Water Treatment Division Demineralisers Medium Flow. Units available Low Salinity Production (m 3...
-
Upload
julie-gillham -
Category
Documents
-
view
217 -
download
2
Transcript of Water Treatment Division Demineralisers Medium Flow. Units available Low Salinity Production (m 3...
Water Treatment Division
Demineralisers Medium Flow. Units available
Low Salinity
Production (m3/day)
4VA0100 2.5
4VA0200 5
4VA0300 10
4VA0400 20
Mod. 4VA0X00: Cancelled• Many membranes replaced in guarantee
period.
• Corrosion problems due to high salinity
• Chlorine remover filter insufficient (chlorine damages the membranes)
• Few pre-treatments available
RO Demineralisers, Medium Flow
Water Treatment Division
Low Salinity
High Salinity
Production (m3/day)
Membranes
4DA1100 4DA2100 4-6 1
4DA1200 4DA2200 8-12 2
4DA1300 4DA2300 14-18 3
4DA1400 4DA2400 20-22 4
Mod. 4DAXX00: Available• Equipments to process water from wells and brackish water,
suitable to treat up to 2.500 mg/l (low salinity) and 9.000 mg/l (high salinity) of TDS, respectively.
• It can be mounted in a small cabinet Mod. 4045500
• Optional production capacity increase with adittional membranes (1-4)
• Options: Chlorine remover filter, silex filter, iron remover filter, organic matter filter. Biocide doser, Bisulfite and water softener for boilers.
Chlorine remover
Filter
Organic Matter Filter
Biocide Doser
Bisulfite Doser
RO Demineralisers Medium
Demineralisers Medium Production Capacity. Units available
Iron remover Filter
Silex-antracite Filter
Water Treatment Division
Models 4DAXX00. Main Features:
Antiscalant doser instead of a water softener with salt.
Antiscalant automatic mixture preparation.
Backwash with demineralised water instead of feeding water. Advantages due to the use of antiscalant:
Ecological: No brine from the water softner regeneration Logistics and easy use: no need to stack salt bags and simplicity Cheaper: antiscalant is cheaper than salt consumption Expansion of the action capacity: wide espectrum
Balance in the ratio production/surface & reject/surface of the membrane compared with the old existing equipments.
RO Demineralisers Medium
Water Treatment Division
Models 4DAXX00. Main Features: Quality of components:
• Programmable PLC Siemens S7-200• Centrífugal Pump Grundfos• Metering Pump Prominent• Stainless steel frame quality AISI-304• Piping of High salinity range in stainless steel AISI-316• Toray membranes: TMG10 (Low salinity), TM710 (High salinity)
Production can be upgraded just by adding membranes to the existing equipment (no need to buy a full new system).
Suitable cabinet assembly
Wide range of pre-treatments available:
RO Demineralisers Medium
Water Treatment Division
Just like a car, the models 4DA have two types of alarms to inform us about any possible failure and its seriuosness.
CAR DEMINERALISER
TYPE OF ALARM
EXAMPLE ACTION EXAMPLE ACTION
NOT CRITICAL
Windscreen wiper water
shortage
Amber light: to stop in a few miles
Flow of demineralised
water production, product dosing.
Failure warning, failure record and equipment stop after 10 days.
CRITICALMotor oil
shortage, brake fluid shortage
Red light: immediate
stop
Water shortage, levels, overcurrent.
To stop the equipment
RO Demineralisers Medium
Models 4DAXX00. Example of anomaly
Water Treatment Division
Buzzer included to alert the customer about
the failures.
• The equipment must recognize the adverse conditions to assure a long operational life.
• The demineralisers are equipments overlooked by the customer (is a non productive equipment) and usually there is not a preventive maintenance of these installations.
• The equipment will stop only if there is an imminent risk to its operating life, avoiding irreversible and expensive damages.
• The customer must be informed of any anomaly (critical or not) without decreasing the business.
RO Demineralisers Medium
Models 4DAXX00. Main Features:
Buzzer Light Alert
Water Treatment Division
Height 2.000 mm
Length 1.550 mmWidth 480 mm It is possible to be installed in cabinet Ref.
4033500 (size with cabinet: Height 2.100 mm x Width 1.500 mm x Depth 900 mm
Demineraliser. Size.
RO Demineralisers Medium
Water Treatment Division
Demineraliser. Available Configuration
Assembly in Plant Configuration
RO Demineralisers Medium
Water Treatment Division
Maintenance of Demineralisers 4DAXXXX
1.- Daily maintenance
To check the level of chemical product.
2.- Every week
To check and to take note of pressures and flows.
3.- Every 3 months
To check the condition of the filters (FS1 & FS2), if necessary they should be changed.
4.- Every 6 months
To clean the small tanks of anti-scalant and backwash water.
RO Demineralisers Medium
Water Treatment Division
Water softener 2x100 litresSalt Consumption:
– Daily need of water: 21 m3 at 70 ºHF (39,2ºHD).
– Necessary regeneration of the water softener every 9 m3
– Number of regenerations per day: (21m3/day) / (9m3/ regeneration) = 2.3 regenerations /day
– Consumption of salt per litre of resin in every regeneration: 0,2 kg/Litres of resin
– Consumption of salt in every regeneration: 0,2 kg/Litre of resin x 100 Litres of resin = 20 kg of salt per regeneration
– Salt consumption per day: 2.3 regenerations / day x 20 kg of salt/regeneration = 46 kg/day
– Salt consumption in the same period of time (124 days): 46 kg/day x 124 days = 5. 704 kg = 228 sacks of 25 kg
Antiscalant dosageConsumption of antiscalant product:
– Daily need of water: 21 m3 at 70 ºHF (39,2ºHD).
– “High” dosage of product: 5 mg/L = 5 g/m3 – Daily product consumption: 21m3 x 5 g/m3 =
105 g/day = 0.105 kg/day– 1 carafe 10 L = 13 kg– So 1 carafe of 10 litres of antiscalant will
last: 13 kg / 0.105 kg/day = 124 days
Example of calculation of Antiscalant vs Water Softener
RO Demineralisers Medium
Water Treatment Division
Conclusion: In 124 days of use:
5.704 Kg of salt =
1 bottle of 10 L (13 Kg)
Make yourself your calculations:
Price/kg Salt x 5.700 kg salt = Euros spent on salt versus
PVP 10 L Antiscalant carafe = 189 ,00 Eur
Example of calculation of Antiscalant vs Water Softener
RO Demineralisers Medium
Water Treatment Division
Difference between antiscalant and water softener.
Antiscalant doser system
+Antiscalant drum
Water softener+
Salt
RO Demineralisers Medium
Water Treatment Division
RO Demineralisers Medium
Car Wash Equipment
Equipment performance
5m3/day
4DA1100 – Low salinity
4DA2100 – High salinity
Equipment performance
10m3/day
4DA1200 – Low salinity
4DA2200 – High salinity
Equipment performance
15m3/day
4DA1300 – Low salinity
4DA2300 – High salinity
Equipment performance
20m3/day
4DA1400 – Low salinity
4DA2400 – High salinity
M-7
M-9
+ accumulation
tank
= 5 m3
M-15+ accumulation
tank
= 10 m3
M-18+ accumulation
tank
= 15 m3
4TB0100
4TB0400
+ accumulation
tank
= 15 m3 Range:
Low salinity: 0 ppm– 2.500 ppm
High salinity : 2.500 ppm – 9.000 ppm
All R.O. equipments must be installed with a pretreatment stage according to the intake water quality !