SUB-1729 PG1...insert grillcraft mesh grille into the grille shell from the front side as shown....
1
2005-2007 SUBARU LEGACY 2005-2007 SUBARU LEGACY UPPER GRILLE KIT UPPER GRILLE KIT INST INSTALL ALL REMOVE PLASTIC FASTNERS AND BOLTS ALONG THE TOP OF THE UPPER GRILLE. NEXT RELEASE PLASTIC GRILLE CLIPS USING A FLAT SCREWDRIVER AND REMOVE GRILLE FROM VEHICLE. 2 1 5 6 3 4 TAPE OFF THE CHROME TRIM ON THE GRILLE IN ORDER TO HELP ELIMINATE SCRATCHING THE CHROME. NEXT CUT THE GRILLE CENTER OUT. A VIEW OF THE GRILLE SHELL AFTER GRINDING THE BACKSIDE FLUSH. TAPE A STRAIGHT LINE ON THE BACK SIDE OF THE GRILLE SHELL AND GRIND THE PLASTIC FLUSH. INSERT GRILLCRAFT MESH GRILLE INTO THE GRILLE SHELL FROM THE FRONT SIDE AS SHOWN. MARK MOUNTING TAB CENTER HOLES. SAND THE GRILLE SHELL CENTER USING A SCOTCH BRITE PAD. NEXT PAINT THE GRILLE SHELL CENTER USING FLAT BLACK SPRAY PAINT “ JUST A LITE COAT” PART# SUB-1729 (3) #8 X 5/8 Hex Screws (3) #8 “Flat” Nuts 7 8 FASTEN GRILLCRAFT GRILLE TO THE FACTORY GRILLE SHELL USING SUPPLIED HARDWARE. DRILL HOLES FOR THE MOUNTING SCREWS USING 3/16 INCH DRILL BIT. For further installation details check our website installs Tel:310-970-0300 Fax:310-970-0400 www.grillcraft.com 2 0 05-2007 SUBARU L L L L L E E E E G G GA A A C C C CY Y Y Y Y Y 2 2 2 2 2 0 0 0 0 0 05-2007 SUBARU L E G G GA A A A A C C C C CY Y Y Y 2 2 2 2 2 2 2 0 0 0 0 0 05 - 2007 SUBARU L L L L L L E E E E E E E G G G G G G GA A A A A A C C C C C CY Y Y Y Y Y Y Y 2 2 2 2 2 0 0 0 0 0 05-2007 SUBARU L L L L L E E E E E G G G G GA A A A A C C C C CY Y Y Y Y UPPE R R R R R G G G GR R R RI L LE K K K K I I I T T T T UPPE R G G G GR R R RI L LE K I T T T T T UPPE R R R R R G G G G G G GR R R R R RI I I I LLE K K K K K K I I I I I T T T T T T T T UPPE R R R R G G G G GR R R R RI I I I LLE K K K K K I I I I I T T T T T I N N NS S S S S S T T T T T I I I I N N N NS S S S T T T T T I I I N N N N N N NS S S S S S S T T T T T T I I I I N N N N NS S S S S T T T T T A LL T T A A A A A L L L L L T T T T T T T T T T T T T A A A A A A LL A A A A A LL T T T T T REMOVE PLASTIC C C FAS FAS FAS FAS FA TNE TN TNE TNE TNERS RS RS RS R AND AND AND AND N BO B B B B LTS ALONG ONG ONG ONG ONG TH TH TH TH HE T ET E T E T E OP OF THE UPPER GR GR GR GR GRILL ILL ILL ILL L E E E. E E NEX NEX NEX NEX E T R T R T R T R T REL EL ELE EL EL ASE PLASTIC C C C GRI GRI GRI GR GR G L L LLE L L CLIPS USING A FL A FL A FL A FL FLAT AT AT AT AT SCR SCR SCR SCR SCREWD EWD EWD EWD EWDRIV RIV RIV RIV RIVER AND REMOVE GRILLE FROM VEHICLE. TAP P AP AP AP APE O E O EO E O E OFF FF FF FF F TH H THE TH H CHROM M M M ME T E T E T E T E E TRIM RIM RIM RIM RIM ON ON ON ON TH TH TH TH THE G EG E G E