EMISSIONS MONITORING TEST REPORT JERSEY CREMATORIUM

EMISSIONS MONITORING TEST REPORT

JERSEY CREMATORIUM Westmount Road

St Helier Jersey JE2 3LP

27th - 29th January 2015

Report Authorised by Date 24th March 2015 Mr S P Atherton Business Manager EA MCertS Level 2 + TE1,2,3,4 MM 03 336

ST/DEM0753/27.01.15

ST/DEM0753/27.01.15/

CONTENTS

1. INTRODUCTION

2. PROCEDURES

2.1 Total Particulate Matter 2.2 Hydrogen Chloride 2.3 Mercury 2.4 Carbon Monoxide 2.5 Volatile Organic Compounds 2.6 Oxygen 2.7 Moisture 2.8 Temperature 2.9 Velocity and Volumetric Flow

3. RESULTS

TABLE 1 – No.1 Cremator Particulate & HCl Emission Results TABLE 2 – No.2 Cremator Particulate & HCl Emission Results TABLE 3 – Mercury Emission Results Tests 4, 5 & 6 TABLE 4 – Mercury Emission Results Tests 10, 11 & 12

4. COMMENTS

5. QUALITY CONTROL

APPENDIX 1 Data Logs and Calculations APPENDIX 2 Analysis Reports APPENDIX 3 Details of Test Cremation Charges

ST/DEM0753/27.01.15/

1. INTRODUCTION

The two cremators at Jersey Crematorium were monitored between the 27th - 29th January 2015 to the requirements given in the UK Process Guidance Note PG5/2 (2012) for emission releases to atmosphere.

The work involved monitoring a range of flue gas components with the plant operating normally.

The plant comprises two Cremators that are designated as the model FTII. Each cremator is fitted with two nozzle mix burners utilising gas as the support fuel. The installation has no form of flue gas treatment plant fitted to abate emissions.

The plant operates under full microprocessor based automatic control that requires little manual intervention.

The cremators were manufactured, installed and commissioned by Facultatieve Technologies Limited to meet the requirements of the Environmental Permitting (England and Wales) Regulations 2010 – (EPR 2010) as relevant to cremators, summarised in the Secretary of State’s Process Guidance Note PG 5/2 (2012).

The flue ducting and test points were in accordance with the requirements of EA TGN M1.

Measurements were undertaken to enable comparisons to be made of the operation of the cremator with the requirements of the Guidance Note in terms of emission releases to air.

Additional tests were carried out to determine the releases of mercury to atmosphere via the chimney over a number of cremation cycles at the request of the Regulator. As the cremators are unabated, reductions in the emissions of mercury are not possible, other than by reducing the mass of mercury introduced to the cremator via the coffin and cadaver.

This report details the monitoring procedures used and the results obtained from this test work along with comparisons with the Guidance Note requirements and comments where appropriate.

Relevant procedures were followed to enable quality control to be maintained throughout the test preparation, site test work, laboratory analysis, calculations and reporting.

ST/DEM0753/27.01.15/

2. PROCEDURES

2.1 Total Particulate Matter

A flue gas sample was extracted and filtered to collect total particulate matter. A Whatman QM-A filter paper was used with a particle retention of not less than 99.5% at a particle size of 0.3 micron. The flue gas extraction employed techniques given in BS EN 13284 Part 1.

The sampling was conducted using apparatus in accordance with the requirements of BS EN 13284 Part 1.

This consisted of a heated known dimension Pyrex glass nozzle, heated Pyrex glass probe liner, heated Pyrex glass filter housing with Titanium filter support containing quartz microfibre filter (all heaters set to 160°C), PTFE sample line, dreschel absorption bottles, gas dryer (silica gel), sample line to pump, pump, gas meter, rotameter, pitot and impulse lines, electronic manometer, type K thermocouple, balance (for gravimetric moisture) and datalogger. Settings tables were pre-prepared to enable isokinetic flow to be maintained (based on online measurements of flue gas velocity and temperature to correct the sampling rate).

Particulate matter analysis was carried out by weighing the filter and probe rinse collection on a calibrated balance, with the media being dried and weighed prior to and following the test.

The tests reported herein were conducted to prove the performance of the cremators relative to PG5/2(2012).

2.2 Hydrogen Chloride

A flue gas sample was extracted and filtered.

A Whatman QM-A filter paper was used with a particle retention of not less than 99.5% at a particle size of 0.3 micron. The flue gas extraction employed techniques given in BS EN 13284 Part 1

The gas sample was then passed through an absorption medium of de-ionised water to collect hydrogen chloride.

The method employed was BS EN 1911 Parts 1-3.

Laboratory analysis for hydrogen chloride was carried out on the absorption medium using Ion Chromatography (IC).

2.3 Mercury

A flue gas sample was extracted and filtered to collect solid phase mercury.

A Whatman QM-A filter paper was used with a particle retention of not less than 99.5% at a particle size of 0.3 micron. The flue gas extraction employed techniques given in BS EN 13284 Part 1.

ST/DEM0753/27.01.15/

The gas sample was then passed through an absorption medium of acidified potassium dichromate to collect vapour phase mercury.

The method employed was BS EN 13211.

Laboratory analysis for solid and vapour phase mercury was carried out on the filter and absorption medium using Inductively Coupled Plasma (ICP-OES) Spectrophotometry.

2.4 Carbon Monoxide

A flue gas sample was continuously extracted, filtered and dried before being passed through a pre- calibrated Siemens Ultramat 23/O2 infrared analyser for the on-line measurement of carbon monoxide. The analyser has a fixed range of 0-1250 mg/Nm3 and was zeroed with air and calibrated with a nominal 800 ppmv carbon monoxide in balance nitrogen gas.


The analyser output was continuously recorded using a Grant 'Squirrel' data logger.

For these tests a relatively high range analyser was used due to the typical pattern of carbon monoxide concentration emissions from cremators being very low (often indicated as zero) for most of the cycle, but with occasional, high, short duration spikes of CO being emitted. The convention since non- continuous emissions monitoring became a mandatory requirement for cremators during 1990, has been to attempt to monitor the magnitude of spikes, as these are often the main contributor to total CO emissions. If the mean one minute emission of CO was say 200 mg/Nm³, it would be expected that the peak concentration during that one minute averaging period would be considerably higher than this. It follows that utilising a lower range analyser would frequently understate CO emissions, despite increasing sensitivity at low CO concentrations.

2.5 Volatile Organic Compounds

A flue gas sample was continuously extracted and filtered before being passed via a heated line through a pre-calibrated Signal 3030PM Flame Ionisation Detection (FID) analyser for the on-line measurement of volatile organic compounds. The analyser was ranged 0-100 ppmv total hydrocarbons and was calibrated using a certified reference gas prior to, and following each test.

zeroed with air passed through a catalytic converter and calibrated with a nominal 50 ppmv propane in balance air gas prior to, and following each test.


The analyser output was continuously recorded using a Grant 'Squirrel' data logger.

Similar comments apply to VOC’s as CO, in that the analyser scaling is set to quantify the peaks that are the nature of the emission.

ST/DEM0753/27.01.15/

2.6 Oxygen

A flue gas sample was continuously extracted from the same position in the flue as the other pollutants extraction, filtered and dried before being passed through a pre-calibrated Siemens Ultramat 23/O2

electrochemical cell analyser for the on-line measurement of flue oxygen.


The analyser was calibrated using a certified reference gas prior to, and following each test.

The output of the analyser was continuously recorded using a Grant 'Squirrel' data logger.

2.7 Moisture

A flue gas sample was extracted and filtered. The gas sample was then passed through an absorption medium to collect any water vapour.


Flue gas moisture was determined gravimetrically by weighing the absorption medium and final gas drier prior to and following the test.

This was carried out alongside testing for hydrogen chloride and mercury.

2.8 Temperature

The cremator temperatures were measured by the use of calibrated Type K thermocouples.

The method employed was BS EN 13284 Part 1.

The gas temperatures were continuously recorded using a Grant 'Squirrel' data logger.

2.9 Velocity and Volumetric Flow

Flue gas velocity was found from inserting a calibrated s-type pitot tube into the flue. The pitot head pressure was then measured using a calibrated electronic manometer.

The method employed was BS EN 13284 Part 1.

The electronic manometer output was continuously recorded using a Grant 'Squirrel' data logger.

Flue gas velocity was then calculated from Bernoulli's equation as the density of the flue gas was known (from measurements of flue gas moisture and temperature).

Flue gas volumetric flow rate was found from the measurement of the flue duct size and hence its area and corrected to normalised conditions (again from measurements of flue gas moisture and temperature).

ST/DEM0753/27.01.15/

3. RESULTS

The results are summarised in the Tables are 60 minute mean results, with sampling commencing two minutes after the coffin is loaded into the cremator

Total Particulate Matter, Hydrogen Chloride, Carbon Monoxide and Volatile Organic Compound determinations are given in Table 1 for No.1 cremator, and Table 2 for No.2 cremator.

Mercury determinations are given in Tables 3 & 4.

Moisture determinations were made on all tests.

Carbon Monoxide, Volatile Organic Compounds, Oxygen, Temperature and Velocity and Volumetric Flow were continuously monitored.

All values in the tables are corrected to the reference conditions of 273K, 101.3kPa, 11%v/v oxygen and dry gas as given in PG5/2(2012) where required.

All data logs and calculations are given in Appendix 1.

All analysis reports are given in Appendix 2.

ST/DEM0753/27.01.15/

Davies & Co.(Environmental} Ltd 'llo- '11(01 ng Jpi I ':JJiS

Test 1

Test2

Test 3

Average

65.63

75.50

37.40

19.79

21.77

- - -

0.31

0.35

78.26 ± 5.88

97.56 ± 7 33

44.86 ±2.42

8.55 ±043

10.65 ±053

10.58 ± 0.53

6.44 ±032

8.55 ±043

0.12 ±001

0.14± 001

69.78 ±5.76

77.74 ±641

34.64± 1.88

21.17 ± 106

23.58 ±us

41.47 ± 207

0.20 ± 001

21.17 ± 106

0.44 ± 002

0.49 ± 0.02

48.83 ± 5.32

51.20 ± 557

32.70 ± 1 88

29.64 ± 148

31.08±1 55

42.96 ±2.15

15.88 ±0.79

29.64 ± 148

0.39±002

0.41 ±002

15.38 ± 0.10

5.3 ± 0.5

3.4 ± 0.3

474 ± 2

2229 ± 45

15.35 ± 0.10

4.7 ± 0.5

3.0 ± 0.3

457 ± 2

1979 ± 40

16.06 ± 0.10

4.5 ± 0.5

2.9 ± 0.3

485 ± 2

2136 ± 43

15.60

4.8

3.1

472

2115

TABLE 1 Jersey Crematorium Cremator No.1 Emissions Monitoring 28th -29th January 2015

Total Particulate Matter & Hydrogen Chloride Sampling

Requirement to

PG5/2 (2012)

Total Particulate Matter - mg/Nm3c.

