Raisbeck King Air Parts Manual 85-119-D_O

MODELS• B300/300 SERIES• B200/A200/200 SERIES• 100/A100• B100• F90/F90-1• E90• 90/A90/B90/C90/ C90-1/C90A/C90B

SYSTEMS• Quiet Turbofan Propellers (TFPS)• Ram Air Recovery System (RARS)• Enhanced Performance Leading Edges (EPLE)• Exhaust Stack Fairings (CESF)• Dual Aft Body Strakes (DABS)• High Float Gear Doors (HFGD) (when HFG-equipped)• Nacelle Wing Lockers (NWLS)• Increased Gross Weight (IGW)

KING AIRS AND SUPER KING AIRS

ISSUED: September, 1990REV. D: APRIL, 2004 Document No.: 85-119

ILLUSTRATED PARTS CATALOGfor all Raisbeck Systems as installed on all

BEECHCRAFT King Air and Super King Air Series equipped with RAISBECK Systems Document No. 85-119

Illustrated Parts Catalog

TABLE OF CONTENTSSECTION

1 . . . . . . . . . . . . .QUIET TURBOFAN PROPELLERS 1-1 A90/B90/C90/C90A/C90B/E90 1-2 100/A100 1-3 B200/A200/200 SERIES 1-4 F90/F90-1

2 . . . . . . . . . . . . .RAM AIR RECOVERY SYSTEM 2-1 B200/A200/200 SERIES

3 . . . . . . . . . . . . .ENHANCED PERFORMANCE LEADING EDGES 3-1 B200/A200/200 SERIES

4 . . . . . . . . . . . . .EXHAUST STACK FAIRINGS 4-1 90/A90/B90/C90/E90/F90/100/A100 4-2 C90A/C90B/AND F90 4-3 B200/A200/200 SERIES 4-4 B300/300 SERIES 4-5 B300 SERIES

5 . . . . . . . . . . . . .DUAL AFT BODY STRAKES 5-1 90/A90/B90/C90/C90A/C90B/E90 5-2 100/A100/B100 5-3 F90/F90-1/ B200/A200/200 SERIES B300/300 SERIES

6 . . . . . . . . . . . . .HIGH FLOAT GEAR DOORS 6-1 90/A90/B90/C90/C90A/C90B/E90 6-2 F90/F90-1 6-3 B200/A200/200 SERIES 6-4 100/A100/B100

7 . . . . . . . . . . . . .NACELLE WING LOCKERS 7-1 90/A90/B90/C90/C90A/C90B/E90 7-2 F90/F90-1 7-3 100/A100/B100 7-4 B200/A200/200 SERIES 7-5 B300/300 SERIES

8 . . . . . . . . . . . . .INCREASED GROSS WEIGHT 8-1 C90/C90A 8-2 E90 8-3 100/A100

-i-APRIL 2004



-ii-APRIL 2004

INTRODUCTION The purpose of this catalog is to provide a method for identifying and ordering spare parts for any Raisbeck System installed on your Beechcraft King Air or Super King Air.

ORGANIZATION This Illustrated Parts Catalog is organized first by Raisbeck System. If a particular System is applicable to more than one model of aircraft, first look up the system (such as Wing Lockers) and then find the applicable aircraft within that System (such as F90/F90-1).

Unless otherwise specified, figures in this manual shall be applicable to the following aircraft:

MODEL APPLICABILITY AIRCRAFT SERIAL NUMBERS 90 LJ-1 THRU LJ-113, EXCEPT LJ-76 A90 LJ-76, LJ-114 THRU LJ-317 B90 LJ-318 THRU LJ-501 C90 LJ-502 THRU LJ-1062 (INCLUDES MODEL C90-1) C90A LJ-1063 THRU LJ-1287, LJ-1289 THRU LJ-1294, LJ-1296 THRU LJ-1299 AND AFTER C90B LJ-1288, LJ-1295, LJ-1300 AND AFTER E90 LW-1 AND AFTER F90 LA-2 THRU LA-204, EXCEPT LA-202 F90-1 LA-202, LA-205 AND AFTER B100 B-2 THRU B-89 & B-93 A100 B-1, B-90 AND AFTER, EXCEPT B-93 B100 BE-2 AND AFTER 200 SERIES (INCLUDES) 200 BB-2 THRU BB-733, BB-735 THRU BB-792, BB-794 THRU BB-828, BB-830 THRU BB-853, BB871 THRU BB-873, BB-892, BB-893, BB-895, BB-912 200C BL-1 THRU BL-36 200T BT-1 THRU BT-22 200CT BN-1 B200 SERIES (INCLUDES) B200 BB-734, BB-793, BB-829, BB-854 THRU BB-870, BB-874 THRU BB-891, BB-894, BB-896 THRU BB- 911, BB-913 AND AFTER B200C BL-37 AND AFTER B200T BT-23 AND AFTER B200CT BN-2 AND AFTER 300 FA-1 AND AFTER 300LW FF-1 AND AFTER B300 FL-1 AND AFTER (ALSO KNOWN AS 350) B300C FM-1 AND AFTER

BEECHCRAFT King Air and Super King Air Series equipped with RAISBECK SystemsDocument No. 85-119


IMPORTANT! WHEN ORDERING PARTS Always use the complete manufacturer’s part number listed in the part number column. BE SURE AIRPLANE SERIAL NUMBER ACCOMPANIES ALL SPARE PARTS ORDERS.

NOTICE Raisbeck Engineering specifically reserves the right to supercede, cancel, and/or declare obsolete any part number, kit, or publication that may be referenced in this manual without prior notice.

WARNING This Illustrated Parts Catalog has but one function; to facilitate ordering replacement parts for Raisbeck Systems installed on Beechcraft King Airs and Super King Airs.

Illustrations in this catalog are to be used only as aids in identifying parts and should not be used as a maintenance reference or for reassembly.

ORDERING PROCEDUREAddress all orders to: PARTS AND SERVICE OPERATIONS RAISBECK ENGINEERING, INC. 4411 South Ryan Way Seattle, WA 98178

USA Domestic 800-537-7277 International 206-723-2000 You may also fax your order to 206-723-2884.

VENDOR-DIRECT ORDERING In some instances, such as Hartzell (Propeller Parts) and B.F. Goodrich (wing leading edge and propeller de-icing parts) you may wish to order directly from our supplier. The parts that qualify have the vendor’s name listed with the part number.

PAYMENT Unless otherwise specifically arranged, all orders will be filled upon receipt of full payment. Payment may be made by company check, wire transfer, or by credit card (VISA & MASTERCARD ONLY). Prices are available through letter, telephone, or fax.

-iii- APRIL 2004

0



APRIL 2004

LIST OF PAGES & TABLE OF CONTENTSFOR

QUIET TURBOFAN PROPELLERS

SYSTEM/AIRCRAFT/ PAGE EFFECTIVE SECTION NO. DATE CONTENTS1-0 1 APR 04 . . . .LIST OF PAGES & TABLE 2 APR 04 OF CONTENTS 3 APR 04

1-1 1 APR 04 . . . .QUIET TURBOFANS (A90/B90/C90/C9OA/ C9OB/E90)

1-1-1 1 APR 04 . . . .TURBOFAN PROPELLERS1-1-1 2 APR 041-1-1 3 APR 041-1-1 4 MAY 951-1-1 5 MAY 951-1-1 6 MAY 951-1-1 7 MAY 951-1-1 8 MAY 951-1-1 9 MAY 951-1-1 10 APR 041-1-1 11 MAY 95

1-1-2 1 MAY 95 . . . .COCKPIT & ELECTRICAL1-1-2 2 MAY 951-1-2 3 MAY 951-1-2 4 MAY 951-1-2 5 MAY 95

1-1-3 1 MAY 95 . . . .ENGINE COMPONENTS1-1-3 2 APR 041-1-3 3 MAY 951-1-3 4 APR 041-1-3 5 MAY 95

1-0PAGE 2



PAGE 31-0



APRIL 2004



SYSTEM/AIRCRAFT/ PAGE EFFECTIVE SECTION NO. DATE CONTENTS

1-2 1 APR 04 . . . . QUIET TURBOFANS (100/AlOO)

1-2-1 1 APR 04 . . . .TURBOFAN PROPELLERS1-2-1 2 APR 041-2-1 3 MAR 041-2-1 4 APR 921-2-1 5 APR 92

1-2-2 1 MAY 95 . . . .COCKPIT & ELECTRICAL1-2-2 2 MAY 951-2-2 3 APR 921-2-2 4 APR 921-2-2 5 APR 921-2-2 6 APR 921-2-2 7 APR 92

1-2-3 1 MAY 95 . . . .ENGINE COMPONENTS1-2-3 2 MAY 951-2-3 3 APR 041-2-3 4 MAY 951-2-3 5 MAY 95

1-0PAGE 2



PAGE 31-0



APRIL 2004



SYSTEM/AIRCRAFT/ PAGE EFFECTIVE SECTION NO. DATE CONTENTS1-3 1 APR 04 . . . .QUIET TURBOFANS (200 SERIES/B200 SERIES)

1-3-1 1 APR 04 . . . .TURBOFAN PROPELLERS1-3-1 2 APR 041-3-1 3 APR 041-3-1 4 APR 921-3-1 5 APR 921-3-1 6 APR 921-3-1 7 MAY 951-3-1 8 APR 921-3-1 9 MAY 951-3-1 10 APR 041-3-1 11 APR 041-3-1 12 APR 041-3-1 13 APR 041-3-1 14 APR 041-3-1 15 APR 04

1-3-2 1 MAY 95 . . . .COCKPIT & ELECTRICAL1-3-2 2 MAY 951-3-2 3 APR 921-3-2 4 APR 921-3-2 5 APR 921-3-2 6 APR 921-3-2 7 APR 92

1-3-3 1 MAY 95 . . . .ENGINE COMPONENTS1-3-3 2 APR 921-3-3 3 MAY 951-3-3 4 MAY 951-3-3 5 MAY 951-3-3 6 MAY 951-3-3 7 MAY 95

1-0PAGE 4



APRIL 2004




1-4 1 APR 04. . . . QUIET TURBOFANS (F90/F90-1)

1-4-1 1 APR 04 . . . .TURBOFAN PROPELLERS1-4-1 2 APR 041-4-1 3 APR 041-4-1 4 JAN 981-4-1 5 JAN 981-4-1 6 JAN 981-4-1 7 JAN 98

1-4-2 1 JAN 98 . . . .COCKPIT & ELECTRICAL1-4-2 2 APR 041-4-2 3 JAN 981-4-2 4 APR 041-4-2 5 JAN 98

1-4-3 1 JAN 98 . . . .ENGINE COMPONENTS1-4-3 2 JAN 981-4-3 3 JAN 98



APRIL 2004

QUIET TURBOFAN PROPELLERSKING AIR A90/B90/C90/C90A/C90B/E90

PAGE 11-1

1-1



APRIL 2004

QUIET TURBOFAN PROPELLERSKING AIR A90/B90/C90/C90A/C90B/E90

1-1-1PAGE 2



PAGE 31-1-1



KING AIR A90/B90/C90/C90A/C90B/E90

FIGURE 1TURBOFAN PROPELLERS

APRIL 2004

1-1-1PAGE 2



PAGE 31-1-1



APRIL 2004

* PART MAY BE OBTAINED THROUGH HARTZELL/BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE.

- ITEM NOT ILLUSTRATED.


UNITS USABLE ITEM PER ONFIGURE NO. PART NO. DESCRIPTION ASSY. CODE1 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 1 HC-D4N-3C/D9290K . PROPELLER (HARTZELL).l la* 7931-4E2271-10 . DE-ICE BOOT . . . . .4 (BF GOODRICH) -1b* D9290 . BLADE (HARTZELL). . .4 lc* D-499 . HUB ASSY (HARTZELL) .l ld* D-5211P . BACKING PLATE . . . .1 (HARTZELL) 1e* 3E2092-4 . DE-ICE HARNESS . . . 4 */ATTACHING PARTS/* 2* B-3339-1 . BOLT (HARTZELL) . . .8 3* A-2048-2 . WASHER (HARTZELL) . .8 -------*------- 4* D-5210P . SPINNER DOME. . . . .1 (HARTZELL) */ATTACHING PARTS/* 5* AN526C1032R8 . SCREW . . . . . . . .20 6* A-1020 . WASHER (HARTZELL) . .20 -------*------- 7* PRP-909-8 . O RING (HARTZELL) . .1 8* C-5292 . CENTERING CONE. . . .1 (HARTZELL) 9* B-632 . SHIM. . . . . . . . .A/R -------*------- 10 85-1500-102 . PROPELLER STOPPER . .1 -------*------- 11* A3044 ..BLOCK ASSY-CARBON . .1 */ATTACHING PARTS/* - MS20392-2C53 ...PIN-CLEVIS . . . . .1 - MS20392-2C53 ...PIN-COTTER . . . . .1

1-1-1PAGE 4



PAGE 51-1-1





MAY 1995

1-1-1PAGE 4



PAGE 51-1-1



MAY 1995

* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE.



UNITS USABLE ITEM PER ONFIGURE NO. PART NO. DESCRIPTION ASSY. CODE

2 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 10 2E1377 . SCREW . . . . . . . .4 (BF GOODRICH)

SEE PAGE 11 FOR USABLE ON CODES AND NOTES.

1-1-1PAGE 6



PAGE 71-1-1




MAY 1995


1-1-1PAGE 6



PAGE 71-1-1



MAY 1995




UNITS USABLE ITEM PER ONFIGURE NO. PART NO. DESCRIPTION ASSY. CODE3 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 11* 90-960028-3 . TARGET BRACKET. . . . 4 2 (BEECHCRAFT) */ATTACHING PARTS/* 12 AN3-5A . BOLT. . . . . . . . . 4 2 13 MS35335-32 . LOCK WASHER . . . . . 4 2 14 AN960-l0L . WASHER. . . . . . . . 4 2 15 MS21043-3 . NUT . . . . . . . . . 4 2


1-1-1PAGE 8



PAGE 91-1-1




MAY 1995


1-1-1PAGE 8



PAGE 91-1-1



MAY 1995





4 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 16* 90-960028-3 . TARGET BRACKET. . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 17 AN3-5A . BOLT. . . . . . . . .1 3 18 MS35335-32 . LOCK WASHER . . . . .1 3 19 AN960-l0L . WASHER. . . . . . . .1 3 20 MS21043-3 . NUT . . . . . . . . .1 3 -------*------- 21* 90-960028-5 . COUNTERWEIGHT . . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 22 AN3-5A . BOLT. . . . . . . . .1 3 23 MS35335-32 . LOCK WASHER . . . . .1 3 24 AN960-l0L . WASHER. . . . . . . .1 3 25 MS21043-3 . NUT . . . . . . . . .1 3 -------*-------


1-1-1PAGE 10



PAGE 111-1-1



APRIL 2004



1-1-1PAGE 10



PAGE 111-1-1



5 86-205C/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 26 90-960028-29 . TARGET BRACKET. . . .1 4 (BEECHCRAFT) 27 90-960028-39 . TARGET BRACKET. . . .1 5 (BEECHCRAFT) */ATTACHING PARTS/* 28 AN960-l0L . WASHER. . . . . . . .2 6 29 MS21043-3 . NUT . . . . . . . . .2 6 30 AN525-l0R10 . SCREW . . . . . . . .2 6 -------*------- 31 90-960028-5 . COUNTERWEIGHT . . . .2 6 (BEECHCRAFT) */ATTACHING PARTS/* 32 AN960-10L . WASHER. . . . . . . .2 6 33 MS21043-3 . NUT . . . . . . . . .2 6 34 AN525-10R10 . SCREW . . . . . . . .1 6

USABLE ON CODES AND NOTES

1. LJ-114 THRU LJ-904, LW-l THRU LW-344.

2. LJ-905 THRU LJ-985, LJ-987 THRU LJ-995, LJ-997 THRU LJ-1010.

3. LJ-986, LJ-996, LJ-1011, LJ-1287,LJ-1289 THRU LJ-1294, LJ-1296 THRU LJ-1299.

4. LJ-1288, LJ-1295 AND LJ-1300 THRU LJ-1332.

5. LJ-1333 AND AFTER.

6. LJ-1288, LJ-1295, LJ-1300 AND AFTER.

MAY 1995





1-2



COCKPIT & ELECTRICALKING AIR A90/B90/C90/C90A/C90B/E90

MAY 1995

1-1-2PAGE 2



PAGE 31-1-2



FIGURE 1COCKPIT & ELECTRICAL


MAY 1995

1-1-2PAGE 2



PAGE 31-1-2



1 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 1 lE1140 . CIRCUIT BREAKER/. . .1 SWITCH (BF GOODRICH) 2* 90-380007-13 . AMMETER (BEECHCRAFT).l 1 3 86-2501-102 . PLACARD . . . . . . .1 2 4 REI-1001-3 . PLACARD . . . . . . A/R 3






MAY 1995

1-1-2PAGE 4



PAGE 51-1-2





MAY 1995

1-1-2PAGE 4



PAGE 51-1-2



2 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 5 3E1964-3 . TIMER . . . . . . . .1 (BF GOODRICH)


1. OPTIONAL SPARE FOR REWORKED AMMETER.

2. INSTALLATION REQUIRED ONLY WHEN MAGICAM IS INSTALLED (SEE 1-1-3, FIGURE 1).

3. USED TO IDENTIFY REWORKED AMMETER, AIRSPEED INDICATOR, PROPELLER TACHOMETER AND PROPELLER TORQUE METER (AS APPLICABLE).

5 REQUIRED FOR MODEL A90 WITHOUT WEIGHT INCREASE. 3 REQUIRED FOR MODEL A90/B90 WITH WEIGHT INCREASE. 3 REQUIRED FOR MODEL C90/C90A. 7 REQUIRED FOR MODEL E90.

4. AIRCRAFT WITH OPTIONAL GROSS WEIGHT INCREASE LJ-1063 THRU LJ- 1137 AND LJ-1146 ONLY.





MAY 1995

1-3



ENGINE COMPONENTSKING AIR A90/B90/C90/C90A/C90B/E90

MAY 1995

1-1-3PAGE 2



PAGE 31-1-3



FIGURE 1ENGINE COMPONENTS


APRIL 2004

1-1-3PAGE 2



PAGE 31-1-3



1 86-205C TURBOFAN PROPELLER . . N/P INSTALLATION 1 3E2090-1 . BRUSH ASSEMBLY . . . .2 1 (BF GOODRICH) */ATTACHING PARTS/* 2 MS51957-50 . SCREW. . . . . . . .2 1 3 AN960C8L . WASHER . . . . . . .4 1 4 MS21045-08 . NUT. . . . . . . . .2 1

5* 90-960028-1 . BRACKET. . . . . . .1 1 (BEECHCRAFT) */ATTACHING PARTS/* 6* 130909B15 . BOLT (BEECHCRAFT). .2 1 7 MS35335-32 . LOCK WASHER. . . . .2 1 8 AN960-l0L . WASHER . . . . . . .2 1 9 NAS679A3 . NUT. . . . . . . . .2 1

10* 50-910584-33 . BRACKET. . . . . . .1 1 (BEECHCRAFT) 11 lE1157 . SHIM (BF GOODRICH) .A/R






MAY 1995

1-1-3PAGE 4



PAGE 51-1-3




KING AIR C90B

APRIL 2004

1-1-3PAGE 4



PAGE 51-1-3



2 86-205C TURBOFAN PROPELLER . . N/P INSTALLATION 12 3E2090-1 . BRUSH ASSEMBLY . . . .2 1 (BF GOODRICH) (OPT RA2090-1) */ATTACHING PARTS/* 13 MS51957-50 . SCREW. . . . . . . .2 1 14 AN960C8L . WASHER . . . . . . .4 1 15 MS21045-08 . NUT. . . . . . . . .2 1 -------*------- 16 92-2502-1 . BRACKET. . . . . . .1 1 (BEECHCRAFT) */ATTACHING PARTS/* 17 AN3-5A . BOLT . . . . . . . .2 1 18 MS35335-32 . LOCK WASHER. . . . .2 1 19 AN960-l0L . WASHER . . . . . . .2 1 20 MS21043-3 . NUT. . . . . . . . .2 1 -------*------- 21 50-910584-33 . BRACKET. . . . . . .1 1 (BEECHCRAFT) 22 lE1157 . SHIM (BF GOODRICH) .A/R 1 -------*-------


KING AIR C90B




MAY 1995

1-1-3PAGE 6



PAGE 71-1-3





MAY 1995

1-1-3PAGE 6



PAGE 71-1-3



3 86-205/88-205 TURBOFAN PROPELLER. . N/P INSTALLATION 27 REI-1001-1 . PLACARD . . . . . . .1 28 86-2501-101 . MAGICAM . . . . . . .1 2


1. LJ-1288, LJ-1295, LJ-1300 AND AFTER.

2. CUSTOMER OPTION.





MAY 1995



APRIL 2004PAGE 1

1-2

QUIET TURBOFAN PROPELLERSKING AIR 100/A100

2-1



APRIL 2004

QUIET TURBOFAN PROPELLERSKING AIR 100/A100

1-2-1PAGE 2



PAGE 31-2-1




APRIL 2004

KING AIR 100/A100

1-2-1PAGE 2



PAGE 31-2-1



APRIL 2004



KING AIR 100/A100


1 91-207 TURBOFAN PROPELLER. . .N/P INSTALLATION 1 HC-D4N-3C/D9290K . PROPELLER (HARTZELL).l la* 7931-4E2271-10 . DE-ICE BOOT . . . . .4 (BF GOODRICH) -1b* D9290 . BLADE (HARTZELL). . .4 lc* D-499 . HUB ASSY (HARTZELL) .l ld* D-5211P . BACKING PLATE . . . .1 (HARTZELL) 1e* 3E2092-4 . DE-ICE HARNESS . . . 4 */ATTACHING PARTS/* 2* B-3339-1 . BOLT (HARTZELL) . . .8 3* A-2048-2 . WASHER (HARTZELL) . .8 -------*------- 4* D-5210P . SPINNER DOME. . . . .1 (HARTZELL) */ATTACHING PARTS/* 5* AN526C1032R8 . SCREW . . . . . . . .20 6* A-1020 . WASHER (HARTZELL) . .20 -------*------- 7* PRP-909-8 . O RING (HARTZELL) . .1 8* C-5292 . CENTERING CONE. . . .1 (HARTZELL) 9* B-632 . SHIM. . . . . . . . .A/R -------*------- 10 85-1500-102 . PROPELLER STOPPER . .1 -------*------- 11* A3044 ..BLOCK ASSY-CARBON . .1 */ATTACHING PARTS/* - MS20392-2C53 ...PIN-CLEVIS . . . . .1 - MS20392-2C53 ...PIN-COTTER . . . . .1

1-2-1PAGE 4



PAGE 51-2-1




APRIL 1992

KING AIR 100/A100

1-2-1PAGE 4



PAGE 51-2-1



APRIL 1992



KING AIR 100/A100

UNITS USABLE ITEM PER ONFIGURE NO. PART NO. DESCRIPTION ASSY. CODE2 91-207 TURBOFAN PROPELLER. . N/P INSTALLATION 10 2E1377 . SCREW . . . . . . . .4 (BF GOODRICH)

2-2



COCKPIT & ELECTRICALKING AIR 100/A100

MAY 1995

1-2-2PAGE 2



PAGE 31-2-2




MAY 1995

THIS INSTRUMENT HASBEEN RE-RANGEMARKED PER

FAA STC SA566INMRAISBECK ENGINEERING, INC.(206) 723-2000/800-537-7277

P/N REI-1001-8

KING AIR 100/A100

1-2-2PAGE 2



PAGE 31-2-2



1 91-207 TURBOFAN PROPELLER . . N/P INSTALLATION 1 7270-5-25 . CIRCUIT BREAKER/ . . .2 SWITCH (KLIXON) 2* 90-380007-13 . AMMETER(BEECHCRAFT). .1 1 3 REI-1001-8 . PLACARD. . . . . . . .7 2


APRIL 1992

KING AIR 100/A100




1-2-2PAGE 4



PAGE 51-2-2




APRIL 1992

KING AIR 100/A100

1-2-2PAGE 4



PAGE 51-2-2



2 91-207 TURBOFAN PROPELLER . . N/P INSTALLATION 4 3E1964-3 . TIMER. . . . . . . . .1 3 (BF GOODRICH) 5 MS24187-Dl . RELAY. . . . . . . . .1 3 6 MDA30 . FUSE . . . . . . . . .3 3


APRIL 1992

KING AIR 100/A100




1-2-2PAGE 6



PAGE 71-2-2



APRIL 1992


KING AIR 100/A100

1-2-2PAGE 6



PAGE 71-2-2



3 91-207 TURBOFAN PROPELLER . . N/P INSTALLATION 7 3E1964-3 . TIMER (BF GOODRICH). .2 4



2. USED TO IDENTIFY REWORKED AMMETER, AIRSPEED INDICATOR,PROPELLER TACHOMETER AND PROPELLER TORQUE METER.

3. MODEL 100 (B-2 THRU B-89 & B-93).

4. MODEL A100 (B-l, B-90 AND AFTER, EXCEPT B-93).

APRIL 1992

KING AIR 100/A100




2-3



MAY 1995

ENGINE COMPONENTSKING AIR 100/A100

1-2-3PAGE 2



PAGE 31-2-3




MAY 1995

KING AIR 100/A100

1-2-3PAGE 2



PAGE 31-2-3



KING AIR 100/A100




APRIL 2004

1 91-207 TURBOFAN PROPELLER . . N/P INSTALLATION 1 4E1311-2 . BRUSH ASSEMBLY . . . .2 1 (BF GOODRICH) 2 3E2044-1 . BRUSH ASSEMBLY . . . .2 2 (BF GOODRICH) */ATTACHING PARTS/* 3 MS51957-50 . SCREW. . . . . . . . .2 3 4 AN960C8L . WASHER . . . . . . . .4 3 5 MS21045-08 . NUT. . . . . . . . . .2 3 -------*------- 6* 90-960028-17 . BRACKET. . . . . . . .1 3 (BEECHCRAFT) - 90-960028-39 . OPTIONAL TO 90-960028-17 */ATTACHING PARTS/* 7* 130909B15 . BOLT (BEECHCRAFT). . .2 3 8 MS35335-32 . LOCK WASHER. . . . . .2 3 9 AN960-l0L . WASHER . . . . . . . .2 3 10 NAS679A3 . NUT. . . . . . . . . .2 3 -------*------- 11* 50-910584-33 . BRACKET. . . . . . . .1 3 (BEECHCRAFT) - 50-910584-27 . OPTIONAL TO 50-910584-33 12 lE1157 . SHIM (BF GOODRICH) A/R


1-2-3PAGE 4



PAGE 51-2-3




MAY 1995

KING AIR 100/A100

1-2-3PAGE 4



PAGE 51-2-3



2 91-207 TURBOFAN PROPELLER . . N/P INSTALLATION 13 REI-1001-1 . PLACARD. . . . . . . .2

USEABLE ON CODES AND NOTES

1. B-l THRU B-232.

2. B-233 AND AFTER.

3. B-1 AND AFTER.

KING AIR 100/A100




MAY 1995



APRIL 2004PAGE 1

1-3

QUIET TURBOFAN PROPELLERS SUPER KING AIR B200/A200/200 SERIES

3-1



APRIL 2004

QUIET TURBOFAN PROPELLERS SUPER KING AIR B200/A200/200 SERIES

1-3-1PAGE 2



PAGE 31-3-1



SUPER KING AIR 200 SERIES/B200 SERIES


APRIL 2004

1-3-1PAGE 2



PAGE 31-3-1




* PART MAY BE OBTAINED THROUGH HARTZELL/BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE. - ITEM NOT ILLUSTRATED.


