-Synchronizer U1/2A9A14-Local Oscillator U1/2A5-Up Converter U1/2A6-NTIA Filter U1/2A12-RF Driver Modules U3A5/10-RF Amplifier Modules U3A1/2/3/4/6/7/8/9

COVER PSR/MSSR/ANTENNA/EG/CITEL/FUSES

PSR TransmitterSheet 1

PSR Microwave AsssemblyAntennaSheet 2

PSR Receiver SDP

Sheet 3

SBCs/SCDIsFiber Option

Sheet 4A

Remote SiteSheet 5

PSR FMACSheet 6

PSR TCMMSheet 7

MSSR ReceiverSheet 9

MSSR TransmitterSheet 8

-Bi Directional Couplers U6DC1/2-Circulator U6HY3-RF Detectors U6A2/3/4- Waveguide Switch U6S1-Coaxial Switches U6S2/3-Waveguide TR Tube U6Z1/2-Coaxial Limitters U6Z3/4/5/6-Compressor Dehydrator U18-Rotary Joint U35A6-Wx Hi/Lo Switch-HB/LB Polarizer

PSR MSSR Antenna/Engine Generator/Citel

-RF Assembly U1/2A1-Stability Monitor U1/2A2-Downconverters U1/2A3/4-Beam Azimuth STC U1/2A9A13/21-Pulse Compressor U1/2A9A11/19-LOAPs U1/2A9A8/9/10/18

-SBCs 1, 2, and 3 U1/2A9A1/3/4-Ethernet Transceivers U1/2A14/15-Channel UPS U1/2A10-8 Port LAN Repeater U7A6/9A1-SCDIs U7A3/4-4 Port LAN Switch W/FO Transceiver U7A6/9A2-MPS 800 Server U7A7/10-Maintenance RCP

-24 Port Flex Switch-OMT U52-SDT-SIU-DVG LAN Hub-RCPs Tower/TRACON-DVGs-SMC (CENRAP)

-FMAC U7A1/2- Pedestal Junction Box-FMAC Junction Box U31A20-I/O Panel U7A14-FMAC Interface U7A15

-Transmitter Control U4A2A2/5-Transmitter Status U4A2A3/6-Transmitter RF Monitor U4A2A4/7

-Mode Generator-Site Services Interface-Control & BIT-Driver Module-Low Duty Cycle Power Amplifier-Fan And Power Supply Unit-Transmitter Interface-RF Changeover Switch (RFCO)-Plot Extractor Processor

-Receiver Interface Assembly-Sum Difference Control Receivers-Video and Timing-Reply Decoder-Site Services Interface-Plot Extractor Processor-Daughter Card-Monitor Panel

Sheet Link Indicator Sheet IndicatorTo/From Sheet Number

Find NumberUnique Number to assist in locating link

Same Sheet Jump

SBCs/SCDIsTelco Option

Sheet 4B

-SBCs 1, 2, and 3 U1/2A9A1/3/4-Ethernet Transceivers U1/2A14/15-Channel UPS U1/2A10-8 Port LAN Repeater U7A6/9A1-SCDIs U7A3/4-8/24 Port LAN Switch U7A6/9A2-MPS 800 Server U7A7/10-OMT Routers-Radar Lan A/B Routers-Maintenance RCP

Antenna Pedestal Status Sheet 10

-Pedestal Low Temp-Sump Oil Level-Clutch Status-Gearbox A/B Oil Level-Gearbox A/B Oil Over Temp-Drive Motor A/B Over Temp

Antenna HeatersSheet 11

-Sump Heater On/Off-Sump Heaters-Gearbox A/B Heaters

Antenna Drive Control

Sheet 12

-Motor Controller A/B-Pedestal Interface U16-Pedestal Local Control Panel

Antenna Interlock Chain

Sheet 13

-Hatch-Handcrank-Safety Switch-Stow Pin

Antenna Polarizer OB LightsSheet 14

-Linear Control-Linear status-Circular Control-Circular Status-Obstruction Lights

Antenna Az Enc & Wx Beam Sw

Sheet 15

-X Encoder Data Path-Y Encoder Data Path-Wx Beam Switch Control & Stat-Encoder & BEAM Sw PS

Engine GeneratorSheet 16

-Citel Base 1 EG Shelter-Citel Base 2 Radar Shelter-EG Status & Controls

Citel Base 3,4,5,6Sheet 17

-Citel Base 3 ECU (Air Conditioner)-Citel Base 4 Radar Shelter-Citel Base 5 Pedestal Room-Citel Base 6 Telco

Fuse DrawingSheet 18

-FMAC Fuse Panel

ASDP U1A19Status:REX PSSDP PSUPSOver TempCPI ActiveFrame CountCPI Fault

TestSignals to RIC

Front Panel

DWG

Local Oscillator U1A5

Freq Sel

MultDiv

COHO

124.2816

E C B A

3224.32 – 3424.32A

Hi Filt

2:1Comb

497.1331.07

5.182.59

F1

F2

F4

F3

J23.88Mhz

J327.19Mhz

J1 +5dBmRF Mon

Up Converter U1A6

524.32Mhz

15db 14db 37dbWaveformSelect

Frame In/O

ut, CP

I In/Out M

aintains Clutter M

ap in Standby C

hannel

1:2Div

F3/F4

F1/F2

Lo Filt

To Stability Monitor A2

RF DriverU3A5 Chan A

2.7 – 2.9 GHz2.8us SP

89us LP FM Chirp

J1

ASDP U2A19

Status:REX PSSDP PSUPSOver TempCPI ActiveFrame CountCPI Fault

TestSignals to RIC

Front Panel

DWG

Local Oscillator U2A5

Freq Sel Mult

Div

COHO

124.2816

E C B A

3224.32 – 3424.32A

Hi Filt

2:1Comb

497.1331.07

5.182.59

F1

F2

F4

F3

J23.88Mhz

J327.19Mhz

J1 +5dBmRF Mon

Up Converter U2A6

524.32Mhz

15db 14db 37dbWaveformSelect

1:2Div

F3/F4

F1/F2

Lo Filt

To Stability Monitor A2

RF DriverU3A10 Chan B

2.7 – 2.9 GHz2.8us SP

89us LP FM Chirp

NTIA Filter U1A12

NTIA Filter U2A12

BCDE

BCDE

J1

PS U4A6A3 42V

PS U4A7A3 42V

1:2Div

U3A2

1:4Div

U3A15

1:4Div

U3A13

U4DC1

U4DC2

RF Amplifier 1U3A6

J1

RF Amplifier 2U3A7

J1

RF Amplifier 3U3A8

J1

RF Amplifier 4U3A9

J1

RF Amplifier 5U3A1

J1

RF Amplifier 6U3A2

J1

RF Amplifier 8U3A4

J1

RF Amplifier 7U3A3

J1

87W

87W

87W

87W

87W

87W

87W

87W

U4SW1

PS U4A7A1 36V

PS U4A7A2 36V

PS U4A6A3 36V

PS U4A6A1 36V

PS U4A5A1 36V

PS U4A4A1 36V

PS U4A4A2 36V

PS U4A4A3 36V

2:1

2:1

2:1

2:1

2:1

2:1

2.45KW

2.45KW

2.45KW

2.45KW

2.45KW

2.45KW

2.45KW

2.45KW 4.9KW

2:1

4.9KW

4.9KW

4.9KW

9.8KW

9.8KW

U3A12 8:1 Combiner

U4AT2

1.1 – 2.5µs SP19.5KW Min

89µsLP18KW Min

TO U6DC1

Driver A Mon/DivU4A20A1

Detected Driver Sample to TCMM RF Mon Chan A U4A2A4

Driver RF for Testing toStability Mon U1A2

U4AT6

Driver B Mon/DivU4A20A2

Detected Driver Sample to TCMM RF Mon Chan A U4A2A4

Driver RF for Testing toStability Mon U1A2

Figure FO-3. PSR Transmitter Sheet 1 of 18

CHANNEL A

CHANNEL B

Test

SHORTN2

Test Sh 31

Sh 32

SHORTN

Sh 31

Sh 3

Sh 73

Sh 34

Sh 73

Sh 34

Sh 25

Sh 36

Sh 36

Switch

Switch

SWCONTR

Wavesel

Adjust for -17dBmAt Stab Mon

Adjust for -17dBmAt Stab Mon

+14dBm

+14dBm +14dBm

+14dBm

1:2 DivU6A4

Ant Rev

1:2 DivU6A2Fwd

U6AT4

From Sheet 1U3A12

8:1 Combiner

PSR Transmitter Sheet 2 of 18

U6DC1Bi Directional Coupler

U6DC2Bi Directional Coupler

3dBU6AT2

3dBU6AT1

1:4 DivU6A1

1:2 DivU6A3Rev

FWDREV FWDREV

3dBU6AT3

TermU6AT8

CIRCULATORU6HY3

U6AT5Waveguide

Dummy Load

Channel B Detected RF Power levels Forward and Reverse to TCMM RF Monitor Card in Unit 4

Channel A Detected RF Power levels Forward and Reverse to TCMM RF Monitor Card in Unit 4

U6Z2ReceiverProtector

TO RF AssemblyREX Channel B

Chan 3 Weather Hi/Lo to RF Assembly U1/2A1 (Coax)

Low BeamTransfer SwitchU6S1

Rotary JointU35A6

LB

HB

Polarizer

Polarizer

CompressorDehydrator

U18

WXHi/Lo Switch

Orthagonal Port

Orthagonal Port

Bull Gear

Pinion

ClutchGear Box

Drive Motor

A

Pinion

ClutchGear Box

Drive Motor

B

Wx Hi/LoCommand/

Status

WGTransition

Chan 2 Target Hi to RF Assembly U1/2A1 (Waveguide)

Chan 1 Target Lo to U6DC2 (Waveguide)

Chan 4 MSSR SUM Channel (Coax)

Chan 6 MSSR Difference Channel (Coax)

Chan 5 MSSR Control Channel (Coax)

CoaxialTransition

CoaxialTransitionCoaxial

Transition

Pre

ssur

ized

to

rado

me

Target HiTransfer SwitchU6S2

Weather Hi/LoTransfer SwitchU6S3

REX B U2

REX A U1

REX B U2

REX A U1

MS

SR

LV

A A

nten

na2.

