Only continue
Transcript of Only continue
Only continue if the light on the hand control is constant or flashing green and if the battery has been charged within the last 7-10 days.
When the seat reaches the top of the tub: • ReleaseyourfingerfromtheUPbutton;
• Sitonthesideflapandrotateontotheseat;
• Extendyourfeetoutinfrontofyouandkeepyour handsabovetheseat;
• PresstheDOWNbuttononthehandcontrol;
• Attachthehandcontrolandbatterytotheedgeof the tub or to a tiled wall.
Forconvenienceduringbathing,youmayraiseorlower theseattoanydesiredheightbypressingtheUPor DOWNbuttonandreleasingittostop.
Whenyouhavefinishedbathing:• Retrievethebatteryandhandcontrol;
• PresstheUPbuttonuntilthesideflapsarelevel withthetopofthetub;
• ReleasetheUPbuttonandmoveontothesideflap;
• Turnwhileliftingeachlegoutofthetub;
• Drainthetub.
5. When you are not using the bath lift:• Disconnectthebatteryandplaceoncharge;
• Storetheliftatthebottomofthetub.
Toremovetheliftfromthetub,placeitinits lowest position and:• Disconnectthebatteryfromthehandcontrol;
• Placethehandcontrolontheseat;
• Foldinthesideflaps;
• Whileholdingthetopofthebackrest,pullthe suction release tags on the rear suction feet then tilt the bath lift forward (fig 4);
• Releasethetagsonthefrontsuctionfeetandlift thebathliftoutofthetub;
• Wrapthehandcontrolcableclockwisearound the seat, positioning the cable coil under the actuatorcasing;
• Looptheremainderofthecablearoundoneof the tubes(fig 5);
• Storethebathliftuprightoronitsside.
Tracks Hand control
Figure 3
Battery
Actuator casingCable coil
Figure 5
Figure 4
Top of backrest
Suction release tag
3
Operating instructions
ContentsUnpacking the bath lift
1.Unpackingthebathlift . . . . . . . . . . . . . 5
Before you start 2. Charging the battery . . . . . . . . . . . . . . . 5
3.Preparingthetubforinstallation . . . . . . . . .6
4. Installing the bath lift . . . . . . . . . . . . . . . 7
Using the bath lift 5. Connecting the hand control . . . . . . . 8
6.Usingthebathlift . . . . . . . . . . . . . . . . . . 8
Removing and storing the bath lift 7. When the bath lift is not in use . . . 10
8.Removingthebathliftfrom the tub . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
9. Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Warranties, maintenance & servicing
10. Maintenance and servicing . . . . . . . 11
11. Warranty . . . . . . . . . . . . . . . . . . . . . . . . 12
Symbols 12.Symbols . . . . . . . . . . . . . . . . . . . . . . . . . 12
Technical data 13.Technicaldata. . . . . . . . . . . . . . . . . . . . 13
Troubleshooting 14.Troubleshooting . . . . . . . . . . . . . . . . . . 15
Parts list 15.Accessories . . . . . . . . . . . . . . . . . . . . . . 18
16.Partslist . . . . . . . . . . . . . . . . . . . . . . . . . . 20
4
1. Unpacking the bath liftOpenthepackagingandensurethebathliftisnotdamagedandthatallpartsareincluded.Ifithas
beendamagedintransitorpartsaremissing,contactyoursupplierimmediately.
Insidetheboxyouwillfind:
• Abathlift,completewithtwosideflapsandhandcontrolattached(see fig 1) • Abattery(see fig 2) • Abatterychargerwithchargingcradleattached(see fig 2)
Ifyourbathliftissuppliedwithoptionalsoftcovers,fitthematthisstage
(seecoverfittinginstructions).
Beforeinstallingorusingthebathliftforthefirsttime,ensureyouchargethebattery
(seesection2,“Chargingthebattery”below).
