NPDES Form 2C - Wastewater Discharge Information · 2014-12-12 · Temperature (winter) VALUE VALUE...

1

Peltier, Hannah

From: Ahrendsen, BlakeSent: Friday, December 12, 2014 9:55 AMTo: Peltier, HannahSubject: FW: NPDES Permit Renewal Application - AR0046116Attachments: WF-06_NPDES_Form_2C_Amendment_121214.pdf; ATT00001..htm; 678528.pdf;

ATT00002..htm

Importance: High

From: Seth Pickens [mailto:[email protected]] Sent: Friday, December 12, 2014 9:49 AM To: Fuller, Kim Cc: Ahrendsen, Blake; Ahrendsen, Blake; Bruce Shackleford; GREG HICKS; [email protected] Subject: Re: NPDES Permit Renewal Application - AR0046116 Importance: High Blake, As requested in Item 3 of the email sent on December 3, 2014, please find attached to this email the updated Section V.A of EPA Form 2C for Outfall 001 for the West Fraser Huttig, AR Facility and the associated lab report test data. As we have now addressed all 4 items from the email below, our application should now be complete. Please let me know if the Department requires any additional information or has any further questions. Cordially, Seth Pickens, B.S., CPSWPPP, CCSI Environmental Scientist Environmental Consulting Operations, Inc Integrating ECOnomy and ECOlogy since 1990 17724 I‐30 Suite 5A Benton, AR 72019 Office ‐ 1‐501‐315‐9009 Cell ‐ 1‐479‐518‐1819 [email protected]

PLEASE PRINT OR TYPE IN THE UNSHADED AREAS ONLY. You may report some or all of this information on separate sheets (use the same format) instead of completing these pages. SEE INSTRUCTIONS.

EPA I.D. NUMBER (copy from Item 1 of Form 1)

V. INTAKE AND EFFLUENT CHARACTERISTICS (continued from page 3 of Form 2-C) OUTFALL NO.

PART A –You must provide the results of at least one analysis for every pollutant in this table. Complete one table for each outfall. See instructions for additional details.

2. EFFLUENT 3. UNITS

(specify if blank) 4. INTAKE (optional)

a. MAXIMUM DAILY VALUE b. MAXIMUM 30 DAY VALUE

(if available) c. LONG TERM AVRG. VALUE

(if available) a. LONG TERM

AVERAGE VALUE

1. POLLUTANT (1)

CONCENTRATION (2) MASS (1)

CONCENTRATION (2) MASS (1) CONCENTRATION (2) MASS d. NO. OF

ANALYSES a. CONCEN-

TRATION b. MASS (1)

CONCENTRATION (2) MASS b. NO. OF

ANALYSES

a. Biochemical Oxygen Demand (BOD) b. Chemical Oxygen Demand (COD) c. Total Organic Carbon (TOC) d. Total Suspended Solids (TSS)

e. Ammonia (as N)

f. Flow VALUE VALUE VALUE

VALUE

g. Temperature (winter)

VALUE VALUE VALUE °C

VALUE

h. Temperature (summer)

VALUE VALUE VALUE °C

VALUE

i. pH MINIMUM MAXIMUM MINIMUM MAXIMUM

STANDARD UNITS PART B – Mark “X” in column 2-a for each pollutant you know or have reason to believe is present. Mark “X” in column 2-b for each pollutant you believe to be absent. If you mark column 2a for any pollutant which is limited either

directly, or indirectly but expressly, in an effluent limitations guideline, you must provide the results of at least one analysis for that pollutant. For other pollutants for which you mark column 2a, you must provide quantitative data or an explanation of their presence in your discharge. Complete one table for each outfall. See the instructions for additional details and requirements.

2. MARK “X” 3. EFFLUENT 4. UNITS 5. INTAKE (optional)



(if available) a. LONG TERM AVERAGE

VALUE 1. POLLUTANT

AND CAS NO.

