TABLE OF CONTENTS 2859 SC 1996 - Bayliner

TABLE OF CONTENTS

1) COVERINGS ......................................................................................................... 2Gelcoat, patch paste, vinyls, fabrics, woodshop materials, carpet

2) HULL HARDWARE ............................................................................................. 3Hull carpet, ext. hardware, swim step/platform, braces & ladder assy

3) DECK HARDWARE ............................................................................................. 5Gunnel, bow/taff/stern/grab/hand/console rails, radar wing,bow platform, deck hatches & trim, deck carpet

5) HARDTOP HARDWARE ..................................................................................... 9Rails, headliner & carpet, hardware, overhead console

6) INTERIOR HARDWARE ..................................................................................... 10Table assy, propane system, port dash and helm console

7) UPHOLSTERY ..................................................................................................... 12All uph, materials, foam, uph rails and hardware, carpet runners

8) TAPES AND LABELS ......................................................................................... 18Hull, interior, exterior, deck, C/B & H/T tapes and labels

9) WINDSHIELD ....................................................................................................... 19Windshield system, windscreen, fasteners and related hardware

10) ELECTRICAL ....................................................................................................... 22Wiring harness, gen. sys, air cond., int/ext lights, gauges, switches, panelsconsole & instruments, audio-visual, communication, radar/autopilot

11) CANVAS ................................................................................................................ 24

12) ENGINE AND CONTROL SYSTEMS .............................................................. 25Engine systems, shifter & control cables, steering sys, fuel sys, vent sys

13) MODULES ............................................................................................................. 26Entertainment center assy, entry door & trim, drip rails, hanging locker,head, galley, exterior bulkhead, vanity assy, plex doors, wood assemblies

14) PLUMBING AND FIXTURES ............................................................................ 31Bilge pump, baitwell, shower, marine head, fresh water,sink/deck/c/b drain systems

15) MANUFACTURING SUPPLIES ........................................................................ 38Manuals, shipping materials, basic manufacturing supplies

16) FACTORY INSTALLED OPTIONS .................................................................. 39

17) DEALER INSTALLED OPTIONS ..................................................................... 41US Marine Parts options only

18) ENGINE OPTIONS .............................................................................................. 43Engine systems & related hardware

1REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

SECTION TITLE PAGENO.

Arl usmarine

Canvas is no longer available. Go to http://www.letastopshop.com

ITEM PART PART DESCRIPTION U/M QTY.NO. NUMBER

2REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

COVERINGSSECTION 1

GELCOAT/PATCHPASTE/PAINT* F50-31943 GELCOAT-WHITE/WHITE QT* F55-31943 PATCH PASTE, WHITE/WHITE EA* F7220 BASECOAT WHITE QT* F50-21204 GELCOAT BLACK QT* F55-21210 PATCH PASTE, BLACK EA

WOODSHOP MATERIALS* 57788 LAM PLY-ELDORADO LEATHER SF* 58790 5/8 LAM PLY-GLOSS LIGHT BEIGE SF* 58790-V LAMINATE-LIGHT BEIGE SF* 58805 5/8 LAMPLY-BRUNE SF* 51488 3/4" STARBOARD-POLAR WHITE-HDPE SF* 38339 1/2" STARBOARD-POLAR WHITE HDPE SF* 6040 1/2" WHITE 2/S DECRAGUARD SF* 36276 1/2" WHITE E-LAM PLYWOOD SF

CARPET* 60934 CARPET- MARCH WINDS SY* 52594 HEADLINER- WHITE OPAL LY* 61148 HULLINER-MULTI-BLUE LY

VINYLS* 57695 VINYL, SAND SURF LY* 60777 VINYL,STERLING BLUE LY* 57921 VINYL, BUFF LY* 57697 VINYL, DYNASTY WHITE LY* 61100 VINYL, DESTINY SAND LY

FABRICS* 60944 FABRIC, ROCKY PLAIN LY* 60935 FABRIC,ORLANDO PLANT LY* 58840 FABRIC,BUFF PAWLEYS LY

CANVAS* 57669 CANVAS-SAND LY

FOR VERIFICATION OF COLOR, REFER TO 1996 COLOR CHART.

* NOT SHOWN

3


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

HULL EXT HARDWARE1 14302 TRIM TAB 12X18 W/PUMP AND INTERNAL FITTING ST 13 4456 1/2" X 3 7/16" BOW EYE (RLED) EA 34 50994 GARBOARD DRAIN PLUG EA 15 50993 GARBOARD DRAIN FLANGE EA 1* 2402 8 X 1 PFH SILICON BRONZE EA 2* 315-1 CLAM SHELLS MIDGET EA 16 52841 SWIM STEP GRAB RAIL EA 17 11394 T-HULL FITTING, 1.5" W/SCUPPER EA 48 708 T-HULL, 3/4" (FISHWELL DRAIN) EA 19 1703 FUEL TANK VENT EA 110 86741 SWIM STEP/PLATFORM11 59287 ETCHED GUNNEL 12' NARROW W/CHAMFER EA 112 60884 GUN’L 1/2"BLACK FT 1213 9225 BLACK GUNNEL END CAP PORT EA 114 9226 BLACK GUNNEL END CAP STBD EA 1* 53827 LABEL, BOARDING LADDER WARNING 10M EA 1* 11765 3/8-16 X 3 HH SS-ALL THREAD .1/.25 EA 4* 11903 3/8 X 4 HH SS ALL THREAD EA 2

SWIM PLATFORM BRACES15 53693 BRACE SWIM STEP EA 416 2353 PIVOT BRACKET EA 4

LADDER ASSEMBLY17 K-5168 BUMPER EA 4* 56181 TRANSOM LADDER W/STEP EA 1* 12293 1" GRAY NYLON WEBBING 100YD/RL YD 1

TURNBUCKLE ASSY* 89 TURNBUCKLE WASHER EA 1* 88 TURNBUCKLE EYE EA 1* 90 TURNBUCKLE STUD EA 120 2353 PIVOT BRACKET EA 2

HULL HARDWARESECTION 2

DRAWINGS ON FOLLOWING PAGE.

* NOT SHOWN


4REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

HULL HARDWARESECTION 2

SC9602

5


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

DECK HARDWARE1 7769 CLEAT 10" 4-HOLE YACHT EA 32 7814 CHROME CHOCK PR 13 SC05703 ANCHOR LOCKER HATCH EA 1* 36327 WHITE CATCH F/HATCH HINGE EA 1* 35343-B ANCHOR DEADEND EA 24 54545 FAIRLEAD W/NYLON ROLLER, 2 7/8" PIN EA 15 53785 PIN Q-RELEASE 2 1/4" W/LANYARD 6" EA 16 58964 BLACK ESCAPE HATCH W/WHITE ACRYLIC EA 17 12460-A SGL TRUMPET HORN S/S EA 18 7821 CLEAT 8" 4-HOLE CHROME EA 29 57496 WIPER MOTOR ASSY EA 1* 53237 22" WIPER BLADE EA 1* 53238 20" WIPER ARM EA 1* 57497 ADAPTER,PANTAGRAPH ASSY EA 1* 59206 WIPER MOTOR COVER,ABS,LT BEIGE EA 110 SC0570201 ENGINE HATCH EA 111 4082 ACOUSTICAL FOAM SF 1612 4354 ALUMINUM TAPE RL 113 OILDEC OIL DISCHARGE DECAL EA 114 58282 GAS SHOCK 120 EA 215 58283 "L" BRACKET, MED-S/S, EA 216 58283 "L" BRACKET, MED-S/S, EA 218 SC05704 BAITWELL HATCH EA 119 12293 1" GRAY NYLON WEBBING YD 2

