o II PARTS MANUAL

CUIRK EQUIPMENT

0

ICHICA o II PARTS MANUAL

No. 2000

Model 210

Tractor

-a 0

Information contained herein pertains to Tractor Section only on

Machine Serial Numbers 5UG101 thru 5UG999

Tractor Scraper (Body Section) see Parts Manual No. 2021

• CLARK EQUIPMENT COMPANY

Construction Machinery Division • Benton Harbor, Michigan, U. S. A.

In Canada: Canadian Clark, Ltd., St. Thomas, Ontario

MICHIGFIEI CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION

WHEN ORDERING REPAIR PARTS To assure the best results and to maintain the original quality built into the machine it is important that only Clark-Approved Parts be used when new parts are required.

IMPORTANT: Always furnish the distributor with the machine serial number when ordering parts. Order through your nearest Clark Distributor, for THE MICHIGAN LINE. Always give serial number of machine. Furnish: Quantity, Part Number and Description.

WHEN PARTS ARE RECEIVED immediately for quantity, correctness and condition. your Michigan Distributor of any error. for damages, during shipment, should be made to the carrier immediately.

INDEX MODEL 210 A Page C Page

Accelerator Pedal and Linkage 7 Cab Assembly 87

Accessories, Engine 1 Cable, Parking Brake 57

Adjuster, Brake Slack 51 Cable, Emergency Stop 7

Air Brake Valve 60 Cable, Engine Stop 7

Air Chamber, Brake 51 Cable, Tachometer 81

Air Cleaner Assembly 3 Cable, Wiring and Battery 85

Air Cleaner Cap 2 Cap, Air Cleaner 2

Air Cleaner Connections 2 Cap, Fuel Filler 13, 15

Air Cleaner Element 3 Cap, Radiator 5

Air Compressor Governor 59 Cap, Reservoir Breather 20, 21

Air Horn 59 Cap, Steering Wheel 63

Air Lines, Brake 59 Cartridge Kit, Oil Filter 47

Air Pressure Gauge 81 Carrier Assembly — Front Drive Planet 54

Air Pressure Sender Unit 59 Case, Transmission 24

Ammeter 81 Cleaner, Air 3

Apron, Bowl and Ejector Hydraulic Pump 73 Check Valve 59

Apron, Bowl and Ejector Hydraulic System 75 Clips 88

Axle Assembly — Front Drive 51 Clutch Cover Group, Transmission 23

Axle Housing 51 Cockpit and Fender 17, 19

Axle Housing Breather 51 Cockpit Cover Plate 17, 19 Compartment, Battery 13, 15

B Compressor, Governor 59 Battery 13, 15 Control Cover Assembly 38 Battery Box 13, 15 Control Cover Breather 38 Battery Compartment 13, 15 Control Valve Assembly 78, 79 Battery Hold Down Cover 13, 15 Controls, Brake 60 Bell Cranks — Steering Assembly 71 Controls, Parking Brake 57 Brake Air Chamber 51 Controls, Steering 65 Brake Air Lines 59 Controls, Transmission 41 Brake Assembly — Front 55 Controls, Valve Levers and Linkage 77 Brake Assembly — Parking 56 Converter Assembly, Torque 43, 44 Brake Controls 60 Converter Charging Pump 43 Brake Controls — Parking Brake Slack Adjuster

57 51

Converter Housing, Torque 44

Brake Valve, Air 51 Converter, Temperature Gauge 81

Bottom Tank, Radiator 5 Core, Radiator 5

Breather, Axle Housing 51 Cover, Battery Hold Down 13, 15

Breather, Control Cover 38 Cushions, Seat and Back-Rest 82

Bucket Seat and Floorboards 82 Cylinder, Steering 72

PM 2000

[ A ]

Check Advise Claims

CUIRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION mICHIcan

Page Page

Dash Lamp 81 Horn, Air 59

Decals 85 Horn Valve 59

Differential and Carrier Assembly — Front Drive 53 Housing, Axle 51

Drum, Brake 51 Housing, Torque Converter 44

Drum, Parking Brake 53 Hourmeter, Engine 81 Hydraulic Oil Reservoir 20, 21

E Hydraulic Pump — Apron, Bowl and Ejector 73 Element, Air Cleaner 3 Hydraulic Pump — Steering 69 Engine and Accessories 1 Hydraulic System Apron, Bowl and Ejector 75 Engine Accessories 1 Hydraulic System — Steering 67 Engine Fan 1 Hydraulic System — Transmission and Torque Converter 47 Engine Hourmeter 81 Engine Oil Pressure Gauge 81 Engine Oil Pressure Sender Unit 1 Ignition Switch 81 Engine Temperature Gauge 81 Input Drive Shaft and Forward Clutch — Group "F" ____ 21 Engine Temperature Sender Unit 1 Instrument Panel 81 Engine Support Angle 11

L F Lamp, Dash 81

Fan, Engine 1 Lamp, Head 9 Fan Shroud, Radiator 5 Light Switch 81 Fenders 17, 19 Low Range Drive Shaft — Group "C" 27 Filter Assembly — Steering System Oil 67 Lower Pivot Pin 71 Filter, Transmission Oil 47 Firewall, Grille, Hood, and Side Panels 9 M First and Third Drive Shaft -- Group "B" 37 Mount, Transmission 11 Floorboards 82 Muffler and Tail Pipe 8 Frame Assembly and Transmission Mount 11 Front Brake Assembly 55 0 Front Drive Axle Assembly 51 Oil Filter Assembly, Steering System 67

Front Drive Differential and Carrier Assembly 53 Oil Filter, Transmission 47 Front Drive Planet Carrier Assembly 54 Oil Pan, Transmission 23 Fuel Gauge 81 Oil Pressure Gauge, Engine 81 Fuel Guage Sender Unit 13, 15 Oil Reservoir, Hydraulic 20, 21 Fuel Filler Cap 13, 15 Output Shaft — Group "0" 25 Fuel Tank and Lines,

Battery Compartment and Batteries 13, 15 P Fuel Tank Strainer 13, 15 Pan, Transmission Oil 23

Panel, Instrument 81 G Panels, Side 9

Gauges, Instrument Panel 81 Parking Brake Assembly 56 Gear Shift Lever, Transmission 41 Parking Brake Cable 57 Glass Pattern Kit, Cab Assembly 87 Parking Brake Controls 57 Governor, Air Compressor 59 Pedal, Accelerator 7 Grille — Front 11 Planet Carrier Assembly — Front Drive 54 Grille — Rear 11 Pipe — Apron, Bowl and Ejector — Hydraulic System 75 Grille, Radiator 9 Pipe Assembly, Transmission and Torque Converter Guard, Transmission — Front 11 Hydraulic System 47 Guard, Transmission — Rear 11 Pipe, Firewall 67

Pipe, Tail 8 H Pitman Arm 63

Handle, Access 17, 19 Pivot Pin — Lower 71 Head Lamps 9 Pivot Pin — Upper 71 Heat Shield 17, 19 Pressure Gauge, Air 81 High Range Drive Shaft — Group "D" 29 Pressure Regulator Valve Assembly 45 Hood 9 Pressure Relief Valve — Steering System 68

[ B PM 2000

MICHIGAll CUIRK EQUIPMENT


Pressure Switch

Propeller Shafts

Pump — Apron, Bowl and Ejector Hydraulic

Pump — Converter Charging

Pump — Steering Hydraulic

Q

Quadrant, Shift Indicator

R Radiator Assembly

Radiator Cap

Radiator Connections

Radiator Core

Radiator Fan Shroud

Radiator Grille

Relief Valve Assembly, Return Cooler Oil

Relief Valve, Steering System Pressure

Regulator Valve Assembly, Pressure

Reservoir, Hydraulic Oil

Return Cooler Oil Relief Valve Assembly

Reverse Drive Shaft — Group "R"

S Safety and Pressure Regulator Valve Assembly

Seat and Floorboards

Seat Suspension Assembly

Second and Fourth Drive Shaft — Group nAH

Sender Unit, Air Pressure

Sender Unit, Engine Oil Pressure

Sender Unit, Engine Temperature

Sender Unit, Fuel Gauge

Shield, Heat Shroud, Fan

Shroud, Rear

Shutter, Ventilator

Side Panels

Steering Assembly and Bell Cranks

Steering Controls

Steering Cylinder Assembly

Steering Gear Assembly

Steering System Oil Filter Assembly

Steering System Pressure Relief Valve Steering Hydraulic Pump

Steering Hydraulic System

Steering Wheel

Strainer Fuel Tank

Support, Engine Angle

Switch, Pressure

Switch, Ignition

Switch, Light

Page

1

49

73

43

69

41

5

5

4

5

5

9

39

68

45

20, 21

39

33

45

82

82

35

59

1

1

13, 15

17, 19

5 9

17, 19 9

71

65

72

63

67

68 69

67

63

13, 15 11

1

81

81

T Page

Tachometer 81

Tail Pipe 8

Tank, Fuel 13, 15

Tank, Radiator Bottom 5

Tank, Radiator Top 5

Temperature Gauge, Converter 81

Temperature Gauge, Engine 81

Tire and Wheel Data 83

Tools 85

Torque Converter Assembly 43, 44

Torque Converter Housing 44

Transmission and Torque Converter Hydraulic System.... 47

Transmission Assembly 22

Transmission Case and Internal Tubing 24

Transmission Controls 41

Transmission Clutch Cover Group 23

Transmission First and Third Drive Shaft — Group "B" 37

Transmission Gear Shift Lever 41 Transmission High Range Drive Shaft — Group "D" 29

Transmission Input Drive Shaft and Forward Clutch — Group "F" 31

Transmission Low Range Drive Shaft — Group "C" 27

Transmission Mount 11

Transmission Oil Pan 23

Transmission Output Shaft — Group "0" 25

Transmission Reverse Drive Shaft — Group "R" 33

Transmission Second and Fourth Drive Shaft — Group "A" 35

U Upper Pivot Pin 71

V Valve, Air Brake 60

Valve Assembly, Control 78, 79

Valve Assembly, Pressure Regulator 45

Valve Assembly, Relief 39

Valve Assembly, Steering Gear 63

Valve, Check 59

Valve Control Levers and Linkage 77

Valve, Horn 59

Valve, Quick Release 59

Valve, Steering System Pressure Relief 68

Ventilator Shutter 17, 19

Wheel and Tire Data 83

Wheel, Steering 63

Wiring and Battery Cables 85

Wiring Diagram 84

Wiring, Pipe and Hose Clips 88

PM 2000

[C ]

NOTES

CLeiRK EQUIPMENT

MICHIGAll CONSTRUCTION MACHINERY DIVISION

PM 2000

CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIG1111

ENGINE AND ACCESSORIES

All orders for engine assembly or components thereof should be placed with the nearest G.M. Diesel

Distributor or Dealer. To obtain the proper items, it is necessary to provide your engine model, serial

number and accessory group type number for the equipment desired. This data is stamped on the options

and accessories plate on the rocker cover of your engine.

Note: Starter, Generator, Voltage Regulator, Fuel Filter and Air Compressor are furnished with engine.

See your local authorized G.M. Diesel Distributor for replacement or service of same.

ENGINE ACCESSORIES Item No.

Part No. Description

No. Req'd.

1 522747 FAN, Engine 1

2 586108 SPACER, Fan 1

3 18C-520 BOLT, Spacer to Fan Hub 6

4 4E-05 LKWSHR, Spacer to Fan Hub 6

5 18C-820 BOLT, Fan to Fan Spacer 6

6 4E-08 LKWSHR, Fan to Fan Spacer 6

7 551323 SENDER UNIT, Engine Temperature 2

8 940643 SENDER UNIT, Engine Oil Pressure 1

9 26F-1 ELBOW, Sender Unit 2

10 542646 NIPPLE 1

11 21F-1 CROSS 1

12 636260 SWITCH, Pressure 1

13 18C-420 BOLT, Regulator to Cockpit 4

14 18D-04 NUT, Regulator to Cockpit 4

NOTES

WHEN ORDERING PARTS, ALWAYS STATE MODEL AND SERIAL NO. OF MACHINE

PM 2000

[ 1 ]

CUIRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHICAll

AIR CLEANER CONNECTIONS Item No.


No. Req'd.

Item No.

Part No.

No. Description Req'd.

1 539042 CLAMP, Hose 2 10 533286 GASKET, Air Intake Adapter 1 2 516058 HOSE, Tube to Air Cleaner 2 11 4E-06 LKWSHR, Adapter Attaching 6 3 539042 CLAMP, Hose 2 12 17C-612 BOLT, Adapter Attaching 6 4 669881 CLAMP, Air Inlet Tube Attaching 1 13 511512 CAP, Air Cleaner 2 5 581660 TUBE, Branched Air Inlet 1 14 524936 EXTENSION, Air Cleaner 2 6 540797 CLAMP, Hose to Tube 1 15 18C-614 BOLT, Air Cleaner Attaching 8 7 513865 HOSE, Tube to Adapter 1 16 18D-06 NUT, Air Cleaner Attaching 8 8 540797 CLAMP, Hose to Adapter 1 17 532687 STRAP, Air Cleaner Mounting 2 9 581661 ADAPTER, Air Intake 1 18 AIR CLEANER — See Index


[ 2 ]

PM 2000

CL RK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAll

AIR CLEANER ASSEMBLY Two Air. Cleaners used on machine — Quantity Indicated is for one Air Cleaner

Item No.

Part No.


Item No.

Part No.


A 1 2 3 4 5 6

532675 944655 944403 944654 944405 532687 944650

AIR CLEANER ASSY (Inc. 1 thru 12)__ BODY BOLT STRAP, Upper WING NUT STRAP, Lower BOLT

1 4

1

1

1

3

3

7 8 9

10 11 12

944649 944653

944652 944633 944653

CUP, Dust GASKET, Dust Cup

§DONACLONE ASSY (See "A") GASKET ELEMENT GASKET

1 1

1 1 1

§Not Sold Separately


PM 2000

[3 ]

CUIRK EQUIPMENT


RADIATOR CONNECTIONS Item No.


No. Req'd.

Item No.

Part No.


1 RADIATOR GRILLE — See Index 19 532276 HOSE, Lower Radiator 1 2 18C-814 BOLT, Clip to Grille 2 20 522632 CLAMP, Lower Hose 1 3 18D-08 NUT, Clip to Grille 2 21 875248 CLAMP, Upper Hose 1 4 18C-814 BOLT, Clip to Radiator 2 22 581424 TUBE, Lower Radiator 1 5 664425 WASHER, Clip to Radiator 2 23 1M-18032 HOSE, Upper Radiator 1 6 592486 CLIP, Radiator to Grille 2 24 522632 CLAMP, Lower Hose 1 7 18D-08 NUT, Clip to Radiator 2 25 875248 CLAMP, Upper Hose 1 8 875248 CLAMP, Upper Hose 1 26 532276 HOSE, Lower Radiator 1 9 1M-18032 HOSE, Upper Radiator 1 27 522632 CLAMP, Lower Hose 1

10 875248 CLAMP, Upper Hose 1 28 18C-1052 BOLT, Radiator to Grille 2 11 581425 TUBE, Upper Radiator 1 29 569069 PAD, Radiator to Grille Mount 2 12 875248 CLAMP, Upper Hose 1 30 569070 WASHER, Radiator to Grille 2 13 1M-18032 HOSE, Upper Radiator 1 31 18D-10 NUT, Radiator to Grille 2 14 875248 CLAMP, Upper Hose 2 32 17C-616 BOLT, Bracket to Radiator 6 15 1M-18032 HOSE, Upper Radiator 1 33 4E-06 LKWSHR, Bracket to Radiator 6 16 875248 CLAMP, Upper Hose 1 34 569067 BRACKET, Radiator to Grille 2 17 581425 TUBE, Upper Radiator 1 35 RADIATOR — See Index 18 522632 CLAMP, Lower Hose 1 36 73F-2 DRAIN COCK, Radiator 2


[ 4 ]

PM 2000

CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION mICHIGRII

RADIATOR ASSEMBLY Item No.


No. Req'd.

Item No.

Part No.


A 569581 RADIATOR ASSY (Inc. 1 thru 20) 1 11 944082 GASKET, Bottom Tank to Core 1 1 946072 TANK, Top 1 12 1C-516 BOLT, Bottom Tank 44 2 862093 GASKET, Radiator Cap 1 13 946076 TANK, Bottom & Oil Cooler 1

3 863364 CAP, Radiator 1 14 946070 TUBE, Overflow 1 4 1C-516 BOLT, Top Tank to Core 44 14A 946071 CLIP, Overflow Tube 2 5 944084 GASKET, Top Tank to Core 1 15 655629 WASHER, Fan Shroud to Side 6 946073 SIDE MEMBER — R.H. 1 Member 10 6A 946074 SIDE MEMBER — L.H. 1 16 4G-408 BOLT, Fan Shroud, to Side Member__ 10 7 4E-05 LKWSHR, Top.Tank to Core 44 17 569600 SHROUD, Fan Blade 1 8 1D-05 NUT, Top Tank to Core 38 18 945787 HEADER BAR 2 9 1D-05 NUT, Bottom Tank to Core 38 19 945094 CORE 1

10 4E-05 LKWSHR, Bottom Tank to Core 44 20 945787 HEADER BAR 2


PM 2000

[5 ]

0 0 0

n 0 Z (#1

c n

0 Z

3 t. n Z

Z m 'a ..<

0 ....

.....,

CA ...

0 Z

MICHIGAll CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

ACCELERATOR PEDAL AND LINKAGE Item No.

Part No.


1 535003 CONNECTOR, Cable Wire 1

2 3G-1008 SCREW, Wire Connector 1

3 17C-408 BOLT, Clip Attaching 1

4 4E-04 LKWSHR, Clip Attaching 1

5 29H-7 CLIP, Emergency Stop Cable 1

6 581659 CABLE, Engine Stop 1

7 29H-9 CLIP, Engine Stop Cable 1

8 594859 CABLE, Emergency Stop 1

9 29H-7 CLIP, Engine & Emergency Stop Cables 2

10 18C-412 BOLT, Clip Attaching 1

11 531905 PLATE, Emergency Stop 1

12 18D-04 NUT, Clip Attaching 1

13 1301361 BALL JOINT

14 18C-444 BOLT, Stop to Floorboard

15 551016 STOP, Accelerator Pedal 1

16 623829 PEDAL, Accelerator

17 1F-207 COTTER, Clevis Pin

18 4F-04051 PIN, Rod to Pedal 1

19 593638 ROD ASSY, Pedal to Bell Crank (Inc. 26, 29) 1

20 551015 BRACKET, Pedal Pivot 1

21 1F-316 COTTER, Clevis Pin 1

22 623762 PIN, Pedal to Bracket

23 18C-412 BOLT, Bracket to Floorboard 2

24 66D-05 NUT, Ball Joint 1

25 18D-04 NUT, Bracket to Floorboard 2

26 8D-04 NUT, Clevis Jam


28 4F-04051 PIN, Clevis to Bell Crank 1

Item No.

Part No.


29 2J-4200 CLEVIS, Rod to Bell Crank 1

30 18D-04 NUT, Stop to Floorboard 1


32 18C-412 BOLT, Bell Crank to Cockpit 4

33 581429 BELL CRANK 1

34 18D-04 NUT, Bell Crank to Cockpit 4

35 1301361 BALL JOINT 1

36 8D-05 NUT, Ball Joint Jam 1

37 581441 ROD ASSY, Bell Crank to Bell Crank (Inc. 24, 31, 35, 36, 38, 39) 1






43 581438 ROD ASSY, Bell Crank to Engine (Inc. 13, 41, 42, 46, 47, 48) 1

44 551090 SPRING, Pedal Return 1

45 530509 CLIP, Pedal Return Spring




49 1F-308 COTTER, Wire Connector

50 351131 CONNECTOR, Cable Wire 1

51 3G-1008 SCREW, Wire Connector 1

52 594857 BRACKET, Cable

53 18D-04 NUT, Clip to Bracket

54 29H-7 CLIP, Engine Stop Cable 1

55 18C-412 BOLT, Clip to Bracket 1


PM 2000 [ 7

MICHIGI111 CUIRK EQUIPMENT


MUFFLER AND TAIL PIPE Item No.


No. Req'd.

Item No.

Part No.


1 544588 MUFFLER 1 13 588384 GASKET, Exhaust Manifold Adapter 1 2 547915 CLAMP, Tail Pipe to Muffler 1 14 4E-06 LKWSHR, Adapter to Exhaust 3 544597 PIPE, Tail 1 Manifold 4 4 15D-06 NUT, Bracket to Muffler Strap 2 15 17C-618 BOLT, Adapter to Exhaust Manifold 4 5 4E-06 LKWSHR, Bracket to Muffler Strap ____ 2 16 588384 GASKET, Exhaust Manifold Adapter 1 6 565500 BRACKET, Muffler Support 1 17 588288 ADAPTER, Exhaust Manifold 1 7 586110 STRAP, Muffler 2 18 4E-06 LKWSHR, Adapter to Exhaust 8 17C-616 BOLT, Bracket to Muffler Strap 2 Manifold 4 9 583270 CLAMP, Tube to Muffler 1 19 17C-618 BOLT, Adapter to Exhaust Manifold 4

10 569215 TUBE, Exhaust 1 20 541869 CLAMP, Tube to Adapter 1 11 541869 CLAMP, Tube to Adapter 1 21 569215 TUBE, Exhaust 1 12 588288 ADAPTER, Exhaust Manifold 1 22 583270 CLAMP, Tube to Muffler 1


[ 8 ] PM 2000

CMRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAN

FIREWALL, GRILLE, HOOD AND SIDE PANELS Item No.


No. Req'd.

Item No.

Part No.


1 583273 SHROUD, Rear 1 19 551434 BUMPER, Hood Side Panel 4 2 18C-618 BOLT, Rear Shroud Attaching 3 20 592384 PANEL, Hood Side — L.H. 1 3 980055 WASHER, Rear Shroud Attaching 3 21 12E-8 LKWSHR, Bumper to Side Panel 4 4 18D-06 NUT, Rear Shroud Attaching 3 22 12D-8 NUT, Bumper to Side Panel 4 5 584698 HOOD 1 23 18C-832 BOLT, Grille to Frame 4 6 980055 WASHER, Hood Attaching 16 24 70D-08 NUT, Grille to Frame 4 7 18C-616 BOLT, Hood Attaching 16 25 71D-08 BASE, Grille to Frame 4 8 980055 WASHER, Hood Attaching 16 26 18D-06 NUT, Grille to Grille 10 9 18D-06 NUT, Hood Attaching 16 27 980055 WASHER, Grille to Grille 10

10 581533 FIREWALL 1 28 18C-616 BOLT, Grille to Grille 10 11 980055 WASHER, Firewall Attaching 12 29 580935 GRILLE (Bolt-In) 1 12 13 14 15

18C-616 980055 18D-06 2G-1006

BOLT, Firewall Attaching WASHER, Firewall Attaching NUT, Firewall Attaching SCREW, Latch Attaching

12 12 12 8

30 31 31A

3G-808 551291 551244

SCREW, Head Lamp Ground LAMP ASSY, Head (Inc. 31A)

]'SEAL UNIT, Head Lamp

2 2 2

16 12E-10 LKWSHR, Latch Attaching 8 32 50D-8 NUT, Head Lamp Ground 2

17 614644 LATCH, Hood Side Panel 4 33 571774 GRILLE ASSY (Inc. 26 thru 29) 1

18 3G-814 SCREW, Bumper to Panel 4 34 581677 PANEL, Hood Side — R.H. 1

f Not Illustrated


PM 2000

[ 9 ]

17 18 19 20 21 22 23 24

29 28 27 30

31

n 0

z

C

0

n

Tn 70

•<

0 z

44 43 42 41 40 39

FRAME ASSEMBLY AND TRANSMISSION MOUNTS

MICHIGAIll CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

FRAME ASSEMBLY AND TRANSMISSION MOUNTS Item

Part

No. No. No. Description

Req'd.

