Ceplattyn KG 10 LC

Safety Data Sheet according to Regulation (EC) No. 1907/2006 (REACH)Printed 11.10.2011Revision 01.02.2008 (GB) Version 1.4CEPLATTYN KG 10 LCA01-02467

FUCHS LUBRITECH GMBH, 67661 Kaiserslautern/ Germany Page 1/5

! 1. Identification of the substance/mixture and of the company/undertaking

Product identifier

Name of product CEPLATTYN KG 10 LC

Manufacturer/distributor FUCHS LUBRITECH GMBHWerner-Heisenberg-Strae 1, D-67661 Kaiserslautern/ GermanyPhone +49 (0) 6301 3206 - 0, Fax +49 (0) 6301 3206 - 940E-Mail [email protected] www.fuchs-lubritech.com

Advice Product Safety ManagementPhone +49 (0) 6301 3206 - 0Fax +49 (0) 6301 3206 - 940

Emergency advice +49 (0)171 / 4632154

Recommended intended purpose(s)Lubricating grease

2. Hazards identification

Labelling according to 67/548/EEC or 1999/45/EC! Remarks for labelling

The product does not require a hazard warning label in accordance with EC directives/German regulations on dangerous substances.Although this product does not require a hazard warning label, we recommend that the safety advice should be observed.Classification happened on the basis of calculation methods of preparation directive (1999/45/EC).Information pertaining to special dangers for human and environmentnone at appropriate handling and storage

3. Composition/information on ingredientsDescriptionAluminium complex grease based on mineral and synthetic oils with graphite and additive package

Additional adviceNo hazardous material resp. below level of consideration according to RL 67/548 EWG

! 4. First aid measuresGeneral informationRemove contaminated soaked clothing immediately.

! In case of inhalationNot applicable: No harmful steam concentration due to low volatility

! In case of skin contactIn case of contact with skin wash off with soap and water.Don't use organic solventsConsult a doctor if skin irritation persists.

In case of eye contactIn case of contact with eyes rinse with plenty of water carefully. In the event of persistent symptoms seek medical treatment.

In case of ingestionDo not induce vomiting.Call for a doctor immediately.

Physician's information / possible symptomsNo symptoms known so far.

Physician's information / possible dangersAspiration hazard when vomiting after swallow up

Treatment (Advice to doctor)Treat symptoms.



! 5. Firefighting measuresSuitable extinguishing mediaFoamDry fire-extinguishing substanceCarbon dioxidesand

Extinguishing media which must not be used for safety reasonswater

! Special hazards arising from the substance or mixtureFire gas of organic material has to be classified as harmful to the respiratory system.

! Special protective equipment for fire-fightersIn case of rescue and maintenance activities in storage containers use environment-independent breathing apparatus because of risk of suffocation by edging out of air oxygenWear suitable personal protective equipment for fire extinguishing measures.

! Additional informationApply foam in large quantities because some of it is destroyed by the product.Fire residues and contaminated firefighting water must be disposed of in accordance with the local regulations.

! 6. Accidental release measures! Personal precautions

Use personal protective clothing.Avoid contact with skin and eyesHigh risk of slipping due to leakage/spillage of product.

Environmental precautionsCollect contaminated water / firefighting water separately.Do not discharge into the drains/surface waters/groundwater.Do not discharge into the subsoil/soil.

Methods for cleaning upTake up residues with absorbent material (e.g. sand, sawdust, general-purpose binder, kieselguhr).After taking up the material dispose according to regulation.Take up mechanically and send for disposal.

Additional InformationInformations for disposal see chapter 13.

! 7. Handling and storageAdvice on safe handlingNo special measures necessary if used correctly.

! Advice on protection against fire and explosionThe product is combustible.Pay attention to general rules of internal fire prevention.

Requirements for storage rooms and vesselsPrevent penetration into the ground.

Advice on storage compatibilityDo not store together with food.

! Further information on storage conditionsKeep container tightly closed, store at cool and aired place, open and handle carefully.Protect from heat and direct solar radiation.Storage temperature may not exceed 40C (=104F).Storage group 10/11

Fire class B

Information on storage stabilitysee Product information

Recommendation(s) for intended usesee Product information



! 8. Exposure controls/personal protectionAdditional advice on system designDo not inhale aerosols caused by spraying application

Additional adviceThis product as such does not contain any relevant ingredients with to be observed limited valuesAs basis for this information served the valid references.

