EXHIBIT E ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS ...skofirm.com... · ACCEPTABLE...
Transcript of EXHIBIT E ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS ...skofirm.com... · ACCEPTABLE...
Ghent Environmental Air Compliance Project KU Exhibit E
EXHIBIT E
ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS
GHENT STATION
The following sub-suppliers have been pre-approved by the Buyer/Engineer to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If the Seller proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to the Buyer/Engineer for approval. Any cost savings to the Seller shall be credited to the Buyer if a substitute sub-supplier is requested and approved. Sufficient data must be provided to the Engineer in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, the Seller shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Buyer’s discretion. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by the Buyer and should be used for base bid purposes. Some Components are preferred by different stations; these are noted in the list and should be used as base bids for the specific station. Where no sub-supplier is named, the Seller shall select based on previous successful service in similar utility power plant applications. The Seller shall indicate on the fill--in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by the Seller. COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Electric) AUMA Actuators Inc. (E645.1.3)
Rotork (E645.1.3) Limitorque Corp. (E645.1.3) Harold Beck &Sons, Inc. (E645.1.3) (Preferred) Rexa
Actuators (Pneumatic) Air Compressor (Screw)
Worcester Bettis Fisher Masonelian Atlas Copco Capital Machinery Systems Ingersol Rand National Pump and Compressor
Aluminum Pigmented Mastic Foster No. 35-01 (15941.1.6)
ANSI/IEEE Vendors Cleveland Switchboard (16120.1.6) Cutler-Hammer (16120.1.6) GE Electrical Distribution and Control (16120.1.6) Group Schneider – Square D (16120.1.6) Keystone (16120.1.6) Siemens (16120.1.6)
Area Lighting In-line Fused Connectors Bussman (16501.1.6)
Page 1 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Auxiliary Relays Allen-Bradley Bulletin 700 Type P (E530.2)
(Preferred) Allen-Bradley Bulletin 700 Type PK (E530.2) General Electric Type HFA or HGA (E530.2) Westinghouse Type MG-6 (E530.2) Allen –Bradley Type 700P, IDEC Potter and Brumfield (Tyco) type KRP (E530.2) Square D Cutler-Hammer (Eaton)
Belf (FMK) DuPont Viton B Polymer with "C" cure or 3M Fluoroel terpolymer (01503.2.19.3.1)
Caulking Compounds (exposed conditions) Tremco “Dymonic” (07410.1.6) Pecora “Dynatrol l” (07410.1.6)
Caulking Compounds (Non-exposed conditions) Tremco Curtain Wall Sealant(07410.1.6)
Caulking Tape Tremco "MBT" Metal Building Tape (07410.1.6) Pecora "BB-50" ExtruSeal (07410.1.6) Protective Treatment Inc., "606 Sealant Tape" (07410.1.6)
Compressed Air Fittings (Grip/Compression Style) Clampett Parker CPI
Compressed Air Fittings (Threaded) Parker CPI IMM (Preferred) Connectors (Special) Gray Tool Company (15221.1.6)
Anchor Darling Pressure Seal (15221.1.6) Connections (Thermowell) Bonney Forge (15221.1.6)
WFI (15221.1.6) WOI (15221.1.6)
Contactors Allen-Bradley (15920.1.5) (Preferred) Cutler-Hammer GE Square D
Contactors (Lighting) ASCO (16501.1.6) Cutler-Hammer (16501.1.6) General Electric (16501.1.6) Siemens (16501.1.6) Square D (16501.1.6)
Control Component Devices Allen-Bradley (Preferred) Cutler-Hammer GE Square D
Control Panel (Temperature) Hoffman Engineering Company (15920.1.5) Honeywell (15920.1.5) Johnson Controls (15920.1.5)
Controllers (Local) Fisher 2502 for Level (K100.9) Fisher 4160 or 4195 Series for Pressure (K100.9) Fisher 4166 or 4196 Series for Temperature (K100.9) Foxboro 43AP series (K100.9)