2. Charging the batteryBefore first operation of your bath lift or after long periods of non-use (typically 7-10 days), fully charge the battery as follows. A flat battery will take up to 2 hours to charge.
i) Slidethebatteryintothetracksonthechargingcradleuntilitclicksintoplace(see fig 2). ii) Plugthechargerintoasocket/outletoutsidethebathroomandswitchontheelectricitysupply
(ifapplicable).
iii) Thelightindicatoronthechargerboxwillinitiallyflashinaquicksequenceofred,green,red,
green, before a constant red light appears to indicate charging is in progress (see fig 2). iv) Whenthebatteryhasbeenfullycharged,theredlightonthechargerboxturnstoaconstant
greenlight,whichindicatesthebatteryisreadyforuse.Werecommendchargingthebattery
aftereachbathwhereverpossibleandleavingitonchargeuntilyournextbath.Thebattery
cannot be overcharged.
v) Whenyouarereadytouseyourfullychargedbattery(seeparagraphiv),switchoffthesocket/
outletorremovethechargerfromthesocket/outlet,then ensure you disconnect the battery from the charging cradle.(Thispreventsthebatterydischargingandwillresetthechargerreadyforitsnextuse.)
5
Diagrams for operation and explanation of use are on the fold-out diagram sheet attached to the rear of this booklet
NOTE:
• Donotchargeinthebathroomoranyhumidarea.Alwayschargeinadryarea,ensuringyourhandsaredryfirst.
•Donotcoverthebatteryorchargerwhilecharging.
•Alwayschargeonahardsurface.
•Duringcharging,thetemperatureofthechargerboxmayexceed40oC/104oF but will gradually decreaseoncetheconstantgreenlightontheboxappears.Userswithsensitive/damagedskinshouldtakecareandallowapproximately3hoursfromstartofchargingbeforehandlingthebox.
•Ensurethatnometalobjectstouchthecontactsonthebattery,asthiswilldamagethebattery.
•UseonlytheLumex®Splashchargersuppliedtochargethebatteryandfornootherpurpose.
3. Preparing the tub for installation i) Removeanynon-slipmatsfromthetub.
ii) Ensurethebottomofthetubiscleanandsmooth,withnooilortubcleanerresiduesthatwill
preventthesuctionfeetfromsticking.
iii) Thesuctionfeetmaynotbesuitableintubsthathavebeenre-enamelledorthathaverippledor
texturedsurfaces.
iv) Itisessentialthatthesideflaps(see fig 1) do not catch under any obstructions such as integral
tub handles, handrails, soap dishes and faucets when rising. If your tub has integral handles
andthesideflapsarelikelytocatch,optionalsideflapprotectorsareavailable(seesection15,
“Accessories”).Thesehookoverintegraltubhandles (see fig 3) and help guide the side flaps
smoothlyoverthehandles.
v) Ensuretherearenooverheadobstructionsattherearofthetub,wherethebathliftwillbe
positioned(e.g.wall-mountedshelves/cupboardsorshowerfixtures),astheymayinterferewith
theupwardmovementoftheseat.Wherepossible,removesuchobstructions.Alternatively,
thebathliftmustbeplacedfurtherforwardinthetubtoavoidtheobstruction(seesection4,
“Installingthebathlift”).
6
4. Installing the bath lifti) Pickupthebathliftholdingitascloseaspossibletoyourbody.
ii) Placethesuctionfeetontheflatbottomofthetubandasfarbackaspossibleattheopposite
endtothefaucets.Ifthereareanyoverheadobstructionsatthebackofthetubthatcannotbe
removedandarelikelytointerferewiththeupwardmovementofthebathlift,movethebathlift
further forward in the tub until clear of the obstacle.
iii) Nowpressfirmlydownontheseat,ensuringallfoursuctionfeetareattachedtothetubsurface.
