SERVICES AND SOLUTIONS FOR A LIVABLE REGION … · Avcorp Industries Inc. (the “Permittee”) To...

19
metrovancouver SERVICES AND SOLUTIONS FOR A LIVABLE REGION PERMIT GVAOG14 Pursuant to: Greater Vancouver Regional District Air Quality Management Bylaw No. 1082, 2008 and the BC Environmental Management Act, S.B.C 2003, c.53 Issued to: Avcorp Industries Inc. (the “Permittee”) To Authorize: the discharge of air contaminants to the air from Aircraft Component Manufacturing Plant Located at: 10025 River Way, Delta, BC V4G 1M7 Effective Period: The terms and conditions set out in the Permit apply to the existing or planned works as of April 24, 2018 and this permit will expire on March 31, 2028. All previous versions of this Permit are invalid. Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng. Amended: April 24, 2018 District Director Page 1 of 19

Transcript of SERVICES AND SOLUTIONS FOR A LIVABLE REGION … · Avcorp Industries Inc. (the “Permittee”) To...

metrovancouverSERVICES AND SOLUTIONS FOR A LIVABLE REGION

PERMIT GVAOG14

Pursuant to:

Greater Vancouver Regional District Air Quality Management Bylaw No. 1082, 2008

and the BC Environmental Management Act, S.B.C 2003, c.53

Issued to:

Avcorp Industries Inc.

(the “Permittee”)

To Authorize:

the discharge of air contaminants to the air from

Aircraft Component Manufacturing Plant

Located at:

10025 River Way, Delta, BC V4G 1M7

Effective Period:

The terms and conditions set out in the Permit apply to the existing or planned works as of

April 24, 2018 and this permit will expire on March 31, 2028.

All previous versions of this Permit are invalid.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Page 1 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

SECTION 1 — AUTHORIZED EMISSION SOURCES

Authorization to discharge air contaminants from the authorized Emission Sources and Works listed below is

subject to the specified terms and conditions.

Approximate locations of the emission sources are shown on the Site Plan in section 4.

EMISSION SOURCE 01: Waste treatment room discharging through two roof exhausts.

MAXIMUM EMISSION FLOW RATE; 460 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 02; Release film application booth discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 225 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:

Good operating practices.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.

Amended: April 24, 2018 District Director

Permit GVAO614

Page 2 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 03: Passivation tank discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 110 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 50 mg/rn3 Nitric Acid

WORKS AND PROCEDURES:

Good operating practices.

EMISSION SOURCE 04: Paint stripping tank discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 140 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration fEC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:

Good operating practices.

EMISSION SOURCE 05: Fuel tank wash-down area discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 140 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:

1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emittedchemical contaminant with a Threshold Limit Value fTLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 3 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 06: Phosphoric acid deoxidizing and anodizing tanks discharging through two roofexhausts.

MAXIMUM EMISSION FLOW RATE: 370 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 10 mg/rn3 Phosphoric Acid

WORKS AND PROCEDURES:

Good operating practices.

EMISSION SOURCE 07: Chromic acid anodizing tank discharging through a Stack(s).

MAXIMUM EMISSION FLOW RATE: 240 m3/rninMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 0.01 mg/rn3 Chromium Expressed as total chromium.

WORKS AND PROCEDURES:

Good operating practices which includes the routine monitoring of the anodizing bath surface tensionso as not to exceed 45 dynes per centimeter.

The Perrnittee shall measure and record the surface tension of the anodizing tank bath once eachoperational day. The methodology employed to measure surface tension shall be consistent withthose in EPA Method 306-B. The surface tension measurements, the frequency of fume suppressantmaintenance additions, and the amount of fume suppressant added during each maintenanceaddition are to be recorded. These readings are to be maintained in a written bound log or otherformat approved by the District Director, and made available for inspection by Metro Vancouver stafffor a minimum period of three years.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVA0614

Page4ofl9

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 08: Boric/sulphuric anodizing tank discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 185 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 10 mg/rn3 Sulphuric Acid Includes acid mists.2. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 09: General ventilation of the penetrant inspection area and the tooling storage roomdischarging through two roof exhausts.

MAXIMUM EMISSION FLOW RATE: 140 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 10% Opacity.2. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 10: Process tank area discharging through two roof exhausts.

MAXIMUM EMISSION FLOW RATE: 560 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.

