3310-06 REAR PROPELLER SHAFT - Quality Service Manual · KYRON 2010.01 3310-00 2) Check Visual...

11-9

PROPELLER SHAFTKYRON 2010.01

3310-06

3310-06 REAR PROPELLER SHAFT

Remove the yoke mounting bolt and nut on the transfer case side of the rear propeller shaft.1.

Put installation marks on the yoke of the rear propeller shaft and the flange of the transfer case.

-

11-10

KYRON 2010.01

3310-06

PROPELLER SHAFT

Remove the intermediate bearing(center) bolts.2.

Remove the yoke and flage mounting bolts and nuts on the rear axle side of the rear propeller shaft. Then, remove the rear propeller shaft.

3.

11-11


3310-00

3310-00 DISASSEMBLY AND REASSEMBLYPROPELLER SHAFT

1) DisassemblyPlace an alignment mark and remove the propeller shaft.Place an alignment on the spiders before removing.

1.

2.

Remove the snap ring with snap ring pliers.3.

Tap the yoke shoulder on shaft with copper hammer to remove the roller bearing. Remove the other bearings with same manner.

4.

If it cannot be removed, hold the welding area with vise and remove the needle bearing by using a suitable drift and hammer.

5.

11-12

KYRON 2010.01

3310-00

PROPELLER SHAFT

Disassemble the universal joint.The universal joint compensates the angle changes due to vertical movementof the axle shaft.

6.

Remove the intermediate bearing bracket and remove the bearing with special tool.

7.

11-13


3310-00

2) CheckVisual Check Check the components for wear and crack and replace if needed.Outer diameter of spider journal.

1.

2.

Clearance between spider journal and bearing.

3.

Run-out of propeller shaft Set up the dial gauge on the center point of propeller shaft and measure the run-out. If the run-out is out of the specified range, correct it with press or replace it with new one.

4.

Starting torque of universal joint.5.

Specified value 17.893 mm

Limit 17.910 mm

Specified value 0.03 ~ 0.098 mm

Limit 0.25 mm

Limit 0.4 mm

Specified value 3 ~ 8 kg.cm

Major causes of vibration6.Balance weights missingExcessive run-out of propeller shafWhen using the general boltsExcessive wear of universal jointStuck in sleeve jointVibration is mainly caused by the angle changes in front and rear universal joint. It normally occurs when the vehicle speed is 60 ~ 100 km/h.

------

SERVICE MANUALWML_101GENERALGENERAL1. DIMENSIONS2. SPECIFICATIONS3. VEHICLE IDENTIFICATION4. MAINTENANCE INTERVAL5. RECOMMENDED FLUIDS AND LUBRICANTS6. JACK-UP POINTS7. PIN ARRANGEMENT OF DIAGNOSTIC CONNECTOR8. ELECTRIC COMPONENTS AND LAYOUT9. STANDARD BOLTS SPECIFICATIONS

WML_201ENGINE GENERALGENERAL1. ENGINE ASSEMBLY LAYOUT2. ENGINE CONTROLS LAYOUT3. ELECTRICAL COMPONENTS AND PREHEATING SYSTEM4. INTAKE SYSTEM LAYOUT5. EXHAUST SYSTEM LAYOUT6. LUBRICATION SYSTEM LAYOUT7. COOLING SYSTEM LAYOUT8. FUEL SYSTEM LAYOUT9. FUEL SUPPLY SYSTEM10. CLEANNESS11. MAINTENANCE AND REPAIR12. GUIDELINES FOR SERVICE WORK SAFETY13. DURING SERVICE WORK FOR INSPECTION14. DURING SERVICE WORK FOR ELECTRIC DEVICES15. OWNER INSPECTIONS AND SERVICES16. STANDARD BOLTS SPECIFICATIONS

WML_202ENGINE ASSEMBLYGENERAL1. MAJOR COMPONENTS IN ENGINE AND ENGINE COMPARTMENT2. SPECIFICATIONS AND PERFORMANCE CURVE3. TIGHTENING TORQUE

WML_203ENGINE FUEL SYSTEMGENERAL1. CAUTIONS FOR DI ENGINE

OVERVIEW AND OPERATION PROCESS1. ELECTRONIC CONTROL OF FUEL SYSTEM2. COMPOSITION OF FUEL SYSTEM3. HYDRAULIC CYCLE IN FUEL LINE (TRANSFER AND HIGH PRESSURE LINE)4. COMPONENTS OF LOW PRESSURE TRANSFER LINE5. COMPONENTS OF HIGH PRESSURE TRANSFER LINE6. CIRCUIT DIAGRAM

WML_204ENGINE INTAKE SYSTEMGENERAL1. ENGINE INTAKE SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. INTAKE SYSTEM LAYOUT2. AIR FLOWS

WML_205ENGINE EXHAUST SYSTEMGENERAL1. INSPECTION BEFORE DIAGNOSIS

OVERVIEW AND OPERATION PROCESS1. EXHAUST SYSTEM LAYOUT

WML_206LUBRICATION SYSTEMGENERAL1. SPECIFICATIONS2. OIL PRESSURE SWITCH

OVERVIEW AND PERATION PROCESS1. LAYOUT AND OVERVIEW2. LUBRICATION DIAGRAM

WML_207ENGINE COOLING SYSTEMGENERAL1. ENGINE COOLING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. COMPONENTS ENGINE COOLING2. COOLING SYSTEM FLOW3. FUNCTION DESCRIPTION OF COOLING SYSTEM

WML_208ENGINE ELECTRICAL SYSTEMGENERAL1.SPECIFICATIONS OF ENGINE ELECTRIC

OVERVIEW AND OPERATION PROCESS1. COMPONENTS OF ELECTRIC IN ENGINE2. COMPONENTS OF ELECTRIC DEVICES IN ENGINE3. CIRCUIT DIAGRAM OF PREHEATING SYSTEM4. CIRCUIT DIAGRAM OF STARTING AND ALTERNATOR

WML_209ENGINE CONTROL SYSTEMGENERAL1. ENGINE ECU AND OTHER COMPONENTS2. TOP VIEW3. SIDE VIEW

OVERVIEW AND OPERATION PROCESS1. ECU INPUTS/OUTPUTS2. STRUCTURE AND FUNCTION OF ECU3. CONTROL FUNCTION OF ECU4. FUEL PRESSURE CONTROL5. FUEL INJECTION CONTROL6. FUEL FLOW CONTROL7. INDIVIDUAL INJECTOR CALIBRATION (C2I)8. MINIMUM DRIVE PULSE (MDP) LEARNING

WML_210CRUISE CONTROL SYSTEMOVERVIEW AND OPERATION PROCESS1. CRUISE CONTROL SWITCH2. CIRCUIT DIAGRAM3. HOW TO OPERATE CRUISE CONTROL SWITCH

WML_301ENGINE ASSEMBLYGENERAL1. MAJOR COMPONENTS IN ENGINE AND ENGINECOMPARTMENT2. SPECIFICATIONS AND PERFORMANCE CURVE3. TIGHTENING TORQUE4. MAJOR CHANGES IN D20DT (EU-IV) ENGINE (COMPARED TO D20DT)