Respiratory protectionnot necessary in general

! Hand protectionWear gloves of PVC at prolonged or intensive skin contact

Eye protectiontightly fitting goggles, in case of splashing

Skin protectionUsual working clothes for chemical industries

General protective measuresAvoid contact with eyes and skinDo not inhale gases/vapours/aerosols.

Hygiene measuresCloths contaminated with product should not be kept in trouser pockets.Follow general rules of industrial hygiene for safe handling of chemical productsAt work do not eat, drink and smoke.Remove soaked clothing immediately.Wash hands before breaks and after work.Use barrier skin cream.

! 9. Physical and chemical propertiesFormpasty

Colourblack

Odourlike mineral oil

Important health, safety and environmental informationValue Temperature at Method Remark

pH value in delivery state not applicable

drop point > 200 C DIN/ISO 2176

Flash point not applicable

Ignition temperature > 300 C

Autoignition unknown

Density 0,88 - 0,93 g/cm3 20 C

Bulk density not applicable

Solubility in water more or less insoluble

Partition coefficient (log pOW)

not determined

Oxidizing propertiesno

Explosive propertiesno

! 10. Stability and reactivityConditions to avoidHeating, unshielded flame, ignition source, electrostatic charge

Materials to avoidReactions with strong oxidising agents.

Hazardous decomposition productsthermal decomposition:Nitrous oxides (NOx)



Sulphurous oxides (SOx)Thermal decomposition

Remark No decomposition if used as directed.

! Additional informationAll grease components show a very low level of reactivity at room temperature

11. Toxicological information

Acute toxicity/Irritability/Sensitization

Value/Validation Species Method Remark

LD50 acute oral > 2000 mg/kg rat Information concerns to main component.

Irritability skin frequent and/or persistent contact may cause skin irritation

Irritability eye no irritating effects known

Skin sensitization No sensitizing effect known

Experiences made from practiceFrequent persistent contact with the skin may cause skin irritation.no harmful effects at appropriate handling and determined usage

Additional informationNo toxical dates available.The declarations of toxicology refer to main component.

! 12. Ecological information

Data on elimination (persistence and degradability)Elimination rate Method of analysis Method Validation

Biological degradability

not determined

Mobility and bioaccumulative potentialThe product has not been tested. Because of the product's consistency and low solubility in water bioavailability is not likely.preparation is water insoluble and does not formate emulsion

Ecotoxicological effectsValue Species Method Validation

Fish not determined

! Behaviour in sewage plantProduct gets duly not into waste water before it is not treated according to the local regulations.The viscous consistency of the product can cause trouble in transport lines and purification plants.

General regulationEcological dates are not available.Do not allow uncontrolled leakage of product into the environment.Product is not allowed to be discharged into aquatic environment, drains or sewage treatment plants.

13. Disposal considerationsWaste code No. Name of waste12 01 12* spent waxes and fats

Wastes marked with an asterisk are considered to be hazardous waste pursuant to Directive 91/689/EEC on hazardous waste.

Recommendations for the productStandardized regulations for residual waste disposal within the EG member states do not exist.German statutes are prescribed in the law of "recycling and waste" (KrW/AbfG)In accordance with regulations for special waste, must be taken to a special waste disposal.The waste disposal has to be proved.used absorbents of chapter 6: EAK 07 06 10

Recommendations for packagingTotally emptied packaging may be taken for recycling.Dispose one-trip container according to local authority prescriptions



EAK 15 01 99 D1: packing material with harmful contamination

Recommended cleansing agentwhite spirit

General informationUltimately responsible for correct classification is the waste producer, as the EWC names different codes for different origins of same wasteTherefore the a.m. recommendation has to be checked in case of need.

14. Transport informationLand and inland navigation transport ADR/RID

No dangerous goods as defined by these transport regulationsMarine transport IMDG

No hazardous goods as defined by prescriptionsAir transport ICAO/IATA-DGR

No hazardous goods as defined by prescriptions

! 15. Regulatory information

VOC standardVOC content 0 %

National regulationsWater hazard class 2 Mixture-WGK according to VwVwS (GER)

preliminary

! 16. Other informationTraining adviceUse information in this MSDS

Recommendend uses and restrictionsusage only according to instructions for use and observance of warning notesNational and local regulations concerning chemicals shall be observed.

! Further informationThe information given in this MSDS is based on the present state of knowledge and is intended to describe our products from the point of view of safety requirements only.Substantial changes to the former version are marked by "!" on the left margin of the paper.All the raw materials in this product are listed in TSCA.Refer to product information paper.

Sources of key data usedMaterial Safety Data Sheets of raw materials

Ceplattyn KG 10 LC

Documents

Transcript of Ceplattyn KG 10 LC