Post on 06-Apr-2018
8/2/2019 Imod Manual
1/14
Owners Manual
Read and understand this entire manual beore riding!
Item Number:
iMod 15130699
Owners Manual
*The iPod product name is used or identifcation purposes only. iPod is a registered trademark o Apple Inc.
8/2/2019 Imod Manual
2/14
WARNING: Riding the iMod can be a hazardous activity.Certain conditions may cause the equipment to ail without ault o themanuacturer. Like other electric vehicles, the iMod can and is intended tomove, and it is thereore possible to lose control, all o and/or get intodangerous situations that no amount o care, instruction or expertise caneliminate. I such things occur you can be seriously injured or die, even whenusing saety equipment and other precautions. RIDE AT YOUR OWN RISKAND USE COMMON SENSE.
This manual contains many warnings and cautions concerning the
consequences o ailing to maintain, inspect or properly use your iMod.Because any incident can result in serious injury or even death, we do notrepeat the warning o potential serious injury or death each time such apossibility is mentioned.
APPROPRIATE RIDER USE ANDPARENTAL SUPERVISIONThis manual contains important saety inormation. It is your responsibilityto review this inormation and make sure that all riders understand allwarnings, cautions, instructions and saety topics and assure that youngriders are able to saely and responsibly use this product. Razor recommendsthat you periodically review and reinorce the inormation in this manualwith younger riders, and that you inspect and maintain your childrensvehicle to insure their saety.
The recommended rider age o 12 and older or iMod is only an estimate,and can be aected by the riders size, weight or skills. Any rider unable to tcomortably on the iMod should not attempt to ride it. A parents decisionto allow his or her child to ride this product should be based on thechilds maturity, skill and ability to follow rules.
Keep this product away rom small children and remember that this productis intended or use only by persons who are, at a minimum, completelycomortable and competent while operating the vehicle.
DO NOT EXCEED THE WEIGHT LIMIT OF 170 pounds (77kg).Rider weight does not necessarily mean a persons size is appropriate to tor maintain control o the iMod.
Do not touch the motor on your iMod when in use as it can become very hot.
Reer to the section on saety or additional warnings.
ACCEPTABLE RIDING PRACTICES ANDCONDITIONSAlways check and obey any local laws or regulations which may aectthe locations where the iMod may be used on public property. The iMod ismeant to be used only in controlled environments ree o potential trachazards and not on public streets or sidewalks. Do not ride your iMod in anyareas where pedestrian or vehicle trac is present.
Ride deensively. Watch out or potential obstacles that could catch yourwheel or orce you to swerve suddenly or lose control. Be careul to avoidpedestrians, skaters, skateboards, scooters, bikes, children or animals whomay enter your path, and respect the rights and property o others.
Do not attempt or do stunts or tricks on your iMod. The iMod is not made towithstand abuse rom misuse such as jumping, curb grinding or any othertype o stunts.
Maintain a hold on the handlebars at all times.
Never carry passengers or allow more than one person at a time to ride theiMod.
Keep your ngers and other body parts away rom the drive chain, steeringsystem, wheels and all other moving components.
Never use headphones, earbuds or a cell phone when riding.
Not suited or video iPod use.
Give ull attention to riding. Stop riding and turn o the iMod power switch too beore adjusting volume or changing channels.
Never attempt to access iPod compartment while riding.
Never hitch a ride with another vehicle.
Do not ride the iMod in wet weather and never immerse the iMod in water, asthe electrical and drive components could be damagedby water or create other possibly unsae conditions.
The iMod is intended or use on solid, fat, clean and dry suraces such aspavement or level ground without loose debris such as rocks or gravel. Neveruse near steps or swimming pools. Wet, slick or uneven and rough suraces
may impair traction and contribute to possible accidents. Do not ride the iModin mud, ice, puddles or water. Avoid excessive speeds that can be associatedwith downhill rides. Never risk damaging suraces such as carpet or fooringby use o a iMod indoors.
Do not ride at night or when visibility is impaired.