WML_302ENGINE FUEL SYSTEMGENERAL1. MAJOR CHANGES IN FUEL SYSTEM OF ENGINE

OVERVIEW AND OPERATION PROCESS1. COMPONENTS OF FUEL SYSTEM2. FUEL FLOW OF D20DT (EU-IV) ENGINE

WML_303ENGINE INTAKE SYSTEMOVERVIEW AND OPERATION PROCESS1. OVERVIEW2. INTAKE SYSTEM LAYOUT

WML_304ENGINE EXHAUST SYSTEMOVERVIEW AND OPERATION PROCESS1. COMPONENTS

WML_305CDPFGENERAL INFORMATION1. OVERVIEW FOR CDPF (EU-IV)2. CDPF (EU-IV) SYSTEM

OVERVIEW AND OPERATION PROCESS1. OVERVIEW2.CDPF (EU-IV) SYSTEM CONTROL3. SOOT FILTERING AND BURNING PROCEDURES4. COMPONENTS OF CDPF SYSTEM

WML_306LUBRICATION SYSTEMOVERVIEW AND OPERATION PROCESS1. OVERVIEW OIL SEPARATORS

WML_307ENGINE COOLING SYSTEMCOOLING SYSTEM1. COMPARISON IN COOLING SYSTEM FOR EACH ENGINE

WATER PUMP1. OVERVIEW

WML_308ENGINE ELECTRIC DEVICESOVERVIEW AND OPERATION PROCESS1. OVERVIEW OF ENGINE ECU2. D20DT (EU-IV) ENGINE'S ECU CIRCUIT


WML_310WML_401ENGINE GENERALGENERAL1. ENGINE ASSEMBLY LAYOUT2. COMPONENTS IN D20DT ENGINE AND D27DT ENGINE3. ENGINE CONTROLS LAYOUT4. ELECTRICAL COMPONENTS AND PREHEATING SYSTEM5. INTAKE SYSTEM LAYOUT6. EXHAUST SYSTEM LAYOUT7. LUBRICATION SYSTEM LAYOUT8. COOLING SYSTEM LAYOUT9. FUEL SYSTEM LAYOUT10. FUEL SUPPLY SYSTEM11. CLEANNESS12. MAINTENANCE AND REPAIR13.GUIDELINES FOR SERVICE WORK SAFETY14. DURING SERVICE WORK FOR INSPECTION15. DURING SERVICE WORK FOR ELECTRIC DEVICES16. OWNER INSPECTIONS AND SERVICES17. STANDARD BOLTS SPECIFICATIONS

WML_402ENGINE ASSEMBLYGENERAL1. MAJOR COMPONENTS IN ENGINE AND ENGINE COMPARTMENT2. ENGINE STRUCTURE3. SPECIFICATIONS AND PERFORMANCE CURVE4. TIGHTENING TORQUE

WML_403ENGINE FUEL SYSTEMGENERAL1. CAUTIONS FOR DI ENGINE

OVERVIEW AND OPERATION PROCESS1. ELECTRONIC CONTROL OF FUEL SYSTEM2. COMPOSITION OF FUEL SYSTEM3. HYDRAULIC CYCLE IN FUEL LINE (TRANSFER AND HIGH PRESSURE LINE)4. COMPONENTS OF LOW PRESSURE TRANSFER LINE5. COMPONENTS OF HIGH PRESSURE TRANSFER LINE

WML_404ENGINE INTAKE SYSTEMGENERAL1. ENGINE INTAKE SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. ENGINE INTAKE COMPONENTS LOCATOR2. AIR FLOWS

OVERVIEW AND OPERATION PROCESS2321-01 AIR FLOW SENSOR(HOT FILM AIR MASS SENSOR)2330-01 INTERCOOLER1715-01 INTAKE MANIFOLD ASSEMBLY

WML_405ENGINE EXHAUST SYSTEMGENERAL1. INSPECTION BEFORE DIAGNOSIS

OVERVIEW AND OPERATION PROCESS1. COMPONENTS LOCATOR OF EXHAUST SYSTEM2. EXHAUST GAS FLOWS

WML_406ENGINE LUBRICATION SYSTEMGENERAL1.SPECIFICATIONS OF ENGINE LUBRICATION

OVERVIEW AND OPERATION PROCESS1. COMPONENTS OF LUBRICATION SYSTEM2.LUBRICATION SYSTEM LAYOUT3. LUBRICATION DIAGRAM

WML_407ENGINE COOLING SYSTEMGENERAL1. ENGINE COOLING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. COMPONENTS ENGINE COOLING2. COOLING SYSTEM FLOW3. FUNCTION DESCRIPTION OF COOLING SYSTEM

WML_408ENGINE ELECTRIC SYSTEMGENERAL1.SPECIFICATIONS OF ENGINE ELECTRIC

OVERVIEW AND OPERATION PROCESS1. COMPONENTS OF ELECTRIC IN ENGINE2. COMPONENTS OF ELECTRIC DEVICES IN ENGINE3. CIRCUIT DIAGRAM OF PREHEATING SYSTEM4. CIRCUIT DIAGRAM OF STARTING AND ALTERNATOR

WML_409ENGINE CONTROL SYSTEMGENERAL1. ENGINE ECU AND OTHER COMPONENTS

OVERVIEW AND OPERATION PROCESS1. ECU INPUTS/OUTPUTS2. STRUCTURE AND FUNCTION OF ECU3. CONTROL FUNCTION OF ECU4. FUEL PRESSURE CONTROL5. FUEL INJECTION CONTROL6. FUEL FLOW CONTROL7. INDIVIDUAL INJECTOR CALIBRATION (C2I)8. MINIMUM DRIVE PULSE (MDP) LEARNING


WML_501ENGINE GENERALGENERAL1. STRUCTURE AND COMPARISON2. ENGINE SPECIFICATIONS AND PERFORMANCE CURVE3. TIGHTENING TORQUE4. MAJOR CHANGES IN D27DTP (POWER UP) ENGINE (COMPARED TO D27DT)4.

OVERVIEW AND OPERATION PROCESS1. ENGINE COMPARTMENT2. SYSTEMS IN ENGINE COMPARTMENT

WML_502ENGINE FUEL SYSTEMOVERVIEW AND OPERATION PROCESS1. MAJOR CHANGES IN FUEL SYSTEM OF D27DTP(POWER UP) ENGINE2. COMPONENTS OF FUEL SYSTEM

WML_503ENGINE INTAKE SYSTEMOVERVIEW AND OPERATION PROCESS1. INTAKE SYSTEM LAYOUT

WML_504ENGINE EXHAUST SYSTEMOVERVIE AND OPERATION PROCESS1. COMPONENTS

WML_505CDPFGENERAL INFORMATION1. OVERVIEW FOR CDPF (EU-IV)2. CDPF (EU-IV) SYSTEM

OVERVIEW AND OPERATION PROCESS1. OVERVIEW2.CDPF (EU-IV) SYSTEM CONTROL3. SOOT FILTERING AND BURNING PROCEDURES4. COMPONENTS OF CDPF SYSTEM

