Lycoming Aircraft Engines Parts Catalog · Lycoming Aircraft Engines Parts Catalog. Part No....

Part No. PC-306-10652 Oliver Street

Williamsport, PA 17701

HO-360-C1AWide Cylinder Flange Crankcase Model Engines

Lycoming Aircraft EnginesParts Catalog

,; t;; tte]: I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

This illustrated parts catalog contains a complete parts listing for the Textron Lycoming HO-360-C lA wide cylinder flange crankcase model aircraft engines.

Major assembly and sub-assembly parts of the engine are listed in the Group Assembly sections in the general sequence of engine build up.

A Service Kits section and Oversize and Undersize Parts List are included to aid in ordering parts as necessary during overhaul.

The Numerical Index is provided for convenience in finding parts when only the part number is known.

Parts coverage of Vendor Accessories used on Textron Lycoming engines may be found in the appropriate Vendor's Parts Catalog. A list of addresses of where to obtain these publications appears in the latest edition of Service Letter No. L114. NOTE

The illustrations, pictures and drawings shown in the publication are typical of the subject matter they portray.

This catalog, when used in conjunction with the appropriate overhaul manual, shall be used for parts identification only. Under no circumstances shall this catalog be used as an assembly or installation document.

Any reference in this document to a suppliers/parts manufacturer's product, by name, trademark, part number or other description is solely for the purposes of identification and does not indicate or infer that Textron Lycoming accepts responsibility for quality control and/or airworthiness of parts which do not pass through the Textron Lycoming quality control system.

All Textron Lycoming publications will bear the copyright notice @Textron Lycoming 1986, "All Rights Reserved", and all Textron Lycoming publications are to be considered copyrighted and may not be reproduced without permission of the company.

SERVICE BULLETINS, INSTRUCTIONS AND LETTERS

Although the information contained in this parts catalog is up-to-date at time of publication, users are advised to procure current information through all Textron Lycoming distributors or from the factory by subscription. Consult the latest edition of Service Letter No. L 114 for subscription information.

HOW TO ORDER PARTS

In ordering parts for your engine, observe the following instructions which will expedite shipment of correct parts required without delay.

a. Always specify the model and serial number of your engine.

b. Always specify part number, nomenclature and quantity required.

1

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

iii3i,teJ:1 Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

TABLE OF CONTENTS

SECTION

Introduction . . . . . . . . . . . . . . Table of Contents . . . . . . . . . . . Oversize and Undersize Parts Listing .

1. CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP Crankcase Assembly ................. . Oil Level Gage Assembly and Crankcase Related Parts . Crankshaft Assembly and Related Parts ........ . Crankshaft Idler Gears, Tachometer Drive and Camshaft Crankcase Attaching Parts . . . . . . . . . . . . .. . .

2. ACCESSORY HOUSING AND RELATED PARTS Accessory Housing Assembly ... .................. . Oil Pump and Accessory Housing Attaching Parts . . . . . . . . . . Propeller Governor Drive, Vacuum Pump Drive and Fuel Pump Covers Oil Filter Base Cover and Breather Fitting . . . . . . . . . . . . . . . . . . .

3. CYLINDER, PISTON AND VALVE TRAIN Connecting Rods, Pistons and Ring Assemblies Cylinder Assembly . . Cylinder Related Parts ............ . Valve Assembly ............... . Cylinder Head Drain Tubes, Intercylinder Cooling Baffles and Rocker Box Covers

4. IGNITION SYSTEM Magnetos, Magneto Drives, Harnesses and Spark Plugs .

5. ELECTRICAL SYSTEM Presto lite Starter and Attaching Parts Sky-Tec Starter and Attaching Parts Alternator Assembly and Belt .... Alternator Mounting and Attaching Parts

6. OIL SUMP AND INDUCTION SYSTEM Oil Sump Assembly and Oil Suction Screen Intake Pipes and Attaching Parts Carburetor Assembly. Priming System ..... .

7. SERVICEKlTSECTION .

8. NUMERICAL INDEX ..

11

PAGE

ii iii

1-1 1-3 1-5 1-7 1-9

2-1 2-3 2-5 2-7

3-1 3-3 3-5 3-7 3-9

4-1

5-1 5-2 5-3 5-5

6-1 6-3 6-5 6-7

7-1

8-1

deggle01

Rectangle

'i j:, i .tel: I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

OVERSIZE AND UNDERSIZE PARTS LISTING

Part No. Description OVERSIZE UNDERSIZE P02 P05 PI0 P15 P20 P30 P40 P50 M03 M06 MlO

.002 .005 .010 .015 .020 .030 .040 .050 .003 .006 .010

61681 GUIDE See Latest Edition of Service Instruction No. 1256.

66610 BUSHING X X 66796 INSERT X 69796 DOWEL X 72057 SEAT X X X X 72058 SEAT X X X 72155-S BUSHlNG X X X X

74230 GUIDE See Latest EditiOn of Service Instruction No. 1256.

74241 RING X 75656-S BUSHING X X X X 75657-S BUSHING X X X

.... --

LW-11997 SEAL See Latest Edition of Service Instruction No. 1324.

