Service Manual hdd14xx hdd16xx 1 0 - Rockbox · root directory of the device. (CD ROM with the...

Micro Audio Jukebox HDD1420/00HDD1620/00/05HDD1630/HDD1635/17

All version

3141 785 30701

Version 1.1

TABLE OF CONTENTS

Chapter

Technical Specification and Service hints.…………………1 Safety Instructions………………………………………………2 Instructions for Use……………………………………………. 3 Mechanical Instructions………………………………………. 4 Exploded view and Service parts list…………………...….. 5 Troubleshooting flow.…………………………………………. 6 Overall Block diagram…………………………………………. 7 Overall Electrical diagram……………………………………. 8 Revision list……………………………………………………… 9

Service Manual

©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips

1.0 TECHNICAL SPECIFICATION and SERVICE HINTS

General Dimensions (WxHxD) : 53.7 X 86.0 X 16.3 mm

(2.11 x 3.39 x 0.64 inch) Weight : 87 g Output power : 2 x 5 mW (16 Ohm) Frequency response : 20 – 16 000 Hs Equalizer : 5-bands Hard disk : Capacity : 4GB – 6GB Display : 128 x 128 pixels, 65K color

Backlight : White Battery : 630 mAh Li-Ion

rechargeable battery

Battery life time: >16hrs File transfer rate using USB2.0 :

>4Mbyte

Battery charging current 450mA

Maximum charging time :

4hr

Battery cutoff voltage: 3.7V Connections: Headphone Line Out Jack

Power Connector

Battery level detection Detection Level Typ. 4-step to 3-step voltage 3.6 – 3.7V 3-step to 2-step voltage 3.53 – 3.6V 2-step to 1-step voltage 3.48 – 3.53V Force Power Off voltage <3.5V Current consumption

DC-IN SUPPLY (4.5V) Battery Charging Current 450mA

BATT. SUPPLY (3.7V) Power Off 300uA Idle 30mA Playback without HDD reading 30mA Playback with HDD reading 345mA File transfer using USB2.0 350mA Headphone out (headphone output load 2x16 ohm) Maximum output power : 10 mW Frequency response : 45Hz – 16kHz (16Ω load)

20Hz – 16kHz (15kΩ load) SNR (A-wght) : 85dB THD (1kHz) : 0.1% Left-Right Channel Separation :

45dB typ. (1k Hz) 40dB typ. (20Hz – 16kHz)

Left-Right Channel Balance :

<1.0dB (1k Hz) <2.0dB (20Hz – 16kHz)

Supported playback format MP3 : 8 - 320 Kbps and VBR WMA : 32 - 192 Kbps Sample rates : 8, 11.025, 16, 22.050

32, 44.1, 48

ID3-tag support : Yes PC Connectivity : USB File Transfer via Windows Media Player 10 for music and picture playback or Windows Explorer for general data (music playback disabled) Firmware and software upgrades

1. If you have not already installed the Device Manager download the latest version of the Device Manager from http://www.philips.com/support. You may need to enter your language preference and the model number e.g.HDD1630, to access the Device/Firmware Manager upgrade file.

2. Download the zip file into a temp folder in your computer. Unzip the file and then double click the Setup.exe file to start the installation of the Device Manager.

3. Once the installation is complete, connect the GoGear to the power supply with the AC/DC adapter.

4. Make sure all other applications such as Philips Device plug-in, Windows Media Player or Windows Explorer that accessing the device are closed or else Device Manager will not recognize the device. Launch the Philips Device Manager at Start->Programs->Philips Device Manager->Philips Device Manager on your PC.

5. Click Update in the dialogue box

the Philips Device Manager will detect the connection of your GoGear and the application will automatically check on the server to see if an update is available and prompt user to download the updated firmware. Click YES to start the downloading.


6. A status bar will show the downloading progress of the firmware. Once the downloading is complete the application will prompt you to install the update onto your GoGear. Click YES to confirm

7. The application will show the status of updating and at

the end you need to click OK to complete the update.

(Please do not disconnect the jukebox during the upgrading process as this interruption may damage the firmware!)

8. Follow all screen instructions to complete the firmware

upgrade.

9. The Device Manager will close automatically once the success message is displayed. Close all opened application and then unplug your GoGear.

10. Once the GoGear micro jukebox is disconnected from the computer, the display will show “Firmware Upgrading” for a couple of seconds and then start up as usual. If the message does not disappear after 2 minutes, do a soft reset by pressing and holding the Power on/off key and the volume + key for a couple of seconds.

Repair the firmware with Device Manager

1. If you have not already installed the Device Manager download the latest version of the Device Manager from http://www.philips.com/support. You may need to enter your language preference and the model number e.g.HDD1630, to access the Device/Firmware Manager upgrade file.

2. Download the zip file into a temp folder in your computer. Unzip the file and then double click the Setup.exe file to start the installation of the Device Manager.

3. Once the installation is complete, connect the GoGear to the power supply with the AC/DC adapter.

4. Make sure all other applications such as Philips Device plug-in, Windows Media Player or Windows Explorer that accessing the device are closed or else Device Manager will not recognize the device. Launch the Philips Device Manager at Start->Programs->Philips Device Manager->Philips Device Manager on your PC.


5. Click YES to start the downloading. A status bar will

show the downloading progress of the firmware. Once the downloading is complete the application will prompt you to install the update onto your GoGear.

6. Once the repair is complete a dialogue box will pop up;

click OK and unplug the GoGear from the computer.

IMPORTANT: All music & content of your micro jukebox will be erased once the factory setting is restored.

7. Follow all screen instructions to complete the repair.

8. The Device Manager will close automatically once the success message is displayed. Close all opened application and then unplug your micro jukebox.

9. Once the GoGear micro jukebox is disconnected from the computer, the display will show “Firmware Upgrading” for a couple of seconds and then start up as usual.

Service Hints Re Rebuild database, firmware and Microsoft (Plays For Sure) copy protection key after replacement of hard disk or PCBA IMPORTANT: All devices having the hard disk or PCBA replaced must have the firmware image, database and the Plays For Sure key rebuilt before returning to customers.

1. Connect the GoGear to the power supply and the computer with the combined charger and USB cable.

2. Reset the device by pressing and holding down the Volume + and the power on/off slider switch until the display turns off.

3. While the device restart, press and hold the volume – key until the Philips splash screen disappear and showing the connection icon to put the device in USB Mass Storage Device mode.

4. The device will be listed as a new drive named

GOGEAR or MDJUKEBOX in Windows Explorer.

5. Launch Windows Explorer and then quick format the new drive to the file system FAT32.


IMPORTANT: All music & content of your micro jukebox will be erased once the device is formatted.

6. Unzip and copy all the content of the shipment ui files of the corresponding model version into the root directory of the device. (CD ROM with the Shipment ui files will be provided to repair workshops.)

7. Disconnect the GoGear from the computer by

clicking on the safely remove hardware icon on the task tray.

8. Wait until the display shows “Burn success”.

9. Reset the device again by pressing and holding down the Volume + and the power on/off slider switch until the display turns off.

10. Upgrade the firmware of the device to the latest version by following the procedure as mentioned under “Firmware software upgrades”

2.0 SAFTETY INSTRUCTIONS

GB WARNING

All ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.

F ATTENTION

Tous les IC et beaucoup d’autressemi-conducteurs sont sensibles auxdécharges statiques (ESD).Leur longévité pourrait être considérablementécourtée par le fait qu’aucune précaution n’estprise à leur manipulation.Lors de réparations, s’assurer de bien être reliéau même potentiel que la masse de l’appareil etenfiler le bracelet serti d’une résistance desécurité.Veiller à ce que les composants ainsi que lesoutils que l’on utilise soient également à cepotentiel.

ESD

D WARNUNG

Alle ICs und viele andere Halbleiter sindempfindlich gegenüber elektrostatischenEntladungen (ESD).Unsorgfältige Behandlung im Reparaturfall kandie Lebensdauer drastisch reduzieren.Veranlassen Sie, dass Sie im Reparaturfall überein Pulsarmband mit Widerstand verbundensind mit dem gleichen Potential wie die Massedes Gerätes.Bauteile und Hilfsmittel auch auf dieses gleichePotential halten.

NL WAARSCHUWING

Alle IC’s en vele andere halfgeleiders zijngevoelig voor electrostatische ontladingen(ESD).Onzorgvuldig behandelen tijdens reparatie kande levensduur drastisch doen verminderen.Zorg ervoor dat u tijdens reparatie via eenpolsband met weerstand verbonden bent methetzelfde potentiaal als de massa van hetapparaat.Houd componenten en hulpmiddelen ook opditzelfde potentiaal.

I AVVERTIMENTO

Tutti IC e parecchi semi-conduttori sonosensibili alle scariche statiche (ESD).La loro longevità potrebbe essere fortementeridatta in caso di non osservazione della piùgrande cauzione alla loro manipolazione.Durante le riparazioni occorre quindi esserecollegato allo stesso potenziale che quello dellamassa dell’apparecchio tramite un braccialettoa resistenza.Assicurarsi che i componenti e anche gli utensilicon quali si lavora siano anche a questopotenziale.

“Pour votre sécurité, ces documentsdoivent être utilisés par des spécia-listes agréés, seuls habilités à réparervotre appareil en panne”.

GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be used.

NL

Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie inzijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,identiek aan de gespecificeerde, worden toegepast.

F

Les normes de sécurité exigent que l’appareil soit remis à l’étatd’origine et que soient utiliséés les piéces de rechange identiquesà celles spécifiées.

D

Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zubeachten. Der Original zustand des Geräts darf nicht verändert werden;für Reparaturen sind Original-Ersatzteile zu verwenden.

I

Le norme di sicurezza esigono che l’apparecchio venga rimessonelle condizioni originali e che siano utilizzati i pezzi di ricambioidentici a quelli specificati.

"After servicing and before returning set to customer perform aleakage current measurement test from all exposed metal parts toearth ground to assure no shock hazard exist. The leakage currentmust not exceed 0.5mA."

CLASS 1LASER PRODUCT

3122 110 03420

GB Warning !Invisible laser radiation when open.Avoid direct exposure to beam.

S Varning !

Osynlig laserstrålning när apparaten är öppnad och spärrenär urkopplad. Betrakta ej strålen.

SF Varoitus !

Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiinanäkymättömälle laserisäteilylle. Älä katso säteeseen!

DK Advarse !

Usynlig laserstråling ved åbning når sikkerhedsafbrydere erude af funktion. Undgå udsaettelse for stråling.

3.0 INSTRUCTION FOR USE

Power Connector

4.0 MECHANICAL INTRUCTIONS

Set Disassembly 1. Remove the cosmetic screw on the back cover by Allen

Key.

2. Finger inset the gap of the top cover assy and the housing, and then carefully lift up the top cover.

3. Generally remove the housing.

4. Remove the 4 screws on four corners. See pointed arrows.


5. Carefully pull out the mainboard assy, which include the HDD drive, LCD, battery and PCBA board.

6. Disconnect the flex cable from the front touch screen module carefully, then free the top cover assy.

7. Lift up the double side tape of the side buttons.

8. Turn to the bottom side.


9. Open up the metal shielding and disconnect the cable connected to the battery. Carefully disassemble the mini mic as circled in the picture from the plastic audio jack holder.