Total Particulate Matter - g/h

Hydrogen Chloride - g/h

Carbon Monoxide

Test Average - mg/Nm3c.

- g/h

First 30 min Average - mg/Nm3c.

Second 30 min Average - mg/Nm3c.


Organic Compounds - mg/Nm

3c.

- g/h

<80

<120

<300

<100

<150 <20

<30

Flue Oxygen

Flue Moisture

Flue Temperature

Volumetric Flow

- %v/v dry

- %v/v

- %w/w

- Deg C

- Nm3/h dry

Note 1 All emiss1ons as corcentrat1 on levels are gren as mg!Nm'corrected to11%vlv oxygen and dry gas

Note 2 All urcerta1nties (±)are cak::ulated to a 95% confiderce 1nte1Yal

Urcerta1nl1es es1lmatedus1ng the procedure suggested 1n the STA Quality Guidance Note QGN:01-01

ST/DEM0753/27.01.15/


Test 7

TestS

Test 9

Average

52.19

71.96

37.91

1.48

2.47

- - -

0.04

0.06

75.86 ± 6.11

103.44 ± S33

27.62 ± 1.73

0.56 ±003

0.76 ± 004

0.92 ± 0.05

0.18 ± 0 01

0.56 ±003

0.08 ± 0 00

0.11± 0 01

58.64 ± 514

74.51 ± 654

49.91 ± 2.SS

0.00 ± 000

0.00 ± 000

0.00 ± 000

0.00 ±000

0.00 ± 000

0.00 ± 000

0.00 ± 000

22.08 ± 3.23

37.92 ± 564

36.20 ± 197

3.87±019

6.64 ± 033

7.23 ±0.36

0.40±002

3.87±019

0.04 ±000

0.07 ±000

16.68 ± 0.10

4.4 ± 0.4

2.8 ± 0.3

428 ± 2

3176 ± 64

16.22 ± 0.10

4.8 ± 0.5

3.1 ± 0.3

464 ± 2

2671 ± 53

15.51 ± 0.10

5.2 ± 0.5

3.3 ± 0.3

447 ± 2

3144 ± 63

16.14

4.8

3.0

446

2997

TABLE 2 Jersey Crematorium Cremator No.2 Emissions Monitoring 27th -28th January 2015

Total Particulate Matter & Hydrogen Chloride Sampling

Requirement to

PG5/2 (2012)

Total Particulate Matter - mg/Nm3c.

Total Particulate Matter - g/h

Hydrogen Chloride - g/h

Carbon Monoxide

Test Average - mg/Nm3c.

- g/h


Second 30 min Average - mg/Nm3c.


Organic Compounds - mg/Nm

3c.

- g/h

<80

<120

<300

<100

<150 <20

<30

Flue Oxygen

Flue Moisture

Flue Temperature

Volumetric Flow

- %v/v dry

- %v/v

- %w/w

- Deg C

- Nm3/h dry

Note 1 All emiss1ons as corcentrat1 on levels are gren as mg!Nm'corrected to11%vlv oxygen and dry gas

Note 2 All urcerta1nties (±)are cak::ulated to a 95% confiderce 1nte1Yal

Urcerta1nt1es est1matedus1ng the procedure suggested 1n the STA Quality Guidance Note QGN:01-01


ST/DEM0753/27.01.15/

Test 4

Test 5

Test6

54.3 ±419

165.3 ± 895

3803.7 ± 2:."6.70

TABLE 3 Jersey Crematorium Mercury Tests Emissions Monitoring 2Bth -29th January 2015 Mercury Sampling

Mercury

Flue Oxygen

- %.t/v dry

16.02

± 0 10

15.17

± 010

15.72

±

0 10

Flue Moisture - %.t/v 5.4 ± 05 4.2 ± 0 4 4.6 ± 05

-%/11/W 3.4 ± 03 2.6 ± 03 2.9 ± 03

Flue Temperature - Deg C 470 ± 2 456 ± 2 471 ± 2

Volumetric Flow - Nm3/h dry 2857 ± 51 2248 ± 45 1945 ± 39

N:lle 1 PJIemss1ons as corcenraion levesl are g1ven as iJQ!Nm'or mJ!Nm

3 correctd b 11'lodv ox )\)en and dry gas

N:lle 2 PJIurcerla1nies (±) are caulaled b a 95%condi erce 1ntr val

Lrcerla1nies esi matd us1n g he procedure suggestd 1n he STA Quality Gu1darce N:lle QGNJ01-01


ST/DEM0753127.01.15/

Test 10

Test 11

Test 12

90.2 ± 503

415.4 ± 2415

480.9 ± 2700

TABLE 4 Jersey Crematorium Mercury Tests Emissions Monitoring 27th -28th January 2015 Mercury Sampling

Mercury

Flue Oxygen

- %.t/v dry

16.20

± 0 10

16.32

± 010

16.04

±

0 10

Flue Moisture - %.t/v 6.4 ± 06 5.5 ± 05 5.5 ± 05

-%/11/W 4.1 ± 04 3.5 ± 03 3.5 ± 03

Flue Temperature - Deg C 417 ± 2 451 ± 2 462 ± 2

Volumetric Flow - Nm3/h dry 3108 ± 62 2449

± 49 2329

±

47

N:lle 1 PJIemss1ons as corcenraion levesl are g1ven as iJQiNm 3 or mJ!Nm3 correctd b 11'lodvox)\)en and dry gas

N:lle 2 PJIurcerla1nies (±) are ca ulaled b a 95%condi erce 1ntrval

Lrcerla1nies esi matd us1n g he procedure suggestd 1n he STA Quality Gu1darce N:lle QGNJ01-01

ST/DEM0753/27.01.15/

4. COMMENTS

The results from these series of tests demonstrate that the plant satisfies the requirements of PG5/2(2012) for the releases to air of particulate matter, hydrogen chloride, carbon monoxide and volatile organic compounds for both cremators.

The cremators operated satisfactorily during testing without any failure or alarm events.

No visible chimney emissions were observed throughout the test work.

Mercury emissions vary widely as would be expected. The mercury releases are not governed by cremator operation, but are directly related to the mass of mercury introduced to the cremator within the cadaver, in the form of dental amalgam tooth fillings. All tests are in excess of the UK mercury emission limit value of 50 µg/Nm3c for abated plant. There is no emission limit value set for unabated plant.

ST/DEM0753/27.01.15/

5. QUALITY CONTROL

All the tests performed were carried out to the methods given in the appropriate listed Standards using calibrated equipment. The gas analysers were calibrated prior to use using suitable calibration gases.

Analysis of the filters and absorbers was carried out in-house and at an external laboratory.

For this test work the following external laboratory was used for the given determinations:

