Storm Series® 3G Front Riggings & MKIV ElectronicsStorm Series® 3G Front Riggings & MKIV...

Storm Series®3G

Front Riggings & MKIV ElectronicsArrow®

Ranger X™Torque™ SP/SE

Power Wheelchairs

Parts Catalog Issued: Feb 3, 2020

The information contained in this document is subject to change without notice. This catalog containsservice parts for Form No. 06-100. If you have any questions regarding this catalog, please contact oneof our Customer Service Representatives.

For Customer Service Support Call:1-800-333-6900

For Faxed In Orders Call:1-800-678-4682 or

1-440-366-0709For Technical Service Call:

1-800-832-4707Literature Can Be Found at:

www.invacare.com or1-800-828-6272

SYMBOL DEFINITIONThroughout this catalog you will notice letters to draw your attention to specific footnotes which are located at thebottom of the page or below specified charts.

HARDWARE MEASUREMENTS

Examples:= Special Comments= General information pertaining to that specific page= No Longer Available

NOTE:NLA

The measurements for the hardware will be listed as follows:Screws, BoltsWashersSpacers

For your convenience, we have supplied an area for you to list your Invacare Representatives.

A,B,C etc.

Diameter X Thread Count/Pitch X LengthInside Diameter X Outside Diameter X ThicknessInside Diameter X Outside Diameter X Length

Name Phone Numbers

© 2020 Invacare Corporation. Elyria, Ohio. Invacare, Yes, you can., the Blue Medallion Design, Storm Series, Arrow, Tarsys are registered trademarks andMKIV, Ranger X, Torque, and GB are trademarks of Invacare Corporation. Otto Bock is a registered trademark of Otto Bock Orthopaedische Industrie GMBH& Co., Tash is a registered trademark of Tash International Inc., Therafin is a registered trademark of W/R/ Medical Electronics Co., Bussman is a registered

trademark of Cooper Industries., MIDI is a registered trademark of Littelfuse Inc., Dynamic is a registered trademark of Dynamic Controls Limited.

Parts Catalog Usage Guide

1Form No. 06-100 To order call toll free 1-800-333-6900, or www.invacare.com

A: READ THIS FIRST (THIS CATALOG IS DIFFERENT!) ...................................................... 6

Electronics - Controller Shroud Covers .................................................................................... 135

Electronics - Dual Legs Integrated Actuator Module (DLIAM) MK6i For ELRPW Front Riggings 103

Electronics - MK6i ~PLEASE READ FIRST ............................................................................. 102Electronics - MKIV Controllers, Programmer and Hardware - MKIV Quad Pulse, RII Retro andRII 80 Amp 119

Electronics - MKIV Controllers, Programmer and Hardware - MKIV TrueTrack ...................... 123

Electronics - MKIV Displays ..................................................................................................... 140

Electronics - MKIV Elevating Seat Toggle Switch .................................................................... 129

Electronics - MKIV Joystick Mounting Hardware and Joystick Accessories ............................ 109

Electronics - MKIV Joystick Options ......................................................................................... 146

Electronics - MKIV Joysticks - PSF and PSR ........................................................................... 107

Electronics - MKIV Joysticks - RII, TCHJOY, A, A+ ................................................................. 105

Electronics - MKIV Mid-Line Swing Bracket Assembly ............................................................ 112

Electronics - MKIV R.I.M. Head Control Assembly .................................................................. 143

Electronics - MKIV R.I.M. Head Control Mounting Hardware ................................................... 142

Electronics - MKIV Sip-N-Puff/Digital Interface and COM12 and COM34 ............................... 138

Electronics - MKIV Swivel Joystick Hardware .......................................................................... 111

Electronics - MKIV TAC and 4-Way Switch .............................................................................. 131

Electronics - MKIV TAC and 4-Way Switch For TRBKTS Option ............................................ 133

Electronics - Quad Link (Before 10/31/05 - ASBA) (Before 4/07/06 - Captain Seat) ............... 113

Electronics - Quad Link (QLA) (After 10/30/05 - ASBA), (QL) (After 4/06/06 - Captain Seat) .. 116

TABLE of CONTENTSDescription Page

Number

2To order call toll free 1-800-333-6900, or www.invacare.comForm No. 06-100

Electronics - Tash and Therafin Accessories ........................................................................... 149

Frame Finishes, Touch-Up Paints and Upholstery Options ..................................................... 7

Front Riggings - Adjustable Angle Footplate Assemblies - AT5543 For AT5044 ..................... 65

Front Riggings - Adjustable Angle Footplate Assemblies- AT5543 .......................................... 62

Front Riggings - Adjustable Heel Loops ................................................................................... 73

Front Riggings - Calf Pads and Attaching Hardware ................................................................ 44

Front Riggings - Flip-Up Footplates - AT5043 .......................................................................... 61

Front Riggings - Footrest and Legrest Accessories ................................................................. 70

Front Riggings - Footrest Support Assemblies ......................................................................... 31

Front Riggings - Footrest Supports - P93M .............................................................................. 52

Front Riggings - Footrest Supports - PW93 ............................................................................. 46

Front Riggings - Footrest Supports - PW93E ........................................................................... 50

Front Riggings - Footrest Supports - PW93ST ......................................................................... 48Front Riggings - Front Rigging Hanger Asbly. - Pin & Sector Style For ASBA Seats (Before7/5/05) and All Van Seats 25Front Riggings - Front Rigging Hanger Hdwr., Pin & Sector Style For ADJASBA (12-16" W)(After 7/4/05) 27Front Riggings - Front Rigging Hanger Hdwr., Pin & Sector Style For ADJASBA/ADJRECL(16-24" W) (After 7/4/05) 29

Front Riggings - Legrest Release Handles and Ratchets ........................................................ 42

Front Riggings - Legrest Support Assembly - AT5544 ............................................................. 34

Front Riggings - Legrest Support Assembly - P904A ............................................................... 40

Front Riggings - Legrest Support Assembly - Wedge Style AT5044 ....................................... 36

Front Riggings - Legrest Support Assembly, Articulating - PAS4A/PAL4A .............................. 41


Number


Front Riggings - One Piece Wooden Footboard and Hardware - S1263 ................................. 67

Front Riggings - Pivot/Slide Tube & 1350 Extra Large Aluminum Footplates - AT5044 .......... 59

Front Riggings - Pivot/Slide Tube & 1651 Composite Footplates - AT5044 ............................ 53

Front Riggings - Pivot/Slide Tube &1651 Composite Footplates ............................................. 55

Front Riggings - Pivot/Slide Tube and 1650, 1450, 1350 Aluminum Footplates ...................... 56

Front Riggings - Power Articulating Legrest - Harness & Hdwr. (After 7/4/05) ........................ 90

Front Riggings - Power Articulating Legrest Kits, ELRPW - (5/1/02-7/26/04) .......................... 98

Front Riggings - Power Articulating Legrest Kits, ELRPW - (After 7/26/04) ............................. 100

Front Riggings - Power Articulating Legrest Kits, POWELR18 - (Before 9/15/01) ................... 92

Front Riggings - Power Articulating Legrest Kits, POWELR20 - (Before 9/15/01) ................... 94

Front Riggings - Power Articulating Legrest, ELRPW - (After 7/26/04) .................................... 86

Front Riggings - Power Articulating Legrest, ELRPW - (Between 5/1/02-7/26/04) .................. 82

Front Riggings - Power Articulating Legrest, POWELR18/POWELR20 - (Before 9/15/01) ..... 75

Front Riggings - Power Articulating/Non-Articulating Legrest - Harness & Hdwr. (Before 7/5/05) 89Front Riggings - Power Non-Articulating Legrest Kits, POWELR18/POWELR20 - (9/15/01 thru4/30/02) 96

Front Riggings - Reference Chart - 70MFX and 90 SWING .................................................... 22

Front Riggings - Reference Chart - AT5544, AT5044, 60HD, 70NHD, PW93, PW93E, 60MFX 14

Front Riggings - Reference Chart - P904, PAL4A, PAS4A ...................................................... 17

Front Riggings - Reference Chart - P93M ................................................................................ 19

Front Riggings - Reference Chart - PW93ST and 70ST TAPER ............................................. 23Front Riggings- Power Non-Articulating Legrest, POWERLR18/POWERLR20 - (9/15/01 Thru4/30/02) 79


Number


Label Locations For TRRO and TRBKTS Options ................................................................... 12

Packaging, Literature and Decals ............................................................................................ 9

TRRO and TRBKTS Option Clarification Reference ................................................................ 13


Number


A: READ THIS FIRST (THIS CATALOG IS DIFFERENT!)


Frame Finishes, Touch-Up Paints and Upholstery Options

Frame Finishes and Touch-Up Paint

Color Number Part Number Bottle Size Frame FinishDeep Purple.6 oz.1031456-NLA08PCobalt Blue.6 oz.1046319-NLA17PAnthracite.6 oz.1033376-NLA22PWet Black.6 oz.1031450-NLA24P

White.6 oz.1031447-NLA29PSunny YellowN/AN/A30P

Red.6 oz.1031455-NLA33PFlat Black.6 oz.1046327-NLA34P

Silver MetallicN/AN/A60PElectric Red.6 oz.1046321-NLA61PElectric Blue.6 oz.1046320-NLA62P

Electric Purple.6 oz.1046322-NLA66PTeflon Black.6 oz.1101320-NLA69PSilver VeinN/AN/A71P

Evergreen with Navy.6 oz.1073892-NLA80PRoyal Blue with Grape.6 oz.1073895-NLA83P

Lavender.6 oz.1073896-NLA84PJeweled Green.6 oz.1101325-NLA101P

Denim Blue.6 oz.1101327-NLA102PMocha Frost.6 oz.1101324-NLA103PElectric Teal.6 oz.1101316-NLA104P

MIdnight Blue.6 oz.1101326-NLA105PBlack Prism.6 oz.1133371-NLA115P

Sunkissed Orange.6 oz.1133372-NLA116PTangerine Red.6 oz.1133373-NLA117P

Fruit Fusion.6 oz.1133374-NLA118PBubblegum Pink.6 oz.1133375-NLA119PGrape Madness.6 oz.1133376-NLA120PLolly Pop Blue.6 oz.1133377-NLA121PCosmic Blue.6 oz.1133378-NLA122P

Celestial Purple.6 oz.1133379-NLA123PVivid Violet.6 oz.1133380-NLA124P

Emerald Green.6 oz.1133381-NLA125PShamrock Green.6 oz.1133382-NLA126P

Grasshopper Green.6 oz.1133383-NLA127P


Frame Finishes, Touch-Up Paints and Upholstery Options

Sparkle Frame Finishes

Color Number Frame FinishWet Black with Twilight Sparkle88P

Upholstery Options

Vinyl Color Nylon Color U240 BlackU67 Black


Packaging, Literature and Decals


Packaging, Literature and DecalsItem

Number Part Number DescriptionNoteQuantity Per

Package Assembly1030364 Carton, Cover 1 11 A1031682 Carton, Cover 1 11 B1036028 Carton, Cover 1 11 C1030365 Carton, Cover 1 11 D

1043198-NLA NLA - Tube, Paper 1 121015609-NLA NLA - Bag, Poly (28" W x 44" D x 80" H) 1 13

1030362 Carton, Tray 1 24 H1036027 Carton, Tray 1 24 ISee Note See Footnote 1 15 K

1021149-NLA NLA - Bag, Poly Zip-Lip (13" L x 9" W) 1 161134791-NLA NLA - Owner's Manual, 3G Storm with MKIV

Electronics1 17 M

1143151-NLA NLA - Owner's Manual, 3G Storm Base with MK6iElectronics

1 17 M1143192-NLA NLA - Owner's Manual, ADJASBA Seat with MK6i

Electronics1 17 M

1143195-NLA NLA - Owner's Manual, Van Seat's with MK6iElectronics

1 17 M00077X031-NLA NLA - Warranty Card 1 18

50000X121 Strap, Battery Lift 1 191012001-NLA NLA - Carton, Joystick 1 110 N40131X011 Carton, Front Riggings 1 11040131X161 Insert, Plain Pad 1 111

1035900 Decal, Transportation 1 1121119281-NLA NLA - Plate, Name, Patent Numbers 1 113

1133255 Decal, Torque SP, Yellow 1 2141144627-NLA NLA - Decal, Torque SP, Black 1 214 L1146486-NLA NLA - Decal, Torque SE, Yellow 1 2141146487-NLA NLA - Decal, Torque SE, Black 1 214 L1133253-NLA NLA - Decal, Yellow - Arrow 1 2141144625-NLA NLA - Decal, Black - Arrow Storm 1 214 L1133254-NLA NLA - Decal, Yellow - Ranger X 1 2141144626-NLA NLA - Decal, Black - Ranger X 1 214 L

1115174 Carton, Corner Reinforcement 1 215 A1129589-NLA Carton, Corner Reinforcement 1 215 B1129590-NLA Carton, Corner Reinforcement 1 215 C1104820-NLA NLA - Package, Decal, Yellow - Torque SP 1 2F,G1144630-NLA NLA - Package, Decal, Black - Torque SP 1 2F,G,L1146488-NLA NLA - Package, Decal, Yellow - Torque SE 1 21146489-NLA NLA - Package, Decal, Black - Torque SE 1 2F,G,L1104818-NLA NLA - Package, Decal, Yellow - Arrow 1 2F,G1144628-NLA NLA - Package, Decal, Black - Arrow 1 2F,G,L1104819-NLA NLA - Package, Decal, Yellow - Ranger X 1 2F,G1144629-NLA NLA - Package, Decal, Black - Ranger X 1 2F,G,L


Packaging, Literature and DecalsItem


Package Assembly1079515-NLA NLA - Kit, T-Nut with Instruction Sheet 1 1E,G

1104863 Package, Cover, Frame Rail - Right/Left 6 1G,JA - 12" W - 20" W Non-Recliner, Extended and H.B. Captain Seats 18" W B - 16" W - 20" W Recliner and 16" W - 20" W Non-Recliner w/Medium/Tall Seat-to-Floor C - 21" W - 24" W Non-Recliner and Recliner, H.B. Captain Seat 22" W D - Base only and all A.S.B.A. seat only models E - Used with Storm base only F - Decal package includes model, transportation and patent numbers decals. G - Not Shown H - 12" W - 20" W Chairs and Base Only I - 21" W - 24" W Chairs J - 3 each Right and Left K - Skid not supplied L - Black Decal is used whenever frame color 30P, Sunny Yellow is ordered. M - Item is no longer available from the Invacare Service Parts Department. Refer to the Invacare Website under "Product

Literature Search". Enter the part number in the "Keywords" field and download a free PDF version copy. N - Can use part #40131X011 for a Joystick also.

NOTE: When adjusting or replacing parts, please refer to your Owner's Manual for assistance.

NOTE:


Label Locations For TRRO and TRBKTS Options


TRRO and TRBKTS Option Clarification ReferenceTRRO and TRBKTS Option was introduced 12/19/05 as an On-Chair option only.


Front Riggings Reference ChartFor AT5544, AT5044, 60HD, 70NHD, PW93, PW93E, 60MFX

NOTE: Calf pads with attaching hardware not included on legrest.NOTE: Pivot/ Slide tube attaching hardware not included.

NOTE: Pivot/Slide tube and footplates do not include heel loops. See footrest and legrest accessories.1651 = Composite footplate with 9-7/8" curved pivot/ slide tube.

AT5543 = Adjustable angle footplate with 9-7/8" straight pivot/ slide tube.1450 = Deluxe aluminum footplate with "L" style pivot/ slide tube.

1350 = Extra large footplate with "L" style pivot/ slide tube.

Support AssembliesPivot/Slide tube and footplates are interchangeable with the support assemblies listed.

RiggingType 60MFXAT5544 60HD 70NHD PW93 PW93E

8881026998

8881070768-NLA

8881070776

8881053149

8881053158

8881045291

RightSee Note(s) A See Note(s) A See Note(s) A See Note(s) A See Note(s) A See Note(s) A

8881026999

8881070769-NLA

8881070777

8881053148

8881053157

8881045292

LeftSee Note(s) A See Note(s) A See Note(s) A See Note(s) A See Note(s) A See Note(s) A

A - Specify frame color when ordering, see page titled "Frame Finishes and Touch-Up Paints". NOTE:

Pivot/ Slide Tube and Footplates

FootplateType

AT554314-15" W

AT554316-24" W

165113-14" W

165115-16" W

165117-24" W

135017-24" W

AT554312-13" W

1062756106044410604421026395105787910578691057859Right1062757106044510604431026396105788010578701057860Left



2" Longer Pivot/ Slide Tube and Footplates

FootplateType

AT554314-15" W

AT554316-24" W

165113-14" W

165115-16" W

165117-24" W

135017-24" W

AT554312-13" W

10627601062758N/A1086515105788110578711057861Right10627611062759N/A1086517105788210578721057862-NLALeft

4" Longer Pivot/ Slide Tube and Footplates

FootplateType

AT554314-15" W

AT554316-24" W

165113-14" W

165115-16" W

165117-24" W

135017-24" W

AT554312-13" W

11211401121138-NLAN/A1086516105842310584211058419-NLARight11211411121139-NLAN/A1086518105842410584221058420-NLALeft

Support Assembly

RiggingType AT5544

8881045291

RightSee Note(s) A8881045292

LeftSee Note(s) A

A - Specify frame color when ordering, see page titled Frame Finishes and Touch-Up Paints. NOTE:

Pivot/ Slide Tube and Footplates

FootplateType

145016-24" W

1028723-NLARight1028724-NLALeft



Support Assemblies - AT5044

Rigging Type AT50448881128698


LeftSee Note(s) A


Pivot/ Slide Tube and Footplates For AT5044

FootplateType

AT554318-24" W

165114" W

165115-16" W

165117-24" W

AT554314-15" W

AT554316-17" W

113206511320631132061113208211320801132078Right113206611320641132062113208311320811132079Left113209311320911132089113211111321091132107Right 2" Longer113209411320921132090113211211321101132108-NLALeft 2" Longer


Front Riggings Reference ChartFor P904, PAL4A, PAS4A

NOTE: Calf pads with attaching hardware not included on legrest.NOTE: Pivot/Slide tube attaching hardware not included.

NOTE: Pivot/Slide tube and footplates do not include heel loops. See footrest and legrest accessories.1650 = Aluminum footplate with "L" style pivot/slide tube.

AT5543 = Adjustable angle footplate wtih 9-7/8" straight pivot/slide tube.1450 = Deluxe aluminum footplate with "L" style pivot/slide tube.

1350 = Extra large footplate with "L" style pivot/slide tube.

Support AssemblyPivot/Slide tube and footplates are interchangeable with the support assemblies listed.

RiggingType P904

8881058646-NLA

RightSee Note(s) A

8881058647-NLA

LeftSee Note(s) A

A - Specify Frame Color when ordering, see page titled "Frame Color and Touch-Up Paint". NOTE:

Pivot/Slide Tube and Footplates

Footplate Type

AT554316-24" W

165014-15" W

165016-24" W

145016-24" W

135017-24" W

AT554314-15" W

1062756106044410588301028723-NLA10586041058612-NLARight1062757106044510588311028724-NLA10586051058613-NLALeft


Front Riggings Reference ChartFor P904, PAL4A, PAS4A

2" Longer Pivot/Slide Tube and Footplates

Footplate Type

AT554316-24" W

165014-15" W

165016-24" W

145016-24" W

135017-24" W

AT554314-15" W

106276010627581086541-NLAN/A1086529-NLAN/ARight106276110627591086551-NLAN/A1086531-NLAN/ALeft


Footplate Type

AT554316-24" W

165014-15" W

165016-24" W

145016-24" W

135017-24" W

AT554314-15" W

N/AN/A1086542-NLAN/A1086530-NLAN/ARightN/AN/A1086552-NLAN/A1086532-NLAN/ALeft

Support AssemblyPivot/Slide tube and footplates are interchangeable with the support assemblies listed.

RiggingType PAL4A/PAS4A (Chrome Only)



Footplate Type

AT554316-24" W

165014-15" W

165016-24" W

145016-24" W

135017-24" W

AT554314-15" W

1091777109177510354561023924-NLA10239071023905-NLARight1091778109177610354571023925-NLA10239081023906-NLALeft


Front Riggings Reference ChartFor P93M

NOTE: Pivot/Slide tube attaching hardware not included.NOTE: Pivot/Slide tube and footplates do not include heel loops. See footrest and legrest accessories.

