Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information...
Transcript of Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information...
![Page 1: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/1.jpg)
Manufactured By:Arctic Industries, Inc.
9731 N.W. 114 Way, Miami,FL 33178(305) 883-5581- Fax: (305) 883-4651Toll Free: (800) 325-0123http://www.arcticwalkins.com
th
WALK-IN COOLERS & FREEZERS
WARRANTYREGISTRATIONREQUIRED, SEE
PAGE 32.
Walk-In Installation, Operation,Maintenance & Warranty Manual
JOB NAME SERIAL NUMBER
![Page 2: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/2.jpg)
![Page 3: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/3.jpg)
SECTION 1. GENERAL INFORMATION
SECTION 2. INSTALLATION 3
SECTION 3. MAINTENANCE 19
SECTION 4. SERVICE
SECTION 5. ELECTRICAL SCHEMATICS 24
SECTION 6. PARTS POLICY/ MINIMUN ORDERS 30
SECTION 7. SELF CONTAINED REFRIGERATION 31
SECTION 8. WARRANTIES. 32
......................................... 21.1 Introduction............................................................................. 21.2 Inspection............................................................................... 21.3 Handling of Panels.................................................................. 2
............................................................2.1 Installation Procedure.............................................................. 32.2 Floor Panels............................................................................. 52.3 Wall Panels.............................................................................. 52.4 Door Panels............................................................................. 62.5 Ceiling Panels.......................................................................... 72.6 Floorless Walk-Ins................................................................... 82.7 Outdoor Installation................................................................. 102.8 Diamond Tread Plate Installation............................................ 132.9 Completing the Installation..................................................... 14
.........................................................3.1 Cleaning.................................................................................. 193.2 Door Hardware........................................................................ 193.3 Ceiling Strength...................................................................... 19
.................................................................... 204.1 Door Closers........................................................................... 204.2 Door Heater Replacement...................................................... 214.3 Door Sweep Replacement...................................................... 224.4 Magnetic Gasket Replacement............................................... 234.5 Thermostat Adjustments ........................................................ 23
.....................................
........................
.......................
............................................................
TABLE OF CONTENTS
1
INSTALLATION MANUAL
![Page 4: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/4.jpg)
SECTION 1: GENERAL INFORMATION
2
![Page 5: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/5.jpg)
SECTION 2: INSTALLATION
3
FIG 1. FLOOR PLAN
FIG 2. TYPES OF PANELS
![Page 6: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/6.jpg)
FIG 3. SITE LAYOUT
4
![Page 7: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/7.jpg)
5
FIG 4. LOCKING DEVICES
MALE LOCK FEMALE LOCK
![Page 8: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/8.jpg)
FIG 5. INSTALLATION DOOR PROBLEMS
6
![Page 9: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/9.jpg)
7
FIG 6. CEILING SUPPORT
![Page 10: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/10.jpg)
FIG 7. FLOOR SCREED
8
![Page 11: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/11.jpg)
FIG 8. INSULATED SLAB
FIG 9. COMBINATION: COOLER FLOORLESS /FREEZER WITH FLOOR
9
![Page 12: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/12.jpg)
10
![Page 13: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/13.jpg)
FIG 10. TYPICAL MEMBRANE COVER INSTALLATION
11
![Page 14: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/14.jpg)
FIG 11. MEMBRANE ROOF ROLL-OUT AND FASTENER PLACEMENT DRAWING
12
![Page 15: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/15.jpg)
FIG 12. CORRECT ADHESIVE APPLICATION
13
![Page 16: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/16.jpg)
14
![Page 17: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/17.jpg)
15
FIG 13. ELECTRICAL SCHEMATIC FOR ARCTIC DOORS
![Page 18: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/18.jpg)
16
FIG 14. TOP MOUNT STRADDLE UNIT
![Page 19: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/19.jpg)
17
FIG 16. STRADDLE UNIT ON WALL PANEL
FIG 15. SIDE MOUNT STRADDLE UNIT
NOTE : FOR OUTDOOR SELF-CONTAINED UNITS SEE SECTION 7 ON PAGE 31.
![Page 20: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/20.jpg)
18
![Page 21: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/21.jpg)
SECTION 3: MAINTENANCE
19
![Page 22: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/22.jpg)
4.1 DOOR CLOSERS
The door closer has been adjusted at the factory so that the rubber roller just touches and slightly turns as itpasses the tip of the hook when the door is closing (Fig.17). When properly installed, the door is self-closing andshould not be slammed. Slamming the door may cause the door closer to fall out of alignment.
