 0.97 2.97 2.33 1.05 2.74 2.20 1.1630°C 3.66 3.29 0.76 3.53 3.22 0.83 3.40 3.14 0.90 3.27 3.06 0.97 3.01 2.86 1.06 2.80 2.70 1.1633°C 3.74 3.74 0.77 3.63 3.63 0.83 3.52 3.52 0.90 3.40 3.40 0.98 3.15 3.15 1.07 2.95 2.95 1.1827°C 3.97 2.26 0.78 3.83 2.21 0.84 3.68 2.15 0.91 3.54 2.10 0.99 3.25 1.96 1.07 3.00 1.85 1.1830°C 3.98 2.78 0.78 3.84 2.73 0.84 3.69 2.67 0.91 3.54 2.61 0.99 3.26 2.45 1.07 3.01 2.32 1.1833°C 3.99 3.26 0.78 3.85 3.21 0.84 3.71 3.14 0.91 3.57 3.07 0.99 3.28 2.88 1.07 3.04 2.73 1.1836°C 4.03 3.69 0.78 3.90 3.62 0.85 3.77 3.54 0.92 3.63 3.45 0.99 3.35 3.22 1.08 3.13 3.03 1.19
358
16°C
19°C
22°C
232
16°C
19°C
22°C
282
16°C
19°C
22°C
AFR (CFM) EWB EDB
Outdoor temperature19°C 25°C 30°C 35°C 40°C 46°C
Remark: Notes:AFR: Air flow rate (CFM) 1. Ratings shown are gross capacities which do not include a deduction for indoor fan motor heat.EWB: Entering Wet Bulb Temp. (⁰C) 2 shows nominal capacities.EDB: Entering Dry Bulb Temp. (⁰C) 3. Direct interpolation is permissible. Do not extrapolate.TC: Total Cooling Capacity (kW) 4. Unit is able to operate at ambient from 10 ⁰C to 46⁰C without pressure trip.SC: Sensible Cooling Capacity (kW)PI: Power Input
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
12
Model: A5WMY20LR – A5LCY20CR Cooling Mode
TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI21°C 5.14 3.59 1.11 4.96 3.49 1.20 4.77 3.40 1.30 4.58 3.30 1.41 4.21 3.07 1.53 3.88 2.89 1.6924°C 5.15 4.30 1.11 4.96 4.20 1.20 4.78 4.10 1.30 4.59 4.00 1.41 4.22 3.73 1.53 3.90 3.52 1.6927°C 5.19 4.87 1.11 5.01 4.76 1.20 4.84 4.65 1.30 4.66 4.53 1.41 4.30 4.22 1.53 4.00 3.96 1.6930°C 5.35 5.35 1.12 5.19 5.19 1.21 5.04 5.04 1.31 4.87 4.87 1.42 4.52 4.52 1.55 4.23 4.23 1.7124°C 5.67 3.35 1.13 5.47 3.27 1.22 5.27 3.18 1.32 5.06 3.09 1.43 4.65 2.88 1.56 4.30 2.71 1.7127°C 5.67 3.83 1.13 5.47 3.75 1.22 5.27 3.66 1.32 5.06 3.57 1.43 4.66 3.34 1.56 4.30 3.17 1.7130°C 5.68 4.73 1.13 5.49 4.63 1.22 5.29 4.53 1.32 5.09 4.42 1.44 4.69 4.13 1.56 4.35 3.91 1.7233°C 5.75 5.75 1.13 5.56 5.56 1.22 5.38 5.38 1.33 5.20 5.20 1.44 4.81 4.81 1.56 4.50 4.50 1.7327°C 6.24 3.28 1.15 6.02 3.20 1.24 5.80 3.12 1.35 5.57 3.03 1.46 5.13 2.83 1.59 4.75 2.67 1.7530°C 6.24 4.00 1.15 6.02 3.91 1.24 5.80 3.82 1.35 5.58 3.73 1.46 5.13 3.49 1.59 4.75 3.31 1.7533°C 6.24 4.67 1.15 6.03 4.58 1.24 5.81 4.49 1.35 5.58 4.39 1.46 5.13 4.13 1.59 4.76 3.92 1.7536°C 6.26 5.29 1.15 6.06 5.19 1.24 5.85 5.08 1.35 5.63 4.97 1.46 5.19 4.66 1.59 4.83 4.42 1.7521°C 5.35 3.74 1.12 5.15 3.65 1.21 4.96 3.55 1.31 4.76 3.45 1.42 4.36 3.21 1.54 4.03 3.02 1.7024°C 5.36 4.54 1.12 5.17 4.43 1.21 4.98 4.33 1.31 4.78 4.22 1.42 4.39 3.94 1.54 4.06 3.72 1.7027°C 5.43 5.16 1.12 5.25 5.04 1.21 5.06 4.91 1.32 4.88 4.76 1.43 4.51 4.42 1.55 4.20 4.14 1.7130°C 5.65 5.65 1.13 5.49 5.49 