1650 = Aluminum footplate with "L" style pivot/slide tube.1450 = Deluxe aluminum footplate with "L" style pivot/slide tube.

1350 = Extra large footplate with "L" style pivot/slide tube.


RiggingType P93M

8881037836-NLA

RightSee Note(s) A

8881037837-NLA

LeftSee Note(s) A



FootplateType

165014-15" W

165016-24" W

145016-24" W

135017-24" W

1031924-NLA1028892-NLA

1057969-NLA1058573-NLARightSee Note(s) A

1031925-NLA1028893-NLA

10579701058574-NLALeftSee Note(s) A

N/A02303X107-NLA N/AN/A

Complete 93BKFootrest Assembly w/

1450 DeluxeAluminum Footplate

and Heel Loopattached. (sold

complete) - Right See Note(s) B

N/A02303X108-NLA N/AN/A

Complete 93BKFootrest Assembly w/

1450 DeluxeAluminum Footplate

and Heel Loopattached. (soldcomplete) - Left See Note(s) B



A - No longer available as a service part individually. Order as a replacement part number 02303X107 Right and 02303X108 LeftFootrest Assembly complete. B - Not Shown. Includes a Footrest Support Assembly, Pivot/Slide Tube w/ Deluxe Aluminum Footplate (1450) and Heel Loopattached. Items are sold complete. Covers 16-20" wide models.

NOTE:




FootplateType

135017-24" W



FootplateType

135017-24" W



NOTE: Footplates do not include heel loops. See footrest and legrest accessories.AT5543 = Adjustable angle footplates without pivot/slide tubes.

AT5043 = Flip up footplates without pivot/slide tubes.

Support AssembliesFootplate Assemblies are interchangeable with the support assemblies listed.

RiggingType 70MFX

8881047481


LeftSee Note(s) A


Support AssembliesFootplate Assemblies are interchangeable with the support assemblies listed.

RiggingType 90 SWING

8881062596


LeftSee Note(s) A

A - Specify frame color when ordering, see page titled "Frame Finishes and Touchup Paints". NOTE:

Footplate Assemblies

FootplateType

AT504312-16" W

AT554312-13" W

AT554314-15" W

AT554317-24" W106257010604381060436-NLA1029434-NLARight1062571106043910604371029435-NLALeft

Front Riggings Reference ChartFor 70MFX and 90 SWING


Front Riggings Reference ChartFor PW93ST and 70ST TAPER

NOTE: Pivot/Slide tube attaching hardware not included.NOTE: Pivot/Slide tube and footplates do not include heel loops. See footrest and legrest accessories.

1651 = Composite footplate with 9-7/8" curved pivot/slide tube.


RiggingType PW93ST

8881070784-NLA

RightSee Note(s) A

8881070785-NLA

LeftSee Note(s) A



RiggingType 70ST TAPER

8881026996


LeftSee Note(s) A



FootplateType

165115-17" W

165118-19" W

165120-24" W105787910578691057859Right105788010578701057860Left


Front Riggings Reference ChartFor PW93ST and 70ST TAPER


FootplateType

165115-17" W

165118-19" W

165120-24" W105788110578711057861Right105788210578721057862-NLALeft


Front Rigging Hanger AssemblyPin & Sector Style For ASBA Seats (Before 7/5/05) and All Van Seats

NOTE: Front rigging hanger assemblies and seat pans share the same mounting hardware, see Seat Panand Mounting Hardware page.


Front Rigging Hanger AssemblyPin & Sector Style For ASBA Seats (Before 7/5/05) and All Van Seats

NOTE: Front rigging hanger assemblies and seat pans share the same mounting hardware, see Seat Panand Mounting Hardware page.

ItemNumber Part Number DescriptionNote

Quantity PerPackage Assembly

1068435 Front Rigging Hanger Assembly w/ Sector Block,Black - Right (12 - 21" D)

1 11 A1068436 Front Rigging Hanger Assembly w/ Sector Block,

Black - Left (12 - 21" D) 1 11 A

1068437-NLA NLA - Front Rigging Hanger Assembly w/ SectorBlock, Black - Right (22" D)

1 11 A1068438-NLA NLA - Front Rigging Hanger Assembly w/ Sector

Block, Black - Left (22" D) 1 11 A

1054571 Kit, Sector Block - Right 1 12 B1054572 Kit, Sector Block - Left 1 12 B1052957 Screw, Hex Head w/ Patch (1/4-20 x 2") 1 131026907 Washer (1/4 x 1/2 x 1/16") 1 14

1070356-NLA NLA - Hanger Assembly, Front Rigging, Pin Style,Black - Right (12 - 21" D)

1 15 C1070357-NLA NLA - Hanger Assembly, Front Rigging, Pin Style,

Black - Left (12 - 21" D)1 15 C

1070358-NLA NLA - Hanger Assembly, Front Rigging, Pin Style,Black - Right (22" D)

1 15 C1070359-NLA NLA - Hanger Assembly, Front Rigging, Pin Style,

Black - Left (22" D) 1 15 C

1027097 Plug Button, Black (3/4") 1 16A - Includes item 2 B - Includes the sector block and items 3 and 4 C - Includes item 6

NOTE:


Front Rigging Hangers and HardwarePin & Sector Style For ADJASBA (12"-16" Wide) (After 7/4/05)


Front Rigging Hangers and HardwarePin & Sector Style For ADJASBA (12"-16" Wide) (After 7/4/05)



1126150 Kit, Side Rail Cap Hardware 2 11 AScrew, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 22Spacer (1/4 x 3/8 x 29/32") 1 23Cap, End, Side Rail, Black 1 24Washer (1/4 x 1/2 x 1/16") 1 25Locknut (1/4-20) 1 26Plug Button, Black (7/8") 1 27

1136019 Kit, Front Rigging Hanger Mounting Hardware 2 18 BScrew, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 49Spacer (1/4 x 3/8 x 3/16") 1 410Cap, End, Side Rail, Black 1 211Washer (1/4 x 1/2 x 1/16") 1 412Locknut (1/4-20) 1 413

1122602 Front Rigging Hanger Assembly w/ Sector Block,Black - Right

1 114 C1122603 Front Rigging Hanger Assembly w/ Sector Block,

Black - Left1 114 C

1054571 Kit, Sector Block - Right 1 115 D1054572 Kit, Sector Block - Left 1 115 D1136006 Front Rigging Hanger Assembly w/ Plug Button, Pin

Style, Adult, Black - Right1 116

1136007 Front Rigging Hanger Assembly w/ Plug Button, PinStyle, Adult, Black - Left

1 1161134426 Package, Plug Button, Black (3/4") 10 117

A - Includes items 2-7 B - Includes items 9-13 C - Includes Front Rigging Hanger and item 15 D - Includes the Sector Block, Screw and Washer

NOTE:


Front Rigging Hangers and HardwarePin & Sector Style For ADJASBA/ADJRECL (16"-24" Wide) (After 7/4/05)


Front Rigging Hangers and HardwarePin & Sector Style For ADJASBA/ADJRECL (16"-24" Wide) (After 7/4/05)Item


Package Assembly1124723 Kit, Side Rail Cap Hardware (Pair) 1 11 A

Screw, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 42Spacer (1/4 x 3/8 x 29/32") 1 43Cap, End, Side Rail, Black 1 24Plug Button, Black (1") 1 25Block, Threaded 1 26

1125726 Kit, Front Rigging Hanger Mounting Hardware (Pair) 1 17 BScrew, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 48Spacer (1/4 x 3/8 x 3/16") 1 49Cap, End, Side Rail, Black 1 210Block, Threaded 1 211

1122602 Front Rigging Hanger Assembly w/ Sector Block,Black - Right

1 112 C1122603 Front Rigging Hanger Assembly w/ Sector Block,

Black - Left1 112 C

1054571 Kit, Sector Block - Right 1 113 D1054572 Kit, Sector Block - Left 1 113 D1136006 Front Rigging Hanger Assembly w/ Plug Button, Pin

Style, Adult, Black - Right1 114

1136007 Front Rigging Hanger Assembly w/ Plug Button, PinStyle, Adult, Black - Left

1 1141134426 Package, Plug Button, Black (3/4") 10 115

A - Includes items 2-6 B - Includes items 8-11 C - Includes Front Rigging Hanger and item 13 D - Includes the Sector Block, Screw and Washer

NOTE:


Footrest Support AssembliesSector Style





8881053158 Footrest Support Assembly, 60 Degree Heavy Duty,Sector, Color - Right

1 11 A,C8881053157 Footrest Support Assembly, 60 Degree Heavy Duty,

Sector, Color - Left1 11 A,C

8881026998 Footrest Support Assembly, 60 Degree MFX,Sector, Color - Right

1 11 A,D8881026999 Footrest Support Assembly, 60 Degree MFX,

Sector, Color - Left1 11 A,D

8881053149 Footrest Support Assembly, 70 DegreeNon-Tapered Heavy Duty, Sector, Color - Right

1 11 A,C8881053148 Footrest Support Assembly, 70 Degree

Non-Tapered Heavy Duty, Sector, Color - Left1 11 A,C

8881026996 Footrest Support Assembly, 70 Degree Tapered,Sector, Color - Right

1 11 A,D8881026997 Footrest Support Assembly, 70 Degree, Tapered,


8881047481 Footrest Support Assembly, 70 Degree MFX,Sector, Color - Right

1 11 A,D8881047480 Footrest Support Assembly, 70 Degree MFX,


8881062596 Footrest Support Assembly, 90 Degree, Sector,Color - Right

1 11 A,D8881062597 Footrest Support Assembly, 90 Degree, Sector,

Color - Left1 11 A,D

1001762 Screw, Socket Button Head (1/4-20 x 1-3/4") 1 121029501 Plug Button, Black (1") 1 13 G1056328 Plug Button, Black (1") 1 13 G1017148 Pivot, Footrest 1 141025736 Locknut (1/4-20) 1 151025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 261017423 Screw, Slotted Hex Washer Head w/ Patch (#10-32

x 1/2")1 17

1025454 Housing, Latch - Right 1 181025455 Housing, Latch - Left 1 181026124 Collar, Anti-Rattle 1 191045267 Screw, Hex Head w/ Patch (1/4-20 x 3/4") 1 1101026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 111 B1020534 Insert, Threaded 1 112 F1070759 Screw, Hex Head (1/4-20 x 1-1/2") 1 1131044214 Nut, Hex with Nylon Cap (1/4-20) 1 1141026703 Kit, Pivot/Slide Tube Mounting Hardware (Pair) 1 1151057846 Kit, Pivot/Slide Tube Mounting Hardware (Pair) 1 116

8881038231 Kit, 3" Extension w/ Hardware (Pair) 1 117 A1026987 Guard, Impact (8" L) 1 1E



A - Specify frame color when ordering. See page titled "Frame Finishes and Touch-Up Paints." B - Item 16 takes 2 C - Uses Item Number 3, Plug Button 1029501 D - Uses Item Number 3, Plug Button 1056328 E - Not Shown. For 70 deg. Tapered Footrest. F - As of 8/15/03, the Threaded Insert was revised from 3 to 5 Holes. Threaded Insert is Backward Compatible and does not

require ordering in Pairs. G - See item #1 footnote C or D for Front Rigging Plug Button usage.

NOTE:


AT5544 Legrest Support Assembly(Sector Style)

12"-24" Wide Chairs


AT5544 Legrest Support Assembly(Sector Style)

12"-24" Wide ChairsItem


Package Assembly1017187 Cover, Top 1 111028529 Screw, Phillips Pan Head (#8-32 x 3/8") 1 22

40363X000 Hex Nut (3/8"-16) 1 131058636-NLA NLA - Washer, Nylon (25/64 x 7/8 x 1/32") 1 24

11919X000-NLA NLA - Screw, Slotted Truss Head (3/8-16 x 1-1/2") 1 157930330-NLA NLA - Locknut (5/16-24) 25 36

1026030 Bolt, Lug (5/16-24 x 1-3/8") 1 171043556-NLA NLA - Tube, Elevating Adjustable Support, Black -

Right 1 18

1043557-NLA NLA - Tube, Elevating Adjustable Support, Black -Left

1 188881048851 Tube, Elevating Adjustable Support, Color - Right 1 18 A8881048852 Tube, Elevating Adjustable Support, Color - Left 1 18 A

1032266 Bracket, Legrest Pad Mounting, Black 1 1904528X002 Bracket, Release, Black 1 110

1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 2111025454 Housing, Latch - Right 1 1121025455 Housing, Latch - Left 1 1127930314 Package, Screw, Slotted Hex Washer Head (#10-32

x 1/2")25 113

42326X001 Bar, Ratchet 1 1147930336-NLA NLA - Nut, Acorn (5/16-24) 25 115

1017148 Pivot, Footrest 1 1161029501 Plug Button, Black (1") 1 117

7930301-NLA NLA - Package, Button Head Cap Screw (1/4-20 x1-3/4")

25 1188881045289 Bracket, Legrest Support, Color - Right 1 119 A8881045290 Bracket, Legrest Support, Color - Left 1 119 A

1040831 Ring, Snap 1 1207930310-NLA NLA - Washer, Nylon (5/16 x 11/16 x 1/16") 25 121

1040060 Tip, Plastic, Black 1 1221037485 Spring, Release 1 1231037125 Cam, Legrest 1 1241037126 Handle, Release 1 1251096974 Kit, Elevating Legrest Ratchet Hardware (Pair) 2 126 B

1096943-NLA NLA - Instruction Sheet, Ratchet Kit 1 1C,D8881045291 Legrest Support Assembly, Sector, Color - Right 1 1A,C8881045292 Legrest Support Assembly, Sector, Color - Left 1 1A,C

A - Specify frame color when ordering. See page titled "Frame Finishes and Touch-Up Paints". B - Includes items 10, 14, 15 and 20-25 C - Not Shown D - Item is no longer available from the Invacare Service Parts Department. Refer to the Invacare Website under "Product

Literature Search". Enter the part number in the "Keywords" field and download a free PDF version copy.

NOTE:

35

To order call toll free 1-800-333-6900, or www.invacare.comForm No. 06-100

Legrest Support Assembly AT5044Wedge Style ("D" shaped tubing)

Specify frame color when ordering. Legrest Support does not include Legrest Pad.



Specify frame color when ordering. Legrest Support does not include Legrest Pad.Item


Package Assembly8881128698 Legrest Support Assembly, Sector, Color - Right 1 11 A,G8881128699 Legrest Support Assembly, Sector, Color - Left 1 11 A,G8881130747 Legrest Support Tube Assembly, Sector, Color -

Right1 12 B

Plug Button, Black (1") 1 13Screw, Socket Button Head (1/4-20 x 1-3/4") 1 14Tube, Legrest Support, Sector, Color - Right 1 15Bolt, Lug (5/16-24 x 1-3/8") 1 16Plug, Insert (7/8") 1 17Screw, Socket Button Head w/ Patch (#10-32 x1/4")

1 28Washer (1/4 x 1/2 x 1/32") 1 29Spacer (5/16 x 1/2 x 3/16") 1 110Spacer, Threaded (10-32 x 1/4 x 5/8") 1 111Nut, Low Cap (5/16"-24) 1 112Housing, Latch - Right 1 113Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 214Locknut (1/4-20) 1 115Screw, Slotted Hex Washer Head w/ Patch (#10-32x 1/2")

1 116Pivot, Footrest 1 117

1140823 Package, Plug Button, Black (1") 10 138881130748 Legrest Support Tube Assembly, Sector, Color -

Left1 12 B

Plug Button, Black (1") 1 13Screw, Socket Button Head (1/4-20 x 1-3/4") 1 14Tube, Legrest Support, Sector, Color - Left 1 15Bolt, Lug (5/16-24 x 1-3/8") 1 16Plug, Insert (7/8") 1 17Screw, Socket Button Head w/ Patch (#10-32 x1/4")

1 28Washer (1/4 x 1/2 x 1/32") 1 29Spacer (5/16 x 1/2 x 3/16") 1 110Spacer, Threaded (10-32 x 1/4 x 5/8") 1 111Nut, Low Cap (5/16"-24) 1 112Housing, Latch - Left 1 113Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 214Locknut (1/4-20) 1 115Screw, Slotted Hex Washer Head w/ Patch (#10-32x 1/2")

1 116Pivot, Footrest 1 117

1140823 Package, Plug Button, Black (1") 10 131130749 Kit, Pivot Rod Assembly - Right 1 118 C





Package AssemblyLocknut (1/4-20) 1 119Lever, Release - Right 1 120Screw, Socket Button Head w/ Patch (#10-32 x1/4")

1 221Washer (1/4 x 1/2 x 1/32") 1 222Spacer, Threaded (10-32 x 1/4 x 5/8") 1 123Rod, Pivot 1 124NLA - Screw, Socket Button Head (1/4-20 x 1-1/4") 1 125Guide, Pivot Rod 1 126Rivnut (10-32 x 1") 1 127NLA - Screw, Phillips Pan Head w/Patch (#10-24 x3/8")

1 128Pin, Roller 1 129Spring, Torsion 1 130Cap, Brake Lever End, Black 1 131

1130584 Package, Cap, Brake Lever End, Black 10 1311130750 Kit, Pivot Rod Assembly - Left 1 118 C

Locknut (1/4-20) 1 119Lever, Release - Left 1 120Screw, Socket Button Head w/ Patch (#10-32 x1/4")

1 221Washer (1/4 x 1/2 x 1/32") 1 222Spacer, Threaded (10-32 x 1/4 x 5/8") 1 123Rod, Pivot 1 124NLA - Screw, Socket Button Head (1/4-20 x 1-1/4") 1 125Guide, Pivot Rod 1 126Rivnut (10-32 x 1") 1 127NLA - Screw, Phillips Pan Head w/Patch (#10-24 x3/8")

1 128Pin, Roller 1 129Spring, Torsion 1 130Cap, Brake Lever End, Black 1 131

1130584 Package, Cap, Brake Lever End, Black 10 1318881164115-NL

ANLA - Kit, Elevating Support Tube, Color - Right 1 132 DPlug, Insert (7/8") 1 17Locknut, Nylon Cap (5/16-24) 1 133Spacer (5/16 x 1/2 x 3/16") 1 134Bolt, Lug (5/16-24 x 1-3/8") 1 135Tube, Elevating Support, Color - Right 1 136Rivnut, Phillips Pan Head (10-24 x 1") 1 137Screw, Phillips Pan Head w/ Patch (10-24 x 3/8") 1 138Washer (#20) 1 139





Package AssemblyLocknut, Nylon Cap (5/16-24) 1 140

8881164116-NLA

NLA - Kit, Elevating Support Tube, Color - Left 1 132 DPlug, Insert (7/8") 1 17Locknut, Nylon Cap (5/16-24) 1 133Spacer (5/16 x 1/2 x 3/16") 1 134Bolt, Lug (5/16-24 x 1-3/8") 1 135Tube, Elevating Support, Color - Left 1 136Rivnut, Phillips Pan Head (10-24 x 1") 1 137Screw, Phillips Pan Head w/ Patch (10-24 x 3/8") 1 138Washer (#20) 1 139Locknut, Nylon Cap (5/16-24) 1 140

1130754 Kit, Legrest Pad Hardware 1 141 ET-Nut (1/4-20) 1 142Plate, Legrest Pad 1 143Locknut (5/16-18) 1 144Spacer, Legrest Pad, Black 1 145Bracket Assembly, Adjustable Legrest Pad, Color 1 146NLA - Washer, Steel (1/4 x 1/2 x 3/64") 1 147Screw, Hex Head w/ Patch (1/4-20 x 1/2") 1 148Screw, Socket Flat Head (5/16-18 x 2-1/4") 1 149

1130753 Kit, Pivot Slide Tube Attaching Hardware 1 150 FBolt, Lug (5/16-24 x 1-3/8") 1 151Washer (#20) 1 152Locknut, Nylon Cap (5/16-24) 1 153

1151367 Kit, Housing Latch Handle w/Hardware - Right 1 1Housing, Latch - Right 1 113Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 214Screw, Slotted Hex Washer Head w/ Patch (#10-32x 1/2")

1 1161151368 Kit, Housing Latch Handle w/Hardware - Left 1 1

Housing, Latch - Left 1 113Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 214Screw, Slotted Hex Washer Head w/ Patch (#10-32x 1/2")

1 116A - Includes items 2, 18, 32, and 41. Specify frame color when ordering this item. B - Includes items 3 thru 17. Specify frame color when ordering this item. C - Includes items 19 thru 31. D - Includes items 7 and 33 thru 40. Specify frame color when ordering this item. E - Includes items 42 thru 49. F - Includes items 51 thru 53. G - Includes items 13, 14 and 16.

