Doc for 07 _ojt 320 b1 b2_ Ed4
-
Upload
maddygaddy -
Category
Documents
-
view
249 -
download
0
Transcript of Doc for 07 _ojt 320 b1 b2_ Ed4
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
1/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 1/48
A318/319/320/321CFM56
A319/320/321IAE V2500
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
2/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 2/48
TRAINEE
SURNAME: Forename:
Licence number:
Experience on an aircraft with similar technology: YESNO
Signature: Date : / /
ON JOB TRAININGType of training: A318/319/320/321 CFM56
A319/320/321 IAE V2500
Type: B1 B1/B2
Starting date : / / Ending Date : / /
Performed at :
DERICHEBOURG ATISARONAUTIQUE STAMP :
PRACTICAL ASSESSORSLicence
number/StampNAME Signature Date
Validation by Quality Department:
Date: Name: Signature:
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
3/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 3/48
SUBJECTThe aim of this document is to record all the practical tasks performed by engineers within ATIS
Aviation, PART 145 FR.145.107 approved maintenance organisation, in order to comply with therequirements of Appendix III of PART 66 to have the B1 or B1/B2 rating on A318/319/320/321CFM56 or/and 319/320/321 IAE V2500 aircraft.
Any task performed in the frame of this On Job Training (OJT) will have to be signed by thetrainee engineer and validated by assessors. This OJT will be performed under the responsibilityof one or more B1 or B1/B2 qualified engineers. (See PRE-REQUISIT on page 4/38)
After this training, the engineer will be able to:- perform verifications of systems, engines, components and operational functions such as
specified in the maintenance manual,- analyse all information in order to make decisions regarding trouble shooting and corrective
actions as per maintenance manual,- describe the component replacement procedures specific to aircraft type.
DURATION- Engineer with B1 or B1/B2 rating and six month experience on an aircraft with a similartechnology: 70 hours(1),
- Engineer with B1 or B1/B2 rating and less than six month experience on an aircraft with asimilar technology: 140 hours(1),
- Engineer with no B1 or B1/B2 rating on an aircraft with a similar technology: four months.(1)The 70/140 hours do not have to be necessarily performed in a row, but can be extended on a period adapted tooperational configuration (availability of aircraft, trainee and assessors).
CLASSIFICATIONClassifies the importance of a task for the completion of the practical training record.Following classifications are used:- Mandatory (M): This indicates that the related task is required for completion of the
practical training record.
- Optional (O): This indicates that the related task is optional. It is recommended toperform at least 70% of those tasks in each ATA chapter.
TASKS CODES- FOT: Functional Operational Test(*)- LOC: Location and identification of system components- MEL: Minimum Equipment List items requiring a maintenance procedure- RIA: Removal Installation Activation- OPC: Operational Check- SGH: Servicing Ground Handling- TSE: Trouble shooting Exercise- TVC: Carry out Thorough Visual Check
- TPR: Thorough Procedural review(*)If ground power or other applicable systems are unavailable a TPR will be carried out in place of a FOT.
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
4/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 4/48
SIGNING OFF THE TASKSPart 66 Appendix 3 paragraph 2.2 requires that the practical training element must consist of theperformance of representative tasks and their assessment, in order to meet the followingobjectives:
a) Ensure safe performance of maintenance, inspections and routine work according to themaintenance manual and other relevant instructions and tasks as appropriate for the typeof aircraft, for example troubleshooting, repairs, adjustments, replacements, rigging andfunctional checks such as engine run, etc, if required,
b) Correctly use all technical literature and documentation for the aircraft,
c) Correctly use specialist/special tooling and test equipment, perform removal andreplacement of components
The nominated trainer/assessor will sign off each task when satisfied that the trainee hasattained the demonstrable level of understanding that is required.
PRE-REQUISITThe trainee must have participated and succeeded in a PART 147 theoretical type rating training(T1/T2 training).
The assessors must have an experience of five years in the line maintenance and two years inthe qualification of type.For any OJT, the assessors will have to make a request by email at the Quality Department forvalidation of pre-requisit.