WML_506WML_507ENGINE COOLING SYSTEMOVERVIEW AND OPERATION PROCESS1. COMPARISON IN COOLING SYSTEM FOR EACH ENGINE

WML_508WML_509CRUISE CONTROL SYSTEMOVERVIEW AND OPERATION PROCESS1. CRUISE CONTROL SWITCH2. CIRCUIT DIAGRAM3. HOW TO OPERATE CRUISE CONTROL SWITCH

WML_510WML_511WML_601ENGINE INFORMATIONGENERAL1. COMPONENT LOCATOR2. DESCRIPTION AND OPERATION

WML_602ENGINE ASSEMBLYGENERAL1. SPECIFICATIONS2. SPECIAL TOOLS AND EQUIPMENT3. FASTENER TIGHTENING SPECIFICATIONS4. FASTENER TIGHTENING SPECIFICATIONS (CONT' D)

WML_603ENGINE FUEL SYSTEMOVERVEIW AND OPERATION PROCESS1. FUEL SYSTEM SPECIFICATION

WML_604WML_605ENGINE EXHAUST SYSTEMGENERAL1. OVERVIEW OF EXHAUST SYSTEM2. OVERVIEW OF MUFFLER3. OVERVIEW OF CATALYTIC CONVERTER4. FASTENER TIGHTENING SPECIFICATIONS

WML_606ENGINE LUBRICATION SYSTEMOVERVIEW AND OPERATION PROCESS1. OIL CIRCULATION

WML_607ENGINE COOLING SYSTEMGENERAL1. GENERAL SPECIFICATIONS2. SPECIAL TOOLS AND EQUIPMENT3. FASTENER TIGHTENING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. GENERAL DESCRIPTION2. COMPONENT LOCATOR

WML_608ENGINE ELECTRIC DEVICESGENERAL1. GENERAL SPECIFICATIONS2. FASTENER TIGHTENING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. CHARGING SYSTEM OPERATION2. STARTING SYSTEM OPERATION3. IGNITION SYSTEM OPERATION4. STARTING AND CHARGING SYSTEM (GASOLINE ENGINE) CIRCUIT

WML_609ENGINE CONTROL SYSTEMGENERAL1. ENGINE DATA DISPLAY TABLE2. FASTENER TIGHTENING SPECIFICATIONS


WML_701ENGINE ASSEMBLYGENERAL1. DESCRIPTION AND OPERATION2. G23D ENGINE ASSEMBLY3. G23D ENGINE STRUCTURE4. DIAGNOSTIC INFORMATION AND PROCEDURE5. GENERAL DIAGNOSIS6. SPECIFICATIONS

WML_702ENGINE INTAKE SYSTEMGENERAL1. SPECIFICATIONS

WML_703ENGINE EXHAUST SYSTEMGENERAL1. SPECIFICATION

OVERVIEW AND OPERATION PROCESS1. DESCRIPTION AND OPERATION

WML_704ENGINE COOLING SYSTEMGENERAL1. GENERAL SPECIFICATIONS2. FASTENER TIGHTENING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. COMPONENT LOCATOR2. DESCRIPTION AND OPERATION3. PWM (PULSE WIDTH MODULATION) ELECTRIC FAN OPERATION

WML_705ENGINE ELECTRIC DEVICESGENERAL1. DIAGNOSTIC INFORMATION AND PROCEDURE

OVERVIEW AND OPERATION PROCESS1. DESCRIPTION AND OPERATION


WML_801ELECTRIC SYSTEMELECTRIC GENERAL1. LOCATIONS OF INTERIOR UNITS AND SENSORS2. SWITCHES, UNITS AND SENSORS IN ENGINE COMPARTMENT3. INTERIOR SWITCHES4. AUDIO / VIDEO SYSTEM5. ELECTRIC COMPONENTS AND LAYOUT

WML_802FUSE AND RELAYGENERAL INFORMATION1. GENERAL INFORMATION

OVERVIEW AND OPERATING PROCESS1. OVERVIEW2. FUSE AND RELAY MOUNTING LOCATION3. CAPACITY AND NAME OF FUSE AND RELAY IN ENGINE COMPARTMENT4. CAPACITY AND NAME OF INTERIOR FUSE AND RELAY5. OPERATING PROCESS OF ICM BOX

WML_803RKSTICS/STICSGENERAL1. STICS OVERVIEW2. SPECIFICATIONS

WML_804IMMOBILIZER SYSTEMGENERAL1. IMMOBILIZER OVERVIEW2. BASIC FUNCTIONS OF IMMOBILIZER KEY (REKES FUNCTION)

WML_805SEAT POSITION WITH MEMORYGENERAL1. SEAT POSITION WITH MEMORY OVERVIEW

WML_806CLUSTERGENERAL1. DESCRIPTIONS OF INDICATOR DISPLAY2.WARNING / INDICATOR PANE

WML_807LAMPGENERAL1. LOCATIONS OF LAMPS AND SPECIFICATIONS

WML_808SWITCHGENERAL1. SWITCH ARRANGEMENT

WML_809WIPER & WASHERGENERAL1. WIPER AND WASHER SYSTEM OVERVIEW

OVERVIEW AND OPERATING PROCESS1. SYSTEM LAYOUT OF WIPER AND WASHER (WITH RAIN SENSOR)2. WIPER / WASHER RELATED FUNCTION AND SPECIFICATION3. WIPER AND WASHER SYSTEM RELATED CIRCUIT4. REAR WIPER

WML_810RAIN SENSORGENERAL1. RAIN SENSING SYSTEM (WITH AUTO LIGHT SENSOR) OVERVIEW

OVERVIEW AND OPERATION PROCESS1. FUNCTIONS AND SPECIFICATIONS OF RAIN SENSING WIPER2. OPERATION MODE OF RAIN SENSING WIPER SYSTEM3. ELECTRICAL WIRING DIAGRAM

WML_811PAS(PARKING AID SYSTEM)GENERAL1. COMPONENT SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. SYSTEM CONFIGURATION2. ALARM INTERVAL AND TROUBLE SHOOTING3. CAUTIONS ON PARKING AID SYSTEM4. CIRCUIT DIAGRAM

WML_812AVGENERAL1. AV HEAD UNIT OVERVIEW

OVERVIEW AND OPERATION PROCESS1. AV SYSTEM CONFIGURATION2. AV HEAD SYSTEM CIRCULATION3. AV SYSTEM FUNCTIONS4. AV SYSTEM SPECIFICATIONS AND CONTROL

WML_813AUDIO SYSTEMOVERVIEW AND INSTALLATION1. AUDIO SYSTEM OVERVIEW

WML_901ION 4-SPEEDGENERAL1. SPECIFICATIONS2. FASTENER TIGHTENING SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. DESCRIPTION AND OPERATION OF AUTOMATIC TRANSMISSION2. APPEARANCE3. SHIFT PATTERN DIAGRAM4. OPERATORS INTERFACES5. CONTROL SYSTEMS6. ELECTRONIC CONTROL SYSTEM7. HYDRAULIC CONTROL SYSTEM8. POWER FLOWS

WML_902AUTOMATIC TRANSMISSION(DC 5-SPEED)GENERAL1. AUTOMATIC TRANSMISSION OVERVIEW2. AUTOMATIC TRANSMISSION (DC 5-SPEED) APPEARANCE3. AUTOMATIC TRANSMISSION STRUCTURE

