Infinity Gaming Magazine - January 2015 Infinity Gaming Magazine
Reference Series 5350a - Diagramas dediagramas.diagramasde.com/audio/Infinity car REF5350a...
Transcript of Reference Series 5350a - Diagramas dediagramas.diagramasde.com/audio/Infinity car REF5350a...
Reference Series
5350a
5,3 CHANNEL POWER AMPLIFIER
SERVICE MANUAL
Infinity Systems, Inc.
250 Crossways Park Dr.
Woodbury, New York 11797 Rev0 8/2007
Released 2007
Discontinued XXXX
- CONTENTS -
BASIC SPECIFICATIONS ………………..……….……..1
DETAILED SPECIFICATIONS ………….…..…….……..2
PACKING……………………….……………..……………3
APPLICATIONS……………………………………………4
INSTALLATION/SETUP…………………………...…...…5
BASIC TROUBLESHOOTING..…….…….………………5
EXPLODED VIEW/PARTS LIST………………………....6
AMPLIFIER BLOCK DIAGRAM……………………..……7
P.C.B. DRAWINGS….………………………………..……8
ELECTRICAL PARTS LIST ……………………………. 11
IC/TRANSISTOR PINOUTS..…………………………….17
SCHEMATICS……………….……..…………..……..…..18
Reference 5350a Basic Specifications
Output Power: 50W RMS x 4 channels plus 150W RMS x 1 channel at 4 ohms ; ≤1% THD (14.4 VDC) 60W RMS x 4 channels plus 300W RMS x 1 channel at 2 ohms ; ≤1% THD
Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms)
Dynamic power: 89W x 4 and 332W x 1 at 2 ohms
Effective damping factor: 6.3 @ 4 ohms
Frequency response: 10Hz – 100kHz (-3dB)
Maximum input signal: 6.0V
Maximum sensitivity: 100mV
Output regulation: 0.12dB @ 4 ohms
Dimensions (L x W x D): 16-9/16" x 9" x 2-11/16" (421mm x 229mm x 69mm)
Fuse: 2 x 40A
Infinity continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice.
1
5350a Reference Series
INFINITY REFERENCE 5350a AMPLIFIER SPECIFICATIONS TEST VOLTAGE 14.4 +0.1V Specification Rating Unit Remarks
Power Output 4ohm loads @ (stereo mode) for each ch @<1.0%THD (Unit:W)(LPF=22K)
≥50W x 4 + 150W x 1 Watts
Power Output 2ohm loads @1kHz/50Hz (stereo mode) for each ch @<1.0%THD (Unit:W)(LPF=22K)
≥75W x 4 + 300W x 1 Watts
Power Output Bridged (Stereo) Mode 4ohm loads 1kHz @<1.0%THD (Unit:W)(LPF=22K) ≥150W x 2 Watts
THD Power 4 ohm loads and 1MD@Reference (Unit:%) LPF=22K ≤0.5% @1kHz/50Hz %
THD Power 2 ohm loads and 1MD@Reference (Unit:%) LPF=22K ≤0.5% @ 1kHz/50Hz %
THD Power 4 ohm loads Bridged (Stereo) Mode (Unit:%) LPF=22K ≤0.5% @1kHz %
Channel Separation @full rated power (+80KHZ) @1kHz ≥45dB
Full rated power Distortion 1kHz/50Hz LPF=22KHz ≤0.1% %
Signal/Noise Ratio a: 1 watt into 4 ohms b: full rated power (dB)
>85 >100
dBA
1V signal input
Input Sensitivity Low Level Input(v) @:full rated power 100mV-6V Volts ±20%
Frequency response (Unit:-3dB) 10Hz~100kHz; 10Hz~200Hz Hz -3dB
High-Pass Crossover Frequency limits +20% 32Hz – 320Hz Hz
Low-Pass Crossover Frequency limits +20% 32Hz – 320Hz; 20Hz – 200Hz Hz
Bass Boost:(Unit:dB) @50Hz (±5Hz ) 0~6dB dB ±1dB
Idle Current ( @ 4ohm) 1.9A A ±0.15A
MAX current: rated power (All channel 2 ohm load) ≤75A A
DC Offset: ≤30mV mV Damping Factor (4ohm): >200 Effective damping factor (4ohm): 6.395 Dynamic Power @ 2 ohms 850W Watts Output Regulation @ 4 ohms 0.03dB dB Remote Operating Voltages: ON 5V OFF 4V Volts ±1V Turn on delay time 2 to 3 Sec Circuit Protection a. Temperature b. Speaker Short Circuit c. Operating Voltage Range
85 ±5 deg C
Yes 8~16V
+0.5V Dimensions (L x W x H): 16-9/16" x 9" x 2-11/16"
(361mm x 229mm x69mm) Inches
mm
Fuses 40A x 2 A 2
5350a Reference Series
Item Part Number Description Qty
1 CH5082901201 Outer Carton 1 2 REF5350a REF5350a Amplifier 1 3 Plastic Bag 1 4 BZL279112001 Packing Foam 1 5 Visit Infinitysystems.com Owner's manual 1 6 Plastic Bag 1 7 Accessory kit consisting of: 1 LS1CJ0402507 Mounting Screws 4 1601-403E-00 SPARE 40A FUSES 2 REMOTE REF AMP Remote Level Control 1 2100-0009-04 (RJ11) control cable 1
PACKAGING
3
5350a Reference Series
To Head UnitRear
To Head UnitFront
Rear Speakers
Subwoofer
Front Speakers
The 5350a can be configured for 5-channel or 3-channel operation, as shown in Figures 9and 10.
INPUT MODE SWITCH:• Use INT (internal mode) to send a signal from
the front and rear inputs to the subwoofer.• Use EXT (external mode) when sending a
dedicated signal to the subwoofer inputs; e.g.,if your source unit has a subwoofer output.
NOTE: Minimum speaker impedance for stereo operation is 2 ohms. Minimum speakerimpedance for bridged operation is 4 ohms.Minimum impedance of any subwoofer or combination of subwoofers is 2 ohms.
APPLICATIONS – 5350a
Figure 9. 5350a connected to four satellite speakers and a single subwoofer. Note crossover and channel assignment settings.
Figure 10. 5350a connected in bridge (3-channel) mode to a pair of satellite speakers and a subwoofer. Note crossover and channel assignment settings.
NOTE: If head unit includes a separate subwoofer output, connect it here and place switch in EXT position.
NOTE: If head unit includes a separate subwoofer output, connect it here and place switch in EXT position.
NOTE: If head unit has only two preamp outputs, do not connect to rear, and place rear input source switch in the FRONT position.
Left Speaker
Subwoofer
Right Speaker
To Head UnitFront Output
4
5350a Reference Series
SETTING INPUT SENSITIVITY1. Initially turn the INPUT LEVEL control(s) to
the minimum (counterclockwise) position.2. On the source unit, increase the volume
control to 3/4 volume. Slowly increase theINPUT LEVEL control(s) toward three o’clockuntil you hear slight distortion in the music.Then reduce the INPUT LEVEL slightly untildistortion is no longer heard.
NOTE: After the source unit is on, blue LEDs (onthe top panel) will light, indicating the amplifieris on. If not, check the wiring, especially theremote connection from the source unit. Alsorefer to “Troubleshooting.”
