DV-P505U SERVICE MANUAL DV-P505E DV-P505E(UK) DV …The following figure shows the block diagram of...
Transcript of DV-P505U SERVICE MANUAL DV-P505E DV-P505E(UK) DV …The following figure shows the block diagram of...
This is a device for DVD playback.
This device is to be used by connecting it to the video input terminal of a TV set.
T Disc navigation system facilitates program search.
T Speedy operation by 2x speed drive.
ADVICEPlease carefully read this guide before using the device. The Hitachi DVD Player has been designed to prevent fire, electrical shock, injury, or harmful radiation. It has been legally fabricated in accordance with the Electrical Appliances Act. Therefore, when using the device, please follow advice in this service guide to keep it safe to use.
1. In brief
2. Features
SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT.
April 2000 Digital Media Products Division, Tokai
SERVICE MANUAL
DV-P505UDV-P505EDV-P505E(UK)DV-P505U(PX)
TK NO. 9002E
DVD PLAYER
I
Before undertaking repair work, please read through this [Precautions for safety].
The following points should be observed in order to prevent accidents from happening and to ensure the safety of the device.
! Degrees of danger or damage that can be caused by faulty operation are indicated by the following marks:
! The following marks identify actions to be taken:
PRECAUTIONS FOR SAFETY(Please follow.)
Under this mark, there is “Possible death or serious injury”.
Under this mark, there is “Possible injury or material damage”.
This mark indicates items to which ‘You should pay attention’.
This mark indicates items ‘You have to accomplish’.
This mark indicates: ‘You should be cau-tious of electric shock’.
This mark indicates ‘Forbidden items’.
! You should pay attention. ! The original part installation and wiring route shall be restored.
Where a special attention is required, it is indicated by a label or stamp. For example, on the cabinet, chassis, or parts.Please respect the indicated items and the ‘Precautions for use’ of the manual.
For safety, some parts are insulated by a tube or a tape, or installed without contact with substrate. The internal wiring is kept a distance from hot or high voltage parts by clamps or routing. Please restore them as initially done to prevent electric shock or fire from happening.
! You should be cautious against electric shock.
Please be careful during operations because there are high voltage and recharging parts inside. An electric shock or death may happen by touching them.When disassembling, assembling, or replacing a part, the power plug has to be pulled off.Touching by error a powered part may cause an electric shock, death, or injury.
! Please check safety after servicing.
Please check if dismounted screws, parts, and wires are reinstalled as before and if the area surrounding the repair is damaged. Please also measure insulation resistance with a ohmmeter and to confirm that it is more than 20MΩ.There is risk of electric shock or fire if the insulation resistance is less than 20MΩ.
! Please use designated parts.
Parts are characterized by uninflammability and voltage resistance. Therefore, parts having these same characteristics must be used in replacement.Especially for parts important in insuring safety, identified by in the schematic or parts list, a part with the identical part number shall be used.If a part with a different part number is used, an electric shock or a fire may occur.
WARNING
CAUTION
WARNING
II
Chapter 1 System Introduction 1
System Specification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1Hitachi DV-P505U/U(PX) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1Hitachi DV-P505E/(UK) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
System Outlook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Front Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Display Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Rear Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Description of adopted new technology. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Digital signal circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Video circuit (DEC substrate). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6Video Output Circuit (VDO substrate) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Audio Circuit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11FRONT (FSW) SUBSTRATE CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12POWER SUPPLY CIRCUIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12CLOCK CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16VIDEO CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16AUDIO CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17About System Reset Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20System Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Chapter 2 Removal and Replacement 21
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22Before You Begin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Disassembly Procedure Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Disassembly Procedure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Removing the Top Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24Removing the Foot Stand . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24Removing the Front Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Removing the MPEG Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26Removing the Power Supply Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Removing the DVD-ROM Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Removing the Outlet Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28Removing the Front Panel Control Boards . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29Connector Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Appendix A Schematics 33
Table Of Contents
Chapter 1 1
System Specification
Hitachi DV-P505U/U(PX)
Specification
General Model ......................................................................................................... DV-P505U/U(PX)
Operating laser ......... Semi-conductor laser : Wave length 650nm(DVD) / 780nm(CD,VCD)
Power supply ............................................................................. DV-P505U : AC120V, 60Hz.............................................................................. DV-P505U (PX) : AC110-240V, 50/60 Hz
Power consumption ........................................................................................................24W
Weight .......................................................................................................................... 3.7 kg
Overall size ...........................................................................434 (W) x 284 (D) x 91 (H) mm
Allowable operating temperature ..................................................................... +5° C~+35° C
Allowable operating humidity ...................................................... 15~75% (no condensation)
Component output terminal Y output level .................................................................................................... 1 Vp-p (75Ω)
PB output level .................................................................................. NTSC : 0.7 Vp-p (75Ω)
..........................................................................................................PAL : 0.698 Vp-p (75Ω)
PR output level .................................................................................. NTSC : 0.7 Vp-p (75Ω)..........................................................................................................PAL : 0.698 Vp-p (75Ω)
Output terminal ..........................................................................................................pin jack
S Video output terminal Y output level ..................................................................................................... 1Vp-p (75Ω)
C output level ................................................................................. NTSC : 0.286Vp-p (75Ω)...............................................................................................................PAL : 0.3Vp-p (75Ω)
Output terminal ......................................................................................................S terminal
Video output Output level ........................................................ 1 Vp-p (synchronous when loaded at 75Ω)
output terminal ...........................................................................................................pin jack
Audio output Output level .....................................................................................200mVrms (lkHz, -20dB)
Mixed 2ch output................................................................................ 1 system (pin jack x 2)
5.1ch output ..................................................................................... 1 system (pin jack x 6)
Sound characteristics : Frequency characteristics ............................................................ CD : 4Hz~20kHz (EIAJ) ..................................................................................... DVD : 4Hz~22kHz (48k sampling) ................................................................................................4Hz~44kHz (96k sampling)
SN ratio ...................................................................................................................110 dB
Dynamic range...........................................................................................................90dB
Total harmonic distortion rate .................................................................................0.005%
Wow/flutter .................................Measurement limit less than (±0.001% W.PEAK)(EIAJ)
Other terminals Digital audio output optical/coaxial.......................................................... Coaxial terminal : 1
(DTS/AC-3/MPEG2, LPCM, OFF commutable) ................................ Optical connector : 1
Accessories Remote control unit .............................................................................................................. 1
Single ‘AAA’ battery.............................................................................................................. 2
AV cord................................................................................................................................. 1
Power cord........................................................................................................................... 1
AC socket (DV-P505U(PX) only) ......................................................................................... 1
System Introduction
Chapter 1
2 Chapter 1
Hitachi DV-P505E/E(UK)
Specification
General Model ......................................................................................................... DV-P505E/E(UK)
Operating laser ......... Semi-conductor laser : Wave length 650nm(DVD) / 780nm(CD,VCD)
Power supply ............................................................................. DV-P505E : AC230V, 50Hz
Power consumption ........................................................................................................24W
Weight ..........................................................................................................................3.7 Kg
Overall size ...........................................................................434 (W) x 284 (D) x 91 (H) mm
Allowable operating temperature ..................................................................... +5° C~+35° C
Allowable operating humidity ...................................................... 15~75% (no condensation)
AV connector output terminal
AV connector output.................................................................................... 21-pin connector
This connector provides the video and signals for connection to a color video TV monitor (or TV set) which has an ‘AV CONNECTOR’ terminal.
S Video output terminal Y output level ..................................................................................................... 1Vp-p (75Ω)
C output level ................................................................................. NTSC : 0.286Vp-p (75Ω)...............................................................................................................PAL : 0.3Vp-p (75Ω)
Output terminal ......................................................................................................S terminal
Video output Output level ........................................................ 1 Vp-p (synchronous when loaded at 75Ω)
Output terminal ..........................................................................................................pin jack
Audio output Output level .....................................................................................200mVrms (lkHz, -20dB)
Mixed 2ch output................................................................................ 1 system (pin jack x 2)
5.1ch output ..................................................................................... 1 system (pin jack x 6)
Sound characteristics : Frequency characteristics ............................................................ CD : 4Hz~20kHz (EIAJ) ..................................................................................... DVD : 4Hz~22kHz (48k sampling) ................................................................................................4Hz~44kHz (96k sampling)
SN ratio ...................................................................................................................110 dB
Dynamic range...........................................................................................................90dB
Total harmonic distortion rate .................................................................................0.005%
Wow fluttertics.............................Measurement limit less than (±0.001% W.PEAK)(EIAJ)
Other terminals Digital audio output optical/coaxial.......................................................... Coaxial terminal : 1
(DTS/AC-3/MPEG2, AC3, LPCM, OFF commutable) ....................... Optical connector : 1
Accessories Remote control unit .............................................................................................................. 1
Single ‘AAA’ battery.............................................................................................................. 2
AV cord................................................................................................................................. 1
Power cord........................................................................................................................... 1
Chapter 1 3
System Outlook
PUSH ENTERTOP MENU
MENU
SETUP
SKIPSTOP PAUSEPLAYOPEN/CLOSEVIRTUAL
SURROUND
POWER/STANDBY
ANDBY button
VIRTUAL SURROUND button
Signal receiving eye for remote control
OPEN/CLOSE button
STOP button
PLAY/PAUSE button
TOP MENU button
SKIP buttons
PUSH ENTER button
Tray
LAST
Video CD
CD DVD
TRACKTITLE CHAPTER
ANGLE
REPEAT ALL A BRANDOM PROGRAMPBC TOTALREMAIN TIME
Linear PCMDolby Digital
MPEG AudioVIRTUAL
H M
kHz bit
S
FRONT
Lights if the stop position is in memory.
Indicates the Track or Title number being played.
Indicates the elapsed time orremaining time of the disc.
Indicates the Audio Type being played.
Indicates the play status.
Indicates the Chapter number.
Indicates the operational mode.Indicates the disc type.
<Display>
MENU button
SETUP buttonPOWER/STANDBY button
4 Chapter 1
Rear Panel
S
S
Y
R
B
P
P
OUT
AC
DV-P505U /U(PX)
335A131
335A132
c
c
AC
DV-P505E / E(UK)
Chapter 1 5
Description of adopted new technology
Digital signal circuit
Data Flow
The following figure shows the block diagram of digital signal circuit.
The disc data read by DVD ROM Drive will be passed to A/V processor (IC1201) throught 16 bits parallel interface. A/V processor (IC1201) parses the system layer and demultiplexes the audio and video streams. Audio is decoded and passed through the audio interface to external audio DACs (IC 1501~1503) and then to the speakers. Video is decoded and output as YCBCR pixels to video encoder (IC2201).
Reference Clock of each IC
IC Reference Clock
IC1201 A/V PROCESSOR System clock and video interface clock are input from X1201 27MHz X'TAL.
Audio interface clock is output at 39 pin named DA-XCK to Audio DAC.
IC1601 FLASH MEMORY Nil (Control signal is generated by IC1201)
IC1202~IC1203 BUFFER RAM Nil (Control signal is generated by IC1201)
IC1604 EEPROM Nil (Control signal is generated by IC1201)
DVD ROMDRIVE
PG1101
FLASH M EM ORY8M bit
IC1602
BUFFER RAM16M bit x 2 SDRAM
IC1202~IC1203
27 M Hz X'TALX1
A/V PROCESSORIC1201
TO AUDIO DAC
TO VIDEOENCODER
EEPROMIC1604
6 Chapter 1
Functions of each IC
The following is the description of the functions of each IC:
1. A/V PROCESSOR (IC1201)It is a single-chip A/V processor that integrates several modules functioning MPEG video decoding, DVD system navigation, Content Scrambling System(CSS), DolbyTM Digital (AC-3), DTS and MPEG audio decoding respectively.Data input is separated into video data and audio data. Then the two data is decoded and output as digital video and digital audio respectively. A build-in RISC transfers data and executes presetting and control of each modeule. System clock, clock of video interface signals operate by inputting 27MHz respectively.
2. Flash Memory (IC1601)A 4Mbits flash memory is used. It stores program of the preceding build-in RISC and its access is controlled by said RISC.
3. BUFFER SDRAM (IC1202~1203)Two 16Mbits SDRAM are used. A/V processor controls it and it is used to decompress audio and video compressed by MPEG.
4. EEPROM (IC1604)
Video circuit (DEC substrate)8bit YCRCB digital video stream (Parallel) output from A/V processor are input to video encoder ADV7170(IC2201). Video encoder is preset in master mode that generates reference signals and receives 27MHz from system clock X1 and outputs Horizontal, Vertical synchronous signals to A/V processor.
By presetting of internal register, video encoder generates:
1. NTSC (North America, Japan, Taiwan)
2. PAL (Europe, Asia)
standard analog video signals.
No. IC FunctionsOperating
Voltage
1 IC1201 A/V PROCESSOR Execute data transfer, presetting and control of each IC.
Execute decompression (decoding) of data compressed by MPEG, AC3, DTS.
3.6V
2 IC1601 FLASH MEMORY Store memory for A/V processor’s RISC software 5V
3 IC1202~IC1203 Memory used for decompression (decoding) of data compressed by MPEG and control by A/V processor.
3.3V
4 IC1604 EEPROM Store program code of system 5V
Chapter 1 7
Filter circuit eliminates high frequency components of analog video signals output from video encoder. Afterwards in S2 processor circuit DC voltage is superposed on C signals then output 3 types of video signals: composite video signals, Y/C(S2) video signals and YPBPR/RGB to RJK substrate via 17P connector (PG2201).
The following is a description of video circuit along signal flow:
VIDEO ENCODER ADV7170 (IC2202)
1. MULTIPLEXER SECTORIt transforms input digital video stream (Input at 1~4, 38~42 pins) in 8bit parallel data then separates them in Y data and CB/CR data and changes simultaneously the rate (6.75MB/S->13.5MB/S).
2. CONVERTER SECTORIt generates various internal timing signals with the synchronous signal as standard by adding synchronous signals generated in IC to Y data, according to the conditions set in the internal register or by adding BURST signals to CB/CR data. At the same time it outputs these synchronous signals to A/V processor (Output at 15,16 pins). In addition, when power is turned ON, RESET signal (Input of L level at 22 pin) is input to reset the register in IC.Moreover, writing in the internal register (presetting) is done via I2C BUS ( 23,24 pins).
3. ENCODER SECTORThe following a~c data are inserted in VIDEO DATA according to preset conditions in the internal register:
a. Closed captionNTSC Mode: 21 lines and 284 lines/ PAL Mode: 22 lines and 335 ines.
b. CGMS (Copy Guard Management System)20 lines and 283 lines of NTSC.
c. Macrovision Copy Prevention System (Anti Taping)Finally it generates Analog Colorstripe, AGC Palses, Pseudo-sync, EOF Back Porch Pulses.
d. D/A CONVERTER (DAC)SECTORConstituted of 10bit DAC, it transforms DIGITAL VIDEO DATA to ANALOG VIDEO DATA for output.