(if available)

a. BELIEVED PRESENT

b. BELIEVED ABSENT

(1) CONCENTRATION (2) MASS



d. NO. OF ANALYSES

a. CONCEN-TRATION b. MASS


b. NO. OF ANALYSES

a. Bromide (24959-67-9)

b. Chlorine, Total Residual

c. Color

d. Fecal Coliform

e. Fluoride (16984-48-8)

f. Nitrate-Nitrite (as N)

EPA Form 3510-2C (8-90) PAGE V-1 CONTINUE ON REVERSE

ITEM V-B CONTINUED FROM FRONT 2. MARK “X” 3. EFFLUENT 4. UNITS 5. INTAKE (optional)



(if available) a. LONG TERM

AVERAGE VALUE 1. POLLUTANT

AND CAS NO.

(if available)

a. BELIEVED PRESENT

b. BELIEVED ABSENT




d. NO. OF ANALYSES

a. CONCEN-TRATION b. MASS


b. NO. OF ANALYSES

g. Nitrogen, Total Organic (as N)

h. Oil and Grease i. Phosphorus (as P), Total (7723-14-0)

j. Radioactivity

(1) Alpha, Total

(2) Beta, Total

(3) Radium, Total

(4) Radium 226, Total

k. Sulfate (as SO4) (14808-79-8)

l. Sulfide (as S)

m. Sulfite (as SO3) (14265-45-3)

n. Surfactants

o. Aluminum, Total (7429-90-5)

p. Barium, Total (7440-39-3)

q. Boron, Total (7440-42-8)

r. Cobalt, Total (7440-48-4)

s. Iron, Total (7439-89-6)

t. Magnesium, Total (7439-95-4)

u. Molybdenum, Total (7439-98-7)

v. Manganese, Total (7439-96-5)

w. Tin, Total (7440-31-5)

x. Titanium, Total (7440-32-6)

EPA Form 3510-2C (8-90) PAGE V-2 CONTINUE ON PAGE V-3

Phone 903/984-0551 FAX 903/984-5914 e-Mail [email protected]

Page 1 of 112/10/2014Printed

Ana-Lab Corp. P.O. Box 9000 Kilgore, TX 75663

LELAP-accredited #02008

Account Project

678528WFS2 -L

Report To

West Fraser, Inc.

Greg Hicks

PO Box 384

Huttig, AR 71742

Report

Employee Owned Integrity Caring Continual Improvement

Table of Contents

PagesDescriptionReport Name

This report consists of this Table of Contents and the following pages:

678528_r03_03_ProjectResults_1355090 Ana-Lab Project P:678528 C:WFS2 1355090 Outfall 001 Permit Renewal 2 678528_r10_05_ProjectQC Ana-Lab Project P:678528 C:WFS2 Project Quality Control Groups 4 678528_r99_09_CoC__1_of_1 Ana-Lab CoC WFS2 678528_1_of_1 2

8 Total Pages:

Corporate Shipping: 2600 Dudley Rd. Kilgore, TX 75662

Form rptTOC Created 10/06/2004 v1.1LDSClient v1.5.50.962

NELAP-accredited #T104704201

Report Page 1 of 9

1

2

3

4


Phone 903/984-0551 FAX 903/984-5914 e-Mail [email protected] Owned Integrity Caring Continual Improvement

Results12/10/2014Printed: Page 1 of 2

Report To

West Fraser, Inc.

Greg Hicks

PO Box 384

Huttig, AR 71742

678528WFS2-LAccount Project

Results

BottleCASFlagsRLUnitsResultsParameter

1355090 Outfall 001 Permit Renewal

12/04/2014 10:30:00M MatthewsCollected by:

12/04/2014Received:

Non-Potable Water Affiliation: West Fraser, Inc.