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
5/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 5/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U05-00-00 - TIME LIMITS / MAINTENANCE CHECKS U
05-001 05-00-00 Daily check M TVC
05-002 05-50-00 Weekly check M TVC
05-003 05-51-11 Walk around check M TVC
U09-00-00 - TOWING&TAXINGU
09-001 09-00-00Towing points/steeringangle limitation
M SGH
U10-00-00 - PARKING AND MOORING U
10-001 10-00-00 Landing gear loking pins M SGH
10-002 10-00-00 Engine / airframe blanging O SGH
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
6/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 6/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U12-00-00 - SERVICINGU
12-001 12-11-28Automatic refuel/defuelprocedures
M SGH
12-001 12-11-28Presure Refuel underManual Control
M FOT
12-003 12-11-28Magnetic Fuel Quantityindicators reading
O SGH
12-004 12-12-29Reservoirs refiling withhand pump
M SGH
12-005 12-13-24Electrical power servicing(IDG)
M SGH
12-006 12-13-49 APU servicing M SGH
12-007 12-13-0 Engine starter servicing O SGH
12-008 12-14-29 Accumulators filing O SGH
12-009 12-14-32
Landing gear gas servicing
procedure using chart O SGH
12-010 12-15-38 Potable water servicing M SGH
12-011 12-16-38 Lavatory servicing M SGH
12-012 12-34-24 Aircraft grounding M SGH
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
7/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 7/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U21-00-00 AIR CONDITIONNING U
21-001 21-00-00ECS/Aircon controls I &indications int he cockpit
M LOC
21-002 21-00-00Aircon. System,components
M LOC
21-003 21-00-00Aircon. System - Defectsrectification & TIS
M TSE
21-004 21-21-00Operational test of CabinRecirc Fans
M FOT
21-005 21-21-41 Recirculation filter M LOC
21-006 21-26-00Deact/reactivation ofavionics vent components
O MEL
21-007 21-26-00Avionics smokeconfiguration control circuit
O FOT
21-008 21-26-00Operational test of theAvionics Eqpt Ventilationfrom the MCDU
O FOT
21-009 21-26-00 Avionics Equipt Ventilationsyst Test (No CFDS)
O FOT
21-010 21-26-00 AEVC M RIA
21-011 21-26-43 Avionics vent demister filter M RIA
21-012 21-28-00Cargo compartmentventilation system
O FOT
21-013 21-28-00Deact/reactivation of cargocompt. vent. Isol. valve
O MEL
21-014 21-31-00Manual pressure control &
monitoring system
O FOT
21-015 21-31-00Operational Test of thePressure Control andMonitoring System
M FOT
21-016 21-43-00Test of the AFT CGOcompartement HeatingSystem
M FOT
21-017 21-51-00Pack flow control &indicating
M FOT
21-018 21-51-00Deact. / reactivation of packflow contrl valve
O MEL
21-019 21-55-00 Emergency ram air inlet M FOT
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
8/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 8/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
21-020 21-61-00Operational test of Packtemp. Control. System
M FOT
21-021 21-63-00Deact. / reactivation of trimair & hot air valves
O MEL
21-022 21-63-00Functional test of cockpit /temperature control
M FOT
21-023 21-63-17 Cabin temperature sensors M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
9/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 9/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U22-00-00 AUTO FLIGHT
22-001 22-00-00AFS controls andindications in cockpit
M LOC
22-002 22-00-00AFS controls andindications in cockpit
M LOC
22-003 22-10-00A/P disengagement andlocking devices
O FOT
22-004 22-60-00 Windshear procedure M MEL
22-005 22-61-00Rudder travel limitingfunction
M FOT
22-006 22-62-00Rudder trim function testand reset
M FOT
22-007 22-63-00 Yaw damper function M FOT
22-008 22-66-00 FAC M RIA
22-009 22-70-00FM Navigation databaseloading
O SGH
22-010 22-70-00 FM MCDU menu Data entry M SGH
22-011 22-70-00Flight plan initializationprocedure
M SGH
22-012 22-81-00 FCU M RIA
22-013 22-82-12 MCDU M RIA
22-014 22-91-00 AFS Ground Scanning test M FOT
22-015 22-97-00AFS land CAT3 capabilitytest M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
10/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 10/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U23-00-00 COMMUNICATION
23-001 23-00-00Com. System controls andindic. In the cockpit
M LOC
23-002 23-00-00 Com. System components M LOC
23-003 23-00-00Com. System - Defectrectification & TIS
M TSE