10. Remove the battery part form PCBA.

11. Lift up the hard disk and disconnect the flex cable underneath from the PCBA.

12. After remove both battery and hard disk.

5.0 EXPLODED VIEW AND SERVICE PARTS LIST

101 114

100 105

103

102 106

107

108

109

110

111

117116

118

115

104

112113

MECHANICAL PARTS 100 994000003554 COSMETIC SREW PHOENIX 101 994000003555 BACK CABINET PHOENIX 102 994000003559 AUDIO JACK HOLDER ASSY 103 994000003556 SHIELDING PHOENIX 104 994000003572 CRADLE HOLDER PHOENIX 105 994000003558 SCREW 1.7X5 PHOENIX 106 994000003557 BATTERY PACK PHOENIX 107 282206200084

282206200079 HDD 4GB (HDD1420/00) HDD 6GB (HDD1620/00/05, HDD1630/17 & HDD1635/17)

108 994000003563 HDD DAMPER PHOENIX 109 994000003564 HDD HOLDER PHOENIX 110 994000003568 HD FPC PHOENIX 111 994000003565 FFC PHOENIX 112 994000003566 KEY FPC 1 PHOENIX 113 994000003567 KEY FPC 2 PHOENIX 114 994000003569

994000003571

PCBA W/Z RADIO LCD PHOENIX (HDD1630/17 & HDD1635/17) PCBA W/O RADIO LCE PHOENIX (HDD1420/00 & HDD1620/00/05)

115 994000003573 RIGHT SIDE KEYPAD PHOENIX 116 994000003574 HOLD KEY PHOENIX 117 994000003575 LEFT SIDE KEYPAD PHOENIX 118 994000003576 HOUSING TOUCHPAD PHOENIX

MISCELLENEOUS 994000003527 EARPHONE SHE9500 994000003577

994000003578 994000003579

AC ADAPTOR AD7150/00 AC ADAPTOR AD7153/17 AC ADAPTOR AD715B/05

994000003791 CRADLE ASSY PHOENIX (HDD1635/17)

5.0 EXPLODED VIEW AND SERVICE PARTS LIST

100

101

105

103

107

106

114

118

118

102

104

116

112 113

115

117

MECHANICAL PARTS 100 994000003554 COSMETIC SREW PHOENIX 101 994000003555 BACK CABINET PHOENIX 102 994000003559 AUDIO JACK HOLDER ASSY 103 994000003556 SHIELDING PHOENIX 104 994000003572 CRADLE HOLDER PHOENIX 105 994000003558 SCREW 1.7X5 PHOENIX 106 994000003557 BATTERY PACK PHOENIX 107 282206200084

282206200079 HDD 4GB (HDD1420/00) HDD 6GB (HDD1620/00/05, HDD1630/17 & HDD1635/17)

108 994000003563 HDD DAMPER PHOENIX 109 994000003564 HDD HOLDER PHOENIX 110 994000003568 HD FPC PHOENIX 111 994000003565 FFC PHOENIX 112 994000003566 KEY FPC 1 PHOENIX 113 994000003567 KEY FPC 2 PHOENIX 114 994000003569

994000003571

PCBA W/Z RADIO LCD PHOENIX (HDD1630/17 & HDD1635/17) PCBA W/O RADIO LCE PHOENIX (HDD1420/00 & HDD1620/00/05)

115 994000003573 RIGHT SIDE KEYPAD PHOENIX 116 994000003574 HOLD KEY PHOENIX 117 994000003575 LEFT SIDE KEYPAD PHOENIX 118 994000003576 HOUSING TOUCHPAD PHOENIX

MISCELLENEOUS 994000003527 EARPHONE SHE9500 994000003577

994000003578 994000003579

AC ADAPTOR AD7150/00 AC ADAPTOR AD7153/17 AC ADAPTOR AD715B/05

994000003791 CRADLE ASSY PHOENIX (HDD1635/17)

6.0 TROUBLESHOOTING FLOW

SYMPTOM 1: NO POWER


SYMPTOM 2: JUKEBOX FREEZES / HANGS UP

Open up the unit, unplug battery connector and reconnect again


SYMPTOM 3: ERROR MESSAGE SCROLLS ON THE DISPLAY


SYMPTOM 4: NO SOUND

7.0 Overall Block Diagram

PortalPlayer

PP5022

U5101.5" CSTN

LCD

U509SDRAM/64MB

U508Flash Memory/ 4MB

1" HDDEIDE Control

Data Bus MIC

J501Earphone

Jack

U505

Audio CodecWM8731L

I2S

U9RTC

PCF8563T

X232.768K

J507Cradle

Connector

J502Li-Lon Battery

U2ChargerBQ24032

LCD Power 2.8V

LCD Backlight x3 LED U502

FM TEA5767HN

KeyPad(TouchPad + 2 Function Key)

Remote Control

USB 2.0Cradle

BD line In, Headphone Out

I2C

Video Out

Line Out

VBUS V_CRADLE

I2S

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

XM2_MA6XM2_MA5

XM2_MD1

XM2_MD7

XM2_MA19

XM2_MD11

BM3_KSI6

XM2_MD12

VCC_BATR

XM2_MD8

XM2_MD3

XM2_MD13

XM2_MA9

USB_RBIAS

BM3_KSI0

XM2_MD4

RESET#

XM2_MA15

XM2_MA18/WE#

GP4

XM2_MA10

XM2_MD5

XM2_MA13

XM2_MD6

PSEL1

USB_VDDA

USBS_DN

XM2_MA1

BM3_KSI3

XM2_MD[0..15]

REMOTE_JACK_D

XM2_MA17/CAS0#

XM2_MD14

XM2_MA2

BM3_KSI2

XM2_MA4

BM3_KSI1

XM2_MA7

I2C_DAT_IN

XM2_ROM.RDY

XM2_MA11

BM3_KSI5

I2C_CLK_IN

XM2_MA20_1

XTAL_33M.IN

XM2_MA14

XM2_MA8

XM2_MA26

BM3_KSI4

XM2_MD9

XM2_MA25

XM2_MA3

CLK_24M.CODEC_R

XM2_MD0

XM2_MD15

XM2_MD2

XM2_MD10

XM2_MA12

BM3_KSI7

XM2_MIO.RDY

CLK_SYS.OUTR

CSC

MBID2

VCC_BATCMBID0MBID1

XM2_MA16/RAS0#

VBUS_SENSE

BZZ_PWM

BZZ_CRL#_R

XM2_MA[1..15]

USBS_DP

OC_CRL_PWR#

+1.2V_AVDD+1.2V_USB_VDDP

XTAL_33M.IN

I2S_SDIN

AT3_HD15AT3_HD14AT3_HD13AT3_HD12AT3_HD11AT3_HD10AT3_HD9AT3_HD8AT3_HD7AT3_HD6

AT3_HD4AT3_HD3AT3_HD2

AT3_HD5

AT3_HD1AT3_HD0

BKL_ON

Cradle_In_S

I2C_DAT_IN

I2C_CLK_IN

XM2_ROM.RDY

XM2_MIO.RDY

XTAL_32K.IN

ACPG#1

ACPG#1

VCC_AC

LEA

VBUS_Detect

PJ_In

S2_R

BZZ_CRL#_R

REMOTE_JACK_D

ADC_EN#_M

VCC_AC

VBUS_DetectLEA

ADC_EN#PJ_In

LCD_D2LCD_D3

LCD_D6LCD_D7

LCD_D1

LCD_D5LCD_D4

LCD_D0

LCD_CS#

OC_USB.PWR#

ADC_EN#

BM3_KSI9

MBID2

MBID0MBID1

+3.3V

+3.3V

VCC_BAT

VBUS

+3.3V +1.2VVCC_MEM+3.3V

+1.2V+1.2V

VCC_MEM

VCC_MEM

+3.3V

VBUS

+3.3V

+1.2V

+3.3V

BM3_KSI4 6

XTAL_32K.IN 4

DBG3_TCK4

DBG3_TDO4

BM3_KSI5 6

AT3_HA1 7

STAT1 5

AT3_HIOR# 7

AT3_HIRQ.0 7

AT3_HDMACK# 7

XM2_ROM.WR#4

I2S_DOUT 6

DBG3_TMS4

XM2_DQML#4

I2S_SCLK 6

XM2_ROM.RD#4

XM2_MA18/WE#4

XM2_MD[0..15]4

DBG3_TRST4

XTAL_24M.IN 4

AT3_HA0 7

ANT_SW1# 6

DBG3_TDI4

AT3_HIOW# 7

XM2_MA20_14

AT3_HRESET# 7

XM2_MA254

XM2_ROM.RDY4

XM2_MA17/CAS0#4

AT3_HDMARQ 7

BM3_KSI106BM3_KSI96,7

XM2_MA264

XM2_DQMH#4

AT3_HCS1# 7

XM2_MA194

XTAL_24M.OUT 4

RESET#4,7

XM2_CKE4

BM3_KSI0 6

XM2_MA16/RAS0#4

AT3_HA2 7

AT3_HIORDY 7

BM3_KSI1 6,7BM3_KSI2 6

AT3_HIRQ.1 7

XM2_SDR_CS0#4

BM3_KSI3 6

AT3_HCS0# 7CLK_SYS.OUT4

I2S_SDIN 6

XM2_MA[1..15]4

BM3_KSI86

XM2_ROM.CS1#4

I2S_LRC 6

CLK_24M.CODEC 6

LCD_ON8

PSEL15

DC-DC_RUN 5

OC_CRL_PWR# 7

USBID-DEV/HOST# 7

BKLT_PWM 8

USB_DP 7USB_DN 7

GPIO2 7GPIO1 7Wake_up# 7

Power_Request# 7

Cradle_in#7

AT3_HD[0:15] 7

I2C_CLK 4,6,7,8

I2C_DAT 4,6,7,8

Power_Out_C 6,7

Current_Set 5

AT3_PWR.OFF 5

ACPG#1 5

AC_PWR 5

LEARNING 5

PJ_In 6

BZZ_PWM6

BKL_ON8

LCD_RST#8

REMOTE_JACK 4,6

TP_PWR#6

GPIO4 4,7

STAT2 5

RTC_WAKE#5

REMOTE_INT4

LCD_D7 8LCD_D6 8LCD_D5 8LCD_D4 8LCD_D3 8

LCD_D1 8LCD_D2 8

LCD_D0 8

BM3_KSI126BM3_KSI116

LCD_R/W# 8LCD_RD# 8

LCD_CS# 8

LCD_RS 8

MUTE6

I2C_C_EN 7

BZZ_CRL# 6

Cradle_in_SW#8

Title

Size DocumentNumber

Rev

Date: Sheet of

PP5022 / USB2.0 R00C

3 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

PP5022 / USB2.0 R00C

3 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

PP5022 / USB2.0 R00C

3 8, 04, 2005星期四八月

Value change

5VREG_ON

DTV_27MHz

DTV_PD[0:7]

Check

RC removed

4/8 IR function remove

Place Close Each Power Pin


For EMI Close to PP5022

For EMI & close PP5022

Battery Shuntdown point detectNow:3.5V

When Power-off reducethe power loss

ACK---

Remove damp Res.

