VOLKSWAGEN

MOOEL IDENTIFICATIONBefore making an estimate or ·using any prices listed, it is recommended that the vehicle firstbe identified by the chassis number. Then, referring to the chart listed below, find the modeland chassis number.

CHASSIS NUMBER LOCATIONBEETLE. SUPER BEETLE & THING -

On identification plate and on frame tunnel under rear seat.GHIA-

On fr.me tunnel under the emergency seat.FASTBACK-SQUAR E BACK-

On tr.me tunnel under the rear seat.411 (TYPE 4)-

On identification plate under rear seat betwellfl inner seat belt mountings.TRUCK & BUS-

On engine cover plate under tlhe .ir cleaner.DASHER -

In engine compartment on front partition above windshield wllSher container.RABBIT & SCIROCCO -

On the suspension strut mounting .t right front wheelhouse.

VANAGON -On plate under vehicle on right side of front crossmember.

JETTA & QUANTUMIn engine compartment on cowl top panel.

ENGINE NUMBER LOCATIONSBEETLE·SUPER BEETLE-GHIA -

On crankcase .t the generator support fl•••.FASTBACK-SQUARE BACK·

On the cr.nkcase beside the joint nur the oil cooler.411 (TYPE 4) -

On right h.nd cr.nkcase h.1f below the breather support.TRUCK & BUS-

On the crankcase fl.nge under the generator support.THING -

On cr.nkcase at genetator support flange.OASHER-RABBIT-SCIROCCO -

On left hand side of engine block .bove fuel pump;VANAGON -

On right hand crankcase behind fan housing.

JETTA -On engine block, under glow plug cylinder 3.

STARTING CHASSIS NUMBERS

BEETLE (TYPE 1).1968 1180000011969 1190000011970 11020000011971 11120000011972 11220000011973 11320000011974 11420000011975 11520000011976 11620000011977 11720000011978 1182000001

SUPER BEETLE (TYPE 1)1971 11120000011972 11220000011973 13320000011974 13420000011975 13520000011976 15620000011977 15720000011978 15820000011979 1592000001

GHIA (TYPE 111968 1480000011969 1490000011970 14020000011971 14120000011972 14220000011973 14320000011974 1442000001

THING19711972197319741975

TRUCK & BUS (TYPE 2)1968 2180000011969 2190000011970 21020000011971 21120000011972 21220000011973 21320000011974 21420000011975 21520000011976 21620000011977 21720000011978 21820000011979 2192000001

FASTBACK·SQUAR EBACK(TYPE 3)

1968 3180000011969 3190000011970 31020000011971 31120000011972 31220000011973 3132000001

411 III 412 (TYPE 411969 4190000011970 41020000011971 41120000011972 41220000011973 41320000011974 4142000001

DASHER19741975197619771978197919801981

18120000011822000001183200000118420000011852000001

32420119473252000001326200000132720000013282000001329200000132A0000001328900001

RABB(T1975197619n19781979197919801980198119811982198219831983PICK-UP1980198119821983SCIROCCO1975197619n197819791980198119821983JETTA1980198119821983VANAGON1980198119821983QUANTUM19821983

17530258681763000001ln300000117830000011793000001 (Imported)1793750050 (Domestic)15A0800001 (Imported)17A0750001 (Domestic)158000001 (Imported)17B000001 (Domestic)15COOOOOl (Imported)17COOO001 (Domestic)150000001 (Imported)170000001 (Domestic)

1.7A070500117800000117C000001170000001

5352000001536200000153720000015382000001539200000153A000000153BOOOOOl53C000001530000001

16A000000116BOOOOOl16C000001160000001

24A00000124800000124C000001240000001

32COOOOOl320000001

F21

VOLKSWAGEN

BODY TYPE NUMBER LOCATIONBEETLE & SUPER BEETlE-

On a plate on reinforcement panel in front luggagecompartment (behind spare wheel or on front crosspanel for model "1301" & "1303"

411 (TYPE 4) -Under front panel beside the hood lock.

GHIA·FASTBACK·NOTCHBACK·SaUAREBACK -On identification plate in front luggage compartmentbesides spare wheel.

TRtlCK & BUS -On identification plate on partition behind passenger seat.

THING -On identification plate under front panel beside hood lock.

DASHER -On right hand wheelhouse in the engine compartment.

RABBIT - SCIROCCO - JETTA-On the front lock carrier to right of hood lock.

VANAGON -On identification plate on right hand hinge pillar.

BEETLE

BODY TYPES11'1113115117151

Standard SedanDeluxe SedanStandardSedan, w/sliding RoofDeluxe Sedan, w/sliding RoofConvertible

SUPER BEETLEToJuly,1972 (1302)-

113 Deluxe Sedan117 Deluxe Sedan, w/sliding Roof151 Convertible

From August 1972 (1303) -133 Deluxe Sedan133 Deluxe Sedan, w/sliding Roof153 Convertible

GHIA

TRUCK & BUS

FASTBACK

saUAREBACK

411 & 412

DASHER

THING

RABBIT

SCIROCCO

VANAGON

JETTA

211215221225231235241251261265281285

311313

365367

421461

321323331

181

171173175177155179

531

255

161163

141143

ConvertibleCoupe

DELIVERY VAN, Sliding Door Right-Sliding Door Right & left

MICRO-BUSMICRO-BUS, w/sliding RoofKOMBIKOMBI, w/sliding RoofMICRO-BUS "l"MICRO-BUS "l" 7 seaterPick-Up, Single Cab

-Double CabMICRO-BUS, 7 Seater

-7 Seater, w/sliding Roof

SedanSedan, w/sliding Roof

VariantVariant, w/sliding Roof

4-000r Sedan "(,,2-000r Station Wagon "L" (Variant)

2-000r Sedan4-000r SedanStation Wagon

4-000r

2-Door Sedan (Imported Version)4-000r Sedan (Imported Version)2-Door Sedan (Domestic Version)4-Door Sedan (Domestic Version)2-Door ConvertiblePick·Up

Coupe

Micro-Bus

2-000r Sedan4- Door Sedan

QUANTUM 321327331

2-000r4-000r4-000r, Square Back

F22

1979-68 VWBUS& TRUCKInformation in the "GUiDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.

9--------I 10 8! '

FRONT BUMPER·1968·72Assembly R&I . .. .. . . . .. . . . . . .. . . 0.5Overhaul

w/o guards .w/guards .

Face bar1 center (pA) 104.05 0.82 side (pA) AT 65.60 0.2

(p.4) LT 65.60 0.23 step pad AT 13.30 0.2

LT 13.30 0.24 joint cover (rubber) .. . 0.00

Guard & cushion.. .. .. .. .. .. .. 08.40 0.2cushion D1.85

STrim mldg 68·69 AT 041.7068·69 LT D41.7070·72 AT D54.0070·72 LT 058.00

rubber insert 68·70 D14.0071·72 014.00

7 Mounting bracket AT 16.75LT 16.75

FRONT BUMPER, 197:J.79Assembly R&I .. .. .. . . . .. . .. .. .. . 0.5Overhaul.. . . .. .. .. .. .. .. . .. .. . . . 1.5

8 Face bar, prime...... 164.95# 1.5chrome 461.50 # 1.5

9 Rubbei cush &end caps . .. .. 71.9510 end caps .. .. .. .. .. .. 8.8511 Deformation element............ 186.45 3.0# Time is for overhaul

1.11.3

2117071118211707114211707113211707292211707291211707197

ZVW151812ZVW1518222417072128241707211D241707212C241707211E241707221C241707221C211707136M211707135E

1968-711 Front crossmember 59.60 # 2.52 cover plate 33.403 Sidemember, outer 68·89 AT D15O.oof; 10.0

68-69 LT D15O.00# 10.070·71 AT 249.15 #10.070·71 LT 249.15#10.0

inner AT DI32.00 § 6.0LT 0132.00 § 6.0

5 Rear, assembly D471.106 sidemember, outer RT 0 88.00 # 8.0

LT D86.00 # 8.07 bracket Dl1.008 inner D48.00§ 4.09 Outrigger, front AT' 65.45

LT 65.4510 center.. .. .. .. .. .. .. .. . 65.4511 rear................... 9.20

211707111J 12 Cover plate, front........ .. .. 51.90 0.522170711113 side, under floor AT 58.55

241iOi221E LT 58.55241707219 1972·79211707271 1 Front erossmember .... 72 59.60 # 2.5

73·79 96.95 # 3.52 cover plate.. .. .. .. 72 .. .. 33.403 Sidemember,outer 72·73 RT 249.15#10.0

72·73 LT 249.15 # 10.074·79 AT 249.15 # 10.574·79 LT 249.15#10.5

inner ..... 72 AT 0132.00§ 6.072 LT D132.00§ 6.073·79 RT 188.90§ 6.073·79 LT 188.90§ 6.0