NOTE: Thesuctionfeetmaynotsticktoverycurvedorcontouredsurfaces.
iv) Unfoldthetwosideflapssotheyrestagainstthesidesofthetub.(Sideflapseasetransfer
onandoffthebathliftandalsopreventfingerentrapment.)Ifsideflapprotectorsarerequired
andhavebeenfittedtointegraltubhandles,ensurethetwosideflapsarerestingsubstantiallyon
them.Ifthesideflapsarestilllikelytocatchunderhandles,movethesideflapprotectorsasfaras
possiblealongthehandlesuntilthesideflapsareoverthem (see fig 4). Ifthisstilldoesnotimprovetheflaps’positiononthesideflapprotectors,movethebathlift
slightlyforwardinthetub.Alternatively,asideflapprotectorextensionkitisavailable(seesection
15,“Accessories”).
v) Fillthetubwithwatertotherequiredlevelensuringtheactuatorcasing(see fig 5) is not
submergedinwater.Checkthatthewatertemperatureisnottoohotbeforeusingthebathlift.
NOTE: Water level will rise when your body enters the tub and
displaces the water.
Thedepthofthewaterisnottoexceedthedepthas
indicatedbythelabel(seeright)onthebackandsides
oftheLumex®Splash.
vi) Thebatterycannowbeconnectedtothehandcontrolonyourbathlift(seesection5,
“Connectingthehandcontrol”).
7
5. Connecting the hand control
NOTE: If the battery has not been used before or has not been used for a long period (typically 7-10
days),ensureyouplaceitonchargebeforeusingthebathlift.
i) Slidethefullychargedbatteryintothetracksonthehandcontrol(see fig 6)untilitclicks into place.
ii) Alwayscheckthebatterystatusindicatoronthehandcontrolbeforeusingthebathlift
(see fig 7).PresstheUPbuttonandobservethefollowingguidelines:
• IfGREENlight,proceedwithyourbath,providedthebatteryhasbeenchargedwithinthe
last 7-10 days.
• IfFLASHINGGREENlight,proceedwithyourbath,providedthebatteryhasbeenchargedwithin
thelast7-10days.Thenchargeimmediatelyafterwards(seesection2,“Chargingthebattery”).
• IfREDlight,doNOT use the bath lift. Charge IMMEDIATELY (seesection2,“Chargingthebattery”). • Ifinanydoubt,rechargethebatterybeforeuse(seesection2,“Chargingthebattery”).
NOTE: ThebatteryisforusesolelywithLumex®Splash bath lifts and cannot be used to operate any
other product.
6. Using the bath lift
NOTE: Ensureallfoursuctionfeetareattachedtothetubsurfacebeforeeachuse.
i) Toraisethebathlift,presstheUPbuttononthehandcontrol(see fig 7). If the side flaps are
caughtonanyobstruction,immediatelylowerthebathliftbypressingtheDOWNbuttononthe
handcontrol.Pulleachsideflapfreefromtheobstruction,thenresumetheliftingoperation.
ii) Asthebathliftreachesthetopofthetub,thesideflaponthesideyouwillbegettingonwillfold
outtoformatransferplatform.
iii) Whenthebathlift’sseatandsideflaparelevelwithandsupportedbythetopofthetub,release
yourfingerfromtheUPbuttonandthebathliftwillstop.
iv) Sitonthesideflapandmoveontotheseat,ensuringnopartofyourbodycanbecometrapped
asyoudoso(e.g.underneaththesideflaps).Youmayfinditeasiertotransferifyouwettheseat
andthesideflapsfirst.Turnasyoulifteachlegoverthesideofthetubthensitbackintheseat
andmakeyourselfcomfortable.