1 583838 FRAME 1

2 18C-1036 BOLT, Engine Trunnion to Frame 2

3 18D-10 NUT, Mount to Frame 2

4 662145 STOP BLOCK, Engine Mount—Welded 4

5 569658 SHIM, Engine Mount 1

6 8C-1028 BOLT, Mounts to Engine 12

7 569000 SUPPORT, Engine Angle 1

8 616800 WASHER, Mount to Frame 2

9 18C-1044 BOLT, Mount to Frame 2

10 569658 SHIM, Engine Mount 1

11 569000 SUPPORT, Engine Angle 1

12 616800 WASHER, Mount to Frame 2

13 18C-1088 * BOLT, Mount to Frame — L.H. 2

14 572231 t WASHER, Front Trunnion Pin — Mb" —

14A 572232 WASHER, Front Trunnion Pin — 1/16"--

15 572231 $WASHER, Front Trunnion Pin —

15A 572232 t WASHER, Front Trunnion Pin — Y16"--

16 569754 PIN, Front Trunnion 1

17 569840 PLATE, Front Trunnion Locking 1

18 4E-10 LKWSHR, Lock Plate Attaching 2

19 74G-1028 BOLT, Lock Plate Attaching 2

20 569754 PIN, Front Trunnion 1

21 569840 PLATE, Front Trunnion Locking 1

22 4E-10 LKWSHR, Lock Plate Attaching 2

23 74G-1028 BOLT, Lock Plate Attaching 2

24 591789 MOUNT, Transmission — R.H. 1

25 18D-16 NUT, Mount to Transmission 8

26 18C-1664 BOLT, Mount to Transmission 8

27 18D-12 NUT, Guard to Frame 2

28 591785 MOUNT, Transmission — L.H. 1

29 24C-1656 BOLT, Mount to Frame 4

Item No.

Part No.



31 70D-12 NUT, Guard to Frame 2

32 71D-12 BASE, Guard to Frame 2

33 582922 GUARD, Drive Shaft & Trans. — Rear 1

34 664428 WASHER, Guard to Frame 2

35 18C-1236 BOLT, Guard to Frame 2

36 18D-08 NUT, Guard to Guard 2

36A 664425 WASHER, Guard to Guard 2

37 18D-12 NUT, Guard to Guard 2

38 18C-1256 BOLT, Guard to Guard 2

39 18C-1248 BOLT, Guard to Frame 2

40 664425 WASHER, Guard to Guard 2

41 18C-828 BOLT, Guard to Guard 2

42 24C-20144 BOLT, Axle Mounting 8

43 570203 COLLAR, Axle Mounting 8

44 537015 NUT, Axle Mounting 8

45 582920 GUARD, Drive Shaft & Trans.—Front 1

46 18C-1032 BOLT, Rear Grille to Frame 6

47 616800 WASHER, Rear Grille to Frame 6

47A 18D-10 NUT, Rear Grille to Frame 6

48 580498 GRILLE, Rear 1

49 570419 *SPRING, Mount to Frame 2


51 588187 *WASHER, Mount to Frame 4

52 580495 GRILLE, Front 1

53 18D-10 NUT, Front Grille to Frame 10

54 616800 WASHER, Front Grille to Frame 10

55 18C-1032 BOLT, Front Grille to Frame 10

56 18D-10 NUT, Engine Trunnion to Frame 2

57 550488 STOP BLOCK, Engine Trunnion — Welded 2

*Items 13, 49, 51 were first used on Serial Number 5UG136 and thereafter tAs Required


PM 2000

[ 11 ]

CUIRK EQUIPMENT


[12] PM 2000

Co"

CNI

0)

\\\ \ ,/.\\1://>\\ \ \\\\ /. \\\

\ A \ \

\\\

\r- \ / \ \\ /

\\ \\\\ )// \

\ ,6 \

\

\Y/ \\ \\

\ \ /\ \\\ // \\ / \\\\ \ \

\\\\\ \ \ \\\ \\ \\/\\\

\ /' zV,, -- / / \ / , /

\ '-

/ /-4----" -0;s7'7)Y//1/ / / /

__ \/ /

CO

FUE

L TA

NK

AN

D LI

NES

, BA

TT

ER

Y C

OM

PAR

TME

NT

AN

D BA

TTER

IES

T-GED-Op

CUIRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION micmcnn

FUEL TANK AND LINES, BATTERY COMPARTMENT AND BATTERIES

For Serial: 5UG105 thru 5UG112, 5UG114 thru 5UG119, 5UG122,

5UG123, 5UG125 thru 5UG130

Item No.


No. Req'd.

Item No.

Part No.


1 943957 STRAINER, Fuel Tank 1 34 11C-6152 BOLT, Hold Down Cover 4

2 556655 CAP, Fuel Tank Filler 1 35 592689 BOX, Battery 1

3 30K-306 ELBOW, Hose to Tank 1 36 4E-06 LKWSHR, Box to Compartment 4

4 18C-832 BOLT, Tank to Frame 1 37 18C-612 BOLT, Box to Compartment 4

5 3G-1008 SCREW, Sender Unit to Tank 5 38 18D-10 NUT, Compartment to Frame 3

6 516737 SENDER UNIT, Fuel Gauge 1 39 591187 t SPACER, Compartment to Frame

7 12E-10 LKWSHR, Sender Unit Terminal 1 40 591187 t SPACER, Compartment to Frame

8 14D-10 NUT, Sender Unit Terminal 1 41 4E-10 LKWSHR, Compartment to Frame

9 627982 GASKET, Sender Unit to Tank 1 42 18C-1024 BOLT, Compartment to Frame 1

10 584092 WASHER, Tank to Frame 1 43 18C-1024 BOLT, Compartment to Frame 3

11 18D-10 NUT, Tank to Frame 1 44 586628 $SHIM, Mounting Plate Support — 1/16"

12 591187 tSPACER, Tank to Frame 44A 586644 $SHIM, Mounting Plate Support — 1/8"

13 18C-1028 BOLT, Tank to Frame 1 45 FRAME — See Index

14 594086 TUBE, Fuel Tank Vent 1 46 731163 ADAPTER, Hose to Filter 1

15 38F-3 CONNECTOR, Tube to Tank 1 47 16F-16 PLUG, Fuel Tank 1

16 14G-1408 SCREW, Clip Attaching 1 48 18D-12 NUT, Rod Support 1

17 30H-18 CLIP, Vent Tube 1 49 591381 PLATE, Fuel Tank Sump 1

18 4E-04 LKWSHR, Clip Attaching 1 50 18C-616 BOLT, Sump Plate Attaching 6

19 584018 HOSE, Fuel Intake 1 51 4E-06 LKWSHR, Sump Plate Attaching 6

20 581204 HOSE, Fuel Return 1 52 25K-40428 "0" RING, Sump Plate to Fuel Tank__ 1

21 585913 ROD, Support Reinforcing 1 53 18D-12 NUT, Fuel Tank Support to Frame ____ 6

22 17D-3 NUT, Hold Down Cover 4 54 585972 WASHER, Rod Support 1

23 103293 WASHER, Hold Down Cover 4 55 18C-1028 BOLT, Tank to Frame 3

24 592692 COVER, Battery Hold Down 2 56 585972 WASHER, Fuel Tank Support to Frame 6

25 18C-832 BOLT, Compartment to Frame 1 57 4E-10 LKWSHR, Tank to Frame 3

26 584092 WASHER, Compartment to Frame 5 58 18C-1228 BOLT, Fuel Tank Support to Frame 6 27 18C-828 BOLT, Compartment to Frame 5

59 591187 $SPACER, Tank to Frame 28 71D-08 BASE, Compartment to Frame 6

60 581676 TANK, Fuel 1 29 70D-08 NUT, Compartment to Frame 6

30 585972 WASHER, Rod Support 1 61 70D-08 NUT, Fuel Tank to Frame 6

31 18D-12 NUT, Rod Support 1 62 71D-08 BASE, Fuel Tank to Frame 6

32 594095 COMPARTMENT, Battery 1 63 584092 WASHER, Fuel Tank to Frame 5

33 BATTERY — EXIDE #XF-25 4 64 18C-828 BOLT, Fuel Tank to Frame 5

tiks Required


PM 2000 [ 13 ]

CUIRK EQUIPMENT

MICHIG1111 CONSTRUCTION MACHINERY DIVISION

[14] PM 2000

FUE

L TA

NK

AN

D L

INES

, B

ATT

ER

Y C

OM

PAR

TME

NT

AN

D BA

TTE

RIES

00

grr co c,

CO

/ \, \

\ \ \\ \

\ \ \\\ ~// \ \\

\\\\ \\ \ \ \ /\ l)

\\\( \\;"—\ -- \// /

CO

\\ 6 K

(//y/(/ / \\\ M

/ -8)0E2 .. / / cw)

!R.

CY)

CUIRK EQUIPMENT


FUEL TANK AND LINES, BATTERY COMPARTMENT AND BATTERIES

For Serial: 5UG101 thru 5UG104, 5UG113, 5UG120, 5UG121,

5UG124, 5UG131 and thereafter

Item No.

Part No.


Item No.

Part No.


1 943957 STRAINER, Fuel Tank 1 29 11C-6152 BOLT, Hold Down Cover 4

2 556655 CAP, Fuel Tank Filler 1 30 592689 BOX, Battery 1

3 30K-306 ELBOW, Hose to tank 1 31 18C-612 BOLT, Box to Compartment 4

4 627982 GASKET, Sender Unit to Tank 1 31A 4E-06 LKWSHR, Box to Compartment 4

5 3G-1008 SCREW, Sender Unit to Tank 5 32 570121 tSHIM, Support Angle — Vs"

6 516737 SENDER UNIT, Fuel Gauge 1 32A 570122 $SHIM, Support Angle — 16 ga.

7 12E-10 LKWSHR, Sender Unit Terminal 1 33 659162 WASHER, Compartment to Frame 5

8 14D-10 NUT, Sender Unit Terminal 1 34 18D-08 NUT, Compartment to Frame 5

9 585913 ROD, Support Reinforcing 1 35 FRAME — See Index

10 584018 HOSE, Fuel Intake 1 36 731163 ADAPTER, Hose to Filter 1

11 594086 TUBE, Fuel Tank Vent 1

37 16F-16 PLUG, Fuel Tank 1 12 38F-3 CONNECTOR, Tube to Tank 1

38 591381 PLATE, Fuel Tank Sump 13 30H-18 CLIP, Vent Tube 1

39 4E-06 LKWSHR, Sump Plate Attaching 6 14 4E-04 LKWSHR, Clip Attaching 1

40 18C-616 BOLT, Sump Plate Attaching 6 15 14G-1408 SCREW, Clip Attaching 1

41 25K-40428 "0" RING, Sump Plate to Fuel Tank 1 16 581204 HOSE, Fuel Return 1

42 585972 WASHER, Rod Support 1 17 17D-3 NUT, Hold Down Cover 4

43 18D-12 NUT, Rod Support 1 18 103293 WASHER, Hold Down Cover 4

44 18D-08 NUT, Fuel Tank to Frame 5 19 592692 COVER, Battery Hold Down 2

45 659162 WASHER, Fuel Tank to Frame 5 20 18C-828 BOLT, Compartment to Frame—Upper 4

46 570121 $SHIM, Support Angle — Vs" 21 584092 WASHER, Compartment to Frame 4

46A 570122 $SHIM, Support Angle — 16 ga 22 71D-08 BASE, Compartment to Frame 4

47 70D-08 NUT, Fuel Tank to Frame 5 23 70D-08 NUT, Compartment to Frame 4

48 71D-08 BASE, Fuel Tank to Frame 5 24 18C-832 BOLT, Compartment to Frame 5

25 18D-12 NUT, Rod Support 1 49 570162 TANK, Fuel 1

26 585972 WASHER, Rod Support 1 50 18C-832 BOLT, Fuel Tank to Frame 5

27 570090 COMPARTMENT, Battery 1 51 584092 WASHER, Fuel Tank to Frame 5

28 BATTERY — EXIDE #XF-25 4 52 18C-828 BOLT, Fuel Tank to Frame 5

tAs Required


PM 2000 [ 15 ]

n 0 Z cn

C n

0 Z

3 / : • n 2

Z ni

V

N

0 Z

0 0 0

CU IRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGIM

COCKPIT AND FENDERS

For Serial: 5UG105 thru 5UG112, 5UG114 thru 5UG119, 5UG122, 5UG123, 5UG125 thru 5UG130

Item No.


No. Req'd.

Item No.

Part No.


1 18D-06 NUT, Tie Plate Attaching 14 23 980055 WASHER, Fender to Frame 4

2 980055 WASHER, Tie Plate Attaching 14 24 18C-616 BOLT, Fender to Cockpit 4

3 18C-616 BOLT, Tie Plate Attaching 14 25 592670 FENDER, L.H. 1

4 594106 PLATE, Cockpit, Oil Reservoir & 26 18D-06 NUT, Fender to Frame 4 Firewa I I Tie 1

27 980055 WASHER, Fender to Cockpit 4 5 ---- .HYDRAULIC OIL RESERVOIR—See Index —

28 18D-06 NUT, Fender to Cockpit 4 6 18D-06 NUT, Fender to Reservoir 1

29 503146 HANDLE, Cockpit Access 1 7 594063 SHIELD, Heat 1

30 18C-512 BOLT, Handle to Cockpit 2 8 18C-616 BOLT, Fender to Reservoir 1

31 18C-816 BOLT, Cockpit to Batt. Compartment__ 1 9 980055 WASHER, Fender to Reservoir 3

32 18D-08 NUT, Cockpit to Battery Compartment 1 10 4E-06 LKWSHR, Fender to Reservoir 3

33 18D-05 NUT, Handle to Cockpit 2 11 18C-616 BOLT, Fender to Reservoir 3

34 583809 GASKET, Ventilator 1 12 592661 FENDER, R.H. 1

35 18C-816 BOLT, Cockpit to Batt. Compartment__ 1 13 980055 WASHER, Fender to Frame 4

36 4E-08 LKWSHR, Cockpit to Batt. Compart.__ 1 14 18C-622 BOLT, Fender to Frame 4

37 583339 PLATE, Cockpit Cover 1 15 18D-06 NUT, Fender to Frame 4

38 18C-410 BOLT, Cover Plate to Cockpit 10 16 980055 WASHER, Fender Gusset Attaching___. 10

39 594418 BUSHING, Cockpit 1 17 18C-624 BOLT, Fender Gusset Attaching 10

18 594743 GUSSET, R.H. Fender 1 40 583800 VENTILATOR, Cockpit I 1

18A 594742 'I- GUSSET, L.H. Fender 1 41 511426 GROMMET, Tachometer Cable 1

19 18D-06 NUT, Fender Gusset Attaching 10 42 18D-06 NUT, Ventilator to Cockpit 4

20 18C-832 BOLT, Cockpit to Frame 1 43 18C-614 BOLT, Ventilator to Cockpit 4

20A 70D-08 NUT, Cockpit to Frame 1 44 530533 GROMMET, Wiring Harness 1

20B 71D-08 BASE, Cockpit to Frame 1 45 18C-612 BOLT, Heat Shield to Cockpit 2

21 583373 COCKPIT 45A 18D-06 NUT, Heat Shield to Cockpit 2

22 18C-622 BOLT, Fender to Frame 4 45B 980055 WASHER, Heat Shield to Cockpit ____ 4

t Not Illustrated


PM 2000 [ 17

n 0 Z tr,

xi C n -1

0 Z

3 t• n

Z

73

0 ■

.... co ... 0 Z

0 0

a = =

mann CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

COCKPIT AND FENDERS

For Serial: 5UG101 thru 5UG104, 5UG113, 5UG120, 5UG121, 5UG124, 5UG131 and thereafter

Item No.


No. Req'd.

Item No.

Part No.


1 HYDRAULIC OIL RESERVOIR — 28B 71D-08 BASE, Cockpit to Frame 4 See Index

28C 70D-08 NUT, Cockpit to Frame 4 2 18D-06 NUT, Fender to Reservoir 1

29 503146 HANDLE, Cockpit Access 1 3 594063 SHIELD, Heat 1

30 18C-512 BOLT, Handle Attaching 2 4 980055 WASHER, Fender to Reservoir 1

5 18C-616 BOLT, Fender to Reservoir 1 31 570125 COCKPIT 1

6 4E-06 LKWSHR, Fender to Reservoir 3 31A 652402 "[GROMMET, Front Lower R.H. Corner 1

7 980055 WASHER, Fender to Reservoir 3 32 18C-618 BOLT, Cockpit to Battery Compartment 6

8 18C-616 BOLT, Fender to Reservoir 3 33 980055 WASHER, Cockpit to Battery

9 592661 FENDER — R.H. 1 Compartment 6

10 980055 WASHER, Fender to Frame 4 34 4E-06 LKWSHR, Cockpit to Battery Compartment 6

11 18C-622 BOLT, Fender to Frame 4

12 18D-06 NUT, Fender to Frame 4 35 18D-05 NUT, Handle Attaching 2

13 18D-06 NUT, Fender Gusset Attaching 10 36 583809 GASKET, Ventilator 1

14 664962 WASHER, Fender Gusset Attaching 10 37 583339 PLATE, Cockpit Cover 1

15 18C-624 BOLT, Fender Gusset Attaching 10 38 18C-410 BOLT, Cover Plate to Cockpit 10

16 594743 GUSSET, Fender — R.H. 1 39 594418 BUSHING, Cockpit 1

16A 594742 "I- GUSSET, Fender — L.H. 1 40 583800 VENTILATOR, Cockpit 1

17 664962 WASHER, Fender Gusset Attaching 6 41 511426 GROMMET, Tachometer Cable 1

18 980055 WASHER, Fender to Cockpit 1 42 18D-06 NUT, Ventilator to Cockpit 4

19 4E-06 LKWSHR, Fender to Cockpit 1 43 18C-614 BOLT, Ventilator to Cockpit

20 18C-616 BOLT, Fender to Cockpit 1 44 530533 GROMMET, Wiring Harness 1

21 18C-622 BOLT, Fender to Frame 4 45 18C-612 BOLT, Heat Shield to Cockpit 2

22 980055 WASHER, Fender to Frame 4

23 18C-616 BOLT,. Fender to Cockpit 3 45A 980055 WASHER, Heat Shield to Cockpit 4

24 592670 FENDER — L.H. 1 45B 18D-06 NUT, Heat Shield to Cockpit 2

25 18D-06 NUT, Fender to Frame 4 46 18D-06 NUT, Tie Plate Attaching 14

26 980055 WASHER, Fender to Cockpit 4 47 980055 WASHER, Tie Plate Attaching 14

27 18D-06 NUT, Fender to Cockpit 3 48 594106 PLATE, Cockpit Oil Reservoir &

28 18C-832 BOLT, Cockpit to Frame 4 Firewall Tie 1

28A 584092 WASHER, Cockpit to Frame 4 49 18C-616 BOLT, Tie Plate Attaching 14

t Not Illustrated


PM 2000

[ 1 9]


HYDRAULIC OIL RESERVOIR

For Serial: 5UG105 thru 5UG112, 5UG114 thru 5UG119, 5UG122, 5UG123, 5UG125 thru 5UG130 Item No.


No. Req'd.

Item No.

Part No.


1 18C-408 BOLT, Cover to Reservoir 10 15 4E-06 LKWSHR, Inspection Cover Attaching 6 2 4E-04 LKWSHR, Cover to Reservoir 10 16 18C-622 BOLT, Reservoir to Frame 3 3 582739 COVER, Reservoir 1 17 980055 WASHER, Reservoir to Frame 3 4 641282 PLUG BUTTON, Reservoir 1 18 18D-06 NUT, Reservoir to Frame 3 5 582760 RESERVOIR, Hydraulic Oil 1 19 26F-5 ELBOW, Drain Cock 1 6 518234 CAP, Reservoir Breather 1 20 5K-611 NIPPLE, Drain Cock 1 7 25K-40428 "0" RING, Sump Plate 1 21 593786 DRAIN COCK, Reservoir 1 8 591381 PLATE, Sump 1 22 13F-12 PLUG, Drain Cock 1 9 18C-612 BOLT, Sump Plate Attaching 6 23 511426 GROMMET, Fuel Sender Wire 1

10 4E-06 LKWSHR, Sump Plate Attaching 6 24 525293 MAGNET, Reservoir 2 11 25K-40428 "0" RING, Inspection Cover 1 25 4E-08 LKWSHR, Reservoir to Fuel Tank 1 12 550389 COVER, Reservoir Inspection 1 26 18C-816 BOLT, Reservoir to Fuel Tank 1 13 550398 RING, Inspection Cover Clamp 1 27 18C-816 BOLT, Reservoir to Fuel Tank 1 14 18C-616 BOLT, Inspection Cover Attaching 6 27A 18D-08 NUT, Reservoir to Fuel Tank 1


[ 20 ]

PM 2000

5

30

29

28

21

16 15

11

18

19 TS-6320-P

CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAIll

HYDRAULIC OIL RESERVOIR For Serial: 5UG101 thru 5UG104, 5UG113, 5UG120, 5UG121, 5UG124, 5UG131 and thereafter Item No.

Part No.


Item No.

Part No,


1 18C-408 BOLT, Cover to Reservoir 10 16 980055 WASHER, Reservoir to Frame 3 2 4E-04 LKWSHR, Cover to Reservoir 10 17 18D-06 NUT, Reservoir to Frame 3 3 582739 COVER, Reservoir 1 18 18C-832 BOLT, Reservoir to Frame 1 4 518234 CAP, Reservoir Breather 1 19 584092 WASHER, Reservoir to Frame 1 5 570207 RESERVOIR, Hydraulic Oil 1 20 71D-08 BASE, Reservoir to Frame 1 6 25K-40428 "0" RING, Sump Plate 1 21 70D-08 NUT, Reservoir to Frame 1 7 591381 PLATE, Sump 1 22 525293 MAGNET, Reservoir 2 8 4E-06 LKWSHR, Sump Plate Attaching 6 23 26F-5 ELBOW, Drain Cock 1 9 18C-612 BOLT, Sump Plate Attaching 6 24 5K-611 NIPPLE, Drain Cock 1

10 25K-40428 "0" RING, Inspection Cover 1 25 593786 DRAIN COCK, Reservoir 1 11 550389 COVER, Reservoir Inspection 1 26 13F-12 PLUG, Drain Cock 1 12 550398 RING, Inspection Cover Clamp 1 27 511426 GROMMET, Fuel Sender Wire 1 13 4E-06 LKWSHR, Inspection Cover Attaching 6 28 980055 WASHER, Reservoir to Fuel Tank 6 14 18C-616 BOLT; Inspection Cover Attaching ____ 6 29 4E-06 LKWSHR, Reservoir to Fuel Tank 6 15 18C-622 BOLT, Reservoir to Frame 3 30 18C-618 BOLT, Reservoir to Fuel Tank 6


PM 2000

[21]

R

Jr-

F

A

41,

TS-1007-P

CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGIM

TRANSMISSION ASSEMBLY Item Part

No.