REMOTE LEVEL CONTROLThe 1300a, 1600a and 5350a include a remotelevel control. This will allow the subwoofer levelto be adjusted from the listening position.Connect the remote level control using the RJ11 jack on the side of the amplifier. Install the control module in the front of the vehiclewithin easy reach of the driver. Both the under-side of the dash and the center console are suitable locations.
UNDER-DASH MOUNTING Select a mounting location that allows easyaccess to the control while driving. Using theREMOTE LEVEL control as a template, mark anddrill holes in the mounting surface. Attach theREMOTE LEVEL control using the mountingscrews provided (Figure 11).
Figure 11. Under-dash mounting of the REMOTE LEVEL control.
Refer to the illustrations on the previous pagesfor control location.
Reconnect the (–) negative lead to the vehicle’sbattery. Apply power to the audio system andplay a dynamic music track.
SETTING THE CROSSOVER(S)Determine your system plans and set thecrossover-mode switch accordingly. If your system design does not include a subwoofer, set the crossover mode to FULL and skip to“Setting Input Sensitivity.”
If your system includes a subwoofer, set thecrossover mode to HP (high-pass) for your full-range speakers. Adjust the crossover frequency to limit bass, and provide increasedsystem volume with less distortion.
Mode Switch: Full: Allows a full-range signal through to thespeakers; can be used with larger full-rangespeakers such as 6" x 9"s.HP: Allows a high-pass signal through to the speakers; should be used with most loudspeakers (can protect your full-range speakers from being overdriven with low frequencies, one cause of speaker damage).LP: Allows only bass to pass through to thespeakers; should be selected when poweringsubwoofers.
High-Pass Filters: Initially set the crossover-frequency control midway. While listening to music, adjust the crossover for the least perceived distortion from the speakers, allowingthem to reproduce as much bass as possible.
Low-Pass Filters: For subwoofers, choose the highest frequency that removes vocal information from the sound of the subwoofer.
If using the 475a to drive a subwoofer(s), set the crossover mode to LP (low-pass) on thechannels connected to the subwoofer.
NOTE: The 1300a, 1600a and the subwoofer output of the 5350a are low-pass only and do not have a crossover-mode switch.
INSTALLATION AND SETUP
Route the cable behind the dash or other interior panels and under the carpet. Do notroute the cable outside the vehicle. Connect theRJ11 cable between the RJ11 receptacle on theamp and the receptacle on the REMOTE LEVELcontrol (Figure 12).
Figure 12. REMOTE LEVEL control electrical connection.
SETTING THE BASS BOOSTThe Bass Boost control will allow you to enhancethe bass output of your system at 50Hz up to 6dB.
AUX OUTPUTReference amplifiers (except 5350a) areequipped with full-range outputs that can beused to connect additional amplifiers.
STATUS LEDsPower: Indicates the amplifier is on.Protection: Refer to “Troubleshooting” for specificindications.
Figure 13. LED status.
TROUBLESHOOTING
• PROBLEM: No audio (POWER LED is off).
CAUSE and SOLUTION: No voltage at BATT+and/or REM terminals, or bad or no groundconnection. Check voltages at amplifier terminals with VOM.
• PROBLEM: No audio (PROTECT LED glows red).
CAUSE and SOLUTION: DC voltage on amplifieroutput. Amplifier may need service; seeenclosed warranty card for service information.
• PROBLEM: No audio (PROTECT LED glows red).
CAUSE and SOLUTION: Amplifier is overheated.Make sure amplifier cooling is not blocked atmounting location; verify that speaker-systemimpedance is within specified limits.
• PROBLEM:No audio (PROTECT LED glows red).
CAUSE and SOLUTION: Voltage less than 9V onBATT+ connection. Check vehicle charging system.
• PROBLEM: No audio (PROTECT LED glows red).
CAUSE and SOLUTION: Voltage greater than16V or less than 8.5V on BATT+ connection.Check vehicle charging system.
• PROBLEM: Distorted audio.
CAUSE and SOLUTION: Input sensitivity is not set properly, or amplifier or source unit isdefective. Check INPUT LEVEL setting, or checkspeaker wires for shorts or grounds.
• PROBLEM: Distorted audio (PROTECT LED glowsintermittently).
CAUSE and SOLUTION: Short circuit in speakeror wire. Remove speaker leads one at a time tolocate shorted speaker or wire, then repair.
• PROBLEM: Music lacks “punch.”
CAUSE and SOLUTION: Speakers are not connected properly. Check speaker connectionsfor proper polarity.
5
5350a Reference Series
Item# Part Number Description Qty 1 SG-0017-2601 Top cover 1 2 GD-600021400 Light panel 1 3 LSIFM0300011 Screw 6 4 SR-F555-0117 Main heat sink 1 5 Main PCB 1 6 MK-0006-2601 Front panel 1 7 LS5KJ0301007 Screw for terminal, RCA jacks 7 8 LS5KP0300807 Screw for F/RP 8 9 XN-10500-012 Knob 7 10 LSIAP0300607 Screw 6 11 LSIAM0300607 Screw 2 12 XG-0018-2601 Bottom plate 1 13 LSIAY0301201 Screw 2 14 PL-L0007-000 Transistor spring clip (2) 8 15 ZL-10037A-15 Space Pole 2 16 PL-L0006-000 Transistor spring clip (1) 6 17 HG-0007-2601 Rear panel 1 18 LSIAA0200501 Screw 1 19 LS1AM0250401 Screw 4 20 CP-B00011400 LED lens 1 21 LED PCB 1