OVERVIEW AND OPERATION PROCESS1. POWER FLOW

WML_903DSI M78 6-SPEED A/TGENERAL INFORMATION1. DSI M78 6-SPEED AUTOMATIC TRANSMISSION GENERAL2. STRUCTURE CHARACTERISTICS AND SPECIFICATIONS3. TIGHTENING TORQUE

OVERVIEW AND OPERATION PROCESS1. GENERAL DESCRIPTION2. ADVANCED SIX SPEED FEATURES3. FUNCTION OF EACH MODE4. LIMP HOME MODE5. TRANSMISSION ELECTRONIC CONTROL SYSTEM6. CONFIGURATION OF CAN RELATED TO TCU7. POWER TRAIN

DIAGNOSIS AND TESTING1. WIRING DIAGRAM2. WIRE HARNESS CONNECTOR CHART3. UNIT CONNECTOR DESCRIPTION

TROUBLE CODE EIAGNOSIS1. DIAGNOSTIC TROUBLE CODE LIST2. SYSTEM DIAGNOSIS

MAINTENANCE OPERATIONS1. OIL TEST2. STALL TEST3. TRANSMISSION RESET PROCEDURE(REPLACEMENT TRANSMISSION)4. FLUID LEVEL INSPECTION5. TRANSMISSION COOLER AND HYDRAULIC LINE FLUSHING PROCEDURE6. LUBRICATION7. TRANSMISSION COOLER AND HYDRAULIC LINE FLUSHING PROCEDURE(NEW TRANSMISSION)

WML_904TGS LEVEROVERVIEW AND OPERATION PROCESS1. OVERVIEW2. LOCATIONS AND COMPONENTS3. INPUT/OUTPUT OF TGS LEVER

WML_905T/M LEVEROVERVIEW AND OPERATIONP ROCESS1. CIRCUIT OF ION 4-SPEED AUTOMATIC T/M2. CIRCUIT OF SHIFT INTER LOCK

WML_906MANUAL TRANSMISSIONGENERAL1. OVERVIEW AND CHARACTERISTICS OF MANUAL TRANSMISSION2. SPECIFICATIONS AND TIGHTENING TORQUE OF MANUAL TRANSMISSION

OVERVIEW AND OPERATION PROCESS1. MANUAL TRANSMISSION SYSTEM

WML_907CLUTCHGENERAL1. CLUTCH SPECIFICATIONS2. TIGHTTENING TORQUE

OVERVIEW AND OPERATION PROCESS1. FUNCTION AND OVERVIEW

WML_908AXLEGENERAL1. AXLE SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. AXLE OVERVIEW

WML_909AXLE (IOP)OVERVIEW AND OPERATION PROCESS1. OVERVIEW2. WHEEL ALIGNMENT

WML_910PART TIME TRANSFER CASE & LOCKING HUB SYSTEMGENERAL1. PART TIME TRANSFER CASE OVERVIEW2. PART TIME TRANSFER CASE SPECIFICATIONS

OVERVIEW AND OPERATION PROCESS1. STRUCTURE2. SYSTEM LAYOUT AND FUNCTIONS3. LOCKING HUB SYSTEM4. POWER FLOW

WML_911PROPELLER SHAFTGENERAL1. SPECIFICATION

OVERVIEW AND OPERATION PROCESS1. OVERVIEW2. COMPONENT LOCATOR3310-01 FRONT PROPELLER SHAFT3310-06 REAR PROPELLER SHAFT3310-00 DISASSEMBLY AND REASSEMBLY PROPELLER SHAFT

WML_912SUSPENSIONGENERAL1. FRONT SUSPENSION SPECIFICATIONS2. REAR SUSPENSION SPECIFICATIONS

WML_913ESPGENERAL1. BRAKE SYSTEM GENERAL INFORMATION2. BRAKE SYSTEM SPECIFICATIONS3. BRAKE OPERATION AND NOISE4. ESP SYSTEM RELATED PRECAUTIONS

OVERVIEW AND OPERATION PROCESS1. ESP SYSTEM OF GENERAL INFORMATION2. PRINCIPLE OF ESP3. HBA (HYDRAULIC BRAKE ASSIST SYSTEM)4. ARP (ACTIVE ROLL-OVER PROTECTION)5. HDC (HILL DESCENT CONTROL)6. ESP COMPONENTS AND LOCATIONS7. INPUT/OUTPUT SIGNALS FOR HDC OPERATION8. ESP HYDRAULIC CIRCUIT DIAGRAM9. HYDRAULIC PRESSURE FOR EACH ESP OPERATING RANGE10. HYDRAULIC CIRCUIT OF HBA(HYDRAULIC BRAKE ASSIST)11. GENERAL INFORMATION OF ABS SYSTEM12. CONFIGURATION OF ABS SYSTEM13. INPUT AND OUTPUT DIAGRAM OF ABS14. HYDRAULIC CIRCUIT OF ABS15. ABS CIRCUIT IN EACH OPERATION RANGE

WML_914STEERINGGENERAL1. POWER STEERING SYSTEM OVERVIEW2. POWER STEERING SPECIPICATIONS

OVERVIEW AND OPERATION PROCESS1. POWER STEERING SYSTEM LAYOUT2. SSPS (SPEED SENSING POWER STEERING) OVERVIEW AND FUNCTIONS3. S.S.P.S OPERATIONS

WML_1001AIR CONDITIONEROVERVIEW AND OPERATION PROCESS1. SYSTEM LAYOUT AND COMPONENTS2. VENTILATION SYSTEM COMPONENTS3. AIR CONDITIONER MODULE WIRING AND LAYOUT4. PTC HEATER AND FFH HEATER LAYOUT5. AMBIENT TEMPERATURE SENSOR6. SENSORS AND ACTUATORS7. AIR CONDITIONER SYSTEM DIAGRAM8. AIR CONDITIONER MODULE SENSORS AND ACTUATORS9. FFH (FUEL FIRED HEATER) SYSTEM COMPONENTS10. FFH OPERATING PROCESS

WML_1002AIR BAGGENERAL1. REMINDER FOR AIR BAG RELATED COMPONENT REPLACEMENT

OVERVIEW AND OPERATION PROCESS1. AIR BAG SYSTEMS (INCLUDING CURTAIN AIR BAGS) OVERVIEW2. AIR BAG SYSTEM LOCATIONS AND RELATED COMPONENTS3. AIR BAG SYSTEM OPERATION PROCESS4. AIR BAG MODULE AND OTHER COMPONENTS5. AIR BAG SYSTEM DEPLOY (FIRING LOOP)6. AIR BAG DEPLOYMENT SIGNAL OUTPUT (CRASH OUT)7. AIR BAG WARNING LAMP OPERATIONAL CONDITIONS8. AIR BAG ELECTRICAL WIRING DIAGRAM

WML_1003SEATGENERAL1. SEAT OVERVIEW

OVERVIEW AND OPERATION PROCESS1. SEAT OVERVIEW2. SEAT BELT OVERVIEW

WML_1004SUNROOFGENERAL1. HAZARD (MANUAL) OPERATION2. RESETTING OF SUNROOF CONTROL UNIT3. TROUBLE DIAGNOSIS

OVERVIEW AND OPERATION PROCESS1. SUNROOF COMPONENTS AND LOCATIONS2. SUNROOF OPERATION AND FUNCTION3.SUNROOF CIRCUIT DIAGRAM

