Rg 550 Service Manual

1

Ver 1.0 2003. 06

Model Name Using Similar Mechanism NEW

CD CD Mechanism Type CDM74F-K6BD71B

Section Base Unit Name BU-K6BD71B

Optical Pick-up Name KSS-213DCP

Tape Deck Model Name Using Similar Machanism CX-JT8

Section Tape Transport Mechanism Type CWM43RR-23

SERVICE MANUAL AEP ModelUK Model

E Model

HCD-RG550/RG660

Amplifier sectionEuropean model:HCD-RG660:Front speakerDIN power output (rated):

160 + 160 watts(6 ohms at 1 kHz, DIN)

Continuous RMS power output (reference):200 + 200 watts (6 ohms at1 kHz, 10% THD)

Music power output (reference):400 + 400 watts (6 ohms at1 kHz, 10% THD)

Other models:HCD-RG660:The following measured at AC 120, 127, 220, 240 V,50/60 HzDIN power output (rated):



HCD-RG550:The following measured at AC 120, 127, 220, 240 V,50/60 HzDIN power output (rated):



SPECIFICATIONS

InputsMD (VIDEO) IN L/R (phono jacks):

voltage 450/250 mV,impedance 47 kilohms

GAME INPUT AUDIO L/R (phono jacks):voltage 250 mV,impedance 47 kilohms

GAME INPUT VIDEO (phono jack):1 Vp-p, 75 ohms

MIC (phone jack) (except for European model):sensitivity 1 mV,impedance 10 kilohms

OutputsPHONES (stereo mini jack):

accepts headphones of8 ohms or more

VIDEO OUT (phono jack):max. output level1 Vp-p, unbalanced, Syncnegative, load impedance75 ohms

SPEAKER: accepts impedance of 6 to16 ohms

SURROUND SPEAKER (HCD-RG660 only):accepts impedance of 24ohms

Sony CorporationHome Audio Company

Published by Sony Engineering Corporation

9-961-000-012003F04-1

© 2003. 06

– Continued on next page –

COMPACT DISC DECK RECEIVER

• HCD-RG550/RG660 is thetuner, deck, CD and amplifiersection in MHC-RG550/RG660. (Photo: HCD-RG550)

2

HCD-RG550/RG660

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

CD player sectionSystem Compact disc and digital

audio systemLaser Semiconductor laser

(λ=780 nm)Emission duration:continuous

Frequency response 2 Hz – 20 kHz (±0.5 dB)Wavelength 780 – 790 nmSignal-to-noise ratio More than 90 dBDynamic range More than 90 dBCD OPTICAL DIGITAL OUT(square optical connector jack, rear panel)Wavelength 660 nmOutput –18 dBm

Tape deck sectionRecording system 4-track 2-channel stereoFrequency response 50 – 13,000 Hz (±3 dB),

using Sony TYPE Icassettes

Wow and flutter ±0.15% W.Peak (IEC)0.1% W.RMS (NAB)±0.2% W.Peak (DIN)

Tuner sectionFM stereo, FM/AM superheterodyne tuner

FM tuner sectionTuning range 87.5 – 108.0 MHzAntenna FM lead antennaAntenna terminals 75 ohms unbalancedIntermediate frequency 10.7 MHz

AM tuner sectionTuning rangeLatin American model: 530 – 1,710 kHz (with the tuning

interval set at 10 kHz)531 – 1,710 kHz (with the tuninginterval set at 10 kHz)

European, Middle Eastern and Philippine models:531 – 1,602 kHz (with the tuninginterval set at 9 kHz)

Other models: 530 – 1,710 kHz (with the tuninginterval set at 10 kHz)531 – 1,602 kHz (with the tuninginterval set at 9 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz

SpeakerFront speaker SS-RG665 for HCD-RG660/RG550:Speaker system 3-way, 3-unit, bass-reflex

typeSpeaker unitsSub Woofer: 15 cm, cone typeWoofer: 15 cm, cone typeTweeter: 5 cm, cone typeNominal impedance 6 ohmsDimensions (w/h/d) Approx. 240 × 363 × 290 mmMass Approx. 4.7 kg net per

speaker

Surround speaker SS-RS660 for HCD-RG660:Speaker system 3-way, 3-unit, bass-reflex

typeSpeaker unitsWoofer: 13 cm, cone typeTweeter: 5 cm, cone typeSuper tweeter: 2 cm, dome typeNominal impedance 24 ohmsDimensions (w/h/d) Approx. 195 × 325 × 225 mmMass Approx. 2.3 kg net per

speaker

GeneralPower requirementsEuropean model: 230 V AC, 50/60 HzArgentine model: 220 V AC, 50/60 HzMexican model: 127 V AC, 60 HzSaudi Arabian model: 120 – 127 V/220 V or

230 – 240 V AC,50/60 HzAdjustable with voltageselector

Other models: 120 V, 220 V or 230 –240 V AC, 50/60 HzAdjustable with voltageselector

Power consumptionEuropean model:HCD-RG660: 190 watts

0.35 watts (at the PowerSaving Mode)

Other models:HCD-RG660: 190 wattsHCD-RG550: 135 watts

Dimensions (w/h/d) Approx. 280 × 325 × 407 mm

MassEuropean model:HCD-RG660: Approx. 10.0 kgOther models:HCD-RG660: Approx. 11.0 kgHCD-RG550: Approx. 9.0 kg

Supplied accessories: AM loop antenna (1)Remote Commander (1)Batteries (2)FM lead antenna (1)Speaker pads HCD-RG660 (16) HCD-RG550 (8)

Design and specifications are subject to change withoutnotice.

3

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardousradiation exposure.

HCD-RG550/RG660

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNIT

The laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.

Laser component in this product is capableof emitting radiation exceeding the limit forClass 1.

Notes on Chip Component Replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of soldering iron around 270°C during

repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

MODEL IDENTIFICATION

– BACK PANEL –

MODEL PARTS No.

RG550: E2, E3, E51 4-247-996-01

RG550: MX 4-247-996-11

RG660: E3 4-247-996-21

RG660: AEP, UK 4-247-996-31

• AbbreviationE2 : 120 V AC area in E modelE3 : 240 V AC area in E modelE51 : 220 V AC area in E modelMX : Mexican model

SETTING AND RELEASING THE CD DISC TRAY LOCKFUNCTIONThis set has a disc tray lock function to prevent discs fordemonstration at shops from theft. While this lock function is set,the tray will not be delivered out even when the OPEN/CLOSEbutton is pressed.

Setting method:Press the OPEN/CLOSE button while pressing the STOP button.After a few seconds, the message “LOCKED” will appear on thefluorescent indicator tube with the tray locked.

Releasing method:Just as the lock is set, press the OPEN/CLOSE button whilepressing the STOP button.After a few seconds, the message “UNLOCKED” will appear withthe lock released.

PARTS No.

LASER DIODE AND FOCUS SEARCH OPERATIONCHECKCarry out the “S curve check” in “CD section adjustment” and checkthat the S curve waveforms is output three times.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARKUnleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40 °C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set to about350 °C.Caution: The printed pattern (copper foil) may peel away if the

heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow) thanordinary solder so use caution not to let solder bridges occur suchas on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder may alsobe added to ordinary solder.

4

TABLE OF CONTENTS

HCD-RG550/RG660

1. GENERALMain Unit ................................................................................ 5Remote Control ....................................................................... 5

2. DISASSEMBLY2-1. Case (Top) ........................................................................... 72-2. CD Door .............................................................................. 72-3. CD Mechanism Block ......................................................... 82-4. Front Panel Section ............................................................. 92-5. Tape Mechanism Deck ...................................................... 102-6. Panel Board, 6 Stream Led Board, Remote Board ............ 102-7. Jack Board ......................................................................... 112-8. Back Panel Section ............................................................ 112-9. Main Board ....................................................................... 122-10. Power Amp Board ............................................................. 122-11. SW Board, Driver Board ................................................... 132-12. CD Block Assy .................................................................. 132-13. Sensor Board ..................................................................... 142-14. Motor (TB) Board ............................................................. 142-15. Motor (LD) Board ............................................................. 152-16. BD Board .......................................................................... 152-17. Optical Pick-up ................................................................. 16

3. TEST MODE ..................................................................... 17

4. ELECTRICAL ADJUSTMENTS ................................. 20

5. DIAGRAMS5-1. IC Pin Descriptions ........................................................... 215-2. Block Diagram –CD Section– ........................................... 255-3. Block Diagram –Tuner/Tape/Panel Section– .................... 265-4. Block Diagram –Amp/Power Supply Section– ................. 275-5. Circuit Boards Location .................................................... 285-6. Note for Printed Wiring Boards

and Schematic Diagrams .................................................. 295-7. Waveforms ......................................................................... 295-8. Printed Wiring Board –CD Mechanism Section (1/2)– .... 305-9. Schematic Diagram –CD Mechanism Section (1/2)– ....... 315-10. Printed Wiring Boards –CD Mechanism Section (2/2)– ... 325-11. Schematic Diagram –CD Mechanism Section (2/2)– ....... 335-12. Schematic Diagram –Main Section (1/4)– ........................ 345-13. Schematic Diagram –Main Section (2/4)– ........................ 355-14. Schematic Diagram –Main Section (3/4)– ........................ 365-15. Schematic Diagram –Main Section (4/4)– ........................ 375-16. Printed Wiring Board –Main Section– .............................. 385-17. Printed Wiring Boards –Panel Section– ............................ 395-18. Schematic Diagram –Panel Section– ................................ 405-19. Printed Wiring Boards –Jack Section– .............................. 415-20. Schematic Diagram –Jack Section– .................................. 425-21. Printed Wiring Board –Power Amp Section– ................... 435-22. Schematic Diagram –Power Amp Section (1/2)– ............. 445-23. Schematic Diagram –Power Amp Section (2/2)– ............. 455-24. Printed Wiring Board

–Transformer Section (HCD-RG550)– ............................. 465-25. Printed Wiring Board

–Transformer Section (HCD-RG660)– ............................. 475-26. Schematic Diagram –Transformer Section– ..................... 485-27. IC Block Diagrams ............................................................ 49

6. EXPLODED VIEWS6-1. Main Section ..................................................................... 526-2. Front Panel Section (1) ...................................................... 536-3. Front Panel Section (2) ...................................................... 546-4. Front Panel Section (3) ...................................................... 556-5. Main Board Section .......................................................... 566-6. CD Mechanism Deck Section (1) ..................................... 576-7. CD Mechanism Deck Section (2) ..................................... 586-8. Base Unit Section .............................................................. 59

7. ELECTRICAL PARTS LIST ........................................ 60

5

HCD-RG550/RG660SECTION 1GENERAL This section is extracted

from instruction manual.

6

HCD-RG550/RG660SECTION 2

DISASSEMBLY

Note : Disassemble the unit in the order as shown below.

2-1. CASE (TOP)(Page 7)

2-2. CD DOOR(Page 7)

SET

2-3. CD MECHANISM BLOCK(Page 8)

2-8. BACK PANEL SECTION(Page 11)

2-9. MAIN BOARD(Page 12)

2-12. CD BLOCK ASSY(Page 13)

2-16. BD BOARD(Page 15)

2-10. POWER AMP BOARD(Page 12)

2-4. FRONT PANEL SECTION(Page 9)

2-5. TAPE MECHANISM DECK(Page 10)

2-6. PANEL BOARD,6 STREAM LED BOARD,REMOTE BOARD(Page 10)

2-13. SENSOR BOARD(Page 14)

2-14. MOTOR (TB) BOARD(Page 14)

2-15. MOTOR (LD) BOARD(Page 15)

2-11. SW BOARD,DRIVER BOARD(Page 13)

2-7. JACK BOARD(Page 11)

2-17. OPTICAL PICK-UP(Page 16)

7

HCD-RG550/RG660

2-2. CD DOOR

Note : Follow the disassembly procedure in the numerical order given.2-1. CASE (TOP)

case (side-R)

case (side-L)

5

qd

qs

qs

qs

qs

q;

6 two screws (case 3 TP2)

qf case (top)

8 screw (+BVTP 3 × 10)




1 two screws (case 3 TP2)

qa two screws (+BVTP 3 × 10)

7 screw (case 3 TP2)

2 screw (case 3 TP2)

2 Pull-out the disc tray.

4 CD door

1 Turn the pulley to the direction of arrow.

pulley

Front panel side

CD mechanism deck (CDM74F-K6BD71B)

3

8

HCD-RG550/RG660

2-3. CD MECHANISM BLOCK

1 CN701

7 CN312(flat type)

5

6

2 three screws (+BVTP 3 × 10)

8 CD mechanism block



MAIN board

MAIN board

9

HCD-RG550/RG660

2-4. FRONT PANEL SECTION

1 CN003

2 CN304 (flat type)

6 connector

7 connector

4 CN305

5 CN310

3 CN311 (flat type)

TRANS board


qa front panel section



10

HCD-RG550/RG660

2-5. TAPE MECHANISM DECK

2 two screws (+BVTP 2.6 × 8)


3 three screws (+BVTP 2.6 × 8)

5 tape mechanism deck

1 connector

2-6. PANEL BOARD, 6 STREAM LED BOARD, REMOTE BOARD

1 volume knob

7 PANEL board

9 6 STREAM LED board

qa REMOTE board

0 CN607







11

HCD-RG550/RG660

2-8. BACK PANEL SECTION

7 back panel section

chassis section

3 two screws (+BVTT 3 × 8)



1 CN101 (flat type)

2 CN303

6

2-7. JACK BOARD


4 shield plate

6 JACK board

5 two mic knobs



12

HCD-RG550/RG660

2-9. MAIN BOARD

2 MAIN board

1 two screws (+BVTP 3 × 10)

MAIN board

2-10. POWER AMP BOARD

6 POWER AMP board

1 CN902

2 screw (+BVTT 3 × 10)

two claws



3 screw (+BVTT 3 × 10)

13

HCD-RG550/RG660

2-12. CD BLOCK ASSY

qs

5 coil springs (insulator)

0 two coil springs (insulator)

7 two insulators

qa two insulators

8 two screws (+BTTB M2.6)

2 holder (213) assy

9 two stoppers (BU)

qd CD block assy

1 floating screw (+PTPWH M2.6)


4 stopper (BU)

3 screw (+BTTB M2.6)

2-11. SW BOARD, DRIVER BOARD

6 DRIVER board2 SW board

3 CN704

4 CN703

7 CN702 (flat type)

5 two screws (+BTTP (M2.6))

1 screw (+BTTP (M2.6))

14

HCD-RG550/RG660

2-13. SENSOR BOARD

2 tray

3 belt (table)

5 pulley (table)

8 screw (+BTTP (M2.6))

9 SENSOR board

7 gear (geneva)

0 CN731




2-14. MOTOR (TB) BOARD

4 Remove the two solderings of motor.

3 MOTOR (TB) board

5 table motor assy (M741)

claw

claw


1

15

HCD-RG550/RG660

2-16. BD BOARD

4 BD board

5 CN708 (flat type)




2-15. MOTOR (LD) BOARD

4 Remove the two solderings of motor.3 MOTOR (LD) board

1 belt (loading)

5 loading motor assy (M751)


16

HCD-RG550/RG660

2-17. OPTICAL PICK-UP

2 sled shaft

1 Slide the leverin the direction of arrow A.

3 Remove the optical pick-up(KSS-213D) in the directionof arrow B.

A

B

1 gear (A)

17

HCD-RG550/RG660SECTION 3TEST MODE

[COLD RESET]• The cold reset clears all data including preset data stored in the

RAM to initial conditions. Execute this mode when returning theset to the customer.

Procedure:1. Press the [POWER] key to turn the power ON.2. Press three keys of x , [GROOVE] and [POWER] simultaneously.3. The message “COLD RESET” is displayed on the fluorescent

indicator tube momentarily, then becomes standby states.

[TUNER STEP CHANGE-OVER](Except AEP and UK models)• A step of AM channels can be changed over between 9 kHz and

10 kHz.Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [TUNER BAND] key to select “AM”.3. Press the [POWER] key to turn the power OFF.4. Press two keys of [ENTER] and [POWER] simultaneously.5. The message “9K STEP” or “10K STEP” is displayed on the

fluorescent indicator tube, and thus the channel step is changedover.

[CD SHIP MODE]• This mode moves the optical pick-up to the position durable to

vibration. Use this mode when returning the set to the customerafter repair.

Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Press two keys of [CD] and [POWER] simultaneously.4. The message “LOCK” is displayed on the fluorescent indicator

tube, and the CD ship mode is set.

[CHANGE-OVER FUNCTION OF MD/VIDEO]• This mode is used to enable function of external input to change

over between MD and VIDEO.Procedure:1. Set to standby state.2. Press two keys of [MD VIDEO ] and [POWER] simultaneously.3. The message “MD” or “VIDEO” is displayed on the fluorescent

indicator tube, and the function of external input is changedover.

[CD TRAY LOCK MODE]• This mode is used to unable to take sample disc out of tray in the

shop.Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Set disc on the tray.4. While pressing the x key, press the Z key for 5 seconds.5. The message “LOCKED” is displayed on the fluorescent

indicator tube and the tray is locked. (Even if pressingthe Z key, the message “LOCKED” is displayed on thefluorescent indicator tube and the tray is locked)

6. To release from this mode, while pressing the x key, pressthe Z key for 5 seconds.

7. The message “UNLOCKED” is displayed on the fluorescentindicator tube and the tray is unlocked.

[AMP TEST MODE]• This mode is used to set the parameter of AMP IC for adjustment

of tone quality and VACS level and display VACS status.Procedure:1. Press the [POWER] key to turn the power ON.2. Press three keys of x , [GAME EQ] and [EFFECT ON/OFF]

simultaneously.3. When the AMP test mode is activated, the message “AMP

TEST” is displayed on the fluorescent indicator tubemomentarily.

4. Press two keys of [GAME EQ] and [DISC 2] simultaneously, modeis changed over to parameter setting of AMP IC and display ofVACS status.

5. When the VACS status, the message VACS level, VACS signallevel, and VACS signal hold level is displayed on the fluorescentindicator tube.

6. Press the [GROOVE] key, DBFB ON/OFF is changed over.7. Press the [GAME MIXING] key, surround ON/OFF is changed

over.8. Press the cursol B and b key, EQ band is changed over to

LOW, MID or HIGH.9. Press the cursol V and v key, EQ curve adjustment value is

changed over between –8dB to +8dB.10. To release from this mode, press two keys of [GAME EQ] and

[MOVIE EQ] simultaneously.

( )

18

HCD-RG550/RG660

[AGING MODE]• This mode can be used for operation check of CD section and

tape deck section.CD section and tape deck section work in parallel.

If an error occurred:The aging operation stops only an error occurred sections anddisplay then status.

If no error occurs:The aging operation continues repeatedly.

Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Set disc on the tray and set tape into the deck.4. Set the “ALL DISCS” mode and “REV OFF” mode.5. Press three keys of x , [GAME EQ] and [DISC SKIP/EX-CHANGE]

simultaneously.6. The message “AGING” is displayed on the fluorescent

indicator tube momentarily, then aging operations of CD andtape are started at the same time.

7. To release from this mode, operate the “COLD RESET”.

1. Display at the Aging ModeDisplay operating state of CD section and tape deck sectionalternately.If an error occurred, stop display which that section.

2. CD SectionThe sequence during the aging mode is following as below.Display at the aging mode is the same as the normal operation.

Aging mode sequence (CD section) :

Start (from disc 1)

Disc chucking

TOC read

Play first track for 2 seconds

Play last track for 2 seconds

EX-change open/close

Open the disc tray

Disc skip

Close the tray

Change the next disc.

3. Tape Deck SectionThe sequence during the aging mode is following as below.If an error occurred, stop display that step.

Aging mode sequence (tape deck section) :

Rewind the tape A and B“AAG-1 or 2”

Shut off

FWD play the tape A“AAG-3”

2 minutes

Fast forward the tape A“AAG-4”

Shut off or 20 seconds

REV play the tape A“AAG-5”

2 minutes

Rewind the tape A“AAG-6”

Shut off

FWD play the tape B“BAG-3”

2 minutes

Fast forward the tape B“BAG-4”

Shut off or 20 seconds

REV play the tape B“BAG-5”

2 minutes

Rewind the tape B“BAG-6”

Shut off

Note: “*AG-*” is display of each step.

19

HCD-RG550/RG660

[GC TEST MODE]• This mode is used to check the fluorescent indicator tube, LED

and key.Procedure:1. Press the [POWER] key to turn the power ON.2. Press three keys of x , [GAME EQ] and [DISC 2] simultaneously.3. Fluorescent indicator tube and LEDs are all turned ON.4. Press two keys of [GAME EQ] and [DISC 2] simultaneously, mode

is changed over.5. In the key check mode, press each key, the defined key number

of every each key list is displayed on the fluorescent indicatortube.

6. In the key count check mode, “KEYCNT 0” is displayed on thefluorescent indicator tube. Each time a key is pressed,“KEYCNT” value increases. However, once a key is pressed, itis no longer taken into account.

7. In the headphone input check mode, connect the headphone,the message “H_P ON” is displayed on the fluorescentindicator tube, and disconnect the headphone, the message “H_POFF” is displayed on the fluorescent indicator tube.

8. In the volume check mode, turn the [VOLUME] knob, thedisplay on the fluorescent indicator tube is changed over to“VOLUME UP”, “VOLUME FLAT” or “VOLUME DOWN”

[MC TEST MODE]• This mode is used to check operations of Amplifier.Procedure:1. Press the [POWER] key to turn the power ON.2. Press three keys of x , [GAME EQ] and [DISC 3] simultaneously.3. When the MC test mode is activated, the message “TEST

MODE” is displayed on the fluorescent indicator tubemomentarily, then VACS level is displayed on the fluorescentindicator tube.