Scientific Analysis Laboratories (SAL) } Hydrogen Chloride Mercury

ST/DEM0753/27.01.15/

APPENDIX 1

Data Logs and Calculations

ST/DEM0753/27.01.15/

Jersey Crematorium Cremator No.1

Data Log 28/01/15

Test 1 Male, 48, Medium, Chipboard, 22830

Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

16:03 482 30.7 15.74 0.00 0.00 9.7

16:04 498 30.6 12.86 3.16 0.00 12.4

16:05 499 30.5 14.78 0.00 0.00 12.0

16:06 490 30.4 15.86 0.00 0.00 12.3

16:07 465 30.4 17.21 1.01 0.00 17.5

16:08 448 30.4 18.54 36.54 1.09 24.0

16:09 452 30.4 18.08 70.10 5.50 25.9

16:10 455 30.5 17.07 7.49 0.00 25.2

16:11 450 30.6 16.74 0.71 0.00 25.0

16:12 457 30.7 16.28 0.00 0.00 16.9

16:13 466 30.9 14.76 0.00 0.00 10.8

16:14 472 31.0 13.78 0.00 0.00 7.7

16:15 471 31.2 14.48 0.00 0.00 7.9

16:16 460 31.4 15.34 0.00 0.00 7.0

16:17 451 31.5 15.21 0.00 0.00 6.3

16:18 465 31.7 14.06 0.00 0.00 7.8

16:19 473 31.9 14.13 3.78 0.00 12.6

16:20 459 32.1 15.22 7.97 0.49 18.1

16:21 471 32.3 15.13 3.50 0.00 12.2

16:22 480 32.4 13.58 0.00 0.00 11.1

16:23 477 32.6 13.24 2.27 0.00 18.1

16:24 481 32.7 15.20 7.11 0.00 18.9

16:25 486 32.9 15.21 14.18 0.00 17.6

16:26 497 33.0 13.93 3.98 0.00 14.4

16:27 489 33.2 12.85 2.35 0.00 25.9

16:28 472 33.3 15.77 19.27 0.00 32.8

16:29 476 33.4 16.55 25.82 0.00 29.2

16:30 476 33.6 16.47 16.77 0.00 28.8

16:31 469 33.7 16.68 34.30 0.00 29.4

16:32 476 33.9 16.78 31.97 0.00 27.4

16:33 473 34.0 16.67 35.82 0.00 26.8

16:34 474 34.1 16.65 33.90 0.00 27.0

16:35 452 34.2 16.45 37.72 0.00 32.7

16:36 469 34.4 16.60 21.50 0.00 24.1

16:37 457 34.6 15.59 12.73 0.00 28.0

16:38 480 34.8 14.85 5.35 0.00 18.4

16:39 482 35.0 14.50 5.49 0.00 17.4

16:40 478 35.2 14.26 6.62 0.00 19.3

16:41 473 35.4 14.64 6.04 0.00 19.7

ST/DEM0753/27.01.15/

16:42 477 35.5 15.15 3.74 0.00 15.5

16:43 473 35.7 14.58 4.69 0.00 17.6

16:44 477 35.8 14.48 2.71 0.00 17.1

16:45 475 35.9 14.57 0.00 0.00 17.8

16:46 485 36.1 14.41 0.58 0.00 16.8

16:47 495 36.2 14.31 0.69 0.00 15.7

16:48 481 36.3 14.56 0.61 0.00 15.7

16:49 475 36.3 15.00 0.65 0.00 16.8

16:50 483 36.4 14.96 0.65 0.00 11.9

16:51 498 36.5 13.86 0.83 0.00 11.2

16:52 487 36.6 14.24 3.04 0.00 15.0

16:53 477 36.7 16.01 2.46 0.00 16.0

16:54 471 36.7 16.14 3.06 0.00 16.6

16:55 469 36.8 16.43 3.26 0.00 16.0

16:56 480 36.9 16.36 3.66 0.00 11.8

16:57 495 36.9 15.42 6.77 0.00 9.0

16:58 497 37.0 14.49 9.09 0.00 10.5

16:59 471 37.0 15.54 6.03 0.00 16.1

17:00 465 37.0 16.64 2.15 0.00 16.0

17:01 461 37.1 16.86 2.09 0.00 15.0

17:02 473 37.1 16.83 2.25 0.00 10.1

17:03 480 37.2 15.88 4.93 0.00 12.0

Average 474 33.9 15.38 8.55 0.12 17.4

Average for first 30 mins of test 10.58 -

Average for second 30 mins of test 6.44 -

Average for first 60 mins of test 8.55 0.12

ST/DEM0753/27.01.15/


Data Log 29/01/15

Test 2 Female, 82, Medium, Chipboard, 22882

Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

11:43 492 35.6 13.98 767.72 13.47 10.9

11:44 465 35.5 13.12 196.76 5.86 23.3

11:45 447 35.4 16.97 32.25 3.91 22.7

11:46 452 35.4 17.90 28.15 0.00 17.2

11:47 446 35.3 17.73 16.25 0.00 12.0

11:48 461 35.3 16.86 3.24 0.00 7.9

11:49 460 35.3 16.03 0.16 0.00 8.1

11:50 462 35.2 15.96 0.00 0.00 8.5

11:51 485 35.1 15.37 0.00 0.00 10.2

11:52 487 35.1 12.30 0.00 0.00 10.4

11:53 476 35.1 13.65 0.00 0.00 13.9

11:54 485 35.1 14.85 0.00 0.00 13.9

11:55 495 35.3 14.49 0.00 0.00 12.0

11:56 471 35.5 14.88 0.20 0.00 19.6

11:57 461 35.6 16.54 12.50 0.00 32.9

11:58 463 35.6 16.74 20.66 0.00 26.0

11:59 463 35.7 16.40 21.82 0.00 24.4

12:00 463 35.7 16.61 20.36 0.00 18.0

12:01 453 35.7 15.46 22.22 0.80 21.0

12:02 487 35.6 15.83 21.22 2.72 11.7

12:03 496 35.5 14.03 21.78 0.00 11.6

12:04 449 35.4 15.11 22.05 0.00 14.5

12:05 474 35.3 14.45 13.69 0.00 7.5

12:06 487 35.3 13.31 5.55 0.00 9.4

12:07 462 35.2 13.56 8.07 0.00 21.5

12:08 454 35.2 15.90 11.35 0.00 22.8

12:09 455 35.2 15.62 8.70 0.00 17.4

12:10 460 35.1 15.58 10.67 0.00 9.9

12:11 479 35.1 13.65 8.04 0.00 8.2

12:12 459 35.1 13.77 6.93 0.00 18.1

12:13 468 35.1 16.05 5.12 0.00 12.7

12:14 449 35.1 15.27 3.82 0.00 14.4

12:15 470 35.1 15.45 1.34 0.00 7.7

12:16 471 35.2 14.02 0.70 0.00 7.2

12:17 472 35.2 14.00 0.00 0.00 7.3

12:18 469 35.1 14.11 0.00 0.00 8.2

12:19 442 35.0 14.53 0.00 0.00 11.3

12:20 467 35.0 15.12 0.00 0.00 7.4

12:21 468 34.9 14.21 0.00 0.00 7.5

ST/DEM0753/27.01.15/

12:22 469 35.0 14.36 0.00 0.00 7.1

12:23 462 35.0 14.53 0.00 0.00 8.5

12:24 440 35.0 15.20 0.00 0.00 8.2

12:25 452 35.0 15.35 0.00 0.00 6.4

12:26 449 35.0 15.05 0.00 0.00 6.2

12:27 446 35.1 15.31 0.00 0.00 6.0

12:28 446 35.1 15.52 0.00 0.00 6.2

12:29 445 35.1 15.57 0.00 0.00 6.1

12:30 437 35.1 15.64 0.00 0.00 5.5

12:31 448 35.2 15.73 0.00 0.00 6.6

12:32 455 35.3 15.91 0.00 0.00 8.8

12:33 424 35.4 14.93 0.00 0.00 19.5

12:34 434 35.5 15.96 0.00 0.00 16.0

12:35 421 35.6 15.99 0.00 0.00 18.3

12:36 439 35.7 16.38 0.00 0.00 13.8

12:37 417 35.8 16.31 0.00 0.00 17.6

12:38 435 35.9 17.03 0.00 0.00 12.3

12:39 420 36.0 16.22 0.00 0.00 20.0

12:40 464 36.1 16.42 0.00 0.00 10.8

12:41 417 36.2 15.77 0.00 0.00 18.3

12:42 444 36.3 17.05 0.00 0.00 15.6

12:43 407 36.3 16.73 0.00 0.00 15.1

Average 457 35.4 15.35 21.17 0.44 13.2




ST/DEM0753/27.01.15/


Data Log 29/01/15


Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

15:09 477 31.5 14.27 158.19 4.48 10.0

15:10 481 31.4 12.43 233.94 7.47 17.6

15:11 451 31.3 16.53 10.29 3.33 21.9

15:12 453 31.3 17.59 30.47 0.00 23.8

15:13 463 31.3 17.04 20.38 0.00 15.9

15:14 474 31.3 16.79 6.15 0.00 12.1

15:15 488 31.4 15.68 1.34 0.00 10.8

15:16 483 31.5 15.10 0.14 0.00 9.1

15:17 485 31.6 14.37 0.00 0.00 8.8

15:18 481 31.6 13.78 0.00 0.00 7.6

15:19 493 31.6 13.67 0.00 0.00 10.3

15:20 500 31.7 13.65 0.00 0.18 22.9

15:21 482 31.8 16.28 25.16 3.29 24.1

15:22 488 31.9 16.42 21.11 0.00 21.8

15:23 483 32.1 16.76 21.02 0.00 23.3

15:24 492 32.3 16.66 28.04 0.64 21.9

15:25 499 32.5 16.12 71.40 2.89 22.2

15:26 487 32.7 16.07 71.57 1.42 25.9

15:27 483 32.9 16.41 50.65 0.00 25.4

15:28 487 33.1 16.63 52.86 0.00 24.3

15:29 481 33.3 16.81 88.83 0.00 23.9

15:30 481 33.4 17.03 71.15 0.00 24.8

15:31 479 33.6 17.10 57.58 0.00 24.5

15:32 476 33.8 17.31 58.25 0.00 23.8

15:33 465 34.0 17.49 86.24 0.00 25.9

15:34 465 34.2 17.54 48.32 0.00 22.7

15:35 487 34.5 17.19 32.18 0.00 14.6

15:36 511 34.7 15.64 28.31 0.00 11.8

15:37 479 34.9 15.57 24.63 0.00 24.4

15:38 463 35.0 17.21 17.13 0.00 26.3

15:39 465 35.2 17.38 16.39 0.00 22.3

15:40 467 35.4 17.08 22.39 0.00 21.2

15:41 479 35.5 16.51 20.28 0.00 15.2

15:42 484 35.7 15.97 19.74 0.00 14.4

15:43 494 35.8 15.69 21.28 0.00 10.8

15:44 497 36.0 14.38 23.93 0.00 8.7

15:45 505 36.0 14.40 22.54 0.00 10.2

15:46 509 36.3 15.15 20.62 0.00 10.8

15:47 505 36.4 15.31 18.65 0.00 11.1

15:48 441 36.4 15.90 17.73 0.00 22.4

ST/DEM0753/27.01.15/

15:49 483 36.5 16.97 15.73 0.00 10.2

15:50 501 36.5 15.77 17.77 0.00 10.1

15:51 502 36.7 15.72 19.04 0.00 10.2

15:52 501 36.7 15.93 17.52 0.00 9.9

15:53 502 36.7 16.00 16.04 0.00 10.2

15:54 499 36.8 16.05 15.29 0.00 9.8

15:55 499 36.8 16.23 14.27 0.00 9.6

15:56 494 36.9 16.24 15.61 0.00 9.7

15:57 501 37.0 16.33 18.00 0.00 10.1

15:58 501 37.2 16.23 19.94 0.00 9.8

15:59 498 37.2 16.24 17.77 0.00 11.2

16:00 436 37.2 16.41 17.58 0.00 22.1

16:01 481 37.3 17.20 10.29 0.00 9.7

16:02 486 37.4 15.86 15.93 0.00 7.7

16:03 486 37.4 15.73 15.13 0.00 8.2

16:04 503 37.5 15.66 14.82 0.00 12.0

16:05 516 37.6 16.14 9.89 0.00 12.6

16:06 484 37.7 16.06 8.46 0.00 20.1

16:07 454 37.7 17.02 4.43 0.00 19.4

16:08 501 37.7 17.11 3.01 0.00 12.7

16:09 493 37.7 16.13 2.62 0.00 11.8

Average 485 34.7 16.06 29.64 0.39 16.0




ST/DEM0753/27.01.15/


)

)


Total Particulate Matter and Hydrogen Chloride

Contract

Date

Location

Engineer(s)

Absorbent

Jersey Crematorium, DEM0753

28th- 29th January 2015

Cremator Stack

SA&ST

H20

Test Log Test 1 Test 2 Test 3

Barometric Pressure(kPa)

101.2

101.2

101.2

Gas Meter Temperature(Deg C) 33.9 35.4 34.7

Oxygen Concentration(o/ov/v dry) 15.38 15.35 16.06

Flue Gas Volumetric Flow(Nm3/h dry) 2229 1979 2136

Time

Gas Meter Reading (Am3

dry)

Absorber Weight(g)

Filter Reference

Filter Weight(g)

Probe Rinse Reference

Probe Rinse Weight(g)

Sample Reference HO

Absorbent Volume(ml)

Absorbent(mg/1 as HO)

Blank(mg/1 as HO)

Calculation: General


Gas Meter temperature(Deg C)

Gas Volume Sampled(Am3

dry)

Gas Volume Sampled(Nm3

dry)

Mass of Dry Gas(g @ 1292.8 g/Nm3

Change in Absorber Weight(g)

Water Vapour Volume(Nm3

@ 803.9 g/Nm3

Gas Volume(Nm3

wet)

Mass of Wet Gas(g)

Moisture Concentration(%v/v)

Moisture Concentration(%ww)

