Radio Equipment Directive (RED) 2014/53/EU Equipment... · (RED) 2014/53/EU Practical approach on...
Transcript of Radio Equipment Directive (RED) 2014/53/EU Equipment... · (RED) 2014/53/EU Practical approach on...
Radio Equipment Directive (RED) 2014/53/EU
Practical approach on implementation:
• CE certificate on June 12, 2017 ?
• Radio products
• Combination radio & non-radio products
20/10/16 Agoria regulations & Standards - Are you RED-y?
Product Validation Expert @ Barco NV [email protected]
Scope, purpose & applicability
Table of content
Scope
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
Purpose
R&TTE RED
◦ Before 13 June 2016 R&TTE
◦ 13 June 2016 – 12 June 2017 R&TTE or RED
◦ From 12 June 2017 onward RED ?
Ensure an efficient use of radio spectrum and avoid harmful interference.
Applicability
Equipment and its (downloadable) software which intentionally emits or receives radio waves for the purpose of radio communication or radio determination
Includes:
◦ broadcast TV and radio receivers
◦ Equipment operating below 9 kHz
RED administrative requirements
Table of content
Scope, purpose, applicability
Admin requirements
Manufacturers shall ensure that radio equipment which they have placed on the market bears a type, batch or serial number or other element allowing its identification
Manufacturers and/or importers shall indicate on the radio equipment their name, registered trade name or registered trade mark and the postal address at which they can be contacted + CE mark.
Manufacturers shall ensure that the radio equipment is accompanied by instructions and safety information in a language which can be easily understood
◦ information includes:
◦ frequency band(s) in which the radio equipment operates
◦ maximum radio-frequency power transmitted in the frequency band(s) in which the radio equipment operates
Manufacturers shall ensure that each item of radio equipment is accompanied by a copy of the EU declaration of conformity or by a simplified EU declaration of conformity.
the packaging shall allow the identification of the Member States or the geographical area within a Member State where restrictions on putting into service or requirements for authorization of use exist
Exclamation mark no longer required
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
Non compliance to RED (art 43)
1. CE marking has been affixed in violation of Article 30 of Regulation (EC) No 765/2008 or of
Article 20 of this Directive;
2. the CE marking has not been affixed;
3. the identification number of the notified body, where the conformity assessment procedure set out in Annex IV is applied, has been affixed in violation of Article 20 or has not been affixed;
4. EU declaration of conformity has not been drawn up;
5. EU declaration of conformity has not been drawn up correctly;
6. Technical documentation is either not available or not complete;
7. Information referred to in Article 10(6) or (7) or Article 12(3) is absent, false or incomplete (see RED admin requirements)
8. Information on the intended use of radio equipment, the EU declaration of conformity or usage restrictions as set out in Article 10(8), (9) and (10) does not accompany the radio equipment (see RED admin requirements)
9. Requirements on identification of economic operators set out in Article 15 are not fulfilled; (see RED admin requirements)
10. Article 5 is not complied with. (procedures in place for series production to remain in conformity with the Directive)
8/10 items are easy rules & paper work Easy to adhere to
Technical documentation: THE challenge !
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
CE certificate on RED ?
Equipment Directive (RED) 2014/53/EU at official EU web site:
https://ec.europa.eu/growth/single-market/european-standards/harmonised-standards/rtte_en
List of harmonized standards under R&TTE: listed in doc 2016/C 249/1 (2016-07-08) 178
List of harmonized standards under RED (2016-10-14): 12
Will also include new series of harmonized standards for
non-Radio Product with Radio module to cover mutual
influence of EMC behavior & radio functionality
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
CE certificate on RED ?
Practically not possible to update CE certificates on 12 June 2017
ETSI standards still needs updates towards RED (status end September):
84 published as ETSI of which 8 as EN (June 2016: 24/0)
11 under vote (June 2016: 83)
5 launch to vote (June 2016: 15)
32 in draft
Tests on end product should be finished by June 11th, 2017
Tests on Radio module for implementation in end product needs to be done months earlier (take into account supply chain / production / logistics)
Use of standards not obliged to proof compliance with directive /alternatives???