6
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
OP
OP OP11 20 200 11 20050
AMP
SPEAKERBALANCEDINPUTUNIT
BALANCEDINPUTUNIT
GAIN CONTROL
BASS BOOSTVARIABLE0dB--6dB/50HZ
MODEL FREQVARIABLE LP11HZ--200HZ/12dB
MAIN AMPSUB
2ohm/4ohm
INPUT FL
+
-
Battery+VAMP2
-VAMP2
+V1
-V1
+VOP
-VOP
POWER SUPPLY
OP OP11 32 80K
AMP
SPEAKER
BALANCEDINPUTUNIT
GAIN CONTROL
MODEL FREQVARIABLE LP32HZ--320HZ/12dB
MAIN AMPFL
2ohm/4ohm
320
INPUT RL
OP OP11 32 80K
AMP
SPEAKER
BALANCEDINPUTUNIT
GAIN CONTROL
MODEL FREQVARIABLE LP32HZ--320HZ/12dB
MAIN AMPRL
2ohm/4ohm
320OP
SPEAKER
BTL-4ohm
+VAMP1
-VAMP1
+V2
-V2
INPUT FR
OP OP11 32 80K
AMP
SPEAKER
BALANCEDINPUTUNIT
GAIN CONTROL
MODEL FREQVARIABLE LP32HZ--320HZ/12dB
MAIN AMPFR
2ohm/4ohm
320
INPUT RR
OP OP11 32 80K
AMP
SPEAKER
BALANCEDINPUTUNIT
GAIN CONTROL
MODEL FREQVARIABLE LP32HZ--320HZ/12dB
MAIN AMPRR
2ohm/4ohm
320OP
SPEAKER
BTL-4ohm
INPUT SUB1
INPUT SUB2
OP
OPOP
OP
DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
BLOCK DIAGRAM
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
7
5350a Reference Series
8
5350a Reference Series
9
5350a Reference Series
10
5350a Reference Series
REFERENCE 5350a Electrical Parts List
Part Number Qty Reference Designator
Main PCB
Resistors
0701-35R6-02 Resistor SMD 5.6Ω 1/4W ±5% 1206 6 R152E R154E R153E R155E R166E R167E
0701-2220-02 Resistor SMD 22Ω 1/8W ±5% 0805 20
R135A R135B R135C R135D R135E R136A R136B R136C R136D R136E R137A R137B R137C R137D R137E R138A R138B R138C R138D R138E
0701-2470-02 Resistor SMD 47Ω 1/8W ±5% 0805 8 R152A R152B R152C R152D R154A R154B R154C R154D
0701-2680-02 Resistor SMD 68Ω ±5% 0805 8 R150A R150B R150C R150D R151A R151B R151C R151D
0701-2750-02 Resistor SMD 75Ω ±5% 0805 4 R101A R101B R101C R101D
0701-2101-02 Resistor SMD 100Ω 1/8W ±5% 0805 22R9 R13 R43 R44 R52 R52A R53 R53A R54A R56 R56A R57 R57A R58A R114 R214 R314 R414 R100A R110B R110C R110D
0701-3101-02 Resistor SMD 100Ω 1/4W ±5% 1206 2 R170E R169E0701-2331-02 Resistor SMD 330Ω 1/8W ±5% 0805 1 R650701-2471-02 Resistor SMD 470Ω 1/8W ±5% 0805 5 R46 R161A R161B R161C R161D0701-2681-02 Resistor SMD 680Ω 1/8W ±5% 0805 2 R150E R151E0701-2751-02 Resistor SMD R0805 750Ω 1/8W ±5% TR 1 R148E
0701-2102-02 Resistor SMD 1KΩ 1/8W ±5% 0805 53
R114A R114B R114C R114D R139A R139B R139C R139D R139E R140A R140B R140C R140D R140E R210 R310 R410 R146A R146B R146C R146D R146E R149A R149B R149C R149D R149E R133A R133B R133C R133D R133E R115A R117A R116A R115C R116C R117C R143A R143B R143C R143D R143E
0701-2222-02 Resistor SMD 2.2KΩ 1/8W ±5% 0805 4 R11A R12 R14 R15 0701-2272-02 Resistor SMD 2.7KΩ 1/8W ±5% 0805 4 R102A R102B R102C R102D0701-2302-02 Resistor SMD 3KΩ 1/8W ±5% 0805 5 R112A R112B R112C R112D R132
0701-2332-02 Resistor SMD 3.3KΩ 1/8W ±5% 0805 13 R18 R19 R20 R145 R145A R145B R145C R145D R145E R148A R148B R148C R148D
0701-2392-02 Resistor SMD 3.9KΩ ±5% R0805 TR 10 R141A R141B R141C R141D R141E R142A R142B R142C R142D R142E
0701-2472-02 Resistor SMD 4.7KΩ 1/8W ±5% 0805 3 R7 R32A R470701-2512-02 Resistor SMD 5.1KΩ 1/8W ±5% 0805 3 R48 R49 R500701-2562-02 Resistor SMD 5.6KΩ 1/8W ±5% 0805 1 R66
0701-2682-02 Resistor SMD 6.8KΩ 1/8W ±5% 0805 10 R21 R22 R107A R107B R107C R107D R109AR109B R109C R109D
0701-2103-02 Resistor SMD 10KΩ 1/8W ±5% 0805 50
R34 R35 R36 R37 R38 R39 R40 R102 R103 R104A R104B R104C R104D R105 R105A R105B R105C R105D R106 R106A R106B R106C R106D R108A R108B R108C R108D R113A R113B R113C R113D R133 R202 R203 R205 R206 R302 R303 R305 R306 R402 R403 R405 R406 R21A R134A R134B R134C R134D R134E
0701-2822-02 Resistor SMD 8.2KΩ 1/8W ±5% 0805 5 R160A R160B R160C R160D R160E
0701-2123-02 Resistor SMD 12KΩ 1/8W ±5% 0805 8 R20A R30A R202A R203A R302A R303A R402A R403A
0701-2133-02 Resistor SMD 1/8W 13KΩ ±5% 0805 1 R41
0701-2153-02 Resistor SMD 15KΩ 1/8W ±5% 0805 12 R27 R30 R163A R163B R163C R163D R163ER164A R164B R164D R164E R164C
Description
11
5350a Reference Series
Part Number Qty Reference DesignatorDescription
Main PCB
0701-2223-02 Resistor SMD 22KΩ 1/8W ±5% 0805 18R10A R67 R101 R201 R201A R301 R301A R401A R401 R23A R24A R25A R26B R26C R111A R111B R111C R111D
0701-2393-02 Resistor SMD 39KΩ 1/8W ±5% 0805 4 R109 R209 R309 R4090701-2473-02 Resistor SMD 47KΩ 1/8W ±5% 0805 4 R16 R17 R28 R20701-2563-02 Resistor SMD 56KΩ 1/8W ±5% 0805 4 R23 R24 R25 R260701-2623-02 Resistor SMD 62KΩ 1/8W ±5% 0805 5 R108 R208 R308 R408 R35A0701-2182-02 Resistor SMD 1.8KΩ 1/8W ±5% 0805 4 R103A R103B R103C R103D0701-2104-02 Resistor SMD 100KΩ 1/8W ±5% 0805 2 R8 R100701-2124-02 Resistor SMD 120KΩ 1/8W ±5% 0805 1 R10701-2224-02 Resistor SMD 220KΩ 1/8W ±5% 0805 1 R510701-2474-02 Resistor SMD R0805 470KΩ 1/8W ±5% TR 1 R420701-2105-02 Resistor SMD 1MΩ 1/8W ±5% 0805 1 R450701-54R7-02 Resistor SMD 4.7Ω 1/2W ±5% 2512 5 R165A R165B R165C R165D R165E0702-3220-02 Resistor 1/2W 22Ω ±5% TR 12.5MM 6 R60 R60A R61 R61A R62 R62A0704-7101-02 Resistor 3W 100Ω ±5% TR 2 R63A R64A0702-7471-02 Resistor 3W 470Ω ±5% 2 R63B R64B0712-7221-02 Resistor 3W 220Ω ±5% 10MM 2 R63 R64