4. Press the [MUSIC EQ] key, the display on the fluorescentindicator tube is changed over to “GEQ MAX”, press the[EFFECT ON/OFF] key, the display on the fluorescent indicatortube is changed over to “GEQ 16”, press the [MOVIE EQ] key,the display on the fluorescent indicator tube is changed over to“GEQ MIN”,

5. Turn the [VOLUME] knob, the display on the fluorescentindicator tube is changed over to “VOLUME MAX”, “VOLUMEMID” or “VOLUME MIN”

6. Press the [GROOVE] key, VACS ON/OFF is changed over.7. When the [REC PAUSE/START] key is pressed with a tape set in

the deck-B, the function is switched “MD” or “VIDEO” andrecording starts. When the m or M key is pressed duringrecording, the tape is rewound back to the beginning ofrecording, the function is switched to “TAPE B”, then playbackstarts.

8. When the [CD SYNC] key is pressed with the test tape (AMS-100, AMS-110A) in the deck, number of space between tunesis counted, then if AMS-110A is set, “OK” is displayed on thefluorescent indicator tube and if AMS-100 is set, “NG” isdisplayed on the fluorescent indicator tube.

9. To release from this mode, press the [POWER] key.

[MODEL, DESTINATION AND VERSION DISPLAY]• This mode is used to check the model, destination and software

version.Procedure:1. Set to the standby state.2. Press three keys of x , [GAME EQ] and [MOVIE EQ]

simultaneously.3. When the model, destination and version display mode is

activated, the model an destination is displayed on thefluorescent indicator tube.

4. Press two keys of [GAME EQ] and [DISC 2] simultaneously, modeis changed over to model and destination display mode andversion display mode.

5. To release from this mode, press the two keys of [GAME EQ]

and [MOVIE EQ] simultaneously.

[CD ERROR CODE DISPLAY]• This mode can be used for error display of CD section.Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Press three keys of x , [GAME EQ] and [DISC 1] simultaneously.Note: Error code is not displayed on the fluorescent indicator tube.

[CD SERVICE MODE]• This mode can run the CD sled motor freely. Use this mode, for

instance, when cleaning the optical pick-up.Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Press three keys of x , [GAME EQ] and Z simultaneously.4. When the CD service mode is activated, the message

“TRAVERS ON” is displayed on the fluorescent indicator tube.5. Press the M key, optical pick-up move to outside track and

the message “SLED OUT” is displayed on the fluorescentindicator tube.

6. Press the m key, optical pick-up move to inside track andthe message “SLED IN” is displayed on the fluorescentindicator tube..

7. Press the [MOVIE EQ] key, traverse ON/OFF is changed over.

[5 REPEAT LIMIT CANCEL]• Number of repeat for CD playback is 5 times when the repeat

mode is “REPEAT”. This mode is used to enables CD to repeatplayback for limitless times.

Procedure:1. Press the [POWER] key to turn the power ON.2. Press the [CD] key to select “CD”.3. Press three keys of x , [GAME EQ] and gG simultaneously.

20


ELECTRICAL ADJUSTMENTS

CD SECTION

Note:1. CD Block is basically designed to operate without adjustment.

Therefore, check each item in order given.2. Use YEDS-18 (3-702-101-01) unless otherwise indicated.3. Use an oscilloscope with more than 10MW impedance.4. Clean the object lens by an applicator with neutral detergent

when the signal level is low than specified value with thefollowing checks.

S-CURVE CHECK

Procedure :1. Connect an oscilloscope to TP (FE) and TP (VC).2. Turn the power on.3. Load a disc (YEDS-18) and actuate the focus search. (In

consequence of open and close the disc tray, actuate the focussearch)

4. Confirm that the oscilloscope waveform (S-curve) issymmetrical between A and B. And confirm peak to peak levelwithin 3 ± 0.5 Vp-p.

Note: • Try to measure several times to make sure than the ratioof A : B or B : A is more than 10 : 7.

• Take sweep time as long as possible and light up thebrightness to obtain best waveform.

RF LEVEL CHECK

Procedure :1. Connect an oscilloscope to TP (RF) and TP (VC).2. Turn the power on.3. Load a disc (YEDS-18) and playback.4. Confirm that oscilloscope waveform is clear and check if RF

signal level is correct or not.

Note: Clear RF signal waveform means that the shape “ ◊ ” can beclearly distinguished at the center of the waveform.

Connecting Location: BD boardBD board

Oscilloscope

TP(FE)TP(VC)

symmetry

S-curve waveform

within 3 ±0.5Vp-p

A

B

TP(RF)

BD boardoscilloscope

TP(VC)

RF signal waveform

VOLT/DIV : 200mVTIME/DIV : 500ns

level : 1.3 ±0.3Vp-p

TP (VC)

TP (RF)

TP (FE)

IC721

– BD Board (Conductor side) –

TP (TE)

21

HCD-RG550/RG660SECTION 5DIAGRAMS

5-1. IC PIN DESCRIPTIONS• IC309 BU2099FV (MULTI CONTROLLER) (MAIN BOARD)

Pin No. Pin Name I/O Pin Description

1 VSS — Ground pin

2 NC — Not used. (Open)

3 DATA I Serial data input from the tape mechanism controller

4 CLOCK I Serial data transfer clock signal input from the system controller

5 LCK I Serial data latch pulse clock signal input from the system controller

6 REC O Recording on/off control signal output “L”: recording

7 BIAS O Recording bias on/off control signal output “L”: bias on

8 A/B ODeck-A/B selection signal output to the deck-A/B select switch

“L”: deck-B, “H”: deck-A

9 PB MUTE OPlayback muting on/off control signal output to the recording/playback equalizer

amplifier “H”: muting on

10 REC MUTE ORecording muting on/off control signal output to the recording/playback equalizer

amplifier “L”: muting on

11 TUNER MUTE O Tuner muting on/off control signal output to the tuner unit “H”: muting on

12 LM-R (CD) O Loading motor drive signal output

13 LM-L (CD) O Loading motor drive signal output

14 TM-R (CD) O Table motor drive signal output

15 TM-L (CD) O Table motor drive signal output

16 SP RERAY O Front speaker on/off relay drive control signal output “L”: front speaker on

17 LINK/MATRIX O Surround speaker on/off relay drive control signal output “H”: surround speaker on

18 SO O Serial data output to the bass boost controller

19 OE — Not used. (Connect to ground.)

20 VDD — Power supply pin (+3.3 V)

22

HCD-RG550/RG660

• IC310 BU2099FV (BASS BOOST CONTROLLER) (MAIN BOARD)Pin No. Pin Name I/O Pin Description

1 VSS — Ground pin


3 DATA I Serial data input from the multi controller

4 CLOCK I Serial data transfer clock signal input from the system controller

5 LCK I Serial data latch pulse clock signal input from the system controller

6 to 8 NC — Not used. (Open)

9 MOTOR VCC O Motor power control signal output “L”: motor power on

10 SOL A O SOL-A control signal output

11 SOL B O SOL-B control signal output

12 LINE OUT MUTE O Line out mute signal output terminal “H”: mute on

13 CD MUTE O CD mute signal output terminal “H”: mute on

14 to 16 CONT 1 to 3 O Bass boost control signal output “H”: bass boost


18 SO O Serial data output Not used. (Open)

19 OE — Not used. (Connect to ground.)

20 VDD — Power supply pin (+3.3 V)

23

HCD-RG550/RG660

• IC601 LC876696B-51Y1-E (SYSTEM CONTROL, FLD CONTROL) (PANEL BOARD)Pin No. Pin Name I/O Pin Description

1 SYS MUTE O System mute signal output

2 BU1924 DATA I Not used in this set. (Connected to ground.)

3 PWR DOWN I Power down signal input

4 LC78646 RESET O CD reset signal output

5 LC78646 CE O CD CE signal output

6 LC78684 CE (MP3) O CD CE (MP3) signal output

7 M61519 CLK O Clock signal output

8 BU2099FV LCK O LCK signal output

9 LC72121 CE O CE signal output

10 LC78684 SYNC I SYNC signal input

11 RESET I Reset signal input from the IC603

12 XT1 I Oscillater connect pin (32.768 kHz)

13 XT2 O Oscillater connect pin (32.768 kHz)

14 VSS1 — Ground pin

15 CF1 I Ceramic vibrator connect pin (8.64 MHz)

16 CF2 O Ceramic vibrator connect pin (8.64 MHz)

17 VDD1 — Power supply pin (+3.3 V)

18 TAPE A STAT I Tape A start signal input

19 TAPE B STAT I Tape B start signal input

20 CD ENCODER I CD encoder switch signal input

21 SW ON/OFF SENSOR I Switch control on/off signal input

22 STREAM IN I Stream in signal input

23 VACS I VACS signal input

24 KEY2 I Key signal input 2



27 PROTECTOR (HOLD) I Protector (Hold) signal input

28 REMOCON IN I Remote control signal input from the RM601

29 BU1924 CLK I Not used in this set. (Connected to ground.)

30 – 41 G12 – G1 O FLD control signal output

42 – 45 P1 – P4 O FLD control signal output



51 VPP — Ground pin


56 SW1 (a) P13 O FLD control signal output

57 SW2 (b) P14 O FLD control signal output

58 SW3 (c) P15 O FLD control signal output

59 SW4 (d) P16 O FLD control signal output

60 SW5 P17 O FLD control signal output




64, 65 P21, P22 O FLD control signal output

66 ENTER LED O Not used in this set. (Open)

67 MD/VIDEO LED O GAME LED (LED610) drive signal output

68 GAME LED O MD/VIDEO LED (LED612) drive signal output

69 TAPE LED O TAPE A/B LED (LED609) drive signal output

70 TUNER LED O TUNER/BAND LED (LED608) drive signal output

71 CD LED O CD LED (LED607) drive signal output


73 CD VDD O CD power control signal output

24

HCD-RG550/RG660

Pin No. Pin Name I/O Pin Description

74 TUNER TUNED I Tuner tuning signal input from the tuner unit

75 TUNER STEREO I Tuner stereo signal input from the tuner unit

76 CD DRF I CD DRF signal input

77 CD WRQ I CD WRQ signal input

78 CD NUMBER SENSOR I CD number sensor signal input

79 TAPE AMS IN I Tape AMS signal input

80 VR ENCODER A I VR encoder (VR601) signal input

81 VR ENCODER B I VR encoder (VR601) signal input

82 TAPE REEL A I Tape reel A signal input

83 TAPE REEL B I Tape reel B signal input

84 MODE SW IN I Mode switch signal input

85 STREAM 1 LED O Stream LED drive signal output

86 STREAM 2 LED/CD MUTE O Stream LED drive signal output

87 STREAM 3 LED O Stream LED drive signal output

88STREAM 4 LED/

O Stream LED drive signal outputMECHA VCC

89 VSS2 — Ground pin


91STREAM 5 LED/

O Stream LED drive signal outputTAPE SOL A

92STREAM 6 LED/

O Stream LED drive signal outputTAPE SOL B

93 POWER LED O POWER LED (LED614) drive signal output

94 POWER RELAY O Power relay signal output

95LC72121/M61529/

O Serial data signal outputBU2099FV DO

96 LC72121 DI I Serial data signal input

97 LC72121/BU2099FV CLK O Serial clock signal output

98 LC78646/LC78684 DO O Serial data signal output

99 LC78646/LC78684 DI I Serial data signal input

100 LC78646/LC78684 CLK O Serial clock signal output

25 25

HCD-RG550/RG660

5-2. BLOCK DIAGRAM — CD SECTION —

8

7

9

10

80

79

70 LIMIT SW

20

TDO

18

10

VO3(+)

FOIN

20TIN

3SPIN

7MUTE

25SLIN

17 VO3(–)

11 VO2(+)12 VO2(–)

26 VO4(+)

27 VO4(–)

2 VO1(+)

1 VO1(–)

A

C

B

D

E

F

LD

PD

RF AMP, FOCUS/TRACKING ERROR AMP,DIGITAL SIGNAL PROCESSOR, DIGIRAL SERVO PROCESSOR,

DIGITAL FILTER, D/A CONVERTERIC721

21

FDO

23

SLDO

22

SPDO

25

CONT

4

A

B

D

E

F

C I-V A

MP

DETECTOR

LDPD

LASER DIODE

OPTICAL PICK-UPBLOCK

(KSS-213D)

2-AXISDEVICE

(FOC

US)

(TRA

CKIN

G)

M702(SPINDLE)

M701(SLED) M

M

FOCUS/TRACKING COIL DRIVE,SPINDLE/SLED MOTOR DRIVE

IC722

49

48X701

16.9344MHz

S701(LIMIT)

79 DATAIN80 DATACK

5 C2FIN

1 LRSY

2 ADDATA3 ADBCK4 ADLRCK

7 CKIN

9 CKOUT

78 RESB

99 I-LC78646/LC78684 DI98 O-LC78646/LC78684 DO100 O-LC78646/LC78684 CLK5 O-LC78646 CE

77 I-CD WRQ

76 I-CD DRF4 O-LC78646 RESET

60DATA

59DATACK

52C2F

58LRSY

57ASDFIN

56ASDACK

55ASLRCK

5416MOUT

106

76 66

53EFLG

50FSX/16MIN

73 CMDOUT74 CMDIN

CE FSYN

CO-

LC78

684

CEI-L

C786

84 S

YNC

75 CL

26MP3RES

64DO

63DI

62CL

78I-CD NUMBER SENS

20I-CD ENCODER

9RINLM-R

11RESET

1O-SYS-MUTE94O-POWER RELAY27I-HOLD

S-MUTEO-POWER

HOLD61

CE

65*WRQ

67DRF

72CD MUTE

66*RES

4 OUT1

2 OUT2

M751(LOADING) M

LOADING MOTOR DRIVEIC701

MP3 DECODERIC801

SYSTEM CONTROLLERIC601 (1/2) S751

OPEN/CLOSEDETECT

OPEN

CLOSE

LEVEL SHIFTQ731

TABLE ADDRESSSENSOR

IC731

+ROTARY

ENCODERRE701

7FINLM-F

9RINTM-R

4 OUT1

2 OUT2

M741(TABLE) M

TABLE MOTOR DRIVEIC712

7FINTM-F

C

B

42LCHO

45RCHO

R-CH

CD-L A

APC

FIN2

FIN1

LDD

LDS

TIN2

TIN1

XOUT

XIN

RF4

EFMIN3 ERROR

CORRECTEQ,AGC

COMMANDINTERFACE

CLOCKGENERATOR

PH, BH

RF AMP

TBAL A/DCONVERTER

D/ACONVERTER

EXTERNALAUDIO IN

SERIAL OUT

D/ACONVERTER

SERVOPROCESSOR

AUTOMATICPOWER CONTROL

Q701

3I-POWER DOWN POWER DOWN

RESET

S-MUTEMIC

O-POWERHOLD

POWER DOWN

RESET

LM-F

LM-R

• SIGNAL PATH

: CD PLAY

• R-ch is omitted due to same as L-ch.

R-CH

DISC TRAYADDRESS DETECT

I/01

– I/0

16A0

– A

8

MDA

TA0

– M

DATA

15M

ADRS

0–

MAD

RS8

29 OE45OEB15 WE42WEB16 RAS41RASB31 LCAS43CASLB30 UCAS44CASUB

MEMORYIC802

2-5,

7-1

0,35

-38,

40-

43

23-3

0, 3

3-40

60-5

3, 5

0

18-2

1, 2

4-28

MUTINGQ311

MUTING CONTROLSWITCH

Q312

TM-F

TM-R

D TUNER/TAPE/PANELSECTION

AMP/POWER SUPPLYSECTION



DOUT

39DOUT

(Page 27)

(Page 27)

(Page 27)

(Page 26)

2626

HCD-RG550/RG660

5-3. BLOCK DIAGRAM — TUNER/TAPE/PANEL SECTION —

CAPSTAN/REELMOTOR DRIVE

Q618

PLUNGER DRIVE(DECK-A)

Q616

MM

TAPE MECHANISMDECK BLOCK

(CAPSTAN/REEL)

(DECK-A)

(DECK-B)

96 I-LC72121 DI97 O-LC72121/BU2099 CLK9 O-LC72121 CE74 I-TUNER TUNE75 I-TUNER STEREO

2 I-BU1924 DI29 I-BU1924 CLK

95 O-LC72121/M61529/BU2099 DO

G

TUNER UNIT

AM LOOP

FM ANT

AM ANT

L-CH

R-CH R-CH

TUNER-L

TU-MUTE

DI

DICL

K

BIAS OSCL201

REC BIASSWITCH

Q228+9V

BIAS OSCQ223

ERASE

HRPE1(REC/PB/ERASE)

(DECK-B)

HP1(PB)

(DECK-A)

L-CH

R-CH R-CH

R-CH

L-CH

R-CH R-CH

22 I-STREAM-IN

23 I-VACS

21 I-SW ON/OFF SENSOR

BAND-PASSFILTER

28 I-REMOCON-INREMOTE CONTROL

RECEIVERRM601

FRONT PANEL KEY

81 I-VR-ENCODER-B80 I-VR-ENCODER-AROTARY

ENCODERVR601

LED DRIVERQ602-605,607

BUFFERQ609,610

FLD601FLUORESCENT

INDICATOR TUBE

MUTINGQ219, 221

PLUNGER DRIVE(DECK-B)

Q617

LED614

A-MODETAPE A STAT

TAPE B STAT

TAPE REEL ATAPE REEL B

B-SOL

A-SOL

CAPM+MECHA-VCC

SOL-A

SOL-B

A-HALF

B-HALF

A-PHOTEB-PHOTE

B-MODE

REC (FWD)

REC (REW)

G1I

G12

P1I

P4•

P5I

P8•

P9I

P22

18

8283

I-TAPE A STATI-TAPE B STATI-TAPE REEL AI-TAPE REEL B

19

93O-POWER LED

8O-BU2099 LCK

79I-TAPE AMS IN

42I

45•

47I

50•

52I

65

30I

41

VACS/STRVACS/STRE

VOLUME

I-KEY2I

I-KEY0

24I

26

O-STREAM 1 LED

O-STREAM 6 LED

85I

88•

91•

92

SO

MCL

K

LCK

LCK

X60132.768kHz

13

12

XT2

XT1

7O-M61529 CLK

16

15RES6018.64MHz

CF2

CF1

POWER HPF

(AEP, UK)

SYSTEM CONTROLLERIC601 (2/2)

FM 75ΩCOAXIAL

PH301DIGITAL

OUT

LED601-606(STREAM1-6)

ANTENNA

34

32BIN (L)

AIN (L)

28 27EQOUT (L)

26PB-OUT (L)

TAI (L) MUTE

DECK A/B SELECT SWITCH, REC/PB EQ AMPIC201

REC-OUT (L) REC-IN (L)

21 EQ 24

DOCLK

CETUNED

ST

RDS DATARDS INT

MULTI CONTROLLERIC309

7 BIAS

1514

6 REC

11

1

TUNER MUTE

MUTE-ON/OFFREC MUTE-ON/OFF

910 REC MUTE

PB MUTE8 A/B13A/B

REC ON/OFFSWITCH

Q222, 225

3DATA4CLOCK5LCK18SO

CLK

DI

13LM-L (CD)LM-F

12LM-R (CD)LM-R

TAPE-L

REC-L

SP-F

1514

TM-L (CD)TM-F

TM-R (CD)TM-R

• SIGNAL PATH

: TUNER (FM/AM)

: TAPE PLAY (DECK-A)

: TAPE PLAY (DECK-B)

: REC

• R-ch is omitted due to same as L-ch.

SURR

LM-FLM-R

TM-FTM-R

D OUT

DISOCLKMCLKLCKMECHA-VCCSOL-ASOL-B

16SP RELAYSP-F

17LINK/MATRIXSURR

O-GAME LED

O-MD/VIDEO LEDO-TAPE LED

O-TUNER LED

O-CD LED

68•

67•

69•

70•

71

LED607I

LED610,LED612

AMSQ210,211

EQQ212

23




D CDSECTION

K AMP/POWER SUPPLYSECTION

H AMP/POWER SUPPLYSECTION

J AMP/POWER SUPPLYSECTION

D OUT+3.3V+3.3VGND

(Page 27)

(Page 27)

(Page 27)

(Page 27)

(Page 27)

(Page 25)

(Page 27)

27 27

HCD-RG550/RG660

5-4. BLOCK DIAGRAM — AMP/POWER SUPPLY SECTION —

JK006

R-CH

PHONES

FRONTSPEAKER

+–

–+

R

L

JK502 (1/2)

SPEAKERJK502

R-CH

R-CH

–VL

–VP

+VP

–VH

OVER LOADDETECT

Q505

OUTPUT LEVELDETECTQ23, 24

DC DETECTQ5, 6

BIASQ507, 509

HOLDQ7 – 9

DC DETECTQ5,6

THERMAL DETECTQ10, 11+

FINAL DRIVEQ501, 503

SWITCHINGQ17, 19, 22

SWITCHINGQ18

R-CH

R-CH

+

+

+TH501,

502

+

R-CH

R-CH

CASCADEQ511, 513, 515

PRE DRIVEQ517, 519

MIC AMPIC001 (1/2)

MIC AMPIC001 (2/2)

MUTINGQ525

+

CURRENTMIRROR

Q521, 523

R-CH ++VL

+VHOUTPUT LEVEL

DETECTQ20, 21

R-CH +MUTEQ321

INPUT SELECT SWITCH, TONE CONTROL, ELECTRICAL VOLUME, BASS BOOST AMP

IC301

BASS BOOST CONTROLLERIC310

19

SAOU

TVA

CS/S

TR

29TOUT2

25OUT2

VR001JK003

3

DATA

4

CLOC

KLC

K

S-M

UTE

MIC

O-PO

WER

HOLD

CLK

SO

5

LCK

40 CD-L

MD-L

2 MIC

39 TUNER-L

38 TAPE-L

28 VOLIN2

MIC LEVELAGCQ001

–30VREGULATORQ533 – 536

(AC IN)

SUB POWERTRANSFORMER

T902

MAIN POWERTRANSFORMER

T901

RECTD2

+VL

TOPOWER AMP

BLOCK

–VL

VL

VL

VF1TO

FLUORESCENTINDICATOR TUBE

VF2

RECTD1

+VH

–VH

–VFLEVER+10V

VH

VH

RECTD902 – 905

+4VREGULATOR

IC602+3.3V (SUB)

DISO

CLKMCLK

LCKMECHA VCC

SOL-ASOL-B

RESET

POWER DOWN

D617

RESET SIGNALGENERATOR

IC603

MIC MIC LEVEL

CD-LA

TUNER-L

TAPE-LREC-L

JTAPE-L

G

K

C

21

DATA

22

CLOC

K

35 RECB-2

36 GAME-L

S-MUTE, O-POWER, HOLD

B

: MIC INPUT

9

MOT

OR V

CC

10

SOL-

A

11

SOL-

B

MEC

HA V

CCSO

L-A

SOL-

B

H

HP F

(Except RG660 AEP, UK)

AEP, UK

MODEL

VOLTAGESELECTOR

S901

Except AEP, UKMODEL

VOLTAGESELECTOR

RY901

RY902

RESET SWITCHQ601

R-CH

+–

–+

R

L

R-CH

FRONT SPEAKERON/OFF RELAY DRIVE

Q304

MUTING CONTROLSWITCH

Q527

POWER OFFMUTING DRIVER

Q529, 530

D513VM+10V

FAN MOTORON/OFF SWITCH

Q371,373

RY501

RY502

RG660

RG660

RG550

SURROUND SPEAKERON/OFF RELAY DRIVE

Q532

M731(FAN)M

SP-F

S-MUTEO-POWERHOLDMIC

SURR

: TAPE PLAY

: REC

: CD PLAY

: TUNER (FM/AM)

SIGNAL PATH

: MD (VIDEO) IN

R-ch is omitted due to same as L-ch.