Amended: April 24, 2018 District Director

Permit GVAO614

Page 5 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 11: Mechanical testing and wet analysis laboratory fume hoods discharging through fourroof exhausts.

MAXIMUM EMISSION FLOW RATE: 145 m3/minMAXIMUM ANNUAL OPERATING HOURS: 6552 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration fEC) for each emitted

chemical contaminant with a Threshold Limit Value fTLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 12: Structural adhesive cutting and sanding booth discharging through a Stack(s).

MAXIMUM EMISSION FLOW RATE: 60 m3/minMAXIMUM ANNUAL OPERATING HOURS: 2340 h/y

MAXIMUM EMISSION QUALITY:1. 50 mg/m3 Particulate Matter2. 10% Opacity.

WORKS AND PROCEDURES:Filters and related appurtenances, together with good operating practices.

EMISSION SOURCE 15: Vapour degreasing tank discharging through a Stack(s).

MAXIMUM EMISSION FLOW RATE: 35 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 6of19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

WORKS AND PROCEDURES:The enclosed tank and solvent recovery system and related appurtenances, together with goodoperating practices.

EMISSION SOURCE 16: Two primer ovens (electric) discharging through two roof exhausts.

MAXIMUM EMISSION FLOW RATE: 120 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 17: Four paint booths (No. 1, 2, 6 & 7) discharging through six roof exhausts.

MAXIMUM EMISSION FLOW RATE: 2300 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 10% Opacity.2. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Filters and related appurtenances, together with good operating practices.

The Permittee shall continuously measure the pressure drop across the spray booth filter banks with adifferential pressure measuring device. The Permittee shall maintain written records of spray boothfilter replacement in a written bound log or other format approved by the District Director, and madeavailable for inspection by Metro Vancouver staff for a minimum period of three years.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 7 of 19

METRO VANCOUVER REGIONAl. DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 18: Paint mixing room discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 45 m3/min

MAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:

1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:

Good operating practices.

EMISSION SOURCE 19: Paint shop oven (electric) discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 10 m3/min

MAXIMUM ANNUAL OPERATING HOURS: 8760 h/y -

MAXIMUM EMISSION QUALITY:

1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 20: Autoclaves (No. 1, 2 & 3) discharging through a Vent(s).

MAXIMUM EMISSION FLOW RATE: 15 m3/min

MAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.

Amended: April 24, 2018 District Director

Permit GVAO614

Page 8 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 21: Two aging ovens (electric) discharging through two roof exhausts.

MAXIMUM EMISSION FLOW RATE: 50 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 10% Opacity.2. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 22: Detail fabrication routers discharging through a wall exhaust.

MAXIMUM EMISSION FLOW RATE: 127 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 20 mg/m3 Particulate Matter2. 10% Opacity.3. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value fTLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Airflow Systems Model DC8 cartridge dust collector and related appurtenances; together with goodoperating practices.

EMISSION SOURCE 23: Shot peening cabinets discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 45 m3/minMAXIMUM ANNUAL OPERATING HOURS: $760 h/y

MAXIMUM EMISSION QUALITY:1. 20 mg/rn3 Particulate Matter2. 10% Opacity.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 9 of 19

METRO VANCOUVER REGIONAl. DISTRICT AIR QUALITY MANAGEMENT PERMIT

WORKS AND PROCEDURES:Universal Model DC500 baghouse and DC100 baghouse (small blast cabinet) and related

appurtenances, together with good operating practices.

EMISSION SOURCE 25: Fuel tank oven (electric) discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 35 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 27: Three paint/bake booths (No. 3, 4, & 5) discharging through six roof exhausts.

MAXIMUM EMISSION FLOW RATE: 2300 m3/min

MAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM PRIMARY BURNER INPUT FIRING RATE: 15.67 GJ/h

MAXIMUM EMISSION QUALITY:1. 10% Opacity.2. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individual

EC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Filters and related appurtenances, together with good operating practices. The paint/bake booths are

fired with natural gas, using good combustion practices and operating procedures.

The individual firing rates are 5.08, 5.51, and 5.08 GJ/hr.

The Permittee shall continuously measure the pressure drop across the spray booth filter banks with a

differential pressure measuring device. The Permittee shall maintain written records of spray booth

filter replacement in a written bound log or other format approved by the District Director, and made

available for inspection by Metro Vancouver staff for a minimum period of three years.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.