WML_1005WML_1006WML_1007BODY REPAIRGENERAL1. DIMENSIONS2. JACK-UP POINTS3. DESIGN CHANGES FOR IMPROVING NVH PERFORMANCE

WML_1101ECU-GASOLINEDIAGNOSIS1. ECU-GASOLINE

WML_1102ECU-DIESELDIAGNOSIS1. ECU-DIESEL

WML_1103BRAKEDIAGNOSIS1. BRAKE

WML_1104AIR-BAGDIAGNOSIS1. AIR-BAG

WML_1105CCCSDIAGNOSIS1. CCCS

WML_1106FATCDIAGNOSIS1. SELF DIAGNOSIS

WML_1107FFHDIAGNOSIS1. FFH

WML_1108P/TRUNKDIAGNOSIS1. P/TRUNK

WML_1109RAIN SENSORDIAGNOSIS1. TROUBLE SHOOTING

WML_1110STICSDIAGNOSIS1. STICS

WML_1111TCDIAGNOSIS1. TC

WML_1112TCUDIAGNOSIS1. TCU

WML_1113TGS LEVERDIAGNOSIS1. TGS LEVER

EWD (LHD)EWL_101GENERAL INFORMATIONGENERAL INFORMATION1. HOW TO READ ELECTRICAL WIRING DIAGRAM

EWL_201CONNECTOR/GROUNDWIRING HARNESS0000-00 WIRING HARNESS, COMPONENTS LOCATION

EWL_202CONNECTOR8210-00 W/H ENGINE ROOM8210-02 W/H MAIN8210-03 W/H FLOOR8210-09 W/H ROOF8210-07 W/H FRT DOOR8210-08 W/H RR DOOR8210-10 W/H DECK

EWL_301POWER DISTRIBUTIONFUSE / RELAY8210-00 ENGINE ROOM FUSE / RELAY BOX8410-00 I/P - LH FUSE / RELAY BOX8410-00 I/P - RH FUSE / RELAY BOX

EWL_302ELECTRICITY DIVIDE8210-00 ENGINE ROOM FUSE / RELAY BOX CIRCUIT8410-00 I/P - LH FUSE / RELAY BOX CIRCUIT8410-00 I/P - RH FUSE / RELAY BOX CIRCUIT8410-00 ICM RELAY BOX CIRCUIT

EWL_401CIRCUITENGINE1461-00 STARTING / CHARGING2820-00 PREHEATING CIRCUIT1491-00 ECU (ENGINE CONTROL UNIIT - D20/D27DT EU-IV)1491-00 ECU (ENGINE CONTROL UNIT - D20/D27DT)1490-00 ECU (ENGINE CONTROL UNIT - GSL G32)1490-00 ECU (ENGINE CONTROL UNIT - GSL G23)8210-00 DIAGNOSIS CIRCUIT

EWL_402CHASSIS3110-00 TCU (6-A/T)3110-00 TCU (5-A/T)3110-00 TCU (4-A/T)3740-00 A/T SHIFT LOCK (4-A/T)3410-00 TCCU4892-00 ABS/ESP4620-00 S.S.P.S (SPEED SENSITIVE POWER STEERING

EWL_403ELECTRIC8810-00 AIR-BAG (CURTAIN AIR-BAG)8010-00 CLUSTER7410-00 POWER SEAT - DRIVER (W/ MEMORY)7410-00 POWER SEAT - DRIVER (W/O MEMORY)7410-00 POWER SEAT - PASSENGER8510-00 ELECTRIC OUTSIDE MIRROR / FOLDING(W/O MEMORY)8510-00 FRT SEAT WARMER8610-00 RR SEAT WARMER8710-00 STICS7830-00 RR WIPER CIRCUIT8510-00 POWER WINDOW CIRCUIT8610-00 HORN7632-00 CIGAR LIGHTER / POWER OUTLET CIRCUIT7340-00 SUN ROOF CIRCUIT8310-00 HEAD LAMP/DRL(DAY TIME RUNNING LIGHT) UNIT CIRCUIT8510-00 HLLD (HEAD LAMP LEVEL G DEVICE) CIRCUIT8320-00 TAIL LAMP CIRCUIT8410-00 TURN SIGNAL / HAZARD LAMP CIRCUIT8210-00 TRAILER LAMP CIRCUIT8310-00 FOG LAMP CIRCUIT4810-00 STOP / BACK-UP LAMP CIRCUIT7770-00 INTERIOR LAMP CIRCUIT7770-00 AUTO DIMMING ROOM MIRROR CIRCUIT8910-00 AUDIO / CLOCK CIRCUIT8790-00 PARKING AID CIRCUIT6810-00 PTC HEATER(POSITIVE TEMPERATURE COEFFICIENT)6910-00 FFH (FUEL FIRED HEATER)6810-00 FATC (FULL AUTO TEMP. CONTROL) CIRCUIT6810-00 AIR-CON (MANUAL) CIRCUIT

EWD (RHD)EWR_101GENERAL INFORMATIONGENERAL INFORMATION1. HOW TO READ ELECTRICAL WIRING DIAGRAM

EWR_201CONNECTOR/GROUNDWIRING HARNESS8201-00 WIRING HARNESS, COMPONENTS LOCATION

EWR_301POWER DISTRIBUTIONFUSE / RELAY8410-02 ENGINE ROOM FUSE / RELAY BOX8410-04 I/P - RH FUSE / RELAY BOX8410-06 I/P - LH FUSE / RELAY BOX

EWR_302ELECTRICITY DIVIDE8210-02 ENGINE ROOM FUSE / RELAY BOX CIRCUIT8410-04 I/P - RH FUSE / RELAY BOX CIRCUIT8410-06 I/P - LH FUSE / RELAY BOX CIRCUIT8410-06 ICM RELAY BOX CIRCUIT

EWR_401CIRCUITENGINE1461-01 STARTING / CHARGING2820-01 PREHEATING CIRCUIT1491-01 ECU (ENGINE CONTROL UNIT - D20/D27DT EU-IV)1491-01 ECU (ENGINE CONTROL UNIT - D20/D27DT)1491-01 ECU (ENGINE CONTROL UNIT - GSL G32)8210-01 DIAGNOSIS CIRCUIT