Line_in_SW

USB wakeup&detect

4/8 Pin SwapChange forPP5022 differencewith PP5020

4/8Check=>Reserved

DTV_RESET#

CLK

ACK

DATA

KSI1KSI0

KSI2KSI3KSI4KSI5KSI6KSI7KSI8KSI9KSI10KSI11KSI12

RecordingVolume upVolume down

View

Like Music

xxxxx

PWR_ON_OFF#

xxxxxHOLD

xxxxx

Phoenix DVT R0D


27M_OFF#

Battery_ID:Low=>Plug-In

PinM17=>LCD_R/W#L16=>LCD_RD#N17=>LCD_CS#J16=>ACPG#1FW3_D[7:0]=>LCD_D[7:0]

PinR10=>TP503 (OC_USB.PWR#)U10=>TP508 (ENA_USB.PWR)U11=>BM3_KSI12 (HOLD)R11=>BM3_KSI11 (LCM_SE<1.9">)

PinR14=>REMOTE_INTU13=>TP510 (Line_in_SW)T13=>VCC_ACR13=>RTC_WAKE#U12=>LEAT12=>VBUS_DetectR12=>ADC_EN#P12=>PJ_In

LCM_SE (1.9"LCD)HOLD

ENA_USB.PWR

OC_USB.PWR#

pin R15=>LCD_RS

PWR_ON_OFF#View

XM2_SDR_CS1#HD_ON/OFF#

unused_only pull high

TouchPad Power Enable

Ckose to U510(PP5022)