LW-13521 BEARING X X* X* X* -- -- .- -- - - c~

LW-13792 SEAL See Latest Edition of Service Instruction No. 1324.

LW-13884 BEARING X X* X* X* LW-16711 BEARING X X X X STD-I065 DOWEL X X X X 14H21950 RING X X 18A19441 BEARING X X X X

* Also available in PI0 oversize.

In addition to the above, studs are available in P03, P07 & P12.

NOTE

When ordering oversize and undersize parts, be sure to specify the required oversize and undersize dimension along with the proper part number. For example, to order bearing L W -13884 in. 003 undersize, order part number LW-13884-M03. Oversize code letter is "P" while undersize code letter is "M". These letters are then followed by the number designating the size in thousandths of an inch.

111

deggle01

Rectangle

'i i:, i It.]: I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

1

1 2 3 4 5 6 7 8 9

10 11 12 13 14

WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKCASE ASSEMBLY

PART NUMBER DESCRIPTION

IIB20061-3SL CRANKCASE ASSEMBl Y (See Note) 75154 STUD 112-13 x 10-1132 lonQ: 50-15 STUD 112-13 x 1-7/8 lonQ: 38-13 STUD, 3/8-16 x 1-5/8 lonQ: 38D-1I STUD 3/8-16 x 2-1/8IonQ:, drilled JIC-12 STUD 5/16-18 x 1-112 lonQ: 31C-13 STUD 5/16-18 x 1-5/8 lonQ: STD-557 DOWEL 112 dia. x 11116IonQ:, hollow STD-514 DOWEL 5116 dia. x 1/2IonQ: STD-1623 INSERT 1/4-20 Helicoil x 3/8 lonQ: LW-13793 STUD. 5/16-18 x 15116IonQ:, drilled 69796 DOWEL Crankshaft bearinQ: 1102 PLUG. 118-27 NPT Allen head STD-1339 PLUG, 1116-27 NPT, Allen head

NOTE

This part is not available as a service item. Refer to Service Kits, Section 7, for applicable Crankcase Assembly and Governor Stud Kit Part Number.

1-1

QTY. PER

ASSY. ,

1 2 8

16 1 2 1 2 2 2 1 2 6 4

deggle01

Rectangle

HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

Figure 1. CRANKCASE ASSEMBLY

1-2

deggle01

Rectangle

lii:ji,te):I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

FIG REF.

2

1

1 1 14

CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP OIL LEVEL GAGE ASSEMBLY AND CRANKCASE RELATED PARTS


BODY, Hydraulic tappet

QTY. PER

ASSY.

1 1 1 1

1 1 1 1 1 1 1 4 2 2 1 1 2 2 8

* Select spring to give a minimum of three threads exposed on adjusting screw to allow field adjustment. Reference latest revision of Textron Lycoming Table of Limits SSP-1776, Part I for spring identification.

** See latest edition of Textron Lycoming Service Instruction No. 1324 for installation.

1-3

deggle01

Rectangle

deggle01

Rectangle

deggle01

Rectangle

'iail!e):- Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

Figure 2. OIL LEVEL GAGE ASSEMBLY AND CRANKCASE RELATED PARTS

1-4

deggle01

Rectangle

'i £; i tIe): I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

3 1 2

1

11


CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKSHAFT ASSEMBLY AND RELATED PARTS

PART NUMBER

72566

DESCRIPTION

GEAR, Starter ring

QTY. PER

ASSY.

1

* See latest edition of Textron Lycoming Service Bulletin No. 475 for proper installation.

1-5

deggle01

Rectangle

deggle01

Rectangle

2


10

1

9

11

3

No.1 CRANKPIN

6 INDEX

4

Figure 3. CRANKSHAFT ASSEMBLY AND RELATED PARTS

1-6

4

4

5

4

deggle01

Rectangle

'i tj i tie): I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

4


CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKSHAFT IDLER GEARS, TACHOMETER DRIVE AND CAMSHAFT


SPACER, Tach. shaft centering

1-7

QTY. PER

ASSY.

1 1 1 1 1 1 1

2

1 1 1

deggle01

Rectangle

'i t; i .t.,: I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

8

2

1

7

6

5 4

Figure 4. CRANKSHAFT IDLER GEARS, TACHOMETER DRIVE AND CAMSHAFT

1-8

deggle01

Rectangle

,; if:;; tIe): I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

5

1 2 3 4 5 6 7 8 9

10 11 12 13 14 15 16 17 18


CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKCASE ATTACHING PARTS


LW-25-1.50 BOLT 1/4-20 x 1-1/2 long:. hex. hd. STD-8 WASHER 1/4 nlain 60803 STRAP Lifting: LW-25-175 BOLT 114-20 x 1-3/4 long:, hex. hd. LW-25-1.13 BOLT 114-20 x 1-118 long:, hex. hd. STD-160 WASHER 114 lock internal teeth STD-1411 NUT 114-20 nlain LW-25S1.50 BOLT 114-20 x 1-112 long:, hex. hd. dr. end STD-8 WASHER 1/4 nlain (Max. 9) STD-1409 NUT 114-20 slotted shear STD-33 WASHER 3/8 nlain 1/16 thick AN960-616L WASHER 3/8 nlain 1132 thick STD-872 NUT 3/8-24 slotted AN6-34A BOLT. 3/8-24 x 3-37/64Ionl!. hex hd STD-33 WASHER 3/8 nlain STD-67~ WASHER 3/8 lock internal teeth STD-596 NUT 3/8-24 Dlain 76220 STUD, 112-20 x 10-45/64 long

1-9

QTY. PER

ASSY.