NOTE:




1027095 Plug Button, Black (7/8") 1 1111919X000-NLA NLA - Screw, Slotted Truss Head (3/8-16 x 1-1/2") 1 12

1058636-NLA NLA - Washer, Nylon (25/64 x 7/8 x 1/32") 1 2340363X000 Hex Nut (3/8"-16) 1 14

7930330-NLA NLA - Locknut (5/16-24) 25 351026030 Bolt, Lug (5/16-24 x 1-3/8") 1 16

8881048851 Tube, Elevating Adjustable Support, Color - Right 1 17 A8881048852 Tube, Elevating Adjustable Support, Color - Left 1 17 A

1027097 Plug Button, Black (3/4") 1 188881058664-NL

ANLA - Tube, Legrest Support, Color - Right 1 19 A

8881058665-NLA

NLA - Tube, Legrest Support, Color - Left 1 19 A1022874 Bumper 1 1101030979 Screw, Phillips Pan Head Tap (#10-32 x 3/4") 1 111

8881058646-NLA

NLA - Legrest Support Assembly, Adult, Color -Right

1 1A,B8881058647-NL

ANLA - Legrest Support Assembly, Adult, Color - Left 1 1A,B

A - Specify frame color when ordering. See page titled "Frame Finishes and Touch-Up Paints". B - Not Shown

NOTE:

P904A Legrest Support Assembly(Pin Style)

Color 14"-24" Wide Chairs




1058478-NLA NLA - Tube, Legrest Support - Right 1 111058479-NLA NLA - Tube, Legrest Support - Left 1 11

1027097 Plug Button, Black (3/4") 1 1240363X000 Hex Nut (3/8"-16) 1 33

1022854-NLA NLA - Screw, Shoulder Slotted Head (1/2 x 1-1/8",3/8-16)

1 141022877-NLA NLA - Tube, Support and Drive Link, Chrome - Right 1 151022878-NLA NLA - Tube, Support and Drive Link, Chrome - Left 1 15

1022848 Tube, Slide, Articulating, Chrome - Right 1 161022849 Tube, Slide, Articulating, Chrome - Left 1 161027377 Washer (#20) 1 17

7930363-NLA NLA - Package, Locknut (5/16"-24) 25 1811232X009 Bolt, Lug (5/16-24 x 1-3/8") 1 19

1022866-NLA NLA - Screw, Socket Button Head (3/8-16 x 3/4") 1 2101049527 Washer, Nylon (3/8 x 3/4 x 1/16") 1 211

1022846-NLA NLA - Bar, Link, Black 1 1121058482-NLA NLA - Legrest Support Assembly, Articulating, Adult,

Chrome - Right1 1A

1058483-NLA NLA - Legrest Support Assembly, Articulating, Adult,Chrome - Left

1 1AA - Not Shown NOTE:

PAS4A/PAL4A Articulating Legrest Support Assembly(Pin Style)

Chrome 14"-24" Wide Chairs


Legrest Release Handles and Ratchets


Legrest Release Handles and RatchetsItem


Package Assembly7930328-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x

11/16")25 11

7930335-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x1/2")

25 121035539 Handle, Release, Black - Right 1 131035540 Handle, Release, Black - Left 1 13

47565X057 Bushing (7/32 x 3/8 x 11/32") 1 141028707 Spring, Release - Right 1 151028708 Spring, Release - Left 1 15

7930332-NLA NLA - Locknut, High Profile (#10-32) 25 161028846-NLA NLA - Rivnut (#10-32) 25 17

1040060 Tip, Plastic, Black 1 187930310-NLA NLA - Washer, Nylon (5/16 x 11/16 x 1/16") 1 1942326X004 Bar, Ratchet - Right/Left 1 110 C

1023811-NLA NLA - Bar, Ratchet - Right 1 110 D1023812-NLA NLA - Bar, Ratchet - Left 1 110 D47328X003 Bushing, Pivot (5/16 x 7/16 x 7/8") 1 111

1040831 Ring, Snap 1 1121037125 Cam, Legrest 1 1131037485 Spring, Release 1 114

7930336-NLA NLA - Nut, Acorn (5/16-24) 25 11504528X002 Bracket, Release, Black 1 116

1037126 Handle, Release 1 1171046329 Kit, Elevating Legrest Ratchet Hardware (Pair) 2 118 A

1046331-NLA NLA - Kit, Articulating Legrest Ratchet Hardware(Pair)

2 118 BA - P904A Legrest B - PAS4A and PAL4A Legrest C - P904A Legrest D - Articulating

NOTE:


Calf Pads and Attaching HardwareNOTE: For replacement calf pads for Power Articulating Legrest, see Power Articulating Legrest page.

Due to a change to the Legrest Calf Pad size made on 4/23/12, you must also order the hardware kit(1066591) when ordering replacement Calf Pads.


Calf Pads and Attaching HardwareNOTE: For replacement calf pads for Power Articulating Legrest, see Power Articulating Legrest page.

Due to a change to the Legrest Calf Pad size made on 4/23/12, you must also order the hardware kit(1066591) when ordering replacement Calf Pads.



8881091759 Pad w/ Cover and Screws, Legrest Vinyl (Pair) 2 11 A,D8881091764 Pad, Legrest, Vinyl - Right/Left 1 11 A,D

88804529X003 Pad, Legrest, Vinyl - Right 1 11 A,B,D88804529X004 Pad, Legrest, Vinyl - Left 1 11 A,B,D

04526X019 Plate, Legrest Pad 1 127930330-NLA NLA - Locknut (5/16-24) 25 13

1025133 Spacer, Legrest Pad, Black 1 141032267 Spacer, Legrest Pad Mounting, Black 1 151037110 Screw, Hex Head (5/16-24 x 3-1/2") 1 161028514 Screw, Hex Head (5/16-24 x 1-1/2") 1 171066591 Hardware, Legrest Pad 1 18 C

Screw, Phillips Pan Head (#10-32 x 11/16") 1 2Screw, Phillips Pan Head (#10-32 x 1") 1 2Instruction Sheet, Legrest Pad Mtg. 1 1

48823X008 Spring, Leaf 1 197930363-NLA NLA - Package, Locknut (5/16"-24) 25 210

1025104 Bracket, Legrest, Chrome 1 1111014807 Screw, Hex Head (5/16-24 x 3-1/4") 1 1121032266 Bracket, Legrest Pad Mounting, Black 1 113

A - Specify upholstery color. See page titled "Frame Finishes, Touch-Up Paints and Upholstery Options". B - 14"-15" Wide Chairs C - Includes Screws and Instruction Sheet. D - Due to a change to the Legrest Calf Pad size made on 4/23/12, you must also order the hardware kit (1066591) when

ordering replacement Calf Pads.

NOTE:


PW93 Footrest Supports(Pin Style)

Color


PW93 Footrest Supports(Pin Style)

ColorItem


Package Assembly1020719 Anti-Rattle, Black 1 11

47565X057 Bushing (7/32 x 3/8 x 11/32") 1 121025716 Screw, Phillips Pan Head (#10-32 x 11/16") 1 131026114 Screw, Phillips Pan Head (#10-32 x 1/2") 1 141035539 Handle, Release, Black - Right 1 151035540 Handle, Release, Black - Left 1 151025735 Locknut (#10-32) 1 16

1028846-NLA NLA - Rivnut (#10-32) 1 171028707 Spring, Release - Right 1 181028708 Spring, Release - Left 1 18

15680X012 Collar, Anti-Rattle (7/8") 1 191070759 Screw, Hex Head (1/4-20 x 1-1/2") 1 1101026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 2111044214 Nut, Hex with Nylon Cap (1/4-20) 1 1121020534 Insert, Threaded 1 113 C1074143 Kit, Slide Tube Mounting Hardware 1 114

8881070776 Footrest Support Assembly, Adult, Color - Right 1 1A,B8881070777 Footrest Support Assembly, Adult, Color - Left 1 1A,B

A - Specify frame color when ordering. See page titled "Frame Finishes, Touch-Up Paints and Upholstery Options". B - Not Shown. C - As of 8/15/03, the Threaded Insert was revised from 3 to 5 Holes. Threaded Insert is Backward Compatible and does not

require ordering in Pairs.

NOTE:


PW93ST Footrest Supports(Pin Style)

Color


PW93ST Footrest Supports(Pin Style)

ColorItem


Package Assembly1025716 Screw, Phillips Pan Head (#10-32 x 11/16") 1 111026114 Screw, Phillips Pan Head (#10-32 x 1/2") 1 121035539 Handle, Release, Black - Right 1 131035540 Handle, Release, Black - Left 1 131025735 Locknut (#10-32) 1 14

1028846-NLA NLA - Rivnut (#10-32) 1 151030434-NLA NLA - Cushion, Tubular Foam 1 161030435-NLA NLA - Cover, Foam Cushion 1 17

1028707 Spring, Release - Right 1 181028708 Spring, Release - Left 1 18

47565X057 Bushing (7/32 x 3/8 x 11/32") 1 1915680X012 Collar, Anti-Rattle (7/8") 1 110

1070759 Screw, Hex Head (1/4-20 x 1-1/2") 1 1111026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 2121044214 Nut, Hex with Nylon Cap (1/4-20) 1 1131020534 Insert, Threaded 1 114 C1074143 Kit, Slide Tube Mounting Hardware 1 115

8881070784-NLA

NLA - Footrest Support Assembly, Adult, Color -Right

1 1A,B8881070785-NL

ANLA - Footrest Support Assembly, Adult, Color -Left

1 1A,BA - Specify frame color when ordering. See page titled "Frame Finishes, Touch-Up Paints and Upholstery Options". B - Not Shown C - As of 8/15/03, the Threaded Insert was revised from 3 to 5 Holes. Threaded Insert is Backward Compatible and does not


NOTE:


PW93E Footrest Supports(Pin Style)

Color


PW93E Footrest Supports(Pin Style)

ColorItem


Package Assembly15680X012 Collar, Anti-Rattle (7/8") 1 21

1027095 Plug Button, Black (7/8") 1 221022874 Bumper 1 131030979 Screw, Phillips Pan Head Tap (#10-32 x 3/4") 1 141035539 Handle, Release, Black - Right 1 151035540 Handle, Release, Black - Left 1 151025716 Screw, Phillips Pan Head (#10-32 x 11/16") 1 16

47565X057 Bushing (7/32 x 3/8 x 11/32") 1 171026114 Screw, Phillips Pan Head (#10-32 x 1/2") 1 181028707 Spring, Release - Right 1 191028708 Spring, Release - Left 1 19

1028846-NLA NLA - Rivnut (#10-32) 1 1101025735 Locknut (#10-32) 1 1111074108 Cap, End Tube, Black (3/4") 1 1121020534 Insert, Threaded 1 113 C1070759 Screw, Hex Head (1/4-20 x 1-1/2") 1 1141026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 2151044214 Nut, Hex with Nylon Cap (1/4-20) 1 1161074143 Kit, Slide Tube Mounting Hardware 1 117

8881070768-NLA


1 1A,B8881070769-NL


1 1A,BA - Specify frame color when ordering. See page titled "Frame Finishes, Touch-Up Paints and Upholstery Options". B - Not Shown C - As of 8/15/03, the Threaded Insert was revised from 3 to 5 Holes. Threaded Insert is Backward Compatible and does not


NOTE:




7930359-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x1/2")

25 117930360-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x

11/16")25 12

47565X057 Bushing (7/32 x 3/8 x 11/32") 1 131107321 Nut, Low Cap (5/16"-24) 1 141027095 Plug Button, Black (7/8") 1 25

11232X009 Bolt, Lug (5/16-24 x 1-3/8") 1 161008935 Spring, Release - Right 1 171008936 Spring, Release - Left 1 171022874 Bumper 1 181030979 Screw, Phillips Pan Head Tap (#10-32 x 3/4") 1 19

67005X000 Rivnut (#10-32) 1 1107930365-NLA NLA - Locknut (#10-32) 25 111

1035539 Handle, Release, Black - Right 1 1121035540 Handle, Release, Black - Left 1 112

8881037836-NLA


1 1A,B8881037837-NL


1 1A,BA - Specify frame color when ordering. See page titled "Frame Finishes, Touch-Up Paints and Upholstery Options". B - Not Shown

NOTE:

P93M Footrest Supports(Pin Style)

Color


Footplate and Pivot Tube Assemblies1651 Composite


Footplate and Pivot Tube Assemblies1651 Composite



See Chart #1 AT5044 Elevating Legrest - Wedge Style 1 11 A1134427 Package, Plug Button, Black, "D" Shaped (3/4") 10 121134428 Pivot/Slide Tube w/ D Insert, Black 1 131134429 Pivot/Slide Tube w/ D Insert, Black (2" Longer) 1 131026879 Footplate, Composite, Small, Black (6" W x 6" L) 1 141026880 Footplate, Composite, Medium, Black (7" W x 6" L) 1 141026881 Footplate, Composite, Large, Black (8" W x 6" L) 1 141025195 Locknut (1/4-20) 1 15

60285X006 Screw, Socket Head (1/4-20 x 2-1/4") 1 161025457 Spacer, Coved (1/4 x 3/4 x 11/32") 1 27

A - Includes items 2-7 NOTE: #1 AT5044 Elevating Legrest - Wedge Style

Curved End

Right/LeftLarge

2" Longer17" - 24" Wide

SmallLong

14" WideSmall

2" Longer14" Wide

MediumLong

15" - 16" WideMedium

2" Longer15" - 16" Wide

LargeLong

17" - 24" Wide113211111320821132109113208011321071132078Right113211211320831132110113208111321081132079Left




1057852 Tube, Pivot/Slide, Curved End, Steel, Black (9-7/8") 1 111057854 Tube, Pivot/Slide, Curved End, 2" Longer, Steel,

Black 1 11

1058418 Tube, Pivot/Slide, Curved End, 4" Longer, Steel,Black

1 111025457 Spacer, Coved (1/4 x 3/4 x 11/32") 1 221027097 Plug Button, Black (3/4") 1 13

7930323-NLA NLA - Package, Locknut (1/4-20) 25 147930366 Package, Socket Head Screw (1/4-20 x 2-1/4") 25 151026879 Footplate, Composite, Small, Black (6" W x 6" L) 1 16 A1026880 Footplate, Composite, Medium, Black (7" W x 6" L) 1 16 B1026881 Footplate, Composite, Large, Black (8" W x 6" L) 1 16 C1026879 Footplate, Composite, Small, Black (6" W x 6" L) 1 16 D1026880 Footplate, Composite, Medium, Black (7" W x 6" L) 1 16 E1026881 Footplate, Composite, Large, Black (8" W x 6" L) 1 16 F

A - 13"-14" Wide B - 15"-16" Wide C - 17" and Wider D - 15"-17" Wide 70ST TAPER and PW93ST E - 18"-19" Wide 70ST TAPER and PW93ST F - 20" and Wider 70ST TAPER and PW93ST

NOTE:

Pivot/Slide Tube and 1651 Composite FootplatesNOTE: Heel Loops are not included. See footrest and legrest accessories.

NOTE: For complete pivot/slide tube and footplate assemblies, see front riggings reference charts


Pivot/Slide Tube and 1650, 1450, 1350 AluminumFootplates

NOTE: Heel Loops are not included. See footrest and legrest accessoriesNOTE: For complete pivot/slide tube and footplate assemblies, see front riggings reference charts.






1027097 Plug Button, Black (3/4") 1 111048834 Pivot/Slide Tube w/ Plug Button, Black 1 12 A1098906 Pivot/Slide Tube w/ Plug Button, Black (2" Longer) 1 12 A1086482 Pivot/Slide Tube w/ Plug Button, Black (4" Longer) 1 12 A1041526 Pivot/Slide Tube w/ Plug Button Assembly, Chrome 1 12 B1041527 Pivot/Slide Tube w/ Plug Button, Black 1 12 C

1100568-NLA NLA - Pivot/Slide Tube w/ Plug Button, Black 1 12 D1100569-NLA NLA - Pivot/Slide Tube Assembly, Extra Large,

Standard Aluminium - 2" Longer, Black1 12 D

1100570-NLA NLA - Pivot/Slide Tube w/ Plug Button, Black (4"Longer)

1 12 D1041527 Pivot/Slide Tube w/ Plug Button, Black 1 12 E1041526 Pivot/Slide Tube w/ Plug Button Assembly, Chrome 1 12 F

1100571-NLA NLA - Pivot/Slide Tube w/ Plug Button, Deluxe,Black

1 12 G1041525-NLA NLA - Pivot/Slide Tube w/ Plug Button, Deluxe

Aluminum, Black1 12 H

44200X059 Footplate, Aluminum, Small, Black (6-3/4" W x 6" L) 1 1344200X027 Footplate, Aluminum, Medium, Black (7-3/4" W x 6"

L)1 13

1043659-NLA NLA - Footplate, Aluminum, Deluxe, Black - Right(8" W x 5-3/4" L)

1 131043660-NLA NLA - Footplate, Aluminum, Deluxe, Black - Left (8"

W x 5-3/4" L)1 13

44200X025 Footplate, Aluminum, Extra Large, Black - Right (8"W x 8-1/2" L)

1 1344200X026 Footplate, Aluminum, Extra Large, Black - Left (8" W

x 8-1/2" L)1 13

1016346 Cap, End, Tube, Black (7/8") 1 14 I1027095 Plug Button, Black (7/8") 1 14 J1006981 Spring, Tension 1 25 I

1036120-NLA NLA - Spring 1 25 L1036123 Spring, Leaf 1 15 J,M

7930354-NLA NLA - Package, Phillips Head Screw (#8-32 x 3/8") 25 26 K1070168 Plug, Push, Footplate 1 17




A - Extra Large footplate for 60MFX, AT5544, 60, 70, PW93, PW93E B - Extra Large footplate for PAL4A C - Extra Large footplate for P93M D - Extra Large and Standard Aluminum footplate for P904 E - Standard Aluminum footplate for P93M F - Standard Aluminum footplate for PAL4 G - Deluxe Aluminum footplate for P904 and AT5544 H - Deluxe Aluminum footplate for P93M I - For Standard Aluminum footplate J - For Extra Large footplate K - Deluxe footplate takes 1 ea. L - Deluxe footplate M - Use one or more leaf springs per assembly as required such that footplate may be moved by hand to the up-right position

and remain in place.

NOTE:


Footplate and Pivot/Slide Tube Assemblies1350 Extra Large Aluminum


Footplate and Pivot/Slide Tube Assemblies1350 Extra Large Aluminum



See Chart #9 Pivot/Slide Tube w/ Extra Large AluminumFootplate Assembly

1 11 A1134427 Package, Plug Button, Black, "D" Shaped (3/4") 10 121134431 Pivot/Slide Tube w/ Plug Buttons, Black 1 131025729 Screw, Phillips Pan Head Tap (#8-32 x 3/8") 1 241002343 Footplate, Aluminum, Extra Large, Black - Right (7"

W x 8-1/2" L)1 15

1002344 Footplate, Aluminum, Extra Large, Black - Left (7" Wx 8-1/2" L)

1 1544200X025 Footplate, Aluminum, Extra Large, Black - Right (8"

W x 8-1/2" L)1 15

44200X026 Footplate, Aluminum, Extra Large, Black - Left (8" Wx 8-1/2" L)

1 151130582 Package, Plug Button, Black (7/8") 10 161036123 Spring, Leaf 1 17

A - Includes items 2-7. NOTE:

#1 Pivot/Slide Tube w/ Extra Large Aluminum Footplate Assembly

Footplate Style Chair Width Right Left1153942115394114" - 15"AT5044, AT5044LIFT1132085113208416" - 24"AT5044, AT5044LIFT




1044082-NLA NLA - Footplate, Black (4-1/4" W x 5-1/4" L) (12" W) 1 111029454-NLA NLA - Washer, Nylon (3/16 x 3/4 x 5/32") 1 22

1025457 Spacer, Coved (1/4 x 3/4 x 11/32") 1 531027097 Plug Button, Black (3/4") 1 241163311 Screw, Socket Button Head (10-32 x 1-1/4") 1 251008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 16

1023967-NLA NLA - Screw, Socket Button Head (1/4-20 x 2-5/8") 1 171029428-NLA NLA - Tube, Footrest, Black 1 181028417-NLA NLA - Cam, Adjustment 1 1940157X020 Spacer, Coved (1/4 x 1 x 9/16") 1 110

7930333 Locknut (1/4-20) 25 1111018739 Washer (1/4 x 5/8 x 3/32") 1 212

1029434-NLA NLA - Flip-Up Footplate Assembly, Black - Right 1 1131029435-NLA NLA - Flip-Up Footplate Assembly, Black - Left 1 113

AT5043 Flip-Up Footplates70deg MFX and 90deg Swingaway Supports

NOTE: Heel Loops are not included. See footrest and legrest accessories.


