AVIC-F900BT (CRT4166) (sm)
-
Upload
doru-razvan -
Category
Documents
-
view
252 -
download
17
Transcript of AVIC-F900BT (CRT4166) (sm)
PIONEER CORPORATION 4-1, Meguro 1-chomePIONEER ELECTRONICS (USA) INC. P.O. Box 1760, LoPIONEER EUROPE NV Haven 1087, Keetberglaan 1, 912PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253
PIONEER CORPORATION 2008
AVIC-F900BT/XS/EW5
, Meguro-ku, Tokyo 153-8654, Japanng Beach, CA 90801-1760, U.S.A.0 Melsele, Belgium Alexandra Road, #04-01, Singapore 159936
ORDER NO.
CRT4166
NAVIGATION AV SYSTEM
AVIC-F900BT/XS/EW5
AVIC-F900BT/XS/RE
This service manual should be used together with the following manual(s):
Manufactured under licence from Dolby Laboratories. “Dolby” and the double-D symbol are trademarks of Dolby Laboratories.
“DTS” and “DTS Digital Out” are registered trademarks of DTS, Inc.
Model No. Order No. Mech.Module Remarks
CX-3212 CRT3896 MS5 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
For details, refer to "Important Check Points for Good Servicing".
K-ZZZ.-001 MAY 2008 Printed in Japan
C
D
F
A
B
E
1 2 3 4
SAFETY INFORMATION
1. Safety Precautions for those who Service this Unit.• Follow the adjustment steps in the service manual when servicing this unit. When check -
ing or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results.
Caution: 1. During repair or tests, minimum distance of 13cm from the focus lens must be kept.2. During repair or tests, do not view laser beam for 10 seconds or longer.
Where in a manufacturer’s service documentation, for example in circuit diagrams or listsof components, a symbol is used to indicate that a specific component shall be replaced onlyby the component specified in that documentation for safety reasons, the following symbol shallbe used:
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repaircomplex products such as those covered by this manual.Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do soand refer the repair to a qualified service technician.
AVIC-F900BT/XS/EW521 2 3 4
C
D
F
A
B
E
5 6 7 8
Additional Laser Caution
Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD respectively. When Q1103 or Q1104 is shorted between their terminals,the laser diodes for DVD or CD will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.
WARNING!The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1.A specially instructed person should do servicing operation of the apparatus.
Laser diode characteristicsWave length:
DVD:660 nm to 670 nmCD:780 nm to 800 nm
DVD : 1.27 mW(Emitting period :9 sec.)CD : 6.26 mW(Emitting period : unlimited)
Maximum output:
AVIC-F900BT/XS/EW5 35 6 7 8
C
D
F
A
B
E
1 2 3 4
[Important Check Points for Good Servicing]In this manual, procedures that must be performed during repairs are marked with the below symbol.Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise.
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.In addition, be sure that there are no pinched wires, etc.
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary.
a Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
AVIC-F900BT/XS/EW541 2 3 4
C
D
F
A
B
E
5 6 7 8
CONTENTS SAFETY INFORMATION .....................................................................................................................................21. SERVICE PRECAUTIONS................................................................................................................................6
1.1 SERVICE PRECAUTIONS.........................................................................................................................61.2 NOTES ON SOLDERING...........................................................................................................................7
2. SPECIFICATIONS.............................................................................................................................................82.1 SPECIFICATIONS ......................................................................................................................................82.2 DISC/CONTENT FORMAT.........................................................................................................................92.3 PANEL FACILITIES ..................................................................................................................................102.4 CONNECTION DIAGRAM........................................................................................................................13
3. BASIC ITEMS FOR SERVICE ........................................................................................................................153.1 CHECK POINTS AFTER SERVICING .....................................................................................................153.2 PCB LOCATIONS.....................................................................................................................................163.3 JIGS LIST .................................................................................................................................................173.4 CLEANING ...............................................................................................................................................18
4. BLOCK DIAGRAM ..........................................................................................................................................204.1 OVERALL CONNECTION DIAGRAM ......................................................................................................204.2 BLOCK DIAGRAM....................................................................................................................................224.3 POWER SUPPLY SYSTEM FIGURE.......................................................................................................32
5. DIAGNOSIS ....................................................................................................................................................365.1 OPERATIONAL FLOWCHART.................................................................................................................365.2 INSPECTION METHOD OF PICKUP UNIT .............................................................................................385.3 DIAGNOSIS FLOWCHART......................................................................................................................415.4 ERROR CODE LIST.................................................................................................................................635.5 CONNECTOR FUNCTION DESCRIPTION .............................................................................................645.6 TROUBLESHOOTING..............................................................................................................................65
6. SERVICE MODE.............................................................................................................................................696.1 TEST MODE.............................................................................................................................................696.2 DVD TEST MODE ....................................................................................................................................826.3 uBOOT MENU..........................................................................................................................................866.4 USING THE TEST DISC ..........................................................................................................................87
7. DISASSEMBLY ...............................................................................................................................................938. EACH SETTING AND ADJUSTMENT..........................................................................................................102
8.1 DVD ADJUSTMENT...............................................................................................................................1028.2 AV UNIT ADJUSTMENT.........................................................................................................................1088.3 FLICKER ADJUSTMENT ....................................................................................................................... 110
9. EXPLODED VIEWS AND PARTS LIST ........................................................................................................ 1129.1 PACKING................................................................................................................................................ 1129.2 EXTERIOR(1) ......................................................................................................................................... 1149.3 EXTERIOR(2) ......................................................................................................................................... 1169.4 EXTERIOR(3) ......................................................................................................................................... 1189.5 DVD MECHANISM MODULE.................................................................................................................120
10. SCHEMATIC DIAGRAM..............................................................................................................................12210.1 AV UNIT(PS/IF SECTION)(GUIDE PAGE)...........................................................................................12210.2 AV UNIT(A/V SECTION)(GUIDE PAGE) ..............................................................................................12810.3 AV UNIT(TUNER SECTION) ................................................................................................................13410.4 AV UNIT(SYSTEM uCOM SECTION)(GUIDE PAGE)..........................................................................13610.5 AV UNIT(RGB LED DRIVER SECTION) ..............................................................................................14210.6 AV UNIT(IF SECTION)(GUIDE PAGE).................................................................................................14410.7 KEYBOARD UNIT ................................................................................................................................15010.8 DVD CORE UNIT(1/2)(GUIDE PAGE) .................................................................................................15210.9 DVD CORE UNIT(2/2) ..........................................................................................................................15810.10 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ...........................................................................16010.11 WAVEFORMS.....................................................................................................................................162
11. PCB CONNECTION DIAGRAM ..................................................................................................................16411.1 AV UNIT ................................................................................................................................................16411.2 KEYBOARD UNIT.................................................................................................................................16811.3 DVD CORE UNIT..................................................................................................................................17011.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B) .............................................................................174
12. ELECTRICAL PARTS LIST.........................................................................................................................175
AVIC-F900BT/XS/EW5 55 6 7 8
C
D
F
A
B
E
1 2 3 4
1. SERVICE PRECAUTIONS1.1 SERVICE PRECAUTIONS
1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction.3. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit.4. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY" .5. After replacing the pickup unit, be sure to skew adjustment. 6. During disassembly, be sure to turn the power off since an internal IC might be destroyed when a connector is plugged or unplugged.
EJECT LOCK MODE for DVD mechanismIn order to change the EJECT LOCK/UNLOCK status of the mechanism, please perform following procedure.
< Procedure >Top Menu -> AV Source -> Source OFF
Short push area "A" -> Short push area "B" -> Long push area "C" on above screen. (In order to change the status, follow the same operation.)
The current status can be confirmed by "OFF" character color.
A BC
Eject Lock: ONEject Lock: OFF
is a trademark of DVD Format/Logo Licensing Corporation.
The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc.and any use of such marks by Pioneer Corporation is under license. Other trademarks and trade names are those of their respective owners.
AVIC-F900BT/XS/EW561 2 3 4
C
D
F
A
B
E
5 6 7 8
1.2 NOTES ON SOLDERING
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.
AVIC-F900BT/XS/EW5 75 6 7 8
C
D
F
A
B
E
1 2 3 4
2. SPECIFICATIONS2.1 SPECIFICATIONS
AVIC-F900BT/XS/EW581 2 3 4
C
D
F
A
B
E
5 6 7 8
2.2 DISC/CONTENT FORMAT
AVIC-F900BT/XS/EW5 95 6 7 8
C
D
F
A
B
E
1 2 3 4
2.3 PANEL FACILITIES
.
.
.
.
AVIC-F900BT/XS/EW5101 2 3 4
C
D
F
A
B
E
5 6 7 8
AVIC-F900BT/XS/EW5 115 6 7 8
C
D
F
A
B
E
1 2 3 4
AVIC-F900BT/XS/EW5121 2 3 4
C
D
F
A
B
E
5 6 7 8
2.4 CONNECTION DIAGRAM
AVIC-F900BT/XS/EW5 135 6 7 8
C
D
F
A
B
E
1 2 3 4
AVIC-F900BT/XS/EW5141 2 3 4
C
D
F
A
B
E
5 6 7 8
3. BASIC ITEMS FOR SERVICE3.1 CHECK POINTS AFTER SERVICING
To keep the product quality after servicing, please confirm following check points.
demrifnocebotmetIserudecorP.oN1 Confirm whether the customer complain has
been solved.If the customer complain occurs with thespecific media, use it for the operation check.
The customer complain must not bereappeared.Display, video, audio and operations must benormal.
2 DVD Measure playback error rates at theinnermost and outermost tracks by using thetest mode with the following disc.DVD test disc (GGV1025)
Deterioration of mecha-drive can bechecked.
3 DVD Play back a DVD.(Menu operation; Title/chapter search)
Display, video, audio and operations must benormal.
4 CD Play back a CD.(Track search)
Display, audio and operations must benormal.
5 FM/AM tuner Check FM/AM tuner action.(Seek, Preset)Switch band to check both FM and AM.
Display, audio and operations must benormal.
6 GPS positioning Connect GPS antenna to the product, andcheck whether the current location is correct.
Current location must be correct.Display and operations must be normal.
7 Map displayTouch-paneloperationRemote-controloperation
Check functions of map scale change andmap scroll.
Display and operations must be normal.
8 Delete data added during the operatingcheck.Check whether no media (CD etc.) is insidethe product.
Make sure to delete data added during theoperating check.The media used for the operating check mustbe ejected.
retfaecnaraeppastinotridrosehctarcsoNkcehcecnaraeppA9receiving it for service.
See the table below for the items to be checked regarding video and audio:
Item to be checked regarding video Item to be checked regarding audionoitrotsiDesion-kcolB
esioNesionlatnoziroHwolootemuloVesiontoD
Disturbed image (video jumpiness) Volume too highgnitautculfemuloVkradooTdetpurretnidnuoSthgirbooT
Mottled color
The error rate must be less than the threshold value.(Refer to the chapter of DIAGNOSIS for the threshold value.)
AVIC-F900BT/XS/EW5 155 6 7 8
C
D
F
A
B
E
1 2 3 4
3.2 PCB LOCATIONS
DVD Core Unit
C
Compound Unit(A)D
Compound Unit(B)E
B
AV UnitA
Keyboard Unit
Unit Number : CWN3169(EW5)Unit Number : CWN3179(RE)Unit Name : AV Unit Unit Number : Unit Name : Keyboard Unit Unit Number : YWX5005 Unit Name : DVD Core Unit Unit Number : CWX3595Unit Name : Compound Unit(A)Unit Number : CWX3559Unit Name : Compound Unit(B)
AVIC-F900BT/XS/EW5161 2 3 4
C
D
F
A
B
E
5 6 7 8
3.3 JIGS LIST
- Grease List NameGreaseGreaseGreaseGreaseLocking agents
Jig No.GEM1024GEM1043GEM1045GEM10501401M
RemarksDVD Mechanism ModuleDVD Mechanism ModuleDVD Mechanism ModuleDVD Mechanism ModuleDVD Mechanism Module (1401M:produced by THREE BOND)
15P FFC GGD1123 Navi Unit <---> SD Unit74P FFC GGD1560 Navi Unit <---> Panel Unit50P FFC GGD1250 Navi Unit <---> AV Unit20P Extension Cable GGD1327 Navi Unit <---> AV UnitTORX screwdriver GGK1068 T8 (For top cover)40P FFC GGD1284 AV Unit <---> DVD Mechanism ModuleDVD-Video GGV1025 Skew adjustmentCD-DA TCD-782 Skew adjustmentTORX driver(T2) GGK1095 Skew adjustmentBond GEM1033 Skew adjustmentService Data Disc GGV1322 for Test Mode, Test Disc
GGD1327
Navi Unit
GGD1250
GGD1560
DVD Mechanism Module
GGD1284
Panel Unit
AV Unit
- Jigs List
AVIC-F900BT/XS/EW5 175 6 7 8
C
D
F
A
B
E
1 2 3 4
3.4 CLEANING
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:
Portions to be cleaned Cleaning toolsDVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008
Portions to be cleaned Cleaning toolsFans Cleaning paper : GED-008
AVIC-F900BT/XS/EW5181 2 3 4
C
D
F
A
B
E
5 6 7 8
AVIC-F900BT/XS/EW5 195 6 7 8
C
D
F
A
B
E
MIC
CP
42
FM/AM
ANT1
CN1
J2
/AM ANT
MJ1
1 2 3 4
4. BLOCK DIAGRAM4.1 OVERALL CONNECTION DIAGRAM
}
}
}
}60
LCJ31
REAR CAMERA INPUT
REAR MONITOR OUTPUT
MUTE
REAR OUTPUT
FRONT OUTPUT
1
24
AUDIO INPUT
VIDEO INPUT1
SUBWOOFER OUTPUT
SYSTEM REMOTE CONTROL
CORD ASSY
CN8011
1
74
LCJ1
1
24
CN803
OTJ211
OTJ1
1 10
1LCJ6
LCJ1
LCD MODULE
PANEL UNIT
TOUCH PANEL
CWX3611
CWX3651
CWX1136
1
4
LCD MODULE ASSY
VIDEO INPUT2
BT
CN
802
FM
CN
1016
(AV MINIJACK IN)
T
22
22
4
74
CXC8914
B KEYBOARD UNIT
AVIC-F900BT/XS/EW5201 2 3 4
C
D
F
A
B
E
1
74
1
24
CN
1016
5 6 7 8
FAN
GND
10A
POWER SUPPLY TERMINALS
ACC
PKB
ILM
RR-
FL-
RR+
FL+
RL-
FR-
FR+
RL+
CN1005
150
OTJ1
MIC ASSY
GPS ANTENNA ASSY
CXC8574
CPM1064
1
16
140
CN1901
CN
1852 2
1
AANT
REVPULSE
5
1
CORD ASSY
1
SPJ221
LCJ1
OTJ4
SPJ11
OT
J5
1
MICBLACK 2.5
1
142
FM/AM TUNER UNIT
GPJ131
CN100120 11
CN100050
140
CN702
1
ANT1401
CN1441
DVD MECHANISM MODULE
SD UNIT
CWX3652
CXM1320
USB
1
OTJ33
OTJ6OTJ11BTJ2
FM/AM ANTENNA IN
CDE8561
(DIGITAL OUT) GRAY 3.5
BUP
OTJ2
TMJ1
1
16
1
CN1021IP BUS
11
20
NAVI UNIT
6 15
15
3
A AV UNIT
1/6A2/6A3/6A4/6A5/6A6/6A
C D E
TUNER SECTION
SYSTEM uCOM SECTION
RGB LED DRIVER SECTION
IF SECTION
A/V SECTION
PS/IF SECTION
AVIC-F900BT/XS/EW5 215 6 7 8
C
D
F
A
B
E
D(NAV
posite
posite
GND
U
G
1 2 3 4
4.2 BLOCK DIAGRAM
to Titan (NAVIBD)
to CPL
GPS Antenna CONN
USB 2.0 Slot*1
RS232CONN*1
Rear Camera CONN
Speaker CONN Speaker Out
Composite In
Composite In (1)
USB 2.0
GPS AntennaGPSAntenna
RadioAntenna
Com
Com
R-sound InL-sound In
Phone Mute Input
Wire Remote Input
Acc/Bup/ILM
Speed Pulse Input
Parking Signal Input
Reverse Signal Input
Reset
Reset Signal
UART(2)
TMC
Composite In (2)
GUIDANCE (Audio Signal)
Source Audio Signal
CPU WatchdogAn Information of Power offAn Answer of Power off
Reverse Signal
VCC 5 V
Speed Pulse
Control Signal
Video Out CONN
Radio Antenna CONN
Phone Mute CONN
Parking Signal CONN
Wire Remote Input
Reverse Signal Input
Power Supply CONN
Speed Pulse CONN
RF Splitter
I2C
AMP E-vol
SD/MMC Slot SDIO(1)
AVSelector ICAudio Unit
FM/AMTuner
FMMPX DARC
Only AVN-Japan
ArrangeWaveform
ArrangeWaveform
VotageDetecting IC
VotageDetecting ICArrange
Waveform
ArrangeWaveform
LPF
DC/DC Switch
DVD or CD (S10.5 comp2)
Systemu-COM
Sence
Digital Out CONN
3RCA CONN
IP-BUS CONN
SD Board
Audio Unit
RearPannel
AVIC-F900BT/XS/EW5221 2 3 4
C
D
F
A
B
E
t
t Signal
T(2)
posite In
Signal)
l
Watchdwer offoff
rse Sign
5 V
d Pulse
comp2)
5 6 7 8
to CPLD(NAVI BD)
Composite In (1)
Composite In (2)
GND
(2)
og
al
Transmitter
Switch
CKS4823-A
5 V In Jack
Digital Out CONN
USB 2.0
H & D GyroADC
I2C(1)
ROM 16-bit
SDIO(1)
133 MHz
USB 2.0
AC97
UART(0)
USP(0)
USB 2.0
GPS Antenna
RS232
I2C(0)UART(2)
VCC 5 V
Reset Signal
ITU-R BT601/6568-bit
Dead Reckoning
G Sensor
GPS Front end
Bluetooth Module
TMC/FM6 Module
BT Antenna
TMC
Mono Out
Speed Pulse
16-bitColor-TFT
Touch Panel4-wire
Headphone Out
LED Driver
LVDS RX
5.8” TFT LCDwith
Touch Panel
LVDS TX
Xilinx CPLDTimingControl
ADC
VolumeController
AuX-in
BT Antenna
Buttons1. Eject2. Menu3. Map4. Mute
DDR1*2(16Meg*32)
SLC Flash 256 MB
Video Decoder
Front PanelKey PadBoard
600 MHz
LCD Board
Navigation Unit
CPU
Audio Codec
UP to 400 MHz DDR or 166 MHz SDRAM Enhanced 32 channel GPS base band 24-bit Color-TFT LCD panel interface 8/16-bit HAND flash interface CMOS/CCD sensor interface USB OTG 2.0 high-speed interface ATA-4 interface (UDMA33) 2 slots SD/SDIO/MMC/MMC4.0/CE-ATA 2 CANBus ports AC97 & I2C Audio CODEC interface3 Universal Serial Ports (USP) & 3 UARTs 2 SPI interface 2 I2C interface PWM interface
AVIC-F900BT/XS/EW5 235 6 7 8
C
D
F
A
B
E
ICBA45
E ISOLA
IC10NJM
3DV
Q3042
AV8
/XS/EW
/XS/R
5
8FVEVDD
SRCMUT
1 2 3 4
AV UNIT(1/2)A
FL
ANT1401
NAVI UNITTMJ1
FM/AMANTENNA
Q1421
AV8
FLQ1401
T1403T1402
T1401
CN1441 Q1441
FM/AM TUNER UNIT
617 8 93 54
FM
_AN
T
1A
M_A
NT
A
B
VC
CA
V8
13V
DD
5V
DD
_3.3
TU
3
SL
CE
2C
E1
CK
10 14
DI
DO
TU
NS
L
23Lc
hF
ML
TU
NC
E2
TU
NC
E1
TU
NC
LKT
UN
DO
TU
ND
I
11 18
LDE
TR
DS
_CK
19 20
RD
S_D
AT
AR
DS
_LO
CK
21R
DS
_HS
LK
HR
CK
HLD
ET
HR
DT
HR
LKH
RH
SLK
Q752
Q753
Q754
Q751
HRCK
HLDET
HRDT
HRLK
HRHSLK
VD8
VD8
MVDD5
SYSTEM-uCOMIC610(1/2)PEG446A
IRQPWRXRES
HSTCMDIRQPW3XRES3
SYSTOMS53IRQPW5XRES5
SYSTOMS55
6 4,5
5V→3VIC607
TC74VHC08FTS1
IR REMOTE
FM DISTRIBUTION
VICS/TMC AMP
3V→5VIC612
TC74VHCT32AFT
3 1,2
MS5TOSYS5
11 12,13
RO
M_V
DD
24
25
20
12
VDD8(DRY)
3VDD5
AMUTEANALOUT
SLVSTS MS5TOSYS3
212223
STANBY MS5_STANDBY3
32
40
CVBS DVDV
WAKEUP
29DVDL
VDD8(REG)134
ILLSNS
72TEIN
78SELSDA
79SELSCL
FML
3GUID
GUIDE
ILMSNS
CN702
DVDL
AMUTE
BCTO 2/2
IPL
MS5_STANDBY59,10
56
CNVSS 4
8
I1714
SREMOTE 66
TUNSL141
TUNCE29
TUNCE18
TUNCLK7
TUNDO5
TUNDI6
LDET26
RCK25
RDT17
RDSLK14
RDS57K18
XOUT
XIN
X60120.000MHz
20
22
XRES64
IRQPW63
HSTCMD38
SLVSTS40
CNVSS16
MS5_STANDBY61
WAKEUP62
TEMPIN137
REMCON3
3
TEMP SENSORTH601
B
103ASENS
73FANCONT
CN
1901
C
77NOSELR
95VST
96VDT
97VCK
GUIDEMUTENOSELR
SWVDD5
U6951
RESET 19
MUTE 85
A AVIC-F900BT
B AVIC-F900BT
C TO 2/2
AMUTEQ3041
AV8
1
3
IC60BD5335
IC603TC7SH04FUS1
IC604TC7S32FU
VOUT
CT
2
4
412
Q2860BUP
AVIC-F900BT/XS/EW5241 2 3 4
C
D
F
A
B
E
GU
B
VIC-F90
VIC-F90
O 2/2
AMUTE41
1
IBD5
S1
C6047S32FU
VOU
4
Q2860
5 6 7 8
32
30
VOUT2
LOUT2
39DVDVV2-1
19L4-1
15L3-1
23L5-1
AV SELECTORIC4171
AN15887A
RVOUT
36SCL
35SDA
34VOUT1
6IN2_L
IC1016BA4558RFVM
73
2IN5+_L
3IN4+_L
EVOLIC4271
PML018A
IDE ISOLATOR/LPF AMP
10
5
Frout_L
IN3_L
11
FL
RLRear_L
12Pre/SW_L
Q4232VR4231Q4231
VIDEO BUFFERVOUT
1VIN
4BCVIN
BACK CAMERA ISOLATORIC4251
NJM2505AF
43V4-1
37V1-1
14
5123
2123
4
22
SREMOTE
PWR AMPIC1007
PAL007C
IN2 OUT2+OUT2-
IN4 OUT4+OUT4-
25B_REMOTE
STBY
MUTE
CN1005
8
12
14
57
ILMILMSNS
ACC
6
ASENSFANUP
FANCONT
CN1016
BCV
12BREMBREMOTE
13
ASENS
11REVREVSNS
10PULSESPEED
9PKBPKBOUT
Q2880
Q2900
PFLPRL
RL+RL-
FL+
CN1000(1/2)
PO
WE
R S
UP
PLY
TE
RM
INA
LSC
OR
D A
SS
YN
AV
I UN
ITO
TJ1
NA
VI U
NIT
SP
J1
27FRV
FL-
9513SWL
FLRL
PFLPRL
ANTB16BUP
Q2870
Q4751
IC1015(1/2)NJM4558V
13DVD LPF
MUTEMUTE
MUTE7
IN1-L
Q3042Q4333
Q4331
Q4332
SWL
POMUTE
29
AANT
GUIDEMUTE30
GUIDE32
SPEED
PCHNG49
PULSE50
PKBPKBOUT42
KMODEKMODEOUT43
REVREVSNS44
AUX-LAV2LS12
AUX-VAV2VINNAVIAL
15
VTR1LAV1LS17
VTR1VAV1VIN19
TELMUTE1
TEIN
BCV23
REARVOUT21
NaviAL23
8KMODEKMODEOUT
Q4752
Q2840
IC1002NJM2904M
SPEED PULSE15
Q2841
Q601
MUT
FANV
AV8V
CN1001
2
20
Q4771I
Q4776
AV8
4681012141618
NAVI5V
FU4771
Q4314
Q4312
VCKVDT
20CLK
19DATA
VST 21STB
AV8
FAN DRIVER
PARKING SENS
REVSNS
ILMSNS
ASENS
TELMUTE
KMODE
RESETHDRST4
0BT/XS/EW5
0BT/XS/RE
SREMOTE
POMUTE
HDRST
RSTMUTE
RSTIN
Q1016(2/2)
Q1016(1/2)
5
3
C608335FVET
CT
VDD UVDD5VDD5
SRCMUTE
MUT
Q2863
Q2861
Q2864
Q2865
Q2862
AV8
AVIC-F900BT/XS/EW5 255 6 7 8
C
D
F
A
B
E
3V→5VIC605HCT08
5V→3VIC609
VHC08
R651
R650
4
1 2 3 4
SYSTEM-uCOMIC610(2/2)PEG446A
NAVI5VIC4601
TPS5103IDB
9
14
Q4661
VCC_SENSE13
VCC
RWMSKIP
10STBYQ4602
19
18
17
LL48
NAVICON
49DCSKIP
88
104
FCONT
BSENS
OUT_U
OUT_D3
FB
NKBUP
NAVI5V
2INV
FU4601
FU4602
DVD8V or CD7.5VIC4641
TPS5103IDB
14VCC_SENSE
10STBY
Q4642
19
18
17
LL58
VDCONT
OUT_U
OUT_D3
FBBU
VD8
2INV
FU4641
FU4642
DVD5VIC4661
TPS5103IDB
14VCC_SENSE
10STBY
Q4663
19
18
17
LL60
92
VDD5CONT
ANTON
OUT_U
OUT_D3
FBKBUP
MVDD5
2INV
FU4661
FU4662
ANTB5
Q4601
RT
5
Q4641
RT
13VCC
13VCC
5
Q4662
RT
36RX
70IPPW
71ASENBO
37TX
Q4733
Q4731
86BSENSN
Q4738
139WREMIN
133WCONT
AV UNIT(2/2)A
90OPTSNS
89OPTON
121RSTOUT
119OFFINFO
126SYSTOC
131SYSTOCV
117BATFAULT
120CPUWDT
118OFFANS
125CTOSYS
128CTOSYSV
124DVEJKY
112ROT1
111ROT0
CTOSYS5CTOSYSV5
OFFANS5CPUWDT5
3
TC74V
68
11
SYSTOCV5BATFAULT5
SYSTOC5OFFINFO5
9,10
TC74
1,24,5
12,13
Q661
Q662
RESETIC601
TC7SH08FUS1
NAVIC
1,2 4
105106107
LEDDTLEDCKLEDCS
5655
51
SIMUKE0SIMUKE1
SIMUKE4
5352
SIMUKE2SIMUKE3
R658 R655
R657 R654
69SYSPW
67SWACPW
SWVDD5 VDD5
Q2881
Q2882
SYSPW3.3V NAVI3V
Q4753
Q4754
SYSPW
FU4631ILMV
Q4631
Q4632
BU
Q2811
Q2812
ILMV
4 2AV8
VIDEO5Q2810
BUP
SWACPW
IC2801BA00CC0WCP-V5
AV8
4 2TU3 VT6IC2830
BA00BC0WFP
TU3
VIDEO5
1
1
SYSPWSWACPW
SYSPW
50DSCKIPCD
VT8
VICS8
VT6
A
AVIC-F900BT/XS/EW5261 2 3 4
C
D
F
A
B
E
ANTB
Q47
YS5YSV5
NS5WDT5
TC7
OCV5AULT5
OC5FO5
9
TC
14
12
Q661
ESETC601H08FUS
IC
4
R658 R
R657 R
8
6
5 6 7 8
1 5
6
IC2890TPD1018F BUP
AANT
B
C
KBUP
Q4732
Q4734
ASENBO
BU BUP
NKBUP
KBUP
NAVIC+
BU
KBUP
33
NAVIC
CN1021
IPBUS-
IPL+IPL
IPBUS+
7
15
IC4721HA12241FP
65
DIN1ROUT
BUS+BUS-
ASENBO8
12
TXRX
8IPPW
STBYIP BUS
CN1015
WIRED REMOTE(Black)
3 1,2
3V→5VIC605
4VHCT08AFTS1
6 4,58 9,1011 12,13
CTOSYSV3CTOSYS3
SYSTOCV3SYSTOC3
OFFANS3CPUWDT3
BATFAULT3
OFFINFO3
ROT1
ROT0
RESETB
OPTONOPTSNS
,10 8
5V→3VIC609
74VHC08FTS1
,2 3,5 6,13 11
1
CN1000(2/2)
9
ILMR7
ILMG6
ILMB5
EJECTDVEJKY3
ROT117
ROT018
RESETB48
OPTON40
OPTSNS41
NAVI33V24
CTOSYSV334
CTOSYS337
OFFANS45
WDOGOFFANS3CPUWDT3
47BATTERY-FAULTBATFAULT3
16SYSTOCV3
35SYSTOC3
38OFFINFOOFFINFO3
46
NAVI3VFU2900
AB
R643104104
R644NMNM
SIMUKE4R646104104
R647NMNM
SIMUKE3R650104104
R651NMNM
SIMUKE2R654104NM
R655NM104
SIMUKE1R657104104
R658NMNM
SIMUKE0
655 R651 R647 R644
654 R650 R646 R643
UVDD5
NAVI UNITOTJ1
TO 1/2
NKBUP
4 2
1
IC2820BA00CC0WCP-V5 KBUP
VT8
WCONTWIREIN
32
1
ILMVILMV(LEDSW)
BUP35 1,3IC4703
S-L2980A33MC-C6S VDD5
BUP3
AU43,4 1IC1008
NJM2125F AV8
AU4
VDD55 1IC4701
BD3931HFP KBUP
UVDD5
VDD5
ILMR
ILMG
ILMB
ILMV
6 1DI AO1
7 2CLK AO2
8 3LD AO3
Q3604
Q3605
LEDDT
LEDCK
LEDCS
Q3606
Q3601
Q3602
Q3603
RED
GREEN
BLUE
IC3601M62343FP
RGB LED DRIVER
A
B AVIC-F900BT/XS/RE
AVIC-F900BT/XS/EW5
C TO 1/2
AVIC-F900BT/XS/EW5 275 6 7 8
C
D
F
A
B
E
1
32
13
AUDIO
1514
16
VDD
1 2 3 4
MA0-11
MDQ0-31
DQM0-3
A16-19
AD0-15
VIDEO+AUDIOIC1501
MN2DS0016AAUB
SRCK
LRCKADOUT3
SDODAC
LTDACSCKDAC
DACCK
174
173175
91
7490
172 DACCLK
SRCKADOUT3
SDODACLRCK
LTDACSCKDAC
DACCLK
DRV395
CONT1
MD
CONT284
97
85
LOADIN93
FD150
TD149
LDIN
FG
HOMETEMP
VIN1RF
VIN3RF
VIN4RF
VIN2RF
VIN5VIN6
DVDMPDRFINN
F+H_G+H
CDMPD
E+G_E+FLPCO2LPCO1
99
98145
123
121
120
122
VIN2142
136137
A
C
D
B
FE1FE2
128116134
130
135131129
RF
CrCb
YComp
152153154161
STANDBY78
HOSTCMD80
SLVSTS79
IRQPWR89
AMUTE87
DSCSNS147
PHOTOSNS144
(CR)(CB)
(Y)(COMPOSIT)
CRCB
YCOMPOSIT
DRV296
NRES
OSCO
OSCI
X1501169
170
DE
BU
G
STANBY
CMDCOMNSTSCOMN
IECOUT179
A16-19
A0-15
A0-15
AD0-15
AD0-15
XRDNRES 28 50NEXOE
101NRST
77XCSSR
51NEXCE
62NEXWE
XCSSR26
12
XWR111
48
CE
OE
WE
RESET
2 1 VSENS
VOLTAGE DETECTIC1003
S-80859CNNB-B9K
VD8 OUTVDD88
VSENCE
SDRAMIC1481
EDS1232AATA-75
2068
CSCLK
XWE17 3NWE
XCAS18 4NCAS
XRAS19 5NRAS
XCSM 6NCSM
22 8BA0
23 10BA1
BA0BA1
MCK 234MCK
232MCKI
CASRAS
WE
CN1951
EXTRG0SDATASCLOCKEXTRG1_SPD_SW
TRCD0
1011
1
6
87
5
9
432
TRCST
TRCCLK
TRCD3TRCD2TRCD1
190191192189
187
183184185186
TRCSTTRCDATA3TRCDATA2TRCDATA1TRCDATA0
188TRCCLKEXTRG0SDATASCLOCKEXTRG1
PR_A20 92P0
VIN1143
VIN3140
VIN4141
FLASH 16M
IC1401CWW1465
LATCHIC1352
TC74LCX16373FT
IC1351TC7SZ08FU
IC1403TC7SZ32FU
XCSFM26
11 XWR2
CE
WE
IC1402CWW1466
412
412
XCSFM1LE
252LE
DVD CORE UNITC
CLAMP94
12|
13VCC33
XCSSR
AVIC-F900BT/XS/EW5281 2 3 4
C
D
F
A
B
E
SRCKADOUT
SDODALRCK
LTDACSCKDA
DACCL
5 6 7 8
AVCC5
VOUTL7
BCK
LRCKDATA
MD
1
32
13
AUDIO 2CH ANALOG OUTIC1801
PCM1753DBQLOUT
MLMC
SCK
1514
16
3
CC
K
20 18CTL2 SLO2-
3ACO2+
4ACO2-
MOTOR DRIVERIC1201
BD7996EFV
2ACO1-
1TOMTOP
FOMFOP
ACO1+
21CTL1
25SLIN2
2629
SPIN10
LDIN13
FG
DISC DETIC1301
TC7SZ125FU
VDD5
B-
CN1201
17SLO2+
16SLO1-
15SLO1+
42V
COILV
39W
COILW
44U
COILU
36HB
HBM30
HW-HWM
31HW+
HWP32
HV-HVM
33HV+
HVP34
HU-HUM
35HU+
HUP
2018
1514
17
1234
910
7
1211
8
13
16
56
Q1104Q1102
VREFVCC5
CN1101
LD(CD)
F-F+T-
T+
FOM
THTEMPB
FOPTOMTOP
LPCO2
25
2019
1234
1011
8
1412
9
15
2117
22
24
57
Q1103Q1101LD(DVD)
VCC
LPCO1
4DSCSNS 2
51ACTIN1
50ACTIN2
513
VINVOUT
ON/OFF
AVCC5 REG.IC1005
S-L2980A50MC-C7J
VCC5VD8
451
VINVOUT
CONT
VCC5 REG.IC1004
NJM2880U1-05
ACD
FE1FE2
78MDCDMPD65MDDVDMPD
RFF+H/G+HF+H_G+HE+G/E+FE+G_E+F
1
DRV3
SLIN1DRV2
CONT1CONT2
MD
FDTD
CR
IECOUT
CBY
COMPOSITSTANBYSLVSTS
HSTCMDSTSCOMNCMDCOMN
IRQPWRAMUTE
VD8
XRESETNRES
WAKE UP
B+
COIL_V
COIL_W
COIL_U
A-
ANALOG LOUT
DiscDetect
8cm8cm
12cmPhotoPHOTOSNS
CN1901
40
21
3
293836
2322
25
20
24
2|1
3432
CN1852
1
CN1301
3
2
1
45
A+
HALL_BIAS-HALL_W-
SWITCHHOME
HALL_W+HALL_V-
HALL_V+HALL_U-HALL_U+
HALL_BIAS+
31VDD5 VCC33
3.3V REG.IC1007
NJM2885DL1-33
OUTIN
82
VCC12
1.2V REG.IC1008
R1232D121B
LXVIN
4
COMPOUND UNIT(A)DS1203 S1204DISC SENS
3
S1202
8cm
S1201
2 12cm5
S12058cm
6 Q1299
CLAMP1 TP1
COMPOUND UNIT(B)E
S1206CLAMP
3VDD
VDD5FU1901 14
|17
VD5
PU (DP8)
CN702A
NAVI UNITOTJ4
AVIC-F900BT/XS/EW5 295 6 7 8
C
D
F
A
B
E
1 2 3 4
KEYBOARD UNITB
RESET
CN801
2
RESETS801
EJECT3
EJECTS804
INT_KEY04
ROT114
1
2
3 A
B
C
Com
Enc-Com
4
7
10
9PUSH
D 8
5
MENUS802
MAPS805
KEY05
INT_KEY16
ROT0 Phase-B
Phase-A
13ROTARY COMMANDER
S803
KEY17
BL-LED8
AUX-V21
AUX-AG20
AUX-VG VGAG
22AUX-L
19
ILMV9
ILMR
D801
10
ILMG11
ILMB
R
G
B12
PUSH
A
C
B D
CN803
3
D815
1
CN802
AV MINIJACK IN
NAVI UNITBTJ2
PANEL UNITOTJ2
R4
L
2AUX-G
1V
2,3
1
BT-ANTANT801
RF_I/O
AVIC-F900BT/XS/EW5301 2 3 4
C
D
F
A
B
E
5 6 7 8
AVIC-F900BT/XS/EW5 315 6 7 8
C
D
F
A
B
E
POWE
2 mA
-> SYVHCT0
R
1 2 3 4
4.3 POWER SUPPLY SYSTEM FIGURE
+B
AV UNIT
SYS u-comM30878FJBGP
VDD5REGULARPOWER SUPPLY5 VBD3931HFP HA12241FP
IP-BUS DRIVER
RESET ICBD5335FVE
NAVI -> SYSTC74VHCT08T
UVDD5
ROM COLLECTIONS-93C568DOI
BUP 3 VS-L2980A33MC-C6C
SYS -> MSTC74VHC08FT
SPEED I/FNJM2904M
ATT CONTROLUMD3N*3
+
DCSKIPCD
FM/AMTUNERUNITX-2026
VT8(8 V)BA00CC0WFP
typ 103 mAmax 140 mA
typ 172 mAmax 200 mA
DISTRIBUTORMACHINE
+
TU3BA00CC0WFP
SYSPW orSWACPW
SYSPWIR REMOTERPMS2401-H19E4AV
2 mA2 mA2 mA
2 mA
SWVDD5
DARCTC74
10 mA
SYS -> DARCTC74VHC08FT
2 mA
1 mA
MAX 45 mATYP 32 mA2 mA
FM/AM TunerFront stepamplifier
TMC/VICS/MSN/DirectTuner Front step amplifier
63 mA
4 mA
11 mA
81 mA
172 mA
25.4 mA
25.4 mA
27.3 mA
427 mA
RGB_LED DRIVEM62343&UMX1N
3 mA
A B C
AVIC-F900BT/XS/EW5321 2 3 4
C
D
F
A
B
E
YST08T
MR
6
DTC
RC08FT
ectmplifier
LED DR43&UMX
3 mA
5 6 7 8
POWER SUPPLY
RQ(WDT,IRQ)TC7WH32FU
3 -> 5AND IPDTC7SET08FU
RST INVTC74SH04
2 mA
OR MUTE CIRCUITTC7S32FU
2 mA
AV SELECTOR
2 mA2 mA
ARC -> SYS74VHCT08T
MS5 ->SYSTC74VHCT32T
2 mA 2 mA
TEMPERATURE CIRCUITIVER1N
AVIC-F900BT/XS/EW5 335 6 7 8
C
D
F
A
B
E
B SNS
>NAVIVHCT0
1 2 3 4
D/DDVD 8 V(MS5)
IP_BUS POWER SUPPLYSW
ASENBO
POWER , AMPPAL007B
SW FOR ANT +
ANTON
SYSPWR orSWACPW
AUTO ANTENNA
AV8(8.3 V)BA00CCOWCP
SWACP
VIDEO ISOLATORNJM2505F
typ 19 mAmax 29.0 mA
VIDEO 5 V
VDCONT
D/DNAVI 5 V
NAVICO
max 2.5A
FCONT
FCONT
SYSPW
ILMV 9 V
KMOD TR PKSYSPW
SYS->NAVITC7SH08FU
SYS-TC74
NAVI 3.3 V
ILMV
DCSKIP
121.6 mA
181.1 mA
24 mA
326.7 mA
30 mA
A B C
D/DDVD 5 V
VDCONT
FCONT
MS5(DVD)MAX 650 mATYP 450 mA
MAX 650 mATYP 450 mA
NAVI, LCD BORD
AVIC-F900BT/XS/EW5341 2 3 4
C
D
F
A
B
E
ST
5 6 7 8
GUIDE MIXNJM2060V
MUTE CIRCUIT
AU4NJM2125
CAPTAIN6
VIDEOLEVELSHIFT
AV SELECTORAN15887A
DVD LPFNJM4558V
PKB SNS
YS->NAVIC74VHCT08FTS1
50 mA9 mA
1 mA5.7 mA
VIDEO BUFFER10.5 mA
37 mA
KEY BORD
AVIC-F900BT/XS/EW5 355 6 7 8
C
D
F
A
B
E
K(200 ms
K(200 ms
K(200 ms
1 2 3 4
5. DIAGNOSIS5.1 OPERATIONAL FLOWCHART
Acc on (USUALLY Acc ON)/BSENS
/ASENS
STATUS
MUTE
ASENBO
SREMOTE
SYSPW
DCSKIPCD
ANTON
SWACPW
DCSKIP
BSENSN
RSTOUT
BATFAULT
CPUWDT
OFFINFO
OFFANS
NAVICON
FANCONTFAN CONTROL
200 msEXTERNALOUTPUTAUDIO
CONTROL
NAVI POWERSUPPLY
CONTROL
NAVI CONTROL
ANTON (Source interlockingmovement, forced OFF)
250 300 ms( SURVEY) POWER SUPPLY MAS1 sec 2 sec
IP-BUSPRETREATMENT
IP-BUS SLAVECONNECTION CHECK
SOUND MUTECONTROL
POWER SUPPLY MAS
SENSE SYSTEM
POWERSUPPLY
CONTROL
IP-BUSSYSTEM
POWER SUPPLY MAS
WAITING FOR SLAVEPOWER SUPPLY
OSCILLATION STOP STANDBY LOOP
500 ms
(At the time of a reset start)
AVIC-F900BT/XS/EW5361 2 3 4
C
D
F
A
B
E
R SUPPLY
R SUPPLY
R SUPPLY
5 6 7 8
8 ms to 16 ms or more
FANCONT(At the time of high temperature)
MASK(200 ms)
16 ms
MAIN LOOP
After mute (300 ms)(After SYSPWR ON, at least 300 ms. MUTE time is extended to OFFANS Low henceforth.)
MASK(200 ms)
MASK(200 ms)
AVIC-F900BT/XS/EW5 375 6 7 8
C
D
F
A
B
E
1 2 3 4
5.2 INSPECTION METHOD OF PICKUP UNIT
Disc to be used CD-DA: TCD-782 DVD-Video: GGV1025
Execution method
START
Is it OK?
Is it OK?
Ckeck partsother than PICK UP
PICK UPcleaned?
Perform lenscleaning
SKEW ADJ.
Is it OK?
LD current check
RF level check
RF level check
Yes
Error rate check
Finished
LD turned on? Check partsNo
Is it OK? PICK UPcleaned?
Perform lenscleaning
Error rate check
Is it OK?
Replace the PICK UP
Replace the PICK UP
Replace the PICK UP
Replace the PICK UP
Check point:AS MAX check
Check point:LD current check
Check point:Error rate check
YesNo
YesNo
YesNo
YesNo
YesNo
YesNo
YesNo
Check point:AS MAX check
Check point:Error rate check
AVIC-F900BT/XS/EW5381 2 3 4
C
D
F
A
B
E
5 6 7 8
LD current check
Status: [Foucs closed] of TEST MODEMode: DVD
No. Disc Check Point Threshold Remarks: LD current1
Status: [Foucs closed] of TEST MODEMode: CD
No. Disc Check Point Threshold Remarks: LD current2 TCD-782 CDLD1 – VCC5_3 (mV) 10 – 60(mA)
Notes: Please pay attention to the laser diode damage by static electricity.
DVDLD1
VCC5_3
CDLD1
VCC5_3
GGV1025 DVDLD1 – VCC5_3 (mV) 10 – 65 (mA)
AVIC-F900BT/XS/EW5 395 6 7 8
C
D
F
A
B
E
1 2 3 4
ASMAX checkASMAX value shows the value of RF level.Status: [Foucs closed] of TEST MODE
No. Disc Check Point Threshold Remarks:8 digits value of
ASMAXmore than
on display 0000 06008 digits value of
ASMAXmore than
on display 0000 0C00
Error rate check
Status: [Tracking Closed] of TEST MODE
No. Disc Check Point Threshold Remarks:less than
1.000E-03less than
1.000E-03less than
2.500E-033 TCD-782 ID: HOME Position
2 GGV1025 ID: 200000
1 GGV1025 ID: 40000
1 GGV1025Only four last digits aredisplayed according to
the product.