Amended: April 24, 2018 District Director

Permit GVAO614

Page 10 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

EMISSION SOURCE 28: Paint booth storage areas (No. 1 & 2) discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 40 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. Chemical Contaminants: The maximum allowable emission concentration (EC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Good operating practices.

EMISSION SOURCE 29: Aluminum polishing booth discharging through a roof exhaust.

MAXIMUM EMISSION FLOW RATE: 380 m3/minMAXIMUM ANNUAL OPERATING HOURS: 2912 h/y

MAXIMUM EMISSION QUALITY:1. 20 mg/rn3 Particulate Matter2. 10% Opacity.3. Chemical Contaminants: The maximum allowable emission concentration fEC) for each emitted

chemical contaminant with a Threshold Limit Value (TLV) is such that the sum of the individualEC/TLV ratios for all such contaminants in any single emission is less than 10.

WORKS AND PROCEDURES:Filters and related appurtenances, together with good operating practices.

EMISSION SOURCE 30: Sulphuric acid and sodium dichromate etch tank discharging through a Stack(s).

MAXIMUM EMISSION FLOW RATE: 120 m3/minMAXIMUM ANNUAL OPERATING HOURS: 8760 h/y

MAXIMUM EMISSION QUALITY:1. 0.025 mg/m3 Chromium VI Compounds2. 0.5 mg/m3 Sulphuric Acid

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 11 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

WORKS AND PROCEDURES:A Fabco (Model # ALC-G275-0600) PVC scrubber and related appurtenances, together with good

operating practices.

Stack Information:Height: 12mDiameter: O.41mExit Temperature f°C): 30

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.

Amended: April 24, 2018 District Director

Permit GVAO614

Page 12 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

SECTION 2— GENERAL REQUIREMENTS AND CONDITIONS

A. AUTHORIZED WORKS, PROCEDURES AND SOURCESWorks and procedures, which this permit authorizes in order to control the discharge of air contaminants, shallbe employed during all operating periods of the related sources. The Permittee shall regularly inspect andmaintain all such works, procedures and sources.

The District Director must be provided with reasonable notice of any changes to or replacement of authorizedworks, procedures or sources. Any changes to or replacement of authorized works, procedures or sourcesmust be approved by the District Director in advance of operation. For certainty, this does not include routinemaintenance or repair.

The discharge criteria described in Section 1 of this permit are applicable on the issued or last amended date ofthis permit unless specified otherwise. If a date different to the issued or last amended date is specified, theexisting works, procedures and sources must be maintained in good operating condition and operated in amanner to minimize emissions.

B. NOTIFICATION OF MONITORING NON-COMPLIANCEThe District Director must be notified immediately of any emission monitoring results, whether from acontinuous emissions monitor or periodic testing, which exceed the quantity or quality authorized in Section 1of this permit. Notification shall be made to Metro Vancouver’s 24-hour number: 604-436-6777, or [email protected].

C. POLLUTION NOT PERMITTEDNotwithstanding any conditions in this permit, no person shall discharge or allow or cause the discharge of anyair contaminant so as to cause pollution as defined in the Greater Vancouver Regional District Air QualityManagement Bylaw No. 1082, 2008 and the Environmental Management Act.

D. BYPASSESThe discharge of air contaminants that have bypassed authorized control works is prohibited unless advanceapproval has been obtained and confirmed in writing from the District Director.

E. EMERGENCY PROCEDURESIn the event of an emergency or condition beyond the control of the Permittee that prevents effectiveoperation of the authorized works or procedures or leads to unauthorized discharge, the Permittee shall:

1. Comply with all applicable statutory requirements;2. Immediately notify the District Director of the emergency or condition and of contingency actions invoked

or planned to mitigate adverse impacts and restore compliance; Notification shall be made to MetroVancouver’s 24-hour number: 604-436-6777; and

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 13 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

3. Take appropriate remedial action for the prevention or mitigation of pollution.

The District Director may specify contingency actions to be implemented to protect human health and theenvironment while authorized works are being restored and/or corrective actions are being taken to preventunauthorized discharges.

If an emergency situation results in a “spill” as defined in the Environmental Management Act Spill ReportingRegulation, the spill shall also be reported immediately to the Provincial Emergency Program by telephoning 1-800-663-3456.