5 Rear assy 72 D471.1073·76 0584.00

4

use seperate parts6 sidemember, outer RT

LTinner RT

LT

129.35# 8.0129.35# 8.068.6579.3067.45t 3.0

Front panel1 wo/air duct... (p3.7) 68·72 491.90# 19.52 (p3.7) 73·79 491.90 # 19.5

w/air duct..... (p3.7)......... 726.00 # 19.53 reinf, Iwrto floor 68·72 038.004 73·79 50.355 extension .. .. .. .. ... 73·79 RT 5.505 73·79 LT 5.50

cover plate.. .. .. .... 68·72 .... 33.40 0.5lower plate.. .. .. .. .. .. .. .. .. .. 71.50

hinge pillar .... (p1.0) 68-72'.. .. 0142.00 § 9.0(p1.0) 73-79 .... 224.35§ 9.0

conn piece, upper ..•.......... 8.20lower .... 72 10.15

73·79 10.158 Emblem, VW, painted .. 68·72 37.75 0,2

73·79 9.55 0.2chrome ... 68-72 031.00 0.2

73-79 35.10 0.2Air intake grille 68·72 55.25

73-79 38.559 trtm frame .. "................. 61.90 0.5

screen 68·79 27.50Windshield

glass, VW, Clear .... ".......... 169.85t 1.6Sunshade ... " .. ... 426.30 t 1.6

NAGS, clear.. .. .. .. .. .. . 220.25t 1.6Sunshade.. .. .. 264.15 t 1.6

rubber chnl 68,]1 57.0072·79 58.00

moulding, reveal................ 10.05joint.................. 1.00

Mirror, inside .. 68·69 61.85 0.270·71 60.30 0.272·79 60.30 0.2

Wiper arm.. .. .. .. .. ... 68 .. .. 10.95 0.169·72 15.00 0.173·79 17.70 0.1

blade 68 .. .. 13.80 0.169·72 10.15 0.173·79 5.20 0.1

motor.. .. . .. .. .. .. ... 68·72 189.75 1.073·79 t72.40 1.0

211703110D washer reservoir................ 27.60 0.42117031090 pump.................. 33.002t1703460E INSTRUMENT PANEL2t1703459E2117034918 10 Instrument panel2117036558 padded211703t15 to 2142164060 ...........•..... 320.85* 3.3 211605045F

211703120A fm 2146164060 320.85* 3.3 2118050458041211703119A unpadded211703t63 102142164060 0135.00i 2.1

2117036tlH fm2142164060 .......•........ 146.70* 2.1215703706G padded strip................... 120.20 1.1215703705(3 grab handle.. .. .. .. .. .. .. . .. .. . 12.00 0,3

11 plate, top cover.. .. .. .. .. . .. .... 108.95* 1.6Glove box door.. .. .. .. .. .. .. . .. . 63.85

FRONT PANEL & W'SHIELO

211805035H211805035J

211805031AJ2118053310211805331F211805268211805267211805257211805269

21180920tF211809201E211809269

2118092498211809249C211853601C211853601E2418536018241853601E211259161

211259163A241853215

21t259165A .

211645101K221645101FCW201CFCW201S

24184512182116451210255853345A315853309

211857501A211857501KOOV

211857501J211955407C211955409A21195540981479554258161955425

176955425A211955113H21195511302119554538823955651

261805051G211805051AP

21185720580412118576438041

211805155D221857121A041

F412

8

crossmember, rear .gusset plate .

9 Outrigger, front .10 center RT

LT11 rear.... .. .12 Cover plate, fronl. .13 side, under floor. .. .. .. .. RT

LT# After necessary dismantling.§ Afteroulerrail is removed.t After aI/ bolted-on parts are removed.

65.4565.4565.459.20

51.90 0.558.5558.55

211703071G211805257

21170302282117030218211703022D2117030210211703304A211703303A211703051C211703110A211703109A211703591211703459211703116211703115

211703119A211703163

211703611H215703706G215703705G

211703071G2117035610211805257

2t1703022D2117030210211703022E211703021E211703304A2t1703303A211703304C211703303C211703051C211703051E

CONTINUED

The times listed are based on new, undamaged O.E.M.parts installed on new undamaged vehiclesas an individual operation. Add for alignment pulls and refinishing as required.

I1979-68 VWBUS& TRUCK

Information In the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate. I

HEAOLAMP

FRONT STRUCTURAL COMPONENTS,GLASS & LAMPS (CONT)

Aim headlamps ... .............. 0.2Assy, woldoor & seal beam

68·73 RT 049.55 0.4 21194104268·73 LT 049.55 0.4 211941041

order component partsMtg ring & hsg . . ...... RT 38.10 321941045

LT 50.55 111941045Door, chrome ............... RT 22.50 0.1 211941176C

LT 24.55 0.1 211941175Csilver ..........•....... RT 22.50 0.1 211941176C

LT 24.55 0.1 211941175CSeal beam ....................... 12.30 0.2 N0176152retaining ringchrome ........................ 21.50 321941049silverto 2172100001 ................ 14.30 111941049fm 2172100001 ............... 14.15 111941049A

PARKING LAMPBody .................. 68 AT 012.00 0.2 211953052E

68 LT 012.00 0.2 211953051E69·72 RT 21.80 0.2 211953052K69·72 LT 21.80 0.2 211953051K73·79 .... 58.75 0.2 2119531830

Lens .................. 68·71 RT 37.75 0.1 211953142J68·71 LT 37.75 0.1 211953141J72 RT 31.65 0.1 211953142P72 LT 31.65 0.1 211953141P73·79 .... 15.85 0.1 211953141T

gasket. .....•••...... 68·72 .... 4.85 211953165C73·79 .... 3.40 211953165D

Bulb .. , ............... 68·72 .... 1.10 N017738273·77 .... 1.35 N0177322

# Cut in w'shld opng or below opening t5.5. Refinish 3.0.§ After front panel is removed 4.0.t With reveal mldgs, add.2.* With air cond add .8.

AIR CONQITI.O~~R ~ HEATERWith any operation requiring a coolant line disconnect, add .9 torecharge system & add for freon.

AiR CONO-1968-69Condenser, early 68·69 069.30 0.7

late 69 0126.45 0.7hsg. upr, early 68-69 016.15

late 69 .. .. 0.00Iwr, early 68·69 D29.35

late 69 . . . . 0.00scoop 042.60

motor, early 68·69 40.80 0.3late 69 014.70 0.3

mount, ear~ 68·69 D 1.95lale 69 . . .. 02.00

fan, early 68·69 D2.55 0.3late 69 .. . . D .00 0.3

screen, early 68·69 D2.05late 69 . . . . D .00

Receiver & dehydrator 011.70 0.4Compressor Dl00.55 0.8

clutch & pulley 68 063.00 0.469 Dl10.00 0.4

pulley only D21.20coil D22.25mounting brkt. 68 D 13.30

69 D13.25brace, side.. .... .. .. 68 07.50

69 D8.00front. 69 D4.15

Pulley, driving " 010.60 0.5idler 68 D 12.90 0.3bracket 09.30support D6.85

Belt.. .. . .. .. .. .. . .. •. . .. .. . . .. .. 17.40 0.3Hosecomp to cond D45.00comp to evap 046.00cond to dehyd 68 . " D 12.00

69 D .00dehyd to evap 68 015.00

ZWl217310ZWl217312ZWl217307ZWl217317ZVW217305ZWl217318ZVW217308ZWl225318ZWl217324ZWl217320ZWl217313ZWl217322ZWl217309ZWl217323ZWl217316ZWl217433ZWl217102ZWl215130ZWl217130ZWl217132ZVW215131ZWl217202ZWl217212ZWl217207ZWl215201ZWl215202ZWl215229ZWl215235ZWl217208ZWl217209ZWl217221

ZWl217402ZWl217412ZWl217404ZWl217405ZWl217408

69 D28.00tube 68 Dl.40

Evaporator core D 75.40 0.8motor D 15.65 1.1fan, wheel D 3.75

Valveexpansion 29.75 0.5camp, high press.. .. .. .. .. .. . .. . 9.55

low press. . . . . .. .. . . . .. . . . 10.60AIRCONO-197o-?3 TOSER

NUMBER 22-301707Condenser 0147.80 0.1

hsg, upper D49.70motor .. . .. .. . . . .. .. .. .. •• •. .. . 53.85 0.3

mount .............•.... 01.50fan blade .. . .. .. .. .. .. .. . .. . . .. 8.70 0.3screen, front .........•......... D 37.90

rear ............•....... D 13.60Receiver·dehyd 31.10 0.4

31.10 0.4Compressor. .. .. . . .. . .. . . . . . .. .. 303.45 0.8

clutch & pulley D63.00 0.4pulley only . .. . .. .. .. .. .. .. . . .. . 88.80coil D22.25mounting brkt... 70 D 13.25