Any readjustment of the door closer can be accomplished by the addition of washers under the top fasteningscrews, in order to lower the hook. Washers installed under the lower screws will raise the hook. (Fig 18)
SECTION 4: SERVICE
20
FIG 18. RE-ADJUSTMENT OF DOOR CLOSER
FIG 17. DOOR CLOSER
![Page 23: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/23.jpg)
FIG 19.1 FIG 19.2
21
![Page 24: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/24.jpg)
FIG 19.3 DOOR SWEEP REPLACEMENT
22
![Page 25: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/25.jpg)
23
4.4 MAGNETIC GASKET REPLACEMENT
4.5 THERMOSTAT ADJUSTMENTS
1. The door gasket snaps into a narrow channel inside the door’s edge and can be removed by pulling itupward starting at the bottom of the door.
2. The new gasket is installed by pushing its dart into the door groove starting at one upper corner. Besure that the gasket is the right size before attempting to install it.
Should temperature requirements change, the thermostat range may be adjusted by means of the screwon the face of the thermostat which is reached through an opening case. Turning clockwise will decreasetemperature, counterclockwise increases it; Some thermostats are provided with an exterioradjusting knob and some may require removal of the case by loosening the screw at the bottom. In allcases, turning the screw or knob in the center of the temperature dial rotates the dial against the pointer. Itshould not be necessary to adjust the differential which should remain at approximately 5 degrees.
Do not set a cooler thermostat below the walk-ins design temperature or product freezing orexcessive evaporator coil icing may result. Always have a competent refrigeration technician make anycritical adjustments made necessary by changing conditions as mentioned in Section 2.9.4.
NOTE:
CAUTION:
FIG 20. MAGNETIC GASKET REPLACEMENT
![Page 26: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/26.jpg)
SECTION 5: ELECTRICAL SCHEMATICS
24
Diagram 1 - Typical Wiring Diagram for Defrost Contractor with Evaporator Holdout with Heater Limit
Diagram 2 -Typical Wiring Diagram for Defrost Contractor with Evaporator Holdour Relay without Heater Limit
![Page 27: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/27.jpg)
25
Diagram 4 - Typical Wiring Diagram for Multiple Evaporators with Heater Limit Defrost and Evaporator
Diagram 3 - Typical Wiring Diagram for Multiple Evaporators Defrost and Evaporator Fan Contractorswith Unit Cooler Holdout Relay.
![Page 28: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/28.jpg)
26
Diagram 5 - Typical Wiring Diagram for Multiple Evaporators with Evaporator Fan Contractors butwithout Heater Limit Defrost
Diagram 6 - Typical Wiring Diagram for Single Evaporator Defrost and Evaporator Fan Contractors
![Page 29: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/29.jpg)
27
Diagram 8 - Typical Wiring Diagram for Multiple Evaporators with Defrost Timer Only
Diagram 7 - Typical Wiring Diagram for Single Evaporator/ Single Phase Defrost and Evaporator Fan Contactors.
![Page 30: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/30.jpg)
28
Diagram 9 - Typical Wiring Diagram for Single with Defrost Timer Only
Diagram 10-Typical wiring Diagram for Single Evaporator with and without Defrost Timer
![Page 31: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/31.jpg)
29
Diagram 11 - Typical Wiring Diagram for Multiple Evaporators with Defrost Switches Connected inSeries and without Holdout Relays/ Heater Limits
![Page 32: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/32.jpg)
6.1 MOST COMMONLY ORDERED REPLACEMENT PARTS
SECTION 6: PARTS POLICY/MINIMUM ORDERS
30
Spring Conversion Kit
![Page 33: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/33.jpg)
SECTION 7:SELF-CONTAINED REFRIGERATION
OUTDOOR SELF CONTAINED REFRIGERATION UNITS
1. Curb material shall be fastened securely to the box ceiling by bolting through with carriage bolts(provided).
2. The membrane roof cover shall be fastened to the box covering the curb. After the roof cover is inplace, open a hole on the roof cover where the evaporator is going to be (25' x 38' size) over lappingthe membrane by an inch, secure it to the curb.
3. Secure the unit to the roof curb. Seal screw heads as necessary to prevent moisture from enteringbeneath membrane.
31
FIG.21:OUTDOOR SELF-CONTAINED UNIT INSTALLATION
![Page 34: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/34.jpg)
SECTION 7: WARRANTY REPLACEMENT
32
![Page 35: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/35.jpg)
33
![Page 36: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/36.jpg)
34
![Page 37: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/37.jpg)
![Page 38: Walk-In Installation, Operation, Maintenance & Warranty Manual · section 1. general information section 2. installation 3 section 3. maintenance 19 section 4. service section 5.](https://reader034.fdocuments.in/reader034/viewer/2022050715/5e0dc1e9a213c133bf2bfe94/html5/thumbnails/38.jpg)
WALK-IN COOLERS & FREEZERS
Manufactured By:Arctic Industries, Inc.
9731 N.W. 114 Way, Miami, FL 33178(305) 883-5581 • Fax: (305) 883-4651
Toll Free: (800) 325-0123http://www.arcticwalkins.com
th
©ARCTIC INDUSTRIES, INC. -ALL RIGHTS RESERVED V.1401