Page 2 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Controllers (Photoelectric) Fisher Pierce N7790B (16501.1.6)
Tork Electric (Preferred)
Convenience Receptacles (Duplex and Single) Hubbell (Generic Cat. No. 5362) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Duplex, gray for finished areas, brown for unfinished areas)
Hubbell (Generic Cat. No. 5362) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Single, gray for finished areas, brown for unfinished areas)
Hubbell (Generic Cat. No. 5361) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Kitchen Range and Clock Outlet)
Hubbell (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Isolated Ground) Hubbell (Generic Cat. No. IG5362) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Ground Fault Interrupting)
Hubbell (Generic Cat. No. GF20L) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Hazardous Rated, Class I, Group D and Class II, Group F areas)
Appleton EFS "U-Line" or Crouse-Hinds ENR Series (16501.1.6)
Convenience Receptacles (Isolated Ground) Hubbell (Generic Cat. No. IG5362) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Damaged Galvanizing and Bare Steel Re-galvanizing
American Solder and Flux Company “Galvanizing Powder M-321” (11503.1.7) Industrial Metal Protectives, Inc. “Zincilate 810” (11503.1.7) ZRC Chemical Products Company “Zinc Rich” (11503.1.7)
Dampers American Warming & Ventilating (15820.1.5) Ruskin Arrow United (15820.1.5) Cesco Products (15820.1.5) Greenheck (15820.1.5)
Page 3 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Dampers (guillotine or louver man-safe isolation, or louver control)
Wahlco Metroflex NEM Power TLT Bachman Clyde Bergemann Bachmann Effox
Detectors (Resistance Temperature) Pyromation (K100.4.2)
Pico (K100.4.2) STI Manufacturing (K100.4.2) JMS Southeast, Inc. – Statesville, NC USA (K100.4.2) Sandelius Instruments – Houston, TX (K100.4.2) TSC – Garland, TX (K100.4.2) Rosemount (Preferred)
Device Plates (unfinished areas) Crouse-Hinds (16501.1.6) Appleton (16501.1.6)
Device Plates (finished areas) Hubbell (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Device Plates (Weatherproof Single Receptacle) Crouse-Hinds WLRS-1 (16501.1.6) Appleton (16501.1.6)
Device Plates (Weatherproof Duplex Receptacle) Crouse-Hinds WLRD-1 (16501.1.6) Appleton (16501.1.6)
Device Plates (Weatherproof Switch Device Plates)
Crouse-Hinds DS185 (16501.1.6) Appleton (16501.1.6)
Desiccant Activated Aluminum Alcoa “Type H151” or “Rhone-Poulenc” (11503.1.7)
Detectors (admittance type high ash level) Drexelbrook Engineering (11503.1.7) Colconda (11503.1.7) Bindicator (11503.1.7) Princo Instruments (11503.1.7) Ohmart Vega
Detectors (Powder level) Drexelbrook Engineering Company (05175.1.7)
Milltronics Baker Bonnert Ohmart Vega
Dew Point Test Apparatus EG&G Chandler Engineering Company “Catalog No. 13-75 with thermometer No. 13-2” (15212.1.6)
Direct Digital Control System (Temperature Control Panel)
Emerson Ovation DCS
Direct Digital Control System (Network Controllers) Emerson Ovation DCS
Direct Digital Control System (Application Specific Controllers)
Emerson Ovation DCS
Page 4 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Direct Digital Control System (Operator Programming Unit)
Emerson Ovation DCS
Direct Digital Control System (Pressure Sensors) Johnson Controls (15920.1.5)
Siemens (15920.1.5) Automatic Logic (15920.1.5) Rosemount Yokogawa (preferred)
Direct Tension Indicators (DTIs) TurnaSure LLC (05120.1.6
Doors (Fire Rated) Amweld “Series 3700” (08100.1.6) Ceco “Regent” (08100.1.6) Mesker “PyroDor” (08100.1.6) Pioneer “Series C” (08100.1.6)