PROPER RIDING ATTIREAlways wear proper protective equipment such as an approved saety helmet.Elbow pads and kneepads are recommended. A helmet may be legallyrequired by local law or regulation in your area. Always wear shoes, neverdrive bareooted or in sandals, and keep shoelaces tied and out o the way othe wheels, motor and drive system.
USING THE CHARGERThe charger supplied with the iMod should be regularly examined or damageto the cord, plug, enclosure and other parts, and in the event o such damage,the iMod must not be charged until the charger has been repaired or replaced.
Use only with the recommended charger.
Use caution when charging. Do not exceed charging time.
The charger is not a toy. Charger should be operated by an adult.
Do not operate charger near fammable materials.
Unplug charger and disconnect rom the battery operated product when not inuse.
Always disconnect rom the charger prior to wiping down and cleaning yourscooter with liquid.
FAILURE TO USE COMMON SENSE AND HEED THEABOVE WARNINGS INCREASES RISK OF SERIOUSINJURY. USE WITH APPROPRIATE CAUTION ANDSERIOUS ATTENTION TO SAFE OPERATION.
SAFETY WARNINGS
1
Saety Warnings ............................................................ 1
Beore You Begin ........................................................... 2
Assembly and Set-Up ................................................. 3-5
Repair and Maintenance ............................................. 6-7
Troubleshooting Guide ................................................ 8-9
iMod Parts .............................................................. 10-11
Saety Reminders ........................................................ 13
Warranty ...................................................................... 13
CONTENTS
8/2/2019 Imod Manual
3/14
Remove contents rom box. Remove the oam separators that protect the components rom damage during shipping.Inspect the contents o the box or scratches in the paint, dents or kinked cables that may have occurred duringshipping. Because the iMod was 95 percent assembled and packed at the actory, there should not be any problems,even i the box has a ew scars or dents.
Estimated Assembly and Set-Up Time
Razor recommends assembly by an adult with experience in bicycle mechanics.Allow up to 15 minutes or assembly, not including initial charge time.Allow up to 18 hours or initial charge (see page 3 or charging inormation).
BEFORE YOU BEGIN
2
WARNING:DO NOT USE NON-RAZORPRODUCTS WITH YOUR
RAZOR iMOD.The iMod has been built to certainRazor design specications. The
original equipment supplied at thetime o sale was selected on thebasis o its compatibility with therame, ork and all other parts.Certain atermarket products mayor may not be compatible.
Need Help? Visit our web site or updates and a list o authorized service centers at www.razor.com or call toll-ree
at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacic Time.
2.5mm, 3mm, 5mm, 6mmhexagonal key wrench
(included)
Bicycle-style tire pumpor Schrader valve tires,
with pressure gauge
(not included)
14mm & 15mm wrenches(included)
spoke wrenches(included)
Kick StandChain Guard
Storage CompartmentUnder Seat
Brake LeverAdjuster
Brake Lever
Front Fork
Speed Control
On/OSwitch
ChargerPort
Required ToolsSome tools may be supplied; however, we recommend the use o mechanics grade tools. Use the supplied tools onlyas a last resort.
Charger
ChargerPlug
ChargerPort
8/2/2019 Imod Manual
4/14
3
ASSEMBLY AND SET-UP
qCharging the BatteryYour iMod may not have a ully charged battery; thereore it is a good idea to charge the battery prior to use. Initialchargetime:18hours Runtime:upto40minutesRechargetime:upto12hours Averagebatterylife:250charge/dischargecycles
depending on the level o depletion
1Turn o power switch beorecharging. Plug the charger into thecharger port on the iMod.
2Plug the charger plug into a walloutlet.
WARNING:Rechargeable batteries are only tobe charged under adult supervision.Always disconnect your iMod romthe charger beore cleaning withliquid.
Note:I your charger does notlook like the one illustrated,your unit has been suppliedwith an alternative charger.The specications and chargingprocedure would not change.
The charger has a small windowwith one LED or two LEDs toindicate the charge status. Reerto the illustration on the chargerunit or the actual charging andcharged status indications oryour model charger.