71 D 16.8072·73 D 45.00

brkt, side 70 .. .. 08.0071 D 10.0572-73 014.15

front 70 D4.1571 9.75

Pulley, driving 70·71 D 11.85 0.572·73 21.40 0.5

belt 70 D 16.10 0.371 20.10 0.372·73 18.55 0.3

Hose, comp to cond .... 70 036.0071 D 28.0072-73 D30.00

comp to evap 70 067.0071 D50.0072-73 D55.00

-cond to dehyd 71·72 D .0072·73 0.00

dehyd to evap D27.00Evaporator core 70·71 D126.45 0.8

motor D35.70 1.1fan. wheel ..................•.. D25.60

Valve, expansion . . . . . . . 34.25 0.5comp, high pressure 9.55

low pressure.... 10.60AIR COND-1973·79, FROM SERIAL

NUMBER22-301707SEE PREVIOUS SECTION EXC

Condenser, front. . . .. .. .. . .. .. .. 52.6076·79 106.80

rear 68.1076-79 115.35

housing, upper, rear D22.50motor. each.. .. .. .. . .. .. .. .. .. . 53:85

mount .. .. .. .. .. . .. . 8.80fan blade, each. . . .. . . . . . . .. . . . . 8.70screen, front D 28.60

rear D40.10Receiver & dehydrator........... 31.10 0.4

HEATER44-47-508.H.P.

Heat exchanger................. 130.00 1.5hose, to fan housing 6.00

warm air, front. .. .. .. .. .. .. 39.00Pipes, rear section

fork piece 68·72 24.5573·79 57.00

rear of fork 68·71 AT D 19.5568·71 LT D19.55

front of fork 68-72 17.3073·79 56.20

Pipes, front sectionwarm air cond 68 . D 2.20

69·72 20.75

ZWl217403 73·74 .... 6.70 2112554778ZWl217406 vent, upper .....•..... 68 D3.45 211255475ZWl217006 69·72 RT 10.75 211255476AZWl217020 69·72 LT D9.65 211255475AZWl217018 73·74 .... 10.20 2112554758

distributor ...................... 61.65 221255881DZWl231057 elbow ............... 68·75 .... 21.25 2112558058059260865 76 13.75 211255805C059260855 front .......................... 25.15 2112558158

center ......................... 39.60 2112558258rear .............. '" 68-72 .... D21.00 221255795

ZWl227310 73·79 .... 29.20 211255795ZWl227304 62-66-688.H.P.ZWl227318 SEE PREVIOUS SECTION EXCZWl227320 Heat exchangerZWl216312 62 & 66 BHP . . . . .. . . .. . . . ... 260.20 1.5 021256091MZWl227325 68 bhp ..................... 260.20 1.5 021256091JZVW227329 conn pipe, hot air ........... RT 20.15 021256332A

LT 19.35 021256331Aelbow ..................... AT 24.95 0.6 0212560528

059260805 LT 24.95 0.6 0212560518ZWl215130 heat control box ............ AT 55.05 0.6 021256206KZWl218132 LT 55.05 0.6 021256205KZWl215131 warm air hose ......•.•..•...... 39.00 211255387ZWl217212 bracket, rear ............... AT 8.90 021256304AZWl232200 LT 1.60 0212563038ZWl234239 70BHPZWl215201 Models wol catalystZWl232212ZWl402225 heat exchanger ....... 68·74 .... 260.20 021256091MZWl215202 75 .... 260.20 021256091TZWl424213 control box ................ AT 55.05 021256206KZWl225202 LT 55.05 021256205K255272807 elbow, front .................... 39.60 021256051C

ZWl227221 conn pipe to fan ...... 68·74 .... 20.15 021256332AZWl232221 75·77 .... 20.15 0212583328

flex hose ...................... 39.00 211255387ZWl219222 Models wlcalalystZVW227402 heat exchanger. .. .. .. .. .. . .. .... 260.20 021256091TZWl232402ZWl219400 pipe, exhaust. . . . . . . . . . . . . . • . . .. 220.55 021251551ZWl227412 afterburner. . . . . . . . •• . •. . .. 197.00 021251201

control box .................... 55.05 021256205KZWl232412 elbow, front ..........•......... 39.60 021256051CZWl219415 conn pipe 10 fan .....•.......... 20.15 0212583328ZWl227411ZWl252406 flex hose ...................... 39.00 211255387ZWl227408ZWl227010ZWl227020ZWl227018803260109059260865059260855

ZWl432336

ZWl432310ZWl402302ZWl227318ZWl402324ZWl218312ZWl402332ZWl402311

043255106F028129087A211255387

211255755C211255755F211255766F211255765F211255785A211255785F

211255477211255477A

I F413 IThe times listed are based on new, undamaged O.E.M.parts Installed on new undamaged vehiclesas an individual operation. Add for alignment pulls and refinishing as required.

1979-68 VWBUS& TRUCK

CAB ASSEMBLY

Information in the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.

~~

VANRails

1 front, above w'shld.. . . . .. .. .. . .. 29.15 # 1.82 side, above door RT 65.80# 2.0

LT 65.80 # 2.03 Rocker panel... (p1.0) 66·71 RT 184.50§ 5.0

(p1.0) 66·71 LT 164.50§ 5.0(p1.0) 72 RT 221.05§ 5.0(p1.0) 72 LT 221.05§ 5.0(p1.0) 73·79 RT 221.05§ 5.0(p1.0) 73·79 LT 221.05§ 5.0

4Lockpillar RT 164.60t 5.5LT 164.60t 5.5

5 Wheelhouse 68·71 RT D45.00* 3.568·71 LT D32.75* 3.572-79 RT 80.70* 3.572·79 LT 80.70* 3.5

PICK-Up, SEE VAN, EXCRails, side above door

6 single cab ATLT

double cab, front .. .. .. .. ... ATLT

rear .

59.55# 2.059.55# 2.065.80 # 2.065.80# 2.028.35

Lock pillar7 single cab.. ... (p1.0) RT 172.80t 5.0

(p1.0) LT 172.80t 5.08 . double cab.... (p1.0) AT 172.80t 5.0

(p1.0) LT 164.60t 5.09 Corner pnl, otr.. (p2.8) RT 324.05 11.0

10 (p1.5) LT 381.40 14.011 inr RT 20.0512 LT 68.0513Sill, below pnl 25.85

Back panel4 upper......... (p1.0) 122805 center 68-71 D74.00

72-79 037.506 lower 0121.157 x-mbr btwn upr & ctr 25.65

glass, wio healed 046.00 1.2wlheated 217.25 1.2

weatherstrip "'"'''''''''''' 34.30II After roof panel is removed.§ Withhinge or lock pillar removed 3.5.t After side panel/s removed 2.5.* After outer panel/s removed.

1meng 81037106 .pulley ,toeng81037106 "".""."".1meng 81037106 .

belt .support ...............•.........

Voltage regulatorto eng 81037106 24.95 0.41meng 81037106................ 27.05 0.4

ALTERNATOR & REGULATORAlternator assy'

2t1831056 55 1 02118317210 amp.. .70 amp........... 1.0

2418535118 pulley,55ampalt 23.20 0.370 amp alt . .. .. . .. .. .. . .. 45.20 0.3

241853515 belt......... 5.70 0.32m~;~~~Voltage regulator.... . .. .. 41.90 0.4211857513H DISTRIBUTOR s IGNITION261851513A Dist assy, 4447 BHP........ .. 225.80 0.42116452018 50 BHP D208.00 0.4221845201A 62 BHP ..•.. 283.65 0.4211837571A 66 BHP 313.60 0.4211637501 68, 10 8HP .. .. .. .. .. 261.95 0.4241637403 cap, exe .. . .. .. .. .. .. .. .. .. .. .. 7.15

4447 8HP 5.15211837601A Ignition coil221837601A wlo emission control.. . ......•.. . 23.10 1.4211845251D wlemission control...... ....•... 23.10 1.4221845251 switch only

21183720SJ 102142164060 .211837205N 1m2142164060 .211837015E cylinder & key 68·70 .211837015G 71-79 .211837015H HORN211837295D Horn............................ 10.55 0.3 1119511138211837217F211837217HI--,-_W..:,:. ..:..H::..::.E=E=L=S...::&=-F:....:R:..:.O.::..:...:N..:..T-=S:.:::U:.:::S=-P-=E::..::N:.:::S..:.::'O~~:,:,:;"'-',"-.