EWR_402CHASSIS3110-01 TCU (6-A/T)3110-01 TCU (DC5 - A/T)3410-01 TCCU4892-01 ABS/ESP

EWR_403ELECTRIC8810-01 AIR-BAG (CURTAIN AIR-BAG)8010-01 CLUSTER7410-13 POWER SEAT - DRIVER (W/ MEMORY)7410-02 POWER SEAT - DRIVER (W/O MEMORY)7410-04 POWER SEAT - PASSENGER8510-01 ELECTRIC OUTSIDE MIRROR (W/O MEMORY)8510-48 FRT SEAT WARMER8510-48 RR SEAT WARMER8710-02 STICS7830-03 RR WIPER CIRCUIT8510-05 POWER WINDOW CIRCUIT8610-06 HORN7632-16 CIGAR LIGHTER / POWER OUTLET CIRCUIT7340-03 SUN ROOF CIRCUIT8310-01 HEAD LAMP / DRL(DAY TIME RUNNING LIGHT) UNIT CIRCUIT8510-00 HLLD (HEAD LAMP LEVEL G DEVICE) CIRCUIT8320-01 TAIL LAMP CIRCUIT8410-01 TURN SIGNAL / HAZARD LAMP CIRCUIT8210-01 TRAILER LAMP CIRCUIT8310-10 FOG LAMP CIRCUIT4810-01 STOP / BACK-UP LAMP CIRCUIT7770-02 INTERIOR LAMP CIRCUIT7770-10 AUTO DIMMING ROOM MIRROR CIRCUIT8910-01 AUDIO / CLOCK CIRCUIT8790-01 PARKING AID CIRCUIT6810-01 PTC (POSITIVE TEMPERATURE COEFFICIENT) HEATER6810-20 FATC (FULL AUTO TEMP. CONTROL) CIRCUIT6810-20 AIR-CON (MANUAL) CIRCUIT4620-12 S.S.P.S(SPEED SENSITIVE POWER STEERING)

OWNERS MANUAL (LHD)OML_00GeneralRECOMMENDED FLUIDS AND LUBRICANTSDIMENSIONSSPECIFICATIONS (I)VEHICLE IDENTIFICATION

OML_01Safety PrecautionsCHECKS BEFORE STARTING A JOURNEYSTARTING THE ENGINE AND DRIVING OFF THE VEHICLESAFETY PRECAUTIONSDIRECT INJECTION TYPE DIESEL ENGINEPRECAUTIONS REGARDING UNAUTHORIZED MODIFICATION & ALTERATION

OML_02Ignition Key, Remote Control KeyREMOTE CONTROL KEY* AND IGNITION KEYREMOTE CONTROL KEY FUNCTIONSKEY FUNCTIONSIMMOBILIZER SYSTEM*OPENING AND CLOSING THE DOORS WITH IGNITION KEYTHEFT DETERRENT SYSTEM

OML_03Opening and ClosingOPENING AND CLOSING DEVICESDOORSWINDOWSSUNROOF*TAILGATEENGINE HOODFUEL FILLER DOOR

OML_04Interior SwitchesINTERIOR SWITCHESLIGHT SWITCHWIPER AND WASHER SWITCHRAIN SENSING WIPER*CRUISE CONTROL SWITCH*OUTSIDE REARVIEW MIRROR CONTROL SWITCHESPOFF (ELECTRONIC STABILITY PROGRAM) SWITCH AND ESP SYSTEM*CENTER SWITCH PANELHDC (HILL DESCENT CONTROL) SWITCH*HEATED GLASS SWITCHAUDIO REMOTE CONTROL SWITCHES ON STEERING WHEEL4-WHEEL DRIVE SYSTEM*SWITCHES IN OVERHEAD CONSOLELIMITED SLIP DIFFERENTIAL (LSD)*LOCKING DIFFERENTIAL (LD)*

OML_05Instrument ClusterInstrument ClusterTachometer, SpeedometerCoolant Temperature Gauge, Fuel GaugeDisplayBattery Charge Warning Light, Air Bag Warning Light, ESP Warning Light, HDC IndicatorImmobilizer Indicator, Seat Belt Reminder,SSPS Warning LightWater Separator Warning LightHow to Drain the Water from the Fuel Filter(Without Additional Water Separator)How to Drain the Water from the Fuel Filter(With Additional Water Separator)4WD Indicators (Part Time T/C Only)Engine Overheat Warning Light, Front Fog Light Indicator, High Beam Indicator, Door Ajar Warning LightEngine Hood Open Warning Light, Engine Oil Pressure Warning Light, Engine Check Warning Light, Cruise Control Indicator*Glow Indicator (Diesel Only), EBD Warning Light, ABS Warning LightBrake Warning Light, Winter Mode Indicator,Low Fuel Level Warning Light

OML_06Transmission and Brake SystemSHIFT LEVER IN MANUAL TRANSMISSIONGEAR SELECTOR LEVER IN AUTOMATIC TRANSMISSION - 5 SPEEDDRIVING TIPS FOR AUTOMATIC TRANSMISSIONGEAR SELECTOR LEVER POSITIONSWINTER (W) / STANDARD (S) MODESAFETY MODE (AUTOMATIC TRANSMISSION)GEAR SELECTOR LEVER IN AUTOMATIC TRANSMISSION - 6 SPEEDDRIVING TIPS FOR AUTOMATIC TRANSMISSIONGEAR SELECTOR LEVER POSITIONSWINTER (W) / STANDARD (S) MODESAFETY MODE (AUTOMATIC TRANSMISSION)PARKING AID SYSTEMBRAKE SYSTEMPARKING BRAKE OPERATION (FOOT OPERATED TYPE)PARKING BRAKE OPERATION (HAND OPERATED TYPE)

OML_07SeatsDRIVER’S SEAT (POWER SEAT)*DRIVER’S SEAT (MANUAL SEAT)PASSENGER’S SEATPOSITION MEMORY SETTING*SECOND ROW SEATSTHIRD ROW SEATS*SEAT HEATING SYSTEM*WARNING AND CAUTION

OML_08Seat Belt and Air BagSEAT BELT AND AIR BAGSEAT BELTHOW TO FASTEN THE THREE POINT SEAT BELTHOW TO FASTEN THE SEAT BELTS IN SECOND ROW CENTER SEATCHILD RESTRAINTS AND PREGNANT WOMANWARNINGS FOR SEAT BELTAIR BAGAIRBAG NON-INFLATION CONDITIONSWARNINGS FOR AIR BAG

OML_09Ventilation, Heating, Air Conditioning and Air Purification SystemHEATER/AIR CONDITIONER SYSTEMWARNINGS AND CAUTIONSSUPPLEMENTARY HEATING DEVICEAUTOMATIC HEATER / AIR CONDITIONER*MANUAL HEATER / AIR CONDITIONERDEFOGGING AND DEFROSTINGREPLACING AIR CONDITIONER FILTER

OML_10Turbocharger SystemCAUTIONS IN USING THE TURBOCHARGERPREVENTIVE MAINTENANCETURBOCHARGER INSPECTION

OML_11Convenience DevicesSTORAGE BOXES AND CONVENIENCE DEVICETILTABLE STEERING WHEEL AND HORNINSIDE REARVIEW MIRRORMAP POCKET / HANDBAG HOOKCENTER CONSOLECENTER CONSOLE / FRONT CUP HOLDER / ASHTRAY HOLDER (DELUXE TYPE)CENTER CONSOLE / FRONT CUP HOLDER / ASHTRAY HOLDER (STANDARD TYPE)OVERHEAD CONSOLECARD HOLDER / SUN VISORS AND VANITY MIRROR LAMPGLOVE BOX / DIGITAL CLOCKREMOVABLE ASHTRAY / STORAGE BOX (FRONT)CIGARETTE LIGHTERPOWER OUTLETREAR ARMREST / ASSIST GRIP AND COAT HOOKROOM LAMPSREAR CUP HOLDER* AND REAR STORAGE BOX, REAR DEFOGGER AND ANTENNAENVELOPE NET AND LUGGAGE HOOKSAUDIO / VIDEO SYSTEM