8
v) Beforeloweringthebathlift,extendyourfeetoutinfrontofyouandkeephandsabovetheseat
toavoidanyriskofentrapment.
vi) Toloweryourselftothebottomofthetub,presstheDOWNbuttononthehandcontrol
(see fig 7).Whenthebuttonisreleased,thebathliftwillstopandremainatthatpositionuntil
the button is pressed again.
vii) Whenyouhavereachedthebottomofthetub,thebathliftwillautomaticallystop.
viii)Whilebathing,youmayusethesuctioncupsonthebatterytoattachthehandcontrol
and battery to the edge of the tub or to a tiled wall. If the hand control and battery fall into the water, there is NO danger as both are waterproof. Ensure you wipe the battery dry before charging.
ix) Whenyouhavefinishedbathing,retrievethebatteryandhandcontrolfromwhereyouhave
storeditbypullingthetagsonthesuctioncups.PresstheUPbuttontoraisethebathlift.When
thebuttonisreleased,thebathliftwillstopandremainatthatpositionuntilthebuttonis
pressed again.
x) Oncethesideflapsarelevelwiththetopofthetub,removeyourfingerfromtheUPbuttonand
movesidewaysontothesideflap,ensuringonceagainthatnopartofthebodycanbecome
trapped as you do so.
xi) Turnwhileliftingeachlegoutofthetub.
xii)Drainthetub.
NOTE:
• IftheREDlightappearsonthehandcontrolwhilelowering,thebathliftwillnotgodownanyfurther.Ifthishappens,presstheUPbuttonandthebathliftwillraiseyoutothetopofthetub.Charge the battery immediately.
•Intheeventofanemergency,slidingthebatteryoutofthehandcontrolcaninstantly terminateallbathliftmovement.
• Whenthebathliftreachesitsmaximumlimitoftravel(upordown),therewillbeashortdelaybefore it will operate again.
•Thebathliftisnotdesignedforcontinuousoperation.Allowatleast15minutesbetweenbaths.
•DoNOTallowtheactuatorbehindthebackresttobeplacedunderaconstantflowofwater (e.g.runningfaucet)andensureitisnottotallysubmergedinwater.
9
7. When the bath lift is not in usei) Ifyouwishtocleanthebathliftwhileitisinthetub(seesection9,“Cleaning”),werecommend
doingsowhenitisatitshighestpositioninthetub.Thisallowsaccessforcleaningboththetub
and the underside of the bath lift.
ii) If the bath lift is stored in the tub, ALWAYS ensure the seat is lowered to the bottom of the tub.
NOTE: If the RED light has appeared on the hand control preventing you from lowering the
bath lift to the bottom of the tub for storage, recharge the battery immediately (see section 2, “ Charging the battery”) and lower the bath lift to the bottom of the tub as soon as possible thereafter.
iii) Disconnectthebatteryandplaceonchargereadyforyournextbath(seesection2,“Charging
thebattery”).Note: If not charging after each bath, ensure you leave the battery connected to the hand control. Disconnectfromthehandcontrolonlyifthebathliftisbeingremoved
fromthetub.
8. Removing the bath lift from the tubi) Ensurethebathliftisinitslowestpositionatthebottomofthetub.
ii) Removethebatteryfromthehandcontrol.
iii) Placethehandcontrolontheseatandfoldthesideflapsin.
iv) Holdthetopofthebackrestandasyoupullthereleasetagsoneachoftherearsuction
feet, tilt the bath lift forward (see fig 8).v) Continuetoreleasethetagsonthefrontsuctionfeetandliftthecompletebathliftoutofthe
tub.
vi) Standthebathliftupright,thenwrapthehandcontrolcableclockwisearoundboththeseat
andtubesensuringthecablecoilispositionedunderneaththeactuatorcasing.Nowloopthe
remainderofthecablearoundoneofthetubes(see fig 9).vii) Storethebathliftuprightorlayitonitsside. NOTE:
•Whenliftingthebathlift,alwaysliftclosetoyourbody.
• Toavoidaccidentaldamagetothehandcontrolwhilecarryingorstoring,ensureitis preventedfromdanglingfreely.