2tl83t40SA2116314058281831405

211837249A

211945119A2119451198211945161

2618455010261845495C261845521A

FRONTDQORSINGLE CAB

Assembly R & I . .. . .. .. .. 0.8Door w/hinges. (p2.5)......... 469.35 # 3.0W'strip around door ... . . . . . . . . . . 63.45 0.3Mouldingside front (d.2) 05.00 0.2

rear (d.1) 010.00 0.1window reveal 68·73 61.60

74·77 61.60Mirror, outside, std 20.85 0.2

pick·up, long top. . . . . . . . . . . . . . 0.3Glass, clear .. .. .. .. .. .. .. .. .. .. . 60.55 1.2

tinted 68·79 100.80 1.2sash channel.. .. . .. .. .. . .. . . .. . 5.15regulator........ 45.15 0.7

Ventframe & w'strip . .. . 116.00glass w/channel & handleclear 112.15tinted 150.70glass only, clear.. .. .. .. .. .. .. .. 32.60 0.8

tinted.. .. . .. .. .. .. .. . 46.05 0.8Handle w/cyl & keys ... 68 76.95 0.5

69·77 69.25 0.5Lock.. 68 D27.00 1.4

69·73 36.30 1.474-77 36.30 1.4

striker......................... 9.10 0.3cylinder & keys . . . . . .. 68 26.80 0.6

69·77 .... 25.55 0.6

15.65 0.338.75 0.32.85 0.3

115.45

211805283A211817518D211817517021180950282118095018211809502C211809501C211809502D2118095010241809252241809251

211801326L211801325L21t801326P211801325P

2618175188.2618175178211817518D211817517D2658175360

21.3514.7013.9030.40 0.5

255841082K265841818A265841819A

2658453018265845315A265645321224847632

2218452918221845291A265847673A

265641606265841606A2118372968265841387

19.0021.2525.45 0.523.25 0.5

Hinge, cab halfto 2152153713 .fm 2152153713 ........•.....1m2162126632 .

Check strap .Reflector

to 2162090464 .. .. .. .. .. 10.90 0.1fm 2162090464 10.90 0.1

seal........................... 7.75DOUBLECAB

Rear doorwI hinge (p2.5)......... 385.55 # 2.2

W'strip around door....... .. .... 45.15 0.7lower, on body.. .. .. .. .. .. 23.40 0.7

Stationary glassrear 68·71 24.75 0.8

72·79 49.05 0.8w'strip D15.00

Vent assembly 87.55 1.2glass only, clear.. .. .. .. .. .. .. .. 17.45 0.3

tinted.. .. .. .. .. .. • .. . 25.55 0.3weatherstrip 45.85

Handle, see cab doorLock 68 D20.60 0.4

69·79 41.10 0.4striker...................... 9.10

Check strap.. .. .. .. .. .. .. .. .. .. . 7.60 0.2Front, reflector Wheel alignment 1.0

261809252G 68, see side assy Toe·in, adjust. . .. . . . . . .. . . . 0.5261809251FII pa;;;t;;~ 1:~~,inner & outer. Suspension, overhaul. .. .. .. . . 7.0265809252' WHEELS265809251 SI;AT TRACKS Wheel (p.5) 68·70 100.65# 0.3

26580907481-'-------=--"---'--'--"'------1 (p.5) 71·79 65.80# 0.3265809073C Seattrack Hub cap 68·70 21.65265809944 outer 68·76 D 17.00 2118013438 71.79 13.90

265809405A 77 10.00 211B01345E chrome 68·70 34.70265809585C inner ~~'76 ~~.~~ m~~\~!~~T' 71·79 29.20

26180542101------E-L-e-C-T-R- .. -·;C-A-·L------1 B~:n~~~f;~~i'~i;~~I"""""'" . 024.002618054318 1 bearing, outer.................. 9.50 § 0.6261805431C GENERA TOR& REGULA TOR 2 inner.. 14.8O§ 0.6261801OB1H Generator assembly261805441C to eng 91037106 1.0 113903031PV CONTINUED

1.0 2119030310V

043903109211903109

111903137D113101211G

113903803E211903803E

021903023FV021903023EV022903109A022903109

021903137A043903803B

111905205AA211905205Q021905205Q021905205E0219052058113905207C111905207C

043905115C043905115C

111905865F111905865L211905853A211905855C

1 2 8 9-1~ ~\ 3 -4 ~ 18 19 ~

6 5;~ ". ~~~~__ ~_~~~e ••.• _~~~

\~~11 • "1r\: '.'17 16

The times listed are based on new, undamaged O.E.M. parts installed on new undamaged vehiclesas an individual operation. Add for alignment pulls and refinishing as required.

211601027F211601027H111601151251601151113601151

251601151A2416011558

211405645D211405625

F414

1979-68 VWBUS& TRUCKInformation in the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.

WAGON& VANHeadlining R & I .Roof panel

1 solid roof..... (p5.0) 557.00#21.02 slidingroof.. .. (p4.7)......... 678.00 28.5

enlarged (plastic) 2264.003 Frame, sliding roof 770.00 § 6.0

rail above slide door4 guide. .. .. .. 41.35§ 1.85 channel.. .. .. .. .. .. .. . .. .. . .. . 7.206 above body side R&L 35.95§ 3.57 rear.. . .. .. .. .. .. .. .. .. .. .. .. .. 44.50§ 2.3

211415205F 8 cover plate 68·70 017.5070·77 28.60

SLIDING ROOF SECTION (FIG K)211415049H 9 Sliding panel 464.30 0.7

10 Weatherstrip. . .. . . . . .. . . . . 72.35 0.5211415131811 Frame.......................... 92.10

12Lining 67.50 0.813 Guide rail, side R&L 91.50

211415501A Cable channel211415501C14 upper center.. .. .. .. .. .. 3.0021141541715 side ..............•........ RT 3.7521141540916 LT 6.7021141556117 lower RT 54.30

211415561A18 LT 41.55211415561C19 Rain gutter...................... 18.6021141545120 Gasket, front.................... 12.00

211415601F21 Guide, w/cable RT 51.80211415621 LT 48.60

211415651022 housing, front.................. 13.40 0.6211415651G04323 cover................. 4.75

24 GUide, front .........•....... R&L 3.9025 rear................. 4.4526 Winding gear.. .. .. .. .. .. . .. .. .. . 32.55 0.427 Handle.. . .. .. .. .. .. .. .. .. .... .... 7.40 0.2

PICK·UP28 Roof panel

wlo double cab. (p2.8) 416.25 13.0wldouble cab.. (p3.3)......... 693.00 16.0

29 Rail, above back panel. . . . . . . . . . . 27.80 § 2.0# Station wagon 27.5§ Afterroof panel is removed.

WHEELS & FRONT SUSPENSION 1 Tierodassy RT 44.50 0.4(CONT) 2 LT 44.50 0.4

------~~:.:..:..:....L----2-11-40-564-1-01 3 end........................... 21.05 0.33 oil seal. .. 8.30 4 Intermediate arm.... . .. 112.85 1.0

spacer 5 shaft package.. .. .. . .. .. .. .. .. . 55.254 wlo disc brake........... 06.30 211405631A6 Damper......................... 17.90 0.55 wI disc brake............. 18.40 2114056318 7 Drag link........................ 57.55 0.96 greaseeap 3.80 2114056918 8 Pitman arm 68·72 107.85 0.5

FRONTSUSPENSION 73·77 78.90 0.5DRUM BRAKE 9 shaft & eam 68·69 0139.00

7 Hub & drum 0213.00 0.8 211405615C 70·72 185.55Brakesupportplate 161.60 1.3 211609139C use gear assembly 73·79

hose.......................... 37.10 0.8 21161170310 worm 68·72 265.958 Steering knuckle & arm 0177.00 1.4 211405311C use gear assembly 73·799 ball·joint,48.3mm 36.60 0.8 211405371A11 Gearassembly 68·72 588.00# 1.7

48.6 mm 88.75 0.8 211405373 73·79 588.00# 1.710 Torsion bar (spring) 273.10 2.7 211411033E12 housing,useassy............... § 3.5

arm & ball·joint 13 end cover 68·72 032.0011 upper RT 279.25 0.8 211405102A STEERINGCOLUM& WHEEL

. LT 279.25 0.8 211405101814 Main shaft12 lower RT 332.20 0.8 211405152 to 2142164060 6874 12635 07LT 260.45 0.8 21140511E . . .13A I b 6869 78600. 25 211401061K fm2142164060 72·74 120.55 0.7x e eam............. . . +. 211401061N15 coupling disc................... 11.65

70·79 786.00* 2.5 211413031F16 flange,. lower 53.2014Shock,standard 68·69 48.40 0.4 211413031P17 Column Jacket 68·69 038.00 1.3

70·79.... 55.40 0.4 211413031G 70·71 042.75 1.3heavy duty 68·69 84.10 0.4 211413031R 102142164060 72.74 57.65 1.3

d· t bl ~g~ 1~!'~~ ~.: 211413035 fm 2142164060 74·79 54.05a JUsa e............ . . 211411309A18 brkt, at inst panel 015.00

15 Stabilizer bar........ .. .. .. 94.40 0.6 19 cap, lower.... .. . 6.90FRONTSUSPEN5/0N 20 Wheel, to 2142164060 .....•...... 153.25 0.4

C!rrD.fJ~'MC '!,R}.fJ'E, sxc fm 2142164060 160.30 0.4"";c run pm"" CA' . # With air cond, add.7.

