OPERATOR INSTRUCTION MANUAL INCLUDING REPAIR PARTS … · operator instruction manual including...
Transcript of OPERATOR INSTRUCTION MANUAL INCLUDING REPAIR PARTS … · operator instruction manual including...
OPERATOR INSTRUCTION MANUAL INCLUDING REPAIR PARTS
FOR MODULAR GENERAL PURPOSE TENT SYSTEM
(MGPTS) TYPE III
Johnson Outdoors Gear LLC Eureka! 625 Conklin Road Binghamton, NY 13903 Customer Service: 1 800 847-1460 Web Site: http://www.eurekamilitarytents.com
25 November 2013 – Revision C
SittinAssem
LayConSettRaiTensyst
OperaOpeOpeOpeOpeOpe
StrikiFol
Appendic
FabriPatHan
MGPTan
MGPGre
ng requiremenmbly Type IIIyout fabric sennect fabric sting up tent pising Type IIInsioning Typetem ating proceduerate doors erate windowerate roof venerate fabric werate stovepiping Type III tld fabric secti
ces
c assembly Ech Hole or Rind Stitching RTS - Tan
n – Basic ItemTS - Green
een – Basic It
nts I tent system ctions ections
poles I tent system e III tent
ures
ws nts
walls pe openings ent system ons
End Module &ip Repair
m Issue (Parts
tem Issue (Par
Table o..................................................................................................
..............
..............
..............
..............
..............
..............
..............
..............
& Fabric assem............................
List)
rts List)
2 / 31
of Conten..........................................................................................................................................................
......................
......................
......................
......................
......................
......................
......................
......................
mbly Mid Mo............................................
.........
.........
Cus
nts ...................................................................................................................................................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
odule Repair &..........................................
.....................
.....................
stomer Servicwww.eurek
...................................................................................................................................................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
.....................
& Replace ..........................................
.....................
.....................
ce: 1 800 847 kamilitarytents
Pag............... ................ ................ ................ ................ ................ ................
................
...............
................
................
................
................
................
................
............. A
............. B
.......... Pl 1
.......... Pl 2
1460 s.com
ge No. 33358
13
16
1919192020202123
00-1 00-1
1 00-1
2 00-1
This sectimodular sissued in tcombinati SITTING
Thesect
Select an be erectedarea, the gthe tent abperimeter
ASSEMB Layout fa
1. Identiand o
on applies to structure (Patethree sizes: smions of length
G REQUIRE
ese instructiontions and inte
area to erect td (see Table 1ground shouldbout 2 feet awtrench.
BLY TYPE I
abric section
ify each fabrine Mid Fabri
the Type III ent # 7,140,37mall, mediumh and to other
MENTS
ns are based oernal arches w
the tent. Ensu1). The area sd not vary by
way from the e
TTent ModSmall Medium Large
II TENT SY
s
c section requc Section.
MGPTS only77) that can u
m and large. TTypes of equ
on the mediumwill differ. Ma
ure the area wshould be cleamore than 6 edge. A drain
Table 1. Areadel: Len
345270
YSTEM
uired. For the
3 / 31
y. The MGPTuse either the The MGPTS cuipment.
NOTE
m MGPTS. Fake modificat
will be large ear of trees, rocinches. A trenage ditch sh
a Setup Requngth Wi4 ft 342 ft 340 ft 34
e medium MG
Cus
TS Type III isType I or Typcan also be co
For other tent tions as requi
enough for thcks and debri
ench should bhould also be d
uirements. dth Hei
4 ft 124 ft 124 ft 12
GPTS, you w
stomer Servicwww.eurek
s an internal fpe III. The Momplexed in v
t sizes, the numired.
e tent and guyis. Choose a
be dug arounddug for water
ight 2 ft 2 ft 2 ft
will need two e
ce: 1 800 847 kamilitarytents
frame supportMGPTS Typevarious
mber of mid
y ropes that wrelatively flat
d the perimeter to exit the
end fabric sec
1460 s.com
ted III is
will t er of
ctions
Fabwar
2. Trans
3. Unfolgreen
Thelace
4. Positiout flaroof p
bric sections arning may res
sport each req
ld each mid f or tan side is
e mid fabric e and gromme
ion end sectioat. Fold side portions are ex
are heavy. Alsult in back in
quired fabric s
fabric sections up. Place th
section (1) haets on one end
ons (2) on eithwalls and endxposed. This
W
lways lift withnjury.
section into ar
n (1) and end hese sections i
as lace and grd.
her side of thd walls of mis will allow ea
4 / 31
WARNING
h your legs no
rea where ten
section (2) sin center area
NOTE
rommets on b
e mid sectionid (1) and endasier access to
Cus
ot your back.
nt will be erec
o that the insia where tent is
both ends. Th
n (1) so that bd sections (2)o the web loo
stomer Servicwww.eurek
Failure to ob
cted.
ide (white sids to be setup.
he end section
becket laces () under roof sop attachment
ce: 1 800 847 kamilitarytents
bserve this
de) is down an
ns (2) have
(3) align. Laysection so thatt points.