TURNBUCKLE ASSY20 88 TURNBUCKLE EYE EA 621 89 TURNBUCKLE WASHER EA 622 90 TURNBUCKLE STUD EA 623 1477 HATCH HINGE EA 924 3031 HATCH CVR LIFT HANDLE EA 425 SC1220831 TRANSOM STORAGE DOOR EA 1* 39733 LIFT RING NON-LOCK W/ 3/8" OFFSET EA 226 54078 HATCH RING 12 X 60 W/HINGE EA 1* 52814 ROD HOLDER ASSY (ON TRANSOM STRG DOOR) EA 4* 7026 1/4" BUNGEE CORD FT 3* 9469 HOG RINGS S/S EA 427 54052 CENTER FWD CABIN WINDOW GLASS EA 128 54051 FWD CABIN WINDOW P + S GLASS EA 229 7561 1/16X3/4 2 SIDE TAPE RL 130 12635 TITE R BOND (SURFACE PREP) PT 131 54102 RAIL,GRAB,CABIN TOP EA 232 50103 60 DEG HND RL END EA 433 50102 60 DEG HND RL CNTR EA 434 53582 NAV LIGHT, GREEN (PORT) EA 135 53583 NAV LIGHT, RED (STBD) EA 1

DECK HARDWARESECTION 3

* NOT SHOWN



6REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9603A

SC9603B

7


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

HELM1 50565 SAFETY STEP F/FT. REST 8-7/8X2-1/4" EA 12 50679 FOOTREST EA 13 52296 ESCAPE HATCH WHITE SMALL (A/B) EA 14 54574 END CAP PT WINDOW W/O EA 15 54575 END CAP STBD WINDOW W/O EA 1* 54589 WIRE COVER (STBD W/S WIRE COVER) EA 16 38200-A COMPASS-FLUSH MOUNT W/PLUG EA 1* 39411 OVERLAY WARNING OPERATOR EA 17 54364 RAIL,HDTP SWAY GRAB (PORT AND STBD) PR 18 9826 30 DEG RAIL END SS 7/8 EA 49 50102 60 DEG HND RL CENTER EA 210 SC2310302 COCKPIT TABLE EA 1* 11395 CUPHOLDER PLASTIC 1" BLACK EA 211 56408 TEAK SEA RAIL FT 8* 13156 ROUND TABLE SUPPORT EA 113 39729 30" TABLE LEG W/THREADS & FLANGE EA 114 39730 TABLE BASE W/STUD EA 115 31310 STEP LIGHT EA 116 61660 MERC SHIFTER ASSY EA 117 61446 HANDLE, GRAB, PORT SEAT EA 118 50101 90 DEG REC BASE EA 119 50101 90 DEG REC BASE EA 120 61034 16" STEERING WHEEL EA 1* 61034-C CENTER FOR STEERING WHEEL EA 1

GUNNEL* 1265 3/4"GUNWALE RUBBER FT 70* 59290 ETCH GUNWALE 12’WIDE EA 5* 59289 ETCH GUNWALE 10’WIDE EA 1* 10994 8 X 3/4 PPH BLK OX/SS EA 2

54096 BOW RAIL ASSEMBLY EA 121 54097 BOW FORM EA 1* 61944 PORT HEEL EA 122 61945 STBD HEEL EA 123 54099 FWD STANCHION EA 224 54100 FWD MID STANCHION EA 225 54101 AFT MID & AFT STANCHION EA 426 36559 45 DEGREE RAIL FITTING EA 227 50106 60 DEG ROUND BASE NH EA 1028 50108 60 DEG RAIL TEE R & L NH EA 8

TRANSOM GATE* 59740 TRANSOM DOORWAY TRIM,PORT EA 1* 59741 TRANSOM DOORWAY TRIM,STBD EA 1* 59551 TRANSOM DOOR STOP,23"X3/4" POLAR STBD EA 1* 51128 L-MOLD W/GROOVE, WHT FT 2* 86311 TRANSOM DOOR, 1/2" POLAR WHT STBD EA 1* 54243 HINGE BUTT, 2X3 CHROME PR 2* 947 #2 BOLT BARREL EA 1* 34700 GLASS DOOR BUMPER EA 1


DRAWINGS ON FOLLOWING PAGE.* NOT SHOWN


8REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9603C

9


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

HARDTOP HARDWARESECTION 5

HARDTOP HARDWARE1 1880 GUTTER W/LIP 12' FT 362 13187 LIGHT POLE STORAGE CLIP EA 13 1181 ANCHOR LIGHT EA 1* 53754 COVER, BLACK PLASTIC EA 15 56070 4"SURF MT.DRM.WHT DOME LT.W/SWT(86) EA 4

HARDTOP RAILS** 54364 RAIL,HDTP SWAY GRAB PR 1** 8494 RECT BASE-30 DEG EA 4

* 50102 60 DEG HND RL CENTER NH EA 66 50103 60 DEG HND RL END NH EA 47 50103 60 DEG HND RL END NH EA 48 54103 RAIL,GRAB,CABIN TOP EA 2

* NOT SHOWN** SEE ITEM NO.'S 7, 8, & 9 ON PAGE 7.

SC9605


10REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

HULL INT ASSY HARDWARE1 10846 ALCOHOL ELECTRIC STOVE GLASS TOP EA 12 86817 FLOOR ACCESS HATCH EA 13 3031 FLUSH RING PULL (FLOOR ACCESS HATCH) EA 14 59206 WIPER MOTOR COVER EA 15 61324 DOME LIGHT 5-1/2" EA 76 SC2310217 MAGAZINE RACK EA 17 53278 GALLEY FAUCET EA 18 59605 GALLEY SINK EA 19 #W1323-35 CLOSET POLE SOCKET ST 110 6059 1-15/16" DOWEL LF 211 D56303 110 PANEL ASSY (REFER TO SECTION 11 FOR COMP. ASSY) EA 112 60597 ZINC SAVER, 30 AMP EA 113 59492 REFRIGERATOR EA 114 SC2310319 REFRIGERATOR FACE, LT. BEIGE EA 115 9980 REFER VENT LARGE EA 116 59207 JUMPSEAT SLOT TRIM (LIGHT BEIGE) EA 2217 SC2310313 DINETTE DOOR (LIGHT BEIGE) EA 1* 55317 WHITE KNOB FOR CABINET DOORS EA 1* 31054 T-TRIM 11/16" WHITE FT 7* 60176 HINGE-CHROME OVERLAY EA 2* 6199 NYLATCH ROLL CATCH EA 418 9622 AM/FM STEREO CASSETTE EA 119 60262 STEREO SPEAKERS, WHITE PR 120 61324 DOME LIGHT, 5-1/2" EA 4

TABLE ASSEMBLY21 SC2310302 DINETTE TABLE (BRUNE SLATE) EA 1* 56408 TEAK-SEA RAIL LF 13* 13156 ROUND TABLE SUPPORT EA 122 39729 30" TABLE LEG W/THREADS & FLANGE EA 123 59639 TABLE BASE W/STUD ANODIZE EA 1* 52571 TABLE BASE PLUG EA 1