R-CH

JK302

L

R

R-CH

JK005

JK004

L

R

VIDEO

AUDIO

VIDEOOUT

GAMEINPUT

MD (VIDEO)IN

37 BUFFERIC304

CENTER VOLATAGEGENERATOR

Q324

VM+10V

TUNER/TAPE/PANELSECTION



CDSECTION



CDSECTION

MCL

KDI

+4V

HOLDQ12

OVER CURRENTDETECT

Q13

O-PO

WER

VM+9V

VM+10VRECT

D319 – 322

RECTD301 – 304

DC DETQ329

VM

VMVCC

DECK+9V, M+9V

+10VREGULATOR

IC313

+9VREGULATOR

IC308D102

P+7VD313 – 315

+9VREGULATOR

IC305

+4VREGULATOR

IC306

B+ SWITCHQ301, 302

RELAY B++9V

+1.8V(MP3)

+3.3V (MAIN)

+1.8VREGULATOR

IC803

POWER ON/OFFRELAY DRIVE

Q330, 331

TUNER/TAPE/PANEL

SECTION

CDSECTION

E

SURROUNDSPEAKER

JK502 (2/2)

VACS/STRMIC+10V

(Page 26)

(Page 25)

(Page 26)

(Page 26)

(Page 25)

(Page 26)

(Page 26)

(Page 26)

(Page 25)

2828

HCD-RG550/RG660

5-5. CIRCUIT BOARDS LOCATION

MAIN board

DRIVER board

SW board

MOTOR (LD) board

MOTOR (TB) board

VIDEO OUT board

BD board

SENSOR boardTRANS board

POWER AMP board

JACK board

PANEL board

REMOTE board

6 STREAM LED board

29 29

HCD-RG550/RG660

5-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS 5-7. WAVEFORMS

Note on Printed Wiring Board:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• : Pattern from the side which enables seeing.

(The other layer’s patterns are not indicated.)

Caution:Pattern face side: Parts on the pattern face side seen from(Conductor Side) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Component Side) the parts face are indicated.

C

B

These are omitted.

E

Q

B

These are omitted.

C E

Q

B

These are omitted.

C E

Q

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• 2 : nonflammable resistor.• C : panel designation.

• Indication of transistor.• A : B+ Line.• B : B– Line.• Voltage and waveforms are dc with respect to ground

under no-signal (detuned) conditions.no mark : FM( ) : CD PLAY[ ] : TAPE PLAY (DECK-A) : TAPE PLAY (DECK-B)⟨⟨ ⟩⟩ : REC

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

F : TUNER (FM/AM)J : CD PLAYE : TAPE PLAY (DECK-A)d : TAPE PLAY (DECK-B)G : RECj : MD (VIDEO) INN : MIC INPUT


Note: The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARKUnleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40 °C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set to about350 °C.Caution: The printed pattern (copper foil) may peel away if the

heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow) thanordinary solder so use caution not to let solder bridges occur suchas on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder may alsobe added to ordinary solder.

– PANEL Board –

1

2

8.64MHz

IC601 qg (CF1)

32.768kHz

IC601 qs (XT1)

1.2Vp-p

1Vp-p

– BD Board –(CD PLAY mode)

1

2

IC721 4 (RF)

1.3Vp-p

3

4

IC721 qd (FE)

Approx.180

mVp-p

IC721 qg (TE)

Approx.150mVp-p

4Vp-p

16.9344MHz

IC721 rk (XOUT)

– MAIN Board –(REC mode)

qa

1.7Vp-p

qs

15.8Vp-p

Q223 (Base)

Q223 (Collector)

11.3µs

11.3µs

3030

HCD-RG550/RG660

5-8. PRINTED WIRING BOARD — CD MECHANISM SECTION (1/2) — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

(Page 38)

C860

R860

C817FB803

FB80

5

FB804

FB806 R806R807

R747

C761

R761

R762

R746

3 4

5

IC801

IC802

BD BOARD(SIDE A)

1-688-077- (11)

11

OPTICALPICK-UPBLOCK

(KSS-213D)

IC722

IC803

IC721

BD BOARD(SIDE B)

1-688-077- (11)

11

M702(SPINDLE)

M

+

–

M701(SLED)M

+

–

S701(LIMIT IN)

TP(RF)

TP(FE)

TP(TE)

TP(VC)

E

BC

MAINBOARDCN312A

7 114 8

22 2815 21

1

A

B

C

D

E

F

2 3 4 5 6 7 8 9 10 11

Ref. No. LocationIC721 E-8IC722 C-9IC801 E-3IC802 F-3IC803 F-9

Q701 B-7

• SemiconductorLocation

31 31

HCD-RG550/RG660

• Refer to page 29 for “5-7. WAVEFORMS”.

5-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 49 for “5-27. IC BLOCK DIAGRAMS”.

(Page 36)

IC B/D

CN708

C711

C712

C721

C719

C720

C718

C717

C715

C716

C714

C706

C707

R73

9

R74

0

R74

1

M702

M701

R738

C747 C748

R707

C705

C709

R730

C746 C708 R729

C743C744

R725R726

R731

C754C742

C753

R760

C756

C722

FB707FB708

R72

0

R71

9

R71

8

R721

C830

R826

R827

R828

R825

C825

R823

R824

C829

FB808

FB701

R765 C734

C735

X701

C732

C733

C729

C811

R817

R818

C812

R819R820

FB807FB801

FB802

C844

C856

C810

R801 R802

C837

R80

3

R80

4

R80

5

C813

C814

C843

C803 C805

C815

C816

R834

R833 R832

IC803

FB80

3

FB80

5

FB80

6

CN710

C802C807

R732

C806

C817

R71

7

R71

6

C741

R728

R745

R701

R706

R708C710

R727C703

C723

R711

R703

R704

R705

C702

C701

FB80

4

C831

C704

R709

S701

R714

R715

TP

TP

TP

TP

C713

R829

R747

R746

R713

C823

C824

R744

R807

R806

IC801

C804

C859

C858

C857 C860

R860

C835

C834

C731

IC721

IC722

IC802

Q701

R722

R702

C761R762R761

FB761

3232

HCD-RG550/RG660

(Page 38)

Ref. No. LocationD701 D-6D711 D-7

IC701 F-6IC712 F-7IC731 E-11

Q731 C-9


1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14 15

CN751

S751

IC731

CN731

CN741

CN74

2

C715

C731

C735

C736

R70

1

R711

R731

R721

R722

R723

R73

5

R73

2

R733

R73

4

D70

1

D71

1

Q731

C751

IC71

2

IC70

1

CN704

C737

R71

3

R712

C741

R70

2

JW702

JW703

JW704

JW705

JW706

JW707

JW70

8

JW711

CN70

3

CN702CN705

R751

C752

CN70

1

JW712

JW701

JW70

9

JW710

JW713

JW714

CN72

1

5-10. PRINTED WIRING BOARDS — CD MECHANISM SECTION (2/2) — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

33 33

HCD-RG550/RG660

5-11. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) —• Refer to page 49 for “5-27. IC BLOCK DIAGRAMS”.

IC B/D

R751

C752CN705

CN704CN721

CN751

C751

IC701

IC712

R701

R713

R711

R723 R721R722

C735C736C737

R735

R733R731

C731

C741CN702

CN703

CN701

RE701

M741

M751

IC731CN731 CN741

CN742

CN751

C715

R702

R712

R732R734

D701

D711S751

Q731

(Page 35)

3434

HCD-RG550/RG660

(Page 36)

5-12. SCHEMATIC DIAGRAM — MAIN SECTION (1/4) — • Refer to page 49 for “5-27. IC BLOCK DIAGRAMS”.

IC B/D

(RG660 AEP/UK)

(EXCEPT RG660 AEP/UK)

D102

R101

R102

C103

R304 R303R302

R301

C102

C101

C301

R317

C321

C323

C327

C325C319

R33

0

C320

C324

C337

R323

C328C3

26

R326

C353C303

C318

R318

D317

C304

C357

C311C312

C310

C355

R39

6

R39

5

R316

C362

C361

R365

JK302

JR124C432 C434

R327

C365

C309

C435

C433

C431

IC301

JR300

C317

R325

C436

C313

C411

C314C412

C352

C356

R329

R380

R355 R356

C342 R354 R358

JR314

C107 C106

CN102 C105

CN308

C351

C300

R305C307

C302

C424

C350

C332

C334

R344

C349

R345

R321

R31

9

C333

C331

R324

R397

R399 R398

R322 R320

R328

CN101

C366

R306C308

Q321

Q322

Q311 Q310

Q312

C393

C425

C354

C428

C430

CN305 3P

(Page 35)

(Page 37)

(Page 42)

35 35

HCD-RG550/RG660

IC B/D

R233

R425

R424

CN309

C402

C202

C201

C203

C204

C237

C244

C232

C266

C248

C267

R267C269R271

C273 C247

C249

C254R284C253

R278

R270R282

R215

C260

C258R287R288 C259

R235

R286

R232R234

C261

C285 R285

Q228

C240 R253R246C221

R245R273

R269

R241 R242

D206

R251

R353

R352

R455

R406

R426

R466

D305

C392

C391 C390

R430

R368

IC310

R272

R400 R401 R402 R404 R405

C401

R486

R407 R408 R409 R410

D306

R216

C250

C272

CN203

HP1

D101

C234

R226 C226

C286

C233

C225

R225

C242

C241

C223

Q223

Q221 Q218

Q225

Q222

IC201

GA1

R307

R231

R266

C268

IC309

R420C450

Q220Q219

L201

R268

R265

C239

R252

D205

R283

R220

CN202

D324

R258

R263

R262

R256 R249

R257 R250 R261 R218

R238R264

C230

C235

C236

D210 D203

D204

C231

Q210Q211

R239

C265

R236

R237

C255

R219

C205

TP63

TP62

TP61

TP56

TP57

TP58

TP59

TP60

R260

D309 L301 C395

C206

R369

PH301

HRPE1

Q212C256

C257

FB1

(Page 37)

(Page 33)

(Page 34)

• Refer to page 29 for “5-7. WAVEFORMS”.

5-13. SCHEMATIC DIAGRAM — MAIN SECTION (2/4) — • Refer to page 49 for “5-27. IC BLOCK DIAGRAMS”.

3636

HCD-RG550/RG660

(Page 37)

5-14. SCHEMATIC DIAGRAM — MAIN SECTION (3/4) —

CN311

CN312

CN306

CN310

R421

R362

R361R480

R363

R364

D311

C370

C369

JR333

C377

R371

R372

D371

D374

C398 D312

CN303

M731

JR339

C448JR343

R299

R390

R498

R499

C447

C378 JR344

C386 R374

C452JR453

C451

C453 C449

JR341

R341

R460 R461

R423 R422

R434

R433

Q371

Q373R373

Q304

(Page 34)

(Page 44)

(Page 42)

(Page 31)

(Page 40)

37 37

HCD-RG550/RG660

(Page 36)

5-15. SCHEMATIC DIAGRAM — MAIN SECTION (4/4) —

R484

CN304

D315 D313

CN307

R346

R387C397

R386

R388

C345

C372

D36

4

R43

1

R379

D314

R482 R481

C399C419C418

D321 D322

C375C374C373

D301 D302 C380

C381

D304D303

C420 C421

R378

D319 D320

R483

R314

C363

IC304

R313

R432

C339C364

D307

C371

JR334

IC305 IC308 IC313

C417

Q331

Q330

D316

Q324

C437

C438

Q301

Q302

R309C305

R311 C359

C306

R310R312

C429

C426

C445

R427

R429

R428

R487

R488

R435 D318 C441

D323

C423

D308

R377 R360

D366

C427

D325

R456

R457

R465

R459

JR332

JR331

JR329

JR330

R384R348

IC306

Q329

C348

(Page 34) (Page 35)

(Page 40)

(Page 44)

3838

HCD-RG550/RG660

IC201

D205R220

R253

R269

R268

R266

R251

R235

R278

R288

R273

Q225

Q219

Q221

R232

R256

R257

R263

R219

R249

R250

R218

R238

R234

Q222R245

R216

R286

R272

R270

R284

R283

R287

C286C225

C231

C452

C230

C226R225

R226

R423 R422

R252

R260

R285

R265

R215

R271

R456

R457

R469

R465

Q218

R346

C202

C285

R241

R267

R262

C201

C205

C204

C203

R242

Q220

R231

R282

R348

R384

C300

JR30

0

R233

C430

Q330

Q212

Q210

Q211

Q331

D307

D203

D210

D204

D366

R246

R258

R377

R237

R239 R264

R236

R261

R378

D206

R484

R481R379R3

60

Q302

R431

R483

JR330

R307

C390

C392

R368

R407R405

R408

R409

R410

C401R430

IC30

9

C391

D305

R404

R402

R369

R486

C402

IC31

0

JR331

JR332

JR32

9

R401 R4

00

R420

R375R4

98

R499

R299

R390

R353

R355R358

Q310

Q311

D306

C366

R424

R426

R356

R354

R316

C342

R466

R425R455

R397

R352

R406

Q312

Q322

Q321

D324

JR339

JR124

R395

JR341

R327

R306

R305

CN308

CN305

1

7

R398

R399

JR343C448

C365

C353

C319

R330

IC301

C433 C435

C434

C449

C432

R325

C431

R317

C361

C356

C355

D101

D309

R102R101

R323

D317

R321 R345

C354C424

C425

JR32

2

R341

R319R396

R322

R344

C447

R329

R324

FB1

C106

C107

D311

D364

R361

R362R363

R421

D312

R460 R461

JR344

JR453C451

R371

R373 R574

R372

D371

D374

R427

R487

R488

R428

R314

R326

R365

R387

C437

C362

C436

C438

Q324

Q329R3

86

R313

R388

R432

R312

R318

R320

R328

C352C378

C429

C441

C427

C351

R301

R304

JR333

R310

R303

R309

R311

C305

C105

C445C4

28

C306

C426

R302

R429

R480

R364

R380

D325D308

IC30

4

C453

C206

R482

1

3

JW309

JW310

JW400

JW390

JW393

JW39

5

JW387

JW300

JW386JW25

3

JW36

0

JW320

JW389

JW26

4

JW37

0

JW396

JW266

JW410

JW43

0JW38

0

JW394

JW42

0

JW397

JW32

4

JW32

5

JW32

6

JW32

3

JW32

2

JW32

1

JW31

9

JW316

JW318

JW315

JW314JW313

JW363

JW362

JW32

7

JW36

5

JW36

7

JW364

D323

JW340 JW384

JW382

JW277

JW385

JW47

0

JW26

7

JW220

JW281

JW268

JW373

JW372

JW359

JW361

JW37

1

JW36

8

JW273

JW49

4

JW217

JW210

JW209

JW216

JW219

JW280

JW218

JW398

JW350JW231

JW330JW223

JW221

JW222

JW392

JW283

JW228

JW282

JW225

JW25

1

JW46

0

JW45

6

JW303

JW302

JW301

JW30

7

JW30

5

JW30

4JW30

8

JW10

8

JW345

JW10

7

JW344

JW342

JW10

6

JW343

JW328

JW33

3JW33

4

JW32

9

JW33

1

JW102

JW103

JW11

2JW

111

JW11

0

JW10

5

JW269

JW448

JW356

JW358

JW357

JW265 JW354

JW33

5JW

355

JW337

JW339

JW338

JW348

JW341

JW347

JW346

JW462

1

JW461

JW45

7

JW466

JW467

JW468

JW48

1

JW47

9

JW478

JW263

JW469

JW44

3

JW44

5

JW471

JW474

JW475

JW472

JW473

JW499

JW459

JW440

JW453

JW455

JW45

8

JW44

6

JW44

4

JW454

JW45

0

JW415

JW42

6

JW44

1

JW43

9

JW43

8JW

434

JW43

3JW

432

JW44

2

JW42

9

JW42

8

JW42

7

JW411

JW271

JW27

2

JW407

JW408

JW409

JW403

JW405

JW406

JW270JW402

JW401

JW422

JW424

JW423

JW43

6

JW417

JW418

JW416

JW421

JW419

JW274

JW23

7

JW238

JW290

JW29

8

JW239

JW235

JW22

6

JW22

7

JW234

JW20

0

JW20

5

JW25

2

JW23

6JW

214

JW206

JW211

JW212

JW213

JW207

JW492JW488

JW487

JW49

3

JW482

JW489

JW491

JW490

JW483 JW276

JW486

JW485

JW484

JW203

JW27

8 JW20

4

JW20

1

JW20

2

JW498

JW2

JW1

JW435

JW497

JW496

JW495

G1

CN306

C418

C419

IC313

C375

IC306

C373

R435

Q301

C420

C421

D304

D303D301

D302

C374

D319D321

D322

D320

CN307

C320

C339

C393

C337

C324

C326

C328

C314

C345

C363

C364

C412

C318

CN303

CN102

C309

C304

C411

IC308

C371

C380

C372

C399

C381

C334

C302

C398

Q304

C332

C386

D316

C417

C377

C310

C397

C327

CN312

C102

C323C317

C325

C303

C357

C101

C370

CN101

D102

C103

C312

CN309

C311

C369

C313

D314

C450

D315C333C331

C321

D313 C367

CN311

CN304

CLP3

Q223

Q228

C250C260

C240

C221

C249

C265C235

C255

C257C258C268

C239

C241

C266

C254

C272

C259

CN202

C248

C273

C247

C253

C269

C267

C232

C237

C244

C261

CLP2

CN310

CN203

R433

R434

C233

C234

C242

L201

C223

C301

Q373

IC30

5

C395

PH301

DIGITALOUT

L301

C307

C308

C350

C349

C359C348

Q371

C423

C236

C256

1

2

3

MAIN BOARD

1-688-080- (13)

13

(AEP, UK)

TUNER UNITSUPPLIED WITH THEASSEMBLED BLOCK

FM 75ΩCOAXIAL

ANTENNA

AM

12

1514

(AEP, UK)

(AEP, UK)

12

1918

A BD BOARDCN710B DRIVER BOARD

CN701

12

(AEP, UK)

EE

E

E

42 22

1 21

1 3

1

M731(FAN)M

(AEP, UK)

E

E

E

1 31 31 31 3

EE

E131 131

E

E

(CHASSIS)

EE

E

E

E

E

E

91

BIAS OSC

8

1

1 3

HP1(PB)

(DECK-A)

HRPE1(REC/PB/ERASE)

(DECK-B)

15

FJACK

BOARDCN004

3130

12

CPANELBOARDCN601

EJACK

BOARDCN007

98

12

D PANEL BOARDCN602

(AEP, UK)

H POWER AMP BOARDCN502 G POWER AMP BOARD

CN501

R

L

MD (VIDEO)IN

JK302

(AEP, UK)

(AEP, UK)

(AEP, UK)

(AEP, UK)

(AEP, UK) (AEP, UK)

(AEP, UK)

(AEP, UK)

E

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8

(Page 41)

(Page 32) (Page 30)

(Page 39)

(Page 43) (Page 43)

(Page 39)

(Page 41)

5-16. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

Ref. No. LocationD101 B-7D102 B-7D203 F-4D204 F-4D205 F-3D206 G-4D210 E-4D301 G-6D302 G-6D303 G-6D304 G-6D305 D-3D306 C-5D307 G-5D308 G-5D309 B-6D311 H-7D312 F-7D313 C-4D314 C-4D315 C-5D316 E-5D317 D-7D318 G-5D319 G-7D320 G-7D321 G-7D322 G-7D323 E-6D324 C-5D325 G-5D364 G-5D366 G-5D371 G-7D374 G-7

IC201 F-3IC301 D-6IC304 F-6IC305 G-6IC306 G-6IC308 G-5IC309 C-3IC310 C-3IC313 G-7

PH301 B-8

Q210 G-4Q211 G-4Q212 G-4Q218 F-2Q219 F-2Q220 F-2Q221 F-2Q222 G-3Q223 G-3Q225 G-3Q228 G-3Q301 G-6Q302 G-5Q304 G-7Q310 C-5Q311 C-5Q312 C-4Q321 C-7Q322 D-7Q324 F-6Q329 F-6Q330 G-5Q331 G-5Q371 G-7Q373 F-7


39 39

HCD-RG550/RG660

(Page 38)

(Page 38)

5-17. PRINTED WIRING BOARDS — PANEL SECTION — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13 14

C

D

MAINBOARDCN304

MAIN BOARD CN311

(AEP,UK)

(E)

(E)

(AEP

,UK)

RM601

VR601

S617 DISC1

S618 DISC2

S619 DISC3

LED614,S614

LED608,S628

LED609,S629

S623MOVE EQ

S622EFFECTON/OFF

ENTER

S612REC PAUSE/

START

S611FM MODE/

REPEAT

S633TUNER MEMORY/

PLAY MODE

SURROUNDS610EDIT/

DERECTION

S632

RG550:CLEAR

S613GAME

MIXING

RG660:SURR SS

MODE

S637MUSIC EQ

S639GROOVE

S624V

S625v

S626b

S642B

S638GAME EQ

VR601VOLUME

S621 Z

S601 X

S602 x

S603 M +

S604 >

S605 ALBUM +

S640 P FILE

S609

S608 .