G EGRILLE IN ORDER TO HEL HEL HEL HEL HELP EL PE P EL P EL P ELIMI IM IM IM M NAT NA NA NA NA NA E SCRA RA RA RA RATCH TCH TCH TCH TCHING ING ING ING ING TH TH TH TH THE C E E E E HROME. NEXT CUT TH TH TH TH TH T E E E E E GRI RI RI RILLE LLE LLE LLE LLE CE CE CE CE CEN N NTE N N R OUT. A VIEW EW EW W W OF OF OF OF OF THE THE THE E THE GR GR GR GR G ILL ILL ILL ILL LLE E E S E E HELL AFTER GR R R R RIN IN IND IN N ING THE BAC B BA BA B KSIDE FLUSH. TAPE A E A E A A A STR STR STR STR STRA AIG A A HT LINE O O O O ON T N T N T N T NTHE HE HE HE HE BAC BAC BAC BAC BA K S K S KS S K SIDE IDE IDE IDE ID OF THE GRILLE SH SH SHE S SH L L LL A L ND GRI GRI GRI GRI GR ND ND ND ND ND THE THE THE THE HE PL PL PL PL PLAST AS AS AS A IC FLUSH. INS INS INS INS NSERT ERT ERT ERT GR G GR GR G IL L LL L CRAFT T T T T MES MES MES MES MESH G HG H G H G H GRIL RIL RIL RIL RI LE LE LE LE LE I I INT I I O THE GRILLE SHELL ELL ELL ELL ELL FRO FRO FRO FRO FROM M M T M M HE HE HE HE HE E FRO F NT SID SID SID SID SIDE A E A E A E A E E S S S S S S SS SS SHO HO HO HOW HO N. MARK MOUNTIN N N NG T GT G T GT G AB AB AB AB AB CEN CEN CEN EN CENTER TE TE TE TE HOLES. SAND THE GRILLE LLE LLE LLE LLE SH SH SH SH SH S ELL ELL ELL ELL ELL CEN CEN CEN CEN CENTE TE TER TE TE USING AS AS AS AS SCOT COT COT COT COTCH CH CH CH CH BRITE PAD. NEXT T T T T PA PA PA PA PAINT INT INT INT TH TH TH THE G E G E G EG EGRIL RIL RIL RIL RILL L LE L L SHELL CENTER ER ER ER ER R USI U U U NG FLAT BLA BLA BLA BLA BLACK K CK CK CK SPR SPR SPR PR SP AY P AY P AY P AY P AY PAIN A T “ JUST A LITE COAT” PART# SUB-17 7 7 7 72 2 2 2 29 9 9 9 9 (3) #8 X X X X X 5 5 5 5 5 5/8 /8 /8 /8 /8 H H H Hex e e Screw w w w ws s s s s (3) ) ) ) ) #8 #8 #8 #8 #8 8 “ “ “ “ “Fl Fl Fl l Flat a at at at” ” ” ” N Nu N N N N ts FASTEN GR GR GR GR GRILL ILL ILL ILLCRA CRA CRA CRA CRAFT T FT T FT GRI GRI GRI GRI GRILLE LL LL LL LL TO THE FACTORY RY RY RY Y R GRILLE SHELL USI USI USI USI USING NG NG NG NG S S SUP S PLIED HARDWARE. DRILL H H H H HOLE OLE OLE OLE OL S F S S S OR THE MO O O OUNT UNT UNT UNT UNTING ING ING ING SC SC SC S REW REW REW REW REWS S S U S SING 3/16 INCH DRI DRI DRI DRI DRILL B LL B LL B LL B BIT. T IT. IT. For further in n n n nst st st st st s al al al al alla la la lati ti ti ti t on on on on on d d d d det e e e e ails che e e eck ck ck ck ck o o o o our website ins ns s s nsta ta ta ta tall ll ll ll ls s s s Te Te Te Te Tel: l: l: l: l:31 31 31 31 310- 0- 0- 0- 0-97 97 97 97 970 0 0- 0 0 0300 Fax:310-970-0400 0 0 0 0 www.grillc c c cra ra ra ra raft ft ft ft ft.c . . . om
Transcript of SUB-1729 PG1...insert grillcraft mesh grille into the grille shell from the front side as shown....
