Proposal of Energy Saving...energy-saving .Calculated at 10% in Japan)Calculate the application...
Transcript of Proposal of Energy Saving...energy-saving .Calculated at 10% in Japan)Calculate the application...
Proposal of Energy Saving1sqm3000JPY~ 5,000JPY/3~5 Years
payback period
Visible light transmittance75%/IR CUT80%/UV CUT99%
20~30%Energy Saving to shield the heat from windows
IRUV CUT COAT Hyper-SP
-Special simulation plan-
Proposal
◆Proposal a trial package,1sqm 5,000JPY to your potential customer
Japan No1. Share, SKETCH insulated glass coating offers to apply by special price. This
special plan aims to recover the initial installation cost in 5 years. Low price energy-
saving measures and its best plan that makes it possible to reduce electricity costs.
Usually Application fee is 8,800 JPY per 1 square meter in Japan. However, it can be
applied 3,000~ 5,000JPY per 1 sqm in order to hasten the initial investment recovery
period. Support the verification and simulate energy saving measurement data, so you
can be calculated until the recovery period and subsequent profit.
① Application 5,000JPY ② Verification & hearing for electricity fee ③ Graph of the temperature difference&simulation
Point of power consumption reductionIn Japan, the air conditioning costs is 44% of the power consumption in the office
buildings. It is the most important challenge is to reduce air conditioning costs during
peak time (10:00 AM to 4:00PM). The basic charge of electricity bills (Contract power
cost) will decide on the basis of the peak value of the largest power consumption month
on the past year. So power consumption of September (the hottest time of the summer) is
the most expensive in one year, it will be the basic charge of electricity bills.
Summer
The rate of heat coming from the window
平成23年5月資源エネルギー庁(東電管内の需要構造推計・業務部門)より
In summer, 71% of heat enters through the
window glass from the outside when the entire
building as 100%. (13% of heat from outer
wall, 9% from the roof, 2 % from the floor
etc. ...) A measure of window glass is most
important for energy-saving and power-saving
of the building.
Low-E Double + coating
Clear Double + coating
Clear Double
Low-E Double
Korean Construction Company measured the temperature at 4 rooms under the same conditions. As a result, the
room temperature was at most 3.6 ℃ lower than the non-coated room. Air conditioning cost reduction rate of the
year was 14% (28%). (※As a condition, the temperature setting of air conditioning change 1 ℃ effects 5% of the
energy-saving .Calculated at 10% in Japan)Calculate the application cost by electricity charges and labor costs in
South Korea, it has proved to be recovered in 4.9 years. South Koreas is the cheapest electricity rates in the
developed countries, it will be recovered within five years even there is winter time.
Energy-saving simulated case in Korea
◆Simulation of a 15-story building◆The indoor temperature comparison
by the changes in the outside air temperatureSection ComparisonEnergy cost (Won)
Energy cost before application
Amount of reduction after coating
Energy cost after application
kWh/year
Section Area(㎡)Unit Price
₩Cost ₩ Comparison
Application
Cost
Reduction
CostPay Back
Period4.9year
◆Singapore golf course
Result of the temperature measurement, the temperature difference of the direct heat at the window was 8 ℃
(maximum) in comparison with the uncoated glass (Low-E glass) Reduction rate of the air conditioning costs
was 20 percent, so recovery of the initial investment simulated in 2.03 years. Because there was high electricity
prices and low applicator cost. For 10 years coating guarantees, we can expect significant cost savings of 20% to
30% more than eight years is. ⇒ 2years payback period and more than eight years profit
Examples of Energy saving simulation
October 1st Sunny
Temperature difference
Maximum 16.5
Inside the room
◆Entertainment facilities in Japan
Because the film can not demonstrate the effect, anyone does not enter the room in the summer time. It was hot
even the air conditioner temperature set 19℃, customer requested to apply “IRUV CUT COAT H-SP" partly and
measured the temperature. Customer comments : “It became cool and possible to set the air conditioning 24 ℃.
We felt the intense heat shielding effect ". The 5% of air conditioning load reduction (about 30-50%).
Simulation of 200sqm application
※Since the above is a reference value, measurement results will change by air conditioning, electricity charges, and environment.
