SERVICE MANUAL AIR CONDITIONER SPLIT · PDF fileSERVICE MANUAL AIR CONDITIONER SPLIT TYPE 2...
Transcript of SERVICE MANUAL AIR CONDITIONER SPLIT · PDF fileSERVICE MANUAL AIR CONDITIONER SPLIT TYPE 2...
FILE No. A90-9611
SERVICE MANUAL
AIR CONDITIONER SPLIT TYPE
2 WAY CASSETTE TYPE, HEATPUMPRAV-103TUH-PERAV-133TUH-PE/RAV-132AH-PERAV-163TUH-PE/RAV-162AH-PE
Printed in UK Dec 1996 s
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-2-
• Operating conditions of units are as follows:
Note 1 : Cooling Capacity is based on the following temperature conditions:Indoor air inlet temperature 27°C DB, 19°C WB.Outdoor air inlet temperature 35°C DB.
Note 2: Heating Capacity is based on the following temperature conditions:Indoor air inlet temperature 20°C DB.Outdoor air inlet temperature 7°C DB, 6°C WB.
Note 3: For details on the Remote Controller and Control Circuitsrefer to Service Manual A90-9503.
OUTDOOR TEMPERATURE -2 TO 43°C (COOL)
-10 TO 21°C (HEAT)
ROOM TEMPERATURE 18 TO 32°C (COOL)
15 TO 29°C (HEAT)
ROOM HUMIDITY LESS THAN 80% (COOL)
CONTENTS
1. SPECIFICATION....................................................................................................................................................3
2. CONSTRUCTION VIEWS......................................................................................................................................6
3. WIRING DIAGRAM................................................................................................................................................8
4. SPECIFICATIONS OF ELECTRICAL PARTS........................................................................................................10
5. INTERFACE PCB.................................................................................................................................................12
6. REFRIGERANT PIPING DIAGRAM......................................................................................................................13
7. PERFORMANCE CHARACTER............................................................................................................................15
8. EXPLODED VIEWS AND PARTS LISTS...............................................................................................................17
SUMMARY
• The units referred to within this manual conform with the protection requirements of Directives 89/336/EECElectromagnetic Compatibility and 73/23/EEC Low Voltage.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-3-
MODEL
Power source
ITEM
Starting current
Power consumption
Running current
Power factor
Operating noise (SPL) (High, Med, Low)
Refrigerant
Phase
Hz
V
kW
%
A
A
dB(A)
Name of refrigerant
Interconnectionpipe
Larger side size
Coupler style
Smaller side size
Coupler style
mm
mm
Condensate drain pipe diameter
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Appearance colour
CEILING PANEL Model
Height
Width
Depth
mm
mm
mm
kg
m3/h
Net weight
Height
Depth
mm
mm
mm
kg
Dimensions Width
Air filter
Specifications are subject to change without notice.
RAV-103TUH-PE
1
220-240
50
0.07
93
0.33
0.6
R-22
Ø12.7
Flare
Ø6.4
Flare
Ø25.5(OD)mm
Grey (zinc galvanized steel+ Thermal insulator)
RBC-U133PG(W)-PE
Silky white (Munsell 2.9Y8.9/0.8)
25
1050
550
4.5
Washable
Finned tube
Transverse flow fan
550
7 x 2
190
910
480
23
W
40/36/34
1.SPECIFICATION
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-4-
MODELITEM RAV-133TUH-PE
3.6kW
kW 4.2Heating capacity
Cooling capacity
1
50
HEATINGCOOLING
2.1 2.2
Power source
Power consumption
Power factor 89 89
Running current 10.3 10.7
Starting current
Operating noise (SPL)
Refrigerant
60
40/36/34
R-22
1.235
Refrigerant control
Interconnection pipe
Ø12.7
Flare
Ø 6.4
Flare7.5
Hz
Phase
kW
%
A
A
dB(A)dB(A)
kg
g/m
mm
m
Indoor unit (High, Med, Low)
Outdoor unit
Name of refrigerant
Charge volume
Add. volume (20-30m)
Larger side size
Coupler style
Smaller side size
Coupler styleStandard length
Maximum length(of one way) *1 m
30
If indoor unit higher m 15
If outdoor unit higher m 30
Condensate drain pipe diameter mmINDOOR UNIT Model RAV-133TUH-PE
Appearance colour Grey (zinc galvanized steel + thermal insulator)
Capillary tube & Expansion valve
50
Dimensions
Height mm 190
910Width mm
Depth mm 480
Net weight kg 23
Heat exchanger type Finned tubeIndoor fan type Transverse flow fan
Air volume m3/h 700Fan motor output W 7 x 2Air filter Washable
OUTDOOR UNIT Model RAV-132AH-PEAppearance colour Bronze white (Munsell 6Y7.5/1)
Dimensions Width mm
Depth mm
Height mm 740
880
310
Net weight kg 61
Ø 25.5 (OD)
Outdoor fan type Propeller fan
Air flow volume m3/h 2,700
Fan motor output W 39
PH230X3-4LSCompressor
Model
1.5
Protective device High pressure switch, Fuse, Crankcase heater, Overload relay, Bimetal thermostat
mm
220-240
Finned tube
Appearance colour Silky white (Munsell 2.9Y8.9/0.8)
Dimensions Width mm
Depth mm
Height mm 25
1050
550
Net weight kg 4.5
Washable
CEILING PANEL Model
Air filter
Specifications are subject to change without notice.