APRIL 2004

1 85-105 TURBOFAN PROPELLER. . . N/P INSTALLATION 1 HC-D4N-3C/D9383K. PROPELLER (HARTZELL). 1 la* 4E2271-10 . DE-ICE BOOT . . . . . 4 (BF GOODRICH) 1b* D9383 . BLADE (HARTZELL). . . 4 lc* D-499 . HUB ASSY (HARTZELL) . 1 ld* D-5211P . BACKING PLATE . . . . 1 (HARTZELL) le* 3E2092-4 . DE-ICE HARNESS . . . 4 */ATTACHING PARTS/* 2* B-3339-1 . BOLT (HARTZELL) . . . 8 3* A-2048-2 . WASHER (HARTZELL) . . 8 -------*------- 4* D-5210P . SPINNER DOME. . . . . 1 (HARTZELL) */ATTACHING PARTS/* 5* B-3845-8 . SCREW . . . . . . . . 20 6* A-1020 . FIBER WASHER . . . . 20 -------*------- 7* PRP-909-8 . O RING (HARTZELL) . . 1 8* C-5292 . CENTERING CONE. . . . 1 (HARTZELL) 9* B-632 . SPACER (HARTZELL) . . A/R -------*------- 10 85-1500-101 .PROPELLER STOPPER . . .2 1 - 85-1500-103 .PROPELLER STOPPER . . .2 2 11* A3044 ..BLOCK ASSY-CARBON . . 1 */ATTACHING PARTS/* - MS20392-2C53 ...PIN-CLEVIS . . . . . 1 - MS20392-2C53 ...PIN-COTTER . . . . . 1

USEABLE ON CODES AND NOTES1. AIRCRAFT EQUIPPED WITH LONG EXHAUST STACKS.2. AIRCRAFT EQUIPPED WITH SHORT EXHAUST STACKS.

1-3-1PAGE 4



PAGE 51-3-1




APRIL 1992


1-3-1PAGE 4



PAGE 51-3-1







APRIL 1992

2 85-105 TURBOFAN PROPELLER. . .N/P INSTALLATION 10 2E1377 . SCREW . . . . . . . . . 4 1 (BF GOODRICH)

SEE PAGE 11 FOR USEABLE ON CODES AND NOTES

1-3-1PAGE 6



PAGE 71-3-1




APRIL 1992


1-3-1PAGE 6



PAGE 71-3-1







MAY 1995

3 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION 11* 90-960028-3 . TARGET BRACKET . . . .4 2 (BEECHCRAFT) */ATTACHING PARTS/* 12 AN3-5A . BOLT . . . . . . . . .4 2 13 MS35335-32 . LOCK WASHER. . . . . .4 2 14 AN960-l0L . WASHER . . . . . . . .4 2 15 MS21043-3 . NUT. . . . . . . . . .4 2 -------*-------

SEE PAGE 11 FOR USABLE ON CODES AND NOTES

1-3-1PAGE 8



PAGE 91-3-1





APRIL 1992

1-3-1PAGE 8



PAGE 91-3-1







MAY 1995

4 85-105 TURBOFAN PROPELLER . . . N/P INSTALLATION 16* 90-960028-15 . TARGET BRACKET . . . . .1 3 (BEECHCRAFT) -16A* 90-960028-9 . TARGET BRACKET . . . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 17 AN3-5A . BOLT . . . . . . . . . .1 3 18 MS35335-32 . LOCK WASHER. . . . . . .1 3 19 AN960-l0L . WASHER . . . . . . . . .1 3 20 MS21043-3 . NUT. . . . . . . . . . .1 3 -------*------- 21* 90-960028-5 . COUNTERWEIGHT. . . . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 22 AN3-5A . BOLT . . . . . . . . . .1 3 23 MS35335-32 . LOCK WASHER. . . . . . .1 3 24 AN960-l0L . WASHER . . . . . . . . .1 3 25 MS21043-3 . NUT. . . . . . . . . . .1 3 -------*-------


1-3-1PAGE 10



PAGE 111-3-1



APRIL 2004



1-3-1PAGE 10



PAGE 111-3-1







APRIL 2004

5 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION (HARTZELL 3BLADE) 26* 90-960028-21 . TARGET BRACKET . . . . 1 4 (BEECHCRAFT) */ATTACHING PARTS/* 27 AN525-l0R10 . SCREW. . . . . . . . . 2 4 28 AN960-10L . WASHER . . . . . . . . 2 4 29 MS21043-3 . NUT. . . . . . . . . . 2 4 -------*------- 30* 90-960028-23 . COUNTERWEIGHT. . . . . 2 5 (BEECHCRAFT) */ATTACHING PARTS/* 31 AN960-l0L . WASHER . . . . . . . . 2 5 32 MS21043-3 . NUT. . . . . . . . . . 2 5 33 AN525-l0R10 . SCREW. . . . . . . . . 1 5


1. BB-2 THRU BB-790, BL-l THRU BL-17.2. BB-791 THRU BB-934, BL-18 THRU BL-41, BN-l, BT-l THRU BT-22. 3. BB-935 THRU BB-1406, BL-42 THRU BL-133, BN-2 THRU BN-4, BT-23 THRU BT-33. 4. BB-1407 THRU BB-1438, BB-1440 THRU BB-1443, AND BT-34.5. BB-1407 THRU BB-1508, BL-138 THRU BL-140, BT-34 THRU BT-38.6. BB-1407 THRU BB-1455, BT-35 THRU BT-38.7. BB-1456 THRU BB-1508, BL-139 THRU BL-140.8. BL-138.9. BB-1509 AND AFTER, BL-141 AND AFTER, BN-5 AND AFTER, BT-35 AND AFTER.

1-3-1PAGE 12



PAGE 131-3-1



FIGURE 6TURBOFAN PROPELLERS APRIL 2004


1-3-1PAGE 12



PAGE 131-3-1







APRIL 2004

6 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION (MCCAULEY 4 BLADE) 34* 90-960028-29 . TARGET BRACKET . . . . 1 6 (BEECHCRAFT) 34a* 90-960028-39 . TARGET BRACKET . . . . 1 7 (BEECHCRAFT) 34b* 90-960029-11 . TARGET BRACKET . . . . 1 8 (BEECHCRAFT) */ATTACHING PARTS/* 35 AN525-l0R10 . SCREW. . . . . . . . . 2 5 36 AN960-10L . WASHER . . . . . . . . 4 5 37 MS21043-3 . NUT. . . . . . . . . . 2 5 ———*———- 38* 90-960028-23 . COUNTERWEIGHT. . . . . 2 5 (BEECHCRAFT) */ATTACHING PARTS/* 39 AN960-l0L . WASHER . . . . . . . . 2 5 40 MS21043-3 . NUT. . . . . . . . . . 2 5 41 AN525-l0R1 . SCREW. . . . . . . . . 1 5


1-3-1PAGE 14



PAGE 151-3-1




APRIL 2004


1-3-1PAGE 14



PAGE 151-3-1







APRIL 2004

7 85-105 TURBOFAN PROPELLER . . . N/P INSTALLATION 42* 3360-078 . TARGET-MAGNETIC . . . . 1 9 (BEECHCRAFT) */ATTACHING PARTS/* 43 AN960C6L . WASHER . . . . . . . . . 1 9 44 MS21043-06 . NUT. . . . . . . . . . . 1 9 SEE PAGE 11 FOR USABLE ON CODES AND NOTES.

3-2



COCKPIT & ELECTRICALSUPER KING AIR B200/A200/200 SERIES

MAY 1995

1-3-2PAGE 2



PAGE 31-3-2




MAY 1995


1-3-2PAGE 2



PAGE 31-3-2



APRIL 1992

1 85-105 TURBOFAN PROPELLER. . . N/P INSTALLATION 1 lE1140 . CIRCUIT BREAKER/SWITCH.l (BF GOODRICH) 2* 90-380007-13 . AMMETER (BEECHCRAFT). .1 1 3 86-2501-102 . PLACARD . . . . . . . .1 2 4 REI-1001-2 . PLACARD . . . . . . . .3 3






1-3-2PAGE 4



PAGE 51-3-2




APRIL 1992


1-3-2PAGE 4



PAGE 51-3-2



APRIL 1992

2 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION 5 4200-002-25 . CIRCUIT BREAKER. . . .2 (KLIXON)





1-3-2PAGE 6



PAGE 71-3-2



APRIL 1992



1-3-2PAGE 6



PAGE 71-3-2



3 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION 6 3E1964-3 . TIMER (B.F. GOODRICH).l



2. INSTALLATION REQUIRED ONLY WHEN MAGICAM IS INSTALLED (SEE 1-3-3, FIGURE 2).

3. USED TO IDENTIFY REWORKED AMMETER AND AIRSPEED INDICATOR.

APRIL 1992





3-3



ENGINE COMPONENTSSUPER KING AIR B200/A200/200 SERIES

MAY 1995

1-3-3PAGE 2



PAGE 31-3-3




APRIL 1992


1-3-3PAGE 2



PAGE 31-3-3



1 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION 1 3E2090-1 . BRUSH ASSEMBLY . . . .2 1 (BF GOODRICH) (OPT RA2090-1) */ATTACHING PARTS/* 2 MS51957-50 . SCREW. . . . . . . .2 1 3 AN960C8L . WASHER . . . . . . .4 1 4 MS21045-08 . NUT. . . . . . . . .2 1 -------*------- 5* 90-960028-1 . BRACKET. . . . . . .1 1 (BEECHCRAFT) */ATTACHING PARTS/* 6* 130909B15 . BOLT (BEECHCRAFT). .2 1 7 MS35335-32 . LOCK WASHER. . . . .2 1 8 AN960-l0L . WASHER . . . . . . .2 1 9 NAS679A3 . NUT. . . . . . . . .2 1 -------*------- 10* 50-910584-33 . BRACKET. . . . . . .1 1 (BEECHCRAFT) 11 lE1157 . SHIM (BF GOODRICH) .A/R


MAY 1995





1-3-3PAGE 4



PAGE 51-3-3




MAY 1995


1-3-3PAGE 4



PAGE 51-3-3



MAY 1995

2 85-105 TURBOFAN PROPELLER. . . N/P INSTALLATION 12 REI-1001-1 . PLACARD . . . . . . . .1 13 86-2501-101 . MAGICAM . . . . . . . .1 2

SEE PAGE 7 FOR USEABLE ON CODES AND NOTES.





1-3-3PAGE 6



PAGE 71-3-3




MAY 1995

SUPER KING AIR B200 SERIES

1-3-3PAGE 6



PAGE 71-3-3



MAY 1995

3 85-105 TURBOFAN PROPELLER . . N/P INSTALLATION 14 3E2090-1 . BRUSH ASSEMBLY . . . .2 3 (BF GOODRICH) (OPT RA2090-1) */ATTACHING PARTS/* 15 MS51957-50 . SCREW. . . . . . . .2 3 16 AN960C8L . WASHER . . . . . . .4 3 17 MS21045-08 . NUT. . . . . . . . .2 3 -------*------- 18 92-2502-1 . BRACKET. . . . . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 19* 130909B15 . BOLT (BEECHCRAFT). .2 3 20 MS35335-32 . LOCK WASHER. . . . .2 3 21 AN960-l0L . WASHER . . . . . . .2 3 22 NAS679A3 . NUT. . . . . . . . .2 3 -------*------- 23* 50-910584-33 . BRACKET. . . . . . .1 3 (BEECHCRAFT) 24 lE1157 . SHIM (BF GOODRICH) .A/R 3 -------*-------


1. BB-1193 AND AFTER, BL-118 AND AFTER, BN-5 AND AFTER, BT-31 AND AFTER.

2. CUSTOMER OPTION

3. BB-1407 AND AFTER, BL-134 AND AFTER, BN-5 AND AFTER, BT-34 AND AFTER.







APRIL 2004PAGE 1

1-4

QUIET TURBOFAN PROPELLERSKING AIR F90/F90-1

4-1



APRIL 2004

QUIET TURBOFAN PROPELLERSKING AIR F90/F90-1

1-4-1PAGE 2



PAGE 31-4-1




APRIL 2004

SUPER KING AIR F90/F90-1

1-4-1PAGE 2



PAGE 31-4-1



APRIL 2004





1 87-1500 TURBOFAN PROPELLER. . .N/P INSTALLATION 1 HC-D4N-3C/D9290$K . PROPELLER HARTZELL). l la* 7931-4E2271-10 . DE-ICE BOOT . . . . .4 (BF GOODRICH) -1b* D9290 . BLADE (HARTZELL). . .4 lc* D-499 . HUB ASSY (HARTZELL) .l ld* D-5211P . BACKING PLATE . . . .1 (HARTZELL) 1e 3E2092-4 . DE-ICE HARNESS */ATTACHING PARTS/* 2* B-3339-1 . BOLT (HARTZELL) . . .8 3* A-2048-2 . WASHER (HARTZELL) . .8 -------*------- 4* D-5210P . SPINNER DOME. . . . .1 (HARTZELL) */ATTACHING PARTS/* 5* AN526C1032R8 . SCREW . . . . . . . .20 6* A-1020 . WASHER (HARTZELL) . .20 -------*------- 7* PRP-909-8 . O RING (HARTZELL) . .1 8* C-5292 . CENTERING CONE. . . .1 (SUPERSEDES B-498) 9* B-632 . SHIM. . . . . . . . .A/R -------*------- 10 85-1500-102 . PROPELLER STOPPER . .1 -------*------- 11* A3044 ..BLOCK ASSY-CARBON . .1 */ATTACHING PARTS/* - MS20392-2C53 ...PIN-CLEVIS . . . . .1 - MS20392-2C53 ...PIN-COTTER . . . . .1

1-4-1PAGE 4



PAGE 51-4-1




JAN 1998


1-4-1PAGE 4



PAGE 51-4-1



JAN 1998





2 87-1500 TURBOFAN PROPELLER. . .N/P INSTALLATION 11* 90-960028-3 . TARGET BRACKET. . . .4 2 (BEECHCRAFT) */ATTACHING PARTS/* 12 AN3-5A . BOLT. . . . . . . . .4 2 13 MS35335-32 . LOCK WASHER . . . . .4 2 14 AN960-l0L . WASHER. . . . . . . .4 2 15 MS21043-3 . NUT . . . . . . . . .4 2

1-4-1PAGE 6



PAGE 71-4-1




JAN 1998


1-4-1PAGE 6



PAGE 71-4-1



USABLE ON CODES

2. LA-2 - LA-1533. LA-154 - LA-236

JAN 1998





3 87-1500 TURBOFAN PROPELLER. . N/P INSTALLATION 16* 90-960028-3 . TARGET BRACKET. . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 17 AN3-5A . BOLT. . . . . . . . .1 3 18 MS35335-32 . LOCK WASHER . . . . .1 3 19 AN960-l0L . WASHER. . . . . . . .1 3 20 MS21043-3 . NUT . . . . . . . . .1 3 -------*------- 21* 90-960028-5 . COUNTERWEIGHT . . . .1 3 (BEECHCRAFT) */ATTACHING PARTS/* 22 AN3-5A . BOLT. . . . . . . . .1 3 23 MS35335-32 . LOCK WASHER . . . . .1 3 24 AN960-l0L . WASHER. . . . . . . .1 3 25 MS21043-3 . NUT . . . . . . . . .1 3 -------*-------

4-2



COCKPIT & ELECTRICALSUPER KING AIR F90/F90-1

JAN 1998

1-4-2PAGE 2



PAGE 31-4-2



APRIL 2004



1-4-2PAGE 2



PAGE 31-4-2



JAN 1998





1 1 REI-1001-9 PLACARD . . . . . . 1

1-4-2PAGE 4



PAGE 51-4-2




APRIL 2004


1-4-2PAGE 4



PAGE 51-4-2



JAN 1998





2 87-1500 TURBOFAN PROPELLER. . N/P INSTALLATION 5 3E1964-3 . TIMER . . . . . . . .1 1 (BF GOODRICH)


1. LA-1 - LA-130

4-3



ENGINE COMPONEMNTSSUPER KING AIR F90/F90-1

JAN 1998

1-4-3PAGE 2



PAGE 31-4-3




JAN 1998


1-4-3PAGE 2



PAGE 31-4-3






1 87-1500 TURBOFAN PROPELLER . . N/P INSTALLATION 1 3E2090-1 . BRUSH ASSEMBLY . . . .2 (BF GOODRICH) (OPT RA2090-1) */ATTACHING PARTS/* 2 MS51957-50 . SCREW. . . . . . . .2 3 AN960C8L . WASHER . . . . . . .4 4 MS21045-08 . NUT. . . . . . . . .2 -------*------- 5* 90-960028-1 . BRACKET. . . . . . .1 (BEECHCRAFT) */ATTACHING PARTS/* 6* 130909B15 . BOLT (BEECHCRAFT). .2 7 MS35335-32 . LOCK WASHER. . . . .2 8 AN960-l0L . WASHER . . . . . . .2 9 NAS679A3 . NUT. . . . . . . . .2 -------*------- 10* 50-910584-33 . BRACKET. . . . . . .1 (BEECHCRAFT) 11 lE1157 . SHIM (BF GOODRICH) .A/R

JAN 1998


0




RAM AIR RECOVERY SYSTEM

APRIL 2004

SYSTEM/AIRCRAFT/ PAGE EFFECTIVESECTION NO. DATE CONTENTS

2-0 1 MAY 95 . . . .LIST OF PAGES & TABLE OF CONTENTS

2-1 1 APR 04 . . . .RAM AIR RECOVERY SYSTEM (B200/A200/200 SERIES)

2-1-1 1 APR 04 . . . .FIXED TURNING VANE2-1-1 2 APR 042-1-1 3 APR 04

2-1-2 1 APR 04 . . . .AIR INTAKE ANTI-ICE2-1-2 2 APR 042-1-2 3 APR 04 2-1-2 4 APR 92 2-1-2 5 MAY 95

2-1-3 1 APR 04 . . . .ENGINE BAFFLE SEALS2-1-3 2 APR 922-1-3 3 MAY 952-1-3 4 APR 922-1-3 5 MAY 952-1-3 6 MAY 952-1-3 7 MAY 95



APRIL 2004PAGE 1

2-1

RAM AIR RECOVERY SYSTEMSUPER KING AIR B200/A200/200 SERIES

1-1



FIXED TURNING VANESUPER KING AIR B200/A200/200 SERIES

APRIL 2004

2-1-1PAGE 2



PAGE 32-1-1



FIGURE 1FIXED TURNING VANE

APRIL 2004


2-1-1PAGE 2



PAGE 32-1-1



APRIL 2004





1 R81-1021 RAM AIR RECOVERY SYSTEM. N/P 1 INSTALLATION 93-1021 RAM AIR RECOVERY SYSTEM. N/P 2 INSTALLATION 1 81-3103-109 . VANE . . . . . . . . . .1 2 81-3119-103 . SUPPORT. . . . . . . . .1 3 81-3119-104 . SUPPORT. . . . . . . . .1 4 AN525-832R12 . SCREW. . . . . . . . . .4 5 MS20364-832A . NUT. . . . . . . . . . .4 6 AN960KD8L . WASHER . . . . . . . . .8 7 MS24694-$5 . SCREW. . . . . . . . . .10 8 AN960-8 . WASHER. . . . . . . . . 10 9 MS20364-832A . NUT. . . . . . . . . . .10

USABLE ON CODES AND NOTES 1. BB-2 THRU BB-1438, BB-1440 THRU BB-1443, BL-1 THRU BL-138, BN-1 THRU BN-4, BT-1 THRU BT-34.

2. BB-1439, BB-1444 AND AFTER, BL-139 AND AFTER, BN-5 AND AFTER, BT-35 AND AFTER.

1-2



APRIL 2004

AIR INTAKE ANTI-ICESUPER KING AIR B200/A200/200 SERIES

2-1-2PAGE 2



PAGE 32-1-2



FIGURE 1AIR INTAKE ANTI-ICE

APRIL 2004


2-1-2PAGE 2



PAGE 32-1-2



APRIL 2004





1 R81-1021 RAM AIR RECOVERY SYSTEM. N/P 1 INSTALLATION 93-1021 RAM AIR RECOVERY SYSTEM. N/P 2 INSTALLATION 1 81-3101-1 PARTICLE SEPARATOR ASSY. .l 2 81-3109-111 . SHIM . . . . . . . . . .2 3 81-3109-113 . SHIM . . . . . . . . . .1 4 MS35206-244 . SCREW. . . . . . . . . .8 5 AN960-8 . WASHER . . . . . . . . .8 6* 130909N28 . NUT (BEECHCRAFT) . . . .8 7 81-3104-3 . PARTICLE SEPARATOR LINKAGE ASSY . . . . . .2 */ATTACHING PARTS/* 8 AN3-llA . BOLT . . . . . . . . . .2 9 AN3-l0A . BOLT . . . . . . . . . .2 10 AN960-10 . WASHER . . . . . . . . .10 12 MS21042L3 . NUT. . . . . . . . . . .4 13 NAS76A3-018 . BUSHING. . . . . . . . .2 14 NAS76A3-007 . BUSHING. . . . . . . . .2 15 5612-86-80 . WASHER (SEASTROM) . . . A/R (IF REQD) - 5612-86-46 . WASHER (SEASTROM). . . .A/R (IF REQD) 16* 101-910020-3 . VANE . . . . . . . . . . 1 17* 101-910020-7 . SEAL . . . . . . . . . . 2 18* 101-910058-3 . RETAINER . . . . . . . 2 19* 101-910058-5 . SEAL PLATE . . . . . . . 2 20* 101-910020-15 . HINGE HALF . .. . . . . .1 (PART OF 101-910020-3) 21* 101-910020-14 . HINGE HALF . . . . . . .1 (PART OF 101-910020-3)


2-1-2PAGE 4



PAGE 52-1-2



FIGURE 2AIR INTAKE ANTI-ICE

APRIL 1992


2-1-2PAGE 4



PAGE 52-1-2



MAY 1995





2 R81-1021 RAM AIR RECOVERY SYSTEM. N/P 1 INSTALLATION 93-1021 RAM AIR RECOVERY SYSTEM. N/P 2 INSTALLATION 15 81-3106-111 . BRACKET. . . . . . . . .1 16 81-3106-112 . BRACKET. . . . . . . . .1 17 81-3108-107 . RETAINER . . . . . . . .1 18 81-3108-108 . RETAINER . . . . . . . .1 19 81-3108-109 . RETAINER . . . . . . . .1 20 81-3110-109 . SPACER /SEE NOTE/. . . .A/R 21 81-3110-111 . SPACER /SEE NOTE/. . . .A/R 22 81-3110-113 . SPACER /SEE NOTE/. . . .A/R 23 81-3111-1 . BRACKET ASSY . . . . . .1 24 81-3111-103 . BRACKET. . . . . . . . .1 25 81-3111-104 . BRACKET. . . . . . . . .1 26 81-3111-109 . SHIM . . . . . . . . . .1 27 81-3112-101 . SEAL . . . . . . . . . .2 28 81-3112-105 . SEAL . . . . . . . . . .1 29 81-3118-3 . ICE SHEDDER ASSY . . . .1 30* 101-910049-75 . RETAINER (BEECHCRAFT). .1 31* 101-910049-73 . RETAINER (BEECHCRAFT). .1 32 81-3121-105 . BOOT . . . . . . . . . .1 (SUPERSEDES 81-3121-101) 33 NAS1104-9 . BOLT . . . . . . . . . .1 34 AN960PD416 . WASHER . . . . . . . . .2 35 MS51865-8 . CAP NUT. . . . . . . . .1 (OPT F2NKTE048 ESNA)USEABLE ON CODE AND NOTES

1. BB-2 THRU BB-1438, BB-1440 THRU BB-1443, BL-l THRU BL-138, BN-lTHRU BN-4, BT-l THRU BT-34.

2. BB-1439, BB-1444 AND AFTER, BL-139 AND AFTER, BN-5 AND AFTER,BT-35 AND AFTER.

NOTE: ITEMS 20, 21 AND 22 ARE INSTALLED AS REQUIRED DEPENDING ON AIRCRAFT CONFIGURATION.

1-3



ENGINE BAFFLE SEALSSUPER KING AIR B200/A200/200 SERIES

APRIL 2004

2-1-3PAGE 2



PAGE 32-1-3



APRIL 1992

FIGURE 1ENGINE BAFFLE SEALS


2-1-3PAGE 2



PAGE 32-1-3



MAY 1995

1 R81-1021 RAM AIR RECOVERY SYSTEM. N/P 1 INSTALLATION 1 81-3107-111 . BULB SEAL. . . . . . . .1 2 81-3106-113 . RETAINER . . . . . . . .1 3* (P/N UNKNOWN) . RETAINER (BEECHCRAFT). .1 */ATTACHING PARTS/* 4 AN525-l0R8 . SCREW. . . . . . . . . .4 5 AN960-10 . WASHER . . . . . . . . .2 6 MS21042L3 . NUT. . . . . . . . . . .2 7* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). .2 -------*------- 8 81-3105-3 . DIAPHRAGM SEAL ASSY. . .1 */ATTACHING PARTS/* 9 AN525-l0R7 . SCREW. . . . . . . . . .17 10 AN960-10 . WASHER . . . . . . . . .17 11 MS21042L3 . NUT. . . . . . . . . . .17 -------*------- 12 81-3105-1 . DIAPHRAGM SEAL ASSY. . .1 */ATTACHING PARTS/* 13 AN525-l0R6 . SCREW. . . . . . . . . .1 14 AN525-l0R7 . SCREW. . . . . . . . . .16 15 AN525-1048 . SCREW. . . . . . . . . .1 16 AN960-10 . WASHER . . . . . . . . .18 17 MS21042L3 . NUT. . . . . . . . . . .18 18 AN970-3 . WASHER . . . . . . . . .1






2-1-3PAGE 4



PAGE 52-1-3



APRIL 1992



2-1-3PAGE 4



PAGE 52-1-3



MAY 1995

2 R81-1021 RAM AIR RECOVERY SYSTEM. N/P 1 INSTALLATION 19 81-3107-107 . BULB SEAL. . . . . . . .1 1 20 81-3107-109 . BULB SEAL. . . . . . . .2 1 21 81-3106-105 . RETAINER . . . . . . . .1 1 22 81-3106-107 . RETAINER . . . . . . . .2 1 23 81-3106-109 . RETAINER . . . . . . . .1 1 24 81-3106-115 . RETAINER . . . . . . . .1 1 25 81-3106-117 . RETAINER . . . . . . . .2 1 26 81-3106-119 . RETAINER . . . . . . . .1 1 27 81-3106-120 . RETAINER . . . . . . . .1 1






2-1-3PAGE 6



PAGE 72-1-3




MAY 1995

29


2-1-3PAGE 6



PAGE 72-1-3



3 93-1021 RAM AIR RECOVERY SYSTEM. N/P 2 INSTALLATION 28 81-3107-113 . BULB SEAL. . . . . . . .1 2 29 101-910188-15 . SEAL RETAINER. . . . . .1 2 (BEECHCRAFT) 30 101-910188-( ) . SEAL RETAINER. . . . . .1 2 (BEECHCRAFT) 31 101-910188-16 . SEAL RETAINER. . . . . .1 2 (BEECHCRAFT)


1. BB-2 THRU BB-1438, BB-1440 THRU BB-1443, BL-1 THRU BL-138, BN-1 THRU BN-4, BT-1 THRU BT-34.

2. BB-1439, BB-1444 AND AFTER, BL-139 AND AFTER, BN-5 AND AFTER, BT-35 AND AFTER.

MAY 1995





0




ENHANCED PERFORMANCE LEADING EDGES

APRIL 2004

3-0 1 APR 04 . . . .LIST OF PAGES & TABLE 2 APR 04 OF CONTENTS 3-1 1 APR 04 . . . .ENHANCED PERFORMANCE LEADING EDGES (B200/A200/200 SERIES

3-1-1 1 APR 04 . . . CENTER SECTION LEADING3-1-1 2 APR 04 EDGE (L/H)3-1-1 3 APR 04 BB-2 THRU BB-64

3-1-2 1 APR 04 . . . .CENTER SECTION LEADING3-1-2 2 APR 04 EDGE (R/H)3-1-2 3 APR 04 BB-2 THRU BB-64

3-1-3 1 APR 04 . . . .CENTER SECTION LEADING3-1-3 2 APR 04 EDGE (L/H)3-1-3 3 APR 04 BB-65 AND AFTER BT-1 AND AFTER BN-1 AND AFTER BL-1 AND AFTER