with FM

MBID0

MBID1

MBID2

0

0

0

w/o FM

0

0

1

6/24

1 TP3TP3

12

R90100K0402

R90100K0402

VS

S2

E7

VS

S4

E10

VS

S5

E11

VD

D_I

O_5

K14

VD

D_I

O_7

N5

VS

S9

G5

RM3_SCL R6

RM3_SDA U5

AT3_HD04 L2

AT3_HD07 P4

AT3_HD06 N4

AT3_HD09 M2

AT3_HD11 P3AT3_HD12 N2

VS

S12

G11

VD

D_I

O_1

0P

9

AT3_HA0 J3

AT3_HD14 R1

AT3_HA2 K1

AT3_HCS0# L4

AT3_S.HDMACK# U1

AT3_H.DMARQ T3

AT3_S.HIOR# U2

AT3_S.HIOW# R4

AT3_HCS1# L3

UA3_TXDG1

UA3_RTSG2

UA3_RXDG3

UA3_CTSE4

USB_DM D17

VD

D_I

O_1

E13

VS

S1

E6

VS

S10

G7

AT3_HD10 N1

AT3_HD15 P2

AT3_HA1 K3

USB_DP E17

VD

D_I

O_2

G14

VD

D_I

O_3

H14

BM3_KSI.00 U7BM3_KSI.01 T8BM3_KSI.02 R8BM3_KSI.03 P8

VS

S3

E8

VD

D_C

OR

E_1

E9

BM3_KSI.04 T9BM3_KSI.05 U8BM3_KSI.06 R9BM3_KSI.07 U9

VD

D_I

O_4

K4

US

B_V

SS

PA

17

VD

D_I

O_6

M14

VS

S6

E12

CLK_DEV.OUT P6

XTAL_24M.IN G16XTAL_24M.OUT G15

XTAL_32K.OUT F14

XTAL_32K.IN E15

CLK_SUS.OUT D12

VS

S7

F5

RESERVEDC16

SPDIF_OUT F4SPDIF_IN H2

I2S_RST P5

I2S_DIN U3

I2S_LRC T5

I2S_DOUT T4I2S_SCLK U4

VS

S8

F13

BM3_KSO.00 U6BM3_KSO.01 R5BM3_KSO.02 R7BM3_KSO.03 T7

VD

D_I

O_8

N13

AT3_HIOW# R3

AT3_HIOR# T1

AT3_HIORDY J2

AT3_HRESET# H3

AT3_HIRQ.0 J4

AT3_HIRQ.1 J1

AT3_HDMARQ R2

AT3_HDMACK# T2CLK_SYS.OUTD7

VS

S11

G9

AT3_HD00 K2AT3_HD01 M4AT3_HD02 L1AT3_HD03 M3

AT3_HD05 M1

AT3_HD13 P1

VS

S13

G13

AT3_HD08 N3

VS

S14

H5

VS

S15

H8

VS

S16

H10

VD

D_I

O_9

P7

OT3_Y.UD U14

OT3_X.CK R15

PM3_PWM0 T15

OT3_Y.CK T14

ADC_AIN.0 U16

OT3_X.UD U15

PM3_PWM1 T16

ADC_AIN.1 U17

FW3_D7 K17

FW3_D6 J15

FW3_D5 J14

FW3_D4 L17

FW3_D3 K16

FW3_D2 K15

FW3_D1 L14

FW3_D0 L15

FW3_SCLK J16FW3_LREQ N17

USB_RREF C17

US

B_V

DD

AE

16U

SB

_VS

SA

D16

XTAL_33M.IN H16XTAL_33M.OUT H15

CD3_BCLK B16

CD3_C2PO A16

CD3_DATA B15

CD3_LRCK A15

FW3_CTL1 M17

FW3_CTL0 L16

DTV3_XCLKP14

DTV3_PD.3N15

DTV3_PD.2P16

DTV3_PD.1N14

DTV3_PD.0R17

DTV3_PD.7M15

DTV3_PD.6N16

DTV3_PD.5P17

DTV3_PD.4M16

XM2_MA02D13

DBG3_TMSF15

LCD3_DB7R14

XM2_MD05B6

XM2_MA10A10

XM2_MA00B12

XM2_MA14A9

DBG3_TDIH17

LCD3_DB4R13 LCD3_DB5T13

LCD3_DB0P12

XM2_MD14C1

XM2_MD12B1

LCD3_CS2#/CLEU10

XM2_MA05B11

XM2_MD06A4

XM2_MA03C13

XM2_MA23E2

LCD3_DB1R12

CNF3_TSTD14

XM2_MD03B4

XM2_MA17A6

XM2_ROM.RDYB14

LCD3_AA0R10

XM2_MA18F1

XM2_MD08C3

XM2_MD01B5

LCD3_CS1#/ALEP10

XM2_MA25D3

XM2_MD09A1

XM2_MD11B2

XM2_MA01A13

XM2_MA11C10

LCD3_RST#T10

XM2_MA15C7

LCD3_CS3#/DLET11

XM2_MA12B10

DBG3_TDOG17

LCD3_DB6U13

XM2_MA09C11

XM2_MA20F3

XM2_MA06C12

XM2_MA13B9

DBG3_TRST#J17

LCD3_DB3U12

XM2_MA24D1

XM2_MA07A11 XM2_MA08D11

XM2_MIO.RDYA14

XM2_MD07C5

XM2_WMSK1B7

XM2_MD02A3

XM2_MA04A12

XM2_WE_NC9

XM2_CS.A#C14

LCD3_RD#U11

LCD3_R/W#R11

XM2_MD04C4

LCD3_DB2T12

XM2_MD00A2

XM2_MA16C6

XM2_MA19E3

XM2_MD13C2

XM2_MD10B3

DBG3_TCKF16

XM2_MA21F2 XM2_MA22E1

XM2_MD15D2

BM3_KSO.06R16 BM3_KSO.07T17

BM3_KSO.05P15

BM3_KSO.04 T6

IR3_RXDG4

IR3_TXDH1

RESET#C15

XM2_CKEA7

XM2_RE_NC8

XM2_CS.B#B13

XM2_CS.C#A8

XM2_CS.D#B8

XM2_WMSK2A5

VD

D_I

O_1

1P

11

VD

D_I

O_1

2P

13

US

B_V

DD

PB

17

VD

D_C

OR

E_2

F6

VD

D_C

OR

E_3

F9

VD

D_C

OR

E_4

F12

VD

D_C

OR

E_5

J5

VD

D_C

OR

E_6

J6

VD

D_C

OR

E_7

J12

VD

D_C

OR

E_8

J13

AV

DD

E14

VS

S17

H13

VS

S18

J7

VS

S19

J9

VS

S20

J11

VS

S21

K5

VS

S22

K8

VS

S23

K10

VS

S24

K13

AV

SS

D15

USB_VBUS F17

VD

D_C

OR

E_9

M6

VD

D_C

OR

E_1

0M

9

VD

D_C

OR

E_1

1M

12

VD

D_C

OR

E_1

2N

9

VS

S25

L5

VS

S26

L7

VS

S27

L9

VS

S28

L11

VS

S29

L13

VS

S30

M5

VS

S31

M13

VS

S32

N6

VS

S33

N7

VS

S34

N8

VS

S35

N10

VS

S36

N11

VS

S37

N12

VD

D_I

O_M

EM

_1D

4

VD

D_I

O_M

EM

_2D

5

VD

D_I

O_M

EM

_3D

6

VD

D_I

O_M

EM

_4D

8

VD

D_I

O_M

EM

_5D

9

VD

D_I

O_M

EM

_6D

10

VD

D_I

O_M

EM

_7E

5

VD

D_I

O_M

32H

4

PP5022

U510

BGA240_21_065MMPP5022

U510

BGA240_21_065MM

1 2R538 100K

04025%R538 100K

04025%

12R557

0/NA0402R557

0/NA0402

1 TP11TP11

12

C532200P0402

50V10%

C532200P0402

50V10%

12

R5662M

04021%

R5662M

04021%

12

R600

0

0402R600

0

0402

12

C5430.1U/NA040216V

C5430.1U/NA040216V

12

C5710P0402

50V+/-10%

C5710P0402

50V+/-10%

1 2

R542100 0402

1%R542100 0402

1%

1 TP9TP9

12

R58810K

04025%

R58810K

04025%

12

C56610U

6.3V0805

10%

C56610U

6.3V0805

10%

1 2R543

10004021%

R543

10004021%

12

C2010P0402

50V+/-10%

C2010P0402

50V+/-10%

12

C58

0.1U040216V+80-20%

C58

0.1U040216V+80-20%

1 2

R550 6.81K04021%

R550 6.81K04021%

1TP506TP506

12R5771M

04021%

R5771M0402

1%

1 TP507TP507

1TP508TP508

12

C5690.1U040216V+80-20%

C5690.1U040216V+80-20%

12

R604100K0402

R604100K0402

12

C59

10U08056.3V10%

C59

10U08056.3V10%

12

R5761M

04021%

R5761M

04021%

12

C472200P0402

50V10%

C472200P0402

50V10%

1 2R60

100K04025%

R60100K04025%

1TP10TP10

12

C46

0.1U040216V+80-20%

C46

0.1U040216V+80-20%

12

C542200P0402

50V10%

C542200P0402

50V10%

12

R603100K/NA0402

R603100K/NA0402

12

R5860

04025%

R5860

04025%

12

R55610K04021%

R55610K04021%

12

R5672M

04021%

R5672M

04021%

1 2R582

100603R582100603

1 2R56810

04021%

R5681004021%

1TP503TP503

12

C710.1U040216V+80-20%

C710.1U040216V+80-20%

1 2

R56415K04021%

R56415K04021%

1 2R541

100K04025%

R541100K04025%

1 2

R51 3304025%

R51 3304025%

1TP2TP2

12

C64

0.1U040216V+80-20%

C64

0.1U040216V+80-20%

1 2R583

1004021%

R583

1004021%

12

C66

0.1U040216V+80-20%

C66

0.1U040216V+80-20%

12

C60

10U08056.3V10%

C60

10U08056.3V10%

1TP504TP504

12

C55

0.1U040216V+80-20%

C55

0.1U040216V+80-20%

12

R572

5.76K04021%

R572

5.76K04021%

12

R57410K/NA04025%

R57410K/NA04025%

12

C68

0.1U040216V+80-20%

C68

0.1U040216V+80-20%

1 TP13TP13

12

C38

0.1U040216V+80-20%

C38

0.1U040216V+80-20%

1 2

R554 1K04025%

R554 1K04025%

12

C37

0.1U040216V+80-20%

C37

0.1U040216V+80-20%

12

C55910U

6.3V0805

10%

C55910U

6.3V0805

10%

12

C39

0.1U040216V+80-20%

C39

0.1U040216V+80-20%

A KD511

1PS79SB30SOD523

D511

1PS79SB30SOD523

12

C67

0.1U040216V+80-20%

C67

0.1U040216V+80-20%

12

C5580.1U040216V+80-20%

C5580.1U040216V+80-20%

12

R607100K/NA0402

R607100K/NA0402

12

C612200P0402

50V10%

C612200P0402

50V10%

1 2R552

0

0402

5%

R552

0

0402

5%

12

C5631U/NA0603

C5631U/NA0603

12R590

00402R590

00402

12

C63

10U08056.3V10%

C63

10U08056.3V10%

1TP8TP8

12

C5620.1U040216V+80-20%

C5620.1U040216V+80-20%

12

R608100K0402

R608100K0402

12

C56510U08056.3V10%

C56510U08056.3V10%

12

C69

0.1U/NA040216V+80-20%

C69

0.1U/NA040216V+80-20%

12

R6739K04021%

R6739K04021%

1 TP509TP509

6

2

1

G1

S1 D1

Q502AAO7600SC70_6_EIAJ

G1

S1 D1

Q502AAO7600SC70_6_EIAJ

12R565

00402

R565

00402

12

R605100K/NA0402

R605100K/NA0402

12R560 0 0402R560 0 0402

1 2

R55 3304025%

R55 3304025%

1TP505TP505

12

C5610.1U040216V+80-20%

C5610.1U040216V+80-20%

12

C482200P0402

50V10%

C482200P0402

50V10%

1 2

R611M

04025%

R611M

04025%

12

R606100K0402

R606100K0402

12

C622200P0402

50V10%

C622200P0402

50V10%

5

3 4

D2 S2

G2

Q502B AO7600SC70_6_EIAJ

D2 S2

G2

Q502B AO7600SC70_6_EIAJ

12

C51

0.1U040216V+80-20%

C51

0.1U040216V+80-20%MiTac Secret

Confidentia

l Docum

ent

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

XM2_CKE_RESET#

XM2_MA18/WE#XM2_MA19

XM2_MA16/RAS0#

XM2_BYTE#

XM2_MA17/CAS0#

XM2_MD3

XM2_MD15

XM2_MD9XM2_MD10

XM2_MD9

XM2_MD11

XM2_MD7

XM2_MD2

XM2_MD5

XM2_MD2XM2_MD1

XM2_MD14

XM2_MD4

XM2_MD13

XM2_MD15

XM2_MD5

XM2_MD10

XM2_MD6

XM2_MD6

XM2_MD12

XM2_MD4

XM2_MD1

XM2_MD0

XM2_MD8

XM2_MD3

XM2_MD13XM2_MD12

XM2_MD8

XM2_MD14

XM2_MD11

XM2_MD7

XM2_MD0

REMOTE_JACK_OP-

REMOTE_JACK_OP+

XM2_MA8

XM2_MA4

XM2_MA2

XM2_MA11

XM2_MA15

XM2_MA7

XM2_MA7

XM2_MA12

XM2_MA9

XM2_MA13

XM2_MA6

XM2_MA10

XM2_MA5XM2_MA4

XM2_MA1

XM2_MA11

XM2_MA13XM2_MA14

XM2_MA5

XM2_MA10

XM2_MA12

XM2_MA9

XM2_MA3

XM2_MA1

XM2_MA2

XM2_MA8

XM2_MA6

XM2_MA3

DBG3_TCK

XTAL_32K.IN_R

RT

C_O

SC

O

RT

C_O

SC

I

DBG3_TMSDBG3_TDI

DBG3_TDO

DBG3_TRST

I2C_CLK

BTV_RTC

REMOTE_JACK

XM2_MA20

REMOTE_JACK

BTV BTV_R

XM2_MA17/CAS0#

XM2_MA1

GPIO4

VCC_MEM

VCC_MEM

VCC_MEM

+3.3V+3.3V+3.3V

+3.3V

+3.3V

+3.3V

VCC_MEM

+1.8V

VCC_MEM

VCC_MEM

+3.3V

+3.3V

VCC_BAT

VCC_BAT

RF_GND

XM2_MA193

CLK_SYS.OUT 3

XM2_MA15 3

XM2_SDR_CS0# 3

XM2_MA17/CAS0# 3XM2_MA16/RAS0# 3

XM2_DQMH# 3

XM2_MA[1..15]3

XM2_ROM.CS1#3

XM2_MA16/RAS0#3

XM2_MA18/WE#3

XM2_MA14 3

XM2_ROM.RD#3XM2_ROM.WR#3

XM2_DQML# 3

XM2_MD[0..15]3

XM2_MA18/WE# 3

XM2_MA17/CAS0#3

XM2_MA20_13

REMOTE_INT 3I2C_CLK 3,6,7,8XTAL_32K.IN 3

I2C_DAT 3,6,7,8

XTAL_24M.OUT 3

XTAL_24M.IN 3

XM2_MA253

XM2_MA153XM2_MA16/RAS0#3

XM2_MA53XM2_MA143

XM2_MA263

XM2_MA193

DBG3_TCK3

DBG3_TDI3DBG3_TRST3

DBG3_TDO3

DBG3_TMS3

XTAL_32K_V 8

REMOTE_JACK 3,6

XM2_CKE3RESET#3,7

RTC_INT#5

DC-DC_START# 5,6

RESET#3,7 XM2_ROM.RDY 3

GPIO4 3,7

Title

Size DocumentNumber

Rev

Date: Sheet of

FLASH / SDRAM / RTC R00C

4 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


4 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


4 8, 04, 2005星期四八月


Only For PP5022 Ver.B CKE reset issueCan be eliminate

Replace for Ver.C

For EMI & close U505 (RTC)

Let "XM2_MA17/CAS0#"open from FAE note

BANK 0 FLASH MEMORY512Kx16Bits => 1MBYTE

REMOTE CONTROL

JTAG CONFIG (HARDWARE SELECT)

BOOT CLOCK SOURCE (HARDWARE SELECT)

RAM TYPE/WIDTH (UPPER 2 BITS ARE FIRMWARE SELECT)

DESCRIPTION

ADDRESS

0 = 16 BIT1 = 8 BIT

00 = Serial (CPU->COP)(DEFAULT)01 = CPU only (CPU)10 = COP only (COP)11 = Parallel (CPU||COP)

0 = IDE0 (DEFAULT)1 = IDE 1

DESCRIPTION

A26 A25

ADDRESS

SRAM 16-BITSRAM 32-BITSDRAM 16-BITSDRAM 32-BIT

DESCRIPTION

0 X 00 X 11 X 01 X 1

ADDRESS

DESCRIPTION

A17 A16

BOOT VECTOR LOCATION (HARDWARE SELECT)

FLASH BUS WIDTH

01

A19

0 00 11 01 1

ADDRESS

EXT ROM0 (0000:0000) (DEFAULT)EXT ROM1 (0800:0000)BOOTROM UARTBOOTROM OTHER

A7 A6 A5 DEFAULT

24.000MHZ (DEFAULT)24.576MHZ48.000MHZRESERVED

0 00 11 01 1

01

A1

0 00 11 01 1

ADDRESS

DESCRIPTION

A15 A14

X X 0

ADDRESS

BOOT OPTION

DESCRIPTION

Phoenix DVT R0D

SDRAM Pin:BYTE# need to pullhigh to VCC_MEM

4/12 Change R & C value for PP5022

4/12 For Sub items

4/12

REMOTE Power-On CONTROL

4/13 change Footprint size fromSOD123(BAT43W-Ir=0.5uA) toSOT523(BAT54T-Ir=2uA)