INTERIOR HARDWARESECTION 6


* NOT SHOWN

11


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

INTERIOR HARDWARESECTION 6

SC9606A

SC9606B


12REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

COCKPIT UPHOLSTERY1 86742 COCKPIT SEAT BACK EA 12 86743 COCKPIT SEAT CUSHION EA 1

86744 HELM SEAT COMPLETE ASSY EA 13 86745 HELM SEAT BACK EA 114 83950 HELM SEAT STORAGE POUCH EA 1

35604 VINYL-MILLER BLACK LY 135759 BLACK NET-F/STORAGE POCKET YD 1

4 86746 HELM SEAT CUSHION EA 15 61538 HINGE-CAST ALUM SEAT PR 1* 53678 HELM SEAT WARNING LABEL EA 16 86747 HELM SEAT SUPPORT BOARD EA 1* 34588 T-TRIM L X T1 LOX 12' FT 77 54004 SUPPORT ASSEMBLY EA 1* 53786 PIN Q-RELEASE 1" WITH LANYARD EA 28 86748 STBD SIDE PANEL ASSEMBLY (DYNASTY WHITE) EA 1

HARTOP VALANCE PADS9 86749 PORT SIDE VALANCE (DYNASTY WHITE) EA 110 86750 PORT FWD VALANCE (DYNASTY WHITE) EA 111 86751 FWD MID VALANCE (DYNASTY WHITE) EA 112 86752 STBD FWD VALANCE (DYNASTY WHITE) EA 113 86753 STBD SIDE VALANCE (DYNASTY WHITE) EA 1

UPHOLSTERYSECTION 7

DRAWING ON FOLLOWING PAGE.

NOTE: FOR ORDERING SKINS ADD A -1 TO THE PART NUMBER.(EXAMPLE 86742-1)

* NOT SHOWN

13


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

UPHOLSTERYSECTION 7

SC9607A


14REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

V-BERTH/BOW UPH ASSY(DYNASTY WHITE)* 86754 V-BERTH CUSHION(ORLANDO PEWTER) EA 11 86755 V-BERTH SHELF PAD, PORT EA 12 86756 V-BERTH SHELF PAD, STBD EA 13 86757 V-BERTH GUNNEL PAD EA 24 86758 CURTAIN VALANCE EA 15 56780-E PRIVACY CURTAIN EA 16 86759 V-BERTH HATCH EA 47 86760 V-BERTH HATCH EA 28 86818 PORT FWD DECK WINDOW COVER EA 19 86819 CENTER FWD DECK WINDOW COVER EA 110 86820 STBD FWD DECK WINDOW COVER EA 111 86821 ESCAPE HATCH BLIND EA

DINETTE LOUNGE ASSEMBLY(ROCKY PLAIN)12 86761 PORT CABIN VALANCE EA 113 86762 FWD DINETTE BACK EA 1* 86763 FWD DINETTE SEAT CUSHION EA 114 86764 AFT DNETTE BACK EA 1* 86765 AFT DINETTE SEAT CUSHION EA 1* 86766 STBD CABIN VALANCE EA 115 86767 DINETTE HATCH EA 316 86768 FLOOR ACCESS HATCH EA 117 332 HINGE 1/2 BUTTERFLY (FLOOR HATCH) EA 118 86769 BUNK CONVERSION CLEAT, FWD EA 119 86770 BUNK CONVERSION CLEAT, AFT EA 1

UPHOLSTERYSECTION 7


* NOT SHOWN

NOTE: FOR ORDERING UPHOLSTERY SKINS ADD A -1 TO THE PART NUMBER(EXAMPLE 85322-1)

15


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

UPHOLSTERYSECTION 7

SC9607B

SC9607C


16REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

AFT BERTH ASSY1 86771 A/B CURTAIN VALANCE EA 12 86772 A/B GUNNEL PAD EA 13 86773 A/B HEADBOARD EA 1* 86774 A/B MATTRESS EA 1* 86775 A/B SHELF FACE EA 1* 86776 A/B ESCAPE HATCH BLIND EA 1* 86777 A/B STORAGE COVER EA 1* 57697 VINYL-DYNASTY WHITE LY 1* 60935 FABRIC,ORLANDO PEWTER LY 6

HEAD ASSY4 86778 HEAD/DASH ACCESS DOOR EA 15 86779 HEAD VALANCE EA 16 86780 HEAD STORAGE SHELF EA 1* 57697 VINYL-DYNASTY WHITE LY 1

59608 BOAT INT. CURTAINS* 59608-A STBD SIDE CURTAIN EA 1* 59608-B PORT SIDE CURTAIN EA 1* 59608-C HEAD CURTAIN EA 1* 59608-D PORT AFT BERTH EA 1* 59608-E V-BERTH PRIVACY EA 1* 59608-F SHOWER DOOR CURTAIN EA 1* 50040 SHOWER CURTAIN-LIGHT BLUE LY 2* 11536 I-BEAM CURTN.TRK. FT 24* 11537 NYLON WHEEL CARRY CURTAIN EA 80* 11538 END STOP-CURTAIN-PLTD STL EA 10* 11539 CEILING BRACKET-CURTAIN EA 24

REMOVEABLE CARPET RUNNERS* 61817 CARTPET RUNNER KIT (MARCH WINDS) KT 1* 60943 CARPET- MARCH WINDS SY 1* 53713 BINDING - GRAY LY 5

SNAP ASSEMBLY* 81 SNAP BUTTON EA 8* 82 SNAP SOCKET EA 8* 86 SNAP STUD EA 8

UPHOLSTERYSECTION 7


* NOT SHOWN

17


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

UPHOLSTERYSECTION 7

SC9607D

SC9607E


18REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

HULL INT LABELS* OIL DEC OIL DISCHARGE DECAL EA 1* 48034 USM SUBASSY QUALITY DECAL EA 1

TAPES & LABELS1 61424 WATERLINE STRIPE,CIERA EXP 96 FT 602 61423 HULL LOGO,BAYLINER (CIERA EXPRESS) EA 23 61420 DECK STRIPE 1/2", CIERA EXP 96 FT 764 61419 DECK STRIPE 3" FT 155 61422 LOGO,2859 CIERA EXPRESS 96 EA 2* 8033 MARINE CORE LABEL EA 16 11024 SLING LABEL UN5/PK EA 4

7 6336 LABEL SEQUT. LIFT HULL UN20M EA 2* 55662 LABEL,USM THANKS/5YEAR/NMMA CLEAR EA 1* 61419 DECK STRIPE 3" CIERA EXP 96 FT 15* 636 TRIM TAB INS LABEL EA 18 61417 LOGO DECK,CIERA EXP,PORT EA 19 61418 LOGO DECK CIERA EXP,STBD EA 1* 61414 STICKER,PPG FIBER GLASS EA 1* 62978 LABEL, YACHT CERTIFICATION EA 1