Prepared: 592828 12/05/2014 09:15:00

EPA 200.7 4.4 12/05/2014 15:29:28LPS QCgroup 592997Analyzed

2.40 mg/L 0.500 7439-95-4Magnesium, Total 05N

Prepared: 592833 12/05/2014 09:30:00

EPA 350.1 2 12/08/2014 10:00:00RSV QCgroup 593136Analyzed

0.111 mg/L 0.020Ammonia Nitrogen 06N

Prepared: 592807 12/10/2014 11:07:06

SM 5210 B-2001 12/10/2014 11:07:06MKC QCgroup 592807Analyzed

8.35 mg/L D2.00 1026-3Biochemical Oxygen Demand (BOD5) 01N

Prepared: 593365 12/09/2014 13:50:33

SM 5310 C-96 12/09/2014 13:50:33ALH QCgroup 593365Analyzed

6.87 mg/L 0.500Total Organic Carbon 03N

The above methods that we used are approved for NPDES reporting as listed in 40 CFR 136 Table 1B or Ana-Lab has specific approval from EPA to use

these methods for NPDES reporting.

Sample Preparation for Sample 1355090

1355090 Outfall 001 Permit Renewal 12/04/2014Received:

Prepared: 592828 12/05/2014 09:15:00

EPA 200.2 2.8 12/05/2014 09:15:00TES QCgroup 592828Analyzed

50/50 mlLiquid Metals Digestion 02N

Prepared: 592833 12/05/2014 09:30:00

EPA 350.2, Rev. 2.0 12/05/2014 09:30:00CDB QCgroup 592833Analyzed

50/50 mlAmmonia Distillation 04N

Prepared: 592807 12/05/2014 07:01:13

SM 5210 B-2001 12/05/2014 07:01:13MKC QCgroup 592807Analyzed

StartedBOD Set StartedN


Form rptPROJRES Created 10/13/2004 v1.2LDSClient v1.5.50.962 www.ana-lab.com

Ark-La-Miss Region: 4720 Viking Dr. Suite A Bossier City LA 71111


Report Page 2 of 9

1

2

3

4


Phone 903/984-0551 FAX 903/984-5914 e-Mail [email protected] Owned Integrity Caring Continual Improvement

Results12/10/2014Printed: Page 2 of 2

Qualifiers:

D - Duplicate RPD was higher than expected

We report results on an 'As Received' or wet basis unless marked 'Dry Weight'. Unless otherwise noted, testing was performed at Ana-lab's

corporate laboratory that holds the following Federal and State certificates: Texas Department of Health Lead Firm Certificate 2110076, US

Department of Agriculture Soil Import Permit S-37592, Texas Commisson on Environmental Quality Drinking Water Laboratory Certificate

TX219, Texas Commission on Environmental Quality NELAP T104704201, Oklahoma Department of Environmental Quality Drinking

Water Certification Lab ID# D9913, EPA Lab Number TX00063, USEPA Approved Perchlorate Testing Lab, Oklahoma Department of

Environmental Quality Laboratory Certificate 8125, Arkansas Department of Environmental Quality Certification #03-070-0, Louisiana

Department of Environmental Quality Laboratory Certification (NELAP, LELAP) #02008, Louisiana Department of Health and Hospitals

Drinking Water (NELAP) # LA030020, US Department of Energy Approved, State of Kansas Department of Health and Environment

Waste Water and Solid/Hazardous Waste Cert. E-10365. The Accredited column designates accreditation by N -- NELAC, or z -- not

covered under NELAC scope of accreditation.

These analytical results relate to the sample tested. This report may NOT be reproduced EXCEPT in FULL without written approval of

Ana-Lab Corp. Unless otherwise specified, these test results meet the requirements of NELAC.

RL is the Reporting Limit (sample specific quantitation limit) and is at or above the Method Detection Limit (MDL). CAS is Chemical

Abstract Service number.

C. H. Whiteside, Ph.D., President


Form rptPROJRES Created 10/13/2004 v1.2LDSClient v1.5.50.962 www.ana-lab.com



Report Page 3 of 9

1

2

3

4


Quality Control Page 1 of 412/10/2014Printed




WFS2 -LAccount Project

West Fraser, Inc.

