substation - PBE Group© · • Substation 0 – 66kV Integral Energy Supply Point • Substation 1...
Transcript of substation - PBE Group© · • Substation 0 – 66kV Integral Energy Supply Point • Substation 1...
Specific Services Include:
• Design• Electrical Engineering• Structural Engineering• PLC/SCADA Design• Project Management• Reticulation Systems• Communications Cabling• Earthing System Design & Testing• Switchroom Manufacture• Substation Construction• Commissioning
This project included the design, construction and commissioning of the following;
• 33/11kV 20MVA Substation• 11kV/433V Substations around the site• 11kV Switchrooms• 11kV Cabling• Communications Cabling
The switchrooms were designed and manufactured at ourTomago Facility, transported to site and craned into position.The benefits of this concept include;
• minimal site works• completely tested off site• re-locatable
Abel Mine for Donaldson Coal
substation
www.pberutherford.com.au
p. +61 (0)2 4961 9619f. +61 (0)2 4964 861139 Laverick Avenue, Tomago, NSW, [email protected]
Specific Services Include:
substations
• Electrical Engineering
• Structural Engineering
• PLC/SCADA Design
• Project Management
• Electrical Installation
• Earthing System Design & Testing
• Switchroom Manufacture
• Commissioning
Airly Colliery Substations 0, 1 & 2
Centennial Coal
This project included the design, constructionand commissioning of the following substations;• Substation 0 – 66kV Integral Energy Supply Point
• Substation 1 – 66/11kV 16MVA Substation
• Substation 3 – 11kV/433V 2.5MVA Substation
These substations were all designed and manufactured as modular units at our Tomago Facility, transported to site and craned into position.
The benefits of this concept include;• minimal site works
• safe and easy access for ongoing maintenance
• re-locatable
www.pberutherford.com.au
p. +61 (0)2 4961 9619f. +61 (0)2 4964 861139 Laverick Avenue, Tomago, NSW, [email protected]
Angus Place East – Centennial Coal
Value: $14M
Duration: 16 Months
Purpose:
Angus Place Colliery established new electrical supply
infrastructure and a ventilation facility for the underground
mine extension known as Angus Place East. The new
facility provided the underground longwall operation with
improved ventilation and electrical supply through surface
to seam shafts and boreholes. The Angus Place Mine is
owned by Centennial Coal in joint venture with SK Kores
Australia Pty Ltd and is operated by Centennial Angus Place.
PBE Rutherford was appointed as
Principal Contractor to Centennial Angus
Place for the design, supply, construction,
testing, commissioning and handover of
the Angus Place East Ventilation Facility
Electrical Infrastructure. This included
a 66kV connection to the Endeavour
Energy 66kV network through to the 11kV
underground switchboard that powers
the mine. The project was based in the
remote location on the Newnes Plateau
near Lithgow.
Scope:
www.pberutherford.com.au
p. +61 (0)2 4961 9619f. +61 (0)2 4964 861139 Laverick Avenue, Tomago, NSW, [email protected]
Project Highlights:
• ASP1 contestable works involving the augmentation of the existing 66kV overhead Endeavour Energy infrastructure for the 66kV connection point.
• 66kV Metering and Switching Station including liaison with the electricity retailer and metering provider (Sub 0).
• 4.5km of buried 66kV transmission lines including dual fibre optic communications.
• 66/11kV Transportable 15MVA Substation (Sub 1).
• 1km of buried dual 11kV transmission lines including dual fibre optic communications.
• 11kV distribution switchroom including 1.5MVA kiosk transformer for surface supply’s and dual PFC Units (Sub 2).
• 11kV underground feeder cables via two 380m deep boreholes suspended from surface to seam including all communication cables.
• 11kV underground distribution panel and remote operating facilities including the ability to back feed to Sub 2 in the event of emergency (Sub 3).
• Fully integrated and comprehensive communication system allowing full diagnostics and remote operation.
www.pberutherford.com.au
p. +61 (0)2 4961 9619f. +61 (0)2 4964 861139 Laverick Avenue, Tomago, NSW, [email protected]
Specific Services Include:
• Design• Electrical Engineering• Structural Engineering• PLC/SCADA Design• Project Management• Reticulation Systems• Communications Cabling• Earthing System Design & Testing• Switchroom Manufacture• Substation Construction• Commissioning
This project included the design, construction and commissioning of the following;
• 66/11kV 20MVA Substation• 11kV/433V Substations around the site• 11kV Switchrooms• 11kV Cabling• Boxcut Earthing Compound• Communications Cabling
The switchrooms were designed and manufactured at ourTomago Facility, transported to site and craned into position.The benefits of this concept include;
• minimal site works• completely tested off site• re-locatable
Narrabri Mine Stage 1 & 2 for Whitehaven Coal
substation
www.pberutherford.com.au
p. +61 (0)2 4961 9619f. +61 (0)2 4964 861139 Laverick Avenue, Tomago, NSW, [email protected]