I2CINTERFACE
S Y N CA D D E R
B U R S TA D D E R
C L O S E DCAPTION
Y/C MIX
C H R O M AE N C O D E R
MACROVIS ION
C G M SDEMULTIPLEXER
C O N V E R T E R
U P S A M P L ED A C
I2C BUS
ENCODER SECTOR
CONVERTER SECTOR
Y
C B/CR
P(1~4, 38~42)
RESET (22)
SDA/SDL (24, 23)
V O L T A G E R E F E R E N C E(25/33/34)
D/AC O N V E R T E R
S E C T O R
Y (27)
C (26) CVBS (32)
Y/G (27)
PB/B (31) P R/R (26)
B L A N K(17)
H /V SYNC OUT(15/16)
C L K(44)
MULT IPLEXERS E C T O R
Block Diagram of VIDEO ENCODER ÃDV7170 (IC2201) interior
8 Chapter 1
Under control of output voltage by DAC pins (25, 33, 34 pins), it output 3 kinds of ANALOG VIDEO SIGNALS:
1. ANALOG COMPOSITE VIDEO SIGNALS (CVBS/32 pin), output voltage 1.0Vpp.
2. ANALOG S VIDEO by ANALOG LUMINANCE SINGLES (Y/27 pin), output voltage 1.0Vpp and ANALOG CHROMA SIGNALS (C/26 pin), BURST part output voltage 286mVpp.
3. ANALOG COMPONENT YPBPR/RGB.
S2 Processing Circuit (only for Japan)
S2 is a standard used in wide television sets possessing screen size switching function in NTSC mode. By inputting VIDEO signals formed by superposing DC voltage on C signal at S input terminal, it switches automatically to TV display size. The DC voltage superposed on C signal varies according to the ASPECT RATIO of VIDEO SIGNALS.
1. Case of SQUEEZE SIGNAL (*1)H-level voltage is input in SQUEEZE INPUT; Q2212 and Q2213 are powered and +4V DC voltage is superposed on C signal output line.
2. Case of LETTER BOX SIGNAL (*2)H-level voltage is input in LETTER INPUT; Q2209, Q2210, and Q2211 are powered and +1.8V DC voltage is superposed on C signal output line.
1. *1: It is a laterally shrunk image information with 525 lines and an aspect ratio of 16:9 carried by the standard TV signal format of 525 lines and an aspect ratio of 4:3. When viewing on a 4:3 TV set, the image appears vertically oblong.
2. *2: It is a wide screen signal in the standard TV signal format of 525 lines and an aspect ratio of 4:3 with coexistence of upper and lower blank areas of 525 lines and an aspect ratio of 4:3 screen and the principal image area of 4:3 aspect ratio (line 53~232/316~495). When viewing on a 4:3 TV set, one sees black areas at the top and bottom of the screen.
Chapter 1 9
Video Output Circuit (VDO substrate)Analog composite video signals (CVBS), analog luminace signals (Y), analog chroma signals (C) and analog component signals (YPBPR/RGB) are sent from DEC substrate to VDO substrate by passing through 17P connector (PG2201~PG1302). From VDO substrate, CVBS signals are output from output terminal J1307 and Y/C signals are output from output terminal J1302. Component signals are output from output terminal J1306 (YPBPR) or J1361 (RGB).
Audio CircuitAudio circuit is shown in page 11.Audio circuit is composed of D/A converter sector (DEC substrate) that transforms digital audio signals output from A/V processor (IC1201), analog processing sector (RJK substrate) that consists of an operational amplifier, and mute circuit (DEC substrate, RJK substrate) for stopping audio output when required.
1. D/A CONVERTER SECTOR (DEC substrate)D/A converter sector is composed of IC1503 that receives and transforms digital audio signals from A/V processor in analog signals.IC1503 is a converter corresponding to FL and FR signals of sampling frequencies 44.1/48/96KHz and data lengths16/20/24bit, and digital audio signals from A/V processor is input at pin 2.To these digital audio signals are inserted FL and FR signals in time sharing mode. When they are input in pin 1, they are separated in FL and FR signals by R clock and after transformation analog FL signals are output at pin 16 and FR signals at pin 13. Moreover, when there are no input signals at pin 2, a signal called ZERO MUTE is output to pin 21 to mute useless noises (See paragraph on MUTE CIRCUIT.)Every functions of IC1503 is preset by IC 1201and controlling signals from IC1201 are input at pins 26, 27,and 28. As for presetting items, there are data length, sampling frequency, signal polarity, and de-emphasis.
2. ANALOG PROCESSING SECTOR (RJK substrate)Analog processing sector is composed of operational amplifier IC1508 that is a filter and operational amplifier IC1510 that amplifies audio signals.Filter portion is composed of RC low pass filter and IC1508 formed active low pass filter and there are 3 sections. The diagram below shows its filter portion circuit (for FL signals only).
VIDEO
S
COMPONENT
PG2201 PG1302
J1307
J1302
J1361
J1306
DEC Substrate VDO Substrate
SCARTSQUEEZE
10 Chapter 1
This 3-section filter constitutes a low pass filter of overall cutoff frequency of 44kHz. Audio signals after low pass filter is amplified by IC1510 by about 6dB and output to audio out1 and audio out2.Here, among audio signals, FL signals are input at pin 3 of IC1508 and output from pin 1, then input to pin 2 of IC1510 then output from pin 1.FR signals are input at pin 5 of IC1508 and output from pin 7, then input to pin 6 of IC1510 then output from pin 7.
3. MUTE CIRCUIT (DEC substrate, RJK substrate)The principal role of mute circuit is the erasing of useless noises occurring when power is turned on.Mute signal for noise erasing is generated by IC1201, reverse-amplified by Q2501 and Q2502. Then by putting Q1310 and Q1311 'ON', it mutes audio signals.In addition, if IC1501 detects no-signal, it generate a mute signal called ZERO MUTE. This latter is reverse-amplified by Q1501 and mutes useless audio signals by putting Q1310 and Q1311 'ON'.
4. 5.1CH Difference List
Output D/A Converter Operational amplifier
Front L/R IC 1503 IC 1508, IC 1510, IC 1517
Surround L IC 1502 IC 1511, IC 1512
Surround R IC 1501 IC 1511, IC 1512
Center IC 1501 IC 1513, IC 1514
SUBW IC 1502 IC 1513, IC 1514, IC 15188
+
-
3
21 +
Filter 2Filter 1 Filter 3
IC1508C1567
R1533
C1571
C1561
R1531
C1563
R1529
C1559
R1527
Chapter 1 11
AUDIO CIRCUIT
12 Chapter 1
FRONT (FSW) SUBSTRATE CIRCUIT1. FL MICOM (IC1701)
It performs communications with IC 1201 ( pins 5, 6, 8, 9 ), including the main frame key, FL tube (IC1702) drive. In addition, it works also in standby mode.
2. INCLUSION OF MAIN FRAME KEY Input is done to FL MICOM at pins 10~13 for operation of S1701 ~ S1709 of mainframe key. Remote control signal is received by ultra-red receiver element (IC1703), output at pin 1 and input to IC 1201 at pin 166.
3. FL TUBE DRIVEGrid voltage of FL TUBE at pins 33~38 is controlled from FL MICOM at pins 39~44; anode voltage of FL TUBE at pins 5~23 from FL MICOM pins 15~32, 35. Filament voltage (AC 3.5V) is supplied from power source to FL TUBE at pins 1, 2, 41, and 42.
4. POWER INDICATORControl signals are output from A/V processor pins 17 and 18 to lights 2-color LED (LED1761) green or red. When power button is pushed 'ON', P. ON/OFF signal is output from A/V processor pin 17 and it switchs ON all system powers and red LED is lighten by a 5V; When standby, only STABLE signal is output to light green LED.
POWER SUPPLY CIRCUIT1. ESSENTIAL OF POWER SUPPLY CIRCUIT OPERATION
Power supply is RCC switching type. Energy is stored in transformer T1, when FETQ1 is 'ON', by AC110~240V impressed at AC inlet. After that, when FETQ1 turns 'OFF', the energy is released to the secondary side power supply. Two diverse circuits from secondary side includes SW (S5V, S 8V, S-8V, S12V) that are put ‘ON’ by A/V processor control. Signal (P. ON / OFF) of PG1201 pin 1 and permanently 'ON' supplies (A5V, A4.5V, AC3.5V, A-24V).Detection of secondary side voltage is by A5V. D15, and C18 compose its secondary side commutating circuit. It is fed back by photo-coupler PHC1 to primary side and maintains stable output voltage and is supplied to FL MICOM and ultra-red reception element.S5V output is from A5V output and by intermediary of output control circuit Q7.S4.5V is output from S5V diode D12.D13 and C16 compose secondary commutating circuit of S12 that is for DVD-ROM drive use.D13 and C16 compose secondary commutating circuits of S8V that is output by 3-terminal regulator IC2. For audio circuit proper +5V power supply, AUD S5V is produced from S8V in 5V regulator IC1504 (in DEC substrate).D19 and C27 compose secondary commutating circuit of S-8V.A-20V is negative power supply to FL tube. D16 and C23 compose its secondary commutating circuit.AC3.5V is for FL tube heater. To prevent fluctuation of output voltage due to that of power source, a self-exciting push-pull circuit is used. It is input from A5V, passes DC/AC inverter composed of transistors Q5, Q6 and transformer T2 and output. It supplies stable voltage without being disturbed by power source fluctuations. It plays an important role in FL tube life maintenance and against brightness decrease.
2. OPERATION OF PROTECTION CIRCUITProtection circuits are different according to different power supplies.For A5V and S5V,when load current increases and exceeds the control limit of the primary side of the regulator, the over current protection circuit of the primary side operates and regulator output will decrease suddenly. At the same time other outputs stop.For S12V and S8V, when load current increases and exceeds the control limit of 3-terminal regulator, the internal over current protection circuit operates and output will suddenly decrease.By pulling off plug from wall socket, eliminating short circuit, replace destroyed parts, and plug in again, the normal state will be restored in its secondary commutate.
Chapter 1 13
CLOCK CIRCUITS
27MHz X'TAL (X1201)
Block diagram for 27 MHz clock circuit is shown in Fig. 5-8-1.
When power is supplied to 27 MHz X'TAL, it generates 27MHz clock and input it to A/V processor (IC1201), video encoder (IC2201).
1. A/V PROCESSORThe A/V processor uses it as CLOCK PCLK2X (input at pins 117) of video interface signal and output digital video stream synchronized to PCLK2X from 8bit video data bus VDATA[7:0] (output at pins 106, 107, 108, 109, 110, 113, 114, 115 )
2. VIDEO ENCODERAt video encoder it is used as system clock CLK (input at pin 44) and output horizontal synchronous HSYNC (output at pin 15 ) and vertical synchronous VSYNC (output at pin 16) to A/V processor.
3. Audio DA ConverterThe audio external frequency clock signal DA-XCK is used as system clock. DA-XCK is supplied from A/V processor (output at pin 39 ) to Audio DAC (input at IC1501~IC1503 pin 5).IC1201: The DA-XCK is used to generates Audio bit clock TBCK (output at pin 40) and LR clock TWS (output at pin 32).
* The Audio Interface Unit inside A/V processor corresponds to sampling frequencies (fs) 44.1kHz (CD-DA, Video-CD), 48kHz, 96kHz (DVD).
The frequency of TBCK is defined by Formula 1:
f TBCK = Audio data bit length * 2 * fs .......................................................................................................1
At A/V decoder, interior DA-XCK is divided into 8 equal parts and output as TBCK (Formula 2)
f TBCK = f DA-XCK /8 ...............................................................................................................................2
Therefore, DA-XCX frequency takes the value 384fs according to formulas 1 and 2. Audio data bit length is fixed 24bit. (Formula 3)
f DA-XCX = Audio data bit length * 2 * fs * 8 = 24 * 2 * fs * 8=384 fs.........................................................3
According to Formulas 2 and 3, A/V decoder drives TBCK
with frequency 48 times of sampling frequency. (Formula 4)
f TBCK =384fs/8 = 48fs..............................................................................................................................4
The relationships between Audio interface signals (DA-XCK, TWS, TBCK) and each sampling frequency are as follows:
T Sampling frequency: 44.1 kHz (For CD-DA and Video-CD)DA-XCK 384*fs=16.934MHzTBCK DA-XCK/8=2.1168MHzTWS TBCK/48=44.1kHz=fs
T Sampling frequency: 48kHz (for DVD)DA-XCK 384*fs=18.432MHzTBCK DA-XCK/8=2.304MHzTWS TBCK/48=48kHz=fs
DA-XCK Is interior clock used for generating TBCK and TWS, DA-XCK takes frequency 384 times the sampling frequency.
TBCK Is Audio bit clock obtained by dividing DA-XCK in 8 equal parts. It takes frequency 48 times that of sampling.
TWS Is clock that identifies channel (Lch or Rch) against all Audio sampling.
14 Chapter 1
T Sampling frequency: 96kHz (for DVD)DA-XCK 384*fs=36.864MHzTBCK DA-XCK/8=4.608MHzTWS TBCK/48=96kHz=fs
Chapter 1 15
16 Chapter 1
Troubleshooting
VIDEO CIRCUIT
NO IMAGE
ARE SIGNALSOUTPUT FROM VIDEOOUTPUT TERMINAL?
YesCHECK S IGNAL
CABLE/ MONITOR
ARE SIGNALSOUTPUT FROM IC2201pins 17,15,13,11,9,7,3?
?
YesCHECK V IDEO OUTPUTSECTOR (PG1302/J1307/
J1302/J1306/J1361) OFR J K P W B
No
No
ARE SIGNALSOUTPUT FROM IC2201
pins 26,27,31,32?Yes CHECK Q2202/Q2203/
Q2204/Q2205/Q2206
No
ARE SIGNALSIC2201
pins 15,16,17,23,24?
No CHECK IC1201
Yes
+5V AT IC2201pins 1,11,20,28,30,
37 (VDD)?No
C H E C K P O W E RSUPPLY CIRCUIT
Yes
IS VOLTAGE ATIC2201 pin 22
(RESET) H LEVEL?No CHECK IC1201
Yes
IS CLOCK INIC2201 pin 44? No CHECK X1
Yes
REPLACE IC2201
Chapter 1 17
AUDIO CIRCUIT
N O S O U N D
IS THEREAN IMAGE?
N oB R E A K D O W N
BEFORE IC1201
Yes
ARE IC1501pins 3, 13, 21
5 V ?
A R E T H E R ESIGNALS AT IC1501~4
pins 1, 16, 17, 18?
ARE IC1504 p in 2 +5V& pin 1 +8V
N oCHECK IC1610
OR +8V L INE ETC.
Yes
B R E A K D O W N O FIC1504
Yes
B R E A K D O W N O FIC1201
N o
A R E T H E R ESIGNALS AT p ins
11, 14 ?N o
Yes
A R E T H E R ESIGNALS AT IC1501~4
pins 6, 7, 8 ?Yes
B R E A K D O W N O FIC1501~4
N o
B R E A K D O W N O FIC1201
IS Q2501B A S E V O L T A G E
0 V ?
IS Q2502C O L L E C T O R
V O L T A G E-8V?
B R E A K D O W N O FQ2501, Q2502
Yes
IS IC1501~4pin10 V O L T A G E
5 V ?
B R E A K D O W N O FIC1501~IC1504
Yes
IS Q1501, Q1502, Q1503C O L L E C T O R V O L T A G E
-8V?
B R E A K D O W N O FQ1501 ,Q1502 ,Q1503
N o
Yes
Yes
ARE S IGNALS ATIC1508, IC1511,
IC1513pins 1,7 ?
B R E A K D O W N O FIC1508, IC1511,
IC1513
N o
N o
N o
N o
ARE S IGNALS ATIC1510, IC1512, IC1514
pins 1,7 ?