16 Hub 121.70 0.8 211405579§ Time is faroverhaul. Withalrcand,add:7.17Brakedisc 68·72 147.80 0.4 211615301A... ",.' '-015."'" '. c· .,

73·79 115.90 0.4 2116153018.' .... :l.:- RQ q. ::~."caliper, wo/pads 71·72 RT 215.30 0.8 211615108

71·72 LT 215.30 0.8 21161510773·79 149.20 0.8 2116151078

Girling 149.20 0.8 211615107818 splash shield RT 20.30 21140559318 LT 20.30 211405593

hose.......................... 28.90 0.8 281611775819 Sirg knuckle & arm ..... 68·72 RT 332.00 1.4 211405312E

68·72 LT 0281.70 1.4 211405311E73·79 AT 332.00 1.4 211405312F73·79 LT 332.00 1.4 211405311F

Shock absorber, std 55.40 0.4 211413031Pheavy duty 84.10 0.4 211413031Radjustable.. . . 174.05 0.4 211413035

# Add for balance, weights 4 valve stem.§ TIme is far ane, both.8.* Time Is to R 41 tube assy. to overhaul, add 4.5.

"STEERING ',<'.'

5 6

,•

9 • ~~1-10 19

~ '" -.fl-12~<Q>

~~13

211415801F211415801F311415811C2114157410211498171A211425021A211415701G2114153718211415371C2114152210211415221F

211415049F

7.3

211817111G241817111G211817111K241817201

211809904A211809908A2118175370211817565G

2118175692118175698

24t877071241877223241877259

241877505A581241877355

241877361313877366A241877365241877364241877363241877523

241877415A241877306241877305241877369241877375241877481241877541241877403161877453

261817111G265817111G261817575C

BODY SIDE PANELS

~.~.' ..

5"' ~ . 3" .~... -1711 ----....~

2

"V-23 14

~

Side panel, outer

I~Y front1 bus & truck .. (p3.0) . .... LT 367.75 19.0 2318091512 van (p2.8) . 386.25 17.5 211809151

rearbus &truck .. (p3.0) 68·70 .... 0411.35 22.0 241809164

1'~ .p (p3.0) 71 .... 0469.00 22.0 241809164A(p3.0) 72·76 .... 702.00 22.0 211809164G(p3.0) 77-79 .... 670.00 22.0 221809164A~f van ........ (p2.8) 68·70 .... 0439.00 20.0 . 211809164(p2.8) 71 .... 0525.00 20.0 211809164C(p2.8) 72·79 .... 702.00 20.0 211809164G

rear11 bus & truck .. (p3.0) 68·70 .... 670.00 19.0 241809163

CONTINUED

The times listed are based on new, undamaged O.E.M. parts Installed on new undamaged vehiclesas an lridlvldual operation. Add for alignment pulls and refinishing as required. F415

1979-68 VWBUS& TRUCKI

BODY SIDE PANELS (CONT) Moulding, reveal 11 striker... 8.10(p3.0) 71-79 670.00 19.0 22t809163 front, w/vent, front.............. 01.40 24185333312 handle 69-79 11.90

van (p2.8) 68-79 613.00 18.0 211809163C rear D9.00 24185333113 hinge R&L 12,50Iwrsection.... (p1.6) 68-70 RT D181.75 22480917BE corner............ . D.80 24185334114 weatherstrip.... .. . 1.30

(p1.6) 68-70 LT D181.75 224809177E wolvent, D6.00 24185334515 spring......................... 10.05(p1.6) 71-79 RT 270.45 221809180 joint.............. 1.00 31585330916 SifI,below lid panel. .... .. .... ... 23.30

5 Inner, wndo opng RT 71.50 221809406C rear, w/vent, front.............. D1.40 241853333 DOUBLE CAB6 LT 162.20 2218094038 rear D10.20 241853353 SE£ SINGLE CAB. EXC

Mldg, front.. (d.2) LT D14.00 0.2 241853535 corner............. D.80 241853341 Outer panel t r

rear R&LD17.00 0.2 241853537 GLA~ RIGHTSIDE 1 on bed (p2.0) 68-70 RT D91.00on cab lock pillar...... D2.00 0.2 241853521A TO Cn 21423()(J(}Q0 2 (p2.0) 68-70 LT 0202.00

Rellector,front.. Dl1.00 0.1 211945555 Glass,rear,clear 96.35> 1.1 2218453310 (p2.0) 71-79 RT 288.90rear D12.00 0.1 211945557 tinted 144.25> 1.1 221845331C (p2.0) 71-79 LT 288.90

seal. D1.50 211945559 weatherstrip 40.80 244845341B# Aftersidepaneflsremoved.Door, gas filler 68·71 D15.00 0.2 211829605 Moulding, front.. '" D6.00 241853345§ With hinge or/ock pillarremoved 3.5.

72.79.... 20.05 0.2 211829605C rear D8.30 241853348t Afterouferpane/isremoved.Cover,slidingdrchnl LT 65.10 0.7 211843797A jointcover 1.00 3158533091-----------------

rubber bead...... .. 2.50 281843799 GLAS5.J.RIGHT SIDEclamp strip. ... . . . . . . . .. . . D6.00 211843818 FROM ,,'H 2152000001

7 Lower runner Glass, rear, clear 96.35 > 1.1slidingdoor..................... 78.80I 2.3 2118016720 tinted 144.25> 1.1

8 Sill panel weatherstrip 38.60below slidingdoor.... 20.30 211809586 Moulding, see to ch 2142300000

9 below Ir side pnl LT 21.35 211809585C SIDE MARKER LAMP10Wheelhouse,rear ~~-70 :::: ~~~:~I~:~g1~~1~1~r:~~bOdY 14.65 0.2

I 72-79 .... 150.30§ 3.0 221801561J t02162090464.................. 11.45 211945363A DROPPANELScoverp ate dOR~~~PANE1·85 211813363 Im21~~~~~:~:.::::::::::::::::: 11::~ 21~~i~~~~ 1 A:~6'd~~~le cab. (p2.6) 651.00# 0.6

11 Panel, outer (p2.2) 68-72 RT 180.95t 11.5 211813356M# Timeiswithdoorremored. w/doublecab .. (p2.0) 561.00# 0.6(p2.2) 68-72LT D145.00t 11.5 211813355L§ Afterouferpanellsremoved. 2 rear (pU) D391.00# 0.5(p2.2) 73-79 RT 175.70t 11.5 211813344Ct Tlme/sforran,13.0forsw. 3 Hook,front R&L 46.55 0.2(p2.2) 73-79 LT 175.70t 11.5 211813343C* Wlthchrometrimm/dg.add.2. rear....... 46.55 0.2

12 innerupper 68-71 RT D37.00 211813402> Aftercornerpane/Isremoved. 4 eye,side 18.85 0.268-71 LT D37.40 211813401:,' .'.. ' . PICK,.,UP BOX, A 5 rear....................... 12.45 0.272-79 AT 53.40 21181340281":-':':"""-."-,-'.:..'..:..'---",-_-=--=,::::.~.::!:-:=........:=~:....:.~_~'-'-I6 Hinge,each 18.00 1.072-79 LT 53.40 2118134018 # Painttimeisforinner&outer.

