Ks2300 t3 Specs Rev2
-
Upload
sunthron-somchai -
Category
Documents
-
view
213 -
download
0
Transcript of Ks2300 t3 Specs Rev2
-
8/19/2019 Ks2300 t3 Specs Rev2
1/2
PowerLine ™ Model KS2300-T3 23 kWe Generator
General Information
- The generator set rating is 21 kilowatts prime power output and 23 kilowatts intermittent or
standby power output. These ratings are based upon standard rating conditions. It may be
necessary to derate the set’s output for altitudes above 5’ !15 meters" or for ambienttemperatures above 1# $ !# %". &lease contact the manufacturer for details on ratings
criteria for the engine and generator or for derate information.
- The engine and brushless four pole '% generator are directly coupled and mounted on a
rugged steel base frame. 'll components are suitable for prime or intermittent usage.- The entire set is thoroughly load tested prior to shipment.
Standard Engine
- (ubota diesel model )23*+*T*,-. In*line turbocharged four cylinder engine with full
flow replaceable lube oil fuel and air filters. /lectronic speed governing provides
isochronous speed regulation no load to full load. /&' certification is 0Interim Tier #.
- iuid cooled with industrial grade radiator and belt driven blower fan.
- 4'/ housing and flywheel directly connected single bearing generator. !%% rotation"
Standard Generator
- 6ewage 4tamford brushless four pole !17 rpm" generator.
- 4olid state 89* 1: automatic voltage regulation.
- %4' approved construction.
Standard Control and !""eorie
- (ey start panel with oil pressure coolant temperature hour meter and glow plug indicator.
- +anual safety shutdown over*ride fuse protection.
- 4afety shutdowns energi;ed*to*run for low oil pressure9high coolant temperature.
- $our anti*vibration mounts between generator set and base frame.
- /lectric fuel transfer and priming pump !12 )
-
8/19/2019 Ks2300 t3 Specs Rev2
2/2
Engine Te"#ni"al Information
+anufacturer (ubota
+odel )23*+*T*,-
%ylinders $our ,ore = 4troke 73.mm = >2.#mm
!3.2? = 3.@#">> cc !122 cu.in."
Autput inter. 2?.1 km [email protected] B&"
Autput cont. 2#.5 km !32.> B&"
%omp. ratio 21.?C1
/ngine weight 27 kg !#5> lbs." dry
$%el S&tem
$uel type D2 psi" maJ
$an type ,lower 6ylon
ater pump -ear case mountedType %entrifugal belt drive
Thermostat aJ pellet type4tat. cracking temp. ?1% !1@$"
Cooling S&tem* "ont+d,
$ully open stat. temp. 75% !175$"
Fecommended coolant 595KKse low silicate ethylene glycol and high
uality water. %onsult manufacturer for details.'ir*to*boil L >.5 ke 5% !122$"
%ooling air reuired #2.51 m39min
!152 cfm"
E#a%t S&tem
+uffler type Industrial grade
+ounting )ertical with rain capFestriction 37mm !1.5" Bg maJ.
.oie Le/el 1 m 3,3+
evels are with industrial grade muffler and open
!no enclosure" configuration.
$ull load inter. 7#.7 d, !'"
$ull load prime 7#.@ d, !'"
6o load 71.5 d, !'"
Generator Te"#ni"al Information
+anufacturer 6ewage94tamford
+odel &I1##/ !4tandard"
%onstruction $our pole brushless
Apen drip*proof !I&23"
4ingle bearing
/Jcitation !std." $ull wave bridge rectifier
/Jcitation !opt." 0/Jcitation ,oost 4ystem
* &rovides up to 3: current for motor starting%ooling air flow ?.3 m39min !251 cfm"
eads # or 12 application dependent
@ B; voltages and ratings* 1>.921. k 1>.921. k)' 115923 H 1
* 21.923. k [email protected].?5 k)' 12927 H 3
* 21.923. k [email protected].?5 k)' 2??9#7 H 3
5 B; M other voltages are available.
&ower $actor 4ingle phase ratings L 1. &$
Three phase ratings L .7 &$
)oltage reg. '4#7 solid state
89* 1: 6 *N $
Temp. rise 15% rise &rime !#% ambient"
125% rise Intermittent !#%"
Tel. interference TB$ O 2:inding pitch Two thirds
%ontrol system 4elf eJcited!n"illar& E4%i5ment
+ounting 4teel base with mounting holes
Isolators $our composite mounts
CS! a55ro/ed "ontr%"tion