1.22 5.32 5.32 1.33 5.15 5.15 1.44 4.77 4.77 1.57 4.46 4.46 1.7324°C 5.89 3.54 1.14 5.68 3.45 1.23 5.47 3.36 1.33 5.25 3.27 1.45 4.82 3.05 1.57 4.45 2.87 1.7327°C 5.90 4.08 1.14 5.69 3.99 1.23 5.48 3.90 1.33 5.26 3.80 1.45 4.83 3.56 1.57 4.47 3.37 1.7330°C 5.93 5.03 1.14 5.72 4.92 1.23 5.52 4.81 1.34 5.31 4.69 1.45 4.89 4.39 1.57 4.53 4.15 1.7333°C 6.03 6.03 1.14 5.84 5.84 1.24 5.66 5.66 1.34 5.47 5.47 1.46 5.07 5.07 1.58 4.74 4.74 1.7527°C 6.47 3.47 1.16 6.24 3.38 1.26 6.01 3.30 1.36 5.77 3.21 1.48 5.31 2.99 1.60 4.91 2.82 1.7630°C 6.48 4.25 1.16 6.25 4.16 1.26 6.02 4.07 1.36 5.78 3.98 1.48 5.31 3.72 1.60 4.91 3.53 1.7633°C 6.49 4.98 1.16 6.27 4.89 1.26 6.04 4.79 1.36 5.80 4.69 1.48 5.33 4.40 1.60 4.94 4.17 1.7736°C 6.53 5.63 1.16 6.32 5.53 1.26 6.10 5.41 1.37 5.88 5.29 1.48 5.42 4.95 1.61 5.06 4.67 1.7721°C 5.54 3.90 1.13 5.34 3.80 1.22 5.14 3.70 1.32 4.92 3.60 1.43 4.52 3.35 1.55 4.16 3.16 1.7124°C 5.57 4.74 1.13 5.37 4.63 1.22 5.17 4.52 1.32 4.96 4.40 1.43 4.56 4.11 1.56 4.21 3.87 1.7227°C 5.66 5.44 1.13 5.48 5.30 1.23 5.29 5.15 1.33 5.10 4.99 1.44 4.72 4.62 1.57 4.39 4.31 1.7330°C 5.95 5.95 1.14 5.77 5.77 1.24 5.60 5.60 1.34 5.41 5.41 1.46 5.01 5.01 1.58 4.68 4.68 1.7524°C 6.10 3.74 1.15 5.88 3.65 1.24 5.66 3.56 1.35 5.43 3.46 1.46 4.98 3.23 1.58 4.60 3.04 1.7427°C 6.12 4.33 1.15 5.90 4.23 1.24 5.68 4.13 1.35 5.45 4.03 1.46 5.00 3.77 1.58 4.62 3.57 1.7430°C 6.17 5.33 1.15 5.95 5.22 1.25 5.74 5.10 1.35 5.52 4.97 1.46 5.08 4.64 1.59 4.72 4.37 1.7533°C 6.31 6.31 1.16 6.12 6.12 1.25 5.93 5.93 1.36 5.74 5.74 1.48 5.31 5.31 1.60 4.97 4.97 1.7727°C 6.70 3.66 1.17 6.46 3.58 1.27 6.22 3.49 1.37 5.97 3.40 1.49 5.48 3.17 1.61 5.06 3.00 1.7830°C 6.71 4.52 1.17 6.47 4.43 1.27 6.23 4.33 1.37 5.98 4.24 1.49 5.49 3.97 1.61 5.08 3.76 1.7833°C 6.73 5.29 1.17 6.50 5.20 1.27 6.26 5.09 1.38 6.02 4.98 1.49 5.53 4.67 1.62 5.13 4.43 1.7836°C 6.79 5.98 1.17 6.58 5.87 1.27 6.35 5.74 1.38 6.12 5.60 1.50 5.66 5.22 1.63 5.28 4.91 1.79
AFR (CFM) EWB EDB
Outdoor temperature19°C 25°C 30°C 35°C 40°C 46°C
418
16°C
19°C
22°C
471
16°C
19°C
22°C
529
16°C
19°C
22°C
Remark: Notes:AFR: Air flow rate (CFM) 1. Ratings shown are gross capacities which do not include a deduction for indoor fan motor heat.EWB: Entering Wet Bulb Temp. (⁰C) 2 shows nominal capacities.EDB: Entering Dry Bulb Temp. (⁰C) 3. Direct interpolation is permissible. Do not extrapolate.TC: Total Cooling Capacity (kW) 4. Unit is able to operate at ambient from -10 ⁰C to 46⁰C without pressure trip.SC: Sensible Cooling Capacity (kW)PI: Power Input
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
13
Model: A5WMY25LR – A5LCY25CR Cooling Mode
TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI TC SC PI21°C 5.86 4.20 1.43 5.65 4.09 1.54 5.44 3.98 1.67 5.22 3.86 1.81 4.79 3.60 1.97 4.43 3.38 2.1724°C 5.86 5.03 1.43 5.66 4.91 1.55 5.45 4.80 1.67 5.23 4.68 1.81 4.80 4.37 1.97 4.44 4.12 2.1727°C 5.91 5.70 1.43 5.71 5.57 1.55 5.51 5.44 1.68 5.30 5.30 1.82 4.89 4.89 1.97 4.55 4.55 2.1830°C 6.09 6.09 1.44 5.92 5.92 1.56 5.74 5.74 1.69 5.55 5.55 1.83 5.15 5.15 1.99 4.82 4.82 2.2024°C 6.46 3.92 1.45 6.23 3.82 1.57 6.00 3.72 1.70 5.77 3.61 1.85 5.30 3.37 2.00 4.90 3.17 2.2127°C 6.46 4.48 1.45 6.24 4.38 1.57 6.01 4.28 1.70 5.77 4.18 1.85 5.30 3.91 2.00 4.90 3.70 2.2130°C 6.47 5.53 1.45 6.25 5.42 1.57 6.03 5.30 1.70 5.80 5.17 1.85 5.34 4.83 2.01 4.95 4.57 2.2133°C 6.55 6.55 1.46 6.34 6.34 1.58 6.13 6.13 1.71 5.92 5.92 1.86 5.48 5.48 2.02 5.12 5.12 2.2227°C 7.11 3.84 1.48 6.86 3.74 1.60 6.61 3.65 1.74 6.35 3.55 1.88 5.84 3.31 2.04 5.41 3.12 2.2530°C 7.11 4.68 1.48 6.86 4.58 1.60 6.61 4.47 1.74 6.35 4.37 1.88 5.84 4.09 2.04 5.41 3.88 2.2533°C 7.11 5.46 1.48 6.87 5.36 1.60 6.62 5.25 1.74 6.36 5.14 1.88 5.85 4.83 2.04 5.42 4.59 2.2536°C 7.14 6.19 1.48 6.90 6.07 1.60 6.66 5.94 1.74 6.42 5.81 1.89 5.92 5.45 2.05 5.50 5.17 2.2621°C 6.09 4.38 1.44 5.87 4.27 1.56 5.65 4.15 1.69 5.42 4.04 1.83 4.97 3.76 1.98 4.59 3.54 2.1924°C 6.11 5.31 1.44 5.89 5.19 1.56 5.67 5.07 1.69 5.44 4.94 1.83 5.00 4.61 1.99 4.62 4.35 2.1927°C 6.18 6.04 1.45 5.98 5.90 1.56 5.77 5.74 1.69 5.56 5.56 1.84 5.14 5.14 2.00 4.78 4.78 2.2030°C 6.44 6.44 1.46 6.26 6.26 1.58 6.07 6.07 1.71 5.87 5.87 1.86 5.44 5.44 2.02 5.08 5.08 2.2324°C 6.71 4.14 1.46 6.47 4.04 1.59 6.23 3.93 1.72 5.98 3.82 1.86 5.49 3.56 2.02 5.07 3.36 2.2327°C 6.72 4.77 1.47 6.48 4.67 1.59 6.24 4.56 1.72 5.99 4.45 1.86 5.50 4.16 2.02 5.09 3.94 2.2330°C 6.76 5.89 1.47 6.52 5.76 1.59 6.29 5.63 1.72 6.05 5.49 1.87 5.57 5.13 2.03 5.17 4.85 2.2333°C 6.87 6.87 1.47 6.66 6.66 1.59 6.45 6.45 1.73 6.23 6.23 1.88 5.77 5.77 2.04 5.40 5.40 2.2527°C 7.37 4.06 1.49 7.12 3.96 1.62 6.85 3.86 1.75 6.58 3.76 1.90 6.05 3.50 2.06 5.59 3.31 2.2730°C 7.38 4.98 1.49 7.12 4.87 1.62 6.86 4.76 1.75 6.59 4.65 1.90 6.05 4.36 2.06 5.60 4.14 2.2733°C 7.40 5.83 1.49 7.14 5.72 1.62 6.88 5.60 1.75 6.61 5.48 1.90 6.08 5.14 2.06 5.63 4.88 2.2736°C 7.44 6.59 1.50 7.20 6.47 1.62 6.95 6.33 1.76 6.70 6.19 1.91 6.18 5.79 2.07 5.76 5.46 2.2821°C 6.32 4.57 1.45 6.09 4.45 1.57 5.85 4.34 1.70 5.61 4.21 1.84 5.15 3.92 2.00 4.74 3.69 2.2024°C 6.35 5.55 1.45 6.12 5.42 1.57 5.89 5.29 1.70 5.65 5.15 1.85 5.19 4.80 2.00 4.80 4.53 2.2127°C 6.45 6.36 1.46 6.24 6.20 1.58 6.03 6.02 1.71 5.81 5.81 1.86 5.37 5.37 2.02 5.01 5.01 2.2330°C 6.78 6.78 1.47 6.58 6.58 1.59 6.38 6.38 1.73 6.17 6.17 1.88 5.71 5.71 2.04 5.33 5.33 2.2524°C 6.95 4.38 1.48 6.70 4.27 1.60 6.45 4.16 1.73 6.19 4.05 1.88 5.68 3.78 2.04 5.24 3.56 2.2427°C 6.97 5.07 1.48 6.72 4.95 1.60 6.47 4.84 1.73 6.21 4.72 1.88 5.70 4.41 2.04 5.27 4.18 2.2530°C 7.03 6.24 1.48 6.78 6.10 1.60 