23-004 23-00-00 Com. System components M TSE
23-005 23-12-00VHF communication systemoperation
O FOT
23-006 23-12-00 VHF system BITE test M FOT
23-007 23-13-00 RMP BITE test M FOT
23-008 23-32-00 PRAM M RIA
23-009 23-32-00 PRAM Tape M RIA
23-010 23-32-00 PRAM initialization M SGH
23-011 23-44-00Service interphone /Mechanic call
O FOT
23-012 23-51-00Audio managementoperational test
O FOT
23-013 23-51-00 ACP switching M FOT
23-014 23-51-12 ACP M RIA
23-015 23-51-00 AMU / ACP BITE test O FOT
23-016 23-71-00 CVR Mic Amplifer O RIA
23-017 23-71-00 CVR M RIA
23-018 23-73-00Cabin and flight crewinterphone (CIDS)
O FOT
23-019 23-73-00CIDS energizing / de-energizing & BITE
O FOT
23-020 23-73-00
FAP and PTP general
operation M FOT
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
11/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 11/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
23-021 23-73-00Cabin Layout and zoneprogramming
M SGH
23-022 23-73-00CIDS system test throughMCDU
M FOT
23-023 23-73-00 CIDS Director M RIA
23-024 23-73-00 DEU A / DEU B M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
12/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 12/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U24-00-00 - ELECTRICAL POWER.N.B. : SERVICING tasks p lease refer to ATA 12-00-00 Chapter
24-001 24-00-00Electrical power controls &ind. In the cockpit
M LOC
24-002 24-00-00Electrical power systemcomponents
M LOC
24-003 24-00-00Electrical system defectsrectification & T/S
M TSE
24-004 24-20-00Deact/Reactivation RATextension control
M MEL RIA
24-005 24-20-00Deact / Reactivation Enginedriven generator
M MEL RIA
24-006 24-22-55 GLC-BTC contactors M RIA
24-007 24-24-00Emergency generationsystem
M FOT
24-008 24-24-00 Emergency generator GCU M FOT
24-009 24-26-00Galley manual an automaticshedding O FOT
24-010 24-28-00 Static inverter test M FOT
24-011 24-30-00Deact / Reactivation of aBCL
O MEL
24-012 24-32-00TR reset via CFDS andfrom panel 103 VU
O FOT
24-013 24-38-00 Battery charge limiter M FOT
24-014 24-41-00External powercontrol/GPCU function
M FOT
24-015 24-41-00Energize a/c electricalnetwork form ext. Power
M FOT
24-016 24-41-00De-Energize a/c electricalnetwork from ext. Power
M FOT
24-017 24-41-34 gpcu (or GAPCU) M RIA
24-018 24-42-00Energize the ground servicenetwork
M FOT
24-019 24-56-00Deact./React. Of Galleysupply system
M MEL
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
13/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 13/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
24-020 24-56-00 Galley supply contactors M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
14/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 14/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U25-00-00 EQUIPMENT AND FURNISHING.
25-001 25-00-00Equipment & furnishingcomponents location
M LOC
25-002 25-11-00 Crew seats M FOT
25-003 25-11-00 3rd occupant seat M RIA
25-004 25-21-00Passenger convertibleseats
O SGH
25-005 25-23-00 Ceiling panels M RIA
25-006 25-23-00 Cove light panels M RIA
25-007 25-25-00PSU / PIU / cove lightpanels
M RIA
25-008 25-35-00 Galley equipment O SGH
25-009 25-00-00
Check of pressure at door
escape slides (no CIDS) O TVC
25-010 25-50-00 Cargo loading system O FOT
25-011 25-53-00Drainage cargocompartment
O SGH
25-012 25-62-00 Doors escape slides M RIA
25-013 25-62-00 Over wing escape slide O RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
15/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 15/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U26-00-00 FIRE PROTECTION.
26-001 26-12-00Fire protection controls &ind. In the cockpit
M LOC
26-002 26-12-00Fire protection systemcomponents
M LOC
26-003 26-12-00Fire protection systemdefect rectification & T/S
M TSE
26-004 26-12-00Engine fire detectionsystem test
M FOT
26-005 26-13-00APU fire detection systemtest
M FOT
26-006 26-15-00Avionics compartmentsmoke detection
O FOT
26-007 26-16-00LDCC Smoke DetectionTest using PTT
M FOT
26-008 26-17-00Test of Lavatory SmokeDetection System
M FOT
26-009 26-17-00 SDCU M RIA
26-010 26-22-00APU auto fire extinguishing& APU LP fuel valve
M FOT
26-011 26-23-00Cargo compartment fireextinguishing system
M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
16/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 16/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U27-00-200. FLIGHT CONTROL