1460 s.com
nd the
y tent t only
Connect f Use the fo
Splsam
1. Find tunder
It issect
2. Find b
fabric section
ollowing proc
it the four perme time on op
the four largerside of tent. C
s very importations are conn
becket lace (2)
ns
cedures to con
rsonnel into twposite ends o
e snap hooks Connect the s
ant to the funnected.
at one end of
nnect becket l
wo person teaf the tent.
(1) at the cennap hooks (1
ctionality of t
roof. You may
5 / 31
lace between
NOTE
ams. Each te
nter edge of en1).
NOTE
the tent that th
y start at either
Cus
each end sect
eam should pe
nd section an
he snap hook
r end of roof.
stomer Servicwww.eurek
tion and mid
erform steps 1
nd mid section
ks at the cente
ce: 1 800 847 kamilitarytents
section:
1-12 at the
n roofs on
er of the two
1460 s.com
3. Lace tone roenter Insertthird lreachi
4. At thelace (ridge
the fabric secoof section ththe white side
t the second loloop (6) throuing the other
e end, tie off l(8) through loand tie off w
ctions togethehrough the firse of the fabricoop (4) throuugh the third side of the ten
last becket lacoop of last becith half-hitch k
er by using thest small gromc and exit the
ugh the secondgrommet (7)nt.
ce by using thcket lace (9). knot.
6 / 31
e following inmmet (2) of th
green or tan d grommet (5) and the seco
he following i Pull the nex
Cus
nstructions. Ihe adjoining rside. All loo
5) and througond loop (4).
instructions: xt-to-last beck
stomer Servicwww.eurek
Insert the firstroof section (ops should be gh the first loo
Repeat this p
Insert the nexket lace (8) ba
ce: 1 800 847 kamilitarytents
t rope loop (1(3). Loops alwpulled tight.
op (1). Insertpattern until
xt-to-last becack towards t
1460 s.com
1) on ways
t the
cket the
5. Pull 1
6. Conn
7. Fold o
1-1/2 inch web
ect D-ring (1
one flap (14)
Fl
b pole loop (
12) on 3/4 inch
Make sure D
over becket l
laps are identi
10) through b
h strap at the
D-ring strap is
lace.
ical. It does n
7 / 31
big grommet
eave to adjoi
NOTE
s below 1-1/2
NOTE
not matter wh
Cus
(11) at perim
ining section’
2 inch web po
hich is on top
stomer Servicwww.eurek
meter.
’s snap hook
ole loop.
or bottom.
ce: 1 800 847 kamilitarytents
(13).
1460 s.com
8. Feed
9. Fold oloop (
10. Conn
11. With Setting up
Sid 1. Locat
2. Make
3. Place inch w
A
1-1/2 inch we
other flap (15(10) through s
ect buckles (
one person at
p tent poles
Stay
de poles are n
te side poles (
e sure each sid
one side poleweb loop (6)
At each corne
eb pole loop
5) along the leslit in outer fl
16) along ent
t each corner
y in your two
ot adjustable.
(1).
de pole (1) ha
e (1) at each cat eave.
er of the tent
(10) at eave t
ength of the telap (15).
tire outer flap
of the tent, st
o person team
. For the med
as two guy ro
corner of ten
make sure we
8 / 31
through slit in
ent over the f
p (15).
tretch fabric t
NOTE
s to perform t
NOTE
dium Type III
opes (2) attach
nt (4). Place c
NOTE
eb loops are p
Cus
n flap (14).
first flap (14)
tight to remov
the following
I MGPTS fou
hed to cap as
cap assembly
pulled through
stomer Servicwww.eurek
and feed 1-1
ve slack.
g procedures.
ur side poles w
ssembly (3).
y spindle (5)
h slit in fabric
ce: 1 800 847 kamilitarytents
/2 inch web p
will be used.
through 1-1/2
c shingle.