No. No. Description

Req'd.

A 282255 *TRANSMISSION ASSY (R-600FS-13) 1

*NOTE: Transmission Assembly, under above designation, includes all items listed on

Pages 23 thru 39. For purpose of identification, illustration above indicates by alpha-

betical designation the individual shaft group location in transmission. Code to

alphabetical designation is given below. Alphabetical designation also appears in

heading of each shaft group covered in parts listings herein.

A — Second and Four Drive Shaft Group

B — First and Third Drive Shaft Group

C — Low Range Drive Shaft Group

D — High Range Drive Shaft Group

F — Input Drive Shaft and Forward Clutch Group

O — Output Shaft Group

R — Reverse Drive Shaft Group


[ 22 ]

PM 2000

MICHIGAll CLARK EQUIPMENT


TRANSMISSION CLUTCH COVER GROUP Item No. Part No. Description

No. Req'd.

1 222074 COVER, Clutch 1 lA 222075 tGASKET, Clutch Cover 1 2 222098 COVER, Clutch 1 2A 222099 tGASKET, Clutch Cover 1 3 5C-616 BOLT & LKWSHR, Clutch Cover 16 4 25K-40120 "0" RING, Suction Pipe 1 5 222073 PIPE, Oil Suction 1 6 222070 SCREEN 1 7 222068 PAN, Oil 1 8 224944 PLUG, Drain—Magnetic 1 9 5C-620 BOLT & LKWSHR, Oil Pan 15

10 222069 GASKET, Oil Pan 2 11 13F-12 PLUG, Oil Level 1 12 5C-616 BOLT & LKWSHR, Clutch Cover 32

t Not Illustrated

WHEN ORDERING PARTS. ALWAYS STATE MODEL AND SERIAL NO. OF MACHINE PM 2000 [ 23 ]

CUIRK EQUIPMENT


TRANSMISSION CASE AND INTERNAL TUBING Item No. Part No. Description

No. Req'd.

1 222051 CASE ASSY, Transmission (Inc. 2 thru 20B) 1 2 222053 *TUBE, Input Clutch Pressure 1 3 222054 *TUBE, 2nd & 4th Clutch Pressure 1 4 222052 *TUBE, Reverse Clutch Pressure 1 5 222058 *TUBE, Reverse Drive Shaft Lubrication — Front 1 6 222061 *TUBE, 2nd & 4th Drive Shaft Lubrication — Front 1 7 222067 SLEEVE, Pressure & Lubrication Tubes 30 8 222062 *TUBE, 2nd & 4th Drive Shaft Lubrication — Rear 1 9 222066 *TUBE, High Range Drive Shaft Lubrication — Rear 1

10 222060 *TUBE, Input Drive Shaft Lubrication — Rear 1 11 222055 *TUBE, 1st & 2nd Clutch Pressure 1 12 222167 CLIP, 1st & 2nd Clutch Pressure Tube 1 12A 1H-415 tRIVET, Clip to Case 1 12B 619018 tWASHER, Clip to Case 1 13 222065 *TUBE, Low Range Drive Shaft Lubrication — Rear 1 14 222063 *TUBE, 1st & 3rd Drive Shaft Lubrication — Rear 1 15 222064 *TUBE, Low Range Drive Shaft Lubrication — Front 1 16 222059 *TUBE, Input Drive Shaft Lubrication — Front 1 17 222057 *TUBE, High Range Clutch Pressure 1 18 222167 CLIP, High Range Clutch Pressure Tube 1 18A 1H-415 tRIVET, Clip to Case 1 18B 619018 tWASHER, Clip to Case 1 19 222056 *TUBE, Low Range Clutch Pressure 1 20 222167 CLIP, Low Range Clutch Pressure Tube 1 20A 1H-420 fRIVET, Clip to Case 1 20B 619018 -MASHER, Clip to Case 1 21 221873 tJET, Lubrication 6

*NOTE: Use two (2) 222067 sleeves (item 7) when replacing any of the above tubes, one at each end of tube. Use 943374 Tube Expander to expand tube into sleeve.

f Not Illustrated

WHEN ORDERING PARTS, ALWAYS STATE MODEL AND SERIAL NO. OF MACHINE [ 24 ] PM 2000

MICHIGAI1 CLARK EQUIPMENT


OUTPUT SHAFT GROUP - "0" Item No.

Part No.


Item No.

Part No.


1

2

3

4

5

6

7

8

9

10

11

12

13

1F-440

222181

25K-60204

226961

1C-824

4E-08

654042

222133

222135

654042

4E-08

1C-824

222224

COTTER, Flange Nut

WASHER, Flange Nut

"0" RING, Flange

SEAL, Flange Oil

BOLT, Front Bearing Cap

LKWSHR, Front Bearing Cap

CONE, Output Shaft Tapered Bearing

GEAR, Low Range Driven (63T)

SPACER, Driven Gear

CONE, Output Shaft Tapered Bearing

LKWSHR, Rear Bearing Cap

BOLT, Rear Bearing Cap

CAP, Rear Bearing

5

5

1

1

1

1

5

5

1

14

14A

14B

14C

15

16

17

18

19

20

21

22

23

23A

222201

222202

222203

222204

710037

222134

710037

222203

222137

221643

222138

669897

222130

225406

$SHIM, Rear Bearing Cap — .004

$SHIM, Rear Bearing Cap — .007

tSHIM, Rear Bearing Cap — .010

tSHIM, Rear Bearing Cap — .020

CUP, Output Shaft Tapered Bearing 1

GEAR, High Range Driven (54T) 1

CUP, Output Shaft Tapered Bearing_ 1

SHIM, Front Bearing Cap 1

CAP, Front Bearing 1

DEFLECTOR, Flange 1

FLANGE ASSY, Output (Inc. 17) 1

NUT, Output Shaft Flange 1

SHAFT, Output (Inc. 23A) 1

tBUSHING, Output Shaft 1

tAs Required fit•lot Illustrated


PM 2000

[ 25 ]

0 z ti

n

O

1:6

Pzi

0

43 42 41 40 39 38

a

O O O


LOW RANGE DRIVE SHAFT GROUP "C" No.

Description Req'd.

RING, Oil Line Adapter Sealing 1

LOCK, Tapered Bearing Nut 1

BOLT, Bearing Cap 6

LKWSHR, Bearing Cap 6

BEARING, Drive Shaft Tapered 1

RING, Tapered Bearing Locating 1

SPACER, Drive Shaft Drive Gear 1

RING, Drive Gear Retaining 1

RING, Input Gear Retaining (Select one at assembly)

Item Part No. No.

1 209781

2 222078

3 1C-720

4 4E-07

5 223318

6 223993

7 222376

8 224004

9

9A 224189 t RING-.121 to .123

9B 224188 tRING-.124 to .126

9C 224190 tRING-.127 to .129

9D 224191 t RING-.130 to .132

9E 224192 t RING-.133 to .135

9F 224193 tRING-.136 to .138

9G 224194 tRING-.139 to .141

9H 224195 tRING-.142 to .144

10 655070 RING, Roller Bearing Locating-Front

11 763193 BEARING, Quill Shaft Roller-Front__

12 223995 RING, Tapered Brg. Locating-Outer__

13 731366 CUP, Quill Shaft Tapered Bearing __

13A 731367 CONE, Quill Shaft Tapered Bearing__

14 224188 RING, Tapered Brg. Locating-Inner____

15 731366 CUP, Quill Shaft Tapered Bearing ____

15A 731367 CONE, Quill Shaft Tapered Bearing__

16 6E-07 LKWSHR, Tapered Bearing Cap

17 1C-720 BOLT, Tapered Bearing Cap

18 214992 HOUSING, Bleed Valve

10J-12

BALL, Bleed Valve

763195

BEARING, Quill Shaft Roller-Rear

222210

RING, Clutch Piston Outer

222619

RING, Clutch Piston Inner

655071

RING, Roller Bearing Locating-Rear__

224433

PISTON, Clutch

Item Part No. No.

25 RING, Drum Hub Retaining (Select one at assembly)

25A 224189 fRING-.121 to .123

25B 224188 tRING-.124 to .126

25C 224190 tRING-.127 to .129

25D 224191 t RING-.130 to .132

25E 224192 tRING-.133 to .135

25F 224193 tRING-.136 to .138

25G 224194 tRING-.139 to .141

25H 224195 tRING-.142 to .144

26 222192 DISC, Clutch Inner 14

27 215509 DRUM ASSY, Clutch (Inc. 18, 19) 1

28 222186 DISC, Clutch Outer 14

29 222187 PLATE, Clutch Disc End 1

30 223994 RING, End Plate Retaining 1

31 215511 HUB ASSY, Clutch Disc 1

32 224187 RING, Clutch Disc Hub Retaining 1

33 224395 SHAFT, Low Range Drive 1

34 222226 SPRING, Clutch Disc Release 21

35 222604 PIN, Release Spring Guide 21

36 222365 SPACER, Clutch Disc Hub 1

37 222104 RING, Drive Shaft Sealing 2

38 222619 RING, Drum Hub Sealing 2

39 222129 CAP, Quill Shaft Tapered Bearing 1

40 222205 $SHIM, Tapered Bearing Cap-.004"

40A 222206 $SHIM, Tapered Bearing Cap-.007"

40B 222207 $SHIM, Tapered Bearing Cap-.010"

41 215769 GEAR, Quill Shaft Input (81T) 1

42 222128 SHAFT, Quill 1

43 222126 GEAR, Drive Shaft Drive (421) 1

44 222103 GASKET, Bearing Cap 1

45 25K-40026 "0" RING, Bearing Cap 1

46 222077 NUT, Tapered Bearing Lock 2

47 800978 CAP ASSY, Bearing (Inc. 1, 45) 1

No. Description

Req'd.

19

20

21

22

23

24

tiks Required


PM 2000

[ 27 ]

1-1

N3 03 u

i,

N 0 0 0


RING, Oil Line Adapter Sealing 1

LOCK, Tapered Bearing Nut 1

BOLT, Bearing Cap 5

LKWSHR, Bearing Cap 5

BEARING, Drive Shaft Tapered 1

RING, Tapered Bearing Locating 1

SPACER, Drive Gear 1

RING, Drive Gear Retaining 1

RING, Input Gear Retaining (Select one at assembly)

Item

Part No.

No.

1 209781

2 222078

3 1C-720

4 6E-07

5 223316

6 223991

7 222377

8 224003

9

9A 224178 t RING-.117 to .119

9B 224179 t RING-.120 to .122

9C. 224177 t RING-.123 to .125

9D 224180 tRING-.126 to .128

9E 224181 t RING-.129 to .131

9F 224182 t RING-.132 to .134

9G 224183 t RING-.135 to .137

9H 224184 tRING-.138 to .140

9J 224185 tRING-.141 to .143

10 663609

11

730245

12 223990

13 731360

13A 731361

14 224177

15 731360

15A 731361

16 6E-07

17

1C-720

18 214992

19

10J-12

20 223406

21

222213

22 222618

RING, Roller Bearing Locating-Front 1

BEARING, Quill Shaft Roller-Front____ 1

RING, Tapered Brg. Locating-Outer__ 1

CUP, Quill Shaft Tapered Bearing ____ 1

CONE, Quill Shaft Tapered Bearing__ 1

RING, Tapered Brg. Locating-Inner__ 1

CUP, Quill Shaft Tapered Bearing ____ 1

CONE, Quill Shaft Tapered. Bearing _ 1

LKWSHR, Tapered Bearing Cap 6

BOLT, Tapered Bearing Cap 6

HOUSING, Bleed Valve 1

BALL, Bleed Valve 1

BEARING, Quill Shaft Roller-Rear 1

RING, Clutch Piston - Outer 1

RING, Clutch Piston - Inner 1


23A 224178 tRING-.117 to .119

CUIRK EQUIPMENT


HIGH RANGE DRIVE SHAFT GROUP "D" Item Part


Req'd.

23B 224179 tRING-.120 to .122

23C 224177 t RING-.123 to .125

23D 224180 tRING-.126 to .128

23E 224181 tRING-.129 to .131

23F 224182 tRING-.132 to .134

23G 224183 tRING-.135 to .137

23H 224184 t RING-.138 to .140

23J 224185 tRING-.141 to .143

23K 224186 tRING-.144 to .146

24 224437 PISTON, Clutch 1

25 660883 RING, Roller Bearing Locating-Rear_ 1








33 224176 RING, Disc Hub Retaining 1

34 224508 SHAFT, High Range Drive 1

35 222226 SPRING, Clutch Release 17




39 222083 CAP, Tapered Bearing 1

40 222084 tSHIM, Tapered Bearing Cap-.004"_

40A 222085 t SHIM, Tapered Bearing Cap-.007"

40B 222086 t SHIM, Tapered Bearing Cap-.010"


42 215771 GEAR, Quill Shaft Input (42T) 1

43 222152 GEAR, Drive Shaft Drive (641) 1




47 800988 CAP ASSY, High Range Bearing (Inc. 1, 45) 1

48 222173 ttDISC, Clutch Disc Spacer (one per group if needed)

tAs Required tNot Illustrated


PM 2000 [ 29 ]

INPUT DRIVE SHAFT AND FORWARD CLUTCH GROUP - "F" TS-1629-P

0 z cf,

0 z

n

VI

0

11 13 15 17 19 21 10 12 14 16 18 20

23 25 27 29 31 33 22 24 26 28 30 32

34

35

36

37

38

51 50 49 48 47 46 45 44 43 42 41 40 39

Item Part No. No. No. Description Req'd.

1 1F-432 COTTER, Input Flange Nut 1

2 222179 WASHER, Input Flange Nut 1

3 25K-60116 "0" RING, Input Flange 1

4 228122 SEAL, Input Shaft Bearing Cap Oil 1

5 222209 RING, Input Flange Sealing 2

6 1C-720 BOLT, Input Shaft Bearing Cap 6

7 4E-07 LKWSHR, Input Shaft Bearing Cap 6

8 222093 GASKET, Input Shaft Bearing Cap 1

9 223314 BEARING, Drive Shaft Tapered 1

10 223992 RING, Tapered Bearing Locating 1

11 224003 RING, Reverse Drive Gear Retaining 1

12

12A 224178

12B 224179

12C 224177

12D 224180

12E 224181

13 663609

14 224177

15 730245

16 223990

17 731360

17A 731361

18

224177

19

731360

19A 731361

20 6E-07

21

1C-720

22 214992

23

10J-12

24 223406

25 222213

26 222618

RING, Quill Shaft Drive Gear Retaining (Select one at assembly)

t RING—.117 to .119

tRING—.120 to .122

t RING—.123 to .125

RING—.126 to .128

RING—.129 to .131

RING, Roller Bearing Locating—Front 1

RING, Quill Shaft Drive Gear Locating 1

BEARING, Quill Shaft Roller—Front____ 1

RING, Tapered Brg. Locating—Outer__ 1

CUP, Quill Shaft Tapered Bearing 1

CONE, Quill Shaft Tapered Bearing 1

RING, Bearing Locating—Inner 1






BALL, Bleed Valve 1

BEARING, Quill Shaft Roller—Rear_ 1

RING, Clutch Piston—Outer 1

RING, Clutch Piston—Inner 1

27 RING, Clutch Drum Hub Retaining (Select one at assembly)

27A 224178 RING—.117 to .119

CLeiRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAI1

INPUT DRIVE SHAFT AND FORWARD CLUTCH GROUP - "F" Item Part


Req'd.

27B 224179 t RING—.120 to .122

27C 224177 t RING—.123 to .125

27D 224180 tRING—.126 to .128

27E 224181

t RING—.129 to .131

27F 224182 t RING—.132 to .134

27G 224183 t RING—,135 to .137

27H 224184

RING—.138 to .140

27J 224185 t RING—.141 to .143

27K 224186 tRING—.144 to .146

28 224437

PISTON, Clutch 1

29

222173

DISC, Clutch Outer 9

30

215521

DRUM ASSY, Clutch (Inc. 22, 23) 1

31

216050

DISC, Clutch Inner 9

32

222172

PLATE, Clutch Disc End 1

33

223989

RING, End Plate Retaining 1

34

660883

RING, Roller Bearing Locating—Rear 1

35

215523

HUB ASSY, Clutch Disc 1

36

224176

RING, Clutch Disc Hub Retaining 1

37 801070 SHAFT ASSY, Input (Inc. 53) 1





42 222083 CAP, Quill Shaft Tapered Bearing ____ 1

43 222618 RING, Clutch Drum Hub Sealing 2

44 222084 t SHIM, Tapered Bearing Cap—.004

44A 222085 t SHIM, Tapered Bearing Cap—.007

44B 222086 t SHIM, Tapered Bearing Cap—.010


46 222081 GEAR, Quill Shaft Drive (59T) 1

47 222168 GEAR, Reverse Drive (61T) 1


49 222092 CAP, Input Shaft Bearing 1

50 222096 DEFLECTOR, Input Flange 1

51 222228 FLANGE ASSY, Input (Inc. 50) 1

52 205928 NUT, Input Flange 1

53 16F-04 PLUG, Input Shaft 1

tAs Required

WHEN ORDERING PARTS, ALWAYS STATE MODEL AND SERIAL NO.. OF MACHINE

PM 2000

[ 31

0 z

70

0

rn

0

z

a

2:1

CLARK EQUIPMENT


REVERSE DRIVE SHAFT GROUP - "R" Item No.

Part No.


1 209781 RING, Oil Line Adapter Sealing 1

2 222078 LOCK, Tapered Bearing Nut 1

3 1C-720 BOLT, Bearing Cap 5

4 4E-07 LKWSHR, Bearing Cap 5



7 224003 RING, Driven Gear Retaining 1

8 RING, Drive Gear Retaining (Select one at assembly)

8A 224178 RING-.117 to .119

8B 224179 fRING-.120 to .122

8C 224177 f RING-.123 to .125

8D 224180 f RING-.126 to .128

8E 224181 RING-.129 to .131

9 663609 RING, Roller Bearing Locating-Front 1

10 224177 RING, Drive Gear Locating 1

11 730245 BEARING, Quill Shaft Roller-Front 1


13 223990 RING, Tapered Brg. Locating-Outer 1

14 731360 CUP, Quill Shaft Tapered Bearing 1

14A 731361 CONE, Quill Shaft Tapered Bearing 1

15 224177 RING, Tapered Brg. Locating-Inner 1

16 731360 CUP, Quill Shaft Tapered Bearing 1

16A 731361 CONE, Quill Shaft Tapered Bearing 1

17 222084 SHIM, Tapered Bearing Cap-.004

17A 222085 fSHIM, Tapered Bearing Cap-.007

17B 222086 SHIM, Tapered Bearing Cap-.010_

18 6E-07 LKWSHR, Tapered Bearing Cap 6

19 1C-720 BOLT, Tapered Bearing Cap 6

20 214992 HOUSING, Bleed Valve 1

21 10J-12 BALL, Bleed Valve 1

22 223406 BEARING, Quill Shaft Roller-Rear 1

23 222213 RING, Piston Outer Sealing 1

24 222618 RING, Piston Inner Sealing 1

Item

Part


Req'd.


25A 224178 RING-.117 to .119

25B 224179 f RING-.120 to .122

25C 224177 fRING-.123 to .125

25D 224180 tRING- .126 to .128

25E 224181 RING-.129 to .131

25F 224182 f RING-.132 to .134

25G 224183 fRING-.135 to .137

25H 224184 f RING-.138 to .140

25J 224185 fRING-.141 to .143

25K 224186 RING-.144 to .146





30 222172 PLATE, Clutch Disc End


32 660883 RING, Roller Bearing Locating-Rear 1




36 224392 SHAFT, Reverse Drive 1





41 222083 CAP, Quill Shaft Tapered Bearing 1


43 222080 GEAR, Drive Shaft Driven (60T) 1





tAs Required


PM 2000 33 ]

0

z

n

0

z

rn

In

0

47 46 45 44 43 42 41 40 39 38 SECOND AND FOURTH DRIVE SHAFT GROUP — "A"

36 37 35 TS-1632-P

11 13 15 17 19 21 23 25 27 29 18 20 22 24 126 28 30

5

MICHIGIM CONSTRUCTION MACHINERY DIVISION CLeIRK EQUIPMENT

SECOND AND FOURTH DRIVE SHAFT GROUP - "A" Item Part No. No. No. Des-cription Req'd.







7 222377 SPACER, Drive Shaft Input Gear 1

8 224003 RING, Input Gear Retaining 1

RING, Quill Shaft Drive Gear Locating-(Select one at assembly)

RING-.117 to .119

t RING-.120 to .122

t RING-.123 to .125

tRING-.126 to .128

tRING-.129 to .131

t RING-.132 to .134

t RING-.135 to .137

RING, Roller Bearing Locating-Front__ 1

BEARING, Quill Shaft Roller-Front _ 1

RING, Tapered Brg. Locating-Outer__ 1



RING, Tapered Brg. Locating-Inner 1





HOUSING, Bleed Ball 1

BALL, Bleed 1

BEARING, Quill Shaft Roller-Rear 1

RING, Piston Outer Sealing 1

RING, Piston Inner Sealing 1

RING, Clutch Drum Hub Retaining (Select one at assembly)

RING-.117 to .119

Item

Part


Req'd.

23B 224179 t RING-.120 to .122

23C 224177 t RING-.123 to .125

23D 224180 t RING-.126 to .128

23E 224181 TRING-.129 to .131

23F 224182 RING-.132 to .134

23G 224183 t RING-.135 to .137

23H 224184 tRING-.138 to .140

23J 224185 t RING-.141 to .143

23K 224186 t RING-.144 to .146











34 224508 SHAFT, Second & Fourth Drive 1


36 222603 PIN, Clutch Disc Release Spring 17




40 222084 tSHIM, Tapered Bearing Cap-.004

40A 222085 tSHIM, Tapered Bearing Cap-.007

40B 222086 tSHIM, Tapered Bearing Cap-.010 -



43 222339 GEAR, Input, First & Third Drive (33 & 58T) 1





9

9A 224178

9B 224179

9C 224177

9D 224180

9E 224181

9F 224182

9G 224183

10 663609

11

730245

12 223990

13

731360

13A 731361

14 224177

15

731360

15A 731361

16

6E-07

17

1C-720

18

214992

19

10J-12

20 223406

21

222213

22

222618

23

23A 224178

tAs Required


PM 2000 [ 35 ]

0

cn

n

0 z

n

In

Pri

0

18 19 20 21 22 23 9 10 11 12 13 14 15 16 17 4

29 28 37 36 35 34 33 32 31 30

FIRST AND THIRD DRIVE SHAFT GROUP — "B" TS-1627-P

24

25

26

27

Item

Part No. No.