3-1-4 1 APR 04 . . . .CENTER SECTION LEADING3-1-4 2 APR 04 EDGE (R/H)3-1-4 3 APR 04 BB-65 AND AFTER BT-1 AND AFTER BN-1 AND AFTER BL-1 AND AFTER

3-1-4a 1 APR 04 . . . .CENTER SECTION LEADING3-1-4a 2 APR 04 EDGE (L/H)3-1-4a 3 APR 04 KIT SERIAL #396 AND AFTER


3-0PAGE 2




ENHANCED PERFORMANCE LEADING EDGES

APRIL 2004

3-1-4b 1 APR 04 . . . .CENTER SECTION LEADING3-1-4b 2 APR 04 EDGE (R/H)3-1-4b 3 APR 04 KIT SERIAL #396 AND AFTER3-1-5 1 APR 04 . . . .NACELLE SUPPORT BRACKETS3-1-5 2 APR 92 (L/H)3-1-5 3 APR 92

3-1-6 1 APR 04 . . . .NACELLE SUPPORT BRACKETS3-1-6 2 APR 92 (R/H)3-1-6 3 APR 92

3-1-7 1 APR 04 . . . .WING-TO-BODY FAIRING3-1-7 2 APR 92 (L/H)3-1-7 3 APR 92 3-1-8 1 APR 04 . . . .WING-TO-BODY FAIRING3-1-8 2 APR 92 (R/H)3-1-8 3 APR 92


BEECHCRAFT King Air and Super King Air Seriesequipped with RAISBECK Systems

RA~ECKEN~NEERNG

Document No. 85-119Illustrated Parts Catalog

APRIL 2004

CENTER SECTION LEADING EDGE (LIB)BB-2 TBRU BB-64

SUPER KING AIR 200 SERIES

3-1-1PAGE 1

3-1-1PAGE 2



PAGE 33-1-1



FIGURE 1CENTER SECTION LEADING EDGE (L/H)

BB-2 THRU BB-64

APRIL 2004


3-1-1PAGE 2



PAGE 33-1-1



1 R81-1503-1 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (L/H) 1 81-3510-5 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-11 . LEADING EDGE . . . . . .1 3 25S-7D-5041-13 . DE-ICE BOOT. . . . . . .1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .39 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .39 -------*------- 8* 101-120060-11 . SEAL (BEECHCRAFT). . . . .1 9 81-3514-3 . DUCT ASSY. . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694C48 . SCREW. . . . . . . . . . .6 11* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .6 12 88-3520-10 . INLET PLUG . . . . . . . .1 -------*-------

APRIL 2004





1-2



CENTER SECTION LEADING EDGE (R/H)BB-2 THRU BB-64


APRIL 2004

3-1-2PAGE 2



PAGE 33-1-2



FIGURE 1CENTER SECTION LEADING EDGE (R/H)

BB-2 THRU BB-64

APRIL 2004


3-1-2PAGE 2



PAGE 33-1-2



APRIL 2004





1 R81-1503-2 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (R/H) 1 81-3510-6 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-12 . LEADING EDGE . . . . . . .1 3 25S-7D-5041-14 . DE-ICE BOOT . . . . . . . 1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .45 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .45 -------*------- 8* 101-120060-11 . SEAL (BEECHCRAFT). . . . .1 9 81-3514-4 . DUCT ASSY. . . . . . . . .2 10 MS24694C48 . SCREW. . . . . . . . . . .6 11* P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .6 -------*------- 12* 101-120017-15 . DOOR ASSY (BEECHCRAFT) . . 1 13 81-3511-105 . SPLICE PLATE . . . . . . . 1 14 81-3503-3 . DOOR ASSEMBLY. . . . . . .1 */ATTACHING PARTS/* 15 40S5-6 . STUD ASSEMBLY (REXNORD). .2 16 40S5-8 . STUD ASSEMBLY (REXNORD). .3 17 4OGl-10 . GROMMET (REXNORD). . . . .5 18 R4T . RETAINING RING (REXNORD) .5 -------*------- 19 81-3511-107 . ANGLE. . . . . . . . . . .1 20 81-3511-109 . ANGLE. . . . . . . . . . .1 21 81-3511-111 . ANGLE. . . . . . . . . . .1 22 81-3511-3 . DOOR SUPPORT ASSEMBLY. . .1 23 244-22C . RECEPTACLE (REXNORD) . . .5 -------*------- 24 88-3520-10 . INLET PLUG . . . . . . . .1 -------*-------

1-3



CENTER SECTION LEADING EDGE (L/H)BB-65 AND AFTERBN-1 AND AFTERBT-1 AND AFTERBL-1 AND AFTER

SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

3-1-3PAGE 2



PAGE 33-1-3




BB-65 AND AFTERBT-1 AND AFTERBN-1 AND AFTERBL-1 AND AFTER

APRIL 2004


3-1-3PAGE 2



PAGE 33-1-3







APRIL 2004

1 R81-1503-1 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (L/H) 1 81-3510-5 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-11 . LEADING EDGE . . . . . . .1 3 25S-7D-5041-13 . DE-ICE BOOT. . . . . . . 1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .39 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE . . . . . . . . .39 -------*------- 8 81-3519-101 . SEAL . . . . . . . . . . .1 9 81-3520-1 . DUCT ASSY. . . . . . . . .1 */ATTACHING PARTS/* 10* 13909Bl9 . BOLT (BEECHCRAFT). . . . .12 11 AN960-l0L . WASHER . . . . . . . . . .12 12* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .12 -------*------- 13 88-3520-10 . INLET PLUG . . . . . . . .1 -------*-------

1-4



CENTER SECTION LEADING EDGE (R/H)BB-65 AND AFTERBN-1 AND AFTERBT-1 AND AFTERBL-1 AND AFTER


APRIL 2004

3-1-4PAGE 2



PAGE 33-1-4




APRIL 2004


BB-65 AND AFTERBT-1 AND AFTERBN-1 AND AFTERBL-1 AND AFTER

3-1-4PAGE 2



PAGE 33-1-4







1 R81-1503-2 RECONTOURED WING LEADING N/P EDGE INSTALLATION (R/H) 1 81-3510-6 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-12 . LEADING EDGE . . . . . . .1 3 25S-7D-5041-14 . DE-ICE BOOT. . . . . . . .1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .45 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .45 -------*------- 8 81-3519-101 . SEAL . . . . . . . . . . .1 9 81-3520-2 . DUCT ASSY. . . . . . . . .1 */ATTACHING PARTS/* 10* 13909Bl9 . BOLT (BEECHCRAFT). . . . .12 11 AN960-l0L . WASHER . . . . . . . . . .12 12* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . . 12 -------*------- 13* 101-120017-15 . DOOR ASSY (BEECHCRAFT) . .1 14 81-3511-105 . SPLICE PLATE. . . . . . . .1 15 81-3503-3 . DOOR ASSEMBLY . . . . . . .1 */ATTACHING PARTS/* 16 40S5-6 . STUD ASSEMBLY (REXNORD) . .2 17 40S5-8 . STUD ASSEMBLY (REXNORD) . .3 18 40Gl-10 . GROMMET (REXNORD) . . . . .5 19 R4T . RETAINING RING (REXNORD) . 5 -------*------- 20 81-3511-107 . ANGLE . . . . . . . . . . .1 21 81-3511-109 . ANGLE . . . . . . . . . . .1 22 81-3511-111 . ANGLE . . . . . . . . . . .1 23 81-3511-3 . DOOR SUPPORT ASSEMBLY . . .1 24 244-22C . RECEPTACLE (REXNORD). . . .5 -------*------- 25 88-3520-10 . INLET PLUG . . . . . . . . 1

APRIL 2004

1-4a



APRIL 2004

CENTER SECTION LEADING EDGE (L/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL #396 AND AFTER

3-1-4aPAGE 2



PAGE 33-1-4a




SERIAL #396 AND AFTER

APRIL 2004


3-1-4aPAGE 2



PAGE 33-1-4a







APRIL 2004

1 R81-1503-1 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (L/H) 1 81-3510-7 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-13 . LEADING EDGE . . . . . . .1 3 25S-7D-5041-13 . DE-ICE BOOT. . . . . . . .1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .39 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE . . . . . . . . .39 -------*------- 8* 101-120060-11 . SEAL . . . . . . . . . . .1 9 81-3514-3 . DUCT ASSY. . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694C48 . SCREW . . . . . . . . . .6 11* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .6 -------*------- 12 CLS2000-1 . PROTECTIVE BOOT . . . . . 1 13 88-3520-10 . INLET PLUG . . . . . . . .1 -------*-------

1-4b



APRIL 2004

CENTER SECTION LEADING EDGE (R/H)SUPER KING AIR 200 SERIES/B200 SERIES

KIT SERIAL #396 AND AFTER

3-1-4bPAGE 2



PAGE 33-1-4b




SERIAL #396 AND AFTER

APRIL 2004


3-1-4bPAGE 2



PAGE 33-1-4b







APRIL 2004

1 R81-1503-2 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (R/H) 1 81-3510-8 . LEADING EDGE ASSEMBLY. . .1 2 81-3503-14 . LEADING EDGE . . . . . . .1 3 25S-7D-5041-14 . DE-ICE BOOT . . . . . . . 1 (BF GOODRICH) */ATTACHING PARTS/* 4 MS24694S6 . SCREW. . . . . . . . . . .8 5 MS24694S50 . SCREW. . . . . . . . . . .45 6 MF1000-08 . NUTPLATE (KAYNAR). . . . .8 7* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .45 -------*------- 8* 101-120060-11 . SEAL (BEECHCRAFT). . . . .1 9 81-3514-4 . DUCT ASSY. . . . . . . . .2 10 MS24694C48 . SCREW. . . . . . . . . . .6 11* (P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .6 -------*------- 12* 101-120017-15 . DOOR ASSY (BEECHCRAFT) . .1 13 81-3511-105 . SPLICE PLATE . . . . . . .1 14 81-3503-3 . DOOR ASSEMBLY. . . . . . .1 */ATTACHING PARTS/* 15 40S5-6 . STUD ASSEMBLY (REXNORD). .2 16 40S5-8 . STUD ASSEMBLY (REXNORD). .3 17 4OGl-10 . GROMMET (REXNORD). . . . .5 18 R4T . RETAINING RING (REXNORD) .5 -------*------- 19 81-3511-107 . ANGLE. . . . . . . . . . .1 20 81-3511-109 . ANGLE. . . . . . . . . . .1 21 81-3511-111 . ANGLE. . . . . . . . . . .1 22 81-3511-3 . DOOR SUPPORT ASSEMBLY. . .1 23 244-22C . RECEPTACLE (REXNORD) . . .5 24 CLS2000-2 . PROTECTIVE PLUG. . . . . .1 25 88-3520-10 . INLET PLUG . . . . . . . .1 -------*-------

1-5



NACELLE SUPPORT BRACKETS (L/H)SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

3-1-5PAGE 2



PAGE 33-1-5



FIGURE 1NACELLE SUPPORT BRACKETS (L/H)

APRIL 1992


3-1-5PAGE 2



PAGE 33-1-5



1 R81-1503-1 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (L/H) 1 81-3512-101 . SUPPORT. . . . . . . . . .1 2 81-3512-103 . SUPPORT. . . . . . . . . .1 3 81-3512-107 . FILLER . . . . . . . . . .1





APRIL 1992

1-6



APRIL 2004

NACELLE SUPPORT BRACKETS (R/H)SUPER KING AIR B200/A200/200 SERIES

3-1-6PAGE 2



PAGE 33-1-6



FIGURE 1NACELLE SUPPORT BRACKETS (R/H)

APRIL 1992


3-1-6PAGE 2



PAGE 33-1-6



1 R81-1503-2 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (R/H) 1 81-3512-102 . SUPPORT. . . . . . . . . .1 2 81-3512-104 . SUPPORT. . . . . . . . . .1 3 81-3512-107 . FILLER . . . . . . . . . .1





APRIL 1992

1-7



APRIL 2004

WING-TO-BODY FAIRING (L/H)SUPER KING AIR B200/A200/200 SERIES

3-1-7PAGE 2



PAGE 33-1-7



FIGURE 1WING-TO-BODY FAIRING (L/H)


APRIL 1992

3-1-7PAGE 2



PAGE 33-1-7



1 R81-1503-1 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (L/H) 1 81-3513-3 . WING-TO-BODY FAIRING . . .1 */ATTACHING PARTS/* 2 AN525-lOR7 . SCREW. . . . . . . . . . .6 3 MS24694S50 . SCREW. . . . . . . . . . .20 4 NAS1169Cl0L . WASHER . . . . . . . . . .10 5 MF1000-3 . NUTPLATE (KAYNAR). . . . .10 6* (P/N UNKNOWN) . NUTPLATE . . . . . . . . .16 -------*------- 7 #425 . ALUMINUM FOIL (3M) . . . .A/R





APRIL 1992

1-8



APRIL 2004

WING-TO-BODY FAIRING (R/H)SUPER KING AIR B200/A200/200 SERIES

3-1-8PAGE 2



PAGE 33-1-8



FIGURE 1WING-TO-BODY FAIRING (R/H)

APRIL 1992


3-1-8PAGE 2



PAGE 33-1-8



1 R81-1503-2 RECONTOURED WING LEADING . N/P EDGE INSTALLATION (R/H) 1 81-3513-4 . WING-TO-BODY FAIRING . . .1 */ATTACHING PARTS/* 2 AN525-l0R7 . SCREW. . . . . . . . . . .6 3 MS24694S50 . SCREW. . . . . . . . . . .20 4 NAS1169Cl0L . WASHER . . . . . . . . . .10 5 MF1000-3 . NUTPLATE (KAYNAR). . . . .10 6* P/N UNKNOWN) . NUTPLATE (BEECHCRAFT). . .16 -------*------- 7 #425 . ALUMINUM FOIL (3M) . . . .A/R





APRIL 1992

0




EXHAUST STACK FAIRINGS

APRIL 2004

SYSTEM/AIRCRAFT/ PAGE EFFECTIVESECTION NO. DATE CONTENTS4-0 1 APR 04 . . . .LIST OF PAGES & 2 APR 04 TABLE OF CONTENTS 4-1 1 APR 04 . . . .EXHAUST STACK FAIRINGS 90/A90/B90/C90/E90/ F90/100/100)(EXCLUDING LA-202, LA-205 AND AFTER) 4-1-1 1 APR 04 . . . .STACK FAIRING4-1-1 2 APR 92 4-1-1 3 APR 92 4-1-1 4 MAY 95 4-1-1 5 MAY 95

4-2 1 APR 04 . . . .EXHAUST STACK FAIRINGS (C90A/C90B (LJ-1063 AND AFTER) AND F90 (LA-202, LA-205 AND AFTER)) WITH PITOT INLET

4-2-1 1 APR 04 . . . .STACK FAIRINGS4-2-1 2 APR 04 4-2-1 3 MAY 95 4-3 1 APR 04 . . . .EXHAUST STACK FAIRINGS (B200/A200/200 SERIES)

4-3-1 1 APR 04 . . . .STACK FAIRINGS 4-3-1 2 MAY 95 4-3-1 3 MAY 95 4-3-1 4 MAY 95 4-3-1 5 MAY 95 4-3-1 6 JAN 98 4-3-1 7 APR 04

4-0PAGE 2




EXHAUST STACK FAIRINGS

APRIL 2004

4-4 1 APR 04 . . . EXHAUST STACK FAIRINGS (B300/300 SERIES) WITH FLAT STACK (EXCLUDING FL-89 AND AFTER, FM-8 AND AFTER, AND FN-1 AND AFTER)

4-4-1 1 APR 04 . . . .STACK FAIRING4-4-1 2 APR 04 4-4-1 3 APR 04 4-5 3 APR 04 . . . .EXHAUST STACK FAIRINGS (B300 SERIES) WITH ROUND STACKS (FL-89 AND AFTER, FM-8 AND AFTER,AND FN-1 AND AFTER) 4-5-1 1 APR 04 . . . .STACK FAIRINGS4-5-1 2 APR 04 4-5-1 3 APR 04




EXHAUST STACK FAIRINGSKING AIR 90/A90/B90/C90/E90/100/A100

SUPER KING AIR F90(EXCLUDING LA-202, LA-205 AND AFTER)

APRIL 2004PAGE 1

4-1

1-1



EXHAUST STACK FAIRINGSKING AIR 90/A90/B90/C90/E90/100/A100

SUPER KING AIR F90(EXCLUDING LA-202, LA-205 AND AFTER)

APRIL 2004

4-1-1PAGE 2



PAGE 34-1-1



KING AIR 90/A90/B90/C90/E90/100/A100SUPER KING AIR F90

FIGURE 1STACK FAIRINGS

(STAINLESS STEEL)

APRIL 1992

4-1-1PAGE 2



PAGE 34-1-1







APRIL 1992

1 R81-1301-1 EXHAUST STACK FAIRING. . . N/P 1 INSTALLATION (L/H ENGINE) R81-1301-2 EXHAUST STACK FAIRING. . . N/P INSTALLATION (R/H ENGINE) 1 R81-3308-5 . FORWARD FAIRING ASSY-L/H .1 (STAINLESS STEEL) 2 R81-3308-3 . . FAIRING-L/H. . . . . . .1 (STAINLESS STEEL) 3 R81-3309-101 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 4 ROS5-5 . STUD ASSEMBLY (REXNORD). .3 5 ROS5-8 . STUD ASSEMBLY (REXNORD). .1 6 4002-N2 . GROMMET (REXNORD). . . . .4 7 R4G . RETAINING RING (REXNORD) .4 8 244-16 . RECEPTACLE (REXNORD) . . .4 -------*------- 9 R81-3308-6 . FORWARD FAIRING ASSY-R/H .1 (STAINLESS STEEL) 10 R81-3308-4 . . FAIRING-R/H. . . . . . .1 (STAINLESS STEEL) 11 R81-3309-103 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 12 R0S5-5 . STUD ASSEMBLY (REXNORD). .3 13 ROS5-8 . STUD ASSEMBLY (REXNORD). .1 14 4002-N2 . GROMMET (REXNORD). . . . .4 15 R4G . RETAINING RING (REXNORD) .4 16 244-16 . RECEPTACLE (REXNORD) . . .4 -------*-------

SEE PAGE 5 FOR USEABLE ON CODE AND NOTES.

4-1-1PAGE 4



PAGE 54-1-1




FIGURE 2STACK FAIRINGS(COMPOSITE)

MAY 1995

4-1-1PAGE 4



PAGE 54-1-1







MAY 1995

2 90-1301-1 EXHAUST STACK FAIRING. . . N/P 1 INSTALLATION 17 R81-3310-5 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 18 R81-3310-7 . . FAIRING. . . . . . . . .1 19 R81-3309-105 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 20 40S5-6 . STUD ASSEMBLY (REXNORD). .4 21 40S5-8 . STUD ASSEMBLY (REXNORD). .1 22 4002-0 . GROMMET (REXNORD). . . . .5 23 R4G . RETAINING RING . . . . . .5 24 244-16 . RECEPTACLE (REXNORD) . . .5 -------*------- 25 R81-3310-6 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 26 R81-3310-8 . . FAIRING. . . . . . . . .1 27 R81-3309-107 . . GASKET . . . . . . . . .1 28 40S5-6 . STUD ASSEMBLY (REXNORD). .4 29 40S5-8 . STUD ASSEMBLY (REXNORDo. .1 30 4002-0 . GROMMET (REXNORD). . . . .5 31 R4G . RETAINING RING (REXNORD) .5 32 244-16 . REEPTACLE (REXNORD). . . .5 -------*-------


1. EXCLUDING LA-202, LA-205 AND AFTER.



PAGE 14-2APRIL 2004

EXHAUST STACK FAIRINGSKING AIR C90A/C90B (LJ-1063 AND AFTER)

SUPER KING AIR F90-1 (LA-202,LA-205 AND AFTER)WITH PITOT INLET

2-1



APRIL 2004

EXHAUST STACK FAIRINGSKING AIR C90A/C90B (LJ-1063 AND AFTER)

SUPER KING AIR F90-1 (LA-202,LA-205 AND AFTER)WITH PITOT INLET

4-2-1PAGE 2



PAGE 34-2-1



APRIL 2004


KING AIR C90A/C90B AND SUPER KING AIR F90-1

4-2-1PAGE 2



PAGE 34-2-1



MAY 1995

1 90-1301-4 EXHAUST STACK FAIRING. . . N/P INSTALLATION 1 R81-3310-13 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 2 R81-3310-15 . . FAIRING. . . . . . . . .1 3 R81-3309-121 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 4 40S5-6 . STUD ASSEMBLY (REXNORD). .3 5 40S5-8 . STUD ASSEMBLY (REXNORD). .3 6 4002-0 . GROMMET (REXNORD). . . . .6 7 R4G . RETAINING RING (REXNORD) .6 8 244-16 . RECEPTACLE (REXNORD) . . .6 -------*------- 9 R81-3310-14 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 10 R81-3310-16 . . FAIRING. . . . . . . . .1 11 R81-3309-123 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 12 40S5-6 . STUD ASSEMBLY (REXNORD). .5 13 4002-0 . GROMMET (REXNORD). . . . .5 14 R4G . RETAINING RING (REXNORD) .5 15 244-16 . RECEPTACLE (REXNORD) . . .5 -------*-------

USEABLE ON CODE AND NOTES

1. LJ-1063 AND AFTER, LA-202, LA-205 AND AFTER, WITH PITOT INLET.




KING AIR C90A/C90B AND SUPER KING AIR F90-1



PAGE 14-3APRIL 2004

EXHAUST STACK FAIRINGSSUPER KING AIR B200/A200/200 SERIES

3-1



EXHAUST STACK FAIRINGSSUPER KING AIR B200/A200/200 SERIES

APRIL 2004

4-3-1PAGE 2



PAGE 34-3-1



FIGURE 1STACK FAIRINGS

(STAINLESS STEEL)

MAY 1995


4-3-1PAGE 2



PAGE 34-3-1



1 R81-1301-1 EXHAUST STACK FAIRING. . . N/P INSTALLATION (L/H ENGINE) R81-1301-2 EXHAUST STACK FAIRING. . . N/P INSTALLATION (R/H ENGINE) 1 R81-3308-5 . FORWARD FAIRING ASSY-L/H .1 (STAINLESS STEEL) 2 R81-3308-3 . . FAIRING-L/H. . . . . . .1 (STAINLESS STEEL) 3 481-3309-101 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 4 40S5-5 . STUD ASSEMBLY (REXNORD). .3 5 40S5-8 . STUD ASSEMBLY (REXNORD). .1 6 4002-N2 . GROMMET (REXNORD). . . . .4 7 R4G . RETAINING RING (REXNORD) .4 8 244-16 . RECEPTACLE (REXNORD) . . .4 -------*------- 9 R81-3308-6 . FORWARD FAIRING ASSY-R/H .1 (STAINLESS STEEL) 10 R81-3308-4 . . FAIRING-R/H. . . . . . .1 (STAINLESS STEEL) 11 R81-3309-103 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 12 40S5-5 . STUD ASSEMBLY (REXNORD). .3 13 40S5-8 . STUD ASSEMBLY (REXNORD). .1 14 4002-N2 . GROMMET (REXNORD). . . . .4 15 R4G . RETAINING RING (REXNORD) .4 16 244-16 . RECEPTACLE (REXNORD) . . .4 -------*-------

MAY 1995





4-3-1PAGE 4



PAGE 54-3-1




MAY 1995


4-3-1PAGE 4



PAGE 54-3-1



2 90-1301-2 EXHAUST STACK FAIRING. . . N/P INSTALLATION 17 R81-3310-1 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 18 R81-3310-3 . . FAIRING. . . . . . . . .1 19 R81-3309-105 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 20 40S5-6 . STUD ASSEMBLY (REXNORD). .5 21 40S5-8 . STUD ASSEMBLY (REXNORD). .1 22 4002-0 . GROMMET (REXNORD). . . . .6 23 R4G . RETAINING RING . . . . . .6 24 244-16 . RECEPTABLE (REXNORD) . . .6 -------*------- 25 R81-3310-2 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 26 R81-3310-4 . . FAIRING. . . . . . . . .1 27 R81-3309-107 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 28 40S5-6 . STUD ASSEMBLY (REXNORD). .5 29 40S5-8 . STUD ASSEMBLY (REXNORD). .1 30 4002-0 . GROMMET (REXNORD). . . . .6 31 R4G . RETAINING RING (REXNORD) .6 32 244-16 . RECEPTACLE (REXNORD) . . .6 -------*-------

MAY 1995





4-3-1PAGE 6



PAGE 74-3-1



JAN 1998



4-3-1PAGE 6



PAGE 74-3-1



APRIL 2004

1. 90-1301-6 INSTALLATION A/C EQUIPPED W/ D4-(FLAT STACK)






3 90-1301-6 EXHAUST STACK FAIRING. . . N/P 1 INSTALLATION 33 R81-3310-21 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 34 R81-3310-23 . FAIRING. . . . . . . . . 1 35 R81-3309-125 . GASKET . . . . . . . . . 1 */ATTACHING PARTS/* 36 40S5-6 . STUD ASSEMBLY (REXNORD). .4 37 40S5-8 . STUD ASSEMBLY (REXNORD). .1 38 4002-0 . GROMMET (REXNORD). . . . .5 39 R4G . RETAINING RING . . . . . .5 40 244-16 . RECEPTABLE (REXNORD) . . .5 -------*------- 41 R81-3310-22 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 42 R81-3310-24 . FAIRING. . . . . . . . .1 43 R81-3309-127 . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 44 40S5-6 . STUD ASSEMBLY (REXNORD). .4 45 40S5-8 . STUD ASSEMBLY (REXNORD). .1 46 4002-0 . GROMMET (REXNORD). . . . .5 47 R4G . RETAINING RING (REXNORD) .5 48 244-16 . RECEPTACLE (REXNORD) . . .5 -------*-------



PAGE 14-4APRIL 2004

EXHAUST STACK FAIRINGSSUPER KING AIR B300/300 SERIES

(FLAT STACK)EXCLUDING FL-89 AND AFTER, FM-8 AND AFTER, FN-1 AND AFTER

4-1



APRIL 2004

EXHAUST STACK FAIRINGSSUPER KING AIR B300/300 SERIES

(FLAT STACK)EXCLUDING FL-89 AND AFTER, FM-8 AND AFTER, FN-1 AND AFTER

4-4-1PAGE 2



PAGE 34-4-1




APRIL 2004

SUPER KING AIR B300/300 SERIES

4-4-1PAGE 2



PAGE 34-4-1



1 90-1301-3 EXHAUST STACK FAIRING. . . N/P 1 INSTALLATION 1 R81-3310-9 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 2 R81-3310-11 . . FAIRING. . . . . . . . .1 3 R81-3309-105 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 4 40S5-6 . STUD ASSEMBLY (REXNORD). .6 5 4002-0 . GROMMET (REXNORD). . . . .6 6 R4G . RETAINING RING (REXNORD) .6 7 244-16 . RECEPTACLE (REXNORD) . . .6 -------*------- 8 R81-3310-10 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 9 R81-3310-12 . . FAIRING. . . . . . . . .1 10 R81-3309-107 . . GASKET . . . . . . . . .1 */ATTACHING PARTS/* 11 40S5-6 . STUD ASSEMBLY (REXNORD). .6 12 4002-0 . GROMMET (REXNORD). . . . .6 13 R4G . RETAINING RING (REXNORD) .6 14 244-16 . RECEPTACLE (REXNORD) . . .6 -------*-------


1. EXCLUDES FL-89 AND AFTER, FM-8 AND AFTER, FN-1 AND AFTER AND FL-1 THRU FL-88, FM-1 THRU FM-7 WITH BEECH KIT 101-9059-1 INSTALLED.