Start End Start End Start End

16:03 17:03 11:43 12:43 15:09 16:09

130.276 130.610 131.109 131.424 131.882 132.232

3653.2 3666.5 3653.2 3664.2 3644.3 3656.1

JE280115F11 JE290115F12 JE290115F13

0.57074 0.58227 0.57484 0.58455 0.54724 0.55384

JE280115R11 JE290115R12 JE290115R13

79.4903 79.4918 79.4918 79.4930 79.4930 79.4938

JE280115H11 JE290115H12 JE290115H13 A&B

500 500 250 250

12 9.8 19 0.05

0.05 0.05 0.05 0.05

101.2 101.2 101.2

33.9 35.4 34.7

0.334 0.315 0.350

0.2968 0.2786 0.3102

383.69 360.18 401.05

13.3 11.0 11.8

0.0165 0.0137 0.0147

0.3133 0.2923 0.3249

396.99 371.18 412.85

5.3 4.7 4.5

3.4 3.0 2.9

ST/DEM0753/27.01.15/


Calculation: Particulate

Increase In FilterWeights(g)

0.01299

0.01094

0.00744

Particulate Emission(mg/Nm3

dry) 43.78 39.27 23.97

Oxygen Concentration(%v/v dry) 15.38 15.35 16.06

Particulate Emission 78.26 69.78 48.83

(mg/Nm 3

@ 11 %v/v Oxygen dry) Flue Gas Volumetric Flow(Nm3/h dry) 2229 1979 2136

Particulate Emission(g/h) 97.56 77.74 51.20

Required Sample Velocity(Nm/s)

2.99

2.64

2.87

Nozzle Used(mm) 6.0 6.0 6.0

Area of Nozzle(m2 ) 0.00002827 0.00002827 0.00002827

Test Duration(mins) 60 60 60

Actual Sample Velocity(Nm/s) 2.92 2.74 3.05

lsokinetic a osure(%) 98 104 106

103

Calculation: HCI


12.00

9.80

19.05

Blank(mg/1 as HO) 0.05 0.05 0.05

Chloride Absorbed(mg/1 as HO) 11.95 9.75 19

Chloride Absorbed(mg as HO) 5.98 4.88 4.75

HO(mg) 5.98 4.88 4.75

HO Emission(mg/Nm3 dry) 20.13 17.50 15.31


HCI Emission 35.99 31.09 31.19

(mg/Nm 3

@ 11 %v/v Oxygen dry)

Flue Gas Volumetric Flow(Nm3/h dry)

2229

1979

2136

HCI Emission(g/h) 44.86 34.64 32.70

ST/DEM0753/27.01.15/


)


Flue Gas Volumetric Flow

Contract

Date

Location

Enginee s)


281h - 291h January 2015

Cremator Stack

SA&ST

Test Log

Flue Gas Temperab..Jre(Deg C)

Test 1

474

Test 2

457

Test 3

485

Flue Gas Pilot Head Sample Points(Pa) 17.4 13.2 16.0

Flue Gas Pilot Head Duct Mean(Pa) 17.8 13.5 16.3

Flue Gas Moisb..Jre(%v/v) 5.3 4.7 4.5

Flue Gas Moisb..Jre(%w/w) 3.4 3.0 2.9

Flue Gas Duct Dimensions(mm)

Flue Gas Duct Area(m2

)

Calculation

Flue Gas Densily(kg/m

3

500 x 41Omm rectangular flue

0.2050 0.4662 0.4779 0.4606

Sample Points

Flue Gas Velocity(Am/s)

Flue Gas Volumelric Flowrate(Am3/h)

Flue Gas Volumelric Flowrate(Am% dry)

Flue Gas Volumelric Flowrate(Nm3/h dry)

Duct Mean


Flue Gas Volumelric Flowrate(Am%) Flue

Gas Volumelric Flowrate(Am3/h dry) Flue

Gas Volumetric Flowate(Nm3/h dry)

8.63 7.42 8.34

6368 5475 6153

6031 5219 5875

2203 1951 2116

8.73 7.53 8.41

6441 5555 6210

6101 5295 5930

2229 1979 2136

ST/DEM0753/27.01.15/


Data Log 27/01/15


Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

11:49 427 34.1 18.87 3.87 0.12 39.6

11:50 419 33.9 17.39 8.78 3.37 45.0

11:51 430 33.7 17.02 4.13 1.10 49.6

11:52 429 33.6 16.82 0.27 0.00 45.6

11:53 430 33.6 16.58 0.00 0.00 43.9

11:54 426 33.6 16.59 0.00 0.00 41.5

11:55 428 33.6 16.28 0.00 0.00 42.2

11:56 427 33.7 16.28 0.00 0.00 39.8

11:57 427 33.8 15.88 0.00 0.00 34.0

11:58 429 33.9 16.42 0.00 0.00 35.3

11:59 427 34.0 16.37 0.00 0.00 32.0

12:00 429 34.1 16.88 0.00 0.00 40.4

12:01 426 34.3 16.63 0.00 0.00 34.9

12:02 428 34.4 16.65 0.25 0.00 42.0

12:03 423 34.5 16.39 1.07 0.11 35.2

12:04 430 34.6 16.17 0.56 0.00 36.6

12:05 427 34.8 15.84 0.23 0.00 31.6

12:06 427 34.8 15.71 0.23 0.00 27.5

12:07 429 34.9 15.45 0.22 0.00 26.8

12:08 426 35.0 15.60 0.20 0.00 31.7

12:09 426 35.2 15.36 2.67 0.00 38.7

12:10 426 35.3 15.67 0.47 0.00 49.9

12:11 427 35.4 16.85 0.95 0.00 53.9

12:12 430 35.6 16.82 0.29 0.00 49.0

12:13 426 35.8 17.13 0.31 0.00 42.4

12:14 427 35.9 16.53 0.00 0.00 35.9

12:15 428 36.1 16.27 0.83 0.00 39.5

12:16 424 36.3 15.65 0.34 0.00 31.2

12:17 425 36.4 16.00 1.89 0.00 34.1

12:18 427 36.6 15.70 0.23 0.00 27.3

12:19 426 36.6 15.78 0.89 0.00 24.8

12:20 431 36.7 15.85 1.44 0.00 27.0

12:21 430 36.7 15.58 0.20 0.00 19.5

12:22 431 36.8 15.57 0.20 0.00 21.6

12:23 433 36.9 15.63 0.19 0.00 20.3

12:24 432 37.0 16.02 0.20 0.00 22.0

12:25 435 37.1 15.71 0.19 0.00 17.1

12:26 436 37.2 16.05 0.22 0.00 19.8

12:27 435 37.2 16.01 0.22 0.00 17.4

ST/DEM0753/27.01.15/

12:28 437 37.3 16.75 0.26 0.00 20.2

12:29 439 37.4 16.59 0.00 0.00 16.3

12:30 439 37.3 17.07 0.28 0.00 21.0

12:31 436 37.4 16.80 0.24 0.00 16.3

12:32 441 37.4 17.41 0.00 0.00 19.4

12:33 453 37.4 16.86 0.00 0.00 13.0

12:34 442 37.5 17.31 0.00 0.00 24.9

12:35 427 37.5 17.11 0.00 0.00 29.3

12:36 422 37.6 17.28 0.27 0.00 36.7

12:37 420 37.6 17.27 0.27 0.00 31.6

12:38 422 37.7 17.32 0.30 0.00 35.8

12:39 418 37.8 17.53 0.32 0.00 32.8

12:40 420 37.9 17.38 0.28 0.00 34.1

12:41 420 38.0 17.88 0.36 0.00 36.8

12:42 419 38.1 17.57 0.00 0.00 31.2

12:43 421 38.2 17.91 0.00 0.00 36.6

12:44 417 38.2 17.75 0.00 0.00 31.8

12:45 422 38.3 17.83 0.00 0.00 36.8

12:46 416 38.4 18.08 0.00 0.00 35.4

12:47 422 38.6 17.72 0.00 0.00 32.4

12:48 420 38.6 18.17 0.00 0.00 37.6

12:49 418 38.7 17.77 0.00 0.00 32.1

Average 428 36.2 16.68 0.56 0.08 32.6




ST/DEM0753/27.01.15/


Data Log 27/01/15


Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

15:16 446 34.3 15.87 0.00 0.00 32.8

15:17 436 34.1 17.56 0.00 0.00 36.9

15:18 442 34.0 17.70 0.00 0.00 28.4

15:19 446 34.0 17.08 0.00 0.00 20.8

15:20 448 34.0 16.89 0.00 0.00 24.7

15:21 447 33.9 17.00 0.00 0.00 24.8

15:22 448 34.0 16.90 0.00 0.00 25.1

15:23 452 34.0 16.38 0.00 0.00 24.3

15:24 458 34.1 15.68 0.00 0.00 23.1

15:25 459 34.1 15.12 0.00 0.00 21.3

15:26 452 34.2 16.48 0.00 0.00 26.8

15:27 456 34.3 16.72 0.00 0.00 22.6

15:28 455 34.3 16.25 0.00 0.00 23.8

15:29 456 34.4 15.79 0.00 0.00 28.3

15:30 457 34.6 15.30 0.00 0.00 28.5

15:31 456 34.7 15.43 0.00 0.00 35.4

15:32 451 34.8 16.36 0.00 0.00 38.4

15:33 450 34.9 16.48 0.00 0.00 33.1

15:34 457 35.0 16.05 0.00 0.00 29.7

15:35 463 35.2 14.31 0.00 0.00 30.4

15:36 461 35.3 15.18 0.00 0.00 40.7

15:37 462 35.4 16.08 0.00 0.00 42.3

15:38 466 35.5 15.66 0.00 0.00 41.6

15:39 469 35.7 15.27 0.00 0.00 46.6

15:40 468 35.8 15.89 0.00 0.00 57.4

15:41 459 36.0 16.84 0.00 0.00 49.5

15:42 454 36.0 17.10 0.00 0.00 39.1

15:43 454 36.2 16.74 0.00 0.00 38.1

15:44 456 36.3 16.24 0.00 0.00 32.6

15:45 457 36.4 15.77 0.00 0.00 35.8

15:46 456 36.5 15.69 0.00 0.00 36.5

15:47 455 36.7 15.82 0.00 0.00 35.4

15:48 455 36.8 15.98 0.00 0.00 35.4

15:49 452 36.9 16.19 0.00 0.00 29.1

15:50 458 37.0 15.63 0.00 0.00 18.5

15:51 464 37.1 14.78 0.00 0.00 19.4

15:52 456 37.2 15.91 0.00 0.00 28.8

15:53 455 37.3 16.51 0.00 0.00 26.1

15:54 459 37.4 16.07 0.00 0.00 18.9

ST/DEM0753/27.01.15/

15:55 463 37.5 15.82 0.00 0.00 17.0

15:56 474 37.5 15.57 0.00 0.00 11.5

15:57 489 37.5 14.94 0.00 0.00 10.4

15:58 475 37.5 15.17 0.00 0.00 15.0

15:59 490 37.5 15.84 0.00 0.00 10.7

16:00 489 37.5 14.65 0.00 0.00 12.2

16:01 487 37.5 15.01 0.00 0.00 12.6

16:02 490 37.5 15.37 0.00 0.00 11.2

16:03 489 37.5 15.24 0.00 0.00 9.7

16:04 487 37.4 15.23 0.00 0.00 9.5

16:05 486 37.4 15.60 0.00 0.00 9.2

16:06 482 37.4 15.99 0.00 0.00 9.0

16:07 479 37.5 16.41 0.00 0.00 8.8

16:08 477 37.5 16.76 0.00 0.00 8.6

16:09 476 37.5 17.10 0.00 0.00 8.5

16:10 475 37.6 17.41 0.00 0.00 8.5

16:11 474 37.5 17.71 0.00 0.00 8.4

16:12 472 37.5 17.99 0.00 0.00 8.2

16:13 463 37.6 18.24 0.00 0.00 7.6

16:14 476 37.5 18.42 0.00 0.00 9.7

16:15 479 37.5 18.50 0.00 0.00 13.7

16:16 464 37.4 17.53 0.00 0.00 19.1

Average 464 36.1 16.22 0.00 0.00 24.1




ST/DEM0753/27.01.15/


Data Log 28/01/15


Time Flue

Gas

oC

Meter

oC

Flue

Oxygen %v/v dry

CO

mg/Nm3

c.