Chargers have built-in over-chargeprotection to prevent battery rombeing over-charged.
Be sure to properly align thegroove on the charger inputplug with the correspondingsocket on the case; otherwise,no charging action will occur.
ChargerPlug
ChargerPort
WARNING: Failing toproperly adjust and tighten the
bolts that ax the handlebar cancause you to lose control and all.
1Remove the plastic cover endo the handlebars beore insertingthe handlebars. Insert handlebarassembly through ront airing andinto ork until it stops. Raise to de-sired height keeping the handlebarsand airing aligned within the red
arrows o the saety zone.
2Tighten down the hexagonalbolt with the 6mm hexagonal keywrench.
qAttaching the Handlebars
qAttaching the Side View Mirrors
1Adjust the rear view mirrorsocket into xed place and tightendown hal hexagonal bolts with3mm hexagonal key wrench.
2Insert the rear view mirror intosockets and tighten down the nutswith 14mm supplied wrench.
8/2/2019 Imod Manual
5/14
4
Check the Razor web site or any updates on the latest repair and maintenance procedures.Turn power switch off before conducting any maintenance procedures.
qAdjusting the Brakes
1To adjust the play, thread thebrake lever adjuster in or out 1/4to 1/2 turn until the desired brakeadjustment is attained. Mostadjustments are complete at thisstep. I brake still needs urtheradjustment, proceed to step 2.
2 I the brake lever adjuster isthreaded outward and the brakestill has too much slack, use therear brake adjuster or additionaladjustment.
WARNING:The brakeis capable o skidding the tire andthrowing an unsuspecting rider.
Practice in an open area ree romobstacles until you are amiliar withthe brake unction. Avoid skiddingto a stop as this can cause you tolose control or damage the rear tire.
Note:The brake lever contains asaety switch to stop the motorwhen the brake is applied. In anemergency, applying the brakewill always stop the motor. Do notdisable or replace this lever withanything other than a genuine Razorreplacement part.
qTesting the BrakesTo use the brake, squeeze the lever to increase the pressure on the brake. The brake lever is tted with a cable adjusterto compensate or cable stretch and/or to ne-tune the lever movement to brake engagement. I brake is not engagingproperly, ollow instructions or adjusting the brakes below.
1Remove the packing materialrom the ront ork.
2Insert the wheel into the rontork with the lock washers on theoutside o the ork.
qAttaching the Front Wheel
3Insert the tab on the lockwasher into the hole on the rontork and tighten the nuts with thesupplied wrenches.
ASSEMBLY AND SET-UP
qChecking Spoke Tension
1 Veriy spoke tension by grasping and shacking each spoke. Spokeshould not be loose rom hub. Look or any play between spoke fangeand hub. Try to turn nipple using your ngers. You should not be able toturn any nipple by hand. Check all spokes and tighten i necessary.
2 Start with spoke closest to tire valveand tighten each nipple. In sequence,exactly 1/4 to 1/2 turn. A single 1/4 to1/2 turn may not be enough to bring thespokes into proper tension. Continuetightening all spokes no more than 1/2turn in sequence until all spokes aretight.
WARNING:Regularlycheck the spoke tension and
retighten the spokes wheneverloose. I you have any doubt, ask anexperienced motorcycle or bicyclemechanic to inspect your spokesto determine i the spokes needtightening or adjusting.
Note:Tightening each nipple morethan a 1/2 turn each can cause thewheel to become distorted andwobbly thus permanently damagingthe wheel.
SpokeFlange
Spoke
Nipple
Hub
Flange
Spoke
Flange
Rim
Nipple
123
28
27
8/2/2019 Imod Manual
6/14
qInating the TiresTires are infated when shipped, but they invariably lose some pressure between the point o manuacturing andyour purchase.
1Using a bicycle style tire pumpequipped or a Schrader-type valve,infate the tires to the PSIindicated on the sidewall o thetires.
Note:The pressurized air suppliesound at gasoline stations aredesigned to infate high-volumeautomobile tires. I you decide touse such an air supply to infateyour iMod tires, rst make sure thepressure gauge is working, thenuse very short bursts to infate tothe correct PSI. I you inadvertentlyover-infate the tire, release theexcess pressure immediately.