1460 s.com
pole
2
4. Find tPush loop awith t
5. Corne6 feet
two end polepin (2) back at middle of ethe pin facing
er poles shoult out along po
s (1). Adjustin when holes
each tent end g up, so that g
ld be aligned ole and 1-foot
t them to maxs are aligned.section’s roof
guy ropes slide
with fabric son either sid
9 / 31
ximum height Place cap af edge. Ensure freely throu
seam (1) in ene of pole.
Cus
by pulling piassembly spinre the flat sid
ugh ring at top
nd section roo
stomer Servicwww.eurek
in (2) out at bndle (3) throude of the pole p.
of. Stakes ma
ce: 1 800 847 kamilitarytents
bottom of polugh 1-1/2 inchis on the grou
ay then be pla
1460 s.com
e. h web und
aced
6. FollowIt is im
Forthe locatheneachit w
7. Drivebe dri
w staking diamportant to h
r the stakes lostakes by the
ated on the sidn place a stakh stake pair o
was originally
e stakes six feiven in until o
agram below. have a stake at
cated on the se following prdes of the ten
ke 1 foot on eaon the side of
placed (align
et out from teonly six inche
Drive in the t each of the m
sides of the terocedure: A pnt, place a corach side fromthe tent, after
ned with fabri
ent edge and aes extend abov
10 / 31
36-inch woomarked point
NOTE
ent, a corner ppair of stakes rner pole at ea
m end of corner you have finic seam).
angle stake slve the ground
Cus
d stakes at allts.
pole may be uwill be locate
ach web loop er pole. Repenished, return
lightly away fd.
stomer Servicwww.eurek
l points indic
used to propered for each w(facing away
eat this procedn the corner po
from tent. W
ce: 1 800 847 kamilitarytents
ated on diagr
rly locate web loop y from tent) dure for ole to where
Wood stakes sh
1460 s.com
ram.
hould
8. UncliRepea
9. Place crosseRepea
10. Start aand rotowar
p the carabinat for all six c
corner pole ged. Loosen roat for all corn
at one cornerotates bottomrd center of te
er/guy rope acarabiners.
guy ropes (1)ope adjustmen
ner pole locati
. One personm of pole undeent. Tighten g
assembly from
) over wood snt to leave pleions.
n lifts corner rer roof fabricguy ropes (1)
Patent # 7
11 / 31
m frame leg, a
stakes (2), maenty of slack.
roof fabric (3c (3) and stand), by sliding t
7,140,377
Cus
and then clip c
aking sure tha. This will m
3) while the seds pole up so tensioner (5),
stomer Servicwww.eurek
carabiner to a
at ropes are nmake it easier t
econd personthat bottom o
, to keep pole
ce: 1 800 847 kamilitarytents
a side web loo
not twisted or to stand poles
n grasps pole (of pole is anges from falling
1460 s.com
op.
s up.
(4) led in g.
11. Repea
12. Roll u
13. Two ppole, slightfreelypole.
at step ten for
up one 9-foot
persons are rerotates bottom
tly in towardsy through ring
r other two co
Guy rope
long sidewal
equired. Stanm of pole und center of ten
g at top. Tigh
orners.
es must be sn
ll of tent. Use
nd end pole upder roof fabrint. Place flat hten guy rope
12 / 31
NOTE
nug, to keep p
e tie straps at
p. One personic (3) and stanside of end p
es (1) to keep
Cus
poles from fal
eave to secur
n lifts roof fands pole up soole towards tpole from fal
stomer Servicwww.eurek
ling.
re the rolled u
abric (3). Otho that bottomtent so that gulling. Repeat
ce: 1 800 847 kamilitarytents
up section.
her person gram of pole is anuy ropes slidet for other end
1460 s.com
asps ngled e d
Raising T
1. Locat
2. Extenholes
Type III tent
te MGPTS Ty
nd leg assemb(4) are aligne
system
ype III foldin
blies to full heed, push pin (
Patent #
g arch assem
eight by pulin(3) back in.