8 19

1 1 3

12 9 2

AR 3 3 1 1 2 2 2 2 4

deggle01

Rectangle

'i i:t i .t-): I Lycoming HO-360-CIA PARTS CATALOG

o co


1,2,6,7

2,4,6,7

o

18

Figure 5. CRANKCASE ATTACHING PARTS

1-10

11,12,13

8,9,10

deggle01

Rectangle

FIG REF.

6


ACCESSORY HOUSING AND RELATED PARTS ACCESSORY HOUSING ASSEMBLY

PART NUMBER

-24

DESCRIPTION

2-1

QTY. PER

ASSY.

1 1 4

2

4 1 4 2

deggle01

Rectangle


Figure 6. ACCESSORY HOUSING ASSEMBLY

2-2

deggle01

Rectangle

'i t; i .1.': I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

FIG REF.

7

ACCESSORY HOUSING AND RELATED PARTS OIL PUMP AND ACCESSORY HOUSING ATTACHING PARTS

PART NUMBER

LW-25-1.50

DESCRIPTION

* See latest edition of Textron Lycoming Service Bulletin No. 524.

2-3

QTY. PER

ASSY.

1 2

deggle01

Rectangle

deggle01

Rectangle

,;tt;,!.,:- Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

7,8,10

7,8,9

, "

I 'L I' , I

I \ '

7,8,9

7,8,11

7,8,9 2

5

Figure 7. OIL PUMP AND ACCESSORY HOUSING ATTACHING PARTS

2-4

deggle01

Rectangle

'i t; i t{e): I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

8


ACCESSORY HOUSING AND RELATED PARTS PROPELLER GOVERNOR DRIVE, VACUUM PUMP DRIVE AND FUEL PUMP COVERS

PART NUMBER

*

LW-38-0.75

DESCRIPTION

BOLT, 3/8-16 x 3/4 long

QTY. PER

ASSY.

4 4 4

1 4

4 1 1 2 2 2

* Used when no propeller governor oil line is installed.

2-5

deggle01

Rectangle

iittitt.':1 Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

Figure 8. PROPELLER GOVERNOR DRIVE, VACUUM PUMP DRIVE AND FUEL PUMP COVERS

2-6

deggle01

Rectangle

FIG REF.

9


ACCESSORY HOUSING AND RELATED PARTS OIL FILTER BASE COVER AND BREATHER FITTING

PART NUMBER

71140

DESCRIPTION

FITTING, Breather

2-7

QTY. PER

ASSY.

1 1 4 4

1 1

1 1

1

deggle01

Rectangle

2

3

7

8

1

6

3 4

11

12


10

9

Figure 9. OIL FILTER BASE COVER AND BREATHER FITTING

2-8

deggle01

Rectangle

'i t§ i .Ie]: I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

FIG REF.

10

CYLINDER, PISTON AND VALVE TRAIN CONNECTING RODS, PISTONS AND RING ASSEMBLIES


* See latest edition of Textron Lycoming Service Instruction No. 1267.

3-1

QTY. PER

ASSY.

4 4 8 8 8 4 4 8 8 4

deggle01

Rectangle

deggle01

Rectangle

i{flitt·HI Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

1

1

8

Figure 10. CONNECTING RODS, PISTONS AND RING ASSEMBLIES

3-2

deggle01

Rectangle

FIG REF.

11 PART

NUMBER


CYLINDER, PISTON AND VALVE TRAIN CYLINDER ASSEMBLY

DESCRIPTION

QTY. PER

ASSY.

4 4 4 4 4

4

8

* See latest edition of Textron Lycoming Service Instruction No. 1256.

3-3

deggle01

Rectangle

deggle01

Rectangle

'i ¥:; i ,Ie]: I Lycoming

2


13~ 14 15

Figure 11. CYLINDER ASSEMBLY

3-4

deggle01

Rectangle

FIG REF.

12

9

PART NUMBER

STD~2090


CYLINDER, PISTON AND VALVE TRAIN CYLINDER RELATED PARTS

DESCRIPTION

QTY. PER

ASSY.

AR

4

4 2

18

* See latest edition of Textron Lycoming Service Instruction No. 1060 for complete push rod application.

* * Due to the size of the area where the part number is stamped, the last five digits may be all that is shown (19357).

3-5

deggle01

Rectangle

deggle01

Rectangle

'itii.!.':' Lycoming

6


1

5

Figure 12. CYLINDER RELATED PARTS

3-6

9

deggle01

Rectangle

FIG REF.