8 de

gree

s B

eam

wid

thP

SR

Ant

enna

1.4

D

egre

es B

eam

wid

th

TO RF AssemblyREX Channel A

To/FromSelected

Channels RF Assembly

U6AT6

U6AT7

CoaxialTransition

U6Z1 ReceiverProtector

LimiterZ3

LimiterZ6

LimiterZ5

LimiterZ4

To MSSR

SUM

Difference ∆

Control ΩTo Chan A Stab Mon

To Chan B Stab Mon

Tx Sample to U3 J1

1.1 – 2.5µs SP19.5KW Min

89µsLP18KW Min

Sh 812

Sh 15

Sh 37

Sh 37

Sh 38

Sh 38

Sh 39

Sh 39

Sh 310

Sh 311

Sh 311

Sh 713

Sh 713

PSR Receiver/ASDP Sheet 3 of 18

A3DC1

RF Assembly U1/2A1

Tgt Lo

Wx Hi/Lo

Tgt Hi

A1DC1

A2DC1

1:3

Divider

1:2

Divider

STC A3Z1

STC A1Z1

STC A2Z1

Isolator

A2HY1

5µs

Delay

20dB

A3AT1A2AR1

A3AR1

A1AR1

A2AR1

Interface

Regulator

CCA A4

30dB

LNAs

Stability Monitor U1/2A2

Driver Sample

Up Converter

Tx Sample

Test Path

Test Source

Wx Hi/Lo Ctrl & Status

Tgt Hi/Lo SelectTest

from Sync A B C

J2 J3 J1

14 Bit

A/D

I/Q

Proc

D

163.88

Target Down Converter U1/2A4

P/O Radar Data

Interface

Test

EPROM

I/Q from

Stby Chan

I/Q to

Stby Chan

(5) Doppler

Filters -54dB

(5) CFAR

Doppler

Merge

14 Bit

ACP

Counter

Test

from Sync

A B C

J2 J3 J1

14 Bit

A/D

I/Q

Proc

D

16

163.88

Weather Down Converter U1/2A3

P/O Radar Data

Interface

Test

EPROM

I/Q from

Stby Chan

I/Q to

Stby Chan

Frequencies in MHz:

A = 3224.32 – 3424.32

B = 497.13

C = 31.07

D = 5.18

Point Tgt

Censor

Clutter & AP

Reject Filter

P/O Radar Interface CCA U1/2A9A10

Range

Smoothing

Map

Generation

Map

ContouringWx Data

To SBC

Serial ACP/ARP

From FMACParallel ACP Count

To DSP

Frequencies in MHz:

A = 3224.32 – 3424.32

B = 497.13

C = 31.07

D = 5.18

WEATHER

TARGET

Tgt Data

To SBC

End to End

Test Results

End to End

Test Results

Coefficients

Tgt Hi/Lo RF

We

ath

er

Hi/L

o R

F

Sta

bili

ty M

on

Te

st R

F

Sta

bili

ty M

on

Te

st R

F

P/O

VM

E6

4x B

US

P/O VME64x BUS

P/O VME64x BUS

Sh 16

Sh 14

Sh 211

Sh 29

Sh 28

Sh 27

Sh 210

Sh 11

Sh 11

Sh 413

Sh 413

-17dBm Upconverter

-15dBm Driver

-13dBm Transmitter

-18 dBm

-28dBm

34dB Gain 69dB Gain

Approx

+14 dBm

Gain -30dB

0-72dB

-28dBm

-23dBm

P/O FDP Cable

Weather Alarms

Radar Timing

Synchronizer FPGA

Long Pulse

Compression

Long Pulse

Compression

Target Processing

Weather Processing

Beam and STC

Control & Status

Target and Weather Beam

and STC control to REX

Timing to other channel

Triggers to Front Panel

REX, UPS, Power Supply Status

RIS

Processing

16

P/O FDP Cable

Target Alarms

Sh 416

Control/Status and Maps to/from ASDP

P/O Radar Interface CCA U1/2A9A10

16

16

DSP CCA U1/2A9A8

Fixed STC

(Tgt & Wx)

Clutter

Maps (5)

Merged STC

(Target 0nly)

When 0 Clutter saturates

STC is added

STC/Clutter Map Processing

Adaptive STC

Short Pulse

Only

ASDP SBC/SCDIs Fiber Option Sheet 4A of 18

SBC U1/2A9A01

Tgt Plot

Processor

Wx Plot

Processor

Tracker

Binary

Integrator

VM

E B

US

Doppler

Adaptation

138.1.1.3

138.1.2.3

138.1.1.4

138.1.2.4

LAN A

LAN A

Gigabit Switch

U7A6A1

LAN B

LAN B

Gigabit switch

U7A9A1

5VPS

U7A26

5VPS

U7A27

SCDI AU7A3

4-Port Ethernet

1 2 3 4

U7A4

SCDI B

1 2 3 4

4-Port Ethernet

SCDI A 138 LAN A

138.1.1.1 138.1.2.1 10.1.1.10 10.1.2.10

138.1.1.2 138.1.2.2 10.1.1.11 10.1.2.11

Se

rial

Po

rt

FMAC Chan A

U7A1

See Detail Sheet 6

24VPS

U7A10

Se

rial

Po

rt

FMAC Chan B

U7A2

See Detail Sheet 6

24VPS

U7A11

SCDI A 10 LAN A

LAN A

4 Port Switch

U7A6A2

Channel UPS

220VAC

U2A10

Channel UPS

220VAC

U1A10

Reset

Relay

U7A16

Reset

Relay

U7A17

ASDP PS

U1A9A13

REX PS

U2A11A2

ASDP PS

U2A9A13

UPS 220VAC

A/B

Switch

MPS-800 Server

U7A7

MPS-800 Server

U7A10

LAN B

4 Port Switch

U7A9A2

UPS 220VAC

UPS Status

UPS Status

Reset Command

From SCDI B

Reset Command

From SCDI A

Chan A/B Asterix Data

Chan A/B Asterix Data

Chan A/B Control & Status

Chan A/B Control & Status

22

0V

AC

PS

22

0V

AC

PS

Se

rial

Po

rt

Se

rial

Po

rt

Pa

ralle

l

Po

rtM

on

ito

r

Po

rt

Pa

ralle

l

Po

rt

Mo

nito

r

Po

rt

Kb

d

Mo

use

Kb

d

Mo

use

FUNCTIONS:

1. Combiner

2. Formatter

3. Cont & Mon

FUNCTIONS:

1. Combiner

2. Formatter

3. Cont & Mon

10.1.2.21

10.1.1.20

TCMM Comms

Port J1

MS

SR

Coefficients

To Doppler

Filters

220VAC

REX PS

U1A11A2220VAC

Sh 921

Sh 920

ACP/ARP

Sh 316

ACP/ARP

SCDI B 138 LAN A

SCDI B 138 LAN B

SCDI A 138 LAN B

SCDI B 10 LAN A

Sh 518

Sh 519

SCDI A 10 LAN B

SCDI B 10 LAN B

FO

Tx/R

xF

O T

x/R

x

Single Mode Fiber to Remote Site

Single Mode Fiber to Remote Site

LAN A

LAN B

Tracks

Plots

Weather

+/- 18.5VDC

+/- 8.0 VDC

+/- 18.5VDC

+/- 8.0 VDC

Status

And

Control

Sh 313

Sh 313

TX/Rx data RS-232

To SBC 1 TCMM COMMS Port J1

TX/Rx data RS-422

TCMM Status & Control CCASh 514

Sh 316

422/232

Conv

U13

I/O Transition CCA

U1/2A9A23

J1

J13

Chan/Chan

Termination

ASDP SBC/SCDIs Telco Option Sheet 4B of 18

SCDI AU7A3

4-Port Ethernet

1 2 3 4

U7A4

SCDI B

1 2 3 4

4-Port Ethernet

138.1.1.1 138.1.2.1 10.1.1.10 10.1.2.10

138.1.1.2 138.1.2.2 10.1.1.11 10.1.2.11

Se

rial

Po

rt

Se

rial

Po

rt

SCDI A 10 LAN A

LAN A

8/24 Port Switch

U7A6A2

A/B

Switch

MPS-800 Server

U7A7

MPS-800 Server

U7A10

LAN B

8/24 Port Switch

U7A9A2

Chan A/B Asterix Data

Chan A/B Asterix Data

Chan A/B Control & Status

Chan A/B Control & Status

22

0V

AC

PS

22

0V

AC

PS

Se

rial

Po

rt

Se

rial

Po

rt

Pa

ralle

l

Po

rtM

on

ito

r

Po

rt

Pa

ralle

l

Po

rt

Mo

nito

r

Po

rt

Kb

d

Mo

use

Kb

d

Mo

use

FUNCTIONS:

1. Combiner

2. Formatter

3. Cont & Mon

FUNCTIONS:

1. Combiner

2. Formatter

3. Cont & Mon

10.1.2.21

10.1.1.20

MS

SR

Sh 921

Sh 920

SCDI B 10 LAN A

Radar LAN A Router

Sh 518

Sh 519

OMT Router

Radar LAN B Router

LA

N A

LA

N B

TELCO

Fractional

T1

TELCO

56kDDS

TELCO

Fractional

T1

SCDI A 10 LAN B

SCDI B 10 LAN B

OMT

Radar LAN A Router

OMT Router

Radar LAN B Router

A

B

B

A

138.1.1.3

138.1.2.3

138.1.1.4

138.1.2.4

LAN A

LAN A

Gigabit Switch

U7A6A1

LAN B

LAN B

Gigabit switch

U7A9A1

5VPS

U7A26

5VPS

U7A27

SCDI A 138 LAN A

FMAC Chan A

U7A1

See Detail Sheet 6

24VPS

U7A10

FMAC Chan B

U7A2

See Detail Sheet 6

24VPS

U7A11Channel UPS

220VAC

U2A10

Channel UPS

220VAC

U1A10

Reset

Relay

U7A16

Reset

Relay

U7A17

ASDP PS

U1A9A13

REX PS

U2A11A2

ASDP PS

U2A9A13

UPS 220VAC

UPS 220VAC

UPS Status

UPS Status

Reset Command

From SCDI B

Reset Command

From SCDI A

220VAC

REX PS

U1A11A2220VAC

Sh 316

ACP/ARP

Sh 316

ACP/ARP

SCDI B 138 LAN A

SCDI B 138 LAN B

SCDI A 138 LAN B

+/- 18.5VDC

+/- 8.0 VDC

+/- 18.5VDC

+/- 8.0 VDC

TX/Rx data RS-422

TCMM Status & Control CCASh 514

SBC U1/2A9A01

Tgt Plot

Processor

Wx Plot

Processor

Tracker

Binary

Integrator

VM

E B

US

Doppler

Adaptation

TCMM Comms

Port J1

Coefficients

To Doppler

Filters

Tracks

Plots

Weather

Status

And

Control

Sh 313

Sh 313

TX/Rx data RS-232

To SBC 1 TCMM COMMS Port J1

422/232

Conv

U13

I/O Transition CCA

U1/2A9A23

J1

J13

Chan/Chan

Termination

Remote Site Sheet 5 of 18

SDT-A

24 Port Flex SwitchLAN A**Single Mode Fiber

from Local Site

LAN B* 24 Port Flex Switch

Eth

erne

tTr

ansc

eive

r

SBC

NIC LAN A

NIC LAN B

UNIO ARTS A

UNIO ARTS B

DVG LAN A Hub

OFF

SIT

E L

AN

A

OFF

SIT

E L

AN

B

10.1.1.33

10.1.2.33

SDT-BE

ther

net

Tran

scei

ver

SBC

NIC LAN A

NIC LAN B

UNIO ARTS A

UNIO ARTS B

DVG LAN A Hub

10.1.1.49

10.1.2.49

10.1.1.14

10.1.2.14

*Single Mode Fiberfrom Local Site

OMT 1Short Haul

ModemShort Haul

Modem

TRACON RCP

TOWER RCP

Nunio Hub Nunio10.1.1.32

10.1.2.32

SIU-AModem

56k DDSModem

56k DDSModified

CD-2 FormatARTS IIIE

STARS

Nunio Hub Nunio

SIU-BModem

56k DDSModem

56k DDS

Maint Port96008 bit

NoneXon/Xoff

Maint Port

96008 bit

NoneXon/Xoff

DVG-1 DVG-2

DVG LAN A

DVG-5

DVG LAN B

DVG6-12

SMC

TELCO

TELCOModifiedCD-2 Format

Local Control

Unit LCU

Remote Control

Unit RCU

SWITCHPair 1

192.

9.20

0.1

192.

9.20

1.1

MAPPER

192.

9.20

0.2

192.

9.20

1.2

DVG-3 DVG-4

SWITCHPair 2

192.

9.20

0.3

192.

9.20

1.3

D-BRITE

192.

9.20

0.4

192.

9.20

1.4

ARTS IIE

J11J15J19

SDT Chassis

J09J13J17

J12J16J20J10J14J18

SDT-A B Output Modified CD-2 Data

DVG LAN A

DVG LAN B

CMC

SDT-A A Output Modified CD-2 Data

SDT-B B Output Modified CD-2 Data

SDT-B A Output Modified CD-2 Data

192.

9.20

0.20

119

2.9.

201.

201

Alpha Numerics

Reconstituted Raw Beacon

192.

9.20

0.50

192.

9.20

1.50

192.

9.20

0.5

192.

9.20

1.5

192.

9.20

1.6-

12

Control Unit

VDCU VDCU VDCU VDCU

Search PretriggerDaisy chained

SearchPretrigger

ACPsARPs

TriggerSearchBeaconWeatherACPs/ARPs

Search PretriggerSearch VideoBeacon VideoWeather Video

ACPs/ARPs

Alpha N

umerics

Alpha N

umerics

Sh 418

Sh 419

192.

9.20

0.6-

12

PSR FMAC Sheet 6 of 18

P/O PedJunction Box

U16

A5,6,7,8,9,10Input Modules

FMACJunction Box

U31A20

FMA

C In

terfa

ce U

7A15

Antenna Commands-Linear Polarization Select-Circular Polarization SelectAntenna Status-Beam Switch-Obstruction Light-LB Circular/Linear-HB Circular/Linear

Pedestal Control-Local Control EnablePedestal Lube Status-Pedestal Temp-Sump Oil Level-Gearbox A/B Overtemp-Gearbox A/B Oil Level-Encoder X/Y PS

E/G Control-Emergency Power Off-Run/StopE/G Status-System Ready-Running-Minor Trouble (Alarm)-Major Trouble (Shutdown)-Transfer Switch Status-Fuel Tank Level Not Low-Fuel Tank Not Leaking-Transfer Switch Om-Commercial Power

UPS Control-Emergency Power OffUPS Status-On Inverter-Load On-Battery Low-I/P Voltage Failure-On Battery-Summary Fault-MDP CB1 (UPS Rect,IP-Closed

Fire Alarm Controller-Radar Room Temp Normal-Radar Room No Smoke/No Fire-Pedestal Room No Smoke/No Fire-E/G Room Temp Normal-E/G Room No Smoke/No Fire-Pedestal Room Temp-Fire Alarm System Trouble-Overall Fire Alarm Status

Antenna 24 Volt Status-Stow Pin-Safety Switch-Hatch-Hand Crank-Interlock D Complete-24 Volt A/B PS

Motor A/B Control-Stop/Start Motor A Rotation-Stop/Start Motor B Rotation-Motor A/B ResetMotor A/B Status-Motor A/B Run-Motor A/B Speed-Motor A/B Overtemp-Motor A/B Current-VSD A/B Alarm

Site Status-AC 1-4 Not Failed-Main CB ClosedDoor Closed-Site Gate, Radar RoomPedestal Room, E/G RoomTemperature Status-Radar, Pedestal,E/G Room

Compressor Dehydrator Status-WG Pressure Status-Compressor Status-Dehydrator Status

Heat & Smoke Detectors

Transmitter Power MonitorTo A/D Converter A10-A Short Pulse-A Long Pulse-A Reverse-B Short Pulse-B Long Pulse-B Reverse

P/O I/O PanelU7A14

A11,12Output Modules

FMAC A U7A1

Azimuth Distribution

A15A17 A16

A14PS

Az Data fromEncoder X & Y

Relay Control to SCDI A Relay FMAC B U7A2

Azimuth Distribution

A15A17 A16A14

PS

Az Data To MSSRand PSR Chan B

A1Power Supply

A2CPU

A3RS-232 Comm

Module

To SCDI ASerial Port

A5,6,7,8,9,10Input Modules

A11,12Output Modules

A1Power Supply

A2CPU

A3RS-232 Comm

Module

To SCDI BSerial Port

P/O

I/O

Pan

elU

7A14

FMAC 24 V PS220VAC

FMAC 24 V PS220VAC

Relay Control to SCDI B Relay

Az Data To MSSRand PSR Chan A

Sh 4

Sh 4

Sh 4

Sh 4

Sh 4

Sh 4

FOR MORE DETAIL, REFERENCE:PSR Manual TI6310.57 Table 2-19

PSR TCMM Sheet 7 of 18

TransmitterControlChan AU4A2A2

TransmitterStatusChan AU4A2A3

TransmitterRF Monitor

Chan AU4A2A4

TransmitterControlChan BU4A2A5

TransmitterStatusChan BU4A2A6

TransmitterRF Monitor

Chan BU4A2A7

Low Beam SwitchU6S1

High Beam SwitchU6S2

Weather SwitchU6S3

Driver Select SwitchU4S1

Tx Amp Power Supplies (8)