ASSEMBLY AND SET-UP
qAttaching your iPod
qInstalling batteries or speakers
1Open the battery port locatedunder the power controller. Install4AA batteries in the battery port.(Batteries not included)
1Open the iPod compartment andattach player to the 30 pin connec-tor. Place the iPod in the compart-ment and securely asten the cover.
5
*The iPod product name is used or identifcation purposes only.
iPod is a registered trademark o Apple Inc.
WARNING: It is yourresponsibility to secure your iPodplayer. Razor is not responsible oriPod damage.
Note:This product was designed
to accommodate ONLY iPods inproduction as o January 2008. Notrecommended or use with videoiPod players.
2A.) To turn on speakers, press the powerbutton.
B.) To turn on iPod unction, press the iPodbutton.
C.) To listen to the FM Radio, press the FMbutton.
D.) FM stations are adjusted by the buttonson the bottom o controller.
E.) Volume adjuster ( )
D
A
Battery Port
EB
C
8/2/2019 Imod Manual
7/14
REPAIR AND MAINTENANCE
4 With two 15mm wrenches,loosen the axle. Push the wheelorward in the slots to loosen thechain.
5Pull the wheel out. Note thearrangement o the hardwaresequence.Note: Your hands will get greasydoing this.
6Install the new chain or wheelby slipping the chain around theaxle. Slide the axle into the slotson the rame. Slide the wheelorward and maneuver the chainonto the rear sprocket, rontsprocket and chain tensioner.
qChain and Rear Tire ReplacementTools required: Phillips screwdriver, 10mm wrench, two (2) 8mm wrenches, and two (2) 17mm wrenches.
1With a Phillips screwdriver,remove the screws that secure thechainguard. Remove chainguard.
2With a 8mm wrench, loosen thebrake cable anchor anddisconnect the cable.
3 With two 10mm wrenches,loosen brake housing anchor anddisconnect. Keep the spacer andwashers together.
7Tighten the brake housinganchor securely.
8Re-attach the chain guard. Testride and check. Readjust as needed.
6
8/2/2019 Imod Manual
8/14
qBattery Care and DisposalDo not store the battery in temperatures above 75 or below -10 F.
CONTAINS SEALED LEAD ACID BATTERIES. BATTERIES MUST BE RECYCLED.
Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed o in anenvironmentally sound manner. Do not dispose o a lead-acid battery in a re. The battery may explode or leak. Do notdispose o a lead-acid battery in your regular household trash. The incineration, land lling or mixing o sealed lead-acid batteries with household trash is prohibited by law in most areas. Return exhausted batteries to a ederal or state
approved lead-acid battery recycler or a local seller o automotive batteries. I you live in Florida or Minnesota, it isprohibited by law to throw away lead-acid batteries in the municipal waste stream.
qChargerThe transormer/charger supplied with the iMod should be regularly examined or damage to the cord, plug, enclosureand other parts, and, in the event o such damage, the iMod must not be charged until it has been repaired or replaced.
Use ONLY with the recommended charger.
qReplacement PartsThe most requently requested replacement parts (wheels, tires, tubes, batteries and chargers) are available orpurchase at some Razor retail partners or online at www.razor.com.
qRepair Centers
For a list o authorized Razor repair centers:Checkonlineatwww.razor.com Sendane-mailorcall866-467-2967forthecenternearestyou.
WARNING:I a batteryleak develops, avoid contact withthe leaking acid and place thedamaged battery in a plastic bag.Reer to the disposal instructions atlet. I acid comes into contact withskin or eyes, fush with cool wateror at least 15 minutes and contact
a physician.
REPAIR AND MAINTENANCE
q Replacing the FuseWARNING:
To prevent shock or short circuit,please ollow the instructionsaccordingly and do not skip orcombine any steps.
