Hydraulic Fracturing PanelHydraulic Fracturing Panel
Water ConsiderationsWater Considerations
Presented at
Texas Groundwater Summit
August 28-30, 2012
byby
Ronald T. Green, Ph.D. , P.G. Geosciences and Engineering Division
Southwest Research Institute®
Amount of Water Needed to Hydraulically Amount of Water Needed to Hydraulically Fracture a WellFracture a Well
�� Water demand Water demand to to frackfrack a well is substantial:a well is substantial:
�� 55--15 acre15 acre--ft (ft (1,500,0001,500,000--5,000,000 gallons5,000,000 gallons) to ) to frackfrack a boreholea borehole
�� Compared with Compared with 100,000 gallons 100,000 gallons to to drilldrill a wella well
DisposalDisposal of of FrackingFracking Waste WaterWaste Water
Page 2
�� DisposalDisposal of of FrackingFracking Waste WaterWaste Water
�� Considerable amount of degraded water Considerable amount of degraded water returns to surface as returns to surface as flowbackflowback: 20% in “dry” formations, 80% in “wet” formations: 20% in “dry” formations, 80% in “wet” formations
�� Quality of Quality of flowbackflowback can be poorcan be poor: : frackingfracking additives plus highadditives plus high--salinity in salinity in situ groundwatersitu groundwater
�� Disposal Disposal of of flowbackflowback in Texas is often in Texas is often by deepby deep--well injectionwell injection
Water Quality of Concern in Flowback
FlowbackFlowback contains contains frackingfracking additivesadditives
�� Precipitated & entrained solids (scaling tendencies) Precipitated & entrained solids (scaling tendencies)
�� Ca, Mg, Ca, Mg, BaBa, , SrSr
�� Mineral scales (calcium carbonate & BaSOMineral scales (calcium carbonate & BaSO44) )
�� Iron solids (iron oxide and iron sulfide) Iron solids (iron oxide and iron sulfide)
Dispersed clay fines, colloids & silts Dispersed clay fines, colloids & silts
Page 3
�� Dispersed clay fines, colloids & silts Dispersed clay fines, colloids & silts
�� High dissolved solids levels (chlorides, sulfates, calcium, etc.) High dissolved solids levels (chlorides, sulfates, calcium, etc.)
�� Bacteria Bacteria
�� Suspended solids, Suspended solids, frackfrack sand (sand (proppantproppant))
�� Liquid & gas hydrocarbons Liquid & gas hydrocarbons
�� Acid gases (COAcid gases (CO2 & H& H2S)S)
�� Friction reducer residue Friction reducer residue
plus formation (i.e., highly saline) waterplus formation (i.e., highly saline) water
An injection well has greater influence
in the direction of maximum horizontal
stress and major faults and fractures
StressStress--Field Induced Preferential FlowField Induced Preferential Flow
Injected fluids tend to follow existing fractures consistent Injected fluids tend to follow existing fractures consistent
with prewith pre--existing stress field instead of as a isotropic sphereexisting stress field instead of as a isotropic sphere
Page 4
stress and major faults and fractures
Isotropic sphere
Actual volume of injection
Regulations Predicated on Isotropic Media
Disposal Well Permit Guidance (Texas)Disposal Well Permit Guidance (Texas)
�� … the applicant shall review … wells that penetrate the … the applicant shall review … wells that penetrate the
proposed disposal zone proposed disposal zone within a 1/4 mile radius of the of the
proposed disposal well to determine if all abandoned proposed disposal well to determine if all abandoned
Page 5
wells have been plugged in a manner that will prevent wells have been plugged in a manner that will prevent
the movement of fluids from the disposal zone into the movement of fluids from the disposal zone into
freshwater strata.freshwater strata.
This This regulation assumes pure radial flow and does not account for heterogeneity that could result from stressthat could result from stress--
field induced directional flowfield induced directional flow
Inadvertent Contaminant Migration Inadvertent Contaminant Migration
Possible Modes of MigrationPossible Modes of Migration
1.1. Migration along fault or through confining layer Migration along fault or through confining layer –– not likely unless vertical not likely unless vertical
separation is minimalseparation is minimal
2.2. Migration via an existing borehole Migration via an existing borehole (i.e., abandoned open well) (i.e., abandoned open well) –– possible, possible,
particularly if an abandoned well is not identified, reasonably close to the particularly if an abandoned well is not identified, reasonably close to the
disposal well, and contaminant is injected into the same horizon as the disposal well, and contaminant is injected into the same horizon as the
screened section of the abandoned wellscreened section of the abandoned well
Page 6
screened section of the abandoned wellscreened section of the abandoned well
Disposal well Abandoned
open wells
Usable aquifer
Confining layer
Zone of injection
Injection of disposal fluids
±
Example: Proposed Injection Well
Page 7
±
0 1 2 3 40.5
Kilometers
A
±
Abandoned Oil/Gas WellsRRC Database is not Comprehensive
Proposed Disposal
Well
Page 8
Well
Symbol
!A Permitted Location
D Canceled Location
R Dry Hole
!( Oil Well
#* Gas Well
") Oil/Gas Well
!. Plugged Oil Well
#0 Plugged Gas Well
"/ Plugged Oil/Gas Well
±
0 1 2 3 40.5
Kilometers
Existing Water Wells
Area of Interest
Page 9
±
Stress-Field Ellipse Indicating Potential Direction of Preferential Flow
Proposed Disposal
Well
¼-mileradius
Page 10
Well
Symbol
!A Permitted Location
D Canceled Location
R Dry Hole
!( Oil Well
#* Gas Well
") Oil/Gas Well
!. Plugged Oil Well
#0 Plugged Gas Well
"/ Plugged Oil/Gas Well
±
0 1 2 3 40.5
Kilometers
Existing Water Wells
Abandoned Wells
Failure of wells used for deep-well disposal of waste fluids and migration of
waste fluids through 1,000s of feet of rock are not the greatest threat
Actual Threat from Disposal Wells
Page 11
are not the greatest threat
Abandoned wells pose the greatest threat in deep-well disposal of waste fluids, and
possibly hydraulic fracking
How Great is the Threat from Abandoned Wells?How Great is the Threat from Abandoned Wells?