2 TCD-782Only four last digits isdisplayed according to
the product.
In this case, the value is displayed for a split second.When you tried to perform [FOCS CLOSE],the display will charge automatically in the following order.[1FFF0000]->[FEMAX]->[FE MIN]->[AS MAX]->[ENV MAX]->[FE normal]->[Spindle gain]->[TEMAX]->[TEMIN] ->[20000000]Watch carefully the value of ASMAX.
AVIC-F900BT/XS/EW5401 2 3 4
C
D
F
A
B
E
5 6 7 8
5.3 DIAGNOSIS FLOWCHART
Is the image in error?
Go to FE related repair process.
Is FE section normal?
BACK END section flow
Can the playback
start?
Is the sound in error?
Repair the defective part.
Normal?
NO
YES
NO
YES
YES
YES
YES
YES
YES
Go to FE section check.
YES
YES
NO
NO
NO
NO
NO
NO
NO
FE section check.
Go to FE section check.
NO
NO
NO
Replace the unit.
YES
YES
Go to FE section check.
NO
YESYES
NO
START
END
NO
NO
NO
NO
Replace the unit.
YES
Normal?
YES
NO
END
NO
YES
YES
YESYES
YES
Does the operation take time?
Is the life of flash memory OK?
Conduct check item 12.
Standby OK? Execute check 1.
Is VDD5 (VCC33, VCC12)
power supply voltage OK?
Execute check 2.
Reset OK? Execute check 3.
Is VD8, VCC5 power supply voltage OK?
Execute check 7.
Is SDRAM IF OK?
Execute check 6.
Is VSENS OK?
Execute check 4.
Is 27 MHz OK?
Execute check 5.
Is AVCC5 voltage OK?
Execute check 8.
Is DACCLK normal?
Execute check 9.
Is the audio circuit OK?
Execute check 10.
Is the video circuit OK?
Execute check 11.
Is AVCC5 voltage OK?
Execute check 8.
AVIC-F900BT/XS/EW5 415 6 7 8
C
D
F
A
B
E
1 2 3 4
Check 1: Standby OK?
<Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference.
NO. Check point Module No. Specification value UnitSTANBY-DGND1 ALL VCC33 V-
0.6 V or moreV
Fig 1.1: STANBY check point
Side A
1
DGND1
STANBY
AVIC-F900BT/XS/EW5421 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?
VDD5
VCC33 (= 3.3 V )VDD5
VCC12 (= 1.2 V )
IC1401 FLASH power supply (Data)IC1402 FLASH power supply (Program)IC1481 SDRAM power supplyIC1501 DVD-LSI power supply
IC1501 DVD-LSI power supply
IC10073.3 V output regulator
IC1008DC/DC converter 1.2 V output
F.E. driver control system
NO. Check point Module No. Specification value Unit123
VDD5_3 - DGND1VCC33_3 - DGND1VCC12_1 - DGND1
ALLALLALL
5.0 ± 0.43.3 ± 0.151.2 ± 0.12
VVV
Side A
Fig 2.2: VDD5, VCC33, VCC12 voltage check points
Fig 2.1: Power supply configuration
<Check> Check the voltage at the “VDD5_3, VCC33_3 and VCC12_1” test point while the power is on. Use the “DGND1” test point at the reference.
DGND1
VCC12_1
VCC33
VDD5_3
AVIC-F900BT/XS/EW5 435 6 7 8
C
D
F
A
B
E
1 2 3 4
Check 3: Reset OK?
NO. Check point Module No. Specification value Unit1 XRES-DGND1 ALL VCC33 ×
0.7 or moreV
Side A
Fig 3.1: RESET check point
<Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference.
DGND1XRES
AVIC-F900BT/XS/EW5441 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 4: Is VSENS OK?
CN1901HOST I/F
VD8 VSENS
VCC33VDD5
STANBYXRES
Fig 4.1: Power supply configuration and VSENS
NO. Check point
IC1501DVD-LSI
IC1007 Regulator
VCC12IC1008 DC/DC converter
IC1003 detection IC
Side A
Fig 4.2: VSENS check point
Module No. Specification value UnitVSENS - DGND1 ALL VCC33 × 0.7
or moreV1
<Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference.
DGND1
VSENS
AVIC-F900BT/XS/EW5 455 6 7 8
C
D
F
A
B
E
1 2 3 4
Check 5: 27 MHz Normal?
<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).
OSCO
OSCI
Fig 5.1: Clock configuration
IC1501
DVD-LSIX1501 27 MHz crystal
VCC33 VCC12
<Check method> Turn the power on, and check with DGND being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components.
NO. Check point Module No. Specification value Unit
2 IC1501 169pin ALL 27 MHz± 50 ppm ppm
GNDFig 5.2: Clock specification value
Side A
Fig 5.3: 27 MHz check point
Specification value
DGND1
IC1501 169pin
AVIC-F900BT/XS/EW5461 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 6: Is SDRAM I/F OK?
<Outline> In order to secure the MPEG stream data as the buffer, the capacity of communication I/F SDRAM between the LSI and the memory is 128Mbit. Be careful as XCSM, XWE, XCAS, XRAS and XSCM of IC1481 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS, NCSM.
MA0~11MDQ0~31MCKXWE (NWE)XCAS (NCAS)XRAS (NRAS)XCSM (NCSM)DQM0DQM1DQM2DQM3BA0BA1
Fig 6.1: SDRAM I/F
IC1481SDRAM
IC1501DVD-LSI
AVIC-F900BT/XS/EW5 475 6 7 8
C
D
F
A
B
E
1 2 3 4
123456789
10111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455
MA0MA1MA2MA3MA4MA5MA6MA7MA8MA9MA10MA11MDQ0MDQ1MDQ2MDQ3MDQ4MDQ5MDQ6MDQ7MDQ8MDQ9MDQ10MDQ11MDQ12MDQ13MDQ14MDQ15MDQ16MDQ17MDQ18MDQ19MDQ20MDQ21MDQ22MDQ23MDQ24MDQ25MDQ26MDQ27MDQ28MDQ29MDQ30MDQ31MCKXWEXCASXRASXCSMDQM0DQM1DQM2DQM3BA0BA1
56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %0.17 ohm or lower56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %
IC1481 25pinIC1481 26pinIC1481 27pinIC1481 60pinIC1481 61pinIC1481 62pinIC1481 63pinIC1481 64pinIC1481 65pinIC1481 66pinIC1481 24pinIC1481 21pinIC1481 2pinIC1481 4pinIC1481 5pinIC1481 7pinIC1481 8pinIC1481 10pinIC1481 11pinIC1481 13pinIC1481 74pinIC1481 76pinIC1481 77pinIC1481 79pinIC1481 80pinIC1481 82pinIC1481 83pinIC1481 85pinIC1481 31pinIC1481 33pinIC1481 34pinIC1481 36pinIC1481 37pinIC1481 39pinIC1481 40pinIC1481 42pinIC1481 45pinIC1481 47pinIC1481 48pinIC1481 50pinIC1481 51pinIC1481 53pinIC1481 54pinIC1481 56pinIC1481 68pinIC1481 17pinIC1481 18pinIC1481 19pinIC1481 20pinIC1481 16pinIC1481 71pinIC1481 28pinIC1481 59pinIC1481 22pinIC1481 23pin
IC1501 16pinIC1501 18pinIC1501 20pinIC1501 22pinIC1501 21pinIC1501 19pinIC1501 17pinIC1501 15pinIC1501 11pinIC1501 9pinIC1501 14pinIC1501 7pinIC1501 237pinIC1501 239pinIC1501 241pinIC1501 243pinIC1501 248pinIC1501 250pinIC1501 252pinIC1501 254pinIC1501 253pinIC1501 251pinIC1501 249pinIC1501 244pinIC1501 242pinIC1501 240pinIC1501 238pinIC1501 236pinIC1501 29pinIC1501 31pinIC1501 33pinIC1501 37pinIC1501 39pinIC1501 41pinIC1501 43pinIC1501 45pinIC1501 44pinIC1501 42pinIC1501 40pinIC1501 38pinIC1501 34pinIC1501 32pinIC1501 30pinIC1501 28pinIC1501 234pinIC1501 3pinIC1501 4pinIC1501 5pinIC1501 6pinIC1501 255pinIC1501 256pinIC1501 26pinIC1501 27pinIC1501 8pinIC1501 10pin
<Check> Check the conductivity at “check point 1” and “check point 2” without power. In case of NG, check the soldering and defective components throughout the “output t input” of the applicable section.
NO. Signal name Check point 1 Check point 2 Specification value
AVIC-F900BT/XS/EW5481 2 3 4
C
D
F
A
B
E
5 6 7 8
Side B
Check point 1 (IC1481)Side A
Check point 2 (IC1501) Fig 6.2: SDRAM I/F check point
AVIC-F900BT/XS/EW5 495 6 7 8
C
D
F
A
B
E
1 2 3 4
Check 7: Is VD8, VCC5 power supply voltage OK?
VD8_1
VD VCC5 (= 5.0V )
Fig 7.1: Power supply configuration
F.E. driver system DISC detection LED
Power supply for PU
IC1004 REG IC for VCC 5V.
NO. Check point Module No. Specification value Unit123
VD8_1 - PGND3VD - PGND3VCC5_1- AGND1
ALLALLALL
8.0 ± 0.48.0 ± 0.45.0 ± 0.1
VVV
Side A
Fig 7.2: VD8, VCC5 voltage check points
<Check> Check the voltage at the “VD8_1, VD and VCC5_1” test point while the power is on. Use the “PGND3 and AGND1” test point at the reference.
VCC5_1
AGND1VDVD8_1
PGND3
AVIC-F900BT/XS/EW5501 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 8: Is AVCC5 voltage OK?
VD AVCC5 (= 5.0 V )
Fig 8.1: Power supply configuration
<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus. Check with PGND and GNDAU being the reference.
NO. Check pointVD - PGND_3AVCC5 - GNDAU1
IC1801Audio-DAC
IC1005 REG IC for AVCC 5 V.
Module No. Specification value Unit12
ALLALL
8.0 ± 0.45.0 ± 0.1
VV
Side A
Fig 8.2: VD8, AVCC5 voltage check points
PGND3
AVCC5
GNDAU
VD
AVIC-F900BT/XS/EW5 515 6 7 8
C
D
F
A
B
E
1 2 3 4
Fig 9.1: Clock configuration
Check 9: Is DACCLK normal?<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501).
DACCLK
<Check method> DVD: DVD-REF-A1 TITLE 1CD: Playback a normal CDDA.Common to all DVD-V compatible modules.Check with DGND being the reference.In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and defective components.
IC1501
DVD-LSIX1501 27 MHz crystal
IC1801Audio-DAC
VCC33 VCC12
GND
Fig 9.2: Clock specification valueSide A
Check point 2 (IC1501 172 pin)Check point 1 (stylus)
Fig 9.3: 27 MHz, DACCLK check point
Specification value 1
Specification value 2 Specification
value 3
NO. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 312
DACCKDACCK
DVDCD
2.0 V~VCC33 V2.0 V~VCC33 V
DGND~0.8 VDGND~0.8 V
36.864 0 MHz ± 300 ppm33.868 8 MHz ± 300 ppm
AVIC-F900BT/XS/EW5521 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 10: Is the audio circuit OK?<Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1901). Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F. The digital audio signal (IECOUT), output from DVD-LSI (IC1501), is output via CN1852.
CN1901HOST I/F
LRCK LOADOUT3SRCK RO
GNDAU
CN1852
IC1801Audio-DAC
IC1501DVD-LSI
IEC
Fig 10.1: Audio circuit
<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB), and check with DGND being the reference. In case of NG, check the applicable line, periphery of major components as described in the above drawing, soldering of the peripheral components and defective components.
NO. Check point 1 (stylus)123
Specification value 1 Specification value 2 Reference waveformADOUT3SRCKLRCK
VCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higher
0.4 V or lower0.4 V or lower0.4 V or lower
Waveform 1Waveform 2Waveform 3
GND
Fig 10.2: Serial 3 lines specification value
Side A
Specification value 1
Specification value 2
Fig 10.3: Serial 3 lines check points
SRCK
LRCK
ADOUT3
AVIC-F900BT/XS/EW5 535 6 7 8
C
D
F
A
B
E
1 2 3 4
The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.
NO.45
Fig 10.4: Analog audio out (LO, RO) specification value.
Side A
Fig 10.5: Analog audio out check point
Specification value is the root-mean-square value (rms).
Check point 1 (stylus)1 400 ± 150 mV1 400 ± 150 mV
Specification value (rms) Reference waveformWaveform 4Waveform 4
LORO
LO GNDAU1 RO
47 kohm 47 kohm
LO
RO
GNDAU1
AVIC-F900BT/XS/EW5541 2 3 4
C
D
F
A
B
E
5 6 7 8
Check with DGND being the reference. Check 2pin cord after connecting it to a jig, etc.
NO. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5
Side A
Fig 10.6: Digital audio signal (IECOUT) check point
IEC
AVIC-F900BT/XS/EW5 555 6 7 8
C
D
F
A
B
E
1 2 3 4
IN IN
OUT
<Outline> At the time of 6ch digital out, the serial 6 lines output from DVD-LSI (IC1501) is output via CN1581. Furthermore, at the time of ripping, the serial 3 lines digital output + SUBC, output from DVD-LSI (IC1501), is output in 4 times speed via CN1851.
CN1851ADOUT0/SUBCADOUT1/BLKCKADOUT2/CLDCKSRCK
LRCKDATA
MCKENA
RIPP
IC1501LSI
IC1851 buffer SW, ripping or 6ch digital out.
IC1852 buffer SW, ripping or 6ch digital out.
IC1853 buffer SW, ripping or 6ch digital out.
SBCKBMUTEEMPHIEC/IPFLG
The signal at CN1851 for 6ch digital out/Ripping.
Pin No. Pin name23211917151311
975432
SRCKLRCKAD0/SUBCAD1/BLKAD2/CLDAD3/DATAIEC/IPFLG-SBCKBMUTEMCKENARIPPEMPH
Pins 1, 6, 8, 10, 12, 14, 16, 18, 20, 22 and 24 are GNDD.
Fig 10.7: 6ch digital out/Ripping circuit
6ch digital out RippingSRCKLRCKADOUT0ADOUT1ADOUT2ADOUT3IEC--BMUTELowHighEMPH
SRCKLRCKSUBCBLKCKCLDCKDATAIPFLG-SBCK-HighLowEMPH
AVIC-F900BT/XS/EW5561 2 3 4
C
D
F
A
B
E
5 6 7 8
Playback DVD-REF-A1 TITLE22 CHAPTER 1, and check with GNDD being the reference. In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.
Check 24pin FFC after connecting it to a jig, etc.
NO. Check point 1 (stylus)789
10111213
SRCKLRCKADOUT0ADOUT1ADOUT2IECMCKENA
Specification value 20.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lowerVCC33 V x 0.3 V or lower
0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lower0.4 V or lowerVCC33 V x 0.3 V or lower
Rip common CDDA, and check with GNDD being the reference. In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.
Check 24pin FFC after connecting it to a jig, etc.
NO. Check point 1 (stylus)1415161718192021
SRCKLRCKSUBCBLKCKCLDCKDATASBCKRIPP
Specification value 1 Specification value 2VCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higher-
Specification value 1
GND Specification value 2
Fig 10.8: 6ch digital out/Ripping specification value
VCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higher-
Specification value 1
AVIC-F900BT/XS/EW5 575 6 7 8
C
D
F
A
B
E
1 2 3 4
Side A
Side B
Fig 10.9: 6ch digital out/Ripping check point
SRCK
LRCK
ADOUT3
ADOUT2
ADOUT1
ADOUT0
RIPP
MCKENA
SBCK
AVIC-F900BT/XS/EW5581 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 11: Is the video circuit OK?
<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the HOST I/F (CN1901) via a buffer circuit.
CN1901HOST I/F
AVCC5CompositeComponent YComponent CbComponent Cr COMPO
Fig 11.1: Video circuit
<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPO signal with an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”.
Video buffer circuitNoMount
IC1501DVD_LSI
Video DAC section
NO.
Check point 1 (stylus)
Specification value Reference waveform1 COMPO 1 000 mVpp ± 5 % Waveform 6
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.
PEAK
COMPO signal Reference value
Color burstPedestal level
BOTTOMHorizontal sync signal
Fig 11.2: Waveform for the case of composite white 100% output
<Video level readjustment method>In case the video composite output is outside of the specification value, readjust the level according to the method described below.(Note : Units are exchanged, the video output is not adjusted. )Turn the volume (VR1671) to adjust the video level within the range of 1.0 ± 0.02 Vpp. The adjustment specification is 1.0 ± 0.02 Vpp.
Adjust this level within the range of 1.0 ± 0.02 Vpp.
AVCC5
Fig 11.3: Video circuit (component)
Q1702(NoMount)Video buffer circuit
Q1701(NoMount)Video buffer circuit
Q1704(NoMount)Video buffer circuit
CN1901HOST I/F
Y Y
Cb Cb
Cr Cr
IC1501LSI
Video DAC section
AVIC-F900BT/XS/EW5 595 6 7 8
C
D
F
A
B
E
1 2 3 4
<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER19 (100% Color Bars), and monitor Y, Cb, and Cr signal with an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”.
NO. Check point 1 (stylus) Specification value Reference waveform1 000 mVpp ± 5%700 mVpp ± 5%700 mVpp ± 5%
Waveform 7Waveform 7Waveform 7
234
YCbCr
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.
PEAK
Y signal Specification value
BOTTOM
PEAK
Cb signal Specification value
BOTTOM
PEAK
Cr signal Specification value
BOTTOM100% Color Bars signal
Fig 11.4 Waveform for the case of component 100% Color Bars output
Side A
Fig 11.5: VIDEO signal check point
Y
COMPO
Cr
Cb
AVIC-F900BT/XS/EW5601 2 3 4
C
D
F
A
B
E
5 6 7 8
Check 12:How to judge whether the flash memory has reached its life or not.
If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory has reached its life.Make judgment regarding the flash memory life by looking at the display of the LD energizing time.
1.Let the LD energizing time displayed. (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life.
Example:
0E000BB8
AVIC-F900BT/XS/EW5 615 6 7 8
C
D
F
A
B
E
1 2 3 4
CH1 : LOCH1 : ADOUT3 CH2 : ROReference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: GNDAU2 1 V/div. 500 usec/div
Waveform 1 Waveform 4
CH1 : SRCK CH1 : IECOUTReference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: DGND2 1 V/div. 500 nsec/div
Waveform 2 Waveform 5
CH1 : LRCKReference voltage: DGND2 1 V/div. 5 usec/div
Waveform 3
AUDIO VIDEO
G->
G->
G-> G->
G->
G->
CH1 : COMPOReference voltage: GNDV1 200 mV/div. 10 usec/div
Waveform 6
Waveform 7
[WHITE 100IRE]
[100% Color Bars]CH1 : YCH2 : CbCH3 : CrReference voltage: GNDV1 200 mV/div. 5 usec/div
AVIC-F900BT/XS/EW5621 2 3 4
C
D
F
A
B
E
5 6 7 8
5.4 ERROR CODE LIST
Error status
OpenRead ErrorFocus Error(Focus Error in mechanism set up)
Surface Error
Address not found(Invalid Track)
Spindle Lock
Carriage HOME
ID/SUBCODE Read Error
AV CHIP decode Error
AV CHIP Recovery NG
Error of PLAY BACK Mode StatusDisc Data Error
No Disc (including Disc loading and ejecting)
Media Error
Temp Error (In Case of High Temperature)
OSD *1It is a disc unable to be played back.NON-PLAYABLE DISC(No display)ERROR-02-99
ERROR-02-90
ERROR-02-9E
ERROR-02-80
ERROR-02-91
ERROR-02-92
ERROR-02-94
ERROR-02-9A
ERROR-02-9B
ERROR-02-9C
Temperature protection circuit is being activated.THERMAL PROTECTION IN MOTION
(No display)
(No display)
UART*2
10h20h
21h
22h
23h
24h
25h
26h
2Ah
2Bh
2Ch
2Dh
40h
00h
30h
Meaning
Door open errorTransfer start error
Focus error
Focus error during set up (A focus has never been achieved with that disc.)
Address not found.
Spindle lock NG (the disc cannot rotate)Carriage home NG (The pick up tries to return to carriage home, but it cannot go back and stopped.)ID/SUBCODE Read Error (ID/SUBCODE cannot be read due to scratch or stain.)AV CHIP decode NG (AV chip cannot be decoded.)
AV CHIP recovery NG
Playback state error (An error due to software bug.)Disc Data NG
Disc has not been inserted. (Including Load in process or Eject in process.)
Loading mechanism error (The disc cannot be clamped.)
A disc containing the unplayable Format only.
High temperature (Playback is stopped because the pick up temperature is 89 C or higher.)
ACCOff/On
SourceOff/On
Eject Play Key
* * * *X X X X
X X X X
X X X X
X
X
X
X
X
X
X
X
*
X
X -X X
X
-
-
Method of reset
- -
X
X
X
X
X
X
X
X
*
-
-
-
-
X
X
X
X
X
X
X
X
*
X
X
-
X
X
X
X
X
X
X
X
X
X
*
-
-
-
-
-
ERROR-02-9D
Loading_Mecha Error 50h
REQUEST errorFailure in issuing read command (chip dependent)Adjustment of L0 is NG.Adjustment of L1 is NG.LD system NGGain adjustment system NG.Gain determining system NG.Servo initial setting related items NG.Disc is not clamped yet.Tracking system NG.Media setting system NG.Focus ErrorError of PLAY BACK Mode StatusError of PLAY BACK Mode Status
Undefined Error
DRM Error
Region code Error NG
CPPM*3 Key Error *4
AWM*5 Error *4
It is a protected disc.PROTECTED DISCRegion code is incorrect.DIFFERENT REGION DISC
It is a disc unable to be played back.NON-PLAYABLE DISC
ERROR-02-A0
ERROR-02-A1
ERROR-02-A2ERROR-02-A3ERROR-02-A4ERROR-02-A5ERROR-02-A6ERROR-02-A7ERROR-02-A8ERROR-02-A9ERROR-02-AAERROR-02-AB
ERROR-02-B0
ERROR-02-B1
ERROR-FF-FF
A0h
A1h
A2hA3hA4hA5hA6hA7hA8hA9hAAhABh
B0h
B1h
FFh
70h
90h
91h
*6
REQUEST error
Failure in issuing the read command
L0 adjustment is NG.L1 adjustment is NGLD system NGGain adjustment system NG.Gain determining system NG.Servo initial setting related items NG.Disc is not clamped yet.Tracking system NGMedia setting system NGJUMP over layers NG
Navigation command error
Retry over
Undefined error
DRM error (All music cannot be played back due to DRM.)Region code NG (Unable to be played back due to incorrect mechanism region.)
Playback the illegally copied disc by DVD-A(Mute the sound on the mechanism side.)
Key Error for playback
- - X -CPRM Key Error *7NON-PLAYABLE DISC
93h Key Error for playback
X
X
XXXXXXXXXX
X
X
X
X X X -
X
X
XXXXXXXXXX
X
X
X
X
X
XXXXXXXXXX
X
X
X
X
X
XXXXXXXXXX
X
X
X
X: Cancel the error by operation. -: Error is not cancelled by operation. *: No setting*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower row is for the Touch Panel model and Full GUI (English version).*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits. *3 CPPM(Content Protection for Prerecorded Media) : A copyright protection technique used in DVD-A. The protection is realized by using the keys recorded on the media and the device key held by the player.*4 DVD-A compatible model only. When an error has occurred, only the audio output will be muted but playback operation will continue. Furthermore, acceptance of the user operation will be the same as usual.*5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified.*6 Notice as an error status will not be given*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. (DVD-VR model only)
(No display)
AVIC-F900BT/XS/EW5 635 6 7 8
C
D
F
A
B
E
1 2 3 4
5.5 CONNECTOR FUNCTION DESCRIPTION
1. TELMUTE 2. DTVVGND 3. RR 4. DTVV 5. RL 6. REARGND 7. FR 8. KMODE 9. FL10. FRONTGND11. SWR12. BREM13. SWL14. SWGND15. VTR1R16. VTR1RGND17. VTR1L18. VTR1LGND19. VTR1V20. VTR1VGND21. REARVOUT22. GNDV23. BCV24. BCVGND
1. FR+ 2. RR+ 3. FR- 4. RR- 5. FL+ 6. RL+ 7. FL- 8. RL- 9. PKB10. PULSE11. REV12. ILM13. AANT14. ACC15. GND16. BUP
1. IPBUS+ 2. IPBUSG 3. IPLG 4. NC 5. IPBUS- 6. IPRG 7. IPL+ 8. ASENBO 9. IPR+10. IPR-11. IPL-
1 3 5 7 9 1113152 4 6 8 10121416
POWER SUPPLY1 3 5 7 9 111315171921232 4 6 8 1012141618202224
AV IN/OUT
1 2 3 45 6 7
8 9 1011
IP-BUS IN (RE)
USB DIGITAL OUT MIC INGPS ANTENNA
WIRED REMOTE
FM/AM ANTENNA
AVIC-F900BT/XS/EW5641 2 3 4
C
D
F
A
B
E
5 6 7 8
5.6 TROUBLESHOOTING
No Power
Key illimination islighted?
Check the following signal in theAV unit.(BSEN/ASEN/ILM, 8 V Powersupply)
Key illumination is
lighted more than 20
seconds?
LCD backlight is OK?
NAVI5V is OK?
Check the Power supply (D/Dconverter) block and Control signal(48pin NAVICON) of the Systemu-com in the AV unit.
LCD unit failure.Power supply
block for "LCD Panel
unit" is OK?
LCD Panel unit failure.NAVI unit failure.
NAVI3V from theNAVI unit is OK?
NAVI unit failure.(NAVI3V is supplied from NAVIunit and also NAVI3V isgenerated from NAVI5V)
NO
YES
NO
YES
NO
(No output)
YES
NO
Key illiminationgo off after 20seconds.
Initial communication errorbetween NAVI and AV unit.- Confirm communication line between 2 unit. (*1)- Change the NAVI unit
(*1)Normal operation after ACC ON- RESETB: High- OFFINFO: L -> H- OFFANS: H -> L- CTOSYS: UART- SYSTOC: UART- CPUWDT: L- BATFAULT: L
Notes:All siganl mentioned above are controlkey signal from System u-com (AVunit) to NAVI unit.The "H" voltage is different depends onthe location. - Port of system u-com: 5 V - Connector of AV unit: 3 V
YES
No Display(White or Gray screen)
YES
NO
(No output)
NO
YES
- FLOWCHART
AVIC-F900BT/XS/EW5 655 6 7 8
C
D
F
A
B
E
1 2 3 4
LCD BD Side ANAVI BD Side BNAVI BD Side A
Case 1 System can not wake-up.
ACC ON ACC OFFPin27: NAVI33V High High This power supply is from NAVI BD to AV BD.Pin5: OFFINFO High Low This signal is from AV BD(system-ucom) to NAVI BD.Pin6: OFFANS Low High This signal is from NAVI BD to AV BD(system-ucom).
(High = 3.3 V)Pin13: SYSTOC Communication line (Sys u-com to NAVI unit)Pin14: CTOSYS Communication line (NABI unit to Sys u-com)
Pin3,5,7,9,11,13,15,17,19 ACC ON ACC OFFNAVI 5V 5V 5V power supply is from AV BD to NAVI BD.
Case 2 Navi image can not be displayed on LCD.
Pin1: TFT_ANODEPin36: LVDSN Video signal (LVDS) from NAVI to LCD BD. Pin2: TFT_ANODE2Pin37: LVDSP Video signal (LVDS) from NAVI to LCD BD. Pin6: TFT_CATHODE
Pin7: TFT_CATHODE
Power supplyfrom LCD BD to
LCD unit
05niP1niP
Pin1
Pin2
Pin19
Pin20
Pin1 Pin74
Chip resistor (0 ohm)
A B
CD
E
B
C
D
F
Pin1 Pin10
- DIAGNOSIS POINT
AVIC-F900BT/XS/EW5661 2 3 4
C
D
F
A
B
E
5 6 7 8
Case 3 Touch panel operation doesn't work
Pin1: nYPONPin2: nXPONPin3: YMONPin4: XMON
Pin29: nYPONPin30: nXPONPin31: YMONPin32: XMON
Case 4 Hard Key doesn't work
Pin8: KEY0 KEY (Push, Menu, Right) signal from KEY BD to LCD BD (DC Voltage)Pin9: KEY1 KEY (MAP, Left, Down ,Up) signal from KEY BD to LCD BD (DC Voltage)Pin11: ROT0 KEY (Rotary) signal from KEY BD to LCD BD (Pulse waveform)Pin12: ROT1 KEY (Rotary) signal from KEY BD to LCD BD (Pulse waveform)
Pin33: ROT0 KEY (Rotary) signal from KEY BD to LCD BD (Pulse waveform)Pin34: ROT1 KEY (Rotary) signal from KEY BD to LCD BD (Pulse waveform)
The signal from touch-panel to LCD BD(Wavefrom pulse can be mintored while operating touch-panel.)
The signal from LCD BD to NAVI BD(Wavefrom pulse can be mintored while operating touch-panel.)
Pin1 Pin4
Pin1 Pin74
Pin1 Pin74
05niP1niP
E
A
D
B
AVIC-F900BT/XS/EW5 675 6 7 8
C
D
F
A
B
E
1 2 3 4
Case 5 Audio (NAVI SOURCE) or Guide voice (BEEP sound) is NG.
Pin19: GUI_P Guidance or BEEP sound Pin28: NAVI L Audio Lch Pin30: NAVI R Audio RchPin29,31: GND
05niP1niPB
AVIC-F900BT/XS/EW5681 2 3 4
C
D
F
A
B
E
5 6 7 8
6. SERVICE MODE6.1 TEST MODE
1. Test mode menu selection method
The main keyboard cannot be used for this operation. Double-click the touch panel directly.
2. Test mode activation method
1. Copy a "TestMode" folder under “TestMode” folder on GGV1322 to a SD card. Note: "TestMode" folder must be on the SD card root. 2. Download a ID file from the Service Site and copy the file to the "TestMode" folder on the SD card. 3. Insert the SD card into the main unit. 4. Turn ACC ON. 5. The test mode menu is displayed.
<< Enter the test mode in the set procedure. >>
When the set procedure is followed (Procedure OK)Start screen
Jig No : GGV1322
AVIC-F900BT/XS/EW5 695 6 7 8
C
D
F
A
B
E
1 2 3 4
3. Test mode menu
No. Test Item Test Content 1 Audio Playback of audio 2 AV Test Not for service 3 TEL Test Not for service 4 GPS CHK GPS receiver test 5 GYRO Gyro test 6 Flash ROM Flash ROM read/write test 7 TMC/VICS FM multiplex error test 8 Dir CMD Not for service 9 Graphics Graphics test 10 Ver Info Display version information of software, mecha, and microcomputers. 11 Touch Correction and test of Touch Panel 12 Key Test Not for service 13 Port Test Display states such as parking and reverse. 14 Voice Test Not for service 15 Memory Not for service 16 MSN-Direct Not for service 17 USB Test Not for service 18 DTV Test Not for service 19 SD Test SD card test 20 EQ Flat/Vo Not for service 21 RGB Illumin Not for service 22 BT Test Not for service 23 Screen Not for service 24 BAK CTL Adjustment of the LCD backlight
AVIC-F900BT/XS/EW5701 2 3 4
C
D
F
A
B
E
5 6 7 8
Audio Test Screen
Gps Viewer Execution Screen
Audio Test Mode
Starttest
<< Key Operation >>[Play] • • • Play[Stop] • • • Stop[Guidance] • • • Output of guidance[Stereo] • • • Output of stereo[OK] • • • Terminate Audio Test.
<< Operation method >>1. Select ‘Start Type’. Normally, ‘Hot’. 2. Press ‘Start’ to start the test.
AVIC-F900BT/XS/EW5 715 6 7 8
C
D
F
A
B
E
1 2 3 4
Tracking
Signal
<< Operation method >>1. When GPS Running is red, press ‘hot’.
<< Operation method >>1. When GPS Running is green, the test is started.2. When Valid Position is green, the measurement is successfully conducted.
<< Operation method >>1. The screen will be in this state if the test is not started.2. To start the test, press ‘hot’.
AVIC-F900BT/XS/EW5721 2 3 4
C
D
F
A
B
E
5 6 7 8
Sats
<< Operation method >>1. The screen will be in this state if the test starts.2. When the blue color bar appears, GPS signal is locked.
<< Operation method >>1. The screen will be in this state if the test is not started.2. To start the test, refer to ‘Start test’ tab.
<< Operation method >>1. When the test starts and a satellite is started to be acquired, the screen will be in this state.Red • • • Not acquired. Yellow • • • Already acquired. Green • • • Acquired and data obtained.
AVIC-F900BT/XS/EW5 735 6 7 8
C
D
F
A
B
E
1 2 3 4
TestGyro Screen
NAND Flash test mode start screen
Write files Conduct a write test to NAND Flash disc.
Read/verify files Conduct a read test to NAND Flash disc. Notes) It will take time by test completion.
Delete Files Conduct a deletion test to NAND Flash disc.
Format disc Conduct a formatting test to NAND Flash disc. Notes) Only the test area of the Flash disc will be formatted.
Gyro-z-bias test1. Press “Start” and wait 2 seconds, then the “Gyro-z-bias” result will be displayed. The result should be within the range between - 2 and 2 degrees.
Gyro-z test1. Rotate the unit 360 degrees. (or 180 degrees) The “Gyro-z” result should be within the range of 360 +/- 14.4 degrees. (or 180 +/- 7.2 degrees)2. Press “Stop” and then press “Start” again.3. Rotate the unit -360 degrees. (or 180 degrees) The “Gyro-z” result should be within the range of -360 +/- 14.4 degrees. (or 180 +/- 7.2 degrees)
Accelerometer Testing1. Set the unit "Face Down" position to +1 g (pointing up). You will then get an “Accel-x” result2. Set the unit "Face Up" position to -1 g (pointing up). You will then get an “Accel-x” result3. Calculate the difference of the two results. The difference should be within the range of 2 +/- 0.1 g. For example, the result of step 1 is "1.045 g" and step 2 is "-0.902 g", the difference is 1.045+0.902=1.947 g.4. Set the unit "Right side up" position to +1 g (pointing up). You will get an “Accel-y” result.5. Set the unit "Right side down" position to -1 g (pointing up). You will get an “Accel-y” result.6. Calculate the difference of the two results. The difference should be within the range of 2 +/- 0.2 g.7. Set the unit "Up side down" position to +1 g (pointing up). You will get an “Accel-z” result.8. Set the unit "Normal" position to -1 g (pointing up). You will get an “Accel-z” result.9. Calculate the difference of the two results. The difference should be within the range of 2 +/- 0.2 g.
AVIC-F900BT/XS/EW5741 2 3 4
C
D
F
A
B
E
5 6 7 8
GpsTmcDemo
TMC measurement selection screen
Graphics Test start screen
<< Test Content >>The TMC error rate can be measured.The frequency can be changed by tapping ‘<’ or ‘>’.The test can be terminated by tapping the left ‘x’ mark.
Start screen
<< Operation method >>1. The screen will be in this state after started.2. Press ‘Test’ to start the test.
AVIC-F900BT/XS/EW5 755 6 7 8
C
D
F
A
B
E
1 2 3 4
<< Operation method >>1. The menu appears when ‘Test’ is pressed. Select the item to test.
<< Operation method >>1. To terminate the test, press ‘File’ and then ‘Exit’.
AVIC-F900BT/XS/EW5761 2 3 4
C
D
F
A
B
E
5 6 7 8
Version Information screen
Touch Panel Test screen
Start screen
Start screen
<< Key operation >>[Get Version] • • • Display the version of Bootloader, GPS, and BSP.
[Get Application Version] • • • Display the version of each application.
[uCOM Ver] • • • Display the microcomputer version and ROM Collection version.[Get DVD-Mecha] • • • Display the DVD and CD mecha version.[Clear] • • • Clear the display of the version of microcomputer, ROM, and mecha.
[GetDeviceID] • • • Display the device ID.
<< Key operation >>[Calibration] • • • Conduct calibration.[Touch panel test] • • • Conduct touch panel test.
AVIC-F900BT/XS/EW5 775 6 7 8
C
D
F
A
B
E
1 2 3 4
Calibration
Touch Panel Test
<< Key operation >>Touch panel calibration can be conducted by tapping five ‘+’ marks.
<< Key operation >>A line appears when a line is drawn by a finger on the touch panel.The test can be terminated by pressing the top right ‘x’ mark.
AVIC-F900BT/XS/EW5781 2 3 4
C
D
F
A
B
E
5 6 7 8
Port Test screen
SD Card Test screen
Start screen
Start screen
<< Key operation >>[Start] • • • Start the test.
<< Key operation >>[Get signal] • • • Display the states of Parking brake, Reverse, K-Mode, and Speed Pulse.The states of Illumination, Cellular mute, OPTSNS, Antenna control, and Remote control are displayed automatically.
[Clear] • • • Clear the display.
[High] • • • Not for service[Low] • • • Not for service
AVIC-F900BT/XS/EW5 795 6 7 8
C
D
F
A
B
E
1 2 3 4
Backlight Test screen
Error screen
Start screen
<< Key operation >>[Backlight Off] • • • The backlight turns off. Notes) No operation can be conducted after this operation. Make a recovery by turning ACC OFF ON.[Backlight on] • • • The backlight turns on.[Set] • • • The brightness of the backlight can be changed.
This is the state when an error occurred in the test.
AVIC-F900BT/XS/EW5801 2 3 4
C
D
F
A
B
E
5 6 7 8
<< Key operation >>3. When the keyboard appears, tap the edit box again to make it active. Then input by keyboard becomes possible.
Enter a desired number and tap ‘Set’ to change the brightness of the backlight.
Backlight Level setting method
<< Key operation >>1. Tap the edit box at the left of the Set button to make it active.2. Then, tap the bottom left of the screen, and the screen will be as shown below. Tap ‘Keyboard’.
AVIC-F900BT/XS/EW5 815 6 7 8
C
D
F
A
B
E
1 2 3 4
6.2 DVD TEST MODE
WMM-14-23-01 E RE UC AU J CN PKB
(1), (2) and (3) are invisible buttons
In this screen, press long the areas (1), (2) and (3) that display the test mode selection screen by implementing the operations below in order.
Detailed procedureStep1 change the screen to source OFF screenStep2 press the area of (1) longStep3 press the area of (2) longStep4 press the area of (3) long
* When the operation above is normally implemented, BEEP sound 1 is output.
If the operation is completed successfully, the screen shifts to test mode screen after (3) is pressed long
The test mode is released by ACC-OFF operation.
Source PlateOFF
SlaveTestMode
DVD(CD) region display
DVD(CD) debug display
DVD(CD) touch direct display
Back
Shift to selected test mode.
Map
AVIC-F900BT/XS/EW5821 2 3 4
C
D
F
A
B
E
5 6 7 8
Image of the test mode.
[Note] Higher level 4 characters only. Lower level 4 characters are spaces.
(1) (2)
Start of the test mode.
TEST
FE test selection EDC1 test selection
Hereafter, to FE test mode image.
Hereafter, to EDC1 test mode image.
[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.
(3)
EDC2 test selection
Hereafter, to EDC2 test mode image.
(4)
LD power on time mode selection
Hereafter, to LD power on time mode image.
Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
Image of the front end test mode.
(2)
FE test mode
Disc type DVD1 layer
FE offset coefficientTE offset coefficientAS offset coefficientENV offset coefficientTG offset coefficientDBAL coefficientVIN1 offset cancel valueVIN2 offset cancel valueVIN3 offset cancel valueVIN4 offset cancel valueVIN5 offset cancel valueVIN6 offset cancel valueVIN7 offset cancel valueVIN8 offset cancel valueVIN9 offset cancel valueVIN10 offset cancel value
Power on
0000 00000FFF 0000
0 x 00 0000
Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
(4) (5)
Disc type DVD2 layer
Disc type CD
0100 0000 0200 0000
Disc type CD-RW
0300 0000
EJECT
EJECT
[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically. If F close is selected during LD-OFF, it will become an error.During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again before F close.
FEMAX levelFEMIN levelASMAX levelENVMAX levelFE normalization coefficientSpindle gain coefficientTEMAX level indicationTEMIN level indication
(2)
Focus close state
(1) (2)
S curve measurement
(2)
F close F search
1A00 0000
F search
1100 0000
1FFF 0000
(3),(4)
CRG+/-
Activates while the key is being pressed.
1B00 0000 : CRG+1C00 0000 : CRG-
(5) (6)
LD-ON/OFF
When LO-ON: 1100 0000When LD-OFF: 1000 000
CRG_HOME
1D00 0000
(8)
Power_OFF
(1) (3)
a b
1 x 00 0000
Remote Control Assy SW
Test mode stopping procedure Reset or ACC OFF-ON.
AVIC-F900BT/XS/EW5 835 6 7 8
C
D
F
A
B
E
1 2 3 4
(2)
(1) (2)
Tracking balance
TBAL coefficient (layer 0)TBAL coefficient (layer 1)TE normalization coefficient (layer 0)TE normalization coefficient (layer 1)Off track adjustment result
Focus Jump
When L0 layer: 2000 0000When L1 layer: 2100 0000
2 x 00 0000
2FFF 0000
(3),(4)
CRG +/-
It operates while the key is being pressed.
2B00 0000 : CRG+2C00 0000 : CRG-
3000 0000
(8)
Power_OFF
(8)
Power_OFF
(5)
Performed including the tracking close processing.
FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)AS normalization adjustment value (layer 1)
RF level value
3FFF 0000
Tracking close state
(1) (2)
(1)
Error rate measurement
Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)AS normalization adjustment value (layer 1)
RF level value indication start
5000 0000
RF level is informed every 500msec.
RF level value indication end
(7) (8)
To (2)
T.OPEN Power_OFF
(1) (3),(4)
Tracking close CRG +/-
It operates while the key is being pressed.
3B00 0000 : CRG+3C00 0000 : CRG-
3FFF 0000
a b
(1) (2)
Tracking close state
Error rate measurement
FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)AS normalization adjustment value (layer 1)
Playback speed switching
4000 0000
4 x 00 0000
(5)
Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)AS normalization adjustment value (layer 1)
Focus Jump
DVDX1.3~1.6CAV
CDX4CLV:4x00 0000
When L0 layer: 4x00 0000When L1 layer: 4x00 0000
(8)
Error display
Power_OFF
Error occurrence
L0 layer DVD X 1.3~1.6CAV, CD X 4CLV :4000 0000L1 layer DVD X 1.3~1.6CAV :4100 0000
[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.
Error occurrence at Power_OFF
Error display
The number for designation of the track number shall be selected from the track numbers previously prepared.Switch to cyclic by (3). Fix by (4).For CD: Tracks 1, 4, 10, 11 and 32For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100
Change the method for ID address designation.Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).
The higher 2 digits of the designated ID are the value showing the test state. The lower 6 digits show the ID.Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.
(7) (8)
To (2)
T.OPEN Power_OFF
(6) (3),(4)
(1)-(4) (3)
(5) (5)
ID Search T.Jump+/-
4A00 0000Jump+ : 4B00 0000Jump- : 4C00 0000
ID designation
ID display
Track number designation
Track number indication
Search start Jump start
AVIC-F900BT/XS/EW5841 2 3 4
C
D
F
A
B
E
5 6 7 8
EDC. Image of the test mode
[Note] Image is the same for both EDC1 and EDC2.
(1) (2)
EDC1/2 test mode
0000 0000
Layer 0 selection Layer 1 selection
0000 0000 0100 0000
1003 0000 1103 0000
(5)
[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.
(1)-(4)
ID designation
EDC1/2 start
Layer 0: 10** ****Layer 1: 11** ****[Note] ** **** is the ID designation value
Layer 0: 20** ****Layer 1: 21** ****[Note] ** **** is the present ID designation value
**** ****[Note] **** **** is the present ID designation value
Legend:… Key operation
… Operational state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
[Note] Eject can be effected any time during the EDC test mode.
Eject
After completion of EJECT operation
EJECT operation
Test mode Eject
Image of the LD power on time mode.
LD power on time mode
0000 0000
CD LD power on time indication
DVD LD power on time indication
10** ****[Note] ** **** is the CD LD
power on time.
20** ****[Note] ** **** is the DVD LD
power on time.
(1) (2)CD LD power on
time setting
Setting time designation
30** ****[Note] ** **** is the setting time.
Setting time registration
DVD LD power on time setting
Setting time designation
40** ****[Note] ** **** is the setting time.
(5) (6)
(1)-(4) (1)-(4)
(5) (5)
(8)
10** ****[Note] ** **** is the CD LD
power on time.
Setting time registration
(8)
20** ****[Note] ** **** is the DVD LD
power on time.
[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.
[Method of setting time designation]Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Cancel by command (8).