APRIL 2004







PAGE 14-5APRIL 2004

EXHAUST STACK FAIRINGSSUPER KING AIR B300 SERIES

FL-89 AND AFTER, FM-8 AND AFTER, FN-1 AND AFTER ORFL-1 THRU FL-88, FM-1 THRU FM-7 WITH BEECH KIT 101-9059-1

(ROUND STACKS)

5-1



EXHAUST STACK FAIRINGSSUPER KING AIR B300 SERIES

FL-89 AND AFTER, FM-8 AND AFTER, FN-1 AND AFTER ORFL-1 THRU FL-88, FM-1 THRU FM-7 WITH BEECH KIT 101-9059-1

(ROUND STACKS)

APRIL 2004

4-5-1PAGE 2



PAGE 34-5-1




APRIL 2004


4-5-1PAGE 2



PAGE 34-5-1



1 90-1301-5 EXHAUST STACK FAIRING. . . N/P 1 INSTALLATION 1 R81-3310-17 . FORWARD FAIRING ASSY-L/H .1 (COMPOSITE) 2 R81-3310-19 . FAIRING. . . . . . . . . .1 3 R81-3309-105 . GASKET . . . . . . . . . .1 */ATTACHING PARTS/* 4 40S5-6 . STUD ASSEMBLY (REXNORD). .6 5 4002-0 . GROMMET (REXNORD). . . . .6 6 R4G . RETAINING RING (REXNORD) .6 7 244-16 . RECEPTACLE (REXNORD) . . .6 -------*------- 8 R81-3310-18 . FORWARD FAIRING ASSY-R/H .1 (COMPOSITE) 9 R81-3310-20 . FAIRING. . . . . . . . . .1 10 R81-3309-107 . GASKET . . . . . . . . . .1 */ATTACHING PARTS/* 11 40S5-6 . STUD ASSEMBLY (REXNORD). .6 12 4002-0 . GROMMET (REXNORD). . . . .6 13 R4G . RETAINING RING (REXNORD) .6 14 244-16 . RECEPTACLE (REXNORD) . . .6 -------*-------


1. FL-89 AND AFTER, FM-8 AND AFTER, FN-l AND AFTER, WITH ROUND STACKS OR FL-1 THRU FL-88, FM-1 THRU FM-7 WITH BEECH KIT 101-9059-1 INSTALLED.





APRIL 2004

0



APRIL 2004


DUAL AFT BODY STRAKES

SYSTEM/AIRCRAFT/ PAGE EFFECTIVESECTION 1 NO. DATE CONTENTS5-0 1 APR 04 . . . .LIST OF PAGES & TABLE OF CONTENTS

5-1 1 APR 92 . . . .DUAL AFT BODY STAKES (90/A90/B90/C90/C90A/ C90B/E90)

5-1-1 1 APR 92 . . . .AFT BODY STRAKES5-1-1 2 APR 925-1-1 3 APR 925-1-1 4 APR 925-1-1 5 APR 92

5-2 1 APR 92 . . . .DUAL AFT BODY STRAKES (100/A100/B100)

5-2-1 1 APR 92 . . . .AFT BODY STRAKES5-2-1 2 APR 925-2-1 3 APR 92

5-3 1 APR 04 . . . .DUAL AFT BODY STRAKES F90/F90-1/ B200/A200/200 SERIES B300/300 SERIES

5-3-1 1 APR 04 . . . .AFT BODY STRAKES5-3-1 2 APR 045-3-1 3 APR 04



PAGE 15-1APRIL 1992

DUAL AFT BODY STRAKESKING AIR 90/A90/B90/C90/C90A/C90B/E90

1-1



APRIL 1992

DUAL AFT BODY STRAKESKING AIR 90/A90/B90/C90/C90A/C90B/E90

5-1-1PAGE 2



PAGE 35-1-1



FIGURE 1AFT BODY STRAKES

APRIL 1992

KING AIR 90/A90/B90/C90/C90A/E90

5-1-1PAGE 2



PAGE 35-1-1



1 R87-1402-1 AFT BODY STRAKE . . . . . . N/P 1 INSTALLATION 1 81-3402-11 . AFT BODY STRAKE ASSY. . . .1 1 (SPARE FOR 81-3402-1) 2 81-3402-12 . AFT BODY STRAKE ASSY. . . .1 1 (SPARE FOR 81-3402-2) 3 81-3402-15 . AFT BODY STRAKE ASSY. . . .1 1 (SPARE FOR 81-3402-5) */ATTACHING PARTS/* 4 AN525-832R8 . SCREW . . . . . . . . . . .3 1 5 MS21059L08K . NUTPLATE (OPT:NAS686A08K) .3 1 -------*------- 6 81-3402-16 . AFT BODY STRAKE ASSY. . . .1 1 (SPARE FOR 81-3402-6) */ATTACHING PARTS/* 7 AN525-832R8 . SCREW . . . . . . . . . . .3 1 8 MS21059L08K . NUTPLATE (OPT:NAS686A08K) .3 1 -------*------- 9 81-3414-101 . PLUG. . . . . . . . . . . .1 1






APRIL 1992

5-1-1PAGE 4



PAGE 55-1-1




APRIL 1992


5-1-1PAGE 4



PAGE 55-1-1




1. LJ-135, LJ-286, LJ-306, LJ-307, LJ-411, LJ-546, LJ-586, LJ-654,LJ-681, LJ-697, LJ-748, LJ-766, LJ-811, LJ-814, LJ-818, LJ- 826, LJ-939, LJ-1002, LJ-1046, LJ-1102, LW-21, LW-85, LW-121, LW-127, LW-165, LW-182, LW-l91, LW-194, LW-223, LW-234, LW-253, LW-275, LW-309, LW-316 AND LW-329

2. LJ-l THRU LJ-134, LJ-136 THRU LJ-285, LJ-287 THRU LJ-305, LJ-308 THRU LJ-410, LJ-412 THRU LJ-545, LJ-547 THRU LJ-585, LJ-587THRU LJ-653, LJ-655 THRU LJ-680, LJ-682 THRU LJ-696, LJ-698 THRULJ-747, LJ-749 THRU LJ-765, LJ-767 THRU LJ-810, LJ-812, LJ-813, LJ-815 THRU LJ-817, LJ-819 THRU LJ-825, LJ-827 THRU LJ-938, LJ-940THRU LJ-1001, LJ-1003 THRU LJ-1045, LJ-1047 THRU LJ-1101, LJ-1103AND SUBS, LW-l THRU LW-20, LW-22 THRU LW-84, LW-86 THRU LW-120, LW-122 THRU LW-126, LW-128 THRU LW-164, LW-166 THRU LW-181, LW-183THRU LW-190, LW-192, LW-193, LW-195 THRU LW-222, LW-224 THRU LW-233, LW-235 THRU LW-252, LW-254 THRU LW-274, LW-276 THRU LW-308,LW-310 THRU LW-315, LW-317 THRU LW-328 AND LW-330 AND SUBS

2 90-1402-1 AFT BODY STRAKE . . . . . . N/P 2 INSTALLATION 10 81-3402-11 . AFT BODY STRAXE ASSY. . . .1 2 (SPARE FOR 90-3402-1) 11 81-3402-12 . AFT BODY STRAKE ASSY. . . .1 2 (SPARE FOR 90-3402-2) 12 81-3402-15 . AFT BODY STRAKE ASSY. . . .1 2 (SPARE FOR 90-3402-5) 13 81-3402-16 . AFT BODY STRAKE ASSY. . . .1 2 (SPARE FOR 90-3402-6) 14 81-3414-101 . PLUG. . . . . . . . . . . .1 2





APRIL 1992



PAGE 15-2APRIL 1992

DUAL AFT BODY STRAKESKING AIR 100/A100/B100

2-1



APRIL 1992

DUAL AFT BODY STRAKESKING AIR 100/A100/B100

5-2-1PAGE 2



PAGE 35-2-1



KING AIR 100/A100/B100

APRIL 1992


5-2-1PAGE 2



PAGE 35-2-1






APRIL 1992


1 87-1402-1 AFT BODY STRAKE . . . . . . N/P INSTALLATION 1 81-3402-11 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 87-3402-1) */ATTACHING PARTS/* 2 AN525-832R10 . SCREW . . . . . . . . . . .2 3 AN960-8 . WASHER. . . . . . . . . . .2 4 MS21042-08 . NUT (OPT:AN365-832) . . . .2 -------*------- 5 81-3402-12 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 87-3402-2) */ATTACHING PARTS/* 6 AN525-832R10 . SCREW . . . . . . . . . . .2 7 AN960-8 . WASHER. . . . . . . . . . .2 8 MS21042-08 . NUT (OPT:AN365-832) . . . .2 -------*------- 9 81-3402-15 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 87-3402-5) */ATTACHING PARTS/* 10 AN525-832R7 . SCREW . . . . . . . . . . .9 11 MS21059L08K . NUTPLATE (OPT:NAS686A08K) .9 12 AN525-1032R7 . SCREW . . . . . . . . . . .1 13 MS21059L3K . NUTPLATE (OPT:NAS686A3K). .1 -------*------- 14 81-3402-16 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 87-3402-6) */ATTACHING PARTS/* 15 AN525-832R7 . SCREW . . . . . . . . . . .9 16 MS21059L08K . NUTPLATE (OPT:NAS686A08K) .9 17 AN525-1032R7 . SCREW . . . . . . . . . . .1 18 MS21059L3K . NUTPLATE (OPT:NAS686A3K). .1 -------*------- 19 81-3414-101 . PLUG. . . . . . . . . . . .1



PAGE 15-3APRIL 2004

DUAL AFT BODY STRAKESSUPER KING AIR F90/F90-1/

B200/A200/200 SERIESB300/300 SERIES

3-1



APRIL 2004

DUAL AFT BODY STRAKESSUPER KING AIR F90/F90-1/

B200/A200/200 SERIESB300/300 SERIES

5-3-1PAGE 2



PAGE 35-3-1




APRIL 2004

SUPER KING AIR F90/F90-1/B200/A200/200 SERIES/ B300/300 SERIES

5-3-1PAGE 2



PAGE 35-3-1



1. SUPER KING AIR MODEL F90 (LA-2 AND AFTER) AND MODELS 200/B200 (BB-2 AND AFTER) AND 200T/B200T (BT-l AND AFTER) AND 300 (FA-l AND AFTER) AND 300LW (FF-l AND AFTER) WITHOUT AVCON INDUSTRIES STC SA2191CE (CARGO DOOR) INSTALLED AND B300 (FL-l AND AFTER).

2. SUPER KING AIR MODELS 200/B200 (BB-2 AND AFTER), 200T/B200T (BT-l AND AFTER) AND 300 (FA-l AND AFTER) AND 300LW (FF-l AND AF-TER) WITH AVCON INDUSTRIES STC SA2191CE (CARGO DOOR) INSTALLED. ALSO SUPER KING AIR MODELS 200C/B200C (BL-l AND AFTER) AND 200CT/ B200CT (BN-l AND AFTER) AND B300C (FM-l AND AFTER).



SUPER KING AIR F90/F90-1/B200/A200/200 SERIES/ B300/300 SERIES


APRIL 2004

1 R81-1402-1 AFT BODY STRAKE . . . . . . N/P INSTALLATION 1 81-3402-11 . AFT BODY STRAXE ASSY. . . .1 1 (SPARE FOR 81-3402-1) - lA 81-3402-17 . AFT BODY STRAKE ASSY. . . .1 2 (SPARE FOR 81-3402-7) 2 81-3402-12 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 81-3402-2) 3 81-3402-15 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 81-3402-5) */ATTACHING PARTS/* 4 AN525-832R7 . SCREW . . . . . . . . . . .2 5 F2000-08 . NUTPLATE (KAYNAR) . . . . .2 -------*------- 6 81-3402-16 . AFT BODY STRAKE ASSY. . . .1 (SPARE FOR 81-3402-6) */ATTACHING PARTS/* 7 AN525-832R7 . SCREW . . . . . . . . . . .2 8 F2000-8 . NUTPLATE (KAYNAR) . . . . .2 -------*------- 9 81-3414-101 . PLUG. . . . . . . . . . . .1

0



6-0 1 APR 04 . . . .LIST OF PAGES & TABLE 2 APR 04 OF CONTENTS 3 APR 04 4 APR 04

6-1 1 APR 92 . . . .FULLY-ENCLOSED MAIN LANDING GEAR DOORS (90/A90/B90/C90/ C90A/C90B/E90)


HIGH FLOAT GEAR DOORS


APRIL 2004

6-0PAGE 2



PAGE 36-0






APRIL 2004

6-2 1 APR 04 . . . .FULLY-ENCLOSED MAIN ANDING GEAR DOORS (F90/F90-1) 6-2-1 1 APR 92 . . . .GEAR DOORS (L/H)6-2-1 2 APR 046-2-1 3 APR 926-2-1 4 MAY 956-2-1 5 MAY 95

6-2-2 1 APR 92 . . . .ACTUATOR ASSEMBLY (L/H)6-2-2 2 APR 046-2-2 3 APR 92

6-2-3 1 APR 92 . . . .LINKAGE ASSEMBLY (L/H)6-2-3 2 APR 046-2-3 3 APR 926-2-3 4 APR 926-2-3 5 APR 92 6-2-3 6 APR 926-2-3 7 APR 92

6-2-4 1 APR 92 . . . .GEAR DOORS (R/H)6-2-4 2 APR 046-2-4 3 APR 926-2-4 4 APR 926-2-4 5 MAY 95

6-2-5 1 APR 92 . . . .ACTUATOR ASSEMBLY (R/H)6-2-5 2 APR 04 6-2-5 3 APR 04

6-2-6 1 APR 92 . . . .LINKAGE ASSEMBLY (R/H) 6-2-6 2 APR 046-2-6 3 APR 926-2-6 4 APR 046-2-6 5 APR 92 6-2-6 6 APR 046-2-6 7 APR 92

6-0PAGE 2



PAGE 36-0






APRIL 2004

6-3 1 APR 04 . . . .HIGH FLOAT GEAR DOORS (B200/A200/200 SERIES)

6-3-1 1 APR 04 . . . .GEAR DOORS (L/H)6-3-1 2 APR 926-3-1 3 MAY 956-3-1 4 MAY 956-3-1 5 MAY 95

6-3-2 1 APR 04 . . . .ACTUATOR ASSEMBLY (L/H)6-3-2 2 APR 926-3-2 3 APR 926-3-2 4 APR 926-3-2 5 APR 926-3-2 6 APR 92

6-3-3 1 APR 04 . . . .LINKAGE ASSEMBLY (L/H)6-3-3 2 APR 92 KIT SERIAL # 1 THRU 2846-3-3 3 APR 926-3-3 4 APR 926-3-3 5 APR 926-3-3 6 APR 926-3-3 7 APR 92

6-3-3a 1 APR 04 . . . .LINKAGE ASSEMBLY (L/H)6-3-3a 2 APR 04 KIT SERIAL #285 AND6-3-3a 3 APR 04 AFTER6-3-3a 4 APR 046-3-3a 5 APR 046-3-3a 6 APR 046-3-3a 7 APR 04

6-0PAGE 4



PAGE 56-0






APRIL 2004

6-3-4 1 APR 04 . . . .GEAR DOORS (R/H)6-3-4 2 APR 926-3-4 3 APR 926-3-4 4 MAY 956-3-4 5 MAY 95

6-3-5 1 APR 04 . . . .ACTUATOR ASSEMBLY (R/H)6-3-5 2 APR 926-3-5 3 APR 926-3-5 4 APR 926-3-5 5 APR 926-3-5 6 APR 92

6-3-6 1 APR 04 . . . .LINKAGE ASSEMBLY (R/H)6-3-6 2 APR 92 KIT SERIAL # 1 THRU 2846-3-6 3 APR 926-3-6 4 APR 926-3-6 5 APR 926-3-6 6 MAY 956-3-6 7 APR 92

6-3-6a 1 APR 04 . . . .LINKAGE ASSEMBLY (R/H)6-3-6a 2 APR 04 KIT SERIAL #285 6-3-6a 3 APR 04 AND AFTER6-3-6a 4 APR 046-3-6a 5 APR 046-3-6a 6 APR 046-3-6a 7 APR 04

6-0PAGE 4



PAGE 56-0






APRIL 2004

6-4 1 APR 04 . . . .HIGH FLOAT GEAR DOORS (100/A100/B100) 6-4-1 1 APR 92 . . . .GEAR DOORS (L/H)6-4-1 2 APR 926-4-1 3 APR 926-4-1 4 MAY 956-4-1 5 MAY 95

6-4-2 1 APR 92 . . . .ACTUATOR ASSEMBLY (L/H)6-4-2 2 APR 926-4-2 3 APR 04

6-4-3 1 APR 92 . . . .LINKAGE ASSEMBLY (L/H)6-4-3 2 APR 92 6-4-3 3 APR 926-4-3 4 APR 926-4-3 5 APR 926-4-3 6 APR 926-4-3 7 APR 92

6-4-4 1 APR 92 . . . .GEAR DOORS (R/H)6-4-4 2 APR 926-4-4 3 APR 926-4-4 4 MAY 956-4-4 5 MAY 95

6-4-5 1 APR 92 . . . .ACTUATOR ASSEMBLY (R/H)6-4-5 2 APR 926-4-5 3 APR 92

6-4-6 1 APR 92 . . . .LINKAGE ASSEMBLY (R/H)6-4-6 2 APR 926-4-6 3 APR 926-4-6 4 APR 92 6-4-6 5 APR 92 6-4-6 6 APR 926-4-6 7 APR 92

1



FULLY ENCLOSED MAIN LANDING GEAR DOORSKING AIR 90/A90/B90/C90/C90A/C90B/E90

THIS SECTION IS INTENTIONALLY LEFT BLANK(RESERVED)

APRIL 2004


RAISBECK ENGINEERNGDocument No. 85·119Illustrated Parts Catalog

APRIL 2004

HIGH FLOAT GEAR DOORSSUPER KING AIR F90/F90-1

6-2PAGE 1

2-1



GEAR DOORS (L/H)SUPER KING AIR F90/F90-1

APRIL 1992

6-2-1PAGE 2



PAGE 36-2-1



FIGURE 1GEAR DOORS (L/H)

APRIL 2004


6-2-1PAGE 2



PAGE 36-2-1



1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. . .1 2 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-105)(-101) 3 81-3713-111 . . HINGE (SPARE FOR . . .1 81-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. . .1 6 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-106)(-102) 7 81-3713-111 . . HINGE (SPARE FOR . . .1 81-3713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . . .1

APRIL 1992





6-2-1PAGE 4



PAGE 56-2-1




MAY 1995


6-2-1PAGE 4



PAGE 56-2-1




2 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 9 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-102 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 21 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2 25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21042L3 . NUT. . . . . . . . . . .6 -------*-------

MAY 1995




2-2



ACTUATOR ASSEMBLY (L/H)SUPER KING AIR F90/F90-1

APRIL 1992

6-2-2PAGE 2



PAGE 36-2-2



FIGURE 1ACTUATOR ASSEMBLY(L/H)

APRIL 2004


6-2-2PAGE 2



PAGE 36-2-2



1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 AN6-2OA . . BOLT . . . . . . . . .2 3 81-3711-103 . . WASHER . . . . . . . .4 4 NAS75-6-025 . . BUSHING. . . . . . . .2 5 81-3711-101 . . ROLLER . . . . . . . .2 6 NAS43HT6-12 . . SPACER . . . . . . . .2 7 AN960-616L . . WASHER . . . . . . . .2 8 MS21042L6 . . NUT. . . . . . . . . .2 9 R81-3718-3 . . ACTUATOR . . . . . . .1 */ATTACHING PARTS/* 10 81-3716-1 . BOLT . . . . . . . . . .1 11* 100951X032XE . WASHER (BEECHCRAFT). . .2 12 81-3715-101 . BUSHING. . . . . . . . .2 13* 130909N2 . NUT (BEECHCRAFT) . . . .1 14 MS24665-285 . COTTER PIN . . . . . . .1 15* 130909Bl9 . BOLT (BEECHCRAFT). . . .4 16 AN960-l0L . WASHER . . . . . . . . .A/R 17* 130909N29 . NUT (BEECHCRAFT) . . . .4 -------*-------

APRIL 1992





2-3



LINKAGE ASSEMBLY (L/H)SUPER KING AIR F90/F90-1

APRIL 1992

6-2-3PAGE 2



PAGE 36-2-3



FIGURE 1LINKAGE ASSEMBLY(L/H)

APRIL 2004


6-2-3PAGE 2



PAGE 36-2-3



1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 90-3707-1 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-131 . FILLER . . . . . . . . .1 3 81-3705-111 . CLIP . . . . . . . . . .1 4 AN3-7A . BOLT . . . . . . . . . .4 5 AN3-5A . BOLT . . . . . . . . . .1 6 AN5-10 . BOLT . . . . . . . . . .1 7 AN960-l0L . WASHER . . . . . . . . .5 8 AN960-516 . WASHER . . . . . . . . .1 9 AN960-516L . WASHER . . . . . . . . .2 10 MS21042L3 . NUT. . . . . . . . . . .5 11 AN310-5 . NUT. . . . . . . . . . .1 12 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 13 90-3707-3 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 14 81-3705-131 . FILLER . . . . . . . . .1 15 81-3705-111 . CLIP . . . . . . . . . .1 16 NAS1669-08L8 . JO-BOLT. . . . . . . . .2 17 NAS1669-3L5 . JO-BOLT. . . . . . . . .1 18 NAS1669-3L9 . JO-BOLT. . . . . . . . .2 19 AN5-10 . BOLT . . . . . . . . . .1 20 AN960-516 . WASHER . . . . . . . . .1 21 AN960-516L . WASHER . . . . . . . . .2 22 AN310-5 . NUT. . . . . . . . . . .1 23 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------





APRIL 1992

6-2-3PAGE 4



PAGE 56-2-3



FIGURE 2LINKAGE ASSEMBLY (L/H)

APRIL 1992


6-2-3PAGE 4



PAGE 56-2-3



2 90-3707-1 LINKAGE ASSY . . . . . . N/P 24 81-3710-101 . BOLT SPACER. . . . . . .2 25 81-3706-110 . SPRING . . . . . . . . .2 26 81-3706-112 . SPRING . . . . . . . . .2 27 81-3705-1 . SUPPORT. . . . . . . . .1 28 81-3705-109 . PLATE. . . . . . . . . .1 29 81-3704-2 . LINK ASSY. . . . . . . .1 30 NAS76A4-008N . . BUSHING. . . . . . . .1 31 81-3703-1 . LINK ASSY. . . . . . . .2 32 81-3702-2 . CAM ASSY . . . . . . . .1 33 NAS76A4-008N . . BUSHING. . . . . . . .1 34 AN3-5A . BOLT . . . . . . . . . .2 35 AN4-11 . BOLT . . . . . . . . . .2 36 AN4-52 . BOLT . . . . . . . . . .2 37 AN5-10 . BOLT . . . . . . . . . .1 38 AN960-l0L . WASHER . . . . . . . . .4 39 AN960-416 . WASHER . . . . . . . . .4 40 AN960-416L . WASHER . . . . . . . . .2 41 AN960-516 . WASHER . . . . . . . . .1 42 AN310-4 . NUT. . . . . . . . . . .4 43 AN310-5 . NUT. . . . . . . . . . .1 44 MS21042L3 . NUT. . . . . . . . . . .2 45 MS24665-132 . COTTER PIN . . . . . . .5





APRIL 1992

6-2-3PAGE 6



PAGE 76-2-3




APRIL 1992


6-2-3PAGE 6



PAGE 76-2-3








APRIL 1992

2-4



APRIL 1992

GEAR DOORS (RH)SUPER KING AIR F90/F90-1

6-2-4PAGE 2



PAGE 36-2-4



FIGURE 1GEAR DOORS

APRIL 2004


6-2-4PAGE 2



PAGE 36-2-4







APRIL 1992

1 90-1005 MAIN GEAR DOOR . . . . .N/P INSTALLATION (R/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. .1 2 81-3713-109 . HINGE (SPARE FOR . . .1 81-3713-105)(-101) 3 81-3713-111 . HINGE (SPARE FOR . . .1 81-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. .1 6 81-3713-109 . HINGE (SPARE FOR . . .1 81-3713-106)(-102) 7 81-3713-111 . HINGE (SPARE FOR . . .1 81-8713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . .1

6-2-4PAGE 4



PAGE 56-2-4



FIGURE 2GEAR DOORS (R/H)

25A

MAY 1995


6-2-4PAGE 4



PAGE 56-2-4







MAY 1995

1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 9 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 ------*------- 21 81-3705-102 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 ------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2 25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21042L3 . NUT. . . . . . . . . . .6

2-5



ACTUATOR ASSEMBLY (R/H)SUPER KING AIR F90/F90-1

APRIL 1992

6-2-5PAGE 2



PAGE 36-2-5



FIGURE 1ACTUATOR ASSEMBLY(R/H)

APRIL 2004


6-2-5PAGE 2



PAGE 36-2-5



1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 AN6-20A . . BOLT . . . . . . . . .2 3 81-3711-103 . . WASHER . . . . . . . .4 4 NAS75-6-025 . . BUSHING. . . . . . . .2 5 81-3711-101 . . ROLLER . . . . . . . .2 6 NAS43HT6-12 . . SPACER . . . . . . . .2 7 AN960-616L . . WASHER . . . . . . . .2 8 MS21042L6 . . NUT. . . . . . . . . .2 9 R81-3718-3 . . ACTUATOR . . . . . . .1 */ATTACHING PARTS/* 10 81-3716-1 . BOLT . . . . . . . . . .1 11* 100951X032XE . WASHER (BEECHCRAFT). . .2 12 81-3715-101 . BUSHING. . . . . . . . .2 13* 130909N2 . NUT (BEECHCRAFT) . . . .1 14 MS24665-285 . COTTER PIN . . . . . . .1 15* 130909Bl9 . BOLT (BEECHCRAFT). . . .4 16 AN960-l0L . WASHER . . . . . . . . .A/R 17* 130909N29 . NUT (BEECHCRAFT) . . . .4 -------*-------





APRIL 2004

2-6



APRIL 1992

LINKAGE ASSEMBLY (R/H)SUPER KING AIR F90/F90-1

6-2-6PAGE 2



PAGE 36-2-6



FIGURE 1LINKAGE ASSEMBLY(R/H)

APRIL 2004


6-2-6PAGE 2



PAGE 36-2-6



1 90-1005 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 90-3707-2 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-131 . FILLER . . . . . . . . .1 3 81-3705-111 . CLIP . . . . . . . . . .1 4 AN3-7A . BOLT . . . . . . . . . .4 5 AN3-5A . BOLT . . . . . . . . . .1 6 AN5-10 . BOLT . . . . . . . . . .1 7 AN960-l0L . WASHER . . . . . . . . .5 8 AN960-516 . WASHER . . . . . . . . .1 9 AN960-516L . WASHER . . . . . . . . .2 10 MS21042L3 . NUT. . . . . . . . . . .5 11 AN310-5 . NUT. . . . . . . . . . .1 12 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 13 90-3707-4 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 14 81-3705-131 . FILLER . . . . . . . . .1 15 81-3705-111 . CLIP . . . . . . . . . .1 16 NAS1669-08L8 . JO-BOLT. . . . . . . . .2 17 NAS1669-3L5 . JO-BOLT. . . . . . . . .1 18 NAS1669-3L9 . JO-BOLT. . . . . . . . .2 19 AN5-10 . BOLT . . . . . . . . . .1 20 AN960-516 . WASHER . . . . . . . . .1 21 AN960-516L . WASHER . . . . . . . . .2 22 AN310-5 . NUT. . . . . . . . . . .1 23 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------





APRIL 1992

6-2-6PAGE 4



PAGE 56-2-6



FIGURE 2LINKAGE ASSEMBLY (R/H)

APRIL 2004


6-2-6PAGE 4



PAGE 56-2-6








APRIL 1992

6-2-6PAGE 6



PAGE 76-2-6




APRIL 2004


6-2-6PAGE 6



PAGE 76-2-6








APRIL 1992



PAGE 16-3

HIGH FLOAT GEAR DOORS (L/H)SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

3-1



GEAR DOORS (L/H)SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

6-3-1PAGE 2



PAGE 36-3-1



APRIL 1992



6-3-1PAGE 2



PAGE 36-3-1



1 R81-1701-1 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. . .1 2 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-105)(-101) 3 81-3713-111 . . HINGE (SPARE FOR . . .1 81-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. . .1 6 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-106)(-102) 7 81-3713-111 . . HINGE (SPARE FOR . . .1 81-3713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . . .1





MAY 1995

6-3-1PAGE 4



PAGE 56-3-1




25A

25A

MAY 1995


6-3-1PAGE 4



PAGE 56-3-1



2 R81-1701-1 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 9 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-102 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 21 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2 25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21042L3 . NUT. . . . . . . . . . .6 -------*-------





MAY 1995

3-2



ACTUATOR ASSEMBLY (L/H)SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

6-3-2PAGE 2



PAGE 36-3-2



FIGURE 1ACTUATOR ASSEMBLY (L/H)

APRIL 1992


6-3-2PAGE 2



PAGE 36-3-2



1 R81-1701-1 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (L/H) 1 R81-3717-1 . ACTUATOR ASSY. . . . . .1 1 2 AN6-17A . . BOLT . . . . . . . . .1 1 3 81-3711-103 . . WASHER . . . . . . . .2 1 4 NAS75-6-025 . . BUSHING. . . . . . . .1 1 5 81-3711-101 . . ROLLER . . . . . . . .1 1 6 NAS43HT6-12 . . SPACER . . . . . . . .1 1 7 AN960-616L . . WASHER . . . . . . . .1 1 8 MS21042L6 . . NUT. . . . . . . . . .1 1 9 R81-3717-101 . . ARM. . . . . . . . . .1 1 10 R81-3717-2 . ACTUATOR ASSY. . . . . .1 1 11 AN6-17A . . BOLT . . . . . . . . .1 1 12 81-3711-103 . . WASHER . . . . . . . .2 1 13 NAS75-6-025 . . BUSHING. . . . . . . .1 1 14 81-3711-101 . . ROLLER . . . . . . . .1 1 15 NAS43HT6-12 . . BUSHING. . . . . . . .1 1 16 AN960-616L . . WASHER . . . . . . . .1 1 17 MS21042L6 . . NUT. . . . . . . . . .1 1 18 R81-3717-102 . . ARM. . . . . . . . . .1 1 */ATTACHING PARTS/* 19 81-3116-1 . BOLT . . . . . . . . . .1 3 -19A 81-3716-3 . BOLT . . . . . . . . . .1 4 -19B* 101-810146-1 . BOLT (BEECHCRAFT). . . .1 5 20* 100951X032XE . WASHER (BEECHCRAFT). . .2 3 -20A AN960-1016L . WASHER . . . . . . . . .2 4 -2OB AN960-1216L . WASHER . . . . . . . . .2 5 21 81-3715-101 . BUSHING. . . . . . . . .2 3 -21A 81-3715-103 . BUSHING. . . . . . . . .2 4 22* 130909N2 . NUT (BEECHCRAFT) . . . .1 1,6 -22A* 130909N20 . NUT (BEECHCRAFT) . . . .1 1,6 23 MS24665-285 . COTTER PIN . . . . . . .1 3,4 -23A MS24665-355 . COTTER PIN . . . . . . .1 5 24 NAS1105-38 . BOLT . . . . . . . . . .2 1 25 AN960-516L . WASHER . . . . . . . . .4 1 26* 105739X-YL2125 . BUSHING (BEECHCRAFT) . .2 1,7 -26A* 101-810009-7 . BUSHING (BEECHCRAFT) . .2 1,7 27 MS21042L5 . NUT. . . . . . . . . . .2 1 -------*------- SEE PAGE 6 FOR USABLE ON CODES AND NOTES.