7,140,377
Patent # 7,1
13 / 31
mblies (1) and
ng pin (3) out
140,377
Cus
d leg assembl
and pulling l
stomer Servicwww.eurek
lies (2).
lower leg out
ce: 1 800 847 kamilitarytents
until the lock
1460 s.com
king
3. Unfollockin
4. Place
5. Repea
6. Using
Use care to
ld the foldingng hole is alig
one leg (2) in
at procedures
g four people,
ensure finger
g arch arms (gned. Then p
nto each arm
one through
carry one co
P
W
rs, or other pa
(5) by pullingush locking p
m (5) to from o
four for the o
mpleted inter
Patent # 7,14
Pate
14 / 31
WARNING
arts are not ca
g the locking ppin (6) back i
one complete
other two inte
rnal arch asse
40,377
ent # 7,140,3
Cus
aught in foldin
pin (6) out thin.
internal arc
ernal arch asse
embly into the
377
stomer Servicwww.eurek
ng arch hinge
hen rotate the
h assembly (
emblies.
e tent.
ce: 1 800 847 kamilitarytents
e points.
arms (5) unt
(7).
1460 s.com
til the
Usepea
7. Identiroof othe firother
If thfitti
8. Tie ofplate
9. To raitwo psides side wnearlyroller
e care to ensuak fitting hold
ify the peak fof the tent. Strst peak fittinpeak holder
he fabric tensing (8), releas
ff peak fittin(11) spacer b
ise the first arpeople at the cof the frame.
will walk the ly vertical. Asr assembly (1
ure fingers, or ders.
fittings (8) whtarting at one ng (8) is fully(9).
ion is too tighse tension on
gs (8) to frambolt, to keep f
rch, locate twcenter of the f
While the twleg to a vertics the frame ar12) while also
W
other parts ar
hich are metaend of the ten
y in the first p
ht to place thethe end poles
me with rope frame from se
wo people at thframe push thwo people in tcal position. Arches are beino raising the fr
Patent
15 / 31
WARNING
re not pinched
al tubes attachnt, place a pe
peak holder (9
NOTE
e second peaks to slacken th
(10) providedeparating from
he center of thhe frame up wthe center areAll four perso
ng raised, havframe assembl
# 7,140,377
Cus
d while insert
hed to flat meeak fitting (8)9), place the
k holder (9) ihe tent fabric
d, by tying ropm tent in wind
he frame and while at the same pushing the ons will be rae one personly.
7
stomer Servicwww.eurek
ting peak fitti
etal plates loca) into a peak second peak
into the secon.
pe from D-rindy conditions
one person ame time workframe up, eac
aising the archguide the fab
ce: 1 800 847 kamilitarytents
ings into
ated on the inholder (9). Ofitting (8) int
nd peak
ngs to a gusse.
at each leg. Tking down thech person at th, when the arbric over each
1460 s.com
nside Once to the
et
he e the rch is
h
10. For th
peak h
11. From
Tensionin
1. Tensi
a. StTpedove
b. R
he second & tholders) and r
one end, view
ng Type III t
oning tent. C
tart at a corneThe same pers
erson rocks bown tensioneertical positio
Repeat procedu
third arch, posraise each arc
w arch assem
tent system
Corners shoul
er. The first pon should gra
back towards ser (3) to tighteon.
ure on other t
sition 2 persoch to a vertica
mblies and mak
d be tensione
person shouldasp pole (2) astake (1) keepen guy ropes
three corners.
16 / 31
ons at each legal position.
ke sure they a
ed first. Tensi
d position himat the top andping base of t
s (4). Both pe
Pat
Cus
g (after placin
are aligned an
ion one corne
mself betweenbelow cap asthe pole in pleople grasp po
tent # 7,140,
stomer Servicwww.eurek
ng the peak fi
nd each is full
er at a time.
n the stakes (1ssembly with ace. Second ole and straig
,377
ce: 1 800 847 kamilitarytents
ittings into the
ly vertical.
1) and pole (2both hands. person slides
ghten pole (2)
1460 s.com
e
2). This
s ) to a
c. R
Sidescre
2. Go inall fraachiev
3. Place
4. Securthrougsectioimporsectio
5. Startin
6. Repea
7. Stakin
a. L
b. L
c. Inlo
Repeat this pro
ewall can be een walls dow
nto tent, it is imame legs (1) ave this) and s
the carabiner
re vertical fabgh slit on opp
ons tightly togrtant for extreons together w
ng at top of v
at these proce
ng sidewalls a
ocate the 12-i
ocate the rop
nsert finger inoops around f
ocedure for th
configured inwn or both clo
mportant thatare in the insidtake tubes (2
r assembly gu
bric sections. posing wall segether. Pull weme wind conwith hook and
vertical fabric
edures for all
and poles:
inch polycarb
pe loops (1) fa
nto a rope loofinger. Insert
he two end po
n three differeoth walls and
t each frame ade perimeter 2) are on the o
uy ropes over
For both attaection. Tie ofweb through landitions. Startd pile fastener
sections, con
fabric connec
bonate stakes.
acing out at th
op (1), twist rostake into bo
17 / 31
oles until entir
NOTE
ent ways: all wscreen walls
arch assemblyof the tent (it outside of the
stakes. Tens
achment pointff wind strapsadder lock foting at the top
rs.
nnect the four
ctions.
