7/30/2019 STONELAND EJW

1/4

MATERIAL SAFETY DATA SHEET

EASTERN COLOR & CHEMICAL COMPANY35 Livingston StreetProvidence, RI 02904

Telephone: (401) 331-9000; Fax: (401) 331-2155Emergency Phone: CHEMTREC - 1-800-424-9300

I. IDENTIFICATION

PRODUCT NAME: STONELAND EJW

CHEMICAL NAME: Ethoxylated alcohol solution.PREPARATION DATE: 12-18-97DOT-- Hazard Classification: Combustible liquid, NOS

Shipping Name:UN No.: NA 1993

DEGREE OF HAZARD: 1. slight; 2. moderate; 3. extreme; 4. potentialcarcinogen, teratogen, mutagen

HEALTH ( 1 ) FLAMMABILITY ( 1 ) REACTIVITY ( 0 )

II. INGREDIENTS AND HAZARDS

Material or Component % CAS No. TLV (Units) HAZARD DATAIsopropanol 7.4 67-63-0 400 ppm OSHA-PEL-8 hrs TWA-----------------------------------------------------------------------PEL = OSHA Permissible Exposure Limit TLV = ACGIH Threshold Limit

STEL= Short-term Exposure Limit TWA = Time-weighted Average----------------------------------------------------------------------THE ABOVE-LISTED INGREDIENTS ARE SUBJECT TO THE REPORTING REQUIREMENTSOF SARA 313, TITLE III, SARA 312.THESE CHEMICALS ARE HAZARDOUS UNDER 29 CFR 1910.1200 AND ARECATEGORIZED AS IMMEDIATE AND DELAYED HEALTH AND PHYSICAL HAZARDS.ALL MATERIALS USED IN THIS MANUFACTURE ARE TSCA REPORTED, CANADIAND.S.L. REGISTERED AND INCLUDED ON THE EUROPEAN INVENTORY OF EXISTINGCHEMICALS (EINECS) IN COMPLIANCE WITH COUNCIL DIRECTIVE 67/548/EEC ANDAMENDMENTS.----------------------------------------------------------------------

III. PHYSICAL DATA

Boiling Point: 212 F Specific Gravity (water=1): 0.9927Vapor Pressure: N/A % Volatiles by Vol.: 10%Vapor Density (air=1): N/A Evaporation rate (water=1): --Solubility in water: Completely soluble in water.Appearance and color: Clear liquid; faint alcoholic scent.

7/30/2019 STONELAND EJW

2/4

Page 1.

cont. of EJW IV. FIRE AND EXPLOSION HAZARD DATA

Flash Point (test method): 205 F (open cup)Flammable Limits: Lel- N/A ; Uel- N/AExtinguishing Media: CO 2 - Foam Water - Dry chemicalSpecial Firefighting Procedures: Wear a self-contained breathing unit

in confined areas.Unusual Fire and Explosion Hazard: NONE

V. REACTIVITY DATA

Stability-- Stable _X__ Unstable ____

Hazardous Polymerization-- May occur ____ Will not occur __X_

Conditions and Materials to Avoid-- Avoid Acids.

Hazardous Decomposition Products-- Thermal decomposition will yield CO,CO2 and other noxious vapors.

VI. SPECIAL PROTECTION

Respiratory-- Respiratory mask with an organic chemical canister -NIOSH approved-when used in confined areas.

Eye Protection-- Wear protective glasses or face shield.Protective Gloves-- Impervious gloves recommended.Ventilation-- Normal room ventilation needed to maintain OSHA

standards. Avoid high concentrations associated withconfined areas.

VII. SPILL OR LEAK PROCEDURES

Steps to be taken in case material is spilled or released--Use dry absorbent. Ventilate area. Keep away from sewers and watersystems by diking. Spill may be slippery.

Waste Disposal Method--Collect dry refuse into a suitable container for disposal.Incinerate or bury in accordance with Federal or local regulations.

VIII. STORING AND HANDLING

Indoor: __X___ Outdoor: _______

7/30/2019 STONELAND EJW

3/4

Normal storage. Keep from freezing.

Page 2.

cont. of EJW IX. HEALTH HAZARD DATA

Routes of Entry: Inhalation _X__ Skin _X__ Ingestion _X__

HAZARD - ACUTE--Eye Contact: Will cause irritation and tearing.Skin Contact: May cause mild irritation, defatting of tissues and

possible dermatitis.

Ingestion: May be harmful if swallowed. Avoid ingestion.Nausea, vomiting and diarrhea may result.Inhalation: Excessive inhalation of vapors may cause nasal and

respiratory irritations. Headaches, drowsiness andlack of coordination may result.

EXPOSURE LIMITS: ACGIH-400 ppm; OSHA-PEL-400 ppm; TLV-TWA-8 hrs;NIOSH-400 ppm; TWA-10 hrs.

HAZARD-CHRONIC--Toxicity: generally non-toxic; use good hygienepractices. Isopropyl Alcohol is not a liver toxin nor a kidneytoxin. However, pre-existing liver, kidney or respiratory

conditions should warn those persons to avoid contact orinhalation because their systems may not detoxify at asufficient rate.

CARCINOGENIC POTENTIAL: Isopropyl Alcohol is not a confirmed cancer-causing material.

X. FIRST-AID RESPONSES

Eyes: Flush with water; see physician.Skin: Remove contaminated clothing. Wash skin with soap and

water; repeat. See physician if irritation persists.

Ingestion: _X__ Promote vomiting; head low; prevent liquid fromdraining into lungs; get medical attention.

____ Do not induce vomiting; see physician.

Inhalation: Remove victim to fresh air; give oxygen if breathingis difficult; keep warm. Get medical attention.

7/30/2019 STONELAND EJW

4/4

While the information and recommendations set forth herein are believedto be accurate as of the date hereof, EASTERN COLOR & CHEMICAL COMPANYmakes no warranty with respect thereto and disclaims all liability fromreliance thereon. BE SAFE--read for product safety information and

pass it on.Page 3.

STONELAND EJW

CLASSIFICATION:

Synthetic scouring agent and surfactant.

PROPERTIES:

Appearance - Clear, colorless liquidpH (2% solution) - 7.6-8.0Solubility - Completely soluble in waterDensity - 8.3 lbs/gallon

GENERAL COMMENTS:

STONELAND EJW is a specially prepared synthetic detergent designedfor emulsification, wetting and soil removal properties in thescouring of cotton, polyester, polyester/cotton, nylon, wool andblends of these fibers, leaving a clean, soft hand to the scouredfabric. This product incorporates a wetting agent, detergent,

sequestering agent and soil anti-redeposition agent to enhanceperformance properties. In desizing, the use of STONELAND EJW isuseful to facilitate enzymatic action in the destruction andremoval of sizing.

APPLICATION:

In cotton, rayon and synthetic fiber scouring, use 0.5-1.0% ofSTONELAND EJW. Heat bath to 125-140F, scour for 30 minutesand rinse when scouring is completed. Soda ash may be added ifdesired.

In scouring wool, it is suggested to use 0.5-1.0% of STONELAND EJWand adjust the scouring bath to pH 7 by the addition of soda ashor sodium bicarbonate. Heat bath to 120-130F, scour for 30minutes and rinse when scouring is completed.

In enzyme desizing operations, STONELAND EJW is used at 0.25-0.5%to facilitate wetting and increase the desizing power of theenzyme.