Legend: … Key operation
… Operational state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
Not for service use
AVIC-F900BT/XS/EW5 855 6 7 8
C
D
F
A
B
E
1 2 3 4
6.3 uBOOT MENU
UBOOT Upgrade
1. Copy the Uboot files named as “uboot.bin” and “uboot.cks” to the SD/MMC card2. Inset SD/MMC card to the Main Unit at first, then enter the Uboot interface.3. Select ““3=UBOOT Upgrade” item in Uboot menu, then select ““1=UBOOT by SD/MMC” item in “UBOOT Upgrade” menu and execute.
UBOOT Upgrade
0=WINCE Upgrade 0=UBOOT by USB1=GPS Tools 1=UBOOT by SD/MMC2=BT Tools 2=Exit3=UBOOT Upgrade Choice: 14=Memory Tools5=Other ToolsCoice: 0
<Uboot Menu> <UBOOT Upgrade Menu>
UBOOT Upgrade UBOOT Upgrade
0=UBOOT by USB 0=UBOOT by USB1=UBOOT by SD/MMC 1=UBOOT by SD/MMC2=Exit 2=ExitChoice: 1 Choice: 1
Star Erase & Write UT!!UT Upgrade OK
Star Erase & Write UT!! Please restart your device!!Read Progress : 31% Read process 100%
<UBOOT Upgrade Menu:Progress Screen> <UBOOT Upgrade Menu:Finish Screen>
4. After the menu of “UBOOT Upgrade” show “UT Upgrade OK”, restart the device.
WINCE Image Upgrade
1. Copy the image files named as “winceimg.bin” and “winceimg.cks” to the SD/MMC card.2. Inset SD/MMC card to the Main Unit at first, then enter the Uboot interface.3. Select “0=WINCE Upgrade” item in Uboot menu, then select “1=WINCE bySD/MMC” item in “WINCE Upgrade” menu and execute.
WINCE Upgrade
0=WINCE Upgrade 0=WINCE by SD/MMC (Format)1=GPS Tools 1=WINCE by SD/MMC2=BT Tools 2=WINCE by USB (Format)3=UBOOT Upgrade 3=WINCE by USB4=Memory Tools 4=Exit5=Other Tools Coice: 1Coice: 0
<Uboot Menu> <WINCE Upgrade Menu>
WINCE Upgrade WINCE Upgrade
0=WINCE by SD/MMC (Format) 0=WINCE by SD/MMC (Format)1=WINCE by SD/MMC 1=WINCE by SD/MMC2=WINCE by USB (Format) 2=WINCE by USB (Format)3=WINCE by USB 3=WINCE by USB4=Exit 4=ExitCoice: 1 Coice: 1
Image RegionChecksum = 0x64463447
Read Progress : 31% CE Upgrade OKPlease restart your device!!
<WINCE Upgrade Menu:Progress Screen> <WINCE Upgrade Menu:Finish Screen>
4. After the menu of “WINCE Upgrade” show “CE Upgrade OK”, restart the device.
AVIC-F900BT/XS/EW5861 2 3 4
C
D
F
A
B
E
5 6 7 8
6.4 USING THE TEST DISC
Test Disc 1 Start Screen Specification
Test Disc 1 Start
1. Copy all files under “Test Disc1” folder on GGV1322 to a SD card. 2. Download a ID file from the Service Site and copy the file to the SD card. 3. Insert the SD card into the Main Unit and turn ACC OFF ON. Then, the test disc starts. The test can be terminated by turning ACC OFF. After turning ACC OFF, remove the SD card.
Test Disc 1 Start Screen
MIC Test
<< Operation method >>1. This screen appears when the Test Disc is activated.2. Tap ‘E-MIC’ to start the test.
<< Operation method >>1. This screen appears when the test is started.2. Put a sound into the microphone while this screen is shown. The sound is recorded.
Jig No : GGV1322
AVIC-F900BT/XS/EW5 875 6 7 8
C
D
F
A
B
E
1 2 3 4
<< Operation method >>1. When this screen appears, the recorded sound is played ‘loudly’.Notes) The sound volume cannot be adjusted.
<< Operation method >>1. When this screen appears, the recorded sound is played ‘quietly’.Notes) The sound volume cannot be adjusted.
<< Operation method >>1. When this screen appears, the recorded sound is muted.Notes) The sound volume cannot be adjusted.
AVIC-F900BT/XS/EW5881 2 3 4
C
D
F
A
B
E
5 6 7 8
<< Operation method >>1. When the test finishes, this screen appears.2. To proceed to the next test, tap ‘OK’. To conduct MIC Test again, tap ‘Retry’.
<< Operation method>>1. This screen appears when the Test Disc is activated.If you tap "GPS_TTFF", the test is started.
GPS Test
<< Operation method >>1. When the test is started, this screen is displayed.When you terminate the test in the way, tap the "Exit".
AVIC-F900BT/XS/EW5 895 6 7 8
C
D
F
A
B
E
1 2 3 4
<< Operation method >>When the positioning is terminated within one minute, the test is completed successfully, and this screen is displayed.If you implement the test again, tap the "Retry".If you go to next step, tap "OK".
Version Check
<< Operation method >>1. This screen appears when the Test Disc is activated. 2. When ‘Version’ is tapped, the test starts. If the "Reality" corresponds to "Plan", the result becomes "OK".
AVIC-F900BT/XS/EW5901 2 3 4
C
D
F
A
B
E
5 6 7 8
<< Operation method >>If the test result is "OK", the blue screen is displayed."Reality" is each version on actual machine and the "Plan" is the version information described in "Information.txt" of SD card.
<< Operation method >>If the test result is "NG", the red screen is displayed.
AVIC-F900BT/XS/EW5 915 6 7 8
C
D
F
A
B
E
1 2 3 4
Test Disc 2 Start Screen Specification
Test Disc 2 Start
1. Copy all files under “Test Disc 2” folder on GGV1322 to a SD card. 2. Download a ID file from the Service Site and copy the file to the SD card. 3. Insert the SD card into the Main Unit and turn ACC OFF ON. Then, the test disc starts.
The test can be terminated by turning ACC OFF. After turning ACC OFF, remove the SD card.
Test Disc 2 Start Screen
The user data is deleted
<< Operation method >>1. This screen appears when the Test Disc is activated.2. If you tap the "Restore", the user data is deleted.
<< Operation method >>If the deletion is terminated, this screen is displayed.
Jig No : GGV1322
Notes:) "Splash screen setting" is not back to default after performing this function. Please set the "Splash screen setting", before performing this function.
AVIC-F900BT/XS/EW5921 2 3 4
C
D
F
A
B
E
5 6 7 8
7. DISASSEMBLY
1 1 1
Fig.1
Removing the Case (Fig.1)
Remove the two screws and then removethe Case.
Note)To remove the screws, use jig No. GGK1068.
Case
NOTE) While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
21
2
1
1
1
1
2
Fig.2
Remove the four screws.
Disconnect the two connectors and thenremove the DVD Mechanism Module.
Removing the DVD Mechanism Module (Fig.2)
DVD Mechanism Module
AVIC-F900BT/XS/EW5 935 6 7 8
C
D
F
A
B
E
1 2 3 4
1
21 2
1
1
112
2
Fig.4
Remove the five screws.
Disconnect the four connectors and thenremove the Navi Unit.
Removing the Navi Unit (Fig.4)Navi Unit
1
2
3
(Right side)
2
1
1
1
3
2
33
1
1
1
(Top side)
(Left side)
Fig.3
Removing the Monitor Assy (Fig.3)
Remove the six screws.
Release the two latches.
Disconnect the three connectors and thenremove the Monitor Assy.
Monitor Assy
Monitor Assy
Monitor Assy
2
AVIC-F900BT/XS/EW5941 2 3 4
C
D
F
A
B
E
5 6 7 8
1
2
3
Remove the screw.
Remove the six screws and then removethe AV Unit.
5
6
4
6
6
2
6
5
2
4
66
2
2
3
22
1 1
2
4 4
6
(Right side)
(Left side)
Fig.5
Remove the two screws.
Remove the seven screws.
Disconnect the connector and thenremove the Heat Sink.
Remove the three screws and thenremove the Chassis(Upper).
Removing the AV Unit (Fig.5)
AV Unit
Chassis(upper)
Chassis(Upper)
Heat Sink
Remove the FFC(CDE8550).
Remove the FFC(CDE8551).
Remove the cord assy(CDE8393).
Remove the cord assy(CDH1381).
AVIC-F900BT/XS/EW5 955 6 7 8
C
D
F
A
B
E
1 2 3 4
1
2
3
1
2
3
1
3 3
3
22
3 3
2 2 2
2
2
SD Unit
3
2
3
3
3
1
1
12
1
Fig.6
Fig.7
Removing the Panel Unit (Fig.6)
Removing the Keyboard Unit (Fig.7)
Panel Unit
LCD Module Assy
Keyboard Unit
Remove the four screws.
Release the five latches and then removethe LCD Module Assy.
Remove the four screws and then removethe Keyboard Unit.
Remove the screw and connectorand then remove the SD Unit.
Disconnect the four connectors.
Remove the five screws and then removethe Panel Unit.
1
AVIC-F900BT/XS/EW5961 2 3 4
C
D
F
A
B
E
5 6 7 8
- How to hold the mechanism section (Fig 1)1. Hold the main frame and the top frame.2. As the mechanical strength of the front part of the top frame is not strong, do not hold this part.3. Do not touch the switches provided on the top face of the mechanism section.4. Be careful not to pull the flexible PCB on the side face.
Fig 1
Do not touch this part. Do not touch this part.
Do not touch this part.
- How to remove the module PCB (Fig 2, Fig 3)1. Put the mechanism section in locked state (disc load standby position).2. Hold the mechanism module with its top face down.3. Make the lands at 2 locations on the pick up flexible PCB short.4. Disconnect the connectors of the pick up flexible PCB and the SPDL flexible PCB. (Be sure to disconnect the connectors as the flexible PCB will be damaged if the PCB is removed without removing the flexible PCB.)5. Remove the solder joint of the lead wire of the load motor and the clamp SW.6. Remove the two screws, and then remove the module PCB. (Lift up point A slightly and remove it toward B direction. Be careful as the point C is connected with a flexible PCB.)7. Disconnect the connector of the 8-12 detection flexible PCB from the PCB.
Solder land (load motor, lead wire of the clamp SW.)
Connector (8-12 detection flexible)
Module PCB
Fig 3Connector (SPDL flexible)
Connector (pick up flexible)
C
B
A
Fig 2
Short
AVIC-F900BT/XS/EW5 975 6 7 8
C
D
F
A
B
E
1 2 3 4
- How to remove the CRG motor assy (Fig 4)1. Remove the module PCB according to the instructions in “How to remove the module PCB”.2. Remove the Mylar tape.3. Remove the flexible PCB of the CRG motor from the connector of the spindle motor.4. Remove the two screws, and then remove the CRG motor assy.
Feeding screw
PU rack
Set screw (CRG) Set screw (CRG)CRG motor assy
Mylar tape
Fig 4
- How to remove the PU unit (Fig 5)1. Remove the module PCB according to the instructions in “How to remove the module PCB”.2. Hang the main shaft holding spring to the CRG chassis temporary hanger.3. Remove the CRG motor assy according to the instructions in “How to remove the CRG motor assy”.4. Remove the holding plate spring of the main shaft.5. While lifting up the tip of the pick up rack, slide the main shaft, and remove the PU unit.
(Note) When mounting the PU unit again, make sure to do the adjustments of the devices mounted thereon according to the descriptions of the service manual. Furthermore, make sure to hang the main shaft holding spring permanently.
PU unit
Sub shaft
Main shaft
Fig 5
Permanent hangingTemporary hanging
CRG chassis temporary hanging section
Main shaft holding spring
Holding plate spring
AVIC-F900BT/XS/EW5981 2 3 4
C
D
F
A
B
E
5 6 7 8
• Notes on disassembly
• When separating the MONITOR ASSY from the MAIN UNIT ASSY, do so slowly. Two FFCs (CDE8554, CDE8556) and one CODE ASSY (CDE8559) are connected. The strength of the joint part of the code and terminals of CDE8559 (CODE ASSY for Bluetooth to connect the keyboard unit and navi unit) is weak, it may break or the code may extend.
Remove after peeling off the tape of CDE8556 and the shield.
• When demounting LCD PANEL ASSY from the grille, be careful not to bend LCD plate (CND4319) as there are snap fits on the right and left. Demount LCD PANEL ASSY by extending snap fits on the grille side.
CDE8559
Snap fit2 place
Do not bend CND4319
Remove snap fits by extending them on the grille side using tweezers or bamboo tweezers.
Do not bend CND4319
Actually does the CODE ASSY (CDE8559) to a left connector of a round inclosing. *
AVIC-F900BT/XS/EW5 995 6 7 8
C
D
F
A
B
E
1 2 3 4
• Be sure to remove the MONITOR ASSY after removing the DVD mecha. If the procedure is done oppositely, the FFC (CDE8556) connecting the MONITOR ASSY and the MAIN UNIT ASSY will be damaged. At assembly, be sure to fix the MONITOR ASSY first and then fix the DVD mecha. If it is done oppositely, the FFC (CDE8556) cannot be folded as intended under the DVD mecha.
• When connecting the code assy connecting 1F AV UNIT and 2F NAVI UNIT (CDH1381) on NAVI UNIT side, do so as shown below.
• The code assy connecting 1F AV UNIT and 2F NAVI UNIT (CDE8393) shall be fitted on the back side of the choke coil (CTH1347) after 1F Chassis Unit and 2F Chassis Unit are fixed, as shown below.
CDE8556
OKHorizontal
NGVertical
CDE8393
CTH1347
AVIC-F900BT/XS/EW51001 2 3 4
C
D
F
A
B
E
5 6 7 8
• When mounting KNOB ASSY (CXC8994) in the MONITOR ASSY, be careful to don't destroy encoder part.
• Since two case (CNB3472) fixing screws are ‘TORX tamper’ (tamper-proof screws with a projection in TORX), a special tool is required.TORX screwdriver(T8) : GGK1068
CSX1135 shaft of an encoder CXC8994
Mark 1 (T8 size)
M2.6 thread
AVIC-F900BT/XS/EW5 1015 6 7 8
C
D
F
A
B
E
1 2 3 4
8. EACH SETTING AND ADJUSTMENT8.1 DVD ADJUSTMENT
1) PrecautionsThis product uses 5 V and 3.3 V as standard voltages.The electrical potential that is the reference for signals,is not GND, but VREF (approximately 2.2 V) and VHALF(approximately 1.65 V).During product adjustments, if the reference voltage ismistakenly taken as GND, and a grounding contact ismade, not only would it be impossible to measure theaccurate electrical potential, but also the servo motorwould malfunction, resulting in the application of astrong impact on the pick up. The following precaution-ary measures should be strictly adhered to, in order toavoid such problems.The reference voltage and GND should not be confusedwhen using the minus probe of a measurement device.When an oscilloscope is being used special care shouldbe taken to make sure that the reference voltage is notconnected to the probe of ch1 (on the minus side),while the probe of ch2 (on the minus side), is connectedto GND. Further, since the body frame of most mea-surement devices have the same electrical potential asthe minus side of the probe, the body frame of the mea-surement device should be set to floating ground.
If the reference voltage is connected to GND by mis-take, turn the regulator OFF immediately, or turn thepower OFF.
Remove the filters and wires used for measurementsonly after the regulator has been turned OFF.For stable circuit operation, keep the mechanismoperating for about one minute or more after theregulator is turned on.
Whenever the product is in the test mode, the softwarewill not take any protective action. For this reason,special care should be taken to make sure that nomechanical or electrical shock could be applied to theproduct when taking measurements in the test mode.Whenever the EJECT key is pressed to eject the disk,no other keys, other than the EJECT key, should bepressed until the disk eject action has been complet-ed.If the product hangs up turn the power OFF immedi-ately. Laser didoes may be damaged, if the volume switch forthe laser power adjustment of the pick up unit, is turned.
Attention)Test mode stopping procedure Reset or ACC OFF-ON.
AVIC-F900BT/XS/EW51021 2 3 4
C
D
F
A
B
E
5 6 7 8
- SKEW adjustment
When one of the following replacements has taken place, SKEW adjustment for the pick up will be required.(1) Replacement of the pick up unit(2) Replacement of the spindle motor(3) Replacement of the carriage chassis(4) Replacement of the main shaft of the pick up unit(5) Replacement of the sub shaft of the pick up unit
Measurement equipment and tools/jigs: OscilloscopeDriver for SKEW adjustment t TORX driver (T2) (GGK1095)Bond for fixing the SKEW (GEM1033)Bond for locking the screw (Locking agents(1401M : produced by THREE BOND))
Disc used: GGV1025
Measurement reference: AGND2 Measurement point: RF
Connection drawingDVD core unit
Enlargement
Symptom in case the adjustment is not adequate: Worsening of the error rate 10(Normally 10 or less.)Large RF jitterRF waveform distortionTracking drawing/Unstable servo
* Caution: Do not look into the laser light during adjustment.
Oscilloscope
RF
AGND2
-4
-3
AVIC-F900BT/XS/EW5 1035 6 7 8
C
D
F
A
B
E
1 2 3 4
There are two adjustment methods: one in which adjustment is performed monitoring RF waveform with an oscilloscopes (method 1), and another in which adjustment is performed checking the numerical value of RF level with OSD (method 2).Adjustment procedures are described below, but please refer to the section of service mode for how to start the test mode and the operation procedures therein.
Replacement of PU UnitFor replacement of PU unit, refer to "Disassembly - How to Remove PU Unit."After mounting PU unit, roughly adjust the skew screw so that the outer periphery without PU becomes horizontal to CRG chassis.
Skew adjustment screw
Adjustment Procedure:1. Connect to the jigs (refer to jig connection diagram) to enable the adjustment of pickup, and turn over DVD mechanism module. To prevent the disc from being scratched as it is turned over, first place a coin having the thickness of about 1.5 mm on the desk, and turn over and set so that the part “ ” shown in the figure comes right above the coin.
2. In case of method 1: Referring to the connection diagram, connect an oscilloscope so that RF signal can be monitored using AGND2 as the reference.
In case of method 2:There is no need for setting equipment. Please go on to step 3.
3. Turn on the power in the test mode, and load the adjustment disc (GGV1025).
Oscilloscope
RF
AGND2
AVIC-F900BT/XS/EW51041 2 3 4
C
D
F
A
B
E
5 6 7 8
4. From ServMecha , select DVD-1 layer in FE Test Mode (Front End Test Mode). (For the details of the test mode, refer to ServMecha in the test mode menu in "6. Test Mode")
5. Select Power On, and after the automatic offset adjustment is completed, move the pickup to the inner periphery (CRG-Home). After turning on LD by selecting LD ON/OFF, select Focus Close to close the focus.
6. After the automatic adjustment is completed in FE Test Focus Close screen, select T.Bal. After the automatic adjustment, select Tracking Close to close the tracking.
7. Use ID Search to perform middle periphery (ID: 100000) search to move PU to the middle periphery.
Explanation of ID SearchID: 4A000000
[Example]To search ID: 40000, select [2] Cursor Left and press [Enter] for 5 times to move the cursor to the 5th digit, and select [3] Cursor Up and press [Enter] for 4 times.When the display is changed to ID: 40000, select [5] Start ID Search and press [Enter].
* If Search operation is failed, please restart from the top menu of ServMecha in the test mode.
8. In case of method 1: Please go on to step 9. In case of method 2: Perform all automatic adjustments after Tracking Open once, and then close the tracking with the command that is available for RF display.
9. Using torx driver (T2) (GGK1095) , In case of method 1: Turn the skew adjustment screw A slightly while monitoring RF waveform level in the oscilloscope and set the level to the maximum. At the middle periphery of pickup, turn the skew adjustment screw B slightly and set the level to the maximum. At the middle periphery of pickup, turn the skew adjustment screw A slightly again and set the level to the maximum. (Adjustments should be performed in the order of A, B, A, and please make sure each adjustment is completed as the screws turned to the right.)
In case of method 2:Turn the skew adjustment screw A slightly while monitoring RF level in OSD and set the level to the maximum. At the middle periphery of pickup, turn the skew adjustment screw B slightly and set the level to the maximum.At the middle periphery of pickup, turn the skew adjustment screw A slightly again and set the level to the maximum.(Adjustments should be performed in the order of A, B, A, and please make sure each adjustment is completed as the screws turned to the right.)
A
B
A
B
AVIC-F900BT/XS/EW5 1055 6 7 8
C
D
F
A
B
E
1 2 3 4
[Criterion for Skew Adjustment OK]
(DVD) Search inner periphery (ID: 40000) and outer periphery (ID: 200000), and respective error rate should be less than 1.000E - 3. If this is not satisfied, start over from step 9. (Disc used: GGV1025)
* If the error rate does not fall within the abovementioned range by method 2, start over by method 1.
10. In FE Test Mode screen, after confirming the disc is stopped by Power OFF, eject the disc by Disc Eject.
11. Apply adhesive agent for fixing the skew, and lock the screws. Refer to the next section for the part to be adhered.
(CD) Conduct a search after moving to the home position by CRG HOME, the error rate should be less than 2.500E - 3. If this is not satisfied, start over from step 9. (Disc used: TCD-782)
SKEW adhesive locations(GEM1033) RAD-SKEW adhesive locations
Cross section of R-SKEW adhesive locations.* Caution: Make a cross link to both the resin section and the sheet metal section.
C
Adhesive application locations
Sheet metal (yoke base) section Resin (suspension support) section
PU case
Sheet metal (yoke base) section
* Caution: Make a cross link to both the case section and the sheet metal section.Adhesive application locations
TAN-SKEW adhesive locations
D & E
PU case
C
D
E
AVIC-F900BT/XS/EW51061 2 3 4
C
D
F
A
B
E
5 6 7 8
Screw locking adhesive location(1401M : produced by THREE BOND)
Screw locking adhesive locationApply the locking agent for more than half of the screw head circumference.* Caution: The locking agent shall not overflow to outside of the PU case.
Precautions in handling the PU.
* Caution: Do not touch the shaded section in the drawing below.
RF level adjustment section
Do not touch the optical parts.
Hologram (be careful for the static electricity)GRT adjustment section
Do not touch the springs.
AVIC-F900BT/XS/EW5 1075 6 7 8
C
D
F
A
B
E
1 2 3 4
8.2 AV UNIT ADJUSTMENT
- Adjustment pointAV UNIT(SIDE A)
AV UNIT(SIDE B)
VR4231
V1VG(GND)
V1V
FRV
FRG
1
CN1016AV CONNECTOR
AVIC-F900BT/XS/EW51081 2 3 4
C
D
F
A
B
E
5 6 7 8
AV
UN
ITA
DJU
ST
ME
NT
Step
Adj
ustm
ent
item
Mod
eIn
puts
igna
l(In
putt
estp
in,s
pecs
,ot
herc
ondi
tions
)
Out
puts
igna
l(M
easu
rem
ent p
oint
,wav
e pa
ttern
)M
asur
ing
inst
rum
ents
Spec
sA
djus
ting
poin
t
1V
ideo
leve
lad
just
men
tA
Vse
lect
orV
TR1
GG
V10
25Ti
tle3
chap
3 pl
ay(w
hite
100
%)
1,0
Vp-
pTo
per
form
AV
uni
t onl
yTP
DV
V (i
nput
)TP
DV
VG
(GN
D)
100I
RE
(whi
te 1
00%
)1,
0 V
p-p
(inpu
t via
75
ohm
)
Mea
sure
men
tpoi
nt:
FRV
FRG
(GN
D)
(To
mea
sure
the
AVU
nit o
nly,
conn
ect
1.4
kohm
betw
een
TPFR
Van
dFR
G.)
Osc
illosc
ope
1.00
V±
0.02
Vp-
p
Mea
sure
betw
een
the
sync
tipan
d10
0IR
E(w
ave
top)
.
Sym
ptom
sw
ithpo
orad
just
men
t.O
verl
evel
:Lu
min
ance
isto
ohi
gh.
Und
erle
vel:
Lum
inan
ceis
too
low
.
VR42
31
AVIC-F900BT/XS/EW5 1095 6 7 8
C
D
F
A
B
E
1 2 3 4
8.3 FLICKER ADJUSTMENTFL
ICK
ERA
DJU
STM
ENT
Adj
ustm
enti
tem
Mea
sure
men
tpoi
ntA
djus
tmen
t poi
ntTh
eco
nten
tsof
adju
stm
ent
Rem
arks
.langis%001
etihwtupnI
gnigA
1Le
ave
form
ore
than
30m
inut
esin
oper
atio
nm
ode.
2Fl
icke
radj
ustm
ent
Scr
een
LCV
R1
Adj
ustt
hefli
cker
leve
lto
min
imum
from
all
dire
ctio
ns.
Sig
nalf
or F
licke
radj
ustm
ent…
Sel
ect “
Gra
phic
s”
“Fl
icer
Adj
ustm
ent”
in th
e Te
st M
ode.
(In
puta
sign
alfo
r al
tern
ate
whi
te a
ndbl
ack
line.
The
lum
inan
cele
velo
fthe
inpu
tsig
nal:
50%
)
AVIC-F900BT/XS/EW51101 2 3 4
C
D
F
A
B
E
5 6 7 8
AVIC-F900BT/XS/EW5 1115 6 7 8
C
D
F
A
B
E
1 2 3 4
9. EXPLODED VIEWS AND PARTS LIST
9.1 PACKING
(1)
NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
""
AVIC-F900BT/XS/EW5
AVIC-F900BT/XS/EW51121 2 3 4
C
D
F
A
B
E
5 6 7 8
(1) PACKING SECTION PARTS LIST
(2) CONTRAST TABLEAVIC-F900BT/XS/EW5 and AVIC-F900BT/XS/RE are constructed the same except for the following:
Installation Manual
Mark No. Description Part No.
1 Polyethylene Bag CEG1401
2 Unit Box See Contrast table(2)
3 Contain Box See Contrast table(2)
4 Protector CHP3550
5 Protector CHP3551
6 Cord CDP1157
7 Cord CDE6825
8 Cord Assy CDP1091
9 Cord Assy CDP1097
10 Screw Assy See Contrast table(2)
11 Screw BMZ50P060FTC
* 12 Polyethylene Bag CEG-127
13 Screw See Contrast table(2)
14 Polyethylene Bag CEG1116
15 Sub Unit Box CHG6491
16 Connector CKX1049
17 Pen CNV8969
18 CD-ROM CPJ1262
19 Microphone Assy CPM1064
20 Clip Holder CZN5471
21 Microphone Holder CZN5472
22 Cushion CZN5473
* 23 Microphone CZX5059
24 GPS Antenna Assy CXC8574
25 Seal CNN2515
26 Water Proof Pad CZN7150
27 Sheet CZN7151
28 Panel CNS8665
29-1 Installation Manual See Contrast table(2)
* 29-2 Warranty Card CRY1265
29-3 Owner's Manual See Owner’s manual parts list(3)
* 29-4 Caution Card CRP1375
30 Attachment Assy CEA4636
Mark No. Description Part No.
Mark No. Description AVIC-F900BT/XS/EW5 AVIC-F900BT/XS/RE 2 Unit Box CHG6485 CHG6603 3 Contain Box CHL6485 CHL6603 10 Screw Assy CEA7395 CEA3797 13 Screw CMZ50P060FTC(x4) CMZ50P060FTC(x8)
29-1 Installation Manual CRD4336 CRD4337
Part No. Language
CRD4336 English, Spanish, German, French, Italian, Dutch
CRD4337 English, Russian
(3) OWNER’S MANUAL PARTS LISTAVIC-F900BT/XS/EW5 AVIC-F900BT/XS/RE
Part No. Language Part No. Language
CRB2700 English CRB2716 English
CRB2701 Spanish CRB2717 Russian
CRB2702 German CRB2718 English
CRB2703 French CRB2719 Russian
CRB2704 Italian
CRB2705 Dutch
CRB2706 English
CRB2707 Spanish
CRB2708 German
CRB2709 French
CRB2710 Italian
CRB2711 Dutch
AVIC-F900BT/XS/EW5 1135 6 7 8
C
D
F
A
B
E
1 2 3 4
9.2 EXTERIOR(1)
AVIC-F900BT/XS/EW5
C
A
B
B
C
D
DE
E
A
21%
AVIC-F900BT/XS/EW51141 2 3 4
C
D
F
A
B
E
5 6 7 8
(1) EXTERIOR(1) SECTION PARTS LIST
(2) CONTRAST TABLEAVIC-F900BT/XS/EW5 and AVIC-F900BT/XS/RE are constructed the same except for the following:
Mark No. Description Part No.
1 Screw BMZ26P050FTC
2 Screw CBA2145
3 FFC CDE8556
4 Case CNB3472
5 Card CNW1231
6 Screw BMZ26P050FTC
7 Screw BPZ20P080FTC
8 Button(MENU, MAP) CAI1705
9 Button(RESET, EJECT) CAI1706
10 Screw(M2 x 3) CBA1797
11 FFC CDE8554
12 FFC CDE8555
13 Cord Assy CDE8559
14 Cover CNN2046
15 Lighting Conductor CNV9902
16 Holder CNV9904
17 Touch Panel CSX1136
18 Jack(CN802) CKN1049
19 Connector(CN803) CKS5749
20 Connector(CN801) CKS5862
21 Antenna(ANT801) CTX1095
22 SD Unit CWX3652
23 Screw(M2 x 2) CBA1771
24 Holder CND3758
25 Holder CND3759
26 Holder CND4319
27 Insulator CNN2044
28 Insulator CNN2045
29 LCD Module CWX3611
30 Panel Unit CWX3651
31 Screw PMB20P040FTC
32 Knob Unit CXC8994
33 Spring YBL5013
34 Grille Unit See Contrast table(2)
35 Screw IMS26P040FTC
36 Holder CND3430
37 Holder CND3431
38 Screw BMZ30P060FTC
39 Screw CMZ50P060FTC
40 Label See Contrast table(2)
41 Gasket CNN2501
42 Gasket CNN2533
43 Insulator CNN2534
Mark No. Description Part No.
Mark No. Description AVIC-F900BT/XS/EW5 AVIC-F900BT/XS/RE34 Grille Unit CXC8985 CXC898640 Label CAN5448 Not used
AVIC-F900BT/XS/EW5 1155 6 7 8
C
D
F
A
B
E
1 2 3 4
9.3 EXTERIOR(2)
A
A
B
C
C
D
D
E
E
(A)
(A) GYH1031(Mylay tape)* Hold the flexible cable to the shield on the Navi Unit.
AVIC-F900BT/XS/EW51161 2 3 4
C
D
F
A
B
E
5 6 7 8
(1) EXTERIOR(2) SECTION PARTS LIST
(2) CONTRAST TABLEAVIC-F900BT/XS/EW5 and AVIC-F900BT/XS/RE are constructed the same except for the following:
Mark No. Description Part No.
1 Screw ASZ26P050FTC
2 Screw(M2 x 3) CBA2096
3 Screw BMZ26P050FTC
4 Screw BMZ26P160FTB
5 Screw(M2.6 x 12) CBA2102
6 Cord Assy CDE8393
7 FFC CDE8550
8 FFC CDE8551
9 Cord Assy CDE8557
10 Cord Assy CDE8561
11 Chassis CNA3041
12 Chassis CNA3043
13 Bracket CND3698
14 Cover CND3917
15 Bracket CND4316
16 Shield CND4317
17 Insulator CNN2042
18 Insulator CNN2043
19 Sheet CNN2294
20 Heat Sink CNR1944
21 Navi Unit(U1) See Contrast table(2)
22 DVD Mechanism Module(MS5AVCOD) CXK6631
23 Fan Motor CXM1320
24 Cord Assy See Contrast table(2)
25 Gasket CNN2529
Mark No. Description Part No.
Mark No. Description AVIC-F900BT/XS/EW5 AVIC-F900BT/XS/RE 21 Navi Unit(U1) CWX3640 CWX3650
24 Cord Assy CDH1381 Not Used
AVIC-F900BT/XS/EW5 1175 6 7 8
C
D
F
A
B
E
1 2 3 4
9.4 EXTERIOR(3)
21%
A
AVIC-F900BT/XS/EW51181 2 3 4
C
D
F
A
B
E
5 6 7 8
(1) EXTERIOR(3) SECTION PARTS LIST
(2) CONTRAST TABLEAVIC-F900BT/XS/EW5 and AVIC-F900BT/XS/RE are constructed the same except for the following:
Mark No. Description Part No.
1 AV Unit See Contrast table(2)
2 Screw BMZ26P060FTC
> 3 Fuse(10 A) CEK1208
4 Connector(CN1016) CKM1460
5 Plug(CN1005) CKM1550
6 Jack(CN1015) CKN1042
7 Connector(CN1021) See Contrast table(2)
8 Connector(CN1001) CKS4674
9 Connector(CN702) CKS5075
10 Connector(CN1000) CKS5732
11 Mini Pin Jack(CN1441) See Contrast table(2)
12 Antenna Jack(ANT1401) CKX1060
13 Holder CNC9921
14 Shield CND3004
15 Holder CND3181
16 Holder CND3693
17 Holder CND3695
18 Shield See Contrast table(2)
19 Holder See Contrast table(2)
20 Shield CND4320
21 Shield CND4563
22 Sheet CNM9805
23 FM/AM Tuner Unit(Y1461) See Contrast table(2)
24 Holder CND4324
25 Shield Unit CXC8983
26 IC(IC1007) PAL007C
27 IC(IC2801, IC2820) BA00CC0WCP-V5
28 Cord Assy CDP1091
29 Cap CNV6727
30 Cord Assy CDP1097
31 Terminal Cover CKX-003
32 Cord CDE6825
33 Cap CNS1472
34 Resistor RS1/2PMF102J
Mark No. Description Part No.
Mark No. Description AVIC-F900BT/XS/EW5 AVIC-F900BT/XS/RE 1 AV Unit CWN3169 CWN3179 7 Connector(CN1021) Not Used CKS3408 11 Mini Pin Jack(CN1441) CKX1046 Not Used 18 Shield CND3769 Not Used 19 Holder CND4315 CND4314
23 FM/AM Tuner Unit(Y1461) CWE2127 CWE2097
AVIC-F900BT/XS/EW5 1195 6 7 8
C
D
F
A
B
E
1 2 3 4
9.5 DVD MECHANISM MODULE
(A) : GEM1045
(B) : GEM1043
(C) : GEM1024
(D) : GEM1050
(C)
(A)
B
CD
E
F
F
(A)
(A)
(A)(A)
(B)
(C)
(A)
(A)
(A)
(A)
(C)(A)
(B)(A)
D
E
(B)
(A)
(C)
F
A
(D)
(A)
A
E
(B)
(B)
(B)
(C)
(C)
(A)
(A)
(B)
D
B
C
AVIC-F900BT/XS/EW51201 2 3 4
C
D
F
A
B
E
5 6 7 8
DVD MECHANISM MODULE SECTION PARTS LIST
Mark No. Description Part No.
1 DVD Core Unit YWX5005
2 Connector(CN1852) CKS4817
3 Connector(CN1101) CKS4841
4 Connector(CN1301) CKS5017
5 Connector(CN1201) CKS5043
6 Connector(CN1901) CKS5054
7 •••••
8 Screw BMZ20P020FTC
9 Screw BMZ20P025FNI
10 Screw CBA1787
11 Washer CBF1038
12 Washer CBF1064
13 Spring CBH2586
14 Spring CBH2588
15 Spring CBH2589
16 Spring CBH2590
17 Spring CBH2591
18 Spring CBH2592
19 Spring CBH2593
20 Spring CBH2596
21 Spring CBH2597
22 Spring CBL1726
23 Spring CBH2599
24 Spring CBH2600
25 Spring CBH2601
26 Spring CBH2926
27 Spring CBH2604
28 Spring CBH2605
29 Spring CBH2710
30 Spring CBH2711
31 Spring CBH2935
32 Spring CBH2890
33 Spring CBL1689
34 Spring CBH2898
35 Shaft CLA4206
36 Shaft CLA4701
37 Lever CNC9933
38 Holder CND2643
39 Frame CND2250
40 Holder CND2251
41 Holder CND3936
42 Sheet CNM6883
43 Sheet CNM8697
44 Sheet CNM9658
45 Sheet CNM9407
46 Cam CNV7156
47 Clamper CNV7158
48 Roller CNV7165
49 Rack CNV7175
50 Damper CNV9061
51 Damper CNV9062
52 Collar CNV8845
53 Lever CNV8865
54 Rack CNV9063
55 Arm CNV8867
56 Arm CNV8868
57 Arm CNV9577
58 Arm CNV8870
59 Arm CNV8871
60 Arm CNV8872
61 Arm CNV8873
62 Gear CNV8874
63 Gear CNV8875
64 Gear CNV8876
65 Gear CNV8877
66 Gear CNV8878
67 Gear CNV8879
68 Lever CNV8903
69 Lever CNV8904
70 Roller CNV8905
71 Lever CNV8908
72 Arm CNV8909
73 Guide CNV9569
74 Arm CNV9116
75 Arm CNV9117
76 Compound Unit(A) CWX3154
77 Compound Unit(B) CWX3394
* 78 Arm Unit CXC7872
79 Frame Unit CXC6442
80 Bracket Unit CXB8685
81 Chassis Unit CXC6443
82 Motor Unit(LOAD)(M1) CXC4912
83 Motor(STEPPING)(M2) CXM1364
84 Arm Unit CXC5486
85 Roller Unit CXC5708
86 Motor(SPDL)(M3) CXM1362
87 Screw JFZ20P018FTC
88 Washer YE20FTC
89 Pickup Unit(Service) CXX2118
90 Screw IMS20P030FTC
91 Collar CNV9570
92 Shaft CLA4771
Mark No. Description Part No.
AVIC-F900BT/XS/EW5 1215 6 7 8
C
D
F
A
B
E
AV
2RS
AS
EN
S
SR
CM
UT
E
NA
VI3
V
AV8
AV
8C
2844
R08
2
D2802RB060L-40
DTC11Q2841
SR
CM
UT
E
AS
EN
S
D2821RB060L-40
AV
2RS
CN
20C
2843
R01
R28
34
R2852
20K
D2831RR264M-400
R28
23
1M
1S
NA
VI3
V
DA
AV8
AV
8V
6.5
V
5.0V
8.3V
1 2 3 4
10. SCHEMATIC DIAGRAM10.1 AV UNIT(PS/IF SECTION)(GUIDE PAGE)
A-a A-b
A-a A-b
A-bA-a
Large sizeSCH diagram
Guide page
Detailed page
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".
1/6A
A-a 1/6
GUIDE
CPUWDT3
SY
ST
OC
3
ROT1
OPTSNS
OPTON
OFFINFO3
SY
ST
OC
V3
OFFANS3
RO
T1
RE
SE
TB
HD
RS
T
DV
EJK
Y
RO
T0
BA
TF
AU
LT3
AV2RG
AV2RS
RESETB
NAVIAR
HDRST
AV2LS
DVEJKY
CT
OS
YS
3
OF
FA
NS
3
OP
TS
NS
KMODEOUT
OF
FIN
FO
3
CP
UW
DT
3
REVSNS
OP
TO
N
CT
OS
YS
V3
PULSE
PKBOUT
PU
LSE
ILMR
ILMG
ILMB
ILMV
FRV
ROT0
AV2VIN
AV2VG
AV2LG
NAVIAL
MONVBS
GUIDEMUTE
VIC
SO
N
SR
EM
OT
E
SY
SP
W
CTOSYSV3
SYSTOCV3
SYSTOC3
CTOSYS3
AN
TO
N
PCHNG
NAVIRG
NAVILG
FRVGND
GUIDEG
ILM
SN
S
TU
3
VID
EO
5
FANV
NAVI3V
BATFAULT3
VT
6
DC
SK
IPC
D
VT8
NAVI5V
AV
8
AV
8
SWACPW
NFCONT
NF
CO
NT
C28
04R
1
C28
11R
1
SY
SP
W
TU
3
BA
TF
AU
LT3
NAVI5GND
IC1002NJM2904M 5
67
C10
22R
1
100/
16C
2810
ILMGND
GNDV
CT
OS
YS
V3
GNDD
Q28102SD1760F5
R28
01
10K
C2842
R1
GNDD
GNDA
C2841
R001
GN
DF
M
GU
IDE
G
RO
T0
DTC114WKQ2840
SY
ST
OC
3
C28
40
R1
R2940 0R0
GN
DR
F
FANGND
100/
16
C28
01
C10
21R
001
C10
20R
001
NAVIRG
RO
T1
GNDFM
R28
0410
0K
NA
VIR
G OP
TS
NS
TU3
100/
16C28
20
HD
RS
T
100/
16C
2830
L1004
FANGND
AV
8
AV8
FANGND
DTC114EUA
Q2812
C28
21R
01
GN
DD
BA00CC0WCP-V5IC2801
Vadj:1.225V
1C
TL
2V
CC
3G
ND
4V
OU
T
5A
DJ
D28
10
UD
ZS
5R6(
B)
VID
EO
5
R28
11
470
BA00CC0WCP-V5IC2820
Vadj:1.225V
1C
TL
2V
CC
3G
ND
4V
OU
T
5A
DJ
SR
EM
OT
E
GNDV
SW
AC
PW
GN
DA
C28
12R
1
GNDRF
SY
ST
OC
V3
GNDV
NAVI5GND
GNDD
NAVI5V
AN
TO
N
GNDD
FA
NG
ND
R28
03
2R2K
C28
31R
01
OF
FA
NS
3
D28
401S
S35
5
FANGND
IC1002NJM2904M
34
21 8
NA
VIL
G
R2946
OP
TO
N
VIC
SO
N
DV
EJK
Y
FRVGND
GNDA
CP
UW
DT
3
NAVI5GND
C28
02R
001
GN
DA
NAVI3GND
VI5
R28
02
2R7K
CN1000
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50L2940
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
C28
33
R1
FR
VG
ND
CT
OS
YS
3
GN
DV
GNDD
GUIDEG
ILM
GN
D AV
8
RE
SE
TB
GN
DD
NA
VI3
GN
D
C28
23
R1
GNDD
GNDA
R28
100R
0
DTA114EUAQ2811
ILM
SN
S
VT
6
OF
FIN
FO
3
VT8
GNDD
R28
32
2R2K
R28
22
2R2K
FANV
ILG
EJT
RES
ILMB
ILMG
ILMR
ILMV
AUR
AURG
AUL
AULG
AUVG
AUV
ROT1
ROTO
NARG
NAR
NALG
NAL
N33V
FRG
FRV
BCGN
BCVN
GMUTE
GUIG
GUI
GSY1
CTSV
STCV
GSY2
CTN
STC
GSY3
OPON
OPSN
PKN
KMB
RVN
OFAN
OFIN
WDOG
RESB
PCHG
PLN
R2947
R2945
R2944
R2943
R2948
R2949
R2950
R2951 0R0
R2952 0R0
R2953 0R0
R2954 0R0
R2960 0R0
R2961 0R0
R2962 0R0
R2963 0R0
R2964 0R0
R2967 0R0
R2968 0R0
R2969 0R0
R2970 0R0
R2971 0R0
R2972 0R0
R2973 0R0
R2974 0R0
R2975 0R0
R2976 0R0
R2977 0R0
R2978 0R0
R2979 0R0
R2980 0R0
R2981 0R0
R2982 0R0
R2983 0R0
R2959 0R0
NC1
NFC
R2941 100
R2942 100
BFA R1016 0R0
R28
41
47K
R2840
100K
R28
42
56K
R2843
51K
R2844
100K
R284551K
R284651K
R28
481KR
28471K
R28
49
560K
R28
50
2K
R28
518R
2K
R28
202R
2KR
2821
10K
BA00BC0WFPIC2830
1V
C2
VIN
3G
ND
4V
DD
5C
R28
303R
6KR
2831
100
GNDD
VICS8VISC8
DC
SK
IPC
DD
2824
1SR
154-
400
D28
23
1SR
154-
400
GN
R2833 0R0
C2805R1
C2800R001
FU2900
CEK1276
250mA
NF
CO
NT
8.3V
VT8GND
ILMGND
EJECT
RESET
ILMB
ILMGILMG
ILMR
ILMV(LEDSW)
NC
AUX-R
AUX-RG
AUX-L
ROT1
AUX-VG
AUX-LG
AUX-V
GND
NaviARG
ROT0
BATTERY_FAULT
BCVGND
OPTSNS
GNDSYS
GNDSYS
GUIDE
PKB
GNDSYS
CTOSYSV3
FRVGND
SYSTOCV3
GUIDEMUTE
OPTON
GUIDEG
BCV
FRV
PULSE
OFFINFO
OFFANS
KMODE
WDOG
RESETB
PCHNG
REV
NaviAR
NaviALG
NaviAL
VIDEO5
NFCONT
NAVI33V
5.0V
SYSTOC3
CTOSYS3
NA
VI5
V
NA
VI5
V
NA
VG
ND
NA
VG
ND
FA
NV
FA
NG
ND
8.3V
3.3V
TU3
NA
VI5
V
NA
VI5
V
NA
VG
ND
NA
VG
ND
AV
8V G
ND
NA
VI5
V
NA
VI5
V
NA
VI5
V
NA
VI5
V
NA
VG
ND
NA
VG
ND
NA
VG
ND
NA
VG
ND
to NAVI UNITSPJ1
SPEED PULSE
8.3V
8.0V8.0V
6.5V
6.5V
3.3V
8.0V
8.3V
5.05.0V
8.3V
V0.5V0.5 5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
8.3V
5.0V
8.3V
8.3V
8.3V
5.0V
EW5
ILMGNDNAVILG
to NAVI UNITOTJ1
>
3/6A
2/6A
3/6A
6/6A
4/6A
Decimal points for resistorand capacitor fixed valuesare expressed as :2.2 t 2R20.022 t R022
Symbol indicates a resistor.No differentiation is made between chip resistors anddiscrete resistors.