Iwrright .... _.... 68-71 RT D44.90 221813240S ~16 1 I-----=S-:::ID:-:E=,":"'L-:::O:-:A:-::D:-:I":"'N:-::G:-D~O~O:-::R-:-----

~~:~~~~D~:~ ~~:~~~~~~ -;~ ~ Assembly R&I 0.568-71 LT D52.30 2218132395 '. . ..-, .co Door72-79 LT 79.85 221813239R ~'t ~~-' -' ..' bus&truck .... (p2.5) 68-73 D582.00 3.5 221843106F

15 airdellectorplate ..... 68-71 D5.65 211813379 . £ -~.' (p2.S) 74-79 728.00 3.5 221843106G

72-79 13.90 221111881133136729N8~~.:'1413 ""-2i;;;i 5~~' 3° 4 van, • wlo ext roof.. (p2.5) 68·73RT 626.00 3.5 21184310SJ68-71 RT 26.75 w/ext roof... (p2.5) 68·73 RT D944.00 3.8 211843106K68-71 LT D15.oo 211813165H (p2.5) 74-79RT 626.00 3.5 211843106P72.79 RT 23.95 211813162M c-.. !r15 all (p2.5) LT 626.00 3.5 214843105E72-79 LT 20.05 211813165N:r 8 r~ Weatherstrip.................... 75.40 0.6 2118437928

Pillar ~1 7.' 1 Moulding, side (d.2) D15.00 0.2 241853532A16 dooropng ..... (p1.0) 68-71 071.00> 3.0 211813421K ~ 9' 10 12 wndoreveal, rear ..... 68-71 D9.00 241853331

(p1.0) 72-79 91.10> 3.0 211813421P ,'. 72-79 D10.20 241853353Moulding (d.l) 09.00 0.2 241853541D front.. 68-71 Dl.40 241853333

17 Mud flap 68-71 DI9.00 0.2 271821811 51NGLECA8 72-79.... 1.60 241853333872-79 30.05 0.2 271821811A Outer panel corner............. D.80 241853341

GLASS,LEFT5IDE 1 onbed (p2.0) 68-70 RT D55.40 11.0 261809044 GLASS&HARDEWARETO CH. 2142300000 (p2.0) 71·79AT D54.05 10.0 261809044C Glass, clear.... .. .. . 69.25 0.8

Glass, front, clear......... 98.10* 1.1 2218453010 2 (p1.5) 68-70 LT D120.95 13.0 261809041E tinted 68-79 D81.00 0.8tinted 128.95* 1.1 221845301E3 (p1.S) 71-79LT 340.85 13.0 261809041H rubber channel D27.00

w/ventwndo, clear............. 69.25* 1.1 2218452810 corner divisionbar 12.65tinted D81.00* 1.1 221845281C w/o b'up Imp (p.6) 68-71 RT D138.15 6.0 261813356M Ventilator frame................. 21.15 0.7

Glass, rear, clear................ 77.95* 1.1 2218453330 (p.6) 68-71 LT D138.15 6.0 261813355L rubber channel.............. ... 32.45tinted 089.00* 1.1 221845333C w/b'up Impw/b 68-71RT 0120.00 6.2 261813356N glass &chennel

W'strip, front.................... 46.50* 1.1 2418453218 w/b 68-71 LT Dl00.00 6.2 261813355N clear 103.10 0.7rear 030.00 * 1.1 2418453438 (p.6) 72 AT Dl03.00 6.0 261813344 tinted _.. 124.80 0.7

GLAS5,LEFTSIDE (p.6) 72 LT Dl09.00 6.0 261813343 glassoniy, clear 17.45 0.8FROM CH 2152000001 (p.6) 73-79 144.55 6.0 261813343C tinted........ .. 25.55 0.8

Glass,front,clear 98.10* 1.1 2218453010 4 Pillarengdr (p.5) D27.40# 2.0 261813418B arm,w/knob 14.70tinted 128.95* 1.1 221845301E5 Wheelhouse, rear 68-70 RT D84.00t 3.0 221801562N Handle,outside

w/vent,clear 69.25* 1.1 2218452810 68-70LT D89.00t 3.0 221801561G w/cyl&key 68-73 60.60 0.2tinted D81.00* 1.1 221845281C 71 RT Dl05.00t 3.0 221801562H wlo cyl&key 74-79.... 28.35 0.2

Glass, rear, clear.... .. . 77.95* 1.1 2218453330 71 LT D98.00t 3.0 221801561H cylinder&keys 68-70 26.30 0.3tinted D89.00* 1.1 221845333C 72·19RT 150.30t 3.0 221801562R 71-73.... 26.30 0.3

W'strip, front or rear............. 37.15t 1.1 221845321C . 72-79LT 150.30t 3.0 2218Of561J 74-79 .... 24.85 0.3Vent glass & frame, fron~ rear 6 Door, gas fdler 68-71 D15.00 0.2 211829605 Lock, front

224847631 72-77 20.05 0.2 211829605C bus &truck.. ..... 68-70 104.15 0.522184529187 Lid, fronl....... (p1.0) 68·76RT 235.75 0.7 261829061E 71-73 104.15 0.5221845291A . (p1.0) 77-79 .... 235.75 0.7 261829061E 74-79 104.15 0.5221847673A8 weatherstrip................... 46.55 261829571 van 68·70 D113.00 0,52218476819 68 .... 66.45 0.3 2618295618' 71-73 164.80 0.5

10 69-79 ,... 66.45 0.3 261829561CCONT/NUED

Information In the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate. I211829221826f829067A

0.3 261829551261829573245827401261809586

12.0 26580904412.0 265809041C12.0 265809042012.0 265809041H

2218453310221845331C2218453218

211945351A

13

14

Engine cover plate

glass only, clear .tinted .

weatherstrip ...........•.......lock arm wiknob "

87.55 0.717.45 0.825.55 0.832.4514.70

2618290510265829051C261829055E26182945382618294738261829447261829445261829361

2218452810221845281C241845285B221847659221847655

221847673A

224847632A22184763282218452916221845291A221847682

211843703H211843703P2118437090211843709E211843710

2218436542218436548221843654A211843654D211843654F

I F416 The times fisted are baaed on nl!w, undamaged O.E.M.parts Installed on new undamaged vehiclesas an Individual operation. Add for alignment pulls and refinishing as required. I

1979-68 VWBUS& TRUCKI Information In the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate. I

74·79 51.70 0.5Lock, rear 68-70 053.00 0.5

71-73 57.15 0.574·79 57.15 0.5

vanw/extroof 021.45 0.5Hold open catchon door.. . . .. .. .. .. .. .. . . . . . . .. . 52.35on body .. .. . . . • . . . . .. .. .. 57.65protective plate

front ................••........rear ................••.........

Hinge, rear ..........••..........supportto 2 I 62030413 .. .. .. .. .. .. .. . .. 48.50fm 2162030413 48.50

Roller guideupper, bus & truck .van wi ext rool .plastic cover .

lower.. .. . .. .. .. . 68-79 .iF A Iter door Is removed.

2.702.70

190.45 # 0.2

17.65 0.307.50 0.3

1.6077.80 0.4

211843654J2118436048211843604E2118436040211843604C

22184369882218436988281843336A

47,50 BHP..................... 37.70 t 0.8 34110130262,66 BHP .. . .. .. .. .. . .. . .. .. .. 78.25 t 0.8 021101301AOOl68,70 BHP

to GO 0000001 . . .. .. . .. . . 66.40 t 0.8 022101301A70 BHP 1mGO 0000001 .. , ,.. 78.25 t 0.8 039101301COOI

Crankshaft pulley44 BHP....................... 44.15* 0.547,50 BHP .. .. .. .. .. 27.50 * 0.5

Oil cooler44,47,50 BHP .......•• : ••...... 061.45 # 1.062,66,68,70 BHP 154.75 # 1.0

Fan housing44,47,50 BHP . .. .. 178.50 # 0.762,66,68,70 BHP 464.20 # 0.7

Fan, w/pulley & hub62,66,68,70 BHP 68·77 200.85 1.0grille, 62,66,68,70..... .. 4.10

Carrier, 44,47 50 BHP 219.7062,66,68,70 BHP 130.95

Rubber mount44,47,50 BHP 68·71 .

72·79 .62,66,68,70 BHP .

retainer , .. . .. R&Lsupport R&L

Olililler .Cover plates .44,47,50 BHPcylinder RT 24.35 0.2

LT 24.35 0.2heater channellower front.. . .. .. .. .. .. RT 23.15

rear RT 23.15LT . 22.25

air deflector.. .. .. . .. .. .. ... R&L 3.00 0.2plate 68·71 R&L 6.30

72·79 4.60crankshaft pulley 68·71 13.75* 0.5

72-79 13.75i 0.5preheat pipe protect 4.90engine, front.. ..•..... 68·71 026.00

72·79 50.20rear 68·71 29.30 0.7

72-79 60.95 0.7Cover plates, 62,66,68 70 BHP

cylinder 68·72 AT 48.0573·79 AT 48.05

all LT 69.75warm air duct, Iwr 68·74 RT 23.15 0.2

68·74 LT 13.60 0.275-79 RT 6.70 0.275-79 LT 13.60 0.2

front 68·74 RT 22.7568-74 LT 24.3075·79 RT 23.1575·79 LT 08.95

rear.. .. . .. .. .. . .. . .. .... RT 35.95LT 54.30

deflector plate RT 11.45LT 9.10

engine, Iront 68·72 020.0073·79 41.85

043101025 70 BHP 41.85021101025P rear AT 12.45

92310194101 LT 22.30022101025K center.... 12.45038101353 exhaust deflector.......... 29.15

043101355H generator .0211013510 alternalor... .. .. . .. 9.80

# Time is with engine remo ved. With air cond add t.t.022101351C§ Withaircondaddf.!.022101351Ht Att.ercrlmder head IS removed.022101351Lf Withalfcondadd.5.