Flash: SST(SST39WF400A-90-4C,1.8V)=283439400001 AMIC(A29L400UG-70F,3.3V)=283480190001

16Mx16(256Mbit): Infineon=283780190001 Sumsung=283780190002

I(charge current)< 0.006mA

Power Supply Voltage:1.65V~1.95V

Power Supply Voltage:1.65V~1.95V

These net length must be equivalent

1234

5678

RP505100K*40804RP505100K*40804

1 2

C9

1U04026.3V+/-10%

C9

1U04026.3V+/-10%

1

23

D4

1PS89SB15SOT523N

D4

1PS89SB15SOT523N

12

R651M/NA04025%

R651M/NA04025%

1 2R2

100K04025%

R2

100K04025%

12

C5670.1U040216V+80-20%

C5670.1U040216V+80-20%

1 2

R5

2M04021%

R5

2M04021%

1 2R50

0/NA

0402 5%

R500/NA

0402 5%

12

C490.1U040216V+80-20%

C490.1U040216V+80-20%

12

R63 10K04025%

R63 10K04025%

1 2 3 4

5 6 7 8

RP50110K*40804

RP50110K*40804

12

R82

100K/NA04025%

R82

100K/NA04025%

1234

5678

RP502

100K*40804

RP502

100K*40804

12

C911U0402

6.3V+/-10%

C911U0402

6.3V+/-10%

1 2

R5790/NA 0402

5%R5790/NA 0402

5%

1 2R575

00603

R575

00603

12

C360.1U040216V+80-20%

C360.1U040216V+80-20%

2

16

Q1ABC847BPNSC70_6_EIAJ

Q1ABC847BPNSC70_6_EIAJ

12

C7512P0402

25V+/-10%

C7512P0402

25V+/-10%

1 2R71

330402

5%R71

330402

5%

OE1

A2

GND3

VCC 5

Y 4

U512

SN74AUC1G126SC70_5

U512

SN74AUC1G126SC70_5

12

C7710P/NA0402

50V+/-10%

C7710P/NA0402

50V+/-10%

VS

SQ

_0A

3

VD

D_0

A9

VS

SQ

_1B

7

VS

SQ

_2C

3

VS

SQ

_3D

7

VD

D_1

E7

A12G1

A9G3

VD

D_2

J9

DQ15A2

DQ0A8

DQ14B1 DQ13B2

DQ2B8 DQ1B9

DQ12C1 DQ11C2

DQ4C8 DQ3C9

DQ10D1 DQ9D2

DQ6D8 DQ5D9

DQ8E1 DQ7E9

A11G2

A8H1 A7H2 A6H3

A0H7

A1H8

A10H9

A5J2 A4J3 A3J7 A2J8

VD

DQ

_0A

7

VD

DQ

_1B

3

VD

DQ

_2C

7

VD

DQ

_3D

3

VS

S_0

A1

VS

S_1

E3

VS

S_2

J1

BA0 G7BA1 G8

LDQM E8UDQM F1CLK F2CKE F3

CAS F7

RAS F8

WE F9

CS G9

NC0 E2

U509

HY5V56DF-HBGA_CSP_54_4

U509

HY5V56DF-HBGA_CSP_54_4

12

C400.1U040216V+80-20%

C400.1U040216V+80-20%

12

R54722K04021%

R54722K04021%

43

5 Q1BBC847BPN

SC70_6_EIAJ

Q1BBC847BPN

SC70_6_EIAJ

1 2R548

100K0402 5%

R548

100K0402 5%

12

R410M04021%

R410M04021%

12

R81004025%

R81004025%

12

R151M04025%

R151M04025%

1 324

X3

24MHZ

X3

24MHZ

12

C5600.1U040216V+80-20%

C5600.1U040216V+80-20%

12

R551100K04021%

R551100K04021%

OSCI1

OSCO2

INT3

VSS4 SDA 5SCL 6CLKOUT 7VDD 8

U9

PCF8563T

U9

PCF8563T

12

R724.7K0402

5%

R724.7K0402

5%

1 2R5550/NA

04025%

R5550/NA

04025%

12

R3810K

04025%

R3810K

04025%

12

BT1

ML414RH/F9C

BT1

ML414RH/F9C

1 2R558

0 0402

R558

0 0402

AKD2

1PS79SB30

SOD523

D21PS79SB30

SOD523

12

R54910K04025%

R54910K04025%

12

C430.1U040216V+80-20%

C430.1U040216V+80-20%

1 2R587

0/NA0603

R587

0/NA0603

12

R5630/NA04025%

R5630/NA04025%1

2

C10.1U040216V+80-20%

C10.1U040216V+80-20%

12

C450.1U040216V+80-20%

C450.1U040216V+80-20%

1 2

R16

1M04025%

R16

1M04025%

11

22

33

44

55

66

77

88

GND1 GND1GND2 GND2

J503

FPC/FFC-12P/0.5MM/NA6239-012-001-800

J503

FPC/FFC-12P/0.5MM/NA6239-012-001-800

1 4X2

32.768KMC146

X2

32.768KMC146

1 2R805

0 0402

R805

0 0402

12

R578100K04025%

R578100K04025%

RY/BY A3

A14C6

A2C1

A0E1

VS

S_1

H1

OEG1

DQ0 E2

DQ1 H2A5D2

DQ7 E5

A7A2

RESETB4

A3A1

A4B1

DQ6 H5

WEA4

A8B5

A9A5

CEF1

VS

S_0

H6

A12B6

A13A6

NC_3C3

A1D1

DQ2 E3

DQ3 H3

A10C5

A16E6 A15D6

A11D5

DQ4 H4

NC_4D4

BYTEF6

A6C2

VC

CG

4DQ5 E4

A17B2

DQ8 F2

DQ9 G2

DQ10 F3

DQ11 G3

DQ12 F4

DQ13 G5

DQ14 F5

DQ15/A-1 G6

NC_0 C4

NC_1 D3

NC_2 B3

U508

SST39WF400A-90-4CBGA48_08MM_2

U508

SST39WF400A-90-4CBGA48_08MM_2

12C557

0.1U040216V+80-20%

C557

0.1U040216V+80-20%

12

C808P0402

50V+/-10%

C808P0402

50V+/-10%

12

R661K04025%

R661K04025%

12

C7015P0402

50V5%

C7015P0402

50V5%

1

3

52

4+

-

U511

G1214SC70_5

+

-

U511

G1214SC70_5

12

C520.1U040216V+80-20%

C520.1U040216V+80-20%

12

R62M04021%

R62M04021%

12

C908P0402

50V+/-10%

C908P0402

50V+/-10%

12R53

100K/NA04025%

R53

100K/NA04025%

MiTac Secret

Confidentia

l Docum

ent

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

IN_+3.3VP

+3.

3VP

_LX

DC-DC_RUN

REGS_PWR

IN_+1.8VP

+1.

8VP

_LX

STAT2

ACPG#1

USBPG#DPPM

REGS_PWR_P

BAT_TS

VBUS

STAT1

ACPG#

ACPG#

REGS_PWR_P

PSELVBUS

AC_PWR

PSEL1PSEL

BAT_T

+1.2VP_FB

IN_+1.2VP

BA

T_P

BAT_PBAT_T

REGS_PWR

REGS_PWR

REGS_PWR

DC-DC_START#

MD_G

IN_+3.3V_HDD1P

+3.3V_HDD1P_FB

REGS_PWR

MD_G

IN_+3.3V_HDD1P

AC

_PW

R

Current_Set

+1.8V

VDD

VCC_BAT

+3.3V

+3.3V

LDO_3.3V

V_CradleVBUS

LDO_3.3V

VDD

+1.2V

+3.3VP

+1.8VP

+1.2VP

+3.3V

+3.3V_HDD1P +3.3V_HDD

VDDVDD

DC-DC_RUN3

DC-DC_START#4,6

AC_PWR3

STAT13

ACPG#13

STAT23

PSEL1 3

Current_Set3

RTC_INT#4RTC_WAKE# 3

REGS_PWR 8

AT3_PWR.OFF3

LEARNING3

Title

Size DocumentNumber

Rev

Date: Sheet of

SYSTEM POWER / RESET R00C

5 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


5 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


5 8, 04, 2005星期四八月

To change into 2A

Value change

SCDS3D16T-3R3T-B奇力新

SCDS3D16T-3R3T-B奇力新

For Only AC or USB Input to Auto-Power-OnTo show the Battery charge status

Battery Connector

Vout = 0.5 x [ 1+ (R1 / R2) ]

Battery Charge cycleNow:4 hours

Soft-Start

To set Battery Charge Currentwhen Plug-in non-high power PC.

Phoenix DVT R0D

Check Pinassignment

4/7 Remove L15 0402GA Bead filter

ADD EMI ESD Protect

Footprint=SPARKGAP-6

Only for XC9217_PWM

Only for XC9217_PWM

4/14 HD Power IC change from XC6366 to TPS62040

SPC-04702-6R8-GP (4.7*4.7*2)沛波

50 mil

dI=Vo*(1-Vo/Vi)/(L*f)Imax=Iomax+(dI/2)