10
9. CleaningCleanthebathliftasfrequentlyasyoucleanyourtub,usingnon-abrasivecleaners.*Ifused
communally,werecommenddisinfectingthebathliftaftereachuse.SOLVENT-basedcleaners,such
as white spirit, should NOT be used.
i) Todisinfectthebathlift,useasoftbrushorclothandwipedownwithasterilizingsolutionor
anti-bacterialcleaner.Rinsetheproductwithcleanwater,thenwipeanddryusingacleancloth.
ii) Bath/medicinaloilsandothersolutionsareeasilyremovedwithwashing-upliquid.Donotallow
oilsorotheradditivestobuildup.Theyshouldberemovedfrequentlyotherwise,overthecourse
oftime,theymayleadtodegradationofthesuctionfeetand/ordiscolorationofthebathlift.
iii) Thebathliftcanbecleanedinanautomatedwashingmachine(toamaximumtemperatureof
73°C/163°Ffor3minutes),howeverthebatteryMUSTberemovedandwashedbyhand.The
batterymustnotbesubjectedtohightemperaturecleaning.
iv) Donotcleanorrinsetheactuatorunderaconstantflowofwater,e.g.runningfaucet,ortotally
submergeitinwater.
v) Ifyourbathliftisfittedwithsoftcovers,ensureyouremovethemonaregularbasistocleanthe
bath lift surfaces.
Itisalsoadvisabletocleanthetubsurfaceunderthesuctionfeetfromtimetotime.
*Cleaningagentsshouldbeusedinaccordancewiththeirmanufacturer’sguidelines.
NOTE: Iftheactuatorisdetachedfromthebathliftforcleaning,ensurethebatteryisalways
disconnectedfromthehandcontrol.
10. Maintenance and servicingRepairsandservicingmustbeentrustedtoaLumex®Splashauthorizeddealerorengineer.
ThebathliftshouldbeinspectedannuallybyaLumex®Splashauthorizeddealerorengineer,who
willcheckthattherearenoloosefittingsoranyotherevidenceofmechanicaldamage.
Intended life - bath liftThedurabilityofthebathlifthasbeentestedinaccordancewithBSEN10535:2006(Hoistsforthe
transferofdisabledpersons-requirementsandtestmethods). If serviced and used in accordance
withtheoperatinginstructions,thebathliftandallparts(excludingbattery)willachieve11,000
liftingcyclesor5years’use,whicheveristhesoonest.
Intended life - batteryIt is essential that the operating instructions with regards to battery use and charging is adhered
to.Thebatterylifeexpectancyis500chargecyclesor1year’suse,whicheveristhesoonest.We
recommendthebatterybereplacedaccordinglyinordertoobtainthebestperformancefromyour
bath lift.
11
11. WarrantyThisproductissoldwiththebenefitthat,intheeventofanydefectofmanufactureormaterial
appearingwithin1yearofthedateofreceiptoftheproduct,thedefectwillberectifiedfreeof
charge, provided that:
i) Reasonableevidenceisprovided(e.g.purchaseinvoiceordeliverynote)thattheproductwas
purchasednotmorethan1yearpriortothedateofclaim;and
ii) Thedefectisnotattributabletoaccidentaldamage(eitherintransitorotherwise),fairwearandtear,willfuldamage,misuseorunauthorizedrepair.
Thebatteryisalsoguaranteedfor1yeartopower(whenfullycharged)onebathingcycle*atfull load (20stone/127kg/280lbs).
Consumers’statutoryrightsarenotaffected.
* The bathing cycle:Foronebath,itisassumedthatthebathliftwillberaisedfromthebottomtotheheightofthetub
andthenloweredintothewatersupportingapersonofupto20stone/127kg/280lbs.Afterbathing,
the bath lift will raise the person to the height of the tub then the seat will be lowered tothebottomof the tub for storage.
12. Symbols Tocomplywithinternationalstandardsformedicalequipment,thefollowingsymbolsarefoundonthebathlift’slabels:
12
Symbol Explanation
Onlydirectcurrentfromasmallbatteryisusedtopoweryourbathlift.ThereisNOconnectiontoelectricityfromanoutletwheninuse,sothereisnoriskofelectricshock.