OML_12In Case of EmergencySTARTING THE ENGINE WITH JUMPER CABLESOVM TOOLSCHANGING A FLAT TIRECAUTIONS WHEN A TIRE IS FLATREMOVING THE SPARE TIRECHANGING A SPARE TIRECAUTIONS WHEN CHANGING THE TIREWHEN THE ENGINE IS OVERHEATINGWATER SEPARATOR WARNING LIGHT AND ENGINE CHECK WARNING LIGHTSHIFT LEVER LOCK RELEASE AND SAFETY MODE RESETTOWING A DISABLED VEHICLEEMERGENCY TOWINGTRAILER TOWINGACCIDENT OR FIREWARNING TRIANGLE*EMISSION REDUCTION DEVICE

OML_13Service and MaintenanceDAILY CHECK LISTLOCATIONS IN ENGINE COMPARTMENTENGINE OILENGINE COOLANTAIR CLEANERPOWER STEERING FLUIDFUEL FILTER AND PRIMING PUMP (Without Additional Water Separator)FUEL FILTER AND WATER SEPARATOR (With Additional Water Separator)FUEL FILTERBRAKE AND CLUTCH FLUID (WITH M/T)WASHER FLUIDBATTERYFUSE AND RELAY BOXTIRESPARE TIRE AND WINTER TIREWIPER BLADE REPLACEMENTSPARK PLUGS (FOR GASOLINE)DO-IT-YOURSELF OPERATIONSCHEDULED MAINTENANCE SERVICES (DIESEL ENGINE)SCHEDULED MAINTENANCE SERVICES (GASOLINE ENGINE)

OML_14LampBULB SPECIFICATIONS AND FUNCTIONAL CHECKLOCATION OF EXTERIOR LAMPSINTERIOR LAMPS

OML_15Vehicle CareVEHICLE CARECARING FOR YOUR VEHICLE UNDER 0°C (32°F)IMPORTANT SAFETY INSTRUCTIONS

OML_16Index

OWNERS MANUAL (RHD)OMR_00GeneralRECOMMENDED FLUIDS AND LUBRICANTSDIMENSIONSSPECIFICATIONS (I)VEHICLE IDENTIFICATION

OMR_01Safety PrecautionsCHECKS BEFORE STARTING A JOURNEYSTARTING THE ENGINE AND DRIVING OFF THE VEHICLESAFETY PRECAUTIONSDIRECT INJECTION TYPE DIESEL ENGINEPRECAUTIONS REGARDING UNAUTHORIZED MODIFICATION & ALTERATION

OMR_02Ignition Key, Remote Control KeyREMOTE CONTROL KEY* AND IGNITION KEYREMOTE CONTROL KEY FUNCTIONSKEY FUNCTIONSIMMOBILIZER SYSTEM*OPENING AND CLOSING THE DOORS WITH IGNITION KEYTHEFT DETERRENT SYSTEM

OMR_03Opening and ClosingOPENING AND CLOSING DEVICESDOORSWINDOWSSUNROOF*TAILGATEENGINE HOODFUEL FILLER DOOR

OMR_04Interior SwitchesINTERIOR SWITCHESLIGHT SWITCHWIPER AND WASHER SWITCHRAIN SENSING WIPER*CRUISE CONTROL SWITCH*OUTSIDE REARVIEW MIRROR CONTROL SWITCHESPOFF (ELECTRONIC STABILITY PROGRAM) SWITCH AND ESP SYSTEM*CENTER SWITCH PANELHDC (HILL DESCENT CONTROL) SWITCH*HEATED GLASS SWITCHAUDIO REMOTE CONTROL SWITCHES ON STEERING WHEEL4-WHEEL DRIVE SYSTEM*SWITCHES IN OVERHEAD CONSOLELIMITED SLIP DIFFERENTIAL (LSD)*LOCKING DIFFERENTIAL (LD)*

OMR_05Instrument ClusterInstrument ClusterTachometer, SpeedometerCoolant Temperature Gauge, Fuel GaugeDisplayBattery Charge Warning Light, Air Bag Warning Light, ESP Warning Light, HDC IndicatorImmobilizer Indicator, Seat Belt Reminder,SSPS Warning LightWater Separator Warning LightHow to Drain the Water from the Fuel Filter(Without Additional Water Separator)How to Drain the Water from the Fuel Filter(With Additional Water Separator)4WD Indicators (Part Time T/C Only)Engine Overheat Warning Light, Front Fog Light Indicator, High Beam Indicator, Door Ajar Warning LightEngine Hood Open Warning Light, Engine Oil Pressure Warning Light, Engine Check Warning Light, Cruise Control Indicator*Glow Indicator (Diesel Only), EBD Warning Light, ABS Warning LightBrake Warning Light, Winter Mode Indicator,Low Fuel Level Warning Light

OMR_06Transmission and Brake SystemSHIFT LEVER IN MANUAL TRANSMISSIONGEAR SELECTOR LEVER IN AUTOMATIC TRANSMISSION - 5 SPEEDDRIVING TIPS FOR AUTOMATIC TRANSMISSIONGEAR SELECTOR LEVER POSITIONSWINTER (W) / STANDARD (S) MODESAFETY MODE (AUTOMATIC TRANSMISSION)GEAR SELECTOR LEVER IN AUTOMATIC TRANSMISSION - 6 SPEEDDRIVING TIPS FOR AUTOMATIC TRANSMISSIONGEAR SELECTOR LEVER POSITIONS - 6 SPEEDWINTER (W) / STANDARD (S) MODE - 6 SPEEDSAFETY MODE (AUTOMATIC TRANSMISSION)PARKING AID SYSTEMBRAKE SYSTEMPARKING BRAKE OPERATION

OMR_07SeatsDRIVER’S SEAT (POWER SEAT)*DRIVER’S SEAT (MANUAL SEAT)PASSENGER’S SEATPOSITION MEMORY SETTING*SECOND ROW SEATSTHIRD ROW SEATS*SEAT HEATING SYSTEM*WARNING AND CAUTION

OMR_08Seat Belt and Air BagSEAT BELT AND AIR BAGSEAT BELTHOW TO FASTEN THE THREE POINT SEAT BELTHOW TO FASTEN THE SEAT BELTS IN SECOND ROW CENTER SEATCHILD RESTRAINTS AND PREGNANT WOMANWARNINGS FOR SEAT BELTAIR BAGAIRBAG NON-INFLATION CONDITIONSWARNINGS FOR AIR BAG

OMR_09Ventilation, Heating, Air Conditioning and Air Purification SystemHEATER / AIR CONDITIONER SYSTEMWARNINGS AND CAUTIONSSUPPLEMENTARY HEATING DEVICEAUTOMATIC HEATER / AIR CONDITIONER*MANUAL HEATER / AIR CONDITIONERDEFOGGING AND DEFROSTINGREPLACING AIR CONDITIONER FILTER