1 222192

2 215517

3 222186

4 224433

5 222619

6 222210

7 214992

8 10J-12

9 1C-720

10 6E-07

11 731360

11A 731361

12 224177

13 731360

13A 731361

14 223990

15 730245

16

16A 224178

16B 224179

16C 224177

16D 224180

16E 224181

16F 224182

16G 224183


DISC, Clutch Inner 8

DRUM ASSY, Clutch (Inc. 7, 8) 1

DISC, Clutch Outer 8

PISTON, Clutch 1

RING, Piston Inner Sealing 1

RING, Piston Outer Sealing 1


BALL, Bleed Valve 1





RING, Tapered Brg. Locating-Inner 1



RING, Tapered Brg. Locating-Outer 1

BEARING, Quill Shaft Roller-Front 1

RING, Driven Gear Locating (Select one at assembly)

tRING-.117 to .119

tRING-.120 to .122

t RING-.123 to .125

t RING-.126 to .128

tRING-.129 to .131

tRING-.132 to .134

t RING-.135 to .137


18 224003 RING, Driven Gear Retaining 1








CLARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAN

FIRST AND THIRD DRIVE SHAFT GROUP - "B" Item

Part


Req'd.




29 215770 GEAR, 2nd & 4th Driven (41T) 1

30 663609 RING, Roller Bearing Locating-Front 1

31 222197 GEAR, Quill Shaft Driven (56T) 1

32 222084 $SHIM, Tapered Bearing Cap-.004

32A 222085 $SHIM, Tapered Bearing Cap-.007

32B 222086 tSHIM, Tapered Bearing Cap-.010






38 224508 SHAFT, 1st & 3rd Drive 1

39 224176 RING, Clutch Disc Hub Retaining 1


41 223406 BEARING, Quill Shaft Roller-Rear 1



44 RING, Clutch Drum Hub Retaining- (Select one at assembly)

44A 224178 RING-.117 to .119

44B 224179 tRING-.120 to .122

44C 224177 tRING-.123 to .125

44D 224180 t RING-.126 to .128

44E 224181 t RING-.129 to .131

44F 224182 t RING-.132 to .134

44G 224183 RING-.135 to .137

44H 224184 tRING-.138 to .140

44J 224185 t RING-.141 to .143

44K 224186 tRING-.144 to .146


46 223994

RING, End Plate Retaining 1

47 222186 t$DISC, Clutch Disc Spacer (One per group if needed)

As Required tNot Illustrated


PM 2000

[ 37 ]

MICHIGAll CMRK EQUIPMENT


CONTROL COVER ASSEMBLY Item No.

Part No.


Item No.

Part No.


1 221777 COVER, Control 1 14 §VALVE, Forward & Reverse Selector 1A 221778 f GASKET, Control Cover 1 (See 9) 1 1B 1C-732 t BOLT, Cover — Long 3 15 224040 RING, Selector Valve Retaining 1 1C 1C-724 t BOLT, Control Cover — Short 11 16 10J-12 BALL, Selector Valve Detent 1D 4E-07 t LKWSHR, Control Cover 14 17 203647 SPRING, Detent Ball 2 224095 RING, Arm Washer Retaining 2 18 1C-632 BOLT, Control Valve to Cover 9 3 616794 WASHER, Selector Arm 1 18A 4E-06 t LKWSHR, Control Valve to Cover 9 4 221788 ARM, 1st, 2nd, 3rd & 4th Selector 1 19 25K-40026 "0" RING, Clutch Pressure 6 4A 221793 tSPACER, Selector Arm 1 20 223987 RING, Shutoff Valve Retaining 1 5 211433 BREATHER, Control Cover 1 21 224040 RING, Selector Valve Retaining 1

6 221788 ARM, Forward & Reverse Selector__ 1 22 203647 SPRING, Detent Ball 1

6A 7 8 8A

221793 616794 221944 25K-40026

f SPACER, Selector Arm WASHER, Selector Arm PLUG, Control Cover

-1'0" RING, Control Cover Plug

1 1 1 1

23 24 25 25A 26

10J-12 209382 220105 1F-208 209382

BALL, Selector Valve Detent LINK, Selector Valve PIN, Clevis

t COTTER, Clevis Pin LINK, Selector Valve

1 1 2 2 1

8B 224047 t RING, Control Cover Plug Retaining _ 1 27 224172 RING, Selector Valve Retaining 1 9 215846 HOUSING ASSY, Control Valve 28 220105 PIN, Clevis 2

(Inc. 10 thru 17, 20 thru 23, 27)____ 1 28A 1F-208 t COTTER, Clevis Pin 2 10 224172 RING, Selector Valve Retaining 1 29 10J-12 BALL, Detent 2 11 §SELECTOR VALVE ASSY (See 9) 1 30 203647 SPRING, Detent Ball 2 12 223987 RING, Spool Retaining 1 31 40K-06 PLUG, Oil Passage 6 13 221943 SPOOL, Center Bore 1 32 208812 SEAL, Selector Arm Oil 2

t Not Illustrated §Not Sold Separately


[ 38 ]

PM 2000

CU IRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION mICHIGAfl

RETURN COOLER OIL RELIEF VALVE ASSEMBLY Item No. Part No. Description

No. Req'd.

A 215988 VALVE ASSY, Relief (Inc. 1 thru 6) 1

1 215989 HOUSING, Relief Valve 1

2 215990 VALVE ASSY, Relief 1

3 223729 SPRING, Actuating 1

4 619019 WASHER, Relief Valve 1

5 4D-05 NUT, Relief Valve 1

6 1F-212 COTTER, Relief Valve Nut 1

7 4E-07 LKWSHR, Housing to Transmission Case 8

8 1C-740 BOLT, Housing to Transmission Case 8

9 221886 f GASKET, Housing to Transmission Case 1

t Not Illustrated


PM 2000

[ 39 ]

18

17

16

15

14

13

12

11

10

9

8

32

33

34

35

36

31

19 20 21

22 23 24 25 26 21 28 29

1 2 3 4 5 6

47 46 45 44 43 42 41 40

48

49

50

51

52

Tha-a53

54

55

63

62

61 60 59 58 57 56

TRANSMISSION CONTROLS

TS-2498-P

0

CA

70

n

0

rn

0 z

a

CI

CMRK EQUIPMENT


TRANSMISSION CONTROLS Item No.

Part No.


1 18C-540 BOLT, Support to Bracket 2


3 4E-07 LKWSHR, Bracket to Transmission 2

4 17C-724 BOLT, Bracket to Transmission. 2


6 4F-06106 PIN, Clevis 1

7 18C-536 BOLT, Support to Cockpit 2

8 581979 SUPPORT, Shift Lever 1

9 1F-412 COTTER, Latch Handle 1

10 581576 HANDLE, Latch 1

11 18D-04 NUT, Latch Attaching 2

12 581572 GUIDE, Latch 1

13 222545 SPRING, Latch 1

14 18C-412 BOLT, Latch Attaching 2

15 619025 WASHER, Latch Spring 1

16 18D-05 NUT, Support Attaching 2

17 581979 SUPPORT, Shift Levers 1

18 509772 KNOB, Shift Lever 2

19 581981 LEVER, Gear Shift 1

20 581980 LEVER, Forward & Reverse Shift 1

21 18C-412 BOLT, Shift Quadrant to Cockpit 2

22 581570 QUADRANT, Shift Indicator 1


24 18D-04 NUT, Shift Quadrant to Cockpit 2

25 18C-536 BOLT, Support to Cockpit 2

26 1301362 BALL SOCKET 1


28 18D-05 NUT, Support to Cockpit 2

29 18C-536 BOLT, Support Attaching 2

30 8D-06 NUT, Ball Socket Jam 1

31 582037 ROD ASSY, Lever to Control Rod — Gear Shift (Inc. 26, 30, 33, 34) 1

32 581979 SUPPORT, Control Rods 1



Item No.

Part No.


35 581984 ROD, Trans. Control — Fwd. & Rev. 1

36 581983 ROD, Trans. Control — Gear Shift 1

37 66D-06 NUT, Ball Socket to Rod 1


39 18D-05 NUT, Support Attaching 2

40 66D-06 NUT, Ball. Socket to Rod 1

41 66D-06 NUT, Ball Socket to Lever 1



44 582039 ROD ASSY, Lever to Control Rod — Forward & Reverse (Inc. 42, 43, 46, 47) 1



47 1301362 BALL SOCKET

48 582021 ROD ASSY, Transmission—Gear Shift (Inc. 49, 50) 1



51 550803 LEVER, Transmission — Fwd. & Rev. 1

52 593022 LEVER, Transmission — Gear Shift 1

53 18D-04 NUT, Lever Clamp 1

54 66D-06 NUT, Ball Socket to Lever

55 18D-04 NUT, Lever Clamp 1



58 18C-424 BOLT, Lever Clamp 1


60 18C-424 BOLT, Lever Clamp

61 582023 ROD ASSY, Transmission — Fwd. & Rev. (Inc. 57, 59) 1

62 593001 BRACKET, Trans. Control Rods 1

63 18D-05 NUT, Support to Bracket 2



66 4F-06106 PIN, Clevis


PM 2000

[ 41 ]

CUIRK EQUIPMENT


[ 42 ] PM 2000

REAR VIEW OF CONVERTER

89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63

TORQUE CONVERTER ASSEMBLY TS-4767-P

25 26

8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

105

104

103

102 101

100 -

99

96

95

94

93

92

44

45

46

47

48

49

50

51 52

55

56

57

58

59 60

61

CUIRK EQUIPMENT


TORQUE CONVERTER ASSEMBLY Item Part No. No.


Item Part No. No . No. Description Req'd.

A 281519

1

CONVERTER ASSY (Inc. 1 thru 105) C-606-6 1

FLYWHEEL—See Engine Parts Manual —

WASHER, Drive Gear to Flywheel 12

BOLT, Drive Gear to Flywheel 12

LOCKWIRE (18 ga. 20" long) 6

BOLT, Converter to Flywheel Housing 12

LKWSHR, Converter to Flywheel Hsg 12

"0" RING, Impeller to Drive Disc 1

IMPELLER, Converter 1

LKWSHR, Impeller to Drive Disc 32

BOLT, Impeller to Drive Disc 32

RING, Impeller Hub Brg. Retaining____ 1

BEARING, Impeller Hub 1

BAFFLE, Oil 1

SEAL, Oil Baffle Oil 1

RING, Driven Gear Retaining 3

GEAR, Pump Shaft Driven (35T) 3

BEARING, Pump Shaft Front 3

SHAFT, Pump Drive 3

"0" RING, Cover to Housing 1

BEARING, Pump Shaft — Rear 3

RING, Outer Washer Retaining (Select one at assembly)

$ .057 to .059

$ .060 to .062

$.063 to .065

.066 to .068

$.069 to .071

$.072 to .074

WASHER, Rear Bearing — Outer 3

WASHER, Rear Bearing — Inner 3

RING, Inner Washer Retaining 3

OUTPUT SHAFT — See Item 57

STEERING PUMP GROUP — See Items 15 thru 18, 20 thru 24

PRESSURE REGULATOR VALVE—(See Index)

PLUG, Housing Drain 1

MAIN PUMP GROUP — See Items 15 thru 18, 20 thru 24

PLUG, Housing Drain 1

31 214295 PIN, Housing to Cover Dowel

32 222001 COVER, Converter

33 221992 SLEEVE, Converter Pump Drive

34 551906 GASKET, Converter Pump

35 4E-06 LKWSHR, Steering & Converter Pump Attaching

36 8D-06 NUT, Steering & Converter Pump Attaching

37 207647 STUD, Steering & Converter Pump Attaching

38 450140 *CONVERTER CHARGING PUMP

39 222035 GEAR, Pump Drive (37T)

40 224009 RING, Drive Gear Retaining

41 218725 SLEEVE, Oil Distributor

42 RING, Turbine Shaft Bearing Retaining (Select one at assembly)

42A 223997 $.095 to .097

42B 223998 $.098 to .100

42C 223999 $.101 to .103

42D 224000 $.104 to .106

43 223334 BEARING, Turbine Shaft

44 216555 STUD, Main Pump Mounting

44A 2D-08 fNUT, Main Pump Mounting

44B 4E-08 tLKWSHR, Main Pump Mounting

45 222025 GEAR, Turbine Shaft Drive (37T)

46 224120 RING, Drive Gear Retaining

47 223570 RING, Turbine Shaft Sealing

48 10J-08 BALL, Oil Distributor Lock

49 f LOCKWIRE (18 ga.)

50 3C-820 BOLT, Support to Housing

51 675543 CUP, Output Shaft Bearing

52 100949 DEFLECTOR, Output Flange

53 209587 SEAL, Output Shaft Oil

54 222179 WASHER, Output Shaft

55 205928 NUT, Output Shaft

56 1F-436 COTTER, Output Shaft Nut

57 222026 SHAFT, Output

58 25K-60116 "0" RING,. Output Shaft

59 222232 FLANGE ASSY, Output (Inc. 52)

60 206770 STUD, Output Shaft Bearing Cap

61 2D-08 NUT, Output Shaft Bearing Cap

62 4E-08 LKWSHR, Output Shaft Bearing Cap

1

1

1

1

10

8

12

1

1

1

1

1

4

2

8

8

2

1

1

1

1

1

1

4

4

4

2 619021

3 224797

4 ----

5 17C-720

6 4E-07

7 218776

8 222017

9 4E-07

10 1C-724

11 223988

12 223368

13 218721

14 214941

15 224036

16 222037

17 225385

18 216095

19 218779

20 731742

21

21A 223595

21B 223960

21C 223961

21D 223962

21E 223963

21F 223964

22 222038

23 100838

24 224039

25

26

27 --

28 13F-20

29 ----

30 13F-20

fAs Required 1- Not Illustrated *NOTE: When Converter Charging Pump Replacement is required, only a new factory built and tested pump should be used. Proper

operation of converter and transmission is dependent on an efficient charging pump. Damage possible by use of a field rebuilt pump can result in repair cost exceeding cost of new pump alone.


PM 2000 [ 43 ]

MICHIG1111 CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

TORQUE CONVERTER ASSEMBLY (Continued) I tem No.


No. Req'd.

Item No.

Part No.


63 209588 CAP, Output Shaft Bearing 1 84 216094 HOUSING, Converter 1

64 209589 tSHIM, Bearing Cap — .004 85 222018 HUB, Impeller 1

64A 209590 tSHIM, Bearing Cap — .007 86 222002 TURBINE, Converter 1

64B 209591 t SHIM, Bearing Cap — .010 87 222004 DRIVE DISC ASSY (Inc. 97) 1

65 222033 GEAR, Output Shaft Driven (35T) 1 88 215265 GEAR, Converter Drive 1

66 13F-20 PLUG, Housing Drain 1 89 222003 GEAR, Converter Driven 1

67 731283 CONE, Output Shaft Bearing 2 90 3C-818 BOLT, Driven Gear to Drive Disc 12

68 1C-722 BOLT, Cover to Housing 12 91 tLOCKWIRE (18 ga.)

69 4E-07 LKWSHR, Cover to Housing 12 92 209673 RING, Converter Support Sealing 1

70 223900 RING, Front Bearing Retaining 1 93 302602 PIN, Reaction Member Spacer Roll ____ 1

71 222027 BAFFLE, Rear Bearing Oil 1 94 711161 RING, Reaction Member Hub Ret. 1

72 222031 TUBE, Output Shaft Oil 1 95 223859 RING, Drive Disc Bearing Retaining__ 1

73 40K-02 PLUG, Lube Line 1 96 224061 RING, Turbine Hub Retaining 2

74 218777 "0" RING,. Oil Baffle 1 97 222006 SLEEVE, Drive Disc 1

75 1C-612 BOLT, Oil Baffle Retaining 3 98 801236 SHAFT, Turbine (Inc. 46) 1

76 616786 WASHER, Oil Baffle Retaining 3 99 222007. HUB, Turbine 1

77 6E-06 LKWSHR, Oil Baffle Retaining 3 100 223387 BEARING, Drive Disc 1

78 201623 PLATE, Corm Housing Inspection 3 101 222223 BOLT, Turbine to Hub 8

79 222019 PLATE, Impeller to Hub Bolt Lock 4 102 222008 PLATE, Turbine to Hub Lock 4

80 1C-408 BOLT, Inspection Plate 6 103 218723 SUPPORT ASSY, Cony. (Inc. 41, 48)____ 1

81 4E-04 LKWSHR, Inspection Plate 6 104 218782 SPACER, Reaction Member 1

82 60K-40700 "0" RING, Impeller to Hub 1 105 801006 REACTION MEMBER & HUB ASSY 83 222221 BOLT, Impeller to Hub 8 (Inc. 93, 104) 1

tAs Required

NOTES


44

PM 2000

CUIRK EQUIPMENT


SAFETY AND PRESSURE REGULATING VALVE ASSEMBLY Item No.

Part No.


Item No.

Part No.

A 215911 VALVE ASSY (Inc. 1 thru 19) 1 12 222044 B 801167 BODY ASSY, Valve (Inc. 1, 6, 7, 11) 1 13 222043 1 ---- § BODY, Valve (See "B") 1 2 25K-40106 "0" RING, Spring Stop 1 14 222041 3 215910 SPRING, Converter Pressure Relief 15 25K-40024

Valve 1 16 633157 4 222045 ADAPTER, Relief Valve Spring 1 17 222047 5 10J-32 BALL, Relief Valve 1 18 654722 6 ---- § RING, Ball Seat Retaining (See "B") 1 19 40K-02 7 § SEAT, Relief Valve Ball (See "B") 1 20 25K-40112 8 222041 STOP, Piston 1 21 25K-30014 9 633157 PIN, Piston Stop Retaining 1 22 222034

10 25K-40024 "0" RING, Piston Stop 1 23 1C-74 11 ---- § PISTON, Valve (See "B") 1 24 4E-07

No. Description

Req'd.

SPRING, Clutch Pressure Valve — Inner 1 SPRING; Clutch Pressure Valve —

Outer 1 STOP, Spring 1 "0" RING, Spring Stop 1 PIN, Spring Stop Retaining 1 STOP, Spring 1 PIN, Spring Stop Retaining 1

tPLUG, Pressure Port 3 t"0" RING, Valve to Converter 2 t"0" RING, Valve to Converter 1 tGASKET, Valve to Converter 1 t BOLT, Valve to Converter 4 t LKWSHR, Valve to Converter 4

1Not Illustrated §Not Sold Separately


PM 2000 [ 45 ]

48 47 46 45 44 43 42 41 40 39 38 31 36 35 34 33

HYDRAULIC SYSTEM — TRANSMISSION AND TORQUE CONVERTER TS-2846—P

0

0 z

0 z

a

20 p

21 I I

II

Kt I —

L I 65 64

63

62

60

22 00.1■0100 ,414 44-7'

59

58

57

56

9 10 11 12 13 14 18 19

31 55

54 53

52

32

51 50

49

23

24

25

26

27

mICHIGAII CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

HYDRAULIC SYSTEM - TRANSMISSION AND TORQUE CONVERTER Item No.

Part No.


RADIATOR — See Index

2 582342 HOSE, Radiator to Return Line 1

3 536367 HOSE, Cooler Line to Radiator 1

4 TORQUE CONVERTER — See Index

5 31F-6 ADAPTER UNION 1

6 582305 HOSE, Converter to Cooler Line 1




10 18C-624 BOLT, Pipe to Frame 2

10A 18D-06 NUT, Pipe to Frame 2

10B 980055 WASHER, Pipe to Frame 2

11 582249 PIPE, Cooler & Suction 1

12 784663 CLAMP, Hose 2

13 585883 HOSE, Tube to Tube 1

14 582242 TUBE, Suction 1

15 18C-618 BOLT, Pipe to Bracket 2

15A 18D-06 NUT, Pipe to Bracket 2

15B 980055 WASHER, Pipe to Bracket 2

16 18D-07 NUT, Filter Attaching 4

17 661428 ADAPTER UNION 1

18 18C-722 BOLT, Filter Attaching 4

19 215500 FILTER ASSY (Inc. 19A) 1

19A 215502 f CARTRIDGE KIT, Filter 2


21 582306 HOSE, Filter to Converter 1

22 582778 HOSE, Pump to Filter — Pressure 1

23 582299 HOSE, Return Line to Transmission 1

24 784663 CLAMP, Hose 1




28 784663 CLAMP, Hose 1


30 784663 CLAMP, Hose 1

31 585883 HOSE, Tube to Stem 1

32 784663 CLAMP, Hose 1

Item No.

Part No.


33 TRANSMISSION ASSY- See Index

34 593117 STEM, Tube to Transmission 1

35 592849 STEM, Tube to Transmission 1

36 784663 CLAMP, Hose 1


38 784663 CLAMP, Hose 1

39 582298 HOSE, Pipe to Transmission 1

40 580734 TUBE, Drain 1

41 784663 CLAMP, Hose 1


43 784663 CLAMP, Hose 1


45 784663 CLAMP, Hose 1

46 784663 CLAMP, Hose 1

47 18C-618 BOLT, Pipe to Bracket 2

47A 18D-06 NUT, Pipe to Bracket 2

47B 980055 WASHER, Pipe to Bracket 2

48 582805 HOSE, Regulator Valve to Pipe 1

49 25K-40110 "0" RING, Hose to Pump 1

50 580591 PIPE 1

51 17C-620 BOLT, Flange Half to Pump 4

51A 4E-06 LKWSHR, Flange Half to Pump 4

52 784663 CLAMP, Hose 1


54 784663 CLAMP, Hose 1

55 663093 FLANGE HALF, Hose to Pump 2

56 663094 FLANGE HALF, Stem to Pump 2

57 17C-720 BOLT, Flange Half to Pump


58 581482 TUBE, Converter Drain 1

59 784663 CLAMP, Hose 1


61 784663 CLAMP, Hose 1

62 593117 STEM, Tube to Converter 1

63 25K-40116 "0" RING, Stem to Pump 1

64 582246 STEM, Hose to Pump 1


tNot Illustrated


PM 2000 [ 47

NOTES

CUIRK EQUIPMENT


[48] PM 2000

CMRK EQUIPMENT


PROPELLER SHAFTS Item No.

Converter to Transmission

Transmission to Axle Description

No. Req'd.