Need longer transition period
ETSI std Voting Approval Adoption Publication OJ Publi.
301 489-1 2016-11-15 2017-01-04 2017-01-14 2017-01-28 2017-05-13
301 489-17 2016-08-23
Late!
2016-10-23 2016-10-23 2017-11-06 2017-02-19
300 328 2016-09-14 2016-11-14 2016-11-14 2016-11-28 2017-03-13
301 893 2017-08-04 2017-10-03 2017-10-03 2017-10-17 2018-01-30
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
Radio Products (RP)
Conformity Assessment Procedure (CAP) according EMC harmonized standards & Radio HS:
◦ EN 301 489-1 EMC for radio eq. & services – tech. req.
◦ EN 301 489-17 EMC BB data transmission services
◦ EN 300 328 ERM wide band mod. in 2,4 GHz band
◦ EN 301 893 ERM BB Radio Access Networks/ 5 GHz band
! Use worldwide certified radio modules when exporting outside EU
! Use antenna with exact same gain as module has been tested with if you want to pass the tests
◦ EN 55032 (EMC – emissions)
◦ EN 55024 (EMC – immunity)
◦ EN 60950-1 (Product Safety ITE)
EMC Directive & Low Voltage Directive are covered by RED
But do not omit reference to 2014/30/EU and 2014/35/EU on CE
A lot of customs officials don’t have a clue! (Turkey, Balkan countries...)
Barco Clickshare CSC-1 Full-featured wireless presentation system for high-profile meeting rooms and boardrooms
Wireless transmission protocol IEEE 802.11 a/g/n 2.4 GHZ and 5 GHz
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP /non RP
Conclusions
References
CAP according LVD & EMC harmonized standards on Barco projector HDX-W12
◦ EN 60950-1 (product safety)
◦ EN 55032 (EMC emissions)
◦ EN 55024 (EMC immunity)
Certificate on WiFi module 802.11a/b/g/n according
◦ EN 300 328 (2,4 GHz wide band mod.)
◦ EN 301 893 (5 GHz)
Combined product: WiFi module integrated in projector:
check ETSI EG 203 367
for assessment on combination
Combined RP & non-RP (case 1)
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
Combined RP & non-RP (case 1)
◦ Is RP in the host non-RP not installed in equivalent assessment conditions or not according to the installation instructions for the radio product :
Full reassessment on the combination
! Assessment doesn’t necessarily require testing!
◦ WiFi module tested in laptop but now combined in projector: assessment (emission spectrum host, crosstalk, ground plane, shielding, …)
◦ Use of an antenna not included in original assessment: test!
◦ Deviation from installation instructions assessment and/or test
◦ Change to the design and/or physical layout of the original RP : test!
◦ …
◦ Do the RP and the non-RP of the combined equipment operate at the same time during normal operation of the combined equipment
Full reassessment on the combination, doesn’t necessarily
require testing.
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
Combined RP & non-RP
When Full reassessment by tests is required:
operation modes of the combined equipment during test should:
◦ cause maximum emissions and immunity responses.
◦ reflect the normal operation of the combined equipment as intended by the manufacturer
EMC compatibility (art. 3.1b)
◦ EN 301 489-1 EMC for radio eq. & services – tech. req.
◦ EN 55032 Radiated Emissions only!