ThebathliftiscategorizedastypeBmedicalequipmentandmeetsinternationalstandardsfor electrical safety.
Thebathliftissealedtotheinternationalstandardsagainsttheeffectsofwaterspray.
Thebatteryissealedtotheinternationalstandardsagainsttheeffectsofimmersioninwatertoadepthof1metre/3.28ft3.
Thehandcontrolisprotectedagainstlongperiodsofimmersioninwaterunderpressure.
Thissymbolisfoundonthehandcontrolandmeansthelightrepresentsthebatterystatus.
PLEASEREADTHEINSTRUCTIONSBEFOREINSTALLATIONORUSE.
Donotbin/dispose.
Serialnumber.
Re-ordernumber.
IP66
IP67
IP68
13
175mm/6.89in 330mm/12.99in
Overallseatwidth-350mm/13.78in.
340mm/13.39in
510mm/20.08in175mm/6.89in
580mm/22.83in
13. Technical dataThebathliftseatandbaseismadeofglass-filledpolypropylene.Thebaseframetubesaremadeofaluminum.ThehandcontrolandbatteryaremadeofABS.Thehandcontrolbuttoncoverandsuctionfeetaremadeofthermoplasticelastomer.
Thebathliftisintheofficialcategoryof“internallypoweredequipment”andisnotsuitableforuseinthepresenceofflammableanaestheticmixturewithairornitrousoxide.
Theequipmentistestedinaccordancewith:•BSEN10535:2006•BSEN60601-1:2006•TheEuropeanCouncilDirective93/42/EECrelatingtoMedicalDevices
ThebathliftcomplieswiththeWEEEdirective.
DISPOSAL: Theplastic,metalparts,packagingmaterialsandsuctionfeetarerecyclablebuttheNickelMetalHydride(NiMH)battery,shouldbedisposedofonlybyreturningittoyoursupplier, themanufactureroranauthorizeddisposalpoint.
Symbol Explanation
Maximumload-liftingcapacity(person).
Caution!Surfacehottotouch.
Bath Lift
Liftingcapacity(person) 127kg/20stone/280lbs
Netweight(excludingbattery) 6.5kg/14.33lbs
SeatheightUP 460mm/18.11in
SeatheightDOWN(loaded) 70mm/2.76in
Powerinput 14.4Vdcnominal7Amax
Dutycycle Notmorethanonebathper15minutes
Degreeofprotection IP66
Hand Control (Battery)
Input 14.4Vdcnominal1.0A
Output 14.4Vdcnominal7Amax
Degreeofprotection IP68
Battery IP67
Battery Charger
Input 100-240Vac50-60Hz1.0A
Output 14.4Vdcnominal1.0A
Operating and charging
Temperatures
Max 40°C(104°F)
Min 0°C(32°F)
Shipping and storage
Weight(packaged) 9kg/19.84lbs
Shippingvolume 0.12m3/4.24ft3
Temperatures
Max 40°C(104°F)
Min -10°C(14°F)
Humidity
Max 90%RH
Min 10%RH
Pressure
Max 125kPa(18.4psi)
Min 73kPa(10.7psi)
14
This product is suitable for transport in pressurized aircraft holds.
15
14. Troubleshooting
Symptom Possible Cause Solution SectionBath lift does not move. No sound from the motor.
•Batteryisflat. •Chargebattery. Section2
•Batteryisnotconnected to hand control.
•Insertbatterycorrectlyintobothtrackson hand control cradle and slide all the waytotheenduntilitclicks.
Section5
•Notpressingcorrectarea on hand control buttons.
•PressarrowheadoneitherUPorDOWNbuttons. Continue to press.
Section5
•Faultyelectronicsinhand control.
•Contactsupplierorauthorizedservice/repair center.
n/a
•Batteryfault. •Contactsupplierorauthorizedservice/repaircenter.Replacebattery.
n/a
•Actuatorfault. •Contactsupplierorauthorizedservice/repair center.
n/a
Red light on hand control is on and bath lift only moves up.