.
he base of the
ope loop to footh loops and
Cus
re tent is tensi
walls down, crolled up.
y is still verticmay be nece
e tent.
sion guy rope
ts of wind stras with an appror both ladder p of the vertic
r buckles on o
e Side Walls.
orm a figure 8drive stake in
stomer Servicwww.eurek
ioned.
cloth walls rol
cal (adjust if nessary to push
es.
aps on sidewaropriate knot lock connect
cal fabric sect
outer flap.
8. Place the tnto ground (se
ce: 1 800 847 kamilitarytents
lled up with
necessary) anh the leg in to
alls, pull strapto keep fabrictions, this is tions attach fa
two newly creee illustration
1460 s.com
nd that
ps c
abric
eated n).
Do will
d. R
e. D
not drive 12-l make it easi
Repeat step c f
Drive a stake th
-inch stakes aer to remove
for all rope lo
hrough the st
ll the way intthe stakes.
ops.
take tube (2)
18 / 31
NOTE
to the ground,
at base of cor
Cus
, leave them a
rner poles.
stomer Servicwww.eurek
about two inc
ce: 1 800 847 kamilitarytents
ches out, this
1460 s.com
OPERAT Operate d Use follow
Door is opinside to p
Outside thstraps, and Operate w Windows
The fabric
The fabric
Each laye
To fully c
TING PROC
doors
wing procedu
pened and cloprevent rain f
he tent there id secured in t
windows
can be opene
c cover and cl
c cover and cl
er must be roll
close the fabri
CEDURES
ures to operate
osed using hofrom being tra
is a sliding dothe closed pos
ed for ventilat
lear windows
lear window c
led up toward
ic cover, the c
e the doors on
ok and pile faapped within t
oor. The slidisition with bu
tion or closed
s are closed by
can each be h
ds the inside t
clear window
19 / 31
n the MGPTS
asteners. Thethe folds) and
ing door can buckles.
d due to inclem
y hook and pi
held open with
to prevent rain
must first be
Cus
S:
e inner door cd secured with
be secured in
ment weather
ile fasteners.
h tie tapes.
n from being
e unrolled and
stomer Servicwww.eurek
can be rolled uh straps at the
the open pos
r. Windows h
trapped with
d secured.
ce: 1 800 847 kamilitarytents
up (towards the top.
sition with att
have three pan
hin the folds.
1460 s.com
he
ached
nels.
Operate r
Do accusmemovpers All timpileconbreamay
Operate f Outside wtied off fo
Operate s The stovepull the cosecure itse
roof vents
not use any tyumulation of ell. If symptove affected pesonal injury o
fuel burning es. Keep roo
e fastener walnsumed by heaathing occur, y result in ser
Roof v
fabric walls
walls can be roor ventilation
stovepipe op
epipe vent is oord (1) to theelf when it is
ype of non-vef carbon monooms such as hersonnel to fror death.
heaters consuf vents clear
ll closures as naters. If sympmove affecte
rious injury or
ent is made fr
olled up (towif needed.
enings
opened and cle opposite sideclosed.
W
ented heaters.oxide gas. Caheadache, dizzresh air. Failu
ume oxygen. of snow, ice, needed to intrptoms such aed personnel tr death to per
from foam and
ards the insid
losed by pullie of the tent.
20 / 31
WARNING
. The use of narbon monoxiziness, fatigueure to comply
Adequate veor debris. Oproduce suffics headache, dto fresh air. Frsonnel.