07051515X102 Resistor 5W 0.15Ω*2 ±5% 3PIN 26*5*18MM 7 R156A R156B R156C R156D R156E R157E R158E
1201-1021-03 Variable resistor 1k multi-loop 2.5 9.5*5*9.5mm 5 VR100A VR100B VR100C VR100D VR100E
1204-5031-18 Potentiometer four joint A50K R0971G2B W=5 KQ L=15MM T=7.5MM M=1MM FREQ 2 VR102F VR102R
1204-5021-05 Potentiometer B5K double joint KQ L=15mm ±5% LEVEL 2 VR101F VR101R0701-2271-02 Resistor SMD 270Ω 1/8W ±5% 0805 2 R161E R162E
Capacitors
06D211054001 Capacitor 1UF/25V ±20% 5*11mm 105 TR 5mm 1 C4006D211056001 Capacitor 1UF/50V ±20% 5*11 105 5.0mm TR 6 C2 C113A C113B C113C C113D C113E06D212256301 Capacitor 2.2UF/50V ±20% 5*11 105 5mm TR 1 C30
06D211064301 Capacitor 10UF/25V φ5*11mm ±20% 105 TR 5mm 10 C108A C108B C108C C108D C108E C31 C101B C101C C101D C101A
06D112264302 Capacitor 22uF/25V ±10% 5*11 105 16C10A C20A C102 C103 C202 C202A C203 C203A C302 C302A C303 C303A C402 C402A C403 C403A
06D211074100 Capacitor 100UF/25V±20% 6.3*11 105 black 5.0mm TR 1 C4106D211076100 Capacitor 100uF/50V ±20% 6.3*11 105 Black 5MM TR 5 C114A C114B C114C C114D C114E06D212264103 Capacitor 220uF/25V ±20% 8*12 105 Black 5MM TR 6 C32 C39 C29 C42 C2A C29A06D212274001 Capacitor 220UF/25V ±20% 8*12 105 5mm 4 C101 C201 C301 C40106D212276001 Capacitor 220uF/50V ±20% 10*17 105 5MM 2 C42A C39A06D214779100 Capacitor 470UF/63V ±20% 13*20 Black 5mm 2 C42B C39B06D212285101 Capacitor 2200UF/35V Φ16*26MM ±20% 105 7.5MM 4 C3 C4 C5 C606D214786101 Capacitor 4700UF/50V ±20% 25*30mm value < 0.04 105 2 C37 C3806D214789100 Capacitor 4700UF/63V ±20% φ35*27mm 2 C37A C38A06S321006000 Capacitor SMD 10pF/50V 0805 NPO ±5% 4 C104 C204 C304 C404 06S121026000 Capacitor SMD 1000pF/50V 0805 X7R ±10% 4 C102A C102B C102C C102D
06S322206000 Capacitor SMD 22pF/50V 0805 NPO ±5% 16C105 C106 C107 C205 C206 C207 C305 C306 C307 C405 C406 C407 C115A C115B C115C C115D
06S324706000 Capacitor SMD 47PF/50V 0805 NPO ±5% 4 C103A C103B C103C C103D
06S121017000 Capacitor SMD 100PF/100V 0805 X7R ±10% 10 C110A C110B C110C C110D C110E C111A C111B C111C C111D C111E
06S321026000 Capacitor SMD 1000pF/50V 0805 NPO ±5% 4 C35 C35A C36 C3A
12
5350a Reference Series
Part Number Qty Reference DesignatorDescription
Main PCB
06S121036000 Capacitor SMD 0.01uF/50V 0805 X7R ±10% 4 C33 C33A C34 C34A
06S121047000 Capacitor SMD 104/100V 0805 X7R ±10% 32
C7 C8 C9 C10 C12 C13 C14 C15 C15A C16 C16A C16B C17 C17A C17B C19 C20 C21 C22 C23 C23A C24 C25 C26 C11 C8A C112AC112B C112C C112D C109E C112E
06S322216000 Capacitor SMD 220pF/50V 0805 NPO ±5% 4 C109A C109B C109C C109D06s128236001 Capacitor SMD 823/50V ±10% X7R 0805 4 C105A C105B C105C C105D06D3C2247701 Capacitor 224/100V ±5% Brown TR 5mm 5 C116A C116B C116C C116D C116E06S124736000 Capacitor SMD 0.047uF/50V 0805 X7R ±10% 5 C28 C104A C104B C104C C104D
Semiconductors
04WY-39AV101 Diode SMD 3.9V DO-213AA 0.5W 1 ZD2A04WY-10BV101 Diode SMD 10V DO-213AA 0.5W 1 ZD304WY-15BV101 Diode SMD 15V DO-213AA 0.5W 3 ZD2 ZD4 ZD504WY-33BV104 Diode 33V DO-35 0.5W 2 2D9 2D8
04PT-4148-01 Diode SMD 1N4148 DO-213AA 25
D2 D3 D4 D6 D6A D7 D7A D100A D100B D100C D100D D100E D101A D101B D101C D101D D101E D102A D102B D102C D102D D102E D101 D102 D2A
04GS-R204-00 Diode FR204 2A 400V 52MM TR 4 D10A D10B D11A D11B04GS-C6A4-00 Diode MIC6A4 1 D1
03T1-Z48N-02 MOS Transistor IRFZ48N TO-220 10 Q11 Q12 Q15 Q16 Q22 Q23 Q24 Q26 Q27 Q28
03P1-A940-02 Transistor 2SA940 PNP TO-220 3 Q20 Q103E Q104E03P1-1015-04 Transistor SMD 2SA1015 SOT-23 PNP 5 Q7 Q9 Q10 Q18 Q21
03P1-B647-01 Transistor 2SB647 1A 120V 0.9W PNP TO-92 TR 9 Q102A Q102B Q102C Q102D Q102E Q103A Q103B Q103C Q103D
03P1-B649-07 Transistor 2SB649A 1.5A 180V 20W PNP TO-126 1 Q3
03N1-1815-04 Transistor SMD 2SC1815 SOT-23 NPN 18Q1 Q1A Q1B Q1C Q1D Q1E Q2 Q4 Q5 Q11A Q12A Q111A Q111B Q111C Q111D Q111E Q4A Q5A
03N1-2073-02 Transistor 2SC2073 NPN TO-220 4 Q19 Q106E Q107E Q105E
03N1-667A-01 Transistor 2SD667AC 1A 120V 0.9W NPN TO-92 TR 9 Q106A Q106B Q106C Q106D Q108A Q108B Q108C Q108D Q108E
03P1-5401-04 Transistor SMD MMBT5401LT1 PNP SOT-23 10 Q112E Q113E Q112A Q112B Q112C Q112D Q113A Q113B Q113C Q113D
03N1-5551-04 Transistor SMD MMBT5551LT1 NPN SOT-23 10 Q100E Q101E Q100A Q100B Q100C Q100D Q101A Q101B Q101C Q101D
03N1-SA13-01 Transistor MPSA13 0.5A 30V NPN TO-92 TR 4 Q105A Q105B Q105C Q105D03P1-1695-13 Transistor 2SA1695 PNP TO-3P 3 Q114E Q115E Q117E03N1-4468-13 Transistor 2SC4468 NPN TO-3P 3 Q109E Q116E Q110E03N1-35CW-26 Transistor TIP35CW NPN T0-247 4 Q109A Q109B Q109C Q109D03P1-36CW-26 Transistor TIP36CW PNP T0-247 4 Q114A Q114B Q114C Q114D01JR-4558-08 Dual Op-Amp SMD NJM4558 SOP-8 4 U102A U102B U102C U102D01NS-393M-08 IC Comparator SMD LM393M SOP-8 1 U201NE-5532-08 Dual Op-Amp SMD N5532 SOP8 NEC 1 U32601-P817-00 Optocoupler PC817 4 2 PC1 PC2