4/14 CoLayout two select one

Case B

Set Adaper power 1A

Set Charg Current 450mA

SMT2=>20milSMT3=>30milSMT4=>50mil

272411476505 : TF041-TH-CAP;47U,6.3V,+/-20%,3216,1.6H, (A case),F930J476MAA,SMT

MSCDRI-2D18-100MG (H=1.8mm)美磊

Use low height Cap.Place it to 1.5mm limitregion

12

R37100K/NA04025%

R37100K/NA04025%1

2

R594100K0402R594100K0402

1

32

DS

Q3

PMF780SNSOT_SC70N_1

DS

Q3

PMF780SNSOT_SC70N_1

12

C8110U

16V1206

C8110U

16V1206

1 2

L10

3.3UH

L10

3.3UH

VIN1

VSS2

CE/MODE3 VOUT 4

LX 5U6

XC9216SOT25

U6

XC9216SOT25

1

23

D506

1PS89SB15SOT523N

D506

1PS89SB15SOT523N

12

JO501SPARKGAP_6JO501SPARKGAP_6

1

23

D3

1PS89SB15SOT523N

D3

1PS89SB15SOT523N

G

DS

DSQ4

AO3415SOT23_FET

DSQ4

AO3415SOT23_FET

12

C320.1U040216V

C320.1U040216V

12

C210.1U0402

10V

C210.1U0402

10V

12

R529100K04025%

R529100K04025%

12

+C2847U

10V3528

+C2847U

10V3528

1 2JO4

SHORT-SMT2

JO4

SHORT-SMT2

1 2JO7

SHORT-SMT3

JO7

SHORT-SMT3

12C31

1U04026.3V+/-10% C31

1U04026.3V+/-10%

12

R3410K04025%

R3410K04025%

1 2JO6

SHORT-SMT3

JO6

SHORT-SMT3

12

R5310/NA

04025%

R5310/NA

04025%

1

32

DS

Q2

PMF780SNSOT_SC70N_1

DS

Q2

PMF780SNSOT_SC70N_1

12


1 2F2

2A/32V

F2

2A/32V

VIN1

VSS2

CE/MODE3 VOUT 4

LX 5U8

XC9216SOT25

U8

XC9216SOT25

12

R54100K04021%

R54100K04021%

1 2JO3

SHORT-SMT3

JO3

SHORT-SMT3

1 2JO2

SHORT-SMT3

JO2

SHORT-SMT3

12

R83100K/NA0402

R83100K/NA0402

12

C539180P0402

50V+/-10%

C539180P0402

50V+/-10%

STAT12

STAT23

AC4

ISET27

PSEL/ISET38 CE9 VSS 11

ISET1 10

TS 12

DPPM 13

TMR14

ACPG18 USBPG19

USB20

LDO 1

GND 21

OUT_0 15

OUT_1 16

OUT_2 17

BAT_0 5

BAT_1 6

U2

BQ24032QFN_RHL20

U2

BQ24032QFN_RHL20

12

C760.1U040210V

C760.1U040210V

12

R6400402

R6400402

1 2JO503

SHORT-SMT3

JO503

SHORT-SMT3

12

R352.32K04021%

R352.32K04021%

12

C6510U

6.3V0805

10%

C6510U

6.3V0805

10%

12

R7533K/NA

04025%

R7533K/NA

04025%

12

C560.1U040210V

C560.1U040210V

12

+C9547U

10V3528

+C9547U

10V35281

2

R522

100K 04021%

R522

100K 04021%

12

R4410K04025%

R4410K04025%

1 2L3

6.8UHSPC-04702

30%L3

6.8UHSPC-04702

30%

12

R57100K/NA0402

R57100K/NA0402

12

R31100K04025%

R31100K04025%

12

GND1GND2

3

J502

MA/3PX1/STACES87212-0300

J502

MA/3PX1/STACES87212-0300

1 2

R33100

0402

R33100

0402

12

C4210U

16V1206

C4210U

16V1206

12

C240.1U040210V

C240.1U040210V

12

C53627P0402

50V5%

C53627P0402

50V5%

1 2JO8

SHORT-SMT3

JO8

SHORT-SMT3

12

R7400402

R7400402

1 2L8

10UHMSCDRI-2D18C

20%

L8

10UHMSCDRI-2D18C

20%

12

R292M

04021%

R292M

04021%

12

R523560K

04021%

R523560K

04021%

1 2F1

2A/32V

F1

2A/32V

12

C7810U

6.3V0805

C7810U

6.3V0805

12

C7910U

6.3V0805

C7910U

6.3V0805

12

R573100K0402

R573100K0402

12

R321M04021%

R321M04021%

12

R2810K04021%

R2810K04021%

VI1

FB 4GND2

EN3

SW 5U7

TPS62200SOT25

U7

TPS62200SOT25

12

R7047K04021%

R7047K04021%

12

R390/NA

0402_DFS5%

R390/NA

0402_DFS5%

1TP6TP6

12

R598100K04025%

R598100K04025%

12

R5991M

04021%

R5991M

04021%

12

R6233K/NA

04025%

R6233K/NA

04025%

1 2R27

0/NA0402

R27

0/NA0402

1

32

DS

Q504

PMF780SNSOT_SC70N_1

DS

Q504

PMF780SNSOT_SC70N_1

12

C221U0402

6.3V+80-20%

C221U0402

6.3V+80-20%

12

R2620K04021%

R2620K04021%

EN1

VIN_02

VIN_13

GND4 FB 5MODE6

SW_0 7SW_1 8

PGND_0 9PGND_1 10

GND111

U3

TPS62040MLFP10A_05MM_GND

U3

TPS62040MLFP10A_05MM_GND

12

C340.1U040216V+80-20%

C340.1U040216V+80-20%

12

C2510U080510V+80-20%

C2510U080510V+80-20%

1 2R530

0/NA

0402R530

0/NA

0402

1 2

L9

3.3UH

L9

3.3UH

12

R48100K0402

R48100K0402

1 2R36 1K

04021%R36 1K

04021%

12

R6933K04021%

R6933K04021%

12

R45

40.2K04021%

R45

40.2K04021%

12

R30100K04025%

R30100K04025%

1 2JO5

SHORT-SMT3

JO5

SHORT-SMT3

A KD5

PMEG3005AEASOD323B

D5

PMEG3005AEASOD323B

12

R41100K0402

R41100K0402

12

C300.1U040210V

C300.1U040210V

12

R73100K04021%

R73100K04021%

12

C7310U

16V1206

C7310U

16V1206

12

C740.1U040210V

C740.1U040210V

12

R4036K04021%

R4036K04021%

12

C2310U

16V1206

C2310U

16V1206

MiTac Secret

Confidentia

l Docum

ent

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

I2S_SCLK_IN

BM3_KSI12

MIC_BIAS

I2C.DAT

BM3_KSI1

BM3_KSI6

DCVDD

I2C.CLK

DBVDD

BM3_KSI0

BM3_KSI10

BM3_KSI8

FM_AUDIO_AC_L

FM_AUDIO_AC_R

BM3_KSI5

BM3_KSI11

HP_OUT_L

I2S_DOUT

MIC_BIASI2S_LRC

AVDD

HPVDD

BM3_KSI2

BM3_KSI3

MIC_IN

BM3_KSI4

I2S_SCLK

BM3_KSI7

I2S_SDIN

PWR_ON_OFF#

BZZ_GND

BM3_KSI12

BM3_KSI1BM3_KSI2

PWR_ON_OFF#BM3_KSI8

BM3_KSI3BM3_KSI0

HP_OUT_R

LED_PWR

AUDIO_LDO_IN

BM3_KSI5BM3_KSI4

BM3_KSI3

BM3_KSI1BM3_KSI2

BM3_KSI0

BM3_KSI5BM3_KSI4BM3_KSI10

BZZ_PWM

BM3_KSI9

HP_OUT_R_1

REMOTE_JACK_1

HP_OUT_R_1 Cradle_R_OUT

HP_OUT_L_AC

REMOTE_JACK_1

FM_OUT_L

FM_OUT_R

AUDIO_LDO_OUT

PJ_In_T

FM_AUDIO_DC_L

HP_OUT_L_AC

MIC_IN_1

FM_OUT_L

FM_OUT_R FM_AUDIO_DC_R

HP_OUT_L_1

PJ_In_T

HP_OUT_R_AC

HP_OUT_R_AC

HP_OUT_L_1

HP_OUT_R_1

MIC_P_IN

MIC_IN_1

+3.3V

GND

GND

+3.3VGND

GND

GND

GND

+3.3V

GND

+3.3V

+1.8V

+3.3V

+3.3V

GND

+3.3V

GND

+1.8V

+1.8V

GND

JGND RF_GND

GND

+3.3V

+3.3V

VCC_MEM

+3.3V

+3.3V

GND GND

GND

GND

GND GND

GND

Power_Out_C3,7

I2S_SDIN 3

BM3_KSI43

I2C_DAT 3,4,7,8

I2S_DOUT 3

BM3_KSI123

BM3_KSI113

CLK_24M.CODEC 3

ANT_SW1#3

BM3_KSI93,7

BM3_KSI33BM3_KSI83

I2C_CLK 3,4,7,8

BM3_KSI103

I2S_LRC 3

BM3_KSI03

I2S_SCLK 3

BM3_KSI53

BM3_KSI23BM3_KSI13,7

DC-DC_START# 4,5

BZZ_PWM3

HP_ANT8

TP_PWR#3

Cradle_R_OUT 7

MUTE3

PJ_In 3

REMOTE_JACK 3,4

BZZ_CRL#3

FM_OUT_L8

FM_OUT_R8

Cradle_L_OUT 7

Title

Size DocumentNumber

Rev

Date: Sheet of

AUDIO / KEY MATRIX R00C

6 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


6 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of


6 8, 04, 2005星期四八月

I2C ADDRESS: 0011011

KEY MATRIX GPI DESCRIPTIONS

MICROPHONE

GPIO

Touch Pad

FUNCTION DESCRIPTIONS

KSI0KSI1KSI2KSI3KSI4KSI5KSI6KSI7KSI8KSI9KSI10KSI11KSI12

RecordingVolume upVolume down

View

Like Music

xxxxx

xxxxx

xxxxxHOLD

xxxxx

HOLD

Buzzer

ACK

CLKDATA

CLK

ACK

DATA

No AGND=>Check

Solder point

JGND is the Antennausing HeadPhoneCable

Close to PhoneJack (J501)

EMI two Cap.s removed for placement

LED Current limit

Check MIC_BIAS

Check FPC Pin assignmentDiff.with Arizona

Phoenix DVT R0D

4/8

4/8 Check Size to smaller

4/14

default high

Co-layout

place R580 under the trace of"Cradle_R_OUT"; Don't out of the trace

Pin E place on the trace ;No Branch

Critical components

PBSS2515FSOT523N

PBSS2515FSOT523N

only for Phoenix

For Soft-star

V(MICBIAS)=0.75*AVDD =>0.75*1.8=1.35V

Input Full Scale input to ADC:V(INMIC)=1*AVDD/3.3=1.8/3.3=0.55V (max)

Replace

BUZZER MUX

CONNECT CGND TO AGND VIAFERRITE BEAD AT THE JACK

LC->CL to Swap

Unuse if need to pull high or low?!