Tx Driver APower Supply

Chan A I/O Transition

RS-422 – RS-232Link to ASDP

Ch ARF GATE

CH. SEL

S1 Ch AON

S2 Ch BON

Ch BRF GATE

A

B

TCMM Circuit Card Location

Pedestal SafetyInterlock

Input Disable N

ot

Dis

able

Out

Low Beam

High Beam

Weather

Driver

Cha

nnel

Cha

nge

Sw

itche

s

Switch Status

Interlock Chain

-Driver Select Indicator-High Beam Indicator-Low Beam Indicator-Weather Indicator

Tx Amp Modules (8)

Tx Driver BPower Supply

Alt

RF

Driv

er F

ail

RF DetectorsU6

-Antenna Reverse Power-Transmitter Reverse Power-Selected Driver Power-Transmitter Group Power

Driver LED

RF Gate Front Panel Not

RS-422 to FMAC A/D

-A/B Short Pulse-A/B Long Pulse-A/B Reverse

-Weather Position Fault-Low Beam Position Fault-High Beam Position Fault-Driver Position Fault-Antenna Reverse Power Fault-Trans Reverse Power Fault-Pulse Width Fault-Duty Cycle Fault-Interlock Fault-Driver RF Power Fail-LP Pulse Width Range MSB-LP Pulse Width Range LSB-SP Pulse Width Range MSB-SP Pulse Width Range LSB

TransmitterCabinet U3

Cabinet UndertempCabinet UndertempWarning 1

5/30 V Power Supplies

Power SupplyDC 1/2 Fault

Power SupplyDriver 2 Fault

Tx Driver AModule

Power SupplyDriver 1 Fault

Amp RF OutSum Fault (8)

Power SupplyFault

Driver RF OutSum Fault

Power SupplyDriver Blank

-RF Gate (8)-RF On (8)

-RF Gate-RF On

Power SupplyBlank

RXD

TXD

RS

-422

RS

-422

Alternat DriverRF Power Fail

Emergency Inhibit Not

-Emergency Inhibit Reset Not-RF Gate Out-Enable Out Not-Blank

NOTE:This drawing is showing Channel A connections and not channel BThe Chan B TCMM cards are shown only as a reference to Chan A

Sh 6

Sh 2

Sh 4

CO

NTR

OL

STA

TUS

RF

MO

N

CO

NTR

OL

STA

TUS

RF

MO

N

CHAN A CHAN B

From CHAN B RF Mon

Driver LED

+5V+30V-15V

+5V+30V-15V

+5V,+30V,-15VPower Supply

4A3A1

+5V,+30V,-15VPower Supply

4A3A2

+30VCB32

+30VCB35

S1C S2C

+5VCB31

+5VCB34

S1B S2B

4A2A

8-E

5V1

4A2A

8-E

6V2

-15VCB33

-15VCB36

S1A S2A

4A2A

8-E

7V1

4A2A

8-E

8V2

4A2A

8-J6

5-1

4A2A

8-J6

5-2

BA

CP

LAN

EB

ehin

dC

B P

anel

LOOPDATARS-232

P1 C23 P1 C11

Driver Module 807888/005

Transmitter Interface 807890/010

PE and Receiver Frame Assembly 808282/058

Control and BIT 807893/002

Fan and Power Supply Unit808363/000

RFCO 808499/054

Mode Generator 808163/003

VCO/ Modulator

Low Duty Cycle Power Amplifier 808125/003

D26

D23

D20

D21

D19

D16

D17

D18

TX Power Supply808316/001

+52V

Multi Output Power Supply808315/001

+5V+28V+/-15V-5.2V

Fan Fail 808364/002

Transmitter BIT: Driver Phase/AmplRF Pulse AmplitudeRF Pulse WidthOvermodulation

Power Supply BIT:Power Supply FaultsFan FailPSU Overtemp

Receiver BIT: Gain 3 dB High or LowNoise MonitorLocal Oscillator

Coupler

Coupler

Σ Fwd

Ω Fwd

Σ R

ev

RF Detector

Temperature Sensor Assy

Monitor/ Regulator

1.25 kW 3.8 kW80 W

System Trigger

14 Bit AzimuthFrom VT

ModulationPulses

RFCO Select/Fault

LRU Fault IndicationSee TI 6310.53

Section 2.8 Table 4

+15

-12

+12

-15PSU Shutdown

Status/Mode In

Status/Mode Out

J27

J28

J29

Coupler

Mode Idents/ Mode Bits

J32

J47

1030 MHz CW Signal used for SSR Transmissions and Receiver LO

1. Produces all Interrogation Pulses

2. Disables Transmitter Output during Sector Inhibit and RF OFF.

3. Generates Mode B with receipt of APM Trigger

4. Generates Triggers:

Internal 50 – 500 HzSelf Test @ P3-32μsSystem @ P3-143μsDisplay @ P3+4μsSTC and RG @ P3+3μsVT/PE @ P3-30μsSLS @ 0-1.5µs before P2

1. Monitors Fan Current:FAN FAIL 1 and FAN FAIL 2 Signals2. Monitors +5V Current from MVPS3. Provides +65V Reference for LDPA Regulator4. Provides -70 for PIN Diode Switch in TX Interface

APM Trigger16MHz Clk

Synth Tgt Modfrom VT

1. Responds to Control Information from asynchronous RS232 Serial Data Link

2. Transfers Control Information to appropriate LRU

3. Loads Site Parameters across Serial Data Link and Stores in EEPROM. Programs Mode Gen with PRF and MIP.

4. Monitors System Parameters and Sends Fault Message to PE.

5. Reports Opposite Channel Status to PE. Performs Channel Change when instructed by PE.

6. Provides Local Interface for FIT Results

10W

10W

10W

1030

MH

z LO

1030 MHz

SK31030 MHz

PRF/Mode Interlace Pattern

Site Services Interface 808366/000

Sel’d Mode

This Chan Status/ Opp TX Disable

This TX Disable/Opp Chan Status

To VT

Plot Extractor ProcessorSBC 808365/0011. Status Monitoring2. FIT3. Instigates Channel Change4. Flash EPROM stores Commissioned Set

8

RS

232

Condor MSSR Interrogator 808136/005

+28

Band Pass Filter

Self Test Oscillator

Self Test Coupler

Fwd Pwr Coupler

1:3 Divider

SLS PIN Diode Switch

0-15 dB

Log Amp 1 of 4 Select

STO Modulation/ 30 dB In/Out

from Mode Gen

Front Panel Sensitivity Adjust

Front Panel Power Adjust

TX Samples to Control & BIT

DetectedTX Samples

90° Phase Shift

SLS Switch Gatefrom Mode Gen

1. 4μs Pulse at -53dBm during RX Self Test(P3 - 32μs)2. SIF and M-4 Reply Pulses at -83dBm on Standby Channel

1090 MHz

Fwd/Rev Sel/SLS Trig from Mode Gen

Self Test Coupler

Self Test Coupler

Fwd Pwr Coupler

To Receiver Modules

To/From Channel B

ToAntenna

Σ

Ω

Δ

Σ

Ω

Δ

Ω R

ev

4 Cooling FansTo TX

Interface

12dB 5dB

+52V

BIT

BIT

BIT

BIT

BIT

J5PL1

PL2

Σ Ω Δ

RFCO Select

Σ Ω Δ

Display Trigger

Mode Idents

J15 J14 J12

TP1 TP5

Mod TTL

SLS Gate

J32

J47To

Control & BIT via Site

Services Interface

BITDetected RF SamplesTemperature Faults

Regulator OvercurrentTo Control & BIT

MSSR Transmitter Sheet 8 of 18

To RX Interface

A

A

A

A

From Receiver Modules

TX Samples from TX Interface

B

B

C

C

C

C

J10

TX Enable from Pedestal I/F Panel

Mode

+52V Inhibit Sh 412

Sh 412

Sh 412

Sh 10

Sh 923

Sh 924

Sh 925

Sh 926

Sh 927

PE and Receiver Frame Assembly 808282/058

Control RX 807891/001

Difference RX 807891/001

Sum RX 807891/001

32

Site Services Interface 808366/000

Receiver Interface Assembly 807899/002

Video and Timing807894/006

Reply Decoder 807896/000

Plot Extractor Processor Single Board Computer 808365/051

Daughter Card 808365/052

1:3Divider

A/D A/D A/D

Control & Monitor System (CMS)

J48

J38

J49

J44

J39

J43

J33

Ch 0 – Cross-Channel Comm (Data/Control)

Ch 2 – Target Reports to SCDI-B

Ch 5 – Control/Status to SCDI-A

Ch 6 – Target Reports to SCDI-A

Ch 7 – Data (Not Used)

Ch 3 – Data (Not Used)

Ch 1 – Control/Status to SCDI-B/CMS

Mul

tibus

II

PCI Bus

Clock Fail

PRF Fail

Self Test Fail

Azimuth FailSynthetic Data

Video Self Test

Synthetic Target

North Ref

Invalid Mode

ACP Warning

System Test

SIF Bracket Detect

M4 Triplet Detect

Σ 8-Bit Video

Δ 8-Bit Video

Ω 8-Bit Video

PCB OK

BIST RUN Error

Video Mon

Σ 60 MHz IF Δ 60 MHz IF

Monopulse Sign Bit

Confidence Bit

1. Video Processing

2. Thresholding

3. Bracket Detection

4. Reply Decoding

5. SVA/SDR Generator

6. Azimuth Counter

7. STC Application

8. RSLS

9. Defruiter/Degarbler

10. Range Zero Determination

14-Bit Azimuth

1030 MHz LO from Driver Module

14-Bit Azimuth to Control &

BIT

16 MHz Clock

1090 MHz Rx Signal from Transmitter Interface

Replies and Status Data BlocksMode, Code, AZ, Range

1. Reply-to-Reply Correlation

2. Scan-to-Scan Tracking

3. False Target Elimination

4. Target Formatting

5. Status Monitoring

6. Interfaces w/ Opp. Channel Plot Extractor

7. Flash EPROM stores Commissioned Set

Comms Links:

1. ASTERIX Formatted Target Reports

2. Cross-Channel Communications

3. Status and Control to CMS/SCDI

Phase Monitor4μs Zero Beat Signal

at P3-32μs

J7

14-B

it A

zim

uth

Azimuth Data In from FMAC A

Cont/Status

Phase Detect

RL180° 0°

1. 16 MHz Clock

2. Interfaces signals from RXs and Mode Gen to Reply Decoder

3. Self Test and Synthetic Target Data Generator

4. Initiates APM

5. Azimuth Data Distribution

6. Monitors AZ Data, Triggers, and Clocks

7. Distributes System Reset with S/W Reset

8. Invalid Mode Interrupt

Σ/Δ Phase Relationship

BS

C:\CMS

\TMC \TML \CHL \SET \APM

CHAN_A.TMCCHAN_B.TMC

SITE.TMC

A*.SET

B*.SET

1. Divides 1030 MHz LO

2. Provides Monopulse Sign Bit (Right =1, Left = 0)

3. Provides Confidence Bit (BS +/- .22° = 0)

RF Amp 14 dB

IF Amp 18 dB

Log Amp80 dB

MAKES A TARGET REPLY FOR EACH AIRCRAFT DETECTED

8-Bit Video

J34

Ch 4 – Cross-Channel Comm (Data/Control)

To/From Channel B

A/B

Video Mon

Video Mon

Condor MSSR Interrogator 808136/005

BIT

To Control & BIT

Target Message Format:TI 6310.56, Section 4, Annex A Tables 6 and 7

CORRELATES ALL REPLIES WITHIN A GROUP Raw and

Polished Target

Messages

16

Mode Bits

16 MHz Clock

Range Zero Pretrigger

Monopulse Sign

To Mode Generator:APM Trigger16MHz Clk

Synth Tgt Mod

Mode Idents/Bits from Mode Generator

From Mode Generator:

VT Trigger @ P3 - 32μs

From Site Services Interface:

Selected Mode BitsS/W Reset

Multibus II Reset

Internal Reset

Mode Bitsto VT

Sel’d Mode

S/W Reset

/CRST to PE

From Site Services Interface:

/CRST Reset

To PE

J33

J34

`

MPS800B

MPS800A

B

B

MSSR Receiver Sheet 9 of 18

A

RX BIT: RX Gain +/- 3 dBNoise MonitorAnalog to Digital FaultLO Monitor

Monitor Panel

BP

Mode Idents

Bracket Detect

SIF PSV

Triplet Detect

Bracket Detect Selected Mode Idents

CH 0 Debug Port

J2

Azimuth Out

32

To VT

A

SW1

Modeto/from

Opp Ch

Mode Selection from Multibus

J10

Rad

ar B

lank

ing

Mul

tibus

II In

terfa

ce

PCB OK

TX Enable from Pedestal I/F Panel

ADG/NMK Faults

J7

Range Listening Interval

BIST RUN

PL62 to PE SBCPL663 ½” Disk Drive

J38

A/B

01

00

Sh 827

Sh 826

Sh 825

Sh 824

Sh 823

Sh 10 Sh 6

Sh 420

Sh 421

ANTENNA PEDESTAL STATUS Sheet 10 of 18

A

S3Status

S2GB OL

GB OT

Pinion

MotorOT

Clu

tch

Gea

r Box

Driv

e M

otor

AU

35B

1U

35A

1

3 Ret4 Sig1 +24

S3Status

S2GB OL

GB OT

Pinion

MotorOT

Clutch

Gear B

oxD

rive Motor B

U35B

2U

35A2 Ret 3

Sig 4+24 1

S2J2 S2J2

B

Junc BoxU35A4

1

3

A

B

A

B

A B

4

1

3

Motor A Overtemp - A

Motor A Overtemp - B

Gearbox A Overtemp - A

Clutch A Engaged - 3

Gearbox A Overtemp - B

Clutch A Engaged - 1

Gearbox A Oil Level

24v

24V Return

A

TB2

1

2

3

4

5

6

7

8

9

10

4700

Junc BoxU35A5

4

1

3

Motor B Overtemp - A

Motor B Overtemp - B

Gearbox B Overtemp - A

Clutch B Engaged - 3

Gearbox B Overtemp - B

Clutch B Engaged - 1

Gearbox B Oil Level

24V

24V Return

B

TB2

1

2

3

4

5

6

7

8

9

10

4700

Pedestal U35

24V Return

24V

Sump Oil LevelC

3

1

4

35A6S6 -10CPed Low Temp

SUMP/BULLGEAR

DPed Lo Temp

Ped Lo Temp Ret

Pedestal JB

U35A3TB2

TB3

J1

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

24V R

et

G

K

N

L

P

H

F

J

U

S

Q

10

9

8

TB4

4700

Pedestal Local Control Panel

U34

A1 Oil Level Transition Module

GB AOil

Level

24V

GB BOil

Level

0V

0V TB3-23

24V

G

K

N

L

P

H

F

J5

J

U

S

Q

J17

J18

Motor A Overtemp

0V 7A15 FIP

Motor B Overtemp

24V 7A15F2

0V 7A15Status Ret

J16Clutch A

Clutch B

GB A OT

GB B OT

J

H

B

A

D

SumpOil

Level

0V

G

C

1

3

A

B

A

B

CRet 3Sig 4+24 1

35S2Sump Oil Lvl

Ped Lo Temp

Ped Lo Temp RetD 10

4K5

TB3-9 0V(7A15)

TB3-13 24V(7A15F2)

Pedestal Temp LoM M

TB3-13 24V(7A15F2)

W1701C

T

K

S

f

N

S

H

F

G

A

B

D

C

A3A5-E2/L2

A3A11-N

A3A4-E1/L1

A3A11-L

A2A6-E2/L2

A2A7-E1/L1

A1A11-N

A1A8-E1/L1

A1A7-E1/L1

A1A10-E2/L2

A1A10-E1/L1

A1A9/E1/L1

A1A9-E2/L2

T

K

S

f

27

17

26

1

N

S

H

F

G

A

B

D

C

5

3

11

4

12

2

1

TransientProtection

U31A12

16

19

TransientProtection

U34A1

A2A9-E1/L1

A2A11-N

A2A9-E2/L2

A2A11-L

A2A1-E2/L2

A2A2-E1/L1

A1A5-N

A1A3-E2/L2

A1A3-E1/L1

A1A4-E2/L2

A1A4-E1/L1

A1A2-E2/L2

A1A1-E2/L2

T

K

S

f

T

K

S

f

N

S

N

S

H

F

G

A

B

D

C

H

F

G

A

B

D

C

W1701B W1701A

W1601C W1601B W1601A

W1802C W1802B W1802A

Motor O

T Ret

PedestalInterface

U16

27

17

26

1

J6 J3 J6 J12 J8

J5 J2 J5 J11 J5116

19

J4 J1 J2 J85

3

16

4

17

2

1

J10

Clutch A

Clutch B

Motor A Overtemp J1-27

0V 7A15 FIP J9-28

Motor B Overtemp J1-8

24V 7A15F2 J9-29

0V 7A15Status Ret

GB A OT

GB B OT

GB A OL

GB B OL

Sump OL

Ped Low Temp

CEC Unit 7A15FMAC Interface

W2001

28

29

J5

0V FIP

24V F2

Motor A OT

Motor B OT

5

18

J52

W2002

ANTENNA HEATERS Sheet 11 of 18

Pinion

Clu

tch

Gea

r Box

Driv

e M

otor

AU

35B

1U

35A

1

S2GB OL

Pinion

Clutch

Gear B

oxD

rive Motor B

U35B

2U

35A2

Junc BoxU35A4

A B

Junc BoxU35A5

Pedestal U35SUMP/BULLGEAR

Pedestal JBU35A3

Pedestal Local Control PanelU34

1

2

3

4

5

6

9

10

TB1Htr 5,6,7 Phase 1

Htr 1 & 2 Phase 2

Htr 5& 6 Neutral

Htr 7& 1 Neutral

Htr 2 Neutral

GB A Htr Neutral

GB A Htr Phase 1

B

35HTR3

35HTR4

35HTR8

35HTR9

C

HTR1

B

35HTR1

35HTR7

35HTR6

35HTR5

35HTR2

HTR1

TB11

2

3

4

5

6

9

10

J3

A

B

C

D

E

C

B

A

J2

To D

P3

CB

4

TB1Htr 4 Phase 2

Htr 8,9,3 Phase 3

Htr 4&8 Neutral

Htr 9 Neutral

Htr 3 Neutral

GB B Htr Neutral

GB B Htr Phase 1

C

2

3

4

5

6

9

10

Htr Off +15C

Htr On +5C

Htr Com1

2

3

P/O TB4X

T

Y

P/O J1

K4

To D

P3

CB

1/2

/3Phase 1Phase 2

Phase 3

TB1-31TB1-32 Neutral

Ground

To D

P3

P/O J5

0V (7A15)

m

n

24V (7A15F4)

TB3-8 0V(7A15)

TB3-12 24V(7A15F2)

Off/Latch +15C

On +5C

Com

X

T

Y

35A6S6 +15CSump Htr Off

35A6S5 +5CSump Htr On

Htr Off

Htr On

Htr Com

CB

Heaters On

J17

NOTE: Wires appear to be crossed.