A 566266 516132 PROP SHAFT ASSY (Inc. 1 thru 16) 1

1 940229 940229 BOLT, Spider & Bearing to Tube 4

2 942735 941573 SPIDER & BEARING (Inc. 2A) 1

2A 941509 941509 tSEAL, Spider & Bearing Grease 4

3 945883 943668 TUBE 1

4 8D-08 8D-08 NUT, Spider & Bearing to Tube 4

5 940250 940256 RETAINER, Felt 1

6 940251 940257 WASHER, Felt Retainer 2

7 942734 940226 SLIP YOKE 1

8 8D-08 8D-08 NUT, Spider & Bearing to Slip Yoke 4

9 942735 941573 SPIDER & BEARING (Inc. 9A) 1

9A 941509 941509 tSEAL, Spider & Bearing Grease 4

10 940229 940229 BOLT, Spider & Bearing to Slip Yoke 4

11 944688 10H-35 FITTING, Spider & Bearing Grease 1

12 10H-25 10H-25 FITTING, Slip Yoke Grease 1

13 942749 940259 WASHER, Felt 1

14 940229 940229 BOLT, Spider & Bearing Attaching 8

15 944688 10H-35 FITTING, Spider & Bearing Grease 1

16 8D-08 8D-08 NUT, Spider & Bearing Attaching 8

t Not Illustrated


PM 2000

[ 49 ]

0 z

0 z

rn

70

0 z

B

C3

27 26 25 24

FRONT DRIVE AXLE ASSEMBLY TS-4859-P

10 11 12

13 14 15 16 17 18 19

20

21

13 12 11

70

42 41 40 39

44 45 46 43

31 32 33 34

7 5 6 1 2 3

29 30

1 76

15 14

35 36 37 38

Ui 0

0 0 0

MARK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION mICHIc1111

FRONT DRIVE AXLE ASSEMBLY Item No.

Part No.


A 130901 AXLE ASSY (Inc. 1 thru 76) 1

1 1C-632 BOLT, Dust Cover 6

2 4E-06 LKWSHR, Dust Cover Bolt 6

3 OMIT (Not used this Application)

4 108477 COVER, Brake Dust 4

5 655673 SPACER, Dust Cover 12

6 BRAKE ASSY, See Index

7 108472 BOLT, Spindle & Brake Attaching ____ 24

8 111338 BOLT, Internal Gear to Hub 12

8A 106762 tWASHER, Internal Gear to Hub Bolt 12

9 107995 HUB, Internal Gear 2

10 107996 GEAR, Internal 2

11 114434 NUT, Inner Spindle 2

12 114434 NUT, Outer Spindle 2

13 108031 "0" RING, Planet Carrier 2

14 PLANET CARRIER — See Index

15 585674 STUD, Wheel 32

16 64D-14 NUT, Wheel 32

17 108478 WASHER, Sun Gear Thrust 2

18 108030 GEAR, Sun 2

19 108475 WASHER, Sun Gear Thrust Cap 2

20 116923 "0" RING, Cap to Carrier Seal 2

21 116937 CAP ASSY, Sun Gear Thrust (Inc. 19) 2

22 106762 WASHER, Thrust Cap Mounting 18

23 1C-824 BOLT, Thrust Cap Mounting 18

24 224073 RING, Sun Gear Retaining 2

25 710855 PLUG, Planet Filler 2

26 1C-1030 BOLT, Planet Carrier 6

27 4E-10 LKWSHR, Planet Carrier 6

28 108028 LOCK, Spindle Nut 2

29 110814 SPRING, Brake Return 2

30 108464 DRUM, Brake 2

31 107983 CATCHER,. Oil 2

32 111476 SEAL, Hub Oil 2

33 731984 CONE, Inner Hub Bearing 2

34 731982 CUP, Inner Hub Bearing 2

35 109129 HUB ASSY (Inc. 34, 36) 2

36 742260 CUP, Outer Hub Bearing 2

37 731988 CONE, Outer Hub Bearing 2

38 108471 SHAFT, Axle 2

39 111461 BOLT, Brake Drum 24

39A 111656 WASHER, Brake Drum 24

Item

Part


Req'd.

40

CAM SHAFT

40A 111254

RIGHT HAND 1

40B 111253

LEFT HAND 1

41

107735

WASHER, Cam Shaft Thrust 2

42

12H-15

FITTING, Brake Spider Grease 2

43

111252

HOUSING, Axle 1

44

12F-300

PLUG, Housing Expansion 1

45

11F-16

PLUG, Housing Filler 1

46 103452

BREATHER, Axe Housing 1

47

107732

NUT, Spindle & Brake Attaching 24

48

111658

WASHER, Spindle & Brake Attaching 24

49 108470 SPINDLE END 2

50 660516 RING, Cam Shaft Retaining 2

51 107736 WASHER, Cam Shaft Retaining 2

52 BRACKET, Air Chamber

52A 111255 RIGHT HAND 1

52B 111256 CLEFT HAND 1

53 11E-135 RETAINER, Cam Shaft Grease 2



56 107010 WASHER, Cam Shaft Retaining 2

57 107739 BUSHING, Air Chamber Bracket 2

58 10H-25 FITTING, Air Chamber Bracket Grease 2

59 108476 *ADJUSTER, Slack — B.W. #226655 2

60 4E-12 LKWSHR, Air Chamber Bracket 4

61 1C-1236 BOLT, Air Chamber Bracket 4

62 110206 *AIR CHAMBER — B.W. #229403 2

62A 944735 *t DIAPHRAGM, Air Chamber — B.W. #234362 2

63 104412 WASHER, Carrier Attaching 4

64 112537 BOLT, Carrier Attaching 4

65 DIFF. & CARRIER ASSY — See Index —

66 17C-1032 BOLT, Carrier Attaching 18

67 104412 WASHER, Carrier Attaching 18

68 593478 BRACKET, Release Valve 1

69 731221 PLUG, Housing Drain 1

70 25K-60124 "0" RING, Cam Shaft 2

71 107739 BUSHING, Brake Spider 2


73 107736 WASHER, Cam Shaft Grease 2


75 4E-06 LKWSHR, Dust Cover 6

76 1C-632 BOLT, Dust Cover 6

'Mot Illustrated *NOTE: Your local authorized Bendix-Westinghouse Distributor is equipped to service and supply these parts.


PM 2000

[ 51 ]

31 30 29 DIFFERENTIAL AND CARRIER ASSEMBLY - FRONT DRIVE TS-3774-P

n JA

0

z 411

0 z

tn

0 z

a C3

10

11

12

13

Item No.

Part No.


A 116477 DIFFERENTIAL & CARRIER ASSY (Inc. 1 thru 45) 1

1 107901 LOCK, Differential Adjusting Nut 2

2 4E-07 LKWSHR, Adjusting Nut Lock 2

3 3C-716 BOLT, Adjusting Nut Lock 2

4 107892 BOLT, Differential Case 8

5 §DIFFERENTIAL CASE, Plain Half (See 49) 1

6 116426 WASHER, Side Gear Thrust 2

7 107958 GEAR, Differential Side 2

8 815748 PINION KIT, Differential 1

9 116422 WASHER, Differential Pinion Thrust — With Tangs

9A 111615 ]'WASHER, Differential Pinion Thrust — Without Tangs 4

10 116427 SPIDER, Differential 1

11 2C-940 BOLT, Ring Gear 12

12 §RING GEAR (See 48) 1

13 § .DIFF. CASE, Flange Half (See 49)

14 104168 NUT, Ring Gear Bolt 12

15 224052 RING, Pinion Bearing Retaining 1

16 731995 BEARING, Inner Pinion 1

17 §PINION (See 48) 1

18 §CAP, Differential Carrier (See 19) ____ 2

19 107962 CARRIER ASSY, Diff. (Inc. 18, 42, 42A) 1

20 710987 CONE, Center Pinion Bearing 1

21 710986 CUP, Center Pinion Bearing 1

22 815352 SPACER KIT, Pinion Bearing 1

23 107973 fSHIM, Pinion Bearing Cage — .004" —

23A 107974 t SHIM, Pinion Bearing Cage — .007" —

23B 107975 t SHIM, Pinion Bearing Cage — .010" —

24 108451 CAGE ASSY, Pinion Bearing (Inc. 21 & 25) 1



DIFFERENTIAL AND CARRIER ASSEMBLY - FRONT DRIVE

Item No.

Part No.


25 710035 CUP, Outer Pinion Bearing 1

26 710034 CONE, Outer Pinion Bearing 1

27 107971 GASKET, Oil Seal Retainer 1

28 1C-1036 BOLT, Oil Seal Retainer 8

28A 4E-10 LKWSHR, Oil Seal Retainer 8

29 107912 TUBE, Oil Drain 1

30 108455 FLANGE, Companion 1

31 107978 WASHER, Pinion Shaft Nut 1

32 107977 NUT, Pinion Shaft 1

33 1F-748 COTTER, Pinion Shaft 1

34 2C-720 BOLT, Brake Drum Attaching 8

34A 4E-07 LKWSHR, Brake Drum Attaching 8

35 107914 DRUM, Brake 1

36 1C-1024 BOLT, Brake Mounting

36A 4E-10 LKWSHR, Brake Mounting 4

37 BRAKE ASSY, See Index

38 108454 RETAINER, Pinion Oil Seal 1

39 10E-04 PLUG, Oil Seal Retainer

40 111368 SEAL, Pinion Oil 1

41 25K-40700 "0" RING, Pinion Bearing Cage 1

42 107965 BOLT, Carrier Cap 4

42A 111657 §WASHER, Carrier Cap Bolt 4

43 731981 CONE, Differential Bearing 2

44 672004 CUP, Differential Bearing 2

45 107969 NUT, Differential Adjusting 2

46 116552 tDIFF. ASSY (Inc. 4 thru 14, 17) 1

47 116519 fDIFF. BODY SUB ASSY (Inc. 4 thru 10, 13, 14) 1

48 815347 ]'GEAR & PINION SET (Inc. 12, 17) ____

49 815649 tDIFF. CASE KIT (Inc. 4, 5, 6, 9, 13) 1

§Not Sold Separately t Not Illustrated *As Required


PM 2000

[ 53 ]



PLANET CARRIER - FRONT DRIVE Item No.


No. Req'd.

Item No.

Part No.


A 117484 CARRIER ASSY 2 4 107990 PINION 3

NOTE: Two Carriers used on Axle — Quantities listed below are for one Carrier

5 107992 ROLLER, Pinion 93

6 107991 WASHER, Pinion Thrust 3

1 107991 WASHER, Pinion Thrust 3 7 10J-16 BALL, Pinion Shaft Lock 3

2 107992 ROLLER, Pinion 93 8 107989 SHAFT, Pinion 3

3 107993 SPACER, Pinion Roller 3 9 117485 CARRIER, Planet 1


[ 54 ]

PM 2000

MICHIGAll CLeIRK EQUIPMENT


BRAKE ASSEMBLY - FRONT Item No.

Part No. No. Description Req'd.

Item No.

Par' No.


A 108456 *BRAKE ASSY (Inc. 1 thru 16) 2 9 LINING, Brake

*NOTE: Two Brake Assemblies required per axle. 9A 108485 Standard — 6 Hole 4 Quantities listed below are for one Brake Assembly

9B 111056 Standard — 8 Hole 4 1 111053 SHOE ASSY, Brake (Inc. 2 thru 5, 7

thru 13, 16) 2 9C 112919 Oversize (V) — 8 Hole 4

2 1F-308 COTTER, Roller Pin Lock Pin 2 10 113249 PLUG, Brake Shoe 32

3 110855 PIN, Roller Pin Lock 2 11 107706 BOLT, Lining to Shoe 32

4 109598 PIN, Brake Cam Roller 2 12 24E-06 LKWSHR, Lining to Shoe 32

5 107707 ROLLER, Brake Cam 2 13 2D-06 NUT, Lining to Shoe 32

6 107713 SPIDER, Brake 1 14 109599 PIN, Brake Shoe Anchor 2

7 110126 PIN, Spring Anchor 1 15 109597 SCREW, Anchor Pin Set 2

8 §SHOE, Brake — See 1 16 107709 BUSHING, Brake Shoe 2



PM 2000

[ 55 ]

MICHIGAn CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

PARKING BRAKE ASSEMBLY

Item No.


No. Req'd.

Item No.


No. Req'd.

A 110594 BRAKE ASSY (Inc. 1 thru 20) 1 11 4E-06 LKWSHR, Lever to Shaft

1 943466 RIVET, Lining to Shoe 24 12 943464 BOLT, Lever to Shaft 1

2 944664 LINING KIT, Brake Shoe (Inc. 1) 1 13 944665 SHOE ASSY, Brake (Inc. 1, 2, 3) 2

3 §SHOE, Brake — See 13 2 14 943458 SPRING, Adjusting Screw 1

4 944659 CAM SHAFT, Brake 1 15 943463 NUT, Adjusting Screw 1

5 944656 PLATE, Brake Mounting 1 16 943462 SCREW, Adjusting 1

6 944658 BRACKET, Cam Shaft Support 1 17 943465 SOCKET, Adjusting Screw 1

7 4E-12 LKWSHR, Anchor Pin 2

8 2D-12 NUT, Anchor Pin 2 18 944657 PIN, Anchor 2

9 944663 WASHER, Shaft to Lever 1 19 944660 BRACE, Anchor Pin 1

10 943455 LEVER, Brake Control 1 20 944661 SPRING, Shoe Return 2



[ 56 ]

PM 2000

MICHIG1111 CMRK EQUIPMENT


PARKING BRAKE CONTROLS Item No.


No. Req'd.

Item No.

Part No.

No. Description, Req'd.

1 4F-08127 PIN, Clevis to Brake 1 10 1F-208 COTTER, Clevis Pin 1

2 1F-414 COTTER, Clevis Pin 11 4E-05 LKWSHR, Lever Attaching 4

3 2J-8300 CLEVIS, Cable to Brake 1 12 18C-512 BOLT, Lever Attaching 4

4 8D-08 NUT, Clevis Jam 13 593026 LEVER, Parking Brake Hand 1

5 104645 CLAMP, Cable 1 14 593027 BLOCK, Conduit Anchor 1

6 18C-514 BOLT, Cable Clamp 2 15 593028 RETAINER, Conduit Ferrule 1

7 593035 CABLE, Parking Brake 16 18C-528 BOLT, Conduit Anchor Block 2

8 552438 GROMMET, Cable to Cockpit 1 17 18D-05 NUT, Conduit Anchor Block 2

9 4F-04051 PIN, Cable to Lever 1 18 18D-05 NUT, Cable Clamp 2


PM 2000

[ 57 ]

16 11 18 19 20 21 22

TO RE LAY VALVE-01.

1 1 1

; 47) 1

I I I /

I / I I / II / I I // I /

I WI' 1 1 1 1 1 11 1

58 51 56 55 54 53

27 ,/ 32 31 30 29 28 33

333675

47 46 45 44 43 42 41 40 39 38

61 60 59

BRAKE AIR LINES — TRACTOR

TS-6352-P

0

z -4

0 z

Rt

70

-t

tn

0 z

a

Coto

O O O

MICHIGEM CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

BRAKE AIR LINES - TRACTOR - G.M. Item No.

Part No.



2 593280 HOSE, Tee to Pipe 1

3 17C-514 BOLT, Fitting to Comprssor 2

3A 4E-05 LKWSHR, Fitting to Compressor 2

4 593650 HOSE, Tee to Governor 1

5 17C-516 BOLT, Adapter to Compressor 2

5A 4E-05 LKWSHR, Adapter to Compressor 2


7 540306 *GOVERNOR — B.W. #275200 1

8 13F-02 PLUG, Governor 1

9 17C-548 BOLT, Governor to Adapter 2

9A 4E-05 LKWSHR, Governor to Adapter 2

10 593388 *HORN, Air — B.W. #223585 1

11 18D-05 NUT, Horn Attaching 1

12 18C-508 BOLT, Horn Attaching 1




16 594132 HOSE, Pipe to Rear Tank Line 1

17 594133 HOSE, Pipe to Relay Valve Line 1

18 592784 HOSE, Brake Valve to Pipe 1


20 593449 HOSE, Q.R.V. to Air Chamber 1

21 26F-2 ELBOW, Hose to Air Chamber 1

22 AIR CHAMBER — See Index 1

23 594091 HOSE, Brake Valve to Front Q.R.V 1


25 18C-512 BOLT, Q.R.V. to Bracket 2

26 AIR CHAMBER — See Index 1

27 593449 HOSE, Q.R.V. to Air Chamber 1


29 507816 *VALVE, Quick Release — B.W. #205000 1

30 593478 BRACKET, Q.R.V 1

31 18D-05 NUT, Q.R.V. to Bracket 2

32 552438 GROMMET, Hose 1

Item No.

Part No.



34 356614 BUSHING, Brake Valve Reducing 1

35 13F-08 PLUG, Brake Valve 1


37 BRAKE CONTROLS — See Index

38 31F-3 ADAPTER UNION

39 356614 BUSHING, Brake Valve Reducing 1




43 593438 HOSE, Brake Valve to Horn Valve 1


45 940643 SENDER UNIT, Air Pressure 1

45A 14D-10 ]'NUT, Sender Unit 1

45B 12E-10 tLKWSHR, Sender Unit 1

46 592783 HOSE, Pipe to Brake Valve 1

47 17F-2 TEE, Horn Valve 1

48 356611 BUSHING, Horn Valve Reducing 1

49 18D-04 NUT, Horn Valve to Floorboard 2

50 530663 *VALVE, Horn — B.W. #228672 1

51 18C-412 BOLT, Horn Valve to Floorboard 2

52 593435 HOSE, Horn . Valve to Horn 1

53 594143 PIPE, Firewall 1

54 26F-4 ELBOW, Hose to Pipe 1

55 593370 *CHECK VALVE — B.W. #228194 1

56 942646 GASKET, Governor to Adapter 1

57 540231 ADAPTER, Governor to Compressor__ 1

58 942646 GASKET, Adapter to Compressor 1

59 AIR COMPRESSOR — See Engine Parts Manual

60 951948 GASKET, Discharge Fitting 1

61 510452 FITTING, Compressor Discharge 1

62 5K-409 NIPPLE, Tee to Fitting 1

63 356616 BUSHING, Tee Reducing 1

64 18F-4 TEE, Compressor

*Your local 'Not Illustrat

authorized Bendix-Westinghouse distributor is equipped to service and supply these parts. ed


PM 2000 [ 59 ]

CUIRK EQUIPMENT


BRAKE CONTROLS Item No.


No. Req'd.

Item No.

Part No.


1 875767 PIN, Pedal to Base 1 8 1F-312 COTTER, Pedal to Valve Pin 1 2 1F-312 COTTER, Pedal to Base Pin 1 9 518259 ROLLER, Pedal • 1 3 518261 PEDAL, Brake 1 10 18D-05 NUT, Valve to Floorboard 3 4 18C-516 BOLT, Base to Floorboard 2 11 18C-516 BOLT, Valve to Floorboard 3 5 1F-312 COTTER, Roller to Pedal Pin 1 12 556562 *VALVE, Air Brake — B.W. #277472W. 1 6 875766 PIN, Roller to Pedal 1 13 18D-05 NUT, Base to Floorboard 2 7 875767 PIN, Pedal to Valve 1 14 594375 BASE, Pedal 1

*NOTE: Your local authorized Bendix-Westinghouse distributor is equipped to service and supply this part.


[ 60 ]

PM 2000

NOTES

mIcHlGaA CUIRK EQUIPMENT


PM 2000

[61]

0

tit

C

0 z

n

0

21 22 23 24 25 26

9 10 11 12 13 4 15 16 17

48 47 46 45 44 43 42 41 40 39 38 37

STEERING GEAR ASSEMBLY TS-1591-P

53

52

51

50

49

18 19 20

27

28

29

30

31 32

33

34

35

36

MICHIG1111 CONSTRUCTION MACHINERY DIVISION CLeiRK EQUIPMENT

STEERING GEAR ASSEMBLY Item No.

Part No.


A 594059 STEERING GEAR ASSY (Inc. 1, 3 thru 20, 28 thru 53)

1 943439 COVER, Valve End 1

2 594124 ARM ASSY, Pitman (Inc. 2A) 1

2A 594123 1- BUSHING, Pitman Arm 1

3 865801 NUT, Pitman Arm 1

4 2E-14 LKWSHR, Pitman Arm 1

5 853391 SEAL, Pitman Shaft Grease 1

6 853357 BUSHING, Pitman Shaft 2

7 §SPOOL, Valve (See 44)

8 73G-732 SCREW, Adapter to Housing 4

8A 4E-07 t LKWSHR, Adapter to Housing

9 943426 ADAPTER ASSY (Inc. 38, 39) 1

10 25K-40224 "0" RING, Adapter to Spacer 1

11 853380 GASKET, Adapter to Housing 1

12 851762 BOLT & WASHER, Clamp 3

13 853527 CLAMP, Ball Return Guide 1

14 13F-08 PLUG, Housing Filler 1

15 730143 BEARING, Housing 1

16 944115 HOUSING ASSY (Inc. 6, 15) 1

17 944116 SHAFT ASSY (Inc. 12, 13, 29, 29A, 37) 1

18 857729 BEARING, Upper Shaft 1

19 861768 WASHER, Upper Shaft Bearing 1

20 853395 SPRING, Upper Bearing 1

21 518331 WHEEL, Steering ______ 1

22 668674 SPRING, Steering Wheel Cap 1

23 628763 CAP, Steering Wheel 1

24 612840 PLATE, Steering Wheel Cap 1

25 695930 SCREW, Steering Wheel Cap 4

Item No.

Part No.


26 628764 RETAINER, Steering Wheel Cap 1

27 648304 NUT, Steering Wheel 1

28 853384 KEY, Steering Wheel 1

29 10J-09 BALL 106

29A 853526 tGUIDE, Ball Return 1

30 4E-06 LKWSHR, Side Cover 3

31 1C-612 BOLT, Side Cover 3

32 853182 COVER, Housing Side (Inc. 34) 1

33 8D-07 NUT, Lash Adjuster 1

34 §BUSHING, Pitman Shaft (See 32) 1

35 851756 GASKET, Side Cover 1

36 944114 GEAR, Pitman Shaft 1

37 853525 NUT, Ba II 1

38 861741 BEARING, Adapter 1

39 25K-40108 "0" RING, Adapter 1

40 860997 BEARING, Worm Thrust 1

41 943438 WASHER 1

42 943440 SPACER, Valve Mounting 1

43 25K-40312 "0" RING, Valve to Spacer 1

44 943435 VALVE ASSY (Inc. 7, 45, 46) 1

45 943437 SPRING, Valve 4

46 943436 PLUNGER, Valve 8

47 25K-40312 "0" RING, Valve to End Cover 1

48 943438 WASHER 1

49 860997 BEARING, Worm Thrust 1

50 943429 SPRING, Valve Spool Preload 1

51 873250 NUT, Worm Bearing _ 1

52 3E-08 LKWSHR, End Cover 6

53 1C-888 BOLT, End Cover 6



PM 2000

[ 63 ]

0

0 z

m

cn 0 z

a C-3

7

6

1

52

\\1 t1-4\4 6 33 32 31 30 29 28

/7? 51u /

0-1 /1 // // 0@- /

50 49 48 47 STEERING CONTROLS TS-3122-P

46 45 44

7 -r" II 12 16 14 15 17

3

0 0 O

MICHIGH CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

STEERING CONTROLS Item No.

Part No.


Item No.

Part No.