VOC

mg/Nm3

c.

Sample

Point

Pa

10:05 432 26.0 15.86 40.74 1.70 33.3

10:06 432 26.0 15.00 40.34 0.46 32.3

10:07 428 26.1 16.23 39.61 0.28 34.1

10:08 432 26.3 16.55 34.10 0.00 25.0

10:09 438 26.4 15.82 21.24 0.00 21.8

10:10 438 26.6 15.55 12.81 0.00 19.2

10:11 442 26.8 15.25 6.83 0.00 18.0

10:12 463 27.0 15.18 3.78 0.00 15.0

10:13 463 27.2 14.83 2.34 0.00 14.3

10:14 463 27.5 14.93 0.68 0.00 14.3

10:15 471 27.7 14.61 0.11 0.00 14.0

10:16 460 28.0 14.10 1.19 0.00 17.3

10:17 457 28.3 14.45 1.36 0.00 18.0

10:18 457 28.5 14.48 0.94 0.00 18.0

10:19 453 28.9 14.73 0.32 0.00 19.8

10:20 449 29.2 14.74 0.64 0.00 20.3

10:21 456 29.5 14.60 0.74 0.00 23.5

10:22 441 29.8 16.09 2.40 0.00 25.9

10:23 453 30.1 16.13 1.84 0.00 20.7

10:24 463 30.4 14.68 0.86 0.00 18.0

10:25 457 30.8 13.46 0.08 0.00 29.5

10:26 447 31.1 15.47 0.36 0.00 42.9

10:27 443 31.5 16.06 2.52 0.00 42.5

10:28 446 31.9 15.49 0.64 0.00 32.6

10:29 460 32.2 14.55 0.11 0.00 32.7

10:30 448 32.6 15.43 0.13 0.00 53.8

10:31 443 33.0 16.63 2.05 0.00 51.0

10:32 443 33.3 16.54 2.78 0.00 43.8

10:33 444 33.6 16.33 1.92 0.00 42.3

10:34 447 33.9 16.03 0.55 0.00 43.4

10:35 449 34.2 15.53 0.13 0.00 42.3

10:36 456 34.5 14.78 0.11 0.00 40.6

10:37 457 34.8 15.28 0.12 0.00 57.5

10:38 445 35.1 16.71 3.90 0.00 56.8

10:39 438 35.4 17.22 4.03 0.00 46.2

10:40 435 35.7 16.96 2.22 0.00 36.0

10:41 445 36.0 16.44 0.15 0.00 36.5

10:42 448 36.2 15.35 1.23 0.00 38.8

10:43 448 36.4 15.10 0.12 0.00 41.0

10:44 442 36.6 15.97 0.00 0.00 44.2

ST/DEM0753/27.01.15/

10:45 443 36.8 16.46 0.00 0.00 39.7

10:46 442 37.1 16.21 0.00 0.00 36.5

10:47 444 37.2 15.21 0.00 0.00 34.9

10:48 443 37.4 15.70 0.00 0.00 35.5

10:49 446 37.6 16.07 0.00 0.00 35.0

10:50 438 37.7 16.23 0.00 0.00 35.3

10:51 446 37.9 14.83 0.00 0.00 38.6

10:52 447 38.1 14.88 0.00 0.00 44.4

10:53 444 38.2 15.70 0.00 0.00 47.5

10:54 437 38.4 16.12 0.00 0.00 42.5

10:55 448 38.5 15.72 0.00 0.00 26.1

10:56 450 38.6 15.02 0.00 0.00 29.2

10:57 449 38.8 15.26 0.00 0.00 35.2

10:58 444 38.9 14.92 0.00 0.00 40.8

10:59 441 39.0 15.84 0.00 0.00 43.4

11:00 441 39.1 16.26 0.00 0.00 39.9

11:01 439 39.2 16.00 0.00 0.00 33.3

11:02 446 39.3 15.43 0.00 0.00 27.0

11:03 446 39.4 15.07 0.00 0.00 26.6

11:04 450 39.5 15.08 0.00 0.00 24.1

11:05 453 39.6 15.24 0.00 0.00 24.3

Average 447 33.5 15.51 3.87 0.04 33.1





ST/DEM0753/27.01.15/

)

)


Total Particulate Matter and Hydrogen Chloride

Contract

Date

Location

Engineer(s)

Absorbent


27th- 28th January 2015

Cremator Stack

SA&ST

H20

Test Log Test 7 Test 8 Test 9


101.2

101.2

101.2

Gas Meter Temperature(Deg C) 36.2 36.1 33.5

Oxygen Concentration(o/ov/v dry) 16.68 16.22 15.51

Flue Gas Volumetric Flow(Nm3/h dry) 3176 2671 3144

Time

Gas Meter Reading (Am3

dry)

Absorber Weight(g)

Filter Reference

Filter Weight(g)


Probe Rinse Weight(g)

Sample Reference HO



Blank(mg/1 as HO)



Gas Meter temperature(Deg C)


dry)


dry)

Mass of Dry Gas(g @ 1292.8 g/Nm3


Water Vapour Volume(Nm3

@ 803.9 g/Nm3

Gas Volume(Nm3

wet)

Mass of Wet Gas(g)

Moisture Concentration(%v/v)

Moisture Concentration(%ww)


11:49 12:49 15:16 16:16 10:05 11:05

127.142 127.595 128.155 128.578 128.602 129.067

3550.1 3564.8 3462.9 3478.1 3530.0 3548.1

JE270115F21 JE270115F22 JE280115F23

0.56630 0.57785 0.56783 0.57707 0.54792 0.55235

JE270115R21 JE270115R22 JE280115R23

79.4871 79.4886 79.4886 79.4897 79.4897 79.4903

JE270114H21 JE270114H22 JE280115H23 A&B

500 500 250 250

7 14 19 0.11

0.05 0.05 0.05 0.05

101.2 101.2 101.2

36.2 36.1 33.5

0.453 0.423 0.465

0.3996 0.3732 0.4138

516.61 482.48 534.98

14.7 15.2 18.1

0.0183 0.0189 0.0225

0.4179 0.3921 0.4363

531.31 497.68 553.08

4.4 4.8 5.2

2.8 3.1 3.3


ST/DEM0753127.01.15/

Calculation: Particulate

Increase In FilterWeights(g)

0.01301

0.01041

0.00499

Particulate Emission(mg/Nm3

dry) 32.57 27.90 12.06


Particulate Emission 75.86 58.64 22.08

(mg/Nm 3


Flue Gas Volumelric Flow(Nm3/h dry)

3176

2671

3144

Particulate Emission(g/h) 103.44 74.51 37.92


4.26

3.56

4.20


Area of Nozzle(m2 ) 0.00002827 0.00002827 0.00002827



lsokinetic 0 osure(%) 92 103 97

97

Calculation: HCI


7.00

14.00

19.11

Blank(mg/1 as HO) 0.05 0.05 0.05

Chloride Absorbed(mg/1 as HO) 6.95 13.95 19.06

Chloride Absorbed(mg as HO) 3.48 6.98 4.77

HO(mg) 3.48 6.98 4.77

HO Emission(mg/Nm3 dry) 8.70 18.69 11.51


HCI Emission 20.25 39.28 21.08

(mg/Nm 3


Flue Gas Volumelric Flow(Nm3/h dry)

3176

2671

3144

HCI Emission(g/h) 27.62 49.91 36.20


ST/DEM0753/27.01.15/

)



Contract

Date

Location

Enginee s)


271h - 281h January 2015

Cremator Stack

SA&ST

Test Log

Flue Gas Temperab..Jre(Deg C)

Test 1

428

Test 2

464

Test 3

447



Flue Gas Moisb..Jre(%v/v) 4.4 4.8 5.2

Flue Gas Moisb..Jre(%w/w) 2.8 3.1 3.3



)

Calculation

Flue Gas Densily(kg/m

3

500 x 41Omm rectangular flue

0.2050 0.4984 0.4735 0.4841

Sample Points


Flue Gas Volumelric Flowrate(Am3/h)

Flue Gas Volumelric Flowrate(Am% dry)

Flue Gas Volumelric Flowrate(Nm3/h dry)

Duct Mean


Flue Gas Volumelric Flowrate(Am%) Flue

Gas Volumelric Flowrate(Am3/h dry) Flue

Gas Volumetric Flowate(Nm3/h dry)