B R E A K D O W N O FIC1510, IC1512, IC1514
N o
B R E A K D O W N O FQ1306~Q1311
Y E S
N o
Yes
Y E S
18 Chapter 1
DV-P505 SERVICE PARTS LIST
SYMBOL P-NO DESCRIPTIONNO
MECHANISM SECTION
101 TS15611 POWER UNIT102 TE13411 CONNECTOR103 TE13421 CONNECTOR [U]103 TE13501 CONNECTOR [E,UK]104 TE13431 CONNECTOR105 TE13441 CONNECTOR106 TE13451 CONNECTOR [U]106 TE13561 CONNECTOR [E,UK]107 TE13461 FUSE108 UQ22621 MECHA ASSY(DVD)109 TA14171 RESISTOR FUSIBLE (R34)110 TE13531 CORD,POWER [U]110 TE13541 CORD,POWER [E]110 TE13551 CORD,POWER [UK]111 TJ14111 PANEL,FRONT [U]111 TJ14112 PANEL,FRONT [E,UK]112 TJ14131 COVER,TOP [U]112 TJ14132 COVER,TOP [E,UK]113 TJ14151 PANEL,TRAY [U]113 TJ14152 PANEL,TRAY [E,UK]114 TJ14261 PANEL,REAR [U]114 TJ14262 PANEL,REAR [E,UK]115 TJ14271 BUTTON [U]115 TJ14272 BUTTON [E,UK]116 KK10323 BELT
ACCESSORIES
802 TE15679 REMOTE HAND SET803 TE13081 CORD,AV
Chapter 1 19
20 Chapter 1
About System Reset FunctionThe player can not work normaily with non-standard discs. If you encounter the abnormal status , please press STOP button once to stop it. If it can’t stop normaily, please press POWER/STANDBY button. If the status is not changed in about 20 seconds after pressing POWER/STANDBY button then just press LAST button and ENTER button concurrently on the front panel to reset the system. After reseting, the system will restart and change into standby mode (The POWER/STANDBY indicator lights in red color ). Therefore, please press POWER/STANDBY button again to start the system. (Pull out the power cord and plug it again, the restarted system will also change into standby state.)
System Utility
How to upgrade the system utility
1. Power on the system and press the OPEN/CLOSE button to open the DVD-ROM tray.
2. Place the version-up CD-R disc into the DVD-ROM.
3. The DVD player will read the CD-R disc and upgrade the system utility version, after about 40 seconds, the DVD-ROM tray will open automatically.
4. Take out the version-up CD-R disc.
5. Pull out the power cord then plug it again.
6. Press the POWER/STANDBY button to restart the system, while the DVD-ROM tray closed, the version had been upgarded already.
NOTE: If the version of the system utility in the CD-R disk is older than original one, then the front display window will shows ‘No play’.
How to check the system utility version
1. At the power on state, press the POWER/STANDBY button and LAST button once in the same time and then release the POWER/STANDBY button only and still press the LAST button continually for more than 5 seconds.
2. The front display window will appear the system utility version.
Chapter 2 21
This chapter contains step-by-step procedures on how to disassemble the consumer product for maintenance and troubleshooting.
To disassemble the computer, you need the following tools:
T Wrist grounding strap and conductive mat for preventing electrostatic discharge
T Flat-bladed screwdriverT Phillips screwdriverT Tweezers
T Flat-bladed screwdriver or plastic stick
NOTE: The screws for the different components vary in size. During the disassembly process, group the screws with the corresponding components to avoid mismatch when putting back the components.
Removal and Replacement
Chapter 2
22 Chapter 2
General Information
Before You BeginBefore proceeding with the disassembly procedure, make sure that you do the following:
1. Turn off the power to the system and all peripherals.
2. Unplug the AC adapter and all power and signal cables from the system.
Chapter 2 23
Disassembly Procedure FlowchartThe flowchart on the succeeding page gives you a graphic representation on the entire disassembly sequence and instructs you on the components that need to be removed during servicing. For example, if you want to remove the system board, you must first remove the keyboard, then disassemble the inside assembly frame in that order.
START
TOP COVER
FRONT PANEL(W/ Foot Stand)
M P E GCONTROL BD.
P O W E R S U P P L YBD.
OUTLET BD.
FRONT PANELCONTROL BD.
(FSW)
M I C R O P H O N EV O L U M E
CONTROL BD.(MVR)
M I C R O P H O N EJACK BD. (FJK)
D V D - R O M
24 Chapter 2
Disassembly Procedure
Removing the Top Cover1. Remove two screws from each side of the machine and three screws from the rear side.
2. Use your hands to pull out the two sides of the top cover.
3. First, lift the top cover up lightly to release it from the front panel clicks, and then lift it up and move it away.
Removing the Foot Stand1. Detach the screw from the foot stand and remove the foot stand.
Chapter 2 25
Removing the Front Panel1. Disconnect the three cables from the MPEG control board.
2. Disconnect one cable from the power supply board.
3. Turn the machine over to remove the screw at the bottom of the front panel.
4. There is a plastic screw at the bottom side of the machine, use a screwdriver to slide the DVD-ROM tray out by turning the screw clockwise.
5. Use your fingers to slide up the DVD-ROM tray cover then push the tray back inside.
26 Chapter 2
6. Detach the clicks on the bottom side and two sides of the machine.
7. Pull the front panel out slightly.
Removing the MPEG Control Board1. Disconnect the five cables and remove the four screws from the MPEG control board as shown below.
2. Remove the MPEG control board away.
Chapter 2 27
Removing the Power Supply Board1. Disconnect the two cables and three screws from the power supply board.
2. Remove the two screws of the power socket on the rear panel of the machine.
3. Slightly lift up the power supply board to remove it from the machine. .
Removing the DVD-ROM Drive1. Detach the two screws on the daugther board and four screws from each side of the DVD-ROM drive and set it
aside.
2. Disconnect the power cable and the IDE cable from the DVD-ROM drive.
28 Chapter 2
3. Remove the four screws to detach the kitting part from top of the DVD-ROM drive.
4. Remove the four screws to detach the DVD-ROM shield and two EMI shields from the bottom of the DVD-ROM drive.
Removing the Outlet Board1. Disconnect the two cables and remove the three screws from the outlet board.
2. Remove the eight screws from the rear panel of the machine.
3. Remove the outlet boards away.
Chapter 2 29
Removing the Front Panel Control Boards1. Remove the five screws from the front panel control board (FSW board).
2. Remove the three screws from the microphone volume control board (MVR board).
3. Slightly lift up the front panel control boards then separate the two boards by detaching the connection connector as shown below.
30 Chapter 2
Connector Location
Chapter 2 31
32 Chapter 2
Appendix A 33
Schematics
Appendix A
76'76' 3//
)5(4
0+=
0+=
0+=
0+=
_/,1.
_6&+
_6&+
_6&+
_6&+
_6&+
_6&+
_6&+
'$'
'$'
'
'
'
'
'
'
%
$
$
'
$
&
&
&
'
'
'
'
'
'
'
'
&
&
&
&
'
&
&
'
&
&
&
&
'
&
%
&
'
&
'
'
%&
%&
&
&
&
&
%
%
%
%
$
%
%
%
1 . S C H 1
9 9 4 5 1 ( M P E G 2 D E C O D E R )
C
1 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
L D 0L D 1 L D 3
L D 2 L D 4 L D 2L D 3 L D 5 L D 1L D 4 L D 6 L D 0L D 5 L D 7 T S D0L D 6L D 7 L C S 3L D 8 L C S 2L D 9 L C S 1L D 1 0L D 1 1 L O EL D 1 2 V F D - C L KL D 1 3 V F D - C S
L D 1 4 Y S S - D O U T T S D1L D 1 5 IR
Y S S - C S JV F D - D A T A
W R L L S C LW R H L S D A
H A 2L A 0L A 1L A 2L A 3
T W SL A 4 L A 4L A 5 L A 5
L A 6L A 7 H A 1
H A 0H C S 3 T D M DXH C S 1
L A 8 H I O C S 1 6L A 9 H R DL A 10 H W RL A 11
H I O R D YL A 12 H R S TL A 13 H I R QL A 14L A 15 H W R Q
H D 1 5H D 1 4
L A 16L A 17L A 18 H D 1 3L A 19 H D 1 2
H D 1 1L A 21 H D 1 0
R S T E S S H D 9T D M DX H D 8
H D 7
H D 6H D 5H D 4
T W S H D 3T S D0 H D 2
H D 1H D 0
T S D1T S D2
H S Y N CD A _ XCK1 V S Y N CT B C K PCLK2XSPDIF PCLK2X
Y U V 7Y U V 6Y U V 5
Y U V 4Y U V 3
XIN Y U V 2Y U V 1Y U V 0D C L K
D S C KD M A 0 D Q MD M A 1 D C S 0D M A 2 D C S 1D M A 3 D B 1 5D M A 4 D B 1 4D M A 5 D B 1 3D M A 6 D B 1 2D M A 7 D B 1 1D M A 8 D B 1 0D M A 9 D B 9D M A 10 D B 8D M A 11 D B 7D C A S D B 6
D B 5D W E D B 4D R A S 0 D B 3
D B 2D B 1D B 0
LD[0. .7]
LD[8. .15]
LA[0. .17]
HD[0. .15]
YUV[0. .7]
DMA[0 . .11 ]
DB[0. .15]
LD[8. .15]
LA[0. .17]
DMA[0 . .11 ]
DB[0. .15]
YUV[0. .7]
HD[0. .15]
L C S 3L C S 2L C S 1
L O E
H A 2
H A 1H A 0H C S 3H C S 1H I O C S 1 6H R DH W R
H I O R D YH R S TH I R Q
H W R Q
H S Y N CV S Y N CPCLK2X
D C L K
D S C KD Q MD C S 0D C S 1
D C A S
D W ED R A S 0
W R H L
T W ST S D0
T S D1T S D2
T B C KSPDIF
XIN
S D AS C L
IR
V F D - C L KV F D - C S
V F D - D A T A
L A 18L A 19
LD[0. .7]
L A 4L A 5
L A 21
D A _ XCK1
R S T E S S
W R L L
Y S S - C S J
Y S S - D O U T
3 V 6
S T B Y
S T B Y
S T B Y
3 V 6
3 V 6
3 V 6
3 V 6
3 V 6
S T B Y
R A 1 2 0 1S R N 4 71234 5
678
R A 1 2 0 4S R N 4 7
1234 5
678
R A 1 2 0 5S R N 4 7
1234 5
678
R A 1 2 0 6S R N 4 71234 5
678
R A 1 2 0 7S R N 4 71234 5
678
R A 1 2 0 8S R N 4 71234 5
678
R A 1 2 0 9S R N 4 71234 5
678
R 1 2 0 3
4 K 7 R 3
1 2
R 1 2 0 4
D U M M Y - R 3
1 2
R 1 2 0 5
4 K 7 R 3
1 2
R 1 2 0 6
4 K 7 R 3
1 2
C 1 2 0 1S C 1 5 0 P
IC1201
E S 4 408
123456789
1 01 11 21 31 41 51 61 71 81 92 02 12 22 32 42 52 62 72 82 93 03 13 23 33 43 53 63 73 83 94 04 14 24 34 44 54 64 74 84 95 05 15 2
53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
101
102
103
104