Simulation of 200sq meter application Set the Air conditiong from 8 AM to 6 PM. ( 10 hours)
2,500 JPY/sqm 500,000 JPY 15 JPY 756,000 JPY 151,200 JPY 3.3 Year 226,800 JPY 2.2 Year
3,000 JPY/sqm 600,000 JPY 10 JPY 504,000 JPY 100,800 JPY 6.0 Year 151,200 JPY 4.0 Year
4,000 JPY/sqm 800,000 JPY 12 JPY 604,800 JPY 120,960 JPY 6.6 Year 181,440 JPY 4.4 Year
5,000 JPY/sqm 1,000,000 JPY 15 JPY 756,000 JPY 151,200 JPY 6.6 Year 226,800 JPY 4.4 Year
Japan 8,800 JPY/sqm 1,760,000 JPY 22 JPY 1,108,800 JPY 221,760 JPY 7.9 Year 332,640 JPY 5.3 Year
2,500 JPY/sqm 500,000 JPY 15 JPY 756,000 JPY 151,200 JPY 3.3 Year 226,800 JPY 2.2 Year
3,500 JPY/sqm 700,000 JPY 15 JPY 756,000 JPY 151,200 JPY 4.6 Year 226,800 JPY 3.1 Year
5,000 JPY/sqm 1,000,000 JPY 15 JPY 756,000 JPY 151,200 JPY 6.6 Year 226,800 JPY 4.4 Year
6,000 JPY/sqm 1,200,000 JPY 15 JPY 756,000 JPY 151,200 JPY 7.9 Year 226,800 JPY 5.3 Year
2,500 JPY/sqm 500,000 JPY 12.6 JPY 635,040 JPY 127,008 JPY 3.9 Year 190,512 JPY 2.6 Year
3,000 JPY/sqm 600,000 JPY 12.6 JPY 635,040 JPY 127,008 JPY 4.7 Year 190,512 JPY 3.1 Year
3,500 JPY/sqm 700,000 JPY 12.6 JPY 635,040 JPY 127,008 JPY 5.5 Year 190,512 JPY 3.7 Year
4,000 JPY/sqm 800,000 JPY 12.6 JPY 635,040 JPY 127,008 JPY 6.3 Year 190,512 JPY 4.2 Year
5,000 JPY/sqm 1,000,000 JPY 10 JPY 504,000 JPY 100,800 JPY 9.9 Year 151,200 JPY 6.6 Year
6,000 JPY/sqm 1,200,000 JPY 10 JPY 504,000 JPY 100,800 JPY 11.9 Year 151,200 JPY 7.9 Year
7,500 JPY/sqm 1,500,000 JPY 10 JPY 504,000 JPY 100,800 JPY 14.9 Year 151,200 JPY 9.9 Year
10,000 JPY/sqm 2,000,000 JPY 10 JPY 504,000 JPY 100,800 JPY 19.8 Year 151,200 JPY 13.2 Year
5,000 JPY/sqm 1,000,000 JPY 12 JPY 604,800 JPY 120,960 JPY 8.3 Year 181,440 JPY 5.5 Year
6,000 JPY/sqm 1,200,000 JPY 12 JPY 604,800 JPY 120,960 JPY 9.9 Year 181,440 JPY 6.6 Year
7,500 JPY/sqm 1,500,000 JPY 12 JPY 604,800 JPY 120,960 JPY 12.4 Year 181,440 JPY 8.3 Year
10,000 JPY/sqm 2,000,000 JPY 12 JPY 604,800 JPY 120,960 JPY 16.5 Year 181,440 JPY 11.0 Year
5,000 JPY/sqm 1,000,000 JPY 10.0 JPY 504,000 JPY 100,800 JPY 9.9 Year 151,200 JPY 6.6 Year
6,000 JPY/sqm 1,200,000 JPY 10.0 JPY 504,000 JPY 100,800 JPY 11.9 Year 151,200 JPY 7.9 Year
7,500 JPY/sqm 1,500,000 JPY 10.0 JPY 504,000 JPY 100,800 JPY 14.9 Year 151,200 JPY 9.9 Year
10,000 JPY/sqm 2,000,000 JPY 10.0 JPY 504,000 JPY 100,800 JPY 19.8 Year 151,200 JPY 13.2 Year
5,000 JPY/sqm 1,000,000 JPY 22 JPY 1,108,800 JPY 221,760 JPY 4.5 Year 332,640 JPY 3.0 Year
6,000 JPY/sqm 1,200,000 JPY 22 JPY 1,108,800 JPY 221,760 JPY 5.4 Year 332,640 JPY 3.6 Year
7,500 JPY/sqm 1,500,000 JPY 22 JPY 1,108,800 JPY 221,760 JPY 6.8 Year 332,640 JPY 4.5 Year
10,000 JPY/sqm 2,000,000 JPY 22 JPY 1,108,800 JPY 221,760 JPY 9.0 Year 332,640 JPY 6.0 Year
Canada
America
(Atlanta)
Mexico
Newzealand
Thai
Reduction of 30%
Initial
investment
recovery
China
Southeast Asia
China
Application Price 200sqm applicationElectricity fee
/kwh
Electricity fee
/a yearReduction of 20%
Initial
investment
recovery
Example of Saving Energy simulation
■Calculate the electricity consumption after application
・Ex)Average temperature= 2℃.