* Note 1 : These mean actual length.
RBC-U133PG(W)-PE
Heat exchanger type
Output kW
V
Maximum height difference
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-5-
ITEM MODEL
Cooling capacity kW
kW
4.5
5.0
Power source V
50
Power consumption kW
Power factor %
Running current A
Starting current
Operatingnoise (SPL)
Indoor unit (high/med/low) 41/37/35
50
R-22
35
Outdoor unit
Refrigerant
Name of refrigerant
Charge volume kg
Add. volume (20-30m) g/m
Capillary tube & Expansion valve
Interconnectionpipe
Larger side size mm ø 12.7
Flare
mm ø 6.4
Coupler style FlareStandard length m 7.5
Maximum length(of one way) *1 m 30
15m
m 30
Condensate drain pipe diameter ø 25.5(OD)
RAV-163TUH-PE
Appearance colour Grey (zinc galvanized steel + thermal insulator)
Dimensions
Height
mm
mm 190
Width mm 910
Depth mm 480
Net weight kg 23Heat exchanger type Finned tube
Transverse flow fan
750
Fan motor output 7 x 2
Air filter
Refrigerant control
880
310
61Finned tubePropeller fan
2,700
39
Dimensions
Height mm
Width mm
Depth mm
Heat exchanger type
Net weight
Outdoor fan type
Air flow volume
Fan motor output
CompressorModel
Output
A
kg
m3/h
kW
W
Hz
Bronze white (Munsell 6Y7.5/1)
740
INDOOR UNIT Model
Heating capacity
Smaller side size
Coupler style
Phase
Indoor fan typeAir volume
OUTDOOR UNIT Model
Appearance colour
W
m3/h
Washable
1.6
RAV-163TUH-PE
1
220-240
COOLING
90
11.1
2.3
HEATING2.2
90
10.6
60
RAV-162AH-PE
PH250X3-4LS
1.5
Protective device
CEILING PANEL Model
Appearance colour
Dimensions Height
Width
Depth
mm
mm
mm
Net weight
Air filter
Specifications are subject to change without notice.
* Note 1 : These mean actual length.
High pressure switch, Fuse, Crankcase heater, Overload relay, Bimetal thermostat
RBC-U133PG(W)-PE
Silky white (Munsell 2.9Y8.9/0.8)
25
550
Washable
4.5
1050
If outdoor unit higher
If indoor unit higher
Maximum height difference
kg
dB (A)
dB (A)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-6-
2. CONSTRUCTION VIEWS
2.1 Indoor unitRAV-103TUH-PERAV-133TUH-PERAV-163TUH-PE
Spa
ce r
equi
red
for
serv
ice
and
inst
alla
tion
(Unit: mm)
550
Vie
w A
20
0
Ceiling opening 510
Panel outer dimension 550
Hang bolt pitch 480
41020 40
40
Han
g bo
lt pi
tch
930
Cei
ling
open
ing
1010
Pan
el o
uter
dim
ensi
on 1
050
73
131
96
186
26
717
0
156
140
190
1050
84
013
04
80
190Lo
ng h
ole
Re
mo
te c
on
tro
ller
60
0
Min
imum
Min
imum
60
0
Min
imum
70
70R
efrig
eran
t pi
ping
joi
nt
(
Gas
∅ 1
2.7)
Wiri
ng c
onne
ctio
n
84
011
0
90
66
20
40
60
29
0
Han
ger
bolt
(4-
M10
)R
efrig
eran
t pi
ping
joi
nt
( L
iqui
d ∅
6.4
)
256
00
A
12.5
83.5
2-4.