1 0 51 0 61 0 71 0 81 0 91 1 01 1 11 1 21 1 31 1 41 1 51 1 61 1 71 1 81 1 91 2 01 2 11 2 21 2 31 2 41 2 51 2 61 2 71 2 81 2 91 3 01 3 11 3 21 3 31 3 41 3 51 3 61 3 71 3 81 3 91 4 01 4 11 4 21 4 31 4 41 4 51 4 61 4 71 4 81 4 91 5 01 5 11 5 21 5 31 5 41 5 51 5 6
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
203
204
205
206
207
208
V C CL A 4L A 5L A 6L A 7L A 8L A 9V S SV C CL A 1 0L A 1 1L A 1 2L A 1 3L A 1 4L A 1 5L A 1 6V S SV C CL A 1 7L A 1 8L A 1 9L A 2 0L A 2 1R E S E T #T D M D X / R S E LV S SV C CT D M D RT D M C L KT D M F ST D M T S C #T W S / S E L _ P L L 1T S D 0 / S E L _ P L L 0V S SV C CT S D 1 / S E L _ P L L 2T S D 2T S D 3M C L KT B C KS P D I F _ D O B MN CV S SV C CR S DR W SR B C KA P L L C A PXINX O U TV C CV S S
DM
A0
DM
A1
DM
A2
DM
A3
DM
A4
DM
A5
VC
CV
SS
DM
A6
DM
A7
DM
A8
DM
A9
DM
A1
0D
MA
11
VS
SV
CC
DC
AS
#D
OE
#/D
SC
K_
EN
DW
E#
DR
AS
0#
DR
AS
1#
DR
AS
2#
VC
CV
SS
DB
0D
B1
DB
2D
B3
DB
4D
B5
VC
CV
SS
DB
6D
B7
DB
8D
B9
DB
10
DB
11
VS
SV
CC
DB
12
DB
13
DB
14
DB
15
DC
S1
#V
SS
VC
CD
CS
0#
DQ
MD
SC
KV
SS
VC
C
D C L KY U V 0Y U V 1Y U V 2Y U V 3Y U V 4
V C CV S S
Y U V 5Y U V 6Y U V 7
P C L 2 X S C NP C L K Q S C N
V S Y N C H #H S Y N C H #
V S SV C C
HD0/DCI0HD1 /DCI1HD2 /DCI2HD3 /DCI3HD4 /DCI4HD5 /DCI5HD6 /DCI6
V S SV C C
HD7/DCI7H D 8 / D C I _ F D S #
H D 9H D 1 0H D 1 1H D 1 2H D 1 3
V S SV C C
H D 1 4H D 1 5
H W R Q # D C I _ R E Q #H R D Q #
H I R Q / D C I _ E R R #H I R S T #
H I O R D YV S SV C C
H W R #H R D #
H I O C S 1 6 #H C S 1 F X #H C S 3 F X #
H A 0H A 1V S S
VC
CH
A2
VP
PA
UX
0A
UX
1A
UX
2V
SS
VC
CA
UX
3A
UX
4A
UX
5A
UX
6A
UX
7L
OE
#V
SS
VC
CLC
S0#
LCS
1#LC
S2#
LCS
3#V
SS
LD0
LD1
LD2
LD3
LD4
VC
CV
SS
LD5
LD6
LD7
LD8
LD9
LD10
LD11
VS
SV
CC
LD12
LD13
LD14
LD15
LW
RL
L#
LW
RH
L#
VS
SV
CC
NC
NC
LA0
LA1
LA2
LA3
VS
S
R 1 2 0 74 7 R 3
1 2
R A 1 2 0 3
S R N 4 7
1234 5
678
R A 1 2 0 2S R N 4 71234 5
678
C 2 5 1 1S C 2 2 P
R 1 2 0 1
4 K 7 R 3
1 2
R 1 2 0 2
D U M M Y - R 3
1 2
0267
/($67
&/2&.6
$''5(66
&$6
5$6
:(
&6[
'40
&5,7,&$/ 75$&(6
,& $''5 ;$
)5217
%$6(
9&&
9&&
7,3$
$9
''
'
$
$
'
'
$
$
$
$
$
$
$
'&
'
&
&
&
'
'
1202817
2 . S C H 1
9 9 4 5 1 ( S D R A M & R O M E M U L A T O R)
C
2 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
D M A 0 M A 0D M A 1 M A 1D M A 2 M A 2D M A 3 M A 3
D M A 4 M A 4 D B 0 D B 1 5 D B 0 D B 1 5D M A 5 M A 5 D B 1 D B 1 4 D B 1 D B 1 4D M A 6 M A 6D M A 7 M A 7 D B 2 D B 1 3 D B 2 D B 1 3
D B 3 D B 1 2 D B 3 D B 1 2
D B 4 D B 1 1 D B 4 D B 1 1D M A 8 M A 8 D B 5 D B 1 0 D B 5 D B 1 0D M A 9 M A 9D M A 10 MA10 D B 6 D B 9 D B 6 D B 9D M A 11 MA11 D B 7 D B 8 D B 7 D B 8
D Q MX D Q MXW E DQMX W E D Q MXC A S C A S
D C S 0 C S 0 R A S 0 R A S 0D B 0 C S 0 C S 1
D B 1 MA11 M A 9 MA11 M A 9D B 2 D C S 1 C S 1 MA10 M A 8 MA10 M A 8D B 3 M A 0 M A 7 M A 0 M A 7
M A 1 M A 6 M A 1 M A 6D R A S 0 R A S 0 M A 2 M A 5 M A 2 M A 5
M A 3 M A 4 M A 3 M A 4D B 4D B 5 D C A S C A SD B 6D B 7
D W E W E
D S C KD B 8 D Q M D Q MXD B 9D B 1 0D B 1 1
D B 1 2D B 1 3D B 1 4D B 1 5
E M R S TW R L LL A 21
L A 18 S C LS D A
W R L L
L A 19
L A 17L A 16
L A 18 L A 15L A 12
L A 7 L A 14L A 6 L A 13L A 5 L A 8L A 4 L A 9L A 3 L A 11L A 2 L O EL A 1 L A 10L A 0 L C S 3
L D 0
L D 1L D 2L D 3L D 4L D 5L D 6L D 7
DMA[0. .11 ]
DB[0. .15]
LA[0. .17]
LD[0. .7]
DMA[0 . .11 ]
D S C KD Q M
LD[0. .7]
LA[0. .17]
E M R S T
D C S 0
D C S 1
D R A S 0
D C A S
D W E
L C S 3
L O E
L A 19
L A 18
L A 2 1
DB[0. .15]
S C LS D A
W R L L
3 V 33 V 3 3 V 33 V 3
S T B Y
S T B Y
S T B Y
S T B Y
S T B Y
3V6S T B Y
3 V 63 V 3
R 1 2 0 8
3 3 R 3
1 2
R 1 2 0 9
3 3 R 3
1 2
R 1 2 1 0
3 3 R 3
1 2
R 1 2 1 1
3 3 R 3
1 2
R 1 2 1 2
3 3 R 3
1 2
R 1 2 1 3
3 3 R 3
1 2
IC1202
H M 5 2 16165
123456789
1 01 11 21 31 41 51 61 71 81 92 02 12 22 32 42 5 2 6
2 72 82 93 03 13 23 33 43 53 63 73 83 94 04 14 24 34 44 54 64 74 84 95 0V C C
D Q 0D Q 1V S S QD Q 2D Q 3V C C QD Q 4D Q 5V S S QD Q 6D Q 7V C C QD Q M LW EC A SR A SC SA 1 1A 1 0A 0A 1A 2A 3V C C V S S
A 4A 5A 6A 7A 8A 9N C
C K EC L K
D Q M UN C
V C C QD Q 8D Q 9
V S S QD Q 1 0D Q 1 1
V C C QD Q 1 2D Q 1 3V S S QD Q 1 4D Q 1 5
V S S
IC1203
H M 5 2 16165
123456789
1 01 11 21 31 41 51 61 71 81 92 02 12 22 32 42 5 2 6
2 72 82 93 03 13 23 33 43 53 63 73 83 94 04 14 24 34 44 54 64 74 84 95 0V C C
D Q 0D Q 1V S S QD Q 2D Q 3V C C QD Q 4D Q 5V S S QD Q 6D Q 7V C C QD Q M LW EC A SR A SC SA 1 1A 1 0A 0A 1A 2A 3V C C V S S
A 4A 5A 6A 7A 8A 9N C
C K EC L K
D Q M UN C
V C C QD Q 8D Q 9
V S S QD Q 1 0D Q 1 1
V C C QD Q 1 2D Q 1 3V S S QD Q 1 4D Q 1 5
V S S
R 1 2 1 4
1 0 R 3
1 2
IC1604
A T 2 4 C01A
1234 5
678A 0
A 1A 2G N D S D A
S C LW P
V C C
C N 1
J S T - C O N 4
1234
R 1 6 0 11 K R 3
12
R A 1 2 1 0
S R N 4 7
1234 5
678
R A 1 2 1 1
S R N 4 7
1234 5
678
R A 1 2 1 2
S R N 4 7
1234 5
678
C 1 6 0 1S C D 1 U
C 1 6 0 2S C D 1 U
C 1 6 0 3S C D 1 U
C 1 6 0 4S C D 1 U
R 2 2 5 3
1 0 R 3
1 2
R 1 6 0 7
D U M M Y - R 3
1 2
R 1 6 0 8
0R3-0 -U
1 2
R 1 6 0 5
D U M M Y - R 3
1 2
R 1 6 0 6
0R3-0 -U
1 2
R 1 6 0 21 K R 3
12
D 3 2 0 1
R B 4 0 0 D
31
2
D 1 2 0 21 N 7 4 9 A
12
C 1 2 2 8E 1 0 U
12
C 1 2 2 9S C D 1 U
C 1 2 3 0E 1 0 0 U
12
Q 1 2 01TIP31A
1
32
R 1 2 1 5
7 5 R 6
1 2
F 1 0 0 1F U S E - D 7 5 A 1 2 5 V
1 2
IC16012 8 S F 0 4 0 A-90
4 3 2 1 32 31 30
56789
1 01 11 21 3
14 15 16 17 18 19 20
2 12 22 32 42 52 62 72 82 9
A12
A15
A16
A18
VC
CW
E#
A17
A 7A 6A 5A 4A 3A 2A 1A 0D Q 0
DQ
1D
Q2
VS
SD
Q3
DQ
4D
Q5
DQ
6
D Q 7C E #A 1 0O E #A 1 1
A 9A 8
A 1 3A 1 4
%
'
&
&
&
&
&
&
&
&
&
&
&
3 . S C H 1
99451 (DVD DRIVE INTERFACE)
C
3 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
H R S T D R S TD R S TD D 1 5 D D 0
H W R D W R D D 1 4 D D 1D D 1 3 D D 2D D 1 2 D D 3
H R D D R D D D 1 1 D D 4D D 1 0 D D 5D D 9 D D 6
H I O R D Y D I O R D Y D D 8 D D 7
H I O C S 1 6 D I O C S 1 6 D W RD R DD I O R D Y
H C S 1 D A C S 1D I R Q D I O C S 1 6D D A 1
H C S 3 D A C S 3 D D A 0 D D A 2D A C S 1 D A C S 3
H I R Q D I R Q
H W R Q D W R Q
H A 0 D D A 0
H A 1 D D A 1
H A 2 D D A 2
H D 0 D D 0H D 1 D D 1H D 2 D D 2H D 3 D D 3
H D 4 D D 4H D 5 D D 5H D 6 D D 6H D 7 D D 7
H D 8 D D 8H D 9 D D 9H D 1 0 D D 1 0H D 1 1 D D 1 1
H D 1 2 D D 1 2H D 1 3 D D 1 3H D 1 4 D D 1 4H D 1 5 D D 1 5
HD[0. .15]HD[0. .15]
H I O R D Y
H I R Q
H R S T
H W R
H R D
H I O C S 1 6
H C S 1
H C S 3
H W R Q
H A 0
H A 1
H A 2
+5V +5V
3 V 63 V 3
S T B Y
R 1 1 0 1
4 7 R 3
1 2
R 1 1 0 2
4 7 R 3
1 2
R 1 1 0 3
4 7 R 3
1 2
R 1 1 0 4
4 7 R 3
1 2
R 1 1 0 5
4 7 R 3
1 2
R 1 1 0 6
4 7 R 3
1 2
R 1 1 0 7
4 7 R 3
1 2
R 1 1 0 8
4 7 R 3
1 2
R 1 1 0 9
4 7 R 3
1 2
R 1 1 1 04 K 7 R 3
12
R 1 1 1 14 K 7 R 3
12
P G 1 101
C O N N - H D D 4 0 A
13
79
1 11 31 51 71 92 12 32 52 72 93 13 33 53 73 9
5
24681 01 21 41 61 82 02 22 42 62 83 03 23 43 63 84 0
R 1 1 1 2
3 3 R 3
1 2
R 1 1 1 3
3 3 R 3
1 2
R 1 1 1 4
3 3 R 3
1 2
R A 1 1 0 1
S R N 4 7
1234 5
678
R A 1 1 0 2
S R N 4 7
1234 5
678
R A 1 1 0 3
S R N 4 7
1234 5
678
R A 1 1 0 4
S R N 4 7
1234 5
678
C 1 6 1 3
E 1 0 U
12
C 1 6 1 5
E 1 0 U
12
C 1 2 0 3
S C D 1 U
C 1 2 0 4
S C D 1 U
C 1 2 0 5
S C D 1 U
C 1 2 0 6
S C D 1 UC 1 2 0 7S C D 1 U
C 1 2 0 8
S C D 1 U
C 1 2 0 9
S C D 1 U
C 1 2 1 0
S C D 1 U
C 1 2 1 1
S C D 1 UC 1 2 1 2S C D 1 U
C 1 2 1 4
S C D 1 U
C 1 2 1 5
S C D 1 U
C 1 2 2 3
E 1 0 U
12
C 1 2 2 4
E 1 0 U
12
C 1 2 2 5
E 1 0 U
12
C 1 2 4 1
S C D 1 U
C 1 2 4 2
S C D 1 U
C 1 2 4 3
S C D 1 U
C 1 2 4 4
S C D 1 UC 1 2 4 5S C D 1 U
C 1 2 4 6
S C D 1 U
C 1 2 4 7
S C D 1 U
C 1 2 4 8
S C D 1 U
C 1 2 4 9
S C D 1 UC 1 2 5 0S C D 1 U
C 1 2 5 1
S C D 1 U
C 1 2 5 2
S C D 1 U
C 2 2 3 5
S C D 1 U
%
%
%
%
&%
%
'
&%
%
% %
4 . S C H 1
99451 (CLOCK & RESET C IRCUIT )
C
4 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
EXTRST
E M R S TD C L K
XIN
A D C L K
PCLK2X
S T B L E D P W R L E D
D A _ X CK1 D A _ X C K
R S T E S S
A D C L K
XIN
D C L K
PCLK2X
E M R S T
EXTRST
R S T E S S
D A _ X CK1 D A _ X C K
S T B LED P W R L E D
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
S T B Y S T B Y
S T B Y S T B Y
S T B Y S T B Y
S T B Y
+5V
S T B Y
R 1 2 1 6
1 M R 3
1 2
R 1 2 1 8
4 7 R 3
1 2R 1 2 1 9
0R3-0 -U
1 2
R 1 2 2 0
4 7 R 3
1 2
R 1 2 2 1
4 7 R 3
1 2
R 1 2 2 2
4 7 R 3
1 2
C 1 2 3 5S C 1 5 P
C 1 6 2 0S C D 1 U
D 1 6 0 11 N 4 1 4 8
12
R 1 6 0 91 0 K R 3
12
C 1 6 1 7E 4 7 U
12
IC1605A
S O H C 1 4 - 1
1 2
1 4
7
IC1605C
S O H C 1 4 - 1
5 6
1 4
7
IC1605B
S O H C 1 4 - 1
3 4
1 4
7
IC1605F
S O H C 1 4 - 1
1 3 1 2
1 4
7
IC1605D
S O H C 1 4 - 1
9 8
1 4
7
D 1 2 0 31 N 4 1 4 8
12
R 1 2 2 31 0 K R 3
12
IC1605E
S O H C 1 4 - 1
1 1 1 0
1 4
7
C 1 2 5 3E 4 7 U
12
C 1 6 0 5S C D 1 U
R 1 2 1 74 7 R 3
12
C 1 2 3 2S C 1 2 P
C 1 2 3 1S C 1 2 P
IC1204A
S O H C 0 4 - 1
1 2
1 4
7
IC1204B
S O H C 0 4 - 1
3 4
1 4
7
IC1204C
S O H C 0 4 - 1
5 6
1 4
7
IC1204D
S O H C 0 4 - 1
9 8
1 4
7
IC1204E
S O H C 0 4 - 1
1 1 1 0
1 4
7
R 1 5 0 1
4 7 R 3
1 2R 1 5 0 2
4 7 R 3
1 2
C 1 2 3 3S C 1 5 P
C 1 5 0 1S C 2 2 P
X1
XTAL-27MHZ
1 2
C 1 2 3 4D U M M Y - C 3
12
C 1 2 3 6D U M M Y - C 3
12
$'
$'
$&
$%%%&'
%/8(
%
%
%
'%
'
$
&
'
'
&
%
&
&
&
&
&
%
%
%
%
%
&
'93( 21/<
1202817
'93( 21/<
-$3$1 '7(50,1$/ 21/<
6 9,'(2 21/<
5('
*5((1
1202817
1202817
5 . S C H 1
9 9 4 5 1 ( T V E N C O D E R )
C
5 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
B L N K O U T_1R G B O N
C V B S O U T C V B S
A D C L KY1F Y1
Y U V 0 C V B S 0Y U V 1Y U V 2Y U V 3Y U V 4Y U V 5Y U V 6Y U V 7
C b
CrF CrS D AS C L
L U M A0 L U M A1 L U M AH S Y N C
Y1V S Y N C
R S T E S S
Cr
C H R O M A 0 C H R O M A 1 C H R O M A
LTBX C V B S 2
S Q E Z