NOTE
d is always op
de to prevent r
ing the cord (To close, pul
Cus
non-vented hide gas is not e, nausea, or
y with this wa
entilation muspen doors, wiient fresh air
dizziness, fatigFailure to com
pen, no opera
rain from bein
(1) attached toll cord to the
stomer Servicwww.eurek
heaters will cavisible and itirregular brea
arning may re
st be maintainindows, flapsto replace oxgue, nausea, o
mply with this
ation is requir
ng trapped wi
o the vent covnear side. Th
ce: 1 800 847 kamilitarytents
ause the t has no athing occur, sult in
ned at all s, hook and xygen or irregular s warning
red.
ithin the folds
ver (2). To ohe vent cover
1460 s.com
s) and
open, r will
STRIKIN
1. Make
2. Unfas
a. U
b. Dwd
3. Loose
4. Remo
5. Remo
6. Strike
a. Gdgu
b. P
c. R
d. Rin
NG TYPE III
e sure fabric is
sten buckles.
Unfasten buck
Detach hook aweb from ladd
etached.
en guy ropes t
ove stakes fro
ove carabiner
e internal arch
Go inside of teown. Removusset plate.
osition intern
Remove leg as
Retract leg assnto the upper
I TENT SYS
s dry before d
kles where fab
and pile fastender locks. Rep
to reduce tens
m rope loops
guy ropes fro
hes.
ent, using fouve internal arc
nal arch on gro
ssemblies from
semblies to shleg until the l
STEM
disassembly.
bric sections j
ners at sidewapeat this proc
sion on fabric
s and stake tub
om stakes.
r persons, stach from peak
ound outside
m folding arc
hortened lengtlocking holes
21 / 31
oin and untie
all connectioncedure until al
c. Do not rem
bes on poles a
arting at one efittings one a
of tent.
h assemblies.
th by pulling are aligned.
Cus
e wind straps
ns, pulling strll of side and
move guy rope
around skirt o
end, slowly loat a time and u
.
locking pin o Push pin bac
stomer Servicwww.eurek
from poles an
aps through scorner wall c
es.
of tent.
ower the legs,untie rope fro
out and pushinck in.
ce: 1 800 847 kamilitarytents
nd knots.
slits. Disconnconnections a
by walking tom D-ring and
ng lower leg u
1460 s.com
nect are
them d
up
e. Rth
f. R
g. Rca
7. Strike
a. R
b. L
c. R
d. M
8. Separ
a. Lm
b. U
c. U
d. U
e. R
f. U
While foldi
Retract foldinghe pin back in
Repeat proced
Remove carabarabiner/guy
e poles.
Remove guy ro
Lower poles to
Remove poles
Move poles to
rate fabric sec
Lift flap to remmid section.
Unhook D-ring
Unhook buckle
Unlace becket
Remove becke
Unhook snap
ing arch assem
g arch arms. Bn when the loc
ures a throug
iner/guy roperope assembl
opes for poles
o the ground i
from 1-1/2 in
location for p
ctions.
move the 1 1/2
g from snap h
es along wher
lace.
et lace from g
hook (2) at th
W
mbly arms, ca
By pulling oucking holes ar
h e for all int
e assembly froly to each leg
s from stakes
in the followi
nch web loop
placement in
Use tw
2-inch web lo
hook at eave j
re the end and
grommets.
he center edge
22 / 31
WARNING
aution must b
ut the locking re aligned.
ernal arches.
om web loopsassembly.
.
ing order: end
.
pole bags.
NOTE
wo-man team
oop from the s
joint sections
d mid section
e of the end a
Cus
be used to avo
pin and swin
s at side eave
d poles then c
ms.
slit at the bec
s (1).
ns meet and un
and mid sectio
stomer Servicwww.eurek
oid pinching f
nging the arms
s and clip one
corner poles.
cket lace betw
nfold flaps.
on.
ce: 1 800 847 kamilitarytents
fingers.
s in, push
e
ween each end
1460 s.com
d and
g. M Fold fabr The follow
1. The e
a. St
b. F
c. F
d. F
e. F
f. R
Move fabric se
ric sections
wing section w
end sections a
tart with the e
old each end
old end wall
old edges of r
old fabric in h
Roll fabric as i
ections for fol
will demonstr
re to be folde
end fabric sec
section wall o
over end sect
roof inward o
half, so that th
illustrated.
lding and plac
rate tent pack
ed as follows:
ction spread o
over the end s
tion roof.
on themselves
he entire widt
23 / 31
cement in tran
king procedur
out flat, with t
section roof a
s, so that both
th of the folde
Cus
nsport bags.
res for the MG
the green or t
as shown.
h meet at the c
ed section is l
stomer Servicwww.eurek
GPTS:
tan side facing
center of the e
less than 5 fe
ce: 1 800 847 kamilitarytents
g upward.
end section ro
eet.