NOTE :
Symbol indicates a capacitor.No differentiation is made between chip capacitors anddiscrete capacitors.
AVIC-F900BT/XS/EW51221 2 3 4
C
D
F
A
B
E
VIC
SO
N
SR
EM
OT
E
SY
SP
W
NF
CO
NT
C28
04R
1
SY
SP
W
C
C0WCP-V5801
V
1C
TL
2V
CC
GN
D
P-V5
1C
TL
VC
C
SR
EM
OT
ED
2840
1SS
355
VIC
SO
N
14 15 16 17
C28
33
R1
C28
23
R1
R28
49
560K
R28
50
2K
P
1V
C2
NF
CO
NT
NA
VI5
V
NA
VI5
V
NA
VG
ND
NA
VG
ND
5.0V
5.0V
5 6 7 8
1/6A
A-b 1/6
RR
RR+
PKB
FL+
ASENS
FR-
ILMSNS
ANTON
SR
CM
UT
E
FR+
SR
EM
OT
E
REVSNS
FANUP
SREMOTE
OFFMUTE
SPEED
RL-
FR
FL-
FL
BREMOTE
RL+
RL
RR-
SPEED
PCHNG
AV
2RS
AS
EN
S
AN
TO
N
SR
CM
UT
E
GU
IDE
MU
TE
MO
NV
BS
NA
VIL
G
AV
2RG
NA
VIR
G
AV
2LG
AV
2VG
AV
2LS
AV
2VIN
NA
VIA
R
NA
VIA
L
GU
IDE
GU
IDE
G
FR
V
FR
VG
ND
RS
TM
UT
E
KM
OD
EO
UT
FA
NU
P
PK
BO
UT
PK
B
AN
TO
N
ILM
B
ILM
R
ILM
G
PO
MU
TE
BR
EM
OT
E FR
FL
RR
RL
ILM
V
RL+
FL+
FR+
FL-
RL-
SYSPW
FR-
RR+
RR-
KB
UP
SYSPW
DCSKIPCD
NA
VI3
V
AV8
AV
8
BU
P
GNDA
R28
814R
7K(1
/4W
)
BUP2
IC1007PAL007C
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
FR
Q28
63U
MD
2N
2E1
2B2
1C3
1E45
1B
62C
GNDD
ILM
G
C28
44
R08
2
GNDD
R28
73
4R7K
GND1
AN
TO
N
R29021K
(1/4W)
R29
0110
0K
R29
034R
7K(1
/4W
)
R2875
4R7K(1/4W)
D2802RB060L-40
DTC114EUAQ2880
2842
R1
C29
32
2R2
(212
5)
GN
DD
GNDD
AV
2LS
GU
IDE
MU
TE
D2862DAN202U
NA
VIR
G
GNDD
GNDD
D28
71
UD
ZS
18(B
)
GNDD
C2926
1
FR
VG
ND
DTC114EUAQ2864
R29
10
47K
33/1
0
C28
62
IC28
90T
PD
1018
F
1O
UT
2G
ND
13
GN
D2
4G
ND
35
VD
D6
IN
7G
ND
4
8G
ND
5
9G
ND
6
10D
IAG
R290047K
D28731SS355
ILM
R
L2871
C28
82
R00
1
C28
61R
1
C29
311
Q28
61U
MD
2N
2E1
2B2
1C3
1E45
1B
62C
GNDD
BU
P
C2922
1(2125)
R28
0410
0K
KM
OD
EO
UT
GNDD
C2925
1
AV
2LG
Q28
60U
MD
2N
2E1
2B2
1C3
1E45
1B
62C
D2860MA111
GNDD
FA
NU
P
GNDD
47/1
6C
2860
DTC114EUAQ2841
KB1
IL1
GNDD
SR
CM
UT
E
L2930
KB
UP
L2870
C29
01R
1
CN1005
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
1000
0/16
C29
10
3300
/16
C29
35
NA
VIA
L
VD
D5
AS
EN
S
NA
VIA
R
C28
72
R00
1
C28
90R
1
RS
TM
UT
E
ILM
V
MO
NV
BS
FR
V
C29
24
R1
DTC124EUAQ2865
C2921
1(2125)
C2923
1(2125)
GNDD
AV
2VG
L2872
D2863DAN202U
D2821RB060L-40
NA
VIL
G
ILM
B
C28
71
R00
1
C2920
1(2125)
D2900
HZU8R2(B1)
R2870
47K
MUT
GU
IDE
R2874
1K(1/4W)
ISN
GNDD
BR
EM
OT
E
PK
B
PK
BO
UT
D2910KS926S2
FL
AV
2RG
Q28
702S
C41
16
Q28
62
2SC
4081
C28
81 1
C28
92R
001
AV
2RS
D2861UDZS8R2(B)
AN
TO
N
GNDD
R2880
10K
R2872
1K
AV
2VIN
C28
91R
001
D2890
1SR154-400
C2927
1
D28
911S
R15
4-40
0
R2865
1K(1/10W)
100/
25C
2929
C29
33
2R2
(321
6)
R28821K
(1/4W)
RR
D28
72
UD
ZS
18(B
)
R28
71
100K
PO
MU
TE
D28
74
PT
Z18
A
R29
2510
K
C2928
1
CN1001
18 19 20
RL
R29
2410
K
D28801SR154-400
GU
IDE
G
R2926
10K
C28
43R
01
D2870
UDZS5R1(B)
C28
70
R00
1
BUP1
GND2
C29
30R
1
10/1
6C
2934
Q29002SC4116
D29
30
ST
70-2
7F
1000
0/16
C29
11
1000
0/16
C29
12
DTC114EUA
Q2881
2SA1576AQ2882
R28
34
100K
D29
11
RB
060L
-40
R29
12
4R7
R29
13
4R7
D2912KS926S2
GNDDN
KB
UP
R29
11
47K
GNDD
AC2
KB2
RV2
MUB
ACC
AANT
ILM
REV
PLS
PKB
RL-
FL-
RL+
FL+
RR-
FR-
RR+
FR+
SW
VD
D5
R2860
390
R2861
390
R2863
22K
R28
62
47K
R28
64
10K
R2868
220
R28
66
10K
R28
67
10K
R2869
100
R28
518R
2K
R2852
20K
R28
53
33K
R2884
4R7K
R28
83
4R7K
D28
22
DA
N20
2U
D2831RR264M-400
R28
23
1M
NA
VIC
D2825
1SS400G
NA
VI3
V
MTB
GNDA
R2920 0R0
R2921 0R0
R2922 0R0
R2923 0R0
R4816
0R0
PWR AMP
ILM
AANT
ACC
GND
IN4
S-GND
REV
IN2
PKB
PW.GND1
IN1
PW.GND2
TAB
PW.GND4
PW.GND3
VCC1/2
OUT2+
STBY
Vehicle I/F
OUT2-
OUT4-
MUTE
OUT4+
VCC3/4
OUT3-
OUT3+
SVR
OUT1+
OUT1-
PULSE
B_REMOTE
AC GND
IN3
AV8
BUP
AANT
sensing "low voltage"or "reset"
emergency MUTE
NA
VI5
V
AV
8V G
ND
AV
8V
1/4W
1/4W
RL+
FL+
RR-
FR-
RL-
RR+
FL-
FR+
AV SECTION
ASENS
ILMSNS
REVSNS
SPEED
PKB
6.5V
14.4V
14.4V
14.4
V
5.0V
5.0V
5.0V
5.0V
5.0V
V3.8V3.8
8.3V
5.0V
600uH
RE
GNDRF GNDRF
2/6A 6/6A5/6A
6/6A
6/6A AV UNIT(PS/IF SECTION)1/6A
The > mark found on some component parts indicatesthe importance of the safety factor of the part.Therefore, when replacing, be sure to use parts ofidentical designation.
R4811
0R0
GNDRF
EW5
GNDRF
AVIC-F900BT/XS/EW5 1235 6 7 8
C
D
F
A
B
E
SP
EE
D1
D28
731S
S35
5
L287
0
2510K
2410K00
PW
R A
MP
TA
B
1 2 3 4
A-a
A-b
A-b 1/6
AS
EN
S
ILM
SN
S
AN
TO
N
RE
VS
NS
FA
NU
P
RL+
FL+
FR
+
FL-
RL-
FR
-
RR
+
RR
-
KBUP
DC
SK
IPC
D
BUP
R28814R7K
(1/4W)
BU
P2
R2873
4R7K
GN
D1
R29
021K
(1/4
W)
R2901100K
R29034R7K
(1/4W)
DT
C11
4EU
AQ
2880
GN
DD
R2910
47K
IC2890TPD1018F
1OUT
2GND1
3GND2
4GND3
5VDD
6IN
7GND4
8GND5
9GND6
10DIAG
R29
0047
K
C2882
R001
GN
DD
BUP
GN
DD
KB
1
IL1
GN
DD
L293
0
KBUP
C2901R1
CN
1005
12345678910111213141516
10000/16C2910
3300/16C2935
C2890R1
L287
2
C2871
R001
D29
00
HZ
U8R
2(B
1)
R28
70
47K
R28
74
1K(1
/4W
)
ISN
GN
DD
D29
10K
S92
6S2
Q28702SC4116
C2881
1
C2892R001
GN
DD
R28
80
10K
R28
72
1K
C2891R001
D28
90
1SR
154-
400 D28911SR154-400
R28
821K
(1/4
W)
R2871
100K
CN
1001
D28
801S
R15
4-40
0
D28
70
UD
ZS
5R1(
B)
C2870
R001
BU
P1
GN
D2
Q29
002S
C41
16
D2930
ST70-27F
10000/16
C2911
10000/16
C2912
D2911
RB060L-40
R2912
4R7
R2913
4R7
D29
12K
S92
6S2
GN
DD
NKBUP R2911
47K
GN
DD
AC
2KB
2
RV
2
AC
C
AA
NT
ILM
RE
V
PLS
PK
B
RL-
FL-
RL+
FL+
RR
-
FR
-
RR
+
FR
+
NAVIC
D28
25
1SS
400G
R48
16
0R0
ILM
AA
NT
AC
C
GN
D
RE
V
PK
B
Veh
icle
I/F
PU
LSE
BU
P
AA
NT
1/4W 1/4W
RL+
FL+
RR
-
FR
-
RL-
RR
+
FL-
FR
+
AS
EN
S
ILM
SN
S
RE
VS
NS
6.5V
14.4
V
600u
H
RE
GN
DR
FG
ND
RF
6/6A
6/6A
AV
UN
IT(P
S/IF
SE
CT
ION
)1/6
A
R48
11
0R0
GN
DR
FEW
5
GN
DR
F
AVIC-F900BT/XS/EW51241 2 3 4
C
D
F
A
B
E
R2873
4R7K
C2871
R001
R2871
100K
C2870
R001
RE
VS
NS
6.5V
5 6 7 8
A-a
A-b
A-b 1/6
RR
RR
+
PK
B
FL+
FR
-
SRCMUTE
FR
+
SREMOTE
FA
NU
P
SR
EM
OT
E
OF
FM
UT
E
SP
EE
D
RL-
FR
FL-
FL
BR
EM
OT
E
RL+
RL
RR
-
SP
EE
D
PC
HN
G
AV2RS
GUIDEMUTE
MONVBS
NAVILG
AV2RG
NAVIRG
AV2LG
AV2VG
AV2LS
AV2VIN
NAVIAR
NAVIAL
GUIDE
GUIDEG
FRV
FRVGND
RSTMUTE
KMODEOUT
FANUP
PKBOUT
PKB
ANTON
ILMB
ILMR
ILMG
POMUTE
BREMOTE
FR
FL
RR
RL
ILMV
SY
SP
W
SY
SP
W
GN
DA
IC10
07P
AL0
07C
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
FR
Q2863UMD2N
2E 1
2B 2
1C 31E
4
51B
62C
GN
DD
ILMG
GN
DD
ANTON
R28
75
4R7K
(1/4
W)
C2932
2R2(2125)
GNDD
GN
DD
AV2LS
GUIDEMUTE
D28
62D
AN
202U
NAVIRG
GN
DD
D2871
UDZS18(B)
GN
DD
C29
26 1
FRVGND
DT
C11
4EU
AQ
2864
33/10
C2862
D28
731S
S35
5
ILMR
L287
1
C2861R1
C29311
Q2861UMD2N
2E 1
2B 2
1C 31E
4
51B
62C
C29
22 1(2
125)
KMODEOUT
GN
DD
C29
25 1
AV2LG
Q2860UMD2N
2E 1
2B 2
1C 31E
4
51B
62C
D28
60M
A11
1
FANUP
GN
DD
47/16 C2860
C11
4EU
A84
1
GN
DD
L287
0
NAVIAL
VDD5
NAVIAR
C2872
R001
RSTMUTE
ILMV
MONVBS
FRV
C2924
R1
DT
C12
4EU
AQ
2865
C29
21 1(2
125)
C29
23 1(2
125) GN
DD
AV2VG
D28
63D
AN
202U
NAVILG
ILMB
C29
20 1(2
125)
MU
T
GUIDE
BREMOTE
PKB
PKBOUT
FL
AV2RG
Q2862
2SC4081
AV2RS
D28
61U
DZ
S8R
2(B
)
AV2VIN
C29
27 1
R28
65
1K(1
/10W
)
100/25 C2929
C2933
2R2(3216)
RR
D2872
UDZS18(B)
POMUTE
D2874
PTZ18A
R292510K
C29
28 1
RL
R292410K
GUIDEG
R29
26
10K
C2930R1
10/16C2934
DT
C11
4EU
A
Q28
81
2SA
1576
AQ
2882
100K
MU
B
SWVDD5
R28
60
390
R28
61
390
R28
63
22K
R2862
47K
R2864
10K
R28
68
220
R2866
10K
R2867
10K
R28
69
100
2852
20K
R2853
33K
R28
84
4R7K
R2883
4R7K
D2822
DAN202U
00
MT
B
R29
200R
0
R29
210R
0
R29
220R
0
R29
230R
0
PW
R A
MP
IN4
S-G
ND
IN2
PW
.GN
D1
IN1
PW
.GN
D2
TA
B
PW
.GN
D4
PW
.GN
D3
VC
C1/
2
OU
T2+
ST
BY
OU
T2-
OU
T4-
MU
TE
OU
T4+
VC
C3/
4
OU
T3-
OU
T3+
SV
R
OU
T1+
OU
T1-
B_R
EM
OT
E
AC
GN
D
IN3
sens
ing
"low
vol
tage
"or
"re
set"
em
erge
ncy
MU
TE
AV
SE
CT
ION
SP
EE
D
PK
B
14.4
V
14.4V
5.0V
5.0V
5.0V
5.0V
V3
.8
V3
.8
2/6A
6/6A
5/6A
The
> m
ark
foun
d on
som
e co
mpo
nent
par
ts in
dica
tes
the
impo
rtan
ce o
f the
saf
ety
fact
or o
f the
par
t.T
here
fore
, whe
n re
plac
ing,
be
sure
to u
se p
arts
of
iden
tical
des
igna
tion.
AVIC-F900BT/XS/EW5 1255 6 7 8
C
D
F
A
B
E
RO
T1
RO
T0
BA
TF
AU
LT3
6
16 17 18
RO
T1
RO
TO
R29
530R
0
R29
540R
0
BF
AR
1016
0R0
8303R6K
RR
264M
-400
RO
T1
RO
T0
BA
TT
ER
Y_F
AU
LT3.
3V
8.3V
5.0V
8.3V
1 2 3 4
A-b
A-a
A-a 1/6
A-b 1/6
AV
2RG
AV
2RS
HD
RS
T
AV
2LS
DV
EJK
Y
ILM
R
ILM
G
ILM
B
ILM
V
AV
2VIN
AV
2VG
AV
2LG
FA
NV
KBUP
DC
VT
8
NA
VI5
V
AV8
BUP
C2804R1
C2811R1
NA
VI5
GN
DC1022
R1
100/16 C2810IL
MG
ND
Q28
10 2SD
1760
F5
D28
02R
B06
0L-4
0
R2801
10K
GN
DD
R29
400R
0
FA
NG
ND
100/16
C2801
C1021R001
C1020R001
R2804100K
TU
3
100/16
C2820
FA
NG
ND
AV
8
DT
C11
4EU
A
Q28
12
C2821R01
BA
00C
C0W
CP
-V5
IC28
01
Vad
j:1.2
25V
1CTL
2VCC
3GND
4VOUT
5ADJ
D2810
UDZS5R6(B)
R2811
470
BA
00C
C0W
CP
-V5
IC28
20
Vad
j:1.2
25V
1CTL
2VCC
3GND
4VOUT
5ADJ
D28
21R
B06
0L-4
0G
ND
V
C2812R1
NA
VI5
GN
D
NA
VI5
V
R2803
2R2K
FA
NG
ND
R29
46
GN
DA
NA
VI5
GN
D
C2802R001
VI5
R2802
2R7K
CN
1000
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
CN
1001
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
C2823
R1
R28100R0
DT
A11
4EU
AQ
2811
VT
8
GN
DD
R2822
2R2K
FA
NV
ILG
EJT
RE
S
ILM
B
ILM
G
ILM
R
ILM
V
AU
R
AU
RG
AU
L
AU
LG
AU
VG
AU
V
R29
47
R29
45
R29
44
R29
43
R29
48
R29
49
R29
50
R29
510R
0
R29
520R
0
NC
1
R29
4110
0
R29
4210
0
R28202R2K
R282110K
D28
31
VIC
S8
VIS
C8
R2823
1M
D2824
1SR154-400
D2823
1SR154-400
D28
25
1SS
400G
GN
DA
R28
330R
0
C28
05R
1
C28
00R
001
VT
8G
ND
ILM
GN
D
EJE
CT
RE
SE
T
ILM
B
ILM
GIL
MG
ILM
R
ILM
V(L
ED
SW
)
NC
AU
X-R
AU
X-R
G
AU
X-L
AU
X-V
G
AU
X-L
G
AU
X-V
VID
EO
5
NAVI5V
NAVI5V
NAVGND
NAVGND
FANV
FANGND
AV
8
NAVI5V
NAVI5V
NAVGND
NAVGND
AV8V GND
AV8V
NAVI5V
NAVI5V
NAVI5V
NAVI5V
NAVGND
NAVGND
NAVGND
NAVGNDto N
AV
I UN
ITS
PJ1
8.3V
8.0V
8.0V
6.5V
6.5V
8.0V
8.3V
8.3V
V0
.5
V0
.5
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
8.3V
8.3V
5.0V
EW
53/6
A
Dec
imal
poi
nts
for
resi
stor
and
capa
cito
r fix
ed v
alue
sar
e ex
pres
sed
as :
2.2t
2R
20.
022t
R02
2
Sym
bol i
ndic
ates
a r
esis
tor.
No
diffe
rent
iatio
n is
mad
e b
etw
een
chip
res
isto
rs a
nddi
scre
te r
esis
tors
.
NO
TE
: Sym
bol i
ndic
ates
a c
apac
itor.
No
diffe
rent
iatio
n is
mad
e b
etw
een
chip
cap
acito
rs a
nddi
scre
te c
apac
itors
.
AVIC-F900BT/XS/EW51261 2 3 4
C
D
F
A
B
E
AV
2LS
AV
2LG
GN
DD
IC28
2011 12 13
AU
L
AU
LG
R29
49
R29
50
D
1SR
AU
X-R
G
AU
X-L
6.5V
6.5V
5 6 7 8
A-b
A-a
A-a 1/6
A-b 1/6
GU
IDE
CP
UW
DT
3
SYSTOC3
RO
T1
OP
TS
NS
OP
TO
N
OF
FIN
FO
3
SYSTOCV3
OF
FA
NS
3
ROT1
RESETB
HDRST
DVEJKY
ROT0
BATFAULT3
RE
SE
TB
NA
VIA
R
CTOSYS3
OFFANS3
OPTSNS
KM
OD
EO
UT
OFFINFO3
CPUWDT3
RE
VS
NS
OPTON
CTOSYSV3
PU
LSE
PK
BO
UT
PULSE
FR
V
RO
T0
AV
2VIN
AV
2VG
NA
VIA
L
MO
NV
BS
GU
IDE
MU
TE
VICSON
SREMOTE
SYSPW
AV2RS
CT
OS
YS
V3
SY
ST
OC
V3
SY
ST
OC
3
CT
OS
YS
3
ASENS
ANTON
PC
HN
G
NA
VIR
G
NA
VIL
G
FR
VG
ND
GU
IDE
G
ILMSNS
SRCMUTE
AV2RG
AV2LG
AV2VG
AV2LS
AV2VIN
TU3
VIDEO5
NA
VI3
V
BA
TF
AU
LT3
VT6
DCSKIPCD
NAVI3V
AV8
AV8
AV
8
SW
AC
PW
NF
CO
NT
NFCONT
SYSPW
TU3
BATFAULT3
C2844
R082
IC10
02N
JM29
04M
567
GN
DV
CTOSYSV3
GN
DD
C28
42
R1
GN
DA
AV2LS
C28
41
R00
1
GNDFM
GUIDEG
ROT0
DT
C11
4WK
Q28
40
SYSTOC3
C2840
R1
GNDRF
NA
VIR
G
ROT1
GN
DF
M
NAVIRG
OPTSNS
AV2LG
TU
3
HDRST
100/16 C2830
DT
C11
4EU
AQ
2841
L100
4
SRCMUTE
AV8
ASENS
FA
NG
ND
GNDD
VIDEO5
AV2VG
SREMOTE
SWACPW
GNDA
GN
DR
F
SYSTOCV3
AV2RG
GN
DV
GN
DD
AV2RS
ANTON
GN
DD
FANGND
C2831R01
OFFANS3
D28401SS355
IC10
02N
JM29
04M
34
21
8
NAVILG
AV2VIN
OPTON
VICSON
DVEJKY
FR
VG
ND
CPUWDT3
GNDA
NA
VI3
GN
D
14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50L2
940
C2833
R1
FRVGND
CTOSYS3
GNDV
GN
DD
GU
IDE
G
ILMGND
AV8
RESETB
C2843R01
GNDD
NAVI3GND
GN
DD
GN
DA
ILMSNS
VT6
OFFINFO3
DT
C
Q2
2SA
1576
AQ
2882
R2834
100K
R2832
2R2K
AU
VG
AU
V
RO
T1
RO
TO
NA
RG
NA
R
NA
LG
NA
L
N33
V
FR
G
FR
V
BC
GN
BC
VN
GM
UT
E
GU
IG
GU
I
GS
Y1
CT
SV
ST
CV
GS
Y2
CT
N
ST
C
GS
Y3
OP
ON
OP
SN
PK
N
KM
B
RV
N
OF
AN
OF
IN
WD
OG
RE
SB
PC
HG
PLN
R29
510R
0
R29
520R
0
R29
530R
0
R29
540R
0
R29
600R
0
R29
610R
0
R29
620R
0
R29
630R
0
R29
640R
0
R29
670R
0
R29
680R
0
R29
690R
0
R29
700R
0
R29
710R
0
R29
720R
0
R29
730R
0
R29
740R
0
R29
750R
0
R29
760R
0
R29
770R
0
R29
780R
0
R29
790R
0
R29
800R
0
R29
810R
0
R29
820R
0
R29
830R
0
R29
590R
0
NF
C
SWVDD5
BF
AR
1016
0R0
R2841
47K
R28
40
100K
R2842
56KR28
43
51K
R28
44
100K
R28
4551
K
R28
4651
K
R28481K
R28471K
R2849
560K
R2850
2K
R28518R2K
R28
52
20K
R2853
33K
R2883
4R7K
D2822
DAN202U
BA
00B
C0W
FP
IC28
30
1VC
2VIN
3GND
4VDD
5C
R28303R6K
R2831100
D28
31R
R26
4M-4
00
GN
DD
DCSKIPCD
NAVI3V
FU
2900
CE
K12
76
250m
A
NFCONT
8.3V
RO
T1
AU
X-V
G
AU
X-L
G
AU
X-V
GN
D
Nav
iAR
G
RO
T0
BA
TT
ER
Y_F
AU
LT
BC
VG
ND
OP
TS
NS
GN
DS
YS
GN
DS
YS
GU
IDE
PK
B
GN
DS
YS
CT
OS
YS
V3
FR
VG
ND
SY
ST
OC
V3
GU
IDE
MU
TE
OP
TO
N
GU
IDE
G
BC
V
FR
V
PU
LSE
OF
FIN
FO
OF
FA
NS
KM
OD
E
WD
OG
RE
SE
TB
PC
HN
G
RE
V
Nav
iAR
Nav
iALG
Nav
iAL
NF
CO
NT
NA
VI3
3V
5.0V
SY
ST
OC
3
CT
OS
YS
3
8.3V
3.3V
TU
3
SP
EE
D P
ULS
E
6.5V
3.3V
5.0V
5.0V
5.0V
8.3V
V3
.8
8.3V
5.0V
8.3V
ILM
GN
DN
AV
ILG
to N
AV
I UN
ITO
TJ1
>
2/6A
3/6A
6/6A
4/6A
AVIC-F900BT/XS/EW5 1275 6 7 8
C
D
F
A
B
E
NO
SE
LR
GU
IDE
MU
TE
AV
R4275
1K
R43
13
R4277
1K
DT
C32
3TK
Q43
14
GNDA
GMUTENormally HUttering Lo
1 2 3 4
10.2 AV UNIT(A/V SECTION)(GUIDE PAGE)
A-a 2/6
2/6A
DVDV
GU
IDE
G
MONVBS
AV
2RS
DVDL
VCK
FRV
AMUTE
VDT
NAVIAL
NAVIAL
IPL
FML
IPLG
AV
2LG
NAVIRG
GUIDE
FM
RT
N
FM
L
AV2VIN
FMRTN
AV
2LS
NAVIAR
AMUTE
NOSELL
AV2RG
AV
1RS
NOSELR
TELMUTE
NAVIRG
IPLG
FMR
RSTMUTE
AV2LG
SELSDA
AV2VG
AV
1LG
IPR
SELSCL
AV2VIN
GUIDEG
AV
2RG
DVDR1
DVDV
VST
AV
1RG
AV8
AV
8
AV8AV8
AV8
AV3VIN
GUIDEMUTE
IPL
AV2RS
DVDR
RSTIN
AV2LS
DVDL
AV1VIN
IPRG
IPR
FM
R
IPR
G
AV
1LS
NAVILG
GU
IDE
HDRST
KM
OD
WCONT
DVDR
WIREIN
NAVILG
AU
4
RSTIN
AV1VG
AV3VG
AV2VG
NAVIAR
C407210
AV2VIN
R4071
47K
C42
021
MONVBS
GNDA
GNDA
NAVIRG
C3042 10
C4188
1
C42
001C
4182
R1
DVDR
VST
IPR
GC
4215
1
R42
74
22K
R41
76
0R0
FM
RT
N
WCONT
GNDV
10/1
6
C40
62
AV2VG
D4311DAN202K
GNDV
GNDV
FM
L
GN
DA
C41
911
R407933
R30411R8K
C407010
C41
921
GNDA
GUIDEMUTE
22C
4183
AV
8
AV2RS
GNDV
L4172
C10
77
R1
C41
81R
1
VD
D5
C1078
R1
C40
80R
01
IPLG
R4195 220
FRV
C407310
R4072
47K
D40
62
1SS
355
GNDA
NOSELL
VID
EO
5
GNDA
C4071
10
R4075
47K
10C4151
22C
4174
C42
211
GNDD
R4200
75
C40
63
R1
WIREIN
GN
DD
47/1
6C
4171
C4075
33P
R4159 47K
C41
94
1
SSCL
C4189 1
C42
061
SELSDA
R4156
100K
D40
61E
DZ
4R3(
B)
Q30
42F
MG
121
15
5
44
22
33
R40
77
47K
R4155
1K
C40
61
R01
VCK
R4078 47KR4076
47K
C41
901
R4272
180
C42
221
10C4152
DVDL
DVDV
C41
931
R4271
0R0
AMUTE
R30
4447
K
VDT
C41
72R
1
R4194 220
NOSELR
GNDV
AV2LG
C41
981
R4073
47K
R30421R8K
GNDA
GUIDE
R4157
100K
IPR
NAVIAL
NAVILG
330/10C4219
R40
61
1K
IC1008NJM2125F
3 2
145
FM
R
R40
4175
GNDA
AN15887AIC4171
VCC1
1
BIAS1
2
GND13
L1-14
L1-25
R1-16
R1-27
L2-18
L2-29
VCC210
BIAS211GND2
12
R2-
1
13
R2-
2
14
L3-1
15
L3-2
16
R3-
117
R3-
218
L4-1
19
L4-2
20
R4-
121
R4-
222
L5-1
23L5
-224
R5-125
R5-2 26ROUT1
27LOUT1
28ROUT2
29LOUT2
30FB2
31VOUT2
32FB1
33VOUT1
34SDA
35SCL
36
V1-
137
V1-
238
V2-
139
V2-
240
V3-
141
V3-
242
V4-
143
V4-
244
V5-
145
V5-
246
V6-
1
47V
6-2
48
R41
53
10K
R40
2175
C4078 33P
Q4312IMD3A
2E 6
2B5
1C4
1E3
2 1B
1 2C
IC1016BA4558RFVM(2/2)
5
67
IC1015NJM4558V(2/2)
5
67
C3041 10
AV2RG
GNDV
Q30
41IM
D3A
2E6
2B5
1C4
1E32
1B
12C
22/10C4220
SSDA
GNDV
IC1015NJM4558V(1/2)
3 4
218
GUIDEG
R408033
R40
74
47K
Q1016IMD2A
2E6
2B5
1C4
1E3
21B
12C
R40
0175
GNDA
C40
76
R1
47/1
6C
4173
R415110K
R4273
180
TELMUTE
R4154
10K
GNDV
SELSCL
C42
171
C42
041
GN
DV
L417
1
IPL
D3041DAP202K
IC1016BA4558RFVM
(1/2)3 4
218
GNDD
C4281 1
R415210K
C40
79R
01
GNDA
AV2LS
R30
4347
K
KM
OD
GNDV
NAVIAR
R42
76
22K
22/10C4232
C4159
2R2
R4312
820
GNDA(DVD)
R75
1
0R0
C41
974R
7
C41
954R
7
C42
034R
7
C42
114R
7
C42
164R
7
C4210 1
C4208 1
C4212 1
C4213 1
C41864R7
C41874R7
C41854R7
C41
991
C42
071
C42
241C42
011
R41
58
68K
C41
56
R1
C41
57
150P
C4158150P
C41
55
R01
C41
54
R1C
4160
220P
C4153
220P
RSTIN
C41
84R
1
4.0V
AV SELECTOR
Rch MUTE
VT
R2L
ISOLATOR LPF AMP10.6kHz 18dB/oct+4.6dB
VT
R3
NAVI L
VT
R2R
VT
R1R
AU4
VT
R1L
NAVI R
DVD R
DVD L
VT
R2
VT
R1
DV
D
DVD LPF
1.0Vrms=2.21dBs
GUIDE
AMUTE
RST
8.3V
8.3V
8.3V
8.3V
V3.8V3.8 8.3V
8.3V
8.3V
4.0V
4.0V
4.0V
4.0V
4.0V
8.3V
8.3V
8.3V
8.3V
8.3V
5.0V
5.0V
8.3V
V3.8V3.8 8.3V
8.3V
8.3V
8.3V
4.0V4.0V
4.0V
8.3V
8.3V
5.0V 5.0V 5.0V 5.0V
RE
R4175
22K
R4174
22K
R4171
22K
R4170
22K
1/6A6/6A
1/6A
4/6A
3/6A 6/6A
AVIC-F900BT/XS/EW51281 2 3 4
C
D
F
A
B
E
DA
R4272
180
R4271
0R0
Q4312IMD3A
1E3
2 1B
1 2C
R4273
180
C4281 1
R43
82
Rch MU
DVD R
DVD L
RE
5 6 7 8
A-b 2/6
2/6A
WIREIN
TELMUTE
BCVIN
RS
TM
UT
E
RVOUT
AV1LG
PO
MU
TE
PRL
NO
SE
LR
VC
K
PRR
PFR
BCGND
NO
SE
LL
AV1LS
KMOD
PFL
BR
EM
OT
E
PFR
HD
RS
T
SWR
GU
IDE
MU
TE
SWR
RR
AV1VIN
VS
T
AV1VG
WCONT
RL
PO
MU
TE
SE
LSC
L
VD
T
AV
8
AV8
AV
8
BC
GN
D
SE
LSD
A
RR
AV1RSM
ON
VB
S
BC
VIN
RL
PFL
SWL
SWL
RVOUT
FR
V
PRL BREMOTE
AV1RG
PRR
EF4357
3
2
1
C4264100/10
C43
3922
00P
C43
71R
001
AG
R43
4747
0
R4335
820
V1RG
V1R
C42
841
R43
4647
0
GNDD
R43
4547
0
C42
93R
1
C42
91R
1
C4252
10
L4371
4R7/16
C4335
RL
GNDA
D43
54M
ALS
068X
C4280
1
R4235 680
RL
FL
C43
4022
00P
R42
74
22K
D43
65
PT
Z27
(B)
R42
51
75
GNDD
R42
32
30K
EF4360
3
2
1
47/1
6C
4289
D43
62
1SR
154-
400
EF4351
3
2
1
D4311N202K
FRV2
C43
4222
00P
R42
5247
K
C43
3722
00P
L4352
R43
4347
0
RR
GNDA
D4355
DAN202U
D43
53M
ALS
068X
EF4352
3
2
1
GNDA
10/1
6C
4294
R4352
10K(1/10W)
SWL
C42
51R
047
GNDA
R43
4847
0
D43
71
UD
ZS
5R6(
B)
EF4356
3
2
1
4R7/16
C4331
R43
3722
K
R42
40
0R0
C43
51
R1
IC42
71
PM
L018
A
IN5-
_L1
IN5+
_L2
IN4+
_L3
IN4-
_L4 5
IN3_
L6
IN2_
L7
IN1_
L8
Vre
f9
Vcc
10F
ront
_L11
Rea
r_L
12P
re/S
W_L
13V
p14
Pre
f15
PG
ND
16P
re/S
W_R
17R
ear_
R
18F
ront
_R
19D
AT
A
20C
LK
21S
TB
22G
ND
23IN
1_R
24IN
2_R
25IN
3_R
26IN
4-_R
27IN
4+_R
28IN
5+_R
Q43
31F
MG
121
15
5
44
22
33
R42
33
680
4R7/16
C4334 FU
4352
CE
K12
59
3.15
A
D4312DAN202K
D43
66M
ALS
068X
EF4353
3
2
1
C42
871
GNDD
EF4355
3
2
1
V2V
V1L
CN101523
1
GNDD
R43
4122
K
TELM
C42
31 1
10/1
6C
4288
GNDD
GNV
D4361
1SS355
C42
54
R1
Q43
33F
MG
121
15
5
44
22
33
C42
85 1
EF4359
3
2
1
L4372
R42
31
22K
R4334
39
C42
96
R1
PO
MU
TE
C4253
10
EF4361
3
2
1
EF4358
3
2
1
BR
EM
OT
E
RR
R4331
820
C4271
10
R42
85
0R0
C43
53R
001
V1LG
C4276
1
BCG
L4271
C43
72R
001
V2G
R43
4222
K
R42
5347
K
GNDD
R43
3822
K
R4275
1K
2SA
1576
AQ
4232
SWR
RVO
GNDV
C43
4122
00P
R43
13
100K
R43
3922
K
R4336
820
V1V
GNDA
R4263
0R0
GNDV
GNDD
GNDA
2E 6
2B5
1C4
D43
31
DA
P20
2K
C42
86 1
Q42312SC4081
Q43
32F
MG
121
15
5
44
22
33
D4352EDZ6R8(B)
R4277
1K
FL
KMD
R4254
100
DT
C32
3TK
Q43
14
D43
57M
ALS
068X
D43601SR154-400
GNDD
V1VG
FR
C4275
1
R4351
15K
WCT
GNDD
D43
72
UD
ZS
5R6(
B)
D43
56M
ALS
068X
FR
D43
63M
ALS
068X
D4351EDZ20(B)
BCV
C4273
1
C4233100/10
GNDD
R4332
820D
4359
MA
LS06
8X
R4333
39
BREM
GNDV
GNDA
R4255
100
C4277
10
RS
TM
UT
E
C43
3822
00P
C43
52
R01
GNDD
R42
86
0R0
R4234
1K
C4274
1
WRI
GNDD
L4231
D43
58M
ALS
068X
EF4354
3
2
1
4R7/16
C4332
GNDD
4R7/
16C
4295
4R7/16
C4336
CN1016
1
2
3
4
5
6
7
8
9
10
11
12
14
15
16
17
18
19
20
21
22
23
24
13
R42370R0
R42
36
1R5K
R43
4447
0
L4351
D43
64
PT
Z27
(B)
HD
RS
T
4R7/16
C4333
R43
4022
K
R42
76
22K
R4293 0R0
R4295 0R0
R42
871K
R42
891K
R42
911K
CCP1483VR4231
13
2
R43
170R
0R
4316
0R0
min
iSM
DC
075F
/24
FU
4351
BCISO
12
0
IC4251
NJM2505AF
Vout1
GND2
V+3
Vin4
5VGND
C42
97 1
GNDA
R4296
0R0
BACK CAMERAISOLATOR
BCVGND
VTR2V
TELMUTE
WIRED REMOTE(Black)
RR
VTR1L
GNDV
FR
VTR1V
SWL
AV
CO
NN
EC
TO
R
TEGMUTENormally HiUttering Low
VTR2GND
BREM
FM
KMODE
FM
FM
EVOL
FRONTGND
IP B
US
VTR1LGND
IP B
US
REARVOUT
IP B
US
SWGND
IP B
US
VTR1VGND
VTR1RGND
GU
IDE
SWR
FL
RL
SE
LOU
T IN
BCV
SE
LOU
T IN
REARGND
CD
/DV
DC
D/D
VD
VIDEO to NAVI
VIDEO BUFFER
VTR1R
TELMUTE
KMOD
MUTE
8.3V
8.3V
8.3V
8.3V
8.3V
8.3V
5.0V 5.0V
5.0V
5.0V
5.0V
40A
1K(OB)
>>
1/6A
AV UNIT(A/V SECTION)2/6A
AVIC-F900BT/XS/EW5 1295 6 7 8
C
D
F
A
B
E
SW
L
6470
RL
C4
EF
4351
31
C4 3470
R4337
15 D
16 R
17 R
18 R
19 A
20 K
21 B
22 D
23 R
24 R
25 R
26 R
27 R
28 R
Q4331FMG12
5
4
3
V2VFR
GN
DD
1
C42
74 15678
R4340
FR
FM
IP BU
IP BU
RL
SELO
RE
AR
GN
D
C
1 2 3 4
A-a
A-b
A-b 2/6
BC
VIN
RV
OU
T
AV
1LG
POMUTE
VCK
PR
R
BC
GN
D
AV
1LS
AV
1VIN
VST
AV
1VG
SELSCL
VDTAV8
BCGND
SELSDA
RR
AV
1RS
MONVBS
BCVIN
RL
RV
OU
T
FRV
PR
LB
RE
MO
TE
AV
1RG
EF
4357
3
2
1
C42
6410
0/10
AG
V1R
G
V1R
C4284
1
C42
52
10
D4354MALS068X
R42
3568
0
3402200P
R4274
22K
R4251
75
R4232
30K
D4362
1SR154-400
FR
V2
R425247K
3372200P
D4353MALS068X
SW
L
C4251R047
EF
4356
3
2
1
4R7/
16
C43
31
22K
R4240
0R0
C4351
R1
11
22
R4233
680
D4366MALS068X
EF
4355
3
2
1
V1L
C4231
1
GN
DD
GN
V
C4254
R1
R4231
22K
C42
53
10
2
EF
4358
3
2
1
R43
31
820
C42
71
10
R4285
0R0
V1L
G
BC
G
R425347K
R42
75
1K
2SA1576AQ4232
SW
R
RV
O
GN
DV
V1V
R42
63
0R0
GN
DV
GN
DD
D4331
DAP202K
C4286
1
Q42
312S
C40
81
D43
52E
DZ
6R8(
B)
FL
KM
D
R42
54
100
D4357MALS068X D
4360
1SR
154-
400
V1V
G
D4356MALS068X
D4363MALS068X
D43
51E
DZ
20(B
)
BC
V
C42
73
C42
3310
0/10
R43
32
820
D4359MALS068X
BR
EM
GN
DV
R42
55
100
GN
DD
R4286
0R0
R42
34
1K
GN
DD
L423
1
D4358MALS068X
EF
4354
3
2
1
4R7/
16
C43
32
GN
DD
CN
1016
91011121415161718192021222324 13
R42
370R
0
R4236
1R5K
22K
R42871K
R42891K
R42911K
CC
P14
83V
R42
31
13
2
BC
ISO
IC42
51
NJM
2505
AF
Vou
t1
GN
D2
V+
3V
in4 5
VG
ND
C42971
GN
DA
BA
CK
CA
ME
RA
ISO
LAT
OR
BC
VG
ND
VT
R1L
GN
DV
VT
R1V
SW
L
AV CONNECTOR
BR
EM
KM
OD
E
FR
ON
TG
ND
VT
R1L
GN
D
S
RE
AR
VO
UT
SW
GN
D
S
VT
R1V
GN
D
VT
R1R
GN
D
SW
R
FL
UT IN
BC
V
D R
D L
D/DVD
VID
EO
to N
AV
I
VID
EO
BU
FF
ER
VT
R1R
8.3V
5.0V
5.0V
5.0V 5.0V 5.0V
1K(O
B)
AV
UN
IT(A
/V S
EC
TIO
N)
2/6A
AVIC-F900BT/XS/EW51301 2 3 4
C
D
F
A
B
E
PR
LB
RE
MO
TE
C4284
1
0
SW
L4R
7/16
820
C42
71R
4275
SW
R
D43
601S
R15
4-40
0
R43
32
BR
EM
C43
321214 13
C42971
GN
DA
SW
L
BR
EM
SW
GN
D
SW
R
5 6 7 8
A-a
A-b
A-b 2/6
WIR
EIN
TE
LMU
TE
RSTMUTE
PR
L
NOSELR
PF
R
NOSELL
KM
OD
PF
L
BREMOTE
PF
R
HDRST
SW
R
GUIDEMUTE
SW
R
RR
WC
ON
T
RL
POMUTE
AV8
AV
8
PF
L
SW
L
SW
L
PR
R
C43392200P
C4371R001
R4347470
R43
35
820
R4346470
GN
DD
R4345470
C4293R1
C4291R1
L437
1
4R7/
16
C43
35
RL
GN
DA
C42
80 1
RL
FL
C43402200P
R4274
22K
D4365
PTZ27(B)
GN
DD
EF
4360
3
2
147/16 C4289
D4362
1SR154-40
EF
4351
3
2
1
D43
11D
AN
202K
C43422200P
C43372200P
L435
2
R4343470
RR
GN
DA
D43
55
DA
N20
2U
EF
4352
3
2
1
GN
DA
10/16 C4294
R43
52
10K
(1/1
0W)
GN
DA
R4348470
D4371
UDZS5R6(B)
R433722K
C4351
R1
IC4271
PML018A
IN5-_L1
IN5+_L2
IN4+_L3
IN4-_L4
5IN3_L 6IN2_L 7IN1_L 8Vref 9Vcc 10Front_L 11Rear_L 12Pre/SW_L 13Vp 14Pref
15 PGND
16 Pre/SW_R
17 Rear_R
18 Front_R
19 DATA
20 CLK
21 STB
22 GND
23 IN1_R
24 IN2_R
25 IN3_R
26 IN4-_R
27 IN4+_R
28 IN5+_R
Q4331FMG12
11
5 5
4 4
22
3 3
4R7/
16
C43
34
FU4352CEK1259
3.15A
D43
12D
AN
202K
EF
4353
3
2
1
C42871
GN
DD
V2V C
N10
1523 1
GN
DD
R434122K
TE
LM
10/16 C4288
D43
61
1SS
355
Q4333FMG12
11
5 5
4 4
22
3 3
C4285
1
EF
4359
3
2
1
L437
2
R43
34
39
C4296
R1
POMUTE
EF
4361
3
2
1
2
BREMOTE
RR
1
10
C4353R001
C42
76 1L4
271
C4372R001
V2G
R434222K
GN
DD
R433822K
1K
C43412200P
R4313
100K
R433922K
R43
36
820
GN
DA
GN
DA
Q43
12IM
D3A
2E6
2B5
1C4
Q4332FMG12
11
5 5
4 4
22
3 3
R42
77
1K
FL
KM
DDTC323TK
Q4314
GN
DD
FR
C42
75 1
R43
51
15K
WC
T
GN
DD D4372
UDZS5R6(B)
FR
C42
73 1
GN
DD
820
3
R43
33
39
GN
DA
C42
77
10
RSTMUTE
C43382200P
C4352
R01
C42
74 1
WR
I
4R7/
16
4R7/16 C4295
1
4R7/
16
C43
36
1234567891011
R4344470
L435
1
D4364
PTZ27(B)
HDRST
4R7/
16
C43
33
R434022K
R4276
22K
R42
930R
0
R42
950R
0
R43170R0
R43160R0
miniSMDC075F/24
FU4351
R43
12
820
R42
96
0R0
VT
R2V
TE
LMU
TE
WIR
ED
RE
MO
TE
(Bla
ck)
RR
FR
MU
TE
GM
UT
EN
orm
ally
Hi
Utte
ring
Low
VT
R2G
ND
FM
KM
OD
E
FM
FM
EV
OL
FR
ON
TG
ND
IP BUS
IP BUSIP BUSIP BUS
GUIDE
FL
RL
SELOUT INSELOUT IN
RE
AR
GN
D
CD/DVDCD/DVD
TE
LMU
TE
KM
OD
MU
TE
8.3V
8.3V
8.3V
8.3V
8.3V
40A
>>
1/6A
AVIC-F900BT/XS/EW5 1315 6 7 8
C
D
F
A
B
E
DV
DV
FM
RG
ND
VC
4070
10
Q304FMG1
5 5
4 4
3 3
47K
180
447K
R40
73
47K
C40
7833
P
567
Q304IMD3
2E 6
2B5
1C4
D30
41D
AP
202K
347K
1 2 3 4
A-b
A-a
A-a 2/6
A-b 2/6
MO
NV
BS
AV2RS
DV
DL
FR
V
NA
VIA
L
NA
VIA
L
AV2LG
NA
VIR
G
GU
IDE
AV
2VIN
AV2LS
NA
VIA
R
AV
2RG
AV1RS
NA
VIR
G
RS
TM
UT
E
AV
2LG
AV
2VG
AV1LG
IPR
AV
2VIN
GU
IDE
G
AV2RG
DV
DR
1
DV
DV
AV1RG
AV
8A
V8
AV
8
AV
3VIN
GU
IDE
MU
TE
AV
2RS
RS
TIN
AV
2LS
AV
1VIN
IPR
G
AV1LSN
AV
ILG
HD
RS
T
DV
DR
NA
VIL
G
AV
1VG
AV
3VG
AV
2VG
NA
VIA
R
C40
7210
AV
2VIN
R40
71
47K
C42021
MO
NV
BS
GN
DA
NA
VIR
G
C30
4210
C41
88 1
C42001
C4182R1
C42151
R4274
22K
R4176
0R0
GN
DV
10/16
C4062
AV
2VG
GN
DV
GNDA
C41911
R40
7933
R30
411R
8K
C41921
GN
DA
GU
IDE
MU
TE
22 C4183
AV8
AV
2RS
GN
DV
L417
2
C1077
R1
C4181R1
VDD5
C10
78
R1
C4080R01
R41
9522
0
FR
V
C40
7310
R40
72
47K
D4062
1SS355
GN
DA
VIDEO5
GN
DA
C40
71
10
R40
75
47K
22 C4174
C4221 1
GN
DD
R42
00
75
C4063
R1
GNDD
47/16 C4171
C40
75
33P
C4194
1
SS
CL
C41
891
C42061
D4061EDZ4R3(B)
22
11
22
R4077
47K
C4061
R01
R40
7847
KR
4076
C41901
R42
72
C4222 1
C41931
C4172R1
R41
9422
0
GN
DV
AV
2LG
C41981
R30
421R
8K
GN
DA
GU
IDE
NA
VIA
L
NA
VIL
G
330/
10C
4219
R42
75
1K
R4061
1K
IC10
08N
JM21
25F
32
14
5
R404175
GN
DA
AN
1588
7AIC
4171
VC
C1
1
BIA
S1
2
GN
D1
3
L1-1
4
L1-2
5
R1-
16
R1-
27
L2-1
8
L2-2
9
VC
C2
10
BIA
S2
11G
ND
212
R2-1
13
R2-2
14
L3-115
L3-216
R3-117
R3-218
L4-119
L4-220
R4-121
R4-222
L5-1 23L5-2
24
R5-
125
R5-
226
RO
UT
127
LOU
T1
28R
OU
T2
29LO
UT
230
FB
231
VO
UT
232
FB
133
VO
UT
134
SD
A
35S
CL
36
V1-137
V1-238V2-1
39V2-2
40V3-1
41V3-2
42V4-1
43V4-2
44V5-1
45V5-2
46 V6-1
47V6-2
48
R402175
C30
4110
AV
2RG
GN
DV
1A
1E3
2 1B
1 2C22
/10
C42
20
SS
DA
GN
DV
IC10
15N
JM45
58V
(1/2
)
34
21
8
GU
IDE
G
R40
8033
R4074
47K
Q10
16IM
D2A
2E6
2B5
1C4
1E32
1B
12C
R400175
C4076
R1
47/16C4173
GN
DV
C42171
C42041
GNDV
L4171
GN
DD
C4079R01
GN
DA
AV
2LS
GN
DV
NA
VIA
R
22/1
0C
4232
C41974R7
C41954R7
C42034R7
C42114R7
C42164R7
C42
101
C42
081
C42
121
C42
131
C41
864R
7
C41
874R
7
C41
854R
7
C41991
C42071
C42241
C42011
C4184R1
4.0V
AV
SE
LEC
TO
R
VTR2L
VTR3
NA
VI L
VTR2R
VTR1R
AU
4
VTR1L
NA
VI R
DV
D R
DV
D L
VTR2
VTR1
DVD
DV
D L
PF1.