Consumption of Air conditioning= 18kW
The electricity consumption after application will be
18kW-(18kW×0.2 )=14.4kW
■Calculate the reduction of electricity consumption
・Ex) Daily power consumption:10h , Days of operation : 365days
Power consumption before coated[kWh]=(18kW×10h×365days)=65,700Wh
Power consumption after coated[kWh]=(14.4kW×10h×365days)=52,560Wh
Yearly reduction of power consumption =657,00Wh- 52,560Wh= 13,140Wh
■Calculate of energy saving cost・Ex) Electricity fee= 15JPY/kwh,
Application area= 200㎡,
Application cost= 200㎡×2,500JPy=500,000JPY
Yearly saving cost =13,140Wh×15JPY=197,100JPY
Payback period = 500,000JPY ÷197,100JPY ≒Recover in 2.5 years. Then if the
durability is 15years, the profit will continue 12.5 years
=197,100JPY×12.5Years=2,463,750JPY
■Easy energy saving calculated using the spreadsheet table by Excel
sheet on the rightCondition 1
Condition 2
Condtition3
If the average room temperature during the
operating time is one degree lower, it is considered to
be 10% energy savings. (※ Source: Energy
Conservation Center, Japan)
Electric bill only
(Excluded :Gas, heavy oil, kerosene, etc. )
Air conditioning is commercial type
(If the air conditioning system is the central air-
conditioning system or the like, it is assumed air
conditioning is commercial type.)
■Simulation conditions reference: Funai Research Institute
Please write only inside space
is automatically calculated
① What is the Mean temperature difference between coated room and uncoated room?
2 ℃ 20 % Energy saving of air conditioning
②
18 kwh
③ After application , the power consumption of air-conditioning is below
18 kwh - 3.6 = 14.4 kwh
④ How many time is your Operation time of air-conditioning ?
10 hours 365
⑤ Power consumption reduction for a year
13140 Wh
⑥ What is the electricity rate ?
15 Yen/kwh
⑦ How many field did you apply ?
200 ㎡
⑧ How much is the application cost ?
200 × 2500 Yen/㎡ = 500000 Yen
⑨ Did you pay other cost for application? How much is it?
Yen ⇒ 500000 Yen
⑩197100 Yen
⑪ Amortization period
2.5 years
Calculating formula of energy saving for IRUV Cut Coat
days for a year
Reduction cost for a year
Total cost is
What is thePower consumption of air conditioning ?
9
Sapporo beer factory
Convenience Store Shopping Mall in Hokkaido
Toyota Car dealer shopKawasaki / Company
Niigata University Funabori Tower Hall
Ministry of Internal Affairsand Institute for Information
and Communications Policy
Tokyo Gakkan Niigata highschool Daiwa house company
Ibaraki Quantum Beam Research Center
Certain clinic in Kyoto
Medical corporation Juzenkai
Higashiyama old people's home in
Kyoto
Japanese MedicalUniversity Hospital
In Chiba
Nagoya, Aichi Prefecture
Special nursing home for the aged
Shoju Garden
Mishima, Shizuoka kenCentral Hospital
Japanise Atomic Energy Agency
JR Kyushu clinic SJR branch clinic
Construction results
Nishitetsu Gion bld in Fukuoka ken Odakyu Express Train
Tokyo tower Tobu Fujigaoka Golf Country Club Elevator in Sumida city Hall ,Tokyo
City hall Tamaho in Yamanashi FILM Fuji Research Institute
Swimming Pool in Mitsui Fudosan com
Ito-Yokado Department store Hotel Okura Akademia Park Chiba
The Windsor Hotels International in Hokkaido
HOTEL JAPAN Shimoda in Shizuoka
Exiv Shirahama AnnexIn Wakayama
Exiv Shirahama in Wakayama
Fukayaso,Nursing Home in Okayama
Construction results