13 PART

NUMBER


CYLINDER, PISTON AND VALVE TRAIN VALVE ASSEMBLY

DESCRIPTION

SEAL, Shroud tube

3-7

QTY. PER

ASSY.

8

deggle01

Rectangle

'i ti i .Ie): I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

13

14

Figure 13. VALVE ASSEMBLY

3-8

deggle01

Rectangle

FIG REF.

14

12


CYLINDER, PISTON AND VALVE TRAIN CYLINDER HEAD DRAIN TUBES, INTERCYLINDER COOLING BAFFLES

AND ROCKER BOX COVERS

PART NUMBER

STD-1925

DESCRIPTION

QTY. PER

ASSY.

4 4

1 1

4 2 2

2 4 4

SCREW, 114-20 x 5/8 long, pan. hd., self-locking 24

3-9

deggle01

Rectangle

TEXTRON Lycoming

3

4,5,6


11

12

Figure 14. CYLINDER HEAD DRAIN TUBES, INTERCYLINDER COOLING BAFFLES AND ROCKER BOX COVERS

3-10

deggle01

Rectangle


IGNITION SYSTEM MAGNETOS, MAGNETO DRIVES, HARNESSES AND SPARK PLUGS

FIG QTY. REF. PART PER

15 NUMBER DESCRIPTION ASSY.

1 STD-713 COTTER PIN 3/32 dia. x 3/4 long 4 2 LW-12681 GASKET Magneto 4 3 62224 GASKET Magneto 2 4 LW-15416 ADAPTER ASSY. Magneto drive 2 5 LW-14910 COUPLING Ma!!neto drive 2 6 LW-14230 CUSHION Ma!!neto drive 4 7 66GP-OSANN MAGNETO Plain Right Slick Model 4370 1

66GR25SANN MAGNETO Retard Left Slick Model 4347 1 8 67P20400 HARNESS ASSY. Right Slick Model M-2976 1

67P20403 HARNESS ASSY. Left Slick Model M-2977 1 9 66M21195 CLAMP Ma!!neto 4

10 STD-475 WASHER 5/16 lock internal teeth 4 10 STD-1410 NUT 5116-18 Dlain 4 12 1182-J7* SPARK PLUG ChamDion (REM38S) or

Auburn (SR83P) 8 ** 0IPI9762-9-48 BAG, Magneto harness attaching 1

* Item No. 12 spark plugs are used in current production only. Additional spark plugs are available for this engine. See latest edition of Textron Lycoming Service Instruction No. 1042 for complete listing of all approved spark plugs.

** See page 4-2 for a breakdown of inqividual parts contained in the magneo and harness attaching parts bag. These parts are to be attached by customer per engine drawing included in each bag.

MAGNETO ISOLATION DRIVE Kit PIN LW-15436 available.

4-1

deggle01

Rectangle

deggle01

Rectangle

Part No.

LW-16266-25-25 LW-14060 STD-8 STD-1874 76734 LW-16266-25-50 72815 73152 STD-692 STD-425 STD-670 LW-M-2375 STD-251 LW-25-1.13 LW-14875

PIN 01 P19762-9-48

Part Name

CLIP, One wire CLIP, Two wire WASHER, 1/4 plain SCREW, 1/4 -20 x 13/16 long ZIP STRAP CLAMP, Four wire BRACKET, Twist BRACKET, Support SCREW, No. 10-32 x 1/2 long WASHER, No. 10 plain LOCKNUT, No. 10-32 PLATE, Spark plug cable WASHER, No. 10 internal lock SOL T, 1/4-20 x 1-1/8 long BRACKET, Extension

ATTACHING HARDWARE

4

10 11


Qty.

4 4

12 4 4 2 1 1 1 1 1 2 2 2 1

4 12i Figure 15. MAGNETOS, MAGNETO DRIVES, HARNESSES AND SPARK PLUGS

4-2

deggle01

Rectangle

'i i:, i lIe): I Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

16

1


ELECTRiCAL SYSTEM PRESTOLITE STARTER AND ATTACHING PARTS


NOTE

See latest edition of Textron Lycoming Service Instruction No. 1154 for complete listing of FAA approved starters, generators, alternators, regulators and relays.

Figure 16. PRESTOLITE STARTER AND ATTACHING PARTS

5-1

4

QTY. PER

ASSY.

4 4 1 3

deggle01

Rectangle

deggle01

Rectangle

'i £; i l{.': I Lycoming HO-360-CIA PARTS CATALOG

FIG. REF.

17 1 2 3 4


ELECTRICAL SYSTEM SKY-TEC STARTER AND ATTACHING PARTS


31B22111 STARTER Skv-Tec (149-24HT) STD-475 WASHER 5/16 lock internal teeth LW-31-1.09 BOLT 5/16-18 x 1-3/32Iomr. hex. hd. STD-1410 NUT, 5/16-18 plain

Figure 17. SKY-TEC STARTERANDATTACHINGPARTS

5-2

QTY. PER

ASSY.

1 4 1 3

deggle01

Rectangle

TEXTRON

FIG REF.