5 x
9L 120
Dra
in p
ipe
join
t
(out
er ∅
25.
5)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-7-
2.2 Outdoor unitRAV-132AH-PERAV-162AH-PE
(2-(20 x 60) slots)
Hole for drain
(2-ø19 hole)
(Liquid side ∅ 6.4)
(Gas side ∅ 12.7)Refrigerant piping joint
Anchor bolt hole
Blow out guidemounting hole
(4-ø3 embosses)
(Space for wiringand piping)
Outlet
(Space for wiringand piping)
Space required for service
When installed with theoutlet faced to the wall side
When installed with theinlet faced to the wall side
(Unit: mm)
(4-(12x18)slots) Air outlet
(Both sides)
Carrying handleElectric partsbox Terminal cover
Refrigerant piping joint
Knock - out hole for drain
Earth screw (M6)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-8-
S
how
s te
rmin
al b
lock
and
figu
res
show
term
inal
num
bers
.
Bro
ken
lines
sho
w w
iring
at s
ite.
Do
not o
pera
te th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
Sym
bol
Nam
e
S
ymbo
l
N
ame
FM
Fan
mot
or
43
Rel
ay
RC
R
unni
ng c
apac
itor
RY
01~
RY
14 R
elay
T
R
T
rans
form
er
S
M01
,02
S
tepp
er m
otor
TA
Sen
sor
C
S
Flo
at s
witc
h
T
C
S
enso
r
DM
D
rain
mot
or
F
Fus
e (P
CB
)
F3
Fus
e (I
nter
face
PC
B)
3.1 RAV-103TUH-PE RAV-133TUH-PE RAV-163TUH-PE
(
)R
Y01
outp
ut
Ear
thS
crew
F2
Indo
or u
nit
Out
door
uni
t (1 P
hase
mod
el)
Rem
ote
Con
trol
ler
CS
43C
N10
(PU
MP
)
TR
RY
01
RY
14
CN
01(T
RA
NS
)
CN
12
RE
MO
CO
N
UL
L
M
H
TA
CN
04(T
A)
CN
05(T
C)
CN
07(F
AN
)T
C
RY
11
WHI
FM
CN
09(L
OU
VE
R)
(L1)
(N) CN
03(S
ER
IAL)
CN
11(F
LOAT
)
43
DM
FP
ower
Sup
ply
220/
240V
5
0Hz
Spa
rkK
iller
FM 01
02
BLU
BLU
OR
N
WHI
RED
RC02
RC01
SM
SM01 02
TR
INT
ER
FAC
EP
CB
3. WIRING DIAGRAM
OR
NB
LKB
LK
RE
DWH
IW
HI
YEL
YELRED
YEL
BLU
OR
N B
LK
RE
D
F3
RY
04
RY
03
RY
02
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-9-
TR
3.2 RAV-132AH-PE RAV-162AH-PE
Power Supply 220/240V 50HzCH
EarthScrew
Earth
RY07
F
1. Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Don't operate the units with magnetic contactor pushed.