Greg Hicks

PO Box 384

Huttig, AR 71742

Report To001

678528

SM 5210 B-2001Non-Potable Water 592807

Blank

FileUnitsMQLMDLReadingPrepSetParameter

Biochemical Oxygen

Demand (BOD5)

592807 0.11 0.200 0.500 mg/L 115028382

Biochemical Oxygen

Demand (BOD5)

592807 0.12 0.200 0.500 mg/L 115028431

Biochemical Oxygen

Demand (BOD5)

592807 0.18 0.200 0.500 mg/L 115028478

Biochemical Oxygen

Demand (BOD5)

592807 -0.04 0.200 0.500 mg/L 115028525

Duplicate

Limit%RPDUnitUnknownResultTypeSampleParameter

Biochemical Oxygen

Demand (BOD5)

1354701 Duplicate 3.97 2.97 mg/L 28.8 20.0

Biochemical Oxygen

Demand (BOD5)

1354743 Duplicate 253 314 mg/L 21.5 20.0

Biochemical Oxygen

Demand (BOD5)

1354766 Duplicate 4.20 4.24 mg/L 0.948 20.0

Biochemical Oxygen

Demand (BOD5)

1354947 Duplicate 35.4 34.2 mg/L 3.45 20.0

Biochemical Oxygen

Demand (BOD5)

1354982 Duplicate 14.0 12.0 mg/L 15.4 20.0

Biochemical Oxygen

Demand (BOD5)

1355016 Duplicate 8.76 8.32 mg/L 5.15 20.0

Biochemical Oxygen

Demand (BOD5)

1355090 Duplicate 32.0 8.35 mg/L 117 20.0

Seed Drop

FileOutUnitsMQLMDLReadingPrepSetParameter

Biochemical Oxygen

Demand (BOD5)

592807 0.957 0.200 0.500 mg/L 115028383

Biochemical Oxygen

Demand (BOD5)

592807 1.03 0.200 0.500 mg/L 115028432

Biochemical Oxygen

Demand (BOD5)

592807 0.980 0.200 0.500 mg/L 115028479

Biochemical Oxygen

Demand (BOD5)

592807 1.02 0.200 0.500 mg/L 115028526

Standard

FileOutLimits%Recover%UnitsKnownReadingSampleParameter

Biochemical Oxygen

Demand (BOD5)

194 198 mg/L 98.0 83.7 - 116 115028384

Biochemical Oxygen

Demand (BOD5)

196 198 mg/L 99.0 83.7 - 116 115028433

Biochemical Oxygen

Demand (BOD5)

192 198 mg/L 97.0 83.7 - 116 115028480

Biochemical Oxygen

Demand (BOD5)