6.54 5.96 1.74 6.29 5.81 1.88 5.79 5.43 2.04 5.38 5.12 2.2533°C 7.18 7.18 1.49 6.97 6.97 1.61 6.76 6.76 1.75 6.54 6.54 1.90 6.06 6.06 2.06 5.66 5.66 2.2827°C 7.63 4.29 1.50 7.36 4.19 1.63 7.08 4.09 1.77 6.80 3.98 1.92 6.24 3.71 2.08 5.77 3.51 2.2930°C 7.65 5.28 1.51 7.37 5.18 1.63 7.10 5.07 1.77 6.81 4.96 1.92 6.26 4.64 2.08 5.79 4.40 2.2933°C 7.67 6.19 1.51 7.41 6.09 1.63 7.13 5.96 1.77 6.85 5.83 1.92 6.31 5.46 2.08 5.84 5.18 2.2936°C 7.74 6.99 1.51 7.50 6.87 1.64 7.24 6.72 1.78 6.98 6.55 1.93 6.45 6.11 2.09 6.02 5.75 2.31
AFR (CFM) EWB EDB
Outdoor temperature19°C 25°C 30°C 35°C 40°C 46°C
507
16°C
19°C
22°C
585
16°C
19°C
22°C
654
16°C
19°C
22°C
Remark: Notes:AFR: Air flow rate (CFM) 1. Ratings shown are gross capacities which do not include a deduction for indoor fan motor heat.EWB: Entering Wet Bulb Temp. (⁰C) 2 shows nominal capacities.EDB: Entering Dry Bulb Temp. (⁰C) 3. Direct interpolation is permissible. Do not extrapolate.TC: Total Cooling Capacity (kW) 4. Unit is able to operate at ambient from -10 ⁰C to 46⁰C without pressure trip.SC: Sensible Cooling Capacity (kW)PI: Power Input
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
14
Outline & Dimension
Indoor Unit
Model: A5WMY 10/15/20/25LR
Dimension A B C A5WMY 10/15LR 800 288 206 A5WMY 20/25LR 1065 310 224
Note: Dimension in mmDrawing No:
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
15
Outdoor Unit
Model: A5LCY 10/15FR
Model: A5LCY 20/25CR
Drawing No: 70014003558
Dimension A B C D E F G H I J K L M N 550 658 51 11 273 16 14 470 96 299 94 60 14 133
Note: Dimension in mmDrawing No: 70014113877
Drawing No: 70014003558
Note: Dimension in mmDrawing No: 70014018771
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
16
Wiring Diagram
Indoor Unit Outdoor Unit Model: A5WMY 10/15LR Model: A5LCY 10/15FR
Drawing number:
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
17
Indoor Unit Outdoor Unit Model: A5WMY 20/25LR Model: A5LCY 20/25CR
Drawing number:
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
18
Troubleshooting LED Light Diagnostic Table
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
19
Error Code Diagnosis by GS02
Diagnosis Step 1. Hold down ON TIMER CANCEL button or OFF TIMER CANCEL button for 5 seconds, a “ ”
indication flashes on the temperature display section. 2. Press TIMER CANCEL repeatedly until indoor buzzer produces a long beep. This indicates the
error code, refers to Error Codes table and is displayed on the temperature display section. 3. A short beep or two consecutive beeps indicate non-corresponding error codes. 4. To cancel the error code display, hold down ON TIMER CANCEL button or OFF TIMER CANCEL
button for 5 seconds. Alternatively, the code display will cancel itself if the button is not pressed for 1 minute.