◦ EN 61000-3-2 / EN 61000-3-3 Harmonics / Flicker
◦ EN 61000-4-X series
Effectively use & support efficient use of radio spectrum to avoid harmful interference (art. 3.2)
Applicable Harmonized standards on the radio product:
◦ EN 300 328 ERM wide band mod. in 2,4 GHz band
◦ EN 301 893 ERM BB Radio Access Networks/ 5 GHz band
◦ EN 301 489-17 EMC BB data transmission services
◦ others
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
CAP according LVD & EMC harmonized standards on Barco Projector PGWX-62L
◦ EN 55032
◦ EN 55024
◦ EN 60950-1
CAP on RED harmonized stand’s & Radio HS on Barco Clickshare CSM-1
◦ EN 301 489-1
◦ EN 301 489-17
◦ EN 300 328
◦ EN 301 893
Combined product: CSM-1 installed PGWX-62L :
check ETSI EG 203 367
for assessment on combination
Combined RP & non-RP (case 2)
◦ EN 55032
◦ EN 55024
◦ EN 60950-1
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
Combined RP & non-RP (case 2)
Barco Clickshare CSM-1 installed in Projector PGWX-62L
Installation instructions for the radio product : Radio Product CSM-1:
To be used & connected with imaging equipment such as display, projector, LED screen, ...
Usually mounted on the back of the imaging equipment
Assessment:
+ Reuse existing assesment, no extra tests
changes CSM PGWX-62L Combination effect on conformity
plastic cover original different model CSM in plastic cover of PGWX plastics do not have any influence
power cord original original use of the 2 original cables no effect
power supply original AC/DC 230 V AC original AC/DC under plastic cover no effect
ethernet cable shorter version of orginal NA
ethernet cable routed inside under plastic cover no effect
data cable shorter version of orginal NA
data cable routed inside under plastic cover no effect
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
Conclusions
Think of the assessment when selecting your radio product:
Design smart & modular!
◦ Don’t go solder your own boards with radio emitting component, without making a cost trade of between test & certification vs certified module
◦ Select radio product which has been tested in the modes you are going to use it
◦ Use connectors which are stated in the installation manual
◦ Use same antenna or antenna with exact same gain
◦ Implement radio product away from high frequency components
◦ Implement radio product away from power cables & other cables in general
◦ Take the same design approach in all your products enables reuse of (parts) of your assessment
Buy smart:
◦ Check the applicable standards AND THEIR VERSIONS on the certificate of the radio product.
◦ Make sure they are not superseded shortly
◦ Radio standards are updated frequently, do not buy too much stock
When standards are not listed as harmonized yet, use the latest ETSI version as a reference
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
References
Radio Equipment Directive (RED) 2014/53/EU http://eur-lex.europa.eu/legal-content/EN/TXT/?qid=1436887281223&uri=CELEX:32014L0053
EU harmonized standards https://ec.europa.eu/growth/single-market/european-standards/harmonised-standards_en
ETSI EG 203 367 http://www.etsi.org/deliver/etsi_eg/203300_203399/203367/01.01.01_60/eg_203367v010101p.pdf
RED Work programm ETSI (status of standards ) https://portal.etsi.org/webapp/WorkProgram/WorkItemPlan.asp?titleType=all&qSORT=HIGHVERSION&qETSI_ALL=&SearchPage=TRUE&qDIRECTIVE=2014%2F53%2FEU&qINCLUDE_SUB_TB=True&qINCLUDE_MOVED_ON=&qSTOP_FLG=N&qKEYWORD_BOOLEAN=OR&qCLUSTER_BOOLEAN=OR&qFREQUENCIES_BOOLEAN=OR&qSTOPPING_OUTDATED=&butExpertSearch=Search&includeNonActiveTB=FALSE&includeSubProjectCode=FALSE&qREPORT_TYPE=RPLAN&optDisplay=ALL
ETSI EN standards (are for free!!) http://www.etsi.org/standards
InCompliane Magazine http://incompliancemag.com/article/the-eus-new-radio-equipment-directive-red-201453eu/
Table of content
Scope, purpose, applicability
Admin requirements
Non compliance
CE certificate on RED ?
Radio Products (RP)
Combined RP/non RP
Conclusions
References
| youtube.com/BarcoTV
| linkedin.com/company/Barco
| twitter.com/Barco
| facebook.com/Barco
Thank you!
Questions?
www.barco.com