0100-M833-08 Dual Op-Amp LM833 SOP-8 9 U101 U101A U101B U101C U101D U201 U302 U303 U301
01TI-L494-09 IC SMD TL494C SO-16 PWM 1 U42202-1602-05 Rectifier UF1602CT AKA 16/200V TO-220 2 D8 D8A2202-1620-05 Rectifier MUR1620CTA KAD 16A/200V TO-220 2 D9 D9A
13
5350a Reference Series
Part Number Qty Reference DesignatorDescription
Main PCB
Miscellaneous
1500-1000-00 Terminal Clear Plating golden cross head screw 1 CON21502-0504-00 Jack Pitch 2.0MM 5PIN Bend 90 degree 1 J21400-0012-06 Jack double joint 2.54 6PIN 1 CON41400-0011-00 Jack 10P8C RJ45 1 RJ451500-0300-01 Terminal Clear Plating golden cross head screw 1 J11333-0203-00 Switch SSH-22H04-G9 2P2T length:9MM INPUT SOURCE 1 SW101F1333-0204-00 Switch SSH-23D04-2P3T Length:9MM LPF/FULL/HPF 2 SW103F SW103R1003-1010-08 Inductor SMD 100MH 100MHZ 4A 2 L7 L31004-3000-10 HF bead 30UH φ12 φ5 11.5mm 2 L5 L61601-403E-00 Fuse 40A 4 F1 (2PCS - in accessory bag)1005-5R04-10 Inductor 5UH φ23 φ1.0*5 2 L1 L21380-0205-00 temperature switch JUC-31F85 ±5 TO-220 2PIN 1 TH11380-0203-00 temperature switch JUC-31F65 ±5 TO-220 2PIN 1 TH21401-0001-04 Fuse holder BXS-03 double joint Black 4PIN 1 for F1
1404-0005-00 RCA With 2 jack, up with red dow with white, plating golden 2 RCA1 RCA2
3000-5350-01 HF transformer φ47 4:13:18 L1=L2=φ1.0*8 4TS S1=S2=φ1.0*5 13TS S3=S4=φ1.0*1 18TS 1 T2
3000-5350-02 HF transformer φ37 6:11 L1=L2=φ0.8*8 6TS S1=S2=φ1.0*5 11TS 1 T105RN-3031-02 Thermal resistor 30K Φ5MM 1 RH2
Input PCB
Resistors
0701-2102-02 Resistor SMD 1KΩ 1/8W ±5% 0805 8 R110E R111E R124E R507 R607 R116E R134 R102E
0701-2680-02 Resistor SMD 68Ω 1/8W ±5% 0805 1 R101E0701-2181-02 Resistor SMD 180Ω 1/8W ±5% 0805 1 R129E0701-2472-02 Resistor SMD 4.7KΩ 1/8W ±5% 0805 1 R123E0701-2562-02 Resistor SMD 5.6KΩ 1/8W ±5% 0805 2 R108E R109E0701-2103-02 Resistor SMD 10KΩ 1/8W ±5% 0805 2 R107E R122E0701-2123-02 Resistor SMD 12KΩ 1/8W ±5% 0805 2 R112E R113E0701-2153-02 Resistor SMD 15KΩ 1/8W ±5% 0805 1 R132E 0701-2203-02 Resistor SMD R0805 20KΩ 1/8W ±5% TR 1 R118E0701-2223-02 Resistor SMD 22KΩ 1/8W ±5% 0805 5 R501 R601 R701 R119E R114E0701-2303-02 Resistor SMD 30KΩ 1/8W ±5% 0805 2 R702 R703
0701-2473-02 Resistor SMD 47KΩ 1/8W ±5% 0805 12 R117E R115E R121E R502 R503 R505 R506 R602 R603 R605 R606 R106E
0701-2563-02 Resistor SMD 56KΩ 1/8W ±5% 0805 1 R103E0701-2104-02 Resistor SMD 100KΩ 1/8W ±5% 0805 1 R128E0701-2154-02 Resistor SMD 150KΩ 1/8W ±5% 0805 1 R105E0701-2205-02 Resistor SMD 2MΩ 1/8W ±5% 0805 1 R131E
1204-5031-18 Potentiometer Four joint A50K R0971G2B W=5 KQ L=15MM T=7.5MM M=1MM LP FREQ 1 VR503
1204-5021-05 Potentiometer B5K double joint KQ L=15mm ±5% BASS LEVEL 1 VR101S
1204-5041-05 Potentiometer 9MM R0971G C500K KQ L=15MM T=7.5MM M=1MM ±10% double joint BASS BOOST 1 VR505
14
5350a Reference Series
Part Number Qty Reference DesignatorDescription
Input PCB
Capacitors
06S321006000 Capacitor SMD 10pF/50V 0805 NPO ±5% 4 C130E C504 C604 C70406S121026000 Capacitor SMD 1000pF/50V 0805 X7R ±10% 1 C102E06S121046000 Capacitor SMD 0.1uF/50V 0805 X7R ±10% 4 C131E C132E C18 C2706D3C2247701 Capacitor 224/100V ±5% Brown TR 5mm 2 C103E C104E06S322206000 Capacitor SMD 22pF/50V 0805 NPO ±5% 4 C505 C506 C605 C60606D346839001 Capacitor 683/63V ±5%TR 5mm 4 C105E C106E C107E C128E06D211064301 Capacitor 10UF/25V φ5*11mm ±20% 105 TR 5mm 3 C101E C133E C129E06D212264102 Capacitor 22uF/25V ±20% 5*11 105 Black 5MM TR 7 C502 C503 C602 C603 C701 C702 C703 06D212274001 Capacitor 220UF/25V ±20% 8*12 105 5mm 2 C501 C601
Semiconductors
03N1-1815-04 Transistor SMD 2SC1815 SOT-23 NPN 1 Q3E0100-M833-08 Dual Op-Amp LM833 SOP-8 1 U50101JR-4558-08 Dual Op-Amp SMD NJM4558 SOP-8 3 U101E U102E U103E2601-0202-00 optocoupler LCR-0202 1 LCR
Miscellaneous
1413-0001-00 Phone jack 6P4C RJ11 Black 1 RJ111505-0609-00 Pin 2.54 6PIN 0.65*0.65 16mm 1 CON11333-0203-00 Switch SSH-22H04-G9 2P2T Length:9MM INT/EXT 1 SW101E
1404-0003-00 RCA With 2 jack, up with red dow with white, plating golden 1 SUB1
LED BOARD
2004-0017-00 LED 3 White with blue light 8 LED1-82100-0035-05 FFC 5PIN 2.0 UL1007 28AWG L=100mm 2.0 105 12000-0017-00 LED Red with red ligth Φ3MM 2P 1 LED3002004-0014-00 LED Φ3.0MM Blue with blue light 1 LED1000701-6102-02 Resistor SMD 1KΩ 1/2W ±5% 2010 2 R1 R22102-0155-02 FFC 2PIN UL1007 red black 28AWG L=400mm 5mm 12102-0154-02 FFC 2PIN UL1007 red black 28AWG L=40mm 5mm 106S121046000 Capacitor SMD 0.1uF/50V 0805 X7R ±10% 2 C1 C2 1502-0504-00 Jack Pitch 2.0MM 5PIN Bend 90 degree 1
MECHANICAL
GD-600020003 Acylic board 334*48*4.0mm Clear Arylic 1
PL-B0007-000 astigmatic paper 334*48*0.25mm Astigmatic film+3M double glue+Alum. Foil 1