18

Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

PART NUMBER

ELECTRICAL SYSTEM ALTERNATOR ASSEMBLY AND BELT

DESCRIPTION

A

BELT, Alternator drive, 3/8 wide

NOTE

See latest edition of Textron Lycoming Service Instruction No. 1154 for complete listing of FAA approved starters, generators, alternators, regulators and relays.

5-3

QTY. PER

ASSY.

1 1 1 1

deggle01

Rectangle

deggle01

Rectangle

'iUi.teJ:. Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

2

Figure 18. ALTERNATOR ASSEMBLY AND BELT

5-4

deggle01

Rectangle

i.J3ilte':' Lycoming HO-360-CIA PARTS CATALOG

FIG REF.

19


ELECTRICAL SYSTEM ALTERNATOR MOUNTING AND ATTACHING PARTS

PART NUMBER

5-5

DESCRIPTION

QTY. PER

ASSY.

1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1

AR AR

1 1

deggle01

Rectangle

iitiitt.]:_ Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINES

15 17

16

Figure 19. ALTERNATOR MOUNTING AND ATTACHING PARTS

5-6

6

10

11

9

8

deggle01

Rectangle


OIL SUMP AND INDUCTION SYSTEM OIL SUMP ASSEMBLY AND OIL SUCTION SCREEN

FIG QTY. REF. PART PER

20 NUMBER DESCRIPTION ASSY.

1 LW-13353 GASKET Oil sumo 1 2 56A22204 SUMP ASSEMBLY Oil 1 3 69602 CONNECTION Intake oioe 4 4 61400 STUD 114-20 x 1-3116Ion!l 4 5 31C-14 STUD 5/16-18 x 1-3/4Ion!l 4 6 1102 PLUG 1I8oioe 2 7 STD-551 PLUG 112-14 NPT Sq. hd .• drilled 1 8 STD-8 WASHER 1I4olain 28 9 STD-160 WASHER 114 lock internal teeth 20

10 LW-25-0.94 BOLT. 114-20 x 15116 long, hex. hd. 8 11 LW-25-1.13 BOLT 114-20 x 1-1/8 long, hex. hd. 2 12 STD-1411 NUT 1/4-20olain 18 13 70484 SCREEN Oil suction 1 14 06E 19769-1. 00 GASKET 1.00 I.D. x 1-114 O.D. x 3/32 annular 1 15 LW-12545 PLUG, 5/8 hex. hd. x 1.00-20 thread 1

6-1

deggle01

Rectangle

TEXTRON

B

9

12

Lycoming HO-360-CIA PARTS CATALOG

o


C>

C>

C>

4 C>

a

C>

C>

~ 6 13

14

Figure 20. OIL SUMP ASSEMBLY AND OIL SUCTION SCREEN

6-2

10

deggle01

Rectangle

'i if:; i .tel: I Lycoming

FIG REF. PART

21 NUMBER

1 71712 71713

2 69603 3 LW-15592-8-28 4 71973 5 73346 6 STD-8 7 STD-160 8 LW-25-1.25 9 1102

10 75444*

* Part shipped loose.


OIL SUMP AND INDUCTION SYSTEM INTAKE PIPES AND ATTACHING PARTS

DESCRIPTION

PIPE Intake cvls. 1 & 2 PIPE Intake cvls. 3 & 4 HOSE 1-3/4I.D x 2-3/16 O.D x 1-3/4 10m!

CLAMP. Hose GASKET 2JJolt flanQe 1-3/4 I D. FLANGE Intake nine. unner WASHER 1/4 nlain WASHER 1/4 lock internal teeth BOL T 1/4-20 x 1-114 lonQ hex. hd. PLUG. 118 nine ADAPTER ASSY., Fuel drain valve

6-3

QTY. PER

ASSY.

2 2 4 8 4 4 8 8 8 2

I 1

deggle01

Rectangle

'i t; i lIe]: I Lycoming

5

2

o

9


1

6

7

3

~10

o

Figure 21. INTAKE PIPES AND ATTACIllNG PARTS

6-4

deggle01

Rectangle

FIG REF. PART

22 NUMBER

1 77154 2 61E22121 3 STD-35 4 STD-475 5 STD-141O


OIL SUMP AND INDUCTION SYSTEM CARBURETOR ASSEMBLY

DESCRIPTION

GASKET Carburetor CARBURETOR HA-6 (10-6030) WASHER 5/16 nlain WASHER 5/16 lock internal teeth NUT, 5/16-18 plain

6-5

QTY. PER

ASSY.

1 1 4 4 4

deggle01

Rectangle

'i tt i .t.]: I Lycoming

5

2


Figure 22. CARBURETOR ASSEMBLY

6-6

deggle01

Rectangle

iii:ti,t.,:, Lycoming

FIG REF.

23 PART

NUMBER

* Assemble in cylinder head.


OIL SUMP AND INDUCTION SYSTEM PRIMING SYSTEM

DESCRIPTION

6-7

QTY. PER

ASSY.

1 1 1 1

1

1 1 3

deggle01

Rectangle

TEXTRON Lycoming

1

18

6


5,13.14,15

7,8,9,10,11

16 7,9,10,11,12

Figure 23. PRIMING SYSTEM

6-8

2

18

3

7

deggle01

Rectangle

Part No.