CMRCC52C
TE
TL
BLK
TD
BLK
WHI
63H
52C
F2
Indoor unit
Outdoor unit
26HD
WaveControlCircuit
20SR20SF
Symbol Name Symbo Name Symbol Name
20SF Solenoid Coil (4 Way Valve) CM Compressor F2 Fuse (T5A)
RY05, 07 Relay 52C Magnetic Contactor 63H High Pressure Switch
51C Overload Relay FMo Fan Motor (Out door) CH Crank Case Heater
20SR Solenoid Coil (2 Way Valve) TL Sensor F Fuse (on PCB)
RCc Running Capacitor (Compressor) TE Sensor TR Transformer
RCo Running Capacitor (Fan motor) 26HD Bimetal Thermostat TD Sensor
WHI FM0
RED
BLK
RED
BLU
BLK WHI WHI
RY05
RED
GRY
RED
RCO
51C
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-10-
4.2. RAV-163TUH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor (x2) PAF-230-7-4 Output (Rated) 7W, 4 pole, 1 phase, 230V, 50Hz
2Running capacitor forindoor fan motor (x2)
EVM45M504UF AC 450V, 0.5µF
3 Transformer (Indoor unit) ST-9586 AC187~264V
4 Stepper motor (x2) MP35EA2 DC12V, 80mNm
5 Relay LY2F AC 240V, 2ab
6 Drain pump PCD-4N230TF-7 AC230V, 0.2A
7 Float switch FS-085-003E AC230V, 0.5A
8Sensor for roomtemperature
Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
9Indoor unit sensor forheat- exchangertemperature.
DTN-C103J40Maximum input34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.1 RAV-103TUH-PE, RAV-133TUH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor (x2) PAF-230-7-4 Output (Rated) 7W, 4 pole, 1 phase, 230V, 50Hz
2Running capacitor for indoorfan motor (x2)
EEP2H105HQA105 AC 500V, 1.0µF
3 Transformer (Indoor unit) ST-9586 AC187~264V
4 Stepper motor (x2) MP35EA2 DC12V, 80mNm
5 Relay LY2F AC 240V, 2ab
6 Drain pump PCD-4N230TF-7 AC230V, 0.2A
7 Float switch FS-085-003E AC230V, 0.5A
8 Sensor for room temperatureMaximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
9Indoor unit sensor for heat-exchanger temperature.
DTN-C103J40Maximum input34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
KΩ
KΩ
KΩ
4. SPECIFICATION OF ELECTRICAL PARTS
KΩ
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-11-
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor PH250X3-4LS Output (Rated) 1.5 kW, 2 pole, 220/240V, 1 phase, 50Hz
2 Outdoor unit fan motor SMF-230-39N-2 Output (Rated) 39W, 6 pole, 230V, 1 phase, 50Hz
3Running capacitor for outdoorfan motor
EEP2G405HQA114 AC 400V, 4 µF
4 Magnetic contactor FMca-1S AC 220-240V, 50Hz
5 High pressure switch ACB-2TBO4WTripping pressure 30kg/cm²GResetting pressure 23kg/cm²G
6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V
7 Crankcase heater AC 240V, 28W
8 Sensor for defrostingMaximum input15.5mA
°C –12 10
67.5 21.3
9 Fuse T5A
10Sensor for cooling operation in lowambient temperature
Maximum input15.5mA
°C –12 10
67.5 21.3
11 Solenoid coil for two-way valve NEV AC 240V AC 220-240V, 50Hz
12 Running capacitor for compressor MT-44MP456W AC 440V 45µF
13Transformer(Outdoor unit)
FT-67 AC 187-264V
14 Overload relay OL-177GM15 AC 240V, Tripping temp: 165°C, Resetting temp: 80°C
15 Bimetal thermostat CS-7 Tripping temp: 110°C, Resetting temp 90°C
4.3 RAV-132AH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor PH230X3-4LS Output (Rated) 1.5 kW, 2 pole, 220/240V, 1 phase, 50Hz
2 Outdoor unit fan motor SMF-230-39N-2 Output (Rated) 39W, 6 pole, 230V, 1 phase, 50Hz
3Running capacitor for outdoorfan motor
EEP2G405HQA114 AC 400V, 4 µF
4 Magnetic contactor FMca-1S AC 220-240V, 50Hz
5 High pressure switch ACB-2TBO4WTripping pressure 30kg/cm²GResetting pressure 23kg/cm²G
6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V
7 Crankcase heater AC 240V, 28W
8 Sensor for defrostingMaximum input15.5mA
°C –12 10
67.5 21.3