1460 s.com
oof.
2. The m
a. St
b. Fmed
c. Fro
d. Fth
e. R
mid sections (
tart with the m
old mid sectiomiddle of the rdge, where w
old the mid soof.
old the edgeshan five feet.
Roll fabric as i
if used) are to
mid section sp
on walls overroof. Fold wa
wall meets roo
ection fabric
s of the mid se
illustrated.
o be folded as
pread out wit
r mid section alls with the wf cloth.
in on itself as
ection one fin
24 / 31
s follows.
th the green o
roof so that thwindows and
s illustrated, s
nal time, so th
Cus
r tan side up,
he two outer door onto roo
so that the edg
hat the width o
stomer Servicwww.eurek
as shown bel
edges of the fof cloth, up to
ges meet at th
of the folded
ce: 1 800 847 kamilitarytents
low.
fabric meet ato the perimete
he middle of t
section is les
1460 s.com
t the er
the
s
Instructio 1) Make s 2) Cut adh 3) Clean a 4) Peel ba 5) Apply p
END OF A
FABRIC A
ns to Patch H
ure area is clea
hesive patch at
area to be patch
acking off patch
patch over hole
APPENDIX A
ASSEMBLY E
ole or Rip in T
an and dry.
least 1” larger
hed with alcoho
h to expose adh
e or rip-use firm
A
END MODUL
Tent Fabric
r than hole or r
ol rub.
hesive.
m pressure and
LE AND FABR
REPAIR
A 00-1
ip in all directi
d pay particular
RIC ASSEMB
ions-round the
r attention to e
BLY MID MO
corners of this
edges.
Appen
DULE
s patch.
ndix A
Hand StitcA. Prepari
If you use
(1) Eto len
(2) (
singl
(3) T (4) T B. Handstdifferent simaking. (1) F
until amouside.
(2) R
grombring
(3) O
sewncomeover
FABRIC A
ching Repair iing Needle and
e two-strand thry
Estimate amounngth.
See Figure 01)e, two, or four-
(a) On
(b) Twthread the sing
(c) Fouthread pullingstrand o
Twist the strand
Tie knot at far e
titches. There aituations. Cho
Flat Stitch. (Semachine repai
unt of material,
Round Stitch. mmets. Insert thg around edge b
Overcast Stitchn patch. Insert es out to one sito the original
ASSEMBLY E
in Fabric Assed Thread
Nread you will nyou will need f
nt of thread req
). Thread sailm-strand thread.
ne end and push
wo-Strand. To through the negle thread stran
ur-Strand. To in half and ins
g it through so tof thread.
d together.
end of the sing
are five commose the one tha
ee Figure 03). rs can be made, each successi
(See Figure 04he materials at before making
h. (See Figure the needle throde and ahead oline of insertio
END MODUL
emblies
NOTE need twice as mfour times as m
quired to comp
maker’s needleas follows:
h the loop throu
make a doubleeedle until the nnd.
form four-stranert the loop enthat the eye is a
gle, two, or fou
on hand stitcheat most closely
This stitch is ue. Pass the neeive entering the
4). This stitch iright angles tothe next stitch
05). This stitcough the materof the point of on before maki
LE AND FABR
REPAIR
B 00-1
much; if you umuch.
plete stitching a
(3) with threa
ugh the eye of
e strand thread,needle is at the
nd thread, bendd into the eye oat the midpoin
r-strand thread
es used to meny resembles the
used as a tempoedle over and ue material from
is used to hando the edge of mh.
ch is used to aprial at an angle insertion, and bing the next sti
RIC ASSEMB
use four-strand,
and cut thread
ad to form a
f the needle.
, pull the e midpoint of
d a length of of the needle,
nt of the double
d.
nd fabric in e repair you are
orary fasteningunder an equal m the opposite
dwork materials and
pply a hand-so that it bring the cord itch.
BLY MID MO
,
e
e
g
Appen
DULE
Figure 01
Figure 02
Figure 03
Figure 04
Figure 05
ndix B
(4) B
seamstitchsameinto tside o
(5) F
of a tof matowarthis ofrom togetpuck
END OF A
FABRIC A
Backstitch (Seem. It is so nameh length into the place to securthe middle of thof the material
Fishbone Stitchtear unit; a pataterial to be sewrd the other, broperation on thside to side. T
ther. Make stiter the fabric.