11.44 10.09 11.69

8441 7446 8625

8072 7087 8180

3145 2626 3102

11.55 10.26 11.84

8525 7572 8741

8152 7207 8290

3176 2671 3144

Jersey Crematorium Mercury Tests

ST/DEM0753/27.01.15/

Data Log 28/01/15

Test 4

Male, 36, Heavy, Chipboard, 22829

Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

14:02 457 31.9 13.90 30.6

14:03 440 31.8 17.19 38.4

14:04 435 31.7 18.20 45.6

14:05 437 31.7 17.83 45.4

14:06 431 31.6 18.12 37.9

14:07 441 31.7 17.47 31.1

14:08 447 31.8 17.29 23.2

14:09 444 31.8 17.08 24.0

14:10 447 31.9 16.98 23.1

14:11 451 32.0 16.65 21.3

14:12 477 32.2 15.59 19.2

14:13 469 32.3 14.82 23.9

14:14 461 32.5 14.35 37.5

14:15 453 32.7 16.83 41.8

14:16 448 32.8 17.28 36.2

14:17 456 33.0 16.37 37.0

14:18 462 33.2 15.17 39.5

14:19 462 33.3 15.27 50.1

14:20 466 33.5 15.91 51.3

14:21 471 33.8 15.85 50.8

14:22 475 33.9 15.84 51.3

14:23 468 34.2 16.29 49.3

14:24 469 34.4 16.51 45.4

14:25 477 34.7 15.92 47.7

14:26 478 34.9 15.55 47.9

14:27 479 35.2 15.47 53.8

14:28 475 35.4 16.47 49.1

14:29 468 35.6 16.93 43.2

14:30 469 35.7 16.42 42.8

14:31 471 35.9 15.93 46.5

14:32 471 36.1 15.95 46.8

14:33 471 36.3 16.10 45.6

14:34 469 36.4 16.08 38.0

14:35 468 36.6 15.80 36.5

14:36 469 36.8 16.00 34.5

14:37 465 36.9 16.03 29.0

14:38 469 37.0 15.43 26.3

14:39 468 37.2 15.75 38.1

ST/DEM0753/27.01.15/

14:40 465 37.3 16.66 37.8

14:41 462 37.5 16.71 33.2

14:42 473 37.6 15.83 25.6

14:43 477 37.7 15.21 30.3

14:44 467 37.7 16.27 36.0

14:45 468 37.9 16.43 29.1

14:46 472 38.0 15.68 27.1

14:47 474 38.1 15.52 27.6

14:48 474 38.2 15.57 27.3

14:49 483 38.3 15.44 25.2

14:50 478 38.4 15.87 25.0

14:51 478 38.5 15.75 19.8

14:52 482 38.5 15.39 17.6

14:53 497 38.6 15.33 15.3

14:54 490 38.6 15.25 16.8

14:55 502 38.6 15.68 12.3

14:56 507 38.7 15.05 10.6

14:57 504 38.8 14.91 10.3

14:58 504 38.8 15.15 10.2

14:59 500 38.8 15.45 9.4

15:00 494 38.8 15.54 8.9

15:01 493 38.9 15.71 9.1

15:02 492 38.9 15.96 8.9

Average 470 35.6 16.02 32.0

ST/DEM0753/27.01.15/

Data Log 29/01/15

Test 5

Female, 72, Mediun, Chipboard, 22881

Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

10:07 453 22.3 13.59 19.2

10:08 445 22.5 16.55 25.6

10:09 431 22.8 17.22 31.8

10:10 424 23.1 17.48 30.2

10:11 425 23.6 17.31 24.1

10:12 425 24.0 16.57 22.3

10:13 452 24.3 16.48 13.2

10:14 443 24.6 15.72 13.9

10:15 463 25.0 15.01 9.9

10:16 462 25.3 14.15 9.4

10:17 465 25.6 14.00 9.3

10:18 465 25.9 13.78 10.2

10:19 452 26.2 13.39 18.1

10:20 439 26.6 14.99 26.5

10:21 439 26.9 16.14 26.1

10:22 435 27.3 16.18 24.1

10:23 451 27.6 15.33 17.8

10:24 467 28.0 15.20 12.1

10:25 458 28.4 13.61 17.7

10:26 455 28.7 14.86 26.2

10:27 451 29.1 15.71 25.2

10:28 450 29.4 15.60 27.0

10:29 462 29.7 15.31 18.4

10:30 457 30.1 14.51 26.4

10:31 456 30.4 15.31 23.4

10:32 460 30.7 14.83 24.9

10:33 459 31.0 15.41 23.4

10:34 465 31.4 15.25 16.3

10:35 473 31.7 14.40 16.8

10:36 476 32.0 14.46 15.3

10:37 466 32.2 14.34 22.3

10:38 479 32.4 15.07 18.1

10:39 464 32.6 14.73 18.4

10:40 472 32.9 14.41 18.6

10:41 466 33.1 14.58 16.3

10:42 478 33.3 15.20 21.4

10:43 461 33.5 15.30 16.8

10:44 487 33.7 14.62 14.6

10:45 469 33.9 15.37 16.0

ST/DEM0753/27.01.15/

10:46 456 34.1 15.05 23.2

10:47 481 34.2 14.51 16.4

10:48 450 34.4 14.82 19.0

10:49 493 34.6 15.08 11.7

10:50 463 34.6 13.67 19.1

10:51 474 34.8 15.62 19.0

10:52 455 34.8 13.85 18.6

10:53 454 34.9 14.67 19.2

10:54 452 35.0 14.79 21.7

10:55 462 35.1 15.65 20.5

10:56 438 35.1 15.12 19.0

10:57 448 35.2 15.65 20.6

10:58 450 35.3 15.82 18.4

10:59 445 35.4 16.04 17.3

11:00 448 35.4 15.55 13.3

11:01 455 35.5 14.83 13.9

11:02 458 35.6 15.50 16.6

11:03 449 35.7 15.28 15.3

11:04 441 35.8 14.96 19.8

11:05 444 35.9 15.29 19.2

11:06 453 36.0 15.91 15.0

11:07 441 36.1 15.59 16.2

Average 456 30.9 15.17 19.0

ST/DEM0753/27.01.15/


Data Log 29/01/15

Test 6

Male, 65, Medium, Chipboard, 22883

Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

13:16 457 33.2 14.54 16.5

13:17 461 33.1 16.37 15.0

13:18 453 33.0 17.19 10.3

13:19 423 32.9 16.92 11.3

13:20 433 32.9 16.77 5.9

13:21 448 33.0 15.90 7.3

13:22 469 33.0 15.80 10.1

13:23 465 33.1 13.50 7.9

13:24 485 33.1 13.43 10.9

13:25 467 33.2 14.52 15.0

13:26 469 33.3 15.19 14.7

13:27 491 33.4 15.60 11.2

13:28 472 33.5 14.20 15.8

13:29 483 33.5 13.98 15.9

13:30 487 33.6 14.71 18.6

13:31 476 33.6 15.41 21.8

13:32 490 33.6 15.09 18.9

13:33 474 33.7 16.17 29.8

13:34 472 33.7 17.02 30.6

13:35 473 33.8 16.93 29.3

13:36 469 33.9 17.08 31.1

13:37 482 33.9 17.09 23.1

13:38 489 34.0 16.52 18.5

13:39 511 34.3 15.00 20.2

13:40 479 34.6 16.20 31.0

13:41 470 34.8 17.19 29.1

13:42 467 35.0 17.40 29.1

13:43 461 35.1 17.41 29.0

13:44 458 34.9 17.29 23.5

13:45 461 34.7 16.80 21.0

13:46 469 34.5 15.82 18.4

13:47 467 34.5 15.29 18.5

13:48 469 34.5 15.25 18.1

13:49 462 34.5 15.51 16.5

13:50 467 34.6 15.32 13.0

13:51 468 34.7 14.72 13.4

13:52 468 34.7 14.97 12.9

13:53 474 34.8 14.99 11.6

13:54 463 34.9 15.11 13.0

ST/DEM0753/27.01.15/

13:55 472 34.9 15.28 9.9

13:56 485 35.0 14.44 7.7

13:57 482 35.1 13.90 11.4

13:58 462 35.1 15.53 15.7

13:59 463 35.2 16.36 12.6

14:00 482 35.3 15.85 8.4

14:01 482 35.4 15.01 7.2

14:02 477 35.4 14.87 6.7

14:03 471 35.5 14.88 6.5

14:04 469 35.6 15.11 6.4

14:05 464 35.6 15.39 6.1

14:06 462 35.7 15.45 6.2

14:07 464 35.8 15.62 6.6

14:08 476 35.8 15.68 7.2

14:09 480 35.9 15.47 7.6

14:10 481 36.0 15.75 7.4

14:11 480 36.0 16.11 7.1

14:12 479 36.0 16.38 7.2

14:13 472 36.1 16.67 6.6

14:14 482 36.2 16.90 8.1

14:15 472 36.2 17.21 11.3

14:16 460 36.3 16.66 11.8

Average 471 34.5 15.72 14.6

ST/DEM0753/27.01.15/


)

)


Mercury

Contract

Date

Location

Enginee s)

Absorbent

Jersey Qematorium, DEM0753


Qemator Stack

ST

4% K2CR20,I 20% HN03 in H20

Test Log


Gas Meter Temperature(Deg C)

Oxygen Concentration(%v/v dry)

Flue Gas Volumetric Flo'A{Nm3/h dry)

Time

Gas Meter Reading(Am3

dry)

Absorber Weight(g)

Filter Reference

Filter Fraction Analysed

Filte [.I!J as Hg)

Filter Blank(g as Hg)


Probe Rinse Volume(ml)

Probe Rinse( g/1 as Hg)

Probe Rinse Blank( g/1 as Hg)

Absorbent Reference


Absorbent( g/1 as Hg)

Absorbent Blank( g/1 as Hg)





dry)


dry)

Mass of Dry Gas(g@ 1292.8 g/Nm3


Water Vapour Volume(Nm3 @ 803.9 g/Nm3

Gas Volume(Nm3 wet)

Mass of Wet Gas(g)

Moisture Concentration("'ov/v)

Moisture Concentration("'ow/w)

Test 4 Test 5 Test 6

103.0 103.0 103.0

35.6 30.9 34.5

16.02 15.17 15.72

2857 2248 1945


14:02 15:02 10:07 11:07 13:16 14:16

129.741 130.188 130.633 131.054 131.474 131.826

3340.3 3358.6 3356.9 3370.3 3362.8 3375.1

JE280115HgF24 JE290115HgF11 JE290115HgF12

1 1 1

0.08 0.19 1.6

0.01 0.01 0.01

Washed into HgA Washed into HgA Washed into HgA

0 0 0

0 0 0

0 0 0

JE280115HgA24 JE290115HgA11 JE290115HgA12 A&B

500 500 250 250

22 74 2500 37

0.5 0.5 0.5 0.5

103.0 103.0 103.0

35.6 30.9 34.5

0.447 0.421 0.352

0.4021 0.3845 0.3177

519.80 497.12 410.73

18.3 13.4 12.3

0.0228 0.0167 0.0153

0.4248 0.4012 0.3330

538.10 510.52 423.03

5.4 4.2 4.6

3.4 2.6 2.9

ST/DEM0753/27.01.15/


Calculation: Mercury

Filter{IJg as Hg)

0.07

0.18

1.59

Probe Rinse(IJg as Hg) 0.00 0.00 0.00

Absorbenl(IJg as Hg) 10.75 36.75 634.00

Total Mercury Sampled(IJg) 10.82 36.93 635.59

Mercury Emission(IJg/Nm3 dry) 26.91 96.04 2000.56


Mercury Emission 54.27 165.26 3803.65

(1Jg/Nm3


Flue Gas Volumetric Flowate(Nm3/h dry)

2857

2248

1945

Mercury Emission(g/h) 0.077 0.216 3.891


4.06

3.20

2.77


Area of Nozzle(m2 ) 0.00002827 0.00002827 0.00002827



lsokinetic Closure(%) 97 118 113

109

ST/DEM0753/27.01.15/


)