APRIL 1992

6-3-2PAGE 4



PAGE 56-3-2




APRIL 1992


6-3-2PAGE 4



PAGE 56-3-2



2 R81-1701-1 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (L/H) 28 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 29 AN6-20A . . BOLT . . . . . . . . .2 2 30 81-3711-103 . . WASHER . . . . . . . .4 2 31 NAS75-6-025 . . BUSHING. . . . . . . .2 2 32 81-3711-101 . . ROLLER . . . . . . . .2 2 33 NAS43HT6-12 . . SPACER . . . . . . . .2 2 34 AN960-616L . . WASHER . . . . . . . .2 2 35 MS21042L6 . . NUT. . . . . . . . . .2 2 36 R81-3718-3 . . ACTUATOR . . . . . . .1 2 */ATTACHING PARTS/* 37 81-3716-1 . BOLT . . . . . . . . . .1 2 38* 100951X032XE . WASHER (BEECHCRAFT). . .2 2 39 81-3715-101 . BUSHING. . . . . . . . .2 2 40* 130909N2 . NUT (BEECHCRAFT) . . . .1 2 41 MS24665-285 . COTTER PIN . . . . . . .1 2 42* 130909Bl9 . BOLT (BEECHCRAFT). . . .4 2,8 -42A* 130909B20 . BOLT (BEECHCRAFT). . . .4 2,8 43 AN960-l0L . WASHER . . . . . . . . .A/R 2,9 -43A AN960-10 . WASHER . . . . . . . . .A/R 2,9 44* 130909N29 . NUT (BEECHCRAFT) . . . .4 2 -------*-------






APRIL 1992

6-3-2PAGE 6




1. BB-2 THRU BB-73 BB-106 AND AFTER BT-l AND AFTER BL-l AND AFTER BN-l AND AFTER

2. BB-74 THRU BB-105

3. BB-2 THRU BB-73 BB-106 THRU BB-613 BT-l THRU BT-13 BL-l THRU BL-6

4. BB-614 THRU BB-1157 BB-1159 THRU BB-1166 BB-1168 THRU BB-1192 BT-14 AND AFTER BL-7 THRU BL-72 BN-l AND AFTER

5. BB-1158 BB-1167 BB-1193 AND AFTER BL-73 AND AFTER

6. ITEM 22 OR 22A MAY BE INSTALLED, DEPENDING ON AIRPLANE CONFIGURATION.




APRIL 1992


3-3



APRIL 2004

LINKAGE ASSEMBLY (L/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL # 1 THRU 284

6-3-3PAGE 2



PAGE 36-3-3




APRIL 1992


6-3-3PAGE 2



PAGE 36-3-3







APRIL 1992

1 R81-1701-1 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3707-1 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-117 . FILLER . . . . . . . . .1 3 81-3705-121 . FILLER . . . . . . . . .1 4 81-3705-111 . CLIP . . . . . . . . . .1 5 NAS1669-3L5 . JO-BOLT. . . . . . . . .2 6 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 7 AN3-4A . BOLT . . . . . . . . . .1 8 AN3-5A . BOLT . . . . . . . . . .1 9 AN5-10 . BOLT . . . . . . . . . .1 10 AN960-10 . WASHER . . . . . . . . .2 11 AN960-516 . WASHER . . . . . . . . .1 12 AN960-516L . WASHER . . . . . . . . .2 13 AN310-5 . NUT. . . . . . . . . . .1 14 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 15 R81-3707-3 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 16 81-3705-117 . FILLER . . . . . . . . .1 17 81-3705-111 . CLIP . . . . . . . . . .1 18 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 19 NAS1669-3L20 . JO-BOLT. . . . . . . . .1 20 AN3-4A . BOLT . . . . . . . . . .1 21 AN3-5A . BOLT . . . . . . . . . .1 22 AN5-10 . BOLT . . . . . . . . . .1 23 AN960-10 . WASHER . . . . . . . . .2 24 AN960-516 . WASHER . . . . . . . . .1 25 AN960-516L . WASHER . . . . . . . . .2 26 AN310-5 . NUT. . . . . . . . . . .1 27 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------

6-3-3PAGE 4



PAGE 56-3-3




APRIL 1992


6-3-3PAGE 4



PAGE 56-3-3







APRIL 1992

2 R81-3707-1 LINKAGE ASSY . . . . . . N/P 28 81-3710-101 . BOLT SPACER. . . . . . .2 29 81-3706-110 . SPRING . . . . . . . . .2 30 81-3706-112 . SPRING . . . . . . . . .2 31 81-3705-105 . SUPPORT. . . . . . . . .1 32 81-3705-109 . PLATE. . . . . . . . . .1 33 81-3704-2 . LINK ASSY. . . . . . . .1 34 NAS76A4-008N . . BUSHING. . . . . . . .1 35 81-3703-1 . LINK ASSY. . . . . . . .2 36 81-3702-2 . CAM ASSY . . . . . . . .1 37 NAS76A4-008N . . BUSHING. . . . . . . .1 38 AN3-5A . BOLT . . . . . . . . . .2 39 AN4-11 . BOLT . . . . . . . . . .2 40 AN4-52 . BOLT . . . . . . . . . .2 41 AN5-10 . BOLT . . . . . . . . . .1 42 AN960-l0L . WASHER . . . . . . . . .4 43 AN960-416 . WASHER . . . . . . . . .4 44 AN960-416L . WASHER . . . . . . . . .2 45 AN960-516 . WASHER . . . . . . . . .1 46 AN310-4 . NUT. . . . . . . . . . .4 47 AN310-5 . NUT. . . . . . . . . . .1 48 MS21042L3 . NUT. . . . . . . . . . .2 49 MS24665-132 . COTTER PIN . . . . . . .5

6-3-3PAGE 6



PAGE 76-3-3




APRIL 1992


6-3-3PAGE 6



PAGE 76-3-3







APRIL 1992

3 R81-3707-3 LINKAGE ASSY . . . . . . N/P 50 81-3710-101 . BOLT SPACER. . . . . . .2 51 81-3706-109 . SPRING . . . . . . . . .2 52 81-3706-111 . SPRING . . . . . . . . .2 53 81-3705-107 . SUPPORT. . . . . . . . .1 54 81-3705-109 . PLATE. . . . . . . . . .1 55 81-3705-115 . FILLER . . . . . . . . .1 56 81-3704-1 . LINK ASSY. . . . . . . .1 57 NAS76A4-008N . BUSHING. . . . . . . . .1 58 81-3703-1 . LINK ASSY. . . . . . . .2 59 81-3702-1 . CAM ASSY . . . . . . . .1 60 NAS76A4-008N . BUSHING. . . . . . . . .1 61 AN3-5A . BOLT . . . . . . . . . .2 62 AN4-11 . BOLT . . . . . . . . . .2 63 AN4-52 . BOLT . . . . . . . . . .2 64 AN5-10 . BOLT . . . . . . . . . .1 65 AN960-l0L . WASHER . . . . . . . . .4 66 AN960-416 . WASHER . . . . . . . . .4 67 AN960-416L . WASHER . . . . . . . . .2 68 AN960-516 . WASHER . . . . . . . . .1 69 AN310-4 . NUT. . . . . . . . . . .4 70 AN310-5 . NUT. . . . . . . . . . .1 71 MS21042L3 . NUT. . . . . . . . . . .2 72 MS24665-132 . COTTER PIN . . . . . . .5

3-3a



APRIL 2004

LINKAGE ASSEMBLY (L/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL # 285 AND AFTER

6-3-3aPAGE 2



PAGE 36-3-3a





APRIL 2004

6-3-3aPAGE 2



PAGE 36-3-3a







1 R81-1701-1 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3707-1 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-117 . FILLER . . . . . . . . .1 3 81-3705-121 . FILLER . . . . . . . . .1 4 81-3705-111 . CLIP . . . . . . . . . .1 5 NAS1669-3L5 . JO-BOLT. . . . . . . . .2 6 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 7 AN3-4A . BOLT . . . . . . . . . .1 8 AN3-5A . BOLT . . . . . . . . . .1 9 AN5-10 . BOLT . . . . . . . . . .1 10 AN960-10 . WASHER . . . . . . . . .2 11 AN960-516 . WASHER . . . . . . . . .1 12 AN960-516L . WASHER . . . . . . . . .2 13 AN310-5 . NUT. . . . . . . . . . .1 14 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 15 R81-3707-5 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 16 81-3705-117 . FILLER . . . . . . . . .1 17 81-3705-111 . CLIP . . . . . . . . . .1 18 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 19 NAS1149D0332K . WASHER . . . . . . . . .1 19a MS21209F1-20 . INSERT . . . . . . . . .1 20 AN3-4A . BOLT . . . . . . . . . .1 21 AN3-5A . BOLT . . . . . . . . . .2 22 AN5-10 . BOLT . . . . . . . . . .1 23 AN960-10 . WASHER . . . . . . . . .2 24 AN960-516 . WASHER . . . . . . . . .1 25 AN960-516L . WASHER . . . . . . . . .2 26 AN310-5 . NUT. . . . . . . . . . .1 27 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------

APRIL 2004

6-3-3aPAGE 4



PAGE 56-3-3a





APRIL 2004

6-3-3aPAGE 4



PAGE 56-3-3a








APRIL 2004

6-3-3aPAGE 6



PAGE 76-3-3a





APRIL 2004

6-3-3aPAGE 6



PAGE 76-3-3a








APRIL 2004

3-4



GEAR DOORS (R/H)SUPER KING AIR B200/A200/200 SERIES

APRIL 2004

6-3-4PAGE 2



PAGE 36-3-4




APRIL 1992


6-3-4PAGE 2



PAGE 36-3-4



1 R81-1701-2 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. . .1 2 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-105)(-101) 3 81-3713-111 . . HINGE (SPARE FOR . . .1 81-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. . .1 6 81-3713-109 . . HINGE (SPARE FOR . . .1 81-3713-106)(-102) 7 81-3713-111 . . HINGE (SPARE FOR . . .1 81-8713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . . .1





MAY 1995

6-3-4PAGE 4



PAGE 56-3-4




25A

25A

MAY 1995


6-3-4PAGE 4



PAGE 56-3-4



1 R81-1701-2 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 9 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 21 81-3107-102 . ANGLE. . . . . . . . . .1 */ATACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2 25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21-42L3 . NUT. . . . . . . . . . .6





MAY 1995

3-5



ACTUATOR ASSEMBLY (R/H)SUPER KING AIR B200/A200/200

APRIL 2004

6-3-5PAGE 2



PAGE 36-3-5



FIGURE 1ACTUATOR ASSEMBLY (R/H)

APRIL 1992


6-3-5PAGE 2



PAGE 36-3-5



1 R81-1701-2 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (R/H) 1 R81-3717-1 . ACTUATOR ASSY. . . . . .1 1 2 AN6-17A . . BOLT . . . . . . . . .1 1 3 81-3711-103 . . WASHER . . . . . . . .2 1 4 NAS75-6-025 . . BUSHING. . . . . . . .1 1 5 81-3711-101 . . ROLLER . . . . . . . .1 1 6 NAS43HT6-12 . . SPACER . . . . . . . .1 1 7 AN960-616L . . WASHER . . . . . . . .1 1 8 MS21042L6 . . NUT. . . . . . . . . .1 1 9 R81-3717-101 . . ARM. . . . . . . . . .1 1 10 R81-3717-2 . ACTUATOR ASSY. . . . . .1 1 11 AN6-17A . . BOLT . . . . . . . . .1 1 12 81-3711-103 . . WASHER . . . . . . . .2 1 13 NAS75-6-025 . . BUSHING. . . . . . . .1 1 14 81-3711-101 . . ROLLER . . . . . . . .1 1 15 NAS43HT6-12 . . BUSHING. . . . . . . .1 1 16 AN960-616L . . WASHER . . . . . . . .1 1 17 MS21042L6 . . NUT. . . . . . . . . .1 1 18 R81-3717-102 . . ARM. . . . . . . . . .1 1 */ATTACHING PARTS/* 19 81-3716-1 . BOLT . . . . . . . . . .1 3 -19A 81-3716-3 . BOLT . . . . . . . . . .1 4 -19B* 101-810146-1 . BOLT (BEECHCRAFT). . . .1 5 20* 10095lX032XE . WASHER (BEECHCRAFT). . .2 3 -20A AN960-1016L . WASHER . . . . . . . . .2 4 -20B AN960-1216L . WASHER . . . . . . . . .2 5 21 81-3715-101 . BUSHING. . . . . . . . .2 3 -21A 81-3715-103 . BUSHING. . . . . . . . .2 4 22* 130909N2 . NUT (BEECHCRAFT) . . . .1 1,6 -22A* 130909N20 . NUT (BEECHCRAFT) . . . .1 1,6 23 MS24665-285 . COTTER PIN . . . . . . .1 3,4 -23A MS24665-355 . COTTER PIN . . . . . . .1 5 24 NAS1105-38 . BOLT . . . . . . . . . .2 1 25 AN960-516L . WASHER . . . . . . . . .4 1 26* 105739X-YL2125 . BUSHING (BEECHCRAFT) . .2 1,7 -26A* 101-810009-7 . BUSHING (BEECHCRAFT) . .2 1,7 27 MS21042L5 . NUT. . . . . . . . . . .2 1 -------*------- SEE PAGE 6 FOR USABLE ON CODES AND NOTES.





APRIL 1992

6-3-5PAGE 4



PAGE 56-3-5




APRIL 1992


6-3-5PAGE 4



PAGE 56-3-5



2 R81-1701-2 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (R/H) 28 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 29 AN6-20A . . BOLT . . . . . . . . .2 2 30 81-3711-103 . . WASHER . . . . . . . .4 2 31 NAS75-6-025 . . BUSHING. . . . . . . .2 2 32 81-3711-101 . . ROLLER . . . . . . . .2 2 33 NAS43HT6-12 . . SPACER . . . . . . . .2 2 34 AN960-616L . . WASHER . . . . . . . .2 2 35 MS21042L6 . . NUT. . . . . . . . . .2 2 36 R81-3718-3 . . ACTUATOR . . . . . . .1 2 */ATTACHING PARTS/* 37 81-3716-1 . BOLT . . . . . . . . . .1 2 38* 100951X032XE . WASHER (BEECHCRAFT). . .2 2 39 81-3715-101 . BUSHING. . . . . . . . .2 2 40* 130909N2 . NUT (BEECHCRAFT) . . . .1 2 41 MS24665-285 . COTTER PIN . . . . . . .1 2 42* 130909Bl9 . BOLT (BEECHCRAFT). . . .4 2,8 -42A* 130909B20 . BOLT (BEECHCRAFT). . . .4 2,8 43 AN960-l0L . WASHER . . . . . . . . .A/R 2,9 -43A AN960-10 . WASHER . . . . . . . . .A/R 2,9 44* 130909N29 . NUT (BEECHCRAFT) . . . .4 2






APRIL 1992

6-3-5PAGE 6




1. BB-2 THRU BB-73 BB-106 AND AFTER BT-l AND AFTER BL-l AND AFTER BN-l AND AFTER

2. BB-74 THRU BB-105

3. BB-2 THRU BB-73 BB-106 THRU BB-613 BT-l THRU BT-13 BL-l THRU BL-6

4. BB-614 THRU BB-1157 BB-1159 THRU BB-1166 BB-1168 THRU BB-1192 BT-14 AND AFTER BL-7 THRU BL-72 BN-l AND AFTER

5. BB-1158 BB-1167 BB-1193 AND AFTER BL-73 AND AFTER





APRIL 1992


3-6



APRIL 2004

LINKAGE ASSEMBLY (R/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL # 1 THRU 284

6-3-6PAGE 2



PAGE 36-3-6




APRIL 1992


6-3-6PAGE 2



PAGE 36-3-6






- ITEM NOT ILLUSTRATED.APRIL 1992

1 R81-1701-2 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3707-2 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-117 . FILLER . . . . . . . . .1 3 81-3705-122 . FILLER . . . . . . . . .1 4 81-3705-111 . CLIP . . . . . . . . . .1 5 NAS1669-3L5 . JO-BOLT. . . . . . . . .2 6 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 7 AN3-4A . BOLT . . . . . . . . . .1 8 AN3-5A . BOLT . . . . . . . . . .1 9 AN5-10 . BOLT . . . . . . . . . .1 10 AN960-10 . WASHER . . . . . . . . .2 11 AN960-516 . WASHER . . . . . . . . .1 12 AN960-516L . WASHER . . . . . . . . .2 13 AN310-5 . NUT. . . . . . . . . . .1 14 MS24665-132 . COTTER PIN . . . . . . .1 ------*------- 15 R81-3707-4 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FQR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 16 81-3705-117 . FILLER . . . . . . . . .1 17 81-3705-111 . CLIP . . . . . . . . . .1 18 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 19 NAS1669-3L20 . JO-BOLT. . . . . . . . .1 20 AN3-4A . BOLT . . . . . . . . . .1 21 AN3-5A . BOLT . . . . . . . . . .1 22 AN5-10 . BOLT . . . . . . . . . .1 23 AN960-10 . WASHER . . . . . . . . .2 24 AN960-516 . WASHER . . . . . . . . .1 25 AN960-516L . WASHER . . . . . . . . .2 26 AN310-5 . NUT. . . . . . . . . . .1 27 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------

6-3-6PAGE 4



PAGE 56-3-6




APRIL 1992


6-3-6PAGE 4



PAGE 56-3-6







APRIL 1992


6-3-6PAGE 6



PAGE 76-3-6




MAY 1995


6-3-6PAGE 6



PAGE 76-3-6







APRIL 1992

3 R81-3707-4 LINKAGE ASSY . . . . . . N/P 50 81-3710-101 . BOLT SPACER. . . . . . .2 51 81-3706-110 . SPRING . . . . . . . . .2 52 81-3706-112 . SPRING . . . . . . . . .2 53 81-3705-108 . SUPPORT. . . . . . . . .1 54 81-3705-109 . PLATE. . . . . . . . . .1 55 81-3705-116 . FILLER . . . . . . . . .1 56 81-3704-2 . LINK ASSY. . . . . . . .1 57 NAS76A4-008N . . BUSHING. . . . . . . .1 58 81-3703-1 . LINK ASSY. . . . . . . .2 59 81-3702-2 . CAM ASSY . . . . . . . .1 60 NAS76A4-008N . . BUSHING. . . . . . . .1 61 AN3-5A . BOLT . . . . . . . . . .2 62 AN4-11 . BOLT . . . . . . . . . .2 63 AN4-52 . BOLT . . . . . . . . . .2 64 AN5-10 . BOLT . . . . . . . . . .1 65 AN960-l0L . WASHER . . . . . . . . .4 66 AN960-416 . WASHER . . . . . . . . .4 67 AN960-416L . WASHER . . . . . . . . .2 68 AN960-516 . WASHER . . . . . . . . .1 69 AN310-4 . NUT. . . . . . . . . . .4 70 AN310-5 . NUT. . . . . . . . . . .1 71 MS21042L3 . NUT. . . . . . . . . . .2 72 MS24665-132 . COTTER PIN . . . . . . .5

3-6a



APRIL 2004

LINKAGE ASSEMBLY (R/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL # 285 AND AFTER

6-3-6aPAGE 2



PAGE 36-3-6a





APRIL 2004

6-3-6aPAGE 2



PAGE 36-3-6a







1 R81-1701-2 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3707-2 LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-117 . FILLER . . . . . . . . .1 3 81-3705-122 . FILLER . . . . . . . . .1 4 81-3705-111 . CLIP . . . . . . . . . .1 5 NAS1669-3L5 . JO-BOLT. . . . . . . . .2 6 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 7 AN3-4A . BOLT . . . . . . . . . .1 8 AN3-5A . BOLT . . . . . . . . . .1 9 AN5-10 . BOLT . . . . . . . . . .1 10 AN960-10 . WASHER . . . . . . . . .2 11 AN960-516 . WASHER . . . . . . . . .1 12 AN960-516L . WASHER . . . . . . . . .2 13 AN310-5 . NUT. . . . . . . . . . .1 14 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 15 R81-3707-6 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) *ATTACHING PARTS/* 16 81-3705-117 . FILLER . . . . . . . . .1 17 81-3705-111 . CLIP . . . . . . . . . .1 18 NAS1669-08Lll . JO-BOLT. . . . . . . . .2 19 NAS1149D0332K . WASHER . . . . . . . . .1 19a MS21209F1-20 . INSERT . . . . . . . . .1 20 AN3-4A . BOLT . . . . . . . . . .1 21 AN3-5A . BOLT . . . . . . . . . .1 22 AN5-10 . BOLT . . . . . . . . . .1 23 AN960-10 . WASHER . . . . . . . . .2 24 AN960-516 . WASHER . . . . . . . . .1 25 AN960-516L . WASHER . . . . . . . . .2 26 AN310-5 . NUT. . . . . . . . . . .1 27 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------

APRIL 2004

6-3-6aPAGE 4



PAGE 56-3-6a





APRIL 2004

6-3-6aPAGE 4



PAGE 56-3-6a







APRIL 2004


6-3-6aPAGE 6



PAGE 76-3-6a



APRIL 2004




AAEBECKENGNEERNGDocument No. 85·119Illustrated Parts Catalog

APRIL 2004

HIGH FLOAT GEAR DOORSKING AIR 100/A100/B100

6-4PAGE 1

4-1



GEAR DOORS (L/H)KING AIR 100/A100/B100

APRIL 1992

6-4-1PAGE 2



PAGE 36-4-1




APRIL 1992


6-4-1PAGE 2



PAGE 36-4-1



APRIL 1992

1 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. . .1 1 -lA R81-3712-3 . MAIN GEAR DOOR ASSY. . .1 2 2 81-3713-109 . . HINGE (SPARE FOR . . .1 87-3713-105)(-101) 3 81-3713-111 . . HINGE (SPARE FOR . . .1 87-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. . .1 1 -5A R81-3712-4 . MAIN GEAR DOOR ASSY. . .1 2 6 81-3713-109 . . HINGE (SPARE FOR . . .1 87-3713-106)(-102) 7 81-3713-111 . . HINGE (SPARE FOR . . .1 87-3713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . . .1






6-4-1PAGE 4



PAGE 56-4-1




MAY 1995

25A

25A


6-4-1PAGE 4



PAGE 56-4-1



MAY 1995

2 90-1007 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (L/H) 9 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-102 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 21 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2 25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21042L3 . NUT. . . . . . . . . . .6 -------*-------USABLE ON CODES AND NOTES

1. MODEL 100/A100 (B-l AND AFTER)

2. MODEL B100 (BE-2 AND AFTER)





4-2



ACTUATOR ASSEMBLY (L/H)KING AIR 100/A100/B100

APRIL 1992

6-4-2PAGE 2



PAGE 36-4-2





APRIL 2004

6-4-2PAGE 2



PAGE 36-4-2



1 90-1007 MAIN GEAR DOOR. . . . . .N/P INSTALLATION (L/H) 1 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 AN6-20A . . BOLT . . . . . . . . .2 3 81-3711-103 . . WASHER . . . . . . . .4 4 NAS75-6-025 . . BUSHING. . . . . . . .2 5 81-3711-101 . . ROLLER . . . . . . . .2 6 NAS43HT6-12 . . SPACER . . . . . . . .2 7 AN960-616L . . WASHER . . . . . . . .2 8 MS21042L6 . . NUT. . . . . . . . . .2 9 R81-3718-3 . . ACTUATOR . . . . . . .1 */ATTACHING PARTS/* 10 81-3716-1 . BOLT . . . . . . . . . .1 11* 100951X032XE . WASHER (BEECHCRAFT). . .2 12 81-3715-101 . BUSHING. . . . . . . . .2 13* AN320-8/M/ . NUT (BEECHCRAFT) . . . .1 14 MS24665-285 . COTTER PIN . . . . . . .1 15 AN3-7A . BOLT . . . . . . . . . .4 16 AN960-l0L . WASHER . . . . . . . . .A/R 17 MS20364-1032 . NUT. . . . . . . . . . .4 -------*-------