1 18D-08 NUT, U-Bolt 2 27 582749 SHIELD, Bearing Dust — Rear 1

2 580783 $SHIM, Clamp Block 28 8D-12 NUT, Steering Clevis to Rod 2

3 580782 BLOCK, Steering Gear Clamp 29 582747 RETAINER, Steering Clevis Bearing 1

4 18C-832 BOLT, Steering Gear Clamp 2 30 713023 CONE, Steering Clevis Bearing 1

5 550594 U-BOLT, Steering Gear 1 31 713024 CUP, Steering Clevis Bearing 1

6 1F-422 COTTER, Crank Retaining Nut 1 32 12H-15 FITTING, Steering Clevis Grease 1

7 590498 WASHER, Crank Retaining 1 33 582746 CLEVIS, Steering 1

8 592905 CRANK, Linkage Shaft 1 34 742010 CONE, Steering Link Bearing 1

9 592952 BOLT, Steering Link to Crank 35 713024 CUP, Steering Clevis Bearing 1

10 659029 BEARING, Linkage Shaft 2 36 713023 CONE, Steering Clevis Bearing 1

11 592877 SHAFT, Steering Linkage 1 37 582748 SHIELD, Bearing Dust =Front 1

12 YOKE — See Scraper Parts Manual or 38 17C-820 BOLT, Bearing Block 2 Tractor Wagon Manual

38A 4E-08 LKWSHR, Bearing Block 2 13 7J-4108 KEY, Crank Retaining

39 582745 BLOCK, Control Rod Bearing 1 14 33G-405 SCREW, Spherical Bearing Lock 1

40 18C-1072 BOLT, Steering Clevis to Link 15 593172 SET SCREW, Spherical Bearing 1

41 592976 BUSHING, Steering Link 1 16 592874 BEARING, Spherical 1

42 66D-10 NUT, Steering Link to Crank 17 583884 LINK ASSY, Steering (Inc. 14, 15, 16,

20, 21) 43 4D-10 NUT, Crank Retaining

18 10H-35 FITTING, Spherical Bearing Grease 1 44 583466 ROD, Steering Control 1

19 592977 SHIELD, Bearing Dust 45 STEERING GEAR -- See Index

20 742009 CUP, Steering Link Bearing 1 46 18C-840 BOLT, Rod to Pitman Arm

21 742009 CUP, Steering Link Bearing 1 47 635682 WASHER, Rod to Pitman Arm 1

22 742010 CONE, Steering Link Bearing 1 48 594134 SLEEVE, Rod to Pitman Arm 1

23 592977 SHIELD, Bearing Dust 1 49 635682 WASHER, Rod to Pitman Arm

24 592976 BUSHING, Steering Link 1 50 18D-08 NUT, Rod to Pitman Arm 1

25 12H-15 FITTING, Steering Link Grease 1 51 18D-08 NUT, Steering Gear Clamp 2

26 8D-10 NUT, Steering Clevis to Link 2 52 550044 CLAMP, Steering Gear 1

As Required

WHEN ORDERING PARTS, ALWAYS STATE MODEL AND SERIAL NO. OF MACHINE PM 2000

[ 65 ]

42 41 40 39 38 37 36

HYDRAULIC SYSTEM — STEERING

45 TS-2880-P

0

0

m

N

0 z

4 5 6 1 8 9 10 11 12 13

ft

4 14

52

51

50

49,

48

41 /

1 46 NiT 7-7 // kk / ■

- -

\ ice_ _ )

•

0 it" 28

29 30

31 32

33

46,

34 35

f0;

15 16

Als

17 18

19 20

21

***0 22

23

24

25 26

21

Oft

('I

4

-A 0

ral

0 O O

CUIRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION minion HYDRAULIC SYSTEM - STEERING

Item No.

Part No.


1 RESERVOIR, Hydraulic Oil—See Index

2 215500 FILTER, Steering System Oil (Inc. 2A) 1

2A 215502 f CARTRIDGE KIT 2

3 18C-720 BOLT, Filter Attaching 4

3A 18D-07 NUT, Filter Attaching 4

4 784663 CLAMP, Hose 1

5 585883 HOSE, Tube to Reservoir 1

6 784663 CLAMP, Hose 1


8 550877 HOSE, Pipe to Cylinder 2

9 25K-40110 "0" RING, Hose to Pump 1



11 STEERING CYLINDER — See Index


13 594178 HOSE, Cylinder to Cylinder 2

14 18D-05 NUT, Relief Valve to Bracket 2

15 663093 FLANGE HALF, Hose to Pump 2

16 581411 BRACKET, Relief Valve 1

17 18C-1020 BOLT, Bracket Attaching 1

18 594081 HOSE, Pump to Relief Valve 1

19 91F-7 "0" RING, Adapter Union 1

20 RELIEF VALVE — See Index


22 18C-536 BOLT, Relief Valve to Bracket 2


24 5K-611 NIPPLE, Tee to Relief Valve 1

25 28K-212 TEE, Relief Valve 1


27 763322 ADAPTER UNION. 1

28 522019 HOSE, Elbow to Relief Valve 1

Item No.

Part No.


29

30

18D-10

669953

NUT, Bracket Attaching

HOSE, Relief Valve to Elbow

31 25K-40128 "0" RING, Stem to Pump 1

32 663095 FLANGE HALF, Stem to Pump 2



34 529791 STEM, Suction 1

35 784663 CLAMP, Hose 1

36 26K-212 ELBOW, Cockpit 2


38 784663 CLAMP, Hose 1


40 18C-620 BOLT, Pipe to Firewall 3

41 594064 HOSE, Steering Gear to Elbow 1

42 594065 HOSE, Steering Gear to Pipe 1

43 594179 HOSE, Steering Gear to Pipe 1

44 18K-6 ELBOW ASSY (Inc. 44A) 2

44A 91F-6 t"0" RING, Elbow 2

45 594070 HOSE, Elbow to Steering Gear 1

46 17K-7 ELBOW ASSY (Inc. 46A) 1

46A 91F-7 t"0" RING, Elbow 1

47 18K-7 ELBOW ASSY (Inc. 47A)

47A 91F-7 t"0" RING, Elbow

48 STEERING GEAR See Index

49 18D-06 NUT, Pipe to Firewall 3

50 594143 PIPE ASSY, Firewall 1

51 672582 HOSE, Relief Valve to Filter

52 26F-6 ELBOW, Hose to Reservoir

53 550924 HOSE, Filter to Reservoir 1

54 36F-6 ADAPTER UNION

tNot Illustrated


PM 2000

[ 67 ]

MICHIGAll CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

PRESSURE RELIEF VALVE - STEERING SYSTEM

Item No.


No. Req'd.

A 536539 VALVE ASSY (Inc. 1 thru 17) 1 1 47D-05 NUT, Acorn 1 2 663792 WASHER, Stat-O-Seal 2 3 944467 CAP, Valve 1 4 883734 PLUNGER, Pilot 1 5 25K-20018 "0" RING 1 6 944469 SEAT, Pilot 1 7 944646 SPRING 1 8 944645 SEAT, Poppet 1 9 §BODY, Valve (See A) —

10 §SCREEN, Poppet 1 11 944643 POPPET ASSY (Inc. 10) 1 12 944468 RING, Back-Up 1 13 91F-6 "0" RING 1 14 944471 SPRING, Pilot 1 15 8D-05 NUT, Jam 1 16 33G-514 SCREW, Adjusting Set 1 17 799584 f PLUG 2



[ 68 ]

PM 2000

•••••%

I

I/

MICHIGN CUIIRK EQUIPMENT


HYDRAULIC PUMP - STEERING Item No.

Part No.


Item No,

Part No.


A 539744 PUMP ASSY (Inc. 1 thru 33) 1 16 §SHIM, Wear Plate (See B & F) 3 B 944710 REPAIR KIT, Minor (Inc. 2, 7, 9, 12, 15, 17 §PIN, Shaft to Gear Dowel (See C) 1

16, 22, 28, 31, 32, 33) 1 18 §GEAR, Drive (See C) 1 C 944712 GEAR & SHAFT SET (Inc. 1, 17, 18, 19 § PLATE, Wear (See F) 2

25) 20 §BEARING, Rol* (See E) 4 D 944776 SEAL KIT, Shaft (Inc. 2, 7, 33) 21 884614 WASHER, Thrupt 1 E 944777 BEARING KIT (Inc. 8, 20) 22 ---- §"O" RING, (See B) 4 F 944787 WEAR PLATE SET (Inc. 16, 19) 23 12G-1072 BOLT,. Cover & Housing to Adapter____ 4

§SHAFT, Drive (See C) 24 §COVER, Pump (See A) 2 §SEAL, Shaft Outer (See B & D) 25 §GEAR, Driven (See C) 3 944782 RETAINER, Shaft Outer Seal 26 944779 HOUSING, Pump Center Section 4 ADAPTER, Pump (See A) 1 27 867753 PIN, Housing to Adapter & Cover 5 944783 RETAINER, Shaft Inner Seal Dowel 4 6 16F-01 PLUG, Adapter Port 3 28 §"O" RING, Horsing (See B) 2 7 §"O" RING, Retainer (See B & D) 29 § KEY, Drive (See B) 1 8 9

10 11 12

884605 BEARING, Shaft (See E) SEAT ASSY, Seal (Inc. 10) (See B) "0" RING, Seal Seat (See B) WASHER, "0" Ring Back-Up (See B) SEAL ASSY, High Pressure (Inc. 11,

30 31 32 33

---- ---- ---- ----

§"O" RING, High Pressure Seal (See B) §RING, Drive Shaft Snap (See B) §RETAINER, Shaft Snap Ring (See B) §SEAL, Shaft Inner (See B & D)

1 1 1 1

13, 14, 29, 30) (See B) 34 551906 f GASKET, Pump to Converter 1 13 §SPRING, High Pressure Seal (See B) 35 8D-06 f NUT, Pump to Converter 6 14 §WASHER, High Pressure Seal (See B) 36 4E-06 f LKWSHR, Pump to Converter 6 15 §RING, Snap (See B) 37 221992 f SLEEVE, Pump Drive 1

§Not Sold Separately — Order Kits. tNot Illustrated


PM 2000 [ 69 ]

0

70

n

0 z

rri zr

0 z

58„ A_

55

54

53

52

36 45 44 43 42 41 40 39

46 41 61

\8 \ 49

50 51

STEERING ASSEMBLY AND BELL CRANKS Figure 1 TS-6360-P

2 21

22

20

23 24 25 26

\-\V

19

33 18

11

34

16

35

123\ 63

62

61

60

59

38 31

29 30 31 32 21 28

MICHIGIM CONSTRUCTION MACHINERY DIVISION CLeiRK EQUIPMENT

STEERING ASSEMBLY AND BELL CRANKS Item No.

Part No.


1 18C-864 BOLT, Pin Retaining 2

2 584757 PIN, Bell Crank to Link 2

3 18D-08 NUT, Pin Retaining 2

4 592002 BELL CRANK ASSY (Inc. 5, 5A, 63) 1

5 584666 BUSHING, Upper Bell Crank 1

5A 583867 t BUSHING, Lower Bell Crank 1

6 584754 PIN, Bell Crank to Steering Assy 1



9 559294 SLEEVE 1

10 12H-25 FITTING, Bell Crank Grease 2

11 559296 BUSHING, Bell Crank 1


13 569812 PIN, Retaining 2

14 569837 BUSHING, Trunnion Pin 2

15 569841 PLATE, Support (Weld to Plate) 2

16 590519 WASHER, Lower Pivot Pin 1

17 559300 BUSHING, Lower Pivot Pin 1

18 569756 PIN, Lower Pivot 1

19 569842 PLATE, Lower Pivot Pin Locking 2

20 4E-10 LKWSHR, Locking Plate Attaching 4

21 18C-1024 BOLT, Locking Plate Attaching 4

22 584621 BUSHING, Upper Pivot Pin 1

23 590573 tSPACER, Upper Pin Segment — 1/2". —

23A 590574 $SPACER, Upper Pin Segment — 1/16" —

24 LOCKWIRE (16 ga. x 10" lg.) 3

25 594053 BOLT, Upper Pivot Pin 6

26 584522 PIN, Upper Pivot 1

27 584620 BUSHING, Upper Pivot Pin 1

28 584763 BUSHING, Upper Bell Crank Pin 1

29 594126 PIPE ASSY, Upper Steering 1


31 571814 PIN, Cylinder to Steering Assy 2


Item No.


No. Req'd.

33

34

35

583865

583865

559367

BUSHING, Upper Cylinder to Steering Assy Pin

BUSHING, Upper Cylinder to Steering Assy Pin

STEERING ASSY (Inc. 14, 17, 22, 27, 28, 29, 33, 34, 40, 42)

2

2

1

36 CYLINDER, Steering — See Index —


38 584758 PIN, Cylinder to Bell Crank 2


40 584669 BUSHING, Lower Bell Crank Pin 1

41 10H-25 FITTING, Trunnion Pin Grease 2

42 559302 BUSHING, Lower Pivot Pin 1

43 584666 BUSHING, Upper Bell Crank 1

44 583867 BUSHING, Lower Bell Crank 1

45 592003 BELL CRANK ASSY (Inc. 11, 43, 44, 46) 1


47 583866 BUSHING, Upper Steering Link 1

48 583866 BUSHING, Lower Steering Link 1

49 592045 LINK ASSY, Steering (Inc. 47, 48, 50) 1

50 559296 BUSHING, Steering Link 1

51 12H-15 FITTING, Grease 1

52 584761 *RECTANGULAR FLAT (Welded on Yoke) 1

53 12H-15 FITTING, Pin Grease 1


55 594550 PIN, Link to Yoke 1


57 591989 t WASHER, Link to Yoke — 6"

57A 591990 tWASHER, Link to Yoke — 1/8"

58 559294 SLEEVE, Steering Link 1

59 559365 LINK, Steering (Inc. 60, 62) 1

60 583866 BUSHING, Lower Steering Link 1

61 12H-15 FITTING, Grease 2

62 583866 BUSHING, Upper Steering Link 1


tNot Illustrated tAs Required *NOTE: Weld 584761 Rectangular Flat off center of the pin as shown in Fig. 1 to the gooseneck nose casting section of the yoke

assembly after the steering links and grease fitting have been assembled to bottom end of steering links to gooseneck pin.


PM 2000 [ 71 ]

CU IRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGAIll

STEERING CYLINDER ASSEMBLY 2 Cylinders used on machine — Quantities listed below are for 1 Cylinder

Item No.


No. Req'd.

Item No.

Part No.


A 591653 CYLINDER ASSY (Inc. 1 thru 27) 1 14 532563 RING, Back-up 1 1 68D-12 NUT, Cylinder Cap to Cylinder 4 15 945114 CAP KIT, Cylinder (Inc. 13, 14) 1 2 591654 CYLINDER (Inc. 3) 1 16 18C-1288 BOLT, Cylinder Cap to Cylinder 4 3 531584 BUSHING, Cylinder 1 17 527496 ADAPTER, Male Chevron 2 4 12H-15 FITTING, Cylinder Grease 1 18 538154 PACKING ASSY 1 5 1F-856 COTTER, Piston Rod Nut 1 19 527497 ADAPTER, Female Chevron 2 6 551606 NUT, Piston Rod 1 20 527812 GLAND, Packing 1 7 550261 RING, Wear 1 21 550450 SEAL, Piston Rod 1 8 541749 PISTON, Bottom Half 1 22 522617 RETAINER, Seal 1 9 541769 PACKING ASSY (Inc. Adapters) 1 23 LOCKWIRE (16 ga.-13" lg.) 2

10 548657 PISTON, Top Half 1 24 3C-820 BOLT, Seal Retainer to Piston Cap 4 11 550261 RING, Wear 1 25 591659 ROD ASSY, Piston (Inc. 27) 1 12 25K-40200 "0" RING, Piston Rod 1 26 10H-25 FITTING, Piston Rod Grease 1 13 25K-80516 "0" RING, Cylinder Cap 1 27 531584 BUSHING, Piston Rod 1

WHEN ORDERING PARTS, ALWAYS STATE. MODEL AND SERIAL NO. OF MACHINE

[ 72 ]

PM 2000

NA, Har . ■\ 17-1 1., wag- II\

i • ;iv" ,

itiliFY:!?1 ■ 175, 1"31 ,\JIrs '

\ , -,/,'

r ‘`\ \ I !IC' ,M‘', • . • • \ •,,,

A k 1

'" 4% '

MICHIG1111 CMRK EQUIPMENT


HYDRAULIC PUMP — APRON, BOWL AND EJECTOR Item No.

Part No.


Item No.

A B

C D E F

582687 944815

944795 944821 944792 944799

PUMP ASSY (Inc. 1 thru 36) REPAIR KIT, Minor (Inc. 2 thru 6, 8

9, 15, 18, 23, 23A, 24, 32, 35) ____ SHAFT SEAL KIT (Inc. 2, 3,4,5, 6, 32) SHAFT & GEAR KIT (Inc. 1, 17, 27)____ BEARING KIT (Inc. 13, 21, 28) WEAR PLATE SET (Inc. 18, 26)

§SHAFT, Drive (See D)

1

1 1 1 1 1 1

18 19 20 21 22 23 23A 24

2 §SEAL, Shaft Outer (See B & C) 1 25 3 §RING, Snap (See B & C) 1 26 4 §SEAL, Shaft Outer (See B & C) 1 27 5 §"0" RING, Outer Seal Retainer 28

(See B & C) 1 29 6 §SEAL, Shaft Inner (See B & C) 1 30 7 16F-02 PLUG, Adapter Port 3 31 8 §"O" RING, Seal Seat (See B) 1 32 9 §SEAL ASSY, High Pressure (Inc. 10, 33

12, 31, 33, 34) (See B) 1 34 10 §WASHER, "0" Ring Back-Up (See B) 1 35 11 12 13 14

944805

875254 944826

RETAINER, Shaft Seal §WASHER, Thrust (See B)

BEARING, Drive Shaft (See E) DOWEL,. Housing to Adapter & Cover

1 1 1

36 37 38

15 §"O" RING, Housing (See B) 2 39 16 944988 HOUSING, Center Section 1 40 17 §GEAR, Drive (See D) 1 41

Part

No. No. Description

Req'd.

---- §SHIM, Wear Plate (See B & F) 4 ---- §COVER, Pump (See A) 1 2C-896 BOLT, Cover to Housing & Adapter__ 2 875364 PLATE, Thrust (See E) 2 12G-1480 BOLT, Cover & Adapter to Housing 4 ---- §"O" RING, (See B) 2 ---- §tWASHER, "0" Ring Back-Up (See B) 2 ---- §"O" RING (See B) 2 209968 PIN, Roll 2 ---- §PLATE, Wear (See F) 2

§GEAR, Driven (See D) 1 §BEARING, Roller (See E) 4 §ADAPTER, Pump (See A) 1

18D-08 NUT, Cover & Adapter to Housing 2 §SPRING, High Pressure Seal (See B)_.._ 1 §"O" RING, Retainer (See B & C) 1 §KEY, Drive (See B) 1 §"O" RING, High Pressure Seal (See B) 1 §SEAT ASSY, Seal (Inc. 8) (See B) 1

944827 BOLT, Retainer 6 2D-08 tNUT, Pump to Converter 4 552161 tGASKET, Pump to Converter 1 4E-08 t LKWSHR, Pump to Converter 4 221988 tSLEEVE, Pump Drive 1 223890 tRING, Snap 1

§Not Sold Separately — Order Kits. t Not Illustrated


PM 2000 [ 73 ]

HYDRAULIC SYSTEM - APRON, BOWL AND EJECTOR TS-3817-P

n 0

ti

0 z

n

in

0

a

23

I 24

> 1

c, -- y.

25

,

, N

N

\r( -N

37 36 35 34 33 32 31

12 13 14

-; . N

15 16 17 18 19 20 21 22

45 44

30 29 28 27

26

10 11 6

40 39 38 43 42 41

46 47

MICHIGAll CONSTRUCTION MACHINERY DIVISION CIfIRK EQUIPMENT

HYDRAULIC SYSTEM - APRON, BOWL AND EJECTOR Item No.

Part No.


Item No.

Part No.


1 PIPE — See Scraper Parts Manual 1 25 FLANGE HALF—See Group "A" Below —

2 36F-6 ADAPTER UNION 1 26 593417 HOSE, Ejector Forward Line 1

3 36F-6 ADAPTER UNION 1 27 593418 HOSE, Ejector Return Line 1

4 675133 HOSE, Ejector Forward Line 28 593417 HOSE, Apron Cylinder Line

5 675133 HOSE, Ejector Return Line 1 29 FLANGE HALF—See Group "A" Below —

6 STEERING ASSY — See Index 30 593417 HOSE, Bowl Cylinder Line 1

7 592832 PIPE, Ejector Forward Line 1 31 FLANGE HALF—See Group "A" Below

8 592833 PIPE, Ejector Return Line 1 32 584153 HOSE, Pump to Valve — Pressure 1

9 592834 PIPE, Apron Cylinder Line 33 TORQUE CONY. — See Index 1

10 592835 PIPE, Bowl Cylinder Line 1 34 784663 CLAMP, Hose 1

11 36F-6 ADAPTER UNION 4 35 585886 HOSE, Tube to Tube 1

12 582708 TUBE, Suction 36 784663 CLAMP, Hose 1

13 18D-06 NUT, Tube Attaching 2 37 FLANGE HALF—See Group "A" Below

14 18C-622 BOLT, Tube Attaching 2 38 582711 TUBE, Tube to Stem 1

15 980055 WASHER, Tube Attaching 4 39 784663 CLAMP, Hose 1

16 784663 CLAMP, Hose 1 40 585886 HOSE, Tube to Stem 1

17 585886 HOSE, Tube to Tube 1 41 784663 CLAMP, Hose 1

18 784663 CLAMP, Hose 1 42 FLANGE HALF—See Group "B" Below —

19 582710 TUBE, Reservoir to Tube 1 43 583283 STEM, Suction 1

20 784663 CLAMP, Hose 1 44 516599 HOSE, Bowl Cylinder Line 1

21 585886 HOSE, Tube to Reservoir 1 45 516599 HOSE, Apron Cylinder Line 1

22 784663 CLAMP, Hose 1 46 PIPE — See Scraper Parts Manual

23 RESERVOIR, Hydraulic Oil—See Index 1 47 36F-6 ADAPTER UNION 1

24 ---- CONTROL VALVE — See Index 48 PIPE — See Scraper Parts Manual

24A 30K-304 t ELBOW, Control Valve 1 49 36F-6 ADAPTER UNION 1

24B 13F-04 t PLUG, Control Valve 1 50 PIPE — See Scraper Parts Manual

tNot Illustrated

Group Flange Half "0" Ring Bolt Lkwshr Size

No. Req'd per Connection 2 1 4 4

,,,k, 663094' 25K-40116 17C-720 4E-07 1 14"

"B" 663096 25K-40208 17C-824 4E-08 2"


PM 2000

[ 75

60,

59 58

51

VALVE CONTROL LEVERS AND LINKAGE TS-6359-P

n

CA

O

a

25 26 27 28 29 30 31

32

11 12. la 9

/ 4IV---------

33

to I\ \ Is)

20 21 22 23 • 24 34 / -:-- ,..,

---= , -- 35

36

No-4---37

38

39

40

41

42

43

44

45

\6\

48 47

52 51 50 49

56 55 54 53

46

2

0

0

MICHICAll CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

VALVE CONTROL LEVERS AND LINKAGE Item No.

Part No.