S607 ALBUM –

S641 ILLUMINATION

S615 DISPLAY

C648

C638 C649

C637

S616 gG

S620 DISC SKIP/ EX-CHANGE

TAPE DECK BLOCKSUPPLIED WITHTHE ASSEMBLED

BLOCK

TUNER/BAND

TAPE A/B

LED612,S630

I /

LED607,S627CD

1-688-085- (12)

12

1-688-083- (12)

12

PANEL BOARD

REMOTE BOARD

FB60

1

C603

C619

C611

C644

3

C604

C602

RES601

X601

C601

C639

FLD601(FLUORESCENT INDICATOR TUBE)

6 STREAM LED BOARD

LED606

LED606(STREAM6)

LED605(STREAM5)

LED604(STREAM4)

LED603(STREAM3) LED602

(STREAM2)LED601

(STREAM1)

LED602LED603LED604LED605LED601

1-688-081- (12)

12

LED610,S631GAME

MD(VIDEO)

S636

M

–

S634CD SYNC

S635

D608 D606

D606 B-7D608 B-6D609 B-6D611 B-6D614 F-10D615 G-10D616 G-11D617 G-4D618 G-5D619 F-3D620 G-11D621 F-10D622 G-4D623 F-4

Ref. No. Location

• Semiconductor LocationRef. No. LocationD624 G-4D625 B-5D626 G-4D627 E-8D628 G-9D629 F-6D630 F-5D631 G-10D633 F-4D634 C-5

IC601 C-7IC602 G-4IC603 F-4

LED601 I-11LED602 I-10LED603 I-10LED604 I-10LED605 I-9LED606 I-9LED607 C-11LED608 C-11LED609 D-11LED610 E-11LED612 D-11LED614 B-12

Q601 F-3

Q602 C-11Q603 C-11Q604 D-11Q605 E-11Q607 D-11Q609 E-10Q610 E-11Q616 F-6Q617 G-8Q618 G-7

RM601 A-11

Ref. No. Location Ref. No. Location

4040

HCD-RG550/RG660

(Page 37)

(Page 36)

5-18. SCHEMATIC DIAGRAM — PANEL SECTION — • Refer to page 29 for “5-7. WAVEFORMS”.

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

DMAIN BOARD CN311

CMAIN

BOARDCN304

S632 SURROUND

S635RG550: CLEAR

RG660: SURR SS MODE

S633TUNER MEMORY/

PLAY MODE

8.6

0

9.7

5.7

3.6

3.4

3.4

1,2

0.8

3.6

1.6

-1.5

-1.5

-1.5

3.6

3.6

-1.5

3.2

0 3.2

0 0 0

-25.

8

-25.

8

3.3

-25.

8

-25.

8

-25.

8

-25.

8

-25.

8

-25.

8

-25.

8

0

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

-25.8

3.3

-25.

8

-25.

8

0.8

0.8

0.8

3.3

8.6

3.3

3.1

3.3

3.5

0

0

0

3.3

3.4 0 0 0 0 0

3.6

3.3

1.4

1.7

1.6

1.7

3.3

3 3 0 3 1.5

1.6

3.3

3.3

3.3

1.9

3.3

0-25.8

3.5

3.4

7.57.5

4 1.3

0

3.3

3.6

3.3

0

5.2

0.4

1

9

0

1.2

1.2

9

9

0

1.2

9

0.7 0 00

0 8.6 8.68.6

-25.

8

-25.

8

E m

odel

AEP,

UK m

odel

AEP,UK model

E model

AEP,UK model

IC602

9P

7P 7P

Q609, 610BUFFER

Q618CAPMDRIVE

Q616TAPE SOL A

DRIVE

TAPE DECK BLOCKSUPPLIED WITHTHE ASSEMBLED

BLOCK

Q617TAPE SOL B

DRIVE

DISC1

3P

Q601 RESET SWITCH

31P

CN604 3P

RM601RPM7240-H4

DISC2

ALBUM –

MD(VIDEO)

ENTER

ALBUM +

DISC3

/

DISC SKIP/EX-CHANGE

Xx

Z

13P

POW

ER HL-3

0105

Q2AT

(STREAM1)

(STREAM2)

(STREAM3)

(STREAM4)

(STREAM5)

(STREAM6)

LED607 – 610, 612HL-30105Q2AT

Q602 – 605,0607LED DRIVE

REMOTE BOARD

6 STREAM LED BOARD

TAPE A/B GAMECD

VOLUME

TUNER/BAND

IC601IC601

REMOTE CONTROLRECEIVER

RM601

EVER +4VREG

IC602RESETIC603

LC876696B-51Y1-E SYSTEM CONTROL,

FLD CONTROL

PANEL BOARD

GAMEMIXING

ILLU

MIN

ATIO

N m –

+. >

gG

m

LED601-606SEL5223S-TP15

b

B

v V

MD(VIDEO)

4

99

98

100

6

10

77

76

5

S

80

81

M9V

18

19

82

83

4VSW

81

82

83

86

94

95

96

97

98

99

100

23

22

1 45 6 7 8 9 10

18 19 20 21 22 23

29

30

33

32

31

34

35

36

37

38

39

40

41

42

43

44

45

47

48

49

50

52535455565758596061626364657380 79 78 77 76 7475

65

64

63

62

61

60

59

58

57

56

55

54

53

52

50

49

48

47

45

44

43

42

41

40

39

38

37

36

35

34

33

32

31

30

VF233 30313241 40 39 38 37 36 35 3442434445474849505253545556575859606162636465VF1

VF2VF1

VM10V

4VSW–VFL

292

7574

996

9597

78

7820

731

S79

M9V

HOLD94

21

D–GN

D

M–G

ND

EVER

4V

JR620

D611

D606–609,611,6121SS355T

VM10V

0.2250V

4.7k

10V

RESE

T

2

R602

100

22p

R608 100

1SS355

1SS355D633

JR62

6 0

4VSW

D634

1SS3

55

41 41

HCD-RG550/RG660

(Page 38)

5-19. PRINTED WIRING BOARDS — JACK SECTION — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

1

A

B

C

D

E

2 3 4 5 6 7 8 9 10 11

E

MAIN BOARD CN305CN308

FMAIN BOARD CN310

(RG660 AEP/UK MODEL)(EXCEPT RG660 AEP/UK MODEL)

1-688-082-

JACK BOARD

(12)12CN006

C018

C011

C015

C014

C017

C012

C013

5 8

14

C054

C016

WIRE002

(CHASSIS)

VR001MIC LEVEL

JK004VIDEOOUT

1-688-084-

VIDEO OUT BOARD

(12)12

R AUDIO L VIDEOJK005

GAME INPUTJK003MIC

1

3 1

4 76

5

2 3

JK006PHONES

14 7

85

2 3

1

2

C057

EXCEPT RG660 AEP/UK MODEL


EXCEPT RG660AEP/UK MODEL


(Page 38)

4242

HCD-RG550/RG660

(Page 36)

(Page 34)

5-20. SCHEMATIC DIAGRAM — JACK SECTION —

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11

FMAIN BOARD

CN310

EMAIN BOARD

4.7

4.7

4.7

4.79.9

9.9

4.7

4.75.3

4.7



RG660 AEP/UK MODEL



EXCEPT RG660AEP/UK MODEL

IC001

CN305 CN308

IC001:A

IC001:B

CN004 5P

CN007 7P 3P

PHONESJK006

JK003MIC

MIC LEVEL

JK004VIDEO OUT

JACK BOARD

VIDEO OUTBOARD

L

R

AUDIO

VIDEO

GAMEINPUT

JK005

JR0050

JR0060

MIC AMP

CN006 2P

C057 0.1

43 43

HCD-RG550/RG660

(Page 38)(Page 38)

(Page 46)

5-21. PRINTED WIRING BOARD — POWER AMP SECTION — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11

C514

C518

C522

C512

C517

C521C511

R537

C513

R504

R502

R597

R503

R595

R81

R99

R86

R55

R92

R95

R56

C33

C540

R571

C527 C524 C526

C525

L501

C34 C37RY501

C41

C24 LP902C23

C22

C9

C10

D1

EP01 LP903

CN1

D2

C13

C11

Q533

C12

C531

CN502CN501

C529

RY502

R570

L502

(–) (+)

L

R

FRONTSPEAKER

L

R

SURROUNDSPEAKER

JK502(1/2)

JK502(2/2)

IMPEDANCEUSE 6–16Ω( )

IMPEDANCEUSE 24Ω( )

RG660

RG660

RG550

L

R

SPEAKERJK502

IMPEDANCEUSE 6–16Ω( )

EP501

R538

GMAIN BOARD CN306

HMAIN BOARD CN307

K TRANS BOARDCN902

(RG660)

JTRANS BOARD

CN902(RG550)

R501

R598

D42

D41

D584

(11)

11

POWER AMP BOARD

RG550:1-688-089-RG660:1-688-699-

(Page 47)

D1 G-9D2 G-10D11 F-7D12 F-8D13 F-9D16 F-11D17 F-11D18 B-3D19 B-3D20 A-3D23 E-4D24 G-4D25 E-4D29 D-4D30 D-5D31 D-4D32 D-4D33 C-4D34 E-4D35 E-4D36 E-4D37 D-4D38 D-4D39 F-6D40 F-6D41 E-4D42 F-4D501 C-4D502 B-4D503 C-4D504 B-4D505 C-3D506 B-3D507 B-4D508 A-4D509 C-2D510 B-4D511 G-4D512 I-3D513 I-5D514 F-8D515 I-10

Q5 F-8Q6 F-8Q7 F-7Q8 F-8

Ref. No. Location

• Semiconductor LocationRef. No. LocationQ9 F-8Q10 B-3Q11 B-3Q12 A-3Q13 A-4Q17 F-4Q18 F-4Q19 F-3Q20 D-4Q21 D-4Q22 E-4Q23 D-4Q24 D-4Q501 E-2Q502 C-2Q503 D-2Q504 B-2Q505 F-2Q506 D-3Q507 E-3Q508 C-2Q509 E-3Q510 C-3Q511 C-4Q512 A-3Q513 C-3Q514 A-3Q515 C-4Q516 B-4Q517 C-4Q518 B-4Q519 C-4Q520 B-4Q521 B-4Q522 A-4Q523 B-4Q524 A-4Q525 C-4Q526 B-5Q527 F-5Q529 I-4Q530 H-6Q532 H-4Q533 I-9Q534 I-9Q535 I-8Q536 I-8

4444

HCD-RG550/RG660

(Page 36)

5-22. SCHEMATIC DIAGRAM — POWER AMP SECTION (1/2) —

7

5

7(RG550)(RG660)

5(RG550)(RG660)

6

6

D509

D510

R45R46

CN501

CN502

R591

R592

R562

JW1

R79

D33

R72

C34 R70

R77

R54

D37

R75Q22

C37

R85

R94

R560

R556

R558

R559

R557

R554

C514

R555

R553

R539

R545

Q519

R531

Q517 R523

R527

C511

R547

D501

R533R535

R530

D502

Q518

Q520

R546

R540EP501

D508

R534R536

C512

R548

R520R526

R528

R61D31

D32

R41 R64

R26

D38

R52

Q11

R51

R50

Q10

D19 D18

R49 R48 R47

D20

Q13

R518

R510

R506

R512

Q50

6

R524

D504 TH502

R511

R509

Q50

5

R505

R519R525 R517

D505

D507

TH501

D503

R529

C530

R90

R86

R99Q20

D24R92

R78R58C42

R59

Q23R60

R56

R55

R74

D34

D36JW2

D35

C30

C45

R53

C40

R91

R96

C31

Q21

R76

D23

D29

R542

R544

C513

R538

Q52

3

R543

R541

C509

R537

C503

Q52

1

Q51

3

Q51

1

Q507

Q509

Q508

C510

Q510

C504

C501

C502

R67

R66

C26

R65

C25 R68

R561

C523

Q51

6

D506

Q24

C35

Q51

4

Q51

2

Q52

2

Q52

4

Q51

5

D25

D30

C507 C505

C508 C506

Q17

JR516

C521 C517

Q525R569

R599

C519

R549

R550

C518C522

C520

Q526

R500

C538JR514

JR513 R521

Q501

R513

JR511Q503

R522

R532

R516

R514

Q502

JR517

Q504

R83

R81

R93

R95

R82

R71

C43

JR512

R515

D41

C33

D42

C41

R43

R69 R98 R62

R42

R27

R97

R63

R508R502

R504

R501

R503

R507

Q19

Q527

Q12

Q18

C540

R595

R597

R596

R598

R964.7k10k

R413.3k10k

(RG550)(RG660)

R832.7k4.7k

(Page 37)

(Page 45)

45 45

HCD-RG550/RG660

(Page 48)

(Page 44)

5-23. SCHEMATIC DIAGRAM — POWER AMP SECTION (2/2) —

C13

C23R20R19R18

D13

R21 R23

R22

R40

C24

R39

R38D17D16

R16 R17

D40

D12

R593C529R576

R575

D513

R577R594

R589

D511

L502

R570R571

L501

EP502

R105

R104R106

R103

R108

R107

R110

R109

C6

C5

C8

C7

R563 R564

Q534

R567 R568

C531

Q536

Q535 R580

R581

R29R100

R44

R73

D11

R4

D39

D514

Q5 Q6

Q529

Q530

D512

R588

C535 C534

C544C543

R574R578

C541 C542

R604R602

R603R601

C532C533

R13

Q8Q9

Q7

EP01

RY502

RY501

R31

D515

C1 C2

C3 C4

CN1

JW3JR2

R9

R7R6

R8

C22

R32 R33

R34R35

R36

R37

JW8

JW11

JW12

JW6 JW7

JW13

D1

C9

C10

C11

C12

R102

R12

R14

Q533

Q532

R587

R586

JK502

R573

C525

C527

R572

C524

C526

JW551 JW552JK502

D2

4646

HCD-RG550/RG660

(Page 43)

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11

LP901

LP904

AC IN

1

2

3

4

5

6

7

8

E2,E3,E51 model

E2,E3,E51 model

MX model

TRANS BOARD

(11)

11

JPOWER AMP

BOARD CN1

11

1

JW934

LP906

JW935

7

6

5

4

3

2

1

8

9

10

11

12

13

14

15

16

17


4

3

2

1

7

6

5

8

POWER TRANSFORMER

WHT

BLK

VOLTAGE SELECTOR

JW903

JW92

0

JW901

JW926

JW909

JW922

JW921

JW913

JW919

JW918

JW924

JW917

JW916

JW915

JW929

JW92

7

JW92

8

JW91

0 JW91

1

JW91

2

JW91

4

JW90

2

JW92

3

JW92

5

JW93

1

JW93

2

JW93

0

120V

220V

230-240V

1-688-088-

Ref. No. LocationD901 A-5D902 C-8D903 B-8D904 C-8D905 B-8D906 A-2


5-24. PRINTED WIRING BOARD — TRANSFORMER SECTION (HCD-RG550) — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

47 47

HCD-RG550/RG660

(Page 43)

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11

E3 model

E3 model

AEP,UK model

TRANS BOARD

(11)

11

JW935

JW934

LP906

KPOWER AMP

BOARD CN1

11

1

LP901

7

6

5

4

3

2

1

8

9

10

11

12

13

14

15

16

17


4

3

2

1

7

6

5

8

POWER TRANSFORMER

LP904

JW915

JW916

JW917

JW914

JW918

JW90

2

JW919

JW913

JW91

0 JW91

1

JW91

2

JW92

0 JW92

3

JW92

7

JW92

8

JW92

4

JW92

5

JW930JW929

JW931

JW932

JW921

JW922

JW909

JW926

JW903

JW901

VOLTAGE SELECTOR

WHT

BLK

AC IN

1

2

3

4

5

6

7

8

120V

220V

230-240V

1-688-698-

Ref. No. LocationD901 A-5D902 C-8D903 B-8D904 C-8D905 B-8D906 A-2


5-25. PRINTED WIRING BOARD — TRANSFORMER SECTION (HCD-RG660) — • Refer to page 28 for “5-5. CIRCUIT BOARDS LOCATION”. : Uses unleaded solder.

4848

HCD-RG550/RG660

(Page 45)

5-26. SCHEMATIC DIAGRAM — TRANSFORMER SECTION —

AEP,UK,MX MODEL

D906

D901

D902D903

D905 D904

RY902

RY901

CN902

C902

T902

JW909

S901

CN901

C901

T901

F902

F905

F903

F904

F906

AC1

AC2

49

HCD-RG550/RG660

IC721 LC78646E-E (BD Board)

5-27. IC BLOCK DIAGRAMS

6059585756555453521

234567891011121314151617181920

21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

SLCOSLCISTEFMIN

RF

FDO

SPDO

SLDO

GPDA

C

FDO

SPDO

SLDO

GPDA

C

CONT

4CO

NT5

SBCK

/CON

T6SB

CK/F

GDE

FECT

CONT

4CO

NT5

SBCK

/CON

T6SB

CK/F

GDE

FECT V/P

V/P

FSEQ

MON

I1M

ONI2

MON

I3M

ONI4

MON

I5

V/P

FSEQ

MON

I1M

ONI2

MON

I3M

ONI4

MON

I5VS

SVD

D(3.

3V)

69 68 67 66 65 64 63 62 61

VSS

VDD5

DRF

RES

WRQ

DO DI CL CE

79 78 77 76 75 74 73 72 71

LDS

80

LDD

FR VVDD

PCKI

STVV

SSPD

O2PD

O1CO

NT1

CONT

2

70

CONT

3

WRQ

DODI

CLCE

FR

VVDDPCKIST

VVSS

SBCK/FG

PDO2PDO1

CONT1-3

SBCK/CONT6CONT4,5

DRF

WRQ

DO DI CL CELDS

LDD

LDSLDD

FR VVDD

PCKI

STVV

SSPD

O2PD

O1CO

NT1

CONT

2CO

NT3

RFVDDRFVSS

FIN1FIN2TIN1TIN2VREF

FIN1

FIN2

TIN1

TIN2

REFI

REFI

DEFECT

FETEC

TERFMON

JITTCADAVDDADAVSS

TDO

SLCOSLCISTEFMIN

RF

FIN1FIN2TIN1TIN2VREFREFI

FETEC

TERFMON

JITTC

JITTC

ADAVDDADAVSS

ADAVDDADAVSS

TDO

DATADATACKLRSYASDFINASDACKASLRCK

DATADATACK

LRSY

RVDDRVSS

RCHOLCHOLVSSLVDD

ASDFINASDACKASLRCK

16MOUTEFLGC2F

FSX/16MIN

EFLGC2F

FSX/16MIN

XVSS

XINXOUTXVDD

16MOUTXVSSXINXOUTXVDD

RVDDRCHORVSSLVSSLCHOLVDD

DATADATACKLRSYASDFINASDACKASLRCK16MOUTEFLGC2F

FSX/16MINXVSS

XINXOUTXVDDRVDDRCHORVSSLVSSLCHOLVDD

39 40

DOUT

TEST

5150494847464544434241

+– MIX PH

BH

MONICONT

AGC

+–

+–

+–

+–

+–

+–

LPF

TBAL

TBAL

RAM

TDO

TRACK JUMP

SW D/A

APC

SUBCODE DECODE CRC

GENERAL PURPOSEPORTS

8FSDIGITAL FILTER

1BIT DAC LPF

ERRORCORRECTION

AUDIO CD

MONITOR SIGNAL SELECTOR

EXTERNALAUDIO IN

AUTO ADJUST

FRAME SYNCDETECT,PROTECT,INSERT,

EFM DECODE

A/D

CLOCKGENERATOR

COMMANDINTERFACE

SERVO PROCESSOR

LEVEL SET

+–

S/H

SW

DRFDRF

ATTENUATIONDEEMPHASIS

INTERPOLATIONMUTE

RUPTURE DEFECT

SLICE LEVELCONTROL

CLV,CAVCONTROL

SERIALOUT

AUDIO OUT

RAM

JITTERDETECT

PLLVCEC

FE TE TEC RF

RFMON

VREF

SPDOSLDO

GPDAC

FSEQ

MONI1-5

FDO

LPF

LPF

EQ

50

HCD-RG550/RG660

IC301 M61529FP (MAIN Board)

IC701, 712 BA6956AN (DRIVER Board)

1 2 3 4 5 6 7 8 9

CONTROL LOGIC

TSD

VREF

OUT2

OUT1

RNF

VM VCC

FIN

GND

RIN

1

REF

2

MIC

3

INA1

REF

EXTERNALINPUT ATT

INPUTATT

4

INB1

5

INC1

6

IND1

7

RECA

1/IN

EX1

8

RECB

1

9

TMI1

10

TMO1

11

TCA1

12

TCB1

13

TCC1

14

TOUT

1

16

BB A

1

17

BB B

1

15

VOLI

N1

VOCALCUT

TONE ATT

+

TONE CONTROL(BASS/MID/TREBLE)

ELECTRICALVOLUME

18

OUT1

19

SAOU

T

20

VCC

BASSBOOST

21

DATA

MCUINTERFACE

42

SUR1

/DPL

1

41

SUR2

/DPL

2

40

INA2

INPUTATT

39

INB2

38

INC2

37

IND2

36

RECA

1/IN

EX2

35

RECB

2

34

TMI2

33

TMO2

32

TCA2

31

TCB2

30

TCC2

29

TOUT

2

27BB

A2

26

BB B

2

28

VOLI

N2

+TONE ATT

TONE CONTROL(BASS/MID/TREBLE) ELECTRICAL

VOLUME

25

OUT2

24

SWOU

T

23

GND

BASSBOOST

22

CLOC

K

+SURROUNDOR

DPL BUFFER

+

51

HCD-RG550/RG660

IC201 HA12237F (MAIN Board)

31PB-NF1 (L)

32AIN (L)

33RIP

34BIN (L)

35REC-RETURN

36GND

37BIN (R)

38NC

39AIN (R)

40PB-NF1 (R)

1

PB-N

F2 (R

)

2

PB-E

Q (R

)

3

EQOU

T (R

)

4

TAI (

R)

5

PBOU

T (R

)

6

NC

7

RECI

N (R

)

8

ALC

(R)

9

NC

10

RECO

UT (R

)

15 REC MUTE OFF/ON

14 MUTE ON/OFF

13 A/B(REC RETURN ON/OFF)

12 HIGH/NORM

11 ALC ON/OFF

30

PB-N

F2 (L

)

29

PB-E

Q (L

)

28

EQOU

T (L

)

27

TAI (

L)

26

PBOU

T (L

)

25

NC

24

RECI

N (L

)

23

ALC

(L)

22

NC

21

RECO

UT (L

)

EQ

ALC

19 IREF

18 GND

17 ALC DET

EQ

20 TEST MODE

16 VCC

93/120(HIGH/NORM) MUTE

A B

A B

RETURN SW

RETURN SW

93/120(HIGH/NORM) MUTE

52


EXPLODED VIEWS

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• Accessories are given in the last of thisparts list.