0Vrm
s=2
.21d
Bs
RS
T
8.3V 8.3V
8.3V
8.3V
V3
.8
V3
.8
8.3V
4.0V
4.0V
5.0V
5.0V
8.3V
V3
.8
V3
.8
8.3V
8.3V
8.3V
8.3V
4.0V
4.0V
4.0V
8.3V
8.3V
5.0V
5.0V
5.0V
5.0V
RE
R41
75
22K
R41
74
22K
R41
71
22K
R41
70
22K
1/6A
6/6A
1/6A
AVIC-F900BT/XS/EW51321 2 3 4
C
D
F
A
B
E
IPR
G
DV
DR
C40
7210
C30
4210
GN
DAC4080
R01
47K
R4
4
R30
421R
8KR
4275
GN
DV
IC10
15N
JM45
58V
(1/2
)
34
C4
V3
.8
V3
.8
8.3V
4.0V
RE
5 6 7 8
A-b
A-a
A-a 2/6
A-b 2/6D
VD
V
GUIDEG
VC
K
AM
UT
E
VD
T
IPL
FM
L
IPLG
NOSELR
FMRTN
FML
FM
RT
N
AM
UT
E
NO
SE
LL
GUIDEMUTE
NO
SE
LR
TE
LMU
TE
IPLG
FM
R
SE
LSD
A
IPR
SE
LSC
L
VS
T
AV
8A
V8
AV8
IPL
DV
DR
DV
DL
IPR
FMR
IPRG
GUIDE
KMOD
WC
ON
T
WIR
EIN
AU4
RS
TIN
GN
DA
DV
DR
VS
T
IPRG
R4274
22K
FMRTN
WC
ON
T
GN
DV
D43
11D
AN
202K
GN
DV
FML
C40
7010
IPLG
C40
7310
NO
SE
LL
GN
DA
10C
4151
WIR
EIN
R41
5947
K
SE
LSD
A
R41
56
100K
Q3042FMG12
11
5 5
4 4
22
3 3
R41
55
1K
VC
K
R40
7847
KR
4076
47K
R42
72
180
10C
4152
DV
DL
DV
DV
R42
71
0R0
AM
UT
E
R304447K
VD
T
NO
SE
LR
R40
73
47K
R41
57
100K
IPR
1K
FMR
R4313
100K
R4153
10K
C40
7833
P
Q43
12IM
D3A
2E6
2B5
1C4
1E3 2
1B
12C
IC10
16B
A45
58R
FV
M(2
/2)
567
IC10
15N
JM45
58V
(2/2
)
567
R42
77
1K
DTC323TKQ4314
Q3041IMD3A
2E 6
2B5
1C4
1E3
2 1B
1 2C
GN
DA
R41
5110
K
R42
73
180
TE
LMU
TE
R41
54
10K
SE
LSC
L
GN
DA
IPL
D30
41D
AP
202K
IC10
16B
A45
58R
FV
M(1
/2)
34
21
8
C42
811
R41
5210
K
R304347K
KMOD
GN
DV
R4276
22K
C41
59
2R2
R43
12
820
GN
DA
(DV
D)
R751
0R0
R4158
68K C4156
R1
C4157
150P
C41
5815
0P
C4155
R01
C4154
R1
C4160
220P
C41
53
220P
RS
TIN
Rch
MU
TE
GM
UT
EN
orm
ally
HU
tterin
g Lo
w
ISO
LAT
OR
LPF
AM
P10
.6kH
z 18
dB/o
ct+4
.6dB
DV
D L
PF
GU
IDE
AM
UT
E
8.3V
8.3V
4.0V
4.0V
4.0V
8.3V
8.3V
8.3V
8.3V
8.3V
4/6A
3/6A
6/6A
AVIC-F900BT/XS/EW5 1335 6 7 8
C
D
F
A
B
E
R14
26
0R0
41
GND
RF
220/
10
7:RE7:EW
1 2 3 4
10.3 AV UNIT(TUNER SECTION)
3/6A
R1442
68
R14
21
150
C1421
2200P
TM
C
GNDRF
R14
431R
5K
R14
41
150
L140
1
GNDRF
C14
2222
00P
T1403
1
2
3
5
L1423
GNDRF
L1403
R14
13
100
R14
1133
GNDRF
CN14
1
2
3
RFIN
C1405
47P
L144
3
C1409
2200P
L142
1
C1423
15P
C144322P
R14
1082
0
C1441
2200P
T1402
1
2
34
5L1
441
GND
C1402
22P
R1412
3R3K
C14
24R
01
C14
06R
01
C1401
27P
C14
08
R01
R14
09
1M
L142
2
C14
44R
01
Q14012SC3357
T1401
1
2
34
5
R14
2468
0
C14
03
27P
R14
4468
0
R14
2518
0
Q14412SC3130
C14
07R
01
C1426
27P
R14
4515
0
ZN
R14
01
CS
A30
-201
N
Q14212SC3127
C14
04
33P
C14
4222
00P
R1422
68
R14
231R
5KL1402
ANT1401CKX1060
1
2
ANTENNAIN
FM DISTRIBUTION
CWE209CWE212
EW5
VICS/TMC AMP
V3
.8
V3
.8
8.3V
8.3V
8.0V
8.3V
8.0V
RE
4
AVIC-F900BT/XS/EW51341 2 3 4
C
D
F
A
B
E
CN
1
CWE2CWE2
V3
.8
V3
.8
8.3V
8.3
8.0
R
5 6 7 8
3/6A
TUNDI
TUNCE1
TUNSL
TUNDO
TUNCLK
TUNCE2
HLDET
HRHSLK
HRLK
HRCK
HRDT
AV8
VDD5
TU
ND
I
HLD
ET
TU
ND
O
TU
NS
L
TU
NC
LK
TU
NC
E1
TU
NC
E2
GNDRF
GNDD
TUNSL
R14
26
0R0
HRLK
Y14611
AM
_AN
T2
RF
_GN
D3
FM
_AN
T4
VC
C5
SL
6C
E2
NC
7W
C8
CE
19
CK
10D
I11
LDE
T12
OS
CG
ND
13R
OM
_VD
D14
DO
15D
GN
D
NC
16C
OM
P17
VD
D_3
.318
RD
S_C
K19
RD
S_D
AT
A20
RD
S_L
OC
K21
RD
S_H
SLK
AG
ND
22B
EG
ND
23Lc
h24
Rch
TUNDO
L1463
HRHSLK
C1464
100P
TUVCC
TUNDI
C14
6810
AV8
C1465R01 TUNCE1
1441
2
3
GNDRF
GNDA
HLDET
GNDA
HRDT
VICS8
L1465
GNDD
FMR
GNDRF
HRCK
L146
2
FML
TU3
GNDA
FMRTN
GNDRF
GNDD
TUNCE2
L1464
TUNCLK
VDD5
VDD33
GNDD GNDRF
L146
1
220/
10
C14
61
220/
10
C14
62
R1470 0R0
R1471 0R0
R1474 0R0
R1475 0R0
R14
6168
0
R14
6268
0
R14
6368
0
R14
6468
0
R14
6568
0
R14
6768
0
R14
6868
0
R14
6622
K
R14760R0
R14770R0
R14780R0
R14790R0
GNDRFGNDRF GNDDGNDA
C1466
R01
ILMGND
ILMGND
C14
69
R01
8mA
MA
X
140m
A M
AX
200m
A M
AX
097:RE127:EW5
FM/AM TUNER UNIT
5.0V
8.3V
3.3V
5.0V
5.0V
3.3V
3.3V
3.3V
8.3V8.3V
8.3V
8.0V8.0V8.0V8.0V
V
V
E
C14
76
R01
GNDRF
C14
58
R01
C14
52
R00
1
AV UNIT(TUNER SECTION)3/6A
2/6A
4/6A
1/6A
AVIC-F900BT/XS/EW5 1355 6 7 8
C
D
F
A
B
E
TE
MP
IN
WIR
EIN
ILM
SN
S
42 43 44 45 4613
5
136
137
138
139
R1
R63
4
100K
R63
3
1K
WAKE
5
5
DD
O
DD
I
VS
S
VC
C1
CLK
1
NC
SLV
ST
S(M
S5T
OS
YS
)V
RE
F
S-M
eter
TU
NS
LA
VS
SW
RE
MIN NC
TM
PIN
VDD8(R
VDD8(D
VDD5
3.3V
5.0V
5.0V
5.0V
8.0V
3.3V
1 2 3 4
10.4 AV UNIT(SYSTEM uCOM SECTION)(GUIDE PAGE)
A-a 4/6
4/6A
CTOSYSV5
CP
UW
DT
5
MS
5TO
SY
S3
DV
DV
DV
DL
DV
DR
TX
CTOSYSV3
OFFANS3
RDSLK
RDT
RCK
RDS57K
SRCMUTE
TU
NS
L
RX
TX
OF
FA
NS
5
SY
ST
OC
5
SY
ST
OC
3
SY
ST
OC
V3
SY
ST
OC
V5
OF
FIN
FO
3
OF
FIN
FO
5
BA
TF
AU
LT5
TUNDO
TUNDI
TUNCLK
TUNCE1
TUNCE2
HLDET
DVEJKY
DDO3
DDI3
RSTIN
DCE3
DCL3
BCLOCK3
DRST3
TUNDO
TUNDI
TUNCLK
TUNCE1
TUNCE2
HLDET
S-meter
DINT3
SDA
SCL
SD/DO
WIREIN
WCONT
DVDR
DVDL
DVDV
TUNSL
VST
SELSCL
SELSDA
VDT
VCK
SRCMUTE
LEDDT
ROT0
ROT1
RE
SE
TB
RESETB
RSTOUTCTOSYS3
CTOSYSV3
SYSTOCV3
SYSTOC3
BATFAULT3
OFFINFO3
CPUWDT3
ASENBO
IPPW
RX
SY
ST
OM
S53
XR
ES
3
OPTON
OPTSNS
CTOSYS5
CTOSYS3
AMUTE
NOSELL
NOSELRIR
QP
W3
XR
ES
3
XR
ES
5
MS
5_S
TA
ND
BY
3
WA
KE
UP
SY
ST
OM
S55
SY
ST
OM
S53
AM
UT
E
BDATABDATA
CP
UW
DT
3
MUTE
REM
IRQ
PW
3
RCK
RDS57K
RDT
RDSLK
TELMUTE
LEDCK
LEDCS
OF
FA
NS
3
BA
TF
AU
LT3
MS
5TO
SY
S5
SY
ST
OM
S55
BSCK
RS
TIN
NFCONT
IRQ
PW
5OPTSNS
RX
DCL3
GNDA
RESETB
GNDV
DRST3
GNDD
SYSTES
CPUWDT3
L705
DDO3
TX
C604
R1
DCE3
C705 R1
L601
DTC124EUAQ752
NOSELL
ROT0
GNDD
TUNCE1
DVDR
L711
DTC124EUAQ751
VDT
SD/DO
SRCMUTE
C61
3
R1
C708 R1
SCL
TUNCLK
HRDT
IPPW
HRLK
DTC124EUAQ753
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37 38 39 40 4114
0
141
142
143
144
L609
WCONT
L610
WIREIN
SELSDA
DTC124EUAQ754
GNDD
R60
1
100K
BCLOCK3
DVDL
GNDD
L707
C61
4
R1
C615R1
R60
2
100K
FB
701
CT
F14
53
C602
R1
GNDP
GNDD
GNDD
IC603
TC7SH04FUS1
NC1
INA2
GND3
OUTY4
5VCC
HLDET
R63
2
0R0
L708
DVDV
DDI3
IC604
TC7S32FU
IN_B1
IN_A2
GND3
OUT_Y4
5VCC
GNDD
C61
7
ROT1
L713
L605
AMUTE
C709
R1
BATFAULT3
GNDD
IC608
BD5335FVE
VOUT1
SUB2
CT3
GND4
5VDD
L608
L704
VCK
DINT3
LEDDT
R71
4
0R0
TUNDO
SYSTOC3
SYSTOCV3
GNDD
OFFANS3
R62
822
K
2 14 365 87
GNDD
L602
CTOSYS3
GNDA
C609 R1
L714
RSTIN
OPTON
L611
OFFINFO3
DVEJKY
TUNCE2
C601R1
HRHSLK
GNDD
NOSELR
R608
680
2
1
4
3 6
5
8
7
R71
5
0R0
TUNDI
TUNSL
SDA
L710
LEDCS
L709
C60
7
R01
5
GNDV
SELSCL
C706 R1
GNDD
GNDD
C605R1
VST
GNDD
C707 R1
CN702
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
HRCK
CTOSYSV3
GNDP
ASENBO
L706
LEDCK
IC605
TC74VHCT08AFTS1
1A1
1B2
1Y3
2A4
5 2B
6 2Y
7 GND 83Y
93A
103B
114Y
124A
134B
14VCC
GNDA
L712
L604
R72
2
100K
S-meter
GNDD
L607
C606
R1
GNDD
R614470
R6152R2K
R613470
R6170R0
R6160R0
IC609
TC74VHC08FTS1
1A1
1B2
1Y3
2A4
5 2B
6 2Y
7 GND 83Y
93A
103B
114Y
124A
134B
14VCC
IC607
TC74VHC08FTS1
1A1
1B2
1Y3
2A4
5 2B
6 2Y
7 GND 83Y
93A
103B
114Y
124A
134B
14VCC
R619
100K
R612
100K
R62
7
100K
R607
680
R618100K
GNDD
R688 100K
R689 100K
X601
VS
S11
86
1
2
3
VD5
AM
UT
XR
ES
IRP
Q
HS
T
SLV ST
BY
DVR DVVG
DA
G
R603
22
R609
100K
R610
1K
R604
22
GNDD
R60
5
100K
C623
R01
C71
1
R01
GNDD
IC601
TC7SH08FUS1
INB1
INA2
GND3
OUTY4
5Vcc
R717
0R0
TELMUTE
R620100
R71
8
220
R62
6
220
R69
7
100K
R69
8
100K
GNDD
GNDD
MS
8V
MS
8VR
BSCK
BSO
PGND
VCC1
GNDD
GNDD
GNDD
C60
8
R1
R73
10R
0
NFCONT
DG
ND
UV
DD
5
AN
AR
OU
T
NC
MVDD
PG
ND
AG
ND
DG
ND
VID
EO
GN
D
VID
EO
GN
D
NAVI3
DG
ND
VD
D8(
DR
Y)
OR 5 5P
GN
D
UVDD5
IRQ
PW
R
AG
ND
UVDD
VD
D5
NC
YPG
ND
CV
BS
UA
RT
SP
EE
D
VID
EO
GN
D
VD
D8(
RE
G)
3 5 AND
AN
ALO
UT
VD
D5
XR
ES
AG
ND
VID
EO
GN
D
DG
ND
BUP3
CR
WA
KE
UP
NC
CB
AM
UT
E
VD
D8(
DR
Y)
VD8
NC
HS
TC
MD
SLV
ST
S
VD
D5
ST
AN
BY
UV
DD
5
UVDD5
NA
VI3
NA
VI3
NA
VI3
UV
DD
5
UV
DD
5
INV5 5
20.000MHz
BSO/TSOBSCK/TSCK
REMOCON
NC
TUNDO
TUNDI
TUNCLK
TUNCE1
TUNCE2
NC
NC
NC
SYSTEST
RDSLK
BYTE
CNVSS
RDT
RDS57K
RESET
XOUT
VSS
XIN
VCC1
NMI
RCK
LDET
NC
DCE
BCLOCK
VICSON
FREQSWRX
TX
HS
TC
MD
(SY
ST
OM
S5)
BS
I/TS
IA
VC
C
NAVI LEVEL SHIFT
5 3 AND
NAVI3
UV
DD
5
NC
NC
NC
AND 5 3
AND 5 3
DG
ND
VD
D5
DRST
DVD
SRCMUTE
RESET
HR
3.3V
3.3V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
8.0V8.0V
3.3V3.3V3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
V3.3V3.3
NAVI UART(VICS)
NAVI UART
DVL DVV
6/6A
1/6A
5/6A
2/6A
3/6A
CN19012/2C
C63
6
R1
AVIC-F900BT/XS/EW51361 2 3 4
C
D
F
A
B
E
OF
FIN
FO
5
SY
ST
OM
S55
1
2
3
4
5
6
7
8
9
0
1
2
3
4
5
6
7
8
9
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37 38 3914
2
143
144
C615R1
GNDV
35 36 37 38
GNDD
DVVG
R717
0R0
100K
100K
GND
GND
VID
EO
GN
D
VID
EO
GN
D
CR
CB
BSO/TSOBSCK/TSCK
REMOCON
NC
TUNDO
TUNDI
TUNCLK
TUNCE1
TUNCE2
NC
NC
NC
SYSTEST
RDSLK
BYTE
CNVSS
RDT
RDS57K
RESET
XOUT
VSS
XIN
VCC1
NMI
RCK
LDET
NC
DCE
BCLOCK
VICSON
FREQSWRX
NC
NC
NC
DRST
5 6 7 8
A-b 4/6
4/6A
FANCONT
SR
EM
OT
E
SY
SP
W
IPP
W
AS
EN
BO
NOSELR
NOSELL
MUTE
FCONT
OPTON
ANTON
LEDDT
LEDCK
LEDCS
@netL
CD
RE
SE
T
BS
RQ
BR
XE
M
TE
MP
IN
WC
ON
T
TU
NS
L
NA
VIC
ON
TE
LMU
TE
WIR
EIN
VCK
VDT
VST
BSENS
VIC
SO
N
FA
NC
ON
T
BS
EN
S
VD
CO
NT
VD
D5C
ON
T
DC
SK
IP
SW
AC
PW
VD
CO
NT
VD
D5C
ON
T
OF
FIN
FO
5
XR
ES
5
OF
FA
NS
5
RS
TO
UT
CP
UW
DT
5
TEMPIN
ASENS
IRQ
PW
5
WA
KE
UP
MS5_STANDBY5
MS5_STANDBY3
MS5TOSYS5
SELSCL
SELSDA
ILM
SN
S
WA
KE
UP
OPTSNS
DV
EJK
Y
SY
ST
OC
V5
SY
ST
OC
5
CT
OS
YS
5
CT
OS
YS
V5
BSENSN
SDA
SCL
BS
EN
SN
MS5TOSYS3
RE
M
DC
SK
IPC
D
CNVSS
RO
T1
RO
T0
SD/DO
SW
AC
PW
SR
EM
OT
E
ILM
SN
S
AN
TO
N
FC
ON
T
NA
VIC
ON
SY
SP
W
SY
SP
W
DC
SK
IPC
D
DC
SK
IP
MS
5TO
SY
S5
MS
5_S
TA
ND
BY
5
NFCONT
AS
EN
S
AS
EN
S
BA
TF
AU
LT5
UVDD5
UVDD5
NA
VI3
V
VIC
SO
N
L612
SR
EM
OT
E
GNDD
R684680
2
1
4
3 6
5
8
7
VD
D5C
ON
T
VD
CO
NT
GNDD
IC610
40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
GNDD
SW
AC
PW
R662100K
C61
9
R1
FA
NC
ON
T
VD
8
R63
2
0R0
C622
R1
C621
R1
R68
3
100K
21 436 58 7
C61
7
R1
R6770R0
GNDD
C62
0
R1
GNDD
R6760R0
L613
BS
EN
S
L611
L615
MV
DD
5
L614
R682
0R0
GNDD
2SA1576AQ601
TH
601
UV
DD
5
39 40
C63
2R
1
C618R1
R66
0
100K
R64
810
0K
R65
922
IC612
TC74VHCT32AFT
1A1
1B2
1Y3
2A4
5 2B
6 2Y
7 GND 83Y
93A
103B
114Y
124A
134B
14VCC
BU
P3
L617
GNDD
C630R1
R68
5
1K
R63
4
100K
R65
710
0K
R64
3
100K
R65
0
100K
R65
410
0K
R64
6
100K
R65
510
0K
R670
100K
R64
1
10K
R64
0
10K
1K
R63
3
1K
R636100K
R65
31K
CN6011
2
3
4
5
6
7
8
9
10
GNDD
R661100KC
4786
R1
R69
0
4R7K
BS
EN
SN
10
C69
6
C4784
47P
C4785
47P
R4783
3R3K
R4784
3R3K
WAKE
SWVDD5
SWVDD5
R69
6
47
R66
3
1K
R66
4
47K
R680
4R7K
R66
8
4R7K
R68
7
100K
R68
6
100K
R665 100K
R64
2
22
R64
5
NM
R64
922
R65
222
GNDD
U695
RPMS2401-H19
1 42 3
R695
47
R666 100K
R681 47K
DTC114EUAQ662
DTC114EUAQ661
GNDD
GNDD
ILM
SN
S
AN
TO
N
DC
SK
IPC
D
FC
ON
T
NA
VIC
ON
DC
SK
IP
SY
SP
W
SY
SP
W
R69
7R
698
D
D
R69
9
100K
GNDD
TSIN
R6711K
AS
EN
S
AS
EN
S
MVDD5
NAVI3
UVDD5
UA
RT
SP
EE
D
BUP3
WA
KE
UP
VD8
MVDD5
VD8
UVDD5
UV
DD
5
UV
DD
5
UV
DD
5
FANCONT
DD
O
DC
L
DD
I
TX
RO
T0
RO
MD
AT
A
RO
T1
CD
RE
SE
T
VS
S
CT
OS
YS
V
SY
ST
OC
V
VC
C1
NC
SR
EM
OT
E
P50
SW
AC
PW
RS
TO
UT
VS
S
CP
UW
DT
BA
TF
AU
LT
OF
FIN
FO
VC
C2
OF
FA
NS
DC
SK
IPC
D
NC
CLK
1
SIM
UK
E4
NA
VIC
ON
CT
OS
YS
NC
DC
SK
IP
SY
ST
OC
NC
RO
MC
LK
SIM
UK
E3
SIM
UK
E2
SIM
UK
E1
SIM
UK
E0
/HO
LD
VCC2
NOSELL
VSS
NOSELR
SELSDA
SELSCL
NC
NC
NFCONT
MUTE
NC
NC
VST
OPTON
VDT
BSENSN
OPTSNS
VCC2
MUTEVO
ANTON
VCK
VSS
TESTIN
FCONT
SD/DO
NC
SDA
LEDDT
LEDCS
BSENS
DINT
ASENS
SCL
LEDCK
ROMCSBS
RQ
BR
ST
VD
CO
NT
BR
XE
N
WA
KE
UP
MS
5_S
TA
ND
BY
VD
D5C
ON
T
HS
TC
MD
(SY
ST
OM
S5)
SLV
ST
S(M
S5T
OS
YS
)
NC
XR
ES
NC
DV
EJK
Y
IRQ
PW
VR
EF
ILLS
NS
S-M
eter
TU
NS
L
BS
I/TS
I
WC
ON
T
AV
SS
VC
C1
AV
CC
VS
S
WR
EM
IN NC
NC
TM
PIN
IPP
WS
YS
PW
AS
EN
BO
TE
IN
NC
UVDD5
3 5 OR
BUP3
VDD8(REG):220MA MAX
VDD8(DRY):1800MA MAX
VDD5 :650MA MAX
PEG446A
NM
CNVSS
TEMPIN
3.3V
3.3V
3.3V3.3V3.3V3.3V
5.0V
5.0V
8.0V
8.0V
5.0V
5.0V
5.0V
8.0V
5.0V
5.0V
8.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V5.0V5.0V 5.0V
5.0V
5.0V
5.0V
5.0VV0.5V0.55.0V5.0V5.0V5.0V
5.0V
5.0V
5.0V
5.0V
5.0V5.0V
5.0V
5.0V
5.0V
5.0V5.0V
8.0V8.0V
3.3V
3.3V
3.3V
3.3V3.3V
5.0V
V0.5V0.5
5.0V
EW
5
RE
RE
R63
9
GNDD
C68
5R
01
6/6A
6/6A1/6A AV UNIT(SYSTEM uCOM SECTION)4/6A
C67
1
C67
2
R01
R01
AVIC-F900BT/XS/EW5 1375 6 7 8
C
D
F
A
B
E
SD
A
SC
L
99100
101
NC
SD
A
DIN
T
SC
L
5.0V
1 2 3 4
A-a
A-b
A-b 4/6
LED
DT
LED
CK
LED
CS
@ne
tL
CDRESET
BSRQ
BRXEM
TEMPIN
WCONT
BS
EN
S
VICSON
FANCONT
BSENS
VDCONT
VDD5CONT
OFFINFO5
OFFANS5
RSTOUT
CPUWDT5
AS
EN
S
MS
5_S
TA
ND
BY
5
MS
5_S
TA
ND
BY
3
MS
5TO
SY
S5
ILMSNS
DVEJKY
SYSTOCV5
SYSTOC5
CTOSYS5
CTOSYSV5
BSENSN
MS
5TO
SY
S3
CN
VS
S
ROT1
ROT0
SWACPW
SREMOTE
ILMSNS
ANTON
FCONT
NAVICON
SYSPW
SYSPW
DCSKIPCD
DCSKIP
ASENS
ASENS
BATFAULT5
NAVI3V
VICSON
L612
SREMOTE
VDD5CONT
VDCONT
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
SWACPW
C619
R1
FANCONT
VD8
R683
100K
2
1
4
36
5
8
7
GN
DD
BSENS
L615
MVDD5
UVDD5
C61
8R
1
IC61
2
TC
74V
HC
T32
AF
T
1A1
1B2
1Y3
2A4 5
2B
62Y
7G
ND
83Y
93A
103B
114Y
124A
134B
14V
CC
BUP3
L617
GN
DD
C63
0R
1
R641
10K
R640
10K
1K
R63
610
0K
R6531K
GN
DD
R690
4R7K
BSENSN
E
R686
100K
R66
510
0K
R642
22
R645
NM
R64922
R65222
R66
610
0K
R68
147
K
DT
C11
4EU
AQ
662
DT
C11
4EU
AQ
661
GN
DD
GN
DD
ILMSNS
ANTON
DCSKIPCD
FCONT
NAVICON
DCSKIP
SYSPW
SYSPW
ASENS
ASENS
MV
DD
5
VD
8
UV
DD
5
UVDD5
UVDD5
UVDD5
ROT0ROMDATA
ROT1CDRESET
CTOSYSV
SYSTOCV
NC
RSTOUT
CPUWDT
BATFAULT
OFFINFO
OFFANS
CTOSYS
SYSTOC
NC
ROMCLK
LED
DT
LED
CS
BS
EN
S
AS
EN
S
LED
CK
RO
MC
S
BSRQ
BRST
BRXEN
NC
NC
DVEJKY
ILLSNS
S-Meter
WCONT
VCC1
VSS
NC
NC
TMPIN
UV
DD
5
35
OR
BU
P3
VD
D8(
RE
G):
220M
A M
AX
VD
D8(
DR
Y):
1800
MA
MA
X
VD
D5
:6
50M
A M
AX
CN
VS
S
3.3V 3.3V
3.3V
3.3V
3.3V
3V
5.0V 5.0V
8.0V 8.0V
5.0V 5.0V
5.0V
8.0V
5.0V
5.0V
8.0V
5.0V
5.0V
5.0V 5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
.0V
5.0V
0V
8.0V
0V
3.3V 3.3V 3.3V
3.3V
.3V
R639
6/6A
6/6A
1/6A
AV
UN
IT(S
YS
TE
M u
CO
M S
EC
TIO
N)
4/6A
AVIC-F900BT/XS/EW51381 2 3 4
C
D
F
A
B
E
LED
DT
LED
CK
LED
CS
105
106
107
2
1
4
3
0A
1T
CTOSY
SYSTO
N
RSTOU
CPUWD
BATFAU
OFFINF
OFFA
CTOSY
SYSTO
N
LK
LED
CS
LED
CK
RO
MC
S
BS
BR
BRX
DVEJK
ILLSN
S-Me
WCO
VC
V
TMP
5 6 7 8
A-a
A-b
A-b 4/6
FA
NC
ON
T
SREMOTE
SYSPW
IPPW
ASENBO
NO
SE
LR
NO
SE
LL
MU
TE
FC
ON
T
OP
TO
N
AN
TO
N
NAVICON
TELMUTE
VC
K
VD
T
VS
T
BS
EN
SDCSKIP
SWACPW
VDCONT
VDD5CONT
XRES5
TE
MP
IN
AS
EN
S
IRQPW5
SE
LSC
L
SE
LSD
A
WAKEUP
OP
TS
NS
BS
EN
SN
SD
A
SC
L
REM
DCSKIPCD
SD
/DO
MS5_STANDBY5
NF
CO
NT
UV
DD
5
UV
DD
5
GN
DD
R68
468
0
21 436 58 7
GN
DDIC
610
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
737475767778798081828384858687888990919293949596979899100
101
102
103
104
GN
DD
R66
210
0K
C62
2
R1
C62
1 R1
R67
70R
0
C620
R1
GN
DD
R67
60R
0
L613
L614
R68
2
0R0
GN
DD
2SA
1576
AQ
601
TH601
C632R1
R660
100K
R648100K
R65922
R685
1K
100K
R657100K
R643
100K
R650
100K
R654100K
R646
100K
R655100K
R67
0
100K
CN
601
1 2 3 4 5 6 7 8 9 10
R66
110
0K
C4786
R1
10
C696
C47
84
47P
C47
85
47P
R47
83
3R3K
R47
84
3R3K
SW
VD
D5
SW
VD
D5
R696
47
R663
1K
R664
47K
R68
0
4R7K
R668
4R7K
R687
100K
GN
DD
U69
5
RP
MS
2401
-H19
1
4
2
3
R69
5
47
R699
100K GN
DD
TS
IN
R67
11K
FA
NC
ON
T
DDO
DCL
DDI
ROTROMDAT
ROTCDRESE
SREMOTE
P50
SWACPW
VSS
VCC2
DCSKIPCD
NC
SIMUKE4
NAVICON
NC
DCSKIP
ROMC
SIMUKE3
SIMUKE2
SIMUKE1
SIMUKE0
/HOLD
VC
C2
NO
SE
LL
VS
S
NO
SE
LR
SE
LSD
A
SE
LSC
L
NC
NC
NF
CO
NT
MU
TE
NC
NC
VS
T
OP
TO
N
VD
T
BS
EN
SN
OP
TS
NS
VC
C2
MU
TE
VO
AN
TO
N
VC
K
VS
S
TE
ST
IN
FC
ON
T
SD
/DO
NC
SD
A
LED
DT
BS
EN
S
DIN
T
AS
EN
S
SC
L
VDCONT
WAKEUP
MS5_STANDBY
VDD5CONT
XRES
IRQPW
IPPWSYSPW
ASENBOTEIN
NC
PE
G44
6A
NM
TE
MP
IN
5.0V 5.0V 5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V 5.0V
5.0V
5.0V
5.0V
V0
.5
V0
.5
5.0V
5.0V
5.0V
5.0V
5.0V
V0
.5
V0
.5
5.0V
EW5
RE
RE
GN
DD
C685R01
C671
C672
R01
R01
AVIC-F900BT/XS/EW5 1395 6 7 8
C
D
F
A
B
E
TU
NC
LK
TU
NC
E1
TU
NC
E2
SE
LSC
L
SE
LSD
A
NO
SE
LR
8 9
10S
ELS
DA
NO
SE
LR
SE
LSC
L
2R2K
R61
70R
0
R61
60R
0
UV
NA
TU
NC
LK
TU
NC
E1
TU
NC
E2
NC
50V
50V
2/6A
1 2 3 4
A-b
A-a
A-a 4/6
A-b 4/6
MS5TOSYS3
DVDV
DVDL
DVDR
TX
OF
FA
NS
3
SR
CM
UT
E
TEMPIN
WCONT
TUNSL
WIREIN
TU
ND
O
TU
ND
I
DV
EJK
Y
RS
TIN VS
T
VD
T
VC
K
SR
CM
UT
E
LED
DT
RO
T0
RO
T1
RESETBR
ES
ET
B
RS
TO
UT
CT
OS
YS
3
CT
OS
YS
V3
SY
ST
OC
V3
SY
ST
OC
3
BA
TF
AU
LT3
OF
FIN
FO
3
CP
UW
DT
3
AS
EN
BO
IPP
W RX
SYSTOMS53
XRES3
OP
TO
N
OP
TS
NS
IRQPW3
XRES3
XRES5
MS5_STANDBY3
WAKEUP
SYSTOMS55
SYSTOMS53
ILMSNS
AMUTE
BD
AT
AB
DA
TA
MU
TE
SYSTOCV5
RE
M
IRQPW3
LED
CK
LED
CS
BS
CK
RSTIN
NF
CO
NT
IRQPW5
OP
TS
NS
RX
GN
DA
RE
SE
TB
CP
UW
DT
3
L612
L705
TX
C60
4
R1
C70
5R
1 L601
RO
T0
L711
VD
T
SR
CM
UT
E
C613
R1
C70
8R
1
IPP
W
1 2 3 4 5 6 7
130
131
132
133
134
135
136
137
138
139
140
141
142
143
144
L609
GN
DD
R1
L707
C614
R1
FB701
CTF1453
C60
2
R1
GN
DP
GN
DD
GN
DD
IC60
3
TC
7SH
04F
US
1
NC
1
INA
2
GN
D3
OU
TY
45V
CC
R632
0R0
L708
IC60
4
TC
7S32
FU
IN_B
1
IN_A
2
GN
D3
OU
T_Y
4 5V
CC
RO
T1
L713
C70
9
R1
BA
TF
AU
LT3
GN
DD
IC60
8
BD
5335
FV
E
VO
UT
1
SU
B2
CT
3G
ND
45V
DD
L704
VC
K
LED
DT
R714
0R0
SY
ST
OC
3
SY
ST
OC
V3
OF
FA
NS
3
GN
DD
L602
CT
OS
YS
3
L714
RS
TIN
OP
TO
N
OF
FIN
FO
3
DV
EJK
Y
C60
1R
1
R715
0R0
L710
LED
CS
L709
C607
R015
GN
DV
C70
6R
1
GN
DD
VS
T
GN
DD
C70
7R
1
CN
702
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
CT
OS
YS
V3
GN
DP
AS
EN
BO
L706
LED
CK
L712
L604
R722
100K
C61
8R
1
GN
DD
L607
C60
6
R1
GN
DD R61
447
0R
615
R61
347
0
IC60
7
TC
74V
HC
08F
TS
1
1A1
1B2
1Y3
2A4 5
2B
62Y
7G
ND
83Y
93A
103B
114Y
124A
134B
14V
CC
R641
10K
R640
10K
1K
R633
1K
R63
100K
VD
5
AMUT
XRES
IRPQ
HST
SLV
STBY
DV
R
WA
KE
DV
VG
DAG
R642
GN
DD
R605
100K
C711
R01 GN
DD
IC60
1
TC
7SH
08F
US
1
INB
1
INA
2
GN
D3
OU
TY
45V
cc
R71
7
0R0
R718
220
R626
220
MS8V
MS8VR
BS
CK
BS
O
PG
ND
NF
CO
NT
DGND
UVDD5
ANAROUT
NC
MV
DD
5
PGND
AGND
DGND
VIDEO GND
VIDEO GND
NA
VI3
DGND
VDD8(DRY)
OR
55
PGND
IRQPWR
AGND
UV
DD
5
VDD5
NC
Y
PGND
CVBS
UARTSPEED
VIDEO GND
VDD8(REG)
ANALOUT
VDD5
XRES
AGND
VIDEO GND
DGND
BU
P3
CR
WAKEUP
NC
CB
AMUTE
VDD8(DRY)
VD
8
NC
HSTCMD
SLVSTS
VDD5
STANBY
DD5
NAVI3 VI3
UVDD5
INV
55
BS
O/T
SO
BS
CK
/TS
CK
RE
MO
CO
N
NC
TU
ND
O
TU
ND
I
SYSTOCV
VREF
ILLSNS
S-Meter
TUNSL
BSI/TSI
WCONT
AVSS
VCC1
AVCC
WREMIN
NC
NC
TMPIN
UVDD5
AN
D 5
3
AN
D 5
3DGND
VDD5
VD
D8(
RE
G):
220M
A M
VD
D8(
DR
Y):
1800
MA
M
VD
D5
:6
50M
A M
AX
DV
D
SR
CM
UT
E
RE
SE
T
3.3V
3.3V
3.3V
5.0V
5.0V 5.0V
5.0V 5.0V
5.0V
5.0V
5.0V
5.0V 5.0V 5.0V 5.0V
5.0V
5.0V
5.0V
5.0V
8.0V
8.0V
8.0V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V 3.3V 3.3V
DV
LD
VV
R639
6/6A
1/6A
5/6A
CN
1901
2/2C
AVIC-F900BT/XS/EW51401 2 3 4
C
D
F
A
B
E
RE
M
BS
CK
2 3 4
SB
SC
KB
SO
/TS
OB
SC
K/T
SC
K
RE
MO
CO
N
SYSTO
F
ILLSN
S-Me
L
WCO
VC
C
WREM
TMP
5 6 7 8
A-b
A-a
A-a 4/6
A-b 4/6
CT
OS
YS
V5
CPUWDT5
CT
OS
YS
V3
RD
SLK
RD
T
RC
K
RD
S57
K
RX
TX
NAVICON
OFFANS5
SYSTOC5
SYSTOC3
SYSTOCV3
SYSTOCV5
OFFINFO3
OFFINFO5
BATFAULT5
TU
ND
O
TU
ND
I
TU
NC
LK
TU
NC
E1
TU
NC
E2
HLD
ET
DD
O3
DD
I3
DC
E3
DC
L3
BC
LOC
K3
DR
ST
3
TU
ND
O
TU
ND
I
TU
NC
LK
TU
NC
E1
TU
NC
E2
HLD
ET
S-m
eter
DIN
T3
SD
A
SC
L
SD
/DO
WIR
EIN
WC
ON
T
DV
DR
DV
DL
DV
DV
TU
NS
L
SE
LSC
L
SE
LSD
A
CT
OS
YS
5
CT
OS
YS
3
DCSKIP
AM
UT
E
NO
SE
LL
NO
SE
LR
CPUWDT3
RC
K
RD
S57
K
RD
T
RD
SLK
TE
LMU
TE
OFFANS3
BATFAULT3
MS5TOSYS5
SYSTOMS55
DC
L3
GN
DV
DR
ST
3
GN
DD
SY
ST
ES
DD
O3
DC
E3
DT
C12
4EU
AQ
752
NO
SE
LL
GN
DD
TU
NC
E1
DV
DR
DT
C12
4EU
AQ
751
SD
/DO
SC
L
TU
NC
LK
HR
DT
HR
LK
DT
C12
4EU
AQ
753
5 6 7 8 9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
WC
ON
T
L610
WIR
EIN
SE
LSD
A
DT
C12
4EU
AQ
754
R601
100K
BC
LOC
K3
DV
DL
GN
DD
C61
5R
1
R602
100K
HLD
ET
DV