APPENDIX B
ASSEMBLY E
e Figure 06). Ted because the he last stitch mare the cord endhe preceding sone stitch leng
h. (See Figure tch can be applwn together. Tringing the nee
he opposite sideTo keep the stittches firmly, bu
B
END MODUL
This stitch is usneedle is alwa
ade. Make twos. Continue bytitch and bringgth in advance
07). This stitclied. Insert neeTake a diagonaedle out betweee, and continuetches uniform, ut do not pull t
LE AND FABR
REPAIR
B 00-2
sed to secure anays set back on o small stitchesy inserting the ging it out on th
of preceding s
ch is used to joedle between twal stitch from oen the two edgee alternating stihold the edges
them tight enou
RIC ASSEMB
n open half of a
s in the needle
he same stitch.
oin edges wo edges
one side es. Repeat itches s smoothly ugh to
BLY MID MO
Fi
Fi
Appen
DULE
gure 06
gure 07
ndix B
Appendix PL 1
MODULAR GENERAL PURPOSE TENT SYSTEM (MGPTS TYPE III)
TAN
BASIC ITEM ISSUE
PL 1 00-1
DESCRIPTION NSN JOG P/N U/M QTY REQD
END MODULE FABRIC ASSY. - TAN
N/A 2480451 EA Small 2
TYPE III EA Medium 2 ○1 EA Large 2
MID MODULE FABRIC ASSY. - TAN
N/A 2480450 EA Small 0
TYPE III EA Medium 1 ○1 EA Large 2
INTERNAL ARCH 8340-01-515-0152 2480343 EA Small 1 TYPE III EA Medium 3
EA Large 5 END POLE 8340-01-477-9525 2480298 EA Small 2
EA Medium 2 EA Large 2
SIDE POLE 8340-01-477-9566 2480297 EA Small 4 EA Medium 4 EA Large 4
STAKES, WOOD 8340-01-478-0133 5440664 EA Small 16 EA Medium 24 EA Large 32
STAKES, PLASTIC 8340-01-478-0136 5685537 EA Small 24 EA Medium 36 EA Large 48
BAGS, END TENT N/A 2480387 EA Small 2 TYPE III EA Medium 2
○1 EA Large 2 BAGS, END FRAME N/A 2480216 EA Small 1
TYPE III EA Medium 1 EA Large 1
BAGS, MID TENT N/A 2480386 EA Small 0 TYPE III EA Medium 1
○1 EA Large 2 BAGS, MID FRAME N/A 2480215 EA Small 0
TYPE III EA Medium 1 EA Large 2
REPAIR KIT 8340-01-491-0486 2480268 TAN EA Small 1 ○1 2480289 GREEN EA Medium 1
Large 1 ○1 Interchangeable with MGPTS Type I
Appendix PL 2
MODULAR GENERAL PURPOSE TENT SYSTEM (MGPTS TYPE III)
GREEN
BASIC ITEM ISSUE
PL 2 00-1
DESCRIPTION NSN JOG P/N U/M QTY REQD END MODULE FABRIC
ASSY. N/A 2480439 EA Small 2
TYPE III EA Medium 2 ○1 EA Large 2
MID MODULE FABRIC ASSY.
N/A 2480438 EA Small 0
TYPE III EA Medium 1 ○1 EA Large 2
INTERNAL ARCH 8340-01-515-0152 2480343 EA Small 1 TYPE III EA Medium 3
EA Large 5 END POLE 8340-01-477-9525 2480298 EA Small 2
EA Medium 2 EA Large 2
SIDE POLE 8340-01-477-9566 2480297 EA Small 4 EA Medium 4 EA Large 4
STAKES, WOOD 8340-01-478-0133 5440664 EA Small 16 EA Medium 24 EA Large 32
STAKES, PLASTIC 8340-01-478-0136 5685537 EA Small 24 EA Medium 36 EA Large 48
BAGS, END TENT N/A 2480395 EA Small 2 TYPE III EA Medium 2
○1 EA Large 2
BAGS, END FRAME N/A 2480216 EA Small 1 TYPE III EA Medium 1
EA Large 1 BAGS, MID TENT N/A 2480396 EA Small 0
TYPE III EA Medium 1 ○1 EA Large 2
BAGS, MID FRAME N/A 2480215 EA Small 0 TYPE III EA Medium 1
EA Large 2 REPAIR KIT 8340-01-491-0486 2480268 TAN EA Small 1
○1 2480289 GREEN EA Medium 1 Large 1
○1 Interchangeable with MGPTS Type I