Ref. No. Part No. Description Remark

6-1. MAIN SECTION


notsupplied

notsupplied

not supplied

not supplied(VIDEO OUT board)

not supplied

#1

#2

#3

#3

#1

#1

#1#1

#1

#1

#1

#2

#1

#1

#1

#1

#1

#1

TU901

M731

#1

1

1

3

45

1

2

1

front panelsection

main board section

CDM74F-K6BD71B

A

A

6

1 3-363-099-41 SCREW (CASE 3 TP2)2 4-245-184-31 CASE (SIDE-R)3 4-245-183-31 CASE (SIDE-L)4 4-246-172-11 CD DOOR (RG550)4 4-246-172-31 CD DOOR (RG660)

5 4-244-849-11 CASE (TOP)6 1-769-939-11 WIRE (FLAT TYPE) (11 CORE)

M731 1-763-072-11 FAN, DCTU901 1-693-626-11 TUNER PACK (FM/AM) (ANTENNA) (AEP,UK)TU901 1-693-628-11 TUNER PACK (FM/AM) (ANTENNA)

(E2,E3,E51,MX)#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3#2 7-685-872-09 SCREW +BVTT 3X8 (S)

#3 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

53

HCD-RG550/RG660

6-2. FRONT PANEL SECTION (1)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

51 4-244-686-01 VOLUME KNOB52 4-238-628-12 MIC KNOB (RG550)53 1-688-081-21 6 STREAM LED BOARD54 A-4748-824-A PANEL BOARD, COMPLETE (RG550)54 A-4748-832-A PANEL BOARD, COMPLETE (RG660:E3)

54 A-4748-860-A PANEL BOARD, COMPLETE (AEP,UK)55 4-244-902-01 FL HOLDER (L)56 4-244-903-01 FL HOLDER (R)57 4-951-620-01 SCREW (2.6X8), +BVTP58 1-769-914-11 WIRE (FLAT TYPE) (9 CORE)

59 1-773-322-11 WIRE (FLAT TYPE) (31 CORE)60 1-827-145-11 WIRE (FLAT TYPE) (13 CORE)61 1-796-487-41 DECK, MECHANICAL62 4-243-608-01 BELT (BR)63 4-243-609-01 BELT (AF)

64 4-243-610-01 BELT (AL)65 A-4749-074-A JACK BOARD, COMPLETE (RG550)65 A-4749-077-A JACK BOARD, COMPLETE (AEP,UK)FLD601 1-518-871-11 INDICATOR TUBE, FLUORESCENT#3 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

FLD601

not supplied

not supplied(REMOTE board)

not supplied

not supplied

54

55

56

57 57

5757

5757

57

57

58

59

60

51

53

61

62

6364

64

65

52#3

#3

54

HCD-RG550/RG660


102

102

101103104

105

106

107

108

109 111

114

113

112

110

112


101 4-244-701-01 CASS DOOR SPRING (B)102 4-238-631-01 TAPE SPRING103 4-244-666-11 CASS DOOR (R)104 4-244-668-01 CASS WINDOW (R)105 4-244-700-01 CASS DOOR SPRING (A)

106 4-244-667-01 CASS WINDOW (L)107 4-244-663-11 CASS DOOR (L)

108 4-244-661-11 SUB PANEL109 4-244-669-01 DISPLAY WINDOW110 4-231-824-01 CAM (A), HEART111 4-231-836-01 SPRING (HEART CAM-A)112 4-224-104-41 DAMPER

113 4-231-841-01 SPRING (HEART CAM-B)114 4-231-825-01 CAM (B), HEART

55

HCD-RG550/RG660


151

152

153

164

154

155

156

157

158

159

160not supplied

161

162

163


151 4-244-899-01 FRONT PANEL (RG550)151 4-244-899-11 FRONT PANEL (AEP,UK)151 4-244-899-21 FRONT PANEL (RG660:E3)152 4-233-980-01 RUBBER FOOT153 4-244-900-01 CURSOL BUTTON

154 4-244-676-11 FUNCTION BUTTON155 4-244-677-01 POWER LENS156 4-244-678-01 FUNCTION LENS

157 4-244-908-01 RECORD BUTTON (B)158 4-246-092-01 DISPLAY BUTTON (B)159 4-244-684-11 EQ BUTTON160 4-244-906-11 CONTROL BUTTON (B)161 4-246-093-01 PAUSE BUTTON (B)

162 4-244-679-11 DISC BUTTON163 4-244-901-01 CURSOL HOLDER164 3-038-018-01 EMBLEM, SONY

56

HCD-RG550/RG660

6-5. MAIN BOARD SECTION


F905F903F904

F902

F906

T901

#3

#1

#1

#1

#1

#1

#1

not supplied

not supplied

not supplied

not supplied

201202

203

204

205

206

207

208

208


201 A-4748-821-A MAIN BOARD, COMPLETE202 4-988-533-01 HOLDER, PWB203 1-688-088-11 TRANS BOARD (RG550)203 1-688-698-11 TRANS BOARD (RG660)204 A-4748-796-A POWER AMP BOARD, COMPLETE (RG550)

204 A-4748-855-A POWER AMP BOARD, COMPLETE (RG660)0205 1-777-071-83 CORD, POWER (AEP,UK)0205 1-791-901-12 CORD, POWER (E2,E3,E51)0205 1-827-226-11 CORD, POWER (MX)

206 3-703-571-11 BUSHING (S) (4516), CORD (E2,E3,E51,MX)

* 206 3-703-244-00 BUSHING (2104), CORD (AEP,UK)207 3-905-609-01 SCREW (TRANSISTOR)

208 4-242-527-01 S-SCREW, ITC+4-8 R0F902 1-533-470-11 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)0F903 1-533-472-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)0F904 1-533-472-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)0F905 1-576-655-11 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)

0F906 1-576-655-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)0T901 1-439-846-11 TRANSFORMER, POWER (RG550)0T901 1-439-855-11 TRANSFORMER, POWER (RG660:E3)0T901 1-439-856-11 TRANSFORMER, POWER (AEP,UK)



57

HCD-RG550/RG660

6-6. CD MECHANISM DECK SECTION (1)(CDM74F-K6BD71B)


251 266

252

253

254

255255

256

256257

257

258

258259

251

256

262

263

264265260

261264

M741

chassis assy

251 4-218-253-21 SCREW (M2.6), +BTTP252 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)253 1-687-134-11 MOTOR (TB) BOARD254 4-243-815-01 TABLE (LOADING)255 4-245-571-02 GEAR (STOPPER)

256 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING257 4-245-570-01 GEAR (JOINT)258 4-245-572-01 BUSHING (GEAR)259 1-687-132-11 SENSOR BOARD

260 4-243-820-01 GEAR (TABLE)261 4-243-819-01 GEAR (GENEVA)262 4-243-816-01 TRAY263 4-243-823-01 BELT (TABLE)264 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING

265 4-243-821-01 PULLEY (TABLE)266 3-231-598-01 SHEET (BA)M741 A-4723-963-A MOTOR ASSY, TABLE (TABLE)

58

HCD-RG550/RG660

6-7. CD MECHANISM DECK SECTION (2)(CDM74F-K6BD71B)

301

302

302

302

303

304

305

306

307

308

309

310

311 312

313

314

315

316

318319

320321

321

322

322

324 323

326

325

317

321

321

320

320

320

305

305

305

305

M751

BU-K6BD71B

RE701

305

322

324


301 1-687-135-11 DRIVER BOARD302 4-218-253-31 SCREW (M2.6), +BTTP303 1-687-669-11 SW BOARD304 4-244-034-01 BELT (LOADING)305 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING

306 4-225-844-01 GEAR (LOADING A)307 4-224-613-01 GEAR (SHAFT)308 1-687-133-11 MOTOR (LD) BOARD309 4-244-108-01 GEAR, SWING310 4-224-609-01 GEAR (LOADING C)

311 4-224-608-01 COLLAR, SWING312 3-016-533-11 WASHER (FR), STOPPER313 4-224-611-01 GEAR (LOADING B)314 4-224-606-01 GEAR (RV)315 4-243-818-01 GEAR (U/D)

316 4-243-822-01 LEVER (LIFTER)317 1-471-035-11 MAGNET ASSY318 4-231-189-01 PULLEY (B), CHUCKING319 X-4955-536-1 HOLDER (213) ASSY320 4-227-549-11 INSULATOR

321 4-227-045-31 SPRING (INSULATOR), COIL322 4-231-151-01 STOPPER (BU)323 1-827-146-11 WIRE (FLAT TYPE) (19 CORE)324 4-218-253-21 SCREW (M2.6), +BTTP325 X-4955-707-1 PULLEY (A5) ASSY, CHUCKING

326 4-243-817-01 CHASSISM751 A-4736-655-A MOTOR ASSY, LOADING (LOADING)RE701 1-477-680-11 ENCODER, ROTARY

(DISC TRAY ADDRESS DETECT)

59

HCD-RG550/RG660

6-8. BASE UNIT SECTION(BU-K6BD71B)



353

#1

352

not supplied

not supplied

not supplied

not supplied

not supplied

not supplied not supplied

notsupplied

351

0351 A-4735-357-A BASE ASSY, OP (including M701,M702)352 1-823-859-11 WIRE (FLAT TYPE) (16 CORE)

353 A-4747-707-A BD BOARD, COMPLETE#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3

60


ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH



When indicating parts by referencenumber, please include the board.

A-4747-707-A BD BOARD, COMPLETE*******************

< CAPACITOR >

C701 1-164-156-11 CERAMIC CHIP 0.1uF 25VC702 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC703 1-164-156-11 CERAMIC CHIP 0.1uF 25VC704 1-126-391-11 ELECT CHIP 47uF 20% 6.3VC705 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C706 1-164-156-11 CERAMIC CHIP 0.1uF 25VC707 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC708 1-164-156-11 CERAMIC CHIP 0.1uF 25VC709 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC710 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C711 1-164-156-11 CERAMIC CHIP 0.1uF 25VC712 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC713 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC714 1-164-156-11 CERAMIC CHIP 0.1uF 25VC715 1-126-401-21 ELECT CHIP 1uF 20% 50V

C716 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC717 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC718 1-115-156-11 CERAMIC CHIP 1uF 10VC719 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC720 1-162-953-11 CERAMIC CHIP 100PF 5% 50V

C721 1-164-156-11 CERAMIC CHIP 0.1uF 25VC722 1-164-156-11 CERAMIC CHIP 0.1uF 25VC723 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC729 1-128-360-11 ELECT CHIP 220uF 20% 10VC731 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C732 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC733 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC734 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC735 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC741 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C742 1-164-156-11 CERAMIC CHIP 0.1uF 25VC743 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC744 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC746 1-164-156-11 CERAMIC CHIP 0.1uF 25VC747 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C748 1-128-360-11 ELECT CHIP 220uF 20% 10VC753 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC754 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC756 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC761 1-162-941-11 CERAMIC CHIP 10PF 0.5PF 50V

C802 1-164-156-11 CERAMIC CHIP 0.1uF 25VC803 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC804 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC805 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC806 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C807 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC810 1-164-156-11 CERAMIC CHIP 0.1uF 25VC811 1-164-156-11 CERAMIC CHIP 0.1uF 25VC812 1-115-156-11 CERAMIC CHIP 1uF 10VC813 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C814 1-126-392-11 ELECT CHIP 100uF 20% 6.3VC815 1-128-360-11 ELECT CHIP 220uF 20% 10VC816 1-164-156-11 CERAMIC CHIP 0.1uF 25VC817 1-164-156-11 CERAMIC CHIP 0.1uF 25VC823 1-162-949-11 CERAMIC CHIP 47PF 5% 50V

C824 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC825 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC829 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC830 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC831 1-162-945-11 CERAMIC CHIP 22PF 5% 50V

C834 1-128-360-11 ELECT CHIP 220uF 20% 10VC835 1-164-156-11 CERAMIC CHIP 0.1uF 25VC837 1-164-156-11 CERAMIC CHIP 0.1uF 25VC843 1-164-156-11 CERAMIC CHIP 0.1uF 25VC844 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C856 1-115-156-11 CERAMIC CHIP 1uF 10VC857 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC858 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC859 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC860 1-162-953-11 CERAMIC CHIP 100PF 5% 50V

< CONNECTOR >

CN708 1-817-244-11 CONNECTOR, FFC 16PCN710 1-778-874-11 CONNECTOR, FFC (LIF(NON-ZIF)) 19P

< FERRITE BEAD >

FB701 1-550-907-21 BEAD, FERRITE (CHIP)FB707 1-550-907-21 BEAD, FERRITE (CHIP)FB708 1-550-907-21 BEAD, FERRITE (CHIP)FB761 1-550-907-21 BEAD, FERRITE (CHIP)FB801 1-550-907-21 BEAD, FERRITE (CHIP)

FB802 1-550-907-21 BEAD, FERRITE (CHIP)FB803 1-550-907-21 BEAD, FERRITE (CHIP)FB804 1-550-907-21 BEAD, FERRITE (CHIP)FB805 1-550-907-21 BEAD, FERRITE (CHIP)

BD


61

HCD-RG550/RG660


FB806 1-550-907-21 BEAD, FERRITE (CHIP)FB807 1-550-907-21 BEAD, FERRITE (CHIP)FB808 1-550-907-21 BEAD, FERRITE (CHIP)

< IC >

IC721 6-701-796-01 IC LC78646E-EIC722 6-704-220-01 IC BA5836FPIC801 6-704-008-01 IC LC78684E-EIC802 6-704-009-01 IC LC32V4265CT-25-MPB-EIC803 6-704-007-01 IC MM1571J

< TRANSISTOR >

Q701 8-729-054-57 TRANSISTOR KTN2907AS-RTK

< RESISTOR >

R701 1-216-841-11 METAL CHIP 47K 5% 1/10WR702 1-216-835-11 METAL CHIP 15K 5% 1/10WR703 1-216-835-11 METAL CHIP 15K 5% 1/10WR704 1-216-835-11 METAL CHIP 15K 5% 1/10WR705 1-216-835-11 METAL CHIP 15K 5% 1/10W

R706 1-216-841-11 METAL CHIP 47K 5% 1/10WR707 1-216-797-11 METAL CHIP 10 5% 1/10WR708 1-216-833-11 METAL CHIP 10K 5% 1/10WR709 1-216-838-11 METAL CHIP 27K 5% 1/10WR711 1-216-815-11 METAL CHIP 330 5% 1/10W

R713 1-216-821-11 METAL CHIP 1K 5% 1/10WR714 1-216-809-11 METAL CHIP 100 5% 1/10WR715 1-216-809-11 METAL CHIP 100 5% 1/10WR716 1-216-809-11 METAL CHIP 100 5% 1/10WR717 1-216-809-11 METAL CHIP 100 5% 1/10W

R718 1-216-809-11 METAL CHIP 100 5% 1/10WR719 1-216-809-11 METAL CHIP 100 5% 1/10WR720 1-216-809-11 METAL CHIP 100 5% 1/10WR721 1-216-809-11 METAL CHIP 100 5% 1/10WR722 1-216-809-11 METAL CHIP 100 5% 1/10W

R725 1-216-819-11 METAL CHIP 680 5% 1/10WR726 1-216-819-11 METAL CHIP 680 5% 1/10WR727 1-216-809-11 METAL CHIP 100 5% 1/10WR728 1-216-841-11 METAL CHIP 47K 5% 1/10WR729 1-216-834-11 METAL CHIP 12K 5% 1/10W

R730 1-216-822-11 METAL CHIP 1.2K 5% 1/10WR731 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR732 1-216-864-11 METAL CHIP 0 5% 1/10WR738 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR739 1-216-864-11 METAL CHIP 0 5% 1/10W

R740 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR741 1-216-864-11 METAL CHIP 0 5% 1/10WR744 1-216-845-11 METAL CHIP 100K 5% 1/10WR745 1-216-809-11 METAL CHIP 100 5% 1/10WR746 1-216-803-11 METAL CHIP 33 5% 1/10W

R747 1-216-803-11 METAL CHIP 33 5% 1/10WR760 1-216-809-11 METAL CHIP 100 5% 1/10WR761 1-216-821-11 METAL CHIP 1K 5% 1/10WR762 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR765 1-216-857-11 METAL CHIP 1M 5% 1/10W

R801 1-216-809-11 METAL CHIP 100 5% 1/10WR802 1-216-809-11 METAL CHIP 100 5% 1/10WR803 1-216-809-11 METAL CHIP 100 5% 1/10W

R804 1-216-809-11 METAL CHIP 100 5% 1/10WR805 1-216-809-11 METAL CHIP 100 5% 1/10WR806 1-216-809-11 METAL CHIP 100 5% 1/10WR807 1-216-809-11 METAL CHIP 100 5% 1/10WR817 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R818 1-216-811-11 METAL CHIP 150 5% 1/10WR819 1-216-821-11 METAL CHIP 1K 5% 1/10WR820 1-216-821-11 METAL CHIP 1K 5% 1/10WR823 1-216-809-11 METAL CHIP 100 5% 1/10WR824 1-216-809-11 METAL CHIP 100 5% 1/10W


R832 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR833 1-216-809-11 METAL CHIP 100 5% 1/10WR834 1-216-809-11 METAL CHIP 100 5% 1/10WR860 1-216-809-11 METAL CHIP 100 5% 1/10W

< SWITCH >

S701 1-771-853-11 SWITCH, DETECTION (LIMIT IN)

< VIBRATOR >

X701 1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz)*************************************************************

1-687-135-11 DRIVER BOARD*************

< CAPACITOR >

C715 1-126-933-11 ELECT 100uF 20% 16VC731 1-126-964-11 ELECT 10uF 20% 50VC735 1-164-159-21 CERAMIC 0.1uF 50VC736 1-164-159-21 CERAMIC 0.1uF 50VC737 1-164-159-21 CERAMIC 0.1uF 50V

C741 1-162-306-11 CERAMIC 0.01uF 30% 16VC751 1-162-306-11 CERAMIC 0.01uF 30% 16VC752 1-164-159-21 CERAMIC 0.1uF 50V

< CONNECTOR >

CN701 1-785-338-11 PIN, CONNECTOR (LIGHT ANGLE) 12PCN702 1-784-766-11 CONNECTOR, FFC 5P

* CN703 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN704 1-785-328-11 PIN, CONNECTOR (LIGHT ANGLE) 2P

< DIODE >

D701 8-719-921-42 DIODE MTZJ-5.1AD711 8-719-109-69 DIODE RD3.6ES-B2

< IC >

IC701 8-759-598-69 IC BA6956ANIC712 8-759-598-69 IC BA6956AN

< TRANSISTOR >

Q731 8-729-029-66 TRANSISTOR DTC114ESA

BD DRIVER

62

HCD-RG550/RG660


< RESISTOR >

R701 1-249-413-11 CARBON 470 5% 1/4WR702 1-247-807-31 CARBON 100 5% 1/4WR711 1-249-417-11 CARBON 1K 5% 1/4WR712 1-249-425-11 CARBON 4.7K 5% 1/4WR713 1-249-433-11 CARBON 22K 5% 1/4W

R721 1-249-425-11 CARBON 4.7K 5% 1/4WR722 1-249-425-11 CARBON 4.7K 5% 1/4WR723 1-249-425-11 CARBON 4.7K 5% 1/4WR731 1-247-807-31 CARBON 100 5% 1/4WR732 1-249-429-11 CARBON 10K 5% 1/4W

R733 1-249-417-11 CARBON 1K 5% 1/4WR734 1-249-430-11 CARBON 12K 5% 1/4WR735 1-247-807-31 CARBON 100 5% 1/4WR751 1-249-425-11 CARBON 4.7K 5% 1/4W