Will work the way it is shown

m

n

TransientProtection

U31A12

TransientProtection

U34A1

A3A12-L

A3A12-Nm

n

m

nW1701B W1701AW1701C

PedestalInterface

U16

A3A1-N

A3A1-L

J6 J3 J6 J12 J8 J921

22

21

22

31

32

7 8Test

Points

W2001To FMACJ5-31/32

ANTENNA Drive Control Sheet 12 of 18

Motor A Start

InterlockComplete

ControlRemoted

PanelControl

HeatersOn

Motor BStart

Stop Stop

Encoder X Encoder Y

Wx BiasPS Polarizer

ReleaseControl

Pedestal Local Control PanelU34

ReleaseControl S7

Pinion

ClutchGear BoxDrive Motor AU35B1 U35A1

Pinion

ClutchGear BoxDrive Motor BU35B2 U35A2

A

B

Pedestal U35

SU

MP

/BU

LLGE

AR

DP4 CB 2/4/6

DP5 CB 2/4/6

Motor Controller A

U14

Motor Controller B

U15

W00543 Phase 380VAC

W00553 Phase 380VAC

Transient ProtectionPanel U31A12A1

(Outside)

4

5

6

Mezzanine Room

1

2

3

TB4

W041B

W042B

W041A3 Phase 380VAC

W042A3 Phase 380VAC

W041C3 Phase 380VAC

Variable Frequency for Antenna Speed

Pedestal InterfaceU16

Antenna Safety SwitchU35S1

TB14

5

6

1

2

3

TB1

4

5

6

1

2

3

TB2TB2

R

S

K7

K5

K1

Stop

Start

A R

un Status

10J6 J7

K3

DriveEnable

Reset A

Interlock Com

plete

64 824 8 10

K6

B R

un Status

24

Transient ProtectionU34A1

Transient ProtectionU31A12

W042C3 Phase 380VAC

Variable Frequency for Antenna Speed

Radar Shelter

Motor A StartMotor A StopMotor B StartMotor B Stop

SCDI Control Enable

Interlock Complete

R

S

K2Stop

Start

6

K4Reset B

4

J9

12

13

47856

CR

14C

R2

CR4

CR7

CR

3

CR

13C

R1A

Interlock Complete

14+13-

12+9-

K2Shown in Local

Control

24V TB3-117A15F2

0V 7A15

24V TB3-107A15F2

11

10

Local Control EnableLocal (PLCP) Control Enable

24V TB3-137A15F2

8

45

1

S5

S6

Motor A StartMotor A Stop

Motor B StopMotor B Start

Local Control StatusDS3 DS2

ControlRemoted

DS1Local (PLCP) Control Status

Interlock Complete

A2A8-E1/L1

A2A11-E2/L2A3A8-E2/L2

A2A12-E1/L1A2A13-E2/L2A2A11-E1/L1A2A12-E2/L2A3A9-E2/L2

A2A8-E1/L1

A2A5-E2/L2A3A5-E2/L2

A2A6-E1/L1A2A7-E2/L2A2A5-E1/L1A2A6-E2/L2A2A4-E2/L2

J12 J6 J3 J6

820

J11 J5 J2 J521 U U U

J5U

J17

11129

106

Ee

HJFGC

Ee

HJFGC

Ee

HJFGC

Ee

HJFGC

W1601 B

J8

820

11129

106

W1601AJ5121

CEC Unit 77A15

24

J5

244

7856

12

24V 7A15F330

13

30

CR6

MSSR A TX Enable

MSSR B TX Enable

PSR TX Enable

J3

J5

J4

CR5

For More Details, See Pedestal Interface

U16 schematic Located in TI 6310.57

Sec 7R

A

A

28 B0V 7A1528

B

B

B

B

B

Modules may be located outside

U31A12A1

W1601 C

Sh 1328

W1701 CW1701 BW1701 A

ANTENNA Interlock Chain 13 of 18

Pedestal Local Control PanelU34

Mezzanine

Transient ProtectionU34A1

Radar Shelter

DS1InterlockComplete

Safety Switch

U35S1

Pedestal Room

Antenna

Deck H

atchU

35S3H

and Crank

U35S

4S

tow P

inU

35S2

U35A3

TB26

5

7

U35A4

10

TB4

6

5

7

10

6

5

7

TB2

J1

R

C

F

E

A

C

D

A

B

J13

J5

J15A

C

B

F

E

C

F

R

A

J16

C

TB3-23

L

J18

J1724V 7A15F1A

E

J16B

0V 7A15

Interlock Chain

Interlock Chain

Interlock Chain

Interlock Chain

Status

Status

Status

Status

H

J

K

0V 7A15

J17

C

B

B

0V 7A15

A

C

B

E

H

J4

J6

C

L

J

K

BJ5

A

C

B

E

H

J1

J3

C

L

J

K

BJ2

Stow Pin Status

Safety Sw Status

0V for Safety Sw

0V for Hatch

Hatch Status

Hand Crank Status

0V for Hand Crank

Interlock 24V

Interlock 0V

Interlock Status

A1A7-E1/L1

A1A8-E2/L2

A1A6 N

A1A6-L

A1A11-E2/L2

A1A2-E1/L1

A1A5-N

A2A10-L

A2A10-N

A2A4-E2/L2

Transient ProtectionU31A12

A

C

B

E

H

J2

J6

C

L

J

K

BJ5

A2A1-E1/L1

A2A2-E2/L2

A2A9-N

A2A9-L

A2A5-E2/L2

A1A8-E2/L2

A1A11-N

A2A10-L

A2A10-N

A3A9-E2/L2

3

14

22

9

J112

13J8

5

4

6

5

J12

W1601B

W1802B

W1701B

W1601C

W1802C

W1701C

W1601A

W1802A

W1701A

Pedestal InterfaceU16

4

6

5

J827

28

28

J9

J2

To K7 Drive Enable

10

TP1 TP2W2001

W2003

FMAC InterfaceU7A15

13J10

5

27

28

28

J5

J7

3

14

22

9

J512 Stow Pin Status

Safety Sw Status

0V for Safety Sw

0V for Hatch

Hatch Status

Hand Crank Status

0V for Hand Crank

Interlock 24V

Interlock 0V

Interlock Status

Sh 1328

ANTENNA Polarizer/OB Lights Sheet 14 of 18

Pedestal Local Control PanelU34

AntennaRadar Shelter

FMAC InterfaceU7A15

AC PowerJunction Box

Linear Polarization

Circular Polarization

Polarizer HTR Line

Polarizer HTR Return

Polarization Command Return

AC Ground

Lights 120VAC

Lights 220/240VAC RTN

Spare

1

2

3

4

5

6

7

8

9

Rotary JointConnector C3

A

B

C

D

E

F

G

H

I

C

CR3

L

CR4

Line Voltage

Linear Command

Circular Command

K

J17L

24V 7A15F2

24V 7A15F2

S4

W0049A

B

E

F

G

H

Not Used

SEEDETAIL

Line

0V 7A15

StatusJ16

AC-Surge Prot240VAC

LNE

LNE

AC-Surge Prot240VAC

LNE

LNE

ObstructionLights

Motor

K1

NOTES:Drawing shown in CircularK1 energized in Circular

S3 S2S4

LB Linear Status

LB Circular Status

S1

220V Motor Drive

Return

Motor

High B

eamS3 S2S4

HB Linear Status

HB Circular Status

S1

220V Motor Drive

Return

Power/Control Box

Low Beam Polarizer

High Beam Polarizer

LB Circular Status

LB Linear Status

HB Circular Status

HB Linear Status

Polarizer Status ReturnN

K

L

H

J

CA5

6

8

9

10

7

TB1

A

B

E

D

CA3

Rotary JointConnector C2

N

K

L

H

J

TB17

J17f

f

TB116

TB14

TB311

TB311

N

K

L

H

J

J3TB321

E

J

K

T

R

P

M

0V 7A15

W0043 AC PowerLine

NeutralGround

Ground TB11

TB11/2/BB

TB2C

Transient Protection Panel

U31A12A1

Neutral

DP-4

CB-8X-Encoder

J6W1701B W1701CW1701A

Pedestal InterfaceU16

W2001K

L

f

From U

34