PL-B0006-000 Glisten paper 334*48*0.15mm Glisten film+3M double glue 1JY218A13A01X Mica with hole 18*13*0.1MM 2DQ6060030306 Insulated paper White Φ3MM TW-1 2SR-RA40-0100 Small Heatsink 25*15*11MM Alum. Extrusion 2JY233A22A001 Mica 33*22*0.1mm 2JY297A22A001 Mica 97*22*0.1mm 4JY264A22A001 Mica 64*22*0.1mm 2ZA-H00040100 Snap bottom φ7.5 M3.5*4 4
15
5350a Reference Series
Part Number Qty Reference DesignatorDescription
MECHANICAL
LS1AM0250401 Screw Plating black Zinc 2.5*4 4LS1AA0301501 Screw PA3*15 Plating black Zinc 2LS1FJ0200801 Screw KA2*8 Black Zinc 2LS1CJ0402507 Screw T4*25MM Plating Nickel 4
XN-10500-011 Knob ABS-757Black 11.7*Ф11MM with red arrow Black painting 1
XN-10500-012 Knob ABS-757Black Ф10.5*9MM with white arrow 7LS5KJ0301007 Screw 3*10MM (Plating Nickel) 7LS5KP0300807 Screw 3*8MM (Plating Nickel) 8LS1AP0300607 Screw 3*6MM (Plating Nickel) 6LS1AM0300607 Screw PM3*6(Plating Nickel) 4KT-200012200 CAP White PVC for RCA 3KT-200021300 CAP Red PVC for RCA 3DQ8069032084 Washer Φ6.9*Φ3.2*0.8MM 2LS1AY0301201 Screw PM3*12MM Plating Black Zinc 2PL-L0007-000 Clipper 30*36*0.8mm flexibility 8PL-L0006-000 Clipper 30*28*0.8mm flexibility 7XG-0018-2601 Bottom plate 385*182*1.2mm,H1-144 silver paintng 1
HG-0007-2601 Rear plate 214*70*1.2mm H1-144 silver painting with silkscreen 1
MK-0006-2601 Front plate 214*70*1.2mm H1-144 silver painting with silkscreen 1
KG-100100500 Snap bottom T07-003-01φ11*φ14*10.8 BlackABS 4LS1AA0200501 Screw PA2*5(Black Zinc) 1LS1FM0300011 Screw KM 3*6MMBlack Zinc 6CP-B00011400 Lens 40*10.8*5.7mm PC cold grey 10C 1GD-600021400 Reflector board 340*53.5*13mm Clear Blue PC 1
SG-0017-2601 Top plate 420*227*62mm dia- casting aluminum alloy, H1-144 silver painting with silkscreen 1
SR-F550-0117 Heatsink 385*216*61mm extrusion, Hair with painting 1JY436A10A10X Insulated paper Red;36*10*1.0mm one side with glue 1JY428A10A10X Insulated paper 28*10*1.0mm Red one side with 3M glue 6ZL-A0001A-15 PC pole φ7.5*φ3.0*6.4mm white LASK-5 2JD-A01970515 Round mat Φ5.0*2.0 black EVA 60 one side with glue 7
16
5350a Reference Series
17
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
FRONT PRE
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
C10222U/25V
R10210K
C106
22P
R10610KC101
220U/25V
3
21
U101Alm833
R10122K
C10410PC103
22U/25VR10310K
C105 22P
R105 10K
C202
22U/25VR20210K
C206
22P
R206
10KC201220U/25V
5
67
U101B
lm833
R20122K
C20410PC203
22U/25VR20310K
C205 22P
R205 10K
CH1
CH21
2RCA1ACH2
3
4RCA1BCH1
C10A
22U/25VR20A47K
R10A22K C20A
22U/25VR30A47K
RJ45 GND
FL1
FR1
RJ45 GND
C202A
22U/25VR202A47K
R201A22K C203A
22U/25VR203A47K
R114100
R214100
C101A10U/16V
C102A 102
R102A2.7K
R104A10K
R103A 1.8K
C103A 47P
R105A10K
R107A
6.8k
C104A 473
R109A
6.8k
C105A 823
R106A10K
5
67
U101ABlm833
3
21
U102AA4558
5
67
U102AB4558
3
21
U101AA
lm833
1 3
2
VR102FAA50K
4 6
5
VR102FBC50K
23
1
4
SW103FA
R101A75
13
2
VR101FAB20K
C101B10U/16V
C102B 102
R104B10K
R103B 1.8K
C103B 47P
R108B
10K
R105B10K
R107B
6.8k
C104B 473
R109B
6.8k
C105B 823
R106B10K
5
67
U101BBlm833
3
21
U102BA4558
5
67
U102BB4558
3
21
U101BAlm833 7 9
8
VR102FCA50K
10 12
11
VR102FDC50K
67
5
8
SW103FB
R101B75
46
5VR101FBB20K
CHA
CHB
R110B100
R102B2.7K
HPF
FLAT
LPF
HPF
FLAT
LPF
CH2
CH1
R111A22K
R111B22K
R115A1K
3
21
U301ALM833
R117A1K
R116A1K
R112A3K
Q1A
2SC1815
TEM
R112B3K
Q1B
2SC1815
TEM
R113A10K
R114A1K
R113B10K
R114B1K
R110A100
84
U102ACTL072
84
U101BCLM833
84
U102BCTL072
84
U101ACLM833
+VOP
-VOP
84
U101CLM833
84
U301CLM833
18
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
REAR PRE
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
R314100
R414
100
C101C10U/16V
C102C 102
R102C2.7K
R104C10K
R103C 1.8K
C103C 47P
R105C10K
R107C
6.8k
C104C 473
R109C
6.8k
C105C 823
R106C10K
5
67
U101CBlm833
3
21
U102CA4558
5
67
U102CB4558
3
21
U101CAlm833 1 3
2
VR102RAA50K
4 6
5
VR102RBC50K
23
1
4
SW103RA
R101C75
13
2
VR101RA
B20K
C101D10U/16V
C102D 102
R102D2.7K
R104D10K
R103D 1.8K
C103D47P
R108D
10K
R105D10K
R107D
6.8k
C104D 473
R109D
6.8k
C105D 823
R106D10K
5
67
U101DBlm833
3
21
U102DA4558
5
67
U102DB4558
3
21
U101DAlm833 7 9
8
VR102RCA50K
10 12
11
VR102RDC50K
67
5
8
SW103RB
R101D75
46
5VR101RBB20K
CH4
CH3
CHC
CHD
R110D100
HPF
FLAT
LPF
HPF
FLAT
LPF
1 2TH2
65 0C
R111C22K
R111D22K
23
1
SW101FASW2P2T
54
6
SW101FBSW2P2T
CH2
CH1
+VOPTEM
R112C3K
Q1C
2SC1815
TEM
R112D3K
Q1D
2SC1815
TEM
R113C10K
R114C1K
R113D10K
R114D1K
R110C100
R115C1K
5
67
U301BLM833
R117C1K
R116C1K
R108C
10K
C30222U/25V
R30210K
C306
22PR30610KC301
220U/25V
3
21
U201A
lm833
R30122K
C30410PC303
22U/25VR30310K
R305 10K
C40222U/25V
R40210K
C406
22P
R406
10KC401220U/25V
5
67
U201B
lm833
R40122K
C40410PC403
22U/25VR40310K
C405 22P
R405 10K
CH3
CH4
3
4RCA2BCH3
1
2RCA2ACH4
RR1
RL1
RJ45 GND
RJ45 GND
C302A
22U/25VR302A47K
R301A22K C303A
22U/25VR303A47K
C402A
22U/25VR402A47K
R401A22K C403A
22U/25VR403A47K
C305 22P
84
U102CC4558
84
U101DCLM833
84
U102DC4558
84
U101CCLM833
+VOP
-VOP
84
U201CLM833
19
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
ADW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
SUB PRE
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