Doors (Grade II, Model 3) Ceco “Regent” (08100.1.6) Pioneer “CH” (08100.1.6)
Doors ( Grade II, Model 4) Amweld “Series 3700” (08100.1.6) Ceco “Regent” (08100.1.6) Mesker “PyroDor” (08100.1.6) Pioneer “Series C” (08100.1.6)
Doors (Grade III, Model 5) Amweld “Series 300” (08100.1.6)
Doors (Insulated Rolling Steel) Atlas “Thermal Series” (.08330.1.6) Cornell “Thermiser” (.08330.1.6) Overhead Door “625” (.08330.1.6)
Doors Sliding Chase Doors (Saino), Electric Power Door (08200.1.6)
Doors Sliding (Clear Glass) L-O-F "Tuf-Flex" or PPG "Herculite" (08200.1.6)
Dry Sorbent Injection System Nol-Tec BSCI
Electronic Control Systems (Temperature Control Panels)
Hoffman Engineering Company (15920.1.5)
Electronic Control Systems (Airflow Switches) Dwyer (15920.1.5)
Electronic Control Systems (Draft Gauges) Dwyer (15920.1.5)
Electronic Control Systems (Duct Thermostat) Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Fan Control Thermostat)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Pressurization Sensors & Pressure Indicators)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5) Rosemount Yokogawa (preferred)
Page 5 of 21
Ghent Environmental Air Compliance Project KU Exhibit E
Electronic Control Systems (Room Thermostats and Humidistats)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Shielded Room Static Pressure Sensor)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Static Outside Probe) Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Expansion Anchor Hilti Kwikbolt (08100.1.6) ITT Philips Red Head Wedge and Sleeve Anchors (08100.1.6) Ramset Trubolt and Dynabolt (08100.1.6) Drilco Maxi-Bolt (08100.1.6)
Expansion Joints (Slip Type) ADSCO (15244.1.6) Expansion Joints (Bellows Type) RM Engineering (15244.1.6)
Papco Wahlco Lortz (metal expansion joints or penetrations)
Fans (Ceiling mounted centrifugal exhaust fan) Penn (15830.1.5)
Greenheck (15830.1.5) Loren Cook (15830.1.5) Twin City Fan – Commercial (15830.1.5)
Fans (Centrifugal) Aerovent (15830.1.5) Hartzell, (15830.1.5) Twin City Fan - Industrial (15830.1.5) Howden
Fans (Centrifugal exhaust) Penn (15830.1.5) Greenheck (15830.1.5) Loren Cook (15830.1.5) Twin City Fan – Commercial (15830.1.5)
Fans (propeller) Aerovent (15830.1.5) Hartzell, (15830.1.5) Twin City Fan - Industrial (15830.1.5) American Warming & Ventilating
Fans (Venaxial and Tubeaxial) Aerovent (15830.1.5) Hartzell, (15830.1.5) Twin City Fan - Industrial (15830.1.5) American Warming & Ventilating
Fans (power roof ventilation wall fans) Aerovent (15830.1.6) Buffalo Forge Industrial Air Fan American Warming & Ventilating
Page 6 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Fasteners Best Quality Fabco self-tapping (07410.1.6)
Buildex TEKs self-drilling, self-tapping screws (07410.1.6)
Fiberglass bag material acid resistant coatings (Pulse Jet Fabric Filter Bags)
I625 by BFG, Acid-Guard(TM) by J.P. Stevens, or equivalent equal (01503.1.7)
Filter Regulators Fisher 67CFR (K100.9)
Filters (Bin Vent) Mikropul-Hosokawa (05175.1.7) Mac Equipment Company (05175.1.7) Fuller Bulk Materials (05175.1.7) United Conveyor Corp. (05175.1.7) Allen-Sherman-Hoff (B&W/Diamond Specialty Equipment) (05175.1.7) Flex-Kleen (05175.1.7) Industrial Accessories Company (05175.1.7) Torit (05175.1.7)
Fire Protection System (Heat Detection) Fenwal “21500 Series” Rate Compensated (13902.1.6)
Fittings (Integrally reinforced branch outlet fittings) Bonney Forge (15221.1.6)
WFI (15221.1.6) WOI (15221.1.6)
Fittings (PP lined, PVDF lined, and PTFE lined) Dow Chemical Company Resistoflex Corporation Peabody Dore
Fittings Rubber lined Dow Chemical Company
Fittings FRP Centrifugally cast Fibercast Company – Fibercast