1 IF-414 COTTER, Clevis Pin 6

2 583281 ROD, Lever to Valve 1

3 590354 SPACER, Lever 1

4 569055 BUSHING, Lever 1

5 583282 ROD, Lever to Valve 1



8 583281 ,ROD, Lever to Valve 1


10 10H-25 FITTING, Lever Grease 3



13 4E-10 LKWSHR, Lever Mounting 1

14 18C-1028 BOLT, Lever' Mounting 1

15 592911 LEVER, Rod Connecting 1

16 581487 ROD ASSY, Bowl Cross (Inc. 63, 65)_. 1

17 18C-1028 BOLT, Control Lever Mounting 1

18 4E-10 LKWSHR, Control Lever Mounting 1

19 568957 PIN, Lever 1

20 590354 SPACER, Valve Levers 1

21 569055 BUSHING, Valve Levers 1

22 •10H-25 FITTING, Valve Levers Grease 3

23 593415 SPACER, Valve Levers 1

24 590342 LEVER, Ejector Control 1

25 509772 KNOB, Ejector Control Lever 1

26 569055 BUSHING, Valve Levers 1

27 590342 LEVER, Apron Control 1

28 509772 KNOB, Apron Control Lever 1

29 593415 SPACER, Control Lever 1

30 569055 BUSHING, Bowl Control Lever 1

31 509772 KNOB, Bowl Control Lever 1

32 590342 LEVER, Bowl Control 1

33 18C-1028 BOLT, Control Lever Mounting 1

34 4E-10 LKWSHR, Control Lever Mounting ____ 1

35 590354 SPACER, Control Lever 1

36 4F-08127 PIN, Rod to Bell Crank Clevis 3

Item No.

Part No.



38 592906 ROD, Bowl Vertical 1

39 592906 ROD, Apron Vertical 1

40 4F-08127 PIN, Rod to Bell Crank Clevis 3


42 592906 ROD, Ejector Vertical 1

43 18C-1028 BOLT, Bell Crank Pin 1

44 4E-10 LKWSHR, Bell Crank Pin 1

45 590354 SPACER, Bell Crank 1











56 568957 PIN, Bell Crank Mounting 1

57 18C-1028 BOLT, Bell Crank Pin 1

58 4E-10 LKWSHR, Bell Crank Pin 1

59 4F-08127 PIN, Control Rod to Bell Crank Clevis 3


61 581487 ROD ASSY, Apron Cross (Inc. 63, 65) 1

62 581487 ROD ASSY, Ejector Cross (Inc. 63, 65) 1

63 8D-08 NUT, Clevis Jam 3

64 592911 LEVER, Apron 1

65 2J-8300 CLEVIS, Rod to Lever 3

66 4F-08127 PIN, Levers to Clevis 3


68 592911 LEVER 1

69 568957 PIN, Valve Levers Mounting 1

70 4F-08127 PIN, Rods to Levers & Valves 6

71 4E-10 LKWSHR, Lever Pin 1

72 18C-1.028 BOLT, Lever Pin 1

I


PM 2000

[ 77 ]

• Li

111 110

109

108

101

115

114

113

112

66 67 68

0

/

0

//i/ ,or tor

0

MICHIGAll CONSTRUCTION MACHINERY DIVISION CLARK EQUIPMENT

18 19 20 21 22 23 24 25 26 21 28 29 30

■

2 3 4

132 131 \

1 1

\ 7 ") ' vs.. ;4, z ,

31 , k / a / i' 44‘ 129 130 ,............ 742LEE-, -4 6'010

e%, ..., ' 6, . NI .. ,,,, r W 4 . ,... 32 128 -----■tx*.■5AM,, --A' .i M., "AllIK All 6"

126 ---.1 127 a II u ■ o

• L_ 3 167 Yr 1 VI I 0 11

iii\,,, ic;), II li • I Qt____, . lir 1 1,

—; 0 33

I _. I 1111Ct) I I I HIIIIIIIII --. i /7 / t oc =

125 --y ■ ' N. - / 1 'NN ,140' (

: Orr ' r Mr

A ,.. i A

•

123 1 ( 54 53 52 51 50 49 48 4746 45 44 43 42 41 40 39 38 31 36 35 34 122

.6,...... . k\k„-..-, A.jz=_ 414 121 L --- ,

I 0 • L /7 111■1 "III. nu A 0

119 1 IN , E3

1

118 'll to I IIIIIIII . CD I Jdi111

111 ..°` A ' 4—:1m ' El .:j 11111WV.At r .A11111Vc\ k 116 78 77 16 75 74 13 12 71 70 69

19 80 81 82 83 84 85 86 87 80 i-789

90 91 92 i1

93 94 95 96

103 102 101 100 99 98 91

106

105

104 TS-6399-P

5 6 1 8 9 10 11 12 13 14 15 16 17

Off

I //

1

///..._

rru

55 56 51 58 59 60 61 62 63 64 65

• A

7777v\"\OINEONIE \■■•■0111.11,

, • /=

CONTROL VALVE ASSEMBLY Item No.


No. Req'd.

Item No.

Part No.


A 582372 VALVE ASSY (Inc. 1 thru 132) 1 8 944876 POPPET 1

1 865149 WASHER 9 25K-20006 "0" RING 1 2 8D-05 NUT, Jam 10 945915 HOSE KIT (Inc 6, 11, 14) 1 3 865149 WASHER 1 11 731745 ELBOW, Oil Line 2 4 944875 SPRING, Poppet 1 12 25K-20010 "0" RING, Poppet Seat 1 5 945861 PLUG, Orifice 1 13 944877 SEAT, Poppet 1

6 731745 ELBOW, Oil Line 2 14 ---- §HOSE — See Item 10 7 25K-20010 "0" RING, Orifice Plug 1 15 16F-04 PLUG, Pipe 1

[ 78 ]

PM 2000


CONTROL VALVE ASSEMBLY (Continued)

Item Part No. No. No. Description Req'd.

16 943179 "0" RING 1 17 944838 PLATE, Seal Retainer 1 18 1C-820 BOLT, Cover 4 19 25K-40128 "0" RING 1 20 943191 COVER 1 21 25K-40120 "0" RING 1 22 4E-08 LKWSHR, Cover 4 23 §HOUSING, Valve — See "A" 24 943184 CHECK 1 25 944858 SPRING, Check 1 26 943181 SEAL, Quad-Ring 1 27 4E-04 LKWSHR 2 28 1C-720 BOLT, Cover to Housing 8 29 4E-07 LKWSHR, Cover to Housing 8 30 945064 COVER 2 31 25K-40116 "0" RING 2 32 1C-412 BOLT, Wiper Mounting 2 33 943180 EYE, Plunger 1 34 943179 "0" RING, Plunger Eye 1 35 893291 *WIPER, Bonded — Plunger 1 36 944837 RING, Seal Back-Up 1 37 ---- §PLUNGER, Operating — See "A" 38 943184 CHECK 1 39 944858 SPRING, Check 1 40 943181 SEAL, Quad-Ring 1 41 944851 GUIDE, Spacing 1 42 944837 RING, Seal Back-Up 1 43 1C-416 BOLT, Cover to Housing 4 43A 4E-04 LKWSHR, Cover to Housing 4 44 660178 ROLL PIN 1 45 944148 PIN 1 46 633157 ROLL PIN 1 47 944851 GUIDE, Spring 1 48 945857 SPRING, Return 1 49 1301171 RING, Retaining 1 50 944972 "0" RING 1 51 944850 RETAINER, Ball 1 52 944971 "0" RING 1 53 944972 "0" RING 1 54 945292 CAP, Detent 1 55 946185 SPRING 1 56 945290 RETAINER, Ball 1 57 945290 RETAINER, Ball 1 58 1301171 RING, Retaining 1 59 660178 ROLL PIN 1 60 943179 "0" RING 1 61 944851 GUIDE, Spring 1 62 944838 PLATE, Seal Retaining 1 63 943181 SEAL, Quad-Ring 1 64 944858 SPRING, Check 1 65 943184 CHECK 1 66 943181 SEAL, Quad-Ring 1 67 1C-412 BOLT 2 67A 4E-04 LKWSHR 2 68 943180 EYE, Plunger 1 69 943179 "0" RING, Plunger Eye 1 70 893291 *WIPER, Plunger 1 71 944837 RING, Seal Back-Up 1

1/All

72 ---- §PLUNGER, Operating — See 73 944837 RING, Seal Back-Up 1

Item No.

Part No Description

No. Req'd.

74 1C-416 BOLT, Cover to Housing 4 74A 4E-04 LKWSHR, Cover to Housing 4 75 944148 PIN 1 76 633157 ROLL PIN 1 77 944851 GUIDE, Spring 1 78 945857 SPRING, Return 1 79 944851 GUIDE, Spring 1 80 943179 "0" RING 1 81 944851 GUIDE, Spring 1 82 944838 PLATE, Seal Retaining 1 83 944837 RING, Back-Up 1 84 943181 SEAL, Quad-Ring 1 85 944858 SPRING, Check 1 86 943184 CHECK 1 87 §PLUNGER, Operating 1 88 943181 SEAL, Quad-Ring 1 89 944837 RING, Back-Up 1 90 893291 *WIPER, Bonded — Plunger 1 91 943179 "0" RING, Plunger Eye 1 92 946186 EYE, Plunger 1 93 1C-412 BOLT, Wiper Mounting 2 94 4E-04 LKWSHR, Wiper Mounting 2 95 945497 CAP, Relief 1 96 944855 SCREW, Relief Adjusting 1 97 944853 NUT, Acorn 1 98 613750 WASHER 1 99 8D-08 NUT, Jam 1

100 613750 WASHER 1 101 25K-40108 "0" RING 1 102 886753 SPRING, Relief 1 103 886739 POPPET, Relief 1 104 944802 RING, Retaining Snap 1 105 945496 VALVE ASSY, Relief (Inc. 104, 107)_ 1 106 40K-04 PLUG, Pipe 1 107 945860 "0" RING 1 108 25K-40108 "0" RING 1 109 875279 CAP 1 110 4E-04 LKWSHR, Cap Mounting 4 111 1C-412 BOLT, Cap Mounting 4 112 945857 SPRING, Return 1 113 945289 CAP, Plunger 1 114 886745 PLUG, Breather 1 115 945294 COVER 1 116 945292 CAP, Detent 1 117 944844 PLUG 1 118 886763 PLUG, Breather 1 119 10J-08 BALL 20 120 944854 CAP, Plunger 1 121 663823 RING, Retaining 1 122 945291 COVER, Detent 1 123 946185 SPRING 1 124 944849 RETAINER, Ball 1 125 944844 PLUG 1 126 886763 PLUG, Breather 1 127 10J-08 BALL 20 128 944854 CAP 1 129 663823 RING, Retaining 1 130 945275 COVER, Detent 1 131 944904 NUT, Acorn 1 132 944873 SCREW, Adjusting 1

§Not Sold Separately *NOTE: For Valve previously using Wiper, Retainer and


[ 79 ] PM 2000

Plate, now use Bonded Plate and Wiper Assembly (Items 35, 70, 90).

n 0

n

0

n

rn

tof

0 z

a C3

03 0

rs) 0 0 0

MICHIG1111 CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

INSTRUMENT PANEL Item No.

Part No.


1 581420 PANEL, Instrument 1

2 626530 CLAMP, Fuel Gauge 1

3 14D-10 NUT, Fuel Gauge 2

3A 12E-10 tLKWSHR, Fuel Gauge 1

4 602350 SEPARATOR, Fuel Gauge Terminal 1

5 551320 GAUGE, Fuel 1

6 12D-8 NUT, Fuel Gauge 2

6A 12E-8 tLKWSHR, Fuel Gauge 1

7 601212 CLAMP, Ammeter 1

8 550735 AMMETER 1

9 14D-10 NUT, Ammeter 4

9A 12E-10 tLKWSHR, Ammeter 2

10 626530 CLAMP, Cony. Temp. Gauge 1

11 14D-10 NUT, Cony. Temp. Gauge 2

11A 12E-10 tLKWSHR, Cony. Temp. Gauge 1

12 551321 GAUGE, Converter Temperature 1

13 12D-8 NUT, Corm Temp. Gauge 2

13A 12E-8 tLKWSHR, Cony. Temp. Gauge 1

14 18G-606 SCREW, Dash Lamp 2

14A 12E-6 tLKWSHR, Dash Lamp 2

15 556891 LAMP,. Dash (Inc. 15A, 53) 1 15A 940287 tBULB, Dash Lamp 1 16 626530 CLAMP, Oil Pressure Gauge 1

17 14D-10 NUT, Oil Pressure Gauge 2

17A 12E-10 tLKWSHR, Oil Pressure Gauge 1

18 602350 SEPARATOR, Oil Pressure Gauge 1

19 523372 GAUGE, Engine Oil Pressure 1

20 12D-8 NUT, Oil Pressure Gauge 2

20A 12E-8 tLKWSHR, Oil Pressure Gauge 1

21 551254 ADAPTER, Oil Pressure Gauge 1

22 525374 ADAPTER, Engine Temp. Gauge 1

23 14D-10 NUT, Engine Temp. Gauge 2

23A 12E-10 tLKWSHR, Engine Temp. Gauge 1

24 551322 GAUGE, Engine Temperature 1

25 12D-8 NUT, Engine Temp. Gauge 2

25A 12E-8 tl-KWSHR, Engine Temp. Gauge 1

26 626530 CLAMP, Engine Temp. Gauge 1

27 14D-10 NUT, Air Pressure Gauge 2

27A 12E-10 tLKWSHR, Air Pressure Gauge 1

28 31G-409 SCREW, Panel to Cockpit 4

29 6E-04 LKWSHR, Panel to Cockpit 4

30 517228 GAUGE, Air Pressure 1

31 626530 CLAMP, Air Pressure Gauge 1

32 12D-8 NUT, Air Pressure Gauge 2

32A 12E-8 tLKWSHR, Air Pressure Gauge 1

I tern No.

Part No.


33 551254 ADAPTER, Air Pressure Gauge 1

34 12D-8 NUT, Adapter 1

34A 12E-8 fl.KWSHR, Adapter 1

35 742710 PLUG BUTTON 1



38 600259 PUSH BUTTON, Starter (Inc. 38A) 1

38A 857420 tRUBBER BOOT, Push Button 1


39A 12E-8 tLKWSHR, Adapter 1

40 940646 CLAMP, Tachometer 1

41 12D-8 NUT, Tachometer 2

41A 12E-8 tLKWSHR, Tachometer 2

42 580857 CABLE, Tachometer 1

42A 511426 tGROMMET,. Tachometer Cable 1

43 941807 TACHOMETER 1



45 3G-1008 SCREW, Ground Wire 1

45A 12D-10 tNUT, Ground Wire 1

45B 12E-10 tLKWSHR, Ground Wire 1

46 525374 ADAPTER, Cony. Temp. Gauge 1



48 551251 DAMPENER, Hourmeter Vibration 1

49 536999 WIRE, Hourmeter Ground 1

50 784700 HOURMETER, Engine 1

51 3G-604 SCREW, Hourmeter 6

51A 12E-6 t LKWSHR, Hourmeter 6

52 695650 WIRE, Ammeter to Ignition Switch 1

53 §WIRE, Dash Lamp — See 15

54 550741 SWITCH, Light 1

54A 550742 tROD, Light Switch 1

54B 550743 tBUSHING, Light Switch 1

55 550740 SWITCH, Ignition 1

56 661556 FUSE — 14 Amp 1

57 590700 WIRE, Ignition Switch to Light Switch 1

58 553620 WIRE, Ignition Switch to Starter Button 1

59 661555 FUSE — 4 Amp 1

60 590699 WIRE, Light Switch to Gauges 1



62 551254 ADAPTER, Fuel Gauge 1




PM 2000 [ 81 ]

mICHIGAII CMRK EQUIPMENT


SEAT AND FLOORBOARDS Item No.

Part No


Item No.

Part No.


A 546687 SEAT ASSY (Inc. 1 thru 5) 1 20 566284 FLOORBOARD & SEAT SUSPENSION 1 944499 CUSHION, Seat ASSY (Inc. 6 thru 11, 15, 16, 20A, 2 944981 CUSHION, Back-Rest 1 20B, 21, 23, 29 thru 32) 1

3 944982 BUCKET 1 20A 580779 FLOORBOARD, (Only) Rear 1

4 1C-610 BOLT, Back-Rest & Cushion Attaching 5 20B 559106 SEAT SUSPENSION ASSY (Inc. 6 thru

5 1C-610 BOLT, Seat Cushion Attaching 2 11, 15, 16, 21, 23, 29 thru 32) 1

6 946131 CARRIAGE ASSY (Inc. 7, 9) 1 21 945798 BUSHING, Seat Suspension Base 4

7 945798 BUSHING, Carriage 2 22 580780 PLATE, Floorboard Clamp 1

8 945804 BOLT, Carriage to Upper Arm 2 23 945804 BOLT, Base to Lower & Upper Arms 4

9 945798 BUSHING, Carriage 2 24 580777 FLOORBOARD, Front 1

10 945804 BOLT, Carriage to Lower Arm 2 25 4E-06 LKWSHR, Floorboard to Cockpit 4 11 43D-08 NUT, Carriage to Lower Arm 2 26 18C-612 BOLT, Floorboard to Cockpit 4 12 1618606 HAIRPIN, Shock Absorber Attaching 2 27 4E-06 LKWSHR, Clamp Plate to Cockpit 4 13 943663 PIN, Shock Absorber Attaching 2 28 18C-612 BOLT, Clamp Plate to Cockpit 4 14 15 16 17

559107 43D-08 43D-08 18C-612

SHOCK ABSORBER ASSY NUT, Base to Upper Arm NUT, Base to Lower Arm BOLT, Rear Floorboard to Cockpit

1 2 2 6

29 30 31

946130 945796 945796

BASE, Seat Suspension ARM, Lower ARM, Upper

1 1 1

18 4E-06 LKWSHR, Rear Floorboard to Cockpit 6 32 43D-08 NUT, Carriage to Upper Arm 2

19 980055 WASHER, Rear Floorboard to Cockpit 6 33 18D-05 NUT, Seat to Carriage 4


[ 82 ]

PM 2000

CMRK EQUIPMENT


WHEEL AND TIRE DATA Item No. Description

No. Req'd.

26.5 x 29 29.5 x 25

TIRE 2 2 523253 543563 RING, Lock 2 3 509445 509445 VALVE STEM ASSY (Inc. 4, 5) 2 4 551684 551684 ADAPTER, Valve Stem 2 5 551685 551685 CAP, Valve 2 6 523247 523247 DRIVER 2 7 559449 559450 WHEEL 2 8 523252 562303 BAND, Bead Seat 2 9 513117 580278 "0" RING 2

10 580479 522329 FLANGE 4 11 529310 tnyG 2

t Not Illustrated


PM 2000 [ 83 ]

0 z IA

0 z

en

0 z

a C3

=I

0 0

0 z 0.

Chrome No. 14 ,

J

— ENGINE OIL PRESSURE SENDER

STARTER

STARTER SOLENOID

Dark Blue No. 14

Black No. 10

White No. 10

Chrome No. 14

White No. 14

Purple No. 14

Dark Green No. 14

Orange No. 14

Brown No. 14

0 z 0 z -.5 1:0

121 SWITCH

TORQUE CONVERTER VOLTAGE I REGULATOR TEMPERATURE

GAUGE

0

LIGHT

HOURMETER

DASH LAMP

ENGINE OIL PRESSURE GAUGE

AIR PRESSURE SENDER STARTER SWITCH

ENGINE TEMPERATURE GAUGE

0

0 z 0

A-2

A-1 o GENERATOR

z z

HOURMETER

PRESSURE SWITCH

CONNECTOR

Dark Blue No. 14

°FUEL LEVEL SENDER

White No. 14

ENGINE TEMPERATURE SENDER

CONNECTOR

a

Yellow No. 14 fu. 14 AMP FUSE

TORQUE CONVERTER TEMPERATURE SENDER TORQUE CONVERTER)

0 z a HEAD LAMP

IGNITION . SWITCH

(1) HEAD LAMP

TRACTOR - SCRAPER MODEL - 210 GM

WIRING DIAGRAM

Light Green No. 14

TS-6389-P

MICHIGAIll CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

WIRING AND BATTERY CABLES

Item No.

Part No.


Item No.

Part No.


1 593225 WIRE ASSY, Head Light to Wiring 6 581063 CABLE, Starter to Ground 1

Harness 1 7 637280 WIRE, Voltage Regulator to Ground__ 1

2 602355 CONNECTOR, Head Light & Starter Solenoid Wire 2 8 583007 HARNESS, Main Wiring 1

3 521310 CABLE (To connect Battery in Series) 3 9 583253 WIRE, Starter Solenoid to Main

Wiring Harness 1

4 592984 CABLE, Battery to Ground 1 10 18D-08 NUT, Ground to Frame 1

5 582702 CABLE, Battery to Starter 1 11 552438 GROMMET, Battery Compartment ____

TOOLS Item No.


No. Req'd.

Item No.

Part No.


12 711264 WRENCH, Wheel 1 17 584853 SLEEVE, Wheel Assy Pilot 2

13 552164 HANDLE, Wheel Wrench 1

14 522996 WRENCH, Hub Bearing — 5%6" 1 18 RING, Packing Compressor

15 522997 WRENCH, Hub Bearing — 5 1 916 1 18A 953069 For EJECTOR CYLINDER 1

16 953066 SLEEVE, Piston Rod Wiper Taper 1 18B 953068 For STEERING CYLINDER 1

DECALS

Item No.


No. Req'd.

Item No.

Part No.


19 547852 *DECAL, Michigan Tractor 2 28 584608 *DECAL, Cold Starting Procedure — Cummins 1

20 547851 *DECAL, Clark Equipment 2

29 548521 *DECAL, Switch Identification — 21 584569 *DECAL, Model 210 2 Cummins 1

22 584607 *DECAL, Torque Converter & 30 548522 *DECAL, Engine Shut Down — Transmission Fill 1 Cummins 1

23 548472 *DECAL, Reservoir & Transmission Oil Level 2 31 584609 *DECAL, Accumulator Safety 1

24 538256 *DECAL, Transmission Drain 1 32 542074 PLATE, Patent 1

25 548520 * DECAL, Torque Converter — 33 6C-605 SCREW, Patent Plate Drive 4 On Instrument Panel

26 538258 *DECAL, Starter 1 34 582867 PLATE, Instruction 1

27 584567 *DECAL, Michigan — Scraper 2 35 6C-605 SCREW, Instruction Plate

*NOTE: Contact your local Michigan Distributor for the above listed Decals.


PM 2000 [ 85 ]

1-1

03 o. 1-1

n 0 z H

70

n

0

xt.

0 z

3 1,3 O 0 0

a

CLeIRK EQUIPMENT


CAB ASSEMBLY

Item No.

Part No.