SUB
C103E224
C104E224
R106E
47K
R105E150K
C131E104
R117E47K
C132E104
R118E21KR115E
47K
C130E
10P
R114E20KR116E1K
C106E683
C129E10u/25V
R113E12K
13
2VR101SAB20K
C105E
683
R107E10K
R109E
5.6K
R108E
5.6K
R101E56
R102E
1KC101E
10/25V
C102E102
R103E47K
CH SUB
C128E683
R112E12K
C107E
683
R111E
1K
R110E
1K
3
21
U101EALM833
5
67
U101EBLM833
3
21
U102EA4558
5
67
U102EB4558
3
21
U103EA4558
5
67
U103EB
4558
11 Hz
50 Hz
20-200Hz
R119E22K
1 1
3 3
2 2
4
RJ11
CON4P-1
R131E2M
R121E47K
R122E10K
R132E15K
R124E1K
Q3E
2SC1815
R128E100K
R123E4.7K
+VOP
C133E
10/25V
R1323K
Q1E
2SC1815
TEM
13
2VR505AC500K
R13310K
R1341K
23
1
SW101EASW2P2TSUB2
1 234
LCR
13
2
VR503AA50K
46
5
VR503BA50K
79
8
VR503CA50K
1012
11
VR503DA50K
R129E180
C50222U/25V
R50247K
C506
22PR50647KC501
220U/25V
3
21
U501A4558
R50122K
C50410PC503
22U/25VR50347K
C505 22P
R505 47K
R5071K
SUB 1
2SUBA
3
4SUBB
C60222U/25V
R60247K
C606
22PR60647KC601
220U/25V
5
67
U501B4558
R60122K
C60410PC603
22U/25VR60347K
C605 22P
R605 47K
R6071K
SUB
SUB
ASU
B B
SUB
ASU
B B
SUB1
C70222U/25V
R70230K
C70122U/25V
R70122K
C70410PC703
22U/25VR70330K
SUB A
RJ45 GND SUB B
C10722P
R10862K
R10947K
3
21
U302A
4558
R1101K
CH1SUB2
C20722P
R20862K
R20947K
5
67
U302B
4558
R2101K
CH2SUB2
C30722P
R30862K
R30947K
3
21
U303A
4558
R3101K
CH3SUB2
C40722P
R40862K
R40947K
5
67
U303B
4558
R4101K
CH4SUB2
84
U102EC4558
84
U103EC4558
84
U101ECLM833
+VOP
-VOP
84
U302C4558
84
U303C4558
84
U501C4558
20
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
FRONT AMP
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
Q100AA06
Q101AA06
R135A22
R136A22
R141A3.9K
R139A1K
Q112AA56
Q113AA56
R137A22
R138A22
R140A1K
Q102A2SB647A
Q108A2SD667A
R150A68
R151A68
Q105AA13R145A
3.3K
R148A3.3K
C110A101
C111A101
C112A
104
C114A
100U/50V
R143A1K
Q106A2SD667A
Q103A2SB647A
Q109ATIP35C
Q114ATIP36C
R156AB0.15/5W
R147A
NC
Q111A2SC1815
PROT
R146A
1K
C113A1UF/25V
+VAMP1
-VAMP1
R133A
1K
R134A10K
C109A221
R160A
8.2K
C108A
10U/25V
-VAMP1
+VAMP1
PRO
R152A47
R156AA0.15/5W
R161A
470
R154A47
+VEE
-VEE
CHA
R142A3.9K
C115A
22
C116A
224M
R165A4.7/0.5W
SPA
R149A
1K
R164A15K
D101AIN4148
R163A15K
D100AIN4148
13
2VR100A
1K
Q100BA06
Q101BA06
R135B22
R136B22
R141B3.9K
R139B1K
Q112BA56
Q113BA56
R137B22
R138B22
R140B1K
Q102B2SB647A
Q108B2SD667A
R150B68
R151B68
Q105BA13R145B
3.3K
R148B3.3K
C110B101
C111B101
C112B
104
C114B
100U/50V
R143B1K
Q106B2SD667A
Q103B2SB647A
Q109BTIP35C
Q114BTIP36C
R156BB
0.15/5W
R147B
NC
Q111B2SC1815
PROT
R146B
1K
C113B
1UF/25V
+VAMP1
-VAMP1
R133B
1K
R134B10K
C109B221
R160B
8.2K
C108B
10U/25V
-VAMP1
+VAMP1
PRO
R152B47
R156BA0.15/5W
R161B
470
R154B47
+VEE
-VEE
CHB
R142B3.9K
C115B
22
C116B
224M
R165B4.7/0.5W
SPB
R149B
1K
R164B15K
D101BIN4148
R163B15K
D100BIN4148
13
2VR100B
1K
D102AIN4148
D102BIN4148
+V1
+V1
-V1
-V1
SPA
1SP
B1
21
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
REAR AMP
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
Q100CA06
Q101CA06
R135C22
R136C22
R141C3.9K
R139C1K
Q112CA56
Q113CA56
R137C22
R138C22
R140C1K
Q102C2SB647A
Q108C2SD667A
R150C68
R151C68
Q105CA13R145C
3.3K
R148C3.3K
C110C101
C111C101
C112C
104
C114C
100U/50V
R143C1K
Q106C2SD667A
Q103C2SB647A
Q109CTIP35C
Q114CTIP36C
R156CB0.15/5W
R147C
NC
Q111C2SC1815
PROT
R146C
1K
C113C
1UF/25V
+VAMP1
-VAMP1
R133C
1K
R134C10K
C109C221
R160C
8.2K
C108C
10U/25V
R152C47
R156CA0.15/5W
R161C
470
R154C47
+VEE
-VEE
CHC
R142C3.9K
C115C
22
C116C
224M
R165C4.7/0.5W
SPC
R149C
1K
R164C15K
D101CIN4148
R163C15K
D100CIN4148
13
2VR100C
1K
Q100DA06
Q101DA06
R135D22
R136D22
R141D3.9K
R139D1K
Q112DA56
Q113DA56
R137D22
R138D22
R140D1K
Q102D2SB647A
Q108D2SD667A
R150D68
R151D68
Q105DA13R145D
3.3K
R148D3.3K
C110D101
C111D101
C112D
104
C114D
100U/50V
R143D1K
Q106D2SD667A
Q103D2SB647A
Q109DTIP35C
Q114DTIP36C
R156DB
0.15/5W
R147D
NC
Q111D2SC1815
PROT
R146D
1K
C113D1UF/25V
+VAMP1
-VAMP1
R133D
1K
R134D10K
C109D221
R160D
8.2K
C108D
10U/25V
R152D47
R156DA0.15/5W
R161D
470
R154D47
+VEE
-VEE
CHD
R142D3.9K
C115D
22
C116D
224M
R165D4.7/0.5W
SPD
R149D
1K
R164D15K
D101DIN4148
R163D15K
D100DIN4148
13
2VR100D
1K
D102DIN4148
D102CIN4148
+V1
+V1
-V1
-V1
SPC
1SP
D1
-VAMP1
+VAMP1
-VAMP1
+VAMP1
22
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
SUB AMP
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
Q100E5551
Q101E5551
R135E22
R136E22
R141E3.9K
R139E1K
Q112E5401
Q113E5401
R137E22
R138E22
R140E1K
Q102E2SB647A
Q108E2SD667A
R150E680
R151E680
Q105E2073R
145E
3.3K
R148E750
C110E101
C111E101
C112E104
C114E
100U/50V
R143E1K
Q106E2SC2073
Q103E2SA940
Q109EC4468
Q114EA1695
R156EB
0.15/5W
R147E
NC
Q111E2SC1815
PROT
R146E
1K
C113E1UF/25V
+VAMP2
-VAMP2
R133E
1K
R134E10K
C109E104
R160E
12K
C108E
10U/25V
R152E4.7
R156EA0.15/5WR161E
270
R154E4.7
+VEE
-VEE
CH SUB
Q107E2SC2073
Q104E2SA940
Q116EC4468
Q117EA1695
R157EB0.15/5W
R166E4.7
R157EA0.15/5W
R162E270
R167E4.7
R142E3.9K
C115E
NC
C116E
224M
R165E4.7/0.5W
SPE
R149E
1K
R164E15K
D101EIN4148
R163E15K
D100EIN4148
13
2VR100E
1K
D102EIN4148
R14
53.