Fittings FRP Filament wound Ameron Corrosion Control Division - Bondstrand Reinforced Plastics Systems Inc. - ABCO Plastics Division Smith Fiberglass Products Inc. Fibercast Company – Fibercast
Fittings HDPE Factory Mutual (FM) approved Phillips Petroleum Company - Driscopipe 1000 FM Class 200
Amsted Industries - Plexco EHMW - Class 200 - FM Bluestripe - Class 200 - FM Redstripe - Class 200 - FM Poly Systems Incorporated, KWH Class 200
Fittings HDPE Non-FM applications Phillips Petroleum Company - Driscopipe 1000 Amsted Industries - Plexco PE 3408 Poly Systems Incorporated, KWH – Sclairpipe
Fittings - Tubing Parker CPI
Fluorescent Dimming System Lutron Grafik Eye series (16501.1.6)
Page 7 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Flow Elements Daniel Industries
Fluidic Techniques Vickery-Simms Vickery Simms/Fluidic Techniques (K100.14) Triad (K100.14) Dieterich Standard (K100.14) Primary Flow Signal (K100.14) Daniel Measurement and Control (K100.14)
Fuses (Slow Blow) Gould Shawmut/GDL (E530.7) Bussman/MDL (E530.7)
Frames Amweld “Series 400” (08100.1.6) Ceco “SF” or “CF” (08100.1.6) Pioneer “Series F Integral” (08100.1.6)
Fuses (Fast Acting) Gould Shawmut/OT (E530.7) Bussman/NON (E530.7)
Fuses (Extremely Fast Acting)
Bussman/KAB (E530.7) Gould Shawmut
Gaskets (Compressed Fiber) Richard Klinger, Inc. – Klingersil (15225.1.6) Garlock, Inc. – Blue-Gard (15225.1.6)
Gaskets (Cloth Inserted Rubber) Manville (15225.1.6)
Gaskets (Spiral Wound) Flexitallic Gasket company (15225.1.6) Garlock (15225.1.6)
Gasket (Spiral Wound Filler) Flexitallic Gasket Company – Flexite Super (15225.1.6) Garlock (15225.1.6)
Glass (Tempered (Clear or Tinited)) L-O-F “Tuf Flex” (08100.1.6) PPG “Herculite” (08100.1.6)
Heater (Electric Unit, Cabinet, and Baseboard) Bransch (15760.1.6) Chromalox (15760.1.6) Markel (15760.1.6) Reddi (15760.1.6) Indeeco (15760.1.6)
Heaters (Throat and Poke Hole) Bylin Heating Systems “Flexible Blanket” (11503.1.7) Hotfoil (11503.1.7)
Heater (Electric Duct) Brasch (15760.1.5) Indeeco (15760.1.5)
Heater (Electric Unit) Brasch (15760.1.5) Modine (15760.1.5) Indeeco (15760.1.5)
Page 8 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Heater (Electric Cabinet) Brasch (15760.1.5)
Modine (15760.1.5) Indeeco (15760.1.5)
Heater (Electric Baseboard) Brasch (15760.1.5) Modine (15760.1.5) Indeeco (15760.1.5)
High Strength Bolts Approved US Supplier (05120.1.6)
Homopolymer Acrylic Material Rychem (11503.1.7) Dolonit (11503.1.7)
Hopper Heaters Isopad (Hotfoil) Bylin Heating Systems, Inc. “Type HT Heating Modules” (11503.1.7) Hotfoil “Type HB Heating Modules” (11503.1.7)
Hoses (rubber or wash down) Gates IMM prefered
Goodall Rubber Co.(Type H butyl and other flexible) (15245.1.6) Rubber Engineering Federal Hose Mfg. (15245.1.6) Universal Metal Hose (15245.1.6) Flexonics, Inc. (15245.1.6) American Boa, Inc. (15245.1.6) Flexible Metal Hose Co. (15245.1.6)
Indicators (pressure) Wika (preferred) Rosemont Perma-Cal Industries111TIDxxAx3LT (K100.2.1) Weksler AA44 (K100.2.1) 3-D Instruments Accu-Drive Series 25 (K100.2.1) Dwyer Series 4000 (K100.2.1)
Indicators (temperature) Wika (K100.2.2) (preferred)
Insulated Rolling Steel Doors Atlas “Thermal Series” (08330.1.6) Cornell “Thermiser” (08330.1.6) Overhead Door “625” (08330.1.6)
Integrally Reinforced Forged Branch Outlet Fittings Bonney Forge (15221.1.6) (15225.1.6) WFI (15221.1.6) (15225.1.6) WOI (15221.1.6)
Insulation (Calcium Silicate) Industrial Insulation Group (15941.1.6) LLC “Calsilite” (15941.1.6)
Insulation (Elastomeric Antisweat) Armstrong “Armaflex” (15941.1.6)
Adhesive for Elastomeric Antisweat Insulation Armstrong 520 Adhesive (15941.1.6)
Insulation (Fiberglass) CertainTeed Manson (15941.1.6) Owens-Coming (15941.1.6) Johns –Manville Corp