C H R O M A C V B S 0S Q U E E Z E
L U MA0 C H R O M A 0
L U M A0 Y 1 F C H R O M A 0 C r FS C S W S C S W
L U M A1 C H R O M A 1 S C S W
S C S WTCTL2
TCTL1
B L N K O U T_1
YUV[0. .7]YUV[0. .7]
A D C L K
H S Y N C
V S Y N C
LTBX
S Q E Z
C V B S
C V B S 2
L U M A
C H R O M A
C b
Y1
CrS D AS C L
TCTL2
TCTL1
S Q U E E Z E
S C S W
R G B O N
B L N K O U T_1
R S T E S S
+5VV
+5VV
+5VV
+5VV
+5VV
S T B Y
+8VA
+8VA
+8VA
+8VA
+8VA
+8VA
+8VA
+8V
+5V
+5V
+5V+5V
+5V
+5V
+ 5 VV
+8V
+ 5 VV
+8VA
+8VA
+8VA
+8VA
+8VA
+ 8 VA
+8VA
C 2 2 0 1E 1 0 0 U
12
L 2 2 01
F E R R I T E
1 2
C 2 2 0 2
E 1 0 U
12
C 2 2 0 3
E 1 0 U
12
C 2 2 0 4
S C D 1 U
C 2 2 0 5
S C D 1 U
C 2 2 0 6
S C D 1 U
C 2 2 0 7
S C D 1 U
C 2 2 0 8
S C D 1 U
R 2 2 0 23 3 R 3
1 2
R 2 2 0 3
3 3 R 3
1 2
C 2 2 0 9S C D 1 U
C 2 2 1 0
S C D 1 U
Q 2 2 01
2 S B 766
2
1
3
R 2 2 0 4
1 0 K R 3
1 2R 2 2 0 5
3 9 0 R 3
1 2
,1
287
*1'
5
5
Q 2 2 07
D T C 1 2 4 EE
21
3
C 2 2 1 2
S C D 1 U R 2 2 0 64 7 0 R 51 2
R 2 2 0 74 7 0 R 51 2
R 2 2 0 84 7 0 R 51 2
,1
287
*1'
5
5
Q 2 208
D T C 1 2 4 EKA
21
3
C 2 2 1 4S C 2 2 P
R 2 2 2 8
1 0 0 R 3
1 2Q 2 2 022 S A 1 037AK
32
1
R 2 2 3 23 3 0 R 3
1 2
R 2 2 3 66 8 0 R 3
12
D 2 2 0 2D A 2 2 8
1 2
3
C 2 2 1 7S C 2 2 P
Q 2 2 032 S A 1 037AK
32
1
R 2 2 3 33 3 0 R 3
1 2
R 2 2 3 76 8 0 R 3
12
D 2 2 0 3D A 2 2 8
1 2
3
C 2 2 2 0S C 2 2 P
L2204L 1 D 8 U H - 2
1 2
L 2 2 03L 1 D 8 U H - 2
1 2
R 2 2 3 0
1 0 0 R 3
1 2
Q 2 2042 S A 1 037AK
32
1
R 2 2 3 43 3 0 R 3
1 2
R 2 2 3 86 8 0 R 3
12
R 2 2 4 3
0R3-0 -U
1 2D 2 2 0 4D A 2 2 8
1 2
3
C 2 2 2 3S C 2 2 P
L 2 2 05L 1 D 8 U H - 2
1 2R 2 2 3 1
1 0 0 R 3
1 2
Q 2 2 052 S A 1 037AK
32
1R 2 2 3 96 8 0 R 3
12
C 2 2 2 5S C D 0 1 U
C 2 2 2 6E 2 2 0 U 1 6V
1 2 R 2 2 5 21 0 0 K R 3
12
R 2 2 4 0
1 0 0 R 3
1 2Q 2 2062 S A 1 037AK
32
1
R 2 2 4 13 3 0 R 3
1 2
R 2 2 4 26 8 0 R 3
12
D 2 2 0 6D A 2 2 8
1 2
3,1
287
*1'
5
5
Q 2 209
D T C 1 2 4EE
21
3
R 2 2 0 91 0 K R 3
12
,1
287
5
5
*1'
Q 2 2 10
D T A 124EE
21
3
Q 2 211
2 S C 4 6 1 7 R - U
21
3
R 2 2 1 22 2 K R 3
12
R 2 2 1 12 7 K R 3
12
,1
287
*1'
5
5
Q 2 2 12
D T C 1 2 4 EE
21
3
R 2 2 1 31 0 K R 3
12
,1
287
5
5
*1'
Q 2 213
D T A 1 24EE
21
3
R 2 2 1 4
1 0 K R 3
1 2
R 2 2 1 51 0 K R 3
1 2
R 2 2 1 64 7 R 3
1 2
,1
287
*1'
5
5
Q 2 2 14
D T C 1 2 4 EE
21
3,1
287
5
5
*1'
Q 2 215
D T A 1 24EE
21
3
R 2 2 1 71 0 K R 3
12
Q 2 2 16
2 S C 4 6 1 7 R - U
21
3
R 2 2 1 84 7 K R 3
12
R 2 2 2 02 2 K R 3
12
R 2 2 1 92 7 K R 3
12
R 2 2 2 11 0 K R 3
12
,1
287
5
5
*1'
Q 2 218
D T A 1 24EE
21
3
,1
287
*1'
5
5
Q 2 2 17
D T C 1 2 4 EE
21
3
R 2 2 2 2
1 0 K R 3
1 2
R 2 2 2 3
1 0 K R 3
1 2
C 2 2 1 1
E 2 2 0 U 1 6V 12
D 2 2 0 7D A 2 2 8
1 2
3
D 2 2 0 8D A 2 2 8
1 2
3
L 2 2 06L 1 D 8 U H - 2
1 2
R 2 2 2 42 4 0 R 3
12
C 2 2 1 3S C 1 0 P
C 2 2 1 5S C 1 0 P
R 2 2 2 52 4 0 R 3
12
C 2 2 1 6S C 1 0 P
R 2 2 2 62 4 0 R 3
12
C 2 2 1 9S C 1 0 P C 2 2 2 1
S C 1 0 P
R 2 2 2 72 4 0 R 3
12
C 2 2 2 2S C 1 0 P C 2 2 2 4
S C 1 0 P
IC2203
A D G 7 2 1
13
4
68
5
2
7
S 1IN2
V D D
S 2IN1
G N D
D 1
D 2
IC2202
A D G 7 2 1
13
4
68
5
2
7
S 1IN2
V D D
S 2IN1
G N D
D 1
D 2
R 2 2 5 4
0R3-0 -U
1 2
L 3 2 02
B L M11A601S
1 2
L3204
B L M11A601S
1 2
L3206
B L M11A601S
1 2
L3207
B L M11A601S
1 2
R 2 2 5 5
0R3-0 -U
1 2
R 2 5 1 0
D U M M Y - R 6
1 2
R 2 2 0 14 7 0 R 3
12
IC2201
A D V 7 1 7 0 S U
123456789
1 01 1
12 13 14 15 16 17 18 19 20 21 22
3 33 23 13 02 92 82 72 62 52 42 3
44 43 42 41 40 39 38 37 36 35 34
V A AP 5P 6P 7P 8P 9P 1 0P 1 1P 1 2G N DV A A
P13
P14
P15
HS
YN
C#
FIE
LD/V
SY
NC
#B
LA
NK
#A
LS
BG
ND
VA
AG
ND
RE
SE
T#
V R E FD A C A
DAC BV A AG N DV A A
DAC DD A C CC O M P
S D A T AS C L O C K
CL
OC
KG
ND P4
P3
P2
P1
P0
TT
XT
XX
RE
QS
RE
SC
RE
SE
T/R
TC
RS
ET
R 2 2 1 04 7 K R 3
12
C 2 2 1 8S C 1 0 P
R 2 2 2 91 0 0 R 3
1 2
D 2 2 0 5D A 2 2 8
1 2
3
R 2 2 4 4
0R3-0 -U
1 2
R 2 2 3 53 3 0 R 3
1 2
L 3 2 01
B L M11A601S1 2
L 3 2 03
B L M11A601S1 2
L 3 2 05
B L M11A601S
1 2
%
%
%
%
'
%
%
'
'
%
%
%
'
%
''
'
'
'
'
'
&
'
'
'
'
%
%
%
6 . S C H 1
99451 (AUDIO DACS)
C
6 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
T W S - 2 M L 2T S D2 M C - 0
A U P O N / O F F T B C K -2 M D - 0
S C K - 1
EXTRST
C E N T E R
M C M C - 2
M C - 1
M C - 0 S R MUTE4T B C K
M D M D - 2
M D - 1
M D - 0
T B C K -2T W S - 1 M L 1
T B C K -1 T S D1 M C - 1T B C K -1 M D - 1
T B C K -0S C K - 1
T W S T W S - 2EXTRST
T W S - 1
T W S - 0 S W
D A _ XCK S C K - 3
SL MUTE3S C K - 1
F - L R C K M L 0F - D A T A M C - 2F - B C K M D - 2
S C K - 1
EXTRST
A M U T E F L O U T
F R O U T MUTE2
A _ M U T E
A U P O N / O F F
M C
M D
D A _ X C K
T B C K
T W S
S C K - 3
TWS-0
T B C K -0
A M U T E
A _ M U T E
MUTE2F R O U T
F L O U T
M L 0
MUTE3
M L 1
EXTRST
MUTE4
M L 2
T S D1
S W
S L
T S D 2
S R
C E N T E R
F - L R C KF - D A T A
F - B C K
S T B Y
-8V
-8V
-8V
-8V
+ 5 V A U
+ 5 V A U
+ 5 V A U
+8V
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
+ 5 V A U
IC1504P Q 2 0 W Z51
1 2 3 4 5
DC
_IN
ON
/OF
FD
C_
OU
TA
DJ
GN
D
C 1 5 0 2E 1 0 0 U 16V
12
R 1 5 0 33 K 9 R 3
12
R 1 5 0 43 K 9 R 3
12
R 1 5 0 5
2 K 2 R 3
1 2
R 1 5 3 00R3-0 -U
1 2
R 1 5 3 1
0R3-0 -U
1 2
R 1 5 1 4 3 3 R 31 2
R 1 5 1 5 3 3 R 31 2
R 1 5 1 6 3 3 R 31 2
R 1 5 1 7 3 3 R 31 2
R 1 5 1 8 3 3 R 31 2
R 1 5 1 9 3 3 R 31 2
R 1 5 2 0 3 3 R 31 2
R 1 5 2 1 3 3 R 31 2
R 1 5 2 2 3 3 R 31 2
R 1 5 2 3 3 3 R 31 2
R 1 5 2 4 3 3 R 31 2
R 1 5 2 5 3 3 R 31 2
R 1 5 2 6 3 3 R 31 2
R 1 5 2 8 3 3 R 31 2
C 1 5 0 4E 4 7 0 U 1 6V
12
C 1 5 0 3E 2 2 0 U 1 6V
12
,1
287
*1'
5
5
Q 2 5 01
D T C 1 2 4 EKA
21
3
%
& (
5
Q 2 5 02D T A 1 43EKA
23 1R 2 5 0 3
4 7 K R 3
12
R 2 5 0 4
2 K 2 R 3
1 2
Q 1 5 01D T A 1 24EKA
3
2
1
R 1 5 0 74 7 K R 3
12
C 1 5 0 8E 1 0 U
12
C 2 5 0 2S C D 1 U
C 3 5 0 1E 1 0 U
12
C 1 5 0 9E 4 7 U
12
C 3 5 0 2S C D 1 U
C 3 5 0 3
S C D 1 U C 3 5 0 4
S C D 1 U
C 1 5 0 6E 4 7 U
12
IC1501
P C M 1716
123456789
1 01 11 21 31 4 1 5
1 61 71 81 92 02 12 22 32 42 52 62 72 8L R C I N
DINB C K I NC L K OXTIX T OD G N DV D DV C C 2 RA G N D 2 RE X T RN CV O U T RA G N D 1 V C C 1
V O U T LN C
E X T LA G N D 2 L
V C C 2 LZ E R OR S T #
C S # / I W OM O D EM U T E
M D / D M 0M C / D M 1
ML/I IS
IC1502
P C M 1716
123456789
1 01 11 21 31 4 1 5
1 61 71 81 92 02 12 22 32 42 52 62 72 8L R C I N
DINB C K I NC L K OXTIX T OD G N DV D DV C C 2 RA G N D 2 RE X T RN CV O U T RA G N D 1 V C C 1
V O U T LN C
E X T LA G N D 2 L
V C C 2 LZ E R OR S T #
C S # / I W OM O D EM U T E
M D / D M 0M C / D M 1
ML/I IS
IC1503
P C M 1716
123456789
1 01 11 21 31 4 1 5
1 61 71 81 92 02 12 22 32 42 52 62 72 8L R C I N
DINB C K I NC L K OXTIX T OD G N DV D DV C C 2 RA G N D 2 RE X T RN CV O U T RA G N D 1 V C C 1
V O U T LN C
E X T LA G N D 2 L
V C C 2 LZ E R OR S T #
C S # / I W OM O D EM U T E
M D / D M 0M C / D M 1
ML/I IS
Q 1 5 02D T A 1 24EKA
3
2
1
R 1 5 1 04 7 K R 3
12
C 1 5 1 1E 4 7 U
12
C 1 5 1 3E 1 0 U
12
C 1 5 1 4E 4 7 U
12
C 2 5 0 4S C D 1 U
Q 1 5 03D T A 1 24EKA
3
2
1
R 1 5 1 24 7 K R 3
12
C 1 5 1 6E 4 7 U
12
C 1 5 1 9E 4 7 U
12
C 2 5 0 7S C D 1 U
C 1 5 1 8E 1 0 U
12
C 3 5 0 5E 1 0 U
12
C 3 5 0 6S C D 1 U
C 3 5 0 7
S C D 1 U C 3 5 0 8
S C D 1 U
C 3 5 0 9E 1 0 U
12
C 3 5 1 0S C D 1 U
C 3 5 1 1
S C D 1 U C 3 5 1 2
S C D 1 U
C 2 5 0 3S C D 1 U
C 2 5 0 6S C D 1 U
C 2 5 0 8S C D 1 U
C 1 5 2 0S C 2 2 P
&
&
%
'
'
'
%
&
&
%
%
%
$
$
$
$
$
$
&
&
$
7 . S C H 1
9 9 4 5 1 ( K A R A O K E)
C
7 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
M I C _ S W
A O L K A O L
M I C S W K A G N D
A O R K A O R
M I C S W K M I C S W
MIC2_VRIN
MIC1_VRIN
T W S - 0 F - L R C KT S D0 F - D A T AT B C K -0 F - B C KS C K - 3EXTRST
M _ 4 A O RM _ 6 A O L
M I C 1 _ V R O U TY S S - C S JY S S - C L KYSS-DINY S S - D O U T
M _ 3M _ 5
M I C 2 _ V R O U T
MIC2
MIC1
M _ 2
MIC2_VRIN
MIC1_VRIN
MIC2
MIC1
M I C 1 _ V R O U T
M I C 2 _ V R O U T
Y S S - C L KY S S - C S J
YSS-DINY S S - D O U T
M I C _ S W
T W S - 0
T B C K-0S C K - 3
F - L R C KF - D A T AF - B C K
T S D0
EXTRST
+5V
+8V
+ 5 V A U
+ 5 V A U
-8V
-8V
R 1 4 0 1
1 0 K R 3
1 2R 1 4 0 2
1 0 K R 3
1 2
R 1 4 0 42 2 0 R 3
12
R 1 4 0 32 2 0 R 3
12
C 1 4 0 1
S C 1 0 0 P
C 1 4 0 2
S C 1 0 0 P
C 1 4 1 6
S C D 1 UC 1 4 0 3E 1 0 U
12
R 1 4 0 51 K R 3
12
R 1 4 0 71 0 0 K R 3
12
C 1 4 0 4E 1 0 U
12
R 1 4 0 61 K R 3
12
R 1 4 0 81 0 0 K R 3
12
R 1 4 1 01 K 8 R 3
12
C 1 4 0 8S C 1 0 00P50V3KX
C 1 4 1 7
S C D 1 U
C 1 4 0 7S C 1 000P50V3KX
R 1 4 0 91 K 8 R 3
12
C 1 4 0 9E 1 0 U
12
C 1 4 1 0E 1 0 U
12
IC1402
B A 4 5 6 0 F
1234
8765
O U T 1-IN1+IN1V E E
V C CO U T 2
-IN2+IN2
P G 2 403
J S T - C O N 4
1234
Q 1 4 02D T A 1 24EKA3
21
R 1 4 2 64 7 K R 3
12
R 1 4 3 4 0R3-0 -U1 2
R 1 4 3 5 0R3-0 -U1 2
R 1 4 3 6 0R3-0 -U1 2
R 1 4 2 82 2 0 K R 3
12
C 1 4 1 9E 1 0 U
12
C 1 4 1 8E 1 0 U
12
R 1 4 3 01 8 K R 3
12
R 1 4 2 91 8 K R 3
12
R 1 4 3 3
4 K 7 R 3
1 2
R 1 4 3 1 1 0 K R 31 2
C 1 4 2 0S C 4 7 0 P R 1 4 3 2
5 6 0 R 3
12
C 1 4 2 1
S C 2 2 0 PC 1 4 2 2
S C 2 2 0 P
C 1 4 2 3
S C D 1 U
C 1 4 2 4E 1 0 U
12
C 1 4 2 5E 4 7 U
12
C 1 4 2 6S C D 1 U
C 1 4 2 7S C D 1 U
C 1 4 2 8S C D 1 U
R 1 4 2 72 2 0 K R 3
12
L 3213 B L M 11A601S1 2
L3214 B L M 11A601S1 2
L3215 B L M 11A601S1 2
L3216 B L M 11A601S1 2
IC1401
Y S S 9 1 5 - U
12
34
5
6
7
8
91 01 1
1 21 3
1 4
2 8
2 72 62 52 42 32 2
2 1
2 0
1 9
1 81 7
1 61 5
DIBCI
D OL/R
D V D D 1
B C O
D V S S 1
A V D D
P L L CA V S SA D C 1
A D C 2V R E F
MICIN
S D S Y
C D OCDIS C K #C S #P 0X I S E L / Z E R O
D V S S 2
DEPI
D V D D 2
IC#XI
A O RA O L
C 1 4 0 6S C 1 0 0 P
C 1 4 0 5S C 1 0 0 P
9)'
32:(5
(
'(&!5-.