TAPES AND LABELSSECTION 8

* NOT SHOWN

SC9608

19


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

WINDSHIELD SYSTEM* 53187 WINDSHIELD 2859 SC EA 11 53187-XC CENTER PANEL EA 1* 52850 5/16 ROUND BUTYL FT 112 9109 YACHT FRONT PANEL VINYL FT 103 53187-01 CENTER PANEL GLASS CLEAR EA 14 53187-XF PORT FRONT PANEL EA 1* 52850 5/16 ROUND BUTYL FT 125 53187-02 FRONT PANEL GLASS CLEAR EA 16 9109 YACHT FRONT PANEL VINYL FT 10* 54838 SILICONE SEALANT BLK DOW TU 17 53187-XH STBD FRONT PANEL EA 1* 52850 5/16 ROUND BUTYL FT 128 53187-02 FRONT PANEL GLASS CLEAR EA 19 9109 YACHT FRONT PANEL VINYL FT 10* 54838 SILICONE SEALANT BLK DOW TU 1* 53946 BLK URE IF 2014 2859 SC W/S FT 1210 53187-XJ PORT WING SECT I (FWD)11 5743 AMESBURY PILE FT 312 5740 DEEP STAN-PRO FLOX SNG FT 2613 5741 SHALLOW STAN PRO FLOX SNG FT 914 53187-04 FWD WING GLASS CLEAR SC EA 115 53187-06 AFT WING GLASS CLEAR SC EA 1* 5744-XU SLIDER KNOB ASSY EA 2* 5748L-XU SLIDER KNOB ASSY EA 119 53945 SUPPORT BAR 23.56 EA 1* 54838 SILICONE SEALANT BLK DOW TU 120 53187-XN STBD WING SECT I (FWD)11 5743 AMESBURY PILE FT 312 5740 DEEP STAN-PRO FLOX SNG FT 2613 5741 SHALLOW STAN PRO FLOX SNG FT 914 53187-04 FWD WING GLASS CLEAR SC EA 115 53187-06 AFT WING GLASS CLEAR SC EA 1* 5744-XU SLIDER KNOB ASSY EA 1* 5745R-XU SLIDER KNOB ASSY EA 119 53945 SUPPORT BAR 23.56 EA 1* 53946 BLK URE IF 2014 2859 SC W/S FT 17* 54838 SILICONE SEALANT BLK DOW TU 1

53187-XU KITS* 8462 .194X.625X.125 BLK WASHER EA 45

WINDSHIELDSECTION 9


* NOT SHOWN


20REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

WINDSHIELDSECTION 9

SC9609A

21


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

1 53352 STBD SIDE CABIN WINDOW 2859SC EA 1STBD WING SECT I (FWD)

2 53351-04 FWD SIDE W/D GLASS SC EA 13 53351-06 AFT SIDE W/D GLASS SC EA 14 5741 SHALLOW STAN PRO FLOX SNG FT 34* 5745R-XU SLIDER LOCK ASSY EA 16 5743 AMESBURY PILE FT 3* 11100-XU WINDOW KNOB-BLACK PLASTIC EA 210 53353 SUPPORT BAR 16.0" EA 1* 53352-XS WINDOW SCREEN ASSY(STBD)* 928 SCRN 100X24 18X16.011 LF 4* 7005 SCREEN SPLINE .155 FT 10* 53351 PORT SIDE CABIN WINDOW 2859SC EA 1

PORT WING SECT I (FWD)* 53351-04 FWD SIDE W/D GLASS SC EA 1* 53351-06 AFT SIDE W/D GLASS SC EA 1* 5741 SHALLOW STAN PRO FLOX SNG FT 34* 5745L-XU SLIDER LOCK ASSY EA 1* 5743 AMESBURY PILE FT 3* 11100-XU WINDOW KNOB-BLACK PLASTIC EA 2* 53353 SUPPORT BAR 16.0" EA 1* 53351-XS WINOW SCREEN ASSY(PORT) EA 1* 928 SCRN 100X24 18X16.011 LF 4* 7005 CREEN SPLINE .155 FT 10

WINDSHIELDSECTION 9

SC9609B

* NOT SHOWN


22REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

BOAT ELEC WIRING* 61858 HARNESS/ FWD DECK (SC) 96 EA 1* 53907 HARNESS, DOCKSIDE 2859SC EA 1* 54036-A HARNESS,HARDTOP EA 1* D56303 PANEL ASSY, DOCKSIDE, 11OV/60HZ EA 1

CIRCUIT BREAKER PANEL1 56303 PANEL,BLANK,SHORE POWER EA 12 2883 5/8" DOMED HOLE PLUG EA 23 10740 5 AMP BRKR RED HNDL EA 14 10742 15 AMP BRKR RED HNDL EA 25 10743 20 AMP BRKR RED HNDL EA 16 10823 30 AMP DBL POLE BRKR-RED EA 17 11520 2 AMP BREAKER-RED EA 18 11521 POLARITY LIGHT EA 1* 11527 BUSS BAR 3 1/2" 5 HOLE EA 19 12869 RIVET BLACK D3001410604 .144-.154 EA 4* 33732 BUSS BAR ASSY 20 PRONG EA 1* 11533 6-32 HEX NUT EA 2* 10994 8 X 3/4 PPH BLK OX/SS EA 4* A53343-A PANEL ASSY, BATTERY SWITCH EA 1

SWITCH PANEL* 1625 10-24 NYLOCK NUT SS EA 4* 14970 10-24 X 1 PRH SS BLACK EA 4* 56838 BATTERY SWITCH, 1/2/BOTH/OFF EA 1* 53343 BATTERY SWITCH BOX-OVAL BASE EA 1* A50135 PANEL ASSY, MACERATOR EA 1

SWITCH PANEL* 10894 SWITCH SPST-OFF(ON) (HORN) EA 2* 50135 PANEL BLANK, MACERATOR EA 1* 13168 SNAP CAP-BLACK EA 2* 13169 COUNTERSINK WASHER - CLEAR EA 2

ELECTRICALSECTION 10

* NOT SHOWN

SC9610

23


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

* 14678 2 LIGHT-SWITCH PLATE ASSY EA 1PANEL ASSEMBLIES

* 13698 2 LIGHT SWITCH PLATE EA 1* 10893 SWITCH-SPST OFF-ON EA 2

INTERIOR LIGHTS* 61324 LIGHT,SURF MT./DRM WHT,SW/HALOG. EA 6* 56070 4"SURF MT.DRM.WHT DOME LT.W/SWT(86) EA 9

ELECTRICAL HARDWARE* 9015 COVER PLATE F/GFR EA 1* 51512 GROUND FAULT RECEPTACLE EA 1* 51628 WALL BOX F/GFI (FIBRE) EA 1* 61543 10 AMP 110VOLT BATTERY CHARGER EA 1* 36192 LOCK NUT F/36000 EA 1* 60784 STRAIN RELIEF FITTING EA 1* 1713 COVER PLATE EA 3* 1704 DUPLEX RECEP IVORY EA 3* 7090 WALL BOX EA 4* 232 BLANK PLATE EA 1* 274 POWER INLET 30AMP EA 1* 275 CORD W/RING 50'(30 AMP) EA 1* 60597 ZINC SAVER 30 AMP EA 1* 4685 12-10 GA 1/4" RING EA 1* 59206 WIPER MOTOR COVER,ABS,LT BEIGE EA 1

EXTERIOR LIGHTS* 31310 LIGHT STEP BLK EA 1* 56070 4"SURF MT.DRM.WHT DOME LT.W/SWT EA 4

NAV & ANCHOR LIGHTS* 53582 LIGHT NAV GREEN HORZ MOUNT EA 1* 53583 LIGHT NAV RED HORZ MOUNT EA 1* 1181 ANCHOR LITE M 50 EA 1