Insulation (Inert Organic Free Flowing Particle) Protexulate (15941.1.6) Page 9 of 21
Ghent Environmental Air Compliance Project KU Exhibit E
Insulation (Mineral Fiber) Delta “Rock Wool” (15941.1.6)
Fibrex (15941.1.6) Industrial Insulation Group (15941.1.6)
Insulation (Perlite) Industrial Insulation Group (15941.1.6) LLC “Sproulle” (15941.1.6) Knauf “Innova” (15941.1.6)
Insulation (Treated Rigid Fiber) Owens-Coming (15941.1.6)
Insulation – Welded Studs for Attachment Nelson (15941.1.6)
Joint Sealant Foster No. 30-45 (15941.1.6) Lamps General Electric (16501.1.6)
Osram Sylvania (16501.1.6) Phillips Lighting (16501.1.6)
Louver (Vertical Storm Proof) Ruskin Manufacturing EME6625 (01500.1.1.32) Arrow United Industries EA-662-VSL (01500.1.1.32) Cesco Products ASL-6 (01500.1.1.32) Construction Specialties R5-5605 (01500.1.1.32) Pottorff ECV-645 (01500.1.1.32)
Lighting Abolite Crouse Hinds (preferred) General Electric (16501.1.6) Holophane Lithonia Stonco
Lighting (area in-line fused connectors) Bussman (16501.1.6) Lighting (contactors) ASCO (16501.1.6)
Cutler-Hammer (16501.1.6) General Electric (16501.1.6) Siemens (16501.1.6) Square D (16501.1.6) Allen-Bradley (preferred)
Meter (Panel) Yokogawa (E530.7) Weschler Electric Corporation (E530.7) Crompton Instruments (E530.7)
Meter (Switch-Board)
Yokogawa (E530.7) Weschler Electric Corporation (E530.7) Crompton Instruments (E530.7)
Motors (Low Voltage)
General Electric (E642.1.3) Reliance (E642.1.3) U.S. Motors (E642.1.3) Toshiba (E642.1.3) Siemens (E642.1.3) Marathon (E642.1.3) TECO-Westinghouse Electric Machinery
Page 10 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Motors (Medium Voltage)
General Electric Reliance TECO-Westinghouse Siemens Toshiba
Photoelectric Controllers Fisher Pierce N7790B (16501.1.6) Tork Electric (preferred)
Pipe Supports Basic Engineers
Grinnell Corp. (15062.1.6) Power Piping Lisega (15062.1.6) Fronek (15062.1.6) Carpenter & Patterson Bergen-Power (15062.1.6)Pipe Supports Limited (15062.1.6) Piping Technology, Inc. (15062.1.6)
Piping (FRP for slurry or water) ABCO RPS (preferred) Smith (Ghent preferred) Fibrex Bondstrand – Ameron Corrosion Control Division (15225.1.6) Plastics Division (15225.1.6)’ Fibercast Company (Centrifugally cast and Filament wound) (15225.1.6) Associated Tube Industries Hastelloy C-276 B622 BrisMet Hastelloy C-276 B622
Piping (HDPE, Factory Mutual Approved) Phillips Petroleum Company “Driscopipe 1000 FM Class 200” (15225.1.6) Amsted Industries – Plexco “EHMW – C;ass 200 - FM”, “Bluestripe – Class 200 – FM”, “Redstripe – Class 200 - FM” (15225.1.6) Poly Systems Incorporated “KWH Class 200” (15225.1.6) ISCO
Piping (HDPE, Non-FM Applications) Phillips Petroleum Company “ Driscopipe 1000” (15225.1.6) Amsted Industries “Plexco PE 3408” (15225.1.6) Poly Systems Incorporated “KWH - Sclairpipe” (15225.1.6) ISCO
Piping (Nickel Alloy Steel) Carpenter Steel Company “Carpenter 20Cb-3” (15225.1.6)
Piping (PP lined, PVDF lined, PTFE lined) Dow Chemical Company (15225.1.6) Resistoflex Corporation (15225.1.6) Peabody Dore (15225.1.6)
Plastic Instrument Enclosures Anderson Greenwood Company (17220.3.4) Cellex Div. of Thermon (17220.3.4) Intertech (17220.3.4) O’Brien Corporation (17220.3.4)
Page 11 of 21
Ghent Environmental Air Compliance Project KU Exhibit E
Piping (rubber lined for slurry) (not for use with gypsum)
ARDCO Holz Rubber Company Rubber Engineering Dow Chemical Company (15225.1.6)
Plug Resistant Orifices CU Services (15248.1.6)
Post Installed Mechanical Anchor Bolts Hilti Kwik-Bolt TZ (15062.1.6)
Positioner Masoneilan SVI2AP (Control Valves) (preferred) Beck (Dampers & Electric Operated Valves) Westlock ICOT