191 198 mg/L 96.5 83.7 - 116 115028527

EPA 350.1 2Non-Potable Water 593136


Form rptPROJQCGrpt Created 01/27/2005 v1.0LDSClient v1.5.50.962 www.ana-lab.com



Report Page 4 of 9

1

2

3

4






Blank


Ammonia Nitrogen 592833 ND 0.00974 0.020 mg/L 115035005

CCV

FileOutLimits%Recover%UnitsKnownReadingParameter

Ammonia Nitrogen 2.00 2.00 mg/L 100 90.0 - 110 115034983

Ammonia Nitrogen 1.96 2.00 mg/L 98.0 90.0 - 110 115034994









Duplicate


Ammonia Nitrogen 1354824 Duplicate 0.178 0.181 mg/L 1.67 20.0

Ammonia Nitrogen 1354837 Duplicate 0.265 0.279 mg/L 5.15 20.0

ICV



LCS

OutFileLimitsRecover%UnitsKnownReadingPrepSetParameter

Ammonia Nitrogen 592833 2.03 2.00 mg/L 101 90.0 - 110 115035006

LCS Dup

Limit%RPDUnitsLCSD%LCS%Limits%KnownLCSDLCSPrepSetParameter

Ammonia Nitrogen 592833 2.03 2.11 2.00 90.0 - 110 101 106 mg/L 3.86 20.0

Mat. Spike

FileLimits %Recovery %UnitsKnownUnknownSpikeSampleParameter

Ammonia Nitrogen 1354824 2.45 0.181 2.00 mg/L 113 80.0 - 120 115035010

Ammonia Nitrogen 1354837 2.43 0.279 2.00 mg/L 108 80.0 - 120 115035014

EPA 200.7 4.4Non-Potable Water 592997

Blank


Magnesium, Total 592828 ND 0.0102 0.500 mg/L 115032566

CCV


Magnesium, Total 26.4 25.0 mg/L 106 90.0 - 110 115032552



Magnesium, Total 24.6 25.0 mg/L 98.4 90.0 - 110 115032572

Magnesium, Total 24.7 25.0 mg/L 98.8 90.0 - 110 115032576

ICL







Report Page 5 of 9

1

2

3

4






ICV



LCS


Magnesium, Total 592828 4.99 5.00 mg/L 99.7 85.0 - 115 115032567

LCS Dup

Limit%RPDUnitsLCSD%LCS%Limits%KnownLCSDLCSPrepSetParameter

Magnesium, Total 592828 4.99 4.93 5.00 85.0 - 115 99.7 98.5 mg/L 1.21 25.0

MS

Limit%RPDUnitsMSD%MS%LimitsKnownUNKMSDMSSampleParameter

Magnesium, Total 1354973 5.70 0 0.988 5.00 75.0 - 125 94.2 mg/L 25.0

MSD


Magnesium, Total 1354973 5.70 5.75 0.988 5.00 75.0 - 125 94.2 95.2 mg/L 1.06 25.0

SM 5310 C-96Non-Potable Water 593365

AWRL


Total Organic Carbon 2.22 2.00 mg/L 111 75.0 - 125 115040179

Blank


Total Organic Carbon 593365 0.110 0.0618 0.500 mg/L 115040178



CCB

FileOutUnitsMQLMDLReadingPrepSetParameter








CCV









Duplicate


Total Organic Carbon 1355739 Duplicate 0.0885 0.0969 mg/L 9.06 20.0

Total Organic Carbon 1355739 Duplicate 0.0854 0.0969 mg/L 12.6 20.0





Report Page 6 of 9

1

2

3

4






ICL



ICV



LCS


Total Organic Carbon 593365 5.34 5.00 mg/L 107 85.0 - 115 115040177



MS


Total Organic Carbon 1354322 14.3 0 4.28 10.0 70.0 - 130 100 mg/L 20.0

Total Organic Carbon 1354399 14.6 0 4.79 10.0 70.0 - 130 98.1 mg/L 20.0

Total Organic Carbon 1354454 12.0 0 1.89 10.0 70.0 - 130 101 mg/L 20.0

Total Organic Carbon 1354978 11.8 0 1.96 10.0 70.0 - 130 98.4 mg/L 20.0

MSD


Total Organic Carbon 1354322 14.3 14.1 4.28 10.0 70.0 - 130 100 98.2 mg/L 1.82 20.0

Total Organic Carbon 1354399 14.6 14.6 4.79 10.0 70.0 - 130 98.1 98.1 mg/L 0 20.0

Total Organic Carbon 1354454 12.0 11.7 1.89 10.0 70.0 - 130 101 98.1 mg/L 2.91 20.0

Total Organic Carbon 1354978 11.8 12.0 1.96 10.0 70.0 - 130 98.4 100 mg/L 1.61 20.0

Standard

FileOutLimits%Recover%UnitsKnownReadingSampleParameter


RPD is Relative Percent Difference: abs(r1-r2) / mean(r1,r2) * 100% Recover% is Recovery Percent: result / known * 100%

Blank - Method Blank; LCS - Laboratory Control Sample; CCV - Continuing Calibration Verification; MS - Matrix Spike; ICV - Initial Calibration

Verification; CCB - Continuing Calibration Blank; AWRL - Ambient Water Reporting Limit





Report Page 7 of 9

1

2

3

4

6785

28 C

oC P

rint G

roup

001

of 0

01

1 of

2

Rep

ort P

age

8 of

9

1 2 3 4

678528 CoC Print Group 001 of 001

2 of 2

Report Page 9 of 9

1

2

3

4

NPDES Form 2C - Wastewater Discharge Information · 2014-12-12 · Temperature (winter) VALUE VALUE...

Documents

Transcript of NPDES Form 2C - Wastewater Discharge Information · 2014-12-12 · Temperature (winter) VALUE VALUE...