1131014758 CLUTCH & TRANSMISSION021101471

21182nl121182nl1C2118275030211827503L2118132598211813259C

261829551211829553245827401

211827401A2118132270211813227H211813175E2118132730211813217C2118132178

2118434368 REAA LAMPS211843436A~..:.-----....:..!:=..:::..:...:=..:~~--'--~--1211843486A211843406E 1968·71

body "" .. " .... " .. 68-69 "" 29.30 0.370·71 .... 51.45 0.3

door " 68-71 " .. 0 22.70lens 68·69 19.35 0.1

70·71.... 37.15 0.1gasket. .... " .. .... 68·69 .. " 5.80

70·71 5.80bulb, single contact.... 68-71 1.35

double contact. .. 68-71 1.101972·79

body " ". 72·79 "" 49.15 0.3lens " 72-79 34.30 0.1gasket, to body 72-79 3.15

to lens.. . .. 72·79 .. " 2.05cap 72·79 13.75bulb, single contact.... 72·79 .. " 1.35

double contact... 72·79 ".. 1.10BACK·UP LAMP

Assy " " 68·71 031.00 0.2see tail lamp 72·79

Door............................ 9.85Lens .. " ..................• "". 11.00 0.2

gasket " "" 03.05Bulb " .. " ". 1.35

LICENSE LAMP211845501F Body & lens 68·71 17.65 0.4 21194316102118454958 72·79 "" 14.90 0.4 211943161E221845495A Gasket ..........• " ... 68-71 .... 01.00 211943131C241845521E 72·79 .. " 1.70 2119431310211829231GI_B-U-lb-. _"_"_"_"_"_,,_,,_,,_,,_,,_,,_,,_,,_._1._70 NO_'7_71_92I211829231R ENGINE211829211EI--'------=::..=:..:.==-~-----1211829211H ENGINE, R & I2\1~~~~1~ Engine R & I, wlo AC. " " ..

w/AC .. " .. " .211829642 Engine, overhaul, wlo AC .211829641 w/AC .

211829642C ENGINE PARTS211829841C361827361331827383

211829332A211829331A

"i..." ! REA A ~OADING POOR

Assembly R&I .. .1 Door, wlo

wndws. . . . . .. (p2.5) 68·71 0338.00 I 1.5w/wndws. (p2.5) 68·71 0230.80 # 2.0all.... .... (p2.5) 72·79 369.85 # 2.0

2 W'strip around door .... 68·71 63.2572-79 ".. 63.25

Moulding, etr (d.2) ".. 21.95 0.2window, reveal R&L 10.05.

joint " . " .. . .. 1.00Name plate, volkswagen.. ..... .. 13.35 0.2

GLASS & HARDEWAREGlass, un·healed 68·76 83.05 1.0

heated 68·79 213.45 1.0tinted 68·79 ".. 382.30 1.0

rubber channel. . . . . . . .. . .. . .. . . 47.353 Handle, wlcyl & keys". 68·71 .. " 46.50 0.6

72·79 ".. 42.40 0.64 Lock.. .. " .. " " .. " .. 68·71 .". 23.30 0.3

72·79 27.35 0.3striker" 68·71 07.80

72·79 .". 8.655 Hinge " .. 68·71 AT 0 35.65 § 0.4

68·71 LT 39.65§ 0.472-79 AT 39.65 § 0.472·79 LT 41.25§ 0.4

7 slay " 68·71 19.8572·79 "" 19.60

8 Torsion bar .... .. .. .. .. .. ... RT 15.05LT 15.05

iF Time lor painting is for inner & outer.§ After lid is removed. 80th .6.

6

0.5

211829105A2118291050

211829105AK211829193C211829193E241853551C255853345A3118533098311853687

.ENGINE LID

Assembly R&I .. . . .. .. .. .. .. . .. .. 0.51 Lid .... "....... (p1.3) 68·71 193.40 0.9

(p1.3) 72-79 193.40 0.9211827025F211827025K

TAIL LAMP

211945237K211945237J211945117B211945241G211945241M211945245A2119452458

N0177322NOI77382

211945231211945241R

411941123411945235211945285N0177322N0177382

211941073A

211941375111941371211941361N0177322

13.75* 0.728.85 * 0.720.20* 0.745.9035.804.95 0.3

111105251F113105251G

111117021E02t1170218

11311902500211191990

021119031AO02111920701C

211199203A021199203E

211199231A211199231C021199231C2111993518021199221A021115351A

113119304G2111193038

043119350B043119352

043119351B311119317A

131119357113119357A113119533H113119533L2111195n2.11119515

211119515A113119523M2111195235

039119300C039119300C021119299M021119358C0211193558021119356E021119355E021119362C0211193618021119362E0211193610021119358021119367

021119320A021119319A021119513F021119513P022119513U0211195220021119527C021119531039119227

211903021BV022119281

F417 II

1.32.0

12.513.6

Crankcase44,47,50,77 BHP 393.50 # 9.062,66,68 BHP 1069.00 # 9.070BHP .. "."" 641.00 I 9.01meng GO 0027787 1069.00 # 9.0

Cyl head, 44,77 BHP 343.20 § 3.850 BHP " " . ".. 343.20 § 3.862,66 BHP D291.00 § 3.868,70 BHP

to ED 0000640 386.30 § 3.8fm ED 0000640.. .. .. 386.30 § 3.8fm GO 0000001 386.30 § 3.8

cover. 44,47,50 BHP 8.1562,66,68,70 BHP . . . . . . . . . . . 10.45

casket• 44,47,50 BHP .. .. .90 0.2

62,66.68.10 BHP . .. .. •• .. . 1.60 0.2retaining spring

44,47.50 BHP .62,66,68,70 BHP .

Cylinder, 44 BHP .

113101481F021101481

CLUTCHDisc, R&I .Housing, R&I .

TRANSMISSIONAssembly, R&I .

CONTINUED

1/ 0.5II 1.0

§ 2.11.60 0431014873.70 021101487

78.25 t 0.8 113101311E003

The times listed .ar~ ~ased on new, undamaged O.E.M. parts installed on new undamaged vehiclesas an indIVIdual operation. Add for alignment pulls and refinishing as required.

1979-68 VWBUS& TRUCKInformation In the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.

CLUTCH & TRANSMISSION (CONT) Air fiow metert 47 to eng GD 0027786 . .. ....•..... 192.05 0229063018Case, R&I, exc.... .. .. .. .. .. .. to eng ED 0000639 282.95 022906301C

fromch2000001............ t 4.2 fmengGD0027787 211.35 0229063010Gearcarrlerassy,R&I............ t 0.3 Elbow.......................... 38.75 022129967AC Axle shaftGear shift housing, R&I t 0.4 iF 17m,II lor busaft,r ,ngln, Isremoved.17m,lor truckIs 1.1 3 outer 68·70 133.60 0.8

iF 17m,Is wIthengln"emoved. Aft",ngln,/sremoyld. 71.79 133.60 0.8§ IncludesRII,ngln" wlthlllrcond,add.6. § 17m,IIwllh,ngln,lnCllr. Wlth,ngln,removed 1.1. Wlthllir 4' I 20 5t nm« Is wIthtf/msremaved. condIIdd.-t. Inner, manua trans 4.4 0.5

auto trans D396.95 0.5/i',f~f~r!:"C:f{I!Q~bsta~M~.~~~.§)~~q~.;!:xHl.l1Srs~at~ii;I;i:~,;&;gE~~r5 joint 102.45

6 beartng housing 68·70 RT 0120.00 1.31968·'" 1968.74 68·70 LT D120.00 1.3

Gasollnetank 68·71 180.001 0.8 211201075D Muffler,44,47,50BHP 68.71 53.0511.3 211251051E 71·79 RT 141.40 1.372 152.901 0.8 211201075H 72.73 130.30 # 1.3 211251051F 71·79 LT 141.40 1.3

to 2142132408 73·74 160.15# 0.9 211201075L 62,66,68 BHP 68.74 240.95 # 1.3 0252510538 7 boot kit........................ 26.50fm 2142132408 73·74 180.00# 0.9 211201075M Installation kit Bearing, rear wheelfillerneck 68·71 029.00 0.3 211201123A 44,47,SOBHP 68.74.... 8.75 2112960098.8 bearing, outer 68-79 49.1010.9