Error Code Diagnosis by Unit Last State Memory 1. Remove battery from remote controller 2. Replace battery again into remote controller 3. Press Mode & ON/OFF buttons together 4. Press Mode button to 5:00 5. Press ON/OFF once 6. Repeat the fault diagnosis steps by wireless handset GS02
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
20
Troubleshooting Guidelines
Error Codes Error Description Action
0 Normal No action.
U0 Insufficient gas
1. Check sensor connection. 2. Check stop valve. 3. Check for gas leak. 4. Check the EXV. 5. Check H8.
U2 DC voltage out of range
1. Check the supply voltage. 2. Check the outdoor fan by rotating with hand. 3. Restart the system. 4. Check power supply waveform.
U4 Communication error
1. Check the indoor unit - outdoor unit connection wires.2. Check the voltage of the signal terminal. 3. Check the indoor fan by rotating with hand. 4. Check the power supply waveform.
U7 Signal transmission error (on outdoor unit PCB)
1. Restart the system. 2. Replace outdoor PCB. 3. Long term monitor on external factor.
UA Installation error 1. Check the indoor and outdoor unit model name. 2. Check the part code on the indoor and outdoor PCB.
UF Communication Error (indoor and outdoor) piping and wiring
1. Check the wiring and piping between indoor and outdoor units. 2. Check refrigerant level. 3. Check refrigerant line on blockage.
UH Anti-freeze function in other room
1. Check which indoor having error A5. 2. Check the supply voltage. 3. Check the indoor and outdoor model name.
A1 Indoor PCB error 1. Check connector connection. 2. Replace indoor PCB.
A3 Water pump error
1. Check for short circuit. 2. Check connection on drain pump. 3. Restart the system. 4. Check the drain water level. 5. Check float switch connection.
A5 Antifreeze
1. Check the air passage. 2. Check the intake air filter. 3. Check dust accumulation on indoor coil. 4. Check wiring and piping. 5. Check the EXV. 6. Check indoor coil sensor resistance value. 7. Check refrigerant level. 8. Check room sensor resistance value.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
21
Error Codes Error Description Action
A6 Indoor fan motor abnormal
1. Check the indoor fan by rotating with hand.
2. Replace indoor fan motor if not rotating smoothly.
3. Check fan motor voltage.
4. Replace indoor PCB if not at the rated voltage.
5. Check fan capacitor's conductivity (AC Motor).
6. Replace fan capacitor if there's conductivity.
C4 Indoor heat exchanger thermistor short/ open 1. Check the connector connection.
2. Check the sensor resistance value. C9 Indoor room thermistor short/ open
E1 Outdoor PCB error
1. Restart the system.
2. Replace outdoor PCB.
3. Check to see that the unit is grounded.
4. Check power supply waveform.
E3 High pressure protection
1. Check installation conditions.
2. Check stop valve.
3. Check HPS connection.
4. Check pressure level by pressure gauge.
5. Wait for 10 minutes then restart the system.
6. Check if H3 is displayed.
E4 Low pressure protection
1. Check stop valve.
2. Check low pressure sensor connection.
3. Check low side pressure and voltage.
4. Check outdoor coil sensor connection.
5. Check sensor resistance value.
6. Check refrigerant level.
E5 Compressor motor lock/overload
1. Check connection on discharge pipe sensor.
2. Check discharge pipe sensor resistance value.
3. Check the EXV.
4. Check the refrigerant line on blockage or shortage.
E6 Compressor lock/start-up error 1. Check with inverter checker.