AUDIO VISUAL EQUIPMENT* 9622 ANALOG AM/FM STEREO CASS EA 1* 60262 SPEAKERS-WHITE 5 1/4" WS 34564 PR 1

WIPER ASSY* 57496 WIPER MOTOR EA 1* 53237 22" WIPER BLADE EA 1* 53238 20" WIPER ARM EA 1* 57497 PANTAGRAPH ADAPTER BLACK EA 1* 54432 WIPER MOTOR COVER ABS (WHITE) EA 1

ELECTRICALSECTION 10

* NOT SHOWN


24REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

CANVAS ASSEMBLY* 61685 H/T CRUISE CURTAIN 2859SC EA 1* 57669 CANVAS-SAND LY 3* 63204 PASKEL ZIPPER CHAIN YD 5* 63206 PASKEL ZIPPER SLIDE EA 2* 12293 1" GRAY NYLON WEBBING FT 4* 35631 AWNING RAIL INSERT-BLACK FT 6

SNAP ASSEMBLY* 81 SNAP BUTTON EA 28* 82 SNAP SOCKET EA 28* 83 SNAP STUD EA 2* 84 SNAP EYE EA 2* 11563 SMALL BASE CANVAS STUD EA 26

TURNBUCKLE ASSEMBLY* 88 TURNBUCKLE EYE EA 4* 89 TURNBUCKLE WASHER EA 4* 90 TURNBUCKLE STUD EA 4* 35562 CANVAS SLIDE TRACK-ANOD ALUM. FT 6

CANVASSECTION 11

* NOT SHOWN

Arl usmarine

Canvas is no longer available. Go to http://www.letastopshop.com

25


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

STEERING SYSTEM* 61034 16" WHEEL 3/4 TAPER 10 DEGREE EA 1* 61034-C STEERING WHEEL CENTER EA 1* 11958 STEERING HELM ASSY EA 1* 11959 90 DEG BEZEL KIT EA 1* 11962 FRICTION KNOB EA 1

ENGINE FUEL SYSTEM* 11992 FUEL FILL CHROME BRASS EA 1* 625 1-1/2FUEL FILL,1 1/2" FT 9* 34761 102 GAL FUEL TANK EA 1* 623 HOSE,FUEL VENT,5/8" FT 10* 1703 GAS TANK VENT EA 1* 32219 GAS FUEL WARNING LABEL-I/O & INBRD EA 1

ENGINE VENT SYSTEM* 60477 LOUVER WHITE /WHITE EA 4* 59663 COLLECTOR, 4" OVAL, 3" ROUND CUTOUT WS/59008 EA 2* 54608 FLANGE, 4" OVAL EA 1* 56772 BLOWER 4" SPECIAL EA 1* 279 HOSE VENT 4" FT 9* 7-322-3 FLANGE 3" WHITE PLASTIC EA 1* 322 HOSE VENT 3" FT 9

ENGINE AND CONTROL SYSTEMSECTION 12

* NOT SHOWN


26REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

HEAD/SHOWER ASSEMBLY1 SC1100102.05 HEAD ENTRY DOOR ASSEMBLY EA 12 930 RIM LATCH SET-NON KEYS EA 13 35734 LATCH SHIM BLK ABS W/ROVEL CAP EA 14 3669 2X2 CHROME BUTT HINGE EA 35 31737 T-TRIM 11/16" WHITE FT 326 58473 HEAD DOOR STOP, (1.25"X 73.75") EA 17 SC1100102.08 VANITY STORAGE DOOR EA 18 34579 GLASS DOOR LATCH/STRIKER EA 19 54534 HATCH RING 12X20" W/HINGE (HEAD STRG) EA 110 38379 BLACK FOAM SEAL (BULB LOC - AB) FT 1711 54517 CORNER EXTRUSION (OUTSIDE) EA 112 54518 CORNER EXTRUSION (INSIDE) EA 1* 55021 STRIP PRIVACY WHITE 69" EA 113 36553 TOWEL ROD 12"BRUSHED ALMNW/WHT END EA 114 36554 TOWEL ROD KIT - WHITE EA 115 6976 MIRROR 12X20X1/8 EA 116 3059 1/8" MIRROR HOLDER EA 617 35842 RECESSED TOILET PAPER HOLDER EA 118 7330 ALUMINUM BACKING PLATE EA 119 1180 SHOWER PUMP LABEL EA 120 2000 ILLUMINATED ROCKER SWITCH EA 121 53278 COMBO MIXER/SPRAY FAUCET EA 122 53280 WALL BRACKET, DREAM WHITE EA 123 13996 MARINE TOILET EA 124 344 4" X 1-1/2" SHOWER DRAIN EA 1* 54578 CABINET HEAD STORAGE (WHITE) EA 1* 54579 SHELF FOR HEAD CABINET EA 1* 83922 PLEX SLIDER DOOR EA 2* 6982 BLK PLASTIC FINGER PULL EA 2* 12317 SLIDER TRACK-TOP-2X1/8"BLACKX12' FT 3* 12318 SLIDER TRACK-BOTTOM-2X1/8"BLACKX12' FT 3

MODULESSECTION 13


* NOT SHOWN

27


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

MODULESSECTION 13

SC9613A


28REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

AFT BERTH ASSEMBLY1 SC2310501.08 HANGING LOCKER DOOR EA 12 31054 T-TRIM 11/16" LT BEIGE FT 63 55317 KNOB, BRASS/CHROME EA 14 #W1323-35 CLOSET POLE SOCKETS ST 15 6059 1 5/16" DOWEL LF 26 SC2310512 A/B ENTRY DOOR EA 17 57690 RIMLATCH-REVERSIBLE (A/B ENTRY DOOR) EA 18 35734 LATCH SHIM BLACK ABS EA 19 31054 EDGE MOLDING FT 1810 3669 2 X 2 CHROME BUTT HINGE EA 311 59420 UPPER PRIVACY STRIP EA 112 59420 LOWER PRIVACY STRIP EA 1

MODULESSECTION 13

SC9613B

29


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

MODULESSECTION 13

GALLEY ASSEMBLY1 SC1100101.17 GALLEY DOOR, 15" X 30-3/4" EA 32 31054 EDGE TRIM FT 253 SC1100101.15 GALLEY DRAWER EA 24 62879 12" METAL SLIDER PR 25 SC1100101.18 HANGING LOCKER DOOR EA 16 52973 CAM LOCK KIT (H/L DOOR) EA 1* #W1323-35 CLOSET POLE SOCKETS (H/L) ST 1* 6059 1 5/16" DOWEL (H/L) LF 27 60176 HINGE,SEMI CONCEALED EA 88 6199 NYLATCH ROLL CATCH W/STKR EA 49 56408 TEAK SEA-RAIL (COUNTER TOP TRIM) LF 511 55317 KNOB, BRASS/CHROME EA 412 31054 EDGE TRIMFT 6213 SC1100101.31 SHELF FIDDLE EA 1* SC2310217 MAGAZINE RACK EA 1* 7249 1/4" RND BAR SATIN FT 4