PPS Material Im-Tech “Procin” (11503.1.7) Amoco “Ryton” (11503.1.7)
Preformed Aluminum Elbows for Pipe Jacketing Nelson (15941.1.6)
Pressure Indicator (Wetted Parts) 3-D Instruments Accu-Drive Series 25 Perma-Cal 111TIDxxAx3LT Dwyer Series 4000 WIKA
Programmable Logic Controllers (PLC) Rockwell Control Logics (Allen-Bradley) “PLC5” or “SLC500” (17053.1.6)
Protective Coatings at Access Doors Ameron PSX 738 (11503.1.7) Pressure Switch -Gauge Dwyer Instruments, Inc. – (Capsu-Photohelic)
(K100.3.1) S-O-R, Inc (K100.3.1). (preferred) United Electric (K100.3.1) Barksdale ASCO Ashcroft
Pressure Switch - Differential (Static Pressure < 500 psi)
Dwyer Instruments, Inc. – (Capsu-Photohelic) (K100.3.1) S-O-R, Inc (K100.3.1). (preferred) United Electric (K100.3.1) Barksdale ASCO Ashcroft
Pressure Switch - Differential (Static Pressure > 500 psi)
Dwyer Instruments, Inc. – (Capsu-Photohelic) (K100.3.1) S-O-R, Inc (K100.3.1). (preferred) United Electric (K100.3.1) Barksdale ASCO Ashcroft
Page 12 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Relays – Protective Type for Motors, Transformers and Switchgear
General Electric/Multilin (16125.4) (preferred) Basler I-T-E Electrical Products (Transformers) (16125.4)
Signal Converters (electric to pneumatic) Rosemount 3311 (K100.13)
Foxboro E69F (K100.13) ITT – Conoflow GT 8 (K100.13) Moore Industries Action Pak Rochester
Silencers Glynn-Johnson 64 (08100.1.6) Universal
Strapping for Support of Insulation on Vertical Pipe Runs
Acro Metal Stamping Co. “Acroflex” (15941.1.6)
Structural Steel Expansion Bearing Assembly
Merriman “Lubrite” (11503.1.7)
Switches (Control)
General Electric Type SB-1 with large cover (E530.7) General Electric Type SB-10 with large cover (E530.7) Electro-Switch Type 24 (E530.7) Electro-Switch Type W (E530.7) Electro-Switch Type 20K (E530.7)
Switches (Dimmers) Lutron “NOVA” series (16501.1.6)
Switches (Disconnect) Square D (16430.5) Switches (Level Switch – Enclosed Cage, 2SPDT) Magnetrol (K100.3.2)
International (K100.3.2) S-O-R, Inc. (K100.3.2)
Switches (Level Switch – Float Type, SPDT) Warrick Series “M” (K100.3.2) ITT Flygt ENM 10 Series (K100.3.2)
Switch Flow (SPDT) Manufacturer’s Standard
Switches (Four way) Hubbell (Generic Cat. No. 1224) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Momentary Contact) Pass & Seymour (16501.1.5) Cooper Wiring (16501.1.5) Leviton (16501.1.5)
Switches (Position Switch – Mechanically Actuated NAMCO Controls EA-170 (K100.8) Honeywell Microswitch Type LS (K100.8) Allen-Bradley (A-B) 802T-ATP (K100.8) Cutler-Hammer
Switches (Proximity) Topworx (Go Switch) 7G23528-A2 (K100.8)
Page 13 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Switches (Push Buttons and Selector Switches) Allen Bradley 800H Series, corrosion resistant
(E530.7) Square D Class 9001 Type K (E530.7) Cutler-Hammer
Switches (Gas Filled Temp.) Allen-Bradley Bulletin 837 (K100.3.1)
Ashcroft Type 400B (K100.3.1) United Electric Series 400 (K100.3.1) S-O-R, Inc. (K100.3.1)
Switches (Selector) Allen-Bradley 800H or 800P, Square D (15920.1.5) Cutler-Hammer
Switches (Single-Pole) Hubbell (Generic Cat. No. 1221) (16501.1.6)
Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Three Way) Hubbell (Generic Cat. No. 1223) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Three-way, Four-way; Class I, Group D and Class II, Group F areas)
Appleton (16501.1.6) Crouse-Hinds “EDS” tumbler series (16501.1.6)
Switches (Toggle) Honeywell Micro Switch Type TL (E530.7)
Switches (Single-pole, gray for finished, brown for unfinished areas)