•Batteryisflatorhas not been fully chargedandStopDescent™hasbeenactivated to prevent the bath lift lowering.
•Chargebatteryimmediately. Section2
Red light on hand control is on but bath lift does not move.
•Batteryisflatandhasnot been charged for long period (typically 7-10days).
•Chargebatteryimmediately.•Chargebatterybeforeuseifbathlifthas
not been used for long periods (typically 7-10days).•DoNOTstartbathwithREDlightonhandcontrol.Chargeimmediately.•EnsurebatteryisplacedonchargeassoonasyoufinishyourbathifFLASHINGGREENlightappearsonhandcontrol.•Whenbathliftisnotinuse,leavebatteryconnectedtohandcontrol.Disconnectonlyforchargingorwhenmovingbathlift.•Itisrecommendedthebatterybechargedafter each bath, wherever possible.
Section2/Section5 & Section7
•Batteryfault. •Contactsupplierorauthorizedservice/repair center.
n/a
Symptom Possible Cause Solution SectionBath lift only moves intermittently.
•Batteryisnotfullycharged.
•Chargebattery. Section2
•Excessiveuserload. •Donotusebathliftifyouweighover20st/127kg/280lbs.
Section13
•Bathlifthasencountered obstruction during lifting, e.g. integral tub handles, soap dish.
•Lowerbathlift,pullflapsfreefromobstruction,thenresumeliftingoperation.•Contactyoursupplierforoptionalsideflapprotectorsandfittoanyintegraltubhandles.
Section6 & Section15
Battery does not appear to be charged.
•Powertochargeris not switched on or charger is not connected to power socket/outlet.
•Ensurechargerplugisconnectedtopowersocket/outletandswitchon (ifapplicable).Checkforlightindicatoronchargerbox.
Section2
•Batteryisnotconnected correctly to charging cradle.
•Insertbatterycorrectlyintobothtrackson charging cradle and slide all the way totheenduntilitclicks.
Section2
•Batteryhasdischarged before use.
• Ensure battery is disconnected from charging cradle when the outlet is switched off or when charger is removed from socket/outlet.•Chargebatteryafterlongperiodsofnon-use(typically7-10days).
Section2
•Interruptiontopower supply or faultysocket/outlet.
•Checkforchargerindicatorlightsatalternativepowersocket/outlet.•Checkifotherelectricalappliances areworking.
n/a
•Chargerfault. •Contactsupplierorauthorizedservice/repair center.
n/a
•Batteryfault. •Contactsupplierorauthorizedservice/repair center.
n/a
Charger is plugged into power socket/outlet but charger indicator lights do not appear.
•Batteryisnotconnected correctly to charging cradle.
•Insertbatterycorrectlyintobothtrackson charging cradle and slide all the way totheenduntilitclicks.
Section2
•Chargerfault. •Contactsupplierorauthorizedservice/repair center.
n/a
16
17
Symptom Possible Cause Solution SectionNo lights appear on hand control when buttons are pressed.
•Batteryisnotconnected correctly to hand control.
•Insertbatterycorrectlyintobothtrackson hand control and slide all the way to theenduntilitclicks.
Section5
•Faultyelectronicsinhand control.
•Contactsupplierorauthorizedservice/repair center.
n/a
Suction feet will not stick to the tub surface.
•Frontsuctionfeetare located over rippled surfaces.
•Donotusebathlift. Section3
•Suctionfeetarelocated on very curved surfaces.
•Positionsuctionfeetonflattersurface of tub.
Section4
•Tubsurfaceisdirty/dustyorenamelisworn.
•Cleantubsurfaceandunderneathsuction feet before installing bath lift.
Section3
•Suctionfeetareoldordamaged.
•Contactsupplierorauthorizedservice/repaircenterforreplacements.
n/a
Bath lift tips backwards in highest position.