'(&!)-.
'(&!095
'(&!9'2
'$
&$
&$
'
'
'
%
'
'
'
'
&
&
%
%
'
%
&
%
&
'
&
$
$
$
$
'
$
'
&
&
%
$
$
$
%
%
%
&
&
'
&
%
&
'
%
%
$
$
%
$
%
%
'
.$5$2. 21/<
.$5$2. 21/<
'93( 3,1
'938 '9' 3,1
8 . S C H 1
99451 ( I /O & CONNECTORS)
C
8 8Monday, March 27, 2000
Title
Size Documen t Number Rev
Date: Sheet of
L A 4L A 5 W R 0 A M U T E
W R H L W R 1W R 2 P . O N / O F F
SPDIFL C S 1
R D 1 F R O U TR D 2
F L O U TMUTE2MUTE3MUTE4S L
S RL D 8 M L 0L D 9 M C C E N T E RL D 1 0 M DL D 1 1 LTBX S WL D 1 2 S Q E ZL D 1 3 M L 1L D 1 4 M L 2L D 1 5 Y S S - C L K
L C S 1 W R 0
L D 8 P SL D 9 YSS-DINL D 1 0 G P I O 2L D 1 1 G P I O 3 C V B SL D 1 2 G P O 0L D 1 3 G P O 1 IR L U M AL D 1 4 G P O 2L D 1 5 G P O 3 C H R O M A
V F D - C L KR D 1 Y1
W R 1 V F D - C SC b
V F D - D A T A S T B LEDP S Cr
B L N K O U T_1 B L N K O U T
C V B S 2P S L D 8 P W R L E D S Q U E E Z EY S S - D A T A L D 9G P I O 2 L D 1 0M I C _ S W L D 1 1GPI0 L D 8GPI1 L D 9GPI2 L D 1 0GPI3 L D 1 1
R D 2
L D 8 A U P O N / O F FL D 9 TCTL1L D 1 0 TCTL2L D 1 1 A_MUTEL D 1 2 S C S WL D 1 3 R G B 0 NL D 1 4 P . O N / O F FL D 1 5 S T B LED
L C S 2 W R 2 MIC2
MIC1M I C _ S W
M A G N D
MIC2_VRINM I C 2 _ V R O U TM I C 1 _ V R O U TMIC1_VRIN
LD[8. .15]LD[8. .15]
M CM D
W R H L
L C S 1
L C S 2
F L O U T
F R O U T
SPDIF
MUTE2MUTE3MUTE4
S L
S R
C E N T E R
S W
C V B S
Y1
C b
Cr
C V B S 2S Q U E E Z E
B L N K O U T_1
MIC2
MIC1M I C _ S W
MIC1_VRIN
MIC2_VRIN
M I C 1 _ V R O U TM I C 2 _ V R O U T
YSS-DIN
M L 0
M L 1M L 2
LTBXS Q E Z
IR
V F D - C L K
V F D - C S
V F D - D A T A
A U P O N / O F FTCTL1TCTL2
L U M A
C H R O M A
L A 4L A 5
S C S WR G B O N
Y S S - C L K
A M U T E
A_MUTE
P W R L E D
S T B LED
S T B Y
S T B Y
S T B Y
S T B YS T B Y
S T B Y
S T B Y
S T B Y
S T B Y
S T B Y
+ 5 V A U
+5V
+8V
S T B Y
-8V
+8V
-8V
+5V
S T B Y
S T B Y
S T B Y
S T B Y
TL2212TP-2TL2213TP-2TL2204TP-2
TL2201TP-2
TL2202T P -2
TL2203T P -2
TL2208TP-2
TL2209TP-2
TL2210T P -2
TL2211
TP-2
P G 2 401
H I T C O N 4
1234
TL2408TP-2TL2409TP-2TL2410TP-2TL2411TP-2
TL2403TP-2TL2404TP-2TL2405TP-2TL2406TP-2
IC1606
S O F 1 3 8
123
645
1 51 41 31 21 11 097
1 6
8
ABC
G 1G 2 AG 2 B
Y0Y1Y2Y3Y4Y5Y6Y7
V C C
G N D
IC1607
S O F 3 7 4
3478
1 31 41 71 8
11 1
25691 21 51 61 9
2 0
1 0
D 0D 1D 2D 3D 4D 5D 6D 7
O CC L K
Q 0Q 1Q 2Q 3Q 4Q 5Q 6Q 7
V C C
G N D
IC1608
S O F 3 7 4
3478
1 31 41 71 8
11 1
25691 21 51 61 9
2 0
1 0
D 0D 1D 2D 3D 4D 5D 6D 7
O CC L K
Q 0Q 1Q 2Q 3Q 4Q 5Q 6Q 7
V C C
G N D
R 1 6 1 2
D U M M Y - R 3
1 2
IC1609
S O F 2 4 4
2468
1 11 31 51 7
11 9
1 81 61 41 29753
2 01 0
1 A 11 A 21 A 31 A 42 A 12 A 22 A 32 A 4
1 G2 G
1Y11Y21Y31Y42Y12Y22Y32Y4
V C CG N D
IC1610
S O F 3 7 4
3478
1 31 41 71 8
11 1
25691 21 51 61 9
2 0
1 0
D 0D 1D 2D 3D 4D 5D 6D 7
O CC L K
Q 0Q 1Q 2Q 3Q 4Q 5Q 6Q 7
V C C
G N D
R 1 6 1 3
D U M M Y - R 3
1 2
C 1 4 2 9S C D 0 1 U
C 1 4 3 0S C D 0 1 U
C 1 4 3 1
S C D 0 1 UC 1 4 3 2
S C D 0 1 U
R 1 4 3 71 0 K R 3
12
C 1 4 3 3
S C D 1 U C 1 4 3 4S C D 0 1 U
P G 2 201
K Y O C O N 1 7
1234567891 01 11 21 31 41 51 61 7
P G 1 201
A M P C O N 13
123456789
1 01 11 21 3
1234567891 01 11 21 3
P G 2 402
J S T - C O N 5
12345
R 1 6 1 54 K 7 R 3
12
L 1 2 01
F E R R I T E
1 2
C 1 2 3 7E 4 7 0 U
12
C 1 6 1 9
S C D 1 U
C 1 6 0 6S C D 1 U
C 1 6 0 7S C D 1 U
C 1 6 0 8S C D 1 U
C 1 6 0 9S C D 1 U
P G 1 602
K Y O C O N 1 0
123456789
1 0
C 2 2 2 8S C D 1 U 2 5 V 5 Z Y
C 2 2 2 9S C D 1 U 2 5 V 5 Z Y
C 2 2 3 0S C D 1 U 2 5 V 5 Z Y
C 2 2 3 1S C D 1 U 2 5 V 5 Z Y
C 2 2 3 2S C D 1 U 2 5 V 5 Z Y
C 2 2 3 3S C D 1 U 2 5 V 5 Z Y
C 2 2 3 4S C D 1 U 2 5 V 5 Z Y
L1401B L M 11A601S12
L 1 4 02B L M 11A601S12
L 1 4 04B L M11A601S12
L 1 4 03B L M11A601S12
L 1 4 05B L M11A601S12
L 1 4 06B L M11A601S12
L 1 4 07B L M 11A601S12
IC1204F
S O H C 0 4 - 1
1 3 1 2
1 4
7
C 1 4 3 5
S C D 0 1 U
L 3 2 12B L M 11A601S12
L 3 2 09B L M11A601S12
L 3 2 08B L M 11A601S12
L1410B L M21A102S1 2
R 1 6 1 43 3 R 3
1 2
L1411B L M21A102S1 2
L1412B L M21A102S1 2
P G 1 5 02
K Y O - C O N N 2 1
123456789
1 01 11 21 31 41 51 61 71 81 92 02 1
C 2 5 1 2
S C 2 2 P
L 2 2 02
N 1 6 0 8 Z 6 0 11 2
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
|LINK|2.SCH NTMT
NTMT
(M)
(M) (M)
(M)(M)
(M)
|3.SCH|4.SCH
NTMT
A
A U D I O O U T L E T B D
B
1 4Wednesday, Apr i l 26, 2000
Title
Size Documen t Number Rev
Date: Sheet of
B R L o u t
A O L
A O LM I C S W B R R o u t
A O RM I C S W
A O R
B R L o u t
B R R o u t
F R O N T - L
F R O N T - RF R
F L
B R - C
W F
B R S W
B R - R
B R - L
A 8 V
A 8 VA 8 V
A 8 V
A 8 V
A 8 V
A 8 V
A 8 V
+ 5 V D
A-8VF R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
A-8V F R - G N D
F R - G N D
F R - G N DA-8VF R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
F R - G N D
A-8V
F R - G N D
A-8V
F R - G N D
F R - G N D
F R - G N DF R - G N D F R - G N D
F R - G N D
A-8V
F R - G N D
F R - G N D
F R - G N DA-8V
F R - G N D A-8V
F R - G N D
A-8V
R 1 5 2 8
1 5 0 R 5
1 2
R 1 5 7 3
1 0 0 K R 5
12
R 1 5 3 4
2 K 2 R 5
1 2
R 2 5 2 4
4 7 K R 5
12
R 2 5 2 3
4 7 K R 5
12
C 1 5 6 0
C 6 8 0 0 P 5 0 V
R 1 5 3 02 K 2 R 5
1 2 C 1 5 6 8
E 4 7 U 1 6 V - 1
1 2
R 3 5 2 5
1 2 K R 5
1 2
C 1 5 8 1S C 5 6 P 5 0 V 5 J N
C 1 5 8 0
E 1 0 0 U 1 6 V - 1
12
R 1 5 2 7
1 5 0 R 5
1 2
R 1 5 7 4
1 0 0 K R 5
12
R 1 5 2 9
2 K 2 R 5
1 2
R 1 5 3 1
2 K 2 R 5
1 2
C 1 5 5 9
C 6 8 0 0 P 5 0 V
C 1 5 6 3
C 8 2 0 P 5 0 V
C 1 5 6 6
E 1 0 0 U 1 6 V - 1
12
C 1 5 6 5
E 1 0 0 U 1 6 V - 112
C 1 5 7 1
S C 4 7 0 P 5 0 V 5 M X
R 1 5 3 2
2 K 2 R 51 2
C 1 5 6 4C 8 2 0 P 5 0 V
C 1 5 7 2
S C 4 7 0 P 5 0 V 5 M X
C 1 5 8 2S C 5 6 P 5 0 V 5 J N
C 1 5 7 9
E 1 0 0 U 1 6 V - 112
R 1 5 4 3
2 7 K R 5
1 2
R 1 5 4 4
2 7 K R 5
1 2
IC1508A
B A 4 5 6 0 F+
-
3
21
84
IC1510A
B A 4 5 6 0 F
+
-
3
21
84
IC1508B
B A 4 5 6 0 F+
-
5
67
84
IC1510B
B A 4 5 6 0 F
+
-
5
67
84
C 1 5 6 7
E 4 7 U 1 6 V - 1
1 2
R 1 5 3 3
2 K 2 R 5
1 2
D 1 5 0 2
H S M 2 8 3 6 C
2
13
C 3 5 0 1
E 1 0 U 1 6 V - 1
1 2
Q 1 5 1 0D T C 3 2 3 T K
31
2
Q 1 5 1 1D T C 3 2 3 T K
31
2
R 1 5 8 5
1 2 0 K R 5
1 2
R 1 5 8 6
1 2 0 K R 5
1 2
R 1 5 8 7
1 2 0 K R 5
1 2
C 1 3 3 2
C D 0 1 U 5 0 V
R 1 5 8 8
6 8 K R 5
1 2
C 1 3 3 4E 1 0 U 1 6 V - 1
1 2R 1 5 8 9
5 6 K R 5
1 2
C 1 3 3 5
C D 0 1 5 U 5 0 V
R 1 5 9 6
6 K 8 R 5
1 2
R 1 5 9 5
5 6 K R 5
1 2
C 1 3 3 1
C D 0 1 5 U 5 0 V
Q 1 5 1 2D T A 1 2 4 E K A
3
2
1
R 1 5 9 2
3 K 9 R 5
1 2
D 1 5 0 3
1 N 4 1 4 8
1 2
D 1 5 0 6
1 N 4 1 4 8
12
R 1 5 8 4
3 K 3 R 5
12
Q 1 5 1 4D T C 3 2 3 T K
31
2
R 1 5 9 3
8 K 2 R 5
1 2
R 1 5 9 4
8 K 2 R 5
1 2
R 1 5 9 1
2 2 K R 5
1 2
Q 1 5 1 3D T A 1 1 4 T K
3
2
1
Q 1 5 1 6D T A 1 1 4 T K
3
2
1
R 1 5 9 9
2 7 K R 5
1 2
C 1 3 3 6
E 1 0 0 U 1 6 V - 1
1 2
C 3 5 0 2
E 1 0 U 1 6 V - 1
1 2
R 3 5 2 6
1 2 K R 5
1 2
C 2 3 0 1
E 1 0 0 U 1 6 V - 112
C 2 3 0 2
E 1 0 0 U 1 6 V - 1
12
R 3 5 0 1
3 3 K R 5
1 2
R 3 5 0 2
3 3 K R 5
1 2
R 3 5 2 9
1 0 K R 5
1 2
R 3 5 3 1
1 0 K R 5
1 2
R 3 5 3 2
1 0 K R 5
1 2
R 3 5 3 0
1 0 K R 5
1 2
IC1516B
B A 4 5 6 0 F
+
-
5
67
84
IC1517B
B A 4 5 6 0 F
+
-
5
67
84
IC1517A
B A 4 5 6 0 F
+
-
3
21
84
C 1 5 8 3
E 2 2 U 1 6 V - 1
1 2
C 1 5 8 4
E 2 2 U 1 6 V - 1
1 2
C 3 0 0 1
E 1 0 0 U 1 6 V - 1
12
C 3 0 0 2
E 1 0 0 U 1 6 V - 112
IC1516A
B A 4 5 6 0 F
+
-
3
21
84
R 1 5 9 0
1 8 K R 5
1 2
P G 3 5 0 1
J S T - C O N 4 - 4
4321
C 1 5 5 7
E 4 D 7 U 3 5 V - 1
1 2
C 1 5 5 8
E 4 D 7 U 3 5 V - 1
1 2
C 1 5 6 2
C 2 7 0 0 P 5 0 V - 1
C 1 5 6 1
C 2 7 0 0 P 5 0 V - 1
G 1G N D P A D
1
G 2G N D P A D
1
G 3G N D P A D
1
G 4G N D P A D
1
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
NTMT
(M)(M)
(M)
(M)
(M) (M)
(M)
(M)
NTMT
(M)
(M) (M)
(M)
NTMT
NTMT
NTMT
NTMT
A
A U D I O O U T L E T B D
B
2 4Wednesday, Apr i l 26, 2000
Title
Size Documen t Number Rev
Date: Sheet of
S R
S L
C E N
S U R - R
S U R - L
B R - L
B R - C
B R - R
C E N T
A 8 VA 8 V
A 8 VA 8 V
A 8 VA 8 V
A-8VS R - G N D
S R - G N DS R - G N D
A-8VS R - G N D
S R - G N D
S R - G N D
A-8VS R - G N D
S R - G N D
S R - G N D
S R - G N D
S R - G N D