27-001 27-00-00Flight control componens &ind. In the cockpit
M LOC
27-002 27-00-00 Flight control components M LOC
27-003 27-00-00Flight control systemdefects rectification & T/S
M TSE
27-004 27-14-00Deactivation / reactivationof aileron servo control
M MEL
27-005 27-14-00Aileron servo controlactuation
M FOT
27-006 27-21-00 Rudder centering spring rod M FOT
27-007 27-22-00 Rudder trim reset function M FOT
27-008 27-23-00Operational test of ruddertravel limitation unit
O FOT
27-009 27-24-00
Test of Rudder SC with
individual Hyd System M FOT
27-010 27-34-00 Elevator sytem M FOT
27-011 27-41-00THS system test-using trimwheels
M FOT
27-012 27-44-51THS : check of no-backwear indicator
O TVC
27-013 27-44-51THS : inspection of gearboxmagnetic chip detector
O TVC
27-014 27-50-00Extending / retracting Flaps& Slats
M FOT
27-015 27-51-00Wingtip brake and pressureoff brake : eng & reset
M FOT
27-016 27-51-00SFCC (Flap system) BITEtest
M FOT
27-017 27-51-00Automatic Integrity Test ofSFCC
M FOT
27-018 27-51-00 S/F control lever M RIA
27-019 27-60-00Ground spoilermaintenance device
M SGH
27-020 27-64-00
Deactivation / reactivation
of spoiler actuator M MEL
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
17/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 17/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
27-021 27-81-00SFCC (slat system) BITEtest
M FOT
27-022 27-81-00 Slat WTB and POB test O FOT
27-023 27-94-00 SEC M RIA
27-024 27-96-00EFCS BITE (GroundScanning) test
M FOT
27-025 27-96-00Ability of ELAC and SEC tocontrol Elevators SC M FOT
27-026 27-96-00Test of the Side StickAssembly
O FOT
27-027 27-96-00Test of the DampingMeasurement (Aileron)
M FOT
27-028 27-96-00Test of the DampingMeasurement (Elevator)
M FOT
27-029 27-96-00 FCDC M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
18/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 18/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U28-00-00. FUELN.B. : For SERVICING tasks please refer to ATA 12-00-00 Chapter
28-001 28-00-00Fuel system control &indications in the cockpit
M LOC
28-002 28-00-00 Fuel system components M LOC
28-003 28-00-00Fuel system defectsrectification & T/S
M TSE
28-004 28-11-00 Water drain system M SGH
28-005 28-12-00Tank venting overpressureprotector
M MEL
28-006 28-15-00Transfer Valves IndividualOperational
O FOT
28-007 28-15-00 Transfer Valves actuator M RIA
28-008 28-21-00 Wing-tank fuel control test O FOT
28-009 28-22-00Bleed APU fuel line fromAPU O FOT
28-010 28-24-00Engine LP fuel shut-offvalve
M FOT
28-011 28-25-00 Defuel /Transfer operations O SGH
28-012 28-25-00Deact/reactivation of refuelvalve (Manual refuel)
O MEL
28-013 28-25-00Deact/reactivation oftransfer defuel valve
O MEL
28-014 28-40-00Deact/reactivation of APULP valve & X-feed valve
O MEL
28-015 28-42-00 FQIC Status Report (BITE) O FOT
28-016 28-42-00 FQIC M RIA
28-017 28-43-00Determination of fuel levelusing M.L.I
O SGH
28-018 28-46-00Tank High Level SensingSystem
M FOT
28-019 28-46-00 FLSS Functional (BITE) test M FOT
28-020 /
Fuel Tank Safety / CDCCL
awareness M TPR
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
19/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 19/48
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
20/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 20/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U29-00-00. HYDRAULIC POWERN.B. : For SERVICING tasks please refer to ATA 12-00-00 Chapter
29-001 29-00-00Hydraulic sytem controls &Ind. In the cockpit
M LOC
29-002 29-00-00Hydraulic systemcomponents & servicepanels
M LOC
29-003 29-00-00
Hydraulic power defects
rectification & T/S M TSE
29-004 29-10-00Press/depressurize Bluehydraulic system (usingelectric pump)
M FOT
29-005 29-12-00Blue hyd. Sys. Electricpump phase unbalancedetector
M FOT
29-006 29-14-00 Reservoir pressurization O SGH
29-007 29-17-00Collector tanks seal drainsystem
O SGH
29-008 29-22-00 RAT Auto Deployment Test M FOT
29-009 29-23-00
Pressurize/ depressurisegreen hydraulic systemfrom yellow hydraulicsystem through PTU usingelectric pump
M FOT
29-010 29-23-00PTU isolation couplingdisconnection reconnection
M SGH
29-011 29-31-00Deact./reactivation ofhydraulic fluid quantity ind.
M MEL
29-012 29-34-00Deact./reactivation ofreservoir pressurization ind.