*************************************************************

A-4749-074-A JACK BOARD, COMPLETE (RG550)A-4749-077-A JACK BOARD, COMPLETE (AEP,UK)

*********************

< CAPACITOR >

C009 1-164-156-11 CERAMIC CHIP 0.1uF 25V(RG550)

C011 1-124-464-11 ELECT 0.22uF 20% 50V(RG550)

C012 1-124-463-00 ELECT 0.1uF 20% 50V(RG550)

C013 1-126-964-11 ELECT 10uF 20% 50V(RG550)

C014 1-126-964-11 ELECT 10uF 20% 50V(RG550)

C015 1-124-257-00 ELECT 2.2uF 20% 50V(RG550)

C016 1-124-257-00 ELECT 2.2uF 20% 50V(RG550)

C017 1-124-584-00 ELECT 100uF 20% 10V(RG550)

C018 1-124-584-00 ELECT 100uF 20% 10V(RG550)

C019 1-162-953-11 CERAMIC CHIP 100PF 5% 50V(RG550)


C021 1-164-156-11 CERAMIC CHIP 0.1uF 25V(RG550)


C023 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V(RG550)

C024 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V(RG550)


C026 1-164-156-11 CERAMIC CHIP 0.1uF 25V(EXCEPT RG660:E3)

C027 1-163-005-11 CERAMIC CHIP 470PF 10% 50V(EXCEPT RG660:E3)

C028 1-163-005-11 CERAMIC CHIP 470PF 10% 50V(EXCEPT RG660:E3)

C029 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V(EXCEPT RG660:E3)

C030 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V(EXCEPT RG660:E3)



< IC >

IC001 8-759-710-97 IC NJM4565M-D (RG550)

< JACK >

JK003 1-770-226-11 JACK (LARGE TYPE) (MIC)(EXCEPT RG660:E3)

JK005 1-764-592-11 JACK 3P (GAME INPUT VIDEO,AUDIO L/R)(EXCEPT RG660:E3)

JK006 1-793-829-11 JACK, HEADPHONE (PHONES)(EXCEPT RG660:E3)

< JUMPER RESISTOR >

JR005 1-216-864-11 METAL CHIP 0 5% 1/10W(RG550)

JR006 1-216-864-11 METAL CHIP 0 5% 1/10W(RG550)

< TRANSISTOR >

Q001 8-729-120-28 TRANSISTOR 2SC1623-L5L6 (RG550)

< RESISTOR >

R005 1-216-833-11 METAL CHIP 10K 5% 1/10W(EXCEPT RG660:E3)

R006 1-216-833-11 METAL CHIP 10K 5% 1/10W(EXCEPT RG660:E3)

R007 1-216-833-11 METAL CHIP 10K 5% 1/10W(RG550)

R008 1-216-845-11 METAL CHIP 100K 5% 1/10W(RG550)

R009 1-216-821-11 METAL CHIP 1K 5% 1/10W(RG550)

R010 1-216-837-11 METAL CHIP 22K 5% 1/10W(RG550)

R011 1-216-809-11 METAL CHIP 100 5% 1/10W(RG550)

R012 1-216-845-11 METAL CHIP 100K 5% 1/10W(RG550)

R013 1-216-809-11 METAL CHIP 100 5% 1/10W(RG550)

R014 1-216-848-11 METAL CHIP 180K 5% 1/10W(RG550)

R015 1-216-833-11 METAL CHIP 10K 5% 1/10W(RG550)

R016 1-216-833-11 METAL CHIP 10K 5% 1/10W(RG550)

R017 1-216-821-11 METAL CHIP 1K 5% 1/10W(RG550)

R018 1-216-834-11 METAL CHIP 12K 5% 1/10W(RG550)

R019 1-216-837-11 METAL CHIP 22K 5% 1/10W(RG550)

R020 1-216-837-11 METAL CHIP 22K 5% 1/10W(RG550)

DRIVER JACK

63

HCD-RG550/RG660


R021 1-216-821-11 METAL CHIP 1K 5% 1/10W(RG550)

< VARIABLE RESISTOR >

VR001 1-227-458-11 RES, VAR, CARBON 50K (MIC LEVEL) (RG550)*************************************************************

A-4748-821-A MAIN BOARD, COMPLETE*********************

7-685-872-09 SCREW +BVTT 3X8 (S)

< CAPACITOR >

C101 1-126-963-11 ELECT 4.7uF 20% 50VC102 1-126-963-11 ELECT 4.7uF 20% 50VC103 1-126-933-11 ELECT 100uF 20% 16VC105 1-162-962-11 CERAMIC CHIP 470PF 10% 50V

(AEP,UK)C106 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C107 1-164-156-11 CERAMIC CHIP 0.1uF 25VC201 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC202 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC203 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC204 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C205 1-162-960-11 CERAMIC CHIP 220PF 10% 50V(AEP,UK)

C206 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC221 1-126-947-11 ELECT 47uF 20% 16VC223 1-137-395-11 FILM 0.022uF 5% 100VC225 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C226 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC230 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC231 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC232 1-126-947-11 ELECT 47uF 20% 16VC233 1-130-471-00 MYLAR 0.001uF 5% 50V

C234 1-130-471-00 MYLAR 0.001uF 5% 50VC235 1-126-960-11 ELECT 1uF 20% 50VC236 1-126-933-11 ELECT 100uF 20% 16VC237 1-126-960-11 ELECT 1uF 20% 50VC239 1-130-485-00 MYLAR 0.015uF 5% 50V

C240 1-126-964-11 ELECT 10uF 20% 50VC241 1-130-479-00 MYLAR 0.0047uF 5% 50VC242 1-130-479-00 MYLAR 0.0047uF 5% 50VC244 1-126-947-11 ELECT 47uF 20% 16VC247 1-126-961-11 ELECT 2.2uF 20% 50V

C248 1-126-961-11 ELECT 2.2uF 20% 50VC249 1-126-961-11 ELECT 2.2uF 20% 50VC250 1-126-961-11 ELECT 2.2uF 20% 50VC253 1-126-933-11 ELECT 100uF 20% 16VC254 1-126-963-11 ELECT 4.7uF 20% 50V

C255 1-126-961-11 ELECT 2.2uF 20% 50VC256 1-126-959-11 ELECT 0.47uF 20% 50VC257 1-126-956-11 ELECT 0.1uF 20% 50VC258 1-126-963-11 ELECT 4.7uF 20% 50VC259 1-128-551-11 ELECT 22uF 20% 25V

C260 1-126-959-11 ELECT 0.47uF 20% 50VC261 1-126-959-11 ELECT 0.47uF 20% 50VC265 1-130-489-00 MYLAR 0.033uF 5% 50VC266 1-130-483-00 MYLAR 0.01uF 5% 50V

C267 1-130-483-00 MYLAR 0.01uF 5% 50VC268 1-126-960-11 ELECT 1uF 20% 50VC269 1-126-960-11 ELECT 1uF 20% 50VC272 1-126-960-11 ELECT 1uF 20% 50VC273 1-126-960-11 ELECT 1uF 20% 50V

C285 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC286 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC300 1-164-156-11 CERAMIC CHIP 0.1uF 25VC301 1-126-964-11 ELECT 10uF 20% 50VC302 1-126-964-11 ELECT 10uF 20% 50V

C303 1-104-665-11 ELECT 100uF 20% 10VC304 1-126-963-11 ELECT 4.7uF 20% 50VC305 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

(AEP,UK)C306 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

(AEP,UK)C307 1-126-964-11 ELECT 10uF 20% 50V

C308 1-126-964-11 ELECT 10uF 20% 50VC309 1-126-964-11 ELECT 10uF 20% 50VC310 1-126-964-11 ELECT 10uF 20% 50VC311 1-126-964-11 ELECT 10uF 20% 50VC312 1-126-964-11 ELECT 10uF 20% 50V

C313 1-107-714-11 ELECT 10uF 20% 16VC314 1-107-714-11 ELECT 10uF 20% 16VC317 1-126-964-11 ELECT 10uF 20% 50VC318 1-126-964-11 ELECT 10uF 20% 50VC319 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C320 1-130-487-00 MYLAR 0.022uF 5% 50VC321 1-130-487-00 MYLAR 0.022uF 5% 50VC323 1-130-487-00 MYLAR 0.022uF 5% 50VC324 1-130-487-00 MYLAR 0.022uF 5% 50VC325 1-130-491-00 MYLAR 0.047uF 5% 50V

C326 1-130-491-00 MYLAR 0.047uF 5% 50VC327 1-130-476-00 MYLAR 0.0027uF 5% 50VC328 1-130-476-00 MYLAR 0.0027uF 5% 50VC331 1-130-494-11 MYLAR 0.082uF 5% 50VC331 1-136-169-00 FILM 0.22uF 5% 50V

C332 1-130-494-11 MYLAR 0.082uF 5% 50VC332 1-136-169-00 FILM 0.22uF 5% 50VC333 1-130-493-00 MYLAR 0.068uF 5% 50VC333 1-136-171-00 FILM 0.33uF 5% 50VC334 1-130-493-00 MYLAR 0.068uF 5% 50V

C334 1-136-171-00 FILM 0.33uF 5% 50VC337 1-126-964-11 ELECT 10uF 20% 50VC339 1-126-934-11 ELECT 220uF 20% 16VC342 1-164-156-11 CERAMIC CHIP 0.1uF 25VC345 1-126-933-11 ELECT 100uF 20% 16V

C348 1-126-947-11 ELECT 47uF 20% 16VC349 1-126-964-11 ELECT 10uF 20% 50VC350 1-126-964-11 ELECT 10uF 20% 50VC351 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC352 1-162-962-11 CERAMIC CHIP 470PF 10% 50V

C353 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC354 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC355 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC356 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC357 1-126-926-11 ELECT 1000uF 20% 10V

C359 1-126-947-11 ELECT 47uF 20% 16V

JACK MAIN

64

HCD-RG550/RG660


C361 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC362 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC363 1-126-964-11 ELECT 10uF 20% 50VC364 1-126-964-11 ELECT 10uF 20% 50VC365 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C366 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC369 1-126-964-11 ELECT 10uF 20% 50VC370 1-126-964-11 ELECT 10uF 20% 50VC371 1-126-947-11 ELECT 47uF 20% 16VC372 1-126-964-11 ELECT 10uF 20% 50V

C373 1-130-483-00 MYLAR 0.01uF 5% 50VC374 1-130-483-00 MYLAR 0.01uF 5% 50VC375 1-126-943-11 ELECT 2200uF 20% 25VC377 1-126-963-11 ELECT 4.7uF 20% 50VC378 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C380 1-126-935-11 ELECT 470uF 20% 16VC381 1-126-947-11 ELECT 47uF 20% 16VC386 1-126-947-11 ELECT 47uF 20% 16VC390 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC391 1-162-953-11 CERAMIC CHIP 100PF 5% 50V

C392 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC393 1-126-959-11 ELECT 0.47uF 20% 50VC395 1-104-665-11 ELECT 100uF 20% 10VC397 1-104-665-11 ELECT 100uF 20% 10VC398 1-126-964-11 ELECT 10uF 20% 50V

C399 1-126-935-11 ELECT 470uF 20% 16VC401 1-164-156-11 CERAMIC CHIP 0.1uF 25VC402 1-164-156-11 CERAMIC CHIP 0.1uF 25VC411 1-107-713-11 ELECT 4.7uF 20% 35VC412 1-107-713-11 ELECT 4.7uF 20% 35V

C417 1-126-926-11 ELECT 1000uF 20% 10VC418 1-130-483-00 MYLAR 0.01uF 5% 50VC419 1-130-483-00 MYLAR 0.01uF 5% 50VC420 1-126-943-11 ELECT 2200uF 20% 25VC421 1-126-934-11 ELECT 220uF 20% 16V

C423 1-126-947-11 ELECT 47uF 20% 16VC424 1-162-919-11 CERAMIC CHIP 22PF 5% 50V




(AEP,UK)

C428 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V(AEP,UK)



C431 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V(AEP,UK)








C441 1-165-128-11 CERAMIC CHIP 0.22uF 16V(AEP,UK)


C447 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC448 1-164-156-11 CERAMIC CHIP 0.1uF 25V


(AEP,UK)C450 1-126-964-11 ELECT 10uF 20% 50VC451 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

(AEP,UK)



< CONNECTOR >

CN101 1-568-830-11 CONNECTOR, FFC 11P (EXCEPT AEP,UK)CN101 1-784-776-11 CONNECTOR, FFC 15P (AEP,UK)

* CN202 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P* CN203 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P

CN303 1-564-506-11 PLUG, CONNECTOR 3P

CN304 1-784-792-11 CONNECTOR, FFC 31PCN306 1-778-982-21 CONNECTOR, BOARD TO BOARD 13PCN307 1-778-982-21 CONNECTOR, BOARD TO BOARD 13P

* CN308 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7PCN310 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P

CN311 1-568-828-11 CONNECTOR, FFC 9PCN312 1-784-780-11 CONNECTOR, FFC 19P

< DIODE >

D101 8-719-988-61 DIODE 1SS355TE-17 (AEP,UK)D102 6-500-522-21 DIODE 10EDB40-TB3D203 8-719-988-61 DIODE 1SS355TE-17D204 8-719-988-61 DIODE 1SS355TE-17D205 8-719-988-61 DIODE 1SS355TE-17

D206 8-719-988-61 DIODE 1SS355TE-17D210 8-719-988-61 DIODE 1SS355TE-17D301 6-500-522-21 DIODE 10EDB40-TB3D302 6-500-522-21 DIODE 10EDB40-TB3D303 6-500-522-21 DIODE 10EDB40-TB3

D304 6-500-522-21 DIODE 10EDB40-TB3D305 8-719-988-61 DIODE 1SS355TE-17D306 8-719-988-61 DIODE 1SS355TE-17D307 8-719-988-61 DIODE 1SS355TE-17D308 8-719-988-61 DIODE 1SS355TE-17

D309 8-719-988-61 DIODE 1SS355TE-17D311 8-719-988-61 DIODE 1SS355TE-17D312 8-719-083-63 DIODE UDZS-TE17-13BD313 6-500-522-21 DIODE 10EDB40-TB3D314 6-500-522-21 DIODE 10EDB40-TB3

D315 6-500-522-21 DIODE 10EDB40-TB3

MAIN

65

HCD-RG550/RG660


D316 6-500-522-21 DIODE 10EDB40-TB3D317 8-719-988-61 DIODE 1SS355TE-17D318 8-719-085-36 DIODE 11EQS04-TB5D319 6-500-522-21 DIODE 10EDB40-TB3D320 6-500-522-21 DIODE 10EDB40-TB3

D321 6-500-522-21 DIODE 10EDB40-TB3D322 6-500-522-21 DIODE 10EDB40-TB3D323 8-719-085-36 DIODE 11EQS04-TB5D324 8-719-988-61 DIODE 1SS355TE-17D325 8-719-988-61 DIODE 1SS355TE-17

D364 8-719-988-61 DIODE 1SS355TE-17D366 8-719-988-61 DIODE 1SS355TE-17D371 8-719-988-61 DIODE 1SS355TE-17D374 8-719-988-61 DIODE 1SS355TE-17

< FERRITE BEAD >

FB1 1-550-907-21 BEAD, FERRITE (CHIP)

< EARTH TERMINAL >

* G1 1-537-738-21 TERMINAL, EARTH

< IC >

IC201 6-702-130-01 IC HA12237FIC301 6-703-650-11 IC M61529FP-D60GIC304 8-759-710-97 IC NJM4565M-DIC305 8-759-701-59 IC NJM78M09FAIC306 6-701-760-01 IC uPC3504AHF

IC308 8-759-701-59 IC NJM78M09FAIC309 6-704-046-01 IC BU2099FVIC310 6-704-046-01 IC BU2099FVIC313 8-759-231-57 IC TA7810S

< JACK >

JK302 1-793-987-11 JACK, PIN 2P (MD(VIDEO)IN)

< JUMPER RESISTOR >

JR124 1-216-864-11 METAL CHIP 0 5% 1/10WJR329 1-216-864-11 METAL CHIP 0 5% 1/10WJR330 1-216-864-11 METAL CHIP 0 5% 1/10WJR331 1-216-864-11 METAL CHIP 0 5% 1/10WJR332 1-216-864-11 METAL CHIP 0 5% 1/10W


JR453 1-216-864-11 METAL CHIP 0 5% 1/10W

< COIL >

L201 1-437-220-11 TRANSFORMER, BIAS OSCILLATIONL301 1-410-527-11 INDUCTOR 100uH

< IC >

PH301 8-749-019-25 IC TOTX141 (DIGITAL OUT)

< TRANSISTOR >

Q210 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q211 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q212 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q218 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q219 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q220 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q221 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q222 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q223 8-729-142-46 TRANSISTOR 2SC2001-LKQ225 6-550-289-01 TRANSISTOR 2SA1235F

Q228 8-729-140-04 TRANSISTOR 2SB1116A-LQ301 6-550-296-01 TRANSISTOR 2SA1980GQ302 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q304 6-550-296-01 TRANSISTOR 2SA1980GQ310 8-729-052-79 TRANSISTOR 2SD1306NETL

Q311 8-729-052-79 TRANSISTOR 2SD1306NETLQ312 6-550-289-01 TRANSISTOR 2SA1235FQ321 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q322 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q324 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q329 6-550-289-01 TRANSISTOR 2SA1235FQ330 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q331 6-550-289-01 TRANSISTOR 2SA1235FQ371 8-729-142-46 TRANSISTOR 2SC2001-LKQ373 8-729-142-46 TRANSISTOR 2SC2001-LK

< RESISTOR >

R101 1-216-833-11 METAL CHIP 10K 5% 1/10WR102 1-216-833-11 METAL CHIP 10K 5% 1/10WR215 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR216 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR218 1-216-849-11 METAL CHIP 220K 5% 1/10W

R219 1-216-833-11 METAL CHIP 10K 5% 1/10WR220 1-216-833-11 METAL CHIP 10K 5% 1/10WR225 1-216-833-11 METAL CHIP 10K 5% 1/10WR226 1-216-833-11 METAL CHIP 10K 5% 1/10WR231 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R232 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR233 1-216-837-11 METAL CHIP 22K 5% 1/10WR234 1-216-837-11 METAL CHIP 22K 5% 1/10WR235 1-216-833-11 METAL CHIP 10K 5% 1/10WR236 1-216-821-11 METAL CHIP 1K 5% 1/10W

R237 1-216-857-11 METAL CHIP 1M 5% 1/10WR238 1-216-853-11 METAL CHIP 470K 5% 1/10WR239 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR241 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR242 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R245 1-216-833-11 METAL CHIP 10K 5% 1/10WR246 1-216-841-11 METAL CHIP 47K 5% 1/10WR249 1-216-853-11 METAL CHIP 470K 5% 1/10WR250 1-216-849-11 METAL CHIP 220K 5% 1/10WR251 1-216-793-11 METAL CHIP 4.7 5% 1/10W

R252 1-216-837-11 METAL CHIP 22K 5% 1/10WR253 1-216-833-11 METAL CHIP 10K 5% 1/10WR256 1-216-833-11 METAL CHIP 10K 5% 1/10WR257 1-216-817-11 METAL CHIP 470 5% 1/10WR258 1-216-809-11 METAL CHIP 100 5% 1/10W

MAIN

66

HCD-RG550/RG660


MAIN

R260 1-216-809-11 METAL CHIP 100 5% 1/10WR261 1-216-817-11 METAL CHIP 470 5% 1/10WR262 1-216-845-11 METAL CHIP 100K 5% 1/10WR263 1-216-833-11 METAL CHIP 10K 5% 1/10WR264 1-216-833-11 METAL CHIP 10K 5% 1/10W

R265 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR266 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR267 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR268 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR269 1-216-833-11 METAL CHIP 10K 5% 1/10W


R282 1-216-809-11 METAL CHIP 100 5% 1/10WR283 1-216-833-11 METAL CHIP 10K 5% 1/10WR284 1-216-833-11 METAL CHIP 10K 5% 1/10WR285 1-216-833-11 METAL CHIP 10K 5% 1/10WR286 1-216-833-11 METAL CHIP 10K 5% 1/10W

R287 1-216-833-11 METAL CHIP 10K 5% 1/10WR288 1-216-833-11 METAL CHIP 10K 5% 1/10WR299 1-216-833-11 METAL CHIP 10K 5% 1/10WR301 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR302 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R303 1-216-837-11 METAL CHIP 22K 5% 1/10WR304 1-216-837-11 METAL CHIP 22K 5% 1/10WR305 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR306 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR307 1-216-809-11 METAL CHIP 100 5% 1/10W


R314 1-216-845-11 METAL CHIP 100K 5% 1/10WR316 1-216-833-11 METAL CHIP 10K 5% 1/10WR317 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR318 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR319 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R320 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR321 1-216-833-11 METAL CHIP 10K 5% 1/10WR322 1-216-833-11 METAL CHIP 10K 5% 1/10WR323 1-216-821-11 METAL CHIP 1K 5% 1/10WR324 1-216-809-11 METAL CHIP 100 5% 1/10W

R325 1-216-833-11 METAL CHIP 10K 5% 1/10WR326 1-216-833-11 METAL CHIP 10K 5% 1/10WR327 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR328 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR329 1-216-864-11 METAL CHIP 0 5% 1/10W

(AEP,UK)


R348 1-216-837-11 METAL CHIP 22K 5% 1/10WR352 1-218-717-11 METAL CHIP 11K 5% 1/10W


R360 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR361 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR362 1-216-837-11 METAL CHIP 22K 5% 1/10WR363 1-216-837-11 METAL CHIP 22K 5% 1/10WR364 1-216-845-11 METAL CHIP 100K 5% 1/10W