Hubbell (Generic Cat. No. 1221) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Two-pole) Hubbell (Generic Cat. No. 1222) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Three-way, gray for finished, brown for unfinished areas)
Hubbell (Generic Cat. No. 1223) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Four-way, gray for finished, brown for unfinished areas)
Hubbell (Generic Cat. No. 1224) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Switches (Three-way, Four-way, Class I, Group D and Class II, Group F areas)
Appleton (16501.1.6) Crouse-Hinds “EDS” tumbler series (16501.1.6)
Page 14 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Switchgear (LV & MV Load Centers) Teflon Slide Plates
ABB Eaton GE I-T-E Powell Siemens Square D Westinghouse Fluorocarbon Co. “Flurogold Type” (13503.1.6)
Terminal Block (Thermocouple Extension Wire) Manufacturer's Standard (E520.6)
Terminal Block (Feed-Through DCS I/O and PLC I/O)
Manufacturer's Standard (E520.6)
Terminal Block (Power 600V) Manufacturer's Standard (E520.6)
Terminal Block (General Purpose Feed-Through) Marathon 1500 (E520.6)
Terminal Block (Shorting) Marathon 1500 (E520.6)
Terminal Strips Entrelec (15920.1.5) Phoenis (15920.1.5) Weidmuller (15920.1.5) Marathon 1500 (15920.1.5)
Thermocouples RDF Temp-Pro YSI Inc. Rosemount Pyco Thermo-Electric Pyromation (K100.4.2) STI Manufacturing (K100.4.2) JMS Southeast, Inc.-Statesville, NC USA (K100.4.2) Sandelius Instruments – Houston, TX (K100.4.2) TSC – Garland, TX (K100.4.2) Conax
Thermowell Connections Bonney Forge (15221.1.6) WFI (15221.1.6) WOI (15221.1.6)
Timing Relays Agastat Series 7000 (E530.2) Agastat Series 7000, Intermatic (15920.1.5)
Transformers (Low Voltage Dry Type) General Electric (16125.4) Hevi Duty ABB Square D GE Sorgel Niagara
Page 15 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Transformers (Power and Load Center)
ABB Siemens Square D General Electric Delta Star Howard Kuhlman Pennsylvania Pacific Crest Niagara Waukesha
Transmitter (Flow) Rosemount – 3051 C or T (K100.6)
Krohne Yokogawa – EJA Series (K100.6) (preferred)
Anderson Greenwood, manifolds (K100.6) Transmitter (Flow) (Non-differential Pressure Types)
Micromotion (K100.6) Brooks/Daniel (K100.6) Rosemount (K100.6) Yokogawa (K100.6)
Transmitter (Level) Rosemount – 3051 C or T (K100.6) Ametek Drexelbrook Bindicator Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds (K100.6)
Transmitter (Level)(4-20 mA) Magnetrol International (K100.6) Rosemount –3051 C or T (K100.6) Ohmart Vega Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds for DP style transmitters (K100.6)
Transmitter (Pressure) Rosemount – 3051 C or T (K100.6) Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds (K100.6)
Transmitter (Vibration) Metrix (K100.16) Robertshaw (K100.16) Rockwell/Entek (K100.16) STI (K100.16) Bently Nevada (K100.16)
Truck Quick-Connect Camlok (05175.1.7)
Tubing Fittings Parker Hannifin CPI (15225.1.6)
Tubing – Grip Type Fittings Parker CPI
Tubing - Socket-Weld Fittings
Parker CPI
Uninterruptable Power Supplies Cyberex Ametek
Page 16 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Valve Manifolds
Anderson Greenwood
Valves (Back-Pressure) Conoflow (15263.1.6) Milton-Roy (15263.1.6) Pulsafeeder (15263.1.6) Sentry (15263.1.6)
Valves ( Bronze) Jenkins
Lunkenheimer William Powell Conbraco (15263.1.6) Crane (15263.1.6) Grinnell (15263.1.6) Nibco (15263.1.6) Powell (15263.1.6) Stockham (15263.1.6) Walwaorth (15263.1.6) Wheatley (15263.1.6)
Valves (Cast Iron) Anchor/Darling (15263.1.6)
Crane (15263.1.6) Grinnell (15263.1.6) KLM (15263.1.6) Newco (15263.1.6) Nibco (15263.1.6)