* NOT SHOWN

SC9613C


30REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

ENTRY DOOR ASSY1 SC1220501.01 STBD ENTRY DOOR EA 12 52098 1/2" ALUM. T-MOLD, 12' FT 123 SC1220501.02 PORT ENTRY DOOR EA 12 52098 1/2" ALUM. T-MOLD, 12' FT 124 3669 2X2 CHROME BUTT HINGE EA 65 1199 #1 HOOK DOOR SHORT EA 16 55018 STRIP PRIVACY WHITE 50" EA 1* 1937 CHROME EDGE TRIM, 7/16" FT 187 6110 ENTRY HATCH, BI-FOLD EA 1* 4030 BLACK HINGE EA 3* 25464 BARREL NUT EA 12* 57516 5/8 PFH W/PATCH EA 128

8 52973 CAM LOCK KIT EA 29 3669 2X2 CHROME BUTT HINGE EA 210 52464 8-32 X 3/16 BARREL NUT EA 411 12970 8-32 X 1/2 PFH S/S BOLT EA 4* 1199 #1 HOOK DOOR SHORT EA 1* 39212 BLACK CANVAS WATER SEAL FT 6

MODULESSECTION 13

SC9613D

* NOT SHOWN

31


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

FRESH WATER SYSTEM1 11993 WATER FILL CHROME BRASS EA 1* 13120 POTABLE WATER WARNING LABEL EA 12 1300 FILL HOSE 1.5" WHITE VINYL FT 113 13192 1.5" 90D NYLON MALE ADAPTER EA 14 9542 35 GAL WATER TANK EA 15 4P-MP-IN9E 1/2 90D PL IN M ADP EA 16 1271 VENT HOSE, 9/16" FT 87 1703 WATER TANK VENT EA 18 57897 H2O HOSE 5/8" BLUE STRP. FT 49 52123 ELBOW 1/2"NPT X 1/2" FLAIR EA 1* 50912 1/2 FL X 1/2 MPT 90DEGREE ELBOW EA 1* 50911 1/2 X 1/2 FL 90DEGREE ELBOW EA 110 39974 FRESH WATER PUMP W/FILTER EA 111 51896 STRAIGHT FEMALE ADAPTER (OUT OF PUMP) EA 112 57897 H2O HOSE 5/8" BLUE STRP. FT 113 50915 1/2 X 1/2 X 1/2 FL TEE EA 114 51074 1/2" DRAIN CAP EA 115 57897 H2O HOSE 5/8" BLUE STRP. FT 516 50915 1/2 X 1/2 X 1/2 FL TEE EA 117 57897 H2O HOSE 5/8" BLUE STRP. FT 418 50915 1/2 X 1/2 X 1/2 FL TEE EA 119 57897 H2O HOSE 5/8" BLUE STRP. (TO HEAD-COLD) FT 320 51896 STRAIGHT FEMALE ADAPTER EA 121 57897 H2O HOSE 5/8" BLUE STRP. FT 122 51896 STRAIGHT FEMALE ADAPTER EA 123 57897 H2O HOSE 5/8" BLUE STRP.5/8 PLYBUTYLENE PIPE FT 1724 52123 ELBOW 1/2"NPT X 1/2" FLAIR EA 125 52123 ELBOW 1/2"NPT X 1/2" FLAIR EA 126 57898 H2O HOSE 5/8" RED STRP.2500/5000 FT 1727 50915 1/2 X 1/2 X 1/2 FL TEE EA 128 57898 H2O HOSE 5/8" BLUE STRP. (TO HEAD-HOT) FT 329 51896 STRAIGHT FEMALE ADAPTER EA 130 57898 H2O HOSE 5/8" BLUE STRP.(TO GALLEY) FT 431 51896 STRAIGHT FEMALE ADAPTER EA 1* 31078 CHROME BAR FAUCET( GALLEY) EA 1* 53278 COMBO,MIXER SPRAY,DREAM WHITE (HEAD) EA 1* 53280 BRACKET, WALL DREAM WHITE EA 132 1307 1/2" CHECK VALVE EA 133 54379 HEATER WATER 6 GALLON EA 1* 1305 1/2" COUPLING EA 134 53012 AAPTER DRAIN GARDEN HOSE TO FLAIR EA 135 57898 2O HOSE 5/8" BLUE STRP. FT 4* 7330 BACKING PLATE-ALUM SWITCH EA 1* 2000 ILUM ROCKER SWITCH EA 1* 1179 WATER PUMP LABEL EA 1

PLUMBING AND FIXTURESSECTION 14


* NOT SHOWN


32REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9614A

33


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

MARINE HEAD SYSTEM-AFT1 57223 SEA STRAINER EA 12 14486 3/4" BRZN THRU HULL CONN EA 13 14791 3/4" SEACOCK EA 1* 13229 HEAD PICK-UP LABEL UN1M EA 14 31229 3/4" BRBX3/4"MIPT W/1.5" BARB EA 15 1115 SFTWL H2O HOSE 3/4" FT 8* 13996 LEFT-HAND MARINE HEAD EA 16 13706 1-1/2" SANITATION HOSE FT 47 13190 1.5" NYLON STRAIGHT MALE ADAPTER EA 18 54054 HOLDING TANK, 30 GALLON EA 19 4P-MP-IN9E 1/2 90D PL IN M ADP EA 110 1271 VENT HOSE, 9/16" FT 611 1703 HOLDING TANK VENT EA 112 13192 1.5" 90D NYLON MALE ADAPTER EA 113 13706 1-1/2" SANITATION HOSE FT 214 4278-A MACERATOR PUMP W/BARB EA 115 12791 1" SANITATION HOSE FT 316 6637 THRU HULL PLAS 1" EA 117 13192 1.5" 90D NYLON MALE ADAPTER EA 118 13706 1-1/2" SANITATION HOSE FT 519 11995 DECK WASTE FITTING BRASS EA 1



* NOT SHOWN


34REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9614B

SC9614C

35


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

MIDSHIP BILGE PUMP SYSTEM1 61039 500 GPH BILGE PUMP EA 12 55609 3/4" BLACK BILGE HOSE FT 83 708 THRU HULL PLAS 3/4" EA 1

AFT BILGE PUMP SYSTEM4 60249 FLOAT SWITCH EA 15 61165 BILGE PUMP 1000 GPH EA 16 55609 3/4" BLACK BILGE HOSE FT 97 3186 LOOM CLAMP EA 68 708 THRU HULL,PLAS 3/4" EA 1

SHOWER DRAIN SYSTEM-AFT* 344 4"X1 1/2" SHWR DRAIN EA 19 4790-E DRAIN ELBOW ONLY EA 110 57544 DRAIN SLIP NUT EA 1* 57545 WASHER EA 111 1115 SFTWL H2O HOSE 3/4" FT 412 50900 PUMPGUARD IN-LINE STRAINER EA 113 1115 SFTWL H2O HOSE 3/4" FT 114 13661 3/4 IN X 1/2 MIP PLS REDUCER EA 115 1399 1/2" FEMALE COUPLING EA 1* 1306 1/2"X3/8" COUPLING EA 116 6893 3.0 GPM SHOWER PUMP EA 117 1306 1/2"X3/8" COUPLING EA 1* 1399 1/2" FEMALE COUPLING EA 118 13661 3/4 IN X 1/2 MIP PLS REDUCER EA 119 1115 SFTWL H2O HOSE 3/4" (TO THRU-HULL) FT 9* 708 THRU HULL PLAS 3/4" EA 1* 7330 BACKING PLATE-ALUM SWITCH EA 1* 2000 ILUM ROCKER SWITCH EA 1* 1180 SHOWER PUMP LABEL EA 1


* NOT SHOWN

SC9614D

ADDITIONALDRAWINGS ONFOLLOWING PAGE.


36REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9614E

SC9614F

37


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

HEAD SINK DRAIN SYSTEM* 57543 2" S/S SINK STRAINER EA 1* 4790-E DRAIN ELBOW EA 1* 57544 DRAIN SLIP-NUT EA 1* 57545 WASHER EA 1* 1115 DRAIN HOSE 1.5" WHITE VINYL FT 1* 708 THRU HULL PLAS 3/4" EA 1

GALLEY SINK DRAIN SYSTEM1 36267 SINK SINGLE DEEP 3 1/2" DRAIN EA 12 36339 3 1/2" WHITE PLAST DRAIN EA 13 59246 WASTE ARM 1.5 X 9" (CUT TO LENGTH) EA 1* 57545 WASHER EA 14 1300 DRAIN HOSE 1.5" WHITE VINYL FT 15 709 THRUHULL PLAS 1.5" EA 1

DECK DRAIN SYSTEM* 8492 THRU-HULL,REV FLANGE 1 1/2"(STEP DRAIN) EA 1* 58927 ADAPTER,FEMALE,NYLON 1.5" 90 DEG EA 1* 1300 DRAIN HOSE 1.5" WHITE VINYL FT 3* 709 THRUHULL PLAS 1.5" EA 16 8492 THRU-HULL,REV FLANGE 1 1/2" EA 47 1300 DRAIN HOSE 1.5" WHITE VINYL FT 68 11394 T-HULL FITTING,1.5"W/SCUPPER EA 4

FISH WELL DRAIN SYSTEM9 1372 THRU HULL 3/4 90 DEG EL EA 110 1272 HOSE-3/4" ID X 1" OD FT 111 708 THRU HULL PLAS 3/4" EA 1


* NOT SHOWN

SC9614G


38REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

MANUALS-PLEASE ORDER THROUGH CUSTOMER SERVICE (360)435-8957

* 60901 OWNERS MANUAL-96 CIERA CRUISER EA 1

MANUFACTURING SUPPLIESSECTION 15

* NOT SHOWN

39


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

BULKHEAD OPTION SC (OBG)DECK HARDWARE

* 54576 END CAP STBD WINDOW W/BLHD EA 1* 54577 END CAP PT WINDOW W/BLHD EA 1

WINDSHIELD SYSTEM1 54646 AFT BULKHEAD EA 12 K-5168 BUMPER EA 1* 55058 FILLER PLATE EA 13 54646-20 BULKHEAD GLASS GRAY STB UPPER EA 14 54646-21 BULKHAD GLASS GRAY STB BTM EA 15 54646-22 BULKHEAD GLASS GRAY PORT EA 16 54650 AFT BULKHEAD DOOR 2859SC EA 17 54650-20 AFT DOOR GLASS GRAY BTM EA 18 54650-21 AFT DOOR GLASS GRAY TOP EA 1* 9109 YACHT FRONT PANEL VINYL FT 16* 52850 5/16 ROUND BUTYL FT 16* 36266 AFT BULKHEAD HINGE 40" S/S EA 1* 53787 DOOR LOCK KIT LEVER HANDLES EA 1* 53879 6-32 X 3/8 PFH SS SCREW EA 5* 53956 STRIKE PLATE BLOCK EA 1* 53955 HINGE BLOCK EA 3* 35903 D-SHAPE SCREW COVER EA 1* 38013 DOOR STOP 1" EA 1* 53954 3.0" S.S. HINGE EA 39 32244 1" BLACK NYLON WEBBING YD 110 53957 SOCKET—FASNAP EA 111 53959 CAP—FASTSNAP EA 112 53958 STUD—FASNAP EA 2

FACTORY OPTIONSSECTION 16

* NOT SHOWN

SC9616


40REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

220V/50HZ ELECTRICAL CONVERSION(OVA)BOAT ELEC WIRING

* E56303 PANEL ASSY, 220 DOCKSIDE EA 1CIRCUIT BREAKER PANEL

* 2883 5/8" DOMED HOLE PLUG EA 2* 10740 5 AMP BRKR RED HNDL EA 1* 10741 10 AMP BRKR RED HNDL EA 3* 11520 2 AMP BREAKER-RED EA 1* 11521 POLARITY LIGHT EA 1* 11527 BUSS BAR 3 1/2" 5 HOLE EA 1* 11531 6-32 X 1/4 PRH BLACK OX/SS EA 9* 12869 RIVET BLACK EA 4* 33732 BUSS BAR ASSY 20 PRONG EA 1* 35398 15 AMP DBL POLE BRKR RED EA 1* 56303 PANEL BLANK, DOCKSIDE (CRUISER) EA 1* 61543 10 AMP., 110 VOLT BATTERY CHARGER EA 1

HULL INT ASSY HARDWARE* 59493 REFERIGERATOR 220V EA 1* 34864 ALCHL ELCT STVE GLASS TOP 220V/50H EA 1

HULL INT LABELS* 35034 LABEL 220 VAC 50HZ EXPORT EA 1

ELECTRICAL HARDWARE* 34866 CORD W/RING 50’16AMP 220V/50HZ EA 1* 34865 POWER INLET 16AMP 220V/50H EA 1* 232 BLANK PLATE EA 4

FRESH WATER SYSTEM* 54472 HEATER WATER 6 GAL 22OV EA 1

FACTORY OPTIONSSECTION 16

* NOT SHOWN

41


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

DEALER INSTALLED OPTIONSSECTION 17

OPTION: ELECTRIC WIPER,PORT* 57496 WIPER MOTOR ASSY EA 1* 53237 22" WIPER BLADE EA 1* 53238 20" WIPER ARM EA 1* 57497 PANTAGRAPH ADAPTER BLACK EA 1* 54432 WIPER MOTOR COVER ABS (WHITE) EA 1

OPTION: CABIN HEAT (FRESH WATER COOLING REQUIRED)1 14790 1/2" BALLVALVE EA 12 1114 SOFT WALL WATER HOSE,5/8" EA 13 1181-EC MALE ADAPTER EA 14 1532 HOSE CLAMP EA 1* 3667 HEATER SWITCH SPDT ON-OFF ON EA 1* 3668 HEATER LABLE EA 1* 55949 HEATER,2 FAN EA 1

NOTE: ON MODELS WITH ELECTRIC WATER HEATER, ORDER ADDITIONAL PARTS BELOW.(FRESH WATER COOLING REQUIRED.)