M MEL
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
21/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 21/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U30-00-00. ICE AND RAIN PROTECTION
30-001 30-00-00Anti-ice system controls &ind. In the cockpit
M LOC
30-002 30-00-00Anti-ice systemcomponents
M LOC
30-003 30-00-00Anti-ice system defectsrectification & T/S
M TSE
30-004 30-11-00Wing ice protection :deact/react of anti-icecontrol valve
M MEL
30-005 30-11-00Wing ice protection groundtest
M FOT
30-006 30-21-00Deact/reactivation of engineanti-ice valve
O MEL
30-007 30-31-00Check of probe heatingchannel
M MEL
30-008 30-31-00 Probe ice protectionoperational test
O FOT
30-009 30-31-00 PHC M RIA
30-010 30-42-00Windshield anti-icing anddefogging operational test
O FOT
30-011 30-42-00 WHC M RIA
30-012 30-71-00Deact/reactivation of Wastewater drain mast heating
O MEL
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
22/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 22/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U31-00-00. INDICATING/RECORDING
31-001 31-00-00System controls andindications int he cockpit
M LOC
31-002 31-00-00Indicating/recording systemcomponents
O LOC
31-003 31-00-00Indicating/recording syst,Deects rectification & T/S
M TSE
31-004 31-21-00 Electrical clock M RIA
31-005 31-21-00 Electrical clock setting M SGH
31-006 31-32-00CFDS general operation,TS & Class 3 faults reading
M FOT
31-007 31-32-00 CFDIU Bite Test O FOT
31-008 31-32-00 Uploading of CFDS filter O SGH
31-009 31-32-00
Activation/Deact. Of PFR
filter O SGH
31-010 31-33-00FDIU fault monotoring Testvia MCDU
M FOT
31-011 31-33-00 OAR disk (if installed) M RIA
31-012 31-35-00 Printer operation O SGH
31-013 31-35-22 Printer servicing M SGH
31-014 31-35-00 Printer M RIA
31-015 31-36-00AIDS general operation ¶meter call-up menus
M FOT
31-016 31-36-00 Print Out of Stored Report O SGH
31-017 31-36-00 Test of DMU M FOT
31-018 31-36-00Update APU Hours andCycles into DMU
M SGH
31-019 31-36-00 DMU M RIA
31-020 31-60-00
EIS (EFIS/ECAM) start /
stop procedure M FOT
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
23/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 23/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
31-021 31-60-00EFIS/ECAM switchingfunctions
M FOT
31-022 31-60-00 EIS system test/display test O FOT
31-023 31-60-00 EIS input test O FOT
31-024 31-63-00 Display Unit M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
24/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 24/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U32-00-00. LANDING GEARN.B : For SERVICING tasks please refer to ATA 12-00-00 Chapter
32-001 32-00-00Landing gear systemcontrols & Ind. Int thecockpit
M LOC
32-002 32-00-00MLG/NLG/MWS and wheelwell components
M LOC
32-003 32-00-00
Ldg Gear defects
rectification & T/S M TSE
32-004 32-11-00
In-Situ explanation of MLGshock absorber spare sealactivating valve andmaintenance practices
O SGH
32-005 32-12-00Maint landing gear doorsground opening & closing
M SGH
32-006 32-22-00Nose landing gear doorsground opening & closing
M SGH
32-007 32-31-00 LGCIU M RIA
32-008 32-41-00 Main nose wheel removal M RIA
32-009 32-42-00Bleeding o brake system &reset of safety valve
O SGH
32-010 32-42-00Deact/reactivation of mainwheel brakes
M MEL
32-011 32-42-00 Normal brake system test O FOT
32-012 32-42-00 Brake unit removal O RIA
32-013 32-44-00Alternate braking with &without antis kid
M FOT
32-014 32-45-00Parking / ultimateemergency braking
M FOT
32-015 32-45-00Release of parking brakepressure
O SGH
32-016 32-46-00BSCU BITE Test andGNDSCAN selection
M FOT
32-017 32-47-00Deact./reacivation of braketemperature sensor
O MEL
32-018 32-49-00TPIS BITE test CFOSprocedure (if installed)
O FOT
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
25/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 25/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
32-019 32-51-00Nose wheel steeringoperational test (CFOS)
M FOT
32-020 32-61-00 LDG NOT DOWN test O FOT
32-021 32-69-00BITE test of the landinggear
M FOT
32-022 32-69-00Simulation of flight, aircrafton ground
O FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
26/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 26/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U33-00-00. LIGHTS
33-001 33-00-00Light controls & ind. In thecockpit
M LOC
33-002 33-00-00Light controls & ind. In thecabin
M LOC
33-003 33-00-00 Light components M LOC
33-004 33-10-00Bulb replacement of pushbutton switches
M RIA
33-005 33-10-00Cockpit general illumination& Integral lighting