Linear Command

Circular Command

24V 7A15F2

J3K

L

f

A2A7-E1/L1

A2A8-E2/L2

A2A11-LF2

A2A13-E1/L1

A3A1-E2/L2

A3A11-L

J6K

L

f

J1213

14

1

J813

14

1

J915

23

29

J515

23

29

Transient ProtectionU34A1

J4

A1A9-E2/L2

Transient ProtectionU31A12

W1601BW1601C

W1601A J5

E

J

K

T

R

P

M LB Circular Status

LB Linear Status

HB Circular Status

HB Linear Status

Pol Status Return

0V 7A15

OB Light StatusFrom

U34

J2

E

J

K

T

R

P

M

A1A6-N

A1A6-L

A2A3-E2/L2

A2A2-E2/L2

A2A1-E1/L1

A1A11-E1/L1

J5

E

J

K

T

R

P

M

J11

5

22

9

20

18

17

15

A2A3-E2/L2

A2A9-N

A2A9-L

A2A8-E2/L2

A2A7-E2/L2

A2A6-E1/L1

A2A5-E1/L1

J51

5

22

9

20

18

17

15

Low B

eam

120VAC

Detail of LED OB Light Circuitry

AC CurrentMonitor

Obstruction LightFMAC Alarm

120 VAC

+

-

ControlTransformer

2:1+

-

40 watt

240VAC 120VAC3A

J1

A

B

E

F

G

H

W1701C

Go To

U34A

1

W1701C

W1601C

Go To U

34A1

Mezzanine Room

Go To

U34A

1

Circ PowerLin Power

Circ PowerLin Power

FAN OUTRELAY

+24V0V

Polarizer Command

K3

PLCP CB12 Amp

-

K1 Relay LocatedIn PLCP

Obstruction Light Out Alarm to FMAC

C NO

G

H

E

J

CB2

Added Circuit BreakerCB2

A BK17

TB121

Detail of INCANDESCENTOB Light Circuitry

ORDETAIL

E

J

G

HTO OB LightsC

B1

CB

2

ANTENNA Az Enc & Wx Beam Sw Sheet 15 of 18

Radar Shelter

CommonEquipment

CabinetU7

Beam Sw Control

Beam Sw Control

Beam Sw Status

Beam Sw Satus

Weather Hi/LO

Rotary JointConnector C2

W0043 AC PowerLine

NeutralGround

TB1 1/2/BBTB2C

Transient Protection Panel

U31A12A1DP-4

CB-8X-Encoder

W1701BW1701A

Pedestal InterfaceU16

W2003

J12

J8J2

Transient ProtectionU34A1

A1A7-E2/L2

Transient ProtectionU31A12

W1601BJ5A

D

G

H

J2

A1A8-E1/L1

A1A10-E2/L2

J5

A3A3-E2/L2

A3A3-E1/L1

DP-5

CB-8Y-Encoder

W0044 AC PowerLine

NeutralGround

TB1 3/4/BBTB2C

Power/Control Box

J150Ω

J2

J4

J3

TVS

SCA

X3

3,6,9

2

1

4

5

CA5

DC-Surge Prot13.8VDC

+-E

+-E

DC-Surge Prot110VDC

+-E

+-E

-70V

+5V

+5/-70V Return

A

B

C

D

E

CA4

Data Prot+/-20VDC

+-

+-

IS-SPDDL

RS-422

A

B

C

Rotary JointConnector C1

-70VDC

+5VDC

+5/-70V Return

Rotary JointChannel 3

X Y

PS Status

PS Status

X Encoder Data5VDC

J3

A

B

CS3

PS3+5VDC

Wx Bm Sw

PS4-70VDC

Wx Bm Sw

292622

282523

GNL

LNG

J7

A

B

J6

A

B

PS1+5VDC

Encoder X

PS2+5VDC

Encoder Y

S1

S2282522

LNG

741

LNG

+5VDC PS Status

-70VDC PS Status

Enc X PS Status

Enc Y PS Status

TB1

TVS

S CA

X1

TVS

S CA

X2

Pin D

iodeW

x Beam

Sw

itch

U39A1Wind Monitor

J8C

D

J4C

D

J8C

D

P/O TransientProtection

U35A7

A11E2

A11E1

Coax toW/G

Transition

W/G to Coax

Transition

J17V

W

W0044 A

C P

ower

W0043

W0044

J16H

J16G

J16A

J16D

J6V

W

J3A3A10-E2/L2

A3A10-E1/L1

V

W

A

D

G

H A1A10-E1/L1

P/O U35A7

A1-E2

J5A

B

C

D

J1

A1-E1

A2-E2

A2-E1

A

B

C

D

A3-J6J2

A3+

A4-

A4+

A

B

C

L

J

I

G

D

A

B

C

L

J

I

G

DJ7J3

A

B

C

L

J

I

G

D

X Encoder A Count -

X Encoder A Count +

X Encoder ARP -

X Encoder ARP +

X Ender B Count -

X Encoder B Count +

+5VDC

5VDC Return

Y Encoder A Count -

Y Encoder A Count +

Y Encoder ARP -

Y Encoder ARP +

Y Ender B Count -

Y Encoder B Count +

+5VDC

5VDC Return

A5-

A5+

A7-

A7+

A8-

A8+

A9-

A9+

A

D

G

H

J6V

W

J1A

B

C

D

J3A

B

C

L

J

I

J4A

B

C

L

J

I

J73

2

1

4

J99

1

3

11

10

2

J1012

4

6

14

13

5

W0701B

W9601B

W9602B W9602C

W9601C

W0701C

J1229

30

29

30

7

26

7

26

J7

J73

2

1

4

J239

1

3

11

10

2

J2412

4

6

14

13

5

W0701A

W9611

W9612

J111

4

7

8

J511

4

7

8

W1601BA2A1-E2/L2

A2A2-E1/L1

A2A4-E2/L2

A2A4-E1/L1

A1A13-E2/L2

A1A12+

A1A12-

A1A13-E1/L1

A1A6-E2/L2

A1A4-E1/L1

A1A4-E2/L2

A1A5-E1/L1

A1A5-E2/L2

A1A6-E1/L1

A1A3-E2/L2

A1A1-E1/L1

A1A1-E2/L2

A1A2-E1/L1

A1A2-E2/L2

A1A3-E1/L1

Low Beam

High Beam

To ADU A/B

A14

A15

X Encoder A Count -

X Encoder A Count +

X Encoder ARP -

X Encoder ARP +

X Ender B Count -

X Encoder B Count +

Y Encoder A Count -

Y Encoder A Count +

Y Encoder ARP -

Y Encoder ARP +

Y Ender B Count -

Y Encoder B Count +

Beam Sw Control +

Beam Sw Control -

Beam Sw Status +

Beam Sw Satus -

Beam Sw Control +

Beam Sw Control -

Beam Sw Status +

Beam Sw Satus -

W00

43W

0044

Wx H

i/LoTo R

EX

W1701C

W1601C

Pedestal Local Control Panel U34

Encoders

TB1-3 +

TB1-4 -

Mezzanine Room/Antenna

To U35A7 W9601/2BPins G & D

A

B

C

L

J

I

G

D

+5VDC

+5VDC

5V Return

5V Return

A6+

A6-

A10+

A10-

Y Encoder Data5VDC

Kohl

er E

/G C

ontro

l Pan

el

Cite

l Bas

e 1

Loca

ted

in E

ngin

e G

ener

ator

She

lter

10 Relay Kit

K1

K9

K8

K7

K6

K5

K4

K3

K2

K10

Overspeed

Overcrank

High EngTemp

Low OilPres

Low WaterTemp

AuxFault

E/G 1 SysReady

Pre-AlmHigh Temp

Pre-almLow Oil Pres

EmergStop

39 Major Alarm

Sys Ready

Minor Alarm&

BatteryCharger

Telephone

FireAlarmFire

AlarmPull

SmokeDetector

HeatDetector

EG DoorClosed

EG Running

EG Remote Start and Normal Stop

43

41

40

30

28

35

38

36

12

56

34

12

EG Start

Transfer Switch on EG

Transfer Switch on Commercial

TB-2 3&4

CR-8Comm

CR-6NC

CR6Comm

CR-8NC

Day Tank Level Not Low

Day Tank Not Leaking

LV

CM

HV

CM = Charger MalfunctionLV = Low VoltageHV = High Voltage

To MinorTrouble Alarm

47

1A1

Emergency Stop

Cite

l Bas

e 2

Loca

ted

in R

adar

She

lter

NOTE:Common Connections between CB1 and CB2 are shared for some connections.AT CB1: Pins C R11,9,8,7,5,4,1 are tied together.AT CB1: Pins C R3,2 are tied together