A 593071 CAB ASSY (Inc. 1 thru 50) 1

1 955833 FINGER LIFT, Sliding Glass 1

2 GLASS PATTERN, Front Sliding Window (See 51) 1

3 138294 CHANNEL, Sliding Window — Top 1

4 GLASS PATTERN, Rear Sliding Window (See 51)

5 955833 FINGER LIFT, Sliding Window 1

6 138295 CHANNEL, Sliding Window — Rear 1

7 138102 BODY, Cab 1

8 2C-816 BOLT, Cab Attaching — ' 1/2 " 2

9 138319 LOCKSTRIP, Rear Window Moulding._ 1

10 GLASS PATTERN, Rear Window

11 138318 MOULDING, Rear Window

12 138288 HINGE, Door Pivot 2

13 9G-520 SCREW, Door Hinge — Allen Head 6

14 138291 PLATE, Hinge Back-Up 2

15 4E-05 LKWSHR, Door Hinge 6

16 1D-05 NUT, Door Hinge 6

17 138232 STRAP, Door Check 2

18 138252 CHANNEL, Sliding Window — Top 1

19 955833 FINGER LIFT, Sliding Glass 2

20 138253 CHANNEL, Sliding Window — Rear 1

21 GLASS PATTERN, Rear Sliding Window (See 51)

22 593219 DOOR ASSY, (Inc. 12 thru 33, 37, 38, 39) 1

22A 138238 PANEL, Door 1

23 138198 HANDLE, Door — Outside 1

24 742950 SCREW, Outside Door Handle 2

Item No.

Part No.


25 138249 LATCH, Inside Door 1

26 17E-10 LKWSHR, Door Latch 4

27 2G-1012 SCREW, Door Latch 4

28 138250 CHANNEL, Sliding Window — Bottom 1

29 138248 STRIP, Door Window Retaining 1

30 17E-10 LKWSHR, Retaining Strip Attaching 6

31 18G-1008 SCREW, Retaining Strip Attaching 6

32 GLASS PATTERN, Front Sliding Window (See 51) 1

33 138251 CHANNEL, Sliding Window — Front 1

34 18G-1008 SCREW, Retaining Strip Attaching 6

35 17E-10 LKWSHR, Retaining Strip Attaching 6

36 138298 STRIP, Sliding Window Retaining 1

37 17E-10 LKWSHR, Check Strap Attaching 4

38 2G-1012 SCREW, Check Strap Attaching 4

39 138379 PLATE, Check Strap Backing 2

40 2D-08 NUT, Cab Attaching — 1/2 " 2

41 4E-08 LKWSHR, Cab Attaching — '1/2 2

42 2C-612 BOLT, Cab Attaching — 3/8" 8

43 4E-06 LKWSHR, Cab Attaching — 3A" 8

44 2D-06 NUT, Cab Attaching — %" 8

45 743200 BUTTON, Plug — Windshield Wiper Hole 1

46 138319 LOCKSTRIP, Windshield Moulding 1

47 GLASS PATTERN, Windshield (See 51) 1

48 138318 MOULDING, Windshield 1

49 138292 CHANNEL, Sliding Window — Bottom 1

50 138293 CHANNEL, Sliding Window — Front 1

51 943863 GLASS PATTERN KIT (Inc. 2, 4, 10, 21, 32, 47) 1


PM 2000

[ 87 ]

TS-5008-P

MICHIGIM CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

WIRING, PIPE AND HOSE CLIPS

The following types of clips are used in connection with the various wiring, fuel, air and hydraulic piping

systems employed in this unit. When replacing clips identification can be made by checking type and

physical dimensions listed to obtain part number.

INSULATED CLIP

ITEM NO.

PART NUMBER A B C D E F

1 29H-7 1/4 1 %2 %2 1/2 .025

2 29H-9 1/4 % ' %2 % .025

3 29H-10 V16 716 %2 1/2 ' .025

4 29H-12 716 21/32 1%2 5/8 .025

5 29H-13 % ' 9/32 9/32 1/2 .025

6 29H-19 1/2 2%2 9/32 1/2 .025

7 29H-21 1/2 3/4 1% 2 1/2 .025

8 29H-36 1 '/4 1 Y1 6 11/32 716 .025

9 29H-50 5/8 2%2 %2 1/2 .025

10 30H-7 '/8 1%2 9/32 1/2 .025

11 30H-19 716 5/8 11/32 5/8 .036

12 30H-45 ' V16 7/8 11/32 5/8 .050

[ 88 ]

PM 2000

CUIRK EQUIPMENT

CONSTRUCTION MACHINERY DIVISION MICHIGNI1

NUMERICAL INDEX Part No. Page No. Part No. Page No. Part No. Page No. Part No. Page No.

1C-408 1C-412 1C-416 1C-516 1C-610 1C-612 1C-632 1C-720

1C-722 1C-724 1C-732 1C-740 1C-748 1C-820 1C-824 1C-888

1D-05

1F-207

1F-208

1F-212

1F-308

1F-312

1F-316

1F-412

1F-414

1F-422

1F-432

1F-436

1F-440

1F-748

1F-856 1H-415 1H-420

2C-612 2C-720 2C-816 2C-896 2C-940

2D-06

2D-08

2D-12

2E-14

2J-4200 2J-8300 3C-716 3C-818 3C-820 3E-08 3G-604 3G-808 3G-814 3G-1008

4D-05

4D-10

4E-04

4E-05

4E-06

1C-1024

1C-1030

1C-1036

1C-1236

1M-18032

2G-1006

2G-1012

27,

7,

7,

1, 5, 2, 4, 8, 13, 20, 21, 38, 56, 63, 67,

29, 35,

43,

13,

13, 21, 57, 15, 43, 69,

44, 38, 31, 37,

38,

25,

5,

38,

7, 41,

57,

55, 73,

57,

43,

15,

15, 44, 59, 17, 47, 82,

44 79 79

5 82 63 51 33 79 44 43 38 39 45 79 51 63 53 51 53 51 87

7 57 39 55 60

7 Al 77 65 31 43 25 53 72 24 24

87 53 87 73 53 87 87 56 63

9 87

7 77 53 44 72 63 81

9 9

81 39 65 20 79 87 19 51 87

4E-07

4E-08

4E-10 4E-12 4F-04051 4F-06106 4F-08127 4G-408 5C-616 5C-620 5K-409 5K-611 6C-605 6E-04 6E-06 6E-07 7J-4108 8C-1028 8D-04 8D-05 8D-06 8D-07 8D-08 8D-10 8D-12 9G-520 10E-04 10H-25 10H-35 10J-08 10J-09 10J-12

10J-16 10J-32 11C-6152 11E-135 11F-16 12D-8 12D-10 12E-6 12E-8 12E-10 12F-300 12G-1072 12G-1480 12H-15 12H-25 13F-02 13F-04 13F-08 13F-12 13F-20 14D-10 14G-1408 15D-06 16F-01 16F-02 16F-04 16F-16 17C-408 17C-514 17C-516 17C-548 17C-612 17C-616 17C-618

1,

.11,

27,

27, 39, 47, 17, 67, 13,

29,

49,

9,

31, 41, 53, 20, 73, 51,

31,

49,

51,

27,

13,

51,

13,

33, 43, 63, 25, 75, 53,

20,

33,

7, 41,

57,

71,

29, 35,

15,

65,

20,

15,

37, 38 44, 45 75, 79 43, 65 79, 87 71, 77 51, 56

7, 57 Al

57, 77 5

23 23 59

21, 67 85 81 44

35, 37 65 11 7

68, 78 43, 69

63 77, 79

65 65 87 53

72, 77 49, 65 43, 79

63 31, 33 37, 38

54 45

13, 15 51 51

9, 81 81 81

9, 81 59, 81

51 69 73

71, 72 71 59

59, 75 59, 63 21, 23 43, 44 59, 81 13, 15

8 69 73

31, 78 13, 15

7 59 59 59

2 4, 8

8

17C-620

17C-720

17C-724

17C-820

17C-824 17C-1032

17D-3

17E-10

17F-2

17K-7

18C-408

18C-410

18C-412

18C-420

18C-424

18C-444

18C-508

18C-512

18C-514

18C-516

18C-520

18C-528

18C-536

18C-540

18C-612

18C-614

18C-616

18C-618

18C-620

18C-622

18C-624

18C-720

18C-722

18C-814

18C-816

18C-820

18C-828

18C-832

18C-840

18C-864

18C-872

18C-880 18C-1020 18C-1024 18C-1028 18C-1032 18C-1036 18C-1044 18C-1052 18C-1072 18C-1088 18C-1228 18C-1236 18C-1248 18C-1256 18C-1288 18C-1664

18D-04

18D-05

18D-06

18D-07

18D-08

18D-10

18D-12

47, 67 43, 47, 75

Al 65

67, 75 51

,. 13, 15 87 59 67

20, 21 17, 19

7, 41, 59 1

41 7

59 17, 19, 57, 59

57 60

1 57

41, 67 41

13, 15, 17, 19 20, 21, 82

2, 17, 19 9, 13, 15, 17

19, 20, 21 9, 19, 21, 47

67 17, 19, 20, 21, 75

17, 19, 47 67 47

4 17, 20

1 11, 13, 15

9, 13, 15, 17 19, 21, 65

65 71 71 71 67

13, 71 13, 77

11 11 11 4

65 11 13 11 11 11 72 11

1,7,41,59 17, 19, 41, 57 59, 60, 67, 82

2, 9, 17, 19, 20 21, 47, 67, 75

47, 67 4, 11, 15, 17, 20

65, 71, 73, 85 4, 11, 13, 67

11, 13, 15

18D-16

18F-4

18G-606

18G-1008

18K-6

18K-7

21F-1

24C-1656

24C-20144

24E-06

25K-20006

25K-20010

25K-20018

25K-30014

25K-40024

25K-40026

25K-40106

25K-40108

25K-40110

25K-40112

25K-40116

25K-40120

25K-40128

25K-40200

25K-40208

25K-40224

25K-40312

25K-40428

25K-40700

25K-60116

25K-60124

25K-60204

25K-80516

26F-1

26F-2

26F-4

26F-5

26F-6

26K-212

28K-212

29H-7

29H-9

29H-10

29H-12

29H-13

29H-19

29H-21

29H-36

29H-50

30H-7

30H-18

30H-19

30H-45

30K-304

30K-306

31F-1

31F-2

31F-3

31F-4

31F-5

31F-6

31G-409

33F-4

33F-5

33F-6

33G-405

33G-514

36F-1

36F-2

27,

13,

29, 35,

47,

15,

31, 37,

63, 47,

75, 23, 67,

20,

31,

20,

7, 7,

13,

13,

11 59 81 87 67 67

1 11 11 55 78 78 68 45 45 33 38 45 79 67 45 79 79 79 72 75 63 63 21 53 43 51 25 72

1 59 59 21 67 67 67 88 88 88 88 88 88 88 88 88 88 15 88 88 75 15 59 59 59 59 47 47 81 59 67 47 65 68 59 59

PM 2000 [ N-1 ]


Part No . Page No. Part No. Page No. Part No. Page No. Part No. Page No.

36F-3 59 108470 51 209382 38 222033 44

36F-4 59 108471 51 209587 43 222034 45

36F-6 47,67,75 108472 51 209588 44 222035 43

38F-3 13,15 108475 51 209589 44 222037 43

40K-02 44,45 108476 51 209590 44 222038 43

40K-04 79 108477 51 209591 44 222041 45

40K-06 38 108478 51 209673 44 222043 45

430-08 82 108485 55 209781 27,29,33,35,37 222044 45

47D-05 68 109129 51 209968 73 222045 45

50D-8 9 109597 55 211433 38 222047 45

60K-40700 44 109598 55 214295 43 222051 24

64D-14 51 109599 55 214941 43 222052 24

66D-05 7 110126 55 214992 .27,29,31,33,35,37 222053 24

66D-06 41 110206 51 215265 44 222054 24

66D-10 65 110594 56 215500 47,67 222055 24

68D-12 72 110814 51 215502 47,67 222056 24

68D-16 11 110855 55 215509 27 222057 24

70D-08 __9,13,15,17,19,21 111053 55 215511 27 222058 24

70D-12 11 111056 55 215513 29 222059 24

71D-08 __9,13,15,17,19,21 111252 51 215515 29 222060 24

71D-12 11 111253 51 215517 37 22206 1 24

73F-2 4 111254 51 215519 37 222062 24

73G-732 63 111255 51 215521 31,33,35 222063 24

74G-1028 11 111256 51 215523 31,33,35 222064 24

91F-6 67,68 111338 51 215768 35 222065 24

91F47 67 111368 53 215769 27 222066 24

100838 43 111461 51 215770 37 222067 24

100949 43 111476 51 215771 29 222068 23

103293 13,15 111615 53 215846 38 222069 23

103452 51 111656 51 215910 45 222070 23

104168 53 111657 53 215911 45 222073 23

104412 51 111658 51 215988 39 222074 23

104645 57 112537 51 215989 39 222075 23

106762 51 112919 55 215990 39 222077 27,29,33,35,37

107010 51 113249 55 216049 31,33 222078 27,29,33,35,37

107706 55 114434 51 216050 29,31,33,35 222079 29,31,33,35,37

107707 55 116422 53 216094 44 222080 33

107709 55 116426 53 216095 43 222081 31,33

107713 55 116427 53 216555 43 222083 29,31,33,35,37

107732 51 116477 53 218721 43 222084 29,31,33,35,37

107735 51 116519 53 218723 44 222085 29,31,33,35,37

107736 51 116552 53 218725 43 222086 29,31,33,35,37

107739 51 116923 51 218776 43 222089 33,35

107892 53 116937 51 218777 44 222092 31

107901 53 117484 54 218779 43 222093 31

107912 53 117485 54 218782 44 222096 31

107914 53 130901 51 220105 38 222098 23

107958 53 138102 87 221643 25 222099 23

107962 53 138198 87 221745 31,33,35,37 222103 27,37

107965 53 138232 87 221777 38 222104 27

107969 53 138238 87 221778 38 222126 27

107971 53 138248 87 221788 38 222128 27

107973 53 138249 87 221793 38 222129 27

107974 53 138250 87 221873 24 222130 25

107975 53 138251 87 221886 39 222133 25

107977 53 138252 87 221943 38 222134 25

107978 53 138253 87 221944 38 222135 25

107983 51 138288 87 221988 73 222137 25

107989 54 138291 87 221992 43,69 222138 25

107990 54 138292 87 222001 43 222152 29

107991 54 138293 87 222002 44 222167 24

107992 54 138294 87 222003 44 222168 31

107993 54 138295 87 222004 44 222172 29,31,33,35

107995 51 138298 87 222006 44 222173 29,31,33,35

107996 51 138318 87 222007 44 222179 31,43

108028 51 138319 87 222008 44 222181 -25

108030 51 138379 87 222017 43 222186 27,37

108031 51 201623 44 222018 44 222187 27,37

108451 53 203647 38 222019 44 222192 27,37

108454 53 205928 31,43 222025 43 222197 37

108455 53 206770 43 222026 43 222198 29,35,37

108456 55 207647 43 222027 44 222201 25

108464 51 208812 38 222031 44 222202 25

[N2]

PM 2000

CLeIRK EQUIPMENT


Part No. Page No. Part No. Page No. Part No. Page No. Part No. Page No.

222203 25 224178 29,31,33,35,37 529310 83 551906 43,69 222204 25 224179 29,31,33,35,37 529791 67 552161 73 222205 27 224180 29,31,33,35,37 530509 7 552164 85 222206 27 224181 29,31,33,35,37 530533 17,19 552438 57,59,85 222207 27 224182 29,31,33,35,37 530663 59 553620 81 222209 31 224183 29,31,33,35,37 531584 72 556562 60 222210 27,37 224184 29,31,33,35,37 531684 67 556655 13,15 222213 29,31,33,35 224185 29,31,33,35,37 531905 7 556891 81 222216 29 224186 29,31,33,35,37 532276 4 559106 82 222221 44 224187 27 532563 72 559107 82 222223 44 224188 27 532675 3 559294 71 222224 25 224189 27 532687 2,3 559295 71 222226 27,29 224190 27 533286 2 559296 71 222228 31 224191 27 535003 7 559300 71 222232 43 224192 27 536367 47 559302 71 222339 35 224193 27 536539 68 559365 71 222365 27 224194 27 536999 81 559367 71 222366 29,31,33,35,37 224195 27 537015 11 559449 83 222376 27 224392 33 538154 72 559450 83 222377 29,35 224395 27 538256 85 562303 83 222545 41 224433 27,37 538258 85 565500 8 222603 31,33,35,37 224437 29,31,33,35 539042 2 566266 49 222604 27,29 224508 29,35,37 539744 69 566284 82 222618 29,31,33,35,37 224797 43 540231 59 568957 77 222619 27,37 224944 23 540306 59 569000 11 223314 31 225385 43 540797 2 569055 77 223315 37 225406 25 541749 72 569067 4 223316 29,33,35 226961 25 541769 72 569069 4 223318 27 228122 31 541869 8 569070 4 223334 43 281519 43 542074 85 569215 8 223368 43 282255 22 542646 1 569581 5 223387 44 302602 44 543563 83 569600 5 223406 29,31,33,35,37 351131 7 544588 8 569658 11 223570 43 356611 59 544597 8 569754 11 223595 43 356614 59 546687 82 569756 71 223729 39 356616 59 547851 85 569812 71 223859 44 450140 43 547852 85 569837 71 223890 73 503146 17,19 547915 8 569840 11 223900 44 507816 59 548472 85 569841 71 223960 43 509445 83 548520 85 569842 71 223961 43 509772 41,77 548521 85 570090 15 223962 43 510452 59 548522 85 570121 15 223963 43 511426 17,19,20,21,81 548657 72 570122 15 223964 43 511512 2 550044 65 570125 19 223987 38 513117 83 550261 72 570162 15 223988 43 513865 2 550389 20,21 570203 11 223989 29,31,33,35 516058 2 550398 20,21 570207 21 223990 29,31,33,35,37 516132 49 550450 72 570419 11 223991 29,33,35 516599 75 550488 11 571774 9 223992 31 516737 13,15 550594 65 572231 11 223993 27,37 517228 81 550735 81 572232 11 223994 27,37 518234 20,21 550740 81 580278 83 223995 27 518259 60 550741 81 580479 83 223997 43 518261 60 550742 81 580495 11 223998 43 518331 63 550743 81 580498 11 223999 43 521310 85 550803 41 580591 47 224000 43 522019 67 550877 67 580734 47 224003 29,31,33,35,37 522329 83 550924 67 580777 82 224004 27 522617 72 551015 7 580779 82 224009 43 522632 4 551016 7 580780 82 224032 51 522747 1 551090 7 580782 65 224036 43 522996 85 551244 9 580783 65 224039 43 522997 85 551251 81 580857 81 224040 38 523247 83 551254 81 580935 9 224047 38 523252 83 551291 9 581063 85 224052 53 523253 83 551320 81 581204 13,15 224061 44 523372 81 551321 81 581411 67 224073 51 524936 2 551322 81 581420 81 224095 38 525293 20,21 551323 1 581424 4 224120 43 525374 81 551434 9 581425 4 224172 38 527496 72 551606 72 581429 7 224176 29,31,33,35,37 527497 72 551684 83 581433 7 224177 29,31,33,35,37 527812 72 551685 83 581438 7

PM 2000

[ N-3 ]

MICHICAll CONSTRUCTION MACHINERY DIVISION CUIRK EQUIPMENT

Part No. Page No. Part No. Page No. Part No. Page No. Part No. Page No.

581441 7 584569 85 593027 57 648304 63 581482 47 584607 85 593028 57 652402 19 581487 581533

77 9

584608 584609

85 85

593035 593071

57 665544(7)12;

25 45

581570 41 584620 71 593117 47 655070 27 581572 41 584621 71 593172 65 655071 27 581576 41 584666 71 593219 87 655629 5 581659 7 584669 71 59322 5 85 655673 51 581660 2 584698 9 593280 59 659029 65 581661 2 584754 71 593370 59 659162 15 581676 13 584757 71 593388 59 660178 79 581677 9 584758 71 593415 77 660516 51 581814 71 584761 71 593417 75 660883 29,31,33,35,37 581978 41 584763 71 593418 75 661428 47 581979 41 584853 85 593435 59 661555 81 581980 41 585674 51 593438 59 661556 81 581981 41 585883 47,67 593449 59 662145 11 581983 41 585886 75 593478 51,59 663093 47,67 581984 41 585913 13,15 593638 7 663094 47,75 582021 41 585972 13,15 593650 59 663095 67 582023 41 586108 1 573786 20,21 663096 75 582037 41 586110 8 594053 71 663609 29,31,33,35,37 582039 41 586628 13 594059 63 663792 68 582242 47 586644 13 594063 17,19 663823 79 582246 47 588187 11 594064 67 664425 4,11 582247 47 588288 8 594065 67 664428 11 582249 47 588384 8 594070 67 664962 19 582298 47 590342 77 594081 67 668674 63 582299 47 590354 77 594086 13,15 669881 2 582305 47 590498 65 594091 59 669897 25 582306 47 590519 71 594095 13 669953 67 582342 47 590573 71 594106 17,19 672004 53 582372 78 590574 71 594123 63 672582 67 582687 73 590699 81 594124 63 675133 75 582702 85 590700 81 594126 71 675543 43 582708 75 591187 13 594132 59 695650 81 582710 75 591381 13,15,20,21 594133 59 695930 63 582711 75 591400 77 594134 65 696073 81 582739 20,21 591653 72 594143 59,67 710034 53 582745 65 591654 72 594178 67 710035 53 582746 65 591659 72 594179 67 710037 25 582747 65 591785 11 594375 60 710855 51 582748 65 591789 11 594418 17,19 710986 53 582749 65 591989 71 594550 71 710987 53 582760 20 591990 71 594742 17,19 711046 67 582778 47 592002 71 594743 17,19 711161 44 582805 47 592003 71 594857 7 711264 85 582867 85 592045 71 594859 7 713023 65 582920 11 592384 9 600259 81 713024 65 582922 11 592486 4 601212 81 730143 63 583007 85 592661 17,19 602350 81 730245 29,31,33,35,37 583253 85 592670 17,19 602355 85 731163 13,15 583270 8 592689 13,15 612840 63 731221 51 583273 9 592692 13,15 613750 79 731283 44 583281 77 592783 59 614644 9 731360 29,31,33,35,37 583282 77 592784 59 616786 44 731361 29,31,33,35,37 583283 75 592832 75 616794 38 731366 27 583339 17,19 592833 75 616800 11 731367 27 583373 17 592834 75 619018 24 731742 43 583382 67 592835 75 619019 39 731745 78 583466 65 592849 47 619021 43 731981 53 583800 17,19 592874 65 619025 41 731982 51 583809 17,19 592877 65 623762 7 731984 51 583838 11 592905 65 623829 7 731988 51 583865 71 592906 77 626530 81 731995 53

-583866 71 592911 77 627982 13,15 742009 65 583867 71 592952 65 628763 63 742010 65 583884 65 592976 65 628764 63 742260 51 584018 13,15 592977 65 633157 45,79 742710 81 584092 13,15;19,21 592984 85 635682 65 742950 87 584153 75 593001 41 636260 1 743200 87 -584522 ,71 593022 41 637280 85 763193 27 584567 85 593026 57 641282 20,81 763195 27

[N4]

PM 2000

o II PARTS MANUAL

Documents

Transcript of o II PARTS MANUAL