OMR_10Turbocharger SystemCAUTIONS IN USING THE TURBOCHARGERPREVENTIVE MAINTENANCETURBOCHARGER INSPECTION

OMR_11Convenience DevicesSTORAGE BOXES AND CONVENIENCE DEVICETILTABLE STEERING WHEEL AND HORNINSIDE REARVIEW MIRRORMAP POCKET / HANDBAG HOOKCENTER CONSOLE / FRONT CUP HOLDER / ASHTRAY HOLDEROVERHEAD CONSOLECARD HOLDER / SUN VISORS AND VANITY MIRROR LAMPGLOVE BOX / DIGITAL CLOCKREMOVABLE ASHTRAY / STORAGE BOX (FRONT)CIGARETTE LIGHTERPOWER OUTLETREAR ARMREST / ASSIST GRIP AND COAT HOOKROOM LAMPSREAR CUP HOLDER* AND REAR STORAGE BOX, REAR DEFOGGER AND ANTENNAENVELOPE NET AND LUGGAGE HOOKSAUDIO / VIDEO SYSTEM

OMR_12In Case of EmergencySTARTING THE ENGINE WITH JUMPER CABLESOVM TOOLSCHANGING A FLAT TIRECAUTIONS WHEN A TIRE IS FLATREMOVING THE SPARE TIRECHANGING A SPARE TIRECAUTIONS WHEN CHANGING THE TIREWHEN THE ENGINE IS OVERHEATINGWATER SEPARATOR WARNING LIGHT AND ENGINE CHECK WARNING LIGHTSHIFT LEVER LOCK RELEASE AND SAFETY MODE RESETTOWING A DISABLED VEHICLEEMERGENCY TOWINGTRAILER TOWINGACCIDENT OR FIREWARNING TRIANGLE*EMISSION REDUCTION DEVICE

OMR_13Service and MaintenanceDAILY CHECK LISTLOCATIONS IN ENGINE COMPARTMENTENGINE OILENGINE COOLANTAIR CLEANERPOWER STEERING FLUIDFUEL FILTER AND PRIMING PUMP (Without Additional Water Separator)FUEL FILTER AND WATER SEPARATOR (With Additional Water Separator)FUEL FILTER (FOR GASOLINE)BRAKE AND CLUTCH FLUID (WITH M/T)WASHER FLUIDBATTERYFUSE AND RELAY BOXTIRESPARE TIRE AND WINTER TIREWIPER BLADE REPLACEMENTSPARK PLUGS (FOR GASOLINE)DO-IT-YOURSELF OPERATIONSCHEDULED MAINTENANCE SERVICES (DIESEL ENGINE)SCHEDULED MAINTENANCE SERVICES (GASOLINE ENGINE)

OMR_14LampBULB SPECIFICATIONS AND FUNCTIONAL CHECKLOCATION OF EXTERIOR LAMPSINTERIOR LAMPS

OMR_15Vehicle CareVEHICLE CARECARING FOR YOUR VEHICLE UNDER 0°C (32°F)IMPORTANT SAFETY INSTRUCTIONS

OMR_16Index

/ColorImageDict > /JPEG2000ColorACSImageDict > /JPEG2000ColorImageDict > /AntiAliasGrayImages false /CropGrayImages true /GrayImageMinResolution 300 /GrayImageMinResolutionPolicy /OK /DownsampleGrayImages true /GrayImageDownsampleType /Bicubic /GrayImageResolution 300 /GrayImageDepth -1 /GrayImageMinDownsampleDepth 2 /GrayImageDownsampleThreshold 1.50000 /EncodeGrayImages true /GrayImageFilter /DCTEncode /AutoFilterGrayImages true /GrayImageAutoFilterStrategy /JPEG /GrayACSImageDict > /GrayImageDict > /JPEG2000GrayACSImageDict > /JPEG2000GrayImageDict > /AntiAliasMonoImages false /CropMonoImages true /MonoImageMinResolution 1200 /MonoImageMinResolutionPolicy /OK /DownsampleMonoImages true /MonoImageDownsampleType /Bicubic /MonoImageResolution 1200 /MonoImageDepth -1 /MonoImageDownsampleThreshold 1.50000 /EncodeMonoImages true /MonoImageFilter /CCITTFaxEncode /MonoImageDict > /AllowPSXObjects false /CheckCompliance [ /None ] /PDFX1aCheck false /PDFX3Check false /PDFXCompliantPDFOnly false /PDFXNoTrimBoxError true /PDFXTrimBoxToMediaBoxOffset [ 0.00000 0.00000 0.00000 0.00000 ] /PDFXSetBleedBoxToMediaBox true /PDFXBleedBoxToTrimBoxOffset [ 0.00000 0.00000 0.00000 0.00000 ] /PDFXOutputIntentProfile () /PDFXOutputConditionIdentifier () /PDFXOutputCondition () /PDFXRegistryName () /PDFXTrapped /False

/Description > /Namespace [ (Adobe) (Common) (1.0) ] /OtherNamespaces [ > /FormElements false /GenerateStructure true /IncludeBookmarks false /IncludeHyperlinks false /IncludeInteractive false /IncludeLayers false /IncludeProfiles true /MultimediaHandling /UseObjectSettings /Namespace [ (Adobe) (CreativeSuite) (2.0) ] /PDFXOutputIntentProfileSelector /NA /PreserveEditing true /UntaggedCMYKHandling /LeaveUntagged /UntaggedRGBHandling /LeaveUntagged /UseDocumentBleed false >> ]>> setdistillerparams> setpagedevice



















































/ColorImageDict > /JPEG2000ColorACSImageDict > /JPEG2000ColorImageDict > /AntiAliasGrayImages false /CropGrayImages true /GrayImageMinResolution 300 /GrayImageMinResolutionPolicy /OK /DownsampleGrayImages true /GrayImageDownsampleType /Bicubic /GrayImageResolution 300 /GrayImageDepth -1 /GrayImageMinDownsampleDepth 2 /GrayImageDownsampleThreshold 1.50000 /EncodeGrayImages true /GrayImageFilter /DCTEncode /AutoFilterGrayImages true /GrayImageAutoFilterStrategy /JPEG /GrayACSImageDict > /GrayImageDict > /JPEG2000GrayACSImageDict > /JPEG2000GrayImageDict > /AntiAliasMonoImages false /CropMonoImages true /MonoImageMinResolution 1200 /MonoImageMinResolutionPolicy /OK /DownsampleMonoImages true /MonoImageDownsampleType /Bicubic /MonoImageResolution 1200 /MonoImageDepth -1 /MonoImageDownsampleThreshold 1.50000 /EncodeMonoImages true /MonoImageFilter /CCITTFaxEncode /MonoImageDict > /AllowPSXObjects false /CheckCompliance [ /None ] /PDFX1aCheck false /PDFX3Check false /PDFXCompliantPDFOnly false /PDFXNoTrimBoxError true /PDFXTrimBoxToMediaBoxOffset [ 0.00000 0.00000 0.00000 0.00000 ] /PDFXSetBleedBoxToMediaBox true

3310-06 REAR PROPELLER SHAFT - Quality Service Manual · KYRON 2010.01 3310-00 2) Check Visual...

Documents

Transcript of 3310-06 REAR PROPELLER SHAFT - Quality Service Manual · KYRON 2010.01 3310-00 2) Check Visual...