123456789

101112 GND1

GND2

J3

0.5MM/HDR/MA-12MOLEX54548-1211

J3

0.5MM/HDR/MA-12MOLEX54548-1211

1 2

R591330

04025%

R591330

04025%

12


1 2L11 120Z/100M

0402

L11 120Z/100M

0402

VIN1

GND2

SHDN3 ADJ 4

VOUT 5U507

AME8834AEIVADJSC70_5

U507


12R23

0

04025%

R23

0

04025%

1 2

L9081K/100M0402

L9081K/100M0402

1 2L506

1K/100M0402

L506

1K/100M0402

1

23

D512

1PS89SB16SOT523N

D512

1PS89SB16SOT523N

12

3 SP501

OWMB-505025S-40-12

SP501

OWMB-505025S-40-12

5

3

1

4

2

6

J501

RA/D5/6P2SJ-A390-002

J501

RA/D5/6P2SJ-A390-002

12

C92610P0402

50V+/-10%

C92610P0402

50V+/-10%

12R584

0/NA0402 5%

R584

0/NA0402 5%

12

R51910K04025%

R51910K04025%

12

C3510P0402

50V+/-10%

C3510P0402

50V+/-10%

12

R53218K/NA04021%

R53218K/NA04021%

1 2R562

0

0402R562

0

0402

1 2

L510

1K/100M0402

L510

1K/100M0402

1 2R42

3304025%

R42330402

5%

12 +

C12 220U4V3528

+

C12 220U4V3528

1 2L5031K/100M0402

L5031K/100M0402

12

C529

10U08056.3V10%

C529

10U08056.3V10%

1

23

Q501PMST3904SOT_SC70N_1

Q501PMST3904SOT_SC70N_1

G

DS

DS

Q6

AO7401SOT_SC70_FET

DS

Q6

AO7401SOT_SC70_FET

12

R595100K04025%

R595100K04025%

12

C1710U080510V

+80-20%

C1710U080510V

+80-20%

12

C57210P/NA0402

50V+/-10%

C57210P/NA0402

50V+/-10%

1

TP501

TOUCHPAD_12_SMD

TP501

TOUCHPAD_12_SMD

1 2L6 120Z/100M/NA

0402

L6 120Z/100M/NA

0402

12

C2610P/NA0402

50V+/-10%

C2610P/NA0402

50V+/-10%

123456

J505

0.5MM/HDR/MA-6

MOLEX54548-0611

J505

0.5MM/HDR/MA-6

MOLEX54548-0611

1 2

L509

1K/100M0402

L509

1K/100M0402

12C14

1U04026.3V +/-10%

C14

1U04026.3V +/-10%

1 2

L9101K/100M0402

L9101K/100M0402

12

C92710P0402

50V+/-10%

C92710P0402

50V+/-10%

1 2

R585330

04025%

R585330

04025%

12

C55010P0402

50V+/-10%

C55010P0402

50V+/-10%

12

C180.1U0402

16V+80-20%

C180.1U0402

16V+80-20%

1 2C534 1U

04026.3V +/-10%C534 1U

04026.3V +/-10%

12

C5490.1U040216V

+80-20%

C5490.1U040216V

+80-20%

1 2 3 4

5 6 7 8

RP503100K*40804

RP503100K*40804

12

R91K04025%

R91K04025%

12

R50610K04021%

R50610K04021%

AK

D5071PS79SB30SOD523

D5071PS79SB30SOD523

1 2L512 120Z/100M

0402

L512 120Z/100M

0402

12

C3310P/NA0402

50V+/-10%

C3310P/NA0402

50V+/-10%

1 2L9111K/100M0402

L9111K/100M0402

1 2 3 4

5 6 7 8

RP504100K*4

0804

RP504100K*4

0804

1 2L501

1UH0805

L501

1UH0805

123456

J506

0.5MM/HDR/MA-6

MOLEX54548-0611

J506

0.5MM/HDR/MA-6

MOLEX54548-0611

1 2

R521004025%

R521004025%12

R22

00402 5%

R22

00402 5%

1 2

R546100K

0402R546100K

0402

12

C5480.1U040216V+80-20%

C5480.1U040216V+80-20%

12

C112200P0402

50V10%

C112200P0402

50V10%

1 2C533 1U

04026.3V +/-10%C533 1U

04026.3V +/-10%

B

EC

Q503

MMST3904

SOT_SC70_1Q503

MMST3904

SOT_SC70_1

12

C4110P0402

50V+/-10%

C4110P0402

50V+/-10%

12

C50647P0402

50V+/-10%

C50647P0402

50V+/-10%

12

R53963.4K04021%

R53963.4K04021%

1 2L514

120Z/100M/NA

0402L514

120Z/100M/NA

0402

12

R55310K/NA04025%

R55310K/NA04025%

1 2R601

2.2K04021%

R601

2.2K04021%

12

R46100K04025%

R46100K04025%

12

C9244700P0402

25V10%

C9244700P0402

25V10%

12

C5410.1U040210V10%

C5410.1U040210V10%

1 2 3 4

5 6 7 8

RP1100K*40804

RP1100K*40804

1

23

D504

1PS89SB15SOT523N

D504

1PS89SB15SOT523N

12

C2710P/NA0402

50V+/-10%

C2710P/NA0402

50V+/-10%

12

C50910U080510V

+80-20%

C50910U080510V

+80-20%

12

R5800/NA04025%

R5800/NA04025%

12

C546

10U08056.3V10%

C546

10U08056.3V10%

12


1 2

L504120Z/100M

0402

L504120Z/100M

0402

1 2L515 120Z/100M

0402

L515 120Z/100M

0402

12

R111K04025%

R111K04025%

1 2L7 120Z/100M

0402

L7 120Z/100M

0402

1 2

R51710K0402

5%

R51710K0402

5%1

2

R5611K/NA04025%

R5611K/NA04025%

1

TP521TP521

1

2

3

4567

GND

SW14V/0.3ARST-1202

GND

SW14V/0.3ARST-1202

12

C9254700P0402

25V10%

C9254700P0402

25V10%

12

R561K04025%

R561K04025%

12

C5124700P0402

50V10%

C5124700P0402

50V10%

2

16 Q805A

BC847BPN/NAQ805ABC847BPN/NA

12

C55310P/NA0402

50V+/-10%

C55310P/NA0402

50V+/-10%

XTI/MCLK 1XTO 2

DC

VD

D3

DG

ND

4D

BV

DD

5

CLKOUT 6

BCLK 7

DACDAT 8

DACLRC 9

ADCDAT 10

ADCLRC 11

HP

VD

D12

LHPOUT13 RHPOUT14

HP

GN

D15

LOUT16 ROUT17

AV

DD

18A

GN

D19

VMID20

MICBIAS21

MICIN22

RLINEIN23

LLINEIN24

MODE 25

CSB 26

SDIN 27

SCLK 28

GN

D0

29

GN

D1

30

GN

D2

31

GN

D3

32

GN

D4

33

GN

D5

34G

ND

635

GN

D7

36G

ND

837

GN

D9

38

U505

WM8731LHVQFN28_4

U505

WM8731LHVQFN28_4

12

C190.1U040216V

C190.1U040216V

12

R17100K04025%

R17100K04025%

1 2

R503

68004025%

R503

68004025%

1 2L517 120Z/100M

0402L517 120Z/100M

0402

1 2L507 120Z/100M

0402

L507 120Z/100M

0402

12

C5440.1U040210V10%

C5440.1U040210V10%

1 2R43 33 0402

5%R43 33 0402

5%

12

C72200P0402

50V10%

C72200P0402

50V10%

4 3

5

Q805BBC847BPN/NA

SC70_6_EIAJ

Q805BBC847BPN/NA

SC70_6_EIAJ

12

L4120Z/100M

0402

L4120Z/100M

0402

12

C5264700P0402

50V10%

C5264700P0402

50V10%

1 2

R592330

04025%

R592330

04025%

1 2R59 0/NA

0402R59 0/NA

0402

12

C52010P/NA040250V+/-10%

C52010P/NA040250V+/-10%

12

C5400.1U040210V10%

C5400.1U040210V10%

12

C55110P/NA0402

50V+/-10%

C55110P/NA0402

50V+/-10%

1 2L5 120Z/100M/NA

0402

L5 120Z/100M/NA

0402

B

EC

Q505

MMST3904

SOT_SC70_1Q505

MMST3904

SOT_SC70_1

12

C547

10U08056.3V10%

C547

10U08056.3V10%

1 2R535 56

0402

R535 56

0402

12

R5598.8K/NA04025%

R5598.8K/NA04025%

12

R528100K04025%

R528100K04025%

1 2R593

47K/NA04021%

R593

47K/NA04021%

1 2JO504

SPARKGAP_6

JO504

SPARKGAP_6

12 +

C8

220U4V3528

+

C8

220U4V3528

1 2L505

1K/100M0402

L505

1K/100M0402

12

C5561U0603

C5561U0603

12

R5101K04025%

R5101K04025%

12

R52010K

04025%

R52010K

04025%

12

C53110P/NA0402

50V+/-10%

C53110P/NA0402

50V+/-10%

12

C5380.1U040210V10%

C5380.1U040210V10%

1 2R518

10K0402

5%R51810K0402

5%1

TP520TP520

12

R54030K04021%

R54030K04021%

A KD510

1PS79SB30/NA

SOD523

D510

1PS79SB30/NA

SOD523

1 2R20 10K

04021%

R20 10K04021%

12

R50510K04021%

R50510K04021%

1

TP502

TOUCHPAD_12_SMD

TP502

TOUCHPAD_12_SMD

1 2

L516120Z/100M

0402L516120Z/100M

0402

12

C554

10U08056.3V10%

C554

10U08056.3V10%

12

R5081M/NA04025%

R5081M/NA04025%

MiTac Secret

Confidentia

l Docum

ent

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

AT3_HD12

AT3_HD2

AT3_HRESET#

AT3_HD7

AT3_HD4

AT3_HA2

AT3_HD3

AT3_HA1

AT3_HD9

AT3_HD0

AT3_HD11AT3_HD10

AT3_HCS1#

AT3_HIOW#

AT3_HD14

AT3_HD6

AT3_HD15

AT3_HIOR#

AT3_HD5

AT3_HD13

AT3_HD1

AT3_HDMACK#

AT3_HD8

AT3_HCS0#

AT3_HA0

AT3_HIORDY

AT3_HIORDY

MN

Wake_Up#

Cradle_R_OUT

I2C_SCL_SW

Cradle_in#

USB_IDPower_Request#

I2C_SDA_SW

Cradle_L_OUT

Cradle_R_OUT

Cradle_in#

GPIO2

GPIO1

Wake_Up#

V_Cradle

I2C_SDA_SW

I2C_SCL_SW

Power_Request#

USB_ID

VBUS

AT3_HIRQ.0

AT3_HDMARQ

Cradle_R_OUT

Cradle_L_OUT

AT3_HA2

AT3_HD1AT3_HD0AT3_HA0

AT3_HD9AT3_HD2

AT3_HDMACK#

AT3_HDMARQ

AT3_HD8

AT3_HD10

AT3_HA1

AT3_HIORDY

AT3_HRESET#

AT3_HD3AT3_HD11AT3_HD4AT3_HD12AT3_HD5AT3_HD13AT3_HD6AT3_HD14AT3_HD7AT3_HD15AT3_HCS0#AT3_HCS1#

AT3_HIOR#

AT3_HIOW#

AT3_HIRQ.0

RESET#

I2C_SDA_SW

I2C_SCL_SWUSB_ID

Power_Request#

Wake_Up#

GPIO1

Cradle_in#

GPIO2

AT3_HDMARQ

AT3_HIRQ.0

AT3_HIRQ.1

Ext_ANT

Cradle_Power_Out

DN

DP

Cradle_L_OUT

Cradle_in#

Ext_ANT

VBUSDNDP

OC#_R

Cradle_Power_Out_R Cradle_Power_Out

USBID-DEV/HOST#

I2C_SDA_SWI2C_SCL_SW

+3.3V_HDD

+3.3V_HDD

+3.3V

+3.3V

+3.3V_HDD

GND

+3.3V

GND

GND

V_Cradle

VBUS

GND

V_Cradle

VBUS

+3.3V

+3.3V

+3.3V

+3.3V

AT3_HIOW#3

AT3_HA03

AT3_HDMARQ3

AT3_HDMACK#3

AT3_HD[0:15]3

AT3_HIOR#3

AT3_HA13

AT3_HIORDY3

AT3_HRESET#3

AT3_HIRQ.13AT3_HCS1#3AT3_HCS0#3

AT3_HA23

AT3_HIRQ.03

USBID-DEV/HOST#3

USB_DP3

USB_DN3

Power_Request#3

Wake_Up#3GPIO13GPIO23

Cradle_R_OUT6

Cradle_in#3

RESET# 3,4

Cradle_L_OUT6

Ext_ANT8

GPIO43,4

BM3_KSI93,6

BM3_KSI13,6

Power_Out_C3,6

OC_CRL_PWR#3

I2C_CLK 3,4,6,8I2C_DAT 3,4,6,8

I2C_C_EN3

Title

Size DocumentNumber

Rev

Date: Sheet of

BATTERY / HDD R00C

7 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

BATTERY / HDD R00C

7 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

BATTERY / HDD R00C

7 8, 04, 2005星期四八月

1" HDD FPC Connector

2 Key buttons to reset

CoLayout

Cradle plug_in-->LCradle plug_out-->H

For EMIVolume up

Power_on/off

Phoenix DVT R0D

Remove 11 Res.

For ESD Negative power Cut

4/8

RC Delay Time: I=C*dV/dt=>t=C*V/I(dV is both sides voltage of Res. ; dt is the time of charge Cap.)

Cradle POWER SWITCH

Cradle toSystem

Logic 0

I2C connectFunction

Logic 1

Floating

I2C_SW

High Bandwidth: 250 MHzFast Transition Speed: 5.2ns max. at 5VLow On-Resistance: 8. at 3.0V

