MED

MED

2

MED

COMPONENTS

3

MED

ENGINE CON SYS

4

AIR INTAKE

ENGINE

MED

LAYOUT

5

MED

COMPONENTS

ECU32-bit CPU which optimally controls the actuators to suit the operating conditions of the engine in accordance with the signals provided by the sensors.

6

ChassisAut o TXSensor sAct uat or s

MED

COMPONENTS

DLC3 Connector16 pin DLC 3 connector is there for connection of diagnostic kit e.g. launch, Carman, JBT etc. for diagnosis.

MIL Blinking may also be used for diagnosis by connecting 13 and 4 number pin of DLC Connector

7

Aut o TX

MED

COMPONENTSCrankshaft Position SensorIt is a pickup coil type sensor which detects the engine speed and performs the cylinder identification

Camshaft Position Sensor It is a pickup coil type sensor which performs the cylinder identification and camshaft’s position

8

MED

COMPONENTSKnock Sensor It is a non-resonant flat type sensor which detects an occurrence of the engine knocking indirectly from the vibration of the cylinder block caused by the occurrence of engine knocking

Throttle Position Sensor It is a non-contact type sensor mounted on the throttle body to detect the opening angle of the throttle valve

9

MED

COMPONENTSEngine Coolant Temp SensorIt is a thermistor type sensor which detects the engine coolant temp

Mass Air Flow sensorIt is a Hot-wire Type sensor having a built-in hot-wire to directly detect the intake air mass and temp

10

MED

COMPONENTSAir Fuel Ratio Sensor (1st Oxygen)It is a Planar type with Heater sensor to detects the oxygen concentration in the exhaust emission. However, it detects the oxygen concentration in the exhaust emission linearly before catalytic convertor

2nd Oxygen sensorIt is a Cup Type with Heater to detect the oxygen concentration in the

exhaust emission by measuring the electromotive force which is generated in the sensor itself.

11

MED

COMPONENTSInjectorsFuel injector opens and sprays the pressurized fuel into the engine. The duration that the injector is open (called the pulse width) is proportional to the amount of fuel delivered.

Each cylinder is having separate fuel injector

12

MED

COMPONENTSIgnition CoilsA DIS (Direct Ignition System) is used in which one ignition coil for each cylinder. The DIS ensures the ignition timing accuracy, reduces high-voltage loss, and realizes the overall reliability of the ignition system by eliminating the distributor

Spark PlugsLong-reach type iridium-tipped spark plugs are used. Spark plug caps, which connect to the spark plugs, are integrated with the ignition coils for air fuel mixture combustion

13

MED

COMPONENTSIdle Speed Con ValveIt is placed on throttle body to sense and set engine idle speed. Cold engine with more idling and once engine comes to normal operating temperature idling at low RPM is set by ISC valve

14

MED

IGNITION

15

MED

THANK YOU

16