2. Check the EXV.
E7 Outdoor DC fan motor lock 1. Check the fan motor connection.
2. Check if foreign matters exist around or in the fan.
E8 Ac input over current
1. Measure the input current.
2. Check the main circuit electrolytic capacitor.
3. Check with inverter checker.
4. Check discharge pressure.
5. Check the installation condition.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
22
Error Codes Error Description Action
E9 EXV error
1. Restart the system.
2. Check the EXV connection.
3. Check EXV coil resistance.
4. Check sensors resistance value.
EA 4-way valve error
1. Check 4WV coil connection.
2. Check the continuity of the 4WV coil and harness.
3. Check the 4WV switching output.
4. Check sensor connection.
5. Check sensor resistance value.
6. Check the refrigerant line on blockage or shortage.
F3 Discharge pipe overheat
1. Check the discharge pipe sensor.
2. Check the EXV.
3. Check the refrigerant line on blockage or shortage.
F6 Heat exchanger overheat
1. Check the installation space.
2. Check the outdoor fan.
3. Check the EXV.
4. Check the coil sensor.
H0 Compressor sensor system abnormality
1. Check the reactor connection.
2. Check the compressor connection. 3. Measure the resistance value between the reactor terminals. 4. Measure the resistance value between the compressor terminals.
H3 High pressure switch error 1. Check pressure sensor connection.
2. Check HPS continuity.
H6 Position sensor abnormality
1. Check for short circuit.
2. Check the electrolytic capacitor voltage.
3. Check compressor harness wire.
4. Check with inverter checker.
H8 AC current sensor error
1. Restart the system.
2. Check capacitor voltage.
3. Measure the rectifier input voltage.
4. Check compressor harness wire.
5. Check with inverter checker.
H9 Outdoor air thermistor short / open
1. Check the sensor connection.
2. Check the sensor resistance value.
J1 Pressure sensor error 1. Check pressure sensor connection.
2. Check pressure and voltage level.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
23
Error Codes Error Description Action
J3 Compressor discharge pipe thermistor short /open / misplaced
1. Check the sensor connection.
2. Check the sensor resistance value.
3. Check indoor coil sensor resistance value.
J5 Suction pipe thermistor short/ open
Same as H9.
J6 Outdoor heat exchanger
J7 Subcooling heat exchanger thermistor short/ open
J8 Liquid pipe thermistor short/ open
J9 Gas pipe thermistor abnormality
LC Communication Error (control PCB and inverter PCB)
1. Check fan motor connection.
2. Check if LED blinking normally at outdoor PCB.
L1 Outdoor PCB error
1. Check the range of power supply.
2. Check connection between compressor and PCB.
3. Check fan motor resistance.
4. Check the power supply waveform.
L3 Electrical box temperature rise
1. Restart the system.
2. Check sensor resistance value.
3. Check heat sink temperature and conditions.
4. Check outdoor fan.
5. Check the installation condition.
L4 Heat sink overheat
1. Restart the system.
2. Check the silicon grease condition on heat sink.
3. Check sensor resistance value.
4. Check heat sink temperature and conditions.
5. Check outdoor fan.
6. Check the installation condition.
L5 IPM error / IGBT error
1. Check stop valve.
2. Check with inverter checker.
3. Check the power transistor and supply voltage
5. Check the compressor phase.
6. Check the discharge pressure.
7. Check the installation condition.
L8 Electrical thermal switch Contact dealers for assistance.
L9 Stall prevention
1. Check installation conditions.
2. Check stop valve. 3. Check difference between high and low pressure side. 4. Check continuity on the power transistor.
5. Check the output voltage.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
24
Error Codes Error Description Action
P1 Open phase or voltage unbalance
1. Check LED on outdoor PCB.
2. Check open phase of power supply voltage.
3. Check voltage balance between phases.
P4 Heat sink thermistor short / open Same as H9.
PJ Capacity setting error 1. Check the connection between capacitor and outdoor PCB.
TECHNICAL SPECIFICATION
TS-A5WMY-L_(i)
25
Product manufactured in an ISO certified facility. This document contains the most current information as of this orienting.
For the most up to date product information, please go to www.acson‐international.com
Revision History List Manual : Inverter Y Wall Mounted L Series TM : A5WMY-L_(i)
Revision Subject Amendment on Manual’s Page No. Date
01 1. Correction on outdoor unit weight 9 09.04.2012
02 1. Correction on performance table 10 30.04.2012