F. AMENDMENTSThe terms and conditions of this permit may be amended, as authorized by applicable legislation. New works,procedures or sources or alterations to existing works, procedures or sources must receive authorization inadvance of operation.

G. STANDARD CONDITIONS AND DEFINITIONSUnless otherwise specified, the following applies to this permit:

1. Gaseous volumes are corrected to standard conditions of 20 degrees Celsius (°C) and 101.325 kiloPascals (kPa) with zero percent moisture.

2. Contaminant concentrations from the combustion of specific fuel types are corrected to the followingOxygen content, unless specified otherwise:• 3% 02 for natural gas and fuel oil; or• 8% O for wood fuel

3. Where compliance testing is required, each contaminant concentration limit in this permit will beassessed for compliance based on a valid test using test methods approved by the District Director.

4. Visual opacity measurements are made at the point of maximum density, nearest the discharge pointand exclude the effect of condensed, uncombined water droplets. Compliance determinations arebased on a six-minute average in accordance with the United States Environmental Protection Agency(US EPA) Method 9: Visual Determination of the Opacity of Emissions from Stationary Sources.Continuous Emission Monitor System (CEMS) opacity compliance determinations are based on a one-hour average (taken from the top of each hour).

5. If authorized in Section 1 of this permit, standby fuel use is restricted to a maximum of 350 hours peryear and to those periods during which the primary authorized fuel is not available. Fuel oil sulphurcontent shall not exceed 15 milligrams per kilogram (mg/kg) and emissions during fuel oil firing shallnot exceed 10% opacity.

6. Definitions in the Environmental Management Act and Air Quality Management Bylaw apply toterminology used in this permit.

7. Threshold Limit Values (TLV) refer to the Time Weighted Average (TWA) exposure limits for substances

specified in the American Conference of Governmental Industrial Hygienists Threshold Limit Valueshandbook, current on the latest date that this permit issuance or amendment came into effect.

8. Sulphur Oxides (S0) are expressed as Sulphur Dioxide.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 14 of 19

METRO VANCOUVER REGIONAL DISTRICT AIR QUALITY MANAGEMENT PERMIT

9. Nitrogen Oxides (NO,,) are expressed as Nitrogen Dioxide.10. The Canadian Council of Ministers of the Environment (CCME) “Environmental Guidelines for

Controlling Emissions of Volatile Organic Compounds from Aboveground Storage Tanks (PN118O)”shall be adhered to for all applicable tanks unless otherwise stated in this permit.

11. Authorized ‘Maximum Annual Operating Hours’ of 8760 hours per year for an emission source isequivalent to authorization for continuous operation of the emission source for an entire calendaryear, including leap years.

H. RECORDS RETENTIONAll records and supporting documentation relating to this permit must be kept for at least three years after thedate of preparation or receipt thereof, and be made available for inspection within 48 hours of a request by anOfficer.

I. HEATING, VENTILATION, AIR CONDITIONING AND INTERNAL COMBUSTION ENGINESAir contaminants discharged from any natural gas-fired heating, ventilation or air conditioning system forbuildings and any internal combustion engine located at the discharge site shall be maintained and operated ina manner prescribed by the manufacturer to ensure good combustion of the fuel with minimum discharge ofair contaminants.

Issued: February 19, 1999 R.H. (Ray) Robb, P. Eng.Amended: April 24, 2018 District Director

Permit GVAO614

Page 15 of 19

ME

TR

OV

AN

CO

UV

ER

RE

GIO

NA

LD

IST

RIC

TA

IRQ

UA

LIT

YM

AN

AG

EM

EN

TP

ER

MIT

SEC

TIO

N3

—R

EPO

RT

ING

RE

QU

IRE

ME

NT

S

AM

ON

ITO

RIN

GR

EQ

UIR

EM

EN

TS

AN

DR

EP

OR

TIN

G

Unl

ess

othe

rwis

eap

prov

edin

wri

ting

byth

eD

istr

ict

Dir

ecto

rpr

ior

toan

ysa

mpl

ing

oran

alys

is,

all

mea

sure

men

tssh

all

bepe

rfor

med

byan

indep

enden

tag

ency

inac

cord

ance

wit

hM

etro

Van

couv

erA

irE

mis

sion

sS

ampl

ing

Pro

gram

Man

ual

ofM

etho

dsan

dS

tand

ard

Ope

rati

ng

Pro

cedu

res

and

the

BCM

inis

try

ofE

nvir

onm

ent

Fiel

dS

ampl

ing

Man

ual,

asth

eym

aybe

amen

ded

from

tim

eto

tim

e.A

nyva

rian

cefr

omth

ese

proc

edur

esm

ust

rece

ive

prio

rw

ritt

enap

prov

alfr

omth

eD

istr

ict

Dir

ecto

r.