75439-1 LW-10332 LW-12272 LW-12681 LW-12795 LW-13353 LW-13792* LW-14260 LW-14995 LW-18639 LW-18661 LW-19296 STD-213 06A19956 06E19769-0.63 06E 19769-1. 00 06E19769-1.25 1691-C 60096 61173 61183 62224 66224 68315 69164 69345 69551 70310 70455 71481 71973 72053 72059 72075 72078 72091 72220 72312 72829 73189 73383 73817 73818 74065 74068


I SERVICE KIT SECTION ...... SEAL AND GASKET KIT

Part Name

SEAL AND GASKET SET LOCKPLA TE, Crankshaft gear LOCKPLA TE, Shroud tube GASKET, Magneto GASKET, Oil filter adapter GASKET, Oil sump SEAL, Crankshaft oil SEAL, Tachometer drive SPRING, Shroud tube LOCKPLA TE, Crankshaft gear SEAL, Shroud tube GASKET, Exhaust flange SEAL, Oil SEAL, Oil GASKET GASKET GASKET GASKET, Fuel pump GASKET, Fuel pump GASKET, Oil pressure housing GASKET, Accessory adapter GASKET, Magneto adapter GASKET, Carburetor GASKET, Accessory drive GASKET, Fuel pump adapter SPACER GASKET, Accessory drive SEAL, Shroud tube GASKET RING, Oil seal GASKET GASKET, Govemor GASKET, Oil level gage SEAL, Oil LOCKPLATE RING, Oil seal GASKET, Oil level gage RING, Oil seal LOCKPLATE GASKET LOCKPLATE LOCKPLATE GASKET, Accessory housing RING, Oil level gage seal RING, Oil level gage plug

7-1

Qty.

1 1 4 2 1 1 1 1 4 1 8 4 1 1 2 1 1 1 1 1 1 3 2 1 1 4 1 8 1 4 4 2 1 6 2 2 1 1 1 1 2 2 1 1 1

deggle01

Rectangle


SERVICE KIT SECTION ....... SEAL AND GASKET SET I

Part No. Part Name Qty.

75439-1 SEAL AND GASKET SET (CONT.) 75906 GASKET, Rocker box cover 4

76510 GASKET, Oil cooler bypass 1

76940* SEAL, Crankshaft oil 1

77154 GASKET, Carburetor 1

77611 GASKET, Exhaust flange 4

8313 GASKET, Vacuum pump 1

* Refer to latest edition of Textron Lycoming Service Instruction No. 1324 for application.

7-2

deggle01

Rectangle

deggle01

Rectangle

Part No.

05K21104 LW-12427 LW-19001 73938 LW-11800 LW-11795 LW-10077 LW-16475 65441 LW-13323 60009 17C21191 17C19386 75089 74241 14H21950 LW-14077 LW-11775 60828 71481 LW-18661 70310 75906


I SERVICE KIT SECTION ...... CYLINDER, PISTON AND RING ASSEMBLY KIT I

Part Name

KIT - CYLINDER, PISTON AND RING ASSY. CYLINDER AND HEAD ASSY. VALVE,Exhaust VALVE, Intake SPRING, Valve, outer SPRING, Valve, inner SEAT, Valve spring, upper, intake SEAT, Valve spring, upper, exhaust SEAT, Valve spring, lower, intake SEAT, Valve spring, lower, exhaust KEY, Valve, intake KEY, Valve, exhaust CAP, Valve stem, exhaust PISTON RING, Piston, compression RING, Piston, oil regulating PIN, Piston PLUG, Piston pin PLUG, Piston pin RING, Oil seal SEAL, Shroud tube SEAL, Shroud tube GASKET, Rocker box cover

7-3

Qty.

1 1 1 1 2 2 1 1 1 1 2 2 1 1 2 1 1 2 2 1 2 2 1

deggle01

Rectangle


SERVICE KIT SECTION ....... CRANKCASE ASSY. AND THRU STUD KIT I

Part No. Part Name Qty.

11 B20061-3SL-S CRANKCASE ASSY. AND THRU STUD KIT 1 11 B20061-3SL CRANKCASE ASSY. 1 STD-1339 PLUG, 1/16 pipe 4 STD-2090 NUT 2 1102 PLUG, 1/8 pipe 6 74887 SPACER 2 76220 THRU STUD 4 SSP-582 TAG (Thin wall bearing) 1 SSP-272 TAG (Piston cooling nozzles) 1

7-4

deggle01

Rectangle

'i i:, i .t.): I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE

NUMERICAL INDEX

PART NO. PART NAME PAGE NO. PART NO. PART NAME PAGE NO.