DV
DD
I3
GN
DD
C617
R1
L605
AM
UT
E
L608
DIN
T3
TU
ND
O
GN
DD
R62822K
2
1
4
3 6
5
8
7
GN
DA
C60
9R
1
L611
TU
NC
E2
HR
HS
LK
GN
DD
NO
SE
LR
R60
8
680
21 436 58 7
TU
ND
I
TU
NS
L
SD
A
SE
LSC
L
GN
DD
C60
5R
1
HR
CK
IC60
5
TC
74V
HC
T08
AF
TS
1
1A1
1B2
1Y3
2A4 5
2B
62Y
7G
ND
83Y
93A
103B
114Y
124A
134B
14V
CC
GN
DA
S-m
eter
R61
447
0R
615
2R2K
R61
347
0
R61
70R
0
R61
60R
0
IC60
9
TC
74V
HC
08F
TS
1
1A1
1B2
1Y3
2A4 5
2B
62Y
7G
ND
83Y
93A
103B
114Y
124A
134B
14V
CC
R61
9
100K
R61
2
100K
R627
100K
R60
7
680
R634
100K
R61
810
0K
100K
GN
DD
R68
810
0K
R68
910
0K
X60
1
VSS1186
1
2
3
R60
3
22
R60
9
100K
R61
0
1K
R60
4
22
C62
3
R01
TE
LMU
TE
R62
010
0
R697
100K
R698
100K
GN
DD
GN
DD
VC
C1
GN
DD
GN
DD
GN
DD
C608
R1 R7310R0
UV
DD
5
35
AN
D
UVDD5
UV
DD
5
NAVI3
NAVI3
UVDD5
20.0
00M
Hz
NC
TU
ND
O
TU
ND
I
TU
NC
LK
TU
NC
E1
TU
NC
E2
NC
NC
NC
SY
ST
ES
T
RD
SLK
BY
TE
CN
VS
S
RD
T
RD
S57
K
RE
SE
T
XO
UT
VS
S
XIN
VC
C1
NM
I
RC
K
LDE
T
NC
DC
E
DDO
DCL
DDI
BC
LOC
K
VIC
SO
N
FR
EQ
SW
RX
TX
VSS
VCC1
DCSKIPCD
NC
CLK1
NAVICON
NC
DCSKIP
HSTCMD(SYSTOMS5)
SLVSTS(MS5TOSYS)VRE
TUNS
BSI/TSI
AVSS
AVC
NA
VI L
EV
EL
SH
IFT5
3 A
ND
NA
VI3
NC
NC
NC
DR
ST
HR
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
3.3V
3.3V 3.3V 3.3V
V3
.3
V3
.3
NA
VI U
AR
T(V
ICS
)
NA
VI U
AR
T
2/6A
3/6A
C636
R1
AVIC-F900BT/XS/EW5 1415 6 7 8
C
D
F
A
B
E
1 2 3 4
10.5 AV UNIT(RGB LED DRIVER SECTION)
5/6A
BLUE
RED
GREEN
R36
05 1K
C36
02 10
R36
12
100
R36
08 1K
R3601
220K
UMX1N
Q3603
E11
B12
C23
E24
5B2
6C1
M62343FP
IC3601
A011
A022
A033
VCC4
GND
6DI
7CLK
8LD
R36
03
2R2K
R36
09
2R2K
C36
07
4R7
C36
01
4R7
ILMGND
R36
06
2R2K
ILMGND
R36
02 1K
UMX1N
Q3604
E11
B12
C23
E24
5B2
6C1
R3604
220K
C36
04
4R7
UMX1N
Q3602
E11
B12
C23
E24
5B2
6C1
R3607
220K
L360
1
UMX1N
Q3601
E11
B12
C23
E24
5B2
6C1
R36
10
120
R36
11
100 (1/1
6W)
(RED)
(MA
X 1
2.0m
A)
(BLUE)
RGB_LED DRIVER PART
(RED)
5.0V5.0V
5.0V
8.0V8.0V
8.0V
8.0V
8.0V
8.0V
8.0V
8.0V
8.0V
5
(GREEN)
C36
11 5
60P
C36
12 5
60P
C36
13 5
60P
AVIC-F900BT/XS/EW51421 2 3 4
C
D
F
A
B
E
N
4
E24
5B2
6C1
)
C36
13 5
60P
5 6 7 8
5/6A
LEDCS
UMX1N
Q3605
E11
B12
C23
E24
5B2
6C1
UMX1N
Q3606
E11
B12
C23
E24
5B2
6C1
LEDDT
ILG2
GNDD
R36
24
100
ILMGND
LEDCK
ILMG
ILMV
R36
18
100
ILMGND
ILMB
ILMGND
GNDD
ILMRILR2
ILB2
R36
16
120
R36
17
150 (1
/16w
) R36
22
150
(1/1
6w)
R36
23
180
ILV2
SWVDD5
GNDD
R3629
0R0
(BLUE)
(MA
X 1
0.8m
A)
(MA
X 9
.0m
A)
5.0V5.0V
8.0V
8.0V
(GREEN)
AV UNIT(RGB LED DRIVER SECTION)5/6A
4/6A
1/6A
AVIC-F900BT/XS/EW5 1435 6 7 8
C
D
F
A
B
E
FU4662
CEK12582.5A
U4642
EK12582.5A
8.0V
>
>
1 2 3 4
10.6 AV UNIT(IF SECTION)(GUIDE PAGE)
A-a 6/6
6/6A
NAVICON
FCONT
FCONT
FCONT
FANV
KMODEOUT
PKBOUT
DCSKIP
VDCONT
VDD5CONT
DCSKIPCD
TX
RX
IPPW
ASENBO
VDCONT
DCSKIP
NAVICON
FCONT
FANCONT
ASENS
BSENS
VDD5CONT
IPR
IPRG
IPLG
IPL
KMOD
FANUP
SYSPW
PKB
BSENSN
VD8
C46
69
R47
GNDD
R46
50
100K
R46
77
1M
C46
70 R1
R461210
PKBOUT
C46
7410
R46
46
8R2K
R4609
150K
C46
1310
C4646
1
DVD5
C46
42
100P
C4605 33P
R46
45
560
330/6R3C4611
L4641
(33uH)
C46
1410
R4671
150K
R4654 180K
R46
48
47K
R46
7618
0K
C46
09
R47
R46
41
560
(1/4
W S
A)
R46
010R
0
R46
063R
3K
L4662
(10uH)
DTC114EUAQ4661
R46
52
820K
C4665 33P
FU4641
CEK1259
GNDD
R46
72
820K
R46
1418
0K
GNDD
GNDD
GNDD
D4661
RB400D
C46
7210
GNDD
R46
0510
0
C4647 R1
GNDD
GNDD
GNDD
GNDD
NAVI5V
GNDD
NAVI5
330/6R3C4671
GNDD
R46
08
47K
GNDD
C46
02
R00
1
GNDD
R46
44
0R0
L4661
(33uH)
GNDD
R46
10
820K
C4608 4R7
GNDD
R46
47
1R5K
D46
62
RB
060L
-40
GNDD
C4666
1
C46
03
R1
R467410
F
C
SP8K2
Q4602
S11G12S23G24
D2-26
D2-17
D1-28
D1-1
C4644
R047
C46
41
R01
MVDD5
C4604
R047
C4664
R047
R467310 (1/10W)
R46
49
3R3K
C46
61R
01
C46
10 R1
GNDD
FC8
C46
43
R1
DTC114EUAQ4601
R46
68
3R3K
GNDD
R46
151M
R46
0710
0K
GNDD
R4651
150K
R46
620R
0
C46
49
R47
GNDD
D46
02
RB
060L
-40
R46
70
47K
C4668 4R7
R4656 10
R46
43
330
FU4661
CEK12582.5A
GNDD
R46
57
1M
C4606
1
VD8
IC4661
TPS5103IDB
Vref=1.185(V)
SS1
INV2
FB3
CT4
5 RT6 GND7 REF8 COMP9 RWMSKIP
10 STBY 11VREG5V_IN
12VREF5
13VCC
14VCC_SENSE
15TRIP
16OUTGND
17OUT_D
18LL
19OUT_U
20LH
R4666
47K
D4601
RB400D
GNDD
NAVI5GND
R46
6910
0K
NAVI5GND
IC4601
TPS5103IDB
Vref=1.185(V)
SS1
INV2
FB3
CT4
5 RT
6 GND
7 REF
8 COMP
9 RWMSKIP
10 STBY 11
VREG5V_IN
12
VREF5
13
VCC
14
VCC_SENSE
15
TRIP
16
OUTGND
17
OUT_D
18
LL
19
OUT_U
20
LH
C46
7310
R46
6710
0
R4653
10
IC4641
TPS5103IDB
SS1
INV2
FB3
CT4
5RT
6GND
7REF
8COMP
9RWMSKIP
10STBY
11VREG5V_IN
12VREF5
13VCC
14VCC_SENSE
15TRIP
16OUTGND
17OUT_D
18LL
19OUT_U
20LH
DTC114EUAQ4641
L4642(10uH)
KMODEOUT
C46
63
R1
R4611 10 (1/10W)
FANV
SP8K2
Q4663
S11G12S23G24
D2-26
D2-17
D1-28
D1-1
C46
01
R01
GNDD
C4645 33P
GNDD
C46
62
R00
1
C46
1210
DTC114EUAQ4662
D4643RB083L-20
220/
10
C46
51
C46
53
10
C46
52
10
SP8K2
Q4642
S11G12S23G24
D2-26
D2-17
D1-28
D1-1
D46
42R
B06
0L-4
0
C46
54
10
D4641
RB400D
C46
504R
7
GNDD
L4601
L4602
R46
02
220
R46
03
4R7K
R46
04
1R5K
R46
63
180
R46
64
4R7K
R46
65
1R5K
DV8
R46
78
220
GNDD
ILMV
FU4602CEK1261
C46074R7
C46674R7
C46484R7
R46
80
0R0
VDCONT
RX
FCONT
ASENS
TX
BSENSN
BSENS
FANCONT
DCSKIPCD
VDD5CONT
ASENBO
DCSKIP
NAVICON
IPPW
IPRG
IPLG
IPL
IPR
KMOD
FANUP
SYSPW
PKB
GNDA
GNDA
FC5N
FC5D
C46
17R
1
C46
1810
C46
19R
1
C46
00R
001
C46
5510
C46
57R
001
C46
56R
1
C46
76R
1
C46
77R
001
C46
7510
GNDD
C46
59R
1
C46
16R
001
C46
58R
001
C46
79R
1
C46
78R
001
FU4601CEK1261
(D)
DVD5V
(D)
(1/8
W)
(1/10W)
(D)
(D)
Vref=1.185(V)
(D)
(D)
(D)(Y
B)
DVD8V
(D)
(D)
NAVI5V
(D)
(D)
(D)
(D)
(D)
(13.5V)
(YB)
(YB)
10uH
27uH
5.0V
H:10.6V/L:7.4V
8.0V
8.0V
8.0V
8.0V
8.0V
5.0V
V0.5V0.5
V0
.5
V0
.5
5.0V
5A
5A
3.15A
(D)
5
5
5
R46
162R
2K
GNDD
>
>
>
>
2/6A
4/6A
1/6A
AVIC-F900BT/XS/EW51441 2 3 4
C
D
F
A
B
E
R46
77
1M
L4662
(10uH)
GNDD
GNDD
D4643RB083L-20
02261
C46
59R
1
C46
58R
001
(13.5V
A
>
5 6 7 8
A-b 6/6
6/6A
IPRG
IPPW
IPLG
IPR
IPL
RX
BSENS
FANUP
FANCONT
ASENS
FANV
KMODEOUT
PKBOUT
KMOD
PKB
ASENB
SYSPW
BSENSN
SYSPW
TX
NKBUP
BU
BU
BU
ASENBO
BK
EE
P
BKEEP
VD
D5
VDD5
D4772RB500V-40
BU
GNDD
DTA114EUAQ4771
FANGND
C47
51R
1
VD
D5
GNDD
D47
22
MA
LS06
8X
IPR+
D4731HZU7R5(B3)
47/1
6C
4774
R47
33
6R8K
C47
21
4700
P
BSI
FU4662
CEK12582.5A
GNDD
D47
52
1SS
355
D47
26U
DZ
S18
(B)
IPL-
GNDD
IPR-
L4701
KBUP
R4732
47K
EF4732
3
2
1
DTC114EUA
Q4772
NS3
C47
31
R1
C47
10
R1
C47
07R
1
R4751
100
D4771
RB500V-40
FNV
Q47
312S
C40
81
R47
7847
0
(1/4
W)
R4723100
FANGND
D47
33R
B50
0V-4
0
EF4731
3
2
1
IPL+
R4724
1K
R47
7722
0
(1/1
0W)
L4721
R4731
2R2K
100/
16C
4776
10/1
6
C47
05
Q47
332S
C40
81
R47
21
4R7K
GNDD
C47
75R
01
R4722100
GNDD
FU4771
CEK1254
L4723
2SA1576AQ4751
R4727
62
CN1021
1
2
3
4
5
6
7
8
9
10
11
IPBUS
D47
35R
B50
0V-4
0
10/1
6C
4704
R4726100
C47
73R
01
2SA1576AQ4752
BUP
GNDD
D47
24
MA
LS06
8X
GNDD
GNDD
D47
21
MA
LS06
8X
R47
34
10K
IPBUS-
L4725
FU4642
CEK1258
IPRG
L4724
R47
56
10K
D47
32R
B50
0V-4
0
DTC114EUAQ4775
Q47
74
IMX
1
1E6
1B5
2C4
2E32
2B
11C
R47
35
100K
C47
09
R1
D4773HZU8R2(B1)
BSB
C47
32
R1
C47
24R
1
HA12241FP
IC4721
DIN11
ROUT2
DIN23
GND4
BUS-
6BUS+
7VCC
8STBY
IPAS
GNDD
R4758
2R7K
C4771
R1
D47
23
MA
LS06
8X
D47
27U
DZ
S18
(B)
D47
34
ED
Z20
(B)
GNDD
D47
25
UD
ZS
18(B
)
UVDD5
R4736
3R3K
GNDD
IC4703S-L2980A33MC-C6S
VIN1
VSS2
ON/OFF3
NC4
5VOUT
GNDD
R47
54
10K
D47
74
HZ
U11
(B2)
R4752
100
R4737
10K
NAVI3V
C47
72
4700
P
R4725100
2SA1587Q4773
D4751
1SS355
C47
02R
1
GNDD
L4722
FNB
BUP3
Q47762SD1760F5
R4757
0R0
DTC114EUAQ4753
2SA1576AQ4754
R4749
4R7K
R47
504R
7K
R47551M
R47
53
1M
D47
36R
B50
0V-4
0
Q47
382S
C40
81
D4737HZU7R5(B3)R4738
47K
R47
39
100K
NBSINBSB
GNDD
C47
061C
4701 1
GNDD
BUP3
NA3B
BSN
NBSN
TP4736
TP4735
IPLG
R4773
10K
R47
71
4R7K
R47
74
5R1K
R47
75
220K
R47
76
4R7K
R47
72
4R7K
GNDD
C46
31
R1
D46
31
UD
ZS
9R1(
B)
GNDD
UMD2N
Q4632GND1 1
IN1 2
OUT1 3 GND24
5 IN2
6 OUT2
Q46312SD1767
R47
28
4R7K
BD3931HFPIC4701
1V
CC
2N
C1
3G
ND
4N
C2
5V
O
NKBUP
NAVIC
FU4631
CEK1247200mA
GNDD
C46
79R
1
C46
78R
001
DTC114EUAQ4732
R46
33
820
2SA1576AQ4734
IP-B
US
INIPL+
IPL-
IPBUSG
IPR-
IPBUS-
NC
ASENBO
IPBUS+
IPRG
IPR+
IPLG
ASENB
2.5A
)
UVDD5
BUP3
MAX 150mA
VDD5
RE
ILMV
IP-BUS
BUP
NAVIC
PARKING SENS/KMODE
FAN DRIVER
VDD5
V0
.5
V0
.5
V0
.5
V0
.5
V0
.5
V0
.5
V0
.5
V0
.5
V0
.5
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
5.0V
3.3V3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
V4.7:L/V6.01:HV4.7:L/V6.01:H
H:1
0.6V
/L:7
.4V
8.0V
8.0V
8.0V
5.0V
1A
RE
5
>>
>
>
1/6A
1/6A
AV UNIT(IF SECTION)6/6A
AVIC-F900BT/XS/EW5 1455 6 7 8
C
D
F
A
B
E
PK
BO
UT
VDD5
752
S355
R47
51
100
2SA
1576
AR
4758
IC47
03S
-L29
80A
33M
C-C
6S
VIN
1
VS
S2
5V
OU
T
1SS
355
R1
BU
P3
R4
3
M
BU
P3
5.0V
3
.0V
1 2 3 4
A-a
A-b
A-b 6/6
IPR
G
IPP
W
IPLG
IPR
IPL
RX
BS
EN
S
AS
EN
B
BS
EN
SN
TX
NK
BU
P
BU
BU
AS
EN
BO
BKEEP
D4722
MALS068X
IPR
+
D47
31H
ZU
7R5(
B3)
R4733
6R8K
C4721
4700P
BS
I
GN
DD D4726
UDZS18(B)
IPL-
GN
DD
IPR
-
L470
1
KB
UP
R47
32
47K
EF
4732
3
2
1
NS
3
C4731
R1
C4707R1
Q47312SC4081
R47
2310
0
D4733RB500V-40
EF
4731
3
2
1
IPL+
R47
24
1K
L472
1
R47
31
2R2K
10/16
C4705
Q47332SC4081
R4721
4R7K
R47
2210
0
GN
DD
L472
3
Q47
51
R47
27
62
CN
1021
1234567891011
IPB
US
D4735RB500V-40
R47
2610
0
BU
P
GN
DD
D4724
MALS068X
GN
DD
GN
DD
D4721
MALS068X
R4734
10K
IPB
US
-
L472
5
IPR
G
L472
4
D4732RB500V-40
R4735
100K
C4709
R1
BS
B
C4732
R1
C4724R1
HA
1224
1FP
IC47
21
DIN
11
RO
UT
2
DIN
23
GN
D4
BU
S-
6B
US
+
7V
CC
8S
TB
Y
IPA
S
2R7K
D4723
MALS068X
D4727UDZS18(B)
D4734
EDZ20(B)
GN
DD
D4725
UDZS18(B)
UV
DD
5
R47
36
3R3K
GN
DD
GN
DD
R4754
10K
R47
37
10K
NA
VI3
V
R47
2510
0
D47
51
L472
2
2SA
1576
AQ
4754
R47
49
4R7K
4750R7K
D4736RB500V-40
Q47382SC4081
D47
37H
ZU
7R5(
B3)
R47
38
47K
R4739
100K
NB
SI
NB
SB
GN
DD
C47061
C47011 G
ND
D
NA
3B
BS
N
NB
SN
TP
4736
TP
4735
IPLG
R4728
4R7K
BD
3931
HF
PIC
4701
1VCC
2NC1
3GND
4NC2
5VO
NK
BU
P
NA
VIC
GN
DD
DT
C11
4EU
AQ
4732
2SA
1576
AQ
4734
IP-BUS IN
IPL+
IPL-
IPB
US
G
IPR
-
IPB
US
-
NC
AS
EN
BO
IPB
US
+
IPR
G
IPR
+
IPLG
AS
EN
B
UV
DD
5
MA
X 1
50m
A
VD
D5
RE
IP-B
US
BU
P
NA
VIC
PA
RK
ING
SE
NS
/KM
OD
E
VD
D5
V0 . 5 V0 . 5 V0 . 5 V0 . 5
5.0V
5.0V
5.0V
5.0V 5.0V 5.0V 5.0V
5.0V
3.3V
3.3V
.3V
3.3V
8.0V
5.0V
RE
5
>
1/6A
AV
UN
IT(I
F S
EC
TIO
N)
6/6A
AVIC-F900BT/XS/EW51461 2 3 4
C
D
F
A
B
E
C470R1
10/16
C470
C47
R1
NA
VI3
V
2SA
1576
AQ
4754
NA
3B
3.3V
3.3V
8.0V
5 6 7 8
A-a
A-b
A-b 6/6
FA
NU
P
FA
NC
ON
T
AS
EN
S
FA
NV
KM
OD
EO
UT
PK
BO
UT
KM
OD
PK
B
SY
SP
W
SY
SP
W
BU
BK
EE
PVDD5
VD
D5
R4677
1M
D47
72R
B50
0V-4
0BU
GN
DD
DT
A11
4EU
AQ
4771
FA
NG
ND
C4751R1
VDD5
GN
DD
47/16 C4774
FU
4662
CE
K12
582.
5A
D4752
1SS355
DT
C11
4EU
A
Q47
72
L466
2
10uH
)
C4710
R1
R47
51
100
D47
71
RB
500V
-40
FN
V
R4778470
(1/4W)
FA
NG
ND
R4777220
(1/10W)
100/16 C4776
GN
DD
C4775R01
FU
4771
CE
K12
54
2SA
1576
AQ
4751
10/16C4704
C4773R01
2SA
1576
AQ
4752
GN
DD
FU
4642
CE
K12
58
R4756
10K
DT
C11
4EU
AQ
4775
Q4774
IMX1
1E 6
1B5
2C 42E
3
2 2B
1 1C
DD
D47
73H
ZU
8R2(
B1)
GN
DD
R47
58
2R7K
C47
71
R1
IC47
03S
-L29
80A
33M
C-C
6S
VIN
1
VS
S2
ON
/OF
F3
NC
45V
OU
T
GN
DD
R4754
10K
D4774
HZU11(B2)
R47
52
100
C4772
4700P
2SA
1587
Q47
73
D47
51
1SS
355
C4702R1
GN
DD
FN
B
BU
P3
Q47
762S
D17
60F
5
D46
43R
B08
3L-2
0
R47
57
0R0
DT
C11
4EU
AQ
4753
R47
49
4R7K
R47504R7K
R47
551M
R4753
1M
BU
P3
R47
73
10K
R4771
4R7K
R4774
5R1K
R4775
220K
R4776
4R7K
R4772
4R7K
GN
DD
C4631
R1D4631
UDZS9R1(B)
GN
DD
UM
D2N
Q46
32G
ND
11
IN1
2
OU
T1
3G
ND
24 5
IN2
6O
UT
2
Q46
312S
D17
67F
U46
31
CE
K12
4720
0mA
C4659 R1
C4658 R001
C4679 R1
C4678 R001
R4633
820
2.5A
(13.
5V)
BU
P3
ILM
V
PA
RK
ING
SE
NS
/KM
OD
E
FA
N D
RIV
ER
V0 . 5 V0 . 5 V0 . 5 V0 . 5 V0 . 5 V0 . 5
5.0V
5.0V
5.0V
3.3V 3.3V
3.3V
3.3V
3.3V
V4
.7
:L
/V
6.
01
:H
V4
.7
:L
/V
6.
01
:H
H:10.6V/L:7.4V
8.0V 8.0V
1A>>
>
>
1/6A
AVIC-F900BT/XS/EW5 1475 6 7 8
C
D
F
A
B
E
VD
8F
U46
41
CE
K12
59
R4644
0R0
FC
8
R46
56
VD
8
R46
53
8.0V
8.0V
>
1 2 3 4
A-b
A-a
A-a 6/6
A-b 6/6
NA
VIC
ON
FC
ON
T
DC
SK
IP
DC
SK
IPC
D
TX
RX
IPP
W
AS
EN
BO
VD
CO
NT
DC
SK
IP
NA
VIC
ON
FC
ON
T
FA
NC
ON
T
AS
EN
S
BS
EN
S
VD
D5C
ON
T
IPR
IPR
G
IPLG IP
L
KM
OD
SY
SP
W
BS
EN
SN
R46
1210
R46
09
150K
C461310
C46
0533
P
330/
6R3
C46
11
C461410
C4609
R47
R46010R0
R46063R3K
DT
C11
4EU
AQ
4661
R4614180K
GN
DD
GN
DD
R4605100
GN
DD
GN
DD
GN
DD
NA
VI5
V
GN
DD
NA
VI5
GN
DD
R4608
47K
C4602
R001
R4610
820K
C46
084R
7
GN
DD
GN
DD
C4603
R1
SP
8K2
Q46
02
S1 1 G1 2 S2 3 G2 4
D2-
26D2-
17D1-
28D1-
1
C46
04
R04
7
C4610R1
DT
C11
4EU
AQ
4601
R4615 1M
R4607100K
D4602
RB060L-40
C46
06 1R
4666
47K
D46
01
RB
400D
NA
VI5
GN
D
NA
VI5
GN
D
IC46
01
TP
S51
03ID
B
Vre
f=1.
185(
V)
SS
1
INV
2
FB
3
CT
4 5R
T
6G
ND
7R
EF
8C
OM
P
9R
WM
SK
IP
10S
TB
Y11
VR
EG
5V_I
N
12
VR
EF
5
13
VC
C
14
VC
C_S
EN
SE
15
TR
IP
16
OU
TG
ND
17
OU
T_D
18
LL
19
OU
T_U
20
LH
R46
1110
(1/1
0W)
C4601
R01
C461210
GN
DD
L460
1
L460
2
R4602
220
R4603
4R7K
R4604
1R5K
DV
8
ILM
V
FU
4602
CE
K12
61
C46
074R
7
VD
CO
NT R
X
FC
ON
T
AS
EN
S TX
BS
EN
SN
BS
EN
S
FA
NC
ON
T
DC
SK
IPC
D
VD
D5C
ON
T
AS
EN
BO
DC
SK
IP
NA
VIC
ON
IPP
W
IPR
G
IPLG IP
L
IPR
KM
OD
SY
SP
W
GN
DA
GN
DA
FC
5N
C4617 R1
C4618 10
C4619 R1
C4600 R001
C4616 R001
FU
4601
CE
K12
61
(D)
DV
D8V
(D)
NA
VI5
V
(D)
(D)
10uH
27uH
8.0V
8.0V
8.0V
8
5.0V
V0
.5
V0
.5
V0 . 5 V0 . 5
5A
5A
3.15
A
(D)
5
R46162R2K
GN
DD
>
>
2/6A 4/6
A
1/6A
AVIC-F900BT/XS/EW51481 2 3 4
C
D
F
A
B
E
ILM
V8.
0V8.
0V8.
0V8
5 6 7 8
A-b
A-a
A-a 6/6
A-b 6/6
FC
ON
T
FC
ON
T
FA
NV
KM
OD
EO
UT
PK
BO
UT
VD
CO
NT
VD
D5C
ON
T
FA
NU
P
PK
B
VD
8
C4669
R47
GN
DD
R4650
100K
R4677
1M
C4670R1
PK
BO
UT
C467410
R4646
8R2K
C46
46 1
DV
D5
C4642
100P
R4645
560
L464
1
(33u
H)
R46
71
150K
FU
CE 2
R46
5418
0K
R4648
47K
R4676180K
R4641
560
(1/4W SA)
L466
2
(10u
H)
R4652
820K
C46
6533
P
FU
4641
CE
K12
59
GN
DD
R4672
820K
GN
DD
GN
DD
D46
61
RB
400D
C467210
C46
47R
1
GN
DD
330/
6R3
C46
71
GN
DD
GN
DD
R4644
0R0
L466
1
(33u
H)
GN
DD
R4647
1R5K
D4662
RB060L-40
C46
66 1
R46
7410
FU
4642
CE
K12
58
C46
44
R04
7
C4641
R01
MV
DD
5
C46
64
R04
7
R46
7310
(1/1
0W)
R4649
3R3K
C4661R01
GN
DD
FC
8
C4643
R1
R4668
3R3K
GN
DD
GN
DD
R46
51
150K
R46620R0
C4649
R47
GN
DD
R4670
47K
C46
684R
7
R46
5610
R4643
330
FU
4661
CE
K12
582.
5A
GN
DD
R4657
1M
VD
8
IC46
61
TP
S51
03ID
B
Vre
f=1.
185(
V)
SS
1
INV
2
FB
3
CT
4 5R
T6
GN
D7
RE
F8
CO
MP
9R
WM
SK
IP10
ST
BY
11V
RE
G5V
_IN
12V
RE
F5
13V
CC
14V
CC
_SE
NS
E
15T
RIP
16O
UT
GN
D
17O
UT
_D
18LL
19O
UT
_U
20LH
GN
DD
R4669100K
C467310
R4667100
R46
53
10
IC46
41
TP
S51
03ID
B
SS
1
INV
2
FB
3
CT
4 5R
T6
GN
D7
RE
F8
CO
MP
9R
WM
SK
IP10
ST
BY
11V
RE
G5V
_IN
12V
RE
F5
13V
CC
14V
CC
_SE
NS
E
15T
RIP
16O
UT
GN
D
17O
UT
_D
18LL
19O
UT
_U
20LH
DT
C11
4EU
AQ
4641
L464
2(1
0uH
)K
MO
DE
OU
T
C4663
R1
FA
NV
SP
8K2
Q46
63
S1 1 G1 2 S2 3 G2 4
D2-
26D2-
17D1-
28D1-
1
GN
DD
C46
4533
P
GN
DD
C4662
R001
DT
C11
4EU
AQ
4662
D46
43R
B08
3L-2
0
220/10
C4651
C4653
10
C4652
10
SP
8K2
Q46
42
S1 1 G1 2 S2 3 G2 4
D2-
26D2-
17D1-
28D1-
1 D4642RB060L-40
C4654
10
D46
41
RB
400D
C46504R7
R4663
180
R4664
4R7K
R4665
1R5K
DV
8
R4678
220
GN
DD
C46
674R
7
C46
484R
7
R4680
0R0
FA
NU
P
PK
B
FC
5D
C4655 10
C4657 R001
C4656 R1
C4676 R1
C4677 R001
C4675 10
GN
DD
C4659 R1
C4658 R001
C4679 R1
C4678 R001
(D)
DV
D5V
(D)
(1/8W)
(1/1
0W)
(D)
Vre
f=1.
185(
V)
(D)
(D)
(D)
(YB)
DV
D8V
(D)
2.5A
(D)
(D)
(D)
(13.
5V)
(YB
)
(YB
)
5.0V
H:1
0.6V
/L:7
.4V
8.0V
8.0V
5.0V
3.15
A
5
5
>
>
>
AVIC-F900BT/XS/EW5 1495 6 7 8
C
D
F
A
B
E
1K1R
6K
AV
1 2 3 4
10.7 KEYBOARD UNIT
B
D801
NSSM025-6502
CN802
1
2
3
4
D80
5
MA
LS06
8X
D80
2
MA
LS06
8X
D80
7
MA
LS06
8X
D80
6
MA
LS06
8X
C805
R1
C806
R1
GNDKEY
C80
3R
01
C80
4R
01
GNDKEY
R80
3R
804
D803
NM
D804
NM
CN8011
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
C80
2N
M
C80
1N
M
D853
D854
D855
D856
D852
D857
D858
D863
D864
D866
D867
D86
8M
ALS
068X
D86
9M
ALS
068X
D87
0M
ALS
068X
D87
1M
ALS
068X
D87
2M
ALS
068X
C85
6N
M
C85
4N
M
R850
NM
GNDKEYGNDKEY
R802 0R0
R801 0R0
D859
D860
D861
D862
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU5R6(B2)
HZU11(B2)
HZU11(B2)
HZU11(B2)
HZU11(B2)
AUX-VG
AUX-V
AUX-AG
AUX-L
AUX-R
GNDKEY
ROT1
ROT0
ILMB
ILMG
ILMR
KEY1
KEY0
ILMV
EJECT
RESET
GNDKEY
PA
NE
L U
NIT
OT
J2
BT-LED
RGB ILM
R
G
BINT_KEY0
INT_KEY1
NC
NC
9V
9V
9V
5V
5V
AVIC-F900BT/XS/EW51501 2 3 4
C
D
F
A
B
E
802
1
2
3
4
R80
3R
804
0R0
0R0
5 6 7 8
B
CSG1155
S805
1
2
3
4
CSG1155
S804
1
2
3
4
CSG1155
S802
1
2
3
4
CSG1155
S801
1
2
3
4
GNDKEY
GNDKEY
CN8031 2
3
1K1R
6K
R806
3K
R808
10K
R807
1R3K
R80
9
2R7K
R80
5
12K
D809
NM
D808
RB521S-30
D81
1
NM
D81
2
RB
521S
-30
D810
NM
SMLE12BC7T(NP)
D815
C807
NM
R810
240
ANT801
CTX1095
1RF_I/O
2GND3NC1
4NC2
5NC3
6NC4
CSX1135
S803
Phase_A 1
Enc_Com 2
A 3
B 4
5Com 6 GND
7 C
8 D
9 Push
10 Phase_B
EJECTRESET
AV-IN
BT-ANT
ROTARY COMMANDER
A
B
C
DPUSH
2
3
4
1
BT-ILM
NAVI UNITBTJ2
MAPMENU SIGNAL
KEY1
KEY0
SW
MAP
C
B
A
PUSH
MENU
D
VOLTAGE[V]
2.63
1.93
1.30
0.66
2.64
1.65
0.81
5V
B KEYBOARD UNIT
AVIC-F900BT/XS/EW5 1515 6 7 8
C
D
F
A
B
E
F
1 2 3 4
10.8 DVD CORE UNIT(1/2)(GUIDE PAGE)
1/2C
C-a 1/2
CWW1465
2/2CF
FT
RF SIGNALFOCUS SERVO LINETRACKING SERVO LINECARRIAGE SERVO LINESPINDLE SERVO LINE
T
C
S
AVIC-F900BT/XS/EW51521 2 3 4
C
D
F
A
B
E
5 6 7 8
1/2C
C-b 1/2
CWW1466
DVD CORE UNIT(1/2)
2/2C
1/2C
2/2C
2/2C
PIC
KU
P U
NIT
(SE
RV
ICE
)(D
P8)
E
M2,M3
M1
D
2/2C
F
T
TF T
F
F
T
SC
C
S
SC
SC
�
�
���
��
AVIC-F900BT/XS/EW5 1535 6 7 8
C
D
F
A
B
E
1 2 3 4
C-a
C-b
C-b 1/2 1 2
DV
D C
OR
E U
NIT
(1/2
)
2/2C
1/2C
2/2C
PICKUP UNIT(SERVICE)(DP8)
F
T
FT
S C
�
AVIC-F900BT/XS/EW51541 2 3 4
C
D
F
A
B
E
F
5 6 7 8
C-a
C-b
C-b 1/2
CW
W14
66
2/2C
E
M2,
M3
M1
D
2/2C
TF
T F
SC
C
S
SC
�
�� �
� �
AVIC-F900BT/XS/EW5 1555 6 7 8
C
D
F
A
B
E
1 2 3 4
C-b
C-a
C-a 1/2
C-b 1/2 1 22/2
CF
FT
RF
SIG
NA
LF
OC
US
SE
RV
O L
INE
TR
AC
KIN
G S
ER
VO
LIN
EC
AR
RIA
GE
SE
RV
O L
INE
SP
IND
LE S
ER
VO
LIN
E
T C S
AVIC-F900BT/XS/EW51561 2 3 4
C
D
F
A
B
E
5 6 7 8
C-b
C-a
C-a 1/2
C-b 1/2
CW
W14
65
AVIC-F900BT/XS/EW5 1575 6 7 8
C
D
F
A
B
E
1 2 3 4
10.9 DVD CORE UNIT(2/2)
2/2C
1/2C
1/2D
1/2C
1/2C
1/2C
NAVI UNITOTJ4
AVIC-F900BT/XS/EW51581 2 3 4
C
D
F
A
B
E
5 6 7 8
2/2C
1/2C
1/2C
1/2C
DVD CORE UNIT(2/2)2/2C
CN702
4/6A
1/2C
AVIC-F900BT/XS/EW5 1595 6 7 8
C
D
F
A
B
E
1 2 3 4
10.10 COMPOUND UNIT(A) AND COMPOUND UNIT(B)
D E
E
D
COMPOUND UNIT(B)
COMPOUND UNIT(A)
CLAMP
C 1/2
S1201
Q1299
S1202 S1204
S1203
R1298
0R0
1
2
3
4
5
6
S1205
R1299
0R0CPT231SCTD
CSN1069
CSN1069
CSN1069
CSN1067
CSN1070
CSN1070
12cm
8cm
DISC SENSDISC SENS
8cm
CN1301C 1/2
AVIC-F900BT/XS/EW51601 2 3 4
C
D
F
A
B
E
5 6 7 8
AVIC-F900BT/XS/EW5 1615 6 7 8
C
D
F
A
B
E
1 2 3 4
10.11 WAVEFORMS
1RF 0.2 V/div(AC) 0.1 μs/div 1RF 0.2 V/div(AC) 50 ns/div 1RF 0.2 V/div(AC) 50 ns/divCDRF(x 4 CLV) CDRF(x 20 CAV Inner peripheral) CDRF(x 20 CAV Peripheral)
1RF 0.2 V/div(AC) 50 ns/div 1RF 0.2 V/div(AC) 50 ns/div 1RF 0.2 V/div(AC) 50 ns/divDVDRF(x 1.3 ZCAV) DVDRF(x 5 CAV Inner peripheral) DVDRF(x 5 CAV Peripheral)
1RF 0.5 V/div 100 μs/div 2TD1 0.1 V/div 100 μs/div 2TD1 0.1 V/div 100 μs/divDVDRF(BD1 mm) Interval FWD Interval REV
VHALF VHALF2.2 Vt
- DVD CORE UNIT Note:1. The encircled number denote measuring points in the circuit diagram. 2. Reference voltage: 1.65 V(TD1,FD1)(=VHALF) 2.2 V(RF)(=VREF)
In the waveform, it is seeing on the GND standard.Offset of 1.65 V or 2.2 V is put in.