Am

inim

umof

5w

orki

ngda

ysad

vanc

eno

tice

mus

tbe

give

npr

ior

tota

king

mea

sure

men

tsre

quir

edby

this

Mon

itor

ing

and

Sam

plin

gP

rogr

am.

Not

ific

atio

nm

ust

begi

ven

toth

eM

etro

Van

couv

erE

nvir

onm

enta

lR

egul

atio

n&

Enf

orce

men

tD

ivis

ion

(pho

ne60

4-43

6-67

77,

Fax

604-

436-

6707

,

emai

lre

gula

tion

enfo

rcem

ent@

met

rova

ncou

ver.

org)

.

Unl

ess

othe

rwis

esp

ecif

ied,

sam

plin

gsh

all

bepe

rfor

med

unde

rop

erat

ing

cond

itio

nsre

pres

enta

tive

ofth

epr

evio

us90

cale

ndar

days

of

oper

atio

n.A

llfi

eld

data

and

calc

ulat

ions

mus

tbe

subm

itte

dw

ith

mon

itor

ing

resu

lts

and

they

shal

lbe

repo

rted

inth

em

etri

cun

its

whi

char

e

used

inth

ispe

rmit

.T

hese

subm

issi

ons

shal

lin

clud

epr

oces

sda

tare

leva

ntto

the

oper

atio

nof

the

sour

ceof

the

emis

sion

san

dth

epe

rfor

man

ce

ofth

eem

issi

onco

ntro

lw

orks

.

The

Per

mit

tee

shal

lco

nduc

tth

efo

llow

ing

mon

itor

ing

and

sam

plin

gan

dsu

bmit

elec

tron

icre

port

sof

the

resu

lts

toth

eD

istr

ict

Dir

ecto

rby

the

dat

essp

ecif

ied

belo

wus

ing

apa

ssw

ord

enab

led

web

base

dap

plic

atio

npr

ovid

edby

Met

roV

anco

uver

.

EM

ISSI

ON

INIT

IAL

DU

ED

ATE

SUB

SEQ

UE

NT

DU

ED

ATE

SR

EQ

UIR

EM

EN

TPA

RA

ME

TE

R(S

)TE

STM

ET

HO

DR

EPO

RT

TYPE

SOU

RC

E

N/A

N/A

N/A

N/A

N/A

N/A

N/A

Issu

ed:

Feb

ruar

y19

,19

99R

.H.

(Ray

)R

obb,

P.En

g.A

men

ded:

Apr

il24

,20

18D

istr

ict

Dir

ecto

r

Per

mit

GV

AO

614

Pag

e16

of19

ME

TR

OV

AN

CO

UV

ER

RE

GIO

NA

LD

IST

RIC

TA

IRQ

UA

LIT

YM

AN

AG

EM

EN

TPE

RM

IT

B.

INF

OR

MA

TIO

NR

EPO

RT

ING

RE

QU

IRE

ME

NT

S

The

Per

mit

tee

shal

lsu

bmit

elec

tron

icre

port

sco

ntai

ning

the

requ

ired

info

rmat

ion

toth

eD

istr

ict

Dir

ecto

rby

the

date

ssp

ecif

ied

belo

wus

ihg

apa

ssw

ord

enab

led

web

base

dap

plic

atio

npr

ovid

edby

Met

roV

anco

uver

.

EM

ISSI

ON

INIT

IAL

DU

ED

ATE

SUB

SEQ

UE

NT

DU

ED

ATE

SR

EQU

IREM

ENT

REP

OR

TTY

PE

SOU

RC

E27

Mar

ch31

,20

19O

nor

befo

reM

arch

31fo

rW

ritt

enre

port

prov

idin

gde

tail

sof

the

type

san

dam

ount

sof

fuel

burn

edin

Fuel

Use

each

sub

seq

uen

tye

ar.

the

prec

edin

gca

lend

arye

ar.