M FOT
33-006 33-14-00Annuciator light test &dimming
M FOT
33-007 33-21-00 Cabin general illumination M FOT
33-008 33-21-00 Cabin lights M RIA
33-009 33-24-00 Lavatory lighting O FOT
33-010 33-25-00 Passenger reading lights O FOT
33-011 33-25-00 Passenger reading lights M RIA
33-012 33-26-00 Lavatory lighted signs O FOT
33-013 33-27-00 Cabin attendant work light O FOT
33-014 33-30-00 Cargo and services lights O FOT
33-015 33-35-00Equipment compartmentlighting
O FOT
33-016 33-40-00 Exterior lights M FOT
33-017 33-41-00 Navigation lights O FOT
33-018 33-51-00 Emergency light test M MEL
33-019 33-51-00Emergency lighting throughPTP
O FOT
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
27/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 27/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
33-020 33-51-00EMER LIGHT SVS fromcockpit and FAP
M FOT
33-021 33-51-00EMER escape path markinglights
M FOT
33-022 33-51-00 EPSU M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
28/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 28/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U34-00-00. NAVIGATION
34-001 34-00-00Navigation system controls& ind. In the cockpit
M LOC
34-002 34-00-00Navigation systemcomponents
M LOC
34-003 34-00-00Navigation system - Defectrectification & T/S
M TSE
34-004 34-10-00ADIRS start / stopprocedure
M SGH
34-005 34-10-00 IR alignment procedure M SGH
34-006 34-13-00 ADR BITE / interface test O FOT
34-007 34-14-00 IR BITE / interface test O FOT
34-008 34-11-00 ADM M RIA
34-009 34-13-00
ALTICAS dynamic slew
tests O FOT
34-010 34-36-00 ILS (MMR) BITE test O FOT
34-011 34-41-00Weather radar BITE test(Safety precautions)
M FOT
34-012 34-42-00 Radio altimeter BITE test O FOT
34-013 34-42-00 Radio altimeter ramp test O FOT
34-014 34-43-00 TCAS BITE test (if installed) O FOT
34-015 34-48-00GPWS/EGPWS (asinstalled)
M FOT
34-016 34-48-00 GPWC M RIA
34-017 34-58-00Satellite navigation system(GPS) (if installed)
M FOT
34-018 34-58-00 GPSSU M RIA
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
29/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 29/48
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
30/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 30/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U35-00-00. OXYGEN
35-001 35-00-00Oxigen system controls &ind. In the cockpit
M LOC
35-002 35-10-00Cockpit and cabin oxygensystem components
M LOC
35-003 35-10-00Crew oxygen systempressure indication-check
M FOT
35-004 35-10-00Crew oxygen system FullFace Mask test
M FOT
35-005 35-10-02Pressure check crewoxygen cylinder
M TVC
35-006 35-11-00Crew oxygen storagecylinder
O RIA
35-007 35-21-00Open cabin emergcontainer door with manual
O FOT
35-008 35-21-00 Emergency oxygen cylinder M RIA
35-009 35-21-00
Emergency oxygen
container O RIA
35-010 35-31-00Indicator check of thetamper seasl on smokehood
O TVC
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
31/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 31/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U36-00-00. PNEUMATIC
36-001 36-00-00Pneumatic system controls& ind. In the cockpit
M LOC
36-002 36-00-00Pneumatic systemcomponents
M LOC
36-003 36-00-00Bleed air supply system -Defect rectification & T/S
M TSE
36-004 36-00-00Pressurization of pneumaticsystem
M FOT
36-005 36-11-00 BMC BITE test O FOT
36-006 36-11-00Deact/ractivation of bleedpress. Reg. Valve (PRV)
M MEL
36-007 36-11-00Deact/reactivation of HPbleed valve
O MEL
36-008 36-11-00CFDS bleed air supplucurrent status readout
M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
32/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 32/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U38-00-00. WATER:WASTE SYSTEMN.B : For SERVICING tasks please refer to ATA 12-00-00 Chapter
38-001 38-10-00Water /waste systemcomponents
M LOC
38-002 38-10-00Pressurization of potablewater tank
O SGH
38-003 38-10-00 Water filter (Galley) O RIA
38-004 38-12-00Functional test of the watersystem
O FOT
38-005 38-12-00functional test/reset of thewater heater
O FOT
38-006 38-13-00Water quantity indicatingsystem test
M FOT
38-007 38-31-00Vacuum toilet systemBITE/test
O FOT
38-008 38-31-00 VSC M RIA
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
33/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 33/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U49-00-00. APUN.B : For SERVICING tasks please refer to ATA 12-00-00 Chapter
49-001 49-00-00APU controls & indicationsin the cockpit
M LOC
49-002 49-00-00APU - Defect rectification &T/S
M TSE
49-003 49-00-00
APU start/shutdown