2005-2007 SUBARU LEGACY2005-2007 SUBARU LEGACYUPPER GRILLE KITUPPER GRILLE KIT INSTINSTALLALL
REMOVE PLASTIC FASTNERS AND BOLTS ALONG THE TOP OFTHE UPPER GRILLE. NEXT RELEASE PLASTIC GRILLE CLIPSUSING A FLAT SCREWDRIVER AND REMOVE GRILLE FROM
VEHICLE.
21
5 6
3 4
TAPE OFF THE CHROME TRIM ON THE GRILLE IN ORDER TOHELP ELIMINATE SCRATCHING THE CHROME. NEXT CUT THE
GRILLE CENTER OUT.
A VIEW OF THE GRILLE SHELL AFTER GRINDING THEBACKSIDE FLUSH.
TAPE A STRAIGHT LINE ON THE BACK SIDE OF THE GRILLESHELL AND GRIND THE PLASTIC FLUSH.
INSERT GRILLCRAFT MESH GRILLE INTO THE GRILLE SHELLFROM THE FRONT SIDE AS SHOWN. MARK MOUNTING TAB
CENTER HOLES.
SAND THE GRILLE SHELL CENTER USING A SCOTCH BRITEPAD. NEXT PAINT THE GRILLE SHELL CENTER USING FLAT
BLACK SPRAY PAINT “ JUST A LITE COAT”
PART# SUB-1729(3) #8 X 5/8 Hex Screws(3) #8 “Flat” Nuts
7 8FASTEN GRILLCRAFT GRILLE TO THE FACTORY GRILLE SHELL
USING SUPPLIED HARDWARE.DRILL HOLES FOR THE MOUNTING SCREWS USING 3/16 INCH
DRILL BIT.
For further installation details check our website installsTel:310-970-0300 Fax:310-970-0400
www.grillcraft.com
2005-2007 SUBARU LLLLLEEEEGGGAAACCCCYYYYYY222220000005-2007 SUBARU LEGGGAAAAACCCCCYYYY22222220000005-2007 SUBARU LLLLLLEEEEEEEGGGGGGGAAAAAACCCCCCCYYYYYYYY222220000005-2007 SUBARU LLLLLEEEEEGGGGGAAAAACCCCCYYYYYUPPERRRRR GGGGRRRRILLE KKKKIIITTTTUPPER GGGGRRRRILLE KITTTTTUPPERRRRR GGGGGGGRRRRRRIIIILLE KKKKKKKIIIIIITTTTTTTTUPPERRRR GGGGGRRRRRIIIILLE KKKKKIIIIITTTTT INNNSSSSSSTTTTTIIIINNNNSSSSTTTTTIIINNNNNNNSSSSSSSTTTTTTIIIINNNNNSSSSSTTTTTALLTTAAAAALLLLLTTTTTTTTTTTTTAAAAAALLAAAAALLTTTTTT
REMOVE PLASTIC C C FASFASFASFASFA TNETNTNETNETNERS RSRSRSR ANDANDANDANDN BOBBBB LTS ALONGONGONGONGONG THTHTHTHHE TE TE TE TE OP OFTHE UPPER GRGRGRGRGRILLILLILLILLL EEE. EE NEXNEXNEXNEXE T RT RT RT RT RELELELEELEL ASE PLASTIC CCC GRIGRIGRIGRGRG LLLLELL CLIPSUSING A FLA FLA FLA FLFLAT AT AT ATAT SCRSCRSCRSCRSCREWDEWDEWDEWDEWDRIVRIVRIVRIVRIVER AND REMOVE GRILLE FROM
VEHICLE.