9 Fuse T5A
10Sensor for cooling operation in lowambient temperature
Maximum input15.5mA
°C –12 10
67.5 21.3
11 Solenoid coil for two-way valve NEV AC 240V AC 220-240V, 50Hz
12 Running capacitor for compressor MT-44MP456W AC 440V 45µF
13Transformer(Outdoor unit)
FT-67 AC 187-264V
14 Overload relay OL-177GM15 AC 240V, Tripping temp: 165°C, Resetting temp: 80°C
15 Bimetal thermostat CS-7 Tripping temp: 110°C, Resetting temp 90°C
KΩ
KΩ
4.4 RAV-162AH-PE
KΩ
KΩ
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-12-
5. INTERFACE PCB FOR LOUVER OPERATION
An additional PCB, referred to as the Interface PCB, is fitted to this unit to operate the dc stepper motors,which drive the louvers. The power supply to the interface PCB is via relay RY11 on the indoor PCB.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-13-
Cooling
Heating
6. REFRIGERANT PIPING DIAGRAM
Refrigerant pipe (Smaller side)ø6.4mm (1/4")
Strainer
Heat exchanger
Indoor unit
Distributor strainercapillary tubeIDø1.5 x 300 l x 2P
Refrigerant pipe (Larger side)ø12.7mm (1/2")
6.1 Indoor unitRAV-103TUH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-14-
Cooling
Heating
Packed valvePacked valve
Strainer
Capillary tubeø2.4 x 500L x 1P
Check valve
Refrigerant pipe (Smaller side)ø6.4mm (1/4")
Strainer
Heat exchanger
Indoor unit
Distributor
Strainer
Refrigerant pipe (Larger side)ø12.7mm (1/2")
6.2 Indoor unitRAV-133TUH-PERAV-163TUH-PE
Distributor strainercapillary tube
Low pressure High pressure
P1
P2
Cooling HeatingHigh pressure Low pressure
Line Pressure
RAV-133TUH-PRAV-163TUH-P
IDφ 2.2x200 L x2PIDφ 1.5x200 L x2P
RAV-132AH-PERAV-162AH-PE
BYPASSCAPILLARY
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAINCAPILLARY
IDφ 2.4x500 L x1P IDφ 0.8x1000 L x1P
CompressorAccumulator
2-wayvalve
Expansionvalve
Dryer
Check jointTE sensor
TL sensor Heat exchanger
Four-way valve
High pressure switch
Outdoor unit
Bypass Capillary tubeø0.8 x 1000L x 1P
Outdoor unitRAV-132AH-PERAV-162AH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-15-
Am
bien
t Tem
p. (
Dry
Bul
b) (
o C)
Capacity Ratio (%)
Am
bien
t Tem
p. (
Wet
Bul
b) (
o C)
Room Temp. (Wet Bulb) (oC)
Room Temp. (Dry Bulb) (oC)
7. PERFORMANCE CHARACTER
7.1 Cooling capacity
7.2 Heating capacity
-2 ~
Capacity Ratio (%)
RAV-132AH-PE
2.883.063.243.423.603.783.964.144.32
RAV-162AH-PE
3.603.824.054.284.504.734.955.185.40
RAV-132AH-PE
5.044.834.624.414.203.993.783.573.363.152.942.732.522.31
RAV-162AH-PE
6.005.755.505.255.004.754.504.254.003.753.503.253.002.75
(KW)
(KW)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-16-
7.3 Cooling capacityRAV-132AH-PERAV-162AH-PE
Indoor Unit
Outdoor Unit
Heating Capacity Ratio
Piping Length (m)
Cooling Capacity Ratio
Piping Length (m)
Out
door
Uni
t Hei
ght H
(m
)
Out
door
Uni
t Hei
ght H
(m
)
7.4 Piping length/additional refrigerant volume
45 5
0.95
Recharge quantity (kg)
30
1.55
25
1.35
Additional amount of refrigerantat installation site (kg)
40 50 20
1.20
20
Filled atfactory
Piping lengthless than (m)
Model
3030
RAV-132AH-PE
l The amount of refrigerant put into the outdoor unit at the factory is equivalent to that which fills up 20m length of refrigerant pipe.
l If the length of refrigerant pipe is 20m or less, addition of refrigerant at the installation site is unnecessary. If the length of the pipeexceeds 20m, add the refrigerant R-22.
l Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction of the compressor. The prescribed amount ofthe replenishment of the refrigerant is shown in the table above.The permissible amount of refrigerant is the prescribed amount ±50g.