Valves ( Cast Steel) Bonney Forge Weir Valves & Controls American Evergy Services (15263.1.6) Atwood/Tricentric (15263.1.6) Cooper (15263.1.6) Crane (15263.1.6) Edward (15263.1.6) Grinnell (15263.1.6) Grove (15263.1.6) Newco (15263.1.6) Pacific (15263.1.6) Powell (15263.1.6) Stockham (15263.1.6) Velan (15263.1.6) Wheatley (15263.1.6) Milwaukee Valve Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Page 17 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Valves (Check) – Insert Type
Keystone/Anderson Greenwood Power & Process (Technocheck) Consolidated (15263.1.6) Dow (15263.1.6) Nupro (15263.1.6) Stockham (15263.1.6) Wheatley (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Check) – Tilting Disc
Anchor/Darling Atwood & Morhill Townley Pacific Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Diaphragm) Hills McCanna
ITT-Engineered Valve Dow (15263.1.6) GEMU (15263.1.6) ITT (15263.1.6) Saunders (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Forged Steel) Vogt Conbraco Industries Inc Yarway Bonney Forge (15263.1.6) Conval (15263.1.6) Crane (15263.1.6) Dresser-Hancock (15263.1.6) Edward (15263.1.6) Grinnell (15263.1.6) Newco (15263.1.6) Raimondii (15263.1.6) RP&C (15263.1.6) Velan (15263.1.6) Walthon Weir Pacific (15263.1.6) Whitey (globe valves) (15263.1.6) Milwaukee Valve Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Page 18 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Valves (Plastic) Asahi/America (15263.1.6)
Chemtrol (15263.1.6) Dresser (FRP valves) (15263.1.6) GEMU (15263.1.6)
Valves (Plug) Nordstrom/Tufline
Velan Newcon Dow (15263.1.6) Durco (15263.1.6) Grinnell (15263.1.6) Moestead (15263.1.6) Mueller (15263.1.6) Stockham (15263.1.6) Wheatley (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco Masoneilan
Valves (Segregation and hopper isolation) DeZurik (05175.1.7)
UCC (05175.1.7) Alstom Power (05175.1.7) ASH (05175.1.7) Fuller Bulk Handling (05175.1.7) Fabrivalve (05175.1.7) ITT (05175.1.7) Clarkson KGA (or KGD) (05175.1.7) Wye Valve (05175.1.7)
Valves (Manual) – Ball Anchor/Daring Edwards ITT-Engineered Valve Jenkins Neles-Jamesbury (15263.1.6) Parker Worcester Valves Apollo (15263.1.6) Dow (15263.1.6) Grove (15263.1.6) Hayward (15263.1.6) McCanna (15263.1.6) KTM (15263.1.6) Nibco (15263.1.6) Velan (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco Valve Technologies
Page 19 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Valves (Manual) – Butterfly Anchor/Darling
BIF Industries (15263.1.6) Dezurik (15263.1.6) Duriron/Durco Fisher Controls International Keystone (15263.1.6) Neles-Jamesbury Rodney Hunt (Allis Chalmers) Power & Process (Norris) Pratt Crane (15263.1.6) Dow (15263.1.6) Dresser (15263.1.6) McCanna (15263.1.6) Saunders (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Drain) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco Parker
Valves (Instrument Blowdown)
Parker
Valves (Instrument Equalizer) Anderson Greenwood
Valves (Instrument Shutoff) Parker
Valves (Instrument Tubing Support Tray) James C. White Company, Inc. Series “Tubetrack” (K120.7)
Valves (Regulating)
Manufacturer's Standard as acceptable to the Purchaser
Valves (Shutoff) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco Velan
Valve (Solenoid) (Type H) ASCO – EFHB8320G174xx (Brass ExP) (K100.7) ASCO – EFHB8320G200xx (Stainless Steel ExP) (K100.7) ASCO – JKH8320G172xx (Brass NEMA 4,<100 dp) (K100.7) ASCO – JKB8320G174xx (Brass NEMA 4) (K100.7)
Valves PreAction (Fire Protection) Match existing equipment (13902.1.6)
Variable Frequency Drives (VFDs), LV & MV Allen-Bradley (preferred) ABB Siemens
Page 20 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Vibration Monitoring Emerson CSI
Bently Nevada XL3300
Wall and Roof Panels Centria (07410.1.6) Fabral (07410.1.6) Morin (07410.1.6)
Weatherproof Coatings Manville “Insulkote” (15941.1.6)
Page 21 of 21