Contract

Date

Location

Engineer(s)



Cremator Stack

ST

Test Log

Flue Gas Temperature(Deg C)

Test 4

470

Test 5

456

Test 6

471



Flue Gas Mo isture(%v/v) 5.4 4.2 4.6

Flue Gas Moisture(%w/w) 3.4 2.6 2.9



)

Calculation

Flue Gas Density(kg/m

3

500 x 410 mm Rectangular Stack

0.2050 0.4689 0.4794 0.4693

Sample Points

Flue Gas Velo city(Am/s)

Flue Gas Volumetric Flowrate(Am3/h)

Flue Gas Volumetric Flowrate(Am3/h dry)

Flue Gas Volumetric Flowrate(Nm3/h dry)

Duct Mean

Flue Gas Velo city(Am/s)



Flue Gas Volumetric Flovnte(Nm3/h dry)

11.69 8.91 7.90

8625 6574 5830

8163 6301 5562

2999 2360 2042

11.13 8.49 7.53

8216 6263 5554

7776 6003 5299

2857 2248 1945

ST/DEM0753/27.01.15/


Data Log 27/01/15

Test 10


Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

10:03 415 18.7 17.44 40.9

10:04 409 18.8 17.01 43.6

10:05 403 18.9 17.33 39.7

10:06 405 19.1 17.19 33.9

10:07 406 19.3 16.82 29.5

10:08 407 19.6 16.55 24.4

10:09 414 19.8 16.02 19.6

10:10 416 20.1 15.90 18.1

10:11 420 20.4 15.97 16.2

10:12 422 20.7 15.98 16.0

10:13 423 21.1 15.98 17.6

10:14 417 21.4 15.91 20.0

10:15 417 21.8 15.58 22.3

10:16 422 22.1 14.86 29.1

10:17 412 22.5 15.69 47.5

10:18 403 22.9 17.41 46.0

10:19 402 23.3 17.30 35.8

10:20 408 23.8 16.68 24.9

10:21 415 24.2 15.68 18.8

10:22 418 24.6 14.58 28.5

10:23 410 25.0 15.98 44.1

10:24 409 25.4 16.86 44.0

10:25 411 25.8 16.44 36.4

10:26 413 26.2 16.05 33.0

10:27 416 26.6 15.62 34.0

10:28 417 27.0 15.53 35.6

10:29 417 27.4 16.12 51.7

10:30 408 27.8 17.33 52.2

10:31 404 28.3 17.63 42.5

10:32 409 28.6 17.04 37.6

10:33 413 29.0 16.23 41.7

10:34 417 29.3 15.85 43.4

10:35 417 29.6 15.85 42.2

10:36 421 29.9 15.84 43.7

10:37 422 30.3 15.87 42.8

10:38 422 30.6 15.91 43.8

10:39 423 30.9 16.01 43.3

10:40 423 31.2 16.08 43.2

ST/DEM0753/27.01.15/

10:41 423 31.4 16.18 39.6

10:42 428 31.7 15.70 31.2

10:43 431 32.0 15.05 36.5

10:44 426 32.2 16.20 48.1

10:45 423 32.5 16.67 45.0

10:46 424 32.7 16.36 29.8

10:47 429 32.9 15.63 26.5

10:48 430 33.1 15.54 32.3

10:49 428 33.3 14.84 46.1

10:50 419 33.5 16.33 50.5

10:51 418 33.7 17.10 45.4

10:52 417 33.9 16.86 37.7

10:53 416 34.2 16.84 34.9

10:54 423 34.4 15.86 37.8

10:55 422 34.5 15.37 41.1

10:56 421 34.7 16.24 46.5

10:57 418 34.9 16.80 44.4

10:58 417 35.0 16.57 38.1

10:59 418 35.2 16.42 35.2

11:00 423 35.3 16.02 30.7

11:01 425 35.4 15.78 28.3

11:02 426 35.6 15.79 29.1

11:03 427 35.7 15.91 28.6

Average 417 28.0 16.20 35.9

ST/DEM0753/27.01.15/

Data Log 27/01/15

Test 11

Female, 89, Mediun, Chipboard, 22874

Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

13:43 425 29.8 16.37 27.6

13:44 430 29.7 17.30 28.0

13:45 433 29.6 17.05 20.3

13:46 434 29.6 17.06 20.7

13:47 435 29.6 17.11 28.1

13:48 434 29.7 17.13 25.0

13:49 436 29.8 17.10 28.9

13:50 438 29.9 16.98 21.5

13:51 443 30.1 16.43 21.3

13:52 448 30.3 15.89 20.2

13:53 446 30.4 16.10 20.5

13:54 444 30.6 17.00 21.9

13:55 442 30.7 17.35 30.6

13:56 437 30.9 17.12 26.2

13:57 439 31.1 16.81 22.8

13:58 443 31.3 16.35 18.0

13:59 465 31.5 15.49 11.8

14:00 474 31.7 14.93 11.4

14:01 468 31.9 14.90 15.1

14:02 453 32.0 14.89 29.3

14:03 443 32.2 15.99 43.3

14:04 442 32.4 16.41 46.0

14:05 445 32.6 15.75 36.0

14:06 449 32.9 15.20 44.7

14:07 443 33.1 16.49 51.9

14:08 439 33.4 16.95 47.5

14:09 439 33.7 16.76 44.9

14:10 440 33.9 16.32 38.3

14:11 440 34.2 16.10 37.4

14:12 440 34.4 16.23 38.1

14:13 440 34.7 16.29 33.1

14:14 446 34.8 15.59 24.9

14:15 446 35.0 15.43 36.2

14:16 439 35.2 16.70 43.3

14:17 436 35.3 16.90 36.0

14:18 441 35.4 16.38 30.2

14:19 445 35.5 16.28 23.4

14:20 447 35.7 15.93 22.2

14:21 447 35.8 16.11 21.4

ST/DEM0753/27.01.15/

14:22 454 35.9 16.10 15.5

14:23 474 35.9 15.08 11.0

14:24 473 36.1 14.56 14.4

14:25 451 36.2 16.02 20.0

14:26 449 36.2 16.76 19.7

14:27 456 36.3 16.51 15.0

14:28 467 36.3 16.01 11.5

14:29 471 36.4 15.54 9.9

14:30 471 36.4 15.38 10.0

14:31 471 36.4 15.46 10.0

14:32 467 36.4 15.67 9.3

14:33 465 36.4 16.00 9.4

14:34 465 36.3 16.33 9.5

14:35 464 36.3 16.46 9.2

14:36 463 36.3 16.64 9.2

14:37 462 36.3 16.81 9.0

14:38 461 36.3 17.01 9.2

14:39 453 36.3 17.26 8.1

14:40 463 36.3 17.36 9.8

14:41 472 36.2 17.55 10.8

14:42 477 36.3 16.88 11.3

14:43 480 36.2 16.91 11.1

Average 451 33.7 16.32 23.0

ST/DEM0753/27.01.15/


Data Log 28/01/15

Test 12


Time

Flue Gas

oC

Meter

oC

Flue O2

%v/v dry

Sample Point

Pa

11:42 453 35.2 15.55 28.2

11:43 440 35.0 17.39 39.1

11:44 450 34.9 17.44 42.3

11:45 447 34.9 17.32 38.8

11:46 448 34.9 17.55 40.4

11:47 449 34.9 17.29 37.0

11:48 451 35.0 17.02 30.1

11:49 450 35.1 16.88 24.0

11:50 455 35.1 17.00 25.4

11:51 454 35.2 16.67 19.7

11:52 463 35.3 16.22 23.0

11:53 463 35.4 15.69 21.2

11:54 464 35.6 15.86 19.1

11:55 457 35.7 16.16 23.4

11:56 457 35.8 16.06 22.2

11:57 483 36.0 15.28 12.3

11:58 482 36.1 13.11 17.0

11:59 456 36.2 15.61 24.7

12:00 463 36.4 16.78 24.3

12:01 466 36.6 16.24 17.6

12:02 477 36.7 15.47 17.3

12:03 463 36.9 14.79 27.4

12:04 447 37.1 16.07 47.0

12:05 450 37.2 17.20 52.8

12:06 445 37.4 16.72 39.2

12:07 447 37.6 16.75 41.5

12:08 439 37.7 16.57 35.5

12:09 446 37.9 16.58 33.9

12:10 445 38.1 16.22 26.1

12:11 448 38.2 16.19 26.2

12:12 451 38.4 15.56 18.5

12:13 457 38.5 15.61 20.2

12:14 460 38.6 15.78 18.1

12:15 466 38.7 15.46 14.5

12:16 453 38.8 15.46 19.7

12:17 464 38.9 15.66 13.9

12:18 461 38.9 15.58 16.1

12:19 473 39.0 15.13 10.4

12:20 479 39.0 15.06 10.6

ST/DEM0753/27.01.15/

12:21 472 39.0 15.14 12.8

12:22 479 39.1 15.44 11.2

12:23 478 39.1 15.48 11.3

12:24 471 39.1 15.46 9.3

12:25 478 39.1 15.74 9.7

12:26 456 39.1 15.18 7.2

12:27 467 39.2 16.18 9.2

12:28 470 39.2 15.68 9.0

12:29 463 39.3 15.83 19.0

12:30 448 39.4 15.54 17.4

12:31 472 39.5 15.96 11.1

12:32 477 39.6 15.93 10.3

12:33 475 39.7 15.93 10.6

12:34 477 39.8 16.01 11.9

12:35 479 39.9 16.05 10.2

12:36 483 40.0 16.24 10.7

12:37 471 40.1 16.02 19.2

12:38 453 40.1 16.03 18.7

12:39 471 40.2 16.37 10.2

12:40 479 40.2 16.47 10.1

12:41 478 40.4 16.53 11.3

12:42 469 40.4 16.48 17.8

Average 462 37.8 16.04 21.1

ST/DEM0753/27.01.15/


)

)


Mercury

Contract

Date

Location

Enginee s)

Absorbent

Jersey Qematorium, DEM0753


Qemator Stack

ST

4% K2CR20;-/ 20% HN03 in H20

Test Log


Gas MeterTemperature(Deg C)

Oxygen Concentration(%v/v dry)

Flue Gas Volumetric Flo'A{Nm3/h dry)

Test 10

103.0

28.0

16.20

3108

Test 11

103.0

33.7

16.32

2449

Test 12

103.0

37.8

16.04

2329

Time

Gas Meter Reading(Am3

dry)

Absorber Weight(g)