Filled atfactory
RAV-162AH-PE
3530
0.35
25
0.15
0.15 0.35
10
1.05
15
1.10
1.35 1.45 1.50 1.60 1.75 1.95
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
LocationPart No Description
No
214 43039240 Canoe Clip
215 43A72001 Drain Pan
216 43A88004 Manual
217 43155086 Spark Killer
218 43A69008 Interface PC Board
219 37555721 Capacitor, Metal Film (RAV-103/133TUH-PE)
219 43155100 Capacitor, Metal Film (RAV-163TUH-PE)
220 43A69002 PC Board
221 43A58002 Transformer
222 43154141 Relay
223 43A62001 Cover, Remote Controller
224 43A69004 Remote Controller
225 43A50002 Sensor (TC)
226 43150118 Sensor (TA)
-17-
LocationPart No Description
No
201 43A22001 Casing Assembly
202 43020288 Fan
203 43151217 Float Switch
204 43A70003 Pump Assembly
205 43020253 Bearing
206 43071019 Drain Connection
207 43070164 Drain Hose
208 43A60002 3 P Terminal
209 43A60001 4 P Terminal
210 43A21014 Fan Motor
211 43019604 Sensor Fix Plate
212 43A22002 Casing Outlet
213 43A44012 Heat Exchanger (RAV-103TUH-PE)
213 43A44010 Heat Exchanger (RAV-133TUH-PE)
213 43A44011 Heat Exchanger (RAV-163TUH-PE)
8. EXPLODED VIEWS AND PARTS LIST
8.1 Indoor unitRAV-103TUH-PERAV-133TUH-PERAV-163TUH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-18-
8.2 CEILING PANELRBC-U133PG(W)-PE
Location Part Description number Number
1 43080392 Filter2 43007108 Plate connect (long)3 43009504 ASM-Grille-Out4 43007107 Bushing5 43007109 Plate connect (short)
Location Part Description number Number
6 43009503 Grille-L-R7 43007124 Support plate8 43009499 ASM-Grille-Out9 43A26001 ASM-Motor
10 43007125 Support plate
1
1
3
10
54
7
6
47
9
55
2
2
74
28
2
8
4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-19-
8.3 Outdoor unitRAV-132AH-PERAV-162AH-PE
LocationNo.
Part No. Description
25 43041837 Compressor, AC220/240V,
50Hz, PH230X3-4LS (RAV-132AH-PE)
25 43041845 Compressor, AC220/240V,
50Hz, PH250X3-4LS (RAV-162AH-PE)26 43146454 Packed Valve (1/4")
27 43146406 Packed Valve (1/2")
28 43147321 Check Joint
29 43146424 Expansion Valve
30 43046198 Coil, 2-Way Valve
31 43146283 1-Way Valve
33 43A58003 Transformer, Power
34 43046151 Valve, 2-Way
35 43193043 Spring
36 43A50001 Sensor, Cond. Out (TL)
37 43150196 Sensor, Heat Exch. (TE)
38 43146418 Valve 4-Way
39 43157167 Heater, Crankcase
41 43146459 Capillary Tube
42 44246235 Capillary Tube
43 43150122 Thermostat, Bimetal
44 43107215 Holder, Sensor (TL)
LocationNo.
Part No. Description
1 43120156 Fan, Propeller2 43A21003 Motor, Fan, AC230V, 50Hz
3 43A43001 Condenser
4 43149212 Base, Spring, A
5 43149198 Spring, Buffer
6 43049132 Base, Spring, B
7 43A69003 PC Board
8 43A49001 Switch, High-Pressure
9 43060479 Terminal, 4P
10 43A60003 Terminal, 2P
11 43A60001 Terminal, 4P
12 43152334 Magnetic Contactor
13 43054286 Relay, Overload
14 43A19001 Guard, Fan
15 43119368 Hanger
16 43A46004 Solenoid Coil
17 43162027 Cover, Electric Parts
18 43155115 Capacitor, Plastic Film, 45MFD, 440V
20 43107215 Holder, Sensor (TE)
22 43148105 Accumulator
23 43145082 Dryer
24 43155080 Capacitor, Electrolytic
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-1-
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807