14

12

13

30

29

3839

27

58

2331

25

26

5756

24

1115

Site

Gat

e C

onta

cts

Site Gate

4047W7201

ShelterDoors

21

1

20

FMA

C In

terf

ace

Pane

l P/O

U7A

15 J

54 In

put M

odul

es

8

7

20

5

1

3

4

2

18

W7205

J36 FMAC AJ46 FMAC B

P1

E/G #1 CMD COMMON

SHIELD

E/G #1 EMERGENCY STOP

13

6

7

2013

W41

BLACK

BROWN

ORANGE

A12TB1

COM

B-1

B-2

11

13

14E/G #1 RUN/STOP

6

11

7

6

20

7

FMA

C A

/B In

terf

ace

Pane

l P/O

U7A

15 J

94/P

18 In

put M

odul

es

8

7

20

5

1

3

4

2EG Running

Major Trouble

Minor Trouble

System Ready

Transfer Switch on EG

Transfer Switch on Commercial

Fuel Tank Not Low

Fuel Tank Not Leaking

9 Status Common24V FIPF11

B8

A1

B7

FMA

C A

/B In

put M

odul

es F

MA

C A

P4,

FM

AC

B P

12

A8

A7

B7

A5

A1

A3

A4

A2

B5

A9

W6401 Radar Shelter Doors

W6401 EG No Fire

W6401 EG No Smoke

W6401 EG Door Closed

Status CommonTo Pin 15

FMAC JBOX

21

1

20

18

22 22Common B9

To A

7CN

1To

A6C

N2

W7206

Engine Generator Shelter

Day

Ta

nk

Koh

ler

Batte

ryC

harg

er

Koh

ler

Tran

sfer

S

witc

h

TelephoneService

B T1B R1

B T9B R9

B T10B R10

B T3B R3

B T7B R7

D T3D R3

D T1D R1

B T12B R12

D T8D R8

D T6D R6

D T7D R7

D T2D R2

D T11D R11

D T4D R4

D T5D R5

D T9D R9

D T4D R4

A T1A R1

A T3A R3

A T7A R7

A T9A R9

A T10A R10

A T12A R12

C T1

C T5

C T4

C T11C R11

C T2

D T9

C T6C R6

C T8

C T9

C T3C R3

A T1A R1

A T3A R3

A T7A R7

A T9A R9

A T10A R10

A T12A R12

C T1

C T3C R3

C T5

C T4

C T11C R11

C T2

C T7

C T6C R6

C T8

C T9

C T12C R12

B T1B R1

B T3B R3

B T7B R7

B T9B R9

B T10B R10

B T12B R12

D T1

D T3D R3

D T5

D T4

D T11D R11

D T2

D T7

D T6D R6

D T8

C T9

D T12D R12

B T2B R2

A T2A R2

A T2A R2

B T2B R2

TelephoneService

SparePhone

WIR

ES IN

CO

ND

UIT

Fire

Ala

rmC

ontr

ol P

anel

K3-NC

K2-NC

W7206

W7206

K1Located in CB1

Engine Generator Sheet 16 of 18

CMU Radar Shelter

FMAC Interface Panel P/O U7A15 J19

Output Modules

W7201

W7205

FMAC JBU31A20

FMAC Int PanelU7A15 J55

FMAC A/B Int Panel P/O U7A15 J95/P17

FMAC A/B IP ModulesA P5/B P13

T1 T1R1 R1T2 T2R2 R2

T15 T15R15 R15T16 T16R16 R16

T13 T13R13 R13T14 T14R14 R14

T11 T11R11 R11T12 T12R12 R12

T9 T9R1 R9T10 T10R10 R10

T7 T7R7 R7T8 T8R8 R8

T5 T5R5 R5T6 T6R6 R6

T3 T3R3 R3T4 T4R4 R4

A B

T1 T1R1 R1T2 T2R2 R2

T11 T11R11 R11T12 T12R12 R12

T9 T9R9 R9T10 T10R10 R10

T7 T7R7 R7T8 T8R8 R8

T5 T5R5 R5T6 T6R6 R6

T3 T3R3 R3T4 T4R4 R4

C D

Citel Base 1 – EG ShelterCitel Base 2 – Radar Shelter

W6401

E280T

E280-24V

E280-24V

E280-24VNot in DoD

E280-24VNot in DoD

E280-24V

E280-24V

E280-24V

E280-24V

E280-24V

E280-24V

E280-24V

E280-24V

E280-24V

Telephone

Spare Telephone

Fire Strobe From

Fire Strobe To

Fire Horn From

Fire Horn To

Fire Pull From

Fire Pull To

Smoke Detector

Heat Detector

Door Closed

EG Running

EG Start/Stop

Emergency Stop

EG Alarm (Minor)

EG Alarm (Major)

On Commercial

On EG

Tank Level Low

Tank Leaking

System Ready

FireHorn

B T8B R8

A T8A R8

A T8A R8

B T8B R8

See Sheet 17 for loop

X

X

Removed withSSM 078

Pedestal RoomDoor Closed

Smoke AlarmZone 3

Fire Alarm PullStation Zone 7

Heat DetectorZone 4

Pedestal Room

B T1B R1

B T5B R5

B T3B R3

B T8B R8

A T1A R1

A T3A R3

A T8A R8

A T5A R5

A T1A R1

A T3A R3

A T8A R8

A T5A R5

B T1B R1

B T3B R3

B T8B R8

B T5B R5

Fire

Ala

rmC

ontr

ol P

anel

Citel Base 3,4,5,6 Sheet 17 of 18

CMU Radar Shelter

FMAC JBU31A20

FMAC Int PanelU7A15 J95/P17

Door

Fire Horn B T6B T6

A T6A R6

A T6A R6

B T6B R6

Fire Strobe B T4B R4

A T4A R4

A T4A R4

B T4B R4

T1 T1R1 R1T2 T2R2 R2

T15 T15R15 R15T16 T16R16 R16

T13 T13R13 R13T14 T14R14 R14

T11 T11R11 R11T12 T12R12 R12

T9 T9R1 R9T10 T10R10 R10

T7 T7R7 R7T8 T8R8 R8

T5 T5R5 R5T6 T6R6 R6

T3 T3R3 R3T4 T4R4 R4

A B

Citel Base 6 – Radar ShelterTelco Connections

T23 T23R23 R23T24 T24R24 R24

T21 T21R21 R21T22 T22R22 R22

T19 T19R19 R19T20 T20R20 R20

T17 T17R17 R17T18 T18R18 R18

T25 T25R25 R25

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

E280T

EG Shelter

6.8k .5W

10k .5W

10k .5W

6.8k .5W

6.8k .5W

SmokeDetector

Heat Detector

Pull

Horn

Pull

Horn

Pull Pull

Horn

Cite

l Bas

e 5

Cite

l Bas

e 4

Cite

l Bas

e 2

Cite

l Bas

e 1

B T8B R8

A T8A R8

B T4B R4

A T4A R4

B T6B R6

A T6A R6

A T8A R8

B T8B R8

A T4A R4

B T4B R4

A T6A R6

B T6B R6

B T7B R7

A T7A R7

B T3B R3

A T3A R3

B T5B R5

A T5A R5

A T7A R7

B T7B R7

A T3A R3

B T3B R3

A T5A R5

B T5B R5

Telephone B T9B R9

A T9A R9

A T9A R9

B T9B R9

To CB6

Ped

esta

l Roo

m-N

o Fi

re K

1 N

/C

Ped

esta

l Roo

m-N

o S

mok

e K

2 N

/C

7108

9T1 T1R1 R1T2 T2R2 R2

T11 T11R11 R11T12 T12R12 R12

T9 T9R9 R9T10 T10R10 R10

T7 T7R7 R7T8 T8R8 R8

T5 T5R5 R5T6 T6R6 R6

T3 T3R3 R3T4 T4R4 R4

A B

Citel Base 4 – Radar ShelterCitel Base 5 – Pedestal Room

Door Closed

Fire Strobe

Smoke Alarm

Heat Sensor

Fire Horn

Fire Pull Station

Telephone

Spare

Spare

E280-24V

E280-24V

E280-24V

E280-24V

E280T

E280-24VNot in DoD

T1 T1R1 R1T2 T2R2 R2

T9 T9R1 R9T10 T10R10 R10

T7 T7R7 R7T8 T8R8 R8

T5 T5R5 R5T6 T6R6 R6

T3 T3R3 R3T4 T4R4 R4

A B

Citel Base 3 – Radar ShelterEnvironmental Control Unit (ECU)

E280-24V

E280-24V

E280-24V

E280-24V

E280AV-110 (120V)

ECU TB1-11ECU TB1-12ECU TB1-13ECU TB1-14

ECU TB1-16

ECU TB1-18

ECU TB1-19ECU TB1-20ECU TB1-21

ECU TB1-23

ECU TB3-1ECU TB3-2ECU TB3-3ECU TB3-4

5

7

8

FMAC A/BA7CN1 P5

Input Module

A5

A7

A8

Not In DoD

24V PS A7PS1

24V PS B7PS2

24VD

C

F2 1A

F3 1A

F4 1A

F5 1A

F6 1A

F7 1A

F8 1A

F9 1A

F10 1A

F11 3A

F12 3A

F1 1AU16 K7

Motor A/B Run

Hatch Safety Switch Hand Crank Stow Pin

*U16 K5Motor A

Tx Enable *U16 K6Motor B

Tx Enable

A Run Status

B Run Status

U34 K4Sump Heater

RelaySump Thermostat

From Motor Controllers

* Contacts on K5&6 enable MSSR and PSR TransmitterContacts are in parallel so either relay can keep Tx operating

0V RTN

* Contacts on K4 supply 3 phase power to sump & GB heaters

0V RTN

Compressor/Dehydrator Status & WG Pressure

Spare

To FMAC A Modules A9 & A10 for A/D conversion of Wind Speed, Motor Amps, and LP/SP forward and reverse power from TCMM A RF Monitor

To FMAC B Modules A9 & A10 for A/D conversion of Wind Speed, Motor Amps, and LP/SP forward and reverse power from TCMM B RF Monitor

To Fire Alarm System

F13 1AGoes to U16 J2 Pin 8, Not Used

FMAC A&B Modules A5, A7, and A8

7A15J10 Pin 18 on W1802, to U31A12 J8 Not Used

220VACJunction Box AUnit 7

Interlock Complete

DP4 CB715A

220VACJunction Box BUnit 7

DP5 CB715A

FMAC A&B Modules A6, A7 and A8

7A15 Fuse Panel 24V distribution Sheet 18 of 18

GB A Oil Level

GB B Oil Level

Sump Oil Level

Ped Low Temp

PLCP U34

0V RTN

0V RTN

0V RTN

0V RTNA Contact

B Contact

D Contact

K5

Oil Level Transition

Module

F1

F2

F3

F4

F5

F6

SCDI-A Selected

SCDI-B Selected

F7

SCDI-A Selected

SCDI-B Selected

F8

F9

F10

F11

F12

F13