49.004.49-0-00 ECB selftest
M SGH
49-004 49-00-00 ECB self test M FOT
49-005 49-32-11Fuel filter diff. Press.Indicator check
M TVC
49-006 49-62-00APU emergency shut downtest
O FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
34/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 34/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U52-00-00. DOORS
52-001 52-00-00 Door indication on ECAM M LOC
52-002 52-10-00Opening / closing &precautions
M FOT
52-003 52-10-00Escape slide disarmingwhen opening from outside
M FOT
52-004 52-21-00Over wing emergency exitsdisarming (A319/A320)
M FOT
52.005 52-21-00Over wing emergency exits(A319/A320)
M RIA
52-006 52-30-00Cargo doors operation withelectric
M FOT
52-007 52-30-00Cargo doors operation withhand pump
O FOT
52-008 52-30-00Deact/reactivation of cargodoor actuators
O MEL
52-009 52-33-00
Bulk cargo door operation
(if installed) O SGH
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
35/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 35/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U53-00-00. FUSELAGE
53-001 53-10-00Opening / closing of theradome
O SGH
53-002 53-10-00Radome inspection fordamage
O TVC
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U54-00-00. NACELLE / PYLONS
54-001 54-50-00 Pylon pressure relief door M LOC
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U56-00-00. WINDOWS
56-001 56-10-00Cleaning of windshield andwindows O SGH
56-002 56-12-00Operation of cockpit slidingwindows
M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
36/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 36/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U71-00-00. POWER CFM 56
71-001 71-00-00 Power Plant components M LOC
71-002 71-00-00Power Plant defectrectification & T/S
M TSE
71-003 71-00-00Opening & closing ofengine cowlings
M SGH
71-004 71-00-00DRY/Wet motoring ofengine
M FOT
71-005 71-00-00 Engine Automatic Start M FOT
71-006 71-00-00 Engine Manual Start M FOT
71-007 71-00-00 Engine Sthutdown M FOT
71-008 71-00-00 Start Abort M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U72-00-00. ENGINE
72-001 72-00-00 FOD inspection O LOC
72-002 72-31-12
Fan blades : limits,
approved repairs,replacement O SGH
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
37/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 37/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U73-00-00. ENGINE FUEL AND CONTROL
73-001 73-00-00Engine fuel and controls /indications in the cockpit
M TVC
73-002 73-00-00Engine fuel and controlscomponents
M TVC
73-003 73-11-00Inspection of the fuelmanifold assy (CFM)
O TVC
73-004 73-11-00 Fuel filter (CFM) O RIA
73-005 73-25-00 EIU BITE test M FOT
73-006 73-29-00FADEC Test on Gmd (EngNON Motoring) (CFM56)
M FOT
73-007 73-29-00FADEC Test on Gmd (EngNON Motoring) (CFM56)
M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U74-00-00. IGNITION
74-001 74-00-00 Ignition indication on ECAM M LOC
74-002 74-00-00 Ignition system components M TVC
74-003 74-00-00Test of the Ignition Systemwith CFDS M FOT
74-004 74-11-00 Ignito plug O TVC
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
38/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 38/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U75-00-00. AIR
75-001 75-00-00 Air system components M TVC
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U76-00-00. ENGINES CONTROLS
76-001 76-00-00Engines systems controls inthe cockpit
M LOC
76-002 76-00-00Engine systems defectrectification & T/S (CFM)
O TSE
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U77-00-00. ENGINE INDICATING
77-001 77-00-00Engine indicating systems
/ECAM panelM TVC
77-002 77-00-00Engine indicating systemscomponents
M TVC
77-003 77-32-00Change configuration ofaccelerometer
M RIA
77-004 77-32-34Operational test of EVMUwith CFDS
M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
39/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 39/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U78-00-00. EXHAUST
78-001 78-00-00Thrust reverser/exhaustcomponents
M TVC
78-002 78-30-00Deact./reactivation of thrustreverser
M MEL
78-003 78-30-00Deactivation of thrustreverser for maintenance
M SGH
78-004 78-31-41Operation of thrust reverserusing CFDS M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U79-00-00. OIL
79-001 79-00-00 Oil system components M TVC
79-002 79-00-00 Oli filters O SGH
79-003 79-00-00Oil filter clogged indicatorsinspection
M RIA
79-004 79-31-00Oil quantity indication onECAM
M MEL
79-005 79-35-00Oil filter clogged warning onECAM
M MEL
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