72·73 DI27.60 0.3 211201129G Tail pipe 9 iriner 13.60# 0.968·74.... 8.65 0.3 211201119 44,47,50BHP 68.74.... 6.40 0.3 211251237810 oilseal,outr&inr 7.20

Activated carbon contn 68·74.... 37.00 175201601A 62,66 BHP 68.74 49.85 0.3 021251171P11 Radius arm 68·71 RT 289.65 0.7mountJng strap 68·74.... 8.25 1136091698 68 BHP 68.74.... 21.65 0.3 021251185F 68·71 LT D218.00 0.7

Intake manifold 68·74 Damper pipe 72·79 RT 289.65 0.747 BHP 68·74 223.55§ 1.7 113129701AB 44,47,50 BHP 68·74.... 14.95 147251157 72-79LT 289.65 0.750 BHP 68·74 227.75§ 1.7 113129701AP bracket 12 Torsion bar .•.......... 68·71 RT 125.85 2.062 BHP 68·74 R&LDI19.75§ 1.7 021129705AD 44,47,50 BHP 68.74 4.85 211251301A 68·71 LT 125.85 2.066SHP 68·74 R&Lo 51.00§ 1.7 021129705L 62,66 BHP 68-74 06.55 0212513018 72·79 125.85 2.068 BHP ,': 68·74 R&L 59.85§ 1.7 021129705AG 1975-79 13 link plate 68·71 Dl00.00 1.5

Throttleposlboner 68·69 .... D89.00 0.3 113131307 M'I Id 7579 9940 021251531 72·79 128.25 1.570·74 ".. 24.55 0.3 113131309A ani 0 . 14 1360control valve 70·74 " .. D55.00 0.2 113131395 Muffler 75·79 126.95 071251053F15 ~OV~~.. ........•....... 4'20high altitude correct 68·74 D12.00 113131401 C~talyst. .:": : 75-79 558.00 043131701E us Ing.................... .

Fuel pump Installall.on kl~ 75-79 7.45 02329805116 Shock absorber1 slandard 68·71 55.25 0.4

44,47,50 BHP 68·74 .". 24.70 0.5 113127025D cfon~~~~~~gdo~ 75.79 268.40 021251501 72·79 63.10 0.462,66,68 BHP 68·74 ".. 216.25 0.5 021127025A f 2162070001 7579 17645 021251503A heavy duty 68·71 82.85 0.4

Carburetor, check locally... ..... 0.6 m...... . 021251185F 72·79 101.40 0.4" '11 Tall pipe 75-79 21.65 d' t bl 17465 041i75·7" iF Wlthalrcondadd.-t; a J~sa e . .

GasoJinetank 75·79 180.00# 0.9 211201075M iF Tlm'lSloroneorboth.Filler neck : 75·79 : 24.70 211201119A 1:,'··:&~lln~rQttlY.s1')ll~~;~;:1. ;~~:,~. ''''. :~": R~FrBUMF,iER;: .1·.::J!t;,(j<i

cap, w/o lOcking 75·79.... 10.30 211201551P AI 35190 021131601 - ,-».~, c." : .;;: .---. - •••• "-'- =', ~."~ ' .• ,~"'.I k' ty 75·79 2330 211201551R r pump.. .. . .. .. .. . .. .. .. .. .. .. .

AClivat~~~btneco~i~' 75.79 :::: 37:00 175201801A Drlveshaft,w/pulley 114.55 021131681t t & b kt 75 79 8 25 1138091698 belt................ .. . 9.65 021131615A

mn g s rap r . .. .. . . .. . . Pressure relief valve 5435 021131604Fuel pump (electric) 75·79 148.60 043906091 .Intake manifold 75·79 R&L 100.35 022133201E :~~~~:~~~~ef~f~~e... 23.40 039131603Air intake distributor 75·79 .. :. 194.85 022133055J 444750626670BHP 11660 021131617AFuel filter 75-79 5.25 133133511 68'BH'P'" 130'55 0211316170Electronic control unit . .. . .. .. .. .. . .. .. .. .. .. .. .

Federal, std trans Two way valve .. ,.. •... 42.00 171906283to 2162077584 75 022906021HV EXHAUSTRECIRCULATIONSYSTEM 21m2162077584 75·76 0.00 022906021NV 1975·79

77·79 027909021S Exhaust gas fillerw/ocatconverter 75·79 114.00w/eat conv ., 114.00pipe, upperto eng GD 0011 000 . .. .. .. .. .. . 58.80fm eng GD 0011000 58.80

Valve, reclrculator D185.90decelerator

10 eng GO 0011000 . . . . . . . . . . 77.85 022133551Afm eng gd 0011000 .. .. .. .. .. 67.50 022133551C

022906021MV Temperature switch D13.25 022131519022906021RV~')'f;· ••roes M-. --• ...,~<~.'-·--·uiP~i'-~.~""'''

022906021ABVVV~/;";';l"<t,~ftEA8i$.I:fD~.8$jg"i.l~·~~~{,f*

auto transto 2162077584 751m2162077584 75·76 .

77·79 .Calif, std trans

to 2162077584 75fm 2162077584 75·76 ....

77-79 " ..auto transto 2162077584 75fm 2162077584 75·76 .

77-79 .harnessto 2162077584 75 456.101m2162077584 75·76 478.05

77-79 456.10relay. . . . . . . .. 81.65series resistance 89.00

Fuel injector 55.05Pressure regulator , . . 45.25Throttle valvehousing 0208.00switch. .. .. .. .. .. .. . .. .. .. .. D43.00

Cold start valve "........... 40.20Auxiliary air reg 65.60Air cleaner

to eng ED 0025000 0244.00to eng GD 0010999 D169.701m eng GD 0011000 386.40

022906021JV022906021PV022906021TV

022906021LV022906021 QV

022906021AAVVV

022971761P022971761R

022971761A8071906059022906079023906031022906035

022133062Q022906111E0229061718022906045A

022129607M022129607S022129607L

021131617E021131617F

022131592C0221315928022906281

11

~ 12~~ 13\""~~1 ;.,".~'14 '\ ,l~.

",~,O q~~.2 .-'

16 3

h~f40)liIIC,

1 drum only 71·79 144.45 0.32 hub only 71-79 135.40 0.6

support plate 68·70 62.65 1.371·79 55.60 1.3

211809615211501619

211609439D211609425L

211501265211501265C211501203

211501203A251598101211501254211501253

211501254E211501253E251598201

211501283211501287211501317

211501066J211501065J211501066K211501065K211511116A211511115A211511115C2115112058211511205E211511225

211511245A

211513031N211513031R211513031K211513033211513035

211707311F211707311HZVW151812ZVW151822241707411C241707411E2417074218241707421C211707336A211707335C211707336E211707335E211707366D21170736502117073978

211707311K

F418

REAR 8l1MPER·1968-72Assembly R&I . . . . . . . . . . . . . .. . . . . 0.4Overhaul.. .. . .. .. .. . .. .. .. .. .. .. 1.1

1 Face bar....... (p1.O) 68·71 .... 165.75 0.8(p1.0) 72. .. .. 165.75 0.8

Guard, w/cushion 68·72 8.40 0.2cushion 68·72 01.85

2Trlm mldg 68·69 075.00 0.970·72 107.40 0.9

3 rubber insert 68·70 D13.0071·72 021.95

4 Mounting brkt 68-71 RT 44.1568·71 LT 43.9072 RT D47.2572 LT 32.60

5 Gravel deflector . . . . . .. 68·72 RT 25.15§ 0.268·72 LT 0 22.65§ 0.2

6 sealto bumper.. .. .. .. 68·72 .... 3.20REAR 8UMPER, 197J.79

Assembly R&I . .. . .. . . .. .. .. .. .. . 0.5Overhaul. . . . . . . . . . . . . . . . . .. . . .. . 1.0

7 Face bar, prime 73·79 165.75# 1.0

CONTINUED

The times listed are based on new, undamaged O.E.M. parts Installed on new undamaged vehiclesas an Individual operation. Add for alignment pulls and refinishing as required.

Hub & drum 68·70 213.65 0.4 211501615G

1979-68 VWBUS & TRUCKI Information in the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.

REAR BUMPER (CONT) NOTESI

chrome 73·79 461.65 # 1.08 Rubber cush & end caps 73·79 81.609 endcaps 73·79 B.85

10 Mounting brkl 73·79 AT 44.2073·79 LT 35.95

11 Cover plate, muffler .... 73·79 .... 16.45 0.2If Time is for oyerhsu!.§ After bumper Is removeaIEA9107

221707311A241707421D

241707219211707336C211707335D211707399A

NOTES

NOTES

I The times listed are based on new, undamaged O.E.M. parts installed on new undamaged vehiclesas an individual operation. Add for alignment pulls and refinishing as required. F419 I