TAPPAPAPAPAPE OE OE OE OE OFF FFFF FF F THHTHETHH CHROMMMMME TE TE TE TEE TRIMRIMRIMRIMRIM ON ONONON THTHTHTHTHE GE GE GE GE GRILLE IN ORDER TOHELHELHELHELHELP ELP EP ELP ELP ELIMIIMIMIMM NATNANANANANA E SCRARARARARATCHTCHTCHTCHTCHINGINGINGINGING TH THTH THTHE CEEEE HROME. NEXT CUT THTHTHTHTHT EEEEE
GRIRIRIRILLELLELLELLELLE CECECECECENNNTENN R OUT.
A VIEW EW EWW W OF OFOF OF OF THETHETHEETHE GRGRGRGRG ILLILLILLILLLLEEE SEE HELL AFTER GRRRRRINININDINN ING THEBACBABABAB KSIDE FLUSH.
TAPE AE AE AE AA STRSTRSTRSTRSTRAAIGAA HT LINE OOOOON TN TN TN TN THE HEHE HEHE BACBACBACBACBA K SK SK SSK SIDEIDEIDEIDEID OF THE GRILLESHSHSHESSH LLLL AL ND GRIGRIGRIGRIGR ND ND ND NDND THETHETHETHEHE PL PL PL PLPLASTASASASA IC FLUSH.
INSINSINSINSNSERTERTERTERT GRG GR GRG ILLLLL CRAFT TT T T MESMESMESMESMESH GH GH GH GH GRILRILRILRILRI LE LELE LE LE IIINTII O THE GRILLE SHELLELLELLELLELLFROFROFROFROFROM MM TMM HE HEHE HE HEE FROF NT SIDSIDSIDSIDSIDE AE AE AE AEE S SS SS SS SS SSHOHOHOHOWHO N. MARK MOUNTINNNNG TG TG TG TG AB ABAB ABAB
CENCENCENENCENTERTETETETE HOLES.
SAND THE GRILLELLELLELLELLE SHSH SHSH SHS ELLELLELLELLELL CENCENCENCENCENTETETERTETE USING A SA SA SA SSCOTCOTCOTCOTCOTCH CHCHCHCH BRITEPAD. NEXTTTTT PAPA PA PAPAINTINTINTINT THTH THTHE GE GE GE GE GRILRILRILRILRILLLLE LL SHELL CENTER ERERERERR USIUUU NG FLAT
BLABLABLABLABLACK KCK CK CK SPRSPRSPRPRSP AY PAY PAY PAY PAY PAINA T “ JUST A LITE COAT”
PART# SUB-1777772222299999(3) #8 XXXXX 5 5 5555/8/8/8/8/8 H H HHexee Screwwwwwsssss(3) ) ) ) ) #8#8#8#8#88 “ ““ ““FlFlFllFlataatatat” ”” ” NNuNNNN ts
FASTEN GRGRGRGRGRILLILLILLILLCRACRACRACRACRAFTT FTTFT GRIGRIGRIGRIGRILLELLLLLLLL TO THE FACTORYRYRYRYYR GRILLE SHELLUSIUSIUSIUSIUSING NG NG NG NG SSSUPS PLIED HARDWARE.
DRILL HHHHHOLEOLEOLEOLEOL S FSSS OR THE MOOOOUNTUNTUNTUNTUNTINGINGINGING SCSCSCS REWREWREWREWREWSSS US SING 3/16 INCHDRIDRIDRIDRIDRILL BLL BLL BLL BBIT.TIT.IT.
For further innnnnstststststs alalalalallalalalatitititit ononononon dd d ddeteeee ails cheeeeckckckckck ooooour website insnsssnstatatatatalllllllllssssTeTeTeTeTel:l:l:l:l:31313131310-0-0-0-0-9797979797000-00 0300 Fax:310-970-04000000
www.grillccccrararararaftftftftft.c... om