AN365-632A Nut 6-7 LW-12427 Cyl. & Head Assy. 3-3 AN6-14 Bolt 5-5 LW-12545 Plug 6-1 AN6-16 Bolt 5-5 LW-12598 Sleeve 6-7 AN6-34A Bolt 1-9 LW-12681 Gasket 4-1 AN960-616L Washer 1-9 LW-12892 Thrust Button 3-5 LW-25-0.94 Bolt 2-3 LW-13323 Seat 3-7 LW-25-0.94 Bolt 2-7 LW-13353 Gasket 6-1 LW-25-0.94 Bolt 6-1 LW-13521 Bearing 3-1 LW-25-1.13 Bolt 1-9 LW-13790 Shaft 3-5 LW-25-1.13 Bolt 2-3 LW-13792 Seal 1-3 LW-25-1.13 Bolt 6-1 LW-13793 Stud 1-1 LW-25-1.25 Bolt 6-3 LW-13796 Shaft 1-7 LW-25-1.50 Bolt 1-9 LW-13884 Bearing 1-3 LW-25-1.50 Bolt 2-3 LW-13923 Bushing 3-1 LW-25Hl.OO Bolt 2-7 LW-14077 Pin 3-1 LW-25S1.50 Bolt 1-9 LW-14230 Cushions 4-1 LW-25-1.75 Bolt 1-9 LW-14260 Seal 2-3 LW-31HO.75 Bolt 5-5 LW-14326 Alternator 5-3 LW-31HO.88 Bolt 1-7 LW-14432 Bracket 6-7 LW-31-0.94 Bolt 5-5 LW-14727 Gage Assy. 1-3 LW-31-1.09 Bolt 5-2 LW-1491O Coupling 4-1 LW-31-1.16 Bolt 5-1 LW-14995 Spring 3-7 LW-38-0.75 Bolt 2-5 LW-15416 Adapter Assy., Mag. 4-1 LW-I0077 Seat 3-7 LW-15572 Starter 5-1 LW-I0382 Bracket 5-5 LW-15592-5-05 Hose 3-9 LW-11485 Shroud Tube Assy. 3-7 LW-15592-8-28 Clamp 6-3 LW-11713 Spring 1-3 L W -16266-25-13 Clamp 6-7 LW-11750-S Conn. Rod Assy. 3-1 LW-16471 Support Assy. 1-5 LW-11775 Plug 3-1 LW-16475 Seat 3-7 LW-11795 Spring 3-7 LW-16711 Bearing 1-3 LW-11800 Spring 3-7 LW-18085 Spring 1-3 LW-11997 Seal 1-3 LW-18639 Lockplate 1-5 LW-12098-0-130 Tube Assy. 6-7 LW-18661 Seal 3-7 LW-12098-0-140 Tube Assy. 6-7 LW-18667 Pin 1-7 LW-12098-0-180 Tube Assy. 6-7 LW-18840 Camshaft Assy. 1-7 LW-12098-0-280 Tube Assy. 6-7 LW-18959-175-25 Clamp 6-7 LW-12186 Nut 3-1 LW-19001 Valve 3-7 LW-12272 Lockplate 3-7 MS20823-6D Elbow 3-3

8-1

deggle01

Rectangle

,; £i; .t.): I Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE

NUMERICAL INDEX (Continued)


STD-8 Washer 1-9 STD-713 Cotter Pin 4-1 STD-8 Washer 2-3 STD-713 Cotter Pin 5-5 STD-8 Washer 2-5 STD-783 Plug 2-5 STD-8 Washer 2-7 STD-784 Plug 2-1 STD-8 Washer 6-1 STD-784 Plug 2-7 STD-8 Washer 6-3 STD-853 Tee 6-7 STD-8 Washer 6-5 STD-872 Nut 1-9 STD-33 Washer 1-9 STD-872 Nut 5-5 STD-33 Washer 2-5 STD-I065 Dowel 1-5 STD-35 Washer 2-3 STD-1339 Plug 1-1 STD-35 Washer 2-5 STD-1353 Insert 3-3 STD-35 Washer 3-3 STD-1409 Nut 1-9 STD-35 Washer 5-1 STD-1410 Nut 2-5 STD-35 Washer 5-5 STD-1410 Nut 3-3 STD-35 Washer 6-5 STD-1410 Nut 4-1 STD-160 Washer 1-9 STD-1410 Nut 5-1 STD-160 Washer 2-3 STD-1410 Nut 5-2 STD-160 Washer 2-5 STD-1410 Nut 6-5 STD-160 Washer 2-7 STD-1411 Nut 1-9 STD-160 Washer 6-1 STD-1411 Nut 2-5 STD-160 Washer 6-3 STD-1411 Nut 3-7 STD-425 Washer 6-7 STD-1421 Nut 6-7 STD-475 Washer 2-5 STD-1420 Nut 2-3 STD-475 Washer 3-3 STD-1623 Insert 1-1 STD-475 Washer 4-1 STD-1727 Washer 5-5 STD-475 Washer 5-1 STD-1821 Hose 3-9 STD-475 Washer 5-2 STD-1925 Screw 3-9 STD-475 Washer 6-5 STD-2090 Nut 3-5 STD-514 Dowel 1-1 STD-2168 Nut 1-7 STD-551 Plug 6-1 STD-2213 Screw 1-5 STD-553 Screw 6-7 STD-2231 Ring 1-7 STD-557 Dowel 1-1 25C-8 Stud 3-3 STD-596 Nut 1-9 25C-ll Stud 2-1 STD-670 Nut 6-7 25C-12 Stud 2-1 STD-678 Washer 1-9 31C-12 Stud 1-1 STD-678 Washer 2-5 31C-12 Stud 2-1 STD-684 Nipple 3-9 31C-12 Stud 3-3 STD-690 Washer 5-5 31C-13 Stud 1-1 STD-692 Screw 6-7 31C-14 Stud 6-1