3K
RTH2
30K
D1014148
D1024148
Q110EC468
Q115EA1695
R158EB0.15/5W
R153E4.7
R158EA0.15/5W
R155E4.7
R169E100
R170E100
SPE1
-VAMP2
+VAMP2
23
5350a Reference Series
1 2 3 4 5 6 7 8
A
B
C
D
87654321
D
C
B
A
DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
POWER
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
R50
5.1K
5
67
84
U3BNE5532
-VEE
R49
5.1K
Q92SA1015
Q102SA1015R67
22K
R665.6K
R6222/0.5W
R31K
R4010K R5
1K
C374700U/50V
C384700U/50V
R3910K
R51220K
C36
102M
C35102M
12345678 9
10111213141516
TL494
U4TL494
Q32SB649A
R122.2K
R164.7K
R183.3K
C6
2200U/35V
C28473
D7IN4148
D6IN4148
D4IN4148
R3810K
R10100K
D1MIC6A4
C32220U/25V
123
J1
POWER
TH185 0C
R41K
R61K
R65330
C14
104
C13104
R41
13K
C7104
C9104
R6022/0.5W
C33103M
R6122/0.5W
C34
103M
D8MUR1620C
D9MUR1620CTR
C41
100U/16V
C8104
2
4
8
6
5
1
3 7
T16:11
2 1
34
F140A*2
C5
2200U/35V
C32200U/35V
C42200U/35V
Q11IRFZ48
Q12IRFZ48
R53100
R52100
Q15IRFZ48
Q16IRFZ48
R57100
R56100
R3015K
R152.2K
3
21
U3ANE5532
D3
IN4148
R37
10K
Q22SC1815
R474.7K
R485.1K
ZD310V
R1747K
R44
100
C3110U/16V
+VO
P
+VEE
+VOP
-VOP
C10104
3
21
U2ALM393
5
67
84
U2BLM393
R13100
R35
10K
R3610K
R46470
R9100
C11104
ZD215V/0.5W
C12104
R42
470K
R34
10K
R43100
R451M
C302.2U/16V
VIN1
REM
R226.8K
C22
104
+VO
P
341
2
PC2P817
VIN1
C15
104
C23
104
+VAMP1
-VAMP1
R2656K
Q42SC1815
Q52SC1815
R216.8K
C29
220U/25V
R2456K
D2
IN4148
R2356K
R2556K
SPA1
SPB1
SPC1
SPD1
PROT
VIN
1
R247K
341
2
PC1P817
Q72SA1015
C21UF/50V
R2715K
R142.2K
PROT
ERO
R8100K
Q12SC1815
ERO
R1120K
DIAG
R74.7K +VOP
C401U/25V
V1
V2
REM
R31A1K
R32A4.7K
12345
J2
CON2
R11A2.2K
Q11A2SC1815
Q12A
2SC1815
-VEE
+VEE
ZD2A3.9V/0.5W
PRO2
PRO
1
PRO1PRO2
B+
3 4L1B
5uH
1 2L1A
5uH
1 2L5
30UH
1 2L6
30UH
12 L7
100UH
R2847K
R26A56K
SPE1
R26B20K
Q4A2SC1815
Q5A2SC1815
R21A10K
C29A
220U/25V
R24A20K
D2A
IN4148
R23A20K
R25A20K
SPA1
SPB1
SPC1
SPD1
PROT
R26C20K
SPE1
C2A220UF/25V C8A
104
R63100/3W
R64100/3W
C24
104
ZD5
15V/0.5WC42
220U/25V
C18
104ZD4
15V/0.5W
C39
220U/25V
R203.3K
R193.3K
Q192SC2073
Q202SA940
+VOP
-VOP
C16
104
C17
104 C25
104
C19
104
C26
104
C20
104
C21
104
C27
104
Q24IRFZ48
Q182SA1015
Q212SA1015
R62A22/0.5W
R3A1K
R5A1K
C37A4700U/63V
C38A4700U/63V
C35
A10
2M
D7AIN4148
D6AIN4148
Q28IRFZ48
R4A1K
R6A1K R58A
100
R54A100
R60A22/0.5W
C33A103M
R61A22/0.5W
C34A
103M
D8AMUR1620C
D9AMUR1620CTR
Q22IRFZ48
Q23IRFZ48
R53A100
R52A100
Q26IRFZ48
Q27IRFZ48
R57A100
R56A100
C15A
104
C23A
104
+VAMP2
-VAMP2
VIN
1
V1
V2
1
10
CON2OUTPUT
SPA
SPB
SPC
SPD
SPE
+VOP
-VOP
2
4
9
8
6
1
3
7
10
5
8
T2
4:13:18
D11BFR204
D10AFR204
R63A220/3W
R64A220/3W
R63B470/3W
R64B470/3W
ZD933V/0.5W
ZD8
33V/0.5W
+V1
-V1
D10BFR204
D11AFR204
C42A
220U/50V
C39A220U/50V
C16A
104
C17A
104
+V2
-V2
C42B
220U/70V
C39B220U/70V
C16B
104
C17B104
1 2L5A
30UH
1 2L6A
30UH
+V1
+V2-V1
-V2
R35A62K
24
5350a Reference Series
1 2 3 4
A
B
C
D
4321
D
C
B
A
12345
CN5
CON5
LED100power
LED300prol
LED4blue
LED3blue
LED2blue
LED1blue
R11K 1/2W
R2
1K 1/2W
LED8
blue
LED7
blue
LED6
blueLED5
blue
C1104
C2104
LED BOARD
DW GNO:
PART NO:
PART NAME:
PRODUCT MODE:
SCALE: 1:1UNIT: MMSIZE: A4REV: 1.0
DRAWN BY: CHECKED BY:APPROVED BY:
DATA:DATA:DATA:
LED
REF5350a
ECN NO DESCRIPTON DATAAPPROVED
JING HUI CHEN 2007.1.25
25
5350a Reference Series