•Bathliftnotstoredproperly after bath.
•Alwayslowerbathlifttobottomoftubafteruse.(Checksuctionfeetsticktotubbeforeeachuse.)
Section7
•Frontsuctionfeetare located over rippled tub surface.
•DONOTUSEbathlift.Rippledsurfacesprevent secure suction.
Section3
•Suctionfeetarelocated on very curved surfaces.
•Positionsuctionfeetonflattersurfaceoftub.DONOTUSEiffrontsuctionfeetdonotsticktocontouredtubsurface.
Section4
•Suctionfeetnotstickingtodirty/dusty tub surface or wornenamel.
•Cleantubsurfaceandunderneathsuction feet before pressing all 4 suction feetfirmlyontotub.
Section3
•Oldordamagedsuction feet will not sticktotubsurface.
•Contactsupplierorauthorizedservice/repaircenterforreplacements.
n/a
18
15. AccessoriesThebathliftcanbesuppliedwitharangeofoptionalaccessories:
Accessory Part No.Soft cover set (back and seat) 5033A-BB3103
Providesevengreatercomfort.
Accessory Part No.Side flap protector 5033A-AB283
Sideflapprotectorsareavailableshouldyourbathliftnotsitfarbackenoughinthetubtoavoidintegralhandles.Suppliedindividually,theprotectorhooksontoatubhandletopreventsideflapfromcatchingwhenraisingthebathlift.Internalhooksectionisuniquelycoatedwithslip-resistantrubbertolimitmovementalonghandle.
Accessory Part No.Side flap protector extension kit 5033A-AB284
Comprises1sideflapprotectorand2clips.Byattachingoneormoresideflapprotectorstogether,awidersideflapprotectorcanbeformedoveranintegraltubhandle.Thislimitsthepossibilityofmovementalongthehandleorincorrectpositioning.Useseveralkitstoattachasmanysideflapprotectorsasrequiredtofitthehandlelength.
19
Accessory Part No.Side flap protector extension kit (non- hooking)
5033A-AB287
Comprises1non-hookingsideflapprotectorand2clips.Whereastandardsideflapprotectorcannotbemovedfurtheralonganintegral tub handle to enable the side flap to rest substantially overit,thiskitenablesanadditionalsideflapprotectortobeattachedbeyondtheendofthetubhandle.Thisprovidesasubstantialsurfaceareaforthesideflaptoglidesmoothlyoverthetubhandle.Useseveralkitstoattachasmanysideflapprotectorsasrequiredbeyondthetubhandle.
Accessory Part No.Extended suction feet set 5033A-BB3100
Raisesthebathliftby25mm/1inchtoenabletheseatandsideflap to reach level with the height of deep tubs.
20
15
1413
1
2
3
4
5
6
10
11
7
7
8
9
MountwayLimitedreservestherighttoalterspecificationstoproductsorpackagingatanytime.
12
16. Parts List
Item No. Description Part no.1 LeftSideFlap 5033A-BB3002L
2 Seat 5033A-BB3001
3 RightSideFlap 5033A-BB3002R
4 SideFlapHingewithScrew 5033A-A167
5 SmartChargerNiMH(US) 5033A-CU-3001
6 Battery 5033A-A230
7 SuctionFoot 5033A-BB3504
8 ActuatorLockingPin 5033A-BB3107
9 ActuatorClamp 5033A-BB3003
10 M6x12mm(0.47in)LongSocketButtonScrew(x4) 5033A-TL539
Item No. Description Part no.11 Actuator 5033A-BB3004
12 HandControlNiMH 5033A-AB105
13 CompleteBaseFrame(NoSuctionFeet) 5033A-BB3007
14 BaseFrameTubeEndCap 5033A-BB3009
15 ActuatorSnapPin 5033A-AB003SuctionFootRemovalTool(notshown) 5033A-BB3901
SuctionFeet(Setof4)withRemovalTool(notshown) 5033A-BB3504S