APRIL 2004

4-3



LINKAGE ASSEMBLY (L/H)KING AIR 100/A100/B100

APRIL 1992

6-4-3PAGE 2



PAGE 36-4-3





APRIL 1992

6-4-3PAGE 2



PAGE 36-4-3



1 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (L/H) 1 90-3707-1 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-131 . FILLER . . . . . . . . .1 3 81-3705-111 . CLIP . . . . . . . . . .1 4 81-3705-127 . SHIM . . . . . . . . . .1 5 AN3-7A . BOLT . . . . . . . . . .4 6 AN3-5A . BOLT . . . . . . . . . .1 7 AN5-10 . BOLT . . . . . . . . . .1 8 AN960-l0L . WASHER . . . . . . . . .5 9 AN960-516 . WASHER . . . . . . . . .1 10 AN960-516L . WASHER . . . . . . . . .2 11 MS21042L3 . NUT. . . . . . . . . . .5 12 AN310-5 . NUT. . . . . . . . . . .1 13 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 14 90-3707-3 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 15 81-3705-131 . FILLER . . . . . . . . .1 16 81-3705-111 . CLIP . . . . . . . . . .1 17 81-3705-127 . SHIM . . . . . . . . . .1 18 NAS1669-08L8 . JO-BOLT. . . . . . . . .2 19 NAS1669-3L5 . JO-BOLT. . . . . . . . .1 20 NAS1669-3L9 . JO-BOLT. . . . . . . . .2 21 AN5-10 . BOLT . . . . . . . . . .1 22 AN960-516 . WASHER . . . . . . . . .1 23 AN960-516L . WASHER . . . . . . . . .2 24 AN310-5 . NUT. . . . . . . . . . .1 25 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------





APRIL 1992

6-4-3PAGE 4



PAGE 56-4-3





APRIL 1992

6-4-3PAGE 4



PAGE 56-4-3








APRIL 1992

6-4-3PAGE 6



PAGE 76-4-3





APRIL 1992

6-4-3PAGE 6



PAGE 76-4-3








APRIL 1992

4-4



GEAR DOORS (R/H)KING AIR 100/A100/B100

APRIL 1992

6-4-4PAGE 2



PAGE 36-4-4




APRIL 1992


6-4-4PAGE 2



PAGE 36-4-4



APRIL 1992

1 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3712-1 . MAIN GEAR DOOR ASSY. . .1 1 -lA R81-3712-3 . MAIN GEAR DOOR ASSY. . .1 2 2 81-3713-109 . . HINGE (SPARE FOR . . .1 87-3713-105)(-101) 3 81-3713-111 . . HINGE (SPARE FOR . . .1 87-3713-107)(-103) 4 MS20253P2-4500 . HINGE PIN. . . . . . . .1 5 R81-3712-2 . MAIN GEAR DOOR ASSY. . .1 1 -5A R81-3712-4 . MAIN GEAR DOOR ASSY. . .1 2 6 81-3713-109 . . HINGE (SPARE FOR . . .1 87-3713-106)(-102) 7 81-3713-111 . . HINGE (SPARE FOR . . .1 87-8713-108)(-104) 8 MS20253P2-4500 . HINGE PIN. . . . . . . .1






6-4-4PAGE 4



PAGE 56-4-4




MAY 1995

25A

25A


6-4-4PAGE 4



PAGE 56-4-4



MAY 1995

2 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 9 81-3705-120 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 10 MS24694-S9 . SCREW. . . . . . . . . .5 11 AN960-8 . WASHER . . . . . . . . .5 12 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 13 81-3705-101 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 14 MS24694-S9 . SCREW. . . . . . . . . .5 15 AN960-8 . WASHER . . . . . . . . .5 16 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 17 81-3705-119 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 18 MS24694-S9 . SCREW. . . . . . . . . .5 19 AN960-8 . WASHER . . . . . . . . .5 20 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 21 81-3705-102 . ANGLE. . . . . . . . . .1 */ATTACHING PARTS/* 22 MS24694-S9 . SCREW. . . . . . . . . .5 23 AN960-8 . WASHER . . . . . . . . .5 24 MS21042L08 . NUT. . . . . . . . . . .5 -------*------- 25 81-3708-3 . PLATE ASSY . . . . . . .2

25A NAS76A5-005N . BUSHING. . . . . . . . .2 */ATTACHING PARTS/* 26 AN3-5A . BOLT . . . . . . . . . .6 27 AN960-10 . WASHER . . . . . . . . .6 28 MS21042L3 . NUT. . . . . . . . . . .6 -------*-------USABLE ON CODES AND NOTES

1. MODEL 100/A100 (B-l AND AFTER)






4-5



ACTUATOR ASSEMBLY (R/H)KING AIR 100/A100/B100

APRIL 1992

6-4-5PAGE 2



PAGE 36-4-5





APRIL 1992

6-4-5PAGE 2



PAGE 36-4-5



1 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 R81-3718-1 . ACTUATOR ASSY. . . . . .1 2 AN6-20A . . BOLT . . . . . . . . .2 3 81-3711-103 . . WASHER . . . . . . . .4 4 NAS75-6-025 . . BUSHING. . . . . . . .2 5 81-3711-101 . . ROLLER . . . . . . . .2 6 NAS43HT6-12 . . SPACER . . . . . . . .2 7 AN960-616L . . WASHER . . . . . . . .2 8 MS21042L6 . . NUT. . . . . . . . . .2 9 R81-3718-3 . . ACTUATOR . . . . . . .1 */ATTACHING PARTS/* 10 81-3716-1 . BOLT . . . . . . . . . .1 11* 10095lX032XE . WASHER (BEECHCRAFT). . .2 12 81-3715-101 . BUSHING. . . . . . . . .2 13* AN320-8/M/ . NUT (BEECHCRAFT) . . . .1 14 MS24665-285 . COTTER PIN . . . . . . .1 15 AN3-7A . BOLT . . . . . . . . . .4 16 AN960-l0L . WASHER . . . . . . . . .A/R 17 MS20364-1032 . NUT. . . . . . . . . . .4 -------*-------





APRIL 1992

4-6



LINKAGE ASSEMBLY (R/H)KING AIR 100/A100/B100

APRIL 1992

6-4-6PAGE 2



PAGE 36-4-6




APRIL 1992


6-4-6PAGE 2



PAGE 36-4-6



1 90-1007 MAIN GEAR DOOR . . . . . N/P INSTALLATION (R/H) 1 90-3707-2 . LINKAGE ASSY (OUTBD) . .1 (SEE FIGURE 2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 2 81-3705-131 . FILLER . . . . . . . . .1 3 81-3705-111 . CLIP . . . . . . . . . .1 4 81-3705-127 . SHIM . . . . . . . . . .1 5 AN3-7A . BOLT . . . . . . . . . .4 6 AN3-5A . BOLT . . . . . . . . . .1 7 AN5-10 . BOLT . . . . . . . . . .1 8 AN960-l0L . WASHER . . . . . . . . .5 9 AN960-516 . WASHER . . . . . . . . .1 10 AN960-516L . WASHER . . . . . . . . .2 11 MS21042L3 . NUT. . . . . . . . . . .5 12 AN310-5 . NUT. . . . . . . . . . .1 13 MS24665-132 . COTTER PIN . . . . . . .1 -------*------- 14 90-3707-4 . LINKAGE ASSY (INBD). . .1 (SEE FIGURE 3 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 15 81-3705-131 . FILLER . . . . . . . . .1 16 81-3705-111 . CLIP . . . . . . . . . .1 17 81-3705-127 . SHIM . . . . . . . . . .1 18 NAS1669-08L8 . JO-BOLT. . . . . . . . .2 19 NAS1669-3L5 . JO-BOLT. . . . . . . . .1 20 NAS1669-3L9 . JO-BOLT. . . . . . . . .2 21 AN5-10 . BOLT . . . . . . . . . .1 22 AN960-516 . WASHER . . . . . . . . .1 23 AN960-516L . WASHER . . . . . . . . .2 24 AN310-5 . NUT. . . . . . . . . . .1 25 MS24665-132 . COTTER PIN . . . . . . .1 -------*-------





APRIL 1992

6-4-6PAGE 4



PAGE 56-4-6



APRIL 1992



6-4-6PAGE 6



PAGE 76-4-6




APRIL 1992


6-4-6PAGE 6



PAGE 76-4-6








APRIL 1992

0



APRIL 2004


WING LOCKERS


APRIL 2004

7-0 1 APR 04 . . . LIST OF PAGES & TABLE 2 APR 04 OF CONTENTS 3 APR 04 4 APR 04 5 APR 04

7-1 1 APR 92 . . . WING LOCKERS (90/A90/ B90/C90/C90A/E90)

7-1-1 1 APR 92 . . . LOCKER INSTALLATION7-1-1 2 APR 92 (L/H)7-1-1 3 APR 927-1-1 4 APR 927-1-1 5 APR 927-1-1 6 APR 927-1-1 7 APR 92

7-1-2 1 APR 92 . . . LOCKER ASSEMBLY (L/H)7-1-2 2 APR 047-1-2 3 APR 047-1-2 4 APR 047-1-2 5 APR 047-1-2 6 APR 047-1-2 7 JAN 98

7-1-3 1 APR 92 . . . LOWER NACELLE FAIRING7-1-3 2 APR 92 (L/H)7-1-3 3 APR 92

7-1-4 1 APR 92 . . . LOCKER INSTALLATION 7-1-4 2 APR 92 (R/H)7-1-4 3 APR 927-1-4 4 APR 927-1-4 5 APR 92 7-1-4 6 APR 92 7-1-4 7 APR 92

7-0PAGE 2



APRIL 2004


WING LOCKERS


PAGE 37-0



APRIL 2004


WING LOCKERS


7-1-5 1 APR 92 . . . .LOCKER ASSEMBLY (R/H)7-1-5 2 APR 047-1-5 3 APR 04 7-1-5 4 APR 04 7-1-5 5 APR 047-1-5 6 APR 047-1-5 7 APR 04

7-1-6 1 APR 92 . . . .LOWER NACELLE FAIRING7-1-6 2 APR 92 (R/H)7-1-6 3 APR 92

7-2 1 APR 92 . . . .WING LOCKERS (F90/F90-1)

7-2-1 1 JAN 98 . . . .LOCKER INSTALLATION7-2-1 2 APR 92 (L/H)7-2-1 3 JAN 987-2-1 4 APR 927-2-1 5 JAN 987-2-1 6 APR 927-2-1 7 JAN 98

7-2-2 1 APR 92 . . . .LOCKER ASSEMBLY (L/H)7-2-2 2 APR 04 7-2-2 3 APR 047-2-2 4 APR 047-2-2 5 APR 047-2-2 6 MAY 957-2-2 7 APR 04

7-2-3 1 APR 92 . . . .LOWER NACELLE FAIRING7-2-3 2 APR 92 (L/H)7-2-3 3 APR 92

7-0PAGE 2



APRIL 2004


WING LOCKERS


PAGE 37-0



APRIL 2004


WING LOCKERS


7-2-4 1 APR 92 . . . .LOCKER INSTALLATION7-2-4 2 APR 92 (R/H)7-2-4 3 APR 927-2-4 4 APR 927-2-4 5 APR 927-2-4 6 APR 927-2-4 7 APR 92

7-2-5 1 APR 92 . . . .LOCKER ASSEMBLY 7-2-5 2 APR 04 (R/H)7-2-5 3 APR 04 7-2-5 4 APR 047-2-5 5 APR 047-2-5 6 MAY 957-2-5 7 APR 04

7-2-6 1 APR 92 . . . .LOWER NACELLE FAIRING7-2-6 2 APR 92 (R/H) 7-2-6 3 APR 92

7-3 1 APR 92 . . . .WING LOCKERS (100/A100/B100)

7-3-1 1 APR 92 . . . .LOCKER INSTALLATION7-3-1 2 APR 92 (L/H)7-3-1 3 APR 927-3-1 4 APR 927-3-1 5 APR 927-3-1 6 APR 927-3-1 7 APR 92

7-0PAGE 4



APRIL 2004


WING LOCKERS


PAGE 57-0



APRIL 2004


WING LOCKERS


7-3-2 1 APR 92 . . . .LOCKER ASSEMBLY (L/H)7-3-2 2 APR 04 7-3-2 3 APR 047-3-2 4 APR 047-3-2 5 APR 047-3-2 6 MAY 957-3-2 7 APR 04

7-3-3 1 APR 92 . . . .LOWER NACELLE FAIRING7-3-3 2 APR 92 (L/H)7-3-3 3 APR 92

7-3-4 1 APR 92 . . . .LOCKER INSTALLATION7-3-4 2 APR 92 (R/H)7-3-4 3 APR 927-3-4 4 APR 927-3-4 5 APR 927-3-4 6 APR 927-3-4 7 APR 92

7-3-5 1 APR 92 . . . .LOCKER ASSEMBLY (R/H)7-3-5 2 APR 04 7-3-5 3 APR 047-3-5 4 APR 047-3-5 5 APR 047-3-5 6 MAY 957-3-5 7 APR 04


7-0PAGE 4



APRIL 2004


WING LOCKERS


PAGE 57-0



APRIL 2004


WING LOCKERS

SYSTEM/AIRCRAFT/ PAGE EFFECTIVESECTION NO. DATE CONTENTS7-4 1 APR 04 . . . .WING LOCKERS (B200 /A200/200 SERIES

7-4-1 1 APR 04 . . . .LOCKER INSTALLATION7-4-1 2 APR 92 (L/H) 7-4-1 3 APR 92 KIT SERIAL #1 THRU 188,7-4-1 4 APR 92 373 THRU 3787-4-1 5 APR 927-4-1 6 APR 927-4-1 7 APR 92

7-4-1a 1 APR 04 . . . .LOCKER INSTALLATION7-4-1a 2 APR 04 (L/H) 7-4-1a 3 APR 04 KIT SERIAL #189 THRU 7-4-1a 4 APR 04 372, 379 AND AFTER7-4-1a 5 APR 047-4-1a 6 APR 047-4-1a 7 APR 04

7-4-2 1 APR 04 . . . .LOCKER ASSEMBLY7-4-2 2 APR 04 (L/H) 7-4-2 3 MAY 95 KIT SERIAL #1 THRU 188,7-4-2 4 APR 92 373 THRU 3787-4-2 5 JAN 987-4-2 6 MAY 957-4-2 7 MAY 95

7-4-2a 1 APR 04 . . . .LOCKER ASSEMBLY7-4-2a 2 APR 04 (L/H) 7-4-2a 3 APR 04 KIT SERIAL #189 THRU 7-4-2a 4 APR 04 372, 379 AND AFTER7-4-2a 5 APR 047-4-2a 6 APR 047-4-2a 7 APR 04

7-4-3 1 APR 04 . . . .LOWER NACELLE FAIRING7-4-3 2 APR 92 (L/H)7-4-3 3 MAR 04

7-0PAGE 6



APRIL 2004


WING LOCKERS


PAGE 77-0



APRIL 2004


WING LOCKERS


7-4-4 1 APR 04 . . . .LOCKER INSTALLATION7-4-4 2 APR 92 (R/H)7-4-4 3 APR 92 KIT SERIAL #1 THRU 7-4-4 4 APR 92 188, 373 THRU 3787-4-4 5 APR 927-4-4 6 APR 927-4-4 7 APR 92

7-4-4a 1 APR 04 . . . .LOCKER INSTALLATION7-4-4a 2 APR 04 (R/H)7-4-4a 3 APR 04 KIT SERIAL #189 THRU 7-4-4a 4 APR 04 372, 379 AND AFTER7-4-4a 5 APR 047-4-4a 6 APR 047-4-4a 7 APR 04

7-4-5 1 APR 04 . . . .LOCKER ASSEMBLY (R/H)7-4-5 2 APR 92 7-4-5 3 MAY 95 KIT SERIAL #1 THRU 7-4-5 4 APR 92 188, 373 THRU 3787-4-5 5 JAN 987-4-5 6 MAY 957-4-5 7 MAY 95

7-4-5a 1 APR 04 . . . .LOCKER ASSEMBLY (R/H)7-4-5a 2 APR 04 KIT SERIAL #189 THRU 7-4-5a 3 APR 04 372, 379 AND AFTER 7-4-5a 4 APR 04 7-4-5a 5 APR 047-4-5a 6 APR 047-4-5a 7 APR 04

7-4-6 1 APR 04 . . . .LOWER NACELLE FAIRING7-4-6 2 APR 92 (R/H)7-4-6 3 MAR 04

7-0PAGE 6



APRIL 2004


WING LOCKERS


PAGE 77-0



APRIL 2004


WING LOCKERS


7-5 1 APR 04 . . . .WING LOCKERS (B300/B300 SERIES)

7-5-1 1 APR 04. . . . LOCKER INSTALLATION7-5-1 2 APR 92 (L/H)7-5-1 3 APR 92 KIT SERIAL #1 THRU 427-5-1 4 APR 92 (300/300LW)7-5-1 5 APR 92 KIT SERIAL #1 THRU 997-5-1 6 APR 92 (B300/B300C)7-5-1 7 APR 92

7-5-1a 1 APR 04 . . . .LOCKER ASSEMBLY (L/H)7-5-1a 2 APR 04 KIT SERIAL #43 AND 7-5-1a 3 APR 04 AFTER (300/300LW)7-5-1a 4 APR 04 KIT SERIAL #100 AND7-5-1a 5 APR 04 AFTER (B300/B300C)7-5-1a 6 APR 047-5-1a 7 APR 04

7-5-2 1 APR 04 . . . .LOCKER ASSEMBLY (L/H)7-5-2 2 APR 92 KIT SERIAL #1 THRU 427-5-2 3 MAY 95 (300/300LW)7-5-2 4 APR 92 KIT SERIAL #1 THRU 997-5-2 5 JAN 98 (B300/B300C)7-5-2 6 MAY 957-5-2 7 MAY 95

7-5-2a 1 APR 04 . . . .LOCKER ASSEMBLY (L/H)7-5-2a 2 APR 04 KIT SERIAL #43 AND 7-5-2a 3 APR 04 AFTER (300/300LW)7-5-2a 4 APR 04 KIT SERIAL #100 AND7-5-2a 5 APR 04 AFTER (B300/B300C) 7-5-2a 6 APR 047-5-2a 7 APR 04

7-0PAGE 8



APRIL 2004


WING LOCKERS

SYSTEM/AIRCRAFT/ PAGE EFFECTIVESECTION NO. DATE CONTENTS7-5-3 1 APR 04 . . . .LOWER NACELLE FAIRING7-5-3 2 APR 92 (L/H)7-5-3 3 APR 04

7-5-4 1 APR 04 . . . .LOCKER INSTALLATION7-5-4 2 APR 92 (R/H)7-5-4 3 APR 92 KIT SERIAL #1 THRU 427-5-4 4 APR 92 (300/300LW)7-5-4 5 APR 92 KIT SERIAL #1 THRU 997-5-4 6 APR 92 (B300/B300C)7-5-4 7 APR 92

7-5-4a 1 APR 04 . . . .LOCKER INSTALLATION7-5-4a 2 APR 04 (R/H)7-5-4a 3 APR 04 KIT SERIAL #43 AND 7-5-4a 4 APR 04 AFTER (300/300LW)7-5-4a 5 APR 04 KIT SERIAL #100 AND7-5-4a 6 APR 04 AFTER (B300/B300C)7-5-4a 7 APR 04

7-5-5 1 APR 04 . . . .LOCKER ASSEMBLY (R/H)7-5-5 2 APR 92 (R/H)7-5-5 3 MAY 95 KIT SERIAL #1 THRU 427-5-5 4 APR 92 (300/300LW)7-5-5 5 JAN 98 KIT SERIAL #1 THRU 997-5-5 6 MAY 95 (B300/B300C)7-5-5 7 MAY 95

7-5-5a 1 APR 04 . . . .LOCKER ASSEMBLY (R/H)7-5-5a 2 APR 04 KIT SERIAL #43 AND 7-5-5a 3 APR 04 AFTER (300/300LW)7-5-5a 4 APR 04 KIT SERIAL #100 AND7-5-5a 5 APR 04 AFTER (B300/B300C)7-5-5a 6 APR 04 7-5-5a 7 APR 04




PAGE 17-1

LOCKER INSTALLATION (L/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

APRIL 1992

1-1



LOCKER INSTALLATION (L/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

APRIL 1992

7-1-1PAGE 2



PAGE 37-1-1



FIGURE 1LOCKER INSTALLATION (L/H)

APRIL 1992


7-1-1PAGE 2



PAGE 37-1-1



1 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 1 85-3510-195 . TOP PLATE. . . . . . . . .1 2 85-3510-187 . RADIUS FILLER. . . . . . .1 3 85-3510-201 . RADIUS FILLER. . . . . . .1 4 85-3510-200 . BACKING PLATE. . . . . . .1 5 85-3510-203 . DOUBLER. . . . . . . . . .1 6 MS21059L4 . NUT PLATE. . . . . . . . .1 */ATTACHING PARTS/* 7 NAS517-2-5 . SCREW. . . . . . . . . . .2 8 NAS517-2-6 . SCREW. . . . . . . . . . .2 9 AN960-8 . WASHER . . . . . . . . . .4 10 NAS679A08 . NUT. . . . . . . . . . . .4 -------*------- 11 85-3510-193 . TOP PLATE. . . . . . . . .1 12 85-3510-185 . RADIUS FILLER. . . . . . .2 13 85-3510-197 . BACKING PLATE. . . . . . .1 14 85-3510-205 . DOUBLER. . . . . . . . . .1 15 MS21059L4 . NUT PLATE. . . . . . . . .1 */ATTACHING PARTS/* 16 NAS517-2-5 . SCREW. . . . . . . . . . .4 17 AN960-8 . WASHER . . . . . . . . . .4 18 NAS679A08 . NUT. . . . . . . . . . . .4 -------*-------





APRIL 1992

7-1-1PAGE 4



PAGE 57-1-1



APRIL 1992



7-1-1PAGE 4



PAGE 57-1-1



APRIL 1992

2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 19 85-3550-1 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-1-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .6 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R





7-1-1PAGE 6



PAGE 77-1-1



APRIL 1992



7-1-1PAGE 6



PAGE 77-1-1



APRIL 1992

3 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 1 PLUS AN960KD8L) 33A AN525-832R8 . SCREW (OPT MS35206-245 . .8 2 PLUS AN960KDL) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 1 34A NAS1329A08K75 . RIVNUT . . . . . . . . . .2 2 -------*------- 35 MS21509L08 . NUTPLATE . . . . . . . . .6 2 36 MS35207-263 . SCREW. . . . . . . . . . .1 2 37 AN960KDl0L . WASHER . . . . . . . . . .1 2 38 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 39 AN525-832R8 . SCREW (OPT MS35206-245 . .6 1 PLUS AN96OKD8L) 39A AN525-832R8 . SCREW (OPT MS35206-245 . .10 2 PLUS AN960KD8L) 40 NAS1329A08K75 . RIVNUT . . . . . . . . . .3 1 40A NAS1329A08K75 . RIVNUT . . . . . . . . . .4 2 41 MS21059L08 . NUTPLATE . . . . . . . . .3 1 41A MS21059L08 . NUTPLATE . . . . . . . . .6 2 -------*-------

USABLE ON CODES

1. MODEL 90/A90/B90/C90 (LJ-l THRU LJ-1062) MODEL E90 (LW-l AND AFTER)

2. MODEL C90A (LW-1063 AND AFTER)





1-2



APRIL 1992

LOCKER ASSEMBLYKING AIR 90/A90/B90/C90/C90A/C90B/E90

7-1-2PAGE 2



PAGE 37-1-2



APRIL 2004

FIGURE 1LOCKER ASSEMBLY (L/H)


7-1-2PAGE 2



PAGE 37-1-2







APRIL 2004

1 85-3550-1 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-41 . DOOR . . . . . . . . . . .1 1 1a 85-3550-47 . DOOR . . . . . . . . . . .1 2 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOT-MAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-101 . CARPET . . . . . . . . . .1

SEE PAGE 5 FOR USABLE ON CODES AND NOTES

7-1-2PAGE 4



PAGE 57-1-2




APRIL 2004


7-1-2PAGE 4



PAGE 57-1-2



* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE. - ITEM NOT ILLUSTRATED.



APRIL 2004

2 85-3550-1 WING LOCKER ASSEMBLY (L/H) . N/P 26 85-3520-091 L. LATCH RECEIVER ASSY. . . .1 85-3520-092 R. LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS16624-4056 . RETAINING RING. . . . . . 1 28 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 29 MS24694-52 . SCREW. . . . . . . . . . .4 30 AN960-10 . WASHER . . . . . . . . . .4 31 NAS679A3 . NUT (OPT MS21083N3). . . .4 -------*------- 32 85-3520-059 . PLATE. . . . . . . . . . .2 1 */ATTACHING PARTS/* 33 MS24693-C27 . SCREW. . . . . . . . . . .12 1 34 AN960C6 . WASHER . . . . . . . . . .12 1 35 NAS679C06 . NUT (OPT MS21083C06) . . .12 1 -------*------- 36 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 1 HARTWELL H117) */ATTACHING PARTS/* 37 AN525-832R28 . SCREW. . . . . . . . . . .2 1 38 AN960-8 . WASHER . . . . . . . . . .2 1 39 NAS679A08 . NUT (OPT MS21083N08) . . .2 1 40 AN3-16A . BOLT . . . . . . . . . . .2 1 41 AN960-10 . WASHER . . . . . . . . . .2 1 42 NAS679A3 . NUT (OPT MS21083N3). . . .2 1 -------*------- 43 MS35489-38 . GROMMET. . . . . . . . . .2 1 -------*------- 60 H43-1714-2 . PIN LATCH ASSY . . . . . .2 2 /ATTACHING PARTS/* 61 MS24693-C49 . SCREW . . . . . . . . . . 12 2 62 AN960C8 . WASHER . . . . . . . . . .12 2 63 NAS679C08 . NUT (OPT MS21083C06) . . .12 2

USABLE ON CODES AND NOTES1. KIT SERIAL # 1 THRU 632. KIT SERIAL # 64 AND AFTER

7-1-2PAGE 6



PAGE 77-1-2



APRIL 2004



7-1-2PAGE 6



PAGE 77-1-2







JAN 1998

3 85-3550-1 WING LOCKER ASSEMBLY (L/H) .N/P 44 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 45 MS24694-57 . SCREW. . . . . . . . . . .2 46 AN960-10 . WASHER . . . . . . . . . .3 47 NAS679A3 . NUT (OPT MS21083N3). . . .3 48 MS24694-54 . SCREW. . . . . . . . . . .1 49 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 50 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 51 MS24694-57 . SCREW. . . . . . . . . . .2 52 AN960-10 . WASHER . . . . . . . . . .2 53 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 54 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 55 AN4-13A . BOLT . . . . . . . . . . 2 56 AN960-416 . WASHER . . . . . . . . . .4 57 NAS679A4 . NUT (OPT MS21083N4). . . .2 58 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 59 85-3520-037 . SEAL . . . . . . . . . . .1

1-3



APRIL 1992

LOWER NACELLE FAIRING (L/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

7-1-3PAGE 2



PAGE 37-1-3



FIGURE 1LOWER NACELLE FAIRING (L/H)


APRIL 1992

7-1-3PAGE 2



PAGE 37-1-3



1 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 1 85-3550-11 . LOWER NACELLE FAIRING. . .1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .67 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 -------*-------





APRIL 1992

1-4



APRIL 1992

LOCKER INSTALLATION (R/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

7-1-4PAGE 2



PAGE 37-1-4




APRIL 1992

FIGURE 1LOCKER INSTALLATION (R/H)

7-1-4PAGE 2



PAGE 37-1-4







APRIL 1992

1 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 1 85-3510-195 . TOP PLATE. . . . . . . . .1 2 85-3510-187 . RADIUS FILLER. . . . . . .1 3 85-3510-201 . RADIUS FILLER. . . . . . .1 4 85-3510-199 . BACKING PLATE. . . . . . .1 5 85-3510-203 . DOUBLER. . . . . . . . . .1 6 MS21059L4 . NUT PLATE. . . . . . . . .1 */ATTACHING PARTS/* 7 NAS517-2-5 . SCREW. . . . . . . . . . .2 8 NAS517-2-6 . SCREW. . . . . . . . . . .2 9 AN960-8 . WASHER . . . . . . . . . .4 10 NAS679A08 . NUT. . . . . . . . . . . .4 -------*------- 11 85-3510-193 . TOP PLATE. . . . . . . . .1 12 85-3510-185 . RADIUS FILLER. . . . . . .2 13 85-3510-197 . BACKING PLATE. . . . . . .1 14 85-3510-205 . DOUBLER. . . . . . . . . .1 15 MS21059L4 . NUT PLATE. . . . . . . . .1 */ATTACHING PARTS/* 16 NAS517-2-5 . SCREW. . . . . . . . . . .4 17 AN960-8 . WASHER . . . . . . . . . .4 18 NAS679A08 . NUT. . . . . . . . . . . .4 -------*-------

