cdn.autodoc.de · Tutorial/Step by step guide for repair and replacement: How to replace a rear...
5
How to replace a rear brake caliper on Volkswagen Golf IV www.autodoc.co.uk 1–5 Carry out replacement in the following order: 1 Loosen the wheel mounting bolts. 2 Raise the rear of the car and secure on supports. 3 Remove the rear wheels. 4.1 Unscrew the brake hose from the brake caliper. 4.2 AutoDoc recommends: Immediately plug the brake line open end to prevent fluid leakage and ingress of dirt into the hydraulic system.
-
Upload
hoangtuyen -
Category
Documents
-
view
217 -
download
0
Transcript of cdn.autodoc.de · Tutorial/Step by step guide for repair and replacement: How to replace a rear...
How to replace a rear brakecaliper on Volkswagen Golf IV
www.autodoc.co.uk 1–5
Carry out replacement in the following order:
1
Loosen the wheel mounting bolts.
2
Raise the rear of the car and secure on supports.
3
Remove the rear wheels.
4.1
Unscrew the brake hose from the brake caliper.
4.2
AutoDoc recommends:
Immediately plug the brake line open end to prevent fluidleakage and ingress of dirt into the hydraulic system.
How to replace a rear brake caliperon Volkswagen Golf IV
www.autodoc.co.uk 2–5
5.1
Disconnect the parking brake cable.
5.2
5.3 6.1
Unscrew the brake caliper fastening
6.2 7
Remove the brake caliper.
How to replace a rear brake caliperon Volkswagen Golf IV
www.autodoc.co.uk 3–5
8.1
Install the brake caliper and fix it.
8.2
8.3 9
Install and fix the brake hose into a new caliper.
10.1
Secure the parking brake cable
10.2
How to replace a rear brake caliperon Volkswagen Golf IV
www.autodoc.co.uk 4–5
11
Bleed the brake caliper system.
12
Install the wheel.
13
Lower the car and working in a cross order,tighten the wheel bolts.
AutoDoc recommends:
Make sure to set the protection cap on the bleeder valve.
AutoDoc recommends:
Check the brake fluid level in the expansion tank and refill ifnecessary.
At the start from standstill after replacing the brake calipers onVolkswagen Golf IV press the brake pedal as far as it can goa few times to adjust its height.
We hope that this informationhave been useful for you!
Video tutorialsWatch our detailed video guides about your Volkswagen GolfIV repair on our youtube channel. Watch video guides.
AutoDoc onlineHighest quality brake calipers for your car Volkswagen GolfIV are available on AutoDoc. Go to the website.
How to replace a rear brake caliperon Volkswagen Golf IV
www.autodoc.co.uk 5–5
AUTODOC — TOP QUALITY AND AFFORDABLE CAR PARTS ONLINE
QUALITY AUTO PARTS VOLKSWAGEN
BRAKE CALIPERS VOLKSWAGEN GOLF IV
BRAKE CALIPERS FOR VOLKSWAGEN BRAKE CALIPERS FOR VOLKSWAGEN GOLF IV
AUTODOC IN SOCIAL MEDIA
Disclaimer:The document contains only general recommendations that may be useful for you when you perform repair or replacement works. AutoDocshall not be liable for any loss, injury, damage of property, acquired in the repair or replacement process due to incorrect usage ormisinterpretation of the provided information.
AutoDoc shall not be liable for any possible mistakes and uncertainties in this guide. The information provided is for informative purposes onlyand cannot replace advice from specialists.
AutoDoc shall not be liable for incorrect or hazardous usage of equipment, tools and car parts. AutoDoc strongly recommends to be carefuland observe the safety rules when performing repair or replacement works. Remember: usage of low quality auto parts does not guaranteeyou the appropriate level of road safety.