8-2

deggle01

Rectangle

,itti,!-):' Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE



38-13 Stud 1-1 69796 Dowel 1-1 38D-17 Stud 1-1 70310 Seal 3-7 50-15 Stud 1-1 LW-11997 Seal 3-7 383-B Nut 3-5 70484 Screen 6-1 1028-B Ball 1-3 71140 Fitting 2-7 1102 Plug 1-1 71481 Ring 3-5 1102 Plug 2-1 71610 Hook 3-9 1102 Plug 3-3 71611 Retainer 3-9 1102 Plug 6-1 71712 Intake Pipes 6-3 1102 Plug 6-3 71713 Intake Pipes 6-3 1102 Plug 6-7 71973 Gasket 6-5 1182-17 Spark Plug 4-1 72057 Seat 3-3 1540 Plug 2-7 72058 Seat 3-3 60009 Key 3-7 72059 Gasket 1-3 60096 Gasket 2-5 72075 Seal 1-3 60430 Cover 2-5 72091 Ring 1-3 60803 Strap 1-9 72155-S Bushing 1-5 61084 Spring 1-3 72312 Ring 1-3 61174 Shaft 2-3 72566 Gear 1-5 61183 Gasket 2-5 72877 Body 1-3 61247 Cover 3-9 73152 Bracket 6-7 61400 Stud 6-1 73346 Flange 6-3 61544 Plunger 1-7 73383 Lockplate 5-5 61681 Guide, Intake 3-3 73437 Rod Assy. 3-5 62224 Gasket 4-1 73818 Gasket 2-1 62417 Plug 2-7 74230 Guide, Exhast 3-3 65098 Fuel Pump Cover 2-5 74241 Ring 3-1 65441 Seat 3-7 74323 Strut 5-5 66610 Bushing 3-3 74637 Bushing 3-5 66796 Insert 3-3 74887 Spacer 3-5 68668 Spring 1-3 74996 Gear Assy. 1-7 68759 Tube Assy. 3-9 75061 Bolt 3-1 68760 Tube Assy. 3-9 75072 Gear Assy. 1-7 68761 Tube Assy. 3-9 75089 Piston 3-1 69106 Cover 2-5 75154 Stud 1-1 69551 Gasket 2-5 75339 Baffle Assy. 3-9 69602 Connection 6-1 75380 Link 5-5 69603 Hose 6-3 75444 Adapter Assy., Fuel 6-3

8-3

deggle01

Rectangle

lit,i.t.,:. Lycoming HO-360-CIA PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE



75656-S Bushing 1-7 37A19773-376 Belt, Alternator 5-3 75657-S Bushing 1-7 56A22204 Sump Assy. 6-1 75888 Stud 2-1 61E22121 Carburetor 6-5 75906 Gasket 3-9 63D21408 Nipple Assy. 6-7 76118 Spacer 1-7 66GP-OSANN Magneto 4-1 76121 Shaft Assy. 1-7 66GR25SANN Magneto 4-1 76220 Stud 1-9 66M21195 Clamp 4-1 76534 Shim 5-5 67P20400 Harness Assy. 4-1 77154 Gasket 6-7 67P20403 Harness Assy. 4-1 77309 Bushing 1-7 77416 Plug 1-5 77467 Spring 1-3 77808 Valve Assy. 1-3 77962 Adapter 1-3 78290 Plunger Assy. 3-7 78531 Body 2-3 0IPI9762-9-48 Bag Attaching 4-1 02A22046 Tee 6-7 05K19423-S Impeller Kit 2-3 06B21644 Gasket 2-7 06EI9769-0.63 Gasket 2-7 06E19769-1.00 Gasket 6-1 06E 19769-1.25 Gasket 1-3 IIB20061-3SL Crankcase Assy. 1-1 13B27123 Crk'shft & Bush. Assy. 1-5 13S19646 Gear 1-5 14H21950 Ring 3-1 15B21319 Socket 3-7 15F19957-34 Rod Assy. 3-5 15F19957-35 Rod Assy. 3-5 15F19957-36 Rod Assy. 3-5 17C19386 Cap 3-7 17C21191 Key 3-7 17F19357 Rocker Assy. 3-5 18A19441 Bearing 1-3 21A21533-24 Housing Assy. 2-1 21M21643 Cover 2-7 31B22111 Starter 5-2 32C19553 Alternator Assy. 5-3 36B194~4 Pulley 5-3

8-4

deggle01

Rectangle

Lycoming Aircraft Engines Parts Catalog · Lycoming Aircraft Engines Parts Catalog. Part No....

Documents

Transcript of Lycoming Aircraft Engines Parts Catalog · Lycoming Aircraft Engines Parts Catalog. Part No....