Faci

lity

Mar

ch31

,20

19O

nor

befo

reM

arch

31fo

rW

ritt

enre

port

prov

idin

gde

tail

sof

the

type

san

dam

ount

sof

prin

cipl

eM

ater

ials

and

each

sub

seq

uen

tye

ar.

prod

ucts

prod

uced

and

prin

cipa

lra

wm

ater

ials

used

inth

epr

eced

ing

cale

ndar

Pro

duct

sye

ar.

Faci

lity

Mar

ch31

,20

19O

nor

befo

reM

arch

31fo

rW

ritt

enre

port

prov

idin

gde

tail

sof

the

type

s,am

ount

san

den

dus

eof

orga

nic

Sol

vent

Use

each

sub

seq

uen

tye

ar.

solv

ents

and

orga

nic

solv

ent-

cont

aini

ngm

ater

ials

used

inth

epr

eced

ing

cale

ndar

year

.

30M

arch

31,

2019

On

orbe

fore

Mar

ch31

for

Wri

tten

repo

rtde

tail

ing

the

dat

esof

and

resu

lts

ofal

lin

spec

tion

san

dS

crub

ber

each

sub

seq

uen

tye

ar.

mai

nten

ance

carr

ied

out

onth

esc

rubb

erdu

ring

the

prev

ious

12m

onth

s.T

here

port

shal

lal

soin

clud

ean

yac

tion

s,ta

ken

orpr

opos

ed,

toso

lve

iden

tifi

edpr

oble

ms.

30Ju

ne30

,20

18N

/AS

crub

ber

Insp

ecti

on&

Mai

nten

ance

Pro

cedu

reIn

form

atio

n-

Oth

erS

ubm

ita

wri

tten

plan

outl

inin

ga

prop

osed

scru

bber

insp

ecti

onan

d

mai

nten

ance

proc

edur

efo

rw

ritt

enap

prov

alby

the

Dis

tric

tD

irec

tor.

Issu

ed:

Feb

ruar

y19

,19

99R

.H.

(Ray

)R

obb,

P.En

g.

Am

ende

d:A

pril

24,

2018

Dis

tric

tD

irec

tor

Per

mit

GV

AO

614

Pag

e17

of

19

ME

TR

OV

AN

CO

UV

ER

RE

GIO

NA

LD

ISTR

ICT

AIR

QU

ALI

TYM

AN

AG

EM

EN

TPE

RM

IT

C.

AM

EN

DE

DO

RA

DD

ITIO

NA

LR

EQ

UIR

EM

EN

TS

Bas

edon

the

resu

lts

ofth

em

onit

orin

gpr

ogra

m,

incl

udin

gth

est

ack

sam

plin

gre

sult

sor

any

oth

erin

form

atio

n,th

eD

istr

ict

Dir

ecto

rm

ay:

1.A

men

dth

em

onit

orin

gan

dre

port

ing

req

uir

emen

tof

any

ofth

ein

form

atio

nre

quir

edby

this

Per

mit

incl

udin

gpl

ans,

prog

ram

san

dst

udie

s.2.

Req

uire

addi

tion

alin

vest

igat

ions

,te

sts,

surv

eys

orst

udie

s.

Issu

ed:

Feb

ruar

y19

,19

99R

.H.

(Ray

)R

obb,

P.E

ng.

Am

ended

:A

pril

24,

2018

Dis

tric

tD

irec

tor

Per

mit

GV

AO

614

Pag

e18

of

19

1-

PHi

MP

ON

-

ILUIzLUUz>-I-I

DCIV.,

-J

z0wLULU>D01]

z>0I-LU

z-J

IJJIU

,

z0I1%)

wU,

4-,

14-,

4-,0-I

0m9Lfl

0r.i0Ia)

4-,Ca)UU1CDCD4-,

a)>.m

0--I

‘IC0

-

LIJ

(DO

)

<C

(JZU

oz

(JO

(!)h

uJ(D

<‘-I

UJO

zwUa.zLU

LU

I a)4-,

CDEx0I00toa)I—Co

U,

4-,C00a)toUU

,

a)

4-,

0U,

C04-,

Co

U0a)

4-,

0Ctoa)toUU,

04-,

4-’

0CU,

CCo

0a)4-,

U,

C00a)-c

H

•.

II

b.D0

C+

-‘LIo

•,

Co

O)

0,

0,

100

>-

Co

010‘-Ia)to

0