2 Lit up the seat and remove thestorage compartment.
5 Close the use cover. Replacethe storage compartment and closethe seat cover.
4Remove the use and replacewith a new one o equalamperage.Note: Amperage rating islocated on top o use. Fuse mustbe replaced with one o equalamperage.
Amperagenumber
1 Make sure the power switch isturned OFF.
3 Locate use cover ontop o battery assembly. Open theuse cover to expose the use.
7
8/2/2019 Imod Manual
9/14
iMod does not run
iMod was running butsuddenly stopped
Short run time (less than30 minutes per charge)
iMod runs sluggishly
Problem Possible Cause Solution
Undercharged battery
Charger is not working
Loose wires or connectors
Burned out use
Motor or electrical switch damage
Undercharged battery
Battery is old and will not acceptull charge
Brakes are not adjusted properly
Driving conditions are too stressul
Tires are not properly infated
iMod is overloaded
Brakes are not adjusted properly
Charge the battery. A new battery should have been charged or at least 18hours beore using the vehicle or the rst time and up to 12 hours ater eachsubsequent use.
Check all connections. Make sure the charger is tightly plugged into thecharging port on the iMod, and that the charger is plugged into the wall.
Make sure power fow to the wall outlet is on.
You may check to see i your charger is working by using a volt meter orasking your local Razor authorized service center to test your charger or you.
Check all wires and connectors to make sure they are tight.
The use will burn out and automatically shut o the power i the motor isoverloaded.An excessive overload, such as too heavy a rider or too steep a hill, couldcause the motor to overheat. Replace the use with a new one o equal
amperage. Correct the conditions that caused the use to burn out and avoidrepeatedly burning out use.
Contact your local Razor authorized service center or diagnosis and repair.
Charge the battery. A new battery should have been charged or at least 18hours beore using the vehicle or the rst time and up to 12 hours ater eachsubsequent use.Check all wires and connectors. Make sure the battery connector is tightlyplugged into the charger connector and that the charger is plugged intothe wall.
Make sure power fow to the wall outlet is on.
Even with proper care, a rechargeable battery does not last orever. Averagebattery lie is 1 to 2 years depending on iMod use and conditions. Replaceonly with a Razor replacement battery.
Reer to adjusting the brakes instructions on page 4.
Use only on solid, fat, clean and dry suraces such as pavement or levelground.
The tires are infated when shipped, but they invariably will lose somepressure between the point o manuacturing and your purchase.Reer to instructions on page 5.
Make sure you do not overload the iMod by allowing more than one riderat one time, exceeding the 170 lb. maximum weight limit, going up a hillor towing objects behind the iMod. I the iMod is overloaded, the use willblow.
Reer to adjusting the brakes instructions on page 4.
TroubleShooTing guide
8
8/2/2019 Imod Manual
10/14
Sometimes the iModdoesnt run, but othertimes it does
Charger gets warm duringuse
iMod does not stop whenapplying the brake
iMod makes loud noises orgrinding sounds
Problem Possible Cause Solution
Loose wires or connectors
Motor or electrical switch damage
Normal response to charger use
Brakes are not adjusted properly
Chain adjustment is too tight or tooloose
Chain is too dry
Check all wires around and all connectors to make sure they are tight.
Contact your local Razor authorized service center or diagnosis and repair.
No action required. This is normal or some chargers and is no cause orconcern. I your charger does not get warm during use, it does not meanthat it is not working properly.
Reer to adjusting the brakes instructions on page 4.
Reer to instructions on page 6 o this manual to properly adjust chain andsprocket.
Apply a lubricant such as 3 in 1TM
or Tri-FlowTM
to the chain.
TroubleShooTing guide
Need Help? Visit our web site or updates and a list o authorized service centers at www.razor.com or call toll-ree
at 866-467-2967Monday - Friday 8:00 AM - 5:00 PM Pacic Time.
9
8/2/2019 Imod Manual
11/14
Keep your Pocket Mod running or years with genuine Razor parts. Visit our web site or e-mail us or more inormation on spare part availability.(Specications subject to change without notice.)