R365 1-216-857-11 METAL CHIP 1M 5% 1/10WR368 1-216-809-11 METAL CHIP 100 5% 1/10WR369 1-216-809-11 METAL CHIP 100 5% 1/10WR371 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR372 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R373 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR374 1-216-841-11 METAL CHIP 47K 5% 1/10WR377 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR378 1-216-833-11 METAL CHIP 10K 5% 1/10WR379 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


R390 1-216-833-11 METAL CHIP 10K 5% 1/10WR395 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR396 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR397 1-216-833-11 METAL CHIP 10K 5% 1/10WR398 1-216-833-11 METAL CHIP 10K 5% 1/10W



R410 1-216-833-11 METAL CHIP 10K 5% 1/10WR420 1-216-833-11 METAL CHIP 10K 5% 1/10WR421 1-216-833-11 METAL CHIP 10K 5% 1/10WR422 1-216-806-11 METAL CHIP 56 5% 1/10WR423 1-216-806-11 METAL CHIP 56 5% 1/10W

R424 1-216-837-11 METAL CHIP 22K 5% 1/10WR425 1-216-837-11 METAL CHIP 22K 5% 1/10WR426 1-216-837-11 METAL CHIP 22K 5% 1/10WR427 1-216-134-00 METAL CHIP 2.2 5% 1/8WR428 1-216-134-00 METAL CHIP 2.2 5% 1/8W

R429 1-216-821-11 METAL CHIP 1K 5% 1/10WR430 1-216-833-11 METAL CHIP 10K 5% 1/10WR431 1-216-847-11 METAL CHIP 150K 5% 1/10WR432 1-216-809-11 METAL CHIP 100 5% 1/10W

0R433 1-215-916-11 METAL OXIDE 680 5% 3W F

0R434 1-215-916-11 METAL OXIDE 680 5% 3W FR435 1-216-857-11 METAL CHIP 1M 5% 1/10WR455 1-218-717-11 METAL CHIP 11K 5% 1/10W


67

HCD-RG550/RG660


R456 1-218-717-11 METAL CHIP 11K 5% 1/10WR457 1-216-837-11 METAL CHIP 22K 5% 1/10WR459 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR460 1-216-821-11 METAL CHIP 1K 5% 1/10WR461 1-216-821-11 METAL CHIP 1K 5% 1/10W


R483 1-216-821-11 METAL CHIP 1K 5% 1/10WR484 1-216-833-11 METAL CHIP 10K 5% 1/10WR486 1-216-809-11 METAL CHIP 100 5% 1/10WR487 1-216-134-00 METAL CHIP 2.2 5% 1/8WR488 1-216-134-00 METAL CHIP 2.2 5% 1/8W


*************************************************************

1-687-133-11 MOTOR (LD) BOARD*****************

*************************************************************

1-687-134-11 MOTOR (TB) BOARD*****************

< CONNECTOR >

CN742 1-784-727-11 CONNECTOR, FFC 5P*************************************************************

A-4748-824-A PANEL BOARD, COMPLETE (RG550)A-4748-832-A PANEL BOARD, COMPLETE (RG660:E3)A-4748-860-A PANEL BOARD, COMPLETE (AEP,UK)

**********************

4-244-902-01 FL HOLDER (L)4-244-903-01 FL HOLDER (R)

< CAPACITOR >

C601 1-124-247-11 ELECT 10uF 20% 35VC602 1-124-247-11 ELECT 10uF 20% 35VC603 1-124-589-11 ELECT 47uF 20% 16VC604 1-124-261-00 ELECT 10uF 20% 50VC611 1-126-916-11 ELECT 1000uF 20% 6.3V

C612 1-115-156-11 CERAMIC CHIP 1uF 10VC614 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC615 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC616 1-115-156-11 CERAMIC CHIP 1uF 10VC617 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C618 1-164-156-11 CERAMIC CHIP 0.1uF 25VC619 1-124-234-00 ELECT 22uF 20% 16VC620 1-164-156-11 CERAMIC CHIP 0.1uF 25VC621 1-164-156-11 CERAMIC CHIP 0.1uF 25VC622 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C635 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC636 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC637 1-126-957-11 ELECT 0.22uF 20% 50VC638 1-124-464-11 ELECT 0.22uF 20% 50VC639 1-126-947-11 ELECT 47uF 20% 35V

C640 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C641 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC642 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC643 1-115-156-11 CERAMIC CHIP 1uF 10VC644 1-124-234-00 ELECT 22uF 20% 16VC646 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C647 1-164-156-11 CERAMIC CHIP 0.1uF 25VC648 1-124-257-00 ELECT 2.2uF 20% 50VC649 1-124-234-00 ELECT 22uF 20% 16VC650 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

< CONNECTOR >

CN601 1-784-753-11 CONNECTOR, FFC 31PCN602 1-784-731-11 CONNECTOR, FFC 9PCN603 1-816-422-11 PIN, CONNECTOR 3PCN605 1-784-735-11 CONNECTOR, FFC 13P

* CN606 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7P

< DIODE >

D606 8-719-988-61 DIODE 1SS355TE-17D608 8-719-988-61 DIODE 1SS355TE-17 (E2,E3,E51,MX)D609 8-719-988-61 DIODE 1SS355TE-17 (AEP,UK)D611 8-719-988-61 DIODE 1SS355TE-17 (RG660)D614 8-719-988-61 DIODE 1SS355TE-17

D615 8-719-988-61 DIODE 1SS355TE-17D616 8-719-988-61 DIODE 1SS355TE-17D617 8-719-988-61 DIODE 1SS355TE-17D618 8-719-988-61 DIODE 1SS355TE-17D619 8-719-988-61 DIODE 1SS355TE-17


D625 8-719-988-61 DIODE 1SS355TE-17D626 8-719-083-61 DIODE UDZS-TE17-11BD627 8-719-988-61 DIODE 1SS355TE-17D628 8-719-988-61 DIODE 1SS355TE-17D629 8-719-988-61 DIODE 1SS355TE-17

D630 8-719-988-61 DIODE 1SS355TE-17D631 8-719-988-61 DIODE 1SS355TE-17D633 8-719-988-61 DIODE 1SS355TE-17D634 8-719-988-61 DIODE 1SS355TE-17

< COIL >

FB601 1-412-473-21 INDUCTOR (SMALL TYPE)

< FLUORESCENT INDICATOR >

FLD601 1-518-871-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC601 6-803-328-01 IC LC876796B-51Y1-EIC602 6-704-045-01 IC MM1574AIC603 8-759-533-04 IC M62703ML-E1

< JUMPER RESISTOR >

JR604 1-216-864-11 METAL CHIP 0 5% 1/10WJR605 1-216-864-11 METAL CHIP 0 5% 1/10WJR606 1-216-864-11 METAL CHIP 0 5% 1/10W

MAIN PANELMOTOR (LD) MOTOR (TB)

68

HCD-RG550/RG660





< DIODE >

LED607 6-500-414-01 LED HL-30105Q2AT (CD)LED608 6-500-414-01 LED HL-30105Q2AT (TUNER/BAND)LED609 6-500-414-01 LED HL-30105Q2AT (TAPE A/B)LED610 6-500-414-01 LED HL-30105Q2AT (GAME)LED612 6-500-414-01 LED HL-30105Q2AT (MD(VIDEO))

LED614 6-500-414-01 LED HL-30105Q2AT (POWER)

< TRANSISTOR >

Q601 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q602 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q603 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q604 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q605 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q607 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q609 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q610 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q616 8-729-140-04 TRANSISTOR 2SB1116A-LQ617 8-729-140-04 TRANSISTOR 2SB1116A-L

Q618 8-729-116-56 TRANSISTOR 2SB1068-L

< RESISTOR >

R030 1-216-809-11 METAL CHIP 100 5% 1/10WR031 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR032 1-216-848-11 METAL CHIP 180K 5% 1/10WR033 1-216-837-11 METAL CHIP 22K 5% 1/10WR034 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R035 1-216-841-11 METAL CHIP 47K 5% 1/10WR036 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR037 1-216-817-11 METAL CHIP 470 5% 1/10WR039 1-216-809-11 METAL CHIP 100 5% 1/10WR040 1-216-845-11 METAL CHIP 100K 5% 1/10W










R087 1-216-820-11 METAL CHIP 820 5% 1/10WR088 1-216-820-11 METAL CHIP 820 5% 1/10WR089 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR090 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR601 1-216-839-11 METAL CHIP 33K 5% 1/10W

R602 1-216-809-11 METAL CHIP 100 5% 1/10W(AEP,UK)

R603 1-216-843-11 METAL CHIP 68K 5% 1/10WR604 1-216-833-11 METAL CHIP 10K 5% 1/10WR605 1-216-833-11 METAL CHIP 10K 5% 1/10WR606 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R607 1-216-849-11 METAL CHIP 220K 5% 1/10WR608 1-216-809-11 METAL CHIP 100 5% 1/10W

(AEP,UK)R609 1-216-833-11 METAL CHIP 10K 5% 1/10WR610 1-216-835-11 METAL CHIP 15K 5% 1/10WR611 1-216-809-11 METAL CHIP 100 5% 1/10W

R612 1-216-809-11 METAL CHIP 100 5% 1/10WR613 1-216-821-11 METAL CHIP 1K 5% 1/10WR614 1-216-821-11 METAL CHIP 1K 5% 1/10WR615 1-216-821-11 METAL CHIP 1K 5% 1/10WR616 1-216-817-11 METAL CHIP 470 5% 1/10W

R623 1-216-198-11 RES-CHIP 1K 5% 1/8W

PANEL

69

HCD-RG550/RG660


R623 1-216-817-11 METAL CHIP 470 5% 1/10WR624 1-216-835-11 METAL CHIP 15K 5% 1/10WR625 1-216-817-11 METAL CHIP 470 5% 1/10WR626 1-216-819-11 METAL CHIP 680 5% 1/10WR627 1-216-821-11 METAL CHIP 1K 5% 1/10W

R628 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR629 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR630 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR631 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR632 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R633 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR634 1-216-833-11 METAL CHIP 10K 5% 1/10WR635 1-216-198-11 RES-CHIP 1K 5% 1/8WR635 1-216-817-11 METAL CHIP 470 5% 1/10WR636 1-216-821-11 METAL CHIP 1K 5% 1/10W

R637 1-216-843-11 METAL CHIP 68K 5% 1/10WR638 1-216-835-11 METAL CHIP 15K 5% 1/10WR639 1-216-817-11 METAL CHIP 470 5% 1/10WR640 1-216-819-11 METAL CHIP 680 5% 1/10WR641 1-216-821-11 METAL CHIP 1K 5% 1/10W

R642 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR643 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR644 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR645 1-216-198-11 RES-CHIP 1K 5% 1/8WR645 1-216-817-11 METAL CHIP 470 5% 1/10W

R646 1-216-849-11 METAL CHIP 220K 5% 1/10WR647 1-200-397-11 METAL 4.7M 5% 1/10WR648 1-216-819-11 METAL CHIP 680 5% 1/10WR649 1-216-198-11 RES-CHIP 1K 5% 1/8WR649 1-216-817-11 METAL CHIP 470 5% 1/10W

R650 1-216-843-11 METAL CHIP 68K 5% 1/10WR651 1-216-833-11 METAL CHIP 10K 5% 1/10WR652 1-216-809-11 METAL CHIP 100 5% 1/10WR653 1-216-805-11 METAL CHIP 47 5% 1/10WR654 1-216-833-11 METAL CHIP 10K 5% 1/10W

R655 1-216-841-11 METAL CHIP 47K 5% 1/10WR656 1-216-841-11 METAL CHIP 47K 5% 1/10WR657 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR658 1-216-833-11 METAL CHIP 10K 5% 1/10WR659 1-216-833-11 METAL CHIP 10K 5% 1/10W

R660 1-216-835-11 METAL CHIP 15K 5% 1/10WR661 1-216-837-11 METAL CHIP 22K 5% 1/10WR662 1-216-819-11 METAL CHIP 680 5% 1/10WR663 1-216-821-11 METAL CHIP 1K 5% 1/10WR664 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R665 1-216-809-11 METAL CHIP 100 5% 1/10WR666 1-216-841-11 METAL CHIP 47K 5% 1/10WR667 1-216-813-11 METAL CHIP 220 5% 1/10WR668 1-216-809-11 METAL CHIP 100 5% 1/10WR669 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R670 1-216-845-11 METAL CHIP 100K 5% 1/10WR671 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR672 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR673 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR674 1-216-839-11 METAL CHIP 33K 5% 1/10W

R675 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR676 1-216-821-11 METAL CHIP 1K 5% 1/10WR677 1-216-851-11 METAL CHIP 330K 5% 1/10W

R678 1-216-841-11 METAL CHIP 47K 5% 1/10WR679 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR680 1-216-809-11 METAL CHIP 100 5% 1/10WR681 1-216-833-11 METAL CHIP 10K 5% 1/10WR682 1-218-867-11 METAL CHIP 6.8K 5% 1/10W

R683 1-216-833-11 METAL CHIP 10K 5% 1/10WR684 1-216-835-11 METAL CHIP 15K 5% 1/10WR685 1-216-837-11 METAL CHIP 22K 5% 1/10WR686 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR687 1-216-833-11 METAL CHIP 10K 5% 1/10W

R688 1-216-835-11 METAL CHIP 15K 5% 1/10WR689 1-216-837-11 METAL CHIP 22K 5% 1/10WR690 1-216-839-11 METAL CHIP 33K 5% 1/10WR691 1-216-833-11 METAL CHIP 10K 5% 1/10WR692 1-216-809-11 METAL CHIP 100 5% 1/10W


R698 1-216-809-11 METAL CHIP 100 5% 1/10WR699 1-216-821-11 METAL CHIP 1K 5% 1/10WR902 1-216-841-11 METAL CHIP 47K 5% 1/10WR903 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR904 1-216-829-11 METAL CHIP 4.7K 5% 1/10W





R925 1-218-717-11 METAL CHIP 11K 5% 1/10WR926 1-216-837-11 METAL CHIP 22K 5% 1/10WR927 1-216-837-11 METAL CHIP 22K 5% 1/10WR931 1-216-182-00 RES-CHIP 220 5% 1/8WR932 1-216-813-11 METAL CHIP 220 5% 1/10W

R933 1-216-813-11 METAL CHIP 220 5% 1/10WR934 1-216-813-11 METAL CHIP 220 5% 1/10WR937 1-216-198-11 RES-CHIP 1K 5% 1/8WR938 1-216-198-11 RES-CHIP 1K 5% 1/8WR939 1-216-198-11 RES-CHIP 1K 5% 1/8W

R940 1-216-198-11 RES-CHIP 1K 5% 1/8WR941 1-216-821-11 METAL CHIP 1K 5% 1/10W

PANEL

70

HCD-RG550/RG660


< VIBRATOR >

RES601 1-795-880-11 VIBRATOR, CERAMIC (8.64MHz)

< SWITCH >

S601 1-762-875-21 SWITCH, KEYBOARD (X)S602 1-762-875-21 SWITCH, KEYBOARD (x)S603 1-762-875-21 SWITCH, KEYBOARD (M +)S604 1-762-875-21 SWITCH, KEYBOARD (>)S605 1-762-875-21 SWITCH, KEYBOARD (ALBUM +)

S607 1-762-875-21 SWITCH, KEYBOARD (ALBUM –)S608 1-762-875-21 SWITCH, KEYBOARD (.)S609 1-762-875-21 SWITCH, KEYBOARD (m –)S610 1-762-875-21 SWITCH, KEYBOARD (EDIT/DIRECTION)S611 1-762-875-21 SWITCH, KEYBOARD (FM MODE/REPEAT)

S612 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)S613 1-762-875-21 SWITCH, KEYBOARD (GAME MIXING)S614 1-762-875-21 SWITCH, KEYBOARD (POWER)S615 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)S616 1-762-875-21 SWITCH, KEYBOARD (gG)

S617 1-762-875-21 SWITCH, KEYBOARD (DISC 1)S618 1-762-875-21 SWITCH, KEYBOARD (DISC 2)S619 1-762-875-21 SWITCH, KEYBOARD (DISC 3)S620 1-762-875-21 SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE)S621 1-762-875-21 SWITCH, KEYBOARD (Z)

S622 1-762-875-21 SWITCH, KEYBOARD (EFFECT ON/OFF)S623 1-762-875-21 SWITCH, KEYBOARD (MOVIE EQ)S624 1-762-875-21 SWITCH, KEYBOARD (V)S625 1-762-875-21 SWITCH, KEYBOARD (v)S626 1-762-875-21 SWITCH, KEYBOARD (b)

S627 1-762-875-21 SWITCH, KEYBOARD (CD)S628 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)S629 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)S630 1-762-875-21 SWITCH, KEYBOARD (MD(VIDEO))S631 1-762-875-21 SWITCH, KEYBOARD (GAME)

S632 1-762-875-21 SWITCH, KEYBOARD (SURROUND)S633 1-762-875-21 SWITCH, KEYBOARD (TUNER MEMORY/

PLAY MODE)S634 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S635 1-762-875-21 SWITCH, KEYBOARD (CLEAR) (RG550)S635 1-762-875-21 SWITCH, KEYBOARD (SURR SS MODE) (RG660)

S636 1-762-875-21 SWITCH, KEYBOARD (ENTER)S637 1-762-875-21 SWITCH, KEYBOARD (MUSIC EQ)S638 1-762-875-21 SWITCH, KEYBOARD (GAME EQ)S639 1-762-875-21 SWITCH, KEYBOARD (GROOVE)S640 1-762-875-21 SWITCH, KEYBOARD (P FILE)

S641 1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION)S642 1-762-875-21 SWITCH, KEYBOARD (B)

< ROTARY ENCODER >

VR601 1-477-194-11 ENCODER, ROTARY (12 TYPE) (VOLUME)

< VIBRATOR >

X601 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)*************************************************************

A-4748-796-A POWER AMP BOARD, COMPLETE (RG550)A-4748-855-A POWER AMP BOARD, COMPLETE (RG660)

***************************

< CAPACITOR >

C1 1-165-319-11 CERAMIC CHIP 0.1uF 50VC2 1-165-319-11 CERAMIC CHIP 0.1uF 50VC3 1-165-319-11 CERAMIC CHIP 0.1uF 50VC4 1-165-319-11 CERAMIC CHIP 0.1uF 50VC5 1-165-319-11 CERAMIC CHIP 0.1uF 50V

C6 1-165-319-11 CERAMIC CHIP 0.1uF 50VC7 1-165-319-11 CERAMIC CHIP 0.1uF 50VC8 1-165-319-11 CERAMIC CHIP 0.1uF 50VC9 1-135-929-11 ELECT 0.0033uF 20% 80VC10 1-135-929-11 ELECT 0.0033uF 20% 80V

C11 1-119-940-51 ELECT 4700uF 20% 50VC12 1-119-940-51 ELECT 4700uF 20% 50VC13 1-104-665-11 ELECT 100uF 20% 25VC22 1-126-959-11 ELECT 0.47uF 20% 50VC23 1-126-957-11 ELECT 0.22uF 20% 50V

C24 1-126-947-11 ELECT 47uF 20% 25VC25 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC26 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC30 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC31 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C33 1-128-552-51 ELECT 47uF 20% 63VC34 1-128-552-51 ELECT 47uF 20% 63VC35 1-164-344-11 CERAMIC CHIP 0.068uF 10% 25VC37 1-128-552-51 ELECT 47uF 20% 63VC40 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C41 1-128-552-51 ELECT 47uF 20% 63VC42 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC43 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC45 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC501 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

C502 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC503 1-164-156-11 CERAMIC CHIP 0.1uF 25VC504 1-164-156-11 CERAMIC CHIP 0.1uF 25VC505 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC506 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C507 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC508 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC509 1-164-733-11 CERAMIC CHIP 820PF 10% 50VC510 1-164-733-11 CERAMIC CHIP 820PF 10% 50VC511 1-126-966-11 ELECT 33uF 20% 35V

C512 1-126-966-11 ELECT 33uF 20% 35VC513 1-126-965-11 ELECT 22uF 20% 50VC514 1-126-965-11 ELECT 22uF 20% 50VC517 1-126-960-11 ELECT 1uF 20% 50VC518 1-126-960-11 ELECT 1uF 20% 50V

C519 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC520 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC521 1-126-961-11 ELECT 2.2uF 20% 50VC522 1-126-961-11 ELECT 2.2uF 20% 50VC523 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C524 1-164-156-11 CERAMIC CHIP 0.1uF 25VC525 1-164-156-11 CERAMIC CHIP 0.1uF 25VC526 1-164-156-11 CERAMIC CHIP 0.1uF 25V

PANEL POWER AMP

71

HCD-RG550/RG660


C527 1-164-156-11 CERAMIC CHIP 0.1uF 25VC529 1-126-961-11 ELECT 2.2uF 20% 50VC530 1-164-156-11 CERAMIC CHIP 0.1uF 25VC531 1-104-665-11 ELECT 100uF 20% 10VC532 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C533 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC534 1-165-319-11 CERAMIC CHIP 0.1uF 50VC535 1-165-319-11 CERAMIC CHIP 0.1uF 50VC538 1-164-005-11 CERAMIC CHIP 0.47uF 25VC540 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C541 1-165-319-11 CERAMIC CHIP 0.1uF 50VC542 1-165-319-11 CERAMIC CHIP 0.1uF 50VC543 1-165-319-11 CERAMIC CHIP 0.1uF 50VC544 1-165-319-11 CERAMIC CHIP 0.1uF 50V

< CONNECTOR >

CN501 1-778-981-21 CONNECTOR, BOARD TO BOARD 13PCN502 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P

< DIODE >

D1 6-500-340-01 DIODE G5SBA60L-6088 (RG550)D1 6-500-360-01 DIODE D10XB20 (RG660)D2 6-500-360-01 DIODE D10XB20D11 8-719-988-61 DIODE 1SS355TE-17D12 6-500-334-01 DIODE MC2836