Oil drilling began in earnest in the Oil drilling began in earnest in the early 1900searly 1900s, some , some
wells have been in existence for almost a century.wells have been in existence for almost a century.
RecordsRecords of wells, especially older wells, are often of wells, especially older wells, are often
incomplete or absentincomplete or absent..
Page 12
Well casing Well casing is estimated is estimated effective for 20 yrseffective for 20 yrs, structural , structural
integrity of older abandoned wells may be compromised.integrity of older abandoned wells may be compromised.
How many? How many? Estimates vary from Estimates vary from less than 10,000 less than 10,000 to to
over over 110,000 (orphan and inactive) wells110,000 (orphan and inactive) wells. .
Is Waste Disposal by DeepIs Waste Disposal by Deep--Well Injection Well Injection a Problem?a Problem?
Disposal of degraded fluids after Disposal of degraded fluids after frackingfracking ((flowbackflowback) by ) by
12,610 disposal wells in Texas 12,610 disposal wells in Texas
RRC requires notification RRC requires notification of all occurrences of of all occurrences of breakoutbreakout, but , but
doesn’t maintain a single databasedoesn’t maintain a single database
Page 13
RRC on RRC on retains records retains records on breakout for on breakout for onlyonly two yearstwo years
There are documented cases There are documented cases of breakoutof breakout
In absence of a centralized database, risk is unknown, but In absence of a centralized database, risk is unknown, but
possible possible
RecommendationsRecommendations
There are several actions the State can take to There are several actions the State can take to mitigate mitigate
the threat the threat of contamination due to “breakout” from a of contamination due to “breakout” from a
disposal well. disposal well.
�� Limit or prohibit injection of liquid wastes into oil/gas Limit or prohibit injection of liquid wastes into oil/gas (i.e., (i.e., productive) productive) formationsformations, particularly formations with a history of , particularly formations with a history of
Page 14
productive) productive) formationsformations, particularly formations with a history of , particularly formations with a history of oil/gas development. oil/gas development. That’s where the abandoned wells are.That’s where the abandoned wells are.
�� Increase the ¼Increase the ¼--mile radial distance mile radial distance from proposed disposal well from proposed disposal well over which abandoned wells are searched.over which abandoned wells are searched.
�� Develop a single database Develop a single database for all occurrences of “breakout”. Risk for all occurrences of “breakout”. Risk from breakout can only be assessed if number of occurrences and from breakout can only be assessed if number of occurrences and their severity are known.their severity are known.
Contact InformationContact Information
Ronald T. Green, Ph.D., P.G.Ronald T. Green, Ph.D., P.G.
Institute ScientistInstitute Scientist
Geosciences and Engineering DivisionGeosciences and Engineering Division
Southwest Research InstituteSouthwest Research Institute
Page 15
Southwest Research InstituteSouthwest Research Institute
6220 Culebra6220 Culebra
San Antonio, Texas 78238San Antonio, Texas 78238
1.210.522.5305 (office)1.210.522.5305 (office)
1.210.522.5184 (fax)1.210.522.5184 (fax)
1.210.316.9242 (cell)1.210.316.9242 (cell)
[email protected]@swri.edu
Page 16
SW Segment of the Carrizo-Wilcox AquiferPrePre--Development Development PotentiometricPotentiometric SurfaceSurface
Groundwater elevation reconstructed with limited
Page 17
reconstructed with limited data and historical evidence of spring flow and flowing artesian wells.
(modified from Deeds et al., 2003)
19291929--30 Carrizo30 Carrizo--Wilcox AquiferWilcox AquiferPotentiometricPotentiometric SurfaceSurface
Pumpage was estimatedat 27,000 acre-ft/yr in
Page 18
at 27,000 acre-ft/yr in1929-30
Zone of depression isabout 150 ft lower thanpre-development groundwater elevation
(modified from Deeds et al., 2003)
1999 Carrizo1999 Carrizo--Wilcox AquiferWilcox AquiferPotentiometricPotentiometric SurfaceSurface
Pumpage was estimatedat 65,000-80,000
Page 19
at 65,000-80,000 acre-ft/yr in 1999
Zones of depression areabout 350 ft lower thanpre-development groundwater elevation
(modified from Deeds et al., 2003)
Page 20
Top Related