S R - G N DS R - G N D
A-8V
S R - G N D
S R - G N DS R - G N D
A-8V A-8VC S - G N D
C S - G N DC S - G N D
C S - G N D
C S - G N DC S - G N D
C S - G N DC S - G N D C S - G N D
C S - G N D
C 1 5 8 8
C D 0 1 U 5 0 V
C 1 5 9 2C 1 0 0 0 P 5 0 V
R 1 5 7 2
1 0 0 K R 5
12
C 1 5 9 1
C 1 0 0 0 P 5 0 V
R 1 5 4 6
1 5 0 R 5
1 2
R 1 5 7 1
1 0 0 K R 5
12
R 1 5 4 82 K 2 R 5
1 2
R 1 5 5 0
2 K 2 R 51 2
C 1 5 9 6
C D 1 5 U 5 0 V
R 1 5 4 5
1 5 0 R 5
1 2
R 1 5 4 7
2 K 2 R 5
1 2
C 1 5 8 7
C D 0 1 U 5 0 V
R 1 5 4 92 K 2 R 5
1 2
C 1 5 9 4
E 1 0 0 U 1 6 V - 1
12
IC1511A
B A 4 5 6 0 F+
-
3
21
84
C 1 5 9 3
E 1 0 0 U 1 6 V - 112
R 1 5 8 3
8 2 K R 5
12
C 1 5 9 5
C D 1 5 U 5 0 V R 1 5 5 1
2 K 2 R 5
1 2
C 1 5 9 7
S C 4 7 0 P 5 0 V 5 M X
R 1 5 5 3
3 9 K R 5
12
R 1 5 5 5
3 6 K R 5
1 2
C 2 5 0 3S C 5 6 P 5 0 V 5 J N
IC1512A
B A 4 5 6 0 F
+
-
3
21
84
C 2 5 0 1
E 1 0 0 U 1 6 V - 112
C 2 5 0 2
E 1 0 0 U 1 6 V - 1
12
R 2 5 3 1
4 7 K R 5
12
R 1 5 5 2
2 K 2 R 5
1 2
R 1 5 8 2
8 2 K R 5
12
C 1 5 9 8
S C 4 7 0 P 5 0 V 5 M X
C 2 5 0 4S C 5 6 P 5 0 V 5 J N
R 1 5 5 6
3 6 K R 5
1 2
R 1 5 5 4
3 9 K R 5
12
C 2 5 0 6
E 1 0 U 1 6 V - 1
1 2
R 2 5 3 2
4 7 K R 5
12
R 1 5 5 7
1 5 0 R 5
1 2
R 1 5 7 0
1 0 0 K R 5
12
C 2 5 0 9
C D 0 1 U 5 0 V
R 1 5 5 9
2 K 2 R 5
1 2
R 1 5 6 1
2 K 2 R 51 2
C 2 5 1 3C 1 0 0 0 P 5 0 V
IC1513A
B A 4 5 6 0 F+
-
3
21
84
IC1514A
B A 4 5 6 0 F
+
-
3
21
84
C 2 5 1 7
C D 1 5 U 5 0 V
R 1 5 8 1
8 2 K R 5
12
R 1 5 6 3
2 K 2 R 5
1 2
C 2 5 1 9
S C 4 7 0 P 5 0 V 5 M X
R 1 5 6 5
3 9 K R 5
12
R 1 5 6 7
3 6 K R 5
1 2
C 2 5 2 3S C 5 6 P 5 0 V 5 J N
C 2 5 1 5
E 1 0 0 U 1 6 V - 112
IC1512B
B A 4 5 6 0 F
+
-
5
67
84
IC1511B
B A 4 5 6 0 F+
-
5
67
84
C 2 5 1 6
E 1 0 0 U 1 6 V - 1
12
C 2 5 2 5
E 1 0 U 1 6 V - 1
1 2
R 2 5 3 3
4 7 K R 5
12
C 2 5 2 2
E 1 0 0 U 1 6 V - 1
12
C 2 5 2 1
E 1 0 0 U 1 6 V - 112
C 2 5 0 5
E 1 0 U 1 6 V - 1
1 2
C 2 5 1 1
C 2 7 0 0 P 5 0 V - 1
C 2 5 0 7
E 4 D 7 U 3 5 V - 1
1 2
C 1 5 8 6
E 4 D 7 U 3 5 V - 1
1 2
C 1 5 8 5
E 4 D 7 U 3 5 V - 1
1 2
C 1 5 8 9
C 2 7 0 0 P 5 0 V - 1
C 1 5 9 0
C 2 7 0 0 P 5 0 V - 1
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
(M)
(M)
DEC-->RJK
(M)
OPTICAL
NTMT
NTMT
NTMT
D-GND
D-GND
D-GNDD-GND
NTMT
D-GND
COAXIAL
NTMT
A
A U D I O O U T L E T B D
B
3 4Wednesday, Apr i l 26, 2000
Title
Size Documen t Number Rev
Date: Sheet of
S W
M U T E 2M U T E 3
A M U T E
M U T E 4
S W
SP-DIF
C E N
S R
S L
F L
F R
W F
S U B W
B R S W
SP-DIF
A 8 V
A 8 V
A 8 V
A 8 V
A-8V A 8 V + 5 V D
+ 5 V D
A-8VA-8V
A-8V
C S - G N D
C S - G N D
A-8V
C S - G N DC S - G N D
C S - G N D
C S - G N D C S - G N D
S R - G N DF R - G N D
S R - G N DC S - G N D
F R - G N DF R - G N D
F
F
+ 5 V D
A 8 V
A-8V
+ 5 V D
F R - G N D
F R - G N D
S R - G N D
C S - G N D
S R - G N D
R 1 5 6 0
5 6 K R 5
1 2
R 1 5 6 9
1 0 0 K R 5
12
R 1 5 5 8
2 2 K R 5
1 2
C 2 5 0 8
E 4 7 U 1 6 V - 1
1 2
C 2 5 1 4
C D 0 1 5 U 5 0 V
R 1 5 6 2
5 6 K R 51 2
C 2 5 1 8
E 4 7 U 1 6 V - 1
1 2
R 1 5 6 4
4 K 7 R 5
1 2R 1 5 6 6
1 8 K R 5
1 2
R 1 5 6 8
4 7 K R 5
1 2R 3 5 3 6
1 0 K R 5
1 2
R 3 5 3 4
1 0 K R 5
1 2
C 2 5 1 2
C D 0 5 6 U 5 0 V
IC1588B
B A 4 5 6 0 F
+
-
5
67
84
IC1513B
B A 4 5 6 0 F+
-
5
67
84
IC1514B
B A 4 5 6 0 F
+
-
5
67
84 R 2 5 3 4
4 7 K R 5
12
C 3 0 0 3
E 1 0 0 U 1 6 V - 1
12
C 3 0 0 4
E 1 0 0 U 1 6 V - 112
IC1588A
B A 4 5 6 0 F
+
-
3
21
84
C 2 5 2 6
E 1 0 U 1 6 V - 1
1 2
C 2 5 1 0
C D 0 4 7 U 5 0 V - 1
R 1 3 5 1
0 R
1 2
R 1 3 5 2
0 R
1 2
P G 1 3 0 1
S M K C O N 2 1
1234567891 01 11 21 31 41 51 61 71 81 92 02 1
G 5
G N D P A D
1
G 6G N D P A D
1
G 7G N D P A D
1
G 8
1
G 9
1
G 1 0
1
G 1 1
1
G 1 2
1
G 1 3
1
G 1 4
1
G 1 5
1
G 1 6
1
G 1 7
1
G 1 8
1
G 1 9
1
G 2 0
1
G 2 1
1
G 2 2
1
G 2 3
1
C 1 3 9 9
S C D 0 1 U 5 0 V 5 M X
C 1 3 9 7
S C D 0 1 U 5 0 V 5 M XC 1 3 9 8
S C D 0 1 U 5 0 V 5 M X
R 1 3 2 7
0 R 5
1 2
R 1 3 2 6
1 0 0 R 5
1 2
R 1 3 0 7
7 5 R 5
1 2
R 1 3 0 60 R 5 12
R 1 3 2 80 R 5 12
J 1 3 0 3
R C A - J A C K 1 3
2
13
IC1302
G P 1 F 3 2 T
VIN1
V C C2
G N D3
Z D 1 3 0 1
S D C - M A 3 0 2 0 - T
312
L 1 3 0 3
F B M 3 2 2 5
1 2
T P 1 3 0 1G N D P A D
1
IC1301
S O H C T 0 4 A
1 A1
1Y2
2 A3
2Y4
3 A5
3Y6
G N D7
4Y84 A95Y1 05 A1 16Y1 26 A1 3V C C1 4
T 1 3 0 1
X F O R M - 1 3
G
G
123
5
4
67
C 1 3 0 2
S C D 1 U 1 6 V 5 M N
C 1 3 0 7
S C D 1 U 1 6 V 5 M N
C 1 3 0 3
S C D 0 1 U 5 0 V 5 M X
C 1 3 2 0
S C D 0 1 U 5 0 V 5 M X
C 1 3 3 8
S C 2 0 P 5 0 V 5 J N
C 1 3 3 7
S C 2 0 P 5 0 V 5 J N
C 1 3 0 1
E 4 7 U 1 6 V - 1
12
C 1 3 0 6E 4 7 U 1 6 V - 1
12
C 1 3 0 4
E 3 3 U 1 0 V12
C 1 3 0 5
S C D 0 1 U 5 0 V 5 M X
L 1 3 0 1COIL -100UH-3U
12
C 1 3 7 4
S C D 0 1 U 5 0 V 5 M X
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
SUPER WOFER
CENTER
SURROUND-R
SURROUND-L
FRONT-R
FRONT-L
DOWN_MIX-R
DOWN_MIX-L
(M)
(M)
(M)
(M)
A
A U D I O O U T L E T B D
B
4 4Wednesday, Apr i l 26, 2000
Title
Size Documen t Number Rev
Date: Sheet of
D M - L
D M - L
D M - R
D M - R
M U T E 3
F R O N T - R
F R O N T - L
M U T E 4
C E N T
S U B W
S U R - L
S U R - R
A M U T E
M U T E 2
A 8 V
A-8V
S R - G N D
C S - G N D
C S - G N D
F
F
F
F
F
F R - G N D
F R - G N D
F R - G N D
S R - G N D
F
R 1 3 2 1
4 7 0 R 5
1 2
R 1 3 2 3
4 7 0 R 5
1 2
Q 1 3 0 9
D T C 3 2 3 T K
31
2
R 1 3 2 0
4 7 0 R 5
1 2
Q 1 3 0 8
D T C 3 2 3 T K
31
2
D 1 3 0 4
H S M 2 8 3 8 C
2
1
3
R 1 3 1 7
4 7 0 R 5
1 2
R 1 3 1 8
4 7 0 R 5
1 2
Q 1 3 0 7
D T C 3 2 3 T K
31
2
R 1 3 1 6
4 7 0 R 5
1 2
R 1 3 1 9
4 7 0 R 5
1 2
D 1 3 0 3
H S M 2 8 3 8 C
2
1
3
R 1 5 8 0
6 8 0 R 5
1 2
R 1 3 1 5
2 7 0 R 5
1 2
R 1 5 7 9
6 8 0 R 5
1 2
R 1 3 1 4
2 7 0 R 5
1 2
J 1 3 0 4
R C A - J A C K 1 2
3
21
6
547
J 1 3 0 5
R C A - J A C K 1 2
3
21
6
547
D 1 5 0 4
H S M 2 8 3 6 C
2
13
D 1 5 0 5
H S M 2 8 3 6 C
2
13
R 2 4 5 0
5 K 6 R 5
12
C 1 3 1 7
C 1 5 0 0 P 5 0 V
C 1 3 1 8
C 1 5 0 0 P 5 0 V
C 1 3 1 2
C 1 0 0 0 P 5 0 V
C 1 3 1 3
C 1 0 0 0 P 5 0 V
C 1 3 1 4
C 1 0 0 0 P 5 0 V
C 1 3 1 6
C D 1 U 5 0 V
Z D 1 3 0 3S D C - M A 3 0 2 0 - T
31 2
R 2 5 3 0
4 K 7 R 5
12
Z D 1 3 0 5S D C - M A 3 0 2 0 - T
31 2
Z D 1 3 0 7
H Z S 3 A 1
12
R 3 5 2 8
2 7 0 R 5
1 2
Q 1 3 1 0
D T C 3 2 3 T K
31
2
Q 1 3 1 1
D T C 3 2 3 T K
31
2
C 1 3 2 5
S C D 1 U 1 6 V 5 M N
C 1 3 1 9
S C D 0 1 U 5 0 V 5 M X
C 1 3 2 2
S C D 0 1 U 5 0 V 5 M X
R 3 5 2 7
2 7 0 R 5
1 2P G 1 3 8 1
J S T - C O N 3 - 4
321
D 1 3 0 2
H S M 2 8 3 8 C2
1
3
R 3 5 1 9
2 7 0 R 5
1 2
R 3 5 2 0
2 7 0 R 5
1 2
Q 1 3 0 6
D T C 3 2 3 T K
31
2
G 2 5
1
G 2 6
1
G 2 7
1
R 1 3 2 2
4 7 0 R 5
1 2
Z D 1 3 0 4
S D C - M A 3 0 2 0 - T
31 2
C 1 3 2 3
S C D 0 1 U 5 0 V 5 M X
Q 1 3 1 2
S D C - M A 3 0 2 0 - T
31 2
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
GREEN
RED
MVR BOARD
S A
M I C B O A R D
A C E R C O N S U M E R
B
1 1Monday, March 20, 2000
Title
Size Documen t Number Rev
Date: Sheet of
P W S W P W S WS T B L E D
P W R L E D
P W R L E D
S T B L E D
V R - G N D
V R - G N D
S 1 7 6 1
S K H U B B 3 4 2 0 - H T
1 2
P G 1 7 6 4
J S T - C O N 6 - 4
654321
L D 1 7 6 1
L E D - R G - 2
3
12
R 1 7 2 5
2 7 0 R
1 2
R 1 7 2 6
2 7 0 R1 2
G 1G N D P A D
1
G 2G N D P A D
1
G 3
G N D P A D1
G 4G N D P A D
1
C 1 7 7 2
C D 1 U 5 0 V - 2
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
NTMT
TOP MENU
PLAY/PAUSE
LEFTDOWN
UP ENTERRIGHT
STOP
VIRTUAL SURROUND
SKIP +/FF
OPEN/CLOSE
MENU
DISC NAVI
SKIP -/REW
9 9 4 5 5 - S C S A n
V F D B O A R D
A C E R I N C O R P O R A T E D
B
1 1Tuesday, February 29, 2000
Title
Size Documen t Number Rev
Date: Sheet of
A C 1A C 2
G R I D 1S E G 1 KI1 G R I D 2
G R I D 3G R I D 4G R I D 5
S E G 2
P W S WS T B L E D
S E G 3 P W R L E D
G R I D 6
S E G 4S E G 1 9
V F D D A T
V F D C L K S E G 1 8KI2 V F D S T B S E G 1 7
KI1 S E G 1 6KI2 S E G 1 5KI3 S E G 1 4KI4 S E G 1 3
S E G 1S E G 2S E G 3S E G 4S E G 5S E G 6S E G 7
KI3 S E G 8S E G 9S E G 1 0S E G 1 1S E G 1 2
IRA C 1
S E G 1 9S E G 1 8S E G 1 7
S E G 5 S E G 1 6S E G 1 5S E G 1 4 IRS E G 1 3S E G 1 2 V F D C L KS E G 1 1 V F D S T BS E G 1 0 V F D D A T