POCKET MOD IMOD PARTS
1 Handlebar Grip (Right/Let)
2 Brake Lever Assembly
3 Side View Mirror (Right/Let)
3-1 Side View Mirror Socket
4 Handlebar
5 Twist Grip Throttle
5-1 Sleeve
6 Front Fairing Cover
6-1 iPod Case
6-2 Speaker Cover
6-3 Audio PC Board
6-4 Audio Cover
6-5 iPod Plug
6-6 Control Board
6-7 Speaker
6-8 Battery Cover
7 Fairing w/Headlamp Cover
8 Front Wheel Complete
9 Front Fork
10 Base Fairing
11 Motor (24V 350W)
12 Kickstand
13 Rear Wheel Complete
14 Chain
15 Chain Guard
16 Battery (2-12V/10AH) w/Fuse
17 Control Module
18 Front Seat Fairing
19 On/O Switch
20 Charger Port w/Wires
21 Seat Fairing
22 Rear Fairing w/Trim (Right/Let)
23 Bottom Cover o Storage Compartment
24 Storage Compartment
10
8/2/2019 Imod Manual
12/14
POCKET MOD IMOD PARTS
11
8/2/2019 Imod Manual
13/14
SB 1918 (CALIFORNIA) DECLARATION
YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS
INVOLVING THE USE OF THIS SCOOTER/ELECTRIC VEHICLE. TO DETERMINE
IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE
COMPANY OR AGENT.
12
8/2/2019 Imod Manual
14/14
Tire InationPeriodically inspect the tires or excess wearand replace as required, and regularly check the
tire pressure and re-infate as necessary. I you
get a fat tire, the inner tube can be patched ora new tube can be purchased rom Razor or an
authorized repair center.
Saety GearAlways wear proper protective equipment suchas an approved saety helmet. Elbow pads and
kneepads are recommended. Always wear shoes,never drive bareooted or in sandals, and keep
shoelaces tied and out o the way o the wheels,
motor and drive system.
Razor Limited WarrantyThe manuacturer warranties this product to be ree o manuacturing deectsor a period o 90 days rom date o purchase. This Limited Warranty doesnot cover normal wear and tear, tires, tubes or cables, or any damage, ailureor loss caused by improper assembly, maintenance, or storage or use o theRazor Pocket Mod.
This Limited Warranty will be void i the product is everusedinamannerotherthanforrecreation;modiedinanyway;rented.
The manuacturer is not liable or incidental or consequential loss or damagedue directly or indirectly to the use o this product.
Razor does not oer an extended warranty. I you have purchased anextended warranty, it must be honored by the store at which it waspurchased.
WARRANTY
Need Help? Visit our web site or updates and a list o authorized service centers at www.razor.com or call toll-ree
at 866-467-2967Monday - Friday 8:00 AM - 5:00 PM Pacic Time.
For your records, save your original sales receipt with this manual and writethe serial number below.
__________________________________________
Item Number:
iMod 15130699
Loose PartsThere should not be any unusual rattles or soundsrom loose parts or broken components. I you are not
sure, ask an experienced mechanic to check.
BrakeCheck the brake or proper unction. When yousqueeze the lever, the brake should provide positive
braking action. When you apply the brake with thespeed control on, the brake cut-o switch will stop
the motor.
Frame, Fork and HandlebarsCheck or cracks or broken connections. Although
broken rames are rare, it is possible or an aggressive
driver to bash into a curb or wall and wreck and bendor break a rame. Get in the habit o inspecting yoursregularly.
SAFETY REMINDERS
q
q
q
q
q
PRE-RIDE CHECKLIST
061208
DO NOT RETURN TO STOREDo not use this vehicle or the frst time until you
have inated the tires to the correct PSI andcharged the battery or at least 18 hours.
Failure to ollow these instructions may damageyour vehicle and void your warranty.
Printed in China or:Razor USA LLCPO Box 3610Cerritos, CA 90703
Copyright 2003 - 2008 Razor USA LLC. All rights reserved. RAZOR and the Razor LogoDesign are among the registered trademarks o Razor USA LLC in the United States and/or
select oreign countries.