AVIC-F900BT/XS/EW51621 2 3 4
C
D
F
A
B
E
5 6 7 8
2TD1 0.1 V/div 500 μs/div 2TD1 0.1 V/div 500 μs/div 2CH1 : TD1 0.5 V/div 10 ms/divMulti 32 FWD Multi 32 REV 3CH2 : A+-A- 10.0 V/div 10 ms/div
4CH3 : B+-B- 10.0 V/div 10 ms/div
Traverse 900 FWD(Short)
VHALF
0t
VHALF VHALF
0t
2CH1 : TD1 0.5 V/div 10 ms/div 2CH1 : TD1 0.5 V/div 20 ms/div 2CH1 : TD1 0.5 V/div 20 ms/div3CH2 : A+-A- 10.0 V/div 10 ms/div 3CH2 : A+-A- 10.0 V/div 20 ms/div 3CH2 : A+-A- 10.0 V/div 20 ms/div
4CH3 : B+-B- 10.0 V/div 10 ms/div 4CH3 : B+-B- 10.0 V/div 20 ms/div 4CH3 : B+-B- 10.0 V/div 20 ms/div
Traverse 900 REV(Short) Traverse 5 000 FWD(Long) Traverse 5 000 REV(Long)
VHALFVHALF VHALF
0t 0t 0t
0t 0t 0t
3CH : A+-A- 10 V/div 50 ms/div 2TD1 0.5 Vdiv 20 ms/div 5FD1 0.5 V/div 1 ms/div4CH2 : B+-B- Play TD Focus CloseID search Inside t Outside
VHALFVHALF0t
0t
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
(LPF of the oscilloscope is set to 10 kHz)
5FD1 0.5 V/div 20 ms/div 5FD1 0.5 V/div 500 μs/divPlay FD Focus Jump L0tL1
VHALF VHALFVHALF
5FD1 0.5 V/div 500 μs/divFocus Jump L1tL0
AVIC-F900BT/XS/EW5 1635 6 7 8
C
D
F
A
B
E
30 35
5
1
1
5
1
5
3041
3042
R3043R
3044C
4210
R4200
638
C2912
C2932
C42
97
L
L7
L709
IC
000
L712
Q751
Q753
R2962
2
C4317
R751
R43
23
4324
R4326
328
465
R4163
R41
65
R43
67
C3041
C3042
Q3041
ONT
NASP
1 2 3 4
11. PCB CONNECTION DIAGRAM11.1 AV UNIT
A
A AV UNIT
CapacitorConnector
P.C.Board Chip PartSIDE B
SIDE A
NOTE FOR PCB DIAGRAMS1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram.2.Viewpoint of PCB diagrams
1
E
E
E
E
E
1
5
1
1
1
1 101 5 10 15 20 25
1
15
1
5
1
5
10
15
20
1
5
10
1
1
1
510
1 5
10
1
5
1
R601
D3041
R
R606
R
C4201
R3628
C4212
C4213
CN601
C4218
R621
C4219
C4220
ANT1401
R
C4232
C4233
L1403
C603C605
TH601
R4021
R4801
R4802
C4061
C4062
C4063C4064
R4811
R4812
R4813
R4814
R4238
R4815
R4239
R4816 C4070
C4071
C4072
C4073
C4075
C4076
C4078
R4821
C40
79
L1441
Y1461
L1442
L1443
C4080
C2911
D4061
D4062
VR4231
R40
61
R685
R4062
C4288C4289
L472
1
R40
71
R40
72
R4073
R4074
C4291
R4075
Y1481
R4076
L1462
C4293
R4077
R4078
C4294
L1465
C4295
R4079
D2911
R4080
R2912
R2913
C672
L1481
L1482L1483
IC602
C68
5
IC605
R4292
CN1
L7
R4296
L4371
R2941
R2942
CN1015R
2947R
2948
R2949
R2950
CN1021
Q1016
C1406
C1407
C1408
C1409
C1023
IC1000
L3601
IC1008
C430
IC1015
C4314
CN1441
C4316
R1410
R1411
R1412
R1413
C1441
C1442
C1443
C1444C
1445
Q1441
C47
21
C47
22
R1433
C47
23
R1434
C1077
R4318
C1078
C1461
C1462
C1463
C1464
C1465
C1466
R4321
R1441
R1442
R1443
R
R1444R1445
R4
T1401
T1402T1403
C1476
R761
R762
R763
R76R7C1481
R4721
C1482
R47
22
R47
23
C1484
R47
24
C1485
C4171
R47
25
C1486
R47
26
C4173C4175
C4751
C4176
Q4751
Q4752
C4371
C4372
C1494
C1495
C1498
R4164R4166
R4167
R4168
D14
81
C2830
R1481
R1482
R1483
R1484
Q2831
C2835
D47
51
C4199
C2836
Q2832
D47
52
C2837
R4751
R4752
R4753
R4754
R4755
D4371
R4756
R4757
R4758 R1491
R1493
R1495
R1496
R14
98
L603L605
C36
02
C36
03
D2835
C36
05
R2832
C36
06
R28
33
R28
35
L4271
R2836
R2837
R2838
R28
39C3611
C3612
C3613
Q3042
R4794
IC3601
10 20 30 40 50 60 70X
130
120
110
100
90
80
70
60
50
40
30
20
10
0
Y
FR
ANTENNA
FM
/AM
TU
NE
R U
NIT
IP-BUS(RE)
NAVI UNITTMJ1
FU 4631 (A,114,85) Fuse 200 mA CEK1247FU 4641 (A,141,8) Fuse 3.15 A CEK1259FU 4661 (A,136,8) Fuse 2.5 A CEK1258FU 4771 (A,115,106) Fuse 1 A CEK1254
>>>>
WIRED REMOTE
AVIC-F900BT/XS/EW51641 2 3 4
C
D
F
A
B
E
15 20
1
5
D3
C4213
C
C
TH601
C4070
C4071
C4072
C4073
R685
C4288
R40
71
R40
72
4074
4076
CN
C
C4316
RR
C417
R4166
R4167
R4168
71
Q30
70
5 6 7 8
A
SIDE A
E
E
E
E
E
E
E
E
E
E
E
E
1
5
1
5
1
5
1
5
1
5
1
5
1
1
5
10
15
20
25
30
35
40 4550 55606570
75
80
85
90
95
100
105
110115120125130135140
1 1 1
1
1
10
15
20
15
10
15
20
1
5
10
15
20
25
30
35
40
25 30 35 40 45 50
1
10
515
1
15
1
1
10
15
20
25
1
5 10
1
5 10
1
1 5 10 15L2940
C2892
D2870
041
R603
R604
R2870
R3041
R2871
R3042
R3043
R60
7
R608
R3044
C42
08
R613R614
R2880
R615R616
R617
C4210
C4212
R620
D2890
4219
D2891
R622R623
R624
L1004
Q4602
R62
7
4220
R4200
FU4631
C4611
C4612 C4613
R634
C4614
R63
5
R638
FU4641
R64
3R
644
R64
6
D4602
R64
7
C610
X601
C611
C612
R65
0
C4631
R65
1
C617
R653C618
R65
4
Q4631
R65
5
Q4632
R656
R65
7R
658
R65
9
C620
C621
C622
R66
0
R661
FU4661
R66
2
R663
R664
Q4642
C42
62
C42
63C4264
C2900
Q4261
C2901
R670
Q2900
R671
C4651
C4652
C4653 C4654
D4631
R676R677
R4632
R4633
C2910
C2912
R682
R683
R684
D4642
D4643
Q4663
R690
C2924
D2900
C4671
R4262
C4672
R4263
C4673
R694
R4264
R29
00
C4674
C2929
R2901
R2902
R2903
C2930
C2931C2932
C42
97
C2933
R4657
C2934
C2935
C4682
C4685
D4662
C4686 C4687
R4279
L4351
L4352
L704
R2924
L705
R2925
L706
R2926
L707
L708L709
D2930
C68
5
IC606
L710
1000
L711
CN1001
L712
L713
EF4353
L714
EF4354
EF4355
CN1005
EF4356
EF4357
IC610
EF4358
R4686
EF4361
CN1016
Q751
FB701
Q752
Q753 Q754
R2962
R29
63
R29
64
IC1002
IC1007
C4302
R2978
R2979
R2980
R714
R2981
R2982
R717
R2983
R718
C4312
C43134314
CN701
C4315
CN702
C4317
IC1020
C43
18
C4702
R72
2
C4704
C4705
C4708
C4710
R732
C4331
C4332
C4333C4334
C701
C4335C4336
C705
C70
6C70
7 C708
D4701
C709
4318R4319
R43204321
R751
R43
22
IC4703
R43
23
R4324
R43
25
R4326 R43
27R4328
R43
29
C4352
C4353
C2801
C2802
C2803
R764
C2804
R765
L4601
R766
L4602
R767
C4363
C4364
1
C2810
FU4771
C2812Q2811
Q2812
C2820
R4351
D4355
C2821
R4352
D43
56
C2822
D43
57
C2823
C2824
D43
58
D2802
R4163
R4164
R41
65
D4361
D4364
D4365 IC2801
D4368
D2810C4774
C4776
R43
67
R2811
C2840
C28
42
C2843
C2844
Q2841
L4641
D2821
C4786
D2822
L4642
D2823 D2824
D2825R2823
L606
IC2820
L611
L612
L613
L615
C2860C2862
L4661L4662
R2840R2841
R2846
C2870
C3041
C3042
Q2870
Q3041
42
R2852
R2853
C2880
L2930
C2881
Q2880
L4681
L4682
5
5
D43
59
2
80 90 100 110 120 130 140 150 160 170
FRONT
CCN1901
NAVI UNITOTJ1
NAVI UNITSPJ1
VEHICLE I/F
AV CONNECTOR
AVIC-F900BT/XS/EW5 1655 6 7 8
C
D
F
A
B
E
0
E
1
1
1
R609
611
R61
625
6
R630
632
R636
641
C609
C613
C4252
C4254
1
R4254
251
C2923
R695R697
R
IC
C69
C696
R
C4338
C4339C
4340
C7
IC4702
R4332
R4333
R4335
C2806
R4338
R4339
C4362
R4340
2811
0
R
R4362
R4363
R43646
08
09
R4
1 2 3 4
A
A AV UNIT
170 160 150 140 130 120 110 10
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E E
E
E
E
E
1
15
1
5
1
5
1
1
5
1
5
1
1
1
1
1
5
10
1
1
5
1
5 10
1
10
1
5
10
15
20
1
5
10
15
20
1
5
10
15
20
R2860
R2861
R2862
R2863
R2864
R2865
R2866
R2867
R2868
C2890
R2869
C2891
Q661
D2871
FU460
Q662
D2872
FU4602
D2873
D2874
R605
R2872R2873
R2874
R2875
D2880
R
R2881
R2883 R2884
R619
C4600
C4601
C4602
C4603
C4604
R
C4605
Q4601
R62
C4606
C4607
C4608
R629
C4609
IC2890
C4610
R631
R
R633
C4616
C4617
R637
C4618C4619
R639C601
C604
R640
R
C606
R642
FU4642
R645
D4601
R648
R649
R4601
R4602
R4603
R4604
R4605
R4606
R4607
C614
R4608
R4609IC4601
C616
R652
R4610
C4251
R4611
R4612
C4253
R4613
R4614
R4615
C4641
C4642
FU4662
C4643
C4644
C629
R665
C4645
Q4641 R666
C4646
R667
C4647
R668
C4648
C4261
C4649
C630
C631
C632
C633
R4628
C634
C4650
C4655
C4656C4657
C4658
C4659
R679
R680
R681
R425
C4661
R4252
C4662
R4253
C4663
C4664
R4255
C4665
Q4661
D4641
R686
C4666
Q4662
R687
C4667
Q4664
C4668
IC4
C4669
R4641
R4642
R4643
R4644
R4645
R4646
R4647
C4670
R4648
R691
R4261
R4649
IC4641
R692
R693
C4675
C4676
C4677
C4678
R698
R4650
C4679
R699
R4651
R4652
R4653
R4654
R4655
R4656
D2910
C4681
D2912
C4683
C4684
R2910
R2911
D4661
Q4681Q4682
C4688
R4662
R4663
R4664
R4665
R4666
R4667
R4668
R4669
IC4661
L701
L702
R4670
R4671R4672
R4673
R4674
R4675
EF4731
R4676
EF4732
IC603
EF4733
R4677
R4678
IC604
R4679
IC607
D4681
EF4351
D4682
EF4352
R4680
R4681
R4682 R4683R4684
IC611
R4685
EF4359
IC612
R4687R4688
IC4681
EF4360
R701
R702
R703
R704
R705
R706
R707
R708
R709
R710
R711R712R713
R716
L2870
IC1021
L2871L2872
C4703
C4711
R733
FU4351
FU4352
Q4331
C702
C703
C4337
C704
D4702
R4701
C710
C4731
C4732
Q4731
Q4732
Q4733
Q4734
C4351
Q4738
R4331
R4337
R768
C4361
C
R4343
Q281
D4731
R4346
D4732D
4733
D4734
D4735
R4731
D4736
R4732
D4737
R4733
R4734
D4351
R4735
D4352
R4736
D4353
R4737
R4738
D4354
R4739
D2801
R2801
R2802
R2803
D4360
R2804
D4362
D4363
R4361
C4771
C4772
D4366
C4773
Q601
Q4771
C4775
R436
Q4772Q4773
R2810
Q4774
Q4775
Q4776
C2841
C4784
Q2840
D2820
C4785
R2820
L601
R2821
R2822
L604
L607
L6
R2829
L6
D4771
D4772
D4773
D4774
D4775
R4771
D4776R
4772
R4773
L614
R4774
R4775
R4776
L617
R4777
R4778
C2861
D2840
Q2860
Q2861
Q2862
Q2863Q2864
R2842
R4783
R2843
R4784
R2844
R4785
R2845
R2847
R2848
R2849
C2871
C2872
R2850
R2851
C2882
D2860
Q2881
D2861
Q2882
D2862 D2863
R2882
Q2865
5
5
1
1
FU 2900 (B,71,7) Fuse 250 mA CEK1276FU 4351 (B,116,117) Fuse 40 A MINISMDC075F/24FU 4352 (B,128,133) Fuse 3.15 A CEK1259FU 4601 (B,103,60) Fuse 5 A CEK1261FU 4602 (B,143,58) Fuse 5 A CEK1261FU 4642 (B,157,71) Fuse 2.5 A CEK1258FU 4662 (B,147,55) Fuse 2.5 A CEK1258
>>>>>>>
AVIC-F900BT/XS/EW51661 2 3 4
C
D
F
A
B
E
E
1
5
1
5
1
F
C4601
Q46014608
R629 R6
R633
R
R639 R6
C6
R642
R645
648
R649
R4601
C
C616
R652
C4251
C4253
C4261
C632
R4252
R4
R4255
R4261
98
IC607
R701
R708
R709
716
IC1021
C4703
Q43
C702
C4337
R4331
R4337
C4361
R4343
D4352
R4361
5 6 7 8
A
SIDE B
100 90 80 70 60 50 40 30 X
130
120
110
100
90
80
70
60
50
40
30
20
10
0
Y
20 10
E
E
E
E
E
E
E
E
E
E
1
5
1
5
1
1
1
5
10
15
20 25 30
35
40
45
505560
1510
15
20
25 30 35
40
45
1
1 5
1
15
15
1
5
1
5
11 1
11 1
1
10
1 5
101
1
5
10
15
20
25
R3610
R3611
R3612
R3613
R3614
R3615
R3616
R3617
R3618
R3619
U4601
R602
R3620
C4200
R609
R3621
R3622
C4202
C4203
R3623
R3624
C4204
R3625
R3626
C4206
R3627
C4207
R610
R3629
R611
R612
R618
C4211
C4215
C4216
C4217
R625
R4001
R626
R628
C4221
C4222
C4224
R63031
R632
R636
637C4231
L1401
L1402
Q4231
Q4232
C602
40
R641
06
C607
C608
C609
C4241
FU
2900
C613
614
C615
C619
L1421
L1422
C4252
L1423
C4254
R4616
C623
R4231
R4232
R4233
R4234
R4041
R4235
R4236
R4237
R4240
R4241
C635
L4701
C636
X1481
C4271
C4273 C4274C4275
C4276
C4277
C4278
C4279
R4251
253
R4254
R688
C4280
R689
C4281
IC4251
C4282
C4283C4284
C2920
C4285
C2921
C4286
C2922
C4287
C2923
C2925
L4722
C2926
C2927
L4723
C2928
L4724
R695
L4725
R696
R697
C4290
L1461
C4292
L1463
L1464
C4296
R4271
R4272
R4273
R4274
R4275 R4276
R4277
R4278
IC4271
C671
R4280
R4281
R4282
R4283
R4284
R2920
R4285
R2921
R4286
R2922
R4287
R2923
R4288
R4289
IC601
L4171
L4172
R4290
R4291
R4293
IC608
R4295
IC609
L4372
C695
C696
C697
R2940
R2943
R2944
R2945
R2946
L731
R2951
R2952
R2953
R2954
C1401C1402
C1403
C1404
R2959
C1405
Q1401
C1020
C1021
C1022
R2960
R2961
R2967
R2968
R2969
R2970
R2971
R2972
R2973
R2974
R2975
C1421
C4301
C1422
R2976
R2977
C1423
C4303
C4304
C1424
Q1421
Q4301
C1425
C1426
R1016
R715
IC1016
R1409
C4311
Q4311
Q4312Q4313
Q4314
C4701C4706
C4707
C4709
D4301
R731
C4711
R1421
R4301
R1422
R1423
R1424
R1425
R1426
C4719
C1451C1452C1453C1454
C1455
D4311
31
C1456
D4312
Q4332
C1457
Q4333
C1458
C4338
R4311
C4339
R4312
R4313
R4314
C4724
R4316 R4317
C4340
C4341
C4342
C711
C4151
C4152C
4153
C1467
C1468
C4154
C1469IC4701
C4155
C4156
IC4702
C4157 C4158
C4159
C1470
C1471
C1472
C1473
C4160
C1474
C4161
C1475
D4331
C2800
R4332
R4333 R4334
C2805
D4721
R4335
C2806
D4722
R4336
D4723
D4724
R4338
D4725
R4339
C4362
D4726
C1483
D4727
C4172
C1487
R4727
R4728
C4174
C1488
R4340
R1461
C1489
C2811
IC4721
R4341
R1462
R4342
C4177
R1463R1464
Q2810
R4344
R4151
R1465
R4345
R4152
R1466
R4346
Q4753
R4153
R1467
R4347
Q4754
R4154
R1468
R4348
R1469
C1491
R4155
C1492
R4156
C1493
R4157
R4158 R4159
C4181
L4231
C4182
C4183
C1497
C4184
R1470
R1471
C4185
C4186
R1472
R1473
C4187
R4160
C4188
R1474
R4161
C4189
R1475
R1476
R4162
R1477R1478
R1479
C4190
C4191
C4192
C4193
C4194
R4749
C4195
C2831
R4362
C2832
R4363
C4197
C2833
R4364
R4170
C4198
R4365
R4171
R1485
R4366
R1486
R1487
R4173
R4174
R4750
R1488
R4175
R1489IC1481
ZNR1401
R4176
IC4171
D4372
R1490
R1492 R1494
R1497
L602
R4187
R4188
L607
L608
L609
D2830D2831
U695
C3601
L610
C3604
R2830
R4194
R4195
R2831
Q3601
Q3602
Q3603
C3607
Q3604
R2834
R4198
C3608
R4199
Q3605
Q3606
IC2830
R4779
R4780
R4781
2874RR
3601
R3602
R3603
R3604
R3605
R3606
R3607
R3608
R3609
1
1
DVV
DVVG
FRVFRG
AVIC-F900BT/XS/EW5 1675 6 7 8
C
D
F
A
B
E
1 2 3 4
11.2 KEYBOARD UNIT
B
SIDE AB KEYBOARD UNIT
1
1
1
1
1
15
1
5
10
1
R802
R807
R809
R810
CN802
C801
C803
C804
C805
C806
C807
R850
S801
S802
S803
S804
S805
D801
D802D805
D809
D810
D815
D854D855
D857
D858
D861
D862
D863D866
D867
D869
D870
D871
D872
ANT801
10 20X
90
80
70
60
50
40
30
20
10
0
Y
AV-IN
ROTARYCOMMANDER
RESET
MENU
EJECT
MAP
BT-ANTENNA
AVIC-F900BT/XS/EW51681 2 3 4
C
D
F
A
B
E
5 6 7 8
B
SIDE BB KEYBOARD UNIT
20 10X
90
80
70
60
50
40
30
20
10
0
Y
1 5 10 15 20
R801
R803
R804
R805
R806
R808
CN801
CN803
C802
C854C856
D803
D804
D806
D807
D808
D811
D812
D852D853D856
D859
D860
D864
D868
PANEL UNITOTJ2
NAVI UNITBTJ2
AVIC-F900BT/XS/EW5 1695 6 7 8
C
D
F
A
B
E
1 2 3 4
11.3 DVD CORE UNIT
C
C DVD CORE UNIT
010 20 4030
10
20
30
40
50
60
70
80
X
Y
PICKUP UNIT(SERVICE)
M2, M3
M1
E
AVIC-F900BT/XS/EW51701 2 3 4
C
D
F
A
B
E
0
UNITE)
5 6 7 8
C
SIDE A
50 60 70 80 90
ACN702
AVIC-F900BT/XS/EW5 1715 6 7 8
C
D
F
A
B
E
1 2 3 4
C
C DVD CORE UNIT
5060708090
D
AVIC-F900BT/XS/EW51721 2 3 4
C
D
F
A
B
E
5
5 6 7 8
C
SIDE B
0102040 300
10
20
30
40
50
60
70
80
X
Y
AVIC-F900BT/XS/EW5 1735 6 7 8
C
D
F
A
B
E
1 2 3 4
11.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B)
ED
ED
C
C
CLAMP
12cm
S1201
R1298
R1299
Q1299
CN1301
16
DISC SENSS1204
DISC SENSS1203
8cmS1202
8cmS1205
COMPOUND UNIT(B)COMPOUND UNIT(A)
AVIC-F900BT/XS/EW51741 2 3 4
C
D
F
A
B
E
5 6 7 8
12. ELECTRICAL PARTS LISTNOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V The expression of the unit in this manual is shown by u instead of µ. Please do not make a mistake.
Circuit Symbol and No. Part No.
Unit Number : CWN3169(EW5)
Unit Number : CWN3179(RE)
Unit Name : AV Unit
Unit Number :
Unit Name : Keyboard Unit
Unit Number : YWX5005
Unit Name : DVD Core Unit
Unit Number : CWX3595
Unit Name : Compound Unit(A)
Unit Number : CWX3559
Unit Name : Compound Unit(B)
AUnit Number : CWN3169(EW5)Unit Number : CWN3179(RE)Unit Name : AV Unit
MISCELLANEOUS
IC 601 (B,46,6) IC TC7SH08FUS1IC 603 (B,121,44) IC TC7SH04FUS1IC 604 (B,121,41) IC TC7S32FUIC 605 (A,42,8) IC TC74VHCT08AFTS1IC 607 (B,105,30) IC TC74VHC08FTS1
IC 608 (B,97,44) IC BD5335FVEIC 609 (B,27,8) IC TC74VHC08FTS1IC 610 (A,107,34) IC PEG446AIC 612 (B,109,42) Logic IC TC74VHCT32AFTIC 1002 (A,147,7) IC NJM2904M
IC 1007 (A,88,128) IC PAL007CIC 1008 (A,56,38) IC NJM2125FIC 1015 (A,64,47) IC NJM4558VIC 1016 (B,69,33) IC BA4558RFVM
IC 2801 (A,168,99) IC BA00CC0WCP-V5
IC 2820 (A,168,88) IC BA00CC0WCP-V5IC 2830 (B,33,36) IC BA00BC0WFPIC 2890 (B,156,104) IC TPD1018FIC 3601 (A,11,20) IC M62343FPIC 4171 (B,67,49) IC AN15887A
IC 4251 (B,103,107) IC NJM2505AFIC 4271 (B,68,73) IC PML018AIC 4601 (B,118,65) IC TPS5103IDBIC 4641 (B,150,24) IC TPS5103IDBIC 4661 (B,150,40) IC TPS5103IDB
IC 4701 (B,88,55) IC BD3931HFPIC 4703 (A,86,45) IC S-L2980A33MC-C6SIC 4721 (B,44,129) IC(RE) HA12241FPQ 601 (B,116,19) Chip Transistor 2SA1576AQ 661 (B,116,46) Chip Transistor DTC114EUA
Q 662 (B,113,22) Chip Transistor DTC114EUAQ 751 (A,79,33) Chip Transistor DTC124EUAQ 752 (A,80,40) Chip Transistor DTC124EUAQ 753 (A,80,37) Chip Transistor DTC124EUAQ 754 (A,84,35) Chip Transistor DTC124EUA
Q 1016 (A,56,31) Transistor IMD2AQ 1401 (B,38,104) Transistor(EW5) 2SC3357Q 1421 (B,38,95) Transistor(EW5) 2SC3127Q 1441 (A,35,86) Transistor(EW5) 2SC3130Q 2810 (B,102,98) Transistor 2SD1760F5
Q 2811 (A,103,96) Chip Transistor DTA114EUAQ 2812 (A,110,98) Chip Transistor DTC114EUAQ 2840 (B,143,8) Transistor DTC114WKQ 2841 (A,157,6) Chip Transistor DTC114EUAQ 2860 (B,120,106) Transistor UMD2N
Q 2861 (B,120,109) Transistor UMD2NQ 2862 (B,112,104) Transistor 2SC4081Q 2863 (B,118,113) Transistor UMD2NQ 2864 (B,115,111) Chip Transistor DTC114EUAQ 2865 (B,112,111) Chip Transistor DTC124EUA
Q 2870 (A,150,112) Transistor 2SC4116Q 2880 (A,164,111) Chip Transistor DTC114EUAQ 2881 (B,124,24) Chip Transistor DTC114EUAQ 2882 (B,122,19) Chip Transistor 2SA1576A
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1755 6 7 8
C
D
F
A
B
E
1 2 3 4
Q 2900 (A,165,123) Transistor 2SC4116
Q 3041 (A,76,50) Transistor IMD3AQ 3042 (A,71,54) Transistor FMG12Q 3601 (B,30,21) Transistor UMX1NQ 3602 (B,22,18) Transistor UMX1NQ 3603 (B,14,18) Transistor UMX1N
Q 3604 (B,28,15) Transistor UMX1NQ 3605 (B,19,17) Transistor UMX1NQ 3606 (B,10,16) Transistor UMX1NQ 4231 (B,59,23) Transistor 2SC4081Q 4232 (B,55,18) Chip Transistor 2SA1576A
Q 4312 (B,77,39) Transistor IMD3AQ 4314 (B,77,34) Transistor DTC323TKQ 4331 (B,102,91) Transistor FMG12Q 4332 (B,93,85) Transistor FMG12Q 4333 (B,93,92) Transistor FMG12
Q 4601 (B,106,64) Chip Transistor DTC114EUAQ 4602 (A,117,65) FET SP8K2Q 4631 (A,119,86) Transistor 2SD1767Q 4632 (A,126,86) Transistor UMD2NQ 4641 (B,140,22) Chip Transistor DTC114EUA
Q 4642 (A,150,24) FET SP8K2Q 4661 (B,112,72) Chip Transistor DTC114EUAQ 4662 (B,139,38) Chip Transistor DTC114EUAQ 4663 (A,151,40) FET SP8K2Q 4731 (B,143,87) Transistor 2SC4081
Q 4732 (B,129,98) Transistor(RE) DTC114EUAQ 4733 (B,150,89) Transistor 2SC4081Q 4737 Transistor(RE) 2SA1576AQ 4738 (B,141,91) Transistor 2SC4081Q 4751 (A,31,12) Chip Transistor 2SA1576A
Q 4752 (A,32,8) Chip Transistor 2SA1576AQ 4753 (B,35,10) Chip Transistor DTC114EUAQ 4754 (B,32,6) Chip Transistor 2SA1576AQ 4771 (B,110,93) Chip Transistor DTA114EUAQ 4772 (B,112,92) Chip Transistor DTC114EUA
Q 4773 (B,115,92) Transistor 2SA1587Q 4774 (B,114,85) Transistor IMX1Q 4775 (B,127,85) Chip Transistor DTC114EUAQ 4776 (B,122,93) Transistor 2SD1760F5D 2802 (A,159,105) Diode RB060L-40
D 2810 (A,106,95) Diode UDZS5R6(B)D 2821 (A,159,92) Diode RB060L-40D 2822 (A,110,94) Diode DAN202UD 2823 (A,120,80) Diode 1SR154-400D 2824 (A,127,80) Diode 1SR154-400
D 2825 (A,131,47) Diode 1SS400GD 2831 (B,38,26) Diode RR264M-400D 2840 (B,152,6) Diode 1SS355D 2860 (B,124,105) Diode MA111D 2861 (B,119,104) Diode UDZS8R2(B)
D 2862 (B,116,108) Diode DAN202UD 2863 (B,113,107) Diode DAN202UD 2870 (A,153,106) Diode UDZS5R1(B)D 2871 (B,169,130) Diode UDZS18(B)D 2872 (B,169,126) Diode UDZS18(B)
D 2873 (B,167,130) Diode 1SS355D 2874 (B,158,111) Diode PTZ18AD 2880 (B,152,131) Diode 1SR154-400D 2890 (A,155,110) Diode 1SR154-400
Circuit Symbol and No. Part No.D 2891 (A,158,110) Diode 1SR154-400
D 2900 (A,170,125) Diode HZU8R2(B1)D 2910 (B,146,72) Diode KS926S2D 2911 (A,59,93) Diode RB060L-40D 2912 (B,145,102) Diode KS926S2D 2930 (A,140,107) Diode ST70-27F
D 3041 (A,71,50) Diode DAP202KD 4061 (A,60,48) Diode EDZ4R3(B)D 4062 (A,58,48) Diode 1SS355D 4311 (B,82,30) Diode DAN202KD 4312 (B,86,32) Diode DAN202K
D 4331 (B,91,96) Diode DAP202KD 4351 (B,109,113) Diode EDZ20(B)D 4352 (B,107,112) Diode EDZ6R8(B)D 4353 (B,123,133) Diode MALS068XD 4354 (B,124,133) Diode MALS068X
D 4355 (A,121,109) Diode DAN202UD 4356 (A,111,119) Diode MALS068XD 4357 (A,107,119) Diode MALS068XD 4358 (A,117,119) Diode MALS068XD 4359 (A,121,119) Diode MALS068X
D 4360 (B,129,112) Diode 1SR154-400D 4361 (A,131,107) Diode 1SS355D 4362 (B,129,106) Diode 1SR154-400D 4363 (B,113,119) Diode MALS068XD 4364 (A,128,106) Diode PTZ27(B)
D 4365 (A,125,106) Diode PTZ27(B)D 4366 (B,122,133) Diode MALS068XD 4371 (A,41,117) Diode UDZS5R6(B)D 4372 (B,44,123) Diode UDZS5R6(B)D 4601 (B,126,60) Diode RB400D
D 4602 (A,115,71) Diode RB060L-40D 4631 (A,122,89) Diode UDZS9R1(B)D 4641 (B,159,21) Diode RB400DD 4642 (A,147,30) Diode RB060L-40D 4643 (A,163,17) Diode RB083L-20
D 4661 (B,159,36) Diode RB400DD 4662 (A,147,46) Diode RB060L-40D 4721 (B,48,122) Diode(RE) MALS068XD 4722 (B,50,118) Diode(RE) MALS068XD 4723 (B,54,115) Diode(RE) MALS068X
D 4724 (B,49,127) Diode(RE) MALS068XD 4725 (B,56,115) Diode(RE) UDZS18(B)D 4726 (B,63,115) Diode(RE) UDZS18(B)D 4727 (B,58,115) Diode(RE) UDZS18(B)D 4731 (B,146,89) Diode HZU7R5(B3)
D 4732 (B,146,93) Diode RB500V-40D 4733 (B,150,93) Diode RB500V-40D 4734 (B,145,96) Diode EDZ20(B)D 4735 (B,148,93) Diode RB500V-40D 4736 (B,141,96) Diode RB500V-40
D 4737 (B,141,95) Diode HZU7R5(B3)D 4751 (A,29,13) Diode 1SS355D 4752 (A,27,13) Diode 1SS355D 4771 (B,120,86) Diode RB500V-40D 4772 (B,122,86) Diode RB500V-40
D 4773 (B,124,83) Diode HZU8R2(B1)D 4774 (B,125,87) Diode HZU11(B2)ZNR1401 (B,16,112) Surge Protector CSA30-201NL 601 (B,123,41) Inductor CTF1410
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51761 2 3 4
C
D
F
A
B
E
5 6 7 8
L 602 (B,41,5) Inductor CTF1410
L 604 (B,120,48) Inductor CTF1410L 605 (A,42,13) Inductor CTF1410L 607 (B,103,35) Inductor CTF1410L 608 (B,100,32) Inductor CTF1410L 609 (B,100,47) Inductor CTF1410
L 610 (B,32,12) Inductor CTF1410L 611 (A,98,20) Inductor CTF1410L 612 (A,102,46) Inductor CTF1410L 613 (A,109,20) Inductor CTF1410L 614 (B,121,24) Inductor CTF1410
L 615 (A,120,34) Inductor CTF1410L 617 (B,115,44) Inductor CTF1410L 704 (A,79,71) Inductor CTF1357L 705 (A,89,69) Inductor CTF1463L 706 (A,95,63) Inductor CTF1306
L 707 (A,80,66) Inductor CTF1306L 708 (A,92,65) Inductor CTF1306L 709 (A,78,65) Inductor CTF1306L 710 (A,90,63) Inductor CTF1306L 711 (A,78,63) Inductor CTF1306
L 712 (A,76,62) Inductor CTF1306L 713 (A,79,60) Inductor CTF1306L 714 (A,93,60) Inductor CTF1306L 1004 (A,148,12) Inductor CTF1334L 1401 (B,22,112) Inductor(EW5) LCTAWR12J2520
L 1402 (B,28,110) Inductor(EW5) LCYCR10K2125L 1403 (A,45,89) Inductor(EW5) LCTAW101J2520L 1421 (B,41,96) Inductor(EW5) LCTCR22K2125L 1422 (B,29,104) Inductor(EW5) LCTCR10K2125L 1423 (B,44,88) Inductor(EW5) LCTAW101J2520
L 1441 (A,38,85) Inductor(EW5) LCTCR15K2125L 1443 (A,44,83) Chip Coil(EW5) LCTAW1R0J2520L 1461 (B,17,109) Chip Coil LCTAW4R7J2520L 1462 (A,38,70) Inductor LCTAW2R2J3225L 1463 (B,24,56) Inductor LCTAW2R2J2520
L 1464 (B,26,54) Chip Ferrite Bead CTF1399L 1465 (A,33,40) Inductor LCTAW2R2J3225L 2870 (B,166,126) Inductor CTF1410L 2871 (B,159,114) Inductor CTF1410L 2872 (B,148,114) Inductor CTF1410
L 2930 (A,135,94) Choke Coil 600 uH CTH1347L 2940 (A,90,11) Inductor CTF1334L 3601 (A,16,13) Chip Coil LCTAW100J2520L 4171 (B,71,62) Chip Coil LCTAW100J2520L 4172 (B,59,60) Chip Coil LCTAW100J2520
L 4231 (B,63,25) Inductor CTF1473L 4271 (A,65,85) Inductor LCYA2R2J2520L 4351 (A,124,110) Inductor LCTC2R2K1608L 4352 (A,129,112) Inductor CTF1556L 4371 (A,38,117) Inductor CTF1334
L 4372 (B,40,123) Inductor CTF1334L 4601 (A,106,63) Choke Coil 27 uH CTH1402L 4602 (A,129,63) Choke Coil 10 uH CTH1403L 4641 (A,140,21) Inductor CTH1255L 4642 (A,160,24) Inductor CTH1257
L 4661 (A,140,34) Inductor CTH1255L 4662 (A,161,39) Inductor CTH1257L 4701 (B,86,44) Inductor CTF1393L 4721 (A,43,129) Inductor(RE) LCYC2R2K1608
Circuit Symbol and No. Part No.L 4722 (B,49,123) Inductor(RE) CTF1334
L 4723 (B,49,120) Inductor(RE) CTF1334L 4724 (B,52,114) Inductor(RE) CTF1334L 4725 (B,48,125) Inductor(RE) CTF1334T 1401 (A,40,104) Coil(EW5) CTC1194T 1402 (A,42,95) Coil(EW5) CTC1193
T 1403 (A,32,96) Coil(EW5) CTC1192TH601 (A,69,28) Thermister CCX1051X 601 (A,91,33) Resonator 20.000 MHz VSS1186VR4231 (A,55,25) Semi-fixed 1 kohm(OB) CCP1483>FU2900 (B,71,7) Fuse 250 mA CEK1276
>FU4351 (B,116,117) Fuse 40 A MINISMDC075F/24>FU4352 (B,128,133) Fuse 3.15 A CEK1259>FU4601 (B,103,60) Fuse 5 A CEK1261>FU4602 (B,143,58) Fuse 5 A CEK1261>FU4631 (A,114,85) Fuse 200 mA CEK1247
>FU4641 (A,141,8) Fuse 3.15 A CEK1259>FU4642 (B,157,71) Fuse 2.5 A CEK1258>FU4661 (A,136,8) Fuse 2.5 A CEK1258>FU4662 (B,147,55) Fuse 2.5 A CEK1258>FU4771 (A,115,106) Fuse 1 A CEK1254
FB701 (A,92,77) Inductor CTF1453EF4351 (B,121,119) EMI Filter CCG1067EF4352 (B,126,119) EMI Filter CCG1067EF4353 (A,128,119) EMI Filter CCG1067EF4354 (A,109,119) EMI Filter CCG1067
EF4355 (A,113,119) EMI Filter CCG1067EF4356 (A,115,119) EMI Filter CCG1067EF4357 (A,119,119) EMI Filter CCG1067EF4358 (A,123,119) EMI Filter CCG1067EF4359 (B,123,119) EMI Filter CCG1067
EF4360 (B,128,119) EMI Filter CCG1067EF4361 (A,130,119) EMI Filter CCG1067EF4731 (B,156,77) EMI Filter CCG1172EF4732 (B,153,57) EMI Filter CCG1172ANT1401 (A,18,118) Antenna Jack CKX1060
U 695 (B,91,26) IR Remote(RE) RPMS2401-H19Y 1461 (A,17,93) FM/AM Tuner Unit(EW5) CWE2127
(A,17,93) FM/AM Tuner Unit(RE) CWE2097> Fuse 10 A CEK1208
RESISTORS
R 601 (A,38,6) RS1/16S104JR 602 (B,39,6) RS1/16S104JR 603 (A,95,23) RS1/16SS220JR 604 (A,96,22) RS1/16S220JR 605 (B,120,38) RS1/16SS104J
R 607 (A,86,31) RS1/16SS681JR 608 (A,88,39) RAB4C681JR 609 (B,100,36) RS1/16SS104JR 610 (B,95,37) RS1/16SS102JR 612 (B,97,31) RS1/16SS104J
R 613 (A,94,41) RS1/16SS471JR 614 (A,93,41) RS1/16SS471JR 615 (A,94,40) RS1/16SS222JR 616 (A,93,40) RS1/16SS0R0JR 617 (A,94,39) RS1/16SS0R0J
R 618 (B,24,10) RS1/16SS104JR 619 (B,110,37) RS1/16SS104J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1775 6 7 8
C
D
F
A
B
E
1 2 3 4
R 620 (A,95,34) RS1/16SS101JR 626 (B,100,30) RS1/16SS221JR 627 (A,95,25) RS1/16SS104J
R 628 (B,88,39) RAB4C223JR 632 (B,100,45) RS1/16SS0R0JR 633 (B,103,42) RS1/16SS102JR 634 (A,101,21) RS1/16SS104JR 636 (B,100,39) RS1/16SS104J
R 639 (B,105,39) RS1/16SS102JR 640 (B,102,39) RS1/16SS103JR 641 (B,100,41) RS1/16SS103JR 642 (B,105,24) RS1/16SS220JR 643 (A,100,17) RS1/16SS104J
R 646 (A,101,17) RS1/16SS104JR 648 (B,107,24) RS1/16S104JR 649 (B,104,45) RS1/16SS220JR 650 (A,102,17) RS1/16SS104J
R 652 (B,106,44) RS1/16SS220JR 653 (A,109,46) RS1/16SS102JR 654 (A,104,17) (EW5) RS1/16SS104JR 655 (A,104,15) (RE) RS1/16SS104JR 657 (A,106,17) RS1/16SS104J
R 659 (A,111,21) RS1/16S220JR 660 (A,115,19) RS1/16S104JR 661 (A,108,16) RS1/16S104JR 662 (A,112,17) RS1/16S104JR 663 (A,116,20) RS1/16SS102J
R 664 (A,116,18) RS1/16SS473JR 665 (B,117,49) RS1/16SS104JR 666 (B,115,23) RS1/16SS104JR 668 (B,118,21) RS1/16SS472JR 670 (A,124,32) RS1/16SS104J
R 671 (A,120,31) RS1/16SS102JR 676 (A,120,28) RS1/16SS0R0JR 677 (A,120,27) RS1/16SS0R0JR 680 (B,119,22) RS1/16SS472JR 681 (B,118,48) RS1/16SS473J
R 682 (A,124,35) RS1/16SS0R0JR 683 (A,122,42) RAB4C104JR 684 (A,122,38) RAB4C681JR 685 (A,69,26) RS1/16S102JR 686 (B,108,36) RS1/16SS104J
R 687 (B,117,42) RS1/16SS104JR 688 (B,43,8) RS1/16SS104JR 689 (B,39,9) RS1/16SS104JR 690 (A,109,48) RS1/16SS472JR 695 (B,97,23) (RE) RS1/16SS470J
R 696 (B,95,29) (RE) RS1/16SS470JR 697 (B,98,24) RS1/16SS104JR 698 (B,106,26) RS1/16SS104JR 699 (B,109,48) RS1/16SS104JR 714 (A,95,76) RS1/10S0R0J
R 715 (B,95,74) RS1/10S0R0JR 717 (A,81,57) RS1/16SS0R0JR 718 (A,93,63) RS1/16SS221JR 722 (A,81,69) RS1/16S104JR 731 (B,94,34) RS1/16SS0R0J
R 751 (A,76,54) RS1/16S0R0JR 1016 (B,69,15) RS1/16SS0R0JR 1409 (B,20,111) (EW5) RS1/16S105J
Circuit Symbol and No. Part No.R 1410 (A,35,102) (EW5) RS1/16S821JR 1411 (A,34,107) (EW5) RS1/16S330J
R 1412 (A,43,88) (EW5) RS1/16S332JR 1413 (A,32,91) (EW5) RS1/16S101JR 1421 (B,37,92) (EW5) RS1/16S151JR 1422 (B,36,93) (EW5) RS1/16S680JR 1423 (B,40,92) (EW5) RS1/16S152J
R 1424 (B,42,93) (EW5) RS1/16S681JR 1425 (B,43,96) (EW5) RS1/16S181JR 1426 (B,26,104) (RE) RS1/4S0R0JR 1441 (A,31,84) (EW5) RS1/16S151JR 1442 (A,32,87) (EW5) RS1/16S680J
R 1443 (A,39,87) (EW5) RS1/16S152JR 1444 (A,40,85) (EW5) RS1/16S681JR 1445 (A,38,83) (EW5) RS1/16S151JR 1461 (B,24,70) RS1/16SS681JR 1462 (B,24,69) RS1/16SS681J
R 1463 (B,24,68) RS1/16SS681JR 1464 (B,24,67) RS1/16SS681JR 1465 (B,24,66) RS1/16SS681JR 1466 (B,26,65) RS1/16SS223JR 1467 (B,24,65) RS1/16SS681J
R 1468 (B,24,58) RS1/16SS681JR 1470 (B,25,46) RS1/16SS0R0JR 1471 (B,25,44) RS1/16SS0R0JR 1474 (B,29,46) RS1/16SS0R0JR 1475 (B,32,44) RS1/16SS0R0J
R 1476 (B,27,49) RS1/16SS0R0JR 1477 (B,27,51) RS1/16SS0R0JR 1478 (B,27,50) RS1/16SS0R0JR 1479 (B,27,52) RS1/16SS0R0JR 2801 (B,160,95) RN1/16SE1002D
R 2802 (B,158,94) RN1/16SE2701DR 2803 (B,157,96) RN1/16SE2201DR 2804 (B,158,99) RS1/16S104JR 2810 (B,110,98) RS1/8S0R0JR 2811 (A,99,97) RS1/16S471J
R 2820 (B,159,84) RS1/16S2201DR 2821 (B,159,86) RS1/16S1002DR 2822 (B,159,88) RS1/16S2201DR 2823 (A,139,48) RS1/16SS105JR 2830 (B,32,27) RS1/16S3601D
R 2831 (B,30,24) RS1/16S10R0DR 2832 (A,27,35) RS1/16S2201DR 2833 (A,32,27) (EW5) RS1/16S0R0JR 2834 (B,37,30) RS1/16S104JR 2840 (A,145,11) RS1/16SS104J
R 2841 (A,145,12) RS1/16SS473JR 2842 (B,145,5) RS1/16SS563JR 2843 (B,147,8) RS1/16SS513JR 2844 (B,148,7) RS1/16SS104JR 2845 (B,149,5) RS1/16SS513J
R 2846 (A,152,6) RS1/16SS513JR 2847 (B,150,7) RS1/16SS102JR 2848 (B,148,5) RS1/16SS102JR 2849 (B,150,5) RS1/16SS564JR 2850 (B,152,9) RS1/16SS202J
R 2851 (B,151,9) RS1/16SS822JR 2852 (A,153,10) RS1/16SS203JR 2853 (A,152,12) RS1/16SS333J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51781 2 3 4
C
D
F
A
B
E
5 6 7 8
R 2860 (B,125,107) RS1/16SS391JR 2861 (B,124,108) RS1/16SS391J
R 2862 (B,121,103) RS1/16SS473JR 2863 (B,115,104) RS1/16SS223JR 2864 (B,117,105) RS1/16SS103JR 2865 (B,122,112) RS1/10S102JR 2866 (B,113,115) RS1/16SS103J
R 2867 (B,116,114) RS1/16SS103JR 2868 (B,114,114) RS1/16SS221JR 2869 (B,112,114) RS1/16SS101JR 2870 (A,152,110) RS1/16S473JR 2871 (A,153,112) RS1/16S104J
R 2872 (B,153,108) RS1/16S102JR 2873 (B,156,108) RS1/16S472JR 2874 (B,149,110) RS1/4S102JR 2875 (B,151,113) RS1/4S472JR 2880 (A,165,120) RS1/16S103J
R 2881 (B,147,132) RS1/4S472JR 2882 (B,142,132) RS1/4S102JR 2883 (B,124,22) RS1/16SS472JR 2884 (B,121,21) RS1/16SS472JR 2900 (A,168,124) RS1/16S473J
R 2901 (A,169,121) RS1/16S104JR 2902 (A,166,127) RS1/4S102JR 2903 (A,166,130) RS1/4S472JR 2910 (B,153,71) RS1/16S473JR 2911 (B,144,108) RS1/16S473J
R 2912 (A,59,90) RS1/4S4R7JR 2913 (A,64,92) RS1/4S4R7JR 2920 (B,91,109) RS1/16S0R0JR 2921 (B,87,114) RS1/16S0R0JR 2922 (B,87,117) RS1/16S0R0J
R 2923 (B,94,108) RS1/16S0R0JR 2924 (A,95,120) RS1/16S103JR 2925 (A,92,120) RS1/16S103JR 2926 (A,102,118) RS1/16S103JR 2940 (B,60,6) RS1/16S0R0J
R 2941 (A,56,9) RS1/16SS101JR 2942 (A,60,15) RS1/16SS101JR 2943 (B,61,12) CTF1556R 2944 (B,61,13) CTF1556R 2945 (B,58,13) CTF1556
R 2946 (B,65,8) CTF1556R 2947 (A,59,21) CTF1675R 2948 (A,60,21) CTF1675R 2949 (A,64,21) CTF1675R 2950 (A,66,21) CTF1675
R 2951 (B,66,18) RS1/16SS0R0JR 2952 (B,68,18) RS1/16SS0R0JR 2953 (B,65,13) RS1/16SS0R0JR 2954 (B,69,11) RS1/16SS0R0JR 2959 (B,76,4) RS1/16S0R0J
R 2960 (B,73,8) RS1/16SS0R0JR 2961 (B,74,8) RS1/16SS0R0JR 2962 (A,77,17) RS1/16SS0R0JR 2963 (A,78,17) RS1/16SS0R0JR 2964 (A,80,21) RS1/16SS0R0J
R 2967 (B,76,18) RS1/16SS0R0JR 2968 (B,76,7) RS1/16SS0R0JR 2969 (B,77,7) RS1/16SS0R0J
Circuit Symbol and No. Part No.R 2970 (B,79,14) RS1/16SS0R0JR 2971 (B,78,7) RS1/16SS0R0J
R 2972 (B,80,7) RS1/16SS0R0JR 2973 (B,81,14) RS1/16SS0R0JR 2974 (B,81,7) RS1/16SS0R0JR 2975 (B,82,7) RS1/16SS0R0JR 2976 (B,83,7) RS1/16SS0R0J
R 2977 (B,84,7) RS1/16SS0R0JR 2978 (A,84,20) RS1/16SS0R0JR 2979 (A,86,18) RS1/16SS0R0JR 2980 (A,87,18) RS1/16SS0R0JR 2981 (A,87,22) RS1/16SS0R0J
R 2982 (A,89,9) RS1/16SS0R0JR 2983 (A,155,8) RS1/16SS0R0JR 3041 (A,74,55) RS1/16S182JR 3042 (A,74,57) RS1/16S182JR 3043 (A,75,53) RS1/16S473J
R 3044 (A,74,53) RS1/16S473JR 3601 (B,28,21) RS1/16S224JR 3602 (B,33,21) RS1/16S102JR 3603 (B,26,24) RS1/16S222JR 3604 (B,22,20) RS1/16S224J
R 3605 (B,18,13) RS1/16S102JR 3606 (B,23,22) RS1/16S222JR 3607 (B,15,20) RS1/16S224JR 3608 (B,15,15) RS1/16S102JR 3609 (B,14,23) RS1/16S222J
R 3610 (B,28,18) RS1/16S121JR 3611 (B,26,20) RS1/16S101JR 3612 (B,30,15) RS1/16S101JR 3616 (B,19,20) RS1/16S121JR 3617 (B,19,22) RS1/16S151J
R 3618 (B,20,15) RS1/16S101JR 3622 (B,10,20) RS1/16S151JR 3623 (B,11,22) RS1/16S181JR 3624 (B,13,16) RS1/16S101JR 3629 (B,70,7) RS1/16S0R0J
R 4001 (B,57,61) RS1/16S750JR 4021 (A,53,49) RS1/16S750JR 4041 (B,57,37) RS1/16S750JR 4061 (A,57,48) RS1/16S102JR 4071 (A,68,46) RS1/16SS473J
R 4072 (A,67,46) RS1/16SS473JR 4073 (A,64,56) RS1/16SS473JR 4074 (A,65,42) RS1/16SS473JR 4075 (A,63,42) RS1/16SS473JR 4076 (A,67,50) RS1/16SS473J
R 4077 (A,64,55) RS1/16SS473JR 4078 (A,64,51) RS1/16SS473JR 4079 (A,62,41) RS1/16SS330JR 4080 (A,62,54) RS1/16SS330JR 4151 (B,64,32) RS1/16SS103J
R 4152 (B,63,33) RS1/16SS103JR 4153 (B,66,33) RS1/16SS103JR 4154 (B,65,32) RS1/16SS103JR 4155 (B,68,35) RS1/16SS102JR 4156 (B,69,36) RS1/16SS104J
R 4157 (B,72,34) RS1/16SS104JR 4158 (B,74,33) RS1/16SS683JR 4159 (B,72,32) RS1/16SS473J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1795 6 7 8
C
D
F
A
B
E
1 2 3 4
R 4170 (B,82,53) RS1/16SS223JR 4171 (B,79,49) RS1/16SS223JR 4174 (B,65,21) RS1/16SS223J
R 4175 (B,63,21) RS1/16SS223JR 4176 (B,75,57) RS1/16SS0R0JR 4194 (B,62,41) RS1/16SS221J
R 4195 (B,63,40) RS1/16SS221JR 4200 (A,75,39) RS1/16S750JR 4231 (B,59,26) RS1/16SS223JR 4232 (B,59,21) RS1/16SS303JR 4233 (B,57,21) RS1/16SS681J
R 4234 (B,57,23) RS1/16SS102JR 4235 (B,62,21) RS1/16SS681JR 4236 (B,54,18) RS1/16SS152JR 4237 (B,57,18) RS1/16SS0R0JR 4240 (B,59,27) RS1/16SS0R0J
R 4251 (B,101,113) RS1/16S750JR 4252 (B,103,112) RS1/16SS473JR 4253 (B,101,111) RS1/16SS473JR 4254 (B,99,111) RS1/16SS101JR 4255 (B,106,112) RS1/16SS101J
R 4263 (A,104,109) RS1/16SS0R0JR 4271 (B,57,65) RS1/16S0R0JR 4272 (B,85,64) (RE) RS1/16S181JR 4273 (B,55,68) (RE) RS1/16S181JR 4274 (B,86,66) (RE) RS1/16S223J
R 4275 (B,84,67) (RE) RS1/16S102JR 4276 (B,52,68) (RE) RS1/16S223JR 4277 (B,50,69) (RE) RS1/16S102JR 4285 (B,58,72) RS1/16SS0R0JR 4286 (B,84,70) RS1/16SS0R0J
R 4287 (B,75,74) RS1/16SS102JR 4289 (B,75,75) RS1/16SS102JR 4291 (B,75,76) RS1/16SS102JR 4293 (B,77,80) RS1/16SS0R0JR 4295 (B,58,76) RS1/16SS0R0J
R 4296 (A,53,74) RS1/16S0R0JR 4312 (B,77,31) RS1/16SS821JR 4313 (B,78,36) RS1/16SS104JR 4316 (B,83,44) RS1/16SS0R0JR 4317 (B,79,44) RS1/16SS0R0J
R 4331 (B,106,92) RS1/16SS821JR 4332 (B,99,92) RS1/16SS821JR 4333 (B,96,85) RS1/16SS390JR 4334 (B,89,85) RS1/16SS390JR 4335 (B,96,92) RS1/16SS821J
R 4336 (B,89,92) RS1/16SS821JR 4337 (B,104,92) RS1/16SS223JR 4338 (B,95,85) RS1/16SS223JR 4339 (B,95,92) RS1/16SS223JR 4340 (B,100,92) RS1/16SS223J
R 4341 (B,90,85) RS1/16SS223JR 4342 (B,90,92) RS1/16SS223JR 4343 (B,103,89) RS1/16SS471JR 4344 (B,94,82) RS1/16SS471JR 4345 (B,94,89) RS1/16SS471J
R 4346 (B,101,89) RS1/16SS471JR 4347 (B,92,82) RS1/16SS471JR 4348 (B,92,89) RS1/16SS471JR 4351 (A,126,111) RS1/16S153J
Circuit Symbol and No. Part No.R 4352 (A,130,111) RS1/10S103J
R 4601 (B,106,61) RS1/10S0R0JR 4602 (B,110,59) RS1/16S2200DR 4603 (B,111,59) RS1/16S4701DR 4604 (B,112,59) RS1/16S1501DR 4605 (B,108,59) RS1/16S101J
R 4606 (B,115,59) RS1/16S332JR 4607 (B,118,59) RS1/16S104JR 4608 (B,115,69) RS1/16S473JR 4609 (B,111,64) RS1/16S1503DR 4610 (B,109,62) RS1/16S8203D
R 4611 (B,120,60) RS1/10S100JR 4612 (B,125,67) RS1/16S100JR 4614 (B,125,64) RS1/16S184JR 4615 (B,142,55) RS1/16S105JR 4616 (B,92,99) RS1/8S222JR 4633 (A,128,85) RS1/16SS821J
R 4641 (B,140,8) RS1/4SA561JR 4643 (B,142,19) RS1/16S331JR 4644 (B,138,20) RS1/16S0R0JR 4645 (B,143,19) RS1/16S5600DR 4646 (B,144,19) RS1/16S8201D
R 4647 (B,145,19) RS1/16S1501DR 4648 (B,147,29) RS1/16S473JR 4649 (B,148,19) RS1/16S332JR 4650 (B,151,19) RS1/16S104JR 4651 (B,144,24) RS1/16S1503D
R 4652 (B,142,22) RS1/16S8203DR 4653 (B,153,19) RS1/10S100JR 4654 (B,157,23) RS1/16S184JR 4656 (B,157,25) RS1/16S100JR 4657 (A,158,17) RS1/16S105J
R 4662 (B,137,35) RS1/10S0R0JR 4663 (B,142,35) RS1/16S1800DR 4664 (B,144,35) RS1/16S4701DR 4665 (B,145,35) RS1/16S1501DR 4666 (B,112,69) RS1/16S473J
R 4667 (B,141,35) RS1/16S101JR 4668 (B,148,35) RS1/16S332JR 4669 (B,150,35) RS1/16S104JR 4670 (B,146,45) RS1/16S473JR 4671 (B,144,40) RS1/16S1503D
R 4672 (B,141,37) RS1/16S8203DR 4673 (B,153,35) RS1/10S100JR 4674 (B,158,43) RS1/16S100JR 4676 (B,157,40) RS1/16S184JR 4677 (B,147,57) RS1/16S105J
R 4678 (B,137,8) RS1/4SA221JR 4680 (B,142,46) RS1/16SS0R0JR 4721 (A,43,127) RS1/16S472JR 4722 (A,41,129) RS1/16S101JR 4723 (A,42,129) (RE) RS1/16S101J
R 4724 (A,55,117) (RE) RS1/16S102JR 4725 (A,59,117) (RE) RS1/16S101JR 4726 (A,62,117) (RE) RS1/16S101JR 4727 (B,60,116) (RE) RS1/16S620JR 4728 (B,43,133) (RE) RS1/16S472J
R 4731 (B,125,100) (RE) RS1/16S222JR 4732 (B,146,87) RS1/16S473JR 4733 (B,125,98) (RE) RS1/16S682J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51801 2 3 4
C
D
F
A
B
E
5 6 7 8
R 4734 (B,153,92) RS1/16S103JR 4735 (B,149,87) RS1/16S104J
R 4736 (B,120,98) (RE) RS1/16S332JR 4737 (B,151,95) RS1/16S103JR 4738 (B,142,93) RS1/16S473JR 4739 (B,144,92) RS1/16S104JR 4749 (B,34,7) RS1/16S472J
R 4750 (B,32,9) RS1/16S472JR 4751 (A,34,13) RS1/16S101JR 4752 (A,34,6) RS1/16S101JR 4753 (A,35,11) RS1/16S105JR 4754 (A,33,11) RS1/16S103J
R 4755 (A,36,8) RS1/16S105JR 4756 (A,33,4) RS1/16S103JR 4757 (A,29,6) RS1/16S0R0JR 4758 (A,29,16) RS1/16S272JR 4771 (B,110,91) RS1/16SS472J
R 4772 (B,109,87) RS1/16SS472JR 4773 (B,115,94) RS1/16SS103JR 4774 (B,113,94) RS1/16SS512JR 4775 (B,112,85) RS1/16SS224JR 4776 (B,112,84) RS1/16SS472J
R 4777 (B,116,88) RS1/10S221JR 4778 (B,118,85) RS1/4S471JR 4783 (B,121,29) RS1/16SS332JR 4784 (B,121,25) RS1/16SS332JR 4811 (A,8,43) (EW5) RS1/16SS0R0J
R 4816 (A,8,56) (RE) RS1/16SS0R0J
CAPACITORS
C 601 (B,122,39) CKSRYB104K16C 602 (B,44,5) CKSRYB104K50C 604 (B,120,46) CKSRYB104K50C 605 (A,39,13) CKSRYB104K16C 606 (B,104,33) CKSRYB104K50
C 607 (B,94,45) CKSRYB153K50C 608 (B,96,36) CKSSYB104K16C 609 (B,96,33) CKSRYB104K16C 613 (B,96,46) CKSRYB104K16C 614 (B,101,45) CKSRYB104K16
C 615 (B,31,9) CKSRYB104K16C 617 (A,100,20) CKSRYB104K16C 618 (A,105,46) CKSRYB104K16C 619 (B,96,41) CKSRYB104K16C 620 (A,108,20) CKSRYB104K16
C 621 (A,122,25) CKSRYB104K16C 622 (A,120,35) CKSRYB104K16C 623 (B,70,16) CKSRYB103K16C 630 (B,113,44) CKSRYB104K50C 632 (B,103,25) CKSRYB104K16C 636 (B,94,39) CKSSYB104K16
C 671 (B,52,10) CKSSYB104K16C 672 (A,48,33) CKSSYB104K16C 685 (A,71,28) CKSSYB104K16C 696 (B,96,28) 10 uF(RE) CCG1171
C 705 (A,81,75) CKSRYB104K25C 706 (A,89,74) CKSRYB104K25C 707 (A,80,75) CKSRYF104Z25C 708 (A,88,74) CKSRYF104Z25
Circuit Symbol and No. Part No.