Start

10:03

126.465

3309.0

End

11:03

127.013

3336.9

Start

13:43

127.657

3365.9

End

14:43

128.113

3385.1

Start

11:42

129.140

3341.6

End

12:42

129.589

3360.3

Filter Reference

Filter Fraction Analysed

Filte IJ9 as Hg)

Filter Blank(g as Hg)


Probe Rinse Volume(ml)

Probe Rinse( g/1 as Hg)

Probe Rinse Blank( g/1 as Hg)

Absorbent Reference


Absorbent( g/1 as Hg)

Absorbent Blank( g/1 as Hg)


JE270115HgF21

1

0.02

0.01

Washed into HgA

0

0

0

JE270115HgA21

500

44

0.5

JE270115HgF22

1

0.03

0.01

Washed into HgA

0

0

0

JE270115HgA22

500

160

0.5

JE280115HgF23

1

0.1

0.01

Washed into HgA

0

0

0

JE280115HgA23 A&B

250 250

370 11

0.5 0.5




dry)


dry)

Mass of Dry Gas(g@ 1292.8 g/Nm3


Water Vapour Volume(Nm3 @ 803.9 g/Nm3

Gas Volume(Nm3

wet)

Mass of Wet Gas(g)

Moisture Concentration("'ov/v)

Moisture ConcentrationF/ow/w)

103.0 103.0 103.0

28.0 33.7 37.8

0.548 0.456 0.449

0.5053 0.4127 0.4010

653.27 533.48 518.46

27.9 19.2 18.7

0.0347 0.0239 0.0233

0.5400 0.4365 0.4243

681.17 552.68 537.16

6.4 5.5 5.5

4.1 3.5 3.5

ST/DEM0753/27.01.15/


Calculation: Mercury

Filter{IJg as Hg)

0.01

0.02

0.09

Probe Rinse(IJg as Hg) 0.00 0.00 0.00

Absorbenl(IJg as Hg) 21.75 79.75 95.00

Total Mercury Sampled(IJg) 21.76 79.77 95.09

Mercury Emission(IJg/Nm3

dry) 43.06 193.31 237.11


Mercury Emission 90.20 415.35 480.86

(1Jg/Nm3


Flue Gas Volumetric FlolJIKate(Nm3/h dry)

3108

2449

2329

Mercury Emission(g/h) 0.134 0.473 0.552


4.42

3.48

3.31


Area of Nozzle(m 2

) 0.00002827 0.00002827 0.00002827



lsokinetic Closure(%) 112 116 119

116

ST/DEM0753/27.01.15/


)

)



Contract

Date

Location

Engineer(s)



Cremator Stack

ST

Test Log

Flue Gas Temperature(Deg C)

Test 10

417

Test 11

451

Test 12

462



Flue Gas Moisture(%v/v) 6.4 5.5 5.5

Flue Gas Mo islure (%w/w) 4.1 3.5 3.5



500 x 410 mm Re clangular Stack

0.2050

Calculation

Flue Gas Density(kg/m3

0.5034 0.4812 0.4738

Sample Points





Duct Mean





11.95 9.77 9.44

8816 7210 6964

8250 6816 6582

3263 2571 2444

11.38 9.31 8.99

8399 6869 6634

7859 6493 6270

3108 2449 2329

/

`

APPENDIX 2

Analysis Reports

/

Davies & Co.(Environmental} Ltd 'llo- '11(01 ng Jpi I':JJiS

!iAL

Scientific Analysis Laboratories Ltd

Certificate of Analysis Ef' ' COI'IC[Ff LI H SC I HI CH "''"' H'

Sce1tJtic AMiysis Lal:xMatorieis a

lifnled ronpany r egislereJ inErYJaJidald

Wales(No 2514786) vthose c.ddress Is at

Ha:111eld House.Hacfrek1 Stree:.Mancnester M1bFE

Hadfiek:l Hcuse

HadIeiO StJeet

ComtliOOK

fv1ancnester

Ml6 9FE

Tel 0161B74 2400

Fax 0161872 0·1

Report Number: 454531-2

Date of Report: 27-Feb-2015

Customer: Davies & Co (Environmental)

Moor Road

Leeds

LS10 200

Customer Contact: Mr Steve Atherton

Customer Job Reference: DEM0753

Customer Purchase Order: 50001045

Date Job Received at SAL: 09-Feb-2015

Date Analyssi Started: 09-Feb-2015

Date Analyssi Completed: 27-Feb-2015

The results reported relate to samples received in the laboratory

Opinions and interpretations expressed herein are outside the scope of UKAS accreditation

This report should not be reproduced except in full without the written approval of the laboratory

Tests covered by this certificate were conducted in accordance with SAL SOPs

All results have been reviewed in accordance with QP22

1549

Report checked

and authorised by :

Kayleigh McCann

Project Manager

Issued by:

Kayleigh McCann

Project Manager

Page 1 of 3

454531-2

/

Davies & Co.(Environmental} Ltd 'lo- '11(01 ng Jpi I ':JJiS

SAL Reference· 454!=..11

Customer Reference: DEM:1753

Aller Ma.lysed as Filter

Miscelal neous

SAL Reference 454531010 454531 011 454531012 454531 013 454531 014

Customer Sam[lle Reterenee JE270115 HGF21

JE27011S HCF22

JE280115 HGF23

JE280H5 HGF24

JE28011S HGFBLANK

Test Semple AR AR AR AR AR

Date Samp ed 27.-J Atl-2015 27..JAN·2015 28-JAN-2015 28-JAN-2015 U..JAN-2015

Oetermni and I Method I LOD I Units j SymOOI

r.A I..'UI ICVAFS(HF Oige•l BS EN 13211) I 0.01 I I u 0.02 0.03 0.10 0.08 <0.01

SAL Reference: 454531

Customer Reference: OEM:l753

Aller Analysed as Hiler

Miscelal neous

SAL Reference 454531015 454531 016

Customer Sample Reference ,I E200115 HGF11

JE290115 HCF12

Test Sem l e AR An

Date Sampled 29-JAtl-2015 29-JAN-2015

Oeterminand Method LOD Units Symbol

N lo"UI ICVAFS(HF Dlge•l BS EN 13211) I 0.01 I I u (1510.19 (Hll5) 1.6


Customer Reference: DEM1753

Malysed as lmOinoer 14%K2Gr207120o/.HMJ3)

T &o7120%HN03)

Msi cel aneous

SAL Referance 454531017 454531 018 454531019 454531020 454531021

Customer Samp e Ref erence JE270116 HCA21 JE270116 HGA22 JE280116 HOA23A

JE280116 HOA23B

JE280115 HGA24

TestSamole AA AA AR AR AA

Date Sampled 27-.JAN·2015 27-JAN·2015 2!hJAN-2015 28-JAN-2015 28-J Ar4-2015

oeterminana I etnoa I LOD I units I Symool

ercurv CVAFS 6S E132·1 0.5 uan u (19·<W (l!i 16{) (U IJ70 11'11 \1!122


Customer Reference: DEM:I753

ImpInger Analysed as lmpil'lgef C 4%K2Cr207120%HI\03) (<%K2Cr207!20•.oHN03)

Nlscell eneous

SAL Ref erence 454531022 454531 023 454531024 454531025

Customer Samp e Reference JE28011!i HGABLANK

JE29011!i HGA11 JE290115 HGA12A

JE290115 HGA128

TestSamole AR AR AR AR

Date Sampled 28-JAN-2015 29-JAN-2015 29-JAN-2015 29-JAN-2015

O@t@rmni and I Method I LOO I Ulllts I Syml>ol

Gf'CUI)' IcvAFS (ESEm·, ,) I o.5 I u9n I u 4).5 (19!i174 I <19)2500 (195) 37

SAL Reference: 4.:i453i

Customer Rere.-ence; DEM:l7 3

lmplnger(Dt water) h'lalyd a:s lmpin9Cf(DI water)

Nlscell eneous

SAL Reference 454531 001 454531002 454531 003 454531 004 454531005

Cu$1omer Sam le Reference JE27011!i H21 JE270115 H22 JE280115 H23A JE26011!i H2JB JE200115 H11

Te!it Sarnpte AA AR A A AA AR

OateSample<l 27-JAN-2015 27-JAN-2015 28-JAN-2015 28-JAN-2015 28-JAN 2015

Oetermnl and I Method I LOO I unos I sv100o1

t-ydrngen Dlbfice I IC I o.os I Mo/1 I u (13)7.0 I (13) 14 I (13) 19 113> 0.11 (13}12

Produced by Sc;entific Analysis Laboratories Ltd, Hadfield House, Hadfield Street, Cornbroo<, Manchester, M16 9FE Page 2 of 3

454531-2

/


SAL Reference· 454!=..11

Customer Reference: DEM:1753

lmplnger(DI water) Ma.lysed as lmoinger(DI wat€r)

Nlscelal neous

SAL Reference 454531 006 454531 007 454531 008 454531 009

Customet" Sampll! Reference JE290115 H12 JE290115 H13A JE 290115 HI 3B JE290115 HOB

Tet Sample AR AR AR AR

Date Sampled 29-JAN-2016 2-JAN-2016 29-JAN-!2016 29-JAt -2016

Oeterminn(l Method LOO Units Symbol

...ydr:>gon Olbrice I IC I o.os I ng/1 I u (13) !).8 I (13l t9 I '13l o.os UJ>o.os

Index to symbols used in 454531-2

Value AR As Recel'led

195 Due to 1e·1esl foun:l inthe sample that are Oliside olthe oormc.lc<:libraton range of theinstrument. anasis wasrond.Jcted c.na dluted carrpie

13 Rccultc hove t<ln bl01ri< corro:;ted.

AnalysisUK6..S !lccrcdited

Produced by Sc1entific Analysis Laboratories Ltd, Hadfield House, Hadfield Street Cornbroo<, Manchester, Mf 6 9FE Page 3 of 3

454531-2


Particulate Weight Determination

Filter I Rinse Referenee Clean Dry Weight g Dirty Dry Weight g

JE270115F21

JE270115F22

JE280115F23

Q9

Q10

Q11

0.56630

0.56783

0.54792

0.57785

0.57707

0.55235

JE280115F11

JE290115F12

JE290115F13

Q12

Q13

Q14

0.57074

0.57484

0.54724

0.58227

0.58455

0.55384

JE270115R21

JE270115R22

JE280115R23

1

2

3

79.48711

79.48857

79.48975

79.48857

79.48975

79.49031

JE280115R11

JE290115R12

JE290115R13

1

2

3

79.49031

79.49177

79.49300

79.49177

79.49300

79.49384

ST/DEM0753/27.01.15/

APPENDIX 3

Details of Test Cremation Charges

Redacted

EMISSIONS MONITORING TEST REPORT JERSEY CREMATORIUM

Documents

Transcript of EMISSIONS MONITORING TEST REPORT JERSEY CREMATORIUM