1

2

3

6

5

4

U11

CM1218-05SC/NASC70_6_EIAJ

U11


1 2C9410P

040250V

10%C9410P

040250V

10%

1 2R524 10K

0402 5%

R524 10K

0402 5%1

2

R85100K04025%

R85100K04025%

1 2R589

0/NA0603_DFS

R589

0/NA0603_DFS

21

34

L518

90Z/100M/NACHOKE_ACM2012

L518

90Z/100M/NACHOKE_ACM2012

12

C5370.1U040216V+80-20%

C5370.1U040216V+80-20%

12


12

R58100K04025%

R58100K04025%

GND 1

RESET 2

VCC4

MN3U5

G692L293TSOT143

U5

G692L293TSOT143

1 2

R21330

04025%

R21330

04025%

A0 1

0B02

GND_0 3

A1 4

0B15

GND_1 6S17

VCC_1 12

1B011

S010

VCC_0 9

1B18

U13

PI5A3158 TDFN12

U13

PI5A3158 TDFN12

1 2R57100402

R57100402

1 2C8910P

040250V

10%C8910P

040250V

10%

12

C5010U080510V+80-20%

C5010U080510V+80-20%

1 2R57000402

R57000402

1 2C56810P

040250V

10%C56810P

040250V

10%

OUT 1GND 2FLAG 3ON4

IN5

U513

FPF2006SC70_5

U513

FPF2006SC70_5

12

R87100K04025%

R87100K04025%

12


1

23

D1

1PS89SB15SOT523N

D1

1PS89SB15SOT523N

12

C20.1U040216V+80-20%

C20.1U040216V+80-20%

1 2C8310P

040250V

10%C8310P

040250V

10%

12

C440.1U0402

16V+80-20%

C440.1U0402

16V+80-20%

1 2C8210P

040250V

10%C8210P

040250V

10%

12

R471M

04021%

R471M

04021%

1 2C8710P

040250V

10%C8710P

040250V

10%

12

R110K04025%

R110K04025%

12

R84100K04025%

R84100K04025%

1 2C56410P

040250V

10%C56410P

040250V

10%

12

R602100K04025%

R602100K04025%

1 2R527 10K

0402 5%

R527 10K

0402 5%

1 2R537 10K

0402 5%

R537 10K

0402 5%

11

22

33

44

55

66

77

88

99

1010

1111

1212

1313

1414

1515

1616

1717

1818

1919

2020

2121

2222

2323

2424

2525

2626

2727

2828

2929

3030

GND1GND1

GND2GND2

GND3GND3

GND4GND4

J507

FM/30P/RAJAEDD1R030HA1

J507

FM/30P/RAJAEDD1R030HA1

12

R77100K04025%

R77100K04025%

AK

D509ESD0603A/NA

DC0603

D509ESD0603A/NA

DC0603

123456789

101112131415161718192021222324252627282930313233343536373839404142434445

GND1GND2

J504

FPC/0.5MM/45PMOLEX51296-4541

J504

FPC/0.5MM/45PMOLEX51296-4541

1 2C9310P

040250V

10%C9310P

040250V

10%

1 2C8410P

040250V

10%C8410P

040250V

10%1 2R526 10K

04025%R526 10K

04025%

AK

D508

ESD0603A/NADC0603

D508

ESD0603A/NADC0603

1

2

3

6

5

4

U10


U10


1 2C8810P

040250V

10%C8810P

040250V

10%

12

C5520.1U040216V+80-20%

C5520.1U040216V+80-20%

1 2

R86 1K/NA04025%

R86 1K/NA04025%

2

1 5

4

3

VCC

GND

U4

74LVC1G125GWSC70_5

VCC

GND

U4

74LVC1G125GWSC70_5

12

R5210K04021%

R5210K04021%

12


12

R78100K04025%

R78100K04025%

12

R525

4.7K

0402 5%

R525

4.7K

0402 5%

1 2R49

0

0402

5%

R49

0

0402

5%

1 2C8610P

040250V

10%C8610P

040250V

10%

1 2C8510P

040250V

10%C8510P

040250V

10%

1

2

3

6

5

4

U12


U12


12

C5750.1U040216V+80-20%

C5750.1U040216V+80-20%

12

C30.1U040216V+80-20%

C30.1U040216V+80-20%

MiTac Secret

Confidentia

l Docum

ent

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

BKL_ON_R

VCC_2.8V_JS

LCD_CS#

LCD_RD#

LCD_CS#

LCD_R/W#

LCD_D2

LCD_D0LCD_D1

LCD_D3

LCD_D7

LCD_D4LCD_D5LCD_D6

LED1_SW

FM_ANT_CFM_ANT

I2C_DAT

I2C_CLK

FM_OUT_L

FM_OUT_R

BK

_RS

BK_FB

VCC_2.8V_FB

LCD_RSLCD_RST#

BKLT_PWM_RC

Ext_ANT_1

SW2

Cradle_in_SW#

FM_ANT_C

+3.3VVCC_2.8V

VCC_2.8V

VCC_3VFM

VCC_3VFM

VCC_3VFM

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

RF_GND

+3.3VVCC_3VFM

RF_GND

VCC_3VFM

RF_GND

RF_GND

RF_GND

LED1

LED2

LED1 LED2

VCC_3VFM_1

RF_GND

+3.3V

RF_GNDRF_GND

RF_GND

RF_GNDRF_GND

LCD_RD#3

LCD_CS#3

LCD_R/W#3

LCD_D23LCD_D33

LCD_D53

LCD_D73

LCD_D03LCD_D13

LCD_D63

LCD_D43

XTAL_32K_V4

FM_OUT_R 6

FM_OUT_L 6

I2C_CLK3,4,6,7

I2C_DAT3,4,6,7

LCD_ON3

LCD_RS3LCD_RST#3

REGS_PWR5

BKLT_PWM3

BKL_ON3

Cradle_in_SW# 3

Ext_ANT7

HP_ANT6

Title

Size DocumentNumber

Rev

Date: Sheet of

FM TUNER / LCM R00C

8 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

FM TUNER / LCM R00C

8 8, 04, 2005星期四八月

Title

Size DocumentNumber

Rev

Date: Sheet of

FM TUNER / LCM R00C

8 8, 04, 2005星期四八月

1.5" CSTN PANEL

Vout = 0.59 x [ 1+ (R1 / R2) ]

Swap return

S/W request to Control enable LCD outputUsing on PA020

Change from 0402 to 0603

Change from 0402 to 0603

FM Switch

Phoenix DVT R0D

High->OnLow ->Off

If CTRL is pulled to GND,it will disconnect LEDsfrom GND

Ip=400mA+Vin*100ns/L =402.27mA

LDO

Place on particular Position

25V

15mils

ANTENNA SWITCH

MSCDRI-2D18-4R7MG (H=1.8mm)美磊

6via6via

6via6via

6via 6via

6via 6via (type:VRD016_008)

2.33V/680ohm = 3.426mA

1 2R536

5.6K04021%

R536

5.6K04021%

12C571

0.1U040210V10%

C5710.1U040210V10%

12

C5700.1U040216V

+80-20%

C5700.1U040216V

+80-20%

12

R820K0402

1%

R820K0402

1%

12

C5220P040250V10%

C5220P040250V10%

NC_01

NC_12

PS03

NC_24

NC_35

CS16

RESET7

RS8

WR9

RD10

D011

D112

D213

314

D415

D516

D617

D718

D819

D920

D1021

D1122

D1223

D1324

D1425

D1526

VSS27

VDD28

NC_429

NC_530

NC_631

NC_732

NC_833

J1

FPC/FFC-0.8MM-33P

PHILIPS9360-304-XXXX

J1

FPC/FFC-0.8MM-33P

PHILIPS9360-304-XXXX

1 2R581

0

0402

R5810

0402

12C514 0.033U0402 16V 10%C514 0.033U0402 16V 10%

1 2R14 0 0402R14 0 0402

12

C524

0.022U

0402

16V10%

C524

0.022U

0402

16V10%

1

TP17TP17

1 2C501

27P 040250V5%

C501

27P 040250V5%

12

R5072204021%

R5072204021%

12

R2447K04025%

R2447K04025%

1 2

R5450

04025%

R5450

04025%

12

C1010U080510V+80-20%

C1010U080510V+80-20%

12

R5332204021%

R5332204021%

12

C4220P040250V10%

C4220P040250V10%

1 2R5090/NA

0402_DFS5%

R5090/NA

0402_DFS5%

12

C151U0402

6.3V+/-10%

C151U0402

6.3V+/-10%

12C515 1000P0402 50V 10%C515 1000P0402 50V 10%

A K

D6

1SS381SOD523

D6

1SS381SOD523

1 2R10 10K 04025%

R10 10K 04025%

1 2L2 120Z/100M/NA

0402

L2 120Z/100M/NA

0402

12

C519

2200P

0402

50V10%

C519

2200P

0402

50V10%

N.C._01

CPOUT2

VCOTANK13

VCOTANK24

VC(VCO)5

DGND6

VCCD7

DATA8

CLOCK9

N.C._210

WR

ITE

/RE

AD

11

BU

SM

OD

E12

BU

SE

NA

BLE

13

SW

PO

RT1

14

SW

PO

RT2

15

XTA

L116

XTA

L217

PH

AS

EFI

L18

PIL

FIL

19

N.C

._3

20

N.C._4 21VAFR 22VAFL 23TMUTE 24MPXO 25VREF 26TIFC 27LIMDEC1 28LIMDEC2 29N.C._5 30

N.C

._6

31IG

AIN

32A

GN

D33

VC

CA

34R

FI1

35R

FGN

D36

RFI

237

TAG

C38

LOO

PS

W39

N.C

._7

40G

ND

41U502

TEA5767HNHVQFN40

U502

TEA5767HNHVQFN40

1 2

R50218K

04021%

R50218K

04021%

12

R54410K04025%

R54410K04025%

1 2R12

0/NA04025%

R12

0/NA04025%

1

TP16TP16

12

C517

0.022U040216V10%

C517

0.022U040216V10%

VIN1

GND2

SHDN3 ADJ 4

VOUT 5U504


U504


12

C60.1U040210V10%

C60.1U040210V10%

1 2C803

220P040250V10%

C803

220P040250V10%

1 2R512

10K

04021%R51210K

04021%

1 2L513

4.7UHMSCDRI-2D18C30%

L513

4.7UHMSCDRI-2D18C30%

12

L50833nH06032%

L50833nH06032%

12

C5450.01U040225V10%

C5450.01U040225V10%

1 2C504

47P 040250V10%

C504

47P 040250V10%

1 2R5160

04025%

R5160

04025%

12

R53418.204021%

R53418.204021%

12

R1843.2K04021%

R1843.2K04021%

1

TP4TP4

1 2R25

10K04021%

R25

10K04021%

12

R8044704025%

R8044704025%

1 2C527 0.1U0402

16V +80-20%

C527 0.1U0402

16V +80-20%

1 2R596

63.4K04021%

R596

63.4K04021%

1 2R513

10K0402 1%R51310K0402 1%

12

C52810U

16V1206

C52810U

16V1206

12C508 0.047U0402 16V 10%C508 0.047U0402 16V 10%

12C516 0.033U0402 16V 10%

C516 0.033U0402 16V 10%

12

C5350.1U040210V10%

C5350.1U040210V10%

A KD505

PMEG3005AEASOD323B

D505

PMEG3005AEASOD323B

12

C291000P040250V+80-20%

C291000P040250V+80-20%

12

L51133nH06032%

L51133nH06032%

12

C5100.033U0402

16V10%

C5100.033U0402

16V10%

VIN1

GND2

SHDN3 ADJ 4

VOUT 5U1


U1


1 2R800

04025%

R800

04025%

12

C5741000P040250V+80-20%

C5741000P040250V+80-20%

12

C5180.022U

040216V10%

C5180.022U

040216V10%

12

C5730.1U040216V+80-20%

C5730.1U040216V+80-20%

1 2C502

220P

040250V10%C502

220P

040250V10%

1 2R514 10K 0402

1%R514 10K 0402

1%

LED 1GND_19 OVP 7GND_06

RS 2FB4

VIN3

SW 8CTRL5

U506

TPS61043HVQFN8_065MM

U506

TPS61043HVQFN8_065MM

12

C5424.7U120610%

C5424.7U120610%

12C511 0.047U0402 16V 10%C511 0.047U0402 16V 10%

12

C5

03

47

00

P0

40

2

50

V1

0%

C5

03

47

00

P0

40

2

50

V1

0%

12

C5300.1U040210V10%

C5300.1U040210V10%

12

C131U0603

C131U0603

12

L122700/100M0805C

L122700/100M0805C

1 2C16 0.1U0402

16V +80-20%

C16 0.1U0402

16V +80-20%

1 2L1 120Z/100M

0402

L1 120Z/100M

0402

1 2R597

6.81K04021%

R597

6.81K04021%

1 2C805

220P040250V10%

C805

220P040250V10%

12

R5

15

1.1

3K

04

02

1%

R5

15

1.1

3K

04

02

1%

12

C5321U0402

6.3V+/-10%

C5321U0402

6.3V+/-10%

1 2R13 0 0402R13 0 0402

12

R50410K04021%

R50410K04021%

12

C5

05

0.1

U

04

02

10

V1

0%

C5

05

0.1

U

04

02

10

V1

0%

1 2C507

0.033U 040216V10%

C507

0.033U 040216V10%

1 2R5110/NA

0402_DFS5%

R5110/NA

0402_DFS5%

12

C5550.1U040216V+80-20%

C5550.1U040216V+80-20%

AK

D501BB202

SO

D523

D501BB202

SO

D523

12

R1933K04021%

R1933K04021%

12

C525

0.022U

0402

16V10%

C525

0.022U

0402

16V10%

12C513 0.047U0402 16V 10%C513 0.047U0402 16V 10%

12

R569100K04025%

R569100K04025%

1

23

Q5BC860BWSOT_SC70N_1

Q5BC860BWSOT_SC70N_1

12

L502120nH06032%

L502120nH06032%

12

R729.4K04021%

R729.4K04021%

A 1

K 2

J2

FPC/FFC-1MM-2P/NAPHILIPS9360-304-XXXX

J2

FPC/FFC-1MM-2P/NAPHILIPS9360-304-XXXX

1 2JS1

SHORT-SMT2

JS1

SHORT-SMT2

12

R6868004025%

R6868004025%

AK

D503BB202

SO

D523

D503BB202

SO

D523

12

R501100K04021%

R501100K04021%

12

L8022700/100M0805C

L8022700/100M0805C

1 2R3 100K

0402

R3 100K

0402

MiTac Secret

Confidentia

l Docum

ent

9.0 REVISION LIST

Version 1.0 (3141 785 30700)

• Initial release HDD1420/HDD1620/HDD1630/DD1635 Version 1.1 (3141 785 30701) Chapter 5 – Service part list revised service 12NC as listed below

• Added the new part cradle assy for HDD1635/17 (994000003791)

Service Manual hdd14xx hdd16xx 1 0 - Rockbox · root directory of the device. (CD ROM with the...

Documents

Transcript of Service Manual hdd14xx hdd16xx 1 0 - Rockbox · root directory of the device. (CD ROM with the...