7-1-4PAGE 4



PAGE 57-1-4




APRIL 1992


7-1-4PAGE 4



PAGE 57-1-4







APRIL 1992

2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-2 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-1-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .6 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------

7-1-4PAGE 6



PAGE 77-1-4




APRIL 1992


7-1-4PAGE 6



PAGE 77-1-4







APRIL 1992

3 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 1 PLUS AN96OKD8L) 33A AN525-832R8 . SCREW (OPT MS35206-245 . .10 2 PLUS AN960KD8L) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 1 34A NAS1329A08K75 . RIVNUT . . . . . . . . . .4 2 -------*------- 35 MS21059L08 . NUTPLATE . . . . . . . . .6 2 36 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 37 AN525-832R8 . SCREW (OPT MS35206-245 . .4 1 PLUS AN960KD8L) 37A AN525-832R8 . SCREW (OPT MS35206-245 . .8 2 PLUS AN960KD8L) 38 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 1 38A NAS1329A08K75 . RIVNUT . . . . . . . . . .2 2 39 MS21059L08 . NUTPLATE . . . . . . . . .6 2 40 MS35207-263 . SCREW. . . . . . . . . . .1 2 41 AN960KDl0L . WASHER . . . . . . . . . .1 2

USABLE ON CODES

1. MODEL 90/A90/B90/C90 (LJ-l THRU LJ-1062) MODEL E90 (LW-l AND AFTER)

2. MODEL C9OA (LJ-1063 AND AFTER)

1-5



APRIL 1992

LOCKER ASSEMBLY (R/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

7-1-5PAGE 2



PAGE 37-1-5



APRIL 2004


FIGURE 1LOCKER ASSEMBLY (R/H)

7-1-5PAGE 2



PAGE 37-1-5







APRIL 2004

1 85-3550-2 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-42 . DOOR . . . . . . . . . . .1 1 1a 85-3550-48 . DOOR . . . . . . . . . . .1 2 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-102 . CARPET . . . . . . . . . .1


7-1-5PAGE 4



PAGE 57-1-5




APRIL 2004


7-1-5PAGE 4



PAGE 57-1-5






APRIL 2004

2 85-3550-2 WING LOCKER ASSEMBLY (R/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . .1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 1 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 1 36 AN960C6 . WASHER . . . . . . . . . .12 1 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 1 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 1 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 1 40 AN960-8 . WASHER . . . . . . . . . .2 1 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 1 42 AN3-16A . BOLT . . . . . . . . . . .2 1 43 AN960-10 . WASHER . . . . . . . . . .2 1 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 1 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 1 -------*------- 62 H3-1714-2 . PIN LATCH ASSY . . . . . .2 2 */ATTACHING PARTS/* 63 MS24693-C49 . SCREW . . . . . . . . . . 12 2 64 AN960C8 . WASHER . . . . . . . . . .12 2 65 NAS679C08 . NUT (OPT MS21083C08). . . 12 2


7-1-5PAGE 6



PAGE 77-1-5




APRIL 2004


7-1-5PAGE 6



PAGE 77-1-5







APRIL 2004

3 85-3550-2 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1


1. KIT SERIAL # 1 THRU 63 2. KIT SERIAL # 64 AND AFTER

1-6



APRIL 1992

LOWER NACELLE FAIRING (R/H)KING AIR 90/A90/B90/C90/C90A/C90B/E90

7-1-6PAGE 2



PAGE 37-1-6




APRIL 1992

FIGURE 1LOWER NACELLE FAIRING (R/H)

7-1-6PAGE 2



PAGE 37-1-6







APRIL 1992

1 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 1 85-3550-12 . LOWER NACELLE FAIRING. . .1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .67 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 -------*-------



PAGE 17-2APRIL 1992

WING LOCKERSSUPER KING AIR F90/F90-1

2-1



JANUARY 1998

LOCKER INSTALLATION (L/H)SUPER KING AIR F90/F90-1

7-2-1PAGE 2



PAGE 37-2-1




APRIL 1992


7-2-1PAGE 2



PAGE 37-2-1







JAN 1998


7-2-1PAGE 4



PAGE 57-2-1




APRIL 1992


7-2-1PAGE 4



PAGE 57-2-1







JAN 1998

2 87-2007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 19 85-3550-3 . WING LOCKER ASSEMBLY/. . .1 1 85-3550-15 . WING LOCKER ASSEMBLY/. . .1 2 (SEE SECTION 7-2-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------

1. -3 LOCKER LA-3 THRU 201, 2042. -15 LOCKER LA-2, 202, 205 & AFTER


7-2-1PAGE 6



PAGE 77-2-1




APRIL 1992


7-2-1PAGE 6



PAGE 77-2-1







JAN 1998

3 87-2007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN960KD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 34 MS35207-263 . SCREW. . . . . . . . . . .1 35 AN960KDl0L . WASHER . . . . . . . . . .1 36 MS21059L08 . NUTPLATE (OPT NAS686L08) .5 37 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 -------*------- 38 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 39 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 40 NAS1329A08K75 . RIVNUT . . . . . . . . . .9 -------*-------

2-2



MAY 1995

LOCKER ASSEMBLY (L/H)SUPER KING AIR F90/F90-1

7-2-2PAGE 2



PAGE 37-2-2



APRIL 2004



7-2-2PAGE 2



PAGE 37-2-2







APRIL 2004

1 85-3550-3 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-41 . DOOR . . . . . . . . . . .1 1 1a 85-3550-47 . DOOR . . . . . . . . . . .1 2 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW(OPT AN3-4A BOLT) . .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-103 . CARPET . . . . . . . . . .1


7-2-2PAGE 4



PAGE 57-2-2



APRIL 2004



7-2-2PAGE 4



PAGE 57-2-2







APRIL 2004

2 85-3550-3 WING LOCKER ASSEMBLY (L/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 38 85-3521-7 . LATCH ASSY (SUPERSEDES . 2 1 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 1 40 AN960-8 . WASHER . . . . . . . . . .2 1 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 1 42 AN3-16A . BOLT . . . . . . . . . . .2 1 43 AN960-10 . WASHER . . . . . . . . . .2 1 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 1 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 1 -------*------- 62 H3-1714-2 . PIN LATCH ASSY . . . . . .2 2 /ATTACHING PARTS/* 63 MS24693-C27 . SCREW . . . . . . . . . . 12 2 64 AN960C6 . WASHER . . . . . . . . . .12 2 65 NAS679C06 . NUT (OPT MS21008C08). . . 12 2


7-2-2PAGE 6



PAGE 77-2-2




MAY 1995


7-2-2PAGE 6



PAGE 77-2-2







APRIL 2004

3 85-3550-3 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DD10L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1


KIT SERIAL # 1 THRU 27KIT SERIAL # 28 AND AFTER

2-3



LOWER NACELLE FAIRINGSUPER KING AIR F90/F90-1

APRIL 1992

7-2-3



PAGE 2 PAGE 37-2-3





APRIL 1992

7-2-3



PAGE 2 PAGE 37-2-3



1 87-2007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 1 85-3550-11 . LOWER NACELLE FAIRING. . .1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .67 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 -------*-------





APRIL 1992

2-4



LOCKER INSTALLATION (R/H)SUPER KING AIR F90/F90-1

APRIL 1992

7-2-4PAGE 2



PAGE 37-2-4





APRIL 1992

7-2-4PAGE 2



PAGE 37-2-4








APRIL 1992

7-2-4PAGE 4



PAGE 57-2-4




APRIL 1992

7-2-4PAGE 4



PAGE 57-2-4



2 87-2007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-4 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-2-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------





APRIL 1992

7-2-4PAGE 6



PAGE 77-2-4





APRIL 1992

7-2-4PAGE 6



PAGE 77-2-4



3 87-2007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN960KD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 34 MS35207-263 . SCREW. . . . . . . . . . .1 35 AN96OKDl0L . WASHER . . . . . . . . . .1 36 MS21059L08 . NUTPLATE (OPT NAS686L08) .5 37 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 -------*------- 38 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 39 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN96OKD8L) 40 NAS1329A08K75 . RIVNUT . . . . . . . . . .9 -------*-------





APRIL 1992

2-5



APRIL 1992

LOCKER ASSEMBLY (R/H)SUPER KING AIR F90/F90-1

7-2-5PAGE 2



PAGE 37-2-5





APRIL 2004

7-2-5PAGE 2



PAGE 37-2-5







APRIL 2004

1 85-3550-4 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-42 . DOOR . . . . . . . . . . .1 3 1a 85-3550-48 . DOOR . . . . . . . . . . .1 4 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-104 . CARPET . . . . . . . . . .1


7-2-5PAGE 4



PAGE 57-2-5





APRIL 2004

7-2-5PAGE 4



PAGE 57-2-5







2 85-3550-4 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-16 WING LOCKER ASSEMBLY (R/H) .N/P 2 26 85-3520-051 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-052 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 3 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 3 36 AN960C6 . WASHER . . . . . . . . . .12 3 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 3 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 3 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 3 40 AN960-8 . WASHER . . . . . . . . . .2 3 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 3 42 AN3-16A . BOLT . . . . . . . . . . .2 3 43 AN960-10 . WASHER . . . . . . . . . .2 3 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 3 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 3 -------*------- 62 H3-1714-2 . PIN LATCH ASSY . . . . . .2 4 /ATTACHING PARTS/* 63 MS24693-C49 . SCREW . . . . . . . . . . 12 4 64 AN960C8 . WASHER . . . . . . . . . .12 4 65 NAS679C08 . NUT (OPT MS21083C08) . . .12 4


APRIL 2004

7-2-5PAGE 6



PAGE 77-2-5




MAY 1995


7-2-5PAGE 6



PAGE 77-2-5







APRIL 2004

3 85-3550-4 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-16 WING LOCKER ASSEMBLY (R/H) .N/P 2 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DD10L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1


1. –4 LOCKER LA-3 THRU 201, 2042. –16 LOCKER LA-2, 202, 205 AND AFTER3. KIT SERIAL # 1 THRU 274. KIT SERIAL # 28 AND AFTER

2-6



APRIL 1992

LOWER NACELLE FAIRING (R/H)SUPER KING AIR F90/F90-1

7-2-6PAGE 2



PAGE 37-2-6





APRIL 1992

7-2-6PAGE 2



PAGE 37-2-6








APRIL 1992



PAGE 17-3

WING LOCKERSKING AIR 100/A100/B100

APRIL 1992

3-1



LOCKER INSTALLATION (L/H)KING AIR 100/A100/B100

APRIL 1992

7-3-1PAGE 2



PAGE 37-3-1





APRIL 1992

7-3-1PAGE 2



PAGE 37-3-1








APRIL 1992

7-3-1PAGE 4



PAGE 57-3-1





APRIL 1992

7-3-1PAGE 4



PAGE 57-3-1



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 19 85-3550-7 . WING LOCKER ASSEMBLY/. . .1 1 -19A 85-3550-9 . WING LOCKER ASSEMBLY/. . .1 2 (SEE SECTION 7-3-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .6 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R






APRIL 1992

7-3-1PAGE 6



PAGE 77-3-1





APRIL 1992


RAISBECK ENGINEERNGDocument No. 85·119Illustrated Parts Catalog


UNITS USABLEITEM PER ON

FIGURE NO. PART NO. DESCRIPTION ASSY. CODE

3 85-1007 WING STORAGE LOCKER. . N/PINSTALLATION (L/H)

28 85-3510-173 FAIRING. · · · · · · .1*/ATTACHING PARTS/*

29 MS24694-S49 SCREW. · · · · · · · .230 AN525-832R8 SCREW (OPT MS35206-245 .2

PLUS AN960KD8L)31 NAS1329A08K75 RIVNUT · · · · · · · .2

-------*-------32 85-3510-192 FAIRING. · · · · · · .1

*/ATTACHING PARTS/*33 AN525-832R8 . SCREW (OPT MS35206-245 .4

PLUS AN960KD8L)34 NAS1329A08K75 RIVNUT · · · · · · · . 4

-------*-------35 85-3510-191 FAIRING. · · · · · · .1

*/ATTACHING PARTS/*36 AN525-832R8 SCREW (OPT MS35206-245 . .6 1

PLUS AN960KD8L)-36A AN525-832R8 SCREW (OPT MS35206-245 .10 2

PLUS AN960KD8L)37 NAS1329A08K75 RIVNUT · · · · · · · . .3 1

-37A NAS1329A08K75 RIVNUT · · · · · · · . .10 238 MS21059L08 NUT PLATE (OPT NAS68 6L08) .3 1

-------*-------


l. MODEL 100/A100 (B-1 AND AFTER) .

2. MODEL B100 (BE-2 AND AFTER).

* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHERSUITABLE SOURCE.


APRIL 1992 7-3-1PAGE 7

3-2



APRIL 1992

LOCKER ASSEMBLY (L/H)KING AIR 100/A100/B100

7-3-2PAGE 2



PAGE 37-3-2



APRIL 2004



7-3-2PAGE 2



PAGE 37-3-2







APRIL 2004

1 85-3550-7 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-9 WING LOCKER ASSEMBLY (L/H) .N/P 2 1 85-3550-41 . DOOR . . . . . . . . . . .1 3 1a 85-3550-47 . DOOR . . . . . . . . . . .1 4 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-103 . CARPET . . . . . . . . . .1

SEE PAGE 7 FOR USABLE ON CODES

7-3-2PAGE 4



PAGE 57-3-2




APRIL 2004


7-3-2PAGE 4



PAGE 57-3-2






APRIL 2004

2 85-3550-7 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-9 WING LOCKER ASSEMBLY (L/H) .N/P 2 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 62 -MS16624-4056 . RETAINING RING. . . . . . 1 63 -85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 62 -MS16624-4056 . RETAINING RING. . . . . . 1 63 -85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 3 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 3 36 AN960C6 . WASHER . . . . . . . . . .12 3 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 3 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 3 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 3 40 AN960-8 . WASHER . . . . . . . . . .2 3 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 3 42 AN3-16A . BOLT . . . . . . . . . . .2 3 43 AN960-10 . WASHER . . . . . . . . . .2 3 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 3 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 3 -------*------- 62 H3-1714-2 . PIN LATCH ASSY . . . . . .2 4 */ATTACHING PARTS/* 63 MS24693-C49 . SCREW . . . . . . . . . . 12 4 64 AN960C8 . WASHER . . . . . . . . . .12 4 65 NAS679C08 . NUT (OPT MS21083C08) . . .12 4 SEE PAGE 7 FOR USABLE ON CODES

7-3-2PAGE 6



PAGE 77-3-2



MAY 1995


61


7-3-2PAGE 6



PAGE 77-3-2







APRIL 2004

3 85-3550-7 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-9 WING LOCKER ASSEMBLY (L/H) .N/P 2 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1

USABLE ON CODES

1. MODEL 100/A100 (B-l AND AFTER)2. MODEL B100 (BE-2 AND AFTER)3. KIT SERIAL # 1 THRU 154. KIT SERIAL # 16 AND AFTER

3-3



LOWER NACELLE FAIRING (L/H)KING AIR 100/A100/B100

APRIL 1992

7-3-3PAGE 2



PAGE 37-3-3






RAISBECK ENGINEERNGDocument No. 85-119Illustrated Parts Catalog


UNITS USABLEITEM PER ON

FIGURE NO. PART NO. DESCRIPTION ASSY. CODE

1 85-1007 WING STORAGE LOCKER. NipINSTALLATION (L/H)

1 85-3550-11 LOWER NACELLE FAIRING. .1*/ATTACHING PARTS/*

2 CR3212-4-3 . RIVET (CHERRY) .673 MS20426AD4-5 . RIVET. . . . . . . . .27

-------*-------

* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHERSUITABLE SOURCE.


APRIL 1992 7-3-3PAGE 3

3-4



LOCKER INSTALLATION (R/H)KING AIR 100/A100/B100

APRIL 1992

7-3-4PAGE 2



PAGE 37-3-4




KING AIR 100/100/B100

APRIL 1992

7-3-4PAGE 2



PAGE 37-3-4




KING AIR 100/100/B100




APRIL 1992

7-3-4PAGE 4



PAGE 57-3-4




APRIL 1992

KING AIR 100/100/B100

7-3-4PAGE 4



PAGE 57-3-4



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-8 . WING LOCKER ASSEMBLY/. . .1 1 -19A 85-3550-10 . WING LOCKER ASSEMBLY/. . .1 2 (SEE SECTION 7-3-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .6 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------


KING AIR 100/100/B100




APRIL 1992

7-3-4PAGE 6



PAGE 77-3-4




KING AIR 100/100/B100

APRIL 1992

7-3-4PAGE 6



PAGE 77-3-4



3 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 1 PLUS AN96OKD8L) -33A AN525-832R8 . SCREW (OPT MS35206-245 . .10 2 PLUS AN960KD8L) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 1 -34A NAS1329A08K75 . RIVNUT . . . . . . . . . .10 2 -------*------- 35 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 36 AN525-832R8 . SCREW (OPT MS35206-245 . .4 1 PLUS AN960KD8L) 38 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 1 -------*-------

USABLE ON CODES

1. MODEL 100/A100 (B-1 AND AFTER)


KING AIR 100/100/B100




APRIL 1992

3-5



APRIL 1992

LOCKER ASSEMBLY (R/H)KING AIR 100/A100/B100

7-3-5PAGE 2



PAGE 37-3-5



APRIL 2004



7-3-5PAGE 2



PAGE 37-3-5



1 85-3550-8 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-10 WING LOCKER ASSEMBLY (L/H) .N/P 2 1 85-3550-42 . DOOR . . . . . . . . . . .1 3 1a 85-3550-48 . DOOR . . . . . . . . . . .1 4 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-104 . CARPET . . . . . . . . . .1






APRIL 2004

7-3-5PAGE 4



PAGE 57-3-5




APRIL 2004


7-3-5PAGE 4



PAGE 57-3-5



2 85-3550-8 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-10 WING LOCKER ASSEMBLY (R/H) .N/P 2 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 62 -MS16624-4056 . RETAINING RING. . . . . . 1 63 -85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 62 -MS16624-4056 . RETAINING RING. . . . . . 1 63 -85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 3 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 3 36 AN960C6 . WASHER . . . . . . . . . .12 3 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 3 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 3 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 3 40 AN960-8 . WASHER . . . . . . . . . .2 3 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 3 42 AN3-16A . BOLT . . . . . . . . . . .2 3 43 AN960-10 . WASHER . . . . . . . . . .2 3 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 3 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 3 -------*------- 62 H3-1714-2 . PIN LATCH ASSY . . . . . .2 4 */ATTACHING PARTS/* 63 MS24693-C49 . SCREW . . . . . . . . . . 12 4 64 AN960C8 . WASHER . . . . . . . . . .12 4 65 NAS679C08 . NUT (OPT MS21083C08) . . .12 4 SEE PAGE 7 FOR USABLE ON CODES




APRIL 2004

7-3-5PAGE 6



PAGE 77-3-5



MAY 1995


61


7-3-5PAGE 6



PAGE 77-3-5







APRIL 2004

3 85-3550-8 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-10 WING LOCKER ASSEMBLY (R/H) .N/P 2 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1

USABLE ON CODES

1. MODEL 100/A100 (B-l AND AFTER)2. MODEL B100 (BE-2 AND AFTER)3. KIT SERIAL # 1 THRU 154. KIT SERIAL # 16 AND AFTER

3-6



LOWER NACELLE FAIRING (R/H)KING AIR 100/A100/B100

APRIL 1992

7-3-6PAGE 2



PAGE 37-3-6





APRIL 1992

7-3-6PAGE 2



PAGE 37-3-6








APRIL 1992



PAGE 17-4

WING LOCKERSSUPER KING AIR B200/A200/200 SERIES

APRIL 2004

4-1



LOCKER INSTALLATION (L/H)SUPER KING AIR B200/A200/200 SERIESKIT SERIAL # 1 THRU 188, 373 THRU 378

APRIL 2004

7-4-1PAGE 2



PAGE 37-4-1





APRIL 1992

7-4-1PAGE 2



PAGE 37-4-1








APRIL 1992

7-4-1PAGE 4



PAGE 57-4-1





APRIL 1992

7-4-1PAGE 4



PAGE 57-4-1



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 19 85-3550-5 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-4-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R





APRIL 1992

4-1a



LOCKER INSTALLATION (L/H)SUPER KING AIR B200/A200/200 SERIES

KIT SERIAL # 189 THRU 372, 379 AND AFTER

APRIL 2004

7-4-1aPAGE 2



PAGE 37-4-1a





APRIL 2004

7-4-1aPAGE 2



PAGE 37-4-1a








APRIL 2004

7-4-1aPAGE 4



PAGE 57-4-1a




APRIL 2004


7-4-1aPAGE 4



PAGE 57-4-1a







APRIL 2004

2 200-5421 WING STORAGE LOCKER. . . . .N/P INSTALLATION (L/H) 19 85-3550-17 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-4-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 NAS517-3-3 . SCREW. . . . . . . . . . .16 (7 OUTBD, 9 INBD) 26 A3235-020-24A . WASHER (TINNERMAN) . . . .16 (7 OUTBD, 9 INBD) 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R */ATTACHING PARTS/* 28 85-3510-217 . SEAL RETAINER (OUTBD) . . 1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 - 85-3510-215 . SEAL RETAINER (INBD) . . .1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 -------*------- 30 85-3510-213 . DOUBLER . . . . . . . . . 1 31 NAS1068A3 . NUTPLATE . . . . . . . . .6 */ATTACHING PARTS/* - MS20426AD3-() . RIVET . . . . . . . . . . 12 */ATTACHING PARTS/* 32 CR3212-4-3 . RIVET (CHERRY) . . . . . .6 33 (P/N UNKNOWN) . LIGHT PLATE (SALVAGEG) . .1 */ATTACHING PARTS/* 34 NAS514P832-10 . SCREW . . . . . . . . . . 6 -------*-------

7-4-1aPAGE 6



PAGE 77-4-1a




APRIL 2004


7-4-1aPAGE 6



PAGE 77-4-1a







APRIL 2004

3 200-5421 WING STORAGE LOCKER. . . . .N/P INSTALLATION (L/H) 35 85-3550-55 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 36 CR3212-4-3 . RIVET (CHERRY) . . . . . .3 -------*------- 37 85-3550-53 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 38 CR3212-4-3 . RIVET (CHERRY) . . . . . .7 -------*------- 39 85-3550-51 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 40 CR3212-4-3 . RIVET (CHERRY) . . . . . .3 41 CR3242-4-3 . RIVET (CHERRY) . . . . . .3 -------*------- 42 85-3550-57 . CAP ASSEMBLY . . . . . . .2 */ATTACHING PARTS/* - A06491-832-1D . SPEED NUT . . . . . . . . 2 (SALVAGED) -------*------- 43 85-3510-207 . NUTPLATE STRIP . . . . . .2 */ATTACHING PARTS/* 44 MS20426AD3-4 . RIVET . . . . . . . . . . 12 -------*------- 45 NAS1329A3K80 . RIVNUT . . . . . . . . . .6 -------*-------

4-2



LOCKER ASSEMBLY (L/H)SUPER KING AIR B200/A200/200 SERIESKIT SERIAL # 1 THRU 188, 373 THRU 378

APRIL 2004

7-4-2PAGE 2



PAGE 37-4-2



APRIL 2004



7-4-2PAGE 2



PAGE 37-4-2





* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE. - ITEM NOT ILLUSTRATED.MAY 1995

1 85-3550-5 WING LOCKER ASSEMBLY (L/H) .N/P 85-3550-41 . DOOR . . . . . . . . . . .1

2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-103 . CARPET . . . . . . . . . .1


7-4-2PAGE 4



PAGE 57-4-2




APRIL 1992


7-4-2PAGE 4



PAGE 57-4-2







JAN 1998

2 85-3550-5 WING LOCKER ASSEMBLY (L/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . 2 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 40 AN960-8 . WASHER . . . . . . . . . .2 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 42 AN3-16A . BOLT . . . . . . . . . . .2 43 AN960-10 . WASHER . . . . . . . . . .2 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2

7-4-2PAGE 6



PAGE 77-4-2



MAY 1995



7-4-2PAGE 6



PAGE 77-4-2







MAY 1995

3 85-3550-5 WING LOCKER ASSEMBLY (L/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1

4-2a



LOCKER ASSEMBLY (L/H)SUPER KING AIR B200/A200/200 SERIES


APRIL 2004

7-4-2aPAGE 2



PAGE 37-4-2a



APRIL 2004



7-4-2aPAGE 2



PAGE 37-4-2a





* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE. - ITEM NOT ILLUSTRATED.APRIL 2004

1 85-3550-17 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-47 . DOOR . . . . . . . . . . .1 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 385-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-103 . CARPET . . . . . . . . . .1

7-4-2aPAGE 4



PAGE 57-4-2a



APRIL 2004



7-4-2aPAGE 4



PAGE 57-4-2a



APRIL 2004

2 85-3550-8 WING LOCKER ASSEMBLY (R/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 H3-1714-2 . PIN LATCH ASSY . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C08 . NUT (OPT MS21083C08) . . .12 -------*-------





7-4-2aPAGE 6



PAGE 77-4-2a



APRIL 2004



7-4-2aPAGE 6



PAGE 77-4-2a







APRIL 2004


4-3



APRIL 2004

LOWER NACELLE FAIRING (L/H)SUPER KING AIR B200/A200/200 SERIES

7-4-3PAGE 2



PAGE 37-4-3





APRIL 1992

7-4-3PAGE 2



PAGE 37-4-3



1 87-2007 WING STORAGE LOCKER. . . . N/P 1 INSTALLATION (L/H) 1 85-3550-13 . LOWER NACELLE FAIRING. . .1 1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 1 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 1 -------*------- 200-5421 WING STORAGE LOCKER. . . . N/P 2 INSTALLATION (L/H) 1 85-3550-19 . LOWER NACELLE FAIRING. . .1 2 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 2 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 2 -------*-------

USEABLE ON CODE

1. KIT SERIAL #1 THRU 188,373 THRU 3782. KIT SERIAL #189 THRU 372,379 AND AFTER





APRIL 2004

4-4



LOCKER INSTALLATION (R/H)SUPER KING AIR B200/A200/200 SERIESKIT SERIAL # 1 THRU 188, 373 THRU 378

APRIL 2004

7-4-4PAGE 2



PAGE 37-4-4




APRIL 1992


7-4-4PAGE 2



PAGE 37-4-4







APRIL 1992


7-4-4PAGE 4



PAGE 57-4-4




APRIL 1992


7-4-4PAGE 4



PAGE 57-4-4



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-6 . WING LOCKER ASSEMBLY/. . .1 1 (SEE SECTION 7-3-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .6 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------





APRIL 1992

7-4-4PAGE 6



PAGE 77-4-4




APRIL 1992


7-4-4PAGE 6



PAGE 77-4-4







APRIL 1992

3 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 PLUS AN960KD8L) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 -------*------- 35 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 36 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 37 NAS1329A08K75 . RIVNUT . . . . . . . . . .9 -------*-------

