1

Talisman Malaysia Limited

HS&E Section

Job Safety AnalysisDoc. No: PM3-HSE-GEN-PR-F-0108Revision: 0

Date: June 2006Page: Appendix 3

JOB SAFETY ANALYSIS WORKSHEETS

JOB SAFETY ANALYSISDATE PERMIT NO:

JOBRadiographic Testing (RT)

WORK TEAMRT Tech.

SEQUENCE OF BASIC JOB STEPSPOTENTIAL ACCIDENTS OR HAZARDSRECOMMENDED SAFE JOB PROCEDURES

1. Raise the Radiography work permit.Conflict with other activities.

2. Conduct surface preparation.Slip and fall. Use certified access or scaffold.

3. Barricade area for activities.Exposure to radiation.Announcement via PA system to warn others of the coming RT activities in the area.

3. Film placement on weld joint. Handling of radio-isotopes (Gamma-Camera)Back injury.Avoid lifting with your back and avoid body twisting.

4. Performing the radiographic testing (RT) onsite.Isotope stuck in its wind-out remote. (Detective). Exposure to radiation.Standby with Isotope recovery Emergency kit and follow procedures. Adhere to RT shooting procedures.

5. Film processing & interpretation in dark room.Chemical splash.Wear right PPE for handling chemical complete with face shield and goggles.

WHAT TO CHECK AND NOT LIMITED TO WITH REFERENCE TO APPENDIX 1 & 2 OF THE JOB SAFETY ANALYSIS SECTION OF MOGP MANUAL

EXPERIENCEYESNOYESNO

Have you done this job before? /Are you knowledgeable with the job to be performed?/

Have you referred to technical drawing/vendor procedure/SSP?/Is supervision/experienced assistance required?/

PPEYESNOYESNO

Hard hat?/Work vest?/

Safety Glasses?/Apron?/

Safety shoes?/Goggle?/

Ear plugs?/Face shield?/

Right type of gloves?/Respiratory protection?/

Safety harness?/

POTENTIAL HAZARDSYESNOYESNO

Slippery floor?/Trapped pressure?/

Congested area?/Pressurized equipment/vessel hazard?/

Tripping? /Fire/explosion hazards?/

Overhead work?/Escape route?/

Working at height?/Shock/electricity/static?/

Scaffolding?/Breaker rack out?/

Secure ladder?/Valve isolation?/

Heavy load?/Guard rotating equipment?/

Hammer strikes?/Power tools hazards?/

Pinch/trap finger, hand?/High noise area, double ear protection?/

Back injury hazard?/Spark/hot slag?/

Swinging object?/Burn (heat/chemical)?/

Falling object?/Near radioactive materials/sources?/

Others closeby?/Environmental spill?/

Sharp object?/Hose connection?/

Eye injury?/Windy?/

Grating/deck opening?/Dusty?/

Blocked drains?/

Prepared by:......................... Reviewed by: .. Closed out: _________________________

TML MANAGING OPERATIONS WITH GENERAL PROCEDURES

Rev. 0