40/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 40/48
U80-00-00. STARTING
80-001 80-00-00starting systemcomponents
M LOC
80-002 80-00-00Starting system - defectrectification & T/S
M TSE
80-003 80-11-00Manual operation of startervalve
M FOT TVC
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
41/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DERICHEBOURG Atis aronautique,Parc Algorithmes, Immeuble Thals 17, Avenue Didier Daurat 31700 Blagnac
Tl. 05 34 60 61 40 -05 34 60 61 50
DOC.FOR.07 ed4 41/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U71-00-00. POWER V2500
71-001 71-00-00 Power Plant components M LOC
71-002 71-00-00Power Plant defectrectification & T/S
M TSE
71-003 71-00-00Opening & closing ofengine cowlings
M SGH
71-004 71-00-00DRY/Wet motoring ofengine
M FOT
71-005 71-00-00 Engine Automatic Start M FOT
71-006 71-00-00 Engine Manual Start M FOT
71-007 71-00-00 Engine Sthutdown M FOT
71-008 71-00-00 Start Abort M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U72-00-00. ENGINE
72-001 72-00-00 FOD inspection O LOC
72-002 72-31-12
Fan blades : limits,
approved repairs,replacement O SGH
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
42/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 42/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U73-00-00. ENGINE FUEL AND CONTROL
73-001 73-00-00Engine fuel and controls /indications in the cockpit
M TVC
73-002 73-00-00Engine fuel and controlscomponents
M TVC
73-003 73-11-00Inspection of the fuelmanifold assy (V2500)
O TVC
73-004 73-11-00 Fuel filter (CFM) O RIA
73-005 73-25-00 EIU BITE test M FOT
73-006 73-29-00FADEC Test on Gmd (EngNON Motoring) (V2500)
M FOT
73-007 73-29-00FADEC Test on Gmd (EngNON Motoring) (V2500)
M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U74-00-00. IGNITION
74-001 74-00-00 Ignition indication on ECAM M LOC
74-002 74-00-00 Ignition system components M TVC
74-003 74-00-00Test of the Ignition Systemwith CFDS M FOT
74-004 74-11-00 Ignitionplug O TVC
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
43/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 43/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U75-00-00. AIR
75-001 75-00-00 Air system components M TVC
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U76-00-00. ENGINES CONTROLS
76-001 76-00-00Engines systems controls inthe cockpit
M LOC
76-002 76-00-00 Engine systems defectrectification & T/S (V2500)
O TSE
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U77-00-00. ENGINE INDICATING
77-001 77-00-00Engine indicating systems/ECAM panel
M TVC
77-002 77-00-00Engine indicating systemscomponents
M TVC
77-003 77-32-00Change configuration ofaccelerometer
M RIA
77-004 77-32-34Operational test of EVMUwith CFDS
M FOT
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
44/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 44/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U78-00-00. EXHAUST
78-001 78-00-00Thrust reverser/exhaustcomponents
M TVC
78-002 78-30-00Deact./reactivation of thrustreverser
M MEL
78-003 78-30-00Deactivation of thrustreverser for maintenance
M SGH
78-004 78-31-41Operation of thrust reverserusing CFDS
M FOT
REMARKS :
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U79-00-00. OIL
79-001 79-00-00 Oil system components M TVC
79-002 79-00-00 Oli filters O SGH
79-003 79-00-00Oil filter clogged indicatorsinspection
M RIA
79-004 79-31-00Oil quantity indication onECAM M MEL
79-005 79-35-00Oil filter clogged warning onECAM
M MEL
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
45/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 45/48
Item Ref. ATA Ref. Subject Class B1/B2TaskCode
DateTrainee'ssignature
Instructor'ssignature
U80-00-00. STARTING
80-001 80-00-00starting systemcomponents
M LOC
80-002 80-00-00Starting system - defectrectification & T/S
M TSE
80-003 80-11-00Manual operation of startervalve
M FOT TVC
REMARKS :
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
46/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 46/48
SUPPLEMENT DEXPERIENCE PRATIQUE
ATA reference Work experience DateTraineessignature
Assessorssignature
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
47/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
DOC.FOR.07 ed4 47/48
SUPPLEMENT DEXPERIENCE PRATIQUE
ATA reference Work experience DateTraineessignature
Assessorssignature
-
8/11/2019 Doc for 07 _ojt 320 b1 b2_ Ed4
48/48
A318/319/320/321 CFM56A319/320/321 IAE V2500
MAINTENANCE PRACTICE TRAINING MANUALB1 ou B1/B2
SUPPLEMENT DEXPERIENCE PRATIQUE
ATA reference Work experience DateTraineessignature
Assessorssignature