4-4a



LOCKER INSTALLATION (R/H)SUPER KING AIR B200/A200/200 SERIES


APRIL 2004

7-4-4aPAGE 2



PAGE 37-4-4a




APRIL 2004


7-4-4aPAGE 2



PAGE 37-4-4a







APRIL 2004


7-4-4aPAGE 4



PAGE 57-4-4a




APRIL 2004


7-4-4aPAGE 4



PAGE 57-4-4a







APRIL 2004

2 200-5421 WING STORAGE LOCKER. . . . .N/P INSTALLATION (R/H) 19 85-3550-18 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-4-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 NAS517-3-3 . SCREW. . . . . . . . . . .16 (7 OUTBD, 9 INBD) 26 A3235-020-24A . WASHER (TINNERMAN) . . . .16 (7 OUTBD, 9 INBD) 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R */ATTACHING PARTS/* 28 85-3510-217 . SEAL RETAINER (OUTBD) . . 1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 - 85-3510-215 . SEAL RETAINER (INBD) . . .1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 -------*------- 30 85-3510-213 . DOUBLER . . . . . . . . . 1 32 CR3212-4-3 . RIVET (CHERRY). . . . . . 6

31 NAS1068A3 . NUTPLATE . . . . . . . . .6 */ATTACHING PARTS/* - MS20426AD3-() . RIVET . . . . . . . . . . 12 33 (P/N UNKNOWN) . LIGHT PLATE (SALVAGEG) . .1 */ATTACHING PARTS/* 34 NAS514P832-10 . SCREW . . . . . . . . . . 6 -------*-------

7-4-4aPAGE 6



PAGE 77-4-4a




APRIL 2004


7-4-4aPAGE 6



PAGE 77-4-4a







APRIL 2004


4-5



LOCKER ASSEMBLY (R/H)SUPER KING AIR B200/A200/200 SERIESKIT SERIAL # 1 THRU 188, 373 THRU 378

APRIL 2004

7-4-5PAGE 2



PAGE 37-4-5



APRIL 1992



7-4-5PAGE 2



PAGE 37-4-5






1 85-3550-6 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-18 . DOOR . . . . . . . . . . .1 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-104 . CARPET . . . . . . . . . .1

7-4-5PAGE 4



PAGE 57-4-5



APRIL 1992



7-4-5PAGE 4



PAGE 57-4-5





* PART MAY BE OBTAINED THROUGH BEECHCRAFT DEALERSHIPS OR ANY OTHER SUITABLE SOURCE. - ITEM NOT ILLUSTRATED.JAN 1998

2 85-3550-6 WING LOCKER ASSEMBLY (R/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . 2 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 40 AN960-8 . WASHER . . . . . . . . . .2 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 42 AN3-16A . BOLT . . . . . . . . . . .2 43 AN960-10 . WASHER . . . . . . . . . .2 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2

7-4-5PAGE 6



PAGE 77-4-5



MAY 1995



7-4-5PAGE 6



PAGE 77-4-5






3 85-3550-6 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1

4-5a



LOCKER ASSEMBLY (R/H)SUPER KING AIR B200/A200/200 SERIES


APRIL 2004

7-4-5aPAGE 2



PAGE 37-4-5a



APRIL 2004



7-4-5aPAGE 2



PAGE 37-4-5a







7-4-5aPAGE 4



PAGE 57-4-5a



APRIL 2004



7-4-5aPAGE 4



PAGE 57-4-5a






2 85-3550-18 WING LOCKER ASSEMBLY (L/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 H3-1714-2 . PIN LATCH ASSY . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C49 . SCREW. . . . . . . . . . .12 36 AN960C8 . WASHER . . . . . . . . . .12 37 NAS679C08 . NUT (OPT MS21083C08) . . .12 -------*-------

7-4-5aPAGE 6



PAGE 77-4-5a



APRIL 2004



7-4-5aPAGE 6



PAGE 77-4-5a






3 85-3550-8 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD- REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1 -------*-------

4-6



APRIL 2004

LOWER NACELLE FAIRING (R/H)SUPER KING AIR B200/A200/200 SERIES

7-4-6PAGE 2



PAGE 37-4-6





APRIL 1992

7-4-6PAGE 2



PAGE 37-4-6



1 87-2007 WING STORAGE LOCKER. . . . N/P 1 INSTALLATION (R/H) 1 85-3550-14 . LOWER NACELLE FAIRING. . .1 1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 1 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 1 -------*------- 200-5421 WING STORAGE LOCKER. . . . N/P 2 INSTALLATION (R/H) 1 85-3550-20 . LOWER NACELLE FAIRING. . .1 2 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 2 3 MS20426AD4-5 . RIVET. . . . . . . . . . .22 2 -------*-------

USEABLE ON CODE

1. KIT SERIAL #1 THRU 188,373 THRU 3782. KIT SERIAL #189 THRU 372,379 AND AFTER





APRIL 2004



PAGE 17-5

WING LOCKERSSUPER KING AIR B300/300 SERIES

APRIL 2004

5-1



LOCKER INSTALLATION (L/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #1 THRU 42, (300/300LW)KIT SERIAL #1 THRU 99, (B300/B300C)

APRIL 2004

7-5-1PAGE 2



PAGE 37-5-1





APRIL 1992

7-5-1PAGE 2



PAGE 37-5-1








APRIL 1992

7-5-1PAGE 4



PAGE 57-5-1




APRIL 1992


7-5-1PAGE 4



PAGE 57-5-1



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-5 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-3-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------





APRIL 1992

7-5-1PAGE 6



PAGE 77-5-1





APRIL 1992

7-5-1PAGE 6



PAGE 77-5-1



3 89-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (L/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 PLUS AN960KD8L) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 35 MS21059L08 . NUTPLATE (OPT NAS686A08) .5 36 MS35207-263 . RIVNUT . . . . . . . . . .1 37 AN960KD10L . RIVNUT . . . . . . . . . .1 -------*------- 38 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 39 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 40 NAS1329A08K75 . RIVNUT . . . . . . . . . .9 -------*-------





APRIL 1992

5-1a



LOCKER INSTALLATION (L/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #43 AND AFTER, (300/300LW)KIT SERIAL #100 AND AFTER, (B300/B300C)

APRIL 2004

7-5-1aPAGE 2



PAGE 37-5-1a




SUPER KING AIR B300/300 SERIESS

APRIL 2004

7-5-1aPAGE 2



PAGE 37-5-1a








APRIL 2004

7-5-1aPAGE 4



PAGE 57-5-1a




APRIL 2004


7-5-1aPAGE 4



PAGE 57-5-1a







APRIL 2004

2 200-5431 WING STORAGE LOCKER. . . . .N/P INSTALLATION (L/H) 19 85-3550-17 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-5-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .14 (7 OUTBD, 7 INBD) 26 A3235-020-24A . WASHER (TINNERMAN) . . . .14 (7 OUTBD, 7 INBD) 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*------- 28 85-3510-217 . SEAL RETAINER (OUTBD) . . 1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 - 85-3510-215 . SEAL RETAINER (INBD) . . .1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 -------*------- 30 85-3510-213 . DOUBLER . . . . . . . . . 1 */ATTACHING PARTS/* 32 CR3212-4-3 . RIVET (CHERRY) . . . . . .6 31 NAS1068A3 . NUTPLATE . . . . . . . . .6 */ATTACHING PARTS/* - MS20426AD3-() . RIVET . . . . . . . . . . 12 33 (P/N UNKNOWN) . LIGHT PLATE (SALVAGEG) . .1 */ATTACHING PARTS/* 34 NAS514P832-10 . SCREW . . . . . . . . . . 6 -------*-------

7-5-1aPAGE 6



PAGE 77-5-1a




APRIL 2004


7-5-1aPAGE 6



PAGE 77-5-1a






SUPER KING AIR B300/300 SERIES SERIES

APRIL 2004


5-2



LOCKER ASSEMBLY (L/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #1 THRU 42, (300/300LW)KIT SERIAL #1 THRU 99 FOR (B300/B300C)

APRIL 2004

7-5-2PAGE 2



PAGE 37-5-2



APRIL 1992



7-5-2PAGE 2



PAGE 37-5-2







7-5-2PAGE 4



PAGE 57-5-2



APRIL 1992



7-5-2PAGE 4



PAGE 57-5-2



2 85-3550-5 WING LOCKER ASSEMBLY (L/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . .2 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 40 AN960-8 . WASHER . . . . . . . . . .2 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 42 AN3-16A . BOLT . . . . . . . . . . .2 43 AN960-10 . WASHER . . . . . . . . . .2 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 -------*-------




7-5-2PAGE 6



PAGE 77-5-2




MAY 1995


7-5-2PAGE 6



PAGE 77-5-2







MAY 1995


5-2a



LOCKER ASSEMBLY (L/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #1 THRU 42, (300/300LW)KIT SERIAL #1 THRU 99 FOR (B300/B300C)

APRIL 2004

7-5-2aPAGE 2



PAGE 37-5-2a



APRIL 2004



7-5-2aPAGE 2



PAGE 37-5-2a






1 85-3550-17 WING LOCKER ASSEMBLY (L/H) .N/P 1 85-3550-47 . DOOR . . . . . . . . . . .1 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 385-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-103 . CARPET . . . . . . . . . .1

7-5-2aPAGE 4



PAGE 57-5-2a



APRIL 2004



7-5-2aPAGE 4



PAGE 57-5-2a






2 85-3550-17 WING LOCKER ASSEMBLY (L/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 H3-1714-2 . PIN LATCH ASSY. . . . . . 2 */ATTACHING PARTS/* 35 MS24693-C49 . SCREW. . . . . . . . . . .12 36 AN960C8 . WASHER . . . . . . . . . .12 37 NAS679C08 . NUT (OPT MS21083C06) . . .12 -------*-------

7-5-2aPAGE 6



PAGE 77-5-2a




APRIL 2004


7-5-2aPAGE 6



PAGE 77-5-2a







APRIl 2004


5-3



APRIL 2004

LOWER NACELLE FAIRING (L/H)SUPER KING AIR B300/300 SERIES

7-5-3PAGE 2



PAGE 37-5-3





APRIL 1992

7-5-3PAGE 2



PAGE 37-5-3




1 87-2007 WING STORAGE LOCKER. . . . N/P 1 INSTALLATION (L/H) 1 85-3550-13 . LOWER NACELLE FAIRING. . .1 1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 1 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 1 -------*------- 200-5421 WING STORAGE LOCKER. . . . N/P 2 INSTALLATION (L/H) 1 85-3550-19 . LOWER NACELLE FAIRING. . .1 2 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 2 3 MS20426AD4-5 . RIVET. . . . . . . . . . .27 2 -------*-------

USEABLE ON CODE

1. KIT SERIAL #1 THRU 42 FOR (300/300LW) KIT SERIAL #1 THRU 99 FOR (B300/300C)2. KIT SERIAL #43 AND AFTER FOR (300/300LW) KIT SERIAL #100 AND AFTER FOR (B300/300C)




APRIL 2004

5-4



LOCKER INSTALLATION (R/H)SUPER KING AIR B300/300 SERIES


APRIL 2004

7-5-4PAGE 2



PAGE 37-5-4





APRIL 1992

7-5-4PAGE 2



PAGE 37-5-4








APRIL 1992

7-5-4PAGE 4



PAGE 57-5-4




APRIL 1992


7-5-4PAGE 4



PAGE 57-5-4



2 85-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 19 85-3550-6 . WING LOCKER ASSEMBLY/. . .1 1 (SEE SECTION 7-5-5 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 MS24694-S49 . SCREW. . . . . . . . . . .2 26 A3235-028-24A . WASHER (TINNERMAN) . . . .2 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R -------*-------





APRIL 1992

7-5-4PAGE 6



PAGE 77-5-4




APRIL 1992


7-5-4PAGE 6



PAGE 77-5-4






APRIL 1992


3 89-1007 WING STORAGE LOCKER. . . . N/P INSTALLATION (R/H) 28 85-3510-173 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 29 MS24694-S49 . SCREW. . . . . . . . . . .2 30 AN525-832R8 . SCREW (OPT MS35206-245 . .2 PLUS AN96OKD8L) 31 NAS1329A08K75 . RIVNUT . . . . . . . . . .2 -------*------- 32 85-3510-191 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 33 AN525-832R8 . SCREW (OPT MS35206-245 . .4 PLUS AN960KD8L) 34 NAS1329A08K75 . RIVNUT . . . . . . . . . .4 35 MS21059L08 . NUTPLATE (OPT NAS686A08) .5 36 MS35207-263 . RIVNUT . . . . . . . . . .1 37 AN960KD10L . RIVNUT . . . . . . . . . .1 -------*------- 38 85-3510-192 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 39 AN525-832R8 . SCREW (OPT MS35206-245 . .9 PLUS AN960KD8L) 40 NAS1329A08K75 . RIVNUT . . . . . . . . . .9 -------*-------

5-4a



LOCKER INSTALLATION (R/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #43 AND AFTER (300/300LW)KIT SERIAL #100 AND AFTER (B300/B300C)

APRIL 2004

7-5-4aPAGE 2



PAGE 37-5-4a





APRIL 2004

7-5-4aPAGE 2



PAGE 37-5-4a








APRIL 2004

7-5-4aPAGE 4



PAGE 57-5-4a




APRIL 2004


7-5-4aPAGE 4



PAGE 57-5-4a






APRIL 2004

2 200-5431 WING STORAGE LOCKER. . . . .N/P INSTALLATION (R/H) 19 85-3550-18 . WING LOCKER ASSEMBLY/. . .1 (SEE SECTION 7-4-2 FOR COMPONENT BREAKDOWN) */ATTACHING PARTS/* 20 85-3510-125 . SPACER -0.250 THICK. . . .A/R 21 85-3510-131 . SPACER . . . . . . . . . .A/R 22 85-3510-157 . SPACER -0.125 THICK. . . .A/R 23 NAS1104-18 . BOLT (OPT AN4-14A) . . . .2 24 AN970-4 . WASHER . . . . . . . . . .2 25 NAS517-3-3 . SCREW. . . . . . . . . . .14 (7 OUTBD, 7 INBD) 26 A3235-020-24A . WASHER (TINNERMAN) . . . .14 (7 OUTBD, 7 INBD) 27 S-3760 . TRIM STRIP (KIRKHILL). . .A/R */ATTACHING PARTS/* 28 85-3510-217 . SEAL RETAINER (OUTBD) . . 1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 - 85-3510-215 . SEAL RETAINER (INBD) . . .1 */ATTACHING PARTS/* 29 NAS1097AD4-4 . RIVET . . . . . . . . . . 2 -------*------- 30 85-3510-213 . DOUBLER . . . . . . . . . 1 31 NAS1068A3 . NUTPLATE . . . . . . . . .6 */ATTACHING PARTS/* - MS20426AD3-() . RIVET . . . . . . . . . . 12 */ATTACHING PARTS/* 32 CR3212-4-3 . RIVET (CHERRY) . . . . . .6 33 (P/N UNKNOWN) . LIGHT PLATE (SALVAGEG) . .1 */ATTACHING PARTS/* 34 NAS514P832-10 . SCREW . . . . . . . . . . 6 -------*-------


7-5-4aPAGE 6



PAGE 77-5-4a




APRIL 2004


7-5-4aPAGE 6



PAGE 77-5-4a







APRIL 2004

3 200-5431 WING STORAGE LOCKER. . . . .N/P INSTALLATION (R/H) 35 85-3550-56 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 36 CR3212-4-3 . RIVET (CHERRY) . . . . . .3 -------*------- 37 85-3550-54 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 38 CR3212-4-3 . RIVET (CHERRY) . . . . . .7 -------*------- 39 85-3550-52 . FAIRING. . . . . . . . . .1 */ATTACHING PARTS/* 40 CR3212-4-3 . RIVET (CHERRY) . . . . . .3 41 CR3242-4-3 . RIVET (CHERRY) . . . . . .3 -------*------- 42 85-3550-57 . CAP ASSEMBLY . . . . . . .2 */ATTACHING PARTS/* - A06491-832-1D . SPEED NUT . . . . . . . . 2 (SALVAGED) -------*------- 43 85-3510-207 . NUTPLATE STRIP . . . . . .2 */ATTACHING PARTS/* 44 MS20426AD3-4 . RIVET . . . . . . . . . . 12 -------*------- 45 NAS1329A3K80 . RIVNUT . . . . . . . . . .4 -------*-------

5-5



LOCKER ASSEMBLY (R/H)SUPER KING AIR B300/300 SERIES


APRIL 2004

7-5-5PAGE 2



PAGE 37-5-5



APRIL 1992


SUPER KING AIR 300/300LW/B300/B300C

7-5-5PAGE 2



PAGE 37-5-5






1 85-3550-6 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-42 . DOOR . . . . . . . . . . .1 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 385-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-104 . CARPET . . . . . . . . . .1

7-5-5PAGE 4



PAGE 57-5-5



APRIL 1992



7-5-5PAGE 4



PAGE 57-5-5





2 85-3550-6 WING LOCKER ASSEMBLY (R/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 85-3520-059 . PLATE. . . . . . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C27 . SCREW. . . . . . . . . . .12 36 AN960C6 . WASHER . . . . . . . . . .12 37 NAS679C06 . NUT (OPT MS21083C06) . . .12 -------*------- 38 85-3521-7 . LATCH ASSY (SUPERSEDES . 2 HARTWELL H117) */ATTACHING PARTS/* 39 AN525-832R28 . SCREW. . . . . . . . . . .2 40 AN960-8 . WASHER . . . . . . . . . .2 41 NAS679A08 . NUT (OPT MS21083N08) . . .2 42 AN3-16A . BOLT . . . . . . . . . . .2 43 AN960-10 . WASHER . . . . . . . . . .2 44 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 45 MS35489-38 . GROMMET. . . . . . . . . .2 -------*-------


7-5-5PAGE 6



PAGE 77-5-5



MAY 1995



7-5-5PAGE 6



PAGE 77-5-5





3 85-3550-6 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1 -------*-------


5-5a



LOCKER ASSEMBLY (R/H)SUPER KING AIR B300/300 SERIES

KIT SERIAL #43 AND AFTER (300/300LW)KIT SERIAL #100 AND AFTER (B300/B300C)

APRIL 2004

7-5-5aPAGE 2



PAGE 37-5-5a



APRIL 2004



7-5-5aPAGE 2



PAGE 37-5-5a





1 85-3550-18 WING LOCKER ASSEMBLY (R/H) .N/P 1 85-3550-48 . DOOR . . . . . . . . . . .1 2 85-3520-037 . SEAL . . . . . . . . . . .A/R 3 85-3560-1 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 4 MS24694-52 . SCREW. . . . . . . . . . .1 5 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 6 AN970-3 . WASHER . . . . . . . . . .3 7 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 8 85-3560-2 . HINGE ASSY . . . . . . . .1 */ATTACHING PARTS/* 9 MS24694-52 . SCREW. . . . . . . . . . .1 10 AN525-l0R8 . SCREW (OPT AN3-4A BOLT). .3 11 AN970-3 . WASHER . . . . . . . . . .3 12 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 13 AC8499B . LOCK ASSY (CHICAGO LOCK) .1 14 85-3520-053 . STRIKER. . . . . . . . . .1 */ATTACHING PARTS/* 15 NAS514P832-7P . SCREW. . . . . . . . . . .2 16 NAS1169DD8L . WASHER (OPT TINNERMAN. . .2 A3135-017-24A) 17 AN960-8 . WASHER . . . . . . . . . .2 18 NAS679A08 . NUT (OPT MS21083N08) . . .2 -------*------- 19 EMC-6411B-ZN . FOOTMAN LOOP (AUSTIN HDW .4 SUPPLY) */ATTACHING PARTS/* 20 MS24694-54 . SCREW. . . . . . . . . . .4 21 AN960-10 . WASHER . . . . . . . . . .8 22 NAS679A3 . NUT (OPT MS21083N3). . . .8 23 MS24694-53 . SCREW. . . . . . . . . . .4 -------*------- 24 85-3520-027 . PLACARD. . . . . . . . . .1 25 85-3550-104 . CARPET . . . . . . . . . .1 -------*-------


7-5-5aPAGE 4



PAGE 57-5-5a



APRIL 2004



7-5-5aPAGE 4



PAGE 57-5-5a



2 85-3550-18 WING LOCKER ASSEMBLY (R/H) .N/P 26 85-3520-091 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 27 MS24694-52 . SCREW. . . . . . . . . . .4 28 AN960-10 . WASHER . . . . . . . . . .4 29 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 30 85-3520-092 . LATCH RECEIVER ASSY. . . .1 */ATTACHING PARTS/* 31 MS24694-52 . SCREW. . . . . . . . . . .4 32 AN960-10 . WASHER . . . . . . . . . .4 33 NAS679A3 . NUT (OPT MS21083N3). . . .4 - MS16624-4056 . RETAINING RING. . . . . . 1 - 85-3520-067 . LATCH RECIEVER(DELRON AF) 1 -------*------- 34 H3-1714-2 . PIN LATCH ASSY . . . . . .2 */ATTACHING PARTS/* 35 MS24693-C49 . SCREW. . . . . . . . . . .12 36 AN960C8 . WASHER . . . . . . . . . .12 37 NAS679C08 . NUT (OPT MS21083C08) . . .12 -------*-------




7-5-5aPAGE 6



PAGE 77-5-5a



APRIL 2004



7-5-5aPAGE 6



PAGE 77-5-5a






3 85-3550-18 WING LOCKER ASSEMBLY (R/H) .N/P 46 85-3520-075 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 47 MS24694-57 . SCREW. . . . . . . . . . .2 48 AN960-10 . WASHER . . . . . . . . . .3 49 NAS679A3 . NUT (OPT MS21083N3). . . .3 50 MS24694-54 . SCREW. . . . . . . . . . .1 51 NAS1169DDl0L . WASHER (OPT TINNERMAN. . .1 A3235-020-24A) -------*------- 52 85-3520-073 . BRACKET. . . . . . . . . .1 */ATTACHING PARTS/* 53 MS24694-57 . SCREW. . . . . . . . . . .2 54 AN960-10 . WASHER . . . . . . . . . .2 55 NAS679A3 . NUT (OPT MS21083N3). . . .2 -------*------- 56 85-3520-077 . GAS SPRING . . . . . . . .1 (SUPERSEDES NORCO A3219-1 HOLD OPEN ROD-REF SVC LTR 8) */ATTACHING PARTS/* 57 AN4-13A . BOLT . . . . . . . . . . .2 58 AN960-416 . WASHER . . . . . . . . . .4 59 NAS679A4 . NUT (OPT MS21083N4). . . .2 60 NAS43DD4-8 . SPACER . . . . . . . . . .4 (SUPERSEDES AN960-416 WASHER-REF SVC LTR 8) -------*------- 61 85-3520-037 . SEAL . . . . . . . . . . .1 -------*-------

5-6



APRIL 2004

LOWER NACELLE FAIRING (R/H)SUPER KING AIR B300/300 SERIES

7-5-6PAGE 2



PAGE 37-5-6





APRIL 1992

7-5-6PAGE 2



PAGE 37-5-6



1 89-1007 WING STORAGE LOCKER. . . . N/P 1 INSTALLATION (R/H) 1 85-3550-14 . LOWER NACELLE FAIRING. . .1 1 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 1 3 MS20426AD4-5 . RIVET. . . . . . . . . . .22 1 -------*------- 200-5421 WING STORAGE LOCKER. . . . N/P 2 INSTALLATION (R/H) 1 85-3550-20 . LOWER NACELLE FAIRING. . .1 2 */ATTACHING PARTS/* 2 CR3212-4-3 . RIVET (CHERRY) . . . . . .57 2 3 MS20426AD4-5 . RIVET. . . . . . . . . . .22 2 -------*-------

USEABLE ON CODE

1. KIT SERIAL #1 THRU 42 FOR (300/300LW) KIT SERIAL #1 THRU 99 FOR (B300/300C)2. KIT SERIAL #43 AND AFTER FOR (300/300LW) KIT SERIAL #100 AND AFTER FOR (B300/300C)





APRIL 2004

0



8-0 1 APR 04 . . . .LIST OF PAGES & TABLE OF CONTENTS

8-1 1 APR 04 . . . .INCREASED GROSS WEIGHT (C90/C90A)

8-1-1 1 APR 04 . . . .OPTIONAL AIRSPEED8-1-1 2 APR 04 INDICATOR (C90A)8-1-1 3 APR 04

8-2 1 APR 92 . . . .INCREASED GROSS WEIGHT (E90)

8-2-1 1 APR 92 . . . .JACKING LIMITATIONS8-2-1 2 APR 92 PLACARD8-2-1 3 APR 92

8-3 1 APR 92 . . . .INCREASED GROSS WEIGHT (100/A100)

8-3-1 1 APR 92 . . . .JACKING LIMITATIONS8-3-1 2 APR 92 PLACARD8-3-1 3 APR 92

8-3-2 1 APR 92 . . . .BALLAST INSTALLATION8-3-2 2 APR 928-3-2 3 APR 92



INCREASED GROSS WEIGHT

APRIL 2004



PAGE 18-1

INCREASED GROSS WEIGHTKING AIR C90/C90A

APRIL 2004

1-1



OPTIONAL AIRSPEED INDICATORSKING AIR C90A

(LJ-1063 THRU LJ-1137 AND LJ-1146)WITH RAISBECK SERVICE BULLETIN 20-31-1

APRIL 2004

8-1-1PAGE 2



PAGE 38-1-1



KING AIR C90A

FIGURE 1OPTIONAL AIRSPEED INDICATOR

APRIL 2004

8-1-1PAGE 2



PAGE 38-1-1



KING AIR C90A




1 SB 20-31-1 DUAL AIRSPEED INDICATOR . N/P 1 200-3101-1 . AIRSPEED INDICATOR. . . . 2 1

USEABLE ON CODES

1. MODEL C90A SERIAL NUMBERS LJ-1063 THRU LJ-1137 AND LJ-1146 EQUIPPED WITH RAISBECK QUEIT TURBOFAN PROPELLERS, DUAL AFT BODY STRAKES AND INCREASED GROSS WEIGHT.

APRIL 2004



PAGE 18-2

INCREASED GROSS WEIGHTKING AIR E90

APRIL 1992

2-1



JACKING LIMITATIONS PLACARDKING AIR E90

APRIL 1992

8-2-1PAGE 2



PAGE 38-2-1



FIGURE 1JACKING LIMITATIONS PLACARD

KING AIR E90

APRIL 1992

8-2-1PAGE 2



PAGE 38-2-1



1 91-205 INCREASED GROSS WEIGHT . . N/P 1 REI-1001-5 . PLACARD. . . . . . . . . .1

KING AIR E90




APRIL 1992



PAGE 18-3

INCREASED GROSS WEIGHTKING AIR 100/A100

APRIL 1992

3-1



JACKING LIMITATIONS PLACARDKING AIR 100/A100

APRIL 1992

8-3-1PAGE 2



PAGE 38-3-1



FIGURE 1JACKING LIMITATIONS PLACARD

APRIL 1992

KING AIR 100/A100

8-3-1PAGE 2



PAGE 38-3-1



1 91-207 TURBOFAN PROPELLER . . . . N/P INSTALLATION 1 REI-1001-6 . PLACARD. . . . . . . . . .1 1 2 REI-1001-7 . PLACARD. . . . . . . . . .1 2

USABLE ON CODES

1. MODEL 100 (B-2 THRU B-89 AND B-93).

2. MODEL A100 (B-l, B-90 AND AFTER, EXCEPT B-93).

KING AIR 100/A100




APRIL 1992

3-2



BALLAST INSTALLATIONKING AIR 100

APRIL 1992

8-3-2PAGE 2



PAGE 38-3-2



FIGURE 2BALLAST INSTALLATION

KING AIR 100/A100

APRIL 1992

8-3-2PAGE 2



PAGE 38-3-2



1 91-207 TURBOFAN PROPELLER . . . . N/P INSTALLATION 1 91-5710-101 . WING BALLAST . . . . . . .2 1 */ATTACHING PARATS/* 2 MS27039C0821 . SCREW (OPT NAS220C-21) . .2 1 3 MS27039C0827 . SCREW (OPT NAS220C-27) . .8 1 4 MS27039C0816 . SCREW (OPT NAS220C-16) . .2 1 5 AN960C8 . WASHER . . . . . . . . . .12 1 -------*-------


1. MODEL 100 (B-2 THRU B-89 AND B-93).

KING AIR 100/A100




APRIL 1992

Raisbeck King Air Parts Manual 85-119-D_O

Documents

Transcript of Raisbeck King Air Parts Manual 85-119-D_O