KI4 S E G 9 S T B L E DS E G 8 P W S WS E G 7 P W R L E DS E G 6S E G 5S E G 4S E G 3S E G 2S E G 1
G R I D 6G R I D 5G R I D 4G R I D 3G R I D 2G R I D 1
A C 2
-20V
5 V
5 V
S T B
5 V5 V
5 V
S T B
-20V5 V
P G 1 7 6 4 B
J S T - C O N 6 - 4
654321
D 1 7 0 1
1 N 4 1 4 8
1 2
D 1 7 0 2
1 N 4 1 4 8
1 2
D 1 7 0 3
1 N 4 1 4 8
1 2
D 1 7 0 4
1 N 4 1 4 8
1 2
D 1 7 0 5
1 N 4 1 4 8
1 2
R 1 7 0 11 0 K R
12
R 1 7 0 21 0 K R
12
R 1 7 0 31 0 K R
12
R 1 7 0 41 0 K R
12
R 1 7 0 91 0 0 R
12
IC1703
R P M 6 9 3 8 - V 4
R O U T1G N D2V C C3
C N 1 7 0 2
J S T - C O N 5 - 4
54321
L 1 7 0 1
COIL -100UH-3U1 2
S 1 7 0 4
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 8
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 1
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 3
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 5
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 6
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 7
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 0 9
S K H U B B 3 4 2 0 - H T
1 2
IC1701
U P D 1 6 3 1 1
S W 11
S W 22
S W 33
S W 44
D O U T5
DIN6
IC7
C L K8
S T B9
K E Y 11 0
K E Y 21 1
K E Y 31 2
K E Y 41 3
VD
D14
SE
G1/K
S1
15S
EG
2/KS
216
SE
G3/K
S3
17S
EG
4/KS
418
SE
G5/K
S5
19S
EG
6/KS
620
SE
G7/K
S7
21S
EG
8/KS
822
SE
G9/K
S9
23S
EG
10/KS
1024
SE
G11/K
S11
25S
EG
12/KS
1226
S E G 1 3 / G R I D 1 62 7S E G 1 4 / G R I D 1 52 8S E G 1 5 / G R I D 1 42 9S E G 1 6 / G R I D 1 33 0S E G 1 7 / G R I D 1 23 1S E G 1 8 / G R I D 1 13 2V D D3 3V E E3 4S E G 1 9 / G R I D 1 03 5S E G 2 0 / G R I D 93 6G R I D 83 7G R I D 73 8G R I D 63 9
GR
ID15
40
GR
ID4
41
GR
ID3
42
GR
ID2
43
GR
ID1
44
VD
D45
LE
D5
46
LE
D4
47
LE
D3
48
LE
D2
49
LE
D1
50
VS
S51
OS
C52
S 1 7 0 2
S K H U B B 3 4 2 0 - H T
1 2
S 1 7 1 0
S W - S L I D E 6
123 4
56
C 1 7 0 4E 3 3 0 U 1 0 V - 1
12
C 1 7 0 5S C D 0 4 7 U 5 0 V 5 K X
C 1 7 0 6
S C D 0 4 7 U 5 0 V 5 K X
Z D 1 7 0 6H Z S 3 A 1
12
P G 1 7 0 1
H I T C O N 1 0
1 0987654321
G 9G N D P A D
1
G 3 4
G N D P A D
1
IC1702
2 5 U 4 8 1 0 6 B A
F 11
F 12
N P3
N P4
P 15
P 26
P 37
P 48
P 59
P 61 0
P 71 1
P 81 2
P 91 3
P 1 01 4
P 1 11 5
P 1 21 6
P 1 31 7
P 1 41 8
P 1 51 9
P 1 62 0
P 1 72 1
P 1 82 2
P 1 92 3
N X2 4
N X2 5
N X2 6
N X2 7
N X2 8
N X2 9
N X3 0
N X3 1
N X3 2
6 G3 3
5 G3 4
4 G3 5
3 G3 6
2 G3 7
1 G3 8
N P3 9
N P4 0
F 24 1
F 24 2
G 6G N D P A D
1
G 4 3G N D P A D
1
G 4 9
G N D P A D1
R 1 7 1 1
1 0 K R 5
1 2
R 1 7 1 2
1 0 K R 5
1 2
R 1 7 0 8
1 0 K R 5
1 2
R 1 7 9 0
5 6 K R 5
1 2
G 4 5
1
G 4 4
1
G 4 6
1
G 4 7
1
G 4 8
1
G 4 11G 4 2
1
G 2
1
G 1
1
G 3
1
G 4
1
G 5
1
G 8
1
G 7
1
G 3 5G N D P A D
1
G 3 3
1
G 3 2
1
G 3 1
1
G 3 0
1
G 2 9
1
G 2 8
1
G 2 7
1
G 2 6
1G 2 5
1G 2 4
1
G 2 3
1
G 2 2
1
G 2 1
1
G 2 0
1
G 1 9
1
G 1 8
1
G 1 7
1
G 1 6
1
G 1 5
1
G 1 4
1
G 1 3
1
G 1 2
1
G 1 1
1
G 1 0
1
C 1 7 0 1E 3 3 0 U 1 0 V - 1
12
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
VIDEO
Y
B-Y
R-Y
S-VIDEO
DEC-->RJK
POWER-->RJK
NTMT
|LINK|2.SCH NTMT
9 9 4 5 4 - S C A
V I D E O O U T L E D B D
B
1 2Tuesday, February 29, 2000
Title
Size Documen t Number Rev
Date: Sheet of
Y2 Y1
C b 1 C b
Cr1 Cr
Y1
Y2
C b 1Cr1 C b
Cr
C V B S
C V B S - G N D
Y
Y - G N D
C - G N D
Y1
Y 1 - G N D
C b
C b - G N D
Cr
C r - G N DB L N KB L N K - G N D
Y - G N D
C
Y
C - G N D
C V B S
C V B S - G N D
Y2
Y 1 - G N D
C b - G N D
C r - G N D
C V B S 2
C V B S - G N D
C bC b - G N D
CrC r - G N D
Y1Y 1 - G N D
B L N K
Y2
Cr
C bC b 1Cr1
C b 1
Cr1
C
Y1
S Q U E E Z E
B L N K - G N D
B L N K - G N D
B L N K - G N D
C - G N D C - G N D C - G N D
+ 5 V
+ 5 V
F
F
F
F
F
FF
F
F
F
J 1 3 0 7
R C A - J A C K 1 5
1
23
45
R 3 3 0 1
6 8 R 5 F
12
Z D 1 3 0 6
S D C - M A 3 0 2 0 - T
312
Z D 1 3 5 1
S D C - M A 3 0 2 0 - T
312
J 1 3 0 6
R C A - J A C K 1 6
5
43
12
67
IC1381
B A 7 6 0 2 F
IN2A1
C T L A2
O U T A3
G N D4
O U T B5
O U T C6
C T L C7
IN2C8
IN1C9G N D1 01 N 1 B1 1C T L B1 2V C C1 3IN2B1 4G N D1 5IN1A1 6
L 1 3 8 1F B M 3 2 2 5
12
J 1 3 8 1
H S N - C O N N 1 4
1 6
7654321
1 5
1 41 31 21 11 098
R 3 3 1 71 0 0 K R 5
12
C 1 3 8 2
E 1 0 0 U 1 6 V - 1
12
C 3 3 1 0 S C D 0 1 U 5 0 V 5 M X
C 3 3 1 2 S C D 0 1 U 5 0 V 5 M X
C 3 3 1 6 S C D 0 1 U 5 0 V 5 M X
C 3 3 1 8 S C D 0 1 U 5 0 V 5 M X
C 3 3 2 0 S C D 0 1 U 5 0 V 5 M X
R 3 3 2 4 0 R 51 2
R 3 3 2 6 0 R 51 2
R 3 3 2 5 0 R 51 2
C 1 3 7 3
COIL -100UH-3U
12
C 1 3 5 1
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 2 7
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 8 1
S C D 1 U 2 5 V 5 K X
R 1 3 8 1
5 6 K R
12
R 3 3 0 5
6 8 R 5 F12
R 3 3 0 3
6 8 R 5 F
12
R 3 3 1 11 0 0 K R
12
R 3 3 1 31 0 0 K R
12
R 3 3 1 91 0 0 K R
12
R 3 3 2 11 0 0 K R
12
R 3 3 2 31 0 0 K R
12
R 3 3 0 2
6 8 R 5 F
12
P G 1 3 0 2
S M K C O N 1 7
1 71 61 51 41 31 21 11 0987654321
G 1G N D P A D
1
G 2G N D P A D
1
G 3G N D P A D
1
G 4G N D P A D
1
G 5G N D P A D
1
G 6G N D P A D
1
G 7G N D P A D
1
G 8G N D P A D
1
G 9G N D P A D
1
G 1 0G N D P A D
1
G 1 1G N D P A D
1
G 1 2G N D P A D
1
G 1 3G N D P A D
1
G 1 4G N D P A D
1
G 1 5G N D P A D
1
G 1 6G N D P A D
1
G 1 7G N D P A D
1
C 1 5 2 0
S C 1 0 0 0 P 5 0 V 5 K X
C 1 5 2 1
S C 1 0 0 0 P 5 0 V 5 K X
C 3 3 1 1 E 1 0 0 0 U 1 6 V
1 2
C 3 3 1 3 E 1 0 0 0 U 1 6 V
1 2
C 3 3 1 7 E 1 0 0 0 U 1 6 V
1 2
C 3 3 2 3 E 1 0 0 0 U 1 6 V
1 2
J 1 3 0 2
YKF51-5505
12345
C 1 4 9 9
S C 1 0 0 0 P 5 0 V 5 K X
C 3 3 1 9 E 2 2 0 U 1 0 V - 1
1 2
C 3 3 2 2
S C D 0 1 U 5 0 V 5 M X
C 3 3 2 1 E 2 2 0 U 1 0 V - 1
1 2
R 3 3 2 7
6 8 R 5 F
12
R 3 3 2 8
6 8 R 5 F
12
R 3 3 2 9
6 8 R 5 F
12
C 1 5 2 2
S C 1 0 0 0 P 5 0 V 5 K X
J B 0 1
F B M 3 2 2 5
1 2C 1 5 2 3
C D 1 U 5 0 V - 2
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
A A
B B
C C
D D
V-GND
V-GND
V-GND
V-GND
NTMT
NTMT
SCART
NTMT
RJK--->VDO
NTMT
9 9 4 5 4 - S C A
V I D E O O U T L E D B D
B
2 2Tuesday, February 29, 2000
Title
Size Documen t Number Rev
Date: Sheet of
D M - L
D M - R
D M - L
D M - R
C V B S 2B L N K
CrB L N K - G N D
C r - G N D
Y1
Y 1 - G N D
C b
C b - G N D
S Q U E E Z E
+ 1 2 V
+ 5 V
D M - G N D
F
F
FF
D M - G N D
F
+ 1 2 V
+ 5 V
Q 1 3 6 3
2 S A 1 0 3 7 A K
3
2
1
R 1 3 6 5
5 6 K R 5
12
R 1 3 6 4
1 0 R 5
12
J 1 3 6 1
AJ -2050
1
3
5
7
9
1 1
1 3
1 5
1 7
1 9
2 1
2
4
6
8
1 0
1 2
1 4
1 6
1 8
2 0
R 1 3 6 7
7 5 R 5
12
Z D 1 3 6 5
S D C - M A 3 0 2 0 - T3
1 2
D 1 3 6 1U D Z S 6 D 2 B
12
Z D 1 3 7 0
S D C - M A 3 0 2 0 - T
312
R 1 3 6 1
1 K 5 R 5
12
R 1 3 6 2
1 K 5 R 5
12
L 1 3 6 2
F B M 3 2 2 5
1 2
T L 1 3 6 2G N D P A D
1
T L 1 3 7 3
G N D P A D1
T L 1 3 6 3G N D P A D
1
C 1 3 7 0
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 7 1
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 6 0
E 1 0 0 U 1 6 V - 1
12
C 1 3 6 2
E 1 0 0 U 1 6 V - 1
12
J B 0 2
F B M 3 2 2 5
1 2
C N 1 3 8 1
J S T - C O N 3 - 4
321
L 1 3 6 1F B M 3 2 2 5
12
T L 1 3 6 1
G N D P A D1
C 1 3 7 5
S C 1 0 0 0 P 5 0 V 5 K X
T L 1 3 9 0G N D P A D
1
T L 1 3 9 1G N D P A D
1
T L 1 3 9 2G N D P A D
1
T L 1 3 9 3G N D P A D
1
T L 1 3 9 4
G N D P A D1
C 1 3 7 2
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 6 6
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 6 1
S C D 1 U 2 5 V 5 K X
C 1 3 6 3
S C D 1 U 2 5 V 5 K X
C 1 3 6 4
S C 1 0 0 0 P 5 0 V 5 K X
C 1 3 6 8
S C D 1 U 2 5 V 5 K X
Q 1 3 6 1
D T C 1 2 4 E K A
IN
OUT
GNDR1
R2
21
3
Q 1 3 6 2
D T C 1 2 4 E K A
IN
OUT
GNDR1
R2
21
3
R 1 3 6 0
1 K 5 R 5
12
Z D 1 3 6 0S D C - M A 3 0 5 1 M
312
Z D 1 3 6 1S D C - M A 3 0 5 1 M
312
C 1 3 6 7
S C D 1 U 2 5 V 5 K X
Z D 1 3 6 4S D C - M A 3 1 5 0 L
31 2 Z D 1 3 6 6
S D C - M A 3 0 2 0 - T
31 2
T L 1 3 9 5
G N D P A D
1
R 1 3 7 1
2 7 R 512
R 1 3 6 3
1 K 5 R 5
12
R 1 3 7 0
6 8 R 5 F12
R 1 3 6 8 6 8 R 5 F
12
R 1 3 6 9 6 8 R 5 F
12
R 1 3 7 2
6 8 R 5 F
12
P G 1 3 6 2
J S T - C O N 4 - 4
4321
P G 1 3 6 1
J S T - C O N 4 - 4
4321
DV-P505UDV-P505EDV-P505E(UK)DV-P505U(PX)
TK No. 9002E Digital Media Products Division, Tokai
Copylight© Hitachi, Ltd. 2000. All rights reserved. Printed in TAIWAN