C 709 (A,88,69) CKSRYF104Z25C 711 (B,95,63) CKSRYB103K16C 1020 (B,69,7) CKSRYB102K50C 1021 (B,67,7) CKSRYB102K50C 1022 (B,62,8) CKSRYB104K50
C 1077 (A,53,29) CKSRYB104K25C 1078 (A,56,29) CKSRYB104K25C 1401 (B,20,109) (EW5) CCSRCH270J50C 1402 (B,25,110) (EW5) CCSRCH220J50C 1403 (B,25,112) (EW5) CCSRCH270J50
C 1404 (B,31,110) (EW5) CCSRCH330J50C 1405 (B,30,108) (EW5) CCSRCH470J50C 1406 (A,35,101) (EW5) CKSRYB103K50C 1407 (A,36,107) (EW5) CKSRYB103K50C 1408 (A,41,88) (EW5) CKSRYB103K50
C 1409 (A,37,93) (EW5) CKSRYB222K50C 1421 (B,34,93) (EW5) CKSRYB222K50C 1422 (B,39,92) (EW5) CKSRYB222K50C 1423 (B,30,99) (EW5) CCSRCH150J50C 1424 (B,42,91) (EW5) CKSRYB103K50
C 1426 (B,29,102) (EW5) CCSRCH270J50C 1441 (A,31,87) (EW5) CKSRYB222K50C 1442 (A,37,87) (EW5) CKSRYB222K50C 1443 (A,36,82) (EW5) CCSRCH220J50C 1444 (A,41,84) (EW5) CKSRYB103K50
C 1452 (B,27,69) CKSSYB103K50C 1458 (B,28,59) CKSRYB103K50
C 1461 (A,31,69) CEVW221M10C 1462 (A,31,58) CEVW221M10C 1464 (A,22,85) CCSRCH101J50C 1465 (A,38,72) CKSRYB103K50C 1466 (A,27,75) CKSRYB103K50
C 1468 (B,24,51) 10 uF CCG1203C 1469 (B,22,51) CKSRYB103K50C 1476 (A,35,38) CKSSYB103K25C 2800 (B,94,103) CKSRYB102K50C 2801 (A,158,98) 100 uF/16 V CCH1565C 2802 (A,163,99) CCSRCH102J50
C 2804 (A,163,101) CKSRYB104K50C 2805 (B,93,101) CKSRYB104K50C 2810 (A,105,101) CEVW101M16C 2811 (B,101,102) CKSRYB104K50C 2812 (A,106,96) CKSRYB104K50
C 2820 (A,158,86) 100 uF/16 V CCH1565C 2821 (A,163,87) CKSRYB103K50C 2823 (A,163,91) CKSRYB104K50C 2830 (A,32,34) CEVW101M16C 2831 (B,32,29) CKSRYB103K50
C 2833 (B,35,28) CKSRYB104K50C 2840 (A,150,11) CKSRYB104K50C 2841 (B,149,9) CKSRYB102K50C 2842 (A,153,8) CKSRYB104K50C 2843 (A,155,10) CKSRYB103K50
C 2844 (A,155,9) CKSRYB823K16C 2860 (A,119,114) CEVW470M16C 2861 (B,120,114) CKSRYB104K50C 2862 (A,110,113) CEVW330M10C 2870 (A,150,109) CKSRYB102K50
C 2871 (B,146,114) CKSRYB102K50
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1815 6 7 8
C
D
F
A
B
E
1 2 3 4
C 2872 (B,157,114) CKSRYB102K50C 2881 (A,167,110) CKSQYB105K16C 2882 (B,145,132) CKSRYB102K50C 2890 (B,161,103) CKSRYB104K50
C 2891 (B,161,106) CKSRYB102K50C 2892 (A,161,110) CKSRYB102K50C 2901 (A,169,129) CKSRYB104K50C 2910 (A,150,64) CEAT103M16(P30)C 2911 (A,59,104) CEAT103M16(P30)
C 2912 (A,77,95) CEAT103M16(P30)C 2920 (B,92,113) CKSQYB105K16C 2921 (B,81,114) CKSQYB105K16C 2922 (B,81,117) CKSQYB105K16C 2923 (B,96,115) CKSQYB105K16
C 2924 (A,99,120) CKSRYB104K50C 2925 (B,92,116) CKSRYB105K10C 2926 (B,78,114) CKSRYB105K10C 2927 (B,78,117) CKSRYB105K10C 2928 (B,94,116) CKSRYB105K10
C 2929 (A,93,114) CEVW101M25C 2930 (A,102,114) CKSRYB104K50C 2931 (A,99,118) CKSRYB105K10C 2932 (A,76,119) CKSQYB225K10C 2933 (A,81,119) CKSYB225K16
C 2934 (A,81,116) CEVW100M16C 2935 (A,147,80) 3 300 uF/16 V CCH1018(P30)C 3041 (A,77,59) 10 uF CCG1203C 3042 (A,75,59) 10 uF CCG1203C 3601 (B,26,22) CKSQYB475K6R3
C 3602 (A,15,18) 10 uF CCG1203C 3604 (B,21,22) CKSQYB475K6R3C 3607 (B,13,22) CKSQYB475K6R3C 3611 (A,7,25) CKSSYB102K50
C 3612 (A,7,23) CKSSYB102K50C 3613 (A,7,22) CKSSYB102K50C 4061 (A,53,37) CKSRYB103K50C 4062 (A,59,43) CEVW100M16
C 4063 (A,53,40) CKSRYB104K50C 4070 (A,67,56) 10 uF CCG1203C 4071 (A,68,49) 10 uF CCG1203C 4072 (A,68,54) 10 uF CCG1203C 4073 (A,68,52) 10 uF CCG1203
C 4075 (A,63,40) CCSRCH330J50C 4076 (A,61,47) CKSRYB104K50C 4078 (A,63,53) CCSRCH330J50C 4079 (A,60,39) CKSRYB103K50C 4080 (A,62,56) CKSRYB103K50
C 4151 (B,63,30) 10 uF CCG1203C 4152 (B,60,31) 10 uF CCG1203C 4153 (B,66,32) CCSSCH221J50C 4154 (B,70,30) CKSSYB104K16C 4155 (B,66,35) CKSSYB103K25
C 4156 (B,74,34) CKSSYB104K16C 4157 (B,73,34) CCSSCH151J50C 4158 (B,71,35) CCSSCH151J50C 4159 (B,77,29) CKSQYB225K10C 4160 (B,65,33) CCSSCH221J50
C 4171 (A,70,61) CEVLW470M16C 4172 (B,73,60) CKSRYB104K50C 4173 (A,58,58) CEVLW470M16
Circuit Symbol and No. Part No.C 4174 (B,74,60) CKSYB226K6R3C 4181 (B,61,57) CKSRYB104K50
C 4182 (B,76,59) CKSRYB104K50C 4183 (B,63,59) CKSYB226K6R3C 4184 (B,64,61) CKSRYB104K50C 4185 (B,58,39) CKSQYB475K10C 4186 (B,57,49) CKSQYB475K10
C 4187 (B,58,42) CKSQYB475K10C 4188 (B,66,61) CKSRYB105K10C 4189 (B,68,61) CKSRYB105K10C 4190 (B,69,58) CKSRYB105K10C 4191 (B,70,58) CKSRYB105K10
C 4192 (B,67,58) CKSRYB105K10C 4193 (B,78,59) CKSRYB105K10C 4194 (B,65,58) CKSRYB105K10C 4195 (B,57,55) CKSQYB475K10C 4197 (B,57,58) CKSQYB475K10
C 4198 (B,79,59) CKSRYB105K10C 4199 (A,57,53) CKSRYB105K10C 4200 (B,78,52) CKSRYB105K10C 4201 (A,57,51) CKSRYB105K10C 4202 (B,79,54) CKSRYB105K10
C 4203 (B,57,52) CKSQYB475K10C 4204 (B,78,51) CKSRYB105K10C 4206 (B,77,50) CKSRYB105K10C 4207 (B,57,48) CKSRYB105K10C 4208 (A,78,22) CKSRYB105K10
C 4210 (A,74,21) CKSRYB105K10C 4211 (B,57,43) CKSQYB475K10C 4212 (A,71,21) CKSRYB105K10C 4213 (A,68,21) CKSRYB105K10C 4215 (B,76,44) CKSRYB105K10
C 4216 (B,58,36) CKSQYB475K10C 4217 (B,75,43) CKSRYB105K10C 4219 (A,72,34) CEVW331M16C 4220 (A,72,43) CEVWNP220M10C 4221 (B,72,39) CKSRYB105K10
C 4222 (B,73,40) CKSRYB105K10C 4224 (B,57,46) CKSRYB105K10C 4231 (B,61,24) CKSRYB105K10C 4232 (A,63,26) CEVWNP220M10C 4233 (A,55,17) CEVQW101M10
C 4251 (B,104,112) CKSRYB473K50C 4252 (B,100,110) 10 uF CCG1203C 4253 (B,105,110) 10 uF CCG1203C 4254 (B,101,104) CKSRYB104K25C 4264 (A,85,109) CEVQW101M10
C 4271 (B,81,67) 10 uF(RE) CCG1203C 4273 (B,84,65) (RE) CKSRYB105K6R3C 4274 (B,78,64) CKSRYB105K6R3C 4275 (B,60,63) CKSRYB105K6R3C 4276 (B,58,66) CKSRYB105K6R3
C 4277 (B,53,70) 10 uF(RE) CCG1203C 4280 (B,61,68) (RE) CKSRYB105K6R3C 4281 (B,59,71) CKSRYB105K6R3C 4284 (B,83,68) CKSRYB105K6R3C 4285 (B,61,70) CKSRYB105K6R3
C 4286 (B,78,71) CKSRYB105K6R3C 4287 (B,60,72) CKSRYB105K6R3C 4288 (A,67,69) CEVW100M16
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51821 2 3 4
C
D
F
A
B
E
5 6 7 8
C 4289 (A,59,69) CEVW470M16C 4291 (A,64,71) CKSRYB104K16
C 4293 (A,61,82) CKSRYB104K16C 4294 (A,62,78) CEVW100M16C 4295 (A,57,78) CEVW4R7M16C 4296 (B,57,63) CKSRYB104K16C 4297 (A,75,65) CKSRYB105K10
C 4331 (A,107,91) CEVW4R7M16C 4332 (A,102,91) CEVW4R7M16C 4333 (A,97,84) CEVW4R7M16C 4334 (A,92,84) CEVW4R7M16C 4335 (A,97,93) CEVW4R7M16
C 4336 (A,92,94) CEVW4R7M16C 4337 (B,106,90) CKSRYB222K50C 4338 (B,96,83) CKSRYB222K50C 4339 (B,96,90) CKSRYB222K50C 4340 (B,99,90) CKSRYB222K50
C 4341 (B,89,83) CKSRYB222K50C 4342 (B,89,90) CKSRYB222K50C 4351 (B,131,109) CKSRYB104K25C 4352 (A,132,112) CKSRYF103Z50C 4353 (A,123,108) CKSRYB102K50
C 4371 (A,38,116) CKSRYB102K50C 4372 (A,41,123) CKSRYB102K50C 4600 (B,113,54) CKSRYB102K50C 4601 (B,107,59) CKSRYB103K25C 4602 (B,114,59) CCSRCH102J50
C 4603 (B,117,59) CKSRYB104K16C 4604 (B,111,61) CKSRYB473K50C 4605 (B,111,63) 33 pF CCG1252C 4606 (B,110,66) CKSRYB105K10C 4607 (B,123,69) 4.7 uF CCG1222
C 4608 (B,110,67) CKSQYB475K10C 4609 (B,124,61) CKSRYF474Z16C 4610 (B,124,64) CKSRYB104K16C 4611 (A,117,56) 330 uF/6.3 V CCH1366C 4612 (A,118,71) 10 uF CCG1223
C 4613 (A,121,71) 10 uF CCG1223C 4614 (A,124,71) 10 uF CCG1223C 4616 (B,139,58) CKSRYB102K50C 4617 (B,139,60) CKSRYB104K50C 4618 (B,110,53) 10 uF CCG1223
C 4619 (B,113,55) CKSRYB104K50C 4631 (A,122,90) CKSRYB104K50C 4641 (B,140,19) CKSRYB103K25C 4642 (B,147,19) CCSRCH101J50C 4643 (B,149,19) CKSRYB104K50
C 4644 (B,144,21) CKSRYB473K50C 4645 (B,144,22) 33 pF CCG1252C 4646 (B,143,25) CKSRYB105K10C 4647 (B,156,23) CKSRYF104Z25C 4648 (B,143,27) CKSQYB475K10
C 4649 (B,156,21) CKSRYF474Z16C 4650 (B,156,28) 4.7 uF CCG1222C 4651 (A,132,21) 220 uF/10 V CCH1409C 4652 (A,154,32) 10 uF CCG1223C 4653 (A,150,32) 10 uF CCG1223
C 4654 (A,157,32) 10 uF CCG1223C 4655 (B,133,22) 10 uF CCG1223C 4656 (B,140,13) CKSRYB104K50
Circuit Symbol and No. Part No.C 4657 (B,141,13) CKSRYB102K50C 4658 (B,163,22) CKSRYB102K50
C 4659 (B,162,22) CKSRYB104K50C 4661 (B,140,35) CKSRYB103K25C 4662 (B,146,35) CCSRCH102J50C 4663 (B,149,35) CKSRYB104K16C 4664 (B,144,37) CKSRYB473K50
C 4665 (B,144,38) 33 pF CCG1252C 4666 (B,143,41) CKSRYB105K10C 4667 (B,156,44) 4.7 uF CCG1222C 4668 (B,142,43) CKSQYB475K10C 4669 (B,156,36) CKSRYF474Z16
C 4670 (B,156,40) CKSRYB104K16C 4671 (A,132,35) 330 uF/6.3 V CCH1366C 4672 (A,157,47) 10 uF CCG1223C 4673 (A,150,47) 10 uF CCG1223C 4674 (A,153,47) 10 uF CCG1223
C 4675 (B,133,32) 10 uF CCG1223C 4676 (B,136,31) CKSRYB104K50C 4677 (B,137,31) CKSRYB102K50C 4678 (B,162,35) CKSRYB102K50C 4679 (B,163,35) CKSRYB104K50
C 4701 (B,86,47) CKSYB105K16C 4702 (A,88,47) CKSRYB104K16C 4704 (A,86,50) CEVW100M16C 4705 (A,92,48) CEVW100M16C 4706 (B,91,47) CKSYB105K25
C 4707 (B,88,45) CKSRYB104K16C 4709 (B,86,45) CKSRYB104K16C 4710 (A,85,47) CKSRYB104K16C 4721 (A,56,117) (RE) CKSRYB472K50C 4724 (B,58,132) (RE) CKSRYB104K50
C 4731 (B,152,54) CKSRYB104K50C 4732 (B,154,73) CKSRYB104K50C 4751 (A,35,10) CKSRYB104K50C 4771 (B,111,87) CKSRYB104K50C 4772 (B,110,84) CKSRYB472K50
C 4773 (B,126,89) CKSRYB103K50C 4774 (A,117,93) CEVW470M16C 4775 (B,114,101) CKSRYB103K50C 4776 (A,118,101) CEVW101M16C 4784 (B,119,30) CCSSCH470J50
C 4785 (B,119,28) CCSSCH470J50C 4786 (A,110,16) CKSRYB104K16
BUnit Number :Unit Name : Keyboard Unit
MISCELLANEOUS
D 801 (A,18,67) LED NSSM025-6502D 802 (A,12,15) Diode MALS068XD 805 (A,8,15) Diode MALS068XD 806 (B,5,8) Diode MALS068XD 807 (B,4,3) Diode MALS068XD 808 (B,9,75) Diode RB521S-30
D 812 (B,14,82) Diode RB521S-30D 815 (A,12,23) LED SMLE12BC7T(NP)D 852 (B,10,78) Diode HZU5R6(B2)
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1835 6 7 8
C
D
F
A
B
E
1 2 3 4
D 853 (B,12,78) Diode HZU5R6(B2)
D 854 (A,14,76) Diode HZU5R6(B2)D 855 (A,11,75) Diode HZU5R6(B2)D 856 (B,18,82) Diode HZU5R6(B2)D 857 (A,23,68) Diode HZU5R6(B2)D 858 (A,23,70) Diode HZU5R6(B2)
D 859 (B,9,74) Diode HZU11(B2)D 860 (B,9,72) Diode HZU11(B2)D 861 (A,17,71) Diode HZU11(B2)D 862 (A,21,65) Diode HZU11(B2)D 863 (A,22,62) Diode HZU5R6(B2)
D 864 (B,7,71) Diode HZU5R6(B2)D 866 (A,14,63) Diode HZU5R6(B2)D 867 (A,7,63) Diode HZU5R6(B2)D 868 (B,5,69) Diode MALS068XD 869 (A,5,58) Diode MALS068X
D 870 (A,7,56) Diode MALS068XD 871 (A,9,67) Diode MALS068XD 872 (A,9,65) Diode MALS068XS 801 (A,8,86) Push Switch CSG1155S 802 (A,11,80) Push Switch CSG1155
S 803 (A,18,51) Switch(ROTARY COMMANDER) CSX1135S 804 (A,18,84) Push Switch CSG1155S 805 (A,24,80) Push Switch CSG1155ANT801 (A,4,39) Antenna CTX1095
RESISTORS
R 801 (B,23,57) RS1/16S0R0JR 802 (A,10,62) RS1/16S0R0JR 803 (B,8,61) RS1/16S102JR 804 (B,17,50) RS1/16S162JR 805 (B,6,76) RS1/16S123J
R 806 (B,20,50) RS1/16S302JR 807 (A,18,76) RS1/16S132JR 808 (B,18,83) RS1/16S103JR 809 (A,18,79) RS1/16S272JR 810 (A,23,66) RS1/16S241J
CAPACITORS
C 803 (A,19,63) CKSRYB103K25C 804 (A,10,63) CKSRYB103K25C 805 (A,13,67) CKSRYB104K25C 806 (A,14,67) CKSRYB104K25
CUnit Number : YWX5005Unit Name : DVD Core Unit
MISCELLANEOUS
IC 1003 (B,72,42) IC S-80859CNNB-B9KIC 1004 (B,75,48) Regulator IC NJM2880U1-05IC 1005 (B,61,58) IC S-L2980A50MC-C7JIC 1007 (B,82,54) IC NJM2885DL1-33IC 1008 (B,80,63) IC R1232D121B
IC 1201 (A,26,15) IC BD7996EFVIC 1301 (B,90,27) IC TC7SZ125FUIC 1351 (B,86,27) IC TC7SZ08FUIC 1352 (B,79,13) IC TC74LCX16373FT
Circuit Symbol and No. Part No.IC 1401 (B,61,32) Flash ROM Unit CWW1465
IC 1402 (B,37,10) Flash ROM Unit CWW1466IC 1403 (B,47,29) IC TC7SZ32FUIC 1481 (B,60,12) IC EDS1232AATA-75-EIC 1501 (A,60,19) IC MN2DS0016AAUBIC 1801 (A,70,52) D/A Converter PCM1753DBQ
Q 1101 (B,62,50) Transistor 2SC4081Q 1102 (B,68,50) Transistor 2SC4081Q 1103 (B,60,45) Transistor 2SB1260Q 1104 (B,66,45) Transistor 2SB1260D 1002 (A,88,66) Diode 1SR154-400
D 1301 (B,12,10) Chip LED CL205IRXTUL 1004 (B,63,60) Inductor CTF1472L 1005 (B,81,49) Inductor CTF1465L 1006 (B,86,64) Inductor CTF1678L 1007 (B,74,63) Inductor CTF1623
L 1101 (B,66,54) Inductor CTF1305L 1482 (B,77,29) Inductor CTF1473L 1502 (A,71,46) Inductor CTF1378L 1503 (A,60,47) Inductor CTF1487L 1504 (A,35,10) Inductor CTF1387
L 1511 (A,63,3) Inductor CTF1680L 1601 (A,41,23) Inductor CTF1473L 1602 (A,55,42) Inductor CTF1473L 1603 (A,54,42) Inductor CTF1473L 1604 (A,52,42) Inductor CTF1473
L 1605 (A,38,32) Inductor CTF1395L 1671 (A,41,19) Inductor CTF1473L 1672 (A,41,20) Inductor CTF1473L 1673 (A,41,21) Inductor CTF1473L 1801 (A,70,61) Inductor CTF1473
L 1901 (A,91,73) Inductor CTF1487L 1902 (A,91,62) Inductor CTF1558X 1501 (A,40,15) Crystal 27.000 MHz CSS1714VR1671 (A,35,20) Semi-fixed 10 kohm(B) CCP1448EF1501 (A,68,46) EMI Filter DTL1106
EF1502 (A,61,44) EMI Filter DTL1106EF1901 (A,87,74) EMI Filter DTF1106EF1903 (A,91,64) EMI Filter DTL1106
RESISTORS
R 1011 (B,72,40) RS1/16SS104JR 1014 (B,82,61) RS1/16SS473JR 1015 (B,76,60) RS1/16SS101JR 1101 (B,63,52) RS1/16SS391JR 1102 (B,62,47) RS1/16SS511J
R 1103 (B,67,53) RS1/16SS391JR 1104 (B,69,47) RS1/16SS561JR 1107 (B,61,53) RS1/16SS6R8JR 1108 (B,65,53) RS1/16SS6R8JR 1109 (B,57,40) RS1/10S1R5J
R 1110 (B,63,40) RS1/10S1R5JR 1111 (B,70,40) RS1/10S1R5JR 1112 (B,64,40) RS1/10S1R5JR 1113 (B,61,40) RS1/10S1R5JR 1114 (B,59,40) RS1/10S1R5J
R 1115 (B,66,40) RS1/10S1R5JR 1116 (B,68,40) RS1/10S1R5JR 1117 (B,64,49) RS1/16SS104J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51841 2 3 4
C
D
F
A
B
E
5 6 7 8
R 1118 (B,70,49) RS1/16SS104JR 1202 (A,19,12) RS1/16SS221J
R 1203 (A,19,11) RS1/16SS221JR 1210 (A,30,27) RS1/16SS101JR 1211 (B,26,18) RS1/16SS3R9JR 1212 (B,27,18) RS1/16SS3R9JR 1214 (B,28,18) RS1/16SS3R9J
R 1215 (B,29,18) RS1/16SS3R9JR 1216 (B,30,18) RS1/16SS3R9JR 1217 (B,31,18) RS1/16SS3R9JR 1219 (A,20,27) RS1/16SS101JR 1223 (A,19,4) RS1/16SS753J
R 1225 (A,19,7) RS1/16SS753JR 1227 (B,13,21) RS1/16SS3R9JR 1228 (B,14,21) RS1/16SS3R9JR 1229 (B,15,21) RS1/16SS3R9JR 1230 (B,16,21) RS1/16SS3R9J
R 1231 (B,17,21) RS1/16SS3R9JR 1232 (B,18,21) RS1/16SS3R9JR 1233 (B,19,21) RS1/16SS3R9JR 1234 (B,20,21) RS1/16SS3R9JR 1240 (B,32,18) RS1/16SS3R9J
R 1241 (B,33,18) RS1/16SS3R9JR 1242 (B,34,18) RS1/16SS3R9JR 1243 (B,37,18) RS1/16SS3R9JR 1244 (B,36,18) RS1/16SS3R9JR 1245 (B,35,18) RS1/16SS3R9J
R 1301 (B,13,13) RS1/16SS391JR 1302 (B,15,13) RS1/16SS471JR 1304 (B,87,23) RS1/16SS563JR 1305 (B,86,23) RS1/16SS243JR 1306 (B,85,23) RS1/16SS683J
R 1307 (B,88,23) RS1/16SS243JR 1314 (B,86,21) RAB4CQ822JR 1351 (B,84,25) RS1/16SS331JR 1401 (B,72,33) RS1/16SS221JR 1402 (B,50,27) RS1/16SS104J
R 1405 (B,48,10) RS1/16SS221JR 1406 (B,25,4) RS1/16SS104JR 1407 (B,25,6) RS1/16SS104JR 1410 (B,47,31) RS1/16SS104JR 1501 (B,71,3) RAB4CQ560J
R 1502 (A,85,3) RS1/16SS104JR 1503 (A,71,2) RS1/16SS560JR 1504 (A,87,23) RAB4CQ104JR 1505 (B,68,3) RAB4CQ560JR 1506 (A,87,19) RAB4CQ104J
R 1507 (B,65,3) RAB4CQ560JR 1508 (A,86,16) RAB4CQ104JR 1509 (A,86,12) RAB4CQ104JR 1510 (A,78,11) RAB4CQ104JR 1511 (A,88,4) RS1/16SS104J
R 1512 (B,59,3) RAB4CQ560JR 1513 (A,44,4) RS1/16SS102JR 1514 (A,80,7) RAB4CQ104JR 1515 (A,43,3) RS1/16SS102JR 1516 (A,76,8) RS1/16SS103J
R 1518 (A,85,5) RS1/16SS104JR 1520 (A,35,8) RS1/16SS221JR 1521 (A,41,11) RAB4CQ101J
Circuit Symbol and No. Part No.R 1522 (B,56,3) RAB4CQ560JR 1523 (A,39,11) RS1/16SS101J
R 1524 (A,39,12) RS1/16SS101JR 1525 (B,53,3) RAB4CQ560JR 1526 (A,36,10) RS1/16SS270JR 1528 (A,43,14) RS1/16SS101JR 1529 (B,53,22) RAB4CQ560J
R 1530 (A,43,15) RS1/16SS105JR 1531 (B,50,22) RAB4CQ560JR 1532 (A,77,22) RS1/16SS103JR 1533 (A,76,27) RS1/16SS103JR 1534 (A,77,26) RS1/16SS103J
R 1535 (A,63,36) RS1/16SS221JR 1537 (A,67,40) RS1/16SS221JR 1538 (A,66,41) RS1/16SS221JR 1540 (A,70,43) RS1/16SS102JR 1541 (A,64,41) RS1/16SS472J
R 1542 (A,60,36) RS1/16SS223JR 1543 (A,59,37) RS1/16SS332JR 1544 (A,57,41) RS1/16SS183JR 1545 (A,61,36) RS1/16SS223JR 1546 (A,59,42) RS1/16SS104J
R 1547 (A,59,41) RS1/16SS473JR 1548 (A,59,36) RS1/16SS104JR 1554 (A,60,39) RS1/16SS221JR 1555 (A,57,38) RS1/16SS221JR 1556 (A,43,7) RS1/16SS104J
R 1557 (A,57,39) RS1/16SS104JR 1559 (A,63,41) RS1/16SS221JR 1560 (A,68,42) RAB4CQ104JR 1562 (A,64,38) RAB4CQ104JR 1565 (A,73,36) RS1/16SS103J
R 1566 (A,72,36) RS1/16SS103JR 1567 (B,68,22) RAB4CQ560JR 1568 (B,65,22) RAB4CQ560JR 1569 (B,62,3) RAB4CQ560JR 1570 (B,60,22) RAB4CQ560J
R 1571 (B,57,22) RAB4CQ560JR 1573 (B,63,19) RS1/16SS560JR 1582 (A,81,25) RS1/16SS103JR 1583 (A,81,27) RS1/16SS103JR 1584 (A,77,28) RS1/16SS103J
R 1601 (A,41,25) RS1/16SS123JR 1602 (A,39,24) RS1/16SS123JR 1607 (A,41,27) RS1/16SS105JR 1609 (A,37,28) RN1/16SE1002DR 1610 (A,43,28) RS1/16SS222J
R 1613 (A,39,28) RS1/16SS223JR 1614 (A,46,35) RS1/16SS105JR 1615 (A,43,32) RS1/16SS105JR 1616 (A,53,36) RS1/16SS2002DR 1672 (A,43,21) RS1/16SS303J
R 1673 (A,37,22) RS1/16SS183JR 1674 (A,34,23) RS1/16SS562JR 1705 (A,55,57) RS1/16SS101JR 1706 (A,52,56) RS1/16SS201JR 1707 (A,55,51) RS1/16SS101J
R 1708 (A,52,50) RS1/16SS201JR 1715 (A,60,56) RS1/16SS201JR 1716 (A,62,57) RS1/16SS101J
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1855 6 7 8
C
D
F
A
B
E
1 2 3 4
R 1719 (A,60,50) RS1/16SS201JR 1720 (A,62,51) RS1/16SS101J
R 1803 (A,72,56) RS1/16SS821JR 1804 (A,74,56) RS1/16SS821JR 1805 (A,72,61) RS1/16SS104JR 1806 (A,74,61) RS1/16SS104JR 1903 (A,89,52) RS1/16SS0R0J
R 1904 (A,90,59) RS1/16S0R0J
CAPACITORS
C 1019 (B,58,59) CCSSCH101J50C 1020 (B,58,57) CKSSYB104K10C 1021 (B,60,60) CKSRYB105K10C 1022 (B,79,47) CKSSYB103K16C 1023 (B,79,49) CKSSYB104K10
C 1024 (B,71,48) CKSQYB475K10C 1025 (B,64,58) CKSRYB105K10C 1026 (B,12,19) CKSSYB104K10C 1027 (A,90,53) CCSSCH101J50C 1028 (B,89,56) CKSRYB105K10
C 1029 (B,89,52) CKSQYB225K10C 1030 (B,84,59) CKSQYB106K6R3C 1031 (B,85,59) CKSQYB106K6R3C 1032 (B,82,59) CKSRYB105K10C 1033 (B,73,59) CKSQYB106K6R3
C 1034 (B,73,57) CKSQYB106K6R3C 1035 (B,45,27) CCSSCH101J50C 1101 (B,61,54) 10 µF CCG1192C 1102 (B,58,50) 100 µF CCG1232C 1103 (B,65,50) 100 µF CCG1232
C 1104 (B,63,43) CKSSYB104K10C 1105 (B,70,43) CKSSYB104K10C 1106 (B,63,45) CKSSYB103K16C 1107 (B,70,45) CKSSYB103K16C 1108 (A,35,36) CKSSYB103K16
C 1109 (A,36,33) CKSRYB105K10C 1110 (A,35,37) CKSSYB103K16C 1111 (A,39,33) CKSRYB105K10C 1201 (B,21,11) CEVW101M16C 1202 (B,15,17) CKSYB475K16
C 1207 (B,16,10) CKSQYB225K10C 1209 (A,32,17) CKSSYB104K10C 1210 (A,32,19) CKSSYB471K50C 1211 (A,19,16) CKSSYB103K16C 1212 (A,19,8) CKSSYB104K10
C 1213 (A,19,9) CKSSYB104K10C 1301 (B,90,25) CKSSYB104K10C 1302 (B,88,25) CKSSYB104K10C 1351 (B,86,25) CKSSYB104K10C 1352 (B,75,19) CKSSYB104K10
C 1353 (B,81,19) CKSSYB104K10C 1354 (B,74,7) CKSSYB104K10C 1355 (B,85,8) CKSSYB104K10C 1356 (B,83,28) CKSYB106K6R3C 1401 (B,72,31) CKSSYB103K16
C 1402 (B,49,33) CKSSYB104K10C 1403 (B,81,27) CKSQYB475K6R3C 1405 (B,48,8) CKSSYB103K16C 1406 (B,25,15) CKSSYB104K10
Circuit Symbol and No. Part No.C 1407 (B,74,27) CKSQYB475K6R3
C 1408 (B,47,27) CKSSYB104K10C 1481 (B,72,5) CKSSYB104K10C 1482 (B,72,7) CKSSYB104K10C 1483 (B,67,5) CKSSYB104K10C 1484 (B,63,5) CKSSYB104K10
C 1485 (B,56,5) CKSSYB104K10C 1486 (B,53,5) CKSSYB104K10C 1487 (B,51,5) CKSSYB104K10C 1488 (B,49,5) CKSSYB104K10C 1490 (B,68,19) CKSSYB104K10
C 1491 (B,77,27) CKSQYB106K6R3C 1492 (B,55,19) CKSSYB104K10C 1493 (B,52,19) CKSSYB104K10C 1494 (B,65,19) CKSSYB104K10C 1496 (B,65,5) CKSSYB102K50
C 1497 (B,61,19) CKSSYB102K50C 1498 (B,77,26) CKSSYB102K50C 1499 (B,49,4) CKSSYB102K50C 1501 (A,68,44) CKSQYB106K6R3C 1502 (A,58,43) CKSQYB106K6R3
C 1503 (A,55,3) CKSSYB104K10C 1504 (A,58,3) CKSSYB104K10C 1505 (A,53,3) CKSSYB104K10C 1506 (A,60,3) CKSSYB104K10C 1507 (A,68,2) CKSSYB104K10
C 1508 (A,65,3) CKSSYB104K10C 1509 (A,69,2) CKSSYB104K10C 1510 (A,43,11) CKSSYB104K10C 1511 (A,76,7) CKSSYB104K10C 1512 (A,76,11) CKSSYB104K10
C 1513 (A,43,10) CKSSYB104K10C 1514 (A,76,17) CKSSYB104K10C 1515 (A,43,16) CKSSYB104K10C 1516 (A,76,15) CKSSYB104K10C 1517 (A,43,17) CKSSYB104K10
C 1518 (A,37,14) CCSSCH8R0D50C 1519 (A,37,16) CCSSCH8R0D50C 1521 (A,76,24) CKSSYB104K10C 1522 (A,77,24) CKSSYB104K10C 1523 (A,58,36) CKSSYB104K10
C 1524 (A,57,37) CKSSYB103K16C 1525 (A,66,36) CKSSYB104K10C 1526 (A,62,40) CKSSYB103K16C 1527 (A,63,35) CKSSYB471K50C 1528 (A,65,36) CKSSYB104K10
C 1529 (A,60,38) CKSSYB103K16C 1530 (A,59,39) CKSSYB224K6R3C 1531 (A,57,42) CKSSYB123K16C 1536 (A,76,20) CKSSYB104K10C 1537 (A,55,43) CKSSYB102K50
C 1538 (A,53,43) CKSSYB102K50C 1539 (A,57,36) CKSSYB104K10C 1540 (A,61,38) CKSSYB103K16C 1560 (A,51,3) CKSSYB104K10C 1577 (A,77,30) CKSSYB104K10
C 1601 (A,41,24) CCSSCH101J50C 1602 (A,43,24) CCSSCH101J50C 1603 (A,37,23) CCSSCH680J50C 1604 (A,39,25) CCSSCH680J50
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW51861 2 3 4
C
D
F
A
B
E
5 6 7 8
C 1608 (A,41,26) CKSSYB103K16
C 1609 (A,43,26) CKSSYB103K16C 1610 (A,53,39) CCSSCH101J50C 1611 (A,53,37) CKSSYB562K25C 1612 (A,55,36) CKSSYB224K6R3C 1613 (A,55,37) CKSSYB224K6R3
C 1614 (A,56,37) CKSSYB333K16C 1615 (A,41,30) CKSRYB105K10C 1616 (A,48,36) CKSSYB104K10C 1617 (A,49,38) CKSSYB104K10C 1618 (A,51,38) CKSSYB104K10
C 1619 (A,51,36) CKSSYB104K10C 1620 (A,50,36) CKSSYB104K10C 1621 (A,50,38) CKSSYB104K10C 1622 (A,52,38) CKSSYB104K10C 1623 (A,52,39) CKSSYB104K10
C 1624 (A,43,27) CKSSYB103K16C 1625 (A,56,36) CKSSYB104K10C 1626 (A,41,31) CKSRYB105K10C 1627 (A,43,23) CKSSYB104K10C 1628 (A,54,36) CKSSYB104K10
C 1629 (A,49,36) CKSSYB104K10C 1630 (A,38,30) CKSQYB106K6R3C 1671 (A,43,18) CKSSYB104K10C 1672 (A,43,19) CKSSYB104K10C 1673 (A,37,21) CKSSYB104K10
C 1674 (A,39,21) CKSSYB104K10C 1675 (A,39,19) CKSRYB105K10C 1676 (A,37,19) CKSRYB105K10C 1677 (A,43,22) CKSSYB104K10C 1801 (A,74,52) CKSSYB104K10
C 1802 (A,67,58) 10 µF CCG1192C 1803 (A,67,56) CKSSYB104K10C 1804 (A,69,58) 10 µF CCG1192C 1805 (A,69,56) CKSSYB104K10C 1808 (A,72,57) CCSRCH182J50
C 1809 (A,75,57) CCSRCH182J50C 1810 (A,72,59) CKSQYB475K6R3C 1811 (A,74,59) CKSQYB475K6R3C 1901 (A,84,74) CKSSYB102K50
DUnit Number : CWX3595Unit Name : Compound Unit(A)
Q 1299 Photo-taransistor CPT231SCTDS 1201 Spring Switch(12cm) CSN1069S 1202 Spring Switch(8cm) CSN1069S 1203 Spring Switch(DISC SENS) CSN1069S 1204 Spring Switch(DISC SENS) CSN1070
S 1205 Spring Switch(8cm) CSN1070R 1298 RS1/16S0R0JR 1299 RS1/16S0R0J
EUnit Number : CWX3559Unit Name : Compound Unit(B)
S 1206 Switch(CLAMP) CSN1067
Circuit Symbol and No. Part No.
Miscellaneous Parts List
Pickup Unit(Service) CXX2118M 1 Motor Unit(LOADING) CXC4912M 2 Motor(STEPPING) CXM1364M 3 Motor(SPINDLE) CXM1362U 1 Navi Unit(EW5) CWX3640
Navi Unit(RE) CWX3650
Circuit Symbol and No. Part No.
AVIC-F900BT/XS/EW5 1875 6 7 8