D13 6-500-335-01 DIODE MC2838D16 6-500-335-01 DIODE MC2838D17 6-500-334-01 DIODE MC2836D18 6-500-335-01 DIODE MC2838D19 6-500-334-01 DIODE MC2836

D20 6-500-335-01 DIODE MC2838D23 8-719-988-61 DIODE 1SS355TE-17D24 8-719-988-61 DIODE 1SS355TE-17D25 8-719-083-67 DIODE UDZS-TE17-20BD29 8-719-988-61 DIODE 1SS355TE-17

D30 8-719-083-52 DIODE UDZS-TE17-16BD31 8-719-988-61 DIODE 1SS355TE-17D32 8-719-988-61 DIODE 1SS355TE-17D33 8-719-988-61 DIODE 1SS355TE-17D34 8-719-988-61 DIODE 1SS355TE-17


D40 8-719-988-61 DIODE 1SS355TE-17D41 8-719-312-08 DIODE FMB-G16LD42 8-719-312-08 DIODE FMB-G16LD501 6-500-334-01 DIODE MC2836D502 6-500-334-01 DIODE MC2836

D503 6-500-335-01 DIODE MC2838D504 6-500-335-01 DIODE MC2838D505 8-719-970-83 DIODE HSS82-TJD506 8-719-970-83 DIODE HSS82-TJD507 8-719-988-61 DIODE 1SS355TE-17

D508 8-719-988-61 DIODE 1SS355TE-17D509 6-500-335-01 DIODE MC2838D510 6-500-334-01 DIODE MC2836

D511 8-719-988-61 DIODE 1SS355TE-17D512 8-719-988-61 DIODE 1SS355TE-17 (RG660)D513 8-719-988-61 DIODE 1SS355TE-17D514 8-719-988-61 DIODE 1SS355TE-17D515 8-719-083-70 DIODE UDZS-TE17-27B

< EARTH TERMINAL >

* EP01 1-537-738-21 TERMINAL, EARTH* EP501 1-537-738-21 TERMINAL, EARTH

< TERMINAL BOARD >

JK502 1-694-877-21 TERMINAL BOARD (8P) (FRONT SPEAKER,SURROUND SPEAKER) (RG660)

JK502 1-694-884-11 TERMINAL BOARD (4P) (SPEAKER) (RG550)

< JUMPER RESISTOR >


JR516 1-216-864-11 METAL CHIP 0 5% 1/10WJR517 1-216-864-11 METAL CHIP 0 5% 1/10W

< COIL >

L501 1-422-009-13 COIL, AIR-COREL502 1-422-009-13 COIL, AIR-CORE

< TRANSISTOR >

Q5 6-550-289-01 TRANSISTOR 2SA1235FQ6 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q7 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q8 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q9 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q10 6-550-316-01 TRANSISTOR 2SB792A(RS)Q11 8-729-055-91 TRANSISTOR SRA2202SFQ12 6-550-645-01 TRANSISTOR 2SC3143K4-TBQ13 6-550-316-01 TRANSISTOR 2SB792A(RS)Q17 6-550-289-01 TRANSISTOR 2SA1235F

Q18 6-550-040-01 FET 2SK3053Q19 6-550-040-01 FET 2SK3053Q20 6-550-317-01 TRANSISTOR 2SD814A(RS)Q21 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q22 6-550-316-01 TRANSISTOR 2SB792A(RS)

Q23 6-550-289-01 TRANSISTOR 2SA1235FQ24 6-550-289-01 TRANSISTOR 2SA1235FQ501 6-550-310-01 TRANSISTOR 2SD2439A (RG550)Q501 6-550-320-01 TRANSISTOR 2SD2562 (RG660)Q502 6-550-310-01 TRANSISTOR 2SD2439A (RG550)

Q502 6-550-320-01 TRANSISTOR 2SD2562 (RG660)Q503 6-550-319-01 TRANSISTOR 2SB1649 (RG660)Q503 6-550-389-01 TRANSISTOR 2SB1588A (RG550)Q504 6-550-319-01 TRANSISTOR 2SB1649 (RG660)Q504 6-550-389-01 TRANSISTOR 2SB1588A (RG550)

Q505 6-550-316-01 TRANSISTOR 2SB792A(RS)Q506 6-550-316-01 TRANSISTOR 2SB792A(RS)Q507 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q508 8-729-120-28 TRANSISTOR 2SC1623-L5L6

POWER AMP

72

HCD-RG550/RG660


Q509 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q510 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q511 6-550-413-01 TRANSISTOR 2SC3478LKQ512 6-550-413-01 TRANSISTOR 2SC3478LKQ513 6-550-413-01 TRANSISTOR 2SC3478LK

Q514 6-550-413-01 TRANSISTOR 2SC3478LKQ515 6-550-317-01 TRANSISTOR 2SD814A(RS)Q516 6-550-317-01 TRANSISTOR 2SD814A(RS)Q517 6-550-316-01 TRANSISTOR 2SB792A(RS)Q518 6-550-316-01 TRANSISTOR 2SB792A(RS)

Q519 6-550-316-01 TRANSISTOR 2SB792A(RS)Q520 6-550-316-01 TRANSISTOR 2SB792A(RS)Q521 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q522 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q523 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q524 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q525 8-729-052-79 TRANSISTOR 2SD1306NETLQ526 8-729-052-79 TRANSISTOR 2SD1306NETLQ527 6-550-289-01 TRANSISTOR 2SA1235FQ529 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q530 6-550-289-01 TRANSISTOR 2SA1235FQ532 8-729-120-28 TRANSISTOR 2SC1623-L5L6 (RG660)Q533 6-550-296-01 TRANSISTOR 2SA1980GQ534 6-550-296-01 TRANSISTOR 2SA1980GQ535 6-550-296-01 TRANSISTOR 2SA1980G

Q536 6-550-289-01 TRANSISTOR 2SA1235F

< RESISTOR >


R12 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR13 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR14 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR16 1-216-821-11 METAL CHIP 1K 5% 1/10WR17 1-216-821-11 METAL CHIP 1K 5% 1/10W

R18 1-216-809-11 METAL CHIP 100 5% 1/10WR19 1-216-835-11 METAL CHIP 15K 5% 1/10WR20 1-216-833-11 METAL CHIP 10K 5% 1/10WR21 1-216-835-11 METAL CHIP 15K 5% 1/10WR22 1-216-839-11 METAL CHIP 33K 5% 1/10W

R23 1-216-839-11 METAL CHIP 33K 5% 1/10WR26 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR27 1-216-833-11 METAL CHIP 10K 5% 1/10W

(RG550)R27 1-216-834-11 METAL CHIP 12K 5% 1/10W

(RG660)R29 1-216-138-00 METAL CHIP 3.3 5% 1/8W

R31 1-216-138-00 METAL CHIP 3.3 5% 1/8WR32 1-216-840-11 METAL CHIP 39K 5% 1/10WR33 1-216-839-11 METAL CHIP 33K 5% 1/10WR34 1-216-844-11 METAL CHIP 82K 5% 1/10W

(RG660)R34 1-218-296-11 METAL CHIP 75K 5% 1/10W

(RG550)

R35 1-216-840-11 METAL CHIP 39K 5% 1/10W

POWER AMP


(RG660)R37 1-218-296-11 METAL CHIP 75K 5% 1/10W

(RG550)R38 1-216-833-11 METAL CHIP 10K 5% 1/10WR39 1-216-845-11 METAL CHIP 100K 5% 1/10W

R40 1-216-833-11 METAL CHIP 10K 5% 1/10WR41 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

(RG550)R41 1-216-833-11 METAL CHIP 10K 5% 1/10W

(RG660)R42 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR43 1-216-826-11 METAL CHIP 2.7K 5% 1/10W

R44 1-216-236-11 RES-CHIP 39K 5% 1/8WR45 1-216-841-11 METAL CHIP 47K 5% 1/10WR46 1-216-841-11 METAL CHIP 47K 5% 1/10WR47 1-216-837-11 METAL CHIP 22K 5% 1/10WR48 1-216-849-11 METAL CHIP 220K 5% 1/10W

R49 1-216-849-11 METAL CHIP 220K 5% 1/10WR50 1-216-833-11 METAL CHIP 10K 5% 1/10WR51 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR52 1-216-841-11 METAL CHIP 47K 5% 1/10WR53 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R54 1-216-835-11 METAL CHIP 15K 5% 1/10WR55 1-260-101-11 CARBON 1.5K 5% 1/2W FR56 1-249-420-11 CARBON 1.8K 5% 1/4WR58 1-216-186-00 RES-CHIP 330 5% 1/8WR59 1-216-184-00 RES-CHIP 270 5% 1/8W

R60 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR61 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR62 1-216-834-11 METAL CHIP 12K 5% 1/10WR63 1-216-834-11 METAL CHIP 12K 5% 1/10WR64 1-216-827-11 METAL CHIP 3.3K 5% 1/10W


(RG550)

R69 1-216-834-11 METAL CHIP 12K 5% 1/10W(RG660)

R70 1-216-835-11 METAL CHIP 15K 5% 1/10WR71 1-216-835-11 METAL CHIP 15K 5% 1/10WR72 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR73 1-216-236-11 RES-CHIP 39K 5% 1/8W

R74 1-216-238-11 RES-CHIP 47K 5% 1/8WR75 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR76 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR77 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR78 1-216-234-00 RES-CHIP 33K 5% 1/8W

R79 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR81 1-260-111-11 CARBON 10K 5% 1/2W FR82 1-216-833-11 METAL CHIP 10K 5% 1/10WR83 1-216-208-00 RES-CHIP 2.7K 5% 1/8W

(RG550)R83 1-216-214-11 RES-CHIP 4.7K 5% 1/8W

(RG660)

R85 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


73

HCD-RG550/RG660

R86 1-260-105-11 CARBON 3.3K 5% 1/2W FR90 1-216-222-00 RES-CHIP 10K 5% 1/8WR91 1-216-178-00 RES-CHIP 150 5% 1/8WR92 1-260-105-11 CARBON 3.3K 5% 1/2W FR93 1-216-206-00 RES-CHIP 2.2K 5% 1/8W

R94 1-216-833-11 METAL CHIP 10K 5% 1/10WR95 1-260-111-11 CARBON 10K 5% 1/2W FR96 1-216-214-00 RES-CHIP 4.7K 5% 1/8W

(RG550)R96 1-216-220-00 RES-CHIP 10K 5% 1/8W

(RG660)R97 1-216-826-11 METAL CHIP 2.7K 5% 1/10W

R98 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR99 1-260-105-11 CARBON 3.3K 5% 1/2W FR100 1-216-138-00 METAL CHIP 3.3 5% 1/8WR102 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR103 1-216-244-00 RES-CHIP 82K 5% 1/8W

R104 1-216-244-00 RES-CHIP 82K 5% 1/8WR105 1-216-244-00 RES-CHIP 82K 5% 1/8WR106 1-216-244-00 RES-CHIP 82K 5% 1/8WR107 1-216-244-00 RES-CHIP 82K 5% 1/8WR108 1-216-244-00 RES-CHIP 82K 5% 1/8W

R109 1-216-244-00 RES-CHIP 82K 5% 1/8WR110 1-216-244-00 RES-CHIP 82K 5% 1/8WR500 1-216-821-11 METAL CHIP 1K 5% 1/10W

0R501 1-245-545-11 METAL OXIDE 0.22 5% 3W F0R502 1-245-545-11 METAL OXIDE 0.22 5% 3W F

0R503 1-245-545-11 METAL OXIDE 0.22 5% 3W F0R504 1-245-545-11 METAL OXIDE 0.22 5% 3W F

R505 1-216-809-11 METAL CHIP 100 5% 1/10WR506 1-216-809-11 METAL CHIP 100 5% 1/10WR507 1-216-822-11 METAL CHIP 1.2K 5% 1/10W

R508 1-216-822-11 METAL CHIP 1.2K 5% 1/10WR509 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR510 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR511 1-216-821-11 METAL CHIP 1K 5% 1/10WR512 1-216-821-11 METAL CHIP 1K 5% 1/10W

R513 1-216-835-11 METAL CHIP 15K 5% 1/10WR514 1-216-835-11 METAL CHIP 15K 5% 1/10WR515 1-216-815-11 METAL CHIP 330 5% 1/10WR516 1-216-815-11 METAL CHIP 330 5% 1/10WR517 1-216-804-11 METAL CHIP 39 5% 1/10W

R518 1-216-804-11 METAL CHIP 39 5% 1/10WR519 1-216-804-11 METAL CHIP 39 5% 1/10WR520 1-216-804-11 METAL CHIP 39 5% 1/10WR521 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR522 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R523 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR524 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR525 1-216-821-11 METAL CHIP 1K 5% 1/10WR526 1-216-821-11 METAL CHIP 1K 5% 1/10WR527 1-216-841-11 METAL CHIP 47K 5% 1/10W

R528 1-216-841-11 METAL CHIP 47K 5% 1/10WR529 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR530 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR531 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR532 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R533 1-216-809-11 METAL CHIP 100 5% 1/10W

R534 1-216-809-11 METAL CHIP 100 5% 1/10WR535 1-216-809-11 METAL CHIP 100 5% 1/10WR536 1-216-809-11 METAL CHIP 100 5% 1/10WR537 1-260-328-11 CARBON 1K 5% 1/2W FR538 1-260-328-11 CARBON 1K 5% 1/2W F

R539 1-216-833-11 METAL CHIP 10K 5% 1/10WR540 1-216-833-11 METAL CHIP 10K 5% 1/10WR541 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR542 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR543 1-216-206-00 RES-CHIP 2.2K 5% 1/8W

R544 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR545 1-216-809-11 METAL CHIP 100 5% 1/10WR546 1-216-809-11 METAL CHIP 100 5% 1/10WR547 1-216-838-11 METAL CHIP 27K 5% 1/10WR548 1-216-838-11 METAL CHIP 27K 5% 1/10W

R549 1-216-818-11 METAL CHIP 560 5% 1/10WR550 1-216-818-11 METAL CHIP 560 5% 1/10WR553 1-216-838-11 METAL CHIP 27K 5% 1/10WR554 1-216-838-11 METAL CHIP 27K 5% 1/10WR555 1-216-841-11 METAL CHIP 47K 5% 1/10W


R561 1-216-843-11 METAL CHIP 68K 5% 1/10WR562 1-216-857-11 METAL CHIP 1M 5% 1/10WR563 1-216-214-00 RES-CHIP 4.7K 5% 1/8WR564 1-216-214-00 RES-CHIP 4.7K 5% 1/8WR567 1-216-214-00 RES-CHIP 4.7K 5% 1/8W

R568 1-216-214-00 RES-CHIP 4.7K 5% 1/8WR569 1-216-853-11 METAL CHIP 470K 5% 1/10WR570 1-260-076-21 CARBON 10 5% 1/2W FR571 1-260-076-21 CARBON 10 5% 1/2W FR574 1-216-182-00 RES-CHIP 220 5% 1/8W

R575 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR576 1-216-837-11 METAL CHIP 22K 5% 1/10WR577 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR578 1-216-182-00 RES-CHIP 220 5% 1/8WR580 1-216-150-11 RES-CHIP 10 5% 1/8W

R581 1-216-246-00 RES-CHIP 100K 5% 1/8WR586 1-216-182-00 RES-CHIP 220 5% 1/8W

(RG660)R587 1-216-182-00 RES-CHIP 220 5% 1/8W

(RG660)R588 1-216-821-11 METAL CHIP 1K 5% 1/10W

(RG660)R589 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R591 1-216-841-11 METAL CHIP 47K 5% 1/10WR592 1-216-835-11 METAL CHIP 15K 5% 1/10WR593 1-216-833-11 METAL CHIP 10K 5% 1/10WR594 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R595 1-245-546-31 METAL OXIDE 0.47 5% 2W F(RG660)





POWER AMP

74

HCD-RG550/RG660


R599 1-216-841-11 METAL CHIP 47K 5% 1/10WR601 1-216-156-00 RES-CHIP 18 5% 1/8WR602 1-216-156-00 RES-CHIP 18 5% 1/8WR603 1-216-156-00 RES-CHIP 18 5% 1/8W

R604 1-216-156-00 RES-CHIP 18 5% 1/8W

< RELAY >

RY501 1-755-373-11 RELAYRY502 1-755-373-11 RELAY (RG660)

< THERMISTOR >

TH501 1-805-217-11 THERMISTOR (1012)TH502 1-805-217-11 THERMISTOR (1012)

*************************************************************

REMOTE BOARD**************

< CONNECTOR >

CN604 1-816-423-11 SOCKET, CONNECTOR 3P

< IC >

RM601 6-600-174-01 IC RPM7240-H4 (IR)*************************************************************

1-687-132-11 SENSOR BOARD**************

< CONNECTOR >

CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P

< IC >

IC731 6-600-174-01 IC RPI-576*************************************************************

1-687-669-11 SW BOARD*********

< SWITCH >

S751 1-786-514-11 SWITCH, LEVER (SLIDE)(OPEN/CLOSE DETECT)

*************************************************************

1-688-088-11 TRANS BOARD (RG550)1-688-698-11 TRANS BOARD (RG660)

************

* 1-533-213-31 HOLDER, FUSE

< CAPACITOR >

C901 1-164-156-11 CERAMIC CHIP 0.1uF 25VC902 1-126-942-61 ELECT 1000uF 20% 25V

< CONNECTOR >

CN901 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P* CN902 1-764-334-11 PLUG, CONNECTOR 11P

< DIODE >

D901 8-719-988-61 DIODE 1SS355TE-17 (E2,E3,E51)D902 8-719-988-61 DIODE 1SS355TE-17D903 8-719-988-61 DIODE 1SS355TE-17D904 8-719-988-61 DIODE 1SS355TE-17D905 8-719-988-61 DIODE 1SS355TE-17

D906 8-719-988-61 DIODE 1SS355TE-17 (AEP,UK,MX)

< RELAY >

0RY901 1-755-496-11 RELAY (E2,E3,E51)0RY902 1-755-276-11 RELAY, POWER (AEP,UK,MX)

< SWITCH >

0S901 1-786-408-11 SW, SL 1-2-3 SWS2301 (VOLTAGE SELECTOR)(E2,E3,E51)

< TRANSFORMER >

0T902 1-439-735-11 TRANSFORMER, POWER (AEP,UK)0T902 1-439-736-11 TRANSFORMER, POWER (E2,E3,E51,MX)*************************************************************

VIDEO OUT BOARD****************

< CONNECTOR >

* CN003 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P

< JACK >

JK004 1-774-227-11 JACK, PIN 1P (VIDEO OUT)*************************************************************

1-688-081-21 6 STREAM LED BOARD*******************

< JUMPER RESISTOR >

JR002 1-216-864-11 METAL CHIP 0 5% 1/10W

< DIODE >

LED601 8-719-058-04 LED SEL5223S-TP15 (STREAM 1)LED602 8-719-058-04 LED SEL5223S-TP15 (STREAM 2)LED603 8-719-058-04 LED SEL5223S-TP15 (STREAM 3)LED604 8-719-058-04 LED SEL5223S-TP15 (STREAM 4)LED605 8-719-058-04 LED SEL5223S-TP15 (STREAM 5)

LED606 8-719-058-04 LED SEL5223S-TP15 (STREAM 6)

< RESISTOR >

R617 1-216-182-00 RES-CHIP 220 5% 1/8WR618 1-216-182-00 RES-CHIP 220 5% 1/8WR619 1-216-182-00 RES-CHIP 220 5% 1/8WR620 1-216-182-00 RES-CHIP 220 5% 1/8WR621 1-216-182-00 RES-CHIP 220 5% 1/8W

R622 1-216-182-00 RES-CHIP 220 5% 1/8WR935 1-216-182-00 RES-CHIP 220 5% 1/8WR936 1-216-182-00 RES-CHIP 220 5% 1/8W

*************************************************************


POWER AMP


REMOTE SENSOR SW TRANS

6 STREAM LED

VIDEO OUT

75

HCD-RG550/RG660

MISCELLANEOUS***************

6 1-769-939-11 WIRE (FLAT TYPE) (11 CORE)58 1-769-914-11 WIRE (FLAT TYPE) (9 CORE)59 1-773-322-11 WIRE (FLAT TYPE) (31 CORE)60 1-827-145-11 WIRE (FLAT TYPE) (13 CORE)61 1-796-487-41 DECK, MECHANICAL

0205 1-777-071-83 CORD, POWER (AEP,UK)0205 1-791-901-12 CORD, POWER (E2,E3,E51)0205 1-827-226-11 CORD, POWER (MX)

252 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)308 1-687-133-11 MOTOR (LD) BOARD

317 1-471-035-11 MAGNET ASSY323 1-827-146-11 WIRE (FLAT TYPE) (19 CORE)352 1-823-859-11 WIRE (FLAT TYPE) (16 CORE)

0F902 1-533-470-11 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)0F903 1-533-472-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)

0F904 1-533-472-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)0F905 1-576-655-11 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)0F906 1-576-655-11 FUSE, GLASS TUBE (DIA.5) (T5AL/250V)

M731 1-763-072-11 FAN, DCM741 A-4723-963-A MOTOR ASSY, TABLE (TABLE)

M751 A-4736-655-A MOTOR ASSY, LOADING (LOADING)RE701 1-477-680-11 ENCODER, ROTARY

(DISC TRAY ADDRESS DETECT)0T901 1-439-846-11 TRANSFORMER, POWER (RG550)0T901 1-439-855-11 TRANSFORMER, POWER (RG660:E3)0T901 1-439-856-11 TRANSFORMER, POWER (AEP,UK)

TU901 1-693-626-11 TUNER PACK (FM/AM) (ANTENNA) (AEP,UK)TU901 1-693-628-11 TUNER PACK (FM/AM) (ANTENNA)

(E2,E3,E51,MX)



76

HCD-RG550/RG660

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.

Ver. Date Description of Revision1.0 2003. 06 New

Rg 550 Service Manual

Documents

Transcript of Rg 550 Service Manual