Adjustable Angle Footplate Assemblies - AT554360deg, 60deg MFX, 70deg, 70deg MFX, PW93, PW93E, 90DEG, AT5544,

P904, PAS4A/PAL4A Swingaway SupportsNOTE: Heel loops are not included. See footrest and legrest accessories.






See Chart Pivot/ Slide Tube with Footplate Assemblies 1 11 A1113572 Footplate, Adjustable Angle, Medium, Black (4-1/4"

W x 8" L)1 12 B,F

1113573 Footplate, Adjustable Angle, Large, Black (5-1/4" Wx 8" L)

1 12 C,F1113574 Footplate, Adjustable Angle, Extra Large, Black

(6-1/4" W x 8" L)1 12 D,F

1058517 Clamp, Footplate 1 131057855 Tube, Pivot and Slide, Straight, Steel, Black (9-7/8"

L)1 14

1057856 Tube, Pivot/Slide, Straight, Steel, Black (11-7/8" L) 1 141121135 Tube, Pivot/Slide, Straight, Steel, Black (13-7/8" L) 1 141091745 Tube, Pivot/Slide, Straight, Steel, Chrome (13-7/8"

L)1 14 E

1048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 151052102 Hinge, Footplate - Right 1 161052103 Hinge, Footplate - Left 1 161029545 Screw, Socket Flat Head (1/4-20 x 3/4") 1 27

7930321-NLA NLA Package, Screw, Socket Button Head (1/4-20 x1-7/8")

25 181026900 Washer (1/4 x 23/32 x 1/16") 1 197930313 Package, Washer, Nylon (5/16 x 7/8 x 1/8") 25 1101036435 Washer, Nylon (1/4 x 7/8 x 1/32") 1 1111025457 Spacer, Coved (1/4 x 3/4 x 11/32") 1 1121026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 1131026907 Washer (1/4 x 1/2 x 1/16") 1 1147930333 Locknut (1/4-20) 25 1151082686 Nut, Barrel, Hex Head (1/4-20 x 11/16") 1 216

A - Includes Items 2 thru 16. B - For 12-13" wide chairs C - For 14-15" wide chairs D - For 16" and wider chairs E - For PAS4A/PAL4A only. F - The footplate design was revised 9/2/2008 with rounder corners and accessory holes changed from 8 to 4. Recommended

to replace in pairs to match sides.

NOTE:

#1 Pivot/ Slide Tube with Footplate Assemblies

Rigging Types90 and 70MFX

FootplateAssembly

w/oPivot/SlideTube

60, 60MFX, 70PW93, PW93EAT5544, P904(9-7/8" Tube)



PAS4A andPAL4A

(13-7/8" Tube)




#1 Pivot/ Slide Tube with Footplate Assemblies

Rigging Types90 and 70MFX

FootplateAssembly

w/oPivot/SlideTube




PAS4A andPAL4A

(13-7/8" Tube)

N/AN/AN/A10604421060436-NLA12-13" W, Right(4-1/4" Footplate)

N/AN/AN/A1060443106043712-13" W, Left(4-1/4" Footplate)

10917751121138-NLA10627581060444106043814-15" W, Right(5-1/4" Footplate)

10917761121139-NLA10627591060445106043914-15" W, Left(5-1/4" Footplate)

1091777112114010627601062756106257016" and Wider,

Right(6-1/4" Footplate)

1091778112114110627611062757106257116" and Wider,

Left(6-1/4" Footplate)


Adjustable Angle Footplate Assemblies AT5543 ForAT5044


Adjustable Angle Footplate Assemblies AT5543 ForAT5044



See Chart #15 Wedge Style AT5044 Elevating Legrests 1 11 A1134427 Package, Plug Button, Black, "D" Shaped (3/4") 10 121134433 Pivot/Slide Tube w/ D Insert, Black 1 131134432 Pivot/Slide Tube w/ D Insert, Black (2" Longer) 1 131113578 Screw, Socket Flat Head (1/4-28 x 3/4") 1 241113573 Footplate, Adjustable Angle, Large, Black (5-1/4" W

x 8" L)1 15

1113574 Footplate, Adjustable Angle, Extra Large, Black(6-1/4" W x 8" L)

1 151113575 Footplate, Adjustable Angle, XX- Large, Black

(7-1/4" W x 8" L)1 15

1113528 Bracket, Adjustable Angle Footplate, Black 1 161025765 Locknut (1/4-28) 1 271096810 Screw, Socket Head (1/4-28 x 1-3/4") 1 181113529 Hinge, Adjustable Angle Footrest 1 191113530 Attachment, Hinge 1 1101065362 Locknut (1/4-28) 1 1111114688 Spacer, Hinge, Black 1 1121021344 Screw, Socket Head (5/16-18 x 1-1/2") 1 113

A - Includes items 2-13. NOTE:

#1 Adjustable Angle Footplates w/ Pivot TubesWedge Style AT5044 Elevating Legrests

StraightSlide Tube(10-1/4")

Right LeftALPT Straight

Slide Tube(12-1/4")

Right Left

1132090113208914" - 15" Wide(5-1/4" Footplate)1132062113206114" - 15" Wide

(5-1/4" Footplate)1132092113209116" - 17" Wide

(6-1/4" Footplate)1132064113206316" - 17" Wide(6-1/4" Footplate)

1132094113209318" - 24" Wide(7-1/4" Footplate)1132066113206518" - 24" Wide

(7-1/4" Footplate)


S1263 One Piece Wooden Footboard and Hardware


S1263 One Piece Wooden Footboard and HardwareItem


Package AssemblySee Chart #1 One Piece Wooden Footboard without Hardware 1 11See Chart Heel Loop Hardware Packages (not shown) 1 1A1054573 Kit, Wooden Footboard Mounting Hardware 1 12 B

NLA - Screw, Phillips Oval Head (#10-32 x 1-1/2") 1 13NLA - Screw, Phillips Oval Head (#10-32 x 1-1/4") 1 34Tube, Pivot/Slide, Chrome - Right (9-1/2" L) 1 15Tube, Pivot/Slide, Chrome - Left (9-1/2" L) 1 15Plug Button, Black (3/4") 1 26Locknut (#10-32) 1 47Cap, End, Tube, Black (7/8") 1 28Lock, Pad Plate, Legrest, Black 1 19Clamp, Black 1 210NLA - Washer, Nylon (3/16 x 7/16 x 1/8") 1 311NLA - Link, Locking, Chrome 1 112

A - Not Shown. B - Includes items 3-12

NOTE:

#1 One Piece Wooden Footboard without Hardware

NOTE: When selecting a wooden footboard for PW93ST or 70 Degree Tapered Footrest, order a 3"narrower footboard to accommodate the 1.5" footrest taper per side. Example: 17" wide chair will use a

14" wide chair footboard. S1263 option is not available for tapered footrest less than 17" wide.Footrest-

Footboard w/Heel Loop Holes

Part Number

Footrest-Footboard w/o

Heel Loop HolesPart Number

ChairWidth

FootboardWidth

FootboardDepth

6"11-5/8"14"48247X003-NLA1034245-NLA6"12-1/2"15"1031910-NLA1034246-NLA6"13-3/4"16"48247X0011034247-NLA6"14-1/2"17"1031911-NLA1034248-NLA6"15-9/16"18"48247X000-NLA1034249-NLA6"16-1/2"19"1031912-NLA1034250-NLA6"17-1/2"20"1031913-NLA1034251-NLA6"18-1/2"21"1031914-NLA1034252-NLA6"19-1/2"22"1031915-NLA1034253-NLA6"20-1/2"23"1031916-NLA1034254-NLA6"21-1/2"24"1031917-NLA1034255-NLA


S1263 One Piece Wooden Footboard and HardwareHeel Loop Hardware Packages (not shown)

(All hardware is included to attach heel loops to footboard.)

Chair Width Part Number PackageIncludes

2 each Heel Loops4 each Screw,

PPH (1/4-20 x 3")4 each Spacer

(1/4 x 11/32 x 1-3/4")4 each Locknut

(1/4-20)

1033904-NLA14-15" Wide

2 each Heel Loops4 each Screw,

PPH (1/4-20 x 3")4 each Spacer

(1/4 x 11/32 x 1-3/4")4 each Locknut

(1/4-20)

1033905-NLA16"-24" Wide


Footrest and Legrest AccessoriesNOTE: Heel loop replacements for Power Articulating Legrest can be found on the Power Articulating

Legrest page.Item


Package Assembly1032243 Strap, Calf w/ Hook and Loop (36" L) 1 1A1032214 H-Strap (24" L) 1 1A,C1032215 H-Strap (26" L) 1 1A,D1032216 H-Strap (31" L) 1 1A,E

8881038231 Kit, 3" Extension w/ Hardware (Pair) 2 1A,B1026987 Guard, Impact (8" L) 1 2A,F

See Chart Heel Loops and Hardware (Not IncludingAT5043/AT5543)

1 1ASee Chart Attaching Hardware Part Numbers (Not Including

AT5043/AT5543)1 1A

See Chart AT5043 and AT5543 Heel Loops, Heel Loops w/Ankle Straps and Hardware

1 1ASee Chart Toe Loops and Hardware 1 1A

A - Not Shown B - Specify frame color when ordering. See page titled "Frame Finishes and Touch-Up Paints". C - 12-14" wide seats D - 15-16" wide seats E - 17" and wider seats F - For 70 deg. Tapered Footrest.

NOTE:

Heel Loops and Hardware (Not Including AT5043/AT5543)

FootplateType

Heel Loop w/Ankle Strap

Pair #Attaching Hardware

Pair #ChairWidth

Heel LoopSingle #

Heel LoopPair #

Heel Loop w/Ankle StrapSingle # Rt.

Heel Loop w/Ankle StrapSingle # Lt.

103593110359061035909-NLA1035908-NLA1035912-NLA1028412-NLA13-14" W

or15-17" WTapered

CompositeSmall(1651)

10359311035918103592010359191035917101762115-16" W

or18-19" WTapered

CompositeMedium(1651)

103593110359301035933-NLA1035932-NLA1035917101762117-24" W

or20-24" WTapered

CompositeLarge(1651)

103590710359061035909-NLA1035908-NLA10359051025234-NLA14-15" WStandardAluminum

(1650)10359071035918103592010359191035917101762116-24" W

StandardAluminum

(1650)1086112-NLA1035918103592010359191035917101762116-24" W

DeluxeAluminum

(1450)70



Legrest page.Heel Loops and Hardware (Not Including AT5043/AT5543)

FootplateType

Heel Loop w/Ankle Strap

Pair #Attaching Hardware

Pair #ChairWidth

Heel LoopSingle #

Heel LoopPair #

Heel Loop w/Ankle StrapSingle # Rt.

Heel Loop w/Ankle StrapSingle # Lt.

10552411035918103592010359191035917101762116-24" WX-Large

Aluminum(1350)

Attaching Hardware Part Numbers (Not Including AT5043/AT5543)

FootplateType

PartNumber

Part Number

Consists of(2) Screw, Phillips Pan Head

(1/4-20 x 2-1/4")(2) Spacer (1/4 x 11/32 x 1-3/4")

(2) Hex Nut w/ Nylon Cap (1/4-20)(2) Flat Washer (1/4 x 5/8 x 1/16")

1035931Composite(1651)

(2) Screw, Phillips Pan Head(1/4-20 x 2-1/2")

(2) Spacer (1/4 x 11/32 x 1-3/4")(2) Locknut (1/4-20)

1035907StandardAluminum

(1650)(2) Screw, Phillips Pan Head

(1/4-20 x 2-1/2")(2) Spacer (1/4 x 11/32 x 1-3/4")

(2) Locknut (1/4-20)1086112-NLA

DeluxeAluminum

(1450)(2) Screw, Phillips Pan Head

(1/4-20 x 2-1/4")(2) Spacer (1/4 x 11/32 x 1-3/4")

(2) Locknut (1/4-20)1055241

X-LargeAluminum

(1350)



Legrest page.AT5043 and AT5543 Heel Loops, Heel Loops w/ Ankle Straps and Hardware

FootplateType

PartNumber

Part Number

Consists of(2) Heel Loops(4) Screw, PPH(1/4-20 x 2-1/4")

(4) Spacer(4) Locknut (1/4-20)

1160723Kit, Heel Loop w/ Hardware,

Adjustable Angle Footplate (Pair)AT5043 Flip-Up

andAT5543 Adj. Angle

(2) Heel Loops w/ Ankle Straps(4) Screw, PPH(1/4-20 x 2-1/4")

(4) Spacer(4) Locknut (1/4-20)

1160724Kit, Heel Loop w/ Ankle Strap and

Hardware, Adjustable AngleFootplate (Pair)

AT5043 Flip-Upand

AT5543 Adj. Angle(2) Screw, Phillips Pan Head

(1/4-20 x 2-1/4")(2) Spacer (1/4 x 11/32 x 1-3/4")

(2) Hex Nut w/ Nylon Cap (1/4-20)(2) Flat Washer (1/4 x 5/8 x 1/16")

1035931Kit, Heel Loop Attaching Hardware

(Pair)Attaching Hardware Only

Toe Loops (1345) and Attaching Hardware

FootplateType

Toe Loopw/o Hardware

Single #Toe Loop

w/o HardwarePair #

AttachingHardware

Part NumberAttaching Hardware

Consists of(4) Screw, Phillips Pan

Head(10-32 x 7/8")(4) Washer

(1/4 x 3/4 x 3/32")(4) Locknut

(10-32)

1037089103708704572X0251651,1650,1450,1350,

Footplates(4) Screw, Phillips Pan

Head(10-32 x 1/2")(4) Washer

(1/4 x 3/4 x 3/32")1104749103708704572X025

AT5043and

AT5543Footplates


Front Riggings - Adjustable Heel Loops


Front Riggings - Adjustable Heel LoopsItem


Package Assembly1191117 Kit, Heel Loop, Adjustable w/ Hardware (Pair) 1 11 A

Heel Loop 1 22NLA - Spacer (1/4 x 11/32 x 1-3/4") 1 23NLA - Screw, Phillips Pan Head (1/4-20 x 2-1/4") 1 24Washer, Flat (1/4 x 5/8 x 1/16") 1 25Nut, Hex, Nylon Cap (1/4-20) 1 26Instruction Sheet, Adjustable Heel Loop 1 1

1191116 Kit, Heel Loop, Adjustable w/ Hardware, Deluxe1450 (Pair)

1 111 BHeel Loop 1 22NLA - Spacer (1/4 x 11/32 x 1-3/4") 1 23Nut, Hex, Nylon Cap (1/4-20) 1 26NLA - Screw, Phillips Pan Head (1/4-20 x 2-1/2") 1 27Instruction Sheet, Adjustable Heel Loop 1 1

A - Kit includes items 2 - 6. Used with all Footplates except Deluxe (1450). B - Kit includes items 2, 3, 6, and item 7. Used with Deluxe (1450) Footplates only.

NOTE:


Power Articulating LegrestPOWELR18/POWELR20 (Before 9/15/01)





1101112-NLA NLA - Legrest Support Assembly, Sector, Black -Right

1 11 A,G1101113-NLA NLA - Legrest Support Assembly, Sector, Black -

Left1 11 A,G

1025454 Housing, Latch - Right 1 121025455 Housing, Latch - Left 1 127930314 Package, Screw, Slotted Hex Washer Head (#10-32

x 1/2")1 13

1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 25 241099685 Plug, Pivot 1 151091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 16

1099694-NLA NLA - Pad, Cushion - Right 1 17 G1099695-NLA NLA - Pad, Cushion - Left 1 27 G

1099671 Bearing, Flange (1/4 x 5/16" Long) 1 281040755 Spacer, Nylon (3/8 x 7/8 x 1/32") 1 19

1006773-NLA NLA - Screw, Socket Button Head (1/4-20 x 1/2") 1 1101012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 2111022597 Screw, Phillips Pan Head Tap (#10-32 x 3/8") 1 1121025729 Screw, Phillips Pan Head Tap (#8-32 x 3/8") 1 113

1014386-NLA NLA - Screw, Phillips Pan Head (#8-32 x 5/8") 1 1141099699-NLA NLA - Bracket, Cover 1 315 G1099687-NLA NLA - Sleeve (5/16 x 3/8 x 7/8") 1 116 G1099692-NLA NLA - Cover, Legrest Support - Right 1 117 G1099693-NLA NLA - Cover, Legrest Support - Left 1 117 G

1102934 Linkage Assembly, Power Leg 1 11860285X012-NLA NLA - Screw, Socket Flat Head (1/4-20 x 2") 1 119

1043599-NLA NLA - Washer, Flat (5/32 x 3/8 x 1/32") 1 2201009838 Screw, Socket Button (1/4-20 x 3/4") 1 1211091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 222

1101398-NLA NLA - Motor, Actuator 1 1231026158 Locknut (5/16-18) 1 2241028769 Locknut (5/16-18) 1 125

1101267-NLA NLA - Screw, Socket Button Head (5/16-18 x 1-1/2") 1 2261101214-NLA NLA - Screw, Socket Button Head (5/16-18 x 2-1/2") 1 1271099667-NLA NLA - Block, Pivot 1 128

1099684 Bearing, Flange (1/4 x 3/4" Long) 1 2291044214 Nut, Hex with Nylon Cap (1/4-20) 1 1300175600 Spacer, Coved (5/16 x 3/4 x 3/8") 1 2311082699 T-Nut (1/4-20) 1 1432

1038785-NLA NLA - Pin, Roll (1/8 x 3/8") 1 1331101883 Glide 1 534

1104102-NLA NLA - Extrusion, Internal Slide - Short (16-3/4" L) 1 135 B,G1104104-NLA NLA - Extrusion, Internal Slide Long (18-3/4" L) 1 135 B,H





1099702 Glide, Internal 1 1361018846 Screw, Socket Button Head (#10-24 x 3/4") 1 137

1099698-NLA NLA - Bracket, Actuator 1 138 G1026907 Washer (1/4 x 1/2 x 1/16") 1 8391100023 Screw, Button Head w/ Patch (1/4-20 x 1/2") 1 1140

1099686-NLA NLA - Bearing, Linear 1 141 G1099676-NLA NLA - Extrusion, External - Short (14-1/2" L) 1 1421099679-NLA NLA - Extrusion, External - Long (16-1/2" L) 1 1421099665-NLA NLA - Plate, Side Pivot 1 1431099666-NLA NLA - Block, Slide 1 144 G7930335-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x

1/2")25 245

1101116-NLA NLA - Calf Pad Bracket Assembly, Black 1 146 G88804529X003 Pad, Legrest, Vinyl - Right 1 14788804529X004 Pad, Legrest, Vinyl - Left 1 1471023965-NLA NLA - Screw, Socket Head (#10-32 x 1-1/2") 1 248

1028516 Washer, Steel (3/16 x 7/16 x 1/16") 1 2491015629-NLA NLA - Bushing 1 250

1101268 Heel Loop Assembly - Right 1 151 F1101269 Heel Loop Assembly - Left 1 151 F7930333 Locknut (1/4-20) 25 1521029545 Screw, Socket Flat Head (1/4-20 x 3/4") 1 253

1060427-NLA NLA - Footplate, Adjustable Angle, Large, Black(5-1/4" W x 8" L)

1 1541008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 1551082686 Nut, Barrel, Hex Head (1/4-20 x 11/16") 1 2561058517 Clamp, Footplate 1 1571052102 Hinge, Footplate - Right 1 1581052103 Hinge, Footplate - Left 1 1581048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 1597930313 Package, Washer, Nylon (5/16 x 7/8 x 1/8") 25 2601099678 Extrusion, Footplate Adapter 1 1611101114 Footplate Assembly, Adjustable Angle, Black - Right