3 1181-EC MALE ADAPTER,5/8" BRB X 1/2" MIP EA 14 1532 HOSE CLAMP,1 3/8" EA 16 4G-T GALVANIZED TEE,1/2" EA 1

* 58552 HOUR METER EA 1

* 34743-B OUTBOARD MOTOR BRACKET EA 1* 52874 MOTOR BRACKET SHIM EA 1

* NOT SHOWN

DRAWING ON FOLLOWING PAGE


42REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

DEALER INSTALLED OPTIONSSECTION 17

SC9617

43


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95

ENGINE OPTIONSSECTION 18


5.7L BRAVO II 2.2/1 ENGINE OPTION (EK8)HULL BASIC HARDWARE

* 58351 1" ACOUSTICAL FOAM LF 7* 4354 2" WIDE ALUM TAPE RL 1

BOAT ELEC WIRING* 61860 PANEL ASSY, DASH SC GAS EA 1

FUSE BLOCK* 31265 5 AMP FUSE EA 1* 31266 7.5 AMP FUSE EA 2* 31267 10 AMP FUSE EA 12* 31268 15 AMP FUSE EA 2* 31269 20 AMP FUSE EA 1* 52096 18 PLACE FUSEBLOCK EA 1

GAUGE PANEL1 58546 SPEEDOMETER EA 12 58550 VOLTMETER EA 13 58549 FUEL GAUGE EA 14 58543 TACH I/O EA 15 58547 OIL PRESS GAUGE EA 16 58548 TEMP GAUGE EA 17 57936 PANEL BLANK, INST./SWITCH EA 18 10893 SWITCH-SPST OFF-ON EA 109 10894 SWITCH SPST-OFF(ON) (HORN) EA 110 50606 IGNITION SWITCH FOR I/O EA 111 10896 SWITCH-SPDT ON-ON EA 1* 13168 SNAP CAP-BLACK EA 2* 13169 COUNTERSINK WASHER - CLEAR EA 2* 61895 HARNESS, ENG/ACCY EA 1* 54040 CABLE KIT, BATTERY EA 1

ENGINE SYSTEMS* 54710 5.7L MERC BRAVO II 2.2 EA 1* 51728 18 -1/4 X 19 PROP EA 1* 36315 3" EXHAUST RISER EXTENSION KIT KT 1* 36617 RISER ELBOW KIT 5.0/5.7 LITRE EA 1

SHIFTER & CONTROL CABLE* 61660 MERCRUISER I/O SHIFTER EA 1* 33727 17' KM CONTROL CABLE (THROTTLE) EA 1* 34436 18' KM CONTROL CABLE (SHIFTER) EA 1

STEERING SYSTEM* 11950 17' (RX-4) STR CABLE EA 1

ENGINE FUEL SYSTEM* 694-EC 3/8BRB X 1/4MIP BRS M ADP EA 1* 624 HOSE,FUEL FEED,3/8" FT 4

* NOT SHOWN


44REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9618A

45


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95


D4.2L BRAVO II(ED8)HULL BASIC HARDWARE

* 58352 1" SOUND BOARD W/VINYL BACK SF 20* 12777 TAPE FOR SOUND BOARD RL 1

BOAT ELEC WIRING* 61862 PANEL ASSY, DASH SC DIESEL EA 1


GAUGE PANEL1 58546 SPEEDOMETER EA 12 58550 VOLTMETER EA 13 58549 FUEL GAUGE EA 14 58544 TACH, 4-6-8 CYL- EA 15 58547 OIL PRESS GAUGE EA 16 58548 TEMP GAUGE EA 17 58403 PANEL BLANK, INST./SWITCH EA 18 10893 SWITCH-SPST OFF-ON EA 109 10894 SWITCH SPST-OFF(ON) (HORN) EA 110 10896 SWITCH-SPDT ON-ON EA 111 50606 IGNITION SWITCH FOR I/O EA 112 13224 DC RED INDICATER LIGHT -LOW EA 1* 61861 HARNESS, ACCESSORY SC DIESEL EA 1* 54041 CABLE KIT, BATTERY EA 1

* NOT SHOWN



46REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95


SC9618B

47


REVISED: 3-4-96

2859 SC 1996

PUBLISHED: 5-30-95


D4.2L BRAVO II(ED8) CONT'DENGINE SYSTEMS

* 58421 D 4.2 BRAVO 2 2.00:1 RATIO EA 1* 51728 18-1/4 X 19 PROP EA 1

SHITER & CONTROL CABLE* 61660 MERCRUISER I/O SHIFTER EA 1* 33727 17' KM CONTROL CABLE EA 1* 34436 18' KM CONTROL CABLE EA 1


ENGINE FUEL SYSTEM* 694-EC 3/8BRB X 1/4MIP BRS M ADP EA 1* 11994 DIESEL FILL CHROME BRASS EA 1* 13370 RACOR 225R FUEL FILTER EA 1* 1743 BRS 1/4" FUEL SHUTOFF VLV EA 1

ENGINE WATER PICKUP SYS13 57223 SEA STRAINER EA 114 39576 1-1/4" BALL VALVE EA 1* 39575 1-1/4" CLOSE BRASS NIPPLE EA 1* 58274 1 1/4" MPTX 1/2" BARB, BRONZE EA 1* 39576 1 1/4" BALL VALVE EA 115 1510 90 DEG TAIL PIECE EA 1* 39575 1 1/4" CLOSE BRASS NIPPLE EA 116 32838 1-1/2" HARDWALL WATER HOSE FT 317 2756 PIPE ADP BRB 11/4X11/4MPS EA 118 order from Mercruiser 1 1/2 SEA STRAINER EA 119 32838 1-1/2" HARDWALL WATER HOSE FT 3

* NOT SHOWN

REFER TO DRAWING ON PREVIOUS PAGE.


48REVISED: 3-4-96

2859 SC 1996

PUBLISHED:5-30-95

7.4L BRAVO II MERC. STRNDRV 300HP (E84)HULL BASIC HARDWARE

* 58351 1" ACOUSTICAL FOAM LF 7* 4354 2" WIDE ALUM TAPE RL 1

BOAT ELEC WIRING* 61860 PANEL ASSY, DASH SC GAS EA 1


GAUGE PANEL1 58546 SPEEDOMETER EA 12 58550 VOLTMETER EA 13 58549 FUEL GAUGE EA 14 58543 TACH, I/O EA 15 58547 OIL PRESS GAUGE EA 16 58548 TEMP GAUGE EA 17 57936 PANEL BLANK, INST./SWITCH EA 18 10893 SWITCH-SPST OFF-ON EA 109 10894 SWITCH SPST-OFF(ON) (HORN) EA 110 50606 IGNITION SWITCH FOR I/O EA 1

13168 SNAP CAP-BLACK EA 2* 13169 COUNTERSINK WASHER - CLEAR EA 2* 61859 HARNESS, ENG/ACCY 2859SC GAS EA 1* 6164 SPEEDO HOSE .28ODX.16ID FT 29

ENGINE SYSTEMS* 34100 300HP-MOD. 330 MERC BRAVO II ENG,SD EA 1* 51728 18-1/4 X 19 PROP EA 1* 54201 3" EXHAUST RISER EXTENSION KIT KT 1* 36618 RISER ELBOW 7.4 LITRE V-8 EA 1

SHIFTER & CONTROL CABLE* 61660 MERC SHIFTER M/C TRIM/TRAILER EA 1* 33727 17' KM CONTROL CABLE EA 1* 34436 18' KM CONTROL CABLE EA 1


ENGINE FUEL SYSTEM* 694-EC 3/8BRB X 1/4MIP BRS M ADP EA 1* 624 HOSE,FUEL FEED,3/8" FT 4* 2BE-9SE 1/4 90 D BRS ST EA 1

REFER TO DRAWING ON PAGE 44.

* NOT SHOWN


TABLE OF CONTENTS 2859 SC 1996 - Bayliner

Documents

Transcript of TABLE OF CONTENTS 2859 SC 1996 - Bayliner