(5-1/4" W)1 162 D

1101115 Footplate Assembly, Adjustable Angle, Black - Left(5-1/4" W)

1 162 D1099704-NLA NLA - Legrest, Power Articulating, Sector, Black,

Short (13"-18" Range) - Right1 163 C,E

1099705-NLA NLA - Legrest, Power Articulating, Sector, Black,Short (13"-18" Range) - Left

1 163 C,E1099706-NLA NLA - Legrest Assembly, Power Articulating, Sector,

Black, Long (15"-20" Range) - Right1 163 C,E

1099707-NLA NLA - Legrest Assembly, Power Articulating, Sector,Black, Long (15"-20" Range) - Left

1 163 C,E



A - Includes items 2-7 B - Includes items 32, 33, 38-40 C - Power articulating legrest before 9/15/01 NLA. See power articulating legrest dated after 7/26/04. Legrest must be ordered

in pairs to match. D - Includes items 32, 39, 40, 48-61 E - Includes items 1, 8-32,7, 41-47, 62 F - Heel loop service part was lengthened 12/13/02. Verify with customer if longer heel loop is present. Order in pairs when

needed along with 2 each of items 48, 49 and 50. G - No longer available, see item 63 part numbers 1099704 and 1099705 H - No longer available, see item 63 part numbers 1099706 and 1099707

NOTE:


Power Non-Articulating LegrestPOWERLR18/POWERLR20 (9/15/01 Thru 4/30/02)






1 11 A,F1101113-NLA NLA - Legrest Support Assembly, Sector, Black -

Left1 11 A,F

1025454 Housing, Latch - Right 1 121025455 Housing, Latch - Left 1 127930314 Package, Screw, Slotted Hex Washer Head (#10-32

x 1/2")25 13

1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 241099685 Plug, Pivot 1 151091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 16

1099694-NLA NLA - Pad, Cushion - Right 1 17 F1099695-NLA NLA - Pad, Cushion - Left 1 17 F

1022597 Screw, Phillips Pan Head Tap (#10-32 x 3/8") 1 281025729 Screw, Phillips Pan Head Tap (#8-32 x 3/8") 1 19

1014386-NLA NLA - Screw, Phillips Pan Head (#8-32 x 5/8") 1 1101099699-NLA NLA - Bracket, Cover 1 111 F1099666-NLA NLA - Block, Slide 1 112 F1099687-NLA NLA - Sleeve (5/16 x 3/8 x 7/8") 1 313 F1099692-NLA NLA - Cover, Legrest Support - Right 1 114 F1099693-NLA NLA - Cover, Legrest Support - Left 1 114 F1043599-NLA NLA - Washer, Flat (5/32 x 3/8 x 1/32") 1 2151101398-NLA NLA - Motor, Actuator 1 116

1026158 Locknut (5/16-18) 1 2171028769 Locknut (5/16-18) 1 118

1101267-NLA NLA - Screw, Socket Button Head (5/16-18 x 1-1/2") 1 2191101214-NLA NLA - Screw, Socket Button Head (5/16-18 x 2-1/2") 1 120

0175600 Spacer, Coved (5/16 x 3/4 x 3/8") 1 2211082699 T-Nut (1/4-20) 1 1022

1038785-NLA NLA - Pin, Roll (1/8 x 3/8") 1 1231101883 Glide 1 524

1109310-NLA NLA - Extrusion, Internal Slide (16-3/4" L) 1 125 F1099702 Glide, Internal 1 1261018846 Screw, Socket Button Head (#10-24 x 3/4") 1 127

1099698-NLA NLA - Bracket, Actuator 1 128 F1026907 Washer (1/4 x 1/2 x 1/16") 1 8291100023 Screw, Button Head w/ Patch (1/4-20 x 1/2") 1 1030

1099686-NLA NLA - Bearing, Linear 1 131 F1109311-NLA NLA - Extrusion, External - Right (14-1/2" L) 1 132 F1109312-NLA NLA - Extrusion, External - Left (14-1/2" L) 1 132 F7930335-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x

1/2")25 233

1101116-NLA NLA - Calf Pad Bracket Assembly, Black 1 134 F88804529X003 Pad, Legrest, Vinyl - Right 1 135





88804529X004 Pad, Legrest, Vinyl - Left 1 1351023965-NLA NLA - Screw, Socket Head (#10-32 x 1-1/2") 1 236

1028516 Washer, Steel (3/16 x 7/16 x 1/16") 1 2371015629-NLA NLA - Bushing 1 238

1101268 Heel Loop Assembly - Right 1 139 E1101269 Heel Loop Assembly - Left 1 139 E7930333 Locknut (1/4-20) 25 1401029545 Screw, Socket Flat Head (1/4-20 x 3/4") 1 241


1 1421008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 1431082686 Nut, Barrel, Hex Head (1/4-20 x 11/16") 1 2441058517 Clamp, Footplate 1 1451052102 Hinge, Footplate - Right 1 1461052103 Hinge, Footplate - Left 1 1461048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 1477930313 Package, Washer, Nylon (5/16 x 7/8 x 1/8") 25 2481099678 Extrusion, Footplate Adapter 1 1491101114 Footplate Assembly, Adjustable Angle, Black - Right

(5-1/4" W)1 150 B

1101115 Footplate Assembly, Adjustable Angle, Black - Left(5-1/4" W)

1 150 B1008432 Screw, Socket Button Head (1/4-20 x 1-1/4") 1 1511025736 Locknut (1/4-20) 25 152

1109313-NLA NLA - Legrest, Power Non-Articulating, Sector,Black (13"-20" Range) - Right

1 153 C,D1109314-NLA NLA - Legrest, Power Non-Articulating, Sector,

Black (13"-20" Range) - Left 1 153 C,D

A - Includes Items 2-7 B - Includes Items 22, 29, 30, 36-49 C - Includes Items 1, 8-35 and 50-52 D - Power Non-articulating legrest NLA. See power articulating legrest dated after 7/26/04. A pair will be required to have

articulation on both sides. E - Heel loop service part was lengthened 12/13/02. Verify with customer if longer heel loop is present. Order in pairs when

needed along with 2 each of items 36, 37 and 38. F - No longer available, see item 53 part numbers 1109313 and 1109314

NOTE:


Power Articulating LegrestELRPW (Between 5/1/02-7/26/04)






1 11 A1111721-NLA NLA - Legrest Support Assembly, Sector, Black -

Left1 11 A

1025454 Housing, Latch - Right 1 121025455 Housing, Latch - Left 1 121017423 Screw, Slotted Hex Washer Head w/ Patch (#10-32

x 1/2")1 13

1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 241079203 Decal, Warning Pinch Point 1 151099685 Plug, Pivot 1 161091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 17

1110968-NLA NLA - Pad, Cushion - Right 1 18 J1110969-NLA NLA - Pad, Cushion - Left 1 18 J1025351-NLA NLA - Screw, Shoulder Hex Socket Head (5/16" x

1-1/4", 1/4-20) 1 29

1025736 Locknut (1/4-20) 1 5101025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 2111099671 Bearing, Flange (1/4 x 5/16" Long) 1 2121026907 Washer (1/4 x 1/2 x 1/16") 1 12131012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 114

1110745-NLA NLA - Plate, Pivot 1 1151110746 Cover, Legrest Support - Right 1 1161110747 Cover, Legrest Support - Left 1 1161009837 Screw, Socket Button Head (1/4-20 x 1") 1 1171091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 1181101883 Glide 1 3190175600 Spacer, Coved (5/16 x 3/4 x 3/8") 1 2201110741 Extrusion, Internal Slide (14-1/4" L) 1 1211099702 Glide, Internal 1 1221018846 Screw, Socket Button Head (#10-24 x 3/4") 1 1231110972 Actuator Motor Bracket Assembly 1 124 B1082699 T-Nut (1/4-20) 1 11251100023 Screw, Button Head w/ Patch (1/4-20 x 1/2") 1 1026

1087417-NLA NLA - Screw, Shoulder Hex Socket Head (5/16" x1", 1/4-20)

1 1271110724 Motor, Actuator - Right 1 1281110725 Motor, Actuator - Left 1 128

8881110977 Calf Pad Assembly with Hardware - Right 1 129 C8881111715 Calf Pad Assembly with Hardware - Left 1 129 C

88804529X003 Pad, Legrest, Vinyl - Right 1 13088804529X004 Pad, Legrest, Vinyl - Left 1 1301110748-NLA NLA - Hardware, Calf Pad Bracket 1 1D,G

1026033 Washer, Nylon (1/4 x 1/2 x 1/16") 1 43183





1099700-NLA NLA - Bracket, Calf Pad Mounting, Black 1 1321029157 Screw, Phillips Pan Head w/Patch (#10-32 x 7/8") 1 2331025765 Locknut (1/4-28) 1 134

1074191-NLA NLA - Screw, Socket Flat Head (1/4-28 x 1/2") 1 1351099690-NLA NLA - Block, Calf Pad 1 136

1111716 Bracket, Calf Pad Block Mounting, Black - Right 1 1371111717 Bracket, Calf Pad Block Mounting, Black - Left 1 1371078214 Screw, Hex Head w/ Patch (1/4-20 x 1/2") 1 2381110742 Bushing, Sleeve 1 139

1079151-NLA NLA - Pin, Roll (5/64 x 5/8") 1 1401110734-NLA NLA - Extrusion, External - ELRPW (10-1/2" L) 1 141

1101114 Footplate Assembly, Adjustable Angle, Black - Right(5-1/4" W)

1 142 E1101115 Footplate Assembly, Adjustable Angle, Black - Left

(5-1/4" W)1 142 E

1023965-NLA NLA - Screw, Socket Head (#10-32 x 1-1/2") 1 2431028516 Washer, Steel (3/16 x 7/16 x 1/16") 1 244

1015629-NLA NLA - Bushing 1 2451101268 Heel Loop Assembly - Right 1 146 H1101269 Heel Loop Assembly - Left 1 146 H


1 1471029545 Screw, Socket Flat Head (1/4-20 x 3/4") 1 2481008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 1491082686 Nut, Barrel, Hex Head (1/4-20 x 11/16") 1 2501052102 Hinge, Footplate - Right 1 1511052103 Hinge, Footplate - Left 1 1511048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 1521016301 Washer, Nylon (5/16 x 7/8 x 1/8") 1 2531099678 Extrusion, Footplate Adapter 1 154

1110743-NLA NLA - Legrest Assembly, Power Articulating, Sector,Black (13"-20" Range) - Right

1 155 F,F1,I1110744-NLA NLA - Legrest Assembly, Power Articulating, Sector,

Black (13"-20" Range) - Left1 155 F,F1,I



A - Includes items 2-8 B - Includes items 13, 25 and 26 C - Includes Items 25, 26 and 30-38 D - Includes Items 25, 26, 31-36, 38 E - Includes Items 10, 13, 25, 26 and 43-54 F - After 4/30/02 MKIV T.A.C. controller software changed from 1.1 to 1.2 to accommodate power articulating legrest made

after 4/30/02. F1 - A new MKIV T.A.C. controller part number 1109552 must be ordered when replacing power articulating or non-

articulating legrest made before 5/1/02. Verify software version before ordering. G - Not Shown H - Heel loop service part was lengthened 12/13/02. Verify with customer if longer heel loop is present. Order in pairs when

needed along with 2 each of items 43, 44 and 45. I - Due to a product enhancement that provides a higher pivot point at the knee, a customer must order a complete right and

left side legrest assembly. see page titled "Power Articulating Legrest After 7/26/04". J - No longer available individually. See Item number 1 for replacement.

NOTE:


Power Articulating Legrest ELRPW After 7/26/04





1125436 Legrest Support Assembly, Sector, Black - Right 1 11 A1125437 Legrest Support Assembly, Sector, Black - Left 1 11 A1025454 Housing, Latch - Right 1 121025455 Housing, Latch - Left 1 121017423 Screw, Slotted Hex Washer Head w/ Patch (#10-32

x 1/2")1 13

1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 241079203 Decal, Warning Pinch Point 1 151099685 Plug, Pivot 1 161091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 171125433 Pad, Cushion - Right 1 181125434 Pad, Cushion - Left 1 18

1025351-NLA NLA - Screw, Shoulder Hex Socket Head (5/16" x1-1/4", 1/4-20)

1 291025736 Locknut (1/4-20) 1 5101025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 1111099671 Bearing, Flange (1/4 x 5/16" Long) 1 2121026907 Washer (1/4 x 1/2 x 1/16") 1 12131012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 1141125424 Plate, Pivot 1 1151110746 Cover, Legrest Support - Right 1 1161110747 Cover, Legrest Support - Left 1 1161009837 Screw, Socket Button Head (1/4-20 x 1") 1 1171091870 Screw, Socket Button Head w/ Patch (1/4-20 x 3/4") 1 1181101883 Glide 1 2190175600 Spacer, Coved (5/16 x 3/4 x 3/8") 1 2201110741 Extrusion, Internal Slide (14-1/4" L) 1 1211099702 Glide, Internal 1 1221018846 Screw, Socket Button Head (#10-24 x 3/4") 1 1231110972 Actuator Motor Bracket Assembly 1 124 B1082699 T-Nut (1/4-20) 1 11251100023 Screw, Button Head w/ Patch (1/4-20 x 1/2") 1 1026

1087417-NLA NLA - Screw, Shoulder Hex Socket Head (5/16" x1", 1/4-20)

1 1271110724 Motor, Actuator - Right 1 1281110725 Motor, Actuator - Left 1 128

8881110977 Calf Pad Assembly with Hardware - Right 1 129 C8881111715 Calf Pad Assembly with Hardware - Left 1 129 C

88804529X003 Pad, Legrest, Vinyl - Right 1 13088804529X004 Pad, Legrest, Vinyl - Left 1 1301110748-NLA NLA - Hardware, Calf Pad Bracket 1 1D,F

1026033 Washer, Nylon (1/4 x 1/2 x 1/16") 1 4311099700-NLA NLA - Bracket, Calf Pad Mounting, Black 1 132

1029157 Screw, Phillips Pan Head w/Patch (#10-32 x 7/8") 1 23387





1025765 Locknut (1/4-28) 1 1341074191-NLA NLA - Screw, Socket Flat Head (1/4-28 x 1/2") 1 1351099690-NLA NLA - Block, Calf Pad 1 136

1111716 Bracket, Calf Pad Block Mounting, Black - Right 1 1371111717 Bracket, Calf Pad Block Mounting, Black - Left 1 1371078214 Screw, Hex Head w/ Patch (1/4-20 x 1/2") 1 2381110742 Bushing, Sleeve 1 139

1079151-NLA NLA - Pin, Roll (5/64 x 5/8") 1 1401121026 Extrusion, External (12-1/2" L)

(ELRPW22 Before 7/22/04) and (ELRPW20 After7/21/04)

1 141

1101114 Footplate Assembly, Adjustable Angle, Black - Right(5-1/4" W)

1 142 E1101115 Footplate Assembly, Adjustable Angle, Black - Left

(5-1/4" W)1 142 E

1023965-NLA NLA - Screw, Socket Head (#10-32 x 1-1/2") 1 2431028516 Washer, Steel (3/16 x 7/16 x 1/16") 1 244

1015629-NLA NLA - Bushing 1 2451101268 Heel Loop Assembly - Right 1 1461101269 Heel Loop Assembly - Left 1 146


1 1471029545 Screw, Socket Flat Head (1/4-20 x 3/4") 1 2481008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 1491082686 Nut, Barrel, Hex Head (1/4-20 x 11/16") 1 2501052102 Hinge, Footplate - Right 1 1511052103 Hinge, Footplate - Left 1 1511048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 1521016301 Washer, Nylon (5/16 x 7/8 x 1/8") 1 2531099678 Extrusion, Footplate Adapter 1 1541126091 Legrest Assembly, Power Articulating, Sector, Black

(13 - 20" Range) - Right1 155 G

1126092 Legrest Assembly, Power Articulating, Sector, Black(13 - 20" Range) - Left

1 155 GA - Includes items 2-7 B - Includes items 13, 25 and 26 C - Includes Items 25, 26 and 30-38 D - Includes Items 25, 26, 31-36, 38 E - Includes Items 10, 13, 25, 26 and 43-54 F - Not Shown G - Power Legrest must be ordered in pairs when replacing older versions on chairs manufactured before 7/27/04

NOTE:




1101400 Harness, ELRPW Power Legrest - Right 1 111101401 Harness, ELRPW Power Legrest - Left 1 111003424 Screw, Socket Head (1/4-20 x 1-3/4") 1 22

1018692-NLA NLA - Clamp, Half, Non-Threaded 1 431056098 Locknut (#8-32) 1 44

1102022-NLA NLA - Bracket, Harness Wire, Black 1 251091871-NLA NLA - Screw, Socket Head (#8-32 x 5/8") 1 467930338-NLA NLA - Nut, Acorn (1/4-20) 25 271101520-NLA NLA - Kit, Power Leg Harness and Mounting

Hardware 2 18 A

1104253-NLA NLA - Tie Wrap (8" L) 10 1BA - Includes items 1-7 B - Not Shown

NOTE:

Power Articulating and Non-Articulating LegrestPOWELR18/POWELR02/ELRPW

Harnesses and Mounting Hardware (Before 7/5/05)


Power Articulating Legrest ELRPWHarnesses and Hardware For ADJASBA Seat (After 7/4/05)


Power Articulating Legrest ELRPWHarnesses and Hardware For ADJASBA Seat (After 7/4/05)



1125679-NLA NLA - Kit, ELRPW Power Articulating LegrestHarnesses and Mounting Hardware (Pair)

2 11 A,BNLA - Screw, Socket Head (#8-32 x 5/8") 1 42Locknut (#8-32) 1 43T-Nut (5/16-18) 1 24NLA - Bracket, Wire Harness, Black 1 45Washer, Flat (5/16 x 5/8 x 1/16") 1 26NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 27Tie Wrap (5-5/8" L) 1 28NLA - Harness, ELRPW Power Legrest - Right 1 19NLA - Harness, ELRPW Power Legrest - Left 1 19

A - Includes items 2-9 B - On 2/28/07 the Dual Leg Actuator Module (DLIAM) harness cable that plugs into item #9 ELRPW Power Legrest Harness

Assembly was lengthened from approximately 3" to 20" long to eliminate the need for the ELRPW Power Legrest Harness Assemblies

NOTE:


Power Articulating Legrest KitsPOWELR18 (Before 9/15/01)

NOTE: Power articulating legrest use sector style front rigging hangers and do not come included withkits. See page titled A.S.B.A. Seat Frame and Hardware for hanger assemblies.NOTE: Torque SP with RII electronics must be upgraded to MKIV A electronics.

NOTE: For 3G bases, a new controller shroud cover may be required. See page titled Controller ShroudCovers.

POWELR18 with 4-way Switch and Non Quad Link Mounting Plate Assembly

Part Number Description Quantity1Power Articulating

Legrest Kit1104249-NLA

See Note(s) B, A1Legrest, Right, Short 18"

(13"-18" Adj. Length)1099704-NLA

See Note(s) A1Legrest, Left, Short 18"

(13"-18" Adj. Length)1099705-NLA

See Note(s) A1Power Leg Harnesses

and Mounting Hardware1101520-NLA1T.A.C. Controller

with Hardware1104248-NLA14-Way Switch1080116-NLA14-Way Switch Mounting

Plate with Hardware107751910Cable Tie (8" Long)20016821Controller Bracket

with Fastener Strips1092659-NLA

1Instruction Sheet, Power Articulating

Legrest Kit1104911

A - Power articulating legrest and KITS before 9/15/01 are NLA. See power articulating legrest or KITS dated after 7/26/04. Legrest must be ordered in pairs to match. B - Kit includes the 9 items listed below the kit part number

NOTE:





POWELR18 with 4-way Switch and Quad Link Mounting Plate Assembly



See Note(s) B, A1Legrest, Right, Short 18"

(13"-18" Adj. Length)1099704-NLA

See Note(s) A1Legrest, Left, Short 18"

(13"-18" Adj. Length)1099705-NLA







Legrest Kit1104911


NOTE:





POWELR20 with 4-way Switch and Non Quad Link Mounting Plate Assembly



See Note(s) B, A1Legrest, Right, Long 20"

(15"-20" Adj. Length)1099706-NLA

See Note(s) A1Legrest, Left, Long 20"

(15"-20" Adj. Length)1099707-NLA







Legrest Kit1104911


NOTE:





POWELR20 with 4-way Switch and Quad Link Mounting Plate Assembly



See Note(s) A, B1Legrest, Right, Long 20"

(15"-20" Adj. Length)1099706-NLA

See Note(s) A1Legrest, Left, Long 20"

(15"-20" Adj. Length)1099707-NLA




Plate with Hardware1077520-NLA10Cable Tie (8" Long)20016821Controller Bracket



Legrest Kit1104911


NOTE:


Power NON-Articulating Legrest KitsPOWELR18/POWELR20 (9/15/01 thru 4/30/02)

NOTE: Power NON-articulating legrest use sector style front rigging hangers and do not come includedwith kits. See page titled A.S.B.A. Seat Frame and Hardware for hanger assemblies.

NOTE: Torque SP with RII electronics must be upgraded to MKIV A electronics.NOTE: For 3G bases, a new controller shroud cover may be required. See page titled Controller Shroud

Covers.POWELR18/ POWELR20 with 4-way Switch and Non Quad Link Mounting Plate

Assembly.

Part Number Description Quantity1Power Non-Articulating


See Note(s) B, A1Legrest, Right

(13"-20" Adj. Length)1109313-NLA

See Note(s) A1Legrest, Left

(13"-20" Adj. Length)1109314-NLA







Legrest Kit1104911

A - Power NON-articulating legrest and KITS before 9/15/01 are NLA. See power articulating legrest or KITS dated after 7/26/04. Legrest must be ordered in pairs to match. B - Kit includes the 9 items listed below the kit part number

NOTE:


Power NON-Articulating Legrest KitsPOWELR18/POWELR20 (9/15/01 thru 4/30/02)

NOTE: Power NON-articulating legrest use sector style front rigging hangers and do not come includedwith kits. See page titled A.S.B.A. Seat Frame and Hardware for hanger assemblies.

NOTE: Torque SP with RII electronics must be upgraded to MKIV A electronics.NOTE: For 3G bases, a new controller shroud cover may be required. See page titled Controller Shroud

Covers.POWELR18/ POWELR20 with 4-way Switch and Quad Link Mounting Plate Assembly

Part Number Description Quantity1Power Non-Articulating


See Note(s) A, B1Legrest, Right

(13"-20" Adj. Length)1109313-NLA

See Note(s) A1Legrest, Left

(13"-20" Adj. Length)1109314-NLA







Legrest Kit1104911

A - Power NON-articulating legrest and KITS before 9/15/01 are NLA. See power articulating legrest or KITS dated after 7/26/04. Legrest must be ordered in pairs to match. B - Kit includes the 9 items listed below the kit part number

NOTE:


Power Articulating Legrest KitsELRPW (5/1/02-7/26/04)



ELRPW with 4-Way Switch and Non-Quad Link Mounting Plate Assembly

Part Number Description Quantity1

Kit, ELRPWPower Articulating


See Note(s) A, B, B1

1Legrest, Right(13"-20" Adj. Length)

1110743-NLA See Note(s) B1, B

1Legrest, Left(13"-20" Adj. Length)

1110744-NLA See Note(s) B, B1

1Power Leg Harnessesand Mounting Hardware1101520-NLA

1T.A.C. Controllerwith Hardware1104248-NLA

14-Way Switch1080116-NLA14-Way Switch Mounting




Legrest Kit1104911

A - Kit includes the 9 items listed below the kit part number B - Due to a product enhancement that provides a higher pivot point at the knee, a customer must order a complete right and leftside legrest assembly. A kit is required when ordering Power Articulating Legrest for the first time. B1 - See page titled "Power Articulating Legrest Kits After 7/26/04".

NOTE:


Power Articulating Legrest KitsELRPW (5/1/02-7/26/04)



ELRPW with 4-Switch and Quad Link Mounting Plate Assembly

Part Number Description Quantity1

Kit, ELRPWPower Articulating


See Note(s) B1, B

1Legrest, Right(13"-20" Adj. Length)

1110743-NLA See Note(s) B1, B

1Legrest, Left(13"-20" Adj. Length)

1110744-NLA See Note(s) B, B1







Legrest Kit1104911

B - Due to a product enhancement that provides a higher pivot point at the knee, a customer must order a complete right and leftside legrest assembly. A kit is required when ordering Power Articulating Legrest for the first time. B1 - See page titled "Power Articulating Legrest Kits After 7/26/04".

NOTE:


Power Articulating Legrest KitsELRPW (After 7/26/04)



ELRPW with 4-Way Switch and Non-Quad Link Mounting Plate Assembly



See Note(s) A

1Legrest, Right(13"-20" Adj. Length)1126091

1Legrest, Left(13"-20" Adj. Length)1126092







Legrest Kit1104911

A - Kit includes the 9 items listed below the kit part number NOTE:


Power Articulating Legrest KitsELRPW (After 7/26/04)



ELRPW with 4-Switch and Quad Link Mounting Plate Assembly


Legrest Kit1126097-NLA1Legrest, Right

(13"-20" Adj. Length)11260911Legrest, Left

(13"-20" Adj. Length)11260921Power Leg Harnesses






Legrest Kit1104911


MK6i Electronics


Dual Legs Integrated Actuator Module (DLIAM) MK6iFor ELRPW Front Riggings


Dual Legs Integrated Actuator Module (DLIAM) MK6iFor ELRPW Front Riggings



1140032 Module, Dual Legs Integrated Actuator (DLIAM) -MK6i (54" L)

1 11 A,B1021742 Screw, Phillips Pan Head (#4-40 x 1/2") 1 22

A - The Dual Legs Integrated Actuator Module is attached to a 12"-16" wide seat pan in the same way when ELRPW Front Riggings are ordered with MK6i electronics

B - On 2/28/07 the Dual Leg Actuator Module (DLIAM) harness cable lengthened from approximately 3" to 20" long to eliminate the need for the ELRPW Power Legrest Harness Assembly part numbers 1125656 RT and 1125657 LT

NOTE:


MKIV JoysticksRII, TCHJOY, A, A+


MKIV JoysticksRII, TCHJOY, A, A+

ItemNumber Description RII TCHJOY A A+

1038608-NLA1065944-NLA1095289-NLA1092610-NLA

JoystickAssemblySee Pictorial See Note(s) D

10402171040217N/A1040217Knob, Joystick110402181040218N/A1040218Skirt,

Joystick21036764-NLA

1036764-NLA

N/A1036764-NLA

Inductive, Joystick3 See Note(s) A See Note(s) B See Note(s) A

N/A1104397-NLA N/AN/AInductive,

Joystick3 See Note(s) C50000X364-NLA50000X364-NLAN/A50000X364-NLABoot,

Joystick41036776-NLA1040190-NLAN/AN/AOverlay,

Joystick Decal51036750-NLA

1036750-NLA

N/AN/ACableAssembly6 See Note(s) B See Note(s) A

N/A1104205-NLA N/AN/ACable

Assembly6 See Note(s) CN/A1040225-NLA

N/A1040225-NLA

Potentiometer,Speed7 See Note(s) A See Note(s) B

N/A1115518-NLA N/AN/APotentiometer,

Speed7 See Note(s) CN/A1025516-NLA1025516-NLA1025516-NLAKnob,

Potentiometer81040185-NLA

1040185-NLA

N/AN/ASwitch, On/OffMomentary9 See Note(s) B See Note(s) A

N/A1115523-NLA N/AN/ASwitch, On/Off

Momentary9 See Note(s) C1040186-NLA

N/AN/AN/ASwitch, Program10 See Note(s) A

N/AN/AN/A1010042

Switch, Toggle SPDT11 See Note(s) A

N/AN/AN/A1108692-NLADecal, RII 80 AMP12

A - Item requires soldering B - Before 10/01/02 item requires soldering C - After 9/30/02 item has a non-soldering connector D - RII 80 amp. decal is not included with joystick. Used on Torque SP's after 10/31/01.

NOTE:


MKIV Joysticks - PSF and PSRNOTE: PSR STANDARD joystick configuration below show the on/off switch on the left side for part #

1075196. When the on/off switch is required on the right side, refer to part number 8881075196 and orderas a configurated part.


MKIV Joysticks - PSF and PSRNOTE: PSR STANDARD joystick configuration below show the on/off switch on the left side for part #

1075196. When the on/off switch is required on the right side, refer to part number 8881075196 and orderas a configurated part.

Item Number Description PSF PSR1075196-NLAN/AJoystick

AssemblySee Pictorial88810751961075195-NLAJoystick

AssemblySee Pictorial1070542-NLAN/AJoystick



AssemblySee Pictorial10402171040217Knob, Joystick110402181040218Skirt, Joystick2

1036764-NLA1036764-NLAInductive, Joystick350000X364-NLA50000X364-NLABoot, Joystick4

1079925-NLA1075034-NLAOverlay, Joystick Decal51036750-NLA1036750-NLACable Assembly61040225-NLA1040225-NLAPotentiometer, Speed71025516-NLA1025516-NLAKnob, Potentiometer81040185-NLA1040185-NLASwitch,

On/Off Momentary9

1010047-NLA1010047-NLASwitch,

Push Button SPST Momentary

10

1010048-NLAN/ASwitch,Push Button SPST11

1010049-NLA1010049-NLABoot, Switch121058464-NLA1058464-NLABoot, Switch13


MKIV Joystick Mounting Hardware and JoystickAccessories

NOTE: Captain Seat joystick tube mounting hardware adapts to the offset joystick tube and comesstandard on-chair.


MKIV Joystick Mounting Hardware and JoystickAccessories

NOTE: Captain Seat joystick tube mounting hardware adapts to the offset joystick tube and comesstandard on-chair.



1092604-NLA NLA - Kit, Straight Joystick Tube with Hardware 1 11 A1093069 Kit, 1/2" Offset Joystick Tube with Hardware 1 12 B1027095 Plug Button, Black (7/8") 1 131052041 Screw, Phillips Pan Head (#4-40 x 3/8") 1 44

1095502-NLA NLA - Package, Tie Wrap (11-1/2" L) 10 151093063 Spacer, Joystick Tube, Black 1 161025714 Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 27

1049591-NLA NLA - Hardware, Joystick Tube Mounting 1 18 C1093071 Clamp, Fixed Height Joystick Tube 1 19 D1139422 Clamp, Height Adjustable Joystick Tube (ARM250) 1 19 F

1027267-NLA NLA - Half Clamp, Threaded Holes 1 1101027266 Half Clamp, Non-Threaded Holes 1 1111027274 Adjustment Lock Assemnbly, Black 1 112

1049582-NLA NLA - Bracket, Joystick Mounting, Black 1 11316690X004-NLA NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 314

1105050-NLA NLA - Kit, Joystick Tube Mounting Hardware -Captain/ Van Seat

1 115 E1025195 Locknut (1/4-20) 1 316

1101524-NLA NLA - Spacer (1/4 x 7/16 x 5/8") 1 3171105049 Clamp Assembly, Fixed Height, Captain/ Van Seat 1 1181057955 Screw, Hex Head (1/4-20 x 1-1/4") 1 319

1055736-NLA NLA - Kit, Toggle Switch Extension 1 1201016401-NLA NLA - Screw, Phillips Round Head (#10-32 x 3/8") 1 321

1006270 Extension, Joystick, "T" Style (1560)(4" W x 5-1/2" L)

1 1G1006271 Extension, Joystick, Straight Style (1561)

(1/2" W x 5" L)1 1G

A - Includes items 3 and 4 B - Includes items 3, 5, 6 and 7. Used for MKIV RII. A, A+, PSF/PSR joysticks (Captain Seats also) C - Includes items 10-14. Used for TCHJOY Touchpad "A" Joystick before 10/4/00 D - For MKIV RII. A, A+, PSF/PSR joystick and (TCHJOY Touchpad "A" Joystick after 10/3/00). Joystick Tube Clamp can be

used as a direct replacement for item 8 part # 1049591 in the field. Individual components are non-saleable. E - Includes items 16-19. Due to product improvement, the joystick mounting bracket with a separate adjustment lock were

replaced with the clamp assembly shown as of 2/20/03 and is backward compatible. F - Introduced 10/31/05 as option (ARM250) and can be used to replace a Fixed Height Joystick Tube Clamp in the field.

Individual components are non-saleable. G - Not Shown

NOTE:




1093063 Spacer, Joystick Tube, Black 1 117930327-NLA NLA - Package, Screw, Phillips Pan Head (#10-32 x

1-1/8")25 32

1049962-NLA NLA - Bracket, Swivel Joystick, MKIV 1 131049963-NLA NLA - Bracket, Swivel Joystick with Hardware 1 141035986-NLA NLA - Joystick Swivel Tube with Hardware, Black 1 151020551-NLA NLA - Washer, Flat (1/4 x 3/8 x 1/16") 1 161005844-NLA NLA - Bushing 1 271002511-NLA NLA - Spring, Hitch Bracket 1 181023670-NLA NLA - Knob, Clamping, Grey 1 191035990-NLA NLA - Tube, Swivel Joystick, Black 1 110

1027095 Plug Button, Black (7/8") 1 111

MKIV Swivel Joystick Hardware




1035528-NLA NLA - Tube, Adjustment, Inside, Mid-Line, Black 1 111016778-NLA NLA - Spring, Extension (9/16 x 1-3/8" L) 1 121035860-NLA NLA - Tube, Adjustment, Outside, Mid-Line, Black 1 13

1027274 Adjustment Lock Assemnbly, Black 1 141035852-NLA NLA - Swing Bracket Assembly, Mid-Line, Black 1 15 B7930349-NLA NLA - Screw, Hex Head (1/4-20 x 1-1/8") 25 36

1027274 Adjustment Lock Assemnbly, Black 1 171071879-NLA NLA - Bracket, Joystick Mounting, Black 1 18 A

1027266 Half Clamp, Non-Threaded Holes 1 191027267-NLA NLA - Half Clamp, Threaded Holes 1 1101071880-NLA NLA - Hardware, Attaching - Mid-Line 1 111 A,C

A - Left side joystick mounting bracket or hardware must be ordered as a special. B - Includes items 1-4 C - Includes items 6-10

NOTE:

MKIV Mid-Line Swing Bracket AssemblyNOTE: Joystick with 90 degree bend replaces the standard tube when joysticks PSF, PSR and (RII part

number 1092610) are used. Joystick tube with 90 degree bend must be ordered as a special when areplacement is needed.


Quad Link Assembly(Before 10/31/05 - ASBA) (Before 4/07/06 - Captain Seat)





1052402-NLA NLA - Kit, Quad Link Assembly - Right 1 11 ANLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 46Spacer, Joystick Tube, Black 1 17NLA - Stud Plate, Quad Link 1 18Screw, Hex Head (1/4-20 x 1-1/2") 1 39Spacer (1/4 x 3/8 x 3/16") 1 310Half Clamp, Non-Threaded Holes 1 111NLA - Half Clamp, Threaded Holes 1 112

1115372-NLA NLA - Kit, Quad Link Assembly - Left 1 11 ANLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 46Spacer, Joystick Tube, Black 1 17NLA - Stud Plate, Quad Link 1 18Screw, Hex Head (1/4-20 x 1-1/2") 1 39Spacer (1/4 x 3/8 x 3/16") 1 310Half Clamp, Non-Threaded Holes 1 111NLA - Half Clamp, Threaded Holes 1 112

1034703-NLA NLA - Kit, Quad Link Assembly - Right 1 11 B,ENLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45Plate, Stud, Quad Link For 1556 Heavy DutyJoystick

1 18Screw, Hex Head (1/4-20 x 1-1/2") 1 39Spacer (1/4 x 3/8 x 3/16") 1 310Half Clamp, Non-Threaded Holes 1 111NLA - Half Clamp, Threaded Holes 1 112Screw, Phillips Flat Head (#10-32 x 1-1/8") 1 213

1114866-NLA NLA - Kit, Quad Link Assembly - Left 1 11 BNLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45





Plate, Stud, Quad Link For 1556 Heavy DutyJoystick

1 18Screw, Hex Head (1/4-20 x 1-1/2") 1 39Spacer (1/4 x 3/8 x 3/16") 1 310Half Clamp, Non-Threaded Holes 1 111NLA - Half Clamp, Threaded Holes 1 112Screw, Phillips Flat Head (#10-32 x 1-1/8") 1 213

1102027-NLA NLA - Kit, Quad Link Assembly - RightFor TCHJOY/TCPDM4 Touchpad

1 11 CNLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 26NLA - Plate, Stud, Quad LinkMKIV TCHJOY/TCPDM4

1 18Screw, Hex Head (1/4-20 x 1-1/2") 1 39Spacer (1/4 x 3/8 x 3/16") 1 310Half Clamp, Non-Threaded Holes 1 111NLA - Half Clamp, Threaded Holes 1 112NLA - Screw, Phillips Flat Head Countersunk (#4-40x 3/8")

1 4141074153-NLA NLA - Kit, Quad Link Assembly - Right

For Van Seats1 11 D

NLA - Ball Plunger Assembly with Lock Washer 2 12Locknut (#10-32) 1 23NLA - Screw, Cap, Socket Head (#10-32 x 1/2") 1 44NLA - Bushing, Bronze (3/16 x 1/4 x 1/4") 1 45Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 46Spacer, Joystick Tube, Black 1 17NLA - Stud Plate, Quad Link 1 18Locknut (1/4-20) 1 315Screw, Hex Head (1/4-20 x 1-1/2") 1 316NLA - Spacer (1/4 x 7/16 x 5/8") 1 317

1114863-NLA NLA - Ball Plunger Assembly with Lock Washer 2 12A - Includes the Quad Link, items 2-12 and used with MKIV RII, A, A+,PSF/PSR joysticks B - Includes the Quad Link, items 2-5 and 8-13 and used with a 1556 Heavy Duty joystick C - Includes the Quad Link, items 2-6, 8-12, 14 and used with TCHJOY/TCPDM4 joysticks. For left side mounted Quad Link,

order as a special D - Includes the Quad Link, items 2-8, 15-17 and used with MKIV RII, A, A+,PSF/PSR joysticks. For left side mounted Quad

Link, order as a special E - Quad Link Assembly is no longer available. Please see Quad Link Assembly (After 10/30/05 & 4/06/06) category and use

new Quad LInk design as a replacement.

NOTE:


Quad Link Assembly (QLA) & (QL)QLA (After 10/30/05 - ASBA), QL (After 4/06/06 - Captain Seat)

When converting an old style Quad Link that attaches to a mounting plate or (a Flex or Touch PadJoystick Tube) is currently on the chair then order the following for:

a) ASBA Seat; Quad Link Mtg. Hdwr. (item 4), Quad Link (item 1) & Ht. Adj. Joystick Tube Clamp (item 11)b) Van Seat; Quad Link Mtg. Hdwr. (item 12), Quad Link (item 1) & Joystick Tube Clamp (item 22)

NOTE: Substitute (item 4 & 12) with 2 ea. of the PPH Screws (item 5) when an offset joystick tube iscurrently on the chair. Additional Joystick Mtg. Hdwr. must be ordered when a 1556 Heavy Duty or TCPD

Touch Pad is used.






Touch Pad is used.Item


Package Assembly1140896 Quad Link w/ Adjustable Joystick Tray (QLA) and

Instruction Sheet - Right1 11

1140897 Quad Link w/ Adjustable Joystick Tray (QLA) andInstruction Sheet - Left

1 111140898 Quad Link (QL) with Instruction Sheet - Right 1 11 I1140899 Quad Link (QL) with Instruction Sheet - Left 1 11 I1140425 Kit, Quad Link Latch Hardware 1 12 A

1140424-NLA NLA - Kit, Quad Link Screw Fastener Hardware 1 13 B1139416 Kit, ASBA/ADJASBA Quad Link Mounting Hardware 1 14 C,C1

Screw, Phillips Pan Head w/ Patch (#10-32 x 3/4") 1 25Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 26Tie Wrap (11-1/2" L) 1 17Spacer, Joystick Tube, Black 1 18Tube, Joystick Offset (1/2") 1 19Plug Button, Black (7/8") 1 110

1105414 Screw, Phillips Pan Head w/ Patch (#10-32 x 3/4") 1 251139422 Clamp, Height Adjustable Joystick Tube (ARM250) 1 111 J

1143041-NLA NLA - Kit, Quad Link Mounting Hardware - Van Seat 1 112 C1,G,H,H1

Plug Button, Black (7/8") 1 113Locknut (1/4-20) 1 314Tube, Joystick Offset (2") 1 115Tie Wrap (11-1/2" L) 1 116NLA - Spacer (1/4 x 7/16 x 5/8") 1 317Screw, Hex Head (1/4-20 x 1-1/4") 1 318Screw, Phillips Pan Head (#10-32 x 1-1/8") 1 219Spacer, Joystick Tube, Black 1 120Screw, Phillips Pan Head w/ Patch (#10-32 x 3/4") 1 221

1139681 Clamp Assembly, Fixed Height, Captain/ Van Seat 1 1221139925-NLA NLA - Kit, 1556 Heavy Duty Joystick To Quad Link

Mounting Hardware1 123 D

Screw, Phillips Pan Head (#10-32 x 1/2") 1 224NLA - Plate, 1556 HD Joystick Quad Link 1 125

1139683-NLA NLA - Kit, TCPD Touch Pad To Quad Link MountingHardware

1 126 EPlate, TCPD Touch Pad Quad Link 1 127Screw, Phillips Pan Head (#4-40 x 3/8") 1 428

1134844 Instruction Sheet, Quad Link 1 1F117






Touch Pad is used.A - Latch Kit includes 4 ea. Button Head Cap Screws (10-32 x 3/8"), 2 ea. Latch Spring Assembly, 4 ea. Phillips Flat C'Sunk

Head Screws, 2 ea. Spring Catch Plates, 2 ea. Socket Head Set Screws (10-32 x 3/8") B - Screw Fastener Kit includes 4 ea. Socket Head Shoulder Screws (3/8 x 3/8"), 2 ea. Socket Head Cap Screws (1/4-20 x

3/8"), 2 ea. Socket Head Set Screws (1/4-20 x 1/2"), 4 ea. Socket Head Set Screws (10-32 x 1/8") C - Includes items 5-10. The Quad Link Mounting Hardware accommodates MKIV RX, A, A+ and PSF/PSR joysticks. C1 - When ordering the Quad Link for the first time, Additional hardware is required for 1556 Heavy Duty and TCPD Touch

Pad joysticks. See pictorial for reference. D - Includes items 24 and 25 E - Includes items 27 and 28 F - Not Shown G - Includes items 13-21. The Quad Link Mounting Hardware accommodates MKIV RX, A, A+ and PSF/PSR joysticks. H - If Quad Link is to be mounted on chairs w/ van seats built Before 4/07/06, then the Armrest Attach. Hdwr. (1074120) for

18" wide or (1101917) for 20" & 22" wide must be ordered as well. H1 - See page titled "Captain Seat Arms and Hardware" page. The new armrest plates have 3 additional holes drilled so that

the quad link can be properly mounted. I - Use with Captain Seats only J - Individual components are non-saleable

NOTE:


MKIV Controllers, Programmer and Hardware MKIV Quad Pulse, RII Retro and RII 80 Amp





1105707-NLA NLA - Controller, MKIV Quad Pulse 1 11 A1095269-NLA NLA - Controller, MKIV RII, Retro 1 12 A,C,F1106819-NLA NLA - Controller, MKIV RII (80 AMP) 1 13 B,D,G

See Chart Controller Mounting Bracket with Hardware 1 14-81092661-NLA NLA - Bracket w/ Fastener Strips, Controller

Mounting1 19 E

1092659-NLA NLA - Kit, Controller Mounting Bracket withFastener Strips, Black

1 110 F1087790-NLA NLA - Bracket, Controller Mounting, Black 1 111 G

1140265 Bracket with Fastener Strips, Controller Mounting 1 112 H1140484-NLA NLA - Bracket, Controller Mounting, Black 1 113 I1040223-NLA NLA - Screw (#8-32 x 1/2") 1 314

1104258 Screw, Hex Head w/ Patch (5/16-18 x 1") 1 2151027263-NLA NLA - Washer, Lock Tooth (3/16 x 3/8 x 1/32") 1 116 O1104260-NLA NLA - Wire, Grounding Jumper Strap E.S.D. 1 1171023263-NLA NLA - Washer, Internal Tooth (M8) 1 2181070504-NLA NLA - Fastener, Hook with Adhesive Back (1" W x

1" L)1 219

1092662-NLA NLA - Package, Fastener, Dual Lock 250 (1/2" W x7/8" L)

10 1201025735 Locknut (#10-32) 1 2211025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 222

1091541-NLA NLA - Screw, Socket Head Cap (5/16-18 x 1/2") 1 2231109091-NLA NLA - Programmer, Remote 1 124

1020818 Switch, Red Flex Ribbon (Tape) Reset 1 125 J1123276 Kit, Switch, Black Egg Reset w/ Hook/Loop

Adhesive Back Fastener & Attaching Screws(EGSBLK)

1 125 K

1107296-NLA NLA - Harness, Battery (22NF) 1 1L,N1109509-NLA NLA - Harness, Battery (GP24) 1 1L,N1108692-NLA NLA - Decal, RII 80 Amp 1 1L,N1105912-NLA NLA - Kit, Electro Static Discharge Ground Strap -

MKIV1 1M,N

1105913-NLA NLA - Instruction Sheet, E.S.D. Strap Kit MKIV 1 1N,P1095204-NLA NLA - Cable, Virtual Service, Charger/Modem 1 1N1064404-NLA NLA - Virtual Service Modem Kit 1 1N1091631-NLA NLA - Virtual Service Software Kit 1 1N1103051-NLA NLA - MKIV One 2 One Software Kit 1 1N1046117-NLA NLA - Printer and Interface 1 1N1091980-NLA NLA - Disk, 3.5 H.D. Floppy with V.S. Software 1 1N1091637-NLA NLA - Adaptor, Null Modem 1 1N1091636-NLA NLA - Service Manual - V.S. Software Kit 1 1N1026572-NLA NLA - Paper, Printer 1 1N





1027280-NLA NLA - Harness, Printer Wiring 1 1NA - It is recommended that an E.S.D. ground strap kit part number 1105912 be ordered when a new controller is needed for

chairs built before 4/12/01. MKIV Quad Pulse Controller is also used for 3GTQ-TS models also B - Battery harness (part number 1107296 for 22NF batteries) or (part number 1109509 for GP 24 batteries) must be present

when the RII 80 AMP controller is used. RII 80 Amp. joystick decal part number 1108692 is also used. C - Used for Torque SP before 11/01/01 D - Used on Torque SP after 10/31/01 E - Comes packaged in item 4 Controller Mounting Bracket with Hardware. See chart for Bracket application F - Comes packaged in item 5 Controller Mounting Bracket with Hardware. See chart for Bracket application G - Comes packaged in item 6 Controller Mounting Bracket with Hardware. See chart for Bracket application H - Comes packaged in item 7 Controller Mounting Bracket with Hardware. See chart for Bracket application I - Comes packaged in item 8 Controller Mounting Bracket with Hardware. See chart for Bracket application J - Before 5/24/04 K - After 5/23/04. The Egg Reset Switch replaced the Red Flex Ribbon (Tape) Reset Switch L - Required when a MKIV RII 80 Amp. Controller is used M - Includes items 14-17 and Instruction Sheet N - Not Shown O - Part #1023263 is no longer available as a service part individually. Must order a complete Controller Mounting Bracket w/

Hardware Kit as a replacement. P - Item is no longer available from the Invacare Service Parts Department. Refer to the Invacare Website under "Product


NOTE:

Item #'s 4-8 Controller Mounting Bracket with Hardware

Seating SystemItem #4

Controller MountingBracket with Hardware

Item #5Controller Mounting

Bracket with HardwareItem #6


Item #7 and #8Controller Mounting

Bracket with HardwareFor TRRO/TRBKTS

OptionN/AN/AN/A1070401-NLA

Van Seat with one

controller See Note(s) A1139436-NLA

N/AN/A1070401-NLA

ASBA/ADJASBA w/one controller See Note(s) A See Note(s) F, D

1140486-NLA N/A1092650-NLA

N/AASBA/ADJASBA withtwo controllers See Note(s) B See Note(s) F, E

1140486-NLA N/A1092650-NLA

N/AASBA/ADJASBA withtwo controllers, shockforks and short base

together as of 5/20/02 See Note(s) B See Note(s) E, G

N/AN/AN/A1070401-NLA

ESS6-STM (ElevatingSeat) with one

controller See Note(s) A

N/AN/A1092650-NLA N/A

ESS6-STM (ElevatingSeat) with two

controllers See Note(s) BN/AN/A1092650-NLA

N/AESS-PTO with twocontrollers See Note(s) B











Option


ESS-PTO with twocontrollers, shock

forks and short basetogether as of 5/20/02 See Note(s) B

N/A1107312-NLA N/AN/APower Tilt Only (PTO)

with one controller See Note(s) C1139436-NLA

N/A1092650-NLA N/A2GT with one

controller See Note(s) B See Note(s) D, G

1139436-NLA N/AN/A1070401-NLA

2GT with one

controller, shock forksand short base

together as of 5/20/02 See Note(s) A See Note(s) G, D1140486-NLA

N/A1092650-NLA N/A2GT/2GR/2GTR with

two controllers See Note(s) B See Note(s) E, G

1140486-NLA N/A1092650-NLA

N/A2GT/2GR/2GTR withtwo controllers, shockforks and short base

together as of 5/20/02 See Note(s) B See Note(s) E, GA - Includes items 9 and 14-19 B - Includes items 10, 14-18 and 20 C - Includes items 11, 14, 16, 17 and 21 D - Includes items 12, 14-19, 22 and 23 E - Includes items 13 and 14-18 F - Used when TRRO or TRBKTS option is ordered G - Used only when TRBKTS option is ordered. TRRO option is not offered

NOTE:

NOTE: Two Controllers = Joystick Controller and Powered Seating System Actuator Controller are being used


MKIV Controllers, Programmer and Hardware MKIV TrueTrack

NOTE: GB motors were not available with the Arrow (301-401HD) user weight selection until 1/26/04 whenthe TTHD GB motors covered all Arrow user weight limits STANDARD. NOTE: GB motors were not

available with the Torque SP (301-351 TQHD) user weight selection until 1/26/04 when the user weightlimit was raised to 400 Lbs. See Motor/Gearbox Assembly Reference Charts for additional

standard/optional on-chair applications for all models





standard/optional on-chair applications for all modelsItem


Package Assembly1110861-NLA NLA - Controller with Instructions, MKIV GB

(TrueTrack) Non-Heavy Duty1 11 A,B,C

1109540-NLA NLA - Controller with Instructions, MKIV GB(TrueTrack) Non-Heavy Duty

1 11 B,D1116603-NLA NLA - Kit, Controller w/ Instructions,

MKIV GB (TrueTrack) Heavy Duty1 11 E,E1,N

See Chart Controller Mounting Bracket with Hardware 1 12-51092661-NLA NLA - Bracket w/ Fastener Strips, Controller

Mounting1 16 F

1092659-NLA NLA - Kit, Controller Mounting Bracket withFastener Strips, Black

1 17 G1087790-NLA NLA - Bracket, Controller Mounting, Black 1 18 H

1140264 Kit, Controller Mounting Bracket w/ Fastener Strips,Black

1 19 I40163X002 Screw, Phillips Round Head (#10-32 x 1/2") 1 310

1104258 Screw, Hex Head w/ Patch (5/16-18 x 1") 1 2111027263-NLA NLA - Washer, Lock Tooth (3/16 x 3/8 x 1/32") 1 2121104260-NLA NLA - Wire, Grounding Jumper Strap E.S.D. 1 1131023263-NLA NLA - Washer, Internal Tooth (M8) 1 214 P1070504-NLA NLA - Fastener, Hook with Adhesive Back (1" W x

1" L)1 215

1092662-NLA NLA - Package, Fastener, Dual Lock 250 (1/2" W x7/8" L)

10 1161025735 Locknut (#10-32) 1 2171025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 218

1091541-NLA NLA - Screw, Socket Head Cap (5/16-18 x 1/2") 1 2191079245-NLA NLA - Clamp, Cable 1 220

1028755 Screw, Phillips Pan Head (#10-32 x 5/8") 1 2211109091-NLA NLA - Programmer, Remote 1 122

1020818 Switch, Red Flex Ribbon (Tape) Reset 1 123 J1123276 Kit, Switch, Black Egg Reset w/ Hook/Loop


1 123 K

1091121-NLA NLA - Cable, Motor Extension, GB (8") 1 1241159217 Package, Thumb Screw (1-1/2" L) 10 1251134214 Kit, GB HD Controller Gasket Connector 1 1M,O,O

11105910-NLA NLA - Kit, ESD Ground Strap - GB 1 1L,M1105911-NLA NLA - Instruction Sheet, ESD Kit (GB) 1 1M,Q





standard/optional on-chair applications for all modelsItem


Package Assembly1118363-NLA NLA - Instruction Sheet, Replacing and Calibrating

MKIV (GB) Controller1 1M

1043576-NLA NLA - Service Manual, MKIV Electronics 1 1M1095204-NLA NLA - Cable, Virtual Service, Charger/Modem 1 1M1064404-NLA NLA - Virtual Service Modem Kit 1 1M1091631-NLA NLA - Virtual Service Software Kit 1 1M1103051-NLA NLA - MKIV One 2 One Software Kit 1 1M1091980-NLA NLA - Disk, 3.5 H.D. Floppy with V.S. Software 1 1M1091637-NLA NLA - Adaptor, Null Modem 1 1M1091636-NLA NLA - Service Manual - V.S. Software Kit 1 1M1046117-NLA NLA - Printer and Interface 1 1M1026572-NLA NLA - Paper, Printer 1 1M1027280-NLA NLA - Harness, Printer Wiring 1 1M

A - It is recommended that an E.S.D. ground strap kit part number 1105910 be ordered when a new controller is needed for chairs built before 4/12/01

B - Controller w/o instructions before 4/1/02 is 1079890 and after 3/31/02 is 1109528 as noted on the controller decal C - Before 4/1/02. No longer available. Use part number 1109540 as a replacement D - After 3/31/02 E - Controller w/o instructions is part number 1116589 as noted on the controller decal. MKIV GB heavy duty TTHD

controllers older than serial number 15704A028 are not compatible with - E1 - Group 24 battery box lids made after 1/25/04 (3/14/04 for VA Government orders) that contain a 125 Amp. fuse F - Comes packaged with item 2 Controller Mounting Bracket with Hardware. See chart for Bracket application G - Comes packaged with item 3 Controller Mounting Bracket with Hardware. See chart for Bracket application H - Comes packaged with item 4 Controller Mounting Bracket with Hardware. See chart for Bracket application I - Comes packaged with item 5 Controller Mounting Bracket with Hardware. See chart for Bracket application J - Before 5/24/04 K - After 5/23/04. The Egg Reset Switch replaced the Red Flex Ribbon (Tape) Reset Switch L - Includes items 10-13 and Instruction Sheet M - Not Shown N - Controller will include a Controller Gasket Connector Kit created 10/26/07 that attaches to the controller motor cables. O - Kit was created 10/26/07 and attaches to the controller motor cables. Includes 2 ea. GB HD Controller Gasket

Connectors, 2 ea. Silicon Lubricant Packets, 1 ea. Instruction Sheet. Individual components are non-saleable. O1 - The kit can retrofit to existing GB HD controllers in the field P - Part #1023263 is no longer available as a service part individually. Must order a complete Controller Mounting Bracket w/

Hardware as a replacement. Q - Item is no longer available from the Invacare Service Parts Department. Refer to the Invacare Website under "Product


NOTE:















OptionN/AN/AN/A1079244-NLA

Van Seat with one

controller See Note(s) A1135972-NLA

N/AN/A1079244-NLA

ASBA/ADJASBA w/one controller See Note(s) A See Note(s) E, D

1092651-NLA N/A1092651-NLA

N/AASBA/ADJASBA withtwo controllers See Note(s) B See Note(s) B, E

1092651-NLA N/A1092651-NLA

N/AASBA/ADJASBA withtwo controllers, shockforks and short base

together as of 5/20/02 See Note(s) B See Note(s) B, F

N/AN/AN/A1079244-NLA

ESS6-STM (ElevatingSeat) with one

controller See Note(s) A


ESS6-STM (ElevatingSeat) with two

controllers See Note(s) BN/AN/A1092651-NLA

N/AESS-PTO with twocontrollers See Note(s) B


ESS-PTO with twocontrollers, shock

forks and short basetogether as of 5/20/02 See Note(s) B

N/A1107311-NLA N/AN/APower Tilt Only (PTO)

with one controller See Note(s) C1135972-NLA

1092651-NLA

N/A2GT with onecontroller See Note(s) B See Note(s) F, D

1135972-NLA N/AN/A1079244-NLA

2GT with one

controller, shock forksand short base

together as of 5/20/02 See Note(s) A See Note(s) F, D1092651-NLA

N/A1092651-NLA N/A2GT/2GR/2GTR with

two controllers See Note(s) B See Note(s) B, F

1092651-NLA N/A1092651-NLA

N/A2GT/2GR/2GTR withtwo controllers, shockforks and short base

together as of 5/20/02 See Note(s) B See Note(s) B, F





standard/optional on-chair applications for all modelsA - Includes items 6, 10-15, 20 and 21 B - Includes items 7, 10-14, 16, 20 and 21 C - Includes items 8, 10, 12, 13, 17, 20 and 21 D - Includes items 9, 10-15, 18-21 E - Used when TRRO or TRBKTS option is ordered F - Used when TRBKTS option is ordered. TRRO option is not offered

NOTE:

NOTE: Two Controllers = Joystick Controller and Powered Seating System Actuator Controller are being used


ElectronicsMKIV Elevating Seat Toggle Switch


ElectronicsMKIV Elevating Seat Toggle Switch



1105700-NLA NLA - Switch, MKIV Elevating Seat Toggle 1 111091496 Kit, Joystick Tube Toggle Switch Mounting

Hardware1 12 A

NLA - Half Clamp, Threaded Holes 1 13Half Clamp, Non-Threaded Holes 1 14Screw, Hex Head w/ Patch (1/4-20 x 1/2") 1 25NLA - Bracket, Toggle Switch Mounting, Black 1 16NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 27

1091497-NLA NLA - Kit, Quad Link Toggle Switch MountingHardware

1 12 BScrew, Hex Head w/ Patch (1/4-20 x 1/2") 1 45NLA - Bracket, Toggle Switch Mounting, Black 1 16NLA - Bracket, Quad Link Toggle Switch Mounting,Black

1 18Screw, Phillips Pan Head (#10-32 x 1-3/8") 1 29Locknut (1/4-20) 1 210Locknut (#10-32) 1 211

1139684-NLA NLA - Kit, Quad Link Toggle Switch MountingHardware

1 12 CLocknut (#10-32) 1 212Screw, Hex Head w/ Patch (1/4-20 x 1/2") 1 213Bracket, Toggle Switch Mounting, Black 1 114Screw, Phillips Pan Head w/Patch (#10-32 x 7/8") 1 215

1105715-NLA NLA - Sensor, Proximity Switch 1 116A - Includes items 3-7 B - Before 10/31/05 and Includes items 5, 6 and 8-11 C - After 10/30/05 and includes items 12-15

NOTE:


MKIV TAC and 4-Way SwitchNOTE: MKIV TAC and 4-way switch are used when Power Articulating Legrest Kits are ordered.


MKIV TAC and 4-Way SwitchNOTE: MKIV TAC and 4-way switch are used when Power Articulating Legrest Kits are ordered.



1104248-NLA NLA - Controller w/ Hardware, MKIV TAC 1 11 A,F1109552-NLA NLA - Controller w/ Hardware, MKIV TAC 1 11 B,E,F1098915-NLA NLA - Controller, MKIV TAC 1 12 G1070462-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 7/8") 1 23

1028769 Locknut (5/16-18) 1 241080116-NLA NLA - Switch, 4-Way (FWT) 1 15 I

60105577 Kit, Switch, 4-Way (FWT) 1 151077519 Kit, 4-Way Switch Joystick Tube Mounting

Hardware1 16 C

NLA - Half Clamp, Threaded Holes 1 17Half Clamp, Non-Threaded Holes 1 18NLA - Bracket, Joystick Mounting, Black 1 19NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 210Washer (#10 Flat) 1 211Screw, Phillips Pan Head (#10-32 x 1/2") 1 212

1077520-NLA NLA - Kit, 4-Way Switch Quad Link MountingHardware

1 16 D,JNLA - Bracket, Quad Link Mounting, Black 1 19Washer (#10 Flat) 1 211Screw, Phillips Pan Head (#10-32 x 1/2") 1 212Locknut (#10-32) 1 213Screw, Phillips Pan Head (#10-32 x 1-3/8") 1 214

1139418 Kit, 4-Way Switch Quad Link Mounting Hardware 1 16 H,JScrew, Phillips Pan Head w/Patch (#10-32 x 7/8") 1 215Screw, Phillips Pan Head (#10-32 x 1/2") 1 216NLA - Washer, Nylon (#10) 1 217Locknut (#10-32) 1 218

1134132 Bracket, 4-Way Switch Quad Link, Black - Right 1 1191134133 Bracket, 4-Way Switch Quad Link, Black - Left 1 119

A - Before 5/1/02 B - After 4/30/02 C - Includes items 7-12 D - Before 11/31/05 and Includes items 9 and 11-14 E - MKIV T.A.C. part number 1109552 is not compatible with power legs with an inline actuator made before 5/1/02 F - Includes items 2-4 G - Part number 1098915 is being sold with the hardware. See item #1 part number 1104248 H - After 11/30/05 and includes items 15-19 I - Part # 1080116 is No Longer Available. Order item #1 part number 60105577 as a replacement. New design is rectangular

in shape. It is recommended to order new Hardware 1077519 as well. J - 4-Way Toggle Switch 60105577 is not compatible with this hardware.

NOTE:


MKIV TAC and 4-Way SwitchFor TRBKTS Option

NOTE: MKIV TAC and 4-way switch are used when Power Articulating Legrest Kits are ordered.


MKIV TAC and 4-Way SwitchFor TRBKTS Option

NOTE: MKIV TAC and 4-way switch are used when Power Articulating Legrest Kits are ordered.Item


Package Assembly1140487-NLA NLA - Controller w/ Hardware, MKIV TAC For

TRBKTS Option1 11 A

1122652 Screw, Hex Head w/ Patch (5/16-18 x 5/8") 1 221080116-NLA NLA - Switch, 4-Way (FWT) 1 13 D

60105577 Kit, Switch, 4-Way (FWT) 1 131077519 Kit, 4-Way Switch Joystick Tube Mounting

Hardware1 14 B

NLA - Half Clamp, Threaded Holes 1 15Half Clamp, Non-Threaded Holes 1 16NLA - Bracket, Joystick Mounting, Black 1 17NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 28Washer (#10 Flat) 1 29Screw, Phillips Pan Head (#10-32 x 1/2") 1 210

1139418 Kit, 4-Way Switch Quad Link Mounting Hardware 1 14 C,EScrew, Phillips Pan Head w/Patch (#10-32 x 7/8") 1 211Screw, Phillips Pan Head (#10-32 x 1/2") 1 212NLA - Washer, Nylon (#10) 1 213Locknut (#10-32) 1 214

1134132 Bracket, 4-Way Switch Quad Link, Black - Right 1 1151134133 Bracket, 4-Way Switch Quad Link, Black - Left 1 115

A - Includes the controller, item 2 and used for TRBKTS Option. B - Includes items 5-10 C - Includes items 11-14 D - Part # 1080116 is No Longer Available. Order item #3 part number 60105577 as a replacement. New design is

rectangular in shape. It is recommended to order new Hardware 1077519 as well. E - Part # 60105577 4-Way Toggle Switch is not compatible with this hardware.

NOTE:


Controller Shroud Covers


Controller Shroud Covers

SeatingSystem

TypeItem 1 Item 2 Item 3 Item 4 Item 5

1104822-NLA 11048391112684-NLA1104841-NLA

1091310-NLA See Note(s) A See Note(s) BOne Controller,

(GB Motorsw/o Wheel locks),

(with or withoutShock Forks) and

Short Base

One Controller,4-Pole Motors or

(GB Motorsw/ Wheel locks),(with or without

Shock Forks) andShort Base

After5/19/02w/ Two

Controllers,Short Base and

Shock ForksPresent

After 7/15/01

To Presentw/ Two

Controllers

Before7/16/01w/ Two

ControllersA.S.B.A. Seat

One Controller,(GB Motors

w/o Wheel locks),(with or without





N/AAfter

7/15/01To Present

w/ TwoControllers

N/AESS6-STMElevating Seat

N/AN/A

After5/19/02w/ Two

Controllers,Short Base and

Shock ForksPresent

After 7/15/01

To Presentw/ Two

ControllersN/A

ESS-PTOElevating Seatw/ Power Tilt

Only

See Note(s) COne Controller,

(GB Motorsw/o Wheel locks),

(with or withoutShock Forks) and

Short Base




N/AN/AN/AVAN Seat

A - Two TrueTrack decals must be ordered when G/B motors are present for chairs made after 6/2/02. B - Shroud cover includes the TrueTrack decals and loop fasteners. C - When a PTO is ordered without the elevate seat option, the controller cover is omitted

NOTE:

NOTE: All controller shroud covers include mounting hardware.NOTE: When a 2G Powered Seating System is present, see the 2G Powered Seating system parts book Form # 99-150 for the correctcontroller shroud cover.NOTE: Two controllers are identified as one chair equipped with a joystick controller and a seating system actuator(s) controller.


Controller Shroud CoversItem


Package Assembly1104706-NLA NLA - Kit, Controller Shroud Mounting Hardware

(Pair)2 16 A

1070580-NLA NLA - Washer, Nylon Retainer (1/4 x 1/2 x 1/32") 1 271070581-NLA NLA - Washer, Nylon Cupped (9/32 x 19/32 x 3/32") 1 281093312-NLA NLA - Spring, Torsion Ejector 1 291110508-NLA NLA - Stud, Phillips Recess (1/4" Dia. x 1" Long, 1/4

Turn)1 210 B

1110509-NLA NLA - Retainer, Stud (1/4" Turn) 1 2111079246-NLA NLA - Fastener, Loop Adhesive Back (1" W x 3" L) 1 2121104799-NLA NLA - Decal, TrueTrack 1 2131092662-NLA NLA - Package, Fastener, Dual Lock 250 (1/2" W x

7/8" L)10 414

1028755 Screw, Phillips Pan Head (#10-32 x 5/8") 1 215See Chart Controller Shroud Covers 1 1C

A - Includes items 7-11 B - Due to a hardware change, when item 10 is requested, refer to Item 6 for chairs manufactured before 2/21/02 C - Not Shown

NOTE:


MKIV Sip-N-Puff/Digital Interface and COM12 and COM34


MKIV Sip-N-Puff/Digital Interface and COM12 and COM34Item


Package Assembly1038635-NLA NLA - Sip-N-Puff w/ Digital Interface 1 18

See Note See Footnote 1 19 D1086241-NLA NLA - Module, Communication, COM34/AUX34 1 191049592-NLA NLA - Kit, COM12/AUX12 and COM34/AUX34

Mounting Hardware1 110 A

NLA - Half Clamp, Threaded Holes 1 11Half Clamp, Non-Threaded Holes 1 12NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 23NLA - Fastener, Dual Lock Hook and LoopAdhesive(2" W x 12" L)

1 14

NLA - Plate, COM12/AUX12 and COM34/AUX34Mounting

1 151049593 Kit, SNP/DI, MK5 SAC, 4WSB, S4WSB, GTAM,

AUX12M6, AUX34M6 Mtg. Hdwr.1 111 B,C

NLA - Half Clamp, Threaded Holes 1 11Half Clamp, Non-Threaded Holes 1 12NLA - Screw, Hex Head (1/4-20 x 1-1/8") 1 23Screw, Phillips Pan Head (#4-40 x 3/8") 1 26Plate, Mounting 1 17

A - Mounting hardware includes items 1-5. Item 4 that is packaged with the kit will only be a 4" long "loop" fastener. B - Includes items 1-3 and 6-7 C - As of 5/22/07 the Mounting Plate holes and the orientation of the Hardware was revised to attach the electronics closer to

the chair. The Mounting Hardware Kit is backward compatible. D - Part is no longer serviceable in the field.

NOTE:


MKIV Displays


MKIV DisplaysItem


Package Assembly1108490-NLA NLA - Display without Switches 1 11

1108489 Display with Switches 1 121049594-NLA NLA - Tube, Flex with Screws 1 13 A

1052041 Screw, Phillips Pan Head (#4-40 x 3/8") 1 441049591-NLA NLA - Hardware, Joystick Tube Mounting 1 15 B1027267-NLA NLA - Half Clamp, Threaded Holes 1 16

1027266 Half Clamp, Non-Threaded Holes 1 171027274 Adjustment Lock Assemnbly, Black 1 18


1093071 Clamp, Fixed Height Joystick Tube 1 111 C1139422 Clamp, Height Adjustable Joystick Tube (ARM250) 1 112 F1020818 Switch, Red Flex Ribbon (Tape) Reset 1 113 D1123276 Kit, Switch, Black Egg Reset w/ Hook/Loop


1 114 E

A - Includes the Flex Tube and item 4 B - Before 10/4/00 and includes items 6-10 C - After 10/3/00 and can be used as a direct replacement for the Joystick Tube Mounting Hardware part number 1049591 in

the field. Individual components are non-saleable D - Before 5/24/04 E - After 5/23/04 the Egg Reset Switch replaced the Red Flex Ribbon (Tape) Reset Switch F - Introduced 10/31/05 as option (ARM250) and can be used to replace a Fixed Height Joystick Tube Clamp in the field

NOTE:




1055149 Cover, Nylon 1 11 B1055151-NLA NLA - Cover, Nylon 1 11 C1055148-NLA NLA - Clamp with Knob, Two-Piece 1 12

1003645 Screw, Socket Button Head (#10-32 x 3/4") 1 437930326-NLA NLA - Package, Screw, Hex Head (1/4-20 x 3/4") 25 841054931-NLA NLA - Bracket, Attaching, Black (12 - 18" W) 1 15 B1054933-NLA NLA - Bracket, Attaching, Black (19 - 24" W) 1 15 C

1031095 Screws with Washers (#10-16 x 7/8") 4 161076284 Screw w/ Washer (#10 x 7/8") 1 46

1054929-NLA NLA - Bracket, Wing, Black 1 271026907 Washer (1/4 x 1/2 x 1/16") 1 887930333 Locknut (1/4-20) 25 89

1026034-NLA NLA - Washer, Nylon (3/16 x 7/16 x 1/8") 1 4107930332-NLA NLA - Locknut, High Profile (#10-32) 25 411

1056347 Hardware, Rim Control Mounting (RIMHW) (12-18"W)

1 112 B,A1056348 Hardware, Rim Control Mounting (RIMHW) (19-24"

W)1 112 C,A

A - Includes items 1-11 B - For 12-18" wide chairs C - For 19-24" wide chairs

NOTE:

MKIV R.I.M. Head Control Mounting Hardware(1500M4)


MKIV R.I.M. Head Control Assembly(1500M4)





1001625 Tie Rod End 1 1148095X000-NLA NLA - Locknut (#10-32) 1 12

1025275-NLA NLA - Screw, Set w/ Patch (#8-32 x 1/4") 1 132001139 O-Ring (1/2" I.D.) 1 141028529 Screw, Phillips Pan Head (#8-32 x 3/8") 1 25

1055002-NLA NLA - Washer, Nylon 1 261056206 Block, Pivot 1 17

1054939-NLA NLA - Ring, Snap 1 281018113 Bearing, Linear 1 19

1055014-NLA NLA - Shield, Push Rod 1 1101021742 Screw, Phillips Pan Head (#4-40 x 1/2") 1 411

1055031-NLA NLA - Bracket, Headrest Mounting, Black 1 11240127X002-NLA NLA - Screw, Phillips Oval Head (#10-32 x 3/4") 1 113

1055145-NLA NLA - Spring, Compression (19/32 x 1-1/4 x 1/32") 1 1141055016-NLA NLA - Rod, Push 1 1151026728-NLA NLA - Screw, Phillips Pan Head (#6-32 x 1/4") 1 116

1010398 Washer, Nylon (1/4 x 1/2 x 1/16") 1 2171025236-NLA NLA - Collar, Shoulder 1 118

50000X364-NLA NLA - Boot, Joystick 1 1191055017-NLA NLA - Rod, Pivot 1 120

11008X014-NLA NLA - Screw, Phillips Round Head (#10-32 x 1") 1 4211038256-NLA NLA - Tie Wrap (4-1/4" L) 1 1221037373-NLA NLA - Cover, Splash 1 1231003766-NLA NLA - Washer, Plain (1/2 x 1 x 1/8") 1 4241025271-NLA NLA - Ribbon Reset Switch and Bracket Assembly 1 125

1056210E-NLA NLA - Reconditioned - Joystick, Remote Head 1 126 A1055023-NLA NLA - Clamp, Horizontal Pivot 1 1271055024-NLA NLA - Clamp, Threaded, Horizontal Pivot 1 1281055144-NLA NLA - Screw, Socket Head (M6 x 1 x 25mm) 1 629

1055028 Tube, Slide, Square, Short 1 1301055025-NLA NLA - Clamp, Vertical Pivot 1 1311055026-NLA NLA - Clamp, Threaded, Vertical Pivot 1 1321055027-NLA NLA - Tube, Slide, Square, Long 1 133

1056213 Hardware, Adjustment 1 134 B1005383 Screw, Socket Button Head (#10-32 x 1") 1 335

1027263-NLA NLA - Washer, Lock Tooth (3/16 x 3/8 x 1/32") 1 3361056211 Kit, Headrest with Hardware, Otto Bock, Small 1 137 C1056212 Kit, Headrest with Hardware, Large 1 138 D

1056087-NLA NLA - Screw, Socket Head (#10-32 x 1/2") 1 4E



A - Includes items 1-25. B - Includes items 27-33 and the Plug Buttons that attach to item 30 and 33 Slide Tubes. The Plug Buttons are not saleable. C - Includes the Headrest Adapter and items 35 and 36. D - Includes the Headrest Adapter and items 35 and 36. The LaBac Headrest is no longer used as of 12/6/10 that was

attached with Screw part # 1056087 (4 ea.). The screw is still available to order for existing LaBac Headrest in the field. E - Used for existing LaBac Headrest in the field only.

NOTE:


MKIV Joystick Options


MKIV Joystick OptionsItem


Package AssemblySee Note See Footnote 1 11 N

1010848-NLA NLA - Clamp, Universal Swivel 1 1212595X000 Handle, Lock, Chrome 1 1315108X000 Locknut (1/4-20) 1 14

1044928-NLA NLA - Joystick Tube with Plug Button Assembly 1 151027095 Plug Button, Black (7/8") 1 161025590 Joystick, Attendant Control (1552M) 1 17

1041544-NLA NLA - Joystick, Heavy Duty 1 181052719-NLA NLA - Kit, Straight Joystick Tube with Hardware 1 19 A1016401-NLA NLA - Screw, Phillips Round Head (#10-32 x 3/8") 1 310

1027095 Plug Button, Black (7/8") 1 1111044917 Hardware, Rear Cane Mount (1673/RCM) 1 112 B1027095 Plug Button, Black (7/8") 1 1131027274 Adjustment Lock Assemnbly, Black 1 114

1025245-NLA NLA - Bracket, Upright, Black -Right 1 1151044918-NLA NLA - Tube, Joystick 1 116

1076284 Screw w/ Washer (#10 x 7/8") 2 1171052309 Tube, Arm Mount with Plug Button, Black 1 118 C1027095 Plug Button, Black (7/8") 1 119

1038638-NLA NLA - Joystick, MKIV Dual/Compact 1 1201108012 Hardware, Dual/Compact Joystick Clamp Mounting 1 121 D1025048 Clamp 1 1221021460 Screw, Socket Button Head (#10-32 x 5/16") 1 423

1025045-NLA NLA - Clamp, Mounting 1 1241027089-NLA NLA - Screw, Socket Head (#10-24 x 1/2") 1 1251026273-NLA NLA - Spacer, Split (3/8" I.D.) 1 126

60102524 Kit, Chin Cup Assembly - 1826 1 127 E1017545 Cup, Chin 1 128

1017612-NLA NLA - Screw, Adaptor 1 129 O90032X000 Screw, Set Socket Cup Point (#8-32 x 1/4") 1 230

1091353-NLA NLA - Touchpad, Joystick Assembly 1 1311092604-NLA NLA - Kit, Straight Joystick Tube with Hardware 1 132 F

1027095 Plug Button, Black (7/8") 1 2331052041 Screw, Phillips Pan Head (#4-40 x 3/8") 1 434

1049591-NLA NLA - Hardware, Joystick Tube Mounting 1 135 G1027267-NLA NLA - Half Clamp, Threaded Holes 1 136

1027266 Half Clamp, Non-Threaded Holes 1 1371027274 Adjustment Lock Assemnbly, Black 1 138


1093071 Clamp, Fixed Height Joystick Tube 1 141 H1139422 Clamp, Height Adjustable Joystick Tube (ARM250) 1 142 I1020818 Switch, Red Flex Ribbon (Tape) Reset 1 143 J


MKIV Joystick OptionsItem


Package Assembly1123276 Kit, Switch, Black Egg Reset w/ Hook/Loop


1 144 K

1108489 Display with Switches 1 1L1108490-NLA NLA - Display without Switches 1 1M

A - Includes the joystick tube and items 10 and 11 B - Includes items 13-17 C - For On-Chair model numbers 1678 and 1679. Includes the joystick tube and item 19 D - Includes items 22-26 E - Includes items 28-30 F - Includes the joystick tube, items 33 and 34 G - Before 10/4/00 and includes items 36-40 H - After 10/3/00. Individual components are non-saleable. Can be used as a direct replacement in the field for the Joystick

Tube Mounting Hardware part number 1049591. I - Introduced 10/31/05 as option (ARM250) and can be used to replace a Fixed Height Joystick Tube Clamp in the field.

Individual components are non-saleable. J - Before 5/24/04 K - After 5/23/04. The Egg Reset Switch replaced the Red Flex Ribbon (Tape) Reset Switch L - Not Shown and used with the Heavy Duty and Touch Pad Joystick M - Not Shown and used with the Remote Joystick N - No longer available as a service part in the field. O - Part #1017612 is no longer available as a service part individually. Order item #27 as a replacement.

NOTE:


Tash and Therafin Accessories


Tash and Therafin AccessoriesItem


Package AssemblyP5820-NLA NLA - Switch, Red Soft 1 11

P5821 NLA - Switch, Green Soft 1 11P5018-NLA NLA - Wafer Board (5018) 1 12 CP5026-NLA NLA - Star Control 1 13 CP5020-NLA NLA - Mini Joystick with Push (5020) 1 14 CP4337-NLA NLA - Multi-Ability Cable 1 15P4353-NLA NLA - CA5 Multi-Connector Box 1 16P5970-NLA NLA - Clamp, "U" 1 17

1142362 Bib Assembly (PKG32669) 1 1BP21456-NLA NLA - Adaptor Clamp - Tash 1 1BP21457-NLA NLA - Adaptor Clamp - Invacare 1 1BP21460-NLA NLA - Midline Swingway System 1 1B

1140824 Kit, Sip-N-Puff, 16" Fixed (PKG32666)Includes: (3) Air Tube Straws, (2) Saliva Traps, Tubing, PivotShaft/Flexible Metal Gooseneck Assembly, andExtruded Figure "8" Clamp to fit 7/8" WheelchairFrame Tubing. Extruded Back Cane Adapter Clamp.

1 1A,B

1108489 Display with Switches 1 1BA - See items included. B - Not Shown C - Must be used with display with switches part #1108489.

NOTE:


Invacare Corporation www.invacare.com

One Invacare WayElyria, Oh USA44036-2125800-333-6900

Technical Support800-832-4707Customer Service800-333-6900

Literature Orders800-333-6900

Form No. 06-100

© 2020 Invacare Corporation. All rightsreserved. Republication, duplication ormodification in whole or in part is prohibitedwithout prior written permission fromInvacare. Trademarks are identified by ™and ®. All trademarks are owned by orlicensed to Invacare Corporation or itssubsidiaries unless otherwise noted.(Revised 02/03/20)

Storm Series® 3G Front Riggings & MKIV ElectronicsStorm Series® 3G Front Riggings & MKIV...

Documents

Transcript of Storm Series® 3G Front Riggings